Comparison of inert markers [chromic oxide or insoluble ash (Celite)] for determining apparent metabolizable energy of wheat- or barley-based broiler diets with or without enzymes

Influence of a Combination of Glycerol Polyethylene Glycol Ricinoleate and Bi-Distilled Oleic Acid in Powder Form on Growth Performance, Nutrient Digestibility, Excreta Nitrogen and Liver Fatty Acid Profile of Broilers Fed Reduced-Energy Diets

The present study aimed to evaluate the effects of an emulsifier in powder form composed of glycerol polyethylene glycol ricinoleate and bi-distilled oleic acid on the growth performance, nutrient digestibility, excreta nitrogen and liver fatty acid profile of broilers fed reduced-energy diets. A total of 720 male ROSS 308 chicks were divided into four homogeneous groups (9 pens/20 chicks per group): positive control (PC), negative control (NC, -70 kcal/kg of AME), EMUL1 and EMUL2 fed an NC diet + 250 and 500 mg/kg of emulsifier. Body weight, average daily gain, average daily feed intake and feed conversion ratio (FCR) were evaluated. Excreta were collected at 24 and 42 d directly from polyethylene trays and pooled to determine the apparent total tract digestibility of dry matter, crude protein, ether extract and gross energy. The apparent metabolizable energy (AME, AMEn) and nitrogen ammonia in excreta were determined. Performances were improved in EMUL1 and EMUL2 during the trial (p < 0.05). The digestibility of nutrients in EMUL1 and EMUL2 was increased in comparison to NC and PC (p < 0.05). Excreta nitrogen ammonia was reduced by EMUL2 at 42 d (p < 0.05). Glycerol polyethylene glycol ricinoleate and bi-distilled oleic acid in powder form modulated liver fatty acid profiles, enhancing oleic acid content in EMUL1 chickens (p < 0.05), while γ-linolenic acid and arachidonic acid were enhanced in EMUL2 (p < 0.05). Based on the findings, it is recommended to administer solidified glycerol polyethylene glycol ricinoleate and bi-distilled oleic acid in diets with reduced energy content for appreciable advantages in terms of growth through higher nutrient digestibility and better hepatic fatty acid composition.

Evaluation of black soldier fly larvae reared on different organic substrates on nutrient digestibility and palatability in cats

This study aimed to evaluate the digestibility and palatability of cat diets by substituting poultry meals (PM) with black soldier fly larvae (BSFL) reared on different organic substrates. The experimental treatments are as follows; CON, a basal diet based on the PM; AF3, 3% PM substituted with BSFL reared on animal-based substrates; AF6, 6% PM substituted with BSFL reared on animal-based substrates; PF3, 3% PM substituted with BSFL reared on plant-based substrates; PF6, 6% PM substituted with BSFL reared on plant-based substrates. In vitro and in vivo methods were used in this study. The in vitro experiment simulated gastric digestion using pepsin and small intestinal digestion using bile and pancreatin, with 6 replicates per diet. The in vivo experiment used 30 and 16 mixed-sex cats to assess digestibility and palatability, respectively. Fecal samples were collected over 3 d for nutrient digestibility and palatability was assessed in a 1 d. In the in vitro experiment, the AF3 had higher in vitro ileal digestibility (IVID) of crude protein (CP) than the CON and PF6, and diets supplemented with BSFL groups had higher IVID of gross energy and ether extract (EE) than the CON. In the in vivo experiment, the AF3 showed higher CP digestibility than the CON, and diets supplemented with BSFL groups had higher EE digestibility than the CON. In palatability evaluation, the AF6 had a lower intake ratio than the CON. The 3% substitution of BSFL showed a significantly higher first sniffing bout than the 6% substitution in animal and plant-based substrates. Additionally, except for the CON, the AF3 exhibited a higher first sniffing bout than the other groups. In conclusion, the AF3 improved CP digestibility in both in vitro and in vivo experiments. Also, the AF3 did not show negative effects on palatability. Therefore, this result indicated that substituting 3% of PM with BSFL reared on animal-based substrate in cat diets was the most efficient alternative.

The effect of protease supplementation in broiler chicken diets containing maize from different batches on growth performance and nutrient digestibility

Maize is the primary energy source in poultry diets. Nutritional and physical traits related to maize composition can affect nutrient utilization, as well as the efficacy of exogenous enzymes. A study was conducted to evaluate the effect of maize from different batches and protease supplementation on growth performance and ileal nutrient digestibility of broiler chickens from 1 to 40 days of age. A total of 1 920-day-old Ross 308 male chicks were assigned in a complete randomized design distributed into a 2 × 2 factorial arrangement comprising maize from two different batches (A and B) without and with protease (0 and 200 g/t), totaling 4 treatments and 12 replicates of 40 broiler chickens each. Experimental diets were divided into starter, grower I, grower II, and finisher phases. Both maize types were analyzed for nutritional composition, hardness, and structural differences in the starch granules via scanning electron microscopy. Feed intake, weight gain (WG), and feed conversion ratio (FCR) were evaluated. Ileal digesta was collected at 35 days to determine the apparent ileal digestibility (AID) of DM, CP, and ileal digestible energy (IDE). Hardness was higher in maize grains from batch A (P < 0.05), which may be associated with the denser and compact starch granules observed in electron microscopy. Broiler chickens fed maize from batch B and supplemented with protease showed greater WG and better FCR from 9 to 19 days (P < 0.05). From 1 to 40 days, birds fed the maize B diet had greater WG and lower FCR compared to those fed the maize A diet (P < 0.05). In the total period, protease supplementation reduced FCR (P < 0.01). No differences were found for AID of DM and CP, but broilers fed maize B diets had greater IDE (P < 0.05). In conclusion, although nutrient ileal digestibility was unaffected by treatments, the use of maize B led to superior growth performance and energy utilization due to its softer endosperm and starch composition, and protease supplementation reduced FCR and increased IDE regardless of maize batch.

Effect of different levels of whole corn germ on energy values and ileal digestibility in broilers

This study evaluated the effects of broiler age (A) and levels of replacement (L) of control diet (CD) on the utilization of energy and nutrients of whole corn germ. 720 one-day-old broilers (b) were allocated at completely randomized design to six treatments and six replicates, in three assays: pre-starter (1-8 days, 10 b/cage), starter (15-22 days, 6 b/cage), and grower (28-35 days, 4 b/cage) phases. The treatments were: CD and four test diets (L): 100, 150, 200, 250, or 300 g kg-1 of the CD replaced by WCG levels. The data were adjusted to the response surface model. The stationary points for apparent energy metabolizable (AME) and AME corrected for nitrogen balance (AMEn) were: 4173 and 3591 kcal kg-1, respectively, and coefficients of gross energy (AMCGE), crude protein (AMCCP), dry matter (AMCDM), and ether extract (AMCEE) were: 49.3, 40.4, 72.6, and 61.3%, respectively; and Ileal digestibility coefficient of crude protein (IDCCP), dry matter (IDCDM), digestibility crude protein values (DCP), and digestibility dry matter value (DDM) were: 78.0, 57.96, 8.50, and 56.17%, respectively. The EP for AMEn was at 18 days of age, 28 g kg-1 WCG. There was a correlation between A and L on digestibility and metabolisability of nutrient's WCG.

Effect of 25-hydroxycholecalciferol supplementation with different dietary available phosphorus levels for broilers

1. Based on the hypothesis that 25-hydroxycholecalciferol (25-OH-D3) inclusion would optimise dietary mineral digestibility and ameliorate growth performance and bone mineralisation in available phosphorus (AvP) deficient-fed broilers, a trial was conducted to evaluate its effect on diets with different levels of AvP.2. Broilers aged 1-21 d were randomly assigned one of the eight treatments, consisting of four dietary levels of AvP (0.45%, 0.42%, 0.39%, and 0.36%) and with or without supplementation with 25-OH-D3 at 69 μg/kg of feed. All diets contained 100 µg/kg of vitamin D3 (cholecalciferol).3. The addition of 25-OH-D3 resulted in higher feed intake and body weight gain, and lower FCR (P < 0.05) compared to non-supplemented diets, whereas AvP levels had a quadratic effect only on feed intake. There were no interactions between treatment factors.4. Increasing AvP levels linearly reduced the ileal digestibility of Ca and P (P < 0.01) and supplementing 25-OH-D3 increased both Ca and P ileal digestibility (P < 0.05), without any interactions observed for ileal digestibility.5. There was an interaction, whereby 25-OH-D3 inclusion increased serum metabolites in broilers fed 0.36% to 0.42% AvP compared to the non-supplemented diets (P < 0.001), whereas, at 0.45% AvP, diets with or without 25-OH-D3 had similar results.6. The P content in bone linearly increased in line with AvP levels (P < 0.05) and supplementation of 25-OH-D3 increased ash bone content (P < 0.001).7. Broilers can benefit from 25-OH-D3 supplementation combined with cholecalciferol with regard to Ca and P utilisation and vitamin D status, allowing for a reduction of dietary AvP levels down to 0.36% without impairing growth performance or bone status.

The Chemical Composition of Soyhulls and Their Effect on Amino Acid and Nutrient Digestibility in Laying Hens during the Peak of Production

This study investigates the chemical composition of soyhulls (SHs) as an alternative feed ingredient and their effect on nutrient and amino acid (AA) digestibility in laying hens during peak production. A total of 200 golden brown hens (28 weeks old) were subjected to random allocation across 5 dietary treatments: a corn-soybean meal (SBM) reference diet and 4 test diets with 25% SHs from different mills (SH1, SH2, SH3, and SH4). Each treatment was replicated four times with ten birds per replicate. Digesta samples were collected during three phases (28-32, 32-36, and 36-40 weeks of age) to measure apparent metabolizable energy (AME), the apparent ileal digestibility (AID) of nutrients, and the standard ileal digestibility (SID) of AAs. The SBM diet had 30.0% crude protein (CP) and 3.78% crude fiber (CF), while the SH diets had 21.0 to 21.5% CP and 11.6% CF. The findings revealed that the AME was lower (p < 0.05) with SH diets (2404 kcal/kg) compared to the SBM diet (2627 kcal/kg) in all three phases. The SH diets had a lower AID of dry matter (DM), crude protein (CP), ash, ether extract (EE), and crude fiber (CF) than the SBM diet by an average of 2.88, 2.25, 4.93, 4.99, and 3.36%, respectively. The AID of nitrogen-free extract (NFE) was higher in the SH diets than the SBM diet by 3.42% in all three phases (p < 0.05). The SH diets had lower uric acid excretion (about 66.93 mg/100 mL) than the SBM diet (about 76.43 mg/100 mL) on average in all three phases. The SH diets had a lower SID of arginine, histidine, isoleucine, lysine, cysteine, valine, and tyrosine than the SBM diet by 2 to 10%, while the SID of methionine was higher in the SH diets than the SBM diet by 2.2% on average in all three phases (p < 0.05). The SH from Sadiq Brother Feed (SH1) had the highest AME and AID of DM, ash, CP, EE, CF, and the SID of AA among the SH diets. These results indicate that SH can partially replace SBM in laying hen diets, but the source and quality of SH should be considered.

The effect of different wheat varieties and exogenous xylanase on bird performance and utilization of energy and nutrients

The aims of the present study were to first, determine the xylan fractions of 10 different wheat cultivar samples and their response to treatment by the same commercial xylanase enzyme preparation. Second, use information obtained to select 5 of the wheats for use within a feeding experiment to determine whether the rate of xylan release can be used to predict the feeding value of the wheats when diets have been supplemented with xylanase. Treatment of 10 different wheat varieties by the same enzyme resulted in varying levels of hydrolysis. Soluble xylan content ranged from 7.85 to 14.40 and 3.20 to 5.13 (mg/g) when treated with and without xylanase, respectively. Oligosaccharide content ranged from 0.34 to 1.58 and 0.05 to 0.54 (mg/g) when treated with and without xylanase, respectively. Five of the 10 wheats were then selected based on the determined xylan fractions to use within a feeding experiment. A total of 360 male Ross 308 broilers were randomly allocated to 60 raised floor pens. A soybean meal (SBM) balancer feed was formulated to contain 12.07 MJ/kg apparent metabolizable energy (AME) and 392.9 g/kg crude protein (CP). Five diets were prepared by mixing 630 g/kg of each of the 5 experimental wheats with 370 g/kg of the balancer. Each diet was split into 2, one of which was supplemented with 100 g/MT of Econase XT (223,000 BXU/g), resulting in a total of 10 diets. The birds were fed the diets from 0 to 28 d of age. Wheat cultivar had an effect (P = 0.044) on feed intake (FI), while the addition of xylanase increased (P < 0.05) weight gain (WG) and improved feed conversion ratio (FCR). Various interactions were observed (P < 0.05) between wheat cultivars and xylanase for AME and nutrient utilization. This study suggests that wheats treated with the same xylanase, differ in their susceptibility to release soluble xylan and oligosaccharides, which may partially explain the varying performance and nutrient digestibility responses noted in the literature.

Effects of supplementation of pomegranate processing by-products and waste cooking oils as alternative feed resources in broiler nutrition

Agricultural residues can be used as alternative feed sources in industrial chicken production. The impacts of different levels of pomegranate peel and waste cooking oil as an agricultural residue on broilers' nutrition were investigated. Results showed that the replacement of 8% pomegranate peel in diets decreased the growth performance of broilers. Supplementing 8% pomegranate peel in diets reduced apparent nutrient digestibility. The highest level of waste oil inclusion in broiler diets indicated negative impacts on apparent zmetabolizable energy and crude fat apparent nutrients digestibility. Broilers fed the diet containing 4% pomegranate peel had a higher Lactobacillus population. The results showed that the Lactobacillus population was lower in broilers fed 8% pomegranate peel powder and 4% waste oil in diets. The inclusion of 8% pomegranate peel powder in diets showed lower villus height and crypt depth in the duodenum, jejunum, and ileum. The inclusion of 4% pomegranate peel decreased the peroxide value (PV) of meat. Dietary inclusion of 4% waste oil raised the PV of meat. Alpha-tocopherol supplementation decreased the PV of meat. Finally, the results provide information that 4% of pomegranate peel and 4% waste oil could be used as an alternative feed ingredient in broiler diets without adverse effects.

Influence of dietary dacitic tuff breccia on laying hen performance and egg quality parameters and bone structure at 85 weeks of age after a non-anorexic molt program at 73 to 77 weeks

The objective of the study was to assess the efficacy of AZOMITE (AZM), a dacitic tuff breccia, in laying hens through egg quality and production parameters. A total of ninety six 73-wk-old Hy-Line W-36 commercial laying hens were randomly assigned to 2 dietary treatments, a control diet and the same diet containing 0.25% AZM, with 24 replicates of 2 hens/replication. From 73 to 77 wk, hens went through nonanorexic molt, and, from 77 to 85 wk, the hens were evaluated for egg production, eggshell quality, and bone health. At wk 85, tibiotarsi were collected for ash and mineral composition, ileal contents were collected for calcium, phosphorus, apparent metabolizable energy corrected for N (AMEn), and apparent nitrogen retention (ANR) evaluation. AZM-fed hens tended to have higher body weight (P = 0.07) from 82 to 83 and 84 to 85 wk, and higher hen day egg production than control (90.54 vs. 79.51%, P = 0.005) from 84 to 85 wk. In general, no differences were reported in feed intake, eggshell color, egg weight, albumen height, Haugh units, or eggshell thickness (P > 0.05). However, shell strength and elasticity were improved (P < 0.02) and yolk color was decreased (P = 0.03) in AZM-fed hens than control. Moreover, the digestibility of Ca, AMEn, and ANR was increased with 0.25% AZM compared to control (P < 0.01). Tibiotarsi P and Ca percentage were lower in AZM-fed birds than control (P < 0.01), without affecting bone strength and mineral density (P > 0.36). Therefore, the use of 0.25% AZM showed a potential in improving egg production and eggshell strength, while maintaining bone quality in post-molt laying hens.

Chemical Compositions of Brown and Green Seaweed, and Effects on Nutrient Digestibility in Broiler Chickens

Simple Summary

This study aimed to analyse the nutritional properties and apparent ileal digestibility of brown and green seaweed on broiler chickens. Proximate content, mineral and amino acid contents were analysed. In addition, the gross energy value of brown and green seaweed was measured. A digestibility trial was conducted to determine the apparent ileal digestibility of seaweed in broiler chickens. Apparent metabolisable energy was determined as well in this study. Birds were fed with 90.30% seaweed-based diet with an indigestible marker. At the end of the feeding trial, birds were euthanised and ileal digesta was collected. Nutrient contents of experimental feed and digesta were analysed, and gross energy was measured. The results revealed that there was no significant difference in the apparent ileal digestibility of dry matter, organic matter, crude lipid and ash contents among the brown and green seaweed-based diets. The findings also demonstrated that the apparent ileal digestibility of crude protein and crude fibre was significantly higher in brown seaweed compared to green seaweed. Nevertheless, no significant difference was observed in the apparent digestibility of metabolisable energy between the types of seaweed.

Abstract

This study aimed to analyse the nutritional properties, apparent ileal digestibility (AID) and apparent metabolisable energy (AME) of broiler chickens fed with brown seaweed (BS) and green seaweed (GS). Proximate analysis was performed to determine the nutrient composition of seaweed. The amino acids were determined using high-performance liquid chromatography (HPLC), and atomic absorption spectroscopy was used to determine the minerals content. The gross energy (GE) was determined using a fully automatic bomb calorimeter, and the AME value was calculated. Titanium dioxide (TiO₂) was used as an indigestible marker to calculate the AID. A digestibility trial was conducted to investigate the effects of seaweeds on crude protein (CP), crude fibre (CF), ether extract (EE), dry matter (DM), organic matter (OM), amino acids (AA) and minerals digestibility, and AME on broiler chickens. Thirty-six broiler chickens were randomly distributed into two dietary treatment groups with six replicates and three birds per replicate. Results showed that brown and green seaweed was a source of macro and micronutrients. For the AME and AID of seaweed-based diets, the results showed that the AME value for BS and GS was 2894.13 and 2780.70 kcal/kg, respectively. The AID of BS and GS was 88.82% and 86.8% for EE, 82.03% and 80.6% for OM, 60.69% and 57.80% for CP, 48.56 and 44.02% for CF, and 17.97 and 19.40% for ash contents, respectively. Meanwhile, the AID of CP and CF was significantly higher for BS compared to the GS. Findings showed that the AID of various AA was 40.96 to 77.54%, and the AID of selected minerals (Ca, Na, K, Mg, Zn, Cu, Fe) for both BS and GS groups were above 90%.

High doses of phytase on growth performance, bone mineralization, diet utilization, and plasmatic myo-inositol of turkey poults

An experiment was conducted to evaluate the growth performance, bone mineral composition, diet utilization, and plasmatic concentration of myo-inositol (MYO) in turkeys fed different phytase doses from 1 to 28 d. A total of three hundred and twenty 1-day-old turkeys were distributed in a completely randomized design with 4 treatments and 8 replicates of 10 birds each. Treatments included a basal diet without phytase; reduced diet (reduced -0.15% available P and -0.18% Ca) without phytase; reduced diet + 2,000 units of phytase (FYT)/kg; and reduced diet + 4,000 FYT/kg. From day 26 to 28, partial excreta collection was conducted, and on day 28, 7 birds per replicate were euthanized for collection of ileal content and left tibia bones were removed from 2 of the same euthanized birds. Feed, excreta, and ileal digesta samples were analyzed to determine nutrient digestibility and metabolizability, ileal digestible energy, and AME. Tibia bones were analyzed for ash, Ca, and P content, and calculation of Seedor index. On day 28, blood samples were collected from 2 turkeys per replicate to analyze plasmatic MYO concentration. Feed conversion ratio was not affected, but phytase supplementation resulted in higher feed intake and body weight gain compared to turkeys fed the reduced diet (P < 0.05), and both doses were similar to the basal diet. Increasing the phytase dose had a linear effect (P < 0.05) on ileal digestibility of P and metabolizability of DM, CP, Ca, and Na, and also on AME. P content in the tibia bone increased linearly (P < 0.05) with phytase supplementation, and the same linear increase (P < 0.05) was observed for plasmatic MYO. In conclusion, the supplementation of turkey poult's diets with high levels of phytase up to 4,000 FYT/kg improves diet utilization by increasing P digestibility and dietary metabolizability, leading to higher P content in the bone and enhancing MYO provision and absorption.

Exogenous α-amylase improves the digestibility of corn and corn-soybean meal diets for broilers

Starch is the main energy source in broiler diets. However, endogenous amylase secretion in young broilers is suboptimal to completely digest dietary starch, so exogenous α-amylase supplementation may help increase starch digestibility. The objective of this study was to assess the supplementation of increasing doses of an exogenous α-amylase (0, 40, 80, 120, and 160 kilo-novo α-amylase units (KNU)/kg) on corn and on a complete corn-soybean meal diet for 25-day-old broilers. Jejunal and ileal apparent digestibility coefficients of available starch, resistant starch, total starch, and DM, DM total tract retention, as well as dietary AME levels were evaluated. Interactions (P < 0.05) between diets and α-amylase showed that the enzyme had a more evident effect on increasing DM jejunal digestibility and AME on corn compared with the complete diet. Corn DM digestibility increased to a maximum of 67.84% with up to 47 KNU/kg, whereas 89 KNU/kg led to a maximum of 53.92% in the complete diet A maximum increase of 64 kcal AME/kg was obtained with 80 KNU/kg on the complete diet, whereas 109 KNU/kg generated 327 kcal AME/kg on corn (P < 0.05). Increasing the α-amylase dose linearly increased ileal digestibility of resistant starch (P < 0.05), and the effect on DM total tract retention was quadratic (P < 0.05). Corn showed a higher digestibility for DM, resistant and total starch, as well as DM total tract retention and AME, compared with the complete diet (P < 0.05). Treatments had no influence on available starch. The inclusion of exogenous α-amylase improves starch, DM, and energy utilization of corn-based and corn-soybean meal-based diets for broilers.

Effect of different doses of phytase and protein content of soybean meal on growth performance, nutrient digestibility, and bone characteristics of broilers

This study evaluated the effects of high phytase doses and soybean meal (SBM) with different CP content on growth performance, ileal nutrient digestibility, digestible energy, plasmatic myo-inositol, phosphate release in vitro, and bone composition of broiler chickens. One thousand two hundred 1-day-old broilers were distributed in a 2 × 2 completely randomized factorial arrangement, with 2 phytase doses (1,000 and 2,500 phytase units [FYT]/kg of feed) and 2 SBM with different CP concentrations (45 and 47%), totaling 4 treatments with 12 replicates of 25 birds each. The chickens received feed and water ad libitum. Diets were based on corn and SBM, with different inclusions of soybean hull used to dilute the CP content of SBM according to each treatment. The inclusion of 2,500 FYT increased weight gain from 0 to 21 d (P < 0.05), whereas growth performance from 22 to 42 d was not affected, and SBM had no effect on growth performance. At day 21, ileal digestibility of dry matter, ash, and P, and digestible energy were greater in diets with 2,500 FYT/kg (P < 0.05), as well as phosphate in vitro release (P < 0.01) compared to the lower dose. At day 42, diets with SBM 47% CP and 2,500 FYT/kg promoted greater digestibility of dry matter, ash, CP, Ca, P, and digestible energy (P < 0.001), and greater phosphate release (P < 0.05) in comparison to other treatments. myo-inositol level in the plasma at 21 and 42 d was higher with the use of 2,500 FYT compared to 1,000 FYT (P < 0.05). The higher phytase dose increased tibia ash, toe ash, and Seedor Index (P < 0.05) at day 21, and the Ca content in tibia was higher with 2,500 FYT and SBM 47% CP at day 42. In conclusion, higher phytase doses for broilers improve weight gain, myo-inositol provision, and bone mineral composition. Nutrient ileal digestibility can be enhanced by higher phytase doses when in combination with SBM of greater nutritional quality.

Apparent total tract and ileal amino acids digestibility values of vegetal protein meals with dietary protease to broiler diet

This experiment was carried out to study the effect of dietary exogenous monocomponent protease on the coefficient apparent total tract (ATTD) and apparent ileal (AID) digestibility of amino acids of corn, soybean meal (SBM), and full fat soybean meal (FFSM) in broilers. A total of 400 males Cobb-500 (14 d of age) were equally allocated in 80 metabolic cages (50 cm × 50 cm × 45 cm) in a completely randomized design and a semi-controlled environment. Eight treatments (basal diet with or without a protease and three ingredients replacing the basal diets in 40% to corn and 30% to SBM and FFSM, with and without protease), with 10 replicates each were evaluated. The protease was added at 200 mg/kg resulting in 15,000 unit of PROT/kg. The total collection of excreta was held during 3 d, after 5 d for adaptation of broilers at the diets. The ileal content was collected on d 21, after slaughter of birds. The enzyme increased (P < 0.05) the ATTD and AID of most amino acids contained in SBM and FFSM. The digestibility of cysteine, glycine, proline, and threonine had higher (P < 0.05) ATTD and AID in all tested ingredients with the use of protease. On average, the dietary protease increased in 5.19% and 3.86% the total and ileal digestibility of amino acids, respectively. It was concluded that the dietary protease exerts major effects on toasted full-fat soybean, followed by soybean meal and corn to broilers.

Amino acid digestibility coefficient values of animal protein meals with dietary protease for broiler chickens

A digestibility experiment was conducted to evaluate the effects of dietary exogenous monocomponent protease on the coefficient of apparent total tract digestibility (ATTD) and coefficient apparent ileal digestibility (AID) of amino acids in meat and bones meal (MBM), poultry byproducts meal (PBPM), and feather meal (FM). A total of 512 Cobb-500 male broiler chickens (aged 14 d) were randomly placed into 64 metabolism cages (8 birds per pen) and were allocated to eight treatments with eight replicates in a semi-controlled environmental room. The experimental diets consisted of the basal diet (corn/SBM) and the replacement of 300 g/kg on a weight basis with MBM, PBPM, or FM. The excreta were collected during 3 d (19 to 21 d), and the ileal digesta (using Celite as an indigestible marker) only 1 d (21 d). The protease contained 75,000 PROT units/g. The use of the enzyme increased (P < 0.05) ATTD for alanine, cysteine, glycine, and threonine in the basal diet and AID for the amino acids alanine, cysteine, glycine, lysine, threonine, and valine for the basal diet (vegetable). Regarding meals, there was an increase (P < 0.05) in the amino acid digestibility in large part due to the amino acids of MBM (14) and PBPM (9), with only five amino acids for FM. The amino acids glycine and threonine showed increases (P < 0.05) in both total and ileal digestibility for all animal meals and for the diet based on corn and soybean meal, which indicates a high specificity of the enzyme for these amino acids. The overall results obtained in this study found satisfactory effectiveness of this exogenous protease. The total collection method was lower by 1.83% of amino acids digestibility than the ileal method.

Measurement of ileal endogenous energy losses and true ileal digestible energy of cereal grains for broiler chickens

Two experiments were conducted to determine the ileal endogenous energy losses (IEEL) and nitrogen-corrected apparent metabolizable energy (AMEn) and true ileal digestible energy (TIDE) of 4 cereal grains (corn, sorghum, wheat, and barley) for broilers. In experiment 1, a glucose-based purified diet was used to determine the IEEL for correcting the apparent ileal digestible energy (AIDE) values to TIDE. The diet was randomly allocated to 6 replicates (6 birds per replicate) of male broilers and fed from 18 to 21 d after hatch. The jejunal and ileal digesta were collected on day 21. The results showed that glucose absorption continued beyond the jejunum but was complete in the terminal ileum demonstrating that endogenous energy losses can be quantified in the ileal digesta of birds by feeding a glucose-based diet. The IEEL were determined to be 347 ± 29.4 kcal/kg DM intake. In experiment 2, 4 experimental diets with similar inclusion (957 g/kg) of grains were developed to determine the AMEn, AIDE, and TIDE. Titanium dioxide (5.0 g/kg) was added to all diets as an indigestible marker. Each diet was randomly allocated to 6 replicates (8 birds per replicate) and fed from 14 to 21 d after hatch, and the ileal digesta were collected on day 21. The AIDE was corrected to TIDE using the IEEL value determined in experiment 1. The TIDE of corn, sorghum, wheat, and barley were determined to be 3,920, 3,650, 3,138, and 2,885 kcal/kg DM, respectively, and was higher (P < 0.05) than the corresponding AMEn values of 3,439, 3,284, 2,576, and 2,371 kcal/kg DM, respectively. No differences were observed between the AMEn and AIDE. The AMEn:TIDE ratio tended (P = 0.06) to be lower for viscous cereals (wheat and barley) than that for nonviscous cereals (corn and sorghum). The apparent ileal digestibility of DM, nitrogen, and starch was positively correlated (P < 0.001) with TIDE (r = 0.990, 0.703, and 0.705, respectively) and the AMEn (r = 0.873, 0.483, and 0.656, respectively). Further studies are warranted to determine the TIDE of a range of ingredients and to investigate the application of TIDE as a potential available energy system in poultry feed formulations.

Rate of feed passage in Japanese quail

The rate of passage (ROP) in the gastrointestinal tract (GIT) influences the exposure time of food to the digestion and absorption processes. Consequently, ROP affects the efficiency of nutrient utilization and energy from the diet. This study aimed to determine the physiological parameters that characterize the digestive response, such as first appearance time (FAT), ROP, mean retention time (MRT) and transit time (TT) in adult Japanese quail (Coturnix coturnix japonica), and to evaluate the effects of sex, apparent metabolizable energy corrected for nitrogen balance (AMEn) content in the diet and different types of markers on these parameters. In the first trial, we investigated the effects of sex and AMEn level (high- and low-energy diet) on the FAT parameter. Thirty-two male and 32 female Japanese quail were randomly allocated to 8 battery cages and assigned to 4 treatments in a 2 × 2 factorial design with 4 replicates of 4 birds for each treatment. To determine the FAT, ferric oxide (1%) was added to the diet, and the excreta of the quail was monitored until the first appearance of the marker. The results indicated significant differences (P < 0.05) in the FAT between males (100 min) and females (56 min), regardless of the AMEn content. In the second trial, thirty-two 32-week-old female Japanese quail in the laying phase were assigned to four treatments in a 2 × 2 factorial design, in which the main independent variables were type of marker (Cr or Ti) and AMEn level (high- and low-energy diets). In order to determine ROP (ET1%), MRT and TT (ET100%), the markers (0.5%: Cr2O3 and 0.5%: TiO2) were added to the diets, and the excreta were collected for 750 min. The excretion times for 1% (ET1%), 25% (ET25%), 50% (ET50%), 75% (ET75%) and 100% (ET100%) were estimated using cumulative excretion curves. No effect was detected for the AMEn level (P > 0.05); however, the effect of different marker types was significant (P < 0.05). This difference increased with time and ET100% was estimated to occur at 59 min. The ROP was estimated to be 68 min. The TT was estimated to be 540 min using Cr and 599 min using Ti, with an average MRT value of 0930 h. Taken together, our findings support the hypothesis that Japanese quail digestion through the GIT can be dynamic and differ based on sex or marker type.

Energy partitioning by broiler breeder hens in conventional daily-restricted feeding and precision feeding systems

An empirical linear mixed model was derived to describe metabolizable energy (ME) partitioning in broiler breeder hens. Its coefficients described ME used for total heat production (HP), growth (ADG), and egg mass (EM). A total of 480 Ross 308 hens were randomly and equally assigned to 2 treatments: precision feeding (PF) and conventional daily-restricted feeding (CON) from 23 to 34 wk of age. The PF system allowed birds to enter feeding stations voluntarily at any time, weighed them, and provided access to feed for 60 s if their BW was less than the breeder-recommended target BW. The CON birds were fed daily each morning. Energetic efficiency of hens was evaluated using residual feed intake (RFI), defined as the difference between observed and predicted ME intake (MEI). The energy partitioning model predicted (P < 0.05): MEI = A × BW0.67 + 1.75 × ADG + 0.75 × EM + ϵ. The coefficient A, a vector of age-specific HP, was 142 kcal/kg0.67/d; the energy requirement for growth and EM was 1.75 and 0.75 kcal/g, respectively. For the CON and the PF hens, respectively, MEI was 366 and 354 kcal/d (P = 0.006); RFI was -5.9 and 6.7 kcal/d (P = 0.009); HP% was 85.5 and 87.7 (P < 0.001); hen-day egg production (HDEP) was 65.5 and 55.2% (P < 0.001). Although the CON hens had higher MEI, the model predicted lower HP%; thus, CON hens had more nutrients available for egg production, increased egg production, and were more energetically efficient than the PF hens. The decreased egg production by the PF hens was likely due to these hens receiving production-related feed increases after an egg was laid. However, feed allocation increases for the CON hens resulted in increasing MEI for all CON hens at the same time. Therefore, the PF hens had lower MEI and lower HDEP than the CON hens.

Effects of phytase supplementation on eggshell and bone quality, and phosphorus and calcium digestibility in laying hens from 25 to 37 wk of age

Effects of dietary available phosphorus (aP) and Ca levels and an Escherichia coli 6-phytase supplementation were studied in Lohmann LSL-Lite hens from 25 to 37 wk of age. Eighty-four hens were used in a completely randomized design with 7 treatments. The treatments were a positive control (PC) diet with 0.45% aP, 3.70% Ca, and 0.16% Na from 25 to 28 wk and 0.38% aP, 3.73% Ca, and 0.15% Na from 29 to 37 wk; a negative control (NC) diet, similar to the PC diet, with 0.22% aP, 3.00% Ca, and 0.13% Na from 25 to 28 wk and 0.19% aP, 3.02% Ca, and 0.13% Na from 29 to 37 wk; the NC diets supplemented with phytase at 150 (NC + 150), 300 (NC + 300), 600 (NC + 600), or 1,200 (NC + 1,200) phytase unit (FTU)/kg; and the PC diet supplemented with phytase at 1,200 (PC + 1,200) FTU/kg. Hen performance, eggshell, and bone quality were measured on a 4-wk basis. Bone breaking strength and ash and apparent ileal digestibility (AID) of P and Ca were determined at 37 wk. One- and 2-way ANOVA were conducted, and Tukey's range test was used to compare multiple means where P ≤ 0.05. No differences in hen performance, eggshell quality, bone breaking strength, bone ash, and P digestibility were observed between the PC and the NC treatments. The NC hens had lower cortical (P < 0.001) and trabecular + medullary bone mineral density (P = 0.004) and total bone mineral content (P < 0.001) than the PC hens. The PC + 1,200 increased cortical bone mineral density (P < 0.001). The reductions of aP and Ca in the NC diet were not deficient for performance but had a minor impact on bone mineralization. The NC + 600 and NC + 1,200 increased AID of P (P = 0.024), and all phytase treatments except the NC + 150 increased AID of Ca (P = 0.010) compared with the NC diet.

Comparison of mathematical and comparative slaughter methodologies for determination of heat production and energy retention in broilers

Understanding factors affecting ME availability for productive processes is an important step in optimal feed formulation. This study compared a modelling methodology with the comparative slaughter technique (CST) to estimate energy partitioning to heat production and energy retention (RE) and to investigate differences in heat dissipation. At hatch, 50 broilers were randomly allocated in one of 4 pens equipped with a precision feeding station. From day 14 to day 45, they were either fed with a low-ME (3,111 kcal/kg ME) or a high-ME (3,383 kcal/kg ME) diet. At day 19, birds were assigned to pair-feeding in groups of 6 with lead birds eating ad libitum (100%) and follow birds eating at either 50, 60, 70, 80, or 90% of the paired lead's cumulative feed intake. Heat production and RE were estimated by CST and with a nonlinear mixed model explaining daily ME intake (MEI) as a function of metabolic BW and average daily gain (ADG). The energy partitioning model predicted MEI = (145.10 + u) BW^0.83 + 1.09 × BW^−0.18 × ADG^1.19 + ε. The model underestimated heat production by 13.4% and overestimated RE by 22.8% compared with the CST. The model was not able to distinguish between net energy for gain values of the diets (1,448 ± 18.5 kcal/kg vs. 1,493 ± 18.0 kcal/kg for the low-ME and high-ME diet, respectively), whereas the CST found a 148 kcal/kg difference between the low-ME and high-ME diets (1,101 ± 22.5 kcal/kg vs. 1,249 ± 22.0 kcal/kg, respectively). The estimates of the net energy for gain values of the 2 diets decreased with increasing feed restriction. The heat increment of feeding did not differ between birds fed with the low- or high-ME diet (26% of MEI). Additional measurements on heat dissipation, physical activity, and immune status indicated that the energetic content of the diet and feed restriction affect some parameters (shank temperature, feeding station visits) but not others (leukocyte counts, heterophil to lymphocyte ratio, and immune cell function).

Post-photostimulation energy intake accelerated pubertal development in broiler breeder pullets

The effect of ME intake (MEI) on the reproductive system was evaluated. Ross 308 broiler breeder pullets (n = 140) were assigned to 2 treatments from 22 to 26 wk of age: (1) Low-energy diet fed restricted (2,807 kcal/kg, low MEI) and (2) high-energy diet fed unrestricted (3,109 kcal/kg, high MEI). Daylength was increased from 8 to 14 h at 22 wk of age with a light intensity of 30 lux. Daily palpation was used to detect sexual maturity via the presence of a hard-shelled egg in the shell gland. Expression of gonadotropin releasing hormone-I (GnRH) and gonadotropin inhibitory hormone (GnIH) genes in the hypothalamus and GnRH receptor (GnRH-RI) and GnIH receptor (GnIH-R) genes in the anterior pituitary gland of each pullet was evaluated from 22 to 26 wk of age using quantitative real time-PCR. Blood samples were taken weekly and luteinizing hormone (LH), follicle stimulating-hormone (FSH), and 17-beta-estradiol (E2) determined using commercial ELISA kits. Carcass samples were used for determination of CP and fat content. Data were analyzed using the MIXED procedure in SAS, and differences were reported where P ≤ 0.05. High MEI treatment pullets had 2.3-fold higher GnRH and 1.8-fold higher GnRH-RI mRNA levels than low MEI pullets. MEI affected neither expression of GnIH and GnIH-R nor carcass protein content. For high MEI (489 kcal/D) and low MEI treatments (258 kcal/D), respectively, from 22 to 26 wk of age (P ≤ 0.05), LH concentration was 3.05 and 1.60 ng/mL; FSH concentration was 145 and 89.3 pg/mL; E2 concentration was 429 and 266 pg/mL, and carcass lipid was 13.9 and 10.3%. The onset of lay for pullets in the high MEI treatment advanced such that 100% had laid by 26 wk of age compared with 30% in the low MEI treatment. We concluded that higher MEI advanced the activation of the hypothalamic–pituitary–gonadal axis and also increased body lipid deposition, and moreover, stimulated reproductive hormone levels which overall accelerated puberty in broiler breeder pullets.

Effects of whole plant brown algae (Laminaria japonica) on zootechnical performance, apparent total tract digestibility, faecal characteristics and blood plasma urea in weaned piglets

Two trials were conducted with 48 newly weaned piglets (28 d old) each 8.6 ± 0.05 kg to study how Laminaria japonica plants (LJ) affect zootechnical performance, feed conversion and the apparent total tract digestibility (ATTD) of crude nutrients. All basal diets consisted of cereals, soybean meal, skim milk powder and premixes according to recommendations (no growth promoters or enzymes). For Trial 1, piglets from 16 litters (50% male-castrated, 50% female) were assigned to three treatment groups (n = 16) in a completely randomised block design. Groups received either 2.5% supplementation with sun dried (SD) or drum dried (DD) LJ powder or 2.5% of diatomaceous earth (control). For Trial 2, piglets from 12 litters received either 5% of diatomaceous earth (control) or one of three mixtures of diatomaceous earth + DD LJ powder (3.3%+1.7%, 1.7%+3.3% or 0.0%+5%; n = 12). Data collection included zootechnical performance, faecal consistency, blood plasma urea (Trial 1 and 2) and ATTD (Trial 2). Metabolisable energy (ME) of DD LJ and diets in Trial 2 was estimated using digestible nutrients. Statistical analysis included two-way ANOVA (treatment, block) and mixed linear regression. During both trials, LJ at dosages ≥2.5% significantly reduced feed:gain ratio compared to control (p ≤ 0.0001, = 0.01 for Trial 1, Trial 2) irrespective of the drying method. ATTD from Trial 2 significantly increased digestibilities of dry matter (DM) and crude ash (CA) (p ≤ 0.01) and significantly decreased digestibilities of organic matter and crude fibre in animals fed ≥3.33% DD LJ (p = 0.01). Fractional digestibility of the DD LJ resulted in limited ME of ~9.3 ± 2.5 MJ/kg DM. Dietary conversion ratios of ME and digestible DM of DD LJ diets from Trial 2 decreased linearly with increasing algal supplementation (R2 = 0.93, 0.94 and pslope = 0.002, 0.002 for MCR, DCR). In conclusion, dried LJ powder was included up to 5% into diets without impairing zootechnical performance. The improved feed conversion in the presence of LJ was partly due to slightly higher ME within the algae diets compared to control. However, piglets receiving LJ during Trial 2 needed significantly lower dietary ME and digestible DM to maintain growth performance. Thus, LJ exerted a performance enhancing effect on weaned piglets. The precise mode-of-action is yet unclear.

Effects of feed form and energy levels on growth performance, carcass yield and nutrient digestibility in broilers

Feed form is well recognized to improve broiler performance, specially by increasing feed intake (FI). However, when different diet energy levels are used, the results differ in the literature. Therefore, this experiment was conducted to evaluate the influence of feed form and dietary metabolizable energy (ME) levels on broiler performance, carcass yield and on the digestibility of DM, CP, starch and gross energy. In total, 1152 male Cobb 500 broilers were evaluated between 35 and 47 days. The birds were distributed according to a completely randomized design in a 2 × 4 factorial arrangement, consisting of two feed forms (mash or pellet) and four ME levels (12.73, 13.06, 13.40 or 13.73 MJ/kg), totaling eight treatments with eight replicates of 18 birds. Broilers fed the lowest ME level presented the lowest weight gain (WG) and worst feed per unit gain (P < 0.01). Metabolizable energy intake increased (P < 0.01) with progressive increments of ME, which, however, did not affect caloric conversion (CC, P > 0.05). Pelleted diets promoted higher FI, WG, ME intake (P < 0.01) and better feed per unit gain and CC (P < 0.05) compared with mash. In mash diets, increasing dietary ME levels promoted a linear increase in WG (P < 0.01) and reduced feed per unit gain (P ≤ 0.05), but did not affect FI (P > 0.05). In pelleted diets, on the other hand, increasing ME levels linearly reduced FI (P < 0.05) and feed per unit gain (P < 0.01). Broilers fed pelleted diets presented higher abdominal fat deposition than those fed mash (P < 0.05). Increasing ME levels reduced the coefficients of ileal apparent digestibility of DM (P < 0.01) and total starch (P < 0.05) but did not affect the digestibility of other evaluated nutrients. The digestibility of all nutrients was lower when pelleted diets were fed compared with mash. Increasing inert material inclusion in the diets at the expense of soybean oil to reduce dietary ME levels promoted higher pellet durability index values (P < 0.05) and the percentage of fines (P < 0.01). Overall, the results suggest that pelleted diets promote better broiler performance because they increase FI, since the digestibility of dietary fractions is reduced. Chickens consuming low-energy pelleted diets may increase FI to compensate for energy deficit. In contrast, broilers fed mash diets may have reached their maximum intake capacity and did not regulate FI by changing feed energy density. When feeding pelleted diets, dietary energy reduction should be considered to reduce feed costs and to improve the carcass quality of broilers.

The efficacy of 2 phytases on inositol phosphate degradation in different segments of the gastrointestinal tract, calcium and phosphorus digestibility, and bone quality of broilers

The anti-nutritional effects of dietary inositol phosphates (IP6 through IP3) have been recognized in broiler chickens; however, inositol hexaphosphate (IP6) is more potent than the lower IP esters. The efficacies of 2 commercial phytases, a Buttiauxella sp. phytase (BSP) and a Citrobacter braakii phytase (CBP) at 500 and 1,000 FTU/kg, were studied on IP6-3 concentrations in the crop, proventriculus + gizzard, and distal ileum digesta, and ileal IP6 disappearance in broilers at day 22. Apparent ileal P and Ca digestibility, and bone quality at days 22 and 33 were also measured. Female Ross 308 broilers (n = 1,890; 30 birds × 7 diets × 9 replicates) were fed corn-soy-based crumbled diets. The 7 diets included a primary breeder recommendation-based positive control diet (PC); the PC marginally reduced in available P by 0.146% and Ca by 0.134% of the diet, (NC1) or moderately reduced by 0.174 and 0.159% of the diet, respectively (NC2). Other diets were the NC1 + BSP or CBP at 500 FTU/kg (NC1+500BSP and NC1+500CBP) and the NC2 + BSP or CBP at 1,000 FTU/kg (NC2+1,000BSP and NC2+1,000CBP). Each of the NC1 and NC2 had distal ileum IP6 disappearance similar to that of PC, but each had lower P digestibility and the majority of measured bone quality parameters than the PC. The ileal IP6 levels were decreased by 52.0 and 32.7% for NC1+500BSP and NC1+500CBP, respectively, relative to NC1 and by 73.6 and 50.9% for NC2+1,000BSP and NC2+1,000CBP, respectively, relative to NC2 (P < 0.001), with a similar effect for distal ileum IP6 disappearance. Overall, phytase in the NC diets increased P digestibility, and femur breaking strength and cortical bone mineral density at days 22 and 33. Overall, each of the phytases at each dose degraded IP6-3 across the gastrointestinal tract segments to increase P digestibility and the P and Ca utilization in bone. However, dietary BSP at 1,000 FTU/kg was most effective. Supplemental phytase degrades phytate to decrease the anti-nutritional effects in a dose- and phytase-dependent manner.

Effect of age on the relationship between metabolizable energy and digestible energy for broiler chickens

A total of 960 male Ross 308 chicks (day-old) were used to investigate the effect of age on the relationship between metabolizable energy (ME) and digestible energy (DE) for broiler chickens. Bird growth variables, nitrogen retention (NR), nitrogen digestibility (ND), as well as the relative weight of liver, pancreas, and the gastrointestinal tract were determined. Practical diets that compared 2 cereals (corn and wheat) and exogenous xylanase (0 or 16,000 BXU/kg) were evaluated at 5 ages (7, 14, 21, 28, and 35 D) in a 2 × 2 × 5 factorial arrangement of treatments with 8 replicates per treatment and started with 30 birds per replicate. A randomized block ANOVA analysis of repeated measures was performed, and a 2 × 2 × 5 factorial structure was used to investigate the 2 dietary treatment factors (cereal type and the presence of xylanase) within the 5 bird ages (7, 14, 21, 28, and 35 D), and their interactions. Apparent metabolizable energy (AME) increased linearly from 7 until 28 D of age, but (P < 0.05) decreased at 35 D of age. Digestible energy was high at 7 D of age, then dropped and remained similar (P > 0.05) from 14 to 35 D of age. The AME: DE ratio was lowest (P < 0.05) at 7 D of age but there were no (P > 0.05) differences thereafter. Cereal type and xylanase supplementation did not (P > 0.05) change the ME: DE ratio. The results indicate that determining ME before 14 D of age may give absolute values that are lower than would be obtained with older birds. ME values that are determined on older broiler chickens may overestimate the energy availability of practical feeds used in broiler starter feeds.

Long-term effects of Buttiauxella sp. phytase on performance, eggshell quality, apparent ileal Ca and P digestibility, and bone properties of white egg layers

Adequate dietary Ca and available phosphorus (avP) are essential to long-term egg production and bone health in laying hens. The effects of dietary Ca and avP levels and Buttiauxella sp. phytase (BSP) were studied in Lohmann LSL Lite hens from 30 to 70 wk of age (woa). Hens (n = 456; 4 per cage) were fed either a primary breeder recommendation-based diet (positive control; PC); the PC with avP and Ca levels reduced by 0.146 and 0.134% of the diet, respectively, without (NC) or with 300 FTU/kg BSP (NC+BSP). Egg production, BW, feed intake, FCR, and eggshell quality from 30 to 70 woa, and apparent ileal digestibility of P (AIDP) and Ca (AIDCa), and bone quality at 32, 48, and 70 woa were measured. The avP and Ca levels in the NC diet were not clinically deficient, as most parameters were unaffected by diet. Hen BW from 34 to 70 woa tended to be 2.9% greater (P = 0.076) for PC and NC+BSP compared to NC. Mid-diaphysis cortical bone mineral content (CBMC) tended to be 10% and 9% higher (P = 0.065) in the NC+BSP hens than in NC hens at 48 and 70 woa, respectively. AIDP of NC+BSP was 24% greater (P = 0.034) than of NC at 32 woa and tended to be 18% greater (P = 0.082) than AIDP of PC at 48 woa, and 25% lower than of NC and PC at 70 woa (P = 0.028). AIDCa was 25% lower for NC+BSP than PC at 48 woa only (P = 0.037). The avP and Ca sufficiency in the NC diet limited the opportunity to determine a phytase effect. Although the supplemental BSP tended to increase BW and 48 and 70 woa CBMC, and increased 32 woa AIDP, the efficacy of BSP could not be determined due to the lack of an NC effect on most parameters. Commercial laying hens can maintain health and productivity at lower than recommended levels of dietary Ca and avP; phytase supplementation may allow for even further reductions.

Energy partitioning by broiler breeder pullets in skip-a-day and precision feeding systems

An empirical nonlinear mixed model was derived to describe metabolizable energy (ME) partitioning in Ross 308 broiler breeder pullets. Its coefficients described ME used for total heat production (HP) and growth. A total of 630 pullets were randomly and equally assigned to 2 treatments: precision feeding (PF) and conventional skip-a-day feeding (CON) from 10 to 23 wk of age. The PF system allowed birds to enter voluntarily at any time, weighed them, and provided access to feed for 60 s if their BW was less than the target BW. Birds in the CON treatment were fed as a group on alternate days. Energetic efficiency of pullets was evaluated using residual total heat production (RHP), defined as the difference between observed and predicted total HP. Additionally, ME intake (MEI), ADG, HP, and cumulative feed conversion ratio (FCR) were calculated for the entire experimental period. The energy partitioning model (P < 0.05) predicted MEI = (120+u)BW0.68 + 1.52(ADG) + ε. Total HP was (120 kcal/kg0.68 + u); the energy requirement for each g of BW gain was 1.52 kcal/d. The random variable u ∼ N (0, σu2) indicated a pen level HP standard deviation σu = 12.1 kcal/kg0.68. Over the experimental period, for CON and PF treatments, respectively, MEI was 194 and 174 kcal/d (P < 0.001); ADG was 15.3 and 15.4 g/d (P = 0.94); HP was 129 and 111 kcal/kg0.68 (P < 0.001); FCR was 4.888 and 4.057 (P < 0.001); and RHP was 0.12 and -0.12 kcal/kg0.68 (P = 0.73). The CON pullets had similar ADG, but higher MEI relative to PF, consistent with levels of heat production predicted by RHP. The PF pullets had lower cumulative FCR compared to CON pullets. The PF pullets lost less energy as heat, likely because they were fed continuously, reducing the need to store and mobilize nutrients compared to CON pullets. Thus, increased feeding frequency likely increased PF pullet efficiency.

Castor bean cake detoxified with calcium hydroxide in diets for pigs at growing and finishing phases

The present study was aimed to evaluate the use of increasing levels of castor bean cake detoxified with calcium hydroxide in diets for pigs at growing and finishing phases on performance, diet digestibility, weight of digestive organs, carcass traits, and economic evaluation. A total of 40 barrows with 44.59 ± 5.16 kg initial weight were fed diets with 0%, 7%, 14%, and 21% detoxified castor bean cake. Increasing levels of detoxified castor bean cake in diets resulted in linear worsening in the average daily gain of the pigs. Dry matter, crude protein, and gross energy digestibilities were adversely affected by the levels of detoxified castor bean cake. A linear decrease in loin eye area and ham yield was detected depending on detoxified castor bean cake inclusion levels. Although the detoxified castor bean cake had no effect on the assessed economic variables, its use in diets for growing and finishing pigs is not recommended.

Effects of processing, particle size and moisturizing of sorghum-based feeds on pellet quality and broiler production

Objective

This study aimed to assess the effect of pelleted and expanded sorghum-based feeds prepared with different moisture levels and particle size of ingredients on metabolizable energy, ileal digestibility of amino acids and broiler performance.

Methods

The experiment was performed with 720 male broiler chicks of the Cobb strain, with treatments of six replications, with 15 birds each; they were arranged in a completely randomized design and 2×2×2 factorial scheme (pelleted or expanded feed processing, 0.8% or 1.6% moisture addition in the mixer, and particle size of 650 or 850 microns).

Results

Higher pellet quality (pellets, % and pellet durability index [PDI]) was obtained in expanded diets and inclusion of 1.6% moisture. The particle size of 850 microns increased the PDI of final diet. All studied treatments had no significant effect on weight gain and broiler carcass and cut yields. Lower feed conversion occurred for birds fed pelleted feed at 42 d. The highest apparent metabolizable energy (AME) and apparent metabolizable energy corrected to zero nitrogen balance (AMEn) values of feed in the initial rearing phase (10 to 13 days) were observed in birds fed pelleted feed or for feed prepared with 1.6% moisture. The highest ileal digestibility coefficients of amino acids were obtained with the consumption of pelleted feed prepared with a particle size of 650 microns and 1.6% moisture.

Conclusion

Pelleted feed prepared with a milling particle size of 650 microns and 1.6% moisture provided increased ileal digestibility of amino acids and AMEn in the starter period. However, the expanded feed improved pellet quality and feed conversion of broilers at 42 days of age. We conclude that factors such as moisture, particle size and processing affect the pellet quality, and therefore should be considered when attempting to optimize broiler performance.

Interaction between xylanase and phytase on the digestibility of corn and a corn/soy diet for broiler chickens

An experiment was carried out to evaluate the digestibility and metabolizability of corn and a corn/soy-based diet with the inclusion or not of xylanase and/or phytase in broilers. In the trial, 1,120 broiler chicks were distributed according to a completely randomized experimental design, consisting of 16 treatments, with 10 replicates of 7 birds each. Treatments were evaluated following a factorial arrangement (4 × 2 × 2), with 4 xylanase levels (zero, 50, 100, or 150 fungal β-xylanase units/kg; FXU), 2 phytase levels (zero or 1,000 phytase units/kg; FTU), and 2 diets (corn/soy or pure corn). The same basal diets were fed from one to 14 d post hatch for all birds, after which the experimental diets were provided until d 25. All birds were euthanized on d 25 for collection of ileal contents. Samples of feed, excreta, and ileal digesta were analyzed for determination of apparent ileal digestibility. The effect of xylanase on the coefficient of apparent dry matter metabolizability and apparent metabolizable energy was increased by the presence of phytase in the complete diet but not in the diet based on pure corn resulting in a diet*phytase*xylanase interaction (P < 0.01; P < 0.001, respectivaly). Equivalent effects were observed for the apparent coefficient of ileal protein digestibility in which xylanase effects were potentiated by the presence of phytase only in the complete diet, resulting in a significant 3-way interaction. In corn there was a limitation in improving digestibility when we added increasing levels of xylanase with phytase. Otherwise in the corn/soy-based diets, the enzymes were potencialized when they were added together. The fact that the effect of xylanase was enhanced by the presence of phytase in complete diets but not in pure corn may be associated with differences in substrate (arabinoxylan and/or phytate) concentration and presentation, diet nutrient balance, or other factors. It can be concluded that the interactive effects of xylanase and phytase can be substantial but may depend on the characteristics of the diet fed.

Exogenous protease supplementation of poultry by-product meal-based diets for broilers: Effects on growth, carcass characteristics and nutrient digestibility

An experiment was conducted to investigate the effects of three levels (0%, 3% and 6%) of poultry by-product meal (PBM) with or without protease on broiler growth, carcass characteristics and nutrient digestibility from 1 to 35 days. Two hundred and forty birds (n = 240) were fed equi-caloric and equi-nitrogenous (ME 2850 kcal/kg; CP 20%) diets throughout the experiment. The enzyme supplementation increased feed intake (p < .01) and body weight gain (p < .01), but feed:gain remained unaffected (p > .05) from 1 to 21 days. Increasing level of PBM decreased feed intake (p < .05), but body weight gain was improved (p < .05) at 3% PBM level during 1 to 21 days. The feed:gain was improved (p < .05) in birds fed diets containing 3% PBM. The feed:gain was also improved in birds fed diets containing 3% PBM from 1 to 35 days. However, feed intake and body weight gain in birds fed diets containing PBM remained unaffected. An interaction (p < .01) on feed intake between enzyme and PBM was noticed during 1 to 21 days. However, no interaction was recorded for body weight gain and feed:gain. The per cent carcass yield improved (p < .01) in birds fed diets supplemented with enzyme. The per cent breast meat yield was depressed (p < .005) in birds fed diets containing PBM. Apparent metabolizable energy (p < .001), nitrogen retention (p < .01), apparent metabolizable energy corrected for nitrogen (p < .001), and apparent digestibility coefficient for nitrogen (p < .01) improved in birds fed diets containing enzyme; however, a reverse was noticed in those fed diets containing only PBM. In conclusion, inclusion of 3% PBM along with supplementation of exogenous protease improved performance and nutrient digestibility in broilers.

Effect of protein source and protease addition on performance, blood metabolites and nutrient digestibility of turkeys fed on low-protein diets from 28 to 55 d post hatch

The objective of this study was to investigate the effect of a monocomponent protease and dietary inclusion of canola meal (CM) and poultry by-product meal (PBM) on growth performance, carcass characteristics and blood metabolites of turkeys fed on low crude protein (CP) diets from 28 to 55 d post hatch. Experimental treatments included control, maize-soybean meal diet including 258.3 g/kg CP; negative control 1 (NC1), maize-soybean meal diet with reduced CP (232.4 g/kg); NC2, control diet (CP, 258.3 g/kg) including CM (80 g/kg) and PBM (80 g/kg); NC3, maize-soybean meal diet with reduced CP (232.4 g/kg) including CM (80 g/kg) and PBM (80 g/kg). Also, the NC1 + P and NC3 + P diets were created by addition of protease enzyme (30 000 units/kg of diet) to the NC1 and NC3 diets, respectively. The NC3 group had lower body weight gain (BWG) compared to those fed on the control diet, and no improvement with enzyme addition (NC3 + P) was achieved. The protease addition to the NC1 diet (NC1 + P) improved BWG to the level of the control diet. The NC1 group had higher feed conversion ratio (FCR) compared to the control and NC3 + P, but protease addition to the NC1 diet improved FCR. Protease addition to the low CP diets resulted in higher nitrogen (N) retention than in the control and NC2 groups. Also, the NC1 + P and NC3 + P diets increased apparent ileal digestibility (AID) of CP compared to the control group. It was concluded that addition of CM (up to 80 g/kg) and PBM (up to 80 g/kg) to turkey diets had no negative effect on growth performance from 28 to 55 d of age. The NC1 + P group achieved the BWG of the control group which was partially due to increases in N retention and AID of CP, but the NC3 + P group failed to recover the growth losses. This difference implies that the efficacy of the protease may depend upon the protein source in the ration.

Chromic oxide and acid-insoluble ash as markers in digestibility studies with growing pigs and sows

The results of three experiments, focused on the determination of endogenous ileal flow (EIF) of amino acids (AA) and nitrogen (N) (Exp. 1), apparent ileal digestibility (AID) of AA and N (Exp. 2), and apparent total tract digestibility (ATTD) of dry matter (DM), organic matter (OM), N, calcium (Ca) and phosphorus (P) (Exps. 2 and 3), were used to compare chromic oxide (Cr₂ O₃ ) and acid-insoluble ash (AIA) as digestibility markers. In Exps. 1 and 2, a total of six gilts fitted with T-cannula in terminal ileum, and in Exp. 3, a total of 24 pregnant sows were used. In Exps. 1 and 2, the pigs were assigned into four dietary treatments according to 4 × 6 crossover design (Exp. 1; diets with 0%, 4%, 8% and 12% of casein; Exp. 2 basal diet with different levels of phytase). In Exp. 3, the sows were assigned to four dietary treatments (basal diet with different levels of phytase) of six sows. In Exps. 1 and 2 ileal digesta and in Exps. 2 and 3 faeces were collected for the determination of EIF, AID and ATTD. Differences in EIF of AA determined by Cr₂ O₃ and AIA ranged (p ˃ 0.05) from -4.62 to 4.54%. The lowest EIF was for methionine and the greatest one for proline, determined by both markers. Apparent ileal digestibility determined by Cr₂ O₃ was slightly greater (p ˃ 0.05) in comparison with AIA. Differences ranged from 1.88% (Arg) to 7.08% (Gly). The greatest AID was for arginine and the lowest one for glycine, determined by both Cr₂ O₃ and AIA. Similarly for ATTD of DM, OM, N, Ca and P, there were no differences in digestibility determined by Cr₂ O₃ and AIA. Both, Cr₂ O₃ and AIA, are suitable and comparable markers for digestibility studies in pigs.

Digestibility marker and ileal amino acid digestibility in phytase-supplemented soybean or canola meals for growing pigs

Two experiments using soybean meal (SBM) or canola meal (CM) were conducted to investigate whether the choice of digestibility marker influenced the apparent ileal digestibility (AID) or standardized ileal digestibility (SID) of N and AA in diets supplemented with phytase. In each experiment, 18 barrows fitted with T-cannulas at the ileocecal junction were assigned to 3 diets consisting of a N-free diet to determine endogenous losses of N and AA, a semipurified diet (SBM in Exp. 1 or CM in Exp. 2), and the semipurified diet supplemented with phytase at 1,000 phytase units/kg. Three digestibility markers including acid-insoluble ash (AIA), chromic oxide (Cr2O3), and titanium dioxide (TiO2) were added to each diet at 3 g/kg. Each diet was fed for 7 d, consisting of a 5-d adjustment and a 2-d collection of ileal digesta. In both studies, basal ileal endogenous losses determined with Cr2O3 as a digestibility marker were lower (P<0.01) than with those determined with AIA or TiO2 digestibility markers. Using SBM as the protein source in Exp. 1, there was no interaction between phytase and digestibility marker on AID or SID of AA. The AID of N and AA in SBM using AIA as a digestibility marker tended to be lower (P<0.1) compared with Cr2O3 or TiO2 digestibility markers. Phytase supplementation increased (P<0.001) the AID of Ca and P. The use of AIA or Cr2O3 digestibility marker tended to be associated with lower (P<0.1) SID values compared with TiO2. Phytase did not affect the SID of N or any AA in SBM except for Met, for which there was an increase (P<0.05) with phytase supplementation. Using CM as the protein source in Exp. 2, there were significant interactions between digestibility marker and phytase. Phytase supplementation had effects (P<0.01) on AID or SID when Cr2O3 or TiO2 was used as the digestibility marker. With Cr2O3 or TiO2 as the digestibility marker in the CM diets, phytase supplementation increased (P<0.05) the SID of N and all AA (except Trp). There was no SID of N or AA response to phytase supplementation of CM when AIA was used as a digestibility marker. In contrast, there were no clear improvements in AA digestibility from phytase supplementation for SBM. Phytase effects on AID or SID of AA were dependent on the digestibility marker used in diets when CM was used as the protein source but not when SBM was used as the protein source. Therefore, AA digestibility response to phytase supplementation may depend on the protein being evaluated as well as the choice of digestibility marker.

Short-term effects of lower oil dried distillers grains with solubles in laying hen rations

Extraction of oil from dried distillers grains has become a common practice among US ethanol producers. The valuable oil has been diverted to markets other than poultry feed, leaving new dried distillers grains with solubles (DDGS) products higher in fiber and purportedly lower in ME. This study compared 3 DDGS products with 10.3, 7.3, or 5.2% ether extract, respectively, with a corn-soy control ration in young Bovan laying hens for a feeding period from 20 to 33 wk of age. The DDGS was fed at the rate of 20% of the ration. Lower oil content of DDGS had no effect on short-term egg production parameters: feed intake, egg production, egg weight or mass, and hen weight gain. The diets containing lower fat DDGS (5.2%) did have reduced AME and kilocalories per day intake for laying hens. For each percent reduction in oil from a normal DDGS sample (10.3%) to medium oil (7.3%) DDGS, AME decreased 42.3 kcal/kg of diet. However, total kilocalories per day intake did sustain good egg production during this short trial.