A polyphenol-enriched cocoa extract reduces free radicals produced by mycotoxins

Polyphenols are characterized by the presence of phenol units in the molecules. These compounds may show antioxidant ability by scavenging reactive oxygen species (ROS) of the free radical type. A polyphenol enriched cocoa extract (PECE) was obtained from cocoa seeds with 28% of procyanidins which were mainly epicatechin oligomers. PECE was very active as free radical scavenger against 2,2'-azinobis-(3-ethylbenzothiazoline-6-sulfonic acid (ABTS), 1,1-diphenyl-2-picrylhydrazyl radical (DPPH) and tris(2,4,6-trichloro-3,5-dinitrophenyl)methyl (HNTTM) radicals; and the tris(2,3,5,6-tetrachloro-4-nitrophenyl)methyl (TNPTM) assay showed that the PECE might not be pro-oxidant. Thus it was considered a good candidate to be tested in in vitro models. It showed mild cytotoxic power on Hep G2 cells and induced ROS in a dose-dependent manner being weak oxidant only at high concentrations near the limit of solubility. The antioxidant properties were assayed in Hep G2 treated with the mycotoxins ochratoxin A (OTA) and/or aflatoxin B1 (AFB1). The PECE was not effective against AFB1 but it increased the cell viability and reduced significantly the amounts of ROS in cells treated with OTA or mixtures of AFB1+OTA. These results are coherent with the role of oxidative pathways in the mechanism of OTA and indicate that polyphenols extracted from cocoa may be good candidates as antioxidant agents.

Comparison between capillary electrophoresis and high performance liquid chromatography for the study of the occurrence of patulin in apple juice intended for infants

Apple juice samples intended for infants purchased in Navarra (Spain) have been analyzed for PAT occurrence. Two capillary electrophoresis methods, based on a MEKC and a CEC system, and an HPLC method were evaluated for the aforementioned study. The CEC system gave less satisfying separations and several practical problems, so samples have been analyzed by MEKC and HPLC. Both methods have been comparable in terms of recovery, precision, limits of detection, volume of organic solvents used and adequate selectivity with regard to PAT and HMF. The analysis time in HPLC has been slightly lower than in the MEKC methodology. The PAT levels obtained in apple juice by both validated methods showed a strong correlation (p<0.001). Therefore, both methodologies are useful for the accurate quantification of patulin in this matrix. The PAT levels obtained in the 20 infant apple juices samples were in a range between <LOD and 29.6 microg L(-1), with a mean concentration of 8.0 microg L(-1) which implies a dietary intake estimation of 104 ng kg(-1)b.w.day(-1) considering a body weight of 10 kg and an apple juice consumption of 130 mL day(-1), 26% of the PMTDI recommended by JECFA.

OTA-producing fungi isolated from stored cocoa beans

AIMS

The aim of this study was to identify fungal populations in unroasted cocoa beans stored in Spain in order to evaluate the ochratoxin A (OTA)-production ability of certain Aspergillus isolates.

METHODS AND RESULTS

Twenty batches of cocoa beans from different origins and with different OTA content were selected for this study. Three Aspergillus carbonarius and 13 Aspergillus niger aggregate strains isolated from these cocoa bean samples were selected to evaluate their OTA synthesis ability, being the only A. carbonarius isolates which are OTA producers [<limit of detection (LOD) = 3520 microg kg(-1) culture medium; LOD = 6 microg kg(-1) culture medium].

CONCLUSIONS

No correspondence was found between the OTA levels in cocoa beans and the presence of OTA-producing fungi. Nonetheless, some samples contained A. carbonarius with a high OTA-producing ability and, consequently, specific fungal controls should be set up during storage to avoid this toxin.

SIGNIFICANCE AND IMPACT OF THE STUDY

Toxigenic fungi in cocoa beans are not well understood. This study attempted to identify these fungi and evaluate their OTA-producing ability.

A simple chemical method reduces ochratoxin A in contaminated cocoa shells

Ochratoxin A (OTA) is a mycotoxin produced by Aspergillus and Penicillium species, which contaminates cocoa among other food commodities. It has been previously demonstrated that the toxin is concentrated in cocoa shells. The aim of this study was to assay a simple chemical method for ochratoxin A reduction from naturally contaminated cocoa shells. In order to determine the efficiency of the method, a high-performance liquid chromatography method with fluorescence detection was set up beforehand and validated. Ochratoxin A was extracted from cocoa shells with methanol-3% sodium bicarbonate solution and then purified with immunoaffinity columns. The recovery attained was 88.7% (relative standard deviation = 6.36%) and the limits of detection and quantification were 0.06 and 0.2 kg/kg, respectively. For decontamination experiments, the solvent extractor ASE 200 was used. First, aqueous solutions of 2% sodium bicarbonate and potassium carbonate were compared under the same conditions (1,500 lb/in2 at 40 degrees C for 10 min). Higher ochratoxin A reduction was obtained with potassium carbonate (83 versus 27%). Then, this salt was used under different conditions of pressure, temperature, and time. The greatest ochratoxin A reduction was achieved with an aqueous potassium carbonate solution (2%), at 1,000 lb/in2 at 90 degrees C for 10 min. This method could probably be applicable to the cocoa industry because it is fast and relatively economic. From the point of view of human health, the use of potassium carbonate, partially eliminated by rinsing the sample with water, does not likely represent a risk for human health.

Determination of patulin in commercial apple juice by micellar electrokinetic chromatography

A novel and validated micellar electrokinetic capillary chromatography (MEKC) method using ultraviolet detection (UV) has been applied to the quantitative analysis of patulin (PAT) in commercial apple juice. Patulin was extracted from samples with an ethylacetate solution. The micellar electrokinetic capillary chromatography (MECK) parameters studied for method optimization were buffer composition, voltage, temperature, and a separation between PAT and 5-hydroxymethylfurfural (HMF) (main interference in apple juice PAT analysis) peaks until reaching baseline. The method passes a series of validation tests including selectivity, linearity, limit of detection and quantification (0.7 and 2.5 microgL(-1), respectively), precision (within and between-day variability) and recovery (80.2% RSD=4%), accuracy, and robustness. This method was successfully applied to the measurement of 20 apple juice samples obtained from different supermarkets. One hundred percent of the samples were contaminated with a level greater than the limit of detection, with mean and median values of 41.3 and 35.7 microgL(-1), respectively.

Occurrence of ochratoxin A in cocoa beans: Effect of shelling

The aim of this study was to investigate the influence of the shelling process on the presence of ochratoxin A (OTA) in cocoa samples. Twenty-two cocoa samples were analysed for the determination of OTA before (cocoa bean) and after undergoing manual shelling process (cocoa nib). In order to determine OTA contamination in cocoa samples, a validated high-performance liquid chromatography (HPLC) method with fluorescence detection was used for the quantitative analysis of ochratoxin A (OTA). In both types of samples, OTA was extracted with methanol-3% sodium hydrogen carbonate solution and then purified using immunoaffinity columns prior to HPLC analysis. Due to the fact that different recovery values were obtained for OTA from both types of samples, a revalidation of the method in the case of cocoa nibs was needed. Revalidation was based on the following criteria: Selectivity, limits of detection and quantification (0.03 and 0.1 microg kg(-1), respectively), precision (within-day and between-day variability) and recovery 84.2% (RSD = 7.1%), and uncertainty (30%). Fourteen of the twenty-two cocoa bean samples (64%) suffered a loss of OTA of more than 95% due to shelling, six samples suffered a loss of OTA in the range 65-95%, and only one sample presented a reduction of less than 50%. The principal conclusion derived from this study is that OTA contamination in cocoa beans is concentrated in the shell; therefore, improvements of the industrial shelling process could prevent OTA occurrence in cocoa final products.

Validation of a high-performance liquid chromatography analytical method for ochratoxin A quantification in cocoa beans

A validated high-performance liquid chromatography (HPLC) method with fluorescence detection for the quantitative analysis of ochratoxin A (OTA) in cocoa beans is described. OTA was extracted with methanol-3% sodium hydrogen carbonate solution and then purified with immunoaffinity columns before its analysis by HPLC. The validation of the analytical method was based on the following criteria: selectivity, linearity, limit of detection and quantification, precision (within- and between-day variability) and recovery, robustness and uncertainty. Detection and quantification limits were 0.04 and 0.1 mug kg(-1), respectively. Recovery was 88.9% (relative standard deviation = 4.0%). This method was successfully applied to the measurement of 46 cocoa bean samples of different origins. A total of 63% of cocoa bean samples was contaminated with a level greater than the limit of detection. The means and medians obtained for cocoa bean were 1.71 and 1.12 mug kg(-1), respectively. Surveillance controls should be set up in both crops and factories involved in transformation processes to avoid this mycotoxin in final products.