Future trends of processed meat products concerning perceived healthiness: A review

Technological and sensory characteristics of hamburgers made with polyunsaturated gelled emulsions

The quest for healthiness has driven the meat industry to seek solutions to reduce or replace saturated animal fat. The replacement (partial or total) of animal fat by polyunsaturated vegetable oils rich in omega fatty acids has gained prominence in terms of making a product healthier. However, an obstacle to this strategy is the effects on the sensory characteristics of the products, which may be unfavorable to consumers. The objective of this study was to evaluate the lipid reformulation of hamburgers through the total replacement of pork fat with canola, sunflower, and corn oil emulsions. The physical-chemical, technological, and sensory properties analyses were performed. There were no significant changes (P > 0.05) in moisture content, protein content, ash content, pH, weight loss (%), moisture retention (%), or shrinkage (%). However, the lipid content was reduced (P < 0.05) and there was a significant improvement in the fatty acid profile with the application of gelled emulsions. The lipid peroxidation and oxidation also increased (P < 0.05) for the samples with the addition of gelled emulsions, and we observed the same behavior for lipid retention (%). In the sensory evaluation, the samples showed good overall acceptance, with hedonic scores ranging from "like slightly" to "like very much." In addition, through check-all-that-apply questions, we observed that the most positive scores given applied to the treatments were applied to the emulsions. The total replacement of animal fat by gelled emulsions is a promising strategy for producing healthier hamburgers.

Ultrasound-assisted oligochitosan/casein complexes stabilized Pickering emulsion: Characterization, stability and its application for lutein delivery

Lutein is a natural pigment with various beneficial biological activities, but its poor water solubility, chemical instability, and low bioavailability limit its application in food processing. In this study, modified casein (CAS-OCS NPs)-based Pickering emulsions were constructed under the combined effect of TGase-type glycation and ultrasound treatment as delivery systems for lutein fortification. Pickering emulsions based on CAS-OCS NPs enhanced the encapsulation efficiency of lutein (87.04 ± 0.30 %). The modification treatments improved the emulsifying properties, environmental stability, and digestive stability, as well as the delivery capability of lutein and antioxidant activity in simulated in vitro gastrointestinal digestion. After glycation modification, the lutein release rate of CAS-OCS NPs-based Pickering emulsions after in vitro digestion was higher than that of untreated casein-based Pickering emulsions, and the maximum release rate was 55.44 ± 0.50 %. Moreover, the CAS-OCS NPs-based Pickering emulsions showed improved lutein bioaccessibility, reaching the maximum value of 58.52 ± 0.52 %. These findings demonstrated the suitability of TGase-type glycation and ultrasound treatment for the preparation of Pickering emulsions to deliver bioactive compounds.

Oxidation mechanism and interrelationship of lipid and protein oxidation in duck leg muscles during sous vide cooking

The laws and interrelationships of lipid and protein oxidation in duck meat during sous vide cooking (SVC) are still unclear. In this study, the oxidation mechanisms of the muscle of duck legs during SVC were investigated from the aspects of fatty acid (FA) profile, antioxidant system activity, enzyme activity, and iron element. Lipid oxidation predominantly occurred within the initial 0-2 h of the SVC process, during which the Thiobarbituric acid reactive substances (TBARS) value escalated to 10-fold of its initial level. Protein oxidation was mainly observed between 0 and 4 h, with the carbonyl content increasing by 23.3%. The FAs profile underwent changes primarily within the initial 0-2 h, and then their proportions continued to evolve in a manner that was favorable for oxidative stability. Following 4 h of SVC, the scavenging rates of ·OH and DPPH· free radicals decreased to the lowest, decreasing by 92.9% and 45.6%. As cooking time increased, lipoxygenase activity increased by more than six times, while Total superoxide dismutase (T-SOD) and GSH-Px activity decreased by 31.7% and 75.2%, respectively. The heme iron content was decreased by 26.1% after 8 h of SV treatment. These data can provide a theoretical foundation for optimizing parameters of the SVC process and improving the oxidative stability of SVC meat products.

Cholesterol oxides and quality attributes of NaCl-substituted low-fat chicken sausages prepared with different antioxidants

This trial investigated how different salts and antioxidants influence cholesterol oxides, microbial profiles, physicochemical properties and organoleptic characteristics of low-fat chicken sausages (CS). CS were formulated with either 2 % NaCl, CS-1; 2 % NaCl +0.02 % butylated hydroxyanisole (BHA), CS-2; 1 % NaCl + 1 % KCl + 0.25 % onionskin extract (OSE), CS-3; 1 % NaCl + 1 % KCl + 0.5 % OSE, CS-4; 1 % NaCl + 1 % K3C6H5O7 + 0.25 % OSE, CS-5 or 1 % NaCl + 1 % K3C6H5O7 + 0.5 % OSE, CS-6, cooked, and refrigerated for 45 d. The Na content in CS-1 and CS-2 (1185 ± 21 mg/100 g) was greater than that in the other CS (640 ± 18 mg/100 g). The 19-hydroxy cholesterol, 7α-hydroxycholesterol, 25-hydroxycholesterol, 5,6β-epoxycholesterol, 7β-hydroxycholesterol and carbonyl content were greater in CS-1 than in the other sausages. The OSE-treated CS group had lower levels of 7β-hydroxycholesterol and 7α-hydroxycholesterol than did the CS-2 group. CS-1 and CS-2 were lighter than the other CS. Malondialdehyde, pH, chemical composition, textural profile, microbial counts, cook loss and sensorial quality were unaffected by additives. The partial replacement of NaCl with KCl and K3C6H5O7, along with the addition of BHA and OSE, decreased the Na and cholesterol oxide contents without affecting the organoleptic qualities of low-fat CS.

Role of calcium salts in modulating benzo[a]pyrene levels in barbecued pork sausages: A study on quality attributes and safety

Benzo[a]pyrene (BaP), known for its carcinogenic and mutagenic properties, is a marker of polycyclic aromatic hydrocarbons (PAHs). This study aimed to investigate the effect of partially replacing sodium chloride with different calcium salts (calcium chloride, calcium gluconate, calcium citrate, and calcium lactate) on BaP formation in barbecued pork sausages. The results revealed that all four calcium salts inhibited BaP formation in barbecued pork sausages (P < 0.05). Specifically, calcium gluconate showed the most significant effect on BaP inhibition, with an inhibition rate of 61.82 %. Furthermore, calcium salts were found to inhibit lipid oxidation in barbecued pork sausages while promoting the Maillard reaction. Further validation experiments used resveratrol and sodium sulfite as lipid oxidation and Maillard reaction inhibitors, respectively. These results indicated that lipid oxidation is the primary pathway for BaP production in barbecued pork sausage and that the addition of calcium salts can effectively block this process.

Wheat Germ as Partial or Total Substitutive of Lean Meat in Low-Fat Cooked Sausages

Wheat germ is a byproduct of the cereal industry that contains high levels of protein, fiber, B vitamins, minerals, and other functional microcomponents. However, so far, few applications have been found in the meat industry despite the growing interest in replacing meat with vegetable proteins. Therefore, the use of wheat germ for the production of low-fat frankfurters was considered. Five different formulations were prepared: control with pork meat and the following four to achieve 25%, 50%, 75%, and 100% lean meat substitution by wheat germ. Proximal composition, color, texture, emulsion characterization, fatty acid profile, fat oxidation, and consumer acceptance were then analyzed. The results showed that the incorporation of wheat germ improved emulsion stability, decreasing significantly total expressible fluid and jelly/fat separation, although increasing the back extrusion force. In terms of the final product, the progressive substitution of meat by germ resulted in significant increases in carbohydrates, in special of fiber, and ash as well as significant decreases in moisture and total fat. Sausages made with germ were darker (L*), as well as harder, chewier, and gummier, but less cohesive and elastic. Similarly, wheat germ substitution improved the quality of the lipid profile showing higher levels of, but decreased acceptability for replacements > 25%. Substitution of meat was feasible up to 25%, a formulation for which there was hardly any significant difference with the control.

Effect of Opuntia ficus-indica Extract in Pro-Healthy Chicken Patties: Physicochemical Properties and Oxidative Stability

Opuntia ficus-indica is a subtropical fruit rich in dietary fibers, carotenoids, vitamins, minerals, and polyphenols. To substitute synthetic additives, its extracts could become an interesting proposal to preserve quality while adding desirable characteristics to meat products. This study aimed to develop healthier chicken patties (with a structured animal fat replacer) added with prickly pear extract (PPE). The extract was analyzed for total phenolic content and antioxidant activity (FRAP, ABTS, DPPH, and ORAC). Four chicken patty formulations were manufactured with total replacement of animal fat by sesame oil emulsion: control, erythorbate 500 ppm, PPE 500, and PPE 750 ppm. Proximate composition and fatty acid profile were analyzed on day 1, and pH, color, and lipid oxidation on days 1, 4, 8, 12, and 16. PPE treatments showed lower TBARSs (p < 0.05) and greater pigment stability at the end of storage, corroborating its potential to delay oxidation reactions. No significant effects on chemical composition, pH, or fatty acid profile were observed (p > 0.05). Unsaturated represented 76.2% of total fatty acids. Therefore, PPE is an effective antioxidant by improving oxidative stability without promoting changes in other properties, besides adding cleaner label approaches and the use of natural ingredients to develop meat products reformulated with unsaturated oils.

Influence of flaxseed-derived diglyceride-based high internal phase Pickering emulsions on the rheological and physicochemical properties of myofibrillar protein gels

The study aimed to investigate the influence of flaxseed-derived diglyceride-based high internal phase Pickering emulsions (HIPPE) at different levels (0%, 10%, 20%, 30%, 40%, and 50%) on the rheological and physicochemical properties of myofibrillar protein (MPs) gels. The study indicated that with increasing HIPPE levels, there was a significant increase in whiteness while a decrease in water-holding capacity. The gels with 10% HIPPE levels had higher ionic bonds, while those with 40% and 50% HIPPE levels showed higher hydrogen bonds. By increasing HIPPE levels in the formation of MP gels, the T2 relaxation time was found to decrease. Additionally, in all MP gels, G' values were significantly higher than G" values over time. Adding lower contents of HIPPE levels resulted in a more compact microstructure. These findings indicate that flaxseed-derived diglyceride-based HIPPEs could be utilized as fat substitutes in meat products to enhance their nutritional quality.

Substitution of Animal Fat and Sodium Nitrite with Hemp Seed Oil: Effect on the Nutritional Value, Sensory Characteristics, and Shelf Life of Fermented Salami

Recently, products of plant origin have been utilized to extend the shelf life of meat products. This study examined the impact of hemp seed oil as a replacement for animal fat and sodium nitrite on the nutritional, physicochemical, technological, and sensory traits of fermented salamis. Five treatments were prepared: S0 (100 mg/kg NaNO2), S1 (2% hemp oil and 50 mg/kg NaNO2), S2 (4% hemp oil and 50 mg/kg NaNO2), S3 (2% hemp oil), and S4 (4% hemp oil). The addition of hemp seed oil did not affect proximate composition but improved fatty acid composition and lipid quality nutritional indices. Microbial growth was consistent across all treatments. Active acidity (pH) and water activity (aw) were influenced by hemp seed oil and/or sodium nitrite. Salamis containing only hemp seed oil exhibited lower redness and chroma values during storage. Hemp seed oil led to higher lipid peroxidation, mitigated by sodium nitrite. The addition of hemp seed oil and varying levels of sodium nitrite significantly impacted salami texture. Sensory evaluation showed consumer acceptance of hemp seed oil-enhanced salamis. In conclusion, hemp seed oil can be used as a functional ingredient to improve the nutritional value and healthiness of fermented meat products when combined with reduced sodium nitrite content.

Blackcurrant Pomace Extract as a Natural Antioxidant in Vienna Sausages Reformulated by Replacement of Pork Backfat with Emulsion Gels Based on High Oleic Sunflower and Flaxseed Oils

The incorporation of a blackcurrant pomace extract (BPE) at 2.5%, 5.0% and 10.0% into an emulsion gel based on high oleic sunflower and linseed oils was examined in order to obtain a functional ingredient to be used as a pork backfat replacer in Vienna sausages. The replacement of the pork backfat with the control emulsion gel reduced the cooking loss but negatively affected the color by decreasing L* and a* values as compared with the traditional product. A decrease in the n-6/n-3 ratio from 10.99 to around 1.54 (by 7 times) was achieved through reformulation, while the PUFA/SFA ratio increased from 0.49 to 1.09. The incorporation of BPE did not have a major impact on the fatty acid profile and improved color by increasing redness, but negatively affected the texture by increasing hardness, gumminess and share force as compared with the sausages reformulated without extract. BPE reduced the pH and the thermal stability of the emulsion gels, increased cooking loss and decreased moisture retention in sausages. BPE increased the oxidative stability of Vienna sausages enriched in polyunsaturated fatty acids; however, the incorporation of BPE into the emulsion gels above 5% affected the sensory scores for appearance, texture and general acceptability of the reformulated sausages.

Amazon Fruits as Healthy Ingredients in Muscle Food Products: A Review

When looking for new ingredients to process red meat, poultry, and fish products, it is essential to consider using vegetable resources that can replace traditional ingredients such as animal fat and synthetic antioxidants that may harm health. The Amazon, home to hundreds of edible fruit species, can be a viable alternative for new ingredients in processing muscle food products. These fruits have gained interest for their use as natural antioxidants, fat replacers, colorants, and extenders. Some of the fruits that have been tested include açai, guarana, annatto, cocoa bean shell, sacha inchi oil, and peach palm. Studies have shown that these fruits can be used as dehydrated products or as liquid or powder extracts in doses between 250 and 500 mg/kg as antioxidants. Fat replacers can be added directly as flour or used to prepare emulsion gels, reducing up to 50% of animal fat without any detrimental effects. However, oxidation problems of the gels suggest that further investigation is needed by incorporating adequate antioxidant levels. In low doses, Amazon fruit byproducts such as colorants and extenders have been shown to have positive technological and sensory effects on muscle food products. While evidence suggests that these fruits have beneficial health effects, their in vitro and in vivo nutritional effects should be evaluated in muscle food products containing these fruits. This evaluation needs to be intended to identify safe doses, delay the formation of key oxidation compounds that directly affect health, and investigate other factors related to health.

Genetically predicted processed meat, red meat intake, and risk of mental disorders: A multivariable Mendelian randomization analysis

BACKGROUND

Previous observational studies have highlighted potential links between the consumption of processed meat and red meat (such as pork, mutton, and beef intake) and the occurrence of mental disorders. However, it is unclear whether a causal association exists. Therefore, we employed the Mendelian randomization (MR) study to investigate the causal effects of genetically predicted processed meat and red meat on mood disorders (MD), anxiety disorders (AD), and major depressive disorder (MDD).

METHODS

Genetic instruments for processed and red meat were selected from the Genome-Wide Association Study (GWAS) of the UK Biobank Study. Their associations with MD (42,746 cases 254,976), AD (35,385 cases and 254,976 controls), and MDD (38,225 cases and 299,886 controls) were obtained from the FinnGen Consortium. The inverse variance weighted (IVW) method was the primary method for two-sample MR analysis. Additionally, we employed complementary analysis to assess the robustness of our MR findings (eg, MR Egger and weighted median). We also conducted multiple sensitivity analyses to investigate horizontal pleiotropy and heterogeneity. Moreover, we performed a univariate and multivariable MR (MVMR) study to evaluate these associations.

RESULTS

In our univariate MR analysis, we observed that genetically predicted beef intake was associated with a reduced risk of MD [odds ratio (OR) = 0.403, 95 % confidence interval (CI) = 0.246-0.659; PIVW = 4.428 × 10-5], AD (OR = 0.443, 95 % CI = 0.267-0.734; PIVW = 1.563 × 10-3), and MDD (OR = 0.373, 95 % CI = 0.216-0.643; PIVW = 3.878 × 10-4). After adjusting for processed meat, pork, and mutton intake in the MVMR analysis, the protective association of beef intake against MD and MDD remained. However, there was no substantial evidence indicating a significant causal relationship between processed meat, pork, and mutton intake and the occurrence of mental disorders. Furthermore, our sensitivity analysis revealed no significant evidence of horizontal pleiotropy.

CONCLUSION

These findings support a causal relationship between genetically predicted beef intake and reducing the risk of MD and MDD.

Effect of flaxseed-derived diglyceride-based high internal phase Pickering emulsion on the quality characteristics of reformulated beef burgers

The study aimed to fabricate healthier beef burgers using high internal phase Pickering emulsion (HIPPE) as animal fat substitute. In this context, HIPPE stabilized by modified soy protein isolates was produced with flaxseed-derived diglycerides (DAGs). Beef burgers were prepared by substituting beef backfat with HIPPE at varying levels (0%, 25%, 50%, 75%, and 100%). Reformulated burgers showed a significant decrease in WHC (from 89.75 to 77.38%), pH (from 5.73 to 5.58), L* values (from 53.5 to 44.5), and b* values (22.9 to 21.8), while a significant increase in a* values (from 24.4 to 6.7), cooking loss (from 20.25 to 30.62), and cooking shrinkage (from 11.27 to 13.05). Texture attributes, including hardness, chewiness, and gumminess, decreased up to 50% fat substitution and increased with increasing levels of fat substitution. Moreover, the rheological properties (G' and G'') and T2 relaxation time were increased with increasing fat replacement. The reformulation with HIPPE resulted in a decrease in SFA (from 3896 to 1712 mg/100 g), ω-6/ω-3 ratio (from 5.29 to 0.47), atherogenic index (from 0.57 to 0.13), and thrombogenic index (from 1.46 to 0.15) and increase in PUFA/SFA ratio (from 0.20 to 2.79). Notably, burgers with 50% fat substitution were more preferred regarding tenderness, while those with 100% fat substitution obtained higher scores for color and flavor than all other treatments. In conclusion, 50% fat replacement using flaxseed-derived diglyceride-based HIPPE improved beef burgers' textural profile and fatty acid composition without compromising the sensory characteristics.

Ultrasonic enhancement of structural and emulsifying properties of heat-treated soy protein isolate nanoparticles to fabricate flaxseed-derived diglyceride-based pickering emulsions

Flaxseed-derived diglyceride (DAG)-based Pickering emulsions were fabricated using soy protein isolate (SPI) nanoparticles as stabilizer. The SPI nanoparticles were prepared under the combined action of heating and ultrasound treatment. The SPI nanoparticles exposed to 600 W power exhibited the smallest particle size (133.36 nm) and zeta potential (-34.77 mV). Ultrasonic treatment did not significantly impact the polypeptide chain's primary structure but induced changes in the secondary structure. The Pickering emulsions stabilized with ultrasound-treated SPI nanoparticles showed smaller particle size, lower zeta potential, and improved emulsifying properties. Notably, at 450 W power, these emulsions showed a higher solid-liquid balance, reduced mean square displacement, backscattering fluctuations, and turbiscan stability index. Besides, they displayed a more compact microstructure with smaller droplets. In conclusion, SPI subjected to heating and 450 W ultrasound power resulted in the fabrication of DAG-based Pickering emulsions with enhanced microstructure and stability.

Comparison of competitive and sandwich immunochromatographic analysis in the authentication of chicken in meat products

Cheap chicken meat is often used as an undeclared substitute in meat products. In this study, two formats of the immunochromatographic assay (ICA) of immunoglobulins of class Y (IgY) as a biomarker for chicken authentication were developed. In both competitive ICA (cICA) and sandwich ICA (sICA), gold nanoparticles (GNP) were conjugated with anti-species antibodies. A simple procedure of sample preparation, which took only 30 min, was proposed. Test systems demonstrated high sensitivity and rapidity: visual limits of detection of IgY and assay durations were 12/14 ng/mL and 10/15 min for cICA and sICA, respectively. The absence of cross-reactivity with the mammalian species confirmed the high specificity of the test systems. Good applicability of the assays was confirmed for the detection of chicken in raw meat mixtures: as low as 3% and 0.2% (w/w) of chicken could be revealed in beef and pork by cICA and sICA, respectively. The influence of heat processing of meat-based products on immune recognition and, consequently, the analytical performance of the test systems was revealed. It was shown that sICA is preferable for the detection of IgY even in thermally processed meat. The proposed ICAs can be recommended for rapid on-site control of meat products' composition.

Exploring Pijuayo (Bactris gasipaes) Pulp and Peel Flours as Fat Replacers in Burgers: A Multivariate Study on Physicochemical and Sensory Traits

Meat products are known for their lipid profile rich in saturated fats and cholesterol, and also for the formation of oxidation compounds; therefore, a reduction in animal fat may result in a product less harmful to health. Pijuayo is an Amazon fruit known for its nutritional properties, such as its fiber and lipid content. For these reasons, it is an attractive fruit to replace animal fat in meat products. The present work used pijuayo pulp and peel flours to partially replace animal fat in beef-based burgers at 25% and 50% levels, considering sensory and physicochemical outcomes evaluated by Principal Component Analysis (PCA), Correspondence Analysis (CA) and Multiple Factor Analysis (MFA). Pijuayo flour affected the physicochemical characteristics evaluated by PCA, where the samples with greater fat replacement were characterized by a high carbohydrate content and instrumental yellowness. The minimal fat replacement did not abruptly affect the PCA's instrumental texture and color, proximal composition, yield properties, and lipid oxidation. The overall liking was greater in the 25% fat reduction treatments, even greater than the control, in which positive sensory attributes for liking were highlighted for those treatments. A small segment of consumers (11% of total consumers) preferred the treatment with greater replacement of fat with pijuayo peel flour, which these consumers tended to characterize as seasoned. However, this treatment had the lowest liking. The MFA showed that the sensory characteristics tender and tasty were strongly correlated with overall liking and were highlighted in the samples of 25% fat reduction, suggesting that the pijuayo improves the tenderness and flavor of reduced-fat burgers. Other inclusion levels between 25% and 50% of fat replacement could be explored, and optimization studies are needed. In addition, the sensory characteristics and flavor-enhancing compounds of the fruit, as well as the nutritional aspects of the inclusion of pijuayo, should be studied, such as the fatty acid profile. These characteristics will be informative to explore pijuayo as a fat replacer at a pilot scale and industrial scale.

Consumer acceptance and quality of game meat "droëwors" sausages with different levels of added fat

Droëwors (dried sausage) is a unique dried meat product from South Africa, which is not smoked, fermented, nor is nitrite used in its production. The objective of the study was to compare the quality parameters and consumer acceptance of common eland meat droëwors with different quantities of added beef fat. Three treatments containing either 10, 15, or 20% (by weight) added beef fat were compared regarding chemical composition, fatty acid profiles, and sensory properties. Increasing the amount of fat in the dried product resulted in a significant decrease in the protein and ash percentages. The sausages with 10% added fat had the most favourable fatty acid profile in terms of nutritional value. Several differences were found in the sensory profiles of the products evaluated by the trained sensory panel; in particular, the evaluation scores for texture improved with increasing fat content. No differences were found between the products by the untrained consumer panel for appearance and taste. When the dataset was analysed according to gender, it was found that women evaluated the 10% fat samples more favourably. This is in line with their stated preference for low-fat meat products. For these reasons, the production of sausages with the lowest fat content can be recommended as they best meet consumer expectations.

Perilla seed oil high internal phase emulsion improve the gel properties of myofibrillar protein

The effects of perilla seed oil high internal phase emulsions stabilized by pea protein (PP-PSO HIPEs) on the gel properties and conformation of myofibrillar protein (MP) gels were investigated. The results showed that the PP-PSO HIPEs with 4.0 % (w/v) PP formed stable HIPEs with low droplet size and good viscoelasticity. The addition of PP-PSO HIPEs (5.0 % - 15.0 %) could significantly improve the MP gel properties (P < 0.05), while the addition of 10.0 % PP-PSO HIPEs showed the highest gel strength and water holding capacity. Otherwise, the MP gels with 10.0 % PP-PSO HIPEs showed higher proportions of immobile water (PT22) and lower proportion of free water (PT23), and the Raman spectra suggested that the content of α-helix decreased, while the content of β-sheet increased (P < 0.05), thus facilitating the formation of better gel properties. Therefore, the addition of PP-PSO HIPEs is a potential alternative for developing fat-reduced meat products.

Evaluation of bigel systems as potential substitutes to partially replace pork backfat in semi-dry sausages

Bigels prepared with olive oil oleogels admixed with κ-carrageenan or κ-carrageenan and gelatin hydrogels (BG1 and BG2, respectively) were characterized with respect to microstructure and textural properties and were used as pork backfat alternatives in semi-dry sausages. Stable oleogel-in-hydrogel type bigels were formed, with BG2 having higher hardness values. Control sausages (CF) were formulated with 20% pork backfat and sausage treatments B1F and B2F had 50% of the pork backfat substituted by BG1 and BG2 bigels, respectively. Moisture, water activity, texture, microbial counts, sensorial and nutritional attributes of the resulting sausages were assessed during fermentation and after pasteurization and storage. Substituted sausages had increased weight loss, moisture, and water activity. Color evaluation revealed that the treatments with bigels exhibited the same trend in color formation and no differences were recorded in L* and a* values of the sausages. Total viable counts and lactic acid bacteria populations were not affected by the addition of bigel systems. Regarding the texture parameters, B2F semi-dry sausages exhibited similar values of hardness and cohesiveness to CF. Sausages formulated with bigels exhibited a reduction in energy (20%), fat (27%), saturated fatty acids (30%) and cholesterol (∼6%) content. B2F sausages had similar liking scores with CF, and they did not show any undesirable sensory attributes. The results demonstrate that bigels are a promising fat alternative to manufacture semi-dry meat products with lower fat content and a better nutritional profile.

A sight of self-assembly mechanism in fish oil oleogels: Phase transition, crystal structure and non-covalent interaction

Fish oils contain ω-3 polyunsaturated fatty acids (PUFAs), but easily cause quality deterioration due to the oxidation. Beeswax-based oleogels could wrap fish oils by beeswax self-assembly. The phase transition, crystal structure and non-covalent interaction were investigated to reveal the self-assembly mechanism from the perspective of beeswax and oil phase characteristics. The results indicated that high unsaturation degree, PUFAs and beeswax additions promoted phase transition, SFC and stable crystal networks. The changes of crystal structures were ascribed to the polymorphism and polymorphic transition. β-Polymorphs could form crystal networks, and β'-polymorphs could influence the size of crystal chains or clusters as well as crystalline domains. Crystalline domain sizes affected crystal morphologies and network structures, including plate-like structures and multi-layer porous structures. UFAs could involve the beeswax self-assembly to change structure characteristics by van der Waals forces and π-π stacking. The OBC remained 100%, when beeswax additions reached more than 6%. Hence, beeswax additions, PUFA contents and unsaturation degree all influenced the self-assembly mechanism and adjusted the macroscopic properties of oleogels.

Characterizations and molecular docking mechanism of the interactions between peptide FDGDF (Phe-Asp-Gly-Asp-Phe) and SOD enzyme

In this study, we investigated the antioxidant properties of dry-cured beef crude peptide (BPH) at different storage periods. The combination characteristics of different concentrations of Phe-Asp-Gly-Asp-Phe (FDGDF) and superoxide dismutase (SOD) at different temperatures were analyzed by ultraviolet-visible spectroscopy, fluorescence spectroscopy, and FT-IR spectroscopy, combined with the detection of a SOD activity detection box. It was found that FDGDF could improve the activity of SOD by changing its secondary structure. Bonds were formed at O32/O40/O52 using quantum chemical simulation calculations, and the Fukui index was higher than that of most atoms, indicating that these atoms were more likely to participate in the reaction. SPR biological force analysis showed that FDGDF and SOD were in a fast binding and dissociation mode. This study revealed the theoretical basis for studying the antioxidant mechanism of dry-cured beef and provided ideas for developing new dry-cured beef products.

The Techno-Functionality of Chia Seed and Its Fractions as Ingredients for Meat Analogs

Eating practices are changing due to awareness about meat consumption associated with social, ethical, environmental, and nutritional issues. Plant-based meat analogs are alternatives to conventional meat products that attempt to mimic all the inherent characteristics of meat fully. Therefore, the search for raw materials that provide these characteristics is increasing. Chia seeds have excellent potential as a functional ingredient in these products since they are a source of proteins, lipids, and fibers. Allied with this, the full use of chia through the seed and its fractions highlights the numerous beneficial characteristics of the formulation regarding nutritional characteristics and techno-functionality. Therefore, this review aims to highlight the potential of chia seed and its fractions for applications in meat-like products. Chia seeds are protein sources. Chia oil is rich in polyunsaturated fatty acids, and its application in emulsions ensures the oil's nutritional quality and maintains its technological characteristics. Defatted chia flour has a high protein content and can be used to extract chia mucilage. Due to its high emulsification capacity, chia mucilage is an effective ingredient for meat products and, consequently, meat-like products. Therefore, this literature review demonstrates the strategic potential of using chia seeds and their fractions to develop meat analogs.

Influence of varying oil phase volume fractions on the characteristics of flaxseed-derived diglyceride-based Pickering emulsions stabilized by modified soy protein isolate

This research aimed to create Pickering emulsions using modified soy protein isolate (SPI) as a stabilizer and flaxseed-derived diglyceride (DAG) as an oil phase. The SPI was modified through a process involving both heating and ultrasound treatment. The result indicated that the droplet size of emulsions increased with the increase in oil content (p < 0.05). For instance, the largest droplet size (23 µm) was observed at an oil-to-SPI dispersion ratio of 4:1 ratio (φ = 80), whereas the smallest droplet size (6.39 µm) was noticed at the 1:4 ratio. During the 7-day storage period, the emulsions with a 4:1 ratio (φ = 80) showed the lowest droplet size increase (from 23 µm to 25.58 µm). In contrast, the emulsions with a 1:1 ratio displayed the highest increase (from 19.39 µm to 74.29 µm). Creaming index results revealed that emulsions with a 4:1 ratio (φ = 80) showed no signs of creaming and phase separation than all other treatments (p < 0.05). Backscattering fluctuations (ΔBS) and turbiscan stability index (TSI) showed that emulsions with 4:1, 2:1, and 1:1 oil-to-SPI dispersion ratios had consistent ΔBS curves with higher and TSI curves with lower values. Optical microscopy, confocal laser scanning, and cryo-scanning electron microscopy revealed that emulsions with oil-to-SPI dispersion ratios of 4:1 and 2:1 had well-organized structures with no visible coalescence. Macromorphological and microrheological investigations demonstrated that emulsions with 80% oil content had the highest viscosity, both moduli, elasticity index, macroscopic viscosity index, and the lowest fluidity index and solid-liquid balance values. Moreover, these emulsions were more resistant to centrifugation and storage environments. In conclusion, the study determined that flaxseed-derived DAG-based high internal phase Pickering emulsions (φ = 80) had superior stability, improved viscoelasticity, and better rheological properties.

Properties and physiological effects of dietary fiber-enriched meat products: a review

Meat is a rich source of high biological proteins, vitamins, and minerals, but it is devoid of dietary fiber, an essential non-digestible carbohydrate component such as cellulose, hemicellulose, pectin, lignin, polysaccharides, and oligosaccharides. Dietary fibers are basically obtained from various cereals, legumes, fruits, vegetables, and their by-products and have numerous nutritional, functional, and health-benefiting properties. So, these fibers can be added to meat products to enhance their physicochemical properties, chemical composition, textural properties, and organoleptic qualities, as well as biological activities in controlling various lifestyle ailments such as obesity, certain cancers, type-II diabetes, cardiovascular diseases, and bowel disorders. These dietary fibers can also be used in meat products as an efficient extender/binder/filler to reduce the cost of production by increasing the cooking yield as well as by reducing the lean meat content and also as a fat replacer to minimize unhealthy fat content in the developed meat products. So, growing interest has been observed among meat processors, researchers, and scientists in exploring various new sources of dietary fibers for developing dietary fiber-enriched meat products in recent years. In the present review, various novel sources of dietary fibers, their physiological effects, their use in meat products, and their impact on various physicochemical, functional, and sensory attributes have been focused.

Improvement strategies for fats and oils used in future food processing based on health orientation and sustainability: research progress, challenges and solutions

As the third largest source of energy in addition to carbohydrates and proteins, lipids provide the body with more than twice as much energy as carbohydrates and proteins and are the accumulated "fuel bank" of the body. They are widely stored in animals, plants and microorganisms and are effectively extracted for dietary use by improved and novel technologies. Under the pressure of the current environment, we should immediately look for new strategies to improve or develop dietary lipids that are compatible with the development of the future food industry, in order to mitigate the environmental and climatic degradation caused by the lipid-producing activities of the animal husbandry industry, to avoid the contradiction between the demand for high quality of human beings and the strain on the resources, and to reduce the health risks caused by saturated fats and trans-fats in meat products. At present, workers concerned are opening up new avenues for the future edible lipids, for example, researches into fat and oil substitutes, the use of biotechnology in lipids and the value-added reuse of waste products is in full swing. The article therefore began with a detailed overview of the known lipids available, understanding their origins and the ways in which they were classified by region. Secondly, possible trends and potential strategies for dietary lipids for use in future foods were presented. Finally, constructive comments are made on the problems and challenges that may be encountered in the research and subsequent industrialization process.

Recent Trends in Active Packaging Using Nanotechnology to Inhibit Oxidation and Microbiological Growth in Muscle Foods

Muscle foods are highly perishable products that require the use of additives to inhibit lipid and protein oxidation and/or the growth of spoilage and pathogenic microorganisms. The reduction or replacement of additives used in the food industry is a current trend that requires the support of active-packaging technology to overcome novel challenges in muscle-food preservation. Several nano-sized active substances incorporated in the polymeric matrix of muscle-food packaging were discussed (nanocarriers and nanoparticles of essential oils, metal oxide, extracts, enzymes, bioactive peptides, surfactants, and bacteriophages). In addition, the extension of the shelf life and the inhibitory effects of oxidation and microbial growth obtained during storage were also extensively revised. The use of active packaging in muscle foods to inhibit oxidation and microbial growth is an alternative in the development of clean-label meat and meat products. Although the studies presented serve as a basis for future research, it is important to emphasize the importance of carrying out detailed studies of the possible migration of potentially toxic additives, incorporated in active packaging developed for muscle foods under different storage conditions.

pH-shift strategy improving the thermal stability and oxidation stability of rice starch/casein-based high internal phase emulsions for the application in fish cake

The thermal stability of the different pH-shift rice starch/casein-based high internal phase emulsions (SC-HIPE) were evaluated in the present study to verify potential in improving the quality of fish cake. The results showed that the pH-shift treatment improved thermal stability (from 27.23% to 76.33%) and oxidation time (from 5.01 h to 6.86 h) of SC-HIPE, which showed the smaller droplet size (decreased from 15.14 to 1.64 μm) and higher storage module. The breaking force of FC with thermal stable SC-HIPE (average 64.95 g) was higher than that with thermal unstable SC-HIPE (51.05 g). The cohesiveness, adhesiveness and chewiness could be improved by adding thermal stable SC-HIPE, compared with pork fat. Additionally, combining sensory evaluation, the thermal stable SC-HIPE improved the gel quality, thus it could be completely replaced pork fat in the preparation of FC, which provided theoretical guidance for the preparation and application of fat substitutes.

Effect of vegetable oil hydrogel emulsion as a fat substitute on the physicochemical properties, fatty acid profile, and color stability of modified atmospheric packaged buffalo burgers

Buffalo burgers were prepared with 50% or 100% buffalo backfat substitution using walnut, and peanut oil emulsion gels (EGs) blended with chia flour. Burgers were stored at 2 °C in modified atmosphere packaging for 12 days. The fat replacement decreased total fat by 26% and increased ash by 34%. Hardness and chewiness decreased with increasing the fat replacement; however, it did not affect springiness and cohesiveness values. Burger reformulations led to an increase in cooking yield (10%). Walnut oil EGs increased PUFA level up to 458%. Both oils enhanced PUFA/SFA and ω-6/ω-3 ratios and atherogenic and thrombogenic indices. Concerning color attribute, about 66% reduction was observed in redness values during the storage period of 12 days. Moreover, the sensory scores for all attributes, i.e., appearance, odor, flavor, and juiciness, were in the acceptable range of five or above in the reformulated burgers. In conclusion, 50% fat substitution using walnut and peanut oil EGs improved the nutritional profile of buffalo burgers without compromising the technological and sensory characteristics.

A review of oil and water retention in emulsified meat products: The mechanisms of gelation and emulsification, the application of multi-layer hydrogels

Emulsified meat products are key deep-processing products due to unique flavor and high nutritional value. Myosin dissolves, and protein aggregation and heat-induced gelation occur after myosin unfolds and hydrophobic groups are exposed. Myosin could form interfacial protein membranes and wrap fat globules. Emulsified fat globules may be filled in heat-induced gel networks. Therefore, this review intends to discuss the influences of heat-induced gelation and interfacial adsorption behavior on oil and water retention. Firstly, the mechanism of heat-induced gelation was clarified from the perspective of protein conformation and micro-structure. Secondly, the mechanism of emulsification stability and its factors affecting interfacial adsorption were demonstrated as well as limitations and challenges. Finally, the structure characteristics and application of multi-layer hydrogels in the gelation and emulsification were clarified. It could conclude that the characteristic morphology, spatial conformation and structure adjustment affected heat-induced gelation and interfacial adsorption behavior. Spatial conformation and microstructure were adjusted to improve the oil and water retention by pH, ionic strength, amino acid, oil phase characteristic and protein interaction. Multi-layer hydrogels facilitated oil and water retention. The comprehensive review of gelation and emulsification mechanisms could promote the development of meat products and improvement of meat processing technology.

Effects of pre-emulsified safflower oil with magnetic field modified soy 11S globulin on the gel, rheological, and sensory properties of reduced-animal fat pork batter

In this work, the differences in macrostructure and microstructure, rheology, and storage stability of pre-emulsified safflower oil (PSO) prepared by natural and magnetic field modified soy 11S globulin were analysised. It was concluded that the PSO with magnetic field modified soy 11S globulin (MPSO) has better emulsifying activity and physical stability. The changes in gel quality, oxidational sensitivity, rheological, and sensory properties of pork batters with different substitute ratios (0%, 25%, 50%, 75%, and 100%) of pork back-fat by MPSO with magnetic field modified soy 11S globulin were studied. Compared to the sample without MPSO, pork batter with MPSO showed higher emulsion stability, apparent viscosity, L^⁎ value, springiness, cohesiveness, and expressible moisture, while lower a^⁎ value and cooking loss. Moreover, added MPSO could be more uniformly distributed into the meat matrix with smaller holes. With the increase in the replacement proportion of pork back-fat, the hardness, water- and fat-holding capacity, and P₂₁ of pork batter significantly decreased (P < 0.05). As revealed by sensory evaluation and TBARS, using MPSO to substitute for pork back-fat decreased the lipid oxidational sensitivity of pork batter, and without negative effects on the appearance, juiciness and overall acceptability. Overall, it is feasible to apply MPSO as a pork-fat replacer to produce reduced-animal fat pork batter with excellent gel and sensory properties.

Sous-vide cooking as a practical strategy to improve quality attributes and shelf stability of reduced-salt chicken breast ham

The objective of this study was to evaluate the general quality attributes and shelf stability of reduced-salt and sous-vide cooked chicken breast hams during 4 weeks of refrigerated storage (4°C). Four treatment groups of chicken breast ham were prepared using a 2 (salt level, 1.5% NaCl (regular) and 0.75% (reduced)) × 2 (cooking method, conventional and sous-vide) factorial arrangement. Based on each chicken breast weight, 20% NaCl solution was injected. Conventional cooking was done at 80°C until the core temperature reached 71°C, whereas sous-vide cooking was conducted at 60°C for 2 h. Sous-vide cooking could decrease cooking loss and shear force of reduced-salt chicken breast ham (P < 0.05). As a result, sensory scores for juiciness and tenderness of reduced-salt and sous-vide cooked chicken breast ham were similar to those of regular-salt and conventionally cooked chicken breast hams (P > 0.05). No adverse impacts on lipid oxidation and microbial safety were found in reduced-salt and sous-vide cooked chicken breast ham during 4 wk of refrigerated storage. Therefore, this study suggests that sous-vide cooking could be a practical thermal process for improving the water-holding capacity and texture of chicken breast ham without adverse impacts on shelf stability. Further studies on the combined application of sous-vide cooking with salt replacers would be warranted to improve the sensorial acceptance of saltiness of sous-vide cooked low-salt meat products.

Gel-type emulsified muscle products: Mechanisms, affecting factors, and applications

The gel-type emulsified muscle products improve fatty acid composition, maintain the oxidative stability, and achieve a better sensory acceptability. This review emphasizes the stabilization mechanisms of these emulsified muscle products. In particular, factors associated with the stability of the emulsified muscle systems are outlined, including the processing conditions (pH and heating), lipids, and emulsifiers. Besides, some novel systems are further introduced, including the Pickering emulsions and organogels, due to their great potential in stabilizing emulsified gels. Moreover, the promising prospects of emulsion muscle products such as improved gel properties, oxidative stability, freeze-thaw stability, fat replacement, and nutraceutical encapsulation were elaborated. This review comprehensively illustrates the considerations on developing gel-type emulsified products and provides inspiration for the rational design of emulsified muscle formulations with both oxidatively stable and organoleptically acceptable performance.

Use of Olive and Sunflower Oil Hydrogel Emulsions as Pork Fat Replacers in Goat Meat Burgers: Fat Reduction and Effects in Lipidic Quality

Diversified strategies to incorporate healthier lipids in processed meat products are being developed. Alternative fat sources to replace animal fat associated with the reduction of fat content are some of the methods used to obtain healthier meat products well recognized by consumers. In order to create a healthier product that can also be consumed in the Halal and Kosher consumer markets, an experimental study was developed to assess the effects of replacing the pork fat (4%) with the same amount of hydrogel emulsion incorporating olive oil or sunflower oil. Three burgers were randomly selected from each lot manufactured and analyzed in triplicate. Burgers were physicochemical analyzed for pH, water activity, composition, fatty acid profile, color, yield, texture, oxidative stability, and volatile compounds and compared according to the fat source. Burgers with hydrogel emulsions can be considered reduced-fat meat products with a healthier fatty acid profile than pork fat burgers. The use of hydrogel emulsions did not negatively affect the quality characteristics assessed in the product and improved the oxidative stability during the storage of cooked burgers. By the characteristics and formulations evaluated, the replacement of pork fat with olive oil hydrogel emulsion proved to be the most effective strategy for obtaining a healthier goat meat product.

Natural Antimicrobials: A Clean Label Strategy to Improve the Shelf Life and Safety of Reformulated Meat Products

Meat is a nutrient-rich matrix for human consumption. However, it is also a suitable environment for the proliferation of both spoilage and pathogenic microorganisms. The growing demand to develop healthy and nutritious meat products with low fat, low salt and reduced additives and achieving sanitary qualities has led to the replacement of the use of synthetic preservatives with natural-origin compounds. However, the reformulation process that reduces the content of several important ingredients (salt, curing salts, etc.), which inhibit the growth of multiple microorganisms, greatly compromises the stability and safety of meat products, thus posing a great risk to consumer health. To avoid this potential growth of spoiling and/or pathogenic microorganisms, numerous molecules, including organic acids and their salts; plant-derived compounds, such as extracts or essential oils; bacteriocins; and edible coatings are being investigated for their antimicrobial activity. This review presents some important compounds that have great potential to be used as natural antimicrobials in reformulated meat products.

Effect of Oudemansiella raphanipies Powder on Physicochemical and Textural Properties, Water Distribution and Protein Conformation of Lower-Fat Pork Meat Batter

The effects of the addition of different amounts (0%, 1%, 2%, 3% and 4%) of Oudemansiella raphanipies powder (ORP) to lower-fat pork batter on its physicochemical, textural and rheological properties, water distribution and protein conformation were evaluated. The results showed that the addition of ORP from 0% to 4% significantly decreased the pH and L* value of pork batter (p < 0.05); however, it also increased the a* value and enhanced the cooking yield of pork batter from 77% to 92%. Pork batter with 1−2% ORP added had an improved texture profile and a higher storage modulus (G’), but the addition of 3−4% ORP resulted in an inferior texture of pork batter and G’. LF-NMR showed that the addition of ORP significantly increased the peak area ratio of immobile water and reduced the peak area ratio of free water (p < 0.05). ORP significantly affected protein secondary structure of pork batter. The α-helix content of pork batter with 1−2% ORP decreased and β-sheet content increased. Overall, the addition level of 1−2% ORP effectively improved the texture and water holding capacity of lower-fat emulsified sausage and provides a new reference for developing nutritional meat products.