Agri-Food Side-Stream Inclusions in the Diet of Alphitobius diaperinus Part 1: Impact on Larvae Growth Performance Parameters

Performance of Hermetia illucens (Diptera: Stratiomyidae) larvae reared on organic waste diets and pupal chitin and chitosan yield

Recently, much research has been oriented towards the influence of different food wastes and agricultural by-products on the final larval biomass and chemical composition of the insect species Hermetia illucens L. (Diptera: Stratiomyidae). However, there is a gap in the literature regarding the possible relationship between the feeding substrate of H. illucens larvae and chitin. In this context, in the present study, larvae of H. illucens derived from two populations (i.e., UNIPI and UTH), were reared on different diets composed of fruits, vegetables, and meat. Based on the results, the larval survival was high for all diets tested. Larval growth in terms of weight gain, larval length, and feed conversion ratio (FCR) depended on the composition of each diet. The chitin and chitosan composition of larvae, reared on different substrates, did not reveal significant differences. Given the fact that the feeding substrate represent a significant cost in the industrial production of insects, its correlation with a high value product (i.e. chitosan) is important. On the other hand, as the prepupal stage of H. illucens is currently used as animal feed, the metabolization of chitin by farmed animals when the larvae or prepupae were offered as feed could have adverse effects. Thus, depending on the final product that is to be produced, industries could benefit from the establishment of a suitable diet.

Larval performance of Zophobas morio (F.) (Coleoptera: Tenebrionidae) on various diets enriched with post-distillation residues and essential oils of aromatic and medicinal plants

The increasing demands for resources driven by the global population necessitate exploring sustainable alternatives for affordable animal protein over the use of traditional protein sources. Insects, with their high protein content, offer a promising solution, especially when reared on agricultural post-distillation residues for enhanced sustainability and cost-effectiveness. We assessed the development of Zophobas morio (F.) (Coleoptera: Tenebrionidae) larvae on diets enriched with essential oils and post-distillation residues from Greek aromatic and medicinal plants. Two aromatic plant mixtures (A and B) were examined. Mixture A consisted of post-distillation residues, while Mixture B incorporated these residues along with essential oils. Insect rearing diets were enriched with different proportions (10, 20, and 30 %) of these mixtures, with wheat bran serving as the control. Enrichment positively influenced larval development without compromising survival. Larval weight remained unchanged with Mixture A, but improved with Mixture B. No adverse effects were detected in the case of the enriched diets, although higher concentrations of Mixture B prolonged development time.

Effects of dietary exposure to plant toxins on bioaccumulation, survival, and growth of black soldier fly (Hermetia illucens) larvae and lesser mealworm (Alphitobius diaperinus)

In their natural habitat, insects may bioaccumulate toxins from plants for defence against predators. When insects are accidently raised on feed that is contaminated with toxins from co-harvested herbs, this may pose a health risk when used for human or animal consumption. Plant toxins of particular relevance are the pyrrolizidine alkaloids (PAs), which are genotoxic carcinogens produced by a wide variety of plant species and the tropane alkaloids (TAs) which are produced by a number of Solanaceae species. This study aimed to investigate the transfer of these plant toxins from substrates to black soldier fly larvae (BSFL) and lesser mealworm (LMW). PAs and the TAs atropine and scopolamine were added to insect substrate simulating the presence of different PA- or TA-containing herbs, and BSFL and LMW were grown on these substrates. Bioaccumulation from substrate to insects varied widely among the different plant toxins. Highest bioaccumulation was observed for the PAs europine, rinderine and echinatine. For most PAs and for atropine and scopolamine, bioaccumulation was very low. In the substrate, PA N-oxides were quickly converted to the corresponding tertiary amines. More research is needed to verify the findings of this study at larger scale, and to determine the potential role of the insect and/or substrate microbiome in metabolizing these toxins.

Effectiveness of a teaching unit on the willingness to consume insect-based food - An intervention study with adolescents from Germany

This study investigated the effect of a four-lesson teaching unit titled "Entomophagy and Sustainability" on the willingness of adolescents in Germany to consume insect-based food (N = 114; M Age = 15.77 years; SD Age = 1.12 years; female = 58.8%). The main aim of the study was to test whether the teaching unit can induce long-term changes in selected nutritional-psychological factors (food disgust, food neophobia, food technology neophobia), attitudes, knowledge, and the willingness to consume insect-based food. For this purpose, a paper-pencil questionnaire was conducted immediately before (pre-test), immediately after (post-test), and approximately six weeks after (follow-up test) the teaching unit. Although significant changes in food disgust, food neophobia, food technology neophobia, attitudes, and knowledge were recorded, adolescents' willingness to consume insect-based food was not significantly increased. Attitudes were identified as the strongest predictor of adolescents' willingness to consume, while knowledge was not a significant predictor. Conclusions and recommendations that can be applied to other educational interventions are provided to increase the effectiveness of the teaching unit.

Valorization of Agricultural Side-Streams for the Rearing of Larvae of the Lesser Mealworm, Alphitobius diaperinus (Panzer)

During the last decade, insects have shown up as a promising answer to the increasing animal protein demand for a continuously growing human population. A wide spectrum of substrates of plant origin can be currently used as insect feed; the sustainability of insect rearing though greatly increases when organic side-streams and wastes are valorized and upcycled through their bioconversion with insects. Additionally, the exploitation of low-cost organic residues as insect feed can also significantly suppress the rearing cost and, consequently, the price of the insect meal. In this context, the aim of our work was to evaluate organic side-streams, generated through several agro-industrial processes, as feeding substrates for the larvae of the lesser mealworm, Alphitobius diaperinus. In a laboratory trial, eleven agricultural side-streams were provided to larvae singly to assess their potential to support complete larval development, whereas in the second trial, larvae were fed two groups of isoproteinic diets consisting of the side-streams that performed well in the first trial. Our results showed the suitability of several agricultural side-streams as feed for A. diaperinus larvae, e.g., barley by-products (classes I and II), sunflower meal, cotton cake and oat sidestream, which, when fed singly, efficiently supported larval growth, resulting in high survival rates and final larval weights, comparable to the control. Similarly, several of the side-streams-based diets tested were shown to be suitable for A. diaperinus rearing. These results aim to contribute to the utilization of agricultural side-streams singly or in composed diets for the rearing of A. diaperinus larvae.

Aflatoxin B1 Metabolism of Reared Alphitobius diaperinus in Different Life-Stages

The presence of carcinogenic aflatoxins in food and feed is a major issue. In prior studies, aflatoxin B1 (AfB1) and known primary metabolites were absent from Lesser Mealworm (LMW, Alphitobius diaperinus) reared on contaminated diets. LMW is a promising alternative protein source. The objectives of this stu\dy were to determine whether LMW can be reared on AfB1-contaminated feed in each life-stage, and to gather more insight into potential metabolites formed. Results suggested no adverse effects in terms of survival/growth when three stages of LMW (larvae, pre-pupae, beetles) were exposed to feed containing AfB1 concentrations of 200 and 600 µg/kg for 48 h. Insect and frass samples were analyzed by LC-MS/MS and high-resolution MS to, respectively, quantify concentrations of AfB1 and its major metabolites, and determine secondary metabolites. No AfB1 or major metabolites were quantified in the insect samples. Mass balance calculations showed that up to 40% of spiked AfB1 could be recovered in the frass, in the form of AfB1, aflatoxicol and AfM1. HRMS results suggested the presence of additional metabolites in the frass, but, due to lack of commercially available reference standards for these compounds, exact identification and quantification was not possible. More research is needed to verify the absence of toxicity.

Influence of Temperature, Relative Humidity and Protein Content on the Growth and Development of Larvae of the Lesser Mealworm, Alphitobius diaperinus (Panzer)

The human population is rapidly growing, subsequently leading to an increase in food and protein demand. Therefore, alternative protein sources have to be evaluated as food and feed. Among the most promising alternative protein sources with significant advantages are insects. Nevertheless, insect rearing conditions have to be optimized prior to insect mass production. In the present study, using laboratory bioassays, we evaluated the effect of several biotic and abiotic factors on the development of the larvae of the lesser mealworm, Alphitobius diaperinus (Panzer). In the first series of bioassays, we investigated A. diaperinus larval growth at three temperatures (25, 30 and 32 °C) and two relative humidity (r.h.) levels (55 and 75%). Furthermore, in the second series of bioassays, the larval growth was assessed on wheat bran-based substrates with different percentages of yeast, i.e., 0%, 10%, 17.5%, 25%, 32.5% and 40%. According to our results, the temperature was shown to be highly important for larval development, with A. diaperinus larvae performing better at the higher temperatures tested, i.e., 30 and 32 °C. In contrast, relative humidity did not have a significant effect on A. diaperinus growth, at least for the relative humidity levels tested. Finally, the increase in the percentage of yeast in the diet increased larval growth, development and survival. Our study aims to highlight the significance of several biotic and abiotic factors for the rearing of A. diaperinus larvae, providing parameters that can be further utilized in mass rearing protocols of this species.

Future Land Use for Insect Meat Production Among Countries: A Global Classification

A potentially suitable alternative to reduce land use by livestock production is insect meat production. However, land use predictions for insect meat production, which are important in the planning of food production strategies in each country, have not been well-performed. To consider the strategy of insect meat production with regard to land use, the categorical perspectives of countries would be highly useful. Here, using previous simulation results, we used random forest machine learning to classify the potential land use of 157 countries for insect meat production under future climate change. From the categorical maps, we showed the global distribution of five different country categories and found that the land area of the countries may be an important factor in considering the future increase in insect meat production. Our classification could be used to help formulate future food policies by considering the increase in insect meat production in each country, as well as regionally and/or globally.

Rearing Tenebrio molitor and Alphitobius diaperinus Larvae on Seed Cleaning Process Byproducts

The exploitation of agricultural byproducts and organic side-streams as insect feeding substrates is advantageous for insect farming both from an economic and a sustainability perspective. In this context, in the present study we evaluated the suitability of ten byproducts of the cereal and legume seed cleaning process for the rearing of larvae of the yellow mealworm, Tenebrio molitor, and the lesser mealworm, Alphitobius diaperinus. Byproducts were offered singly to 20 T. molitor and 50 A. diaperinus larvae with provision of carrots as moisture source. After four weeks of undisturbed development, larval weight and survival was evaluated biweekly until pupation. Feed utilization and economic feasibility parameters were determined for each byproduct at the end of the bioassays. Our results show the suitability of several of the byproducts tested for the rearing of T. molitor and A. diaperinus larvae. The best results though among the byproducts tested in terms of larval growth and survival, development time and feed utilization were obtained with larvae fed with lupin and triticale byproducts, which efficiently supported complete larval development. The results of our study aim to boost the integration of circular economy strategies with insect farming practices.

Agri-Food Side-Stream Inclusion in The Diet of Alphitobius Diaperinus. Part 2: Impact on Larvae Composition

Insects are gaining interest as an alternative protein source for feed/food purposes. Although the lesser mealworm (LM) is commercially produced for human consumption, published data on its nutrient composition is scarce. This study reports on LM larvae reared on 18 different diets composed of side-streams to (1) determine the nutritional composition of the larvae and (2) study the effect of dietary changes on the larval nutrient composition. The LM larvae proved to be of good nutritional value with essential amino acids profiles comparable with that of beef and linoleic acid (C18:2) was the most dominant essential fatty acids in the larvae. The side-stream based diets varied on dry matter basis in protein (16-34%) and lipid content (2-19%). The nutrient content of the larvae reared on diets that supported good growth ranged between 37% and 49% of protein, 22% and 26% of lipid and 4% to 6% of chitin on dry matter basis. No significant correlations were identified between the larval protein or lipid content and that of the diet, but it was found between the diet nutrients and larval growth. Based on larval growth data and economic considerations, diets composed of wheat middlings with a 10-15% inclusion of rapeseed meal were identified as suitable feed for LM. Highest larval yields were obtained with diets containing 15-22% of proteins and 5-10% of lipids.