Food waste treatment in an anaerobic dynamic membrane bioreactor (AnDMBR): Performance monitoring and microbial community analysis

Mechanistic insights into different illumination positions control algae production in anaerobic dynamic membrane filtration (AnDM) during decentralized wastewater treatment

Sunlight illumination has the potential to control the stability and sustainability of dynamic membrane (DM) systems. In this study, an up-flow anaerobic sludge blanket (UASB) reactor was combined with DM under different illumination positions (direct, indirect and no illumination) to treat wastewater. Results indicated that the UASB achieved a COD removal up to 87.05 % with an average methane production of 0.28 L/d. Following treatment by the UASB, it was found that under illumination, the removal of organic substances by DM exhibited poor performance due to algal proliferation. However, the DM systems demonstrated efficient removal of ammonia nitrogen, ranging from 96.21 % to 97.67 % after stabilization. Total phosphorus removal was 45.72 %, and membrane flux remained stable when directly illuminated. Conversely, the DM system subjected to indirect illumination showed unstable membrane flux and severe fouling resistance. These findings offer valuable insights into optimizing illumination positions in DM systems under anaerobic conditions.

Comparative study of high-performance mesophilic and thermophilic anaerobic membrane bioreactors in the co-digestion of sewage sludge and food waste: Methanogenic performance and energy recovery potential

To support smart cities in terms of waste management and bioenergy recovery, the co-digestion of sewage sludge (SeS) and food waste (FW) was conducted by the anaerobic membrane bioreactor (AnMBR) under mesophilic and thermophilic conditions in this study. The biogas production rate of the thermophilic AnMBR (ThAnMBR) at the SeS to FW ratio of 0:100, 75:25, 50:50 and 100:0 was 2.84 ± 0.21, 2.51 ± 0.26, 1.54 ± 0.26 and 1.31 ± 0.08 L-biogas/L/d, inconspicuous compared with that of the mesophilic AnMBR (MeAnMBR) at 3.00 ± 0.25, 2.46 ± 0.30, 1.63 ± 0.23 and 1.30 ± 0.17 L-biogas/L/d, respectively. The higher hydrolysis ratio and the poorer rejection efficiencies of the membrane under thermophilic conditions, resulting that the permeate COD, carbohydrate and protein of the ThAnMBR was higher than that of the MeAnMBR. The lost COD that might be converted into biogas was discharged with the permeate in the ThAnMBR, which was partly responsible for the inconspicuous methanogenic performance. Furthermore, the results of energy recovery potential assessment showed that the energy return on investment (EROI) of the MeAnMBR was 4.54, 3.81, 2.69 and 2.22 at the four SeS ratios, which was higher than that of the ThAnMBR at 3.29, 2.97, 2.02 and 1.80, respectively, indicating the advantage of the MeAnMBR over the ThAnMBR in energy recovery potential. The outcomes of this study will help to choose a more favorable temperature to co-digest SeS and FW to support the construction of smart cities.

Energy and nutrient recovery from municipal and industrial waste and wastewater-a perspective

This publication highlights the latest advancements in the field of energy and nutrient recovery from organics rich municipal and industrial waste and wastewater. Energy and carbon rich waste streams are multifaceted, including municipal solid waste, industrial waste, agricultural by-products and residues, beached or residual seaweed biomass from post-harvest processing, and food waste, and are valuable resources to overcome current limitations with sustainable feedstock supply chains for biorefining approaches. The emphasis will be on the most recent scientific progress in the area, including the development of new and innovative technologies, such as microbial processes and the role of biofilms for the degradation of organic pollutants in wastewater, as well as the production of biofuels and value-added products from organic waste and wastewater streams. The carboxylate platform, which employs microbiomes to produce mixed carboxylic acids through methane-arrested anaerobic digestion, is the focus as a new conversion technology. Nutrient recycling from conventional waste streams such as wastewater and digestate, and the energetic valorization of such streams will also be discussed. The selected technologies significantly contribute to advanced waste and wastewater treatment and support the recovery and utilization of carboxylic acids as the basis to produce many useful and valuable products, including food and feed preservatives, human and animal health supplements, solvents, plasticizers, lubricants, and even biofuels such as sustainable aviation fuel.

ONE-SENTENCE SUMMARY

Multifaceted waste streams as the basis for resource recovery are essential to achieve environmental sustainability in a circular economy, and require the development of next-generation waste treatment technologies leveraging a highly adaptive mixed microbial community approach to produce new biochemicals, biomaterials, and biofuels from carbon-rich organic waste streams.

High-rate anaerobic digestion of sewage sludge using anaerobic dynamic membrane bioreactor under various sludge composition and organic loading rates

This study investigates the effects of sludge compositions and organic loading rates (OLRs) on stable biomethane production during sludge digestion. Batch digestion experiments evaluate the effects of alkaline-thermal pretreatment and waste activated sludge (WAS) fractions on the biochemical methane potential (BMP) of sludge. A lab-scale anaerobic dynamic membrane bioreactor (AnDMBR) is fed with a mixture of primary sludge and pretreated WAS. Monitoring of volatile fatty acid to total alkalinity (FOS/TAC) helps maintain operational stability. The highest average biomethane production rate of 0.7 L/L·d is achieved when the OLR, hydraulic retention time, WAS volume fraction, and FOS/TAC ratio are 5.0 g COD/L·d, 12 days, 0.75, and 0.32, respectively. This study finds functional redundancy in two pathways: hydrogenotrophic and acetolactic. An increase in OLR promotes bacterial and archaeal abundance and specific methanogenic activity. These results can be applied to the design and operation of sludge digestion for stable, high-rate biomethane recovery.

Enhancement of biomethane recovery from batch anaerobic digestion by exogenously adding an N-acyl homoserine lactone cocktail

Biomethane recovered through anaerobic digestion (AD) is a renewable, sustainable, and cost-effective alternative energy source that has the potential to help address rising energy demands. Efficient bioconversion during AD depends on the symbiotic relationship between hydrolytic bacteria and methanogenic archaea. Interactions between microorganisms occur in every biological system via a phenomenon known as quorum sensing (QS), in which signaling molecules are simultaneously transmitted and detected as a mode of cell-to-cell communication. However, there's still a lack of understanding on how QS works in the AD system, where diverse bacteria and archaea interact in a complex manner. In this study, different concentrations (0.5 and 5 μM) of signaling molecules in the form of an N-acyl homoserine lactone cocktail (C6-, C8-, C10-, and 3-oxo-C6-HSL) were prepared and introduced into anaerobic batch reactors to clearly assess how QS affects AD systems. It was observed that the methane yield increased with the addition of AHLs: a 5 μM AHL cocktail improved the methane yield (341.9 mL/g-COD) compared to the control without AHLs addition (285.9 mL/g-COD). Meanwhile, evidence of improved microbial growth and cell aggregation was noticed in AHLs-supplemented systems. Our findings also show that exogenously adding AHLs alters the microbial community structure by increasing the overall bacterial and archaeal population counts while favoring the growth of the methanogenic archaea group, which is essential in biomethane synthesis.

Anaerobic membrane bioreactors for pharmaceutical-laden wastewater treatment: A critical review

Pharmaceuticalsare a diverse group of chemical compounds widely used for prevention and treatment of infectious diseases in both humans and animals. Pharmaceuticals, either in their original or metabolite form, find way into the wastewater treatment plants (WWTPs) from different sources. Recently, anaerobic membrane bioreactors (AnMBR) has received significant research attention for the treatment of pharmaceuticals in various wastewater streams. This review critically examines the behaviour and removal of a wide array of pharmaceuticals in AnMBR with primary focus on their removal efficiencies and mechanisms, critical influencing factors, and the microbial community structures. Subsequently, the inhibitory effects of pharmaceuticals on the performance of AnMBR and membrane fouling are critically discussed. Furthermore, the imperative role of membrane biofouling layer and its components in pharmaceuticals removal is highlighted. Finally, recent advancements in AnMBR configurations for membrane fouling control and enhanced pharmaceuticals removal are systemically discussed.

A Novel Anaerobic Gravity-Driven Dynamic Membrane Bioreactor (AnGDMBR): Performance and Fouling Characterization

Despite numerous studies undertaken to define the development and significance of the dynamic membrane (DM) formed on some coarse materials, the optimization of reactor configuration and the control of the membrane fouling of anaerobic dynamic membrane bioreactor (AnDMBR) need to be further investigated. The aim of this study was to design a novel anaerobic gravity-driven dynamic membrane bioreactor (AnGDMBR) for the effective and low-cost treatment of municipal wastewater. An 800 mesh nylon net was determined as the optimal support material based on its less irreversible fouling and higher effluent quality by the dead-end filtration experiments. During the continuous operation period of 44 days, the reactor performance, DM filtration behavior and microbial characteristics were studied and compared with the results of recent studies. AnGDMBR had a higher removal rate of chemical oxygen demand (COD) of 85.45 ± 7.06%. Photometric analysis integrating with three-dimensional excitation–emission matrix fluorescence spectra showed that the DM effectively intercepted organics (46.34 ± 16.50%, 75.24 ± 17.35%, and 66.39 ± 17.66% for COD, polysaccharides, and proteins). The addition of suspended carriers effectively removed the DM layer by mechanical scouring, and the growth rate of transmembrane pressure (TMP) and the decreasing rate of flux were reduced from 18.7 to 4.7 Pa/h and 0.07 to 0.01 L/(m²·h²), respectively. However, a dense and thin morphological structure of the DM layer was still observed in the end of reactor operation and plenty of filamentous microorganisms (i.e., SJA-15 and Anaerolineaceae) and the acidogens (i.e., Aeromonadaceae) predominated in the DM layer, which was also embedded in the membrane pore and led to severe irreversible fouling. In summary, the novel AnGDMBR has a superior performance (higher organic removal and lower fouling rates), which provides useful information on the configuration and operation of AnDMBRs for municipal wastewater treatment.

A review on anaerobic membrane bioreactors for enhanced valorization of urban organic wastes: Achievements, limitations, energy balance and future perspectives

Sustainable urban development is threatened by an impending energy crisis and large amounts of organic wastes generated from the municipal sector among others. Conventional waste management methods involve greenhouse gas (GHG) emission and limited resource recovery, thus necessitating advanced techniques to convert such wastes into bioenergy, bio-fertilizers and valuable-added products. Research and application experiences from different scale applications indicate that the anaerobic membrane bioreactor (AnMBR) process is a kind of high-rate anaerobic digester for urban organic wastes valorization including food waste and waste sludge, while the research status is still insufficiently summarized. Through compiling recent achievements and literature, this review will focus on the following aspects, including AnMBR treatment performance and membrane fouling, technical limitations, energy balance and techno-economic assessment as well as future perspectives. AnMBR can enhance organic wastes treatment via complete retention of functional microbes and suspended solids, and timely separation of products and potential inhibitory substances, thus improving digestion efficiency in terms of increased organics degradation rates, biogas production and process robustness at a low footprint. When handling high-solid organic wastes, membrane fouling and mass transfer issues can be the challenges limiting AnMBR applications to a wet-type digestion, thus countermeasures are required to pursue extended implementations. A conceptual framework is proposed by taking various organic wastes disposal and final productions (permeate, biogas and biosolids) utilization into consideration, which will contribute to the development of AnMBR-based waste-to-resource facilities towards sustainable waste management and more economic-environmental benefits output.

Comparison of three anaerobic digestion reactors for low-carbon wastewater treatment

In this study, three anaerobic digestion reactors using up-flow anaerobic sludge blanket (UASB), anaerobic sequencing batch reactor (AnSBR), and anaerobic membrane bioreactor (AnMBR) were studied. The chemical oxygen demand (COD), gas production, sludge performance, and microbial characteristics of the anaerobic digestion process were assessed. The results showed that the average COD removal efficiencies reached 86%, 83%, and 85%, with corresponding removed rates of 2.49, 0.48, and 0.79 kg COD m-3 d-1 in UASB, AnSBR, and AnMBR, respectively. After the reactors attained stable operation, both extracellular polymeric substances and soluble microbial products decreased in all the reactors compared with the seed sludge. Methanothrix was the dominant archaea for methane production in the UASB, the relative abundance of which increased from 58.3% to 83.4%. These results identify UASB as the most suitable reactor for anaerobic digestion when treating wastewater with low carbon. Such reactors are important for the application and development of the energy self-sufficiency in sewage treatment. PRACTITIONER POINTS: UASB, SBR, and MBR were adopted to treat low-carbon wastewater using anaerobic digestion process. UASB performed the highest COD removal from low-carbon wastewater. The main microorganisms in UASB were Methanothrix, Methanomassiliicoccus, and Methanobacterium.

Methanogenic performance and microbial community during thermophilic digestion of food waste and sewage sludge in a high-solid anaerobic membrane bioreactor

The methanogenic performance and microbial community of the thermophilic anaerobic mono-digestion and co-digestion of food waste and sewage sludge in a high-solid membrane bioreactor were investigated by a continuous experiment. The methane recovery rate of the system reached 98.0% and 89.0% when the substrate was pure food waste and 25% sewage sludge substitution, respectively. Kinetics characterization showed that hydrolysis was the rate-limiting step in both mono-digestion and co-digestion while methanogenic performance and microbial community were significantly affected by feed condition. The dominant archaea for methane generation shifted from Methanothermobacter thermophilus (72.82%) to Methanosarcina thermophila (96.25%) with sewage sludge gradually added from 0% to 100% in the substrate. The relationships between digestion performance, such as the accumulation of soluble proteins in the reactor, and functional microbial groups were also carefully analyzed. Finally, reasonable metabolic pathways for mono-digestion and co-digestion were summarized.

Enhanced anaerobic digestion of waste-activated sludge via bioaugmentation strategy-Phylogenetic investigation of communities by reconstruction of unobserved states (PICRUSt2) analysis through hydrolytic enzymes and possible linkage to system performance

In this study, anaerobic digestion of waste-activated sludge was bioaugmented with hydrolytic bacteria, Bacteroidetes uniformis (Bacteroidetes, B) and Clostridium sp. (Firmicutes, F) at various dosages. Bioaugmentation resulted in enhanced methane conversion of waste-activated sludge. The highest methane yield of 298.1 mL CH₄/g-COD, 85.2% COD conversion efficiency was obtained when Bacteroidetes uniformis and Clostridium sp. were augmented at 100 and 900 CFU/mL, respectively. The microbial community analysis demonstrated that bioaugmentation increased the proportion of Bacteroidetes, Firmicutes, and Proteobacteria. Furthermore, at the highest methane yield, the principal methanogenic pathway was altered from acetoclastic to a mixture of hydrogenotrophic and acetoclastic; the major species shifted from Methanosaeta concilii to Methanobacterium subterraneum. Predicted gene analysis revealed that increased expression of hydrolases resulted in enhanced methane conversion through bioaugmentation.

Anaerobic self-forming dynamic membrane bioreactors (AnSFDMBRs) for wastewater treatment - Recent advances, process optimization and perspectives

Recently, anaerobic self-forming dynamic membrane bioreactors (AnSFDMBRs) have attracted increasing attention, and are considered as an alternative to conventional anaerobic membrane bioreactors (AnMBRs). The key advantages of AnSFDMBRs include high flux, low propensity towards fouling, and low capital and operational costs. Although there have been several reviews on AnMBRs, very few reviews on AnSFDMBR system. Previous AnSFDMBR studies have focused on lab-scale to investigate the long-term flux, methods to improve performance and the associated mechanisms. Microbial analysis showed that the phyla namely Proteobacteria, Bacteroidetes and Firmicutes are dominant in both bulk sludge and cake biofilm, but their abundance is low in biocake. This review critically examines the fundamentals of AnSFDMBRs, operational conditions, process optimization and applications. Moreover, the current knowledge gaps (e.g., dynamic membrane module optimization, membrane surface modification and functional microbes enrichment) that should be studied in future to design an efficient AnSFDMBR system for treatment of diverse wastewaters.

Effect of high concentration of ammonium on production of n-caproate: Recovery of a high-value biochemical from food waste via lactate-driven chain elongation

Ammonium accumulation is inevitable during the fermentation of food waste (FW), challenging the application of chain elongation process upgrading FW into the high-value biochemical n-caproate, which is a medium chain carboxylate. This study is the first to investigate ammonium inhibition of lactate-driven chain elongation process. The short-term exposure of a Clostridium IV-dominated chain elongating reactor microbiome at an ammonium concentration of 1-4 g L^-1 linearly decreased n-caproate production by 25-80%. High levels of ammonium (≥5 g L^-1) could cause failure of chain elongation, shifting the product from n-caproate to propionate. The involved mechanisms revealed that ammonium reshaped the microbial community from Clostridium IV domination to Clostridium IV and Propionibacterium co-domination (based on 16S rRNA sequencing) and reduced the activities of key enzymes involved in the reversed β-oxidization pathway. We propose an effective strategy from our study, which is the first one to do in our knowledge, to upgrade raw FW without dilution to n-caproate: lowering the ammonium accumulation to 1.0 g L^-1 at the setup phase for adaptation and prolonging the hydraulic retention time (10 days) during the operation phase for the colonization of chain-elongation bacteria. These findings lay a foundation for the implementation of the LCE process on FW, providing an alternative way to alleviate the global FW crisis.

Perspectives on microbial community in anaerobic digestion with emphasis on environmental parameters: A systematic review

This paper review is aiming to comprehensively identify and appraise the current available knowledge on microbial composition and microbial dynamics in anaerobic digestion with focus on the interconnections between operational parameters and microbial community. We systematically searched Scopus, Web of Science, pubmed and Embase (up to August 2019) with relative keywords to identify English-language studies published in peer-reviewed journals. The data and information on anaerobic reactor configurations, operational parameters such as pretreatment methods, temperature, trace elements, ammonia, organic loading rate, and feedstock composition and their association with the microbial community and microbial dynamics were extracted from eligible articles. Of 306 potential articles, 112 studies met the present review objectives and inclusion criteria. The results indicated that both aceticlastic and hydrogenotrophic methanogenesis are dominant in anaerobic digesters and their relative composition is depending on environmental conditions. However, hydrogenotrophic methanogens are more often observed in extreme conditions due to their higher robustness compared to aceticlastic methangoens. Firmicutes and Bacteroidetes phyla are most common fermentative bacteria of the acidogenic phase. These bacteria secrete lytic enzymes to degrade organic matters and are able to survive in extreme conditions and environments due to their spores. In addition, among archaea Methanosaeta, Methanobacterium, and Methanosarcinaceae are found at high relative abundance in anaerobic digesters operated with different operational parameters. Overall, understanding the shifts in microbial composition and diversity as results of operational parameters variation in anaerobic digestion process would improve the stability and process performance.

Symbiotic integration of bioprocesses to design a self-sustainable life supporting ecosystem in a circular economy framework

Climate change, resource depletion and unsustainable crop productivity are major challenges that mankind is currently facing. Natural ecosystems of earth's biosphere are becoming vulnerable and there is a need to design Bioregenerative Life Support Systems (BLSS) which are ecologically engineered microcosms that could effectively deal with problems associated with urbanization and industrialization in a sustainable manner. The principles of BLSS could be integrated with waste fed biorefineries and solar energy to create a self-sustainable bioregenerative ecosystem (SSBE). Such engineered ecosystems will have potential to fulfil urban life essentials and climate change mitigation thus generating ecologically smart and resilient communities which can strengthen the global economy. This article provides a detailed overview on SSBE framework and its improvement in the contemporary era to achieve circular bioeconomy by means of effective resource recycling.

The transition temperature (42 °C) from mesophilic to thermophilic micro-organisms enhances biomethane potential of corn stover

Mesophilic and thermophilic digestion has long been considered as preferred temperature ranges for anaerobic digestion. However, in this study, the effects of temperatures (37, 42, 47, and 55 °C) on the biomethane potential of corn stover were conducted with batch experiments, and the highest biomethane potential was at 42 °C. It was inferred that the change of feed materials, e.g., pretreatment caused by acidification (pH 6.0) during the lag time (4 days), was the main driver for higher biomethane potential. The natural pretreatment stimulated by a slight digestive temperature increase to 42 °C can enhance the biomethane potential of corn stover without adding extra acid. Meanwhile, metabolic pathways of methanogens changed from acetoclastic to mixotrophic and hydrogenotrophic methanogenesis. Based on these results, the transition temperature (42 °C) from mesophilic to thermophilic micro-organisms could be a promising option for corn stover anaerobic digestion.

Inhibition of norfloxacin on anaerobic digestion: Focusing on the recoverability and shifted microbial communities

Antibacterial properties of norfloxacin (NOR) could cause adverse impact on engineered biological process. In this study, the objective was to investigate the inhibitory effects of NOR on anaerobic digestion focusing on the recoverability and microbial community changes. The effects of different concentrations of NOR on anaerobic digestion were studied with three continuous feed cycles. Results showed that NOR seriously inhibited the methane production with an 50% inhibitory concentration (IC₅₀) of 0.41 mM. In addition, with extending of exposure time, inhibitory effect increasingly strengthened and the IC₅₀ values decreased to 0.16 mM and 0.07 mM in the second and third feeding cycle, respectively. However, when the inhibitor in supernatant was removed, the performance recovered and the relative methane yield increased by 9 times from 25.38 mL/g VS to 257.05 mL/g VS. The transformation of NOR showed that the degradation of NOR in the anaerobic digestion was difficult and the recovery was due to the removal of NOR. The microbial analysis revealed that the inhibition of NOR on bacteria of Candidatus_Cloacimonas, Petrimonas, Ercella, Sphaerochaeta and hydrogenotrophic methanogens of Methanoculleus and Methanobacterium was recoverable when NOR was removed. However, it was irreversible for acetoclastic methanogen of Methanosaeta. These findings provided comprehensive understanding on the characteristics of NOR inhibition and also provided feasible strategy to recover the NOR inhibited anaerobic digestion.

A comparative study of artificial cow and sheep rumen fermentation of corn straw and food waste: Batch and continuous operation

To optimize the artificial rumen microorganism sources and develop a stable artificial rumen system, batch and continuous operation were investigated with corn straw and food waste as substrates. The batch trials evaluated the volatile fatty acid (VFA) yield, biogas production, and lignocellulose degradation efficiency. The continuous test evaluated the performance of the artificial cow and sheep rumen systems using a dynamic membrane bioreactor (DMBR) with a stepwise organic loading rate at mesophilic temperature. The anaerobic digestion (AD) of the lignocellulose biomass after rumen fermentation pretreatment and of the permeate from the artificial rumen system were also evaluated for CH₄ production. The results indicated that the cow rumen microorganisms were more suitable than sheep rumen microorganisms for lignocellulosic biomass pretreatment and maximized the CH₄ yield through the AD process without inhibition. After approximately four months of continuous operation, a stable and continuous artificial rumen system for lignocellulosic biomass degradation was achieved with cow rumen fluid as inoculum. Based on analysis of the core lignocellulose-degrading enzyme levels and gel filtration chromatography, the cow rumen microorganisms could secrete more extracellular multienzyme complexes to hydrolyze lignocellulosic biomass than the sheep rumen microorganisms in vitro. During the batch and continuous operations, a high diversity and similar richness of bacteria and fungi demonstrated that the cow rumen microorganisms can be used as a preferred inoculum for the artificial rumen system. The use of an artificial cow rumen system with a DMBR is a promising way to construct a stable and continuous artificial rumen system to biodegrade lignocellulosic biomass for biogas production.

Acclimatization of anaerobic sludge with cow manure and realization of high-rate food waste digestion for biogas production

Long-term acclimatization of anaerobic sludge was conducted by operating a mesophilic continuously stirred anaerobic reactor (CSTR) with continuous feeding of food wastes (FW) and cow manure (CM). During the long-term acclimatization, continued increase of enzyme activity was revealed, while the microbial structure tended stable as shown by the Shannon index and microbial community. By biomethane potential analysis, the acclimated sludge had a methane yield about 13 times higher than the initial anaerobic sludge. The acclimated sludge was subsequently used for FW digestion with stepwise organic loading rate increase without CM addition. The functional phyla of Bacteroidetes and Proteobacteria, which originated from CM but not very abundant, were significantly enriched not only during sludge acclimatization with CM addition but also in the process of FW digestion without CM addition. A microbe coexistence network was proposed to support an explanation of the metabolic pathways of FW digestion using the acclimated sludge.

Membrane processes

This literature review provides a review for publications in 2018 and 2019 and includes information membrane processes findings for municipal and industrial applications. This review is a subsection of the annual Water Environment Federation literature review for Treatment Systems section. The following topics are covered in this literature review: industrial wastewater and membrane. Bioreactor (MBR) configuration, membrane fouling, design, reuse, nutrient removal, operation, anaerobic membrane systems, microconstituents removal, membrane technology advances, and modeling. Other sub-sections of the Treatment Systems section that might relate to this literature review include the following: Biological Fixed-Film Systems, Activated Sludge, and Other Aerobic Suspended Culture Processes, Anaerobic Processes, and Water Reclamation and Reuse. This publication might also have related information on membrane processes: Industrial Wastes, Hazardous Wastes, and Fate and Effects of Pollutants.

Food-processing wastes

Literature published in 2018 and literature published in 2019 related to food-processing wastes treatment for industrial applications are reviewed. This review is a subsection of the Treatment Systems section of the annual Water Environment Federation literature review and covers the following food-processing industries and applications: general, meat and poultry, fruits and vegetables, dairy and beverage, and miscellaneous treatment of food wastes. PRACTITIONER POINTS: This article summarizes literature reviews published in 2018 and in 2019 related to food processing wastes treatment for industrial applications are reviewed. This review is a subsection of the Treatment Systems section of the annual Water Environment Federation literature review and covers the following food processing industries and applications: general, meat and poultry, fruits and vegetables, dairy and beverage, and miscellaneous treatment of food wastes.

Higher load operation by adoption of ethanol fermentation pretreatment on methane fermentation of food waste

The study aims to examine whether ethanol fermentation pretreatment (EP) of food waste can contribute to high load operation on methane fermentation using an anaerobic membrane bioreactor (AnMBR). The hydraulic retention time was reduced stepwise from 20 to 5 days to increase the load by increasing the feeding volume. The corresponding organic loading rate (OLR) ranged from 6.6 to 26.5 g-COD/L/day. The control series (without pretreatment) was operable to an OLR of 8.8 g-COD/L/day versus 26.5 g-COD/L/day for the EP series. In the control series, the major volatile fatty acid (VFA) produced by acidogenesis in the reactor was propionic acid because based on Gibbs free energy variations for the methane conversion, acetic acid conversion was not as easy as from propionic acid as from ethanol in the EP series. EP proved effective in avoiding VFA accumulation and subsequent decreased pH. Therefore, EP significantly improves AnMBR performance.

Antagonistic effect of zinc oxide nanoparticle and surfactant on anaerobic digestion: Focusing on the microbial community changes and interactive mechanism

The objective of this study was to evaluate the antagonistic effect of emerging pollutants of zinc oxide nanoparticles (ZnO NPs) and sodium dodecyl sulfate (SDS) on anaerobic digestion and explore their potential mechanism. The results indicated that at a low inhibitory concentration of ZnO NPs (1.0 mM), the practical co-inhibition was decreased by 24% and 18% in co-existence of 50 mg/L SDS and 300 mg/L SDS, respectively. More importantly, the co-existence of 300 mg/L SDS greatly enhanced methanogenesis of organics in seriously inhibited case (2.0 mM of ZnO NPs). The microbial community analysis showed that co-existed SDS enhanced the growth of Methanothrix, Methanosarcina and Methanobacterium. The antagonistic enhancement could be attributed to the net charge reversal, partially agglomeration of ZnO NPs and/or reduction of Zn²⁺ release in the presence of SDS. These findings could provide useful information for evaluating the co-inhibition of SDS and ZnO NPs on biological processes.

Carbon cloth enhances treatment of high-strength brewery wastewater in anaerobic dynamic membrane bioreactors

Anaerobic dynamic membrane bioreactors (AnDMBRs) can improve the efficiency of organic matter removal during wastewater treatment at a low cost. However, application of AnDMBRs for treatment of high-strength wastewater is usually unsuccessful. This study investigated whether use of conductive carbon cloth as the supporting material in an AnDMBR permits higher organic loading rates for treatment of brewery wastewater than non-conductive polyester cloth. The AnDMBR with carbon cloth operated stably with a COD removal efficiency of 98% even when high concentrations of influent COD (10,000 mg/L) were provided, while the polyester cloth reactor deteriorated when reactors were fed only 5000 mg/L influent COD. Microorganisms capable of direct interspecies electron transfer (DIET), including Geobacter and Methanothrix species, dominated the surface of the carbon cloth. These results demonstrate that carbon cloth provides an excellent supporting material for AnDMBRs by stimulating growth of microorganisms that can directly transport electrons to and from conductive materials.

Enhanced hydrolysis and acidification of cellulose at high loading for methane production via anaerobic digestion supplemented with high mobility nanobubble water

In this study, CH₄ production from anaerobic digestion (AD) of refractory cellulose was investigated at a high loading of 3.5 (VS_cellulose/VS_inoculum) under nanobubble water (NBW) addition. A longer proton spin-spin relaxation time (2611-2906 ms) of NBW during 35 days' storage reflected its high mobility and diffusion of water molecules. Higher volatile fatty acids were yielded at the hydrolysis-acidification stage under NBW addition. Methanogenesis tests showed that Air-NBW and CO₂-NBW supplementation accelerated the utilization of crystalline cellulose, achieving methane yields of 264 and 246 mL CH₄/g-VS_reduced, increasing by 18% and 10% compared to deionized water addition (the control), respectively. In addition, under NBW addition the cellulose crystallinity reduction was enhanced by 14-20% with microbial community being enriched with hydrolytic and methanogenic bacteria. Results from this work suggest that NBW environment with no chemical addition and relatively low energy consumption is advantageous for enhanced AD process of cellulosic biomass.

Cow manure as additive to a DMBR for stable and high-rate digestion of food waste: Performance and microbial community

Cow manure (CM) was added to a dynamic membrane bioreactor (DMBR) operated under anaerobic condition for enhancing food waste (FW) digestion for over 300 days with stepwise increase of organic loading rates (OLRs) from 1.07 to 11.9 g COD/L/day. At a FW/CM ratio of 3.5:1 (based on volatile solids), the mixed liquor pH was always above 8.0 and no apparent volatile fatty acids (VFAs) accumulation occurred even at the highest OLR of 11.9 g COD/L/day (hydraulic retention time as 10 days and solid retention time as 15.5 days, correspondingly), indicating a very stable operation condition which resulted in an average CH₄ yield as high as 250 mL/g COD and CH₄ production as high as 2.71 L CH₄/L/day. The hardly biodegradable organic components, such as cellulose, hemicellulose, and lignin, were effectively degraded by 78.3%, 58.8%, and 47.5%, respectively. Significantly high anaerobic digestion reaction ratios, especially the hydrolysis ratio which is usually the limiting factor, were calculated based on experimental results. Furthermore, the high lignocellulase contents and coenzyme F₄₂₀ levels, along with the decrease of cellulose crystallinity from 72.6% to 16.4% in the feedstock, provided strong evidence of an enhanced biological activity by CM addition. By high-throughput sequencing analysis, more abundant and diverse bacterial, archaeal, and fungal genera were identified from the DMBR sludge. With CM addition, the biodegradation of lignocellulose might have produced sufficient H₂ and CO₂ for the hydrogenotrophic methanogens such as Methanoculleus, Methanomassiliicoccus, and Methanobacterium, which were highly tolerant to ammonium inhibition, and then the elevated ammonium level would have provided high buffering capacity in the DMBR thus ensuring a stable condition for high rate FW digestion and CH₄ production.

Effect of shear velocity and feed concentration on the treatment of food waste in an anaerobic dynamic membrane Bioreactor: Performance Monitoring and microbial community analysis

The formation of the dynamic membrane (DM) in an anaerobic dynamic membrane bioreactor (AnDMBR) treating food waste was, previously, found to be beneficial to the stable performance of an anaerobic digestion system. This study examines the effect of shear velocity and feed concentration on the performance and microbial community of an AnDMBR treating food waste. The shear velocity was varied from 0.04 to 1.74 m/h, using three different feed concentrations (50, 80, and 100 g-COD/L). The highest average methane production rate of 2.6 L-CH₄/L/d was achieved at a feed concentration and shear velocity of 100-g COD/L and 0.34 m/h, respectively. Increasing shear velocity, within certain limits, is beneficial to AnDMBR systems, promoting better mixing, substrate-biomass interactions, and DM layer formation. Methanosarcina flavescens proliferated (69%) at high shear velocities when acetic acid was the major volatile fatty acid. The abundance ratio between Bacteroidetes and Firmicutes showed a linear relationship to methanogenic performance.