1
|
Topalcengiz Z, Chandran S, Gibson KE. A comprehensive examination of microbial hazards and risks during indoor soilless leafy green production. Int J Food Microbiol 2024; 411:110546. [PMID: 38157635 DOI: 10.1016/j.ijfoodmicro.2023.110546] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/14/2023] [Revised: 10/26/2023] [Accepted: 12/16/2023] [Indexed: 01/03/2024]
Abstract
Produce grown under controlled environment agriculture (CEA) is often assumed to have a reduced risk of pathogen contamination due to the low chance of exposure to outdoor contaminant factors. However, the 2021 outbreak and numerous recalls of CEA-grown lettuce and microgreens demonstrate the possibility of pathogen introduction during indoor production when there is a failure in the implementation of food safety management systems. Indoor production of commercial leafy greens, such as lettuce and microgreens, is performed across a range of protective structures from primitive household setups to advanced and partially automatized growing systems. Indoor production systems include hydroponic, aquaponic, and aeroponic configurations. Hydroponic systems such as deep water culture and nutrient film technique comprised of various engineering designs represent the main system types used by growers. Depending on the type of leafy green, the soilless substrate, and system selection, risk of microbial contamination will vary during indoor production. In this literature review, science-based pathogen contamination risks and mitigation strategies for indoor production of microgreens and more mature leafy greens are discussed during both pre-harvest and post-harvest stages of production.
Collapse
Affiliation(s)
- Zeynal Topalcengiz
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA; Department of Food Engineering, Faculty of Engineering and Architecture, Muş Alparslan University, 49250 Muş, Türkiye
| | - Sahaana Chandran
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA
| | - Kristen E Gibson
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA.
| |
Collapse
|
2
|
Thomas GA, Paradell Gil T, Müller CT, Rogers HJ, Berger CN. From field to plate: How do bacterial enteric pathogens interact with ready-to-eat fruit and vegetables, causing disease outbreaks? Food Microbiol 2024; 117:104389. [PMID: 37919001 DOI: 10.1016/j.fm.2023.104389] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/18/2023] [Revised: 09/11/2023] [Accepted: 09/17/2023] [Indexed: 11/04/2023]
Abstract
Ready-to-eat fruit and vegetables are a convenient source of nutrients and fibre for consumers, and are generally safe to eat, but are vulnerable to contamination with human enteric bacterial pathogens. Over the last decade, Salmonella spp., pathogenic Escherichia coli, and Listeria monocytogenes have been linked to most of the bacterial outbreaks of foodborne illness associated with fresh produce. The origins of these outbreaks have been traced to multiple sources of contamination from pre-harvest (soil, seeds, irrigation water, domestic and wild animal faecal matter) or post-harvest operations (storage, preparation and packaging). These pathogens have developed multiple processes for successful attachment, survival and colonization conferring them the ability to adapt to multiple environments. However, these processes differ across bacterial strains from the same species, and across different plant species or cultivars. In a competitive environment, additional risk factors are the plant microbiome phyllosphere and the plant responses; both factors directly modulate the survival of the pathogens on the leaf's surface. Understanding the mechanisms involved in bacterial attachment to, colonization of, and proliferation, on fresh produce and the role of the plant in resisting bacterial contamination is therefore crucial to reducing future outbreaks.
Collapse
Affiliation(s)
- Gareth A Thomas
- School of Biosciences, Cardiff University, Sir Martin Evans Building, Museum Avenue, Cardiff, CF10 3AX, UK
| | - Teresa Paradell Gil
- School of Biosciences, Cardiff University, Sir Martin Evans Building, Museum Avenue, Cardiff, CF10 3AX, UK
| | - Carsten T Müller
- School of Biosciences, Cardiff University, Sir Martin Evans Building, Museum Avenue, Cardiff, CF10 3AX, UK
| | - Hilary J Rogers
- School of Biosciences, Cardiff University, Sir Martin Evans Building, Museum Avenue, Cardiff, CF10 3AX, UK
| | - Cedric N Berger
- School of Biosciences, Cardiff University, Sir Martin Evans Building, Museum Avenue, Cardiff, CF10 3AX, UK.
| |
Collapse
|
3
|
Mohammad ZH, Prado ID, Sirsat SA. Comparative microbial analyses of hydroponic versus in-soil grown Romaine lettuce obtained at retail. Heliyon 2022; 8:e11050. [PMID: 36281368 PMCID: PMC9587268 DOI: 10.1016/j.heliyon.2022.e11050] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/16/2022] [Revised: 07/11/2022] [Accepted: 10/07/2022] [Indexed: 11/06/2022] Open
Abstract
The overarching goal of this study was to assess the microbiological profile of hydroponically grown Romaine lettuce and in-soil Romaine lettuce (organic and conventional). Thirty-six samples of hydroponic lettuce, seventy-two samples organic lettuce (thirty-six bagged lettuce and thirty-six non-bagged lettuce), and thirty-six conventionally grown lettuce was purchased from retail stores. A portion of each sample was analyzed for aerobic bacteria (APC), coliforms and E. coli, and yeasts and molds (YM). Another portion of each sample was enriched for Salmonella, E. coli O157:H7, Listeria monocytogenes, and Staphylococcus aureus, and confirmed with RT-PCR. No statistical differences were found in the microbial profile (P > 0.05) between the different farming practices. The APC, coliforms, E. coli, and YM counts were similar across bagged samples. The results demonstrated that APC and E. coli were significantly higher (P<0.05) in organic non-bagged samples compared to other practices. Salmonella and L. monocytogenes were detected in some organically and conventionally grown lettuce samples but were only detected in 3 hydroponically grown lettuce samples. This study indicated that hydroponically grown lettuce obtained at retail may have food safety risks similar to organic and conventional systems. These findings highlight the need for food safety training and educational programs.
Collapse
|
4
|
Vidovic S, Paturi G, Gupta S, Fletcher GC. Lifestyle of Listeria monocytogenes and food safety: Emerging listericidal technologies in the food industry. Crit Rev Food Sci Nutr 2022; 64:1817-1835. [PMID: 36062812 DOI: 10.1080/10408398.2022.2119205] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022]
Abstract
Listeria monocytogenes, a causative agent of listeriosis, is a major foodborne pathogen. Among pathogens, L. monocytogenes stands out for its unique ecological and physiological characteristics. This distinct lifestyle of L. monocytogenes has a significant impact on food safety and public health, mainly through the ability of this pathogen to multiply at refrigeration temperature and to persist in the food processing environment. Due to a combination of these characteristics and emerging trends in consumer preference for ready-to-eat and minimally processed food, there is a need to develop effective and sustainable approaches to control contamination of food products with L. monocytogenes. Implementation of an efficient and reliable control strategy for L. monocytogenes must first address the problem of cross-contamination. Besides the preventive control strategies, cross-contamination may be addressed with the introduction of emerging post packaging non-thermal or thermal hurdles that can ensure delivery of a listericidal step in a packed product without interfering with the organoleptic characteristics of a food product. This review aims to present the most relevant findings underlying the distinct lifestyle of L. monocytogenes and its impact on food safety. We also discuss emerging food decontamination technologies that can be used to better control L. monocytogenes.
Collapse
Affiliation(s)
- Sinisa Vidovic
- Food Safety Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
| | - Gunaranjan Paturi
- Food Safety Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
| | - Sravani Gupta
- Food Safety Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
| | - Graham C Fletcher
- Food Safety Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
| |
Collapse
|
5
|
Kang JH. Understanding inactivation of Listeria monocytogenes and Escherichia coli O157:H7 inoculated on romaine lettuce by emulsified thyme essential oil. Food Microbiol 2022; 105:104013. [PMID: 35473974 DOI: 10.1016/j.fm.2022.104013] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/21/2022] [Revised: 02/23/2022] [Accepted: 03/01/2022] [Indexed: 12/15/2022]
Abstract
Effects of thyme essential oil (TEO) emulsion (TEE) with cationic charge formulated using cetylpyridinium chloride (CPC) on attachment strength and inactivation of Listeria monocytogenes and Escherichia coli O157:H7 on romaine lettuce surface were examined in this study. Regardless of the inoculation time (2 h and 24 h), pathogen attachment was stronger on the adaxial surface of the romaine lettuce than on the abaxial surface because of the lower roughness of the former. Moreover, attachment strength increased with increasing inoculation time. TEE washing had the strongest inhibitory effect on pathogen attachment at 2 h when compared with that of TEO, CPC, and sodium hypochlorite (SH), demonstrating a 3.32 and 2.53 log-reduction in the size of the L. monocytogenes and E. coli O157:H7 populations, respectively, compared to the control samples. Additionally, the TEE washing effects were maintained even after inoculation for 24 h, and it decreased attachment to adaxial surface of the samples. These results indicate that TEE could be a good alternative to SH in improving the microbiological safety of romaine lettuce.
Collapse
Affiliation(s)
- Ji-Hoon Kang
- Department of Food Science and Biotechnology, Global K-Food Research Center, Hankyong National University, Anseong-si, 17579, Republic of Korea.
| |
Collapse
|
6
|
Investigation on the Microbial Diversity of Fresh-Cut Lettuce during Processing and Storage Using High Throughput Sequencing and Their Relationship with Quality. Foods 2022; 11:foods11121683. [PMID: 35741879 PMCID: PMC9222426 DOI: 10.3390/foods11121683] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/12/2022] [Revised: 06/04/2022] [Accepted: 06/06/2022] [Indexed: 02/04/2023] Open
Abstract
Microbial community distribution in vegetables can affect their quality. This study analyzed the distribution of the microbial community at various stages during processing and storage with the microbial diversity analysis, and evaluated the correlation between the dominant bacteria and sensory quality of lettuce using correspondence analysis with multiple regression analysis. Results showed that the process of washing, cutting, then disinfection and dewatering could change the community distribution and dominant bacteria in lettuce, and maintain better texture, morphology, aroma, color qualities of lettuce. The total number of colonies and relative abundance of Xanthomonas in fresh-cut lettuce decreased, while Afipia and Ralstonia increased during processing and pre-storage (storage for 6 h, 12 h and 1 d). After storage for 3 d, the total number of colonies in lettuce increased (more than 5 log CFU/g), especially the relative abundance of Pseudomonas, which led to the obvious deterioration of the sensory quality of lettuce. Throughout the process, the number of Bacillus cereus, Staphylococcus aureus, and E. coli was less than 100 CFU/g and 3 MPN/g. The number of typical pathogenic bacteria, Salmonella, Listeria monocytogenes and E. coli O157:H7, was below the detection limit. Overall, the prevention and control of psychrotrophic Pseudomonas in lettuce was still necessary. These results will provide useful information for the fresh-cut lettuce industry.
Collapse
|
7
|
Doren J, Hadad R, McKEAG L, Tucker C, Newbold E. Food Safety Risks of Harvesting Dropped and Drooping Produce: A Review. J Food Prot 2022; 85:571-582. [PMID: 34914837 DOI: 10.4315/jfp-21-369] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/29/2021] [Accepted: 12/10/2021] [Indexed: 11/11/2022]
Abstract
ABSTRACT The Produce Safety Rule of the Food Safety Modernization Act (FSMA) sets forth minimum standards for fruit and vegetable production in the United States. One provision states that growers must not harvest dropped produce because damage or ground contact may contaminate produce. In an unpublished survey of 2020 food safety inspections conducted by the Northeast Center to Advance Food Safety, handling of dropped produce covered by the FSMA was a common misunderstood and noncompliance issue among growers in the Northeast. In consideration of this provision's on-farm practicality, this review was conducted to evaluate the risks associated with dropped and drooping produce, to guide growers in making informed risk management decisions, and to answer the following questions: (i) what are the risk factors that influence transferability of pathogens from touching the ground to produce and (ii) what are the risks associated with harvesting dropped or drooping produce covered under the Produce Safety Rule? A search of online databases revealed 12 relevant publications, which highlighted moisture, contact time, and crop features as affecting contamination rates from a ground surface to a crop surface. Soil and mulch posed a differential risk, with bare soil generally presenting a lower risk than plastic mulch. The effects of other mulch types are unclear. Mulches may promote pathogen persistence in soil, although they may also protect produce from contaminated soils. These studies were limited in their scope and applicability and most did not directly address dropped produce. Research is needed to clarify the various effects of dropped and drooping produce, the impact of ground surface type on pathogen survivability and transfer, soil and crop features that facilitate contamination, and postharvest risks of harvesting dropped or drooping produce. A comprehensive understanding of these issues will guide growers in implementing preventive measures and better managing risk in a way practicable to each farm's unique conditions. HIGHLIGHTS
Collapse
Affiliation(s)
- Johanna Doren
- Northeast Center to Advance Food Safety, University of Vermont Extension, Bennington, Vermont 05201
| | - Robert Hadad
- Cornell Vegetable Program, Cornell Cooperative Extension, Rochester, New York 14617
| | - Lisa McKEAG
- Center for Agriculture, Food, and the Environment, University of Massachusetts Extension, Amherst, Massachusetts 01003, USA
| | - Caitlin Tucker
- Cornell Vegetable Program, Cornell Cooperative Extension, Rochester, New York 14617
| | - Elizabeth Newbold
- Northeast Center to Advance Food Safety, University of Vermont Extension, Bennington, Vermont 05201
| |
Collapse
|
8
|
Xylia P, Chrysargyris A, Botsaris G, Skandamis P, Tzortzakis N. Salmonella Enteritidis survival in different temperatures and nutrient solution pH levels in hydroponically grown lettuce. Food Microbiol 2022; 102:103898. [PMID: 34809930 DOI: 10.1016/j.fm.2021.103898] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/25/2021] [Revised: 08/23/2021] [Accepted: 09/08/2021] [Indexed: 11/04/2022]
Abstract
Due to climate change, with contaminated and less fertile soils, and intense weather phenomena, a turn towards hydroponic vegetable production has been made. Hydroponic cultivation of vegetables is considered to be a clean, safe and environmentally friendly growing technique; however, incidence of microbial contamination i.e. foodborne pathogens, might occur, endangering human health. The aim of this study was to investigate the effects of different plant growth stages, pH (values 5, 6, 7, 8) and bacterial inoculum levels (3 and 6 log cfu/mL) on hydroponically cultivated lettuce spiked with Salmonella Enteritidis. The results revealed that the pH and inoculum levels affected the internalization and survival of the pathogen in the hydroponic environment and plant tissue. Younger plants were found to be more susceptible to pathogen internalization compared to older ones. Under the current growing conditions (hydroponics, pH and inoculum levels), no leaf internalization was observed at all lettuce growth stages, despite the bacterium presence in the hydroponic solution. Noticeably, bacteria load at the nutrient solution was lower in low pH levels. These results showed that bacterium presence initiates plant response as indicated by the increased phenols, antioxidants and damage index markers (H2O2, MDA) in order for the plant to resist contamination by the invader. Nutrient solution management can result in Taylor-made recipes for plant growth and possible controlling the survival and growth of S. Enteritidis by pH levels.
Collapse
Affiliation(s)
- Panayiota Xylia
- Department of Agricultural Sciences, Biotechnology and Food Science, Cyprus University of Technology, Limassol, Cyprus
| | - Antonios Chrysargyris
- Department of Agricultural Sciences, Biotechnology and Food Science, Cyprus University of Technology, Limassol, Cyprus
| | - George Botsaris
- Department of Agricultural Sciences, Biotechnology and Food Science, Cyprus University of Technology, Limassol, Cyprus
| | - Panagiotis Skandamis
- Faculty of Food Science & Technology, Agricultural University of Athens, Athens, Greece
| | - Nikolaos Tzortzakis
- Department of Agricultural Sciences, Biotechnology and Food Science, Cyprus University of Technology, Limassol, Cyprus.
| |
Collapse
|
9
|
Recent advances in anti-adhesion mechanism of natural antimicrobial agents on fresh produce. Curr Opin Food Sci 2021. [DOI: 10.1016/j.cofs.2021.01.009] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
10
|
Rhizobacteria Impact Colonization of Listeria monocytogenes on Arabidopsis thaliana Roots. Appl Environ Microbiol 2021; 87:e0141121. [PMID: 34550783 PMCID: PMC8579980 DOI: 10.1128/aem.01411-21] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/02/2023] Open
Abstract
In spite of its relevance as a foodborne pathogen, we have limited knowledge about Listeria monocytogenes in the environment. L. monocytogenes outbreaks have been linked to fruits and vegetables; thus, a better understanding of the factors influencing its ability to colonize plants is important. We tested how environmental factors and other soil- and plant-associated bacteria influenced L. monocytogenes' ability to colonize plant roots using Arabidopsis thaliana seedlings in a hydroponic growth system. We determined that the successful root colonization of L. monocytogenes 10403S was modestly but significantly enhanced by the bacterium being pregrown at higher temperatures, and this effect was independent of the biofilm and virulence regulator PrfA. We tested 14 rhizosphere-derived bacteria for their impact on L. monocytogenes 10403S, identifying one that enhanced and 10 that inhibited the association of 10403S with plant roots. We also characterized the outcomes of these interactions under both coinoculation and invasion conditions. We characterized the physical requirements of five of these rhizobacteria to impact the association of L. monocytogenes 10403S with roots, visualizing one of these interactions by microscopy. Furthermore, we determined that two rhizobacteria (one an inhibitor, the other an enhancer of 10403S root association) were able to similarly impact 10 different L. monocytogenes strains, indicating that the effects of these rhizobacteria on L. monocytogenes are not strain specific. Taken together, our results advance our understanding of the parameters that affect L. monocytogenes plant root colonization, knowledge that may enable us to deter its association with and, thus, downstream contamination of, food crops. IMPORTANCE Listeria monocytogenes is ubiquitous in the environment, being found in or on soil, water, plants, and wildlife. However, little is known about the requirements for L. monocytogenes' existence in these settings. Recent L. monocytogenes outbreaks have been associated with contaminated produce; thus, we used a plant colonization model to investigate factors that alter L. monocytogenes' ability to colonize plant roots. We show that L. monocytogenes colonization of roots was enhanced when grown at higher temperatures prior to inoculation but did not require a known regulator of virulence and biofilm formation. Additionally, we identified several rhizobacteria that altered the ability of 11 different strains of L. monocytogenes to colonize plant roots. Understanding the factors that impact L. monocytogenes physiology and growth will be crucial for finding mechanisms (whether chemical or microbial) that enable its removal from plant surfaces to reduce L. monocytogenes contamination of produce and eliminate foodborne illness.
Collapse
|
11
|
Hu Y, Khomenko O, Shi W, Velasco-Sánchez Á, Ashekuzzaman SM, Bennegadi-Laurent N, Daly K, Fenton O, Healy MG, Leahy JJ, Sørensen P, Sommer SG, Taghizadeh-Toosi A, Trinsoutrot-Gattin I. Systematic Review of Dairy Processing Sludge and Secondary STRUBIAS Products Used in Agriculture. FRONTIERS IN SUSTAINABLE FOOD SYSTEMS 2021. [DOI: 10.3389/fsufs.2021.763020] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022] Open
Abstract
Worldwide dairy processing plants produce high volumes of dairy processing sludge (DPS), which can be converted into secondary derivatives such as struvite, biochar and ash (collectively termed STRUBIAS). All of these products have high fertilizer equivalent values (FEV), but future certification as phosphorus (P)-fertilizers in the European Union will mean they need to adhere to new technical regulations for fertilizing materials i.e., content limits pertaining to heavy metals (Cd, Cu, Hg, Ni, Pb, and Zn), synthetic organic compounds and pathogens. This systematic review presents the current state of knowledge about these bio-based fertilizers and identifies knowledge gaps. In addition, a review and calculation of greenhouse gas emissions from a range of concept dairy sludge management and production systems for STRUBIAS products [i.e., biochar from pyrolysis and hydrochar from hydrothermal carbonization (HTC)] is presented. Results from the initial review showed that DPS composition depends on product type and treatment processes at a given processing plant, which leads to varied nutrient, heavy metal and carbon contents. These products are all typically high in nutrients and carbon, but low in heavy metals. Further work needs to concentrate on examining their pathogenic microorganism and emerging contaminant contents, in addition to conducting an economic assessment of production and end-user costs related to chemical fertilizer equivalents. With respect to STRUBIAS products, contaminants not present in the raw DPS may need further treatment before being land applied in agriculture e.g., heated producing ashes, hydrochar, or biochar. An examination of these products from an environmental perspective shows that their water quality footprint could be minimized using application rates based on P incorporation of these products into nutrient management planning and application by incorporation into the soil. Results from the concept system showed that elimination of methane emissions was possible, along with a reduction in nitrous oxide. Less carbon (C) is transferred to agricultural fields where DPS is processed into biochar and hydrochar, but due to high recalcitrance, the C in this form is retained much longer in the soil, and therefore STRUBIAS products represent a more stable and long-term option to increase soil C stocks and sequestration.
Collapse
|
12
|
Reduction of the attachment, survival and growth of L. monocytogenes on lettuce leaves by UV-C stress. Lebensm Wiss Technol 2021. [DOI: 10.1016/j.lwt.2021.111528] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/25/2023]
|
13
|
Factors contributing to Listeria monocytogenes transmission and impact on food safety. Curr Opin Food Sci 2020. [DOI: 10.1016/j.cofs.2020.09.009] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
|
14
|
Kang J, Song KB. Combined washing effect of noni extract and oregano essential oil on the decontamination of
Listeria monocytogenes
on romaine lettuce. Int J Food Sci Technol 2020. [DOI: 10.1111/ijfs.14685] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
Affiliation(s)
- Ji‐Hoon Kang
- Department of Food Science and Technology Chungnam National University Daejeon 34134 Korea
| | - Kyung Bin Song
- Department of Food Science and Technology Chungnam National University Daejeon 34134 Korea
| |
Collapse
|
15
|
Sidhu RK, Cavallaro ND, Pola CC, Danyluk MD, McLamore ES, Gomes CL. Planar Interdigitated Aptasensor for Flow-Through Detection of Listeria spp. in Hydroponic Lettuce Growth Media. SENSORS (BASEL, SWITZERLAND) 2020; 20:E5773. [PMID: 33053744 PMCID: PMC7600482 DOI: 10.3390/s20205773] [Citation(s) in RCA: 18] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 09/16/2020] [Revised: 10/09/2020] [Accepted: 10/10/2020] [Indexed: 02/07/2023]
Abstract
Irrigation water is a primary source of fresh produce contamination by bacteria during the preharvest, particularly in hydroponic systems where the control of pests and pathogens is a major challenge. In this work, we demonstrate the development of a Listeria biosensor using platinum interdigitated microelectrodes (Pt-IME). The sensor is incorporated into a particle/sediment trap for the real-time analysis of irrigation water in a hydroponic lettuce system. We demonstrate the application of this system using a smartphone-based potentiostat for rapid on-site analysis of water quality. A detailed characterization of the electrochemical behavior was conducted in the presence/absence of DNA and Listeria spp., which was followed by calibration in various solutions with and without flow. In flow conditions (100 mL samples), the aptasensor had a sensitivity of 3.37 ± 0.21 k log-CFU-1 mL, and the LOD was 48 ± 12 CFU mL-1 with a linear range of 102 to 104 CFU mL-1. In stagnant solution with no flow, the aptasensor performance was significantly improved in buffer, vegetable broth, and hydroponic media. Sensor hysteresis ranged from 2 to 16% after rinsing in a strong basic solution (direct reuse) and was insignificant after removing the aptamer via washing in Piranha solution (reuse after adsorption with fresh aptamer). This is the first demonstration of an aptasensor used to monitor microbial water quality for hydroponic lettuce in real time using a smartphone-based acquisition system for volumes that conform with the regulatory standards. The aptasensor demonstrated a recovery of 90% and may be reused a limited number of times with minor washing steps.
Collapse
Affiliation(s)
- Raminderdeep K. Sidhu
- Department of Biological & Agricultural Engineering, Texas A&M University, College Station, TX 77843, USA;
| | - Nicholas D. Cavallaro
- Agricultural & Biological Engineering, Institute of Food and Agricultural Sciences, University of Florida, Gainesville, FL 32611, USA;
| | - Cicero C. Pola
- Department of Mechanical Engineering, Iowa State University, Ames, IA 50011, USA;
| | - Michelle D. Danyluk
- Food Science and Human Nutrition, Institute of Food and Agricultural Sciences, University of Florida, Gainesville, FL 32611, USA;
| | - Eric S. McLamore
- Agricultural & Biological Engineering, Institute of Food and Agricultural Sciences, University of Florida, Gainesville, FL 32611, USA;
| | - Carmen L. Gomes
- Department of Mechanical Engineering, Iowa State University, Ames, IA 50011, USA;
| |
Collapse
|
16
|
Kyere EO, Foong G, Palmer J, Wargent JJ, Fletcher GC, Flint S. Biofilm formation of Listeria monocytogenes in hydroponic and soil grown lettuce leaf extracts on stainless steel coupons. Lebensm Wiss Technol 2020. [DOI: 10.1016/j.lwt.2020.109114] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/07/2023]
|
17
|
Iannetti L, Schirone M, Neri D, Visciano P, Acciari VA, Centorotola G, Mangieri MS, Torresi M, Santarelli GA, Di Marzio V, Marfoglia C, Migliorati G, Pomilio F. Listeria monocytogenes in poultry: Detection and strain characterization along an integrated production chain in Italy. Food Microbiol 2020; 91:103533. [PMID: 32539961 DOI: 10.1016/j.fm.2020.103533] [Citation(s) in RCA: 13] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/05/2020] [Revised: 04/09/2020] [Accepted: 04/22/2020] [Indexed: 12/18/2022]
Abstract
In this study, thirteen batches of broiler chicken from an integrated Italian poultry company were investigated for the detection of Listeria monocytogenes. The prevalence was evaluated in faeces samples at farm level and after transport, caecal contents and carcass neck skin from 2 slaughterhouses (M1 and M2), for a total of 2080 samples, throughout a 27-month period. No positive results were recorded in faeces, while the overall prevalence of contamination in carcass neck skin was 26.7%. Then, 123 isolates out of 139 positive skin samples, with the prevalent serotypes 4b (76%) and 1/2b (94%) from slaughterhouses M1 and M2 respectively, were PFGE characterized, showing the presence of 18 different pulsotypes and 8 genetic clusters. The same pulsotypes were found in carcasses from different farms, but slaughtered in the same abattoir, highlighting the environmental origin of contamination. The persistence of the pathogen over long time seemed to be very likely, considering that undistinguishable pulsotypes were found in carcasses slaughtered in the same slaughterhouse after periods up to 18 months long. The implementation of cleaning and sanitation at slaughterhouse level could represent the main factor for the control of such pathogen in the poultry meat processing line.
Collapse
Affiliation(s)
- Luigi Iannetti
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Maria Schirone
- Faculty of Bioscience and Technology for Food, Agriculture and Environment, University of Teramo, Via R. Balzarini, 1, 64100, Teramo, Italy.
| | - Diana Neri
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Pierina Visciano
- Faculty of Bioscience and Technology for Food, Agriculture and Environment, University of Teramo, Via R. Balzarini, 1, 64100, Teramo, Italy
| | - Vicdalia Aniela Acciari
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Gabriella Centorotola
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Maria Silvia Mangieri
- Faculty of Bioscience and Technology for Food, Agriculture and Environment, University of Teramo, Via R. Balzarini, 1, 64100, Teramo, Italy
| | - Marina Torresi
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Gino Angelo Santarelli
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Violeta Di Marzio
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Cristina Marfoglia
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Giacomo Migliorati
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| | - Francesco Pomilio
- Istituto Zooprofilattico Sperimentale dell'Abruzzo e del Molise "G. Caporale", Via Campo Boario, 64100, Teramo, Italy
| |
Collapse
|