Comparison of the efficacies of a novel aspergillus niger mycelium with separate and combined effectiveness of phytase, acid phosphatase, and pectinase in dephosphorylation of wheat-based feeds fed to growing broilers

Effects of Adding Phytase from Aspergillus niger to a Low Phosphorus Diet on Growth Performance, Tibia Characteristics, Phosphorus Excretion, and Meat Quality of Broilers 35 days after hatching

This study was designed to determine the effect of phytase extracted from Aspergillus niger (Natuphos^® E) on growth performance, bone mineralization, phosphorous excretion, and meat quality parameters in broilers fed available phosphorous (aP)-deficient diet. In total, 810 one-day-old Indian River broilers were randomly allotted into one of three dietary treatments, with six replicates per treatment. The three dietary treatments were 1) control group (CON: basal diet with sufficient aP), 2) low phytase (LPY: available phosphorus-deficient diet supplemented with 0.01% phytase), and 3) high phytase (HPY: available phosphorus-deficient diet supplemented with 0.02% phytase). Average daily gain and, feed intake, and feed conversion ratio were measured for 35 days. Excreta were collected from each pen on day 35. One broiler from each cage was euthanized to collect visceral organs and tibia samples. Broiler chickens fed LPY and HPY showed improved (P<0.05) growth performance compared to broilers fed CON on day 35. The tibia length of HPY-fed broilers was more than those of broilers fed other diets on day 35 (P<0.05). However, tibia calcium and phosphorous contents in LPY-fed broilers was higher (P<0.05) than in CON and HPY-fed broilers. Tibia length and calcium and phosphorous content showed a positive correlation (P<0.05) with the weight gain of broilers on day 35. Phosphorous level in the excreta of LPY- and HPY-fed broilers was lesser than those of CON broilers on day 35 (P<0.05). Furthermore, HPY-fed broilers showed lower (P<0.05) phosphorous content in the excreta than LPY-fed broilers. LPY- and HPY-fed broilers showed higher (P<0.05) liver weight than the CON broilers. In conclusion, broilers fed aP-deficient diet supplemented with phytase from Aspergillus excreted less phosphorus, which enhanced growth performance and tibia development from time of hatching to day 35 post-hatching.

Effect of supplemental phytase and xylanase in wheat-based diets on prececal phosphorus digestibility and phytate degradation in young turkeys

This study aimed to investigate the effect of phytase and a combination of phytase and xylanase on the prececal phosphorus digestibility (pcdP) of wheat-based diets in turkeys. A low-P basal diet (BD) based on cornstarch and soybean meal, and 2 diets containing 43% of different wheat genotypes (genotype diets GD₆ or GD₇) were fed to turkeys from 20 to 27 d of age. Diets were fed either without enzyme supplementation or supplemented with phytase (500 FTU/kg) or a combination of phytase and xylanase (16,000 BXU/kg). At 27 d of age, digesta were sampled from the lower ileum of animals to determine pcdP and pc myo-inositol 1,2,3,4,5,6-hexakis (dihydrogen phosphate) (InsP₆) disappearance, and to analyze the concentrations of lower inositol phosphate isomers. Similar pcdP was observed in non-supplemented BD and GD (∼36%). Phytase alone increased the pcdP in all diets by 8 to 12%, but a beneficial effect of xylanase was found only for BD. Similar results were found for pc InsP₆ disappearance, although xylanase addition compared to phytase alone decreased pc InsP₆ disappearance in GD₇ compared to phytase alone. Animals fed GD₇ performed better than those fed GD₆; however, these differences could not be linked to the pcdP. The pattern of lower inositol phosphates in digesta also changed with enzyme supplementation, resulting in lower proportions of InsP₅ and higher proportions of InsP₄. Phytase alone decreased Ins(1,2,3,4,6)P₅ but increased D-Ins(1,2,3,4,5)P₅ and D-Ins(1,2,5,6)P₄ concentrations. An additional increase in D-Ins(1,2,3,4,5)P₅ and D-Ins(1,2,5,6)P₄ concentrations was achieved with xylanase, although for the former isomer, this was observed only with GD. These results indicate that enzyme supplementation alters the pc degradation of InsP₆, and that combining both enzymes had a minor additional effect on the pcdP from wheat-based diets when compared to phytase alone.

Effects of dietary phosphorous supplementation on laying performance, egg quality, bone health and immune responses of laying hens challenged with Escherichia coli lipopolysaccharide

Background

Phosphorus is an essential nutrient to maintain poultry health and performance. The objective of this study was to evaluate the effect of dietary phosphorus levels on egg production, egg quality, bone health, immune responses of laying hens challenged with Escherichia coli lipopolysaccharide.

Methods

Three hundred laying hens at 28 wk were randomly divided into 2 dietary treatments with 10 replicates of 15 birds. The wheat-soybean based diets contained either 0.12% or 0.4% non-phytate phosphorus (NPP). At 32 wk of age, all the birds of each dietary treatment were injected into the abdomen with 1.5 mg/kg body weight (BW) of either LPS or saline once a day at 24-h intervals for continuous 9 d. The performance of laying hens was evaluated for 9 d. The eggs after the fifth injection were collected to value the egg quality. Three hours after the first injection, blood was collected to measure serum metabolite and immune response associated parameters. Three hours after the fifth injection, the hens were euthanized to obtain tibia, cecal tonsils and jejunum.

Results

Compared with saline-injected hens, LPS-injected hens had lower feed intake and egg production (P < 0.05). Eggshell thickness, strength, albumin height and Haugh unit were significantly increased in LPS-injected hens compared with saline-injected hens (P < 0.05). Furthermore, laying hens challenged with LPS had lower villious height/ crypt depth ration than those received saline. Serum calcium, phosphorus and SOD activities significantly decreased in the LPS-injected hens compared with the control (P < 0.05). LPS up-regulated expression of IL-1β, IL-6 and IL-10 in cecum, and serum concentration of MDA, IL-1β and IL-6 (P < 0.05), whereas 0.40% dietary non-phytate phosphorus supplementation significantly increased (P < 0.05) villi height/crypt depth ratio, decreased (P < 0.05) serum MDA and IFN-γ concentration compared with the 0.12% non-phytate phosphorus group.

Conclusion

In summary, this study demonstrates that 0.40% dietary non-phytate phosphorus supplementation significantly increased calcium and phosphorus levels of eggshell, increased villi height/crypt depth ratio, decreased serum MDA and IFN-γ concentration compared with the 0.12% non-phytate phosphorus groups. The results indicate that high level of dietary non-phytate phosphorus exerts a potential effect in alleviating systemic inflammation of LPS-challenged laying hens.

Feeding value of field beans (Vicia faba L. var. minor) with and without enzyme containing tannase, pectinase and xylanase activities for broilers

Effects of field beans with various tannin content and exogenous enzyme mixture containing tannase, pectinase and xylanase activities on N-corrected dietary apparent metabolisable energy (AMEn), coefficients of dry matter (DMR) and nitrogen retention (NR), fat digestibility, gastrointestinal tract (GIT) development, jejunal villus morphometry, ileal digesta viscosity and sialic acid were examined. Birds' growth performance and energy conversion ratio (ECR) were also measured. Birds were fed one of eight mash diets. The Control diet contained as major ingredients wheat (400 g/kg) and soybean meal (SBM) (127 g/kg and 221 g crude protein/kg and 12.83 MJ AMEn/kg. To reduce nutrient density, the Control diet also contained washed sand at 119 g/kg. Another three diets containing 300 g/kg of each of three experimental field bean cultivar samples in replacement for SBM and sand were also mixed. Each diet was fed to nine pens with two male Ross 308 broilers. Diets high in tannin had low AMEn, ECR, DMR and NR (p < 0.001). Feeding field beans increased (p < 0.001) the weights of the pancreas and the proventriculus and gizzard (PG) of the birds. Supplementing diets with the enzyme mixture improved (p < 0.001) feed conversion efficiency, AMEn and all nutrient utilisation coefficients despite the tannins in diets. The enzyme mixture reduced ileal digesta viscosity (p < 0.001) and the weight of pancreas, total GIT and PG (p < 0.05) of the birds. It can be concluded that the feeding value of field beans with different tannin contents may vary when fed to broilers. The supplementation of the enzyme mixture improved the feeding value of diets for broilers. The beneficial effect of the addition of the enzyme mixture seems to be mediated through reduced ileal digesta viscosity and improved nutrient availability.

High dose of phytase on apparent and standardized total tract digestibility of phosphorus and apparent total tract digestibility of calcium in canola meals from Brassica napus black and Brassica juncea yellow fed to growing pigs

A total of 42 barrows weighing 19.8 ± 1.22 kg were fed seven diets to give six replicates per treatment. The experiment was conducted in a factorial arrangement with factors being (1) two canola meals (CM) types and (2) three phytase levels (0, 500, and 2500 FTU kg−1). The basal endogenous phosphorus (P) losses and standardized total tract digestibility (STTD) was calculated using the P-free method. There was no effect of CM types on feed intake and fecal P output, but an interaction effect was observed for P intake (CM × phytase; P < 0.05). Supplementation of phytase (2500 FTU kg−1) reduced (P < 0.001) fecal P output (g d−1), and the output was reduced by 58% in Brassica napus black (BNB) and 64% in Brassica juncea yellow (BJY) diets. Supplementation of phytase improved (P < 0.001) both apparent total tract digestibility (ATTD) and STTD of P in both BNB and BJY, regardless of dose. The basal endogenous P loss (EPL) was determined to be 111.28 ± 35.09 mg kg−1 of dry matter intake (DMI). There was no further improvement in STTD of P when phytase was increased from 500 to 2500 FTU kg−1 in both CM types. The ATTD of calcium (Ca) was increased (P < 0.001) in BNB and BJY when phytase was supplemented at 500 and 2500 FTU kg−1. The results, therefore, indicate that supplementation of phytase at 500 FTU kg−1 improved both ATTD and STTD of P in two CM types, but a super dose of 2500 FTU kg−1 had no additional benefit. Similarly, ATTD of Ca was increased when phytase was supplemented at 500 FTU kg−1 without further improvement at 2500 FTU kg−1.

Starch digestibility, energy utilization, and growth performance of broilers fed corn-soybean basal diets supplemented with enzymes

A study was conducted to evaluate the effects of dietary α-amylase and β-xylanase supplementation of corn-soy diets, formulated with or without supplemental phytase, on growth performance, energy utilization, and starch digestibility in broiler chickens. A total of 336 slow-feathering, Cobb × Cobb 500 male broilers were randomly distributed to 6 treatments having 8 replicates of 7 birds each. Birds were fed a common starter diet to d 14 post-hatch (3,050 kcal/kg AMEn, 21.7% CP, 1.05% Ca, and 0.53% nPP). The experimental diets were provided afterwards until d 25. A 2 × 3 factorial arrangement of 2 control diets (basal = corn-soy diet without added phytase or PHY = corn-soy diet formulated with 1,000 phytase units/kg) and 3 carbohydrase supplementations (0, 80 kilo-Novo α-amylase units/kg, or 80 kilo-Novo α-amylase units/kg + 100 fungal β-xylanase units/kg) was used from d 14 to 25. Excreta were collected from 21 to 24 d and all birds were euthanized at 25 d for jejunum and ileum content collection. Samples of feed, excreta, and jejunal and ileal digesta were analyzed for determination of total tract retention and ileal apparent digestibility. No interactions between diet and carbohydrase were observed. Broilers fed diets formulated with phytase or supplemented with amylase + xylanase had higher BW gain (BWG) and lower FCR (P < 0.05) when compared with birds fed diets without carbohydrases. Relative to the basal diet, AMEn was increased (P < 0.01) by 70 kcal/kg and 99 kcal/kg when birds were fed the diet supplemented with amylase and amylase + xylanase, respectively. Starch digestibility in the jejunum and ileum was increased (P < 0.05) by 3.5% and 2.4%, respectively, when birds were fed the diet supplemented with amylase + xylanase. Results from this experiment show that corn-soy diets having phytase and supplemented with amylase and xylanase led to increased growth performance, AMEn, and starch digestibility in broilers. Furthermore, the efficacy of exogenous amylase and xylanase was independent of the presence of microbial phytase.

The impact of phosphorus on the immune system and the intestinal microbiota with special focus on the pig

There is increasing interest in dietary ingredients that are appropriate to support digestive and immune functions, but also maintain a stable microbial ecosystem in the gastrointestinal tract (GIT), particularly in weaned pigs. P is an essential nutrient for both microbes and their host, as it is involved, for example, in bone formation, energy metabolism, cellular signalling and stabilisation of cell membranes. Non-ruminant animals have limited access to phytate, the main storage form of P in plant seeds. The release of P bound to phytate requires phytase activity of plant or microbial origin, resulting in the formation of variable phosphorylated inositol phosphates (InsPs). The present review focuses on interactions between variations in dietary P supply, the immune system of the host, and the intestinal microbial ecosystem. Although results on the interaction between P and the immune system are inconsistent, several studies in different species have shown a positive impact of dietary P and phytase addition on the adaptive immune response. Recent studies with pigs suggest that P supply may influence intestinal microbial composition and activity. Individual InsPs or phosphate may also affect properties of pathogenic micro-organisms, such as metabolism or virulence. In conclusion, P may be considered as part of an integrated approach to support immune functions and maintain a stable microbial ecosystem in the GIT, thereby providing a barrier against potential pathogens. Within this regard, differences in phytate-P content and intrinsic phytase activity of plant feedstuffs, as well as the formation of individual InsPs, have to be taken into account.

Effect of controlled lactic acid fermentation on selected bioactive and nutritional parameters of tempeh obtained from unhulled common bean (Phaseolus vulgaris) seeds

BACKGROUND

Tempeh is a traditional Indonesian food of high nutritional quality obtained by fungal fermentation of dehulled, soaked and cooked legumes. The aim of this research was to study the effect of Lactobacillus plantarum DSM 20174 activity on selected parameters of tempeh made from unhulled seeds of common bean (Phaseolus vulgaris). Lactobacillus plantarum cells were applied during soaking of seeds (submerged fermentation) or during solid state fermentation with Rhizopus microsporus var. chinensis (co-cultivation).

RESULTS

Tempeh obtained from common beans contained 200 g kg⁻¹ protein of 34% in vitro bioavailability. Fungal fermentation caused decomposition of raffinose, stachyose and verbascose levels in seeds, on average by 93, 84 and 73% respectively. Enhanced antiradical (DPPH•, ABTS•+) capacity was accompanied by increased soluble phenol content. Application of Lactobacillus in the fermentation procedure increased tempeh protein and in vitro protein bioavailability by 18 and 17% respectively. Mixed culture tempeh contained lower levels of stachyose (25%), verbascose (64%) and condensed tannins (20%). Co-cultivation enhanced both DPPH•-scavenging activity and antioxidant capacity.

CONCLUSION

The application of Lactobacillus in most cases improved the nutritional parameters of tempeh from unhulled common beans. It may also be recommended to obtain products with diverse antioxidant properties as compared with fungal fermentation alone.

The influence of inoculum composition on selected bioactive and nutritional parameters of grass pea tempeh obtained by mixed-culture fermentation with Rhizopus oligosporus and Aspergillus oryzae strains

Tempeh is a popular Indonesian product obtained from legume seeds by solid-state fermentation with Rhizopus sp. The aim of this research was to study the effect of simultaneous mixed-culture fermentation of grass pea seeds on selected parameters of products as compared to traditional tempeh. The inoculum contained different ratios of Rhizopus oligosporus and Aspergillus oryzae spores. The simultaneous fermentation of grass pea seeds with inoculum consisting of 1.2 × 10(6) R. oligosporus and 0.6 × 10(6) A. oryzae spores (per 60 g of seeds) resulted in a product of improved quality, as compared with traditionally made tempeh (obtained after inoculation with 1.2 × 10(6) R. oligosporus spores), at the same fermentation time. This product had radical scavenging ability 70% higher than the one obtained with pure R. oligosporus culture and contained 2.23 g/kg dm of soluble phenols. The thiamin and riboflavin levels were above three (340 µg/g dm) and two (50.50 µg/g dm) folds higher than in traditionally made tempeh, respectively. The product had 65% in vitro bioavailability of proteins and 33% in vitro bioavailability of sugars. It also contained 40% less 3-N-oxalyl-L-2, 3-diaminopropionic acid (0.074 g/kg dm), as compared to traditional tempeh.

Effects of freeze-dried Mitsuokella jalaludinii culture and Natuphos(®) phytase supplementation on the performance and nutrient utilisation of broiler chickens

BACKGROUND

Phytate-bound phosphorus (P) in poultry diets is poorly available to chickens. Hence exogenous phytase is often added to their diets. Mitsuokella jalaludinii is a rumen bacterial species that produces high phytase activity. In this study the effects of freeze-dried active M. jalaludinii culture (FD-AMJC) and Natuphos(®) phytase (phytase N) supplementations on the growth performance and nutrient utilisation of broiler chickens fed a low-available P (aP) diet were evaluated.

RESULTS

Supplementation of FD-AMJC or phytase N to the low-aP diet improved the feed intake, feed conversion rate, body weight gain, dry matter (DM) digestibility and P, Ca and Mn retention, increased the tibia bone ash content, Ca and P concentrations in tibia DM and P and Zn concentrations in plasma and reduced the P excretion of broiler chickens. However, the feed conversion rate, P and Ca retention, DM digestibility and reduction of P excretion were better with FD-AMJC than phytase N supplementation. Supplementation of FD-AMJC to the low-aP diet also improved the apparent metabolisable energy value of the diet, Cu and Zn retention and crude protein digestibility, but phytase N supplementation did not.

CONCLUSION

FD-AMJC supplementation was more efficient in improving nutrient utilisation and reducing P excretion in chickens than phytase N supplementation.

Multi-carbohydrase and phytase supplementation improves growth performance and liver insulin receptor sensitivity in broiler chickens fed diets containing full-fat rapeseed

The effect of a combination of carbohydrase and phytase enzymes on growth performance, insulin-like growth factor 1 gene expression, insulin status, and insulin receptor sensitivity in broiler chickens fed wheat-soybean meal diets containing 6% (starter) and 12% (grower-finisher) of full-fat rapeseed (canola type; low glucosinolate, low erucic acid) from 1 to 42 d of age was studied. A total of 510 one-day-old male broiler chickens were randomly assigned to 3 dietary treatments, with 17 pens per treatment and 10 birds per pen. The dietary treatments consisted of a control diet and P- and Ca-deficient diets supplemented with either phytase (500 U/kg) or a combination of phytase and a multi-carbohydrase enzyme (Superzyme OM). The diets were pelleted at 78 degrees C and were fed ad libitum throughout the starter (9 d), grower (18 d), and finisher (15 d) phases of the experiment. Over the entire trial, growth performance of birds fed the phytase-supplemented diet did not differ from birds fed the control diet. The use of phytase in combination with a multicarbohydrase enzyme improved (P = 0.007) the feed conversion ratio from 1.90 to 1.84. Insulin liver receptor sensitivity increased by 9.3 and 12.3% (P = 0.004) for the phytase- and the carbohydrase-phytase-supplemented diets, respectively. There was no effect of phytase alone or carbohydrase and phytase supplementation on total plasma cholesterol, high-density lipoprotein cholesterol, and blood glucose levels. However, low-density lipoprotein cholesterol decreased (P = 0.007) for the phytase-carbohydrase treatment. Gene expression of insulin-like growth factor 1 tended to decrease by 32% (P = 0.083) after phytase-carbohydrase supplementation. The combination of carbohydrase and phytase enzymes may serve as an attractive means of facilitating nutrient availability for digestion and thus enhance the feeding value of wheat-soybean meal-based diets containing full-fat rapeseed. However, the extent to which the effects of enzyme addition on insulin receptors are associated with growth performance of broiler chicken requires further research.

Influence of an enzyme cocktail and phytase individually or in combination in Ven Cobb broiler chickens

1. An experiment (21 d) was conducted to determine if the response of chicks to a cocktail of xylanase, amylase, and protease (XAP) or Escherichia coli-derived phytase individually or in combination when fed a nutritionally marginal maize-soybean meal diet is age-dependent. 2. A total of 250 one-day-old Ven Cobb broiler chicks were allocated to 5 dietary treatments in a randomised complete block design. The treatments were as follows: (1) positive control with supplemental inorganic P; (2) negative control (NC) marginal in P and ME; (3) NC plus XAP to provide (per kg of diet) 650, 1650 and 4000 U of xylanase, amylase, and protease, respectively; (4) NC plus phytase added to provide 1000 phytase units/kg; and (5) NC plus a combination of XAP and phytase. 3. Low ME and P in the NC diet depressed weight gain and gain:feed. A cocktail of XAP alone did not improve performance, but phytase supplementation improved weight gain. The enzymes were additive in their effects on growth performance. 4. The enzymes had no effect on ileal digestible energy. Ileal N digestibility was higher in diets with XAP or phytase individually compared with NC. Both phytase and XAP individually and in combination improved ileal P digestibility compared with NC. 5. Total tract nutrient retention and ME increased as the birds grew older. There were age x diet interactions in total tract retention of P and Ca; improvement in P retention due to phytase use decreased by 50% as the chicks matured. 6. The current study shows that a combination of XAP and phytase improved performance, but the enhancement in performance appears to be due mainly to phytase. Both XAP and phytase were effective in improving P digestibility and retention of chicks receiving nutritionally marginal maize-soybean meal. 7. The data also showed that the chicks benefited more from the enzyme addition at a younger age and that the contribution of the enzymes to nutrient retention decreased with age in chickens.

Effects of phytate and phytase on the performance and immune function of broilers fed nutritionally marginal diets

The effects of phytate and phytase on broiler performance and cellular and humoral immunity was assessed by using 504 Cobb 500 female broilers fed nutritionally marginal diets. At 1 d of age, the chicks were randomly allocated to 6 treatments in a 2 x 3 factorial arrangement including 2 levels of phytate P (0.22 or 0.44%) and 3 dose rates of an Escherichia coli-derived phytase [0, 500, or 1,000 phytase units (FTU)/kg of feed]. Both low- and high-phytate diets were corn and soy based with the same nutritional specifications (AME 2,900 kcal/kg, CP 21.00%, Ca 0.78%, and nonphytate P0.28%), differing only in the concentration of phytate P. The immune status of birds was measured at 14, 21, and 28 d of age. The results revealed that phytase improved feed intake, BW, and feed conversion ratio (P < 0.05), whereas high dietary phytate depressed bird performance (P < 0.05). There was no interaction between phytate and phytase on bird performance. Feeding phytase increased the percentages of erythrocyte rosette-forming cells and erythrocyte-antibody complement cells by 3.03 and 1.83% at d 21, and by 2.76 and 2.20% at d 28, respectively (P < 0.05). The percentages of CD4(+)CD8(+) T lymphocyte subsets were also increased by phytase (P < 0.05), without affecting the ratio of CD4(+) and CD8(+). The levels of intestinal secretory IgA were improved with phytase at d 14, 21, and 28 (P < 0.05). Antibodies against Newcastle disease virus vaccine were enhanced at d 21 and 28 in the high-phytate diets with phytase addition (P < 0.05). Increasing the phytase dose to 1,000 FTU/kg did not improve immune function further than 500 FTU/kg. The results suggest that application of phytase in nutritionally marginal diets could enhance lymphocyte numbers and the seral and mucosal antibodies of 1- to 28-d-old broilers, suggesting that both phytate and phytase may have a role in gastrointestinal health and immune competence.

Evolving enzyme technology: impact on commercial poultry nutrition

The use of exogenous enzymes to improve the nutritional value of poultry diets is a relatively new concept. The technology is rapidly evolving, with new enzymes, enzyme combinations, and novel applications being developed as rapidly as regulatory restrictions will allow. Most researchers in the field of poultry nutrition would consider phytase to be the last significant leap forward in terms of enzyme use in the animal feed industry. However, there is a great deal of ongoing research into the next generation of enzymes with a focus on ingredient quality, predictability of response via least-square models, improvements in food safety, effect of bird age, effect of various side activities and enzyme dose, maximisation of net income and reduction in environmental pollution. It is the purpose of the present review article to summarise the current research in the area of feed enzymes for poultry and to speculate on future applications of enzymes and new enzyme technologies that may be of value to the industry in the coming years.

Age-Related Influence of a Cocktail of Xylanase, Amylase, and Protease or Phytase Individually or in Combination in Broilers

This 21-d experiment was conducted to determine if the response of chicks to a cocktail of xylanase, amylase, and protease (XAP) or Escherichia coli-derived phytase individually or in combination when fed a nutritionally marginal corn-soybean meal diet is age-dependent. Six hundred 1-d-old chicks were allocated to 5 dietary treatments in a randomized complete block design. The treatments were as follows: 1) positive control with supplemental inorganic P; 2) negative control (NC) marginal in P and ME; 3) NC plus XAP to provide (per kg of diet) 650, 1,650, and 4,000 U of xylanase, amylase, and protease, respectively; 4) NC plus phytase added to provide 1,000 phytase units/kg; and 5) NC plus a combination of XAP and phytase. Low ME and P in the NC diet depressed weight gain and gain:feed (P < 0.001). A cocktail of XAP alone did not improve performance, but phytase supplementation improved (P < 0.001) weight gain. The enzymes were additive in their effects on growth performance. The enzymes had no effect on ileal digestible energy. Ileal N digestibility was higher (P < 0.05) in diet with XAP or phytase individually compared with NC. Both phytase and XAP individually and in combination improved (P < 0.01) ileal P digestibility compared with NC. Total tract nutrient retention and ME increased (P < 0.01) as the birds grew older. There were age x diet interactions (P < 0.001) on total tract retention of P and Ca; improvement in P retention due to phytase use decreased by 50% as the chicks matured. The current study shows that a combination of XAP and phytase improved performance, but the enhancement in performance appears to be mainly from phytase. Both XAP and phytase were effective in improving P digestibility and retention of chicks receiving nutritionally marginal corn-soybean meal. The data also shows that the chicks benefited more from the enzyme addition at a younger age and that the contribution of the enzymes to nutrient retention decreased with age in chickens.

Prediction of ingredient quality and the effect of a combination of xylanase, amylase, protease and phytase in the diets of broiler chicks. 2. Energy and nutrient utilisation

1. In order to investigate the effects of xylanase, amylase, protease and phytase in the diets of broiler chickens containing graded concentrations of metabolisable energy (ME), two 42-d experiments were conducted using a total of 2208 broiler chicks (8 treatments with 12 replicate pens in each experiment). 2. Four diets including one positive and three negative control diets were used. Three maize/soybean meal-based negative control (NC) diets were formulated to be identical in available phosphorus (P), calcium (Ca) and amino acids but NC1 contained approximately 0.17 MJ/kg less ME than NC2 and approximately 0.34 MJ/kg less ME than NC3. A positive control (PC) was fed for comparison and was formulated to be adequate in all nutrients, providing approximately 0.63 MJ/kg ME, 0.13% available P, 0.12% Ca and 1 to 2% amino acids more than NC1. 3. The reduction in nutrient density between NC1 and PC was determined using ingredient quality models Avichecktrade mark Corn and Phychecktrade mark that can predict the response to exogenous enzymes in maize/soybean meal-based broiler diets. Supplementation of each diet with or without a cocktail of xylanase, amylase, protease and phytase gave a total of 8 dietary treatments in a 4 x 2 factorial arrangement. The same treatments and diet designs were used in both experiments but conducted in different locations using different batches of maize, soybean meal and minor ingredients. 4. In both experiments, digestibility was improved by the addition of exogenous enzymes, particularly those for P, Ca and certain amino acids. In addition, the supplementation of the PC with enzymes elicited a positive response indicating that over-the-top addition of xylanase, amylase, protease and phytase may offer a nutritionally and economically viable alternative to feed cost reduction. 5. It can be concluded that the digestibility of nutrients by broilers fed on maize/soybean meal-based diets can be improved by the use of a combination of xylanase, amylase, protease and phytase.

Efficacy of an Escherichia coli Phytase in Broilers Fed Adequate or Reduced Phosphorus Diets and Its Effect on Carcass Characteristics

Five experiments (EXP) were conducted to assess the efficacy of an Escherichia coli phytase compared with 2 commercially available fungal phytases. In EXP 1 and 2, male broiler chicks were fed experimental diets that included a P-deficient control (0.13% available P; 0.88% Ca) alone or with graded levels of KH(2)PO(4) (0, 0.05, 0.10, or 0.15%) or phytase at levels of 250, 500, 1,000, 2,000, or 4,000 phytase units/kg of E. coli phytase (EXP 1 and 2), fungal phytase 1 (EXP 2), or fungal phytase 2 (EXP 2). In EXP 1 and 2, weight gain and tibia ash (mg/chick and %) responded linearly (P < 0.05) to inorganic P addition. In EXP 2, each level of E. coli phytase released more P than either fungal phytases 1 or 2, whether based on tibia ash weight (mg/chick) or percentage. In EXP 3, 4, and 5, dietary treatments containing adequate or deficient levels of P were fed with or without supplemental E. coli phytase. In EXP 3, weight gain and tibia ash were reduced (P < 0.05) by P deficiency, but gain and tibia ash of chicks fed E. coli phytase (250, 500, or 1,000 phytase units/kg) did not differ (P > 0.05) from that of chicks fed the P-adequate diet. In addition, carcass yield of broilers fed E. coli phytase was not reduced (P > 0.05). In EXP 4, E. coli phytase effectively supported weight gain, tibia ash, breast yield, and leg yield compared with birds fed the P-adequate diet, but clavicle breakage during processing was increased in birds fed E. coli phytase. In EXP 5, E. coli phytase again effectively supported weight gain, and no differences (P > 0.05; compared with the P-adequate diet) were noted for clavicle ash, diameter, or breaking strength. No differences (P > 0.05) in bone breakage during processing were noted among treatments. These results indicate that the addition of E. coli phytase to P-deficient broiler diets improves growth, bone, and carcass performance and is more effective at releasing phytate-bound P than the other phytase products that were tested.

Cloning, sequencing and characterization of a novel phosphatase gene, phoI, from soil bacterium Enterobacter sp. 4

A gene, phoI, coding for a phosphatase from Enterobacter sp. 4 was cloned in Escherichia coli and sequenced. Analysis of the sequence revealed one open reading frame (ORF) that encodes a 269-amino acid protein with a calculated molecular mass of 29 kDa. PhoI belongs to family B acid phosphatase and exhibits 49.4% identity and 62.4% homology to the hel gene from Heamophilus influenzae, which encoded an outer membrane protein (P4). The optimum pH and temperature for phosphatase activity were pH 5.5 and 40 degrees C, respectively. Its specific activity on rho-nitrophenyl phosphatate was 70 U/mg at pH 5.5 and 40 degrees C. Enzyme activity was inhibited by Al3+, EDTA, and DTT, but fivefold activated by Cu2+ ion (350 U/mg). PhoI showed a strong synergistic effect when used with a purified E. coli phytase, AppA, to estimate combination effects.

Carbohydrases, protease, and phytase have an additive beneficial effect in nutritionally marginal diets for broiler chicks

To investigate the additive effects of xylanase, amylase, protease, and phytase in the diets of broiler chickens, a study was conducted using 1,152 growing broiler chicks (8 treatments with 12 replicate pens of 12 chicks). The birds were fed a corn/soybean-based negative control (NC) diet that was formulated to be nutritionally marginal in terms of metabolizable energy, Ca, and P. A nutritionally adequate positive control (PC) diet was fed for comparison. The NC diet was supplemented with phytase; a cocktail of xylanase, amylase, and protease (XAP); or a combination of phytase and XAP at 100 or 200 mg of each enzyme/kg (200 mg of XAP/kg provided a guaranteed minimum of 300 U of xylanase, 400 U of amylase, and 4,000 U of protease/kg; 200 mg of phytase/kg provided a guaranteed minimum of 1,000 U of phytase/kg). Growth performance, ileal digestible energy (IDE), and the digestibility coefficients of N, Ca, P, and DM were calculated. Individually and in combination, both phytase and XAP improved (P < 0.05) gain-to-feed ratio compared with the NC diet, particularly at the highest inclusion concentration. Body weight gain followed a similar trend, showing an improvement of approximately 6 to 7% with either enzyme individually and a 14% improvement with a combination of phytase and XAP. The effect of enzymes on IDE and nutrient digestibility coefficients was not as marked, but a 165 kcal/kg reduction in IDE was noted between the NC and PC diets, and a combination of phytase and XAP improved IDE by >100 kcal/kg. It can be concluded that the use of phytase and XAP individually in a corn/soybean meal-based diet is effective in improving nutrient digestibility and performance of broilers fed nutritionally marginal diets. Furthermore, there may be an additive effect of phytase and XAP on broiler performance, giving a cost-effective nutritional strategy for the profitable production of poultry products.

Towards complete dephosphorylation and total conversion of phytates in poultry feeds

The rate of phytate P removal from feed (level of dephosphorylation, DL) and the extent to which the molecule of phytic acid is deprived of phosphate moieties (conversion degree, CD) were studied in vitro and in a feeding trial with broilers fed corn-soybean diets. In the in vitro model, phytase A asymptotically increased DL and CD. Phytase B influenced DL only at low dosages of phytase A [0 or 250 phytase activity units (FTU)/kg], but it enhanced CD irrespective of phytase A activity. In the feeding trial, 3-phytase A and 6-phytase A (at 750 FTU/kg) exerted similar effects on broiler performance and similarly influenced bone mineralization, P retention, and Ca retention. Phytase B [6,400 acid phosphatase activity units (ACPU)/kg] enhanced feed intake, BW gain (BWG), toe ash, and P retention but not the retention of Ca. Myo-inositol fed at 0.1% significantly increased BWG, but it reduced P retention. Under conditions of a higher CD (excess of phytase B), 3-phytase A was more effective in enhancing performance than 6-phytase A, but it reduced Ca retention. Lower phytase B activities (0 to 3,200 ACPU/kg) with added 6-phytase A were more necessary for optimal growth of chickens than for enhanced P and Ca retention (4,800 to 6,400 ACPU/kg). The efficacy of both forms of phytase A and phytase B depended on the Ca level in feed. There is enough evidence to conclude that myo-inositol phosphates resulting from simultaneous action of 3-phytase A and phytase B affect bird physiology differently than intermediates accumulated by the action of 6-phytase A and phytase B.

Polyvalent cation effects on myo-inositol hexakis dihydrogenphosphate enzymatic dephosphorylation in dairy wastewater

Information is needed on organic polyphosphates such as myo-inositol 1,2,3,5/4,6-hexakis dihydrogenphosphate or phytate (IP6) contribution to the sources and sinks of dissolved phosphorus (PO4-P) in the soil-manure-water system. Effects of Na+, Ca2+, Al3+, and Fe3+ and cation to IP6-P mole ratios on the enzymatic dephosphorylation of IP6 were studied to determine controlling mechanisms of dephosphorylation and persistence in manure. Phytate- and PO4-P were analyzed by high-performance liquid chromatography. Phytate dephosphorylation by Aspergillus ficuum (Reichardt) Henn. phytase EC 3.1.3.8 decreases by 50 +/- 3.6 and 40 +/- 4% at pH 4.5 and 6, respectively, as Ca2+ concentrations increase and cation to IP6-P mole ratios reach 6:6. Polyanionic IP6 has a high affinity for Al3+ and Fe3+ and reductions in dephosphorylation average 27 and 32% at a cation to IP6-P mole ratio of 1:6 for Al3+ and Fe3+, respectively, while reaching more than 99% at a mole ratio of 6:6. A phytase-hydrolyzable phosphorus (PHP) fraction is native to ruminant animal manure and is proportional to total solids (TS) concentration in 1 to 100 g L(-1) suspensions. Added phytase, in effect, increases water-extractable P content of manure and the risk of environmental P dispersion. As the bioavailability and ecological effect of IP6-P appear to be regulated not only by pH-controlled enzyme activity but also by the associated counterions, the differential protective effects of cations influence the accuracy of manure PHP fraction estimates and increase phytate resistance to enzymatic dephosphorylation that may lead to its persistence in manure.

Efficacy of supplementation of a phytase-producing bacterial culture on the performance and nutrient use of broiler chickens fed corn-soybean meal diets

We evaluated the efficacy of supplementation of active Mitsuokella jalaludinii culture (AMJC) on the growth performance, nutrient use, and mineral concentrations in tibia bone and plasma of broiler chickens fed corn-soybean meal diets. Dietary treatments included low-nonphytate P (NPP) feed (containing 0.24% and 0.232% NPP for chicks from 1 to 21 and 22 to 42 d of age, respectively), low-NPP feed added with different levels of AMJC (equivalent to 250, 500, 750, and 1,000 U phytase/kg of feed), and normal-NPP feed (containing 0.46 and 0.354% NPP for chicks from 1 to 21 and 22 to 42 d of age, respectively). Supplementation of AMJC to low-NPP feed increased (P < 0.05) weight gain and feed intake and decreased (P < 0.05) feed:gain ratio of chickens during the whole experiment (Days 1 to 42). Supplementation of AMJC increased (P < 0.05) the AME value, digestibility of DM and CP, and retention of P, Ca, and Cu. Mn retention in broilers was only increased (P < 0.05) by AMJC supplementation from 18 to 20 d of age, and Zn retention was improved (P < 0.05) only at a high level of AMJC (equivalent to 1,000 U phytase/kg of feed) supplementation. Chicks fed low-NPP feed added with AMJC had similar tibia ash percentages as those fed the normal-NPP diet. Generally, supplementing AMJC to low-NPP feed increased (P < 0.05) Ca, decreased significantly (P < 0.05) Mn and Cu, but did not affect Zn and P concentrations in tibia ash. Supplementing AMJC also increased (P < 0.05) plasma P but had no effect on plasma Ca or Mn. Plasma Zn concentration was increased only when a high level of AMJC (equivalent to 1,000 U phytase/kg of feed) was used. In conclusion, AMJC supplementation to low-NPP feed improved growth performance; AME value; digestibility of CP and DM; use of Ca, P, and Cu; and bone mineralization.