1
|
Schreur-Piet I, Heuts JPA. The Effect of Macromonomer Surfactant Microstructure on Aqueous Polymer Dispersion and Derived Polymer Film Properties. Biomacromolecules 2024. [PMID: 38860966 DOI: 10.1021/acs.biomac.4c00292] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 06/12/2024]
Abstract
Water-borne coatings were prepared from poly(methyl methacrylate-co-butyl acrylate) latexes using different methacrylic acid containing macromonomers as stabilizers, and their physical properties were determined. The amphiphilic methacrylic acid macromonomers containing methyl, butyl, or lauryl methacrylate as hydrophobic comonomers were synthesized via catalytic chain transfer polymerization to give stabilizers with varying architecture, composition, and molar mass. A range of latexes of virtually the same composition was prepared by keeping the content of methacrylic acid groups during the emulsion polymerization constant and by only varying the microstructure of the macromonomers. These latexes displayed a range of rheological behaviors: from highly viscous and shear thinning to low viscous and Newtonian. The contact angles of the resulting coatings ranged from very hydrophilic (<10°) to almost hydrophobic (88°), and differences in hardness, roughness, and water vapor sorption and permeability were found.
Collapse
Affiliation(s)
- Ingeborg Schreur-Piet
- Department of Chemical Engineering & Chemistry and Institute for Complex Molecular Systems, Eindhoven University of Technology, P.O. Box 513, 5600 MB Eindhoven, The Netherlands
| | - Johan P A Heuts
- Department of Chemical Engineering & Chemistry and Institute for Complex Molecular Systems, Eindhoven University of Technology, P.O. Box 513, 5600 MB Eindhoven, The Netherlands
| |
Collapse
|
2
|
Zhang S, Li R, An Z. Degradable Block Copolymer Nanoparticles Synthesized by Polymerization-Induced Self-Assembly. Angew Chem Int Ed Engl 2024; 63:e202315849. [PMID: 38155097 DOI: 10.1002/anie.202315849] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/19/2023] [Revised: 12/20/2023] [Accepted: 12/28/2023] [Indexed: 12/30/2023]
Abstract
Polymerization-induced self-assembly (PISA) combines polymerization and in situ self-assembly of block copolymers in one system and has become a widely used method to prepare block copolymer nanoparticles at high concentrations. The persistence of polymers in the environment poses a huge threat to the ecosystem and represents a significant waste of resources. There is an urgent need to develop novel chemical approaches to synthesize degradable polymers. To meet with this demand, it is crucial to install degradability into PISA nanoparticles. Most recently, degradable PISA nanoparticles have been synthesized by introducing degradation mechanisms into either shell-forming or core-forming blocks. This Minireview summarizes the development in degradable block copolymer nanoparticles synthesized by PISA, including shell-degradable, core-degradable, and all-degradable nanoparticles. Future development will benefit from expansion of polymerization techniques with new degradation mechanisms and adaptation of high-throughput approaches for both PISA syntheses and degradation studies.
Collapse
Affiliation(s)
- Shudi Zhang
- State Key Laboratory of Supramolecular Structure and Materials, College of Chemistry, Jilin University, Changchun, 130012, China
| | - Ruoyu Li
- State Key Laboratory of Supramolecular Structure and Materials, College of Chemistry, Jilin University, Changchun, 130012, China
| | - Zesheng An
- State Key Laboratory of Supramolecular Structure and Materials, College of Chemistry, Jilin University, Changchun, 130012, China
- Key Laboratory for Molecular Enzymology and Engineering of Ministry of Education, School of Life Sciences, Jilin University, Changchun, 130012, China
| |
Collapse
|
3
|
Liao G, Derry MJ, Smith AJ, Armes SP, Mykhaylyk OO. Determination of Reaction Kinetics by Time-Resolved Small-Angle X-ray Scattering during Polymerization-Induced Self-Assembly: Direct Evidence for Monomer-Swollen Nanoparticles. Angew Chem Int Ed Engl 2024; 63:e202312119. [PMID: 37996999 PMCID: PMC10952692 DOI: 10.1002/anie.202312119] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/18/2023] [Revised: 10/25/2023] [Accepted: 11/23/2023] [Indexed: 11/25/2023]
Abstract
The kinetics of heterogeneous polymerization is determined directly using small-angle X-ray scattering (SAXS). This important advancement is exemplified for the synthesis of sterically-stabilized diblock copolymer nanoparticles by reversible addition-fragmentation chain transfer (RAFT) dispersion polymerization of benzyl methacrylate (BzMA) in mineral oil at 90 °C. The principle of mass balance is invoked to derive a series of equations for the analysis of the resulting time-resolved SAXS patterns. Importantly, there is a continuous change in the X-ray scattering length density for the various components within the reaction mixture. This enables the volume fraction of unreacted BzMA monomer to be calculated at any given time point, which enables the polymerization kinetics to be monitored in situ directly without relying on supplementary characterization techniques. Moreover, SAXS enables the local concentration of both monomer and solvent within the growing swollen nanoparticles to be determined during the polymerization. Data analysis reveals that the instantaneous rate of BzMA polymerization is proportional to the local monomer concentration within the nanoparticles. In principle, this powerful new time-resolved SAXS approach can be applicable to other heterogeneous polymerization formulations.
Collapse
Affiliation(s)
- Guoxing Liao
- Department of ChemistryUniversity of SheffieldDainton BuildingSheffieldS3 7HFUK
- South China Advanced Institute for Soft Matter Science and TechnologySchool of Emergent Soft MatterGuangdong Provincial Key Laboratory of Functional and Intelligent Hybrid Materials and DevicesSouth China University of TechnologyGuangzhou510640China
| | - Matthew J. Derry
- Department of ChemistryUniversity of SheffieldDainton BuildingSheffieldS3 7HFUK
- Aston Advanced Materials Research CentreAston UniversityAston TriangleBirminghamB4 7ETUK
| | - Andrew J. Smith
- Beamline I22Diamond Light Source LtdDiamond HouseDidcotOX11 0DEUK
| | - Steven P. Armes
- Department of ChemistryUniversity of SheffieldDainton BuildingSheffieldS3 7HFUK
| | | |
Collapse
|
4
|
Vasylyshyn T, Patsula V, Filipová M, Konefal RL, Horák D. Poly(glycerol monomethacrylate)-encapsulated upconverting nanoparticles prepared by miniemulsion polymerization: morphology, chemical stability, antifouling properties and toxicity evaluation. NANOSCALE ADVANCES 2023; 5:6979-6989. [PMID: 38059042 PMCID: PMC10697003 DOI: 10.1039/d3na00793f] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 09/19/2023] [Accepted: 11/10/2023] [Indexed: 12/08/2023]
Abstract
In this report, upconverting NaYF4:Yb3+,Er3+ nanoparticles (UCNPs) were synthesized by high-temperature coprecipitation of lanthanide chlorides and encapsulated in poly(glycerol monomethacrylate) (PGMMA). The UCNP surface was first treated with hydrophobic penta(propylene glycol) methacrylate phosphate (SIPO) to improve colloidal stability and enable encapsulation by reversible addition-fragmentation chain transfer miniemulsion polymerization (RAFT) of glycidyl methacrylate (GMA) in water, followed by its hydrolysis. The resulting UCNP-containing PGMMA particles (UCNP@PGMMA), hundreds of nanometers in diameter, were thoroughly characterized by transmission (TEM) and scanning electron microscopy (SEM), dynamic light scattering (DLS), infrared (FTIR) and fluorescence emission spectroscopy, and thermogravimetric analysis (TGA) in terms of particle morphology, size, polydispersity, luminescence, and composition. The morphology, typically raspberry-like, depended on the GMA/UCNP weight ratio. Coating of the UCNPs with hydrophilic PGMMA provided the UCNPs with antifouling properties while enhancing chemical stability and reducing the cytotoxicity of neat UCNPs to a non-toxic level. In addition, it will allow the binding of molecules such as photosensitizers, thus expanding the possibilities for use in various biomedical applications.
Collapse
Affiliation(s)
- Taras Vasylyshyn
- Institute of Macromolecular Chemistry, Czech Academy of Sciences Heyrovského nám. 2 162 00 Prague 6 Czech Republic
| | - Vitalii Patsula
- Institute of Macromolecular Chemistry, Czech Academy of Sciences Heyrovského nám. 2 162 00 Prague 6 Czech Republic
| | - Marcela Filipová
- Institute of Macromolecular Chemistry, Czech Academy of Sciences Heyrovského nám. 2 162 00 Prague 6 Czech Republic
| | - Rafal Lukasz Konefal
- Institute of Macromolecular Chemistry, Czech Academy of Sciences Heyrovského nám. 2 162 00 Prague 6 Czech Republic
| | - Daniel Horák
- Institute of Macromolecular Chemistry, Czech Academy of Sciences Heyrovského nám. 2 162 00 Prague 6 Czech Republic
| |
Collapse
|
5
|
Brotherton EE, Josland D, György C, Johnson EC, Chan DHH, Smallridge MJ, Armes SP. Histidine-Functionalized Diblock Copolymer Nanoparticles Exhibit Enhanced Adsorption onto Planar Stainless Steel. Macromol Rapid Commun 2023; 44:e2200903. [PMID: 36534428 DOI: 10.1002/marc.202200903] [Citation(s) in RCA: 4] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/18/2022] [Revised: 12/12/2022] [Indexed: 12/23/2022]
Abstract
RAFT aqueous emulsion polymerization of isopropylideneglycerol monomethacrylate (IPGMA) is used to prepare a series of PGEO5MA46 -PIPGMAy nanoparticles, where PGEO5MA is a hydrophilic methacrylic steric stabilizer block bearing pendent cis-diol groups. TEM studies confirm a spherical morphology while dynamic light scattering (DLS) analysis indicated that the z-average particle diameter can be adjusted by varying the target degree of polymerization for the core-forming PIPGMA block. Periodate oxidation is used to convert the cis-diol groups on PGEO5MA46 -PIPGMA500 and PGEO5MA46 -PIPGMA1000 nanoparticles into the analogous aldehyde-functionalized nanoparticles, which are then reacted with histidine via reductive amination. In each case, the extent of functionalization is more than 99% as determined by 1 H NMR spectroscopy. Aqueous electrophoresis studies indicate that such derivatization converts initially neutral nanoparticles into zwitterionic nanoparticles with an isoelectric point at pH 7. DLS studies confirm that such histidine-derivatized nanoparticles remain colloidally stable over a wide pH range. A quartz crystal microbalance is employed at 25°C to assess the adsorption of both the cis-diol- and histidine-functionalized nanoparticles onto planar stainless steel at pH 6. The histidine-bearing nanoparticles adsorb much more strongly than their cis-diol counterparts. For the highest adsorbed amount of 70.5 mg m-2 , SEM indicates a fractional surface coverage of 0.23 for the adsorbed nanoparticles.
Collapse
Affiliation(s)
- Emma E Brotherton
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Daniel Josland
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Csilla György
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Edwin C Johnson
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Derek H H Chan
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Mark J Smallridge
- GEO Specialty Chemicals, Hythe, Southampton, Hampshire, SO45 3ZG, UK
| | - Steven P Armes
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| |
Collapse
|
6
|
Shape-Shifting Thermoresponsive Block Copolymer Nano-Objects. J Colloid Interface Sci 2023; 634:906-920. [PMID: 36566636 DOI: 10.1016/j.jcis.2022.12.080] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/16/2022] [Revised: 12/15/2022] [Accepted: 12/16/2022] [Indexed: 12/23/2022]
Abstract
In this Feature Article, we review our recent progress in the design of shape-shifting thermoresponsive diblock copolymer nano-objects, which are prepared using various hydroxyl-functional (meth)acrylic monomers (e.g. 2‑hydroxypropyl methacrylate, 4‑hydroxybutyl acrylate or hydroxybutyl methacrylate) to generate the thermoresponsive block. Unlike traditional thermoresponsive polymers such as poly(N-isopropylacrylamide), there is no transition between soluble and insoluble polymer chains in aqueous solution. Instead, thermally driven transitions between a series of copolymer morphologies (e.g. spheres, worms, vesicles or lamellae) occur on adjusting the aqueous solution temperature owing to a subtle change in the partial degree of hydration of the permanently insoluble thermoresponsive block. Such remarkable self-assembly behavior is unprecedented in colloid science: no other amphiphilic diblock copolymer or surfactant system undergoes such behavior at a fixed chemical composition and concentration. Such shape-shifting nano-objects are characterized by transmission electron microscopy, dynamic light scattering, small-angle X-ray scattering, rheology and variable temperature 1H NMR spectroscopy. Potential applications for this fascinating new class of amphiphiles are briefly considered.
Collapse
|
7
|
Hunter SJ, Penfold NJW, Jones ER, Zinn T, Mykhaylyk OO, Armes SP. Synthesis of Thermoresponsive Diblock Copolymer Nano-Objects via RAFT Aqueous Emulsion Polymerization of Hydroxybutyl Methacrylate. Macromolecules 2022; 55:3051-3062. [PMID: 35492576 PMCID: PMC9047412 DOI: 10.1021/acs.macromol.2c00379] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/22/2022] [Revised: 04/01/2022] [Indexed: 02/08/2023]
Affiliation(s)
- Saul J. Hunter
- Dainton Building, Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, Yorkshire S3 7HF, U.K
| | - Nicholas J. W. Penfold
- Dainton Building, Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, Yorkshire S3 7HF, U.K
| | | | - Thomas Zinn
- ESRF - The European Synchrotron, 38043 Grenoble, France
| | - Oleksandr O. Mykhaylyk
- Dainton Building, Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, Yorkshire S3 7HF, U.K
| | - Steven P. Armes
- Dainton Building, Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, Yorkshire S3 7HF, U.K
| |
Collapse
|
8
|
Kim HJ, Ishizuka F, Kuchel RP, Chatani S, Niino H, Zetterlund PB. Synthesis of low glass transition temperature worms comprising a poly(styrene- stat-n-butyl acrylate) core segment via polymerization-induced self-assembly in RAFT aqueous emulsion polymerization. Polym Chem 2022. [DOI: 10.1039/d1py01636a] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/19/2023]
Abstract
Synthesis of nanodimensional polymeric worms of low glass transition temperature using aqueous polymerization-induced self-assembly.
Collapse
Affiliation(s)
- Hyun Jin Kim
- Cluster for Advanced Macromolecular Design (CAMD), School of Chemical Engineering, The University of New South Wales, Sydney, NSW, 2052, Australia
| | - Fumi Ishizuka
- Cluster for Advanced Macromolecular Design (CAMD), School of Chemical Engineering, The University of New South Wales, Sydney, NSW, 2052, Australia
| | - Rhiannon P. Kuchel
- Electron Microscope Unit, The University of New South Wales, Sydney, NSW, 2052, Australia
| | - Shunsuke Chatani
- Hiroshima R&D Center, Mitsubishi Chemical Corporation, 20-1 Miyuki-cho, Otake, Hiroshima 739-0693, Japan
| | - Hiroshi Niino
- Hiroshima R&D Center, Mitsubishi Chemical Corporation, 20-1 Miyuki-cho, Otake, Hiroshima 739-0693, Japan
| | - Per B. Zetterlund
- Cluster for Advanced Macromolecular Design (CAMD), School of Chemical Engineering, The University of New South Wales, Sydney, NSW, 2052, Australia
| |
Collapse
|
9
|
Penfold NJW, Neal TJ, Plait C, Leigh AE, Chimonides G, Smallridge MJ, Armes SP. Reverse sequence polymerization-induced self-assembly in aqueous media: a counter-intuitive approach to sterically-stabilized diblock copolymer nano-objects. Polym Chem 2022. [DOI: 10.1039/d2py01064j] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
Abstract
A 500 nm charge-stabilized latex is converted into 40 nm sterically-stabilized nanoparticles via reverse sequence polymerization-induced self-assembly (PISA).
Collapse
Affiliation(s)
- Nicholas J. W. Penfold
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Thomas J. Neal
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Corentin Plait
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Andrew E. Leigh
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | - Gwen Chimonides
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| | | | - Steven P. Armes
- Dainton Building, Department of Chemistry, The University of Sheffield, Brook Hill, Sheffield, South Yorkshire, S3 7HF, UK
| |
Collapse
|
10
|
Wang G, Cai G, Zhang M, Wang Z, Li C, Zhang Y. Synthesis of polymeric emulsifiers based on ketoaldehyde resin and their application in emulsifying styrene/water two‐phase system. J Appl Polym Sci 2021. [DOI: 10.1002/app.52107] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
Affiliation(s)
- Guolin Wang
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Guiting Cai
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Menghao Zhang
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Ziyu Wang
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Chaofeng Li
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Yanwu Zhang
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| |
Collapse
|
11
|
Oral I, Grossmann L, Fedorenko E, Struck J, Abetz V. Synthesis of Poly(methacrylic acid)- block-Polystyrene Diblock Copolymers at High Solid Contents via RAFT Emulsion Polymerization. Polymers (Basel) 2021; 13:3675. [PMID: 34771234 PMCID: PMC8588034 DOI: 10.3390/polym13213675] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/03/2021] [Revised: 10/12/2021] [Accepted: 10/15/2021] [Indexed: 11/16/2022] Open
Abstract
The combination of polymerization-induced self-assembly (PISA) and reversible-addition fragmentation chain transfer (RAFT) emulsion polymerization offers a powerful technique to synthesize diblock copolymers and polymeric nanoparticles in a controlled manner. The RAFT emulsion diblock copolymerization of styrene and methacrylic acid (MAA) by using a trithiocarbonate as surfactant and RAFT agent was investigated. The Z-group of the RAFT agent was modified with a propyl-, butyl- and dodecyl- sidechain, increasing the hydrophobicity of the RAFT agent to offer well-controlled polymerization of poly(methacrylic acid)-block-polystyrene (PMAA-b-PS) diblock copolymers at high solid contents between 30-50 wt% in water. The kinetic data of the PMAA homopolymerization with the three different RAFT agents for various solvents was investigated as well as the RAFT emulsion polymerization of the diblock copolymers in pure water. While the polymerization of PMAA-b-PS with a propyl terminus as a Z-group suffered from slow polymerization rates at solid contents above 30 wt%, the polymerization with a dodecyl sidechain as a Z-group led to full conversion within 2 h, narrow molar mass distributions and all that at a remarkable solid content of up to 50 wt%.
Collapse
Affiliation(s)
- Iklima Oral
- Institute of Physical Chemistry, Universität Hamburg, Grindelallee 117, 20146 Hamburg, Germany; (I.O.); (L.G.); (E.F.); (J.S.)
| | - Larissa Grossmann
- Institute of Physical Chemistry, Universität Hamburg, Grindelallee 117, 20146 Hamburg, Germany; (I.O.); (L.G.); (E.F.); (J.S.)
| | - Elena Fedorenko
- Institute of Physical Chemistry, Universität Hamburg, Grindelallee 117, 20146 Hamburg, Germany; (I.O.); (L.G.); (E.F.); (J.S.)
| | - Jana Struck
- Institute of Physical Chemistry, Universität Hamburg, Grindelallee 117, 20146 Hamburg, Germany; (I.O.); (L.G.); (E.F.); (J.S.)
| | - Volker Abetz
- Institute of Physical Chemistry, Universität Hamburg, Grindelallee 117, 20146 Hamburg, Germany; (I.O.); (L.G.); (E.F.); (J.S.)
- Helmholtz-Zentrum Hereon, Institute of Membrane Research, Max-Planck-Straße 1, 21502 Geesthacht, Germany
| |
Collapse
|
12
|
Wan J, Fan B, Putera K, Kim J, Banaszak Holl MM, Thang SH. Polymerization-Induced Hierarchical Self-Assembly: From Monomer to Complex Colloidal Molecules and Beyond. ACS NANO 2021; 15:13721-13731. [PMID: 34375086 DOI: 10.1021/acsnano.1c05089] [Citation(s) in RCA: 17] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/13/2023]
Abstract
The nanoscale hierarchical design that draws inspiration from nature's biomaterials allows the enhancement of material performance and enables multifarious applications. Self-assembly of block copolymers represents one of these artificial techniques that provide an elegant bottom-up strategy for the synthesis of soft colloidal hierarchies. Fast-growing polymerization-induced self-assembly (PISA) renders a one-step process for the polymer synthesis and in situ self-assembly at high concentrations. Nevertheless, it is exceedingly challenging for the fabrication of hierarchical colloids via aqueous PISA, simply because most monomers produce kinetically trapped spheres except for a few PISA-suitable monomers. We demonstrate here a sequential one-pot synthesis of hierarchically self-assembled polymer colloids with diverse morphologies via aqueous PISA that overcomes the limitation. Complex formation of water-immiscible monomers with cyclodextrin via "host-guest" inclusion, followed by sequential aqueous polymerization, provides a linear triblock terpolymer that can in situ self-assemble into hierarchical nanostructures. To access polymer colloids with different morphologies, three types of linear triblock terpolymers were synthesized through this methodology, which allows the preparation of AXn-type colloidal molecules (CMs), core-shell-corona micelles, and raspberry-like nanoparticles. Furthermore, the phase separations between polymer blocks in nanostructures were revealed by transmission electron microscopy and atomic force microscopy-infrared spectroscopy. The proposed mechanism explained how the interfacial tensions and glass transition temperatures of the core-forming blocks affect the morphologies. Overall, this study provides a scalable method of the production of CMs and other hierarchical structures. It can be applied to different block copolymer formulations to enrich the complexity of morphology and enable diverse functions of nano-objects.
Collapse
|
13
|
Cao J, Tan Y, Chen Y, Zhang L, Tan J. Expanding the Scope of Polymerization-Induced Self-Assembly: Recent Advances and New Horizons. Macromol Rapid Commun 2021; 42:e2100498. [PMID: 34418199 DOI: 10.1002/marc.202100498] [Citation(s) in RCA: 33] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/30/2021] [Revised: 08/18/2021] [Indexed: 12/26/2022]
Abstract
Over the past decade or so, polymerization-induced self-assembly (PISA) has become a versatile method for rational preparation of concentrated block copolymer nanoparticles with a diverse set of morphologies. Much of the PISA literature has focused on the preparation of well-defined linear block copolymers by using linear macromolecular chain transfer agents (macro-CTAs) with high chain transfer constants. In this review, a recent process is highlighted from an unusual angle that has expanded the scope of PISA including i) synthesis of block copolymers with nonlinear architectures (e.g., star block copolymer, branched block copolymer) by PISA, ii) in situ synthesis of blends of polymers by PISA, and iii) utilization of macro-CTAs with low chain transfer constants in PISA. By highlighting these important examples, new insights into the research of PISA and future impact these methods will have on polymer and colloid synthesis are provided.
Collapse
Affiliation(s)
- Junpeng Cao
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China
| | - Yingxin Tan
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China
| | - Ying Chen
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou, 510006, China
| | - Li Zhang
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China.,Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou, 510006, China
| | - Jianbo Tan
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China.,Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou, 510006, China
| |
Collapse
|
14
|
Ramezanpour M, Rezaee Shirin-Abadi A. Emulsion polymerization using three types of RAFT prepared well-defined cationic polymeric stabilizers based on 2-dimethylaminoethyl methacrylate (DMAEMA): a comparative study. Colloid Polym Sci 2021. [DOI: 10.1007/s00396-021-04836-3] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
15
|
Baddam V, Välinen L, Tenhu H. Thermoresponsive Polycation-Stabilized Nanoparticles through PISA. Control of Particle Morphology with a Salt. Macromolecules 2021. [DOI: 10.1021/acs.macromol.0c02771] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Affiliation(s)
- Vikram Baddam
- Department of Chemistry, University of Helsinki, PB 55, Helsinki 00014, Finland
| | - Lauri Välinen
- Department of Chemistry, University of Helsinki, PB 55, Helsinki 00014, Finland
| | - Heikki Tenhu
- Department of Chemistry, University of Helsinki, PB 55, Helsinki 00014, Finland
| |
Collapse
|
16
|
Oral I, Abetz V. A Highly Selective Polymer Material using Benzo-9-Crown-3 for the Extraction of Lithium in Presence of Other Interfering Alkali Metal Ions. Macromol Rapid Commun 2021; 42:e2000746. [PMID: 33644940 DOI: 10.1002/marc.202000746] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/19/2020] [Revised: 01/11/2021] [Indexed: 12/13/2022]
Abstract
The recovery of lithium from global water resources continues to be challenging due to interfering metal ions with similar solution properties. Hence, a lithium-selective diblock copolymer system containing crown ethers (CEs) is developed. A polystyrene-block-poly(methacrylic acid) diblock copolymer is synthesized first via a one-pot solution-emulsion reversible addition-fragmentation chain transfer polymerization. A subsequent Steglich esterification yields the CE functionalized polymer. The complexation properties with different alkali metals are first investigated by liquid-liquid extraction (LLE) in dichloromethane (DCM) - water systems using free benzo-9-crown (B9C3), benzo-12-crown-4 (B12C4), and benzo-15-crown-5 (B15C5) CEs as reference components, followed by the correspondingly CE-functionalized polymers. Extraction complexation constants in the aqueous phase are determined and the impact of the complexation constants on the extractability is estimated. The B9C3 CE is especially appealing since it has the smallest cavity size among all CEs. It is too small to complex sodium or potassium ions; however, it forms sandwich complexes with a lithium-ion resulting in extraordinary complexation constants in polymer systems avoiding other interfering alkali metal ions. On this basis, a new material for the efficient extraction of lithium ion traces in global water resources is established.
Collapse
Affiliation(s)
- Iklima Oral
- Institute of Physical Chemistry, Universität, Hamburg, Martin-Luther-King-Platz 6, Hamburg, 20146, Germany
| | - Volker Abetz
- Institute of Physical Chemistry, Universität, Hamburg, Martin-Luther-King-Platz 6, Hamburg, 20146, Germany.,Helmholtz-Zentrum Geesthacht, Centre for Material and Coastal Research, Institute of Membrane Research, Max-Planck-Straße 1, Geesthacht, 21502, Germany
| |
Collapse
|
17
|
Fuentes-Exposito M, Norsic S, Février T, Dugas PY, Boutti S, Devisme S, Bonnet A, D'Agosto F, Lansalot M. Surfactant-free emulsion polymerization of vinylidene fluoride mediated by RAFT/MADIX reactive poly(ethylene glycol) polymer chains. Polym Chem 2021. [DOI: 10.1039/d1py00728a] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/17/2023]
Abstract
Vinylidene fluoride (VDF) emulsion polymerization is conducted in the presence of xanthate-end functionalized poly(ethylene glycol)s leading to stable PVDF latexes.
Collapse
Affiliation(s)
- Mathieu Fuentes-Exposito
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, UMR 5128, Catalysis, Polymerization, Processes and Materials (CP2M), 43 Bd du 11 Novembre 1918, 69616 Villeurbanne, France
| | - Sébastien Norsic
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, UMR 5128, Catalysis, Polymerization, Processes and Materials (CP2M), 43 Bd du 11 Novembre 1918, 69616 Villeurbanne, France
| | - Thibaut Février
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, UMR 5128, Catalysis, Polymerization, Processes and Materials (CP2M), 43 Bd du 11 Novembre 1918, 69616 Villeurbanne, France
| | - Pierre-Yves Dugas
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, UMR 5128, Catalysis, Polymerization, Processes and Materials (CP2M), 43 Bd du 11 Novembre 1918, 69616 Villeurbanne, France
| | - Salima Boutti
- ARKEMA, Centre de Recherche Rhône-Alpes (CRRA), Rue Henri Moissan - CS 42063, 69491 Pierre-Bénite Cedex, France
| | - Samuel Devisme
- ARKEMA, Centre de recherche, développement, applications et technique de l'ouest (Cerdato), 13 route de Launay, 27470 Serquigny, France
| | - Anthony Bonnet
- ARKEMA, Centre de Recherche Rhône-Alpes (CRRA), Rue Henri Moissan - CS 42063, 69491 Pierre-Bénite Cedex, France
| | - Franck D'Agosto
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, UMR 5128, Catalysis, Polymerization, Processes and Materials (CP2M), 43 Bd du 11 Novembre 1918, 69616 Villeurbanne, France
| | - Muriel Lansalot
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, UMR 5128, Catalysis, Polymerization, Processes and Materials (CP2M), 43 Bd du 11 Novembre 1918, 69616 Villeurbanne, France
| |
Collapse
|
18
|
Dao TPT, Vezenkov L, Subra G, Ladmiral V, Semsarilar M. Nano-assemblies with core-forming hydrophobic polypeptide via polymerization-induced self-assembly (PISA). Polym Chem 2021. [DOI: 10.1039/d0py00793e] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/26/2023]
Abstract
The aim of this study is to produce self-assembled structures with hydrophobic polypeptide cores via Reversible Addition–Fragmentation chain Transfer (RAFT) – mediated Polymerisation-Induced Self-Assembly (PISA).
Collapse
Affiliation(s)
| | - Lubomir Vezenkov
- Institut des Biomolécules Max Mousseron
- IBMM
- Univ Montpellier
- CNRS
- ENSCM
| | - Gilles Subra
- Institut des Biomolécules Max Mousseron
- IBMM
- Univ Montpellier
- CNRS
- ENSCM
| | - Vincent Ladmiral
- Institut Charles Gerhardt Montpellier
- ICGM
- Univ Montpellier
- CNRS
- ENSCM
| | | |
Collapse
|
19
|
Hunter SJ, Lovett JR, Mykhaylyk OO, Jones ER, Armes SP. Synthesis of diblock copolymer spheres, worms and vesicles via RAFT aqueous emulsion polymerization of hydroxybutyl methacrylate. Polym Chem 2021. [DOI: 10.1039/d1py00517k] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/03/2023]
Abstract
RAFT aqueous emulsion polymerization of hydroxybutyl methacrylate using a poly(glycerol monomethacrylate) precursor leads to diblock copolymer spheres, worms or vesicles. A pseudo-phase diagram is constructed and the vesicles are briefly evaluated as a Pickering emulsifier.
Collapse
Affiliation(s)
- Saul J. Hunter
- Dainton Building
- Department of Chemistry
- The University of Sheffield
- Sheffield
- UK
| | - Joseph R. Lovett
- Dainton Building
- Department of Chemistry
- The University of Sheffield
- Sheffield
- UK
| | | | | | - Steven P. Armes
- Dainton Building
- Department of Chemistry
- The University of Sheffield
- Sheffield
- UK
| |
Collapse
|
20
|
Hunter SJ, Armes SP. Pickering Emulsifiers Based on Block Copolymer Nanoparticles Prepared by Polymerization-Induced Self-Assembly. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2020; 36:15463-15484. [PMID: 33325720 PMCID: PMC7884006 DOI: 10.1021/acs.langmuir.0c02595] [Citation(s) in RCA: 29] [Impact Index Per Article: 7.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/01/2020] [Revised: 11/27/2020] [Indexed: 05/28/2023]
Abstract
Block copolymer nanoparticles prepared via polymerization-induced self-assembly (PISA) represent an emerging class of organic Pickering emulsifiers. Such nanoparticles are readily prepared by chain-extending a soluble homopolymer precursor using a carefully selected second monomer that forms an insoluble block in the chosen solvent. As the second block grows, it undergoes phase separation that drives in situ self-assembly to form sterically stabilized nanoparticles. Conducting such PISA syntheses in aqueous solution leads to hydrophilic nanoparticles that enable the formation of oil-in-water emulsions. Alternatively, hydrophobic nanoparticles can be prepared in non-polar media (e.g., n-alkanes), which enables water-in-oil emulsions to be produced. In this review, the specific advantages of using PISA to prepare such bespoke Pickering emulsifiers are highlighted, which include fine control over particle size, copolymer morphology, and surface wettability. This has enabled various fundamental scientific questions regarding Pickering emulsions to be addressed. Moreover, block copolymer nanoparticles can be used to prepare Pickering emulsions over various length scales, with mean droplet diameters ranging from millimeters to less than 200 nm.
Collapse
Affiliation(s)
- Saul J. Hunter
- Department of Chemistry,
Dainton Building, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, U.K.
| | - Steven P. Armes
- Department of Chemistry,
Dainton Building, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, U.K.
| |
Collapse
|
21
|
Dergunov SA, Pinkhassik E. Bilayer-Templated Two-Dimensional RAFT Polymerization for Directed Assembly of Polymer Nanostructures. Angew Chem Int Ed Engl 2020; 59:18405-18411. [PMID: 32558032 DOI: 10.1002/anie.202006793] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/11/2020] [Indexed: 11/08/2022]
Abstract
Co-localization of monomers, crosslinkers, and chain-transfer agents (CTA) within self-assembled bilayers in an aqueous suspension enabled the successful directed assembly of nanocapsules using a reversible addition-fragmentation chain transfer (RAFT) process without compromising the polymerization kinetics. This study uncovered substantial influence of the organized medium on the course of the reaction, including differential reactivity based on placement and mobility of monomers, crosslinkers, and CTAs within the bilayer.
Collapse
Affiliation(s)
- Sergey A Dergunov
- Department of Chemistry, University of Connecticut, 55 North Eagleville Road, Storrs, CT 06269, USA
| | - Eugene Pinkhassik
- Department of Chemistry, University of Connecticut, 55 North Eagleville Road, Storrs, CT 06269, USA
| |
Collapse
|
22
|
Dergunov SA, Pinkhassik E. Bilayer‐Templated Two‐Dimensional RAFT Polymerization for Directed Assembly of Polymer Nanostructures. Angew Chem Int Ed Engl 2020. [DOI: 10.1002/ange.202006793] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
Affiliation(s)
- Sergey A. Dergunov
- Department of Chemistry University of Connecticut 55 North Eagleville Road Storrs CT 06269 USA
| | - Eugene Pinkhassik
- Department of Chemistry University of Connecticut 55 North Eagleville Road Storrs CT 06269 USA
| |
Collapse
|
23
|
Sugihara S, Kawakami R, Irie S, Maeda Y. Poly[di(ethylene glycol) vinyl ether]-stabilized poly(vinyl acetate) nanoparticles with various morphologies via RAFT aqueous emulsion polymerization of vinyl acetate. Polym J 2020. [DOI: 10.1038/s41428-020-00417-3] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022]
|
24
|
Dao TPT, Vezenkov L, Subra G, Amblard M, In M, Le Meins JF, Aubrit F, Moradi MA, Ladmiral V, Semsarilar M. Self-Assembling Peptide—Polymer Nano-Objects via Polymerization-Induced Self-Assembly. Macromolecules 2020. [DOI: 10.1021/acs.macromol.0c01260] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
Affiliation(s)
- T. P. Tuyen Dao
- Institut Européen des Membranes, IEM, University Montpellier, CNRS, ENSCM, Montpellier 34095, France
- Institut Charles Gerhardt Montpellier, ICGM, Univ Montpellier, CNRS, ENSCM, Montpellier 34095, France
- Institut des Biomolécules Max Mousseron, IBMM, Univ Montpellier, CNRS, ENSCM, Montpellier 34095, France
| | - Lubomir Vezenkov
- Institut des Biomolécules Max Mousseron, IBMM, Univ Montpellier, CNRS, ENSCM, Montpellier 34095, France
| | - Gilles Subra
- Institut des Biomolécules Max Mousseron, IBMM, Univ Montpellier, CNRS, ENSCM, Montpellier 34095, France
| | - Muriel Amblard
- Institut des Biomolécules Max Mousseron, IBMM, Univ Montpellier, CNRS, ENSCM, Montpellier 34095, France
| | - Martin In
- Laboratoire Charles Coulomb, L2C, Univ Montpellier, CNRS, Montpellier 34095, France
| | - Jean-François Le Meins
- Laboratoire de Chimie des Polymères Organiques, LCPO UMR 5629, Université Bordeaux, CNRS, Pessac 33607, France
| | - Florian Aubrit
- Laboratoire de Chimie des Polymères Organiques, LCPO UMR 5629, Université Bordeaux, CNRS, Pessac 33607, France
| | - Mohammad-Amin Moradi
- Institute for Complex Molecular Systems, Eindhoven University of Technology, Eindhoven 5612 AZ, The Netherlands
| | - Vincent Ladmiral
- Institut Charles Gerhardt Montpellier, ICGM, Univ Montpellier, CNRS, ENSCM, Montpellier 34095, France
| | - Mona Semsarilar
- Institut Européen des Membranes, IEM, University Montpellier, CNRS, ENSCM, Montpellier 34095, France
| |
Collapse
|
25
|
Coumes F, Balarezo M, Rieger J, Stoffelbach F. Biobased Amphiphilic Block Copolymers by RAFT‐Mediated PISA in Green Solvent. Macromol Rapid Commun 2020; 41:e2000002. [DOI: 10.1002/marc.202000002] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/02/2020] [Revised: 03/18/2020] [Accepted: 03/18/2020] [Indexed: 01/14/2023]
Affiliation(s)
- Fanny Coumes
- Sorbonne UniversitéCNRS Institut Parisien de Chimie Moléculaire UMR 8232, Equipe Chimie des Polymères Paris Cedex 05 75252 France
| | - Mauricio Balarezo
- Sorbonne UniversitéCNRS Institut Parisien de Chimie Moléculaire UMR 8232, Equipe Chimie des Polymères Paris Cedex 05 75252 France
| | - Jutta Rieger
- Sorbonne UniversitéCNRS Institut Parisien de Chimie Moléculaire UMR 8232, Equipe Chimie des Polymères Paris Cedex 05 75252 France
| | - François Stoffelbach
- Sorbonne UniversitéCNRS Institut Parisien de Chimie Moléculaire UMR 8232, Equipe Chimie des Polymères Paris Cedex 05 75252 France
| |
Collapse
|
26
|
D'Agosto F, Rieger J, Lansalot M. RAFT‐vermittelte polymerisationsinduzierte Selbstorganisation (PISA). Angew Chem Int Ed Engl 2020. [DOI: 10.1002/ange.201911758] [Citation(s) in RCA: 34] [Impact Index Per Article: 8.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/14/2023]
Affiliation(s)
- Franck D'Agosto
- Univ Lyon Université Claude Bernard Lyon 1 CPE Lyon CNRS UMR 5265 Chemistry, Catalysis, Polymers and Processes (C2P2) 43 Bd du 11 Novembre 1918 69616 Villeurbanne Frankreich
| | - Jutta Rieger
- Sorbonne Université and CNRS UMR 8232 Institut Parisien de Chimie Moléculaire (IPCM), Polymer Chemistry Team (ECP) 4 Place Jussieu 75005 Paris Frankreich
| | - Muriel Lansalot
- Univ Lyon Université Claude Bernard Lyon 1 CPE Lyon CNRS UMR 5265 Chemistry, Catalysis, Polymers and Processes (C2P2) 43 Bd du 11 Novembre 1918 69616 Villeurbanne Frankreich
| |
Collapse
|
27
|
D'Agosto F, Rieger J, Lansalot M. RAFT‐Mediated Polymerization‐Induced Self‐Assembly. Angew Chem Int Ed Engl 2020; 59:8368-8392. [DOI: 10.1002/anie.201911758] [Citation(s) in RCA: 250] [Impact Index Per Article: 62.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/13/2019] [Indexed: 12/31/2022]
Affiliation(s)
- Franck D'Agosto
- Univ Lyon Université Claude Bernard Lyon 1 CPE Lyon CNRS UMR 5265 Chemistry, Catalysis, Polymers and Processes (C2P2) 43 Bd du 11 Novembre 1918 69616 Villeurbanne France
| | - Jutta Rieger
- Sorbonne Université and CNRS UMR 8232 Institut Parisien de Chimie Moléculaire (IPCM) Polymer Chemistry Team (ECP) 4 Place Jussieu 75005 Paris France
| | - Muriel Lansalot
- Univ Lyon Université Claude Bernard Lyon 1 CPE Lyon CNRS UMR 5265 Chemistry, Catalysis, Polymers and Processes (C2P2) 43 Bd du 11 Novembre 1918 69616 Villeurbanne France
| |
Collapse
|
28
|
Galanopoulo P, Dugas PY, Lansalot M, D'Agosto F. Poly(ethylene glycol)-b-poly(vinyl acetate) block copolymer particles with various morphologies via RAFT/MADIX aqueous emulsion PISA. Polym Chem 2020. [DOI: 10.1039/d0py00467g] [Citation(s) in RCA: 18] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/06/2023]
Abstract
The polymerization-induced self-assembly (PISA) of amphiphilic diblock copolymers of poly(ethylene glycol)-b-poly(vinyl acetate) in water was achieved through macromolecular design via interchange of xanthate (MADIX) polymerization in emulsion.
Collapse
Affiliation(s)
| | | | - Muriel Lansalot
- Univ Lyon
- Université Claude Bernard Lyon 1
- CPE Lyon
- CNRS
- UMR 5265
| | - Franck D'Agosto
- Univ Lyon
- Université Claude Bernard Lyon 1
- CPE Lyon
- CNRS
- UMR 5265
| |
Collapse
|
29
|
Liu C, Hong CY, Pan CY. Polymerization techniques in polymerization-induced self-assembly (PISA). Polym Chem 2020. [DOI: 10.1039/d0py00455c] [Citation(s) in RCA: 96] [Impact Index Per Article: 24.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/26/2022]
Abstract
The development of controlled/“living” polymerization greatly stimulated the prosperity of the fabrication and application of block copolymer nano-objects.
Collapse
Affiliation(s)
- Chao Liu
- CAS Key Laboratory of Soft Matter Chemistry
- Department of Polymer Science and Engineering
- University of Science and Technology of China
- Hefei
- P. R. China
| | - Chun-Yan Hong
- CAS Key Laboratory of Soft Matter Chemistry
- Department of Polymer Science and Engineering
- University of Science and Technology of China
- Hefei
- P. R. China
| | - Cai-Yuan Pan
- CAS Key Laboratory of Soft Matter Chemistry
- Department of Polymer Science and Engineering
- University of Science and Technology of China
- Hefei
- P. R. China
| |
Collapse
|
30
|
Abstract
Mother Nature produces a perfectly defined architecture that inspires researchers to make polymeric macromolecules for an array of functions. The present article describes recent development in the PISA to synthesize polymeric nano-objects.
Collapse
Affiliation(s)
- Shivshankar R. Mane
- Polymer Science and Engineering Division
- CSIR – National Chemical Laboratory
- Pune 411008
- India
| |
Collapse
|
31
|
Hatton FL, Derry MJ, Armes SP. Rational synthesis of epoxy-functional spheres, worms and vesicles by RAFT aqueous emulsion polymerisation of glycidyl methacrylate. Polym Chem 2020. [DOI: 10.1039/d0py01097a] [Citation(s) in RCA: 14] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/02/2023]
Abstract
The rational synthesis of epoxy-functional diblock copolymer nano-objects has been achieved by RAFT aqueous emulsion polymerisation of glycidyl methacrylate under mild conditions (50 °C, pH 7) to preserve the epoxy groups.
Collapse
Affiliation(s)
- Fiona L. Hatton
- Dainton Building
- Department of Chemistry
- University of Sheffield
- Sheffield
- UK
| | - Matthew J. Derry
- Dainton Building
- Department of Chemistry
- University of Sheffield
- Sheffield
- UK
| | - Steven P. Armes
- Dainton Building
- Department of Chemistry
- University of Sheffield
- Sheffield
- UK
| |
Collapse
|
32
|
RAFT mediated miniemulsion copolymerization of ethylene and BMA and their non-isothermal model-free kinetic analysis. Polym Bull (Berl) 2019. [DOI: 10.1007/s00289-019-02715-0] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/31/2022]
|
33
|
Dai X, Yu L, Zhang Y, Zhang L, Tan J. Polymerization-Induced Self-Assembly via RAFT-Mediated Emulsion Polymerization of Methacrylic Monomers. Macromolecules 2019. [DOI: 10.1021/acs.macromol.9b01689] [Citation(s) in RCA: 51] [Impact Index Per Article: 10.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/04/2023]
Affiliation(s)
- Xiaocong Dai
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
| | - Liangliang Yu
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
| | - Yuxuan Zhang
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
| | - Li Zhang
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou 510006, China
| | - Jianbo Tan
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou 510006, China
| |
Collapse
|
34
|
Brotherton EE, Hatton FL, Cockram AA, Derry MJ, Czajka A, Cornel EJ, Topham PD, Mykhaylyk OO, Armes SP. In Situ Small-Angle X-ray Scattering Studies During Reversible Addition-Fragmentation Chain Transfer Aqueous Emulsion Polymerization. J Am Chem Soc 2019; 141:13664-13675. [PMID: 31364361 PMCID: PMC6716212 DOI: 10.1021/jacs.9b06788] [Citation(s) in RCA: 83] [Impact Index Per Article: 16.6] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/26/2019] [Indexed: 11/29/2022]
Abstract
Polymerization-induced self-assembly (PISA) is a powerful platform technology for the rational and efficient synthesis of a wide range of block copolymer nano-objects (e.g., spheres, worms or vesicles) in various media. In situ small-angle X-ray scattering (SAXS) studies of reversible addition-fragmentation chain transfer (RAFT) dispersion polymerization have previously provided detailed structural information during self-assembly (see M. J. Derry et al., Chem. Sci. 2016 , 7 , 5078 - 5090 ). However, conducting the analogous in situ SAXS studies during RAFT aqueous emulsion polymerizations poses a formidable technical challenge because the inherently heterogeneous nature of such PISA formulations requires efficient stirring to generate sufficiently small monomer droplets. In the present study, the RAFT aqueous emulsion polymerization of 2-methoxyethyl methacrylate (MOEMA) has been explored for the first time. Chain extension of a relatively short non-ionic poly(glycerol monomethacrylate) (PGMA) precursor block leads to the formation of sterically-stabilized PGMA-PMOEMA spheres, worms or vesicles, depending on the precise reaction conditions. Construction of a suitable phase diagram enables each of these three morphologies to be reproducibly targeted at copolymer concentrations ranging from 10 to 30% w/w solids. High MOEMA conversions are achieved within 2 h at 70 °C, which makes this new PISA formulation well-suited for in situ SAXS studies using a new reaction cell. This bespoke cell enables efficient stirring and hence allows in situ monitoring during RAFT emulsion polymerization for the first time. For example, the onset of micellization and subsequent evolution in particle size can be studied when preparing PGMA29-PMOEMA30 spheres at 10% w/w solids. When targeting PGMA29-PMOEMA70 vesicles under the same conditions, both the micellar nucleation event and the subsequent evolution in the diblock copolymer morphology from spheres to worms to vesicles are observed. These new insights significantly enhance our understanding of the PISA mechanism during RAFT aqueous emulsion polymerization.
Collapse
Affiliation(s)
- Emma E. Brotherton
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Fiona L. Hatton
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Amy A. Cockram
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Matthew J. Derry
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Adam Czajka
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Erik J. Cornel
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Paul D. Topham
- Aston Institute of
Materials Research, Aston University, Birmingham B4 7ET, United Kingdom
| | - Oleksandr O. Mykhaylyk
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| | - Steven P. Armes
- Dainton Building,
Department of Chemistry, University of Sheffield, Brook Hill, Sheffield, South Yorkshire S3 7HF, United Kingdom
| |
Collapse
|
35
|
Brunel F, Lesage de la Haye J, Lansalot M, D’Agosto F. New Insight into Cluster Aggregation Mechanism during Polymerization-Induced Self-Assembly by Molecular Dynamics Simulation. J Phys Chem B 2019; 123:6609-6617. [DOI: 10.1021/acs.jpcb.9b03622] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
Affiliation(s)
- Fabrice Brunel
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, C2P2, 43 Bvd. du 11 Novembre 1918, F-69616 Villeurbanne, France
| | - Jennifer Lesage de la Haye
- Univ Lyon, Université Claude Bernard Lyon 1, CNRS, CNES, ArianeGroup, LHCEP, Bât. Raulin, 2 Rue Victor Grignard, F-69622 Villeurbanne, France
| | - Muriel Lansalot
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, C2P2, 43 Bvd. du 11 Novembre 1918, F-69616 Villeurbanne, France
| | - Franck D’Agosto
- Univ Lyon, Université Claude Bernard Lyon 1, CPE Lyon, CNRS, C2P2, 43 Bvd. du 11 Novembre 1918, F-69616 Villeurbanne, France
| |
Collapse
|
36
|
Bekanova MZ, Neumolotov NK, Jablanović AD, Plutalova AV, Chernikova EV, Kudryavtsev YV. Thermal stability of RAFT-based poly(methyl methacrylate): A kinetic study of the dithiobenzoate and trithiocarbonate end-group effect. Polym Degrad Stab 2019. [DOI: 10.1016/j.polymdegradstab.2019.03.017] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/23/2022]
|
37
|
Liu W, Zhang S, Li Q, Li X, Wang H. Preparation, rheology, and film properties of polyacrylate latex using amphiphilic macroreversible addition-fragmentation chain transfer agents as surfactants. J Appl Polym Sci 2019. [DOI: 10.1002/app.47463] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
Affiliation(s)
- Weiwei Liu
- State Key Laboratory of Organic-Inorganic Composites; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
- Beijing Engineering Research Center for the Synthesis and Applications of Waterborne Polymers; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
| | - Shuangkun Zhang
- State Key Laboratory of Organic-Inorganic Composites; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
| | - Qi Li
- State Key Laboratory of Organic-Inorganic Composites; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
- Beijing Engineering Research Center for the Synthesis and Applications of Waterborne Polymers; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
| | - Xiaoyu Li
- State Key Laboratory of Organic-Inorganic Composites; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
- Beijing Engineering Research Center for the Synthesis and Applications of Waterborne Polymers; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
| | - Haiqiao Wang
- State Key Laboratory of Organic-Inorganic Composites; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
- Beijing Engineering Research Center for the Synthesis and Applications of Waterborne Polymers; Beijing University of Chemical Technology; Beijing 100029 People's Republic of China
| |
Collapse
|
38
|
Yang P, Ning Y, Neal TJ, Jones ER, Parker BR, Armes SP. Block copolymer microparticles comprising inverse bicontinuous phases prepared via polymerization-induced self-assembly. Chem Sci 2019; 10:4200-4208. [PMID: 31015951 PMCID: PMC6460954 DOI: 10.1039/c9sc00303g] [Citation(s) in RCA: 37] [Impact Index Per Article: 7.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/18/2019] [Accepted: 03/11/2019] [Indexed: 12/15/2022] Open
Abstract
Traditionally, post-polymerization processing routes have been used to obtain a wide range of block copolymer morphologies. However, this self-assembly approach is normally performed at rather low copolymer concentration, which precludes many potential applications. Herein, we report a facile method for the preparation of block copolymer particles exhibiting complex internal morphology via polymerization-induced self-assembly (PISA). More specifically, a series of diblock copolymers were synthesized by reversible addition-fragmentation chain transfer (RAFT) alternating copolymerization of styrene (St) with N-phenylmaleimide (NMI) using a poly(N,N-dimethylacrylamide) (PDMAC) stabilizer as a soluble precursor. Conducting such PISA syntheses in a 50 : 50 w/w ethanol/methyl ethyl ketone (MEK) mixture leads directly to the formation of micrometer-sized PDMAC-P(St-alt-NMI) diblock copolymer particles at 20% w/w solids. Adjusting the degree of polymerization (DP) of the core-forming P(St-alt-NMI) block to target highly asymmetric copolymer compositions provides convenient access to an inverse bicontinuous phase. TEM studies of intermediate structures provide useful insights regarding the mechanism of formation of this phase. SEM studies indicate that the final copolymer particles comprise perforated surface layers and possess nanostructured interiors. In addition, control experiments using 1,4-dioxane suggest that the high chain mobility conferred by the MEK co-solvent is essential for the formation of such inverse bicontinuous structures. One-pot PISA formulations are reproducible and involve only cheap, commercially available starting materials, so they should be readily amenable to scale-up. This augurs well for the potential use of such nanostructured micrometer-sized particles as new organic opacifiers for paints and coatings.
Collapse
Affiliation(s)
- Pengcheng Yang
- Department of Chemistry , University of Sheffield , Brook Hill , Sheffield , South Yorkshire S3 7HF , UK . ; ;
| | - Yin Ning
- Department of Chemistry , University of Sheffield , Brook Hill , Sheffield , South Yorkshire S3 7HF , UK . ; ;
| | - Thomas J Neal
- Department of Chemistry , University of Sheffield , Brook Hill , Sheffield , South Yorkshire S3 7HF , UK . ; ;
| | - Elizabeth R Jones
- Department of Chemistry , University of Sheffield , Brook Hill , Sheffield , South Yorkshire S3 7HF , UK . ; ;
| | - Bryony R Parker
- Department of Chemistry , University of Sheffield , Brook Hill , Sheffield , South Yorkshire S3 7HF , UK . ; ;
| | - Steven P Armes
- Department of Chemistry , University of Sheffield , Brook Hill , Sheffield , South Yorkshire S3 7HF , UK . ; ;
| |
Collapse
|
39
|
Serkhacheva NS, Prokopov NI, Chernikova EV, Kozhunova EY, Lebedeva IO, Borisov OV. Emulsifier‐free reversible addition–fragmentation chain transfer emulsion polymerization of alkyl acrylates mediated by symmetrical trithiocarbonates based on poly(acrylic acid). POLYM INT 2019. [DOI: 10.1002/pi.5817] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
Affiliation(s)
- Natalia S Serkhacheva
- MIREA – Russian Technological University, Lomonosov Institute of Fine Chemical Technologies pr. Vernadskogo, 86, Moscow Russian Federation
| | - Nikolay I Prokopov
- MIREA – Russian Technological University, Lomonosov Institute of Fine Chemical Technologies pr. Vernadskogo, 86, Moscow Russian Federation
| | - Elena V Chernikova
- Faculty of ChemistryLomonosov Moscow State University Lenin Hills, 1, bld. 3, Moscow Russian Federation
| | - Elena Y Kozhunova
- Faculty of PhisicsLomonosov Moscow State University Lenin Hills, 1, bld. 2, Moscow Russian Federation
| | - Inna O Lebedeva
- Peter the Great St Petersburg Polytechnic University Polytekhnicheskaya, 29, St.Petersburg Russian Federation
- Institut des Sciences Analytiques et de Physico‐Chimie pour l'Environnement et les Matériaux 2 av. P. Angot Pau France
| | - Oleg V Borisov
- Peter the Great St Petersburg Polytechnic University Polytekhnicheskaya, 29, St.Petersburg Russian Federation
- Institut des Sciences Analytiques et de Physico‐Chimie pour l'Environnement et les Matériaux 2 av. P. Angot Pau France
| |
Collapse
|
40
|
Boulding NA, Millican JM, Hutchings LR. Understanding copolymerisation kinetics for the design of functional copolymers via free radical polymerisation. Polym Chem 2019. [DOI: 10.1039/c9py01294j] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
Abstract
We report the free radical copolymerisation kinetics and co-monomer sequence distribution for a series of functional copolymers based on MMA.
Collapse
|
41
|
Hatton FL, Park AM, Zhang Y, Fuchs GD, Ober CK, Armes SP. Aqueous one-pot synthesis of epoxy-functional diblock copolymer worms from a single monomer: new anisotropic scaffolds for potential charge storage applications. Polym Chem 2019. [DOI: 10.1039/c8py01427b] [Citation(s) in RCA: 30] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/07/2023]
Abstract
The one-pot synthesis of highly anisotropic epoxy-functional diblock copolymer worms is achieved directly in water using a single monomer (glycidyl methacrylate).
Collapse
Affiliation(s)
- Fiona L. Hatton
- Dainton Building
- Department of Chemistry
- University of Sheffield
- Sheffield
- UK
| | - Albert M. Park
- School of Applied and Engineering Physics
- Cornell University
- Ithaca
- USA
| | - Yiren Zhang
- Materials Science and Engineering
- Cornell University
- Ithaca
- USA
| | - Gregory D. Fuchs
- School of Applied and Engineering Physics
- Cornell University
- Ithaca
- USA
| | | | - Steven P. Armes
- Dainton Building
- Department of Chemistry
- University of Sheffield
- Sheffield
- UK
| |
Collapse
|
42
|
Chernikova EV, Lysenko EA, Serkhacheva NS, Prokopov NI. Self-Assembly of Amphiphilic Block Copolymers during Reversible Addition-Fragmentation Chain Transfer Heterophase Polymerization: Problems, Achievements, and Outlook. POLYMER SCIENCE SERIES C 2018. [DOI: 10.1134/s1811238218020042] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
43
|
Ebeling B, Belal K, Stoffelbach F, Woisel P, Lansalot M, D'Agosto F. Polymer Nanospheres with Hydrophobic Surface Groups as Supramolecular Building Blocks Produced by Aqueous PISA. Macromol Rapid Commun 2018; 40:e1800455. [PMID: 30198165 DOI: 10.1002/marc.201800455] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/11/2018] [Revised: 07/24/2018] [Indexed: 11/12/2022]
Abstract
A robust and straightforward synthesis of waterborne polymer nanospheres bearing the supramolecular association unit dialkoxynapthalene at their surface is presented using polymerization-induced self-assembly (PISA). A RAFT agent bearing this unit is first employed to produce poly(acrylic acid) chains, which are then chain-extended with styrene (S) to spontaneously form the nano-objects via RAFT aqueous emulsion polymerization. The particular challenge posed by the dialkoxynapthalene hydrophobicity can be overcome by the use of PISA and the deprotonation of the poly(acrylic acid). At pH = 7, very homogeneous latexes are obtained. The particle diameters can be tuned from 36 to 105 nm (with a narrow particle size distribution) by varying the molar mass of the PS block. The surface accessibility of the dialkoxynapthalene moieties is demonstrated by complexation with the complementary host cyclobis(paraquat-p-phenylene) (CBPQT4+ · Cl- ), highlighting the potential of the nanospheres to act as building blocks for responsive supramolecular structures.
Collapse
Affiliation(s)
- Bastian Ebeling
- Chemistry, Catalysis, Polymers and Processes (C2P2), CNRS UMR 5265, CPE Lyon, Université Claude Bernard Lyon 1, 43 Bd du 11 Novembre 1918, 69616, Villeurbanne, France
| | - Khaled Belal
- Unité Matériaux et Transformations (UMET), CNRS UMR 8207, ENSCL, INRA, Université de Lille, 59000, Lille, France
| | - François Stoffelbach
- Equipe Chimie des Polymères, CNRS UMR 8232, Institut Parisien de Chimie Moléculaire, Sorbonne Université, 75252, Paris Cedex 05, France
| | - Patrice Woisel
- Unité Matériaux et Transformations (UMET), CNRS UMR 8207, ENSCL, INRA, Université de Lille, 59000, Lille, France
| | - Muriel Lansalot
- Chemistry, Catalysis, Polymers and Processes (C2P2), CNRS UMR 5265, CPE Lyon, Université Claude Bernard Lyon 1, 43 Bd du 11 Novembre 1918, 69616, Villeurbanne, France
| | - Franck D'Agosto
- Chemistry, Catalysis, Polymers and Processes (C2P2), CNRS UMR 5265, CPE Lyon, Université Claude Bernard Lyon 1, 43 Bd du 11 Novembre 1918, 69616, Villeurbanne, France
| |
Collapse
|
44
|
Zhou D, Kuchel RP, Dong S, Lucien FP, Perrier S, Zetterlund PB. Polymerization-Induced Self-Assembly under Compressed CO2
: Control of Morphology Using a CO2
-Responsive MacroRAFT Agent. Macromol Rapid Commun 2018; 40:e1800335. [DOI: 10.1002/marc.201800335] [Citation(s) in RCA: 34] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/01/2018] [Revised: 07/12/2018] [Indexed: 11/12/2022]
Affiliation(s)
- Dewen Zhou
- Centre for Advanced Macromolecular Design; School of Chemical Engineering; University of New South Wales; Sydney NSW 2052 Australia
| | - Rhiannon P. Kuchel
- Mark Wainwright Analytical Centre; University of New South Wales; Sydney NSW 2052 Australia
| | - Siming Dong
- Centre for Advanced Macromolecular Design; School of Chemical Engineering; University of New South Wales; Sydney NSW 2052 Australia
| | - Frank P. Lucien
- Centre for Advanced Macromolecular Design; School of Chemical Engineering; University of New South Wales; Sydney NSW 2052 Australia
| | - Sébastien Perrier
- Department of Chemistry; University of Warwick; Gibbet Hill; Coventry CV4 7AL UK
- Faculty of Pharmacy and Pharmaceutical Sciences; Monash University; 381 Royal Parade Parkville VIC 3052 Australia
| | - Per B. Zetterlund
- Centre for Advanced Macromolecular Design; School of Chemical Engineering; University of New South Wales; Sydney NSW 2052 Australia
| |
Collapse
|
45
|
Khor SY, Quinn JF, Whittaker MR, Truong NP, Davis TP. Controlling Nanomaterial Size and Shape for Biomedical Applications via Polymerization-Induced Self-Assembly. Macromol Rapid Commun 2018; 40:e1800438. [PMID: 30091816 DOI: 10.1002/marc.201800438] [Citation(s) in RCA: 101] [Impact Index Per Article: 16.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/06/2018] [Revised: 07/13/2018] [Indexed: 11/06/2022]
Abstract
Rapid developments in the polymerization-induced self-assembly (PISA) technique have paved the way for the environmentally friendly production of nanoparticles with tunable size and shape for a diverse range of applications. In this feature article, the biomedical applications of PISA nanoparticles and the substantial progress made in controlling their size and shape are highlighted. In addition to early investigations into drug delivery, applications such as medical imaging, tissue culture, and blood cryopreservation are also described. Various parameters for controlling the morphology of PISA nanoparticles are discussed, including the degree of polymerization of the macro-CTA and core-forming polymers, the concentration of macro-CTA and core-forming monomers, the solid content of the final products, the solution pH, the thermoresponsitivity of the macro-CTA, the macro-CTA end group, and the initiator concentration. Finally, several limitations and challenges for the PISA technique that have been recently addressed, along with those that will require further efforts into the future, will be highlighted.
Collapse
Affiliation(s)
- Song Yang Khor
- ARC Centre of Excellence in Convergent Bio-Nano Science and Technology, Monash Institute of Pharmaceutical Sciences, Monash University, 381 Royal Parade, Parkville, VIC, 3052, Australia
| | - John F Quinn
- ARC Centre of Excellence in Convergent Bio-Nano Science and Technology, Monash Institute of Pharmaceutical Sciences, Monash University, 381 Royal Parade, Parkville, VIC, 3052, Australia
| | - Michael R Whittaker
- ARC Centre of Excellence in Convergent Bio-Nano Science and Technology, Monash Institute of Pharmaceutical Sciences, Monash University, 381 Royal Parade, Parkville, VIC, 3052, Australia
| | - Nghia P Truong
- ARC Centre of Excellence in Convergent Bio-Nano Science and Technology, Monash Institute of Pharmaceutical Sciences, Monash University, 381 Royal Parade, Parkville, VIC, 3052, Australia
| | - Thomas P Davis
- ARC Centre of Excellence in Convergent Bio-Nano Science and Technology, Monash Institute of Pharmaceutical Sciences, Monash University, 381 Royal Parade, Parkville, VIC, 3052, Australia.,Department of Chemistry, University of Warwick, Gibbet Hill, Coventry, CV47AL, UK
| |
Collapse
|
46
|
György C, Lovett JR, Penfold NJW, Armes SP. Epoxy-Functional Sterically Stabilized Diblock Copolymer Nanoparticles via RAFT Aqueous Emulsion Polymerization: Comparison of Two Synthetic Strategies. Macromol Rapid Commun 2018; 40:e1800289. [DOI: 10.1002/marc.201800289] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/13/2018] [Revised: 05/17/2018] [Indexed: 01/08/2023]
Affiliation(s)
- Csilla György
- Dainton Building; Department of Chemistry; University of Sheffield; Brook Hill Sheffield South Yorkshire S3 7HF UK
| | - Joseph R. Lovett
- Dainton Building; Department of Chemistry; University of Sheffield; Brook Hill Sheffield South Yorkshire S3 7HF UK
| | - Nicholas J. W. Penfold
- Dainton Building; Department of Chemistry; University of Sheffield; Brook Hill Sheffield South Yorkshire S3 7HF UK
| | - Steven P. Armes
- Dainton Building; Department of Chemistry; University of Sheffield; Brook Hill Sheffield South Yorkshire S3 7HF UK
| |
Collapse
|
47
|
Mellot G, Beaunier P, Guigner JM, Bouteiller L, Rieger J, Stoffelbach F. Beyond Simple AB Diblock Copolymers: Application of Bifunctional and Trifunctional RAFT Agents to PISA in Water. Macromol Rapid Commun 2018; 40:e1800315. [DOI: 10.1002/marc.201800315] [Citation(s) in RCA: 30] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/24/2018] [Revised: 05/19/2018] [Indexed: 12/18/2022]
Affiliation(s)
- Gaëlle Mellot
- Sorbonne Université; CNRS; Institut Parisien de Chimie Moléculaire; UMR 8232; Equipe chimie des polymères; F-75252 Paris Cedex 05 France
| | - Patricia Beaunier
- Sorbonne Université; CNRS; Laboratoire de Réactivité de Surface; UMR 7197 F-75252 Paris Cedex 05 France
| | - Jean-Michel Guigner
- Sorbonne Université; CNRS; Institut de Minéralogie; de Physique des Matériaux et de Cosmochimie; UMR 7590 - IRD - MNHN F-75005 Paris France
| | - Laurent Bouteiller
- Sorbonne Université; CNRS; Institut Parisien de Chimie Moléculaire; UMR 8232; Equipe chimie des polymères; F-75252 Paris Cedex 05 France
| | - Jutta Rieger
- Sorbonne Université; CNRS; Institut Parisien de Chimie Moléculaire; UMR 8232; Equipe chimie des polymères; F-75252 Paris Cedex 05 France
| | - François Stoffelbach
- Sorbonne Université; CNRS; Institut Parisien de Chimie Moléculaire; UMR 8232; Equipe chimie des polymères; F-75252 Paris Cedex 05 France
| |
Collapse
|
48
|
Serkhacheva N, Plutalova A, Kozhunova E, Prokopov N, Chernikova E. Amphiphilic Triblock Copolymers Based on Acrylic Acid and Alkyl Acrylates Synthesized via RAFT Polymerization-Induced Self-Assembly and RAFT Miniemulsion Polymerization. POLYMER SCIENCE SERIES B 2018. [DOI: 10.1134/s1560090418020070] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
|
49
|
Tan J, Xu Q, Li X, He J, Zhang Y, Dai X, Yu L, Zeng R, Zhang L. Enzyme-PISA: An Efficient Method for Preparing Well-Defined Polymer Nano-Objects under Mild Conditions. Macromol Rapid Commun 2018; 39:e1700871. [DOI: 10.1002/marc.201700871] [Citation(s) in RCA: 55] [Impact Index Per Article: 9.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/20/2017] [Revised: 01/25/2018] [Indexed: 01/18/2023]
Affiliation(s)
- Jianbo Tan
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter; Guangzhou 510006 China
| | - Qin Xu
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Xueliang Li
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Jun He
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Yuxuan Zhang
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Xiaocong Dai
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Liangliang Yu
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Ruiming Zeng
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
| | - Li Zhang
- Department of Polymeric Materials and Engineering; School of Materials and Energy; Guangdong University of Technology; Guangzhou 510006 China
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter; Guangzhou 510006 China
| |
Collapse
|
50
|
Capasso Palmiero U, Maraldi M, Manfredini N, Moscatelli D. Zwitterionic Polyester-Based Nanoparticles with Tunable Size, Polymer Molecular Weight, and Degradation Time. Biomacromolecules 2018. [PMID: 29522318 DOI: 10.1021/acs.biomac.8b00127] [Citation(s) in RCA: 21] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/22/2022]
Abstract
Biodegradable polymer nanoparticles are an important class of materials used in several applications for their unique characteristics. In particular, the ones stabilized by zwitterionic materials are gaining increased interest in medicine as alternative to the more common ones based on poly(ethylene glycol) thanks to their superior stability and ability to avoid both the accelerated blood clearance and allergic reactions. In this work, a novel class of zwitterionic based NPs has been produced, and a method to independently control the nanoparticle size, degradation time, and polymer molecular weight has been developed and demonstrated. This has been possible by the synthesis and the fine-tuning of zwitterionic amphiphilic block copolymers obtained via the combination of ring-opening polymerization and reversible addition-fragmentation chain transfer polymerization. The final results showed that when two block copolymers contain the same number of caprolactone units, the one with longer oligoester lateral chains degrades faster. This phenomenon is in sharp contrast with the one seen so far for the common linear polyester systems where longer chains result in longer degradation times, and it can be used to better tailor the degradation behavior of the nanoparticles.
Collapse
Affiliation(s)
- Umberto Capasso Palmiero
- Department of Chemistry, Materials and Chemical Engineering , Politecnico di Milano , Via Mancinelli 7 , 20131 Milano , Italy.,Department of Chemistry and Applied Biosciences, Institute for Chemical and Bioengineering , ETH Zurich , 8092 Zurich , Switzerland
| | - Matteo Maraldi
- Department of Chemistry and Applied Biosciences, Institute for Chemical and Bioengineering , ETH Zurich , 8092 Zurich , Switzerland
| | - Nicolò Manfredini
- Department of Chemistry and Applied Biosciences, Institute for Chemical and Bioengineering , ETH Zurich , 8092 Zurich , Switzerland
| | - Davide Moscatelli
- Department of Chemistry, Materials and Chemical Engineering , Politecnico di Milano , Via Mancinelli 7 , 20131 Milano , Italy
| |
Collapse
|