Direct microscopic observation and viability determination of Campylobacter jejuni on chicken skin

Status quo: Levels of Campylobacter spp. and hygiene indicators in German slaughterhouses for broiler and turkey

Poultry is a common reservoir for Campylobacter and a main source for human campylobacteriosis. With broiler being the predominant poultry for food production, most food safety related research is conducted for this species, for turkey, few studies are available. Although animals are typically colonized at the farm level, the slaughtering process is considered an important factor in re- and cross-contamination. We examined the development of Campylobacter, E. coli and total colony counts (TCC) after several processing steps in three broiler and one turkey slaughterhouses. Whole carcass rinsing and neck skin sampling was applied for broilers resulting in 486 samples in total, while 126 neck skin samples were collected for turkeys. A decrease in the loads of the different bacterial groups along the broiler slaughtering process was observed. Campylobacter mean counts dropped from 4.5 ± 1.7 log10 CFU/ml after killing to 1.6 ± 0.4 log10 CFU/ml after chilling. However, an increase in Campylobacter counts was evident after evisceration before the values again decreased by the final processing step. Although the Campylobacter prevalence in the turkey samples showed a similar development, the bacterial loads were much lower with 1.7 ± 0.3 log10 CFU/g after killing and 1.7 ± 0.4 log10 CFU/g after chilling compared to those of broilers. The loads of E. coli and total colony count of turkey were higher after killing, were reduced by scalding and remained stable until after chilling. This study highlights trends during the slaughtering process in reducing the levels of Campylobacter, E. coli, and total colony counts for broiler and turkey carcasses, from the initial step to after chilling. These results contribute to our understanding of microbial dynamics during meat processing.

Combining antimicrobial substances for Campylobacter post harvest mitigation on chicken breast fillet and chicken skin - any synergistic effects?

AIMS

To reduce Campylobacter along the food chain, we investigated the mitigation potential of four antimicrobial compounds against Campylobacter using a new evaluation scheme.

METHODS AND RESULTS

Using the checkerboard method, the minimum inhibitory concentration (MIC) values of two organic acids (peroxyacetic acid and lactic acid) and two plant extracts (carvacrol and resveratrol) against a C. jejuni and a C. coli field isolate were determined as well as the fractional inhibitory concentration (FIC) indices of combined treatment. The lowest MIC values were found for peroxyacetic acid (0.03 mg mL-1) and carvacrol (0.06 mg mL-1). Based on subsequent sensory studies, peroxyacetic acid and carvacrol were selected for challenge tests to quantitatively determine the reducing potential against Campylobacter on chicken meat and chicken skin. Applying peroxyacetic acid significantly reduced Campylobacter counts on chicken skin with maximum reductions of 3.3 log-units (P < .0001), while the combination of peroxyacetic acid and carvacrol resulted in significant reductions of only 0.4 log-units on chicken breast fillet 24 hours after treatment but not thereafter (P = .0192).

CONCLUSIONS

Peroxyacetic acid is suitable as a postharvest intervention measure to reduce Campylobacter concentration on chicken skin without reducing consumer acceptance.

Prevalence, Tetracycline Resistance and Tet(O) Gene Identification in Pathogenic Campylobacter Strains Isolated from Chickens in Retail Markets of Lima, Peru

Background: In this study, we aimed to estimate the prevalence, tetracycline resistance and presence of Tet(O) in Campylobacter strains isolated from chicken in markets of Lima, Peru. Methods: A total of 250 chicken samples were obtained from traditional markets (skin, n = 120) and supermarkets (meat, n = 130). Samples were subjected to microbiological assays for identification of Campylobacter spp. according to ISO 10272-2017, and the isolates were then submitted to species identification by PCR. Phenotypic resistance to tetracyclines was assessed by the Kirby−Bauer test, and the presence of the Tet(O) gene was determined by PCR. Results: A significantly higher prevalence (p < 0.0001) of Campylobacter coli in skin samples from traditional markets (97.5%) than in meat samples from supermarkets (36.2%) was observed. On the other hand, Campylobacter jejuni was confirmed only in 3.1% of meat samples. All Campylobacter species isolated from skin and meat samples were phenotypically resistant to tetracyclines; however, the presence of the Tet(O) gene in C. coli was identified in 76.9% and 66.0% of skin and meat samples, no significant statistical difference (p = 0.1488) was found between these prevalence. All C. jejuni isolated from chicken meat samples from supermarkets were positive for Tet(O) gene. Conclusions: This study confirms the high prevalence of C. coli isolated from chicken sold in traditional markets and supermarkets in Lima, Peru, and in more than 70% of these strains, phenotypic resistance to tetracyclines could be linked with expression of the Tet(O) gene. It is necessary to evaluate other genes involved in resistance to tetracyclines and other groups of antibiotics in campylobacter strains isolated from chicken meat.

Select Phytochemicals Reduce Campylobacter jejuni in Postharvest Poultry and Modulate the Virulence Attributes of C. jejuni

Consumption or handling of poultry and poultry products contaminated with Campylobacter species are a leading cause of foodborne illness in humans. Current strategies employed to reduce Campylobacter in live chickens provide inconsistent results indicating the need for an alternative approach. This study investigated the efficacy of phytochemicals, namely, turmeric, curcumin, allyl sulfide, garlic oil, and ginger oil, to reduce Campylobacter jejuni in postharvest poultry and sought to delineate the underlying mechanisms of action. Two experiments were conducted on the thigh skin of the chicken, and each experiment was repeated twice. Samples were inoculated with 50 μl (∼10⁷ CFU/sample) of C. jejuni strain S-8 and allowed to adhere for 30 min. Skin samples were dipped into their respective prechilled treatment solutions (0.25 and 0.5% in experiments 1 and 2, respectively) at 4°C for an hour to simulate chilling tank treatment, followed by plating to enumerate C. jejuni (n = 3 samples/treatment/trial). The mechanisms of action(s) were investigated using subinhibitory concentration (SIC) in adhesion, quorum sensing, and gene expression analyses. Adhesion assay was conducted on the monolayers of ATCC CRL-1590 chicken embryo cells challenged with C. jejuni and incubated in the presence or absence of phytochemicals for 1.5 h, followed by plating to enumerate adhered C. jejuni. The effects of phytochemicals on quorum sensing and cell viability were investigated using Vibrio harveyi bioluminescence and LIVE/Dead BacLight^TM bacterial viability assays, respectively. In addition, droplet digital PCR determined the gene expression analyses of C. jejuni exposed to phytochemicals. Data were analyzed by GraphPad Prism version 9. C. jejuni counts were reduced by 1.0–1.5 Log CFU/sample with garlic oil or ginger oil at 0.25 and 0.5% (p < 0.05). The selected phytochemicals (except curcumin) reduced the adhesion of C. jejuni to chicken embryo cells (p < 0.05). In addition, all the phytochemicals at SIC reduced quorum sensing of C. jejuni (p < 0.05). The cell viability test revealed that cells treated with 0.25% of phytochemicals had compromised cell membranes indicating this as a mechanism that phytochemicals use to damage/kill C. jejuni. This study supports that the application of phytochemicals in postharvest poultry would significantly reduce C. jejuni in poultry meat.

Rapid determination of viable but non-culturable Campylobacter jejuni in food products by loop-mediated isothermal amplification coupling propidium monoazide treatment

Campylobacter is the leading cause of foodborne human diarrhea worldwide. This microbe in the viable but non-culturable (VBNC) state can evade detection by routinely used culture-based methods and remain viable for extended periods of time. Bacteria in this dormancy state can resume their metabolic activity and virulence by resuscitation under favorable conditions, and subsequently cause infections. In this study, an assay combining loop-mediated isothermal amplification (LAMP) and propidium monoazide (PMA) treatment was developed for the detection and quantification of VBNC C. jejuni in agri-foods. PMA-qLAMP targeting the hipO gene demonstrated 100% high specificity to C. jejuni. A linear detection of C. jejuni was achieved between 8.77 × 102 and 8.77 × 07 CFU/mL with a coefficient of determination (R2) of 0.9956, indicating a good quantitative capacity. C. jejuni was effectively induced into the VBNC state by osmotic stress (i.e., 7% NaCl, w/v) over 48 h. VBNC C. jejuni cells were spiked into three representative food products and determined by PMA-qLAMP coupled with plating assay. The detection limits of PMA-qLAMP were 1.58 × 102 CFU/mL in milk, 3.78 × 102 CFU/g in chicken breast meat, and 4.33 × 102 CFU/g in romaine lettuce. PMA-qLAMP demonstrated rapid (25-40 min), specific (100% inclusivity and 100% exclusivity) and sensitive (~102 CFU/mL) determination of VBNC C. jejuni. This method can be applied in the agri-food industry to decrease the risks related to the consumption of contaminated agri-foods with pathogenic bacteria in the VBNC state and reduce the burden of C. jejuni infections to public health.

Evaluation of effect of chilling steps during slaughtering on the Campylobacter sp. counts on broiler carcasses

Campylobacter spp. play an increasing role as foodborne pathogens, with poultry representing the main vehicle of infection, and control measures at the slaughterhouse have been implemented in the last years. In this study, 2 trials were performed, evaluating the effect of the chilling phases currently applied in an industrial slaughterhouse on the Campylobacter sp. contamination of broiler carcasses. In the first trial, neck skin samples were taken from 13 flocks before and after the on-chain air chilling and submitted to analysis of Campylobacter sp. count; in the second trial, 63 carcasses or cuts stored in the chilling room for variable times, with or without skin, were submitted to analysis of Campylobacter sp. count. A selection of 75 isolates was identified by PCR. All carcass skin samples taken from the first trial showed Campylobacter sp. counts higher than 0.7 log cfu/g. A wide variability in the counts (about 3 logs) was detected, showing a high correlation between the counts obtained before and after chilling. A slight decrease (P = 0.011) was observed after chilling (mean difference of about 0.3 log cfu/g), also if variability was observed among the flocks; the number of samples with high Campylobacter sp. counts (≥3 log cfu/g) was reduced (P = 0.010). In the second trial, low counts were generally detected (almost all lower than 3 log cfu/g). An evident decreasing trend was observed during storage, but the survival rate of Campylobacter on the cuts with skin was higher. All the isolates were identified as Campylobacter jejuni (72%) or Campylobacter coli. The data obtained were compared with the threshold limit set by EC Regulation 2073/2005, evidencing the impact of the sampling point on the counts. Our results highlighted the importance of applying a hurdle strategy including on-chain chilling and strict respect of the cold chain, allowing the food business operator to fulfill the process hygiene criteria and avoiding the delivery of highly contaminated meats.

Detection and identification of adhesins involved in adhesion of Campylobacter jejuni to chicken skin

Campylobacter jejuni is the leading cause of bacterial food poisoning worldwide. Chickens are considered to be one of the major reservoirs of Campylobacter infection in humans due to colonization of their intestinal tract. When the chickens are slaughtered and processed, the entire skin of the carcass becomes contaminated with campylobacters. We observed that the number of C. jejuni attached to chicken skin was reduced significantly after treatment of the skin with sodium hydroxide followed by washing with PBS, implying that adhesion factors involved in binding to C. jejuni may exist on skin. Such potential binding-related proteins present in alkaline extracts of the skin surface were detected by a two-dimensional overlay assay and identified by liquid chromatography mass spectrometry (LC-MS). Chicken serum albumin (CSA) was identified as a major protein in these alkaline extracts and confirmed by ELISA to bind specifically to C. jejuni. Moreover, using the same approach, flagellar hook protein E (FlgE) and major outer membrane protein (MOMP) in C. jejuni were identified as bacterial adhesins that bound to the CSA. The ability to bind CSA was also confirmed using recombinant FlgE and MOMP of C. jejuni expressed in Escherichia coli. The present findings suggest that adhesins expressed on C. jejuni cells may bind specifically via proteins present on the skin, as well as by physical attachment.

Comparison of Campylobacter jejuni Slaughterhouse and Surface-Water Isolates Indicates Better Adaptation of Slaughterhouse Isolates to the Chicken Host Environment

Campylobacter jejuni is an emerging food-borne pathogen that poses a high risk to human health. Knowledge of the strain source can contribute significantly to an understanding of this pathogen, and can lead to improved control measures in the food-processing industry. In this study, slaughterhouse and surface-water isolates of C. jejuni were characterized and compared in terms of their antimicrobial resistance profiles and adhesion to stainless steel and chicken skin. Resistance of C. jejuni biofilm cells to benzalkonium chloride and Satureja montana ethanolic extract was also tested. The data show that the slaughterhouse isolates are more resistant to ciprofloxacin, and adhere better to stainless steel at 42 °C, and at 37 °C in 50% chicken juice. Additionally, biofilm cells of the isolate with the greatest adhesion potential (C. jejuni S6) were harvested and tested for resistance to S. montana ethanolic extract, benzalkonium chloride, and erythromycin; and for efflux-pump activity, as compared to their planktonic cells. The biofilm cells showed increased resistance to both S. montana ethanolic extract and erythromycin, and increased efflux-pump activity. These data indicate adaptation of C. jejuni slaughterhouse isolates to the chicken host, as well as increased biofilm cell resistance due to increased efflux-pump activity.

Prevalence of and Risk Factors for Campylobacter spp. Colonization of Broiler Chicken Flocks in Greece

The prevalence and risk factors for Campylobacter spp. colonization of broiler flocks and broiler carcass contamination in Greek slaughterhouses were investigated. Over a 14-month period, a pool of 10 ceca and 5 neck skin samples from chicken carcasses were collected from each of 142 batches of broiler flocks slaughtered in 3 different slaughterhouses. Information on potential risk factors for Campylobacter infection in broilers was collected by an on-farm interview and linked according to the Campylobacter contamination status of broiler flocks and differences in farm characteristics and management practices identified from questionnaires. Campylobacter spp. was isolated from 73.94% and 70.42% of ceca (95% CI 65.92-80.94) and carcasses (95% CI 62.19-77.78), respectively. A significant correlation (p < 0.001) between the presence of Campylobacter spp. in broiler ceca and contamination of carcasses was found, suggesting the spread of the microorganism on the skin of carcasses during the slaughtering procedure. A multiple logistic regression showed the disinfection of the poultry house being conducted by unskilled personnel (odds ratio [OR] ¼ = 3.983) as a significant risk factor (p < 0.05) and the use of straw litter as bedding material (OR ¼ = 0.170) and closure of windows during the intervals of production cycles (OR ¼ = 0.396) as significant protective factors (p < 0.05) for broiler flock contamination. These results are important and help further the understanding of the epidemiology of Campylobacter spp. derived from poultry in Greece.

Current Status of Campylobacter Food Poisoning in Japan

According to the annual food poisoning statistics compiled by the Ministry of Health, Labour and Welfare (MHLW) in Japan, Campylobacter replaced Salmonella and Vibrio parahaemolyticus as the leading bacterium responsible for food poisoning in 2003. Although in 2006 the number of cases of Campylobacter food poisoning was 3,439 on the basis of the MHLW statistics, it was estimated to be 1,545,363 on the basis of active surveillance, suggesting that passive surveillance yields an incidence about 450 times lower than that revealed by active surveillance. Epidemiological investigations of Campylobacter food poisoning in Japan have shown that chicken meat and its products are the most important sources of infection, as is the case in other industrialized nations. Over the last two decades, the consumption of fresh raw chicken meat and liver has been increasing in Japan. Although the MHLW recommends that chicken meat should only be eaten after thorough cooking, it is likely to account for much of the increased incidence of human campylobacteriosis. In response to this situation, the Expert Committee on Microorganisms/Viruses, Food Safety Commission of Japan, Cabinet Office, Government of Japan (FSCJ) has revised the previous risk profile of C. jejuni/coli in chicken meat by adding new findings for 2018. Moreover, the MHLW revised the Poultry Slaughtering Business Control and Poultry Meat Inspection Act in 2014 aiming at stepwise introduction of the Hazard Analysis Critical Control Point (HACCP) system into poultry processing plants. Subsequently, the Japanese government amended the Food Sanitation Act in 2018, requiring all food business operators to implement hygiene control based on HACCP principles as a general rule. This paper reviews the current status of Campylobacter food poisoning due to consumption of chicken meat in Japan and extracts the issues underlying each step of the food supply chain in order to examine the implementation of effective measures for risk management.

Effect of morphological changes in feather follicles of chicken carcasses after defeathering and chilling on the degree of skin contamination by Campylobacter species

Campylobacter jejuni and C. coli are the leading causes of enteric infections in many developed countries. Healthy chickens are considered to act as reservoirs of campylobacters, as the organisms colonize the intestinal tract. Once infected birds enter a processing plant, contamination of chicken carcasses with campylobacters occurs over the entire skin during defeathering and evisceration due to leakage of crop and/or intestinal contents. Although the role of feather follicles in the contamination of chicken carcasses by campylobacters during processing is still debatable, it has been considered that the microorganisms would be entrapped and retained in the follicles due to the morphological changes resulting from defeathering and chilling. In the present study, we observed the morphology of feather follicles in chicken carcasses after defeathering and chilling. A total of 3,133 feather follicles were examined for morphological changes before and after chilling. Shortly after defeathering, most (91.5%) of the follicles were closed, whereas after chilling they were either closed (85.5%) or open (6%), although a small proportion of enlarged follicles became smaller or closed (2.6%). Moreover, 5.9% of the follicles that were slightly open became further enlarged after chilling. Furthermore, the proportion of enlarged feather follicles that became closed after chilling showed no discernible relationship with the degree of campylobacter contamination in different areas of the carcass skin, suggesting that campylobacters may not be confined to feather follicles as a result of the morphological changes attributable to defeathering and chilling.

Campylobacter jejuni transducer like proteins: Chemotaxis and beyond

Chemotaxis, a process that mediates directional motility toward or away from chemical stimuli (chemoeffectors/ligands that can be attractants or repellents) in the environment, plays an important role in the adaptation of Campylobacter jejuni to disparate niches. The chemotaxis system consists of core signal transduction proteins and methyl-accepting-domain-containing Transducer like proteins (Tlps). Ligands binding to Tlps relay a signal to chemotaxis proteins in the cytoplasm which initiate a signal transduction cascade, culminating into a directional flagellar movement. Tlps facilitate substrate-specific chemotaxis in C. jejuni, which plays an important role in the pathogen's adaptation, pathobiology and colonization of the chicken gastrointestinal tract. However, the role of Tlps in C. jejuni's host tissue specific colonization, physiology and virulence remains not completely understood. Based on recent studies, it can be predicted that Tlps might be important targets for developing strategies to control C. jejuni via vaccines and antimicrobials.

Quantification of loosely associated and tightly associated bacteria on broiler carcass skin using swabbing, stomaching, and grinding methods

This research was conducted to quantify bacterial populations after swabbing or stomaching, followed by grinding the swabbed or stomached broiler skins. For each of 3 replications, 3 eviscerated broilers were randomly taken from a processing line in a local broiler processing plant. Ten swabs and 10 stomachs per bird were conducted on the left- and the right-side skins (10×7 cm), respectively, which were then finally ground. Results indicated that mesophilic aerobic bacteria (MAB) in the first swabbed sample were significantly lower than those in the first stomached sample (P<0.05), with no difference seen for the remaining sampling times (P>0.05). During 10 swabbings followed by final grinding, 8, 9, and 83% of MAB were detected after the first swabbing, after the second through 10th swabbings, and after final grinding of the skin, respectively. During 10 stomachings followed by the final grinding, 17, 18, and 65% of MAB were detected after the first stomaching, after the second through 10th stomachings, and after final grinding of the skin, respectively. Escherichia coli (E. coli) and coliforms were significantly higher in the first stomaching than those in the first swabbing (P<0.05), with no difference seen between the 2 sampling methods for the rest sampling times (P>0.05). Populations of E. coli and coliforms decreased step-wisely from the highest after grinding to the intermediate after first and second sampling, and to the least after 10th sampling (P<0.05), regardless of swabbing or grinding. In this study, less than 35% of MAB seemed loosely associated in the skin of eviscerated broiler, whereas more than 65% of MAB looked tightly associated, which were not recovered by stomaching or swabbing even 10 times but were recovered by grinding the skin.

Biofilm spatial organization by the emerging pathogen Campylobacter jejuni: comparison between NCTC 11168 and 81-176 strains under microaerobic and oxygen-enriched conditions

During the last years, Campylobacter has emerged as the leading cause of bacterial foodborne infections in developed countries. Described as an obligate microaerophile, Campylobacter has puzzled scientists by surviving a wide range of environmental oxidative stresses on foods farm to retail, and thereafter intestinal transit and oxidative damage from macrophages to cause human infection. In this study, confocal laser scanning microscopy (CLSM) was used to explore the biofilm development of two well-described Campylobacter jejuni strains (NCTC 11168 and 81-176) prior to or during cultivation under oxygen-enriched conditions. Quantitative and qualitative appraisal indicated that C. jejuni formed finger-like biofilm structures with an open ultrastructure for 81-176 and a multilayer-like structure for NCTC 11168 under microaerobic conditions (MAC). The presence of motile cells within the biofilm confirmed the maturation of the C. jejuni 81-176 biofilm. Acclimation of cells to oxygen-enriched conditions led to significant enhancement of biofilm formation during the early stages of the process. Exposure to these conditions during biofilm cultivation induced an even greater biofilm development for both strains, indicating that oxygen demand for biofilm formation is higher than for planktonic growth counterparts. Overexpression of cosR in the poorer biofilm-forming strain, NCTC 11168, enhanced biofilm development dramatically by promoting an open ultrastructure similar to that observed for 81-176. Consequently, the regulator CosR is likely to be a key protein in the maturation of C. jejuni biofilm, although it is not linked to oxygen stimulation. These unexpected data advocate challenging studies by reconsidering the paradigm of fastidious requirements for C. jejuni growth when various subpopulations (from quiescent to motile cells) coexist in biofilms. These findings constitute a clear example of a survival strategy used by this emerging human pathogen.

Relevance of Campylobacter to public health--the need for a One Health approach

Campylobacter species belong to the most important foodborne bacteria which cause gastroenteritis in humans in both developed and developing countries. With increasing reporting rates, the public awareness towards Campylobacter infections is growing continuously. This strengthens the necessity to establish intervention measures for prevention and control of thermophilic Campylobacter spp. along the food chain, as in particular poultry and poultry meat represent a major source of human infections. An interdisciplinary One Health approach and a combined effort of all stakeholders are necessary to ultimately reduce the burden of campylobacteriosis cases in humans. Numerous studies point out, however, that at present a complete elimination of Campylobacter in the food chain is not feasible. The present aim should therefore be to establish control measures and intervention strategies to minimize the occurrence of Campylobacter spp. in livestock (e.g. poultry flocks) and to reduce the quantitative Campylobacter burden in animals and foods. To this end, a combination of intervention methods at different stages of the food chain appears most promising. That has to be accompanied by targeted consumer advice and education campaigns to raise the awareness towards Campylobacter infections.

Effect of hot water spray on broiler carcasses for reduction of loosely attached, intermediately attached, and tightly attached pathogenic (Salmonella and Campylobacter) and mesophilic aerobic bacteria

Chickens are known to harbor many bacteria, including pathogenic microorganisms such as Salmonella and Campylobacter. The objective of this study was to evaluate the efficacy of hot water spray (HWS, 71°C for 1 min) in reducing bacterial contamination of prechilled broiler carcasses. For each of 4 replications, skin samples from 5 broilers were collected at 3 processing stages: after bleeding (feathers removed manually), after evisceration (with/without HWS), and after water chilling. Broiler skin was quantitatively assessed for loosely attached (by rinsing the skin), intermediately attached (by stomaching the rinsed skin), and tightly attached (by grinding the rinsed/stomached skin) mesophilic aerobic bacteria (MAB) and Campylobacter as well as for the prevalence of Salmonella and Campylobacter. Broiler skins possessed 6.4 to 6.6 log cfu/g, 3.8 to 4.1 log cfu/g, and 2.8 to 3.5 log cfu/g of MAB populations after bleeding, evisceration, and chilling, respectively. The HWS resulted in more than 1 log unit of reduction in MAB immediately after evisceration and immediately after chilling regardless of microbial sampling method. Compared with MAB, the contamination of Campylobacter was low (1.7 to 2.6 log cfu/g) after bleeding, but the level was not reduced throughout the processing steps regardless of HWS. The application of HWS reduced the prevalence of Salmonella after chilling, but not for Campylobacter except for loosely attached cells. After hot water exposure, a partially cooked appearance was seen on both broiler skin and skinless breast surface. More research is required to effectively eliminate pathogenic organisms during processing and suppress any recovery of bacteria regardless of attachment type after chilling.

Quo vadis? - Monitoring Campylobacter in Germany

Campylobacter is a poorly recognized foodborne pathogen, leading the statistics of bacterially caused human diarrhoea in Europe during the last years. In this review, we present qualitative and quantitative German data obtained in the framework of specific monitoring programs and from routine surveillance. These also comprise recent data on antimicrobial resistances of food isolates. Due to the considerable reduction of in vitro growth capabilities of stressed bacteria, there is a clear discrepancy between the detection limit of Campylobacter by cultivation and its infection potential. Moreover, antimicrobial resistances of Campylobacter isolates established during fattening of livestock are alarming, since they constitute an additional threat to human health. The European Food Safety Authority (EFSA) discusses the establishment of a quantitative limit for Campylobacter contamination of broiler carcasses in order to achieve an appropriate level of protection for consumers. Currently, a considerable amount of German broiler carcasses would not comply with this future criterion. We recommend Campylobacter reduction strategies to be focussed on the prevention of fecal contamination during slaughter. Decontamination is only a sparse option, since the reduction efficiency is low and its success depends on the initial contamination concentration.

Campylobacter spp. as a Foodborne Pathogen: A Review

Campylobacter is well recognized as the leading cause of bacterial foodborne diarrheal disease worldwide. Symptoms can range from mild to serious infections of the children and the elderly and permanent neurological symptoms. The organism is a cytochrome oxidase positive, microaerophilic, curved Gram-negative rod exhibiting corkscrew motility and is carried in the intestine of many wild and domestic animals, particularly avian species including poultry. Intestinal colonization results in healthy animals as carriers. In contrast with the most recent published reviews that cover specific aspects of Campylobacter/campylobacteriosis, this broad review aims at elucidating and discussing the (i) genus Campylobacter, growth and survival characteristics; (ii) detection, isolation and confirmation of Campylobacter; (iii) campylobacteriosis and presence of virulence factors; and (iv) colonization of poultry and control strategies.

Effect of temperature and contact time on Campylobacter jejuni attachment to, and probability of detachment from, stainless steel

The effect of temperature and contact time on attachment of six Campylobacter jejuni strains to, and probability of their detachment from, stainless steel were determined. Triplicate stainless steel coupons (SSC) were exposed to C. jejuni cell suspensions at 4, 25, 37, and 55 degrees C for 30 min. An increase in temperature enhanced the numbers of cells of all strains of C. jejuni attaching to stainless steel from approximately 4 log/cm(2) at 4 degrees C to approximately 5 log/cm(2) at 55 degrees C. Cells attached to SSC at 4 and 25 degrees C for 30 min were detached by the successive blotting technique on a series of Campylobacter blood-free selective agar plates. The probability of detachment was significantly (P < 0.05) higher at 4 degrees C (> or = 0.219) than at 25 degrees C (> or = 0.111) for five of the six strains tested, suggesting the strength of attachment was weaker at 4 degrees C than at 25 degrees C for these strains. C. jejuni cells were allowed to attach to SSC at 4 degrees C for 1, 15, 30, 45, 60, 120, 180, 240, and 300 min. The numbers of cells attaching to SSC reached approximately 4 log/cm(2) after 1 min of contact and increased slowly thereafter to approximately 5 log/cm(2) after 300 min of contact. The probability of detachment significantly (P < 0.05) decreased from 0.443 after 1 min to 0.134 after 240 min of contact, indicating bacterial attachment was strengthened over time. These data suggest that to reduce the numbers of adhered cells on processing surfaces, low-temperature and early bacterial detachment procedures should be applied.

Effect of refrigeration and frozen storage on the Campylobacter jejuni recovery from naturally contaminated broiler carcasses

Campylobacter jejuni is the most common thermophilic Campylobacter associated with human enteritis in many countries. Broilers and their by-products are the main sources for human enteritis. Refrigeration and freezing are used to control bacterial growth in foods. The effect of these interventions on survival of Campylobacter jejuni is yet not quite understood. This study evaluated the effect of storage temperature on the survival of C. jejuni in chicken meat stored for seven days at 4°C and for 28 days at -20°C. The influence of selective enrichment on recovery of Campylobacter was also evaluated. Thirty fresh chicken meat samples were analyzed and 93.3% was contaminated with termotolerant Campylobacter spp. with average count of 3.08 Log10 CFU/g on direct plating. After refrigeration, 53.3% of the analyzed samples tested positive for Campylobacter and the average count was 1.19 Log10 CFU/g. After storage at -20°C, 36.6% of the samples were positive with a verage count of 0.75 Log10 CFU/g. C. jejuni was detected after enrichment, respectively, in 50% of the fresh, 36.7% of the refrigerated and 33.3% of the frozen meat samples analyzed. No difference was detected for the recovery of C. jejuni from fresh, refrigerated or frozen samples after selective enrichment, showing that this microorganism can survive under the tested storage conditions.

Long-term survival of Campylobacter jejuni at low temperatures is dependent on polynucleotide phosphorylase activity

Campylobacter jejuni is a leading cause of bacterial gastroenteritis worldwide. Infection generally occurs after ingestion of contaminated poultry products, usually conserved at low temperatures. The mechanisms promoting survival of C. jejuni in the cold remain poorly understood despite several investigations. The present study provides insight into the survival mechanism by establishing the involvement of polynucleotide phosphorylase (PNPase), a 3'-5' exoribonuclease with multiple biological functions in cold survival. The role of PNPase was demonstrated genetically using strains with altered pnp genes (which encode PNPase) created in C. jejuni F38011 and C. jejuni 81-76 backgrounds. Survival assays carried out at low temperatures (4 and 10 degrees C) revealed a difference of 3 log CFU/ml between the wild-type and the pnp deletion (Deltapnp) strains. This did not result from a general requirement for PNPase because survival rates of the strains were similar at higher growth temperatures (37 or 42 degrees C). trans-Complementation with plasmid pNH04 carrying the pnp gene under the control of its natural promoter restored the cold survival phenotype to the pnp deletion strains (at 4 and 10 degrees C) but not to the same level as the wild type. In this study we demonstrate the role of PNPase in low-temperature survival of C. jejuni and therefore attribute a novel biological function to PNPase directly related to human health.

Culture and detection of Campylobacter jejuni within mixed microbial populations of biofilms on stainless steel

Campylobacter jejuni is the most frequently reported cause of foodborne illness in the United States, but its survival outside the host is poor. The objective of this research was to examine the formation and composition of biofilms by C. jejuni alone and within mixed bacterial populations from the poultry-processing environment. C. jejuni growth was assessed with four media, two temperatures, and two atmospheric conditions to develop culture methods for liquid media that would allow growth within the biofilms. Growth kinetics was followed at four cell densities to determine temporal compatibility within biofilm mixtures. Analysis of the biofilms by confocal laser scanning microscopy showed that C. jejuni formed a biofilm when incubated without other bacteria. The average surface area of stainless steel covered by C. jejuni increased by 50% from 24 to 48 h, remained level to 96 h, and then decreased by 88% by 168 h. C. jejuni and mixed bacterial populations formed biofilms during incubation periods of up to 7 days. The area of the mixture was significantly greater than for C. jejuni alone at 24 h, was approximately the same at 48 h, and was significantly less by 168 h. When incubated with either of two initial inoculum densities of other bacteria, the number of C. jejuni was enhanced after 24 h. The intensity of fluorescence and cell viability were monitored by epifluorescence microscopy. This study provides the basis for studying interactions of Campylobacter spp. with other bacteria in the environment, which will aid in the design of effective intervention strategies.

Survival of Campylobacter jejuni on Poultry Skin and Meat at Varying Temperatures

Researchers have recently found a much higher prevalence of Campylobacter on skin-on poultry products vs. skinless products. These data suggest that contamination is associated primarily with poultry skin, and Campylobacter may not survive on skinless poultry meat. Therefore, the objective of this study was to quantify the survival of Campylobacter poultry skin vs. meat under differing storage conditions. Skin and meat were irradiated to eliminate native microflora and inoculated with Campylobacter jejuni (~5.0 x 10(5) cfu/mL). Meat and skin samples were packaged in polystyrene trays, covered with Cryovac film, and then subjected to 1 of the following storage conditions: 1) 4 degrees C for 11 d; 2) 4 degrees C for 1 d, then -3 degrees C for 10 d; 3) 4 degrees C for 1 d, -3 degrees C for 1 d, then 4 degrees C for 9 d; or 4) 4 degrees C for 1 d, -3 degrees C for 1 d, 20 degrees C for 1 h on d2, then 4 degrees for 9 d. On d 0, 2, 3, 5, 7, 9, and 11, populations of Campylobacter were determined. The experiment was replicated 3 times. In each experiment, populations of surviving Campylobacter were not affected by storage conditions (P > or = 0.05), and there was no interaction between temperature treatments and sample type. Surviving Campylobacter populations were affected (P < or = 0.05) by sample type (skin vs. meat). Campylobacter, in the absence of competing microflora, survived well on poultry skin and meat at the temperatures tested. In all experiments, higher populations were established on the inoculated skin vs. inoculated meat. These populations remained consistently 0.4 to 0.9 log(10) cfu/g higher on skin vs. meat. Poultry skin topography may account, in part, for these higher populations on skin.

Prevalence and antimicrobial resistance of Campylobacter jejuni and Campylobacter coli isolated from raw chicken meat and human stools in Korea

Prevalence of Campylobacter in raw chicken meat and human stools and subsequent antibiotic resistance profiles of the pathogenic isolates obtained from 2000 through 2002 were investigated. Campylobacter jejuni and Campylobacter coli were isolated from 570 of the 923 raw chicken meat samples collected from traditional markets, large retail stores, or department stores in Korea, resulting in the isolation rate of 61.8%. A total of 579 Campylobacter isolates were obtained from raw chicken (36.3% for C. jejuni and 26.4% for C. coli) with the average population of 335.6 CFU/g. From 513 human stool samples, 15 isolates of Campylobacter were detected. Seasonal variation in the quantification of C. coli was not noticeable throughout the year, while the isolation rate of C. jejuni was the highest in September through October (840 CFU/g) followed by that of July through August and May through June in decreasing order, showing a significant seasonal effect (P < 0.05). Contamination of Campylobacter was more severe in raw chicken meat sold in traditional markets than in those sold in large retail stores and department stores. Prevalence of Campylobacter in raw chicken sold in traditional markets was significantly influenced by seasonal changes (P < 0.05), whereas the samples obtained from other places was less affected by the seasonal changes. Susceptibilities of the 594 chicken isolates to ciprofloxaxin, chloramphenicol, erythromycin, kanamycin, nalidixic acid, and tetracycline were determined by an E-test. Campylobacter isolates were the most resistant to nalidixic acid (91.4%) followed by ciprofloxaxin (87.9%), tetracycline (87.2%), kanamycin (30.6%), erythromycin (19.4%), and chloramphenicol (1.3%). Human isolates showed a similar resistance to the six antibiotics tested. The proportion of Campylobacter isolates with multidrug resistance to four or more antimicrobials obtained from 2000 through 2002 ranged from 28 to 43.5%, indicating that it could be a serious health-threatening factor. This study suggests that it is prudent to establish an effective National Monitoring Program in Korea for the prevention and control of Campylobacter spp.

Morphological and physiological responses of Campylobacter jejuni to stress

Under conditions of stress, cells of Campylobacter assume a coccoid shape that may be an evolutionary strategy evolved by the organism to enable survival between hosts. However, the physiology of Campylobacter as it devolves from spiral to coccoid-shaped morphology is poorly understood. In this study, conditions influencing the survival of Campylobacter jejuni ATCC 35921 in broth were determined. Cells in late log phase were resuspended in broth at 4 or 60 degrees C. The culturability of these cold- or heat-stressed cell suspensions was determined by spread plate counts and the activity of cells by the direct viable count technique and 5-cyano-2,3-ditolyltetrazolium chloride staining. C. jejuni changed form completely from culturable to viable but nonculturable cells (VBNC) within 25 days at 4 degrees C, and 15 min at 60 degrees C. Light microscopy of C. jejuni VBNC cells showed that the spiral-shaped cells became coccoid, and transmission electron microscopy of C. jejuni VBNC cells showed that the outer membrane was lost in aging cell suspensions. Furthermore, a limited proteomic study was carried out to compare C. jejuni proteins that exhibited increased or decreased synthesis on exposure to 60 degrees C.

Comparison of different sampling techniques and enumeration methods for the isolation and quantification of Campylobacter spp. in raw retail chicken legs

Comparable quantitative data of Campylobacter spp. on chicken products are a major data lack for quantitative risk assessment approaches. The objective of this study was to compare two different sampling techniques for the isolation and enumeration of Campylobacter spp. in chicken and to evaluate a suitable enumeration method comparing the most probable number (MPN) technique to the direct plating method. For this, 90 packages containing at least two raw chicken legs were examined for the comparison of sampling techniques, rinsing one leg and homogenizing 25 g of skin of the other leg of each package; both sample preparation types were examined by direct plating method and MPN technique in 40 out of 90 packages. Of the skin samples, 70% (63/90), and of the rinse samples, 77% (69/90), were Campylobacter-positive. Enumeration of Campylobacter spp. by direct plating revealed a median of log 4 cfu/leg surface in skin samples (S.D.=0.6) and a median of log 4.3 cfu/leg surface in rinse samples (S.D.=0.9) of the rinse samples; 73% (37/51) had higher numbers of Campylobacter spp. than the skin samples although the difference was not significant (p=0.08). The correlation coefficient of Campylobacter counts in skin and rinse samples was 0.43. The prevalence of Campylobacter spp. in rinse samples was 58% (23/40). In 5% (2/40) of the rinse samples, numbers of Campylobacter spp. could be detected only by the MPN technique due to the lower detection limit compared to the direct plating method. The MPN technique turned out to be unsuitable for the enumeration of Campylobacter spp. in skin samples because a layer formation on the top of the incubated MPN-tubes leads to irregular MPN results. Out of 80% (16/20) of the compared rinse samples, the direct plating detected higher numbers of Campylobacter spp., with a median count of log 4.2 cfu/leg surface (S.D.=1) compared the MPN technique where a median of log 4 cfu/leg surface (S.D.=1.1) was obtained. The difference was not significant (p=0.05). A highly positive correlation coefficient of 0.9 was observed between the direct plating and the MPN technique. Both sampling methods, rinsing the chicken leg and homogenizing the skin, are suitable for the detection and quantification of Campylobacter spp.; the direct plating method was superior to the MPN technique for enumerating Campylobacter spp. in raw chicken legs at retail level because enumeration is more rapid and less laborious.

Transformation of Escherichia coli K-12 with a high-copy plasmid encoding the green fluorescent protein reduces growth: implications for predictive microbiology

The green fluorescent protein (GFP) of the jellyfish Aequorea victoria has been widely used as a biomarker and has potential for use in developing predictive models for growth of pathogens on naturally contaminated food. However, constitutive production of GFP can reduce growth of transformed strains. Consequently, a high-copy plasmid with gfp under the control of a tetracycline-inducible promoter (pTGP) was constructed. The plasmid was first introduced into a tetracycline-resistant strain of Escherichia coli K-12 to propagate it for subsequent transformation of tetracycline-resistant strains of Salmonella. In contrast to transformed E. coli K-12, which only fluoresced in response to tetracycline, transformed Salmonella fluoresced maximally without tetracycline induction of gfp. Although pTGP did not function as intended in Salmonella, growth of parent and GFP E. coli K-12 was compared to test the hypothesis that induction of GFP production reduced growth. Although GFP production was not induced during growth on sterile chicken in the absence of tetracycline, maximum specific growth rate (mumax) of GFP E. coli K-12 was reduced 40 to 50% (P < 0.05) at 10, 25, and 40 degrees C compared with the parent strain. When growth of parent and GFP strains of E. coli K-12 was compared in sterile broth at 40 degrees C, mumax and maximum population density of the GFP strain were reduced (P < 0.05) to the same extent (50 to 60%) in the absence and presence of tetracycline. These results indicated that transformation reduced growth of E. coli K-12 independent of gfp induction. Thus, use of a low-copy plasmid or insertion of gfp into the chromosome may be required to construct valid strains for development of predictive models for growth of pathogens on naturally contaminated food.

Influence of inoculation levels and processing parameters on the survival of Campylobacter jejuni in German style fermented turkey sausages

This study investigated the influence of inoculum levels and manufacturing methods on the survival of Campylobacter (C.) jejuni in raw fermented turkey sausages. Sausages were prepared and inoculated with C. jejuni. After inoculation, these sausages were processed and ripened for 8 days. Samples were taken throughout the ripening process. The presence of C. jejuni was established bacteriologically. Additionally, lactic acid bacteria were enumerated, pH values and water activity were measured to verify the ripening process. To detect changes in genotype and verify the identity of the recovered clones, AFLP analysis was carried out on the re-isolated strains. Whereas no C. jejuni were detectable when inoculating the sausages with the lowest inoculum (0.08-0.44 log(10) cfu/g sausage emulsion), C. jejuni were detectable for 12-24h by enrichment when inoculated with approximately 2 log(10) cfu/g. After inoculation with 4 and 6 log(10) cfu/g respectively, C. jejuni were detectable without enrichment for 12-48 h and by enrichment for 144 h at the most. The greatest decrease of the C. jejuni population occurred during the first 4 h of ripening. Only a very high inoculum level allowed the survival of the organism during a fermentation process and during ripening to pose a potential risk for consumers. Lower initial Campylobacter inoculums will be eliminated during proper ripening of the sausages, if sufficient decrease in water activity and pH-value is ensured.

In situ localization of Escherichia coli O157:H7 in food by confocal scanning laser microscopy

The aim of this study was to use confocal scanning laser microscopy to examine the in situ localization of Escherichia coli O157:H7 on beef (knuckle or brisket) and carrots and in semisoft cheese made from pasteurized milk. Using a combination of specific immunolabeling and dual-excitation confocal scanning laser microscopy, it was possible to clearly demonstrate the localization of E. coli O157:H7 within various food types. In carrots, bacteria were found mainly at cell junctions and in intracellular spaces up to 50 microm deep. In beef, bacteria were located primarily between muscle fibers and within connective tissue (at a depth of 25 microm), whereas in cheese the bacteria occurred singly or in small clumps of up to 10 cells and were observed within the protein matrix of the cheese. These results revealed how E. coli O157:H7 can penetrate beef and carrot surfaces where it is protected from decontamination processes.

Survival of cold-stressed Campylobacter jejuni on ground chicken and chicken skin during frozen storage

Campylobacter jejuni is prevalent in poultry, but the effect of combined refrigerated and frozen storage on its survival, conditions relevant to poultry processing and storage, has not been evaluated. Therefore, the effects of refrigeration at 4 degrees C, freezing at -20 degrees C, and a combination of refrigeration and freezing on the survival of C. jejuni in ground chicken and on chicken skin were examined. Samples were enumerated using tryptic soy agar containing sheep's blood and modified cefoperazone charcoal deoxycholate agar. Refrigerated storage alone for 3 to 7 days produced a reduction in cell counts of 0.34 to 0.81 log10 CFU/g in ground chicken and a reduction in cell counts of 0.31 to 0.63 log10 CFU/g on chicken skin. Declines were comparable for each sample type using either plating medium. Frozen storage, alone and with prerefrigeration, produced a reduction in cell counts of 0.56 to 1.57 log10 CFU/g in ground chicken and a reduction in cell counts of 1.38 to 3.39 log10 CFU/g on chicken skin over a 2-week period. The recovery of C. jejuni following freezing was similar on both plating media. The survival following frozen storage was greater in ground chicken than on chicken skin with or without prerefrigeration. Cell counts after freezing were lower on chicken skin samples that had been prerefrigerated for 7 days than in those that had been prerefrigerated for 0, 1, or 3 days. This was not observed for ground chicken samples, possibly due to their composition. C. jejuni survived storage at 4 and -20 degrees C with either sample type. This study indicates that, individually or in combination, refrigeration and freezing are not a substitute for safe handling and proper cooking of poultry.

Direct microscopic observation of viability of Campylobacter jejuni on chicken skin treated with selected chemical sanitizing agents

The objective of this research was to determine the effect of chlorine, acidified sodium chlorite, and peracetic acid treatments on viable Campylobacter jejuni located at various depths within follicles or folds of chicken skin. Chicken skin was inoculated with C. jejuni transformed with P(c)gfp plasmid (GFP-Campylobacter), which also codes for kanamycin resistance. Effectiveness of sanitizer treatments was determined by plate count. C. jejuni were also observed on chicken skin by confocal scanning laser microscopy, whereby viable and nonviable cells were differentiated by their ability to take up staining with 5-cyano-2,3-ditolyl tetrazolium chloride. Sodium hypochlorite, peracetic acid, and acidified sodium chlorite were each applied at 40 or 100 ppm for 2 or 15 min. Each sanitizer resulted in approximately a 1-log decrease (CFU) when used at 100 ppm for 15 min and no significant decrease when used at 40 ppm for 2 min. Numbers of viable cells observed on the skin by direct microscopic count were similar to numbers obtained by plate count. Although viable counts decreased with sanitizer treatments, the total number of Campylobacter cells (live plus dead) attached to the skin remained unchanged. After each chemical treatment, viable C. jejuni were observed at depths of 0 to 10, 11 to 20, and 21 to 30 microm in folds or follicles of chicken skin. Most of the C. jejuni that survived treatment were located at 0 to 10 microm depth, which is where most of the viable cells were located before treatment. The inability of chemical sanitizers to effectively eliminate C. jejuni on chicken skin does not appear to be a result of protection by location in feather follicles or other depressions in the skin.