1
|
Pagano M, Hernando H, Cueto J, Serrano DP, Moreno I. Maximizing aromatic hydrocarbon production through catalytic pyrolysis of lignocellulosic residues over ZSM-5 zeolite using both batch and continuous reaction systems. BIORESOURCE TECHNOLOGY 2025; 423:132212. [PMID: 39947260 DOI: 10.1016/j.biortech.2025.132212] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/09/2024] [Revised: 01/28/2025] [Accepted: 02/09/2025] [Indexed: 02/28/2025]
Abstract
This study investigates the influence of lignocellulosic biomass properties on aromatic hydrocarbon (AR) production by catalytic pyrolysis using a ZSM-5 zeolite as catalyst in a fixed-bed reactor. First, using a batch reaction system, vine and olive pruning, oak, and wheat straw were tested as feedstocks. A high lignin content in the biomass increased both char yield and bio-oil oxygen content, although not affecting AR production. In contrast, a high alkali and alkaline metal content reduced the AR yield. Oak was selected for the catalyst-bed temperature optimisation in a continuous reactor, as this biomass led to a low char yield and a bio-oil with a reduced oxygen content and a significant AR share. The highest AR carbon yield (15.1 wt% during the first hour of reaction) was achieved at 450 °C. Higher temperatures (500 °C) promoted severe cracking reactions leading to gases, while lower temperatures (400 °C) provoked a faster catalyst deactivation due to enhanced deposition of carbonaceous matter with a higher concentration of oxygenated oligomeric/heavy species. AR formation from light oxygenates, followed by the oligomerization/cyclization/aromatization pathway, is affected earlier along the time on stream than through Diels-Alder condensation reactions.
Collapse
Affiliation(s)
- Maurizio Pagano
- Thermochemical Processes Unit, IMDEA Energy Institute, Avda. Ramón de la Sagra, 3, 28935 Móstoles, Madrid, Spain; Chemical and Environmental Engineering Group, Rey Juan Carlos University, c/Tulipán, s/n, 28933 Móstoles, Madrid, Spain
| | - Héctor Hernando
- Thermochemical Processes Unit, IMDEA Energy Institute, Avda. Ramón de la Sagra, 3, 28935 Móstoles, Madrid, Spain
| | - Jennifer Cueto
- Thermochemical Processes Unit, IMDEA Energy Institute, Avda. Ramón de la Sagra, 3, 28935 Móstoles, Madrid, Spain
| | - David P Serrano
- Thermochemical Processes Unit, IMDEA Energy Institute, Avda. Ramón de la Sagra, 3, 28935 Móstoles, Madrid, Spain; Chemical and Environmental Engineering Group, Rey Juan Carlos University, c/Tulipán, s/n, 28933 Móstoles, Madrid, Spain
| | - Inés Moreno
- Thermochemical Processes Unit, IMDEA Energy Institute, Avda. Ramón de la Sagra, 3, 28935 Móstoles, Madrid, Spain; Chemical and Environmental Engineering Group, Rey Juan Carlos University, c/Tulipán, s/n, 28933 Móstoles, Madrid, Spain.
| |
Collapse
|
2
|
Hoang AT, Nguyen XP, Duong XQ, Ağbulut Ü, Len C, Nguyen PQP, Kchaou M, Chen WH. Steam explosion as sustainable biomass pretreatment technique for biofuel production: Characteristics and challenges. BIORESOURCE TECHNOLOGY 2023; 385:129398. [PMID: 37385558 DOI: 10.1016/j.biortech.2023.129398] [Citation(s) in RCA: 32] [Impact Index Per Article: 16.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/11/2023] [Revised: 06/23/2023] [Accepted: 06/24/2023] [Indexed: 07/01/2023]
Abstract
The biorefining process of lignocellulosic biomass has recently emerged as one of the most profitable biofuel production options. However, pretreatment is required to improve the recalcitrant lignocellulose's enzymatic conversion efficiency. Among biomass pretreatment methods, the steam explosion is an eco-friendly, inexpensive, and effective approach to pretreating biomass, significantly promoting biofuel production efficiency and yield. This review paper critically presents the steam explosion's reaction mechanism and technological characteristics for lignocellulosic biomass pretreatment. Indeed, the principles of steam explosion technology for lignocellulosic biomass pretreatment were scrutinized. Moreover, the impacts of process factors on pretreatment efficiency and sugar recovery for the following biofuel production were also discussed in detail. Finally, the limitations and prospects of steam explosion pretreatment were mentioned. Generally, steam explosion technology applications could bring great potential in pretreating biomass, although deeper studies are needed to deploy this method on industrial scales.
Collapse
Affiliation(s)
- Anh Tuan Hoang
- Institute of Engineering, HUTECH University, Ho Chi Minh City, Viet Nam
| | - Xuan Phuong Nguyen
- PATET Research Group, Ho Chi Minh City University of Transport, Ho Chi Minh City, Viet Nam
| | - Xuan Quang Duong
- Institute of Mechanical Engineering, Vietnam Maritime University, Haiphong, Viet Nam
| | - Ümit Ağbulut
- Department of Mechanical Engineering, Faculty of Engineering, Duzce University, 81620, Düzce, Türkiye
| | - Christophe Len
- PSL Research University, Chimie ParisTech, CNRS, Paris Cedex 05, France
| | - Phuoc Quy Phong Nguyen
- PATET Research Group, Ho Chi Minh City University of Transport, Ho Chi Minh City, Viet Nam
| | - Mohamed Kchaou
- Department of Mechanical Engineering, College of Engineering, University of Bisha, P.O. Box 1, Bisha, Saudi Arabia
| | - Wei-Hsin Chen
- Department of Aeronautics and Astronautics, National Cheng Kung University, Tainan 701, Taiwan; Research Center for Smart Sustainable Circular Economy, Tunghai University, Taichung 407, Taiwan; Department of Mechanical Engineering, National Chin-Yi University of Technology, Taichung 411, Taiwan.
| |
Collapse
|
3
|
Álvarez C, González A, Ballesteros I, Gullón B, Negro MJ. In Vitro Assessment of the Prebiotic Potential of Xylooligosaccharides from Barley Straw. Foods 2022; 12:foods12010083. [PMID: 36613299 PMCID: PMC9818743 DOI: 10.3390/foods12010083] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/14/2022] [Revised: 12/12/2022] [Accepted: 12/19/2022] [Indexed: 12/29/2022] Open
Abstract
Barley straw was subjected to hydrothermal pretreatment (steam explosion) processing to evaluate its potential as a raw material to produce xylooligosaccharides (XOS) suitable for use as a prebiotic. The steam explosion pretreatment generated a liquid fraction containing solubilised hemicellulose. This fraction was purified using gel permeation chromatography to obtain a fraction rich in XOS DP2-DP6. The sample was characterised through analytical techniques such as HPAEC-PAD, FTIR and MALDI-TOF-MS. The prebiotic activity was evaluated using in vitro fermentation in human faecal cultures through the quantification of short-chain fatty acid (SCFA) and lactate production, the evolution of the pH and the consumption of carbon sources. The total SCFA production at the end of fermentation (30 h) was 90.1 mM. Positive significant differences between the amount of XOS from barley straw and fructooligosaccharides after incubation were observed.
Collapse
Affiliation(s)
- Cristina Álvarez
- Advanced Biofuels and Bioproducts Unit, Department of Energy, Research Centre for Energy, Environment and Technology (CIEMAT), 28040 Madrid, Spain
- Correspondence: ; Tel.: +34-91-346-60-57
| | - Alberto González
- Advanced Biofuels and Bioproducts Unit, Department of Energy, Research Centre for Energy, Environment and Technology (CIEMAT), 28040 Madrid, Spain
| | - Ignacio Ballesteros
- Advanced Biofuels and Bioproducts Unit, Department of Energy, Research Centre for Energy, Environment and Technology (CIEMAT), 28040 Madrid, Spain
| | - Beatriz Gullón
- Department of Chemical Engineering, Faculty of Science, University of Vigo (Campus Ourense), As Lagoas, 32004 Ourense, Spain
| | - María José Negro
- Advanced Biofuels and Bioproducts Unit, Department of Energy, Research Centre for Energy, Environment and Technology (CIEMAT), 28040 Madrid, Spain
| |
Collapse
|
4
|
Evaluation and Identification of Key Economic Bottlenecks for Cost-Effective Microbial Oil Production from Fruit and Vegetable Residues. FERMENTATION-BASEL 2022. [DOI: 10.3390/fermentation8070334] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/04/2023]
Abstract
Intensive horticultural systems for the production of vegetables in greenhouses represent one of the main industries generating organic waste, as those that do not meet the quality standards for the fresh market or the processing industry are discarded. This highlights the importance of using these residues as raw material for other applications, such as bioenergy and bioproducts production, within the framework of a bio-based economy that maximizes the utilization of biomass resources in a sustainable manner. In this work, the microbial oil production from discarded pepper using the oleaginous yeast Cryptococcus curvatus was evaluated. Overall, a total lipid accumulation of 16.8 g/L was achieved with a fatty acid profile suitable to produce biodiesel. The lipid yield obtained was 0.12 g/g sugars. In addition, experimental results were used to assess the techno-economic feasibility of a proposed microbial oil plant using the software Aspen Plus. This plant yields approximately 96 kg of microbial oils/ton dry discarded pepper, with an estimated Minimum Selling Price of 7 €·kg−1. These figures point out the necessity of increasing the yield of microbial oil production and considering the utilization of possible by-products, such as mannitol and cell debris, to improve the economic performance of the process.
Collapse
|
5
|
Exploring Environmental and Economic Costs and Benefits of a Forest-Based Circular Economy: A Literature Review. FORESTS 2021. [DOI: 10.3390/f12040436] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
Abstract
The role of a forest sector in the transition to a circular economy (CE) is critical. Therefore, the purpose of this study is to summarize the main findings of the most important published articles and to provide insights on the interdisciplinary space at the interface of concepts related to a forest-based CE. Moreover, it attempts to assess the challenges raised from adopting the CE in forest sector. Through a systematic literature review, 69 scientific publications were selected and evaluated by two sights: (i) a descriptive analysis and (ii) a cluster analysis of the keywords related to the forest-based CE. The study highlights the need for additional survey on optimizing the interaction between forest ecosystem services and circular economy. Further discussion is also needed about the relations of the key factors associated with the forest-based circular economy, as they emerged from the cluster analysis and the co-occurrence network map.
Collapse
|
6
|
Advanced Bioethanol Production: From Novel Raw Materials to Integrated Biorefineries. Processes (Basel) 2021. [DOI: 10.3390/pr9020206] [Citation(s) in RCA: 33] [Impact Index Per Article: 8.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/21/2022] Open
Abstract
The production of so-called advanced bioethanol offers several advantages compared to traditional bioethanol production processes in terms of sustainability criteria. This includes, for instance, the use of nonfood crops or residual biomass as raw material and a higher potential for reducing greenhouse gas emissions. The present review focuses on the recent progress related to the production of advanced bioethanol, (i) highlighting current results from using novel biomass sources such as the organic fraction of municipal solid waste and certain industrial residues (e.g., residues from the paper, food, and beverage industries); (ii) describing new developments in pretreatment technologies for the fractionation and conversion of lignocellulosic biomass, such as the bioextrusion process or the use of novel ionic liquids; (iii) listing the use of new enzyme catalysts and microbial strains during saccharification and fermentation processes. Furthermore, the most promising biorefinery approaches that will contribute to the cost-competitiveness of advanced bioethanol production processes are also discussed, focusing on innovative technologies and applications that can contribute to achieve a more sustainable and effective utilization of all biomass fractions. Special attention is given to integrated strategies such as lignocellulose-based biorefineries for the simultaneous production of bioethanol and other high added value bioproducts.
Collapse
|
7
|
Ultrasonically-Assisted Dissolution of Sugarcane Bagasse during Dilute Acid Pretreatment: Experiments and Kinetic Modeling. ENERGIES 2020. [DOI: 10.3390/en13215627] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/11/2022]
Abstract
Ultrasonic irradiation is known to enhance various physicochemical processes. In this work, the effect of ultrasound on the dissolution of sugarcane bagasse was studied, with the specific aims of quantifying the effect at low solids loading and mild reaction conditions, and determining whether the enhancement of dissolution by ultrasound is independent of temperature. The effects of agitation speed, reaction time, and sonication were examined on the dissolution of the biomass substrate at varying reaction temperatures during the pretreatment process. Sugarcane bagasse was mixed with a 0.3 M solution of sulfuric acid in a reaction vessel to undergo pretreatment. A kinetic model was applied to the mass dissolution of the biomass, as sonicated runs showed higher mass losses at each reaction time, compared to the non-sonicated runs. The ultrasonic enhancement in mass dissolution was seen to increase for an increase in the reaction time. It was observed that the induction period for the dissolution was eliminated by the application of ultrasound. Ultrasound was found to be more effective than temperature at enhancing mass dissolution at low solids loadings, and the effect of ultrasound was also found to be dependent on the temperature employed.
Collapse
|