Alternative disinfection methods to chlorine for use in the fresh-cut industry

The effect of physico-chemical treatment in reducing Listeria monocytogenes biofilms on lettuce leaf surfaces

The purpose of this research was to characterize Listeria monocytogenes from several environmental and clinical sources and assess the efficacy of single and combined physico-chemical treatments in reducing biofilm on lettuce leaves. PCR analysis of L. monocytogenes isolates collected from different clinical (10 strains) and environmental sources (12 strains) was used to look for the presence of one Listeria-specific gene and five virulence genes. Biofilms of L. monocytogenes were developed on lettuce leaves over 24 h. A 5-min ultrasound and a 300-ppm sodium hypochlorite (NaOCl) wash resulted in similar reductions in cell numbers of 0.82 log CFU cm-2. For chlorine dioxide (ClO2) at 60 ppm, the cell numbers were reduced by ∼5.45 log CFU cm-2. A combined treatment of 5 min of ultrasound plus 300 ppm NaOCl or 40 ppm ClO2, provided maximal efficacy, reducing the number of L. monocytogenes on the lettuce surface to non-detectable levels. Therefore, ClO2 has the potential to replace NaOCl for the disinfection of food products in the food industry.

Strategies for Microbial Decontamination of Fresh Blueberries and Derived Products

Increasing consumption of blueberries is associated with appreciation of their organoleptic properties together with their multiple health benefits. The increasing number of outbreaks caused by pathogenic microorganisms associated with their consumption in the fresh state and the rapid spoilage of this product which is mainly caused by moulds, has led to the development and evaluation of alternatives that help mitigate this problem. This article presents different strategies ranging from chemical, physical and biological technologies to combined methods applied for microbial decontamination of fresh blueberries and derived products. Sanitizers such as peracetic acid (PAA), ozone (O3), and electrolyzed water (EOW), and physical technologies such as pulsed light (PL) and cold plasma (CP) are potential alternatives to the use of traditional chlorine. Likewise, high hydrostatic pressure (HHP) or pulsed electrical fields (PEF) successfully achieve microbial reductions in derivative products. A combination of methods at moderate intensities or levels is a promising strategy to increase microbial decontamination with a minimal impact on product quality.

Microbiological safety of ready-to-eat minimally processed vegetables in Brazil: an overview

The market of ready-to-eat minimally processed vegetables (RTE-MPV) is increasing in Brazil and many other countries. During processing, these vegetables go through several steps that modify their natural structure while maintaining the same nutritional and sensory attributes as the fresh produce. One of the most important steps is washing-disinfection, which aims to reduce the microbial load, prevent cross-contamination and inactivate pathogenic microorganisms that may be present. Nonetheless, the presence of pathogens and occurrence of foodborne illnesses associated with consumption of RTE-MPV concern consumers, governments and the food industry. This review brings an overview on the microbiological safety of RTE-MPV, focusing on Brazilian findings. Most of the published data are on detection of Salmonella spp. and Listeria monocytogenes, indicating that their prevalence may range from 0.4% to 12.5% and from 0.6% to 3.1%, respectively. The presence of these pathogens in fresh produce is unacceptable and risky, mainly in RTE-MPV, because consumers expect them to be clean and sanitized and consequently safe for consumption without any additional care. Therefore, proper control during the production of RTE-MPV is mandatory to guarantee products with quality and safety to consumers. © 2020 Society of Chemical Industry.

Amaranthus tricolor crude extract inhibits Cronobacter sakazakii isolated from powdered infant formula

The purpose of this study was to elucidate the antibacterial activity and possible mechanism of action of Amaranthus tricolor crude extract (ATCE) against Cronobacter sakazakii isolated from powdered infant formula (PIF). The antibacterial activity of ATCE was assessed by measuring the diameter of inhibition zone (DIZ), minimum inhibitory concentration (MIC), and minimum bactericidal concentration (MBC). The possible mechanism of action of ATCE was revealed by analyzing the effects of ATCE on growth curves and changes in cell membrane potential, intracellular pH, content of bacterial protein and genomic DNA, and cell morphology. Finally, ATCE was applied to the disinfection of C. sakazakii in biofilm on stainless steel tube. The results showed that the DIZ, MIC, and MBC of ATCE against C. sakazakii strains were from 14.35 ± 0.67 to 14.84 ± 0.67 mm, 20 mg/mL, and 40 mg/mL, respectively. Treatment with ATCE ended the logarithmic growth phase of C. sakazakii, and led to depolarization of the cell membranes, reducing intracellular pH and bacterial protein and genomic DNA contents, and resulting in cytoplasmic leakage and deformation. In addition, ATCE effectively inactivated C. sakazakii in biofilm, reducing viable bacteria by approximately 6.5 log cfu/mL bacterial count after treatment with 1 MIC (1 MIC = 20 mg/mL) of ATCE for 20 min at 25°C. Our findings showed that ATCE inactivated C. sakazakii strains isolated from PIF and has potential as a natural disinfectant to reduce the contamination of PIF by C. sakazakii.

Evaluation of a sanitizing washing step with different chemical disinfectants for the strawberry processing industry

Strawberries are often consumed fresh or only receive minimal processing, inducing a significant health risk to the consumer if contamination occurs anywhere from farm to fork. Outbreaks of foodborne illness associated with strawberries often involve a broad range of microbiological agents, from viruses (human norovirus) to bacteria (Salmonella spp. and Listeria monocytogenes). The addition of sanitizers to water washes is one of the most commonly studied strategies to remove or inactivate pathogens on berries as well as avoid cross contamination due to reuse of process wash water. The risk posed with the safety issues of by-products from chlorine disinfection in the fruit industry has led to a search for alternative sanitizers. We evaluated the applicability of different chemical sanitizers (peracetic acid (PA), hydrogen peroxide (H₂O₂), citric acid (CA), lactic acid (LA) and acetic acid (AA)) for the inactivation of S. enterica, L. monocytogenes and murine norovirus (MNV-1) on strawberries. A control treatment with chlorine (NaClO) (100 ppm) was included. For each sanitizer, different doses (40, 80 and 120 ppm for PA and 1, 2.5 and 5% for H₂O₂, LA, AA and CA) and time (2 and 5 min) were studied in order to optimize the decontamination washing step. The best concentrations were 80 ppm for PA, 5% for H₂O₂ and 2.5% for organic acids (LA, AA and CA) after 2 min treatment. Results indicate that the sanitizers selected may be a feasible alternative to chlorine (100 ppm) for removing selected pathogenic microorganisms (P > 0.05), with reductions about ≥2 log for bacterial strains and ≥ 1.7 log for MNV-1. As the washing water may also increase the microbial counts by cross-contamination, we observed that no pathogenic bacteria were found in wash water after 5% H₂O₂ and 80 ppm PA after 2 min treatment. On the other hand, we also reported reductions about total aerobic mesophyll (TAM) (0.0-1.4 log CFU/g) and molds and yeasts (M&Y) (0.3-1.8 log CFU/g) with all alternative sanitizers tested. Strawberries treated did not shown significant differences about physio-chemical parameters compared to the untreated samples (initial). For this study, the optimal sanitizer selected was PA, due to the low concentration and cost needed and its microbiocidal effect in wash water and fruit. Notwithstanding the results obtained, the effect of PA in combination with other non-thermal technologies such as water-assisted ultraviolet (UV-C) light should be studied in future research to improve the disinfection of strawberries.

Use of α-cyclodextrin to Promote Clean and Environmentally Friendly Disinfection of Phenolic Substrates via Chlorine Dioxide Treatment

The use of chlorine dioxide to disinfect drinking water and ameliorate toxic components of wastewater has significant advantages in terms of providing safe water. Nonetheless, significant drawbacks toward such usage remain. These drawbacks include the fact that toxic byproducts of the disinfection agents are often formed, and the complete removal of such agents can be challenging. Reported herein is one approach to solving this problem: the use of α-cyclodextrin to affect the product distribution in chlorine dioxide-mediated decomposition of organic pollutants. The presence of α-cyclodextrin leads to markedly more oxidation and less aromatic chlorination, in a manner that is highly dependent on analyte structure and other reaction conditions. Mechanistic hypotheses are advanced to explain the cyclodextrin effect, and the potential for use of α-cyclodextrin for practical wastewater treatment is also discussed.

Optimization of Electrolysis Parameters for Green Sanitation Chemicals Production Using Response Surface Methodology

Electrolyzed water (EW) shows great potential as a green and economical sanitation solution for the food industry. However, only limited studies have investigated the optimum electrolysis parameters and the bactericidal effect of acidic electrolyzed water (AcEW) and alkaline electrolyzed water (AlEW). Here, the Box–Behnken experimental design was used to identify the optimum parameters. The tests were conducted with different types of electrodes, electrical voltages, electrolysis times, and NaCl concentrations. There were no obvious differences observed in the physico-chemical properties of EW when different electrodes were used. However, stainless steel was chosen as it meets most of the selection criteria. The best-optimized conditions for AcEW were at 11.39 V, 0.65 wt.% NaCl, and 7.23 min, while the best-optimized conditions for AlEW were at 10.32 V, 0.6 wt.% NaCl, and 7.49 min. The performance of the optimum EW (AcEW and AlEW) compared with commercial cleaning detergents for the food industry was then evaluated. The bactericidal activity of AcEW and AlEW was examined against Escherichia coli ATCC 10536 at different temperatures (30 °C and 50 °C) for 30 s. The results show that both AcEW and AlEW have the ability to reduce the Escherichia coli to non-detectable levels (less than 2 log CFU/mL).

Evaluation of the combined treatment of ultraviolet light and peracetic acid as an alternative to chlorine washing for lettuce decontamination

The potential of using ultraviolet light (UV) in combination of peracetic acid (PAA) as an alternative to chlorine washing for lettuce was evaluated. Shredded iceberg lettuce was dip-inoculated with a four-strain Salmonella cocktail to final levels of 6-7.5 log CFU/g, following by air-drying and overnight cold storage. The inoculated lettuce (80 g) was then washed in turbid tap water containing 6% lettuce juice extract and silicon dioxide (turbidity of ~60 NTU; COD of ~2000 mg/L) while being treated with 1) 10 or 20 ppm free chlorine, 2) PAA solution (40 and 80 ppm), 3) UV (10, 20 and 30 mW/cm2), 4) a combination of UV and PAA for 1, 2, and 5 min. Among all the single treatments, the 30 mW/cm2 UV treatment achieved the highest Salmonella reduction on lettuce. For the 2-min treatment group, the 30 mW/cm2 UV treatment achieved 1.98 log reduction, while the 80 ppm PAA and 20 ppm free chlorine resulted in 1.52 and 1.23 log reduction, respectively. The combined treatment of 30 mW/cm2 UV and 80 ppm PAA achieved significantly higher (P < .05) Salmonella reduction than the 20 ppm free chlorine washing. For the 5-min treatment group, the combined treatment resulted in 3.24 log reduction, while the 20 ppm free chlorine washing only achieved 1.24 log reduction. The effect of the combined treatment of 30 mW/cm2 UV and 80 ppm PAA was also compared with 20 ppm free chlorine washing on larger sample sizes of 200, 500, and 1000 g lettuce. The increase of sample size from 80 g to 1000 g did not significantly (P < .05) affect the inactivation of Salmonella on lettuce for the combined treatment. In addition, the combined treatment of 80 ppm PAA and 30 mW/cm2 UV was able to maintain the Salmonella population in wash water under the detection limit of 0.3 log CFU/mL. It was therefore concluded that the combined treatment of 30 mW/cm2 UV and 80 ppm PAA could be used as an alternative to chlorine washing for lettuce decontamination.

Application of essential oils and polyphenols as natural antimicrobial agents in postharvest treatments: Advances and challenges

The use of natural antimicrobial agents is an attractive ecological alternative to the synthetic fungicides applied to control pathogens during postharvest. In order to improve industrial production systems, postharvest research has evolved toward integration with science and technology aspects. Thus, the present review aims to draw attention to the achieved advances and challenges must be overcome, to promote application of essential oils and polyphenols as antimicrobial agents, against phytopathogens and foodborne microorganisms during postharvest. Besides that, it attempts to highlight the use of coating and encapsulation techniques as emerging methods that improve their effectiveness. The integral knowledge about the vegetable systems, molecular mechanisms of pathogens and mechanisms of these substances would ensure more efficient in vitro and in vivo experiences. Finally, the cost-benefit, toxicity, and ecotoxicity evaluation will be guaranteed the successful implementation and commercialization of these technologies, as a sustainable alternative to minimize production losses of vegetable commodities.

Agaric acid reduces Salmonella biofilm formation by inhibiting flagellar motility

Salmonella biofilms are a common cause of contaminations in the food or feed industry. In a screening for novel compounds to combat biofilm-associated foodborne outbreaks, we identified agaric acid as a Salmonella Typhimurium biofilm inhibitor that does not affect planktonic growth. Importantly, the remaining biofilm cells after preventive treatment with agaric acid were significantly more sensitive to the common disinfectant hydrogen peroxide. Screening of a GFP-promoter fusion library of biofilm related genes revealed that agaric acid downregulates the transcription of genes responsible for flagellar motility. Concurrently, swimming motility was completely abrogated in the presence of agaric acid, indicating that biofilm inhibition occurs via interference with the motility phenotype. Moreover, agaric acid also reduced biofilm formation of Pseudomonas aeruginosa, Staphylococcus aureus and Escherichia coli. Agaric acid thus shows potential as an anti-virulence compound that inhibits both motility and biofilm formation.

Effectiveness of a peracetic acid solution on Escherichia coli reduction during fresh-cut lettuce processing at the laboratory and industrial scales

Fresh leafy greens like lettuce can be consumed raw and are susceptible to foodborne pathogens if they become contaminated. Recently, the number of reported pathogenic foodborne outbreaks related to leafy greens has increased. Therefore, it is important to try to alleviate the human health burden associated with these outbreaks. Processing of fresh-cut lettuce, including washing, is a step in the supply chain that needs to be well controlled to avoid cross-contamination. Current measures to control the quality of lettuce during washing include the use of chemicals like chlorine; however, questions regarding the safety of chlorine have prompted research for alternative solutions with peracetic acid (PAA). This study evaluates the effectiveness of a PAA (c.a. 75 mg/L) solution on the reduction of a commensal E. coli strain during the washing of fresh-cut lettuce. Experiments were performed at the laboratory scale and validated at the industrial scale. We observed that the use of PAA was not adversely affected by the organic load in the water. The contact time and dose of the PAA showed to be relevant factors, as observed by the approximately 5-log reduction of E. coli in the water. Results showed that once introduced during washing, E. coli remained attached to the lettuce, thus supporting the need to control for pathogenic bacteria earlier in the supply chain (e.g., during primary production) as well as during washing. Moreover, our results showed that the use of PAA during washing did not have an apparent effect on the levels of fluorescent pseudomonads (FP) and total heterotrophic bacteria (THB) in lettuce. Overall, our results at the laboratory and industrial scales confirmed that during the processing of fresh-cut produce, where the accumulation of soil, debris, and other plant exudates can negatively affect washing, the use of a PAA (c.a. 75 mg/L) solution was an effective and safe wash water disinfectant that can potentially be used at the industrial scale.

Optimizing the Environmental Profile of Fresh-Cut Produce: Life Cycle Assessment of Novel Decontamination and Sanitation Techniques

Fresh-cut vegetables, namely those that undergo processes such as washing, sorting, or chopping while keeping their fresh state, constitute an important market element nowadays. Among those operations, the washing step becomes really important due both to the extensive use of water resources and to the utilization of controversial water sanitizing agents, such as chlorine. To ideally eliminate those chlorinated compounds while decreasing water consumption, four novel filtrating technologies (pulsed corona discharge combined with nanofiltration, NF-PCD; classical ultrafiltration, UF; nanofiltration membranes integrating silver nanoparticles, NF-AgNP; and microfiltration with cellulose acetate membranes containing chitin nanocrystals, ChCA) have been proposed to eliminate any contaminating agent in recirculated water. Here, we performed a life cycle assessment (LCA) to assess the environmental effects of introducing these new solutions and to compare those impacts with the burden derived from the current strategy. The novel technologies showed a decreased environmental burden, mainly due to the enhanced water recirculation and the subsequent decrease in energy consumption for pumping and cooling the water stream. The environmental gain would be maintained even if a certain amount of chlorine was still needed. This analysis could serve as an aid to decision-making while evaluating the introduction of new sanitizing techniques.

Principles and applications of non-thermal technologies and alternative chemical compounds in meat and fish

Conventional methods of food preservation have demonstrated several disadvantages and limitations in the efficiency of the microbial load reduction and maintain food quality. Hence, non-thermal preservation technologies (NTPT) and alternative chemical compounds (ACC) have been considered a high promissory replacer to decontamination, increasing the shelf life and promoting low levels of physicochemical, nutritional and sensorial alterations of meat and fish products. The combination of these methods can be a potential alternative to the food industry. This review deals with the most critical aspects of the mechanisms of action under microbial, physicochemical, nutritional and sensorial parameters and the efficiency of the different NTPT (ultrasound, high pressure processing, gamma irradiation and UV-C radiation) and ACC (peracetic acid, bacteriocins, nanoparticles and essential oils) applied in meat and fish products. The NTPT and ACC present a high capacity of microorganisms inactivation, ensuring low alterations level in the matrix and high reduction of environmental impact. However, the application conditions of the different methods as exposition time, energy intensity and concentration thresholds of chemical compounds need to be specifically established and continuously improved for each matrix type to reduce to the maximum the physicochemical, nutritional and sensorial changes. In addition, the combination of the methods (hurdle concept) may be an alternative to enhance the matrix decontamination. In this way, undesirable changes in meat and fish products can be further reduced without a decrease in the efficiency of the decontamination.

Modelling the combined effect of chlorine, benzyl isothiocyanate, exposure time and cut size on the reduction of Salmonella in fresh-cut lettuce during washing process

This work aimed to study the effect of the combination of Sodium hypochlorite, the most used disinfectant by the vegetable industry, with a natural antimicrobial, benzyl-isothiocyanate (BITC), considering cutting surface and contact time, on the reduction of Salmonella in fresh-cut produce in washing operations under typical industrial conditions. Overall, the combinations of disinfectant and process parameters resulted in a mean reduction of Salmonella of 2.5 log CFU/g. According to statistical analysis, free chlorine and BITC concentrations, contact time and cut size exerted a significant effect on the Salmonella reduction (p ≤ 0.05). The optimum combination of process parameter values yielding the highest Salmonella reduction was a lettuce cut size of 15 cm2 washed for 110 s in industrial water containing 160 mg/L free chlorine and 40 mg/L BITC. A predictive model was also derived, which, as illustrated, could be applied to optimize industrial disinfection and develop probabilistic Exposure Assessments considering the effect of washing process parameters on the levels of Salmonella contamination in leafy green products. The present study demonstrated the efficacy of chlorine to reduce Salmonella populations in fresh-cut lettuce while highlighting the importance of controlling the washing process parameters, such as, contact time, cut size and concentration of the disinfectant to increase disinfectant efficacy and improve food safety.

Risk assessment of trihalomethanes exposure by consumption of IV gamma products: Evidences from a Portuguese regional survey

•

The consumption of IV gamma products is increasing worldwide.

•

Salad mix is the IV gamma product most consumed by respondents.

•

Consumption patterns are not associated with the main socio-demographic characteristics of consumers.

•

Levels of THMs on the analysed samples are negligible, as evaluated by GC–MS.

•

Risk assessment indicated no health concerns for the studied population.

Due to the current demand for healthier food, the IV gamma products industry has grown over the years. Additionally, it is well known that chlorine is a disinfectant largely used in this industry. However, the risk assessment associated with the formation of carcinogenic by-products from this halogenated disinfection has not been widely studied. The aim of this study was to assess the trihalomethanes (THMs) exposure through the consumption of IV gamma products, more specifically, salad mixes, and potential health risk in Portuguese population using a deterministic method. The quantification of THMs in salad mixes from the most representative Portuguese brands was performed by gas chromatography coupled to mass spectrometry (GC–MS). The THMs exposures were estimated by combining the THMs concentration data with a ready-to-eat salad mix consumption survey (case study applied in the Lisboa e Vale do Tejo area; n = 271). The concentration of THMs in all samples was below the limit of quantification of the equipment (1 μg/L), and this limit was used for the evaluation of the exposure. It was found that it is very small for the consumption pattern of these products in the studied population categories, suggesting that there is no risk for consumers due to the halogenated disinfection process. The highest estimated daily exposure was 7,65X10⁻⁵ mg/ kg bw/ week, which corresponds to a person who consumes such products daily.

In Situ Generation of Chlorine Dioxide for Decontamination of Salmonella, Listeria monocytogenes, and Pathogenic Escherichia coli on Cantaloupes, Mung Beans, and Alfalfa Seeds

ABSTRACT

In situ generation of chlorine dioxide to reduce microbial populations on produce surfaces has been shown to be effective on produce models. This study examined the treatment for decontamination of bacterial pathogens on whole cantaloupes and sprout seeds. Whole cantaloupes, mung beans, and alfalfa seeds were inoculated with Salmonella, Listeria monocytogenes, and Shiga toxin-producing Escherichia coli, sprayed with or dipped in 0.4 to 1.6% sodium chlorite (NaClO2) solutions, dried, and treated with 6 mM hydrochloric acid (HCl; sequential treatment). Controls were samples treated with NaClO2 or HCl (individual treatment). The pathogen populations on samples before and after treatments were enumerated to determine the reductions of pathogen populations by the treatments. The methods of applying NaClO2 and HCl (dipping for 30 min or spraying 0.2 g on cantaloupe rind [2 by 2 cm]), NaClO2 concentrations of 0.4 to 1.6% for cantaloupes, and treatment times of 5, 15, and 30 min for sprout seeds were evaluated to identify treatment parameters. For cantaloupes treated with spraying with 1.6% NaClO2, the sequential treatment caused significantly (P < 0.05) higher reductions (6.2 to 7.7 log CFU/cm2) than the combined reductions (3.2 to 5.2 log CFU/cm2) by the individual treatments. For cantaloupes treated by dipping in 1.6% NaClO2 and by spraying with 0.4 and 0.8% NaClO2, the reductions caused by the sequential treatment were not significantly (P > 0.05) different from those by the individual treatments. For mung beans, sequential 15- and 30-min treatments caused significantly (P < 0.05) higher reductions of 4.3 to 5.0 and 4.7 to 6.7 log CFU/g, respectively, than the individual treatments. The sequential 15-min treatment also caused high reductions of 5.1 to 7.3 log CFU/g on alfalfa seeds. The treatments did not bleach the color of cantaloupes and did not affect the germination rates of mung beans and alfalfa seeds. This study identified 1.6% NaClO2 and 6 mM HCl for sequential spraying treatment for cantaloupes and for sequential dipping (15-min) treatment for mung beans and alfalfa seeds that may be used for decontamination of whole cantaloupes and sprout seeds.

HIGHLIGHTS

Antibacterial Activity of Chrysanthemum buds Crude Extract Against Cronobacter sakazakii and Its Application as a Natural Disinfectant

Cronobacter sakazakii is an opportunistic food-borne pathogen that endangers the health of neonates and infants. This study aims to elucidate the antibacterial activity and mechanism of Chrysanthemum buds crude extract (CBCE) against C. sakazakii and its application as a natural disinfectant. The antibacterial activity was evaluated by the determination of the diameter of inhibition zone (DIZ), minimum inhibitory concentration (MIC), and minimum bactericide concentration (MBC). The antibacterial mechanism was explored based on the changes of growth curve assay, intracellular ATP concentration, membrane potential, intracellular pH (pH_in), content of soluble protein and nucleic acid, and cell morphology. Finally, the inactivation effects of CBCE against C. sakazakii in biofilm on stainless steel tube, tinplate, glass, and polystyrene were evaluated. The results showed that the DIZ, MIC, and MBC of CBCE against C. sakazakii were 14.55 ± 0.44-14.84 ± 0.38 mm, 10 mg/mL, and 20 mg/mL, respectively. In the process of CBCE acting on C. sakazakii, the logarithmic growth phase of the tested bacteria disappeared, and the concentrations of intracellular ATP, pH_in, bacterial protein, and nucleic acid were reduced. Meanwhile, CBCE caused the cell membrane depolarization and leakage of cytoplasm of C. sakazakii. In addition, about 6.5 log CFU/mL of viable C. sakazakii in biofilm on stainless steel tube, tinplate, glass, and polystyrene could be inactivated after treatment with 1 MIC of CBCE for 30 min at 25°C. These findings reveal the antibacterial activity and mechanism of CBCE against C. sakazakii and provide a possibility of using a natural disinfectant to kill C. sakazakii in the production environment, packaging materials, and utensils.

Effect of ultrasound processing on the bioaccessibility of phenolic compounds and antioxidant capacity of selected vegetables

Ultrasound processing can result in cell wall disruption, facilitating the release of the cellular content. Therefore, we hypothesized that sonication of vegetables could be used as a pre-treatment to increase the bioaccessibility of phenolic and antioxidant compounds. Overall, sonication (40 kHz, 250 W, 4 °C, 20 min) did not affect the main physicochemical parameters of tomato, lettuce, zucchini, and green and red pepper (p < 0.05). The polyphenolic content and antioxidant activity of digestive enzymatic extracts was higher than that of water:methanol extracts (p < 0.05). In addition, sonication resulted in increased bioaccessibility of phenolic compounds in lettuce and green pepper (p < 0.05), while no effect was observed for tomato, red pepper, and zucchini samples suggesting a matrix-dependent effect. The amount of phenolic compounds and antioxidants released by vegetables during a simulated gastrointestinal digestion may be higher than the one that can be expected from measurements in usual aqueous-organic extracts.

Antibacterial activity of the noni fruit extract against Listeria monocytogenes and its applicability as a natural sanitizer for the washing of fresh-cut produce

This study was conducted to investigate the antibacterial activity of the noni fruit extract (NFE) against Listeria monocytogenes (ATCC, 19111 and 19115) and assess its applicability for the washing of fresh-cut produce. Based on the results of the disc diffusion test, L. monocytogenes (ATCC, 19111 and 19115) was susceptible to the activity of NFE than other pathogens studied. Additionally, results of the time-kill assay indicated that NFE at a concentration of 0.5-0.7% effectively killed L. monocytogenes within 7 h. Furthermore, analysis of the intracellular components such as nucleic acids and proteins released from the bacterial cells and their SEM imaging revealed that NFE could increase the membrane permeability of cells resulting in their death. Compared to their unwashed samples, washing of romaine lettuce, spinach, and kale with 0.5% NFE gave a reduction of 1.47, 2.28, and 3.38 log CFU/g, respectively against L. monocytogenes (ATCC, 19111 and 19115), which is significantly different to that of NaOCl. A significant correlation was observed between the antibacterial effect induced due to NFE washing with the surface roughness of the fresh-cut produce than its surface hydrophobicity. Moreover, washing with NFE was not found to affect the color of the samples. These results indicated that NFE demonstrates good antibacterial activity against L. monocytogenes and can be used as a natural sanitizer to ensure the microbiological safety of fresh-cut produce.

Inactivation of molds on the surface of wheat sprouts by chlorophyllin-chitosan coating in the presence of visible LED-based light

The present study clearly demonstrated the significant antifungal activity of chlorophyllin-chitosan complex (Chl-CHS) after activation with visible light. This phenomenon afterwards was successfully applied for better microbial control of highly popular food- germinated wheat sprouts. Obtained results indicated that photoactivated Chl-CHS complex (0.001% Chl-0.1% CHS and 0.005% Chl-0.5% CHS, 405 nm, 76 J/cm²) considerably inhibited (83%) the growth of dominating sprout pathogenic microfungus Fusarium graminearum in vitro. Moreover, obvious delay of fungus growth by 4 days after treatment was observed. The efficiency of antifungal treatment strongly depended on used Chl-CHS complex concentration. The coating of wheat grains with Chl-CHS (0.005% Chl-0.5% CHS) and illumination with visible light (405 nm; 76 J/cm²) inactivated the molds on the surface of grains by 79%. It is important to note, that no grain surface microstructure damage observed by SEM imaging have been found. No inhibiting effects on seed germination process, viability, average weight of grains, length of seedlings and content of chlorophyll a and chlorophyll b in the seedlings or eventually visual quality after Chl-CHS coating of grains and illumination with visible light have been observed. In conclusion, chlorophyllin-chitosan coating in the concert with visible light has great potential as cost-effective, environmentally friendly and sustainable strategy for better microbial control of highly contaminated sprouts.

Post-process treatments are effective strategies to reduce Listeria monocytogenes on the surface of leafy greens: A pilot study

Growth of L. monocytogenes is among the most important factors affecting the risk of human listeriosis. In ready to eat leafy greens, the use of anti-Listeria treatments represents a good alternative to inhibit growth during storage. Several commercially available antimicrobial agents have been suggested as effective intervention strategies. Among them, phage preparations and bacteriocin-producing strains have shown promising results against L. monocytogenes. In this study, we investigate the efficacy of two commercially available surface treatments, the bacteriophage formulation PhageGuard Listex (Micreos Food Safety B.V., NL) and the bacteriocin-producing culture SafePro® (CHR Hansen, DK) to inactivate L. monocytogenes in fresh-cut curly endive after processing and during storage. Fresh-cut endive was inoculated with a cold-adapted L. monocytogenes cocktail of 6 strains (4.4 ± 0.0 log cfu/g) and treated with the anti-Listeria treatments. The treatments were applied using a spray system at two different places within the processing line, on the conveyor belt and in the centrifuge. A total of 5 different treatments were applied: i) Untreated (CT); ii) PhageGuard Listex on the conveyor belt (Listex_Conveyor); iii) PhageGuard Listex during centrifugation (Listex_Centrifuge); iv) SafePro on the conveyor belt (SafePro_Conveyor); and v) SafePro during centrifugation (SafePro_Centrifuge). Samples were stored 3 days at 5 °C plus 5 days at 8 °C. PhageGuard Listex treatment reduced L. monocytogenes in fresh-cut endive by 2.5 logs, regardless of the place of treatment application (conveyor belt or centrifuge). On the other hand, SafePro only reduced L. monocytogenes by 0.2 and 0.4 logs, at the conveyor belt and centrifuge, respectively. Maximum L. monocytogenes reductions of about 3.5 log units were observed in fresh-cut endive treated with PhageGuard Listex after 3 days of storage. At the end of the shelf life (8 days), the initial trends were maintained and the fresh-cut curly endive treated with PhageGuard Listex showed the lowest L. monocytogenes concentration. However, by the end of the shelf-life, L. monocytogenes showed higher levels (1.3-fold) than immediately after the application of the treatment. One hypothesis could be that L. monocytogenes cells, which were able to survive the anti-Listeria treatments, were also able to proliferate under the specific storage conditions. Based on the obtained results, PhageGuard Listex seems to be a promising decontamination agent for leafy greens aiming to reduce growth of the bacteria but further work is needed.

The antimicrobial activity of coenzyme Q0 against planktonic and biofilm forms of Cronobacter sakazakii

Coenzyme Q₀ (CoQ₀) has demonstrated antitumor, anti-inflammatory, and anti-angiogenic activities. Cronobacter sakazakii is an opportunistic foodborne pathogen associated with high mortality in neonates. In this study, the antimicrobial activity and possible antimicrobial mechanism of CoQ₀ against C. sakazakii were investigated. Moreover, the inactivation effect of CoQ₀ on C. sakazakii in biofilms was also evaluated. The minimum inhibitory concentration (MIC) of CoQ₀ against C. sakazakii strains ranged from 0.1 to 0.2 mg/mL. Treatment caused cell membrane dysfunction, as evidenced by cell membrane hyperpolarization, decreased intracellular ATP concentration and cell membrane integrity, and changes in cellular morphology. CoQ₀ combined with mild heat treatment (45, 50, or 55 °C) decreased the number of viable non-desiccated and desiccated C. sakazakii cells in a time- and dose-dependent manner in reconstituted infant milk. Furthermore, CoQ₀ showed effective inactivation activity against C. sakazakii in biofilms on stainless steel, reducing the number of viable cells and damaging the structure of the biofilm. These findings suggest that CoQ₀ has a strong inactivate effect on C. sakazakii and could be used in food production environments to effectively control C. sakazakii and reduce the number of illnesses associated with it.

Reduction of Escherichia coli O157:H7 and naturally present microbes on fresh-cut lettuce using lactic acid and aqueous ozone

Lactic acid (LA) is an effective sanitizer for disinfection of fresh produce. Tap water is generally used to wash disinfected fresh produce because sanitizer residues negatively affect the quality and organoleptic properties of the produce. However, tap water is ineffective for secondary disinfection compared with sanitizers. Thus, we propose a disinfection method using LA plus aqueous ozone (AO), an oxidizing sanitizer that does not lead to secondary residue. We compared the proposed method of 1% LA (90 s) plus 1 mg L-1 AO (30 s) or 2 mg L-1 AO (30 s) with the traditional method of 100 ppm chlorine (120 s) or 1% LA (120 s) plus tap water (30 s) and 2 mg L-1 AO (150 s). Microbial analysis showed that LA plus AO led to the greatest reductions in microbes (Escherichia coli O157:H7, aerobic mesophilic counts, aerobic psychrophilic counts, moulds, and yeasts) during storage (0-5 days at 5 °C). Quality analysis (colour, sensory qualities, electrolyte leakage, polyphenolic content, and weight loss) showed that LA + AO did not cause additional quality loss compared with tap water treatment. These results indicate that the hurdle technology proposed (LA plus AO) has a good potential for use in fresh produce disinfection.

A Novel Way for Whey: Cheese Whey Fermentation Produces an Effective and Environmentally-Safe Alternative to Chlorine

Cheese whey has been described as an environmental hazard due to its high organic content. Although it has been suggested that whey can be used as food disinfectant, it continues to pose an environmental problem because it still contains a high organic load. Here, we aimed to develop a low-cost, scalable fermentation protocol to produce a disinfectant from dairy waste that has very little organic content and high levels of lactic acid. Fermentation was achieved with industrial whey from ewe, goat, and cow’s milk, using a specific mesophilic-lactic acid bacteria starter mix over 120 h, which yielded the highest lactic acid production and the lowest lactose content. Antibacterial activity was observed against Listeria monocytogenes, Salmonella enterica, and Escherichia coli O157:H7, plus a total of thirteen other food pathogenic and spoilage strains, and antibacterial activities were determined to be highest after 120 h. We further validated this whey’s application as a disinfectant in shredded lettuce and compared its efficacy to that of chlorine, evaluating microbial quality, texture, color, and sensory perception, pH, and O2 and CO2 determinations. Results showed that not only was microbial quality better when using our whey solution (p < 0.05), but also the quality indicators for whey were statistically similar to those treated with chlorine. Hence, our work validates the use of an industrial waste whey as a low-cost, efficient, and environmentally safe disinfectant, with potential applications for minimally processed foodstuffs as an alternative to chlorine.

The impact of chlorine and heat on the infectivity and physicochemical properties of bacteriophage MS2

Enteric viruses and bacteriophages are exposed to various inactivating factors outside their host, and among them chlorine and heat are the most commonly used sanitizer in water industry and treatment in the food industry, respectively. Using MS2 phages as models for enteric viruses, we investigated the impact of free chlorine and heat on their physicochemical properties. Free chlorine was first evaluated alone. No increase in either capsid permeability or hydrophobicity was observed. The negative surface charge slightly increased suggesting molecular changes in the capsid. However, a weakening of the capsid by chlorine was suggested by differential scanning fluorimetry. This phenomenon was confirmed when chlorination was followed by a heat treatment. Indeed, an increase in the inactivation of MS2 phages and the permeability of their capsids to RNases was observed. More interestingly, an increase in the expression of hydrophobic domains at the phage surface was observed, but only for phages remaining infectious. The chlorine-caused weakening of the capsid suggested that, for an optimal use, the oxidant should be followed by heat. The increased permeability to RNases and the expression of hydrophobic domains may contribute to the development or improvement of molecular methods specific for infectious enteric viruses.

Rechargeable polyamide-based N-halamine nanofibrous membranes for renewable, high-efficiency, and antibacterial respirators

Emerging infectious diseases (EIDs) have been acknowledged as a major public health concern worldwide. Unfortunately, most protective respirators used to prevent EID transmission suffer from the disadvantage of lacking antimicrobial activity, leading to an increased risk of cross-contamination and post-infection. Herein, we report a novel and facile strategy to fabricate rechargeable and biocidal air filtration materials by creating advanced N-halamine structures based on electrospun polyamide (PA) nanofibers. Our approach can endow the resultant nanofibrous membranes with powerful biocidal activity (6 log CFU reduction against E. coli), an ultrahigh fine particle capture efficiency of 99.999% (N100 level for masks), and can allow the antibacterial efficacy and air filtration performance to be renewed in a one-step chlorination process, which has never been reported before. More importantly, for the first time, we revealed the synergistic effect involving the intrinsic structure of polymers and the assembling structure of nanofibers on the chlorination capacity. The successful fabrication of such a fascinating membrane can provide new insights into the development of nanofibrous materials in a multifunctional, durable, and renewable form.

Salmonella enterica Growth Conditions Influence Lettuce Leaf Internalization

Human pathogens on plants (HPOP) have evolved complex interactions with their plant host. Stomatal internalization is one such mode of interaction, where bacteria are attracted to stomata and penetrate into the substomatal cavity by a process mediated by chemotaxis. Internalization enables HPOP to evade the hostile environment of the leaf surface and find a protected, nutrient-rich niche within the leaf. Numerous studies have documented attachment and entry of the foodborne pathogens, Salmonella enterica and Escherichia coli into stomata. Internalization, however, varies considerably among different pathogens and in different plants, and both bacterial and plant’s factors were reported to influence HPOP attachment and internalization. Here we have studied the effect of laboratory growth conditions, on the internalization of Salmonella enterica serovar Typhimurium (STm) into lettuce leaf. We have further tested the potential involvement of universal stress-proteins in leaf internalization. We found that STm grown in Luria Bertani broth devoid of NaCl (LBNS), or in diluted LB (0.5×LB) internalized lettuce leaf better (62 ± 5% and 59 ± 7%, respectively) compared to bacteria grown in LB (15 ± 7%). Growth under non-aerated conditions also enhanced STm internalization compared to growth under aerated conditions. Growth temperature of 25 and 37°C did not affect STm internalization, however, growth at 42°C, significantly augmented leaf internalization. Since, the tested growth conditions represent moderate stresses, we further investigated the involvement of five universal-stress genes in STm leaf internalization following growth in LBNS medium. Knockout mutations in ydaA, yecG, ybdQ, and uspAB, but not in ynaF, significantly reduced STm internalization compared to the wild-type (wt) strain, without affecting bacterial attachment and motility. Transduction of the mutations back to the parent strain confirmed the linkage between the mutations and the internalization phenotype. These findings support a specific role of the universal-stress genes in leaf internalization. The present study highlights the complexity of bacterial internalization process and may provide partial explanation for the variable, sometimes-contrasting results reported in the literature regarding stomatal internalization by HPOP. Characterization of the regulatory networks that mediate the involvement of usp genes and the tested growth factors in STm internalization should contribute to our understanding of human pathogens-plant interactions.

Orthogonal array design for optimization of phenyllactic acid-sodium alginate blend coating and its effect on the browning and quality of minimally processed lily bulbs

BACKGROUND

In order to develop active packaging of lily products, we for the first time investigated the effects of phenyllactic acid (PLA) incorporated into a sodium alginate (SA)-based coating on the quality of minimally processed lily bulbs stored at 4 °C for 15 days.

RESULTS

L9 (3⁴ ) orthogonal array design showed that the optimal concentrations of PLA, SA and glycerinum were 0.03, 0.03 and 0.05 mol L^-1 , respectively, to prepare a blend coating. It was noticed that a PLA-SA blend coating treatment could inhibit browning and maintain the firmness and ascorbic acid of minimally processed lily bulbs. Compared with the control, polyphenol oxidase (PPO), peroxidase (POD) and phenylalanine ammonia-lyase (PAL) activities of PLA-SA blend coating treated minimally processed lily bulbs reduced by about 31%, 21% and 29% on the 15th day, respectively. Total phenolic and quinone contents decreased, respectively, by 16% and 55% at the same time. Moreover, PLA-SA blend coating treatment eliminated the accumulation of malonaldehyde (MDA) while inhibiting microbial growth of minimally processed lily bulbs.

CONCLUSIONS

These results showed PLA-SA blend coating could effectively maintain quality of minimally processed lily bulbs stored at 4 °C, and it might be a prospective technology. © 2018 Society of Chemical Industry.