Production of ostrich meat pâtés: Design of a food safety management system

In recent years, there has been a growing interest in ostrich breeding, and the commercial breeding of these birds has attracted the attention of new breeders, and it has become a great alternative to agricultural production. The study on the production of pâtés was conducted in 2019 in Almaty (Kazakhstan). During the formation of two new formulations of pâtés, the following safety system parameters were taken into account: microflora development; oxidation number (intensity of oxidation products accumulation). The aim of the study is to obtain the optimal characteristics of ostrich meat preservation in the production of pâtés. As a result of the study, it was found that ostrich meat samples have high nutritional value. Meat is characterized by a high content of protein, low content of fat, and carbohydrates are almost absent. Also, it was found that concentration of arachidonic acid in ostrich meat was 3 times higher as compared to beef (p ≤ 0.05). Therefore, the introduction of inulin and carrageenan polysaccharides into the recipe of ostrich pâtés allows one to significantly improve their shelf life and based on the developed recipe it is possible to start the production of pâtés.

Effect of different vacuum levels for beef brisket during cold storage: A microbiological and physicochemical analysis

Effect of packaging at different vacuum levels such as 7.2 Pa (99.99% vacuum), 30 kPa (70.39%), 70 kPa (30.91%), and 101.33 kPa (0%, atmospheric condition) using a specially designed airtight container on physicochemical and microbial properties of beef brisket cuts during cold storage was investigated. Dramatic pH increase was found only in air atmospheric packaging. Higher vacuum level yielded higher water holding capacity and lower volatile basic nitrogen (VBN), 2-thiobarbituric acid (TBA), and growth rate of aerobic bacteria and coliforms, whereas the fatty acid composition showed no difference among various vacuum levels. The highest vacuum level (7.2 Pa) yielded no increases in VBN, TBA, and coliform and the least increase in aerobe counts. For bacterial communities, higher vacuum levels yielded higher proportions of Leuconostoc, Carnobacterium, and lactobacilli belonging to the phylum Firmicutes and lower proportions of Pseudomonas belonging to the phylum Proteobacteria. Predictive curves for bacterial communities showed that just a little oxygen significantly affects the bacterial dominance based on different oxygen dependence of individual bacteria and their logarithmic changes by vacuum level.

Impact of Gamma Irradiation and Kale Leaf Powder on Amino Acid and Fatty Acid Profiles of Chicken Meat under Different Storage Intervals

The present study was planned to determine the effect of kale leaf powder and gamma rays on variations in the pH, amino acid and fatty acid profiles of chicken meat at different storage intervals. Significant changes (p ≤ 0.05) in the pH, amino acid and fatty acid profiles of chicken meat following different treatments (KLP (1% and 2%) and gamma irradiation (3k Gy)) were reported at 0, 7 and 14 days of storage. The pH value of the chicken meat sample decreased with the addition of kale leaf powder, whereas the value increased following a gamma irradiation dose of 3 kGy and with the passage of time. During different storage intervals, the minimum reduction in the amino acid and fatty acid quantities in the chicken meat samples was reported after gamma irradiation treatment. However, with the addition of KLP, the amount of amino acids and fatty acids in the chicken meat samples increased. Conclusively, the pH was observed to be reduced in the meat following combined treatment (irradiation + KLP), whereas the 2% KLP treatment improved the amino acid and fatty acid profiles of the chicken samples.

The Activity of Chosen Antioxidant Enzymes in Ostrich Meat in Relation to the Type of Packaging and Storage Time in Refrigeration

The aim of the study was to investigate the changes in the activity of antioxidant enzymes, i.e., superoxide dismutase (SOD), glutathione peroxidase (GPx) and glutathione reductase (GR), and 2,2-diphenyl-1-picrylhydrazyl (DPPH) free radical scavenging activity in ostrich meat, as influenced by various packaging systems and storage time under refrigeration. Three packaging methods were used: vacuum packaging (VP) and modified atmosphere packaging (MAP) in two combinations of gases, MAP1 (40% O₂/40% CO₂/20% N₂) and MAP2 (60% O₂/30% CO₂/10% N₂). Meat samples were taken from the M. ilifibularis (IF) muscles of eight ostriches in each treatment group. The meat samples were stored in a refrigerator in 2 °C and analyzed at days 0, 4, 8, 12 and 16. The lowest level of SOD activity during storage was observed in ostrich muscles packed in vacuum, as compared to MAP1 and MAP2. In turn, the highest increase in GPx activity was recorded in VP, especially up to day 8 of storage, when this parameter reached maximum value (54.37). GR increased up to the eighth day of storage in MAP1 and VP. Between the 12th and 16th days of storage, stabilization of the GR activity level was observed only in VP, while under MAP1, it further decreased. DPPH remained relatively stable until the eighth day of storage and after this period, a decrease in this parameter was recorded, reaching the lowest value on day 12 for all types of packaging systems.

The Anti-Inflammatory Effect of a γ-Lactone Isolated from Ostrich Oil of Struthio camelus (Ratite) and Its Formulated Nano-Emulsion in Formalin-Induced Paw Edema

The ostrich oil of Struthio camelus (Ratite) found uses in folk medicine as an anti-inflammatory in eczema and contact dermatitis. The anti-inflammatory effect of a γ-lactone (5-hexyl-3H-furan-2-one) isolated from ostrich oil and its formulated nano-emulsion in formalin-induced paw edema was investigated in this study. Ostrich oil was saponified using a standard procedure; the aqueous residue was fractionated, purified, and characterized as γ-lactone (5-hexyl-3H-furan-2-one) through the interpretation of IR, NMR, and MS analyses. The γ-lactone was formulated as nano-emulsion using methylcellulose (MC) for oral solubilized form. The γ-lactone methylcellulose nanoparticles (γ-lactone-MC-NPs) were characterized for their size, shape, and encapsulation efficiency with a uniform size of 300 nm and 59.9% drug content. The γ-lactone was applied topically, while the formulated nanoparticles (NPs) were administered orally to rats. A non-steroidal anti-inflammatory drug (diclofenac gel) was used as a reference drug for topical use and ibuprofen suspension for oral administration. Edema was measured using the plethysmograph method. Both γ-lactone and γ-lactone-MC-NPs showed reduction of formalin-induced paw edema in rats and proved to be better than the reference drugs; diclofenac gel and ibuprofen emulsion. Histological examination of the skin tissue revealed increased skin thickness with subepidermal edema and mixed inflammatory cellular infiltration, which were significantly reduced by the γ-lactone compared to the positive control (p-value = 0.00013). Diuretic and toxicity studies of oral γ-lactone-MC-NPs were performed. No diuretic activity was observed. However, lethargy, drowsiness, and refusal to feeding observed may limit its oral administration.

Physical Characteristics and Microbial Quality of Ostrich Meat in Relation to the Type of Packaging and Refrigerator Storage Time

The aim of this study was to evaluate the effect of the packaging system type on the physical characteristics and microbial changes in ostrich meat during refrigerated storage. The applied packaging systems were vacuum packaging (VP) and modified atmosphere packaging (MAP) using two combinations of gases: MAP1 (40% O₂/40% CO₂/20% N₂) and MAP2 (60% O₂/30% CO₂/10% N₂). Eight meat samples were obtained in three replicates for all parameters, except for pH, for which six replicates were obtained from the M. ilifibularis (IF) muscle, and were stored in a refrigerator at 2 °C and analyzed at 0, 4, 8, 12 and 16 days for the effect of packaging methods on physical meat quality. The initial pH (5.99) decreased at the end of the storage time for MAP1 to 5.81, whereas VP was stable from day 0 to 12 and increased up to 6.08 on day 16. Regarding meat color, the L* value increased during storage for MAP1 and MAP2 from 36.99 to 40.75 and 41.60, respectively, whereas it declined for VP to 34.22. The same tendencies were reported for redness (a*) and yellowness (b*). Drip loss was the lowest in MAP1 and highest in VP. The lowest total viable bacteria counts were identified in VP, as compared to MAP1 and MAP2.

Evaluation of the Spoilage-Related Bacterial Profiles of Vacuum-Packaged Chilled Ostrich Meat by Next-Generation DNA Sequencing Approach

Monitoring the development of the bacterial community in packaged raw meat refrigerated until two weeks is important for identifying the spoilage-related bacteria, preventing meat putrefaction, and prolong the shelf life. This study aimed to evaluate the influence of vacuum-packaging (VP) on the development of spoilage-related bacterial profiles in chilled ostrich meat among three manufacturing batches produced in different periods by using culture-dependent and 16S rDNA amplicon sequencing. Similar to the culture-dependent method, 16S rDNA sequencing showed that Photobacterium was the most prevalent genus detected in VP ostrich meat after 14 days of cold storage. The second-largest group was the population of lactic acid bacteria (LAB), mainly dominated by Carnobacteriaceae including Carnobacterium spp. and Lactobacillaceae with Lactobacillus spp. Our results suggest that these taxa could contribute to spoilage of VP ostrich meat and shorten its shelf life, especially Photobacterium spp., which is considered as a potential meat spoiler.

The influence of age and gender on emu (Dromaius novaehollandiae) fat

Studies were carried out to determine the influence of age and sex on two types of fat (back fat and abdominal fat) in the emu, as these are factors that influence the composition of animal tissues. The material involved 26 emus at the age 1 (6 males), 3 (6 males) and 15 years (8 females and 6 males), kept on the same farm and fed the feed of the same nutritional value. The basic chemical composition, cholesterol and mineral content, as well as fatty acid profile of back and abdominal fat of emu were determined. Abdominal fat was characterized by higher content of fat and ash, as well as Mn and Ba. Back fat, on the other hand, showed a higher level of protein, cholesterol, C16:1 and the elements K, P, Si, Na, Ca, Mg, Fe, Zn, Se and Cu. With age, regardless of the type of fat tissue, fat content decreased and water content increased. The highest content of protein, ash, cholesterol, some fatty acids (C18:0, C18:1n9c, C18:2n6c), generally higher content of MUFA, PUFA and the elements K, P, Ca, Mg, Fe, Zn, Pb, Se, Cr, Cd, were found in the fatty tissue of 15-year-old emus. Sex did influence the content of Si, Ca, Cu, Sr, which was higher in the fatty tissue of males. The composition of emu storage fat is determined by factors such as age, sex and the location of the fat tissue in the body.

The Composition of Fatty Acids in Ostrich Meat Influenced by the Type of Packaging and Refrigerated Storage

Ostrich meat is a high-quality dietetic product, however, it is very sensitive to deterioration during storage. The aim of this study was to assess the effect of packaging systems on the fatty acid (FA) profiles in ostrich meat during refrigerated storage. The systems were: Vacuum packaging (VP) and modified atmosphere packaging (MAP) in two combinations of gases: MAP1 (40% O₂/40% CO₂/20% N₂) and MAP2 (60% O₂/30% CO₂/10% N₂). Samples were taken from the M. ilifibularis (IF) muscles of eight ostriches in each treatment group. The packs were stored in a refrigerator at 2 °C and analyzed at 0, 4, 8, 12 and 16 days. The packaging conditions and storage time had an impact on the concentration of bioactive compounds such as polyunsaturated fatty acids (PUFA), including n-3 such as C18:3, C20:5 (EPA) and C22:6 (DHA). The least changes in composition of n-3 and the sum of PUFA were recorded in ostrich meat packaged in vacuum, followed by that packaged using MAP1 and MAP2. The sum of n-6 PUFAs decreased significantly by 2.1% for MAP2, and only by 0.7% for vacuum packaging as the experiment progressed. A significant deterioration of these compounds was observed in all package systems, especially from day 12 until day 16 of storage.

Meat quality traits in the Greater rhea (Rhea americana) as influenced by muscle, sex and age

Meat from the Greater rhea (Rhea americana) could compete with traditional red meats, diversifying the market of protein products of animal origin. The meat from 32 rheas was used to study quality aspects and this included ultimate pH (pHu), color, water-holding capacity (WHC%), cooking loss (CL%) and tenderness. The muscles sampled were the Gastrocnemius pars externa, Iliofibularis and Obturatorius medialis from both sexes at multiple ages (10, 12, 14, 16 months). Age at slaughter affected WHC%, CL%, and color in raw meat and tenderness in cooked meat. Muscles under study showed differences in terms of pHu, raw meat color, and tenderness of cooked meat. Sex did not have a significant effect on any of the variables studied. According to our results, rhea meat from younger animals, between 10 to 14 months old, was tender and moderately juicy and the visual color was appreciated by the consumers.

The Effect of PUFA-Rich Plant Oils and Bioactive Compounds Supplementation in Pig Diet on Color Parameters and Myoglobin Status in Long-Frozen Pork Meat

The study evaluated the effect of pig diet supplementation with rapeseed or linseed oil, and vitamin E or selenium, or both vitamin E and selenium on color parameters and myoglobin content of pork Semimembranosus muscle after long-term freezing storage during nine months. The influence of the type of the bioactive compounds added to pig diet on the content of myoglobin or oxymyoglobin, metmyoglobin and deoksymyoglobin in Semimembranosus m. was also assessed. The results indicate that the presence of oils rich in polyunsaturated fatty acids (PUFA) in pig diet improves the color of pork meat. Supplementation of dietary plant oils or dietary oils with antioxidants tended to increase significantly the concentration of oxymyoglobin and decrease the concentration of metmyoglobin in meat compared to the control group. The highest content of oxymyoglobin was observed in meat obtained from pigs fed diets with linseed oil. The best color scores (highest a* parameter) was noted for rapeseed oil group (with no addition of antioxidants). In conclusion, the addition of antioxidants to pigs’ forage supplemented with PUFA-rich oils is not recommended in order to improve color of long-term frozen pork.

Bioactive Compounds in Functional Meat Products

Meat and meat products are a good source of bioactive compounds with positive effect on human health such as vitamins, minerals, peptides or fatty acids. Growing food consumer awareness and intensified global meat producers competition puts pressure on creating new healthier meat products. In order to meet these expectations, producers use supplements with functional properties for animal diet and as direct additives for meat products. In the presented work seven groups of key functional constituents were chosen: (i) fatty acids; (ii) minerals; (iii) vitamins; (iv) plant antioxidants; (v) dietary fibers; (vi) probiotics and (vii) bioactive peptides. Each of them is discussed in term of their impact on human health as well as some quality attributes of the final products.

Effects of Packaging Methods on Shelf Life of Ratite Meats

Over the last years a growing demand for ratite meat, including ostrich, emu, and rhea has been observed in the world. Ratite meat is recognised as a dietetic product because of low level of fat, high share of PUFA, favourable n6/n3 ratio, and higher amounts of iron content in comparison with beef and chicken meat. The abundance of bioactive compounds, e.g. PUFA, makes ratite meat highly susceptible to oxidation processes. Moreover, pH over 6 creates favourable environment for fast microbial growth during storage conditions affecting its shelf life. However, availability of information on ratite meat shelf life among consumers and industry is still limited. Thus, the aim of the present review is to provide current information about the effect of ratite meat packaging type, i.e. air packaging, vacuum packaging with skin pack, modified atmosphere packaging (MAP), on its shelf life quality during storage, including technological and nutritional properties.