1
|
Yun JH, Lee H, Nam JW, Ko M, Park J, Lee DH, Lee SG, Kim HS. Unlocking synergies: Harnessing the potential of biological methane sequestration through metabolic coupling between Methylomicrobium alcaliphilum 20Z and Chlorella sp. HS2. Bioresour Technol 2024; 399:130607. [PMID: 38499203 DOI: 10.1016/j.biortech.2024.130607] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/24/2024] [Revised: 03/09/2024] [Accepted: 03/15/2024] [Indexed: 03/20/2024]
Abstract
A halotolerant consortium between microalgae and methanotrophic bacteria could effectively remediate in situ CH4 and CO2, particularly using saline wastewater sources. Herein, Methylomicrobium alcaliphilum 20Z was demonstrated to form a mutualistic association with Chlorella sp. HS2 at a salinity level above 3.0%. Co-culture significantly enhanced the growth of both microbes, independent of initial inoculum ratios. Additionally, increased methane provision in enclosed serum bottles led to saturated methane removal. Subsequent analyses suggested nearly an order of magnitude increase in the amount of carbon sequestered in biomass in methane-fed co-cultures, conditions that also maintained a suitable cultural pH suitable for methanotrophic growth. Collectively, these results suggest a robust metabolic coupling between the two microbes and the influence of the factors other than gaseous exchange on the assembled consortium. Therefore, multi-faceted investigations are needed to harness the significant methane removal potential of the identified halotolerant consortium under conditions relevant to real-world operation scenarios.
Collapse
Affiliation(s)
- Jin-Ho Yun
- Cell Factory Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Integrative Biotechnology, College of Biotechnology and Bioengineering, Sungkyunkwan University, Suwon, Gyeonggi-do 16419, Republic of Korea; Department of Environmental Biotechnology, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea.
| | - Hyewon Lee
- Synthetic Biology Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Biosystems and Bioengineering, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea.
| | - Jang-Won Nam
- Cell Factory Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Environmental Biotechnology, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea.
| | - Minji Ko
- Synthetic Biology Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Biosystems and Bioengineering, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea.
| | - Jaehyun Park
- Cell Factory Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea.
| | - Dae-Hee Lee
- Department of Integrative Biotechnology, College of Biotechnology and Bioengineering, Sungkyunkwan University, Suwon, Gyeonggi-do 16419, Republic of Korea; Synthetic Biology Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Biosystems and Bioengineering, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea; Graduate School of Engineering Biology, Korea Advanced Institute of Science & Technology (KAIST), Daejeon 34141, Republic of Korea.
| | - Seung-Goo Lee
- Synthetic Biology Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Biosystems and Bioengineering, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea; Graduate School of Engineering Biology, Korea Advanced Institute of Science & Technology (KAIST), Daejeon 34141, Republic of Korea.
| | - Hee-Sik Kim
- Cell Factory Research Center, Korea Research Institute of Bioscience and Biotechnology (KRIBB), Daejeon 34141, Republic of Korea; Department of Environmental Biotechnology, KRIBB School of Biotechnology, University of Science & Technology (UST), Daejeon 34113, Republic of Korea.
| |
Collapse
|
2
|
Wang Z, Liao Y, Yan L, Liao B. Biological performance and membrane fouling of a microalgal-bacterial membrane photobioreactor for wastewater treatment without external aeration and carbonation. Environ Res 2024; 247:118272. [PMID: 38246292 DOI: 10.1016/j.envres.2024.118272] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/23/2023] [Revised: 01/10/2024] [Accepted: 01/18/2024] [Indexed: 01/23/2024]
Abstract
Biological nutrient removal processes involving the use of activated sludge (AS) to treat municipal wastewater normally result in high aeration energy consumption and significant greenhouse gas (GHG) emissions. Therefore, developing cost-efficient and environmentally friendly processes for wastewater treatment is vital. In this work, a novel non-aerated microalgal-bacterial membrane photobioreactor (MB-MPBR) was proposed, and its feasibility for organic contaminant and nutrient removals was evaluated, for the first time. The effects of inoculation ratio (microalgae to bacteria (M/B)) on the biological performance and membrane fouling were systematically investigated. The results showed that 95.9% of the chemical oxygen demand (COD), 74.5% of total nitrogen (TN), 98.5% of NH4+-N and 42.0% of total phosphorus (TP) were removed at an inoculation M/B ratio of 3:2 at steady state, representing a significant improvement compared to the M/B inoculation ratio of 1:3. Additionally, the higher inoculation M/B ratio (3:2) significantly promoted the biomass production owing to the favorable mutual exchange of oxygen and carbon dioxide between microalgae and bacteria. Cake layer formation was the primary fouling mechanism owing to the absence of aeration scouring on the membrane surface. The membrane fouling rate was slightly higher at the higher inoculation ratio (M/B = 3:2) owing to the increased biomass and extracellular polymeric substances (EPS) productions, despite the larger particle size. These results demonstrated that the non-aerated MB-MPBR could achieve superior biological performance, of which the inoculation M/B ratio was of critical importance for the initiation and maintenance of microalgal-bacterial symbiotic system, yet possibly caused severer membrane fouling in the absence of external aeration and carbonation. This study provides a new perspective for further optimizing and applying non-aerated MB-MPBR to enhance municipal wastewater treatment.
Collapse
Affiliation(s)
- Zhaozhao Wang
- College of Civil and Architectural Engineering, North China University of Science and Technology, Tangshan, 063210, PR China; College of Energy and Environmental Engineering, Hebei University of Engineering, Handan, 056038, PR China; Department of Chemical Engineering, Lakehead University, 955 Oliver Road, Thunder Bay, ON, P7B 5E1, Canada.
| | - Yichen Liao
- Department of Chemical Engineering, Lakehead University, 955 Oliver Road, Thunder Bay, ON, P7B 5E1, Canada
| | - Lina Yan
- College of Chemical Engineering, North China University of Science and Technology, Tangshan, 063210, PR China
| | - Baoqiang Liao
- Department of Chemical Engineering, Lakehead University, 955 Oliver Road, Thunder Bay, ON, P7B 5E1, Canada.
| |
Collapse
|
3
|
Pereira ASADP, Silva TAD, Magalhães IB, Ferreira J, Braga MQ, Lorentz JF, Assemany PP, Couto EDAD, Calijuri ML. Biocompounds from wastewater-grown microalgae: a review of emerging cultivation and harvesting technologies. Science of The Total Environment 2024; 920:170918. [PMID: 38354809 DOI: 10.1016/j.scitotenv.2024.170918] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/29/2023] [Revised: 01/22/2024] [Accepted: 02/10/2024] [Indexed: 02/16/2024]
Abstract
Microalgae biomass has attracted attention as a feedstock to produce biofuels, biofertilizers, and pigments. However, the high production cost associated with cultivation and separation stages is a challenge for the microalgae biotechnology application on a large scale. A promising approach to overcome the technical-economic limitations of microalgae production is using wastewater as a nutrient and water source for cultivation. This strategy reduces cultivation costs and contributes to valorizing sanitation resources. Therefore, this article presents a comprehensive literature review on the status of microalgae biomass cultivation in wastewater, focusing on production strategies and the accumulation of valuable compounds such as lipids, carbohydrates, proteins, fatty acids, and pigments. This review also covers emerging techniques for harvesting microalgae biomass cultivated in wastewater, discussing the advantages and limitations of the process, as well as pointing out the main research opportunities. The novelty of the study lies in providing a detailed analysis of state-of-the-art and potential advances in the cultivation and harvesting of microalgae, with a special focus on the use of wastewater and implementing innovative strategies to enhance productivity and the accumulation of compounds. In this context, the work aims to guide future research concerning emerging technologies in the field, emphasizing the importance of innovative approaches in cultivating and harvesting microalgae for advancing knowledge and practical applications in this area.
Collapse
Affiliation(s)
| | | | - Iara Barbosa Magalhães
- Federal University of Viçosa, Department of Civil Engineering, Viçosa, Minas Gerais, Brazil.
| | - Jessica Ferreira
- Federal University of Viçosa, Department of Civil Engineering, Viçosa, Minas Gerais, Brazil.
| | - Matheus Quintão Braga
- Federal University of Viçosa, Department of Civil Engineering, Viçosa, Minas Gerais, Brazil.
| | | | - Paula Peixoto Assemany
- Federal University of Lavras, Department of Environmental Engineering, Lavras, Minas Gerais, Brazil.
| | | | - Maria Lúcia Calijuri
- Federal University of Viçosa, Department of Civil Engineering, Viçosa, Minas Gerais, Brazil.
| |
Collapse
|
4
|
Ren Z, Fu R, Sun L, Li H, Bai Z, Tian Y, Zhang G. Unraveling biological behavior and influence of magnetic iron-based nanoparticles in algal-bacterial systems: A comprehensive review. Sci Total Environ 2024; 915:169852. [PMID: 38190907 DOI: 10.1016/j.scitotenv.2023.169852] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/24/2023] [Revised: 12/19/2023] [Accepted: 12/30/2023] [Indexed: 01/10/2024]
Abstract
Magnetic iron-based nanoparticles have been found to stimulate algae growth and harvest, repair disintegrated particles and improve stability, and facilitate operation in extreme environments, which help improve the wide application of algal-bacterial technology. Nevertheless, up to now, no literature collected to systematically review the research progress of on the employment of magnetic iron-based nanoparticles in the algal-bacterial system. This review summarizes the special effects (e.g., size effect, surface effect and biological effect) and corresponding properties of magnetic iron-based nanoparticles (e.g., magnetism, adsorption, electricity, etc.), which is closely related to biological effects and algal-bacterial behaviors. Additionally, it was found that magnetic iron-based nanoparticles offer remarkable impacts on improving the growth and metabolism of algal-bacterial consortia and the mechanisms mainly include its possible iron uptake pathways in bacteria and/or algae cells, as well as the magnetic biological effect of magnetic iron-based nanoparticles on algae-bacteria growth. Furthermore, in terms of the mechanism for establishing the algae-bacteria symbiotic relationship, the most recent works reveal that the charge effect, material transfer and signal transmission of magnetic iron-based nanoparticles possess a large array of potential mechanisms by which it can affect the establishment of algal-bacterial symbiosis. This discussion is expected to promote the progress of magnetic iron-based nanoparticles, as an eco-friendly, convenient and cost-effective technology that can be applied in algal-bacterial wastewater treatment fields.
Collapse
Affiliation(s)
- Zhijun Ren
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Ruiyao Fu
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Li Sun
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China.
| | - Huixue Li
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Zijia Bai
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Yu Tian
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China
| | - Guangming Zhang
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China; State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China.
| |
Collapse
|
5
|
Huang J, Cheng S, Zhang Y, Teng J, Zhang M, Lin H. Optimizing aeration intensity to enhance self-flocculation in algal-bacterial symbiosis systems. Chemosphere 2023; 341:140064. [PMID: 37673189 DOI: 10.1016/j.chemosphere.2023.140064] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/01/2023] [Revised: 08/31/2023] [Accepted: 09/02/2023] [Indexed: 09/08/2023]
Abstract
Effectuating optimal wastewater treatment via algae-bacterial symbiosis (ABS) systems necessitates the precise selection of aeration intensity. This study pioneers an in-depth investigation into the interplay of aeration intensity on the microalgal-bacterial consortia's self-flocculation efficacy and the overall treatment performance within ABS systems. The research provides evidence for a direct association between aeration intensity and biomass proliferation, indicating enhanced pollutant removal efficiency with escalated intensities (1.0 and 1.5 L min-1), though the variance lacks statistical significance. The peak self-flocculation efficacy of the microalgal-bacterial consortium (82.39% at 30 min) was manifested at an aeration intensity of 1.0 L min-1. The meticulous analysis of biomass properties showed the complexity of self-flocculation capacity in the consortium, which involves a dynamic interplay of several pivotal factors, including floc size, zeta potential, and EPS content. In situations where these factors pose conflicting influences, the determining factor emerges as the dominant influencer. In this study, the optimal aeration intensity was identified as 1 L min-1, shedding light on the critical threshold for ABS system operation. This study not only enriches the understanding of microalgal-bacterial wastewater treatment mechanisms but also fosters innovative strategies to enhance the performance of such systems.
Collapse
Affiliation(s)
- Jiahui Huang
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua, 321004, China; Key Laboratory of Watershed Earth Surface Processes and Ecological Security, Zhejiang Normal University, Jinhua, Zhejiang, China.
| | - Sihan Cheng
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua, 321004, China; Key Laboratory of Watershed Earth Surface Processes and Ecological Security, Zhejiang Normal University, Jinhua, Zhejiang, China.
| | - Yuwei Zhang
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua, 321004, China; Key Laboratory of Watershed Earth Surface Processes and Ecological Security, Zhejiang Normal University, Jinhua, Zhejiang, China.
| | - Jiaheng Teng
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua, 321004, China; Key Laboratory of Watershed Earth Surface Processes and Ecological Security, Zhejiang Normal University, Jinhua, Zhejiang, China.
| | - Meijia Zhang
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua, 321004, China; Key Laboratory of Watershed Earth Surface Processes and Ecological Security, Zhejiang Normal University, Jinhua, Zhejiang, China.
| | - Hongjun Lin
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua, 321004, China; Key Laboratory of Watershed Earth Surface Processes and Ecological Security, Zhejiang Normal University, Jinhua, Zhejiang, China.
| |
Collapse
|
6
|
Li R, Song M, Yin D, Ye X, Yu J, Chen X. Indole-3-acetic acid mediated removal of sludge toxicity by microalgae: Focus on the role of extracellular polymeric substances. Bioresour Technol 2023; 387:129700. [PMID: 37604255 DOI: 10.1016/j.biortech.2023.129700] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/27/2023] [Revised: 08/17/2023] [Accepted: 08/18/2023] [Indexed: 08/23/2023]
Abstract
The use of indole-3-acid (IAA) as an additive aided in achieving the objectives of reducing sludge extract toxicity, increasing Tetradesmus obliquus biomass yield, and enhancing extracellular polysaccharide production. Proteomics analysis can unveil the microalgae's response mechanism to sludge toxicity stress. With 10-6 M IAA addition, microalgae biomass reached 3.426 ± 0.067 g/L. Sludge extract demonstrated 78.3 ± 3.2% total organic carbon removal and 72.2 ± 2.1% toxicity removal. Extracellular polysaccharides and proteins witnessed 2.08 and 1.76-fold increments, respectively. Proteomic analysis indicated that Tetradesmus obliquus directed carbon sources towards glycogen accumulation and amino acid synthesis, regulating pathways associated with carbon metabolism (glycolysis, TCA cycle, and amino acid metabolism) to adapt to the stressful environment. These findings lay the groundwork for future waste sludge treatment and offer novel insights into microalgae cultivation and extracellular polysaccharide enrichment in sludge.
Collapse
Affiliation(s)
- Renjie Li
- National Engineering Research Center of Industrial Wastewater Detoxication and Resource Recovery, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Meijing Song
- National Engineering Research Center of Industrial Wastewater Detoxication and Resource Recovery, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Danning Yin
- National Engineering Research Center of Industrial Wastewater Detoxication and Resource Recovery, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Xiaoyun Ye
- National Engineering Research Center of Industrial Wastewater Detoxication and Resource Recovery, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Jiayu Yu
- National Engineering Research Center of Industrial Wastewater Detoxication and Resource Recovery, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Xiurong Chen
- National Engineering Research Center of Industrial Wastewater Detoxication and Resource Recovery, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China.
| |
Collapse
|
7
|
Li Q, Xu Y, Liang C, Peng L, Zhou Y. Nitrogen removal by algal-bacterial consortium during mainstream wastewater treatment: Transformation mechanisms and potential N 2O mitigation. Water Res 2023; 235:119890. [PMID: 36958220 DOI: 10.1016/j.watres.2023.119890] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/20/2022] [Revised: 02/08/2023] [Accepted: 03/17/2023] [Indexed: 06/18/2023]
Abstract
This work investigated nitrogen transformation pathways of the algal-bacterial consortium as well as its potential in reducing nitrous oxide (N2O) emission in enclosed, open and aerated reactors. The results confirmed the superior ammonium removal performance of the algal-bacterial consortium relative to the single algae (Chlorella vulgaris) or the activated sludge, achieving the highest efficiency at 100% and the highest rate of 7.34 mg N g MLSS-1 h-1 in the open reactor with glucose. Enhanced total nitrogen (TN) removal (to 74.6%) by the algal-bacterial consortium was achieved via mixotrophic algal assimilation and bacterial denitrification under oxygen-limited and glucose-sufficient conditions. Nitrogen distribution indicated that ammonia oxidation (∼41.8%) and algal assimilation (∼43.5%) were the main pathways to remove ammonium by the algal-bacterial consortium. TN removal by the algal-bacterial consortium was primarily achieved by algal assimilation (28.1-40.8%), followed by bacterial denitrification (2.9-26.5%). Furthermore, the algal-bacterial consortium contributed to N2O mitigation compared with the activated sludge, reducing N2O production by 35.5-55.0% via autotrophic pathways and by 81.0-93.6% via mixotrophic pathways. Nitrogen assimilation by algae was boosted with the addition of glucose and thus largely restrained N2O production from nitrification and denitrification. The synergism between algae and bacteria was also conducive to an enhanced N2O reduction by denitrification and reduced direct/indirect carbon emissions.
Collapse
Affiliation(s)
- Qi Li
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China
| | - Yifeng Xu
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China
| | - Chuanzhou Liang
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China
| | - Lai Peng
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China.
| | - Yan Zhou
- School of Civil and Environmental Engineering, Nanyang Technological University 639798, Singapore
| |
Collapse
|
8
|
Zhou Y, Li X, Chen J, Wang F. Treatment of antibiotic-containing wastewater with self-suspended algae-bacteria symbiotic particles: Removal performance and reciprocal mechanism. Chemosphere 2023; 323:138240. [PMID: 36841454 DOI: 10.1016/j.chemosphere.2023.138240] [Citation(s) in RCA: 9] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/08/2022] [Revised: 01/30/2023] [Accepted: 02/22/2023] [Indexed: 06/18/2023]
Abstract
Emerging contaminants such as antibiotics in wastewater have posed a challenge on conventional biological treatment processes. Algae-bacteria symbiotic mode could improve the performance of biological treatment processes. Self-suspended algae-bacteria symbiotic particles (ABSPs) were prepared with Chlorella vulgaris and Bacillus subtilis using the sol-gel method and hollow glass microspheres in this study. The removal effect of nitrogen and phosphorus as well as the feedback mechanism of ABSPs under tetracycline stress were investigated through three-cycles wastewater treatment experiments. The antioxidant enzyme activity and phycosphere extracellular polymeric substance (EPS) content were identified as well. The results indicated that the removal rates of NH4+-N, TP, COD, and tetracycline in the ABSPs group finally reached 96.18%, 95.44%, 81.36%, and 74.20%, respectively, which were higher than the single algae group apparently. The phycosphere EPS content increased by 20.41% and algae cell structure maintained integrity in ABSPs group as compared with that in single algae group. This study demonstrates that the self-suspended ABSPs can improve contaminants removal performance and alleviate the antioxidant stress response of algae through algal-bacterial reciprocity mechanism.
Collapse
Affiliation(s)
- Yuhang Zhou
- College of Life and Environmental Sciences, Hangzhou Normal University, Hangzhou, 311121, China
| | - Xinjie Li
- College of Life and Environmental Sciences, Hangzhou Normal University, Hangzhou, 311121, China
| | - Jiaqi Chen
- College of Life and Environmental Sciences, Hangzhou Normal University, Hangzhou, 311121, China
| | - Fan Wang
- College of Life and Environmental Sciences, Hangzhou Normal University, Hangzhou, 311121, China; School of Engineering, Hangzhou Normal University, Hangzhou, 311121, China.
| |
Collapse
|
9
|
Dang BT, Bui XT, Nguyen TT, Ngo HH, Nghiem LD, Huynh KPH, Vo TKQ, Vo TDH, Lin C, Chen SS. Effect of biomass retention time on performance and fouling of a stirred membrane photobioreactor. Sci Total Environ 2023; 864:161047. [PMID: 36565885 DOI: 10.1016/j.scitotenv.2022.161047] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/28/2022] [Revised: 12/13/2022] [Accepted: 12/15/2022] [Indexed: 06/17/2023]
Abstract
Co-culture of microalgae-activated sludge has the potential to purify wastewater while reduce energy demand from aeration. In this work, a mechanically stirred membrane photobioreactor (stirred-MPBR) was used to evaluate the impact of the biomass retention time (BRT) on the treatment performance and membrane fouling. Results showed that stirred-MPBR was affected by BRT during treating domestic wastewater at a flux of 16.5 L m-2 h-1. The highest productivity was attained at BRT 7d (102 mg L-1 d-1), followed by BRT 10d (86 mg L-1 d-1), BRT 5d (85 mg L-1 d-1), and BRT 3d (83 mg L-1 d-1). Statistical analysis results showed that BRT 7d had a higher COD removal rate than BRT 10d, however, there is no difference in total nitrogen removal rate. The highest TP removal occurred when the biomass operated at BRT as short as 3d. Reduced BRTs caused a change in the microalgae-activated sludge biomass fraction that encouraged nitrification activity while simultaneously contributing to a higher fouling rate. The bound protein concentrations dropped from 31.35 mg L-1 (BRT 10d) to 10.67 mg L-1 (BRT 3d), while soluble polysaccharides increased from 0.99 to 1.82 mg L-1, respectively. The concentrations of extracellular polymeric substance fractions were significantly altered, which decreased the mean floc size and contributed to the escalating fouling propensity. At the optimum BRT of 7d, the stirred-MPBR showed sufficient access to light and nutrients exchange for mutualistic interactions between the microalgae and activated sludge.
Collapse
Affiliation(s)
- Bao-Trong Dang
- Faculty of Chemical Engineering, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City 700000, Viet Nam; Vietnam National University Ho Chi Minh (VNU-HCM), Linh Trung ward, Ho Chi Minh City 700000, Viet Nam
| | - Xuan-Thanh Bui
- Vietnam National University Ho Chi Minh (VNU-HCM), Linh Trung ward, Ho Chi Minh City 700000, Viet Nam; Key Laboratory of Advanced Waste Treatment Technology & Faculty of Environment and Natural Resources, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City, Viet Nam.
| | - Thanh-Tin Nguyen
- Key Laboratory of Advanced Waste Treatment Technology & Faculty of Environment and Natural Resources, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City, Viet Nam; Department of Materials Science and Engineering, University of Wisconsin-Milwaukee, Milwaukee, WI 53211, USA
| | - Huu Hao Ngo
- School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, NWS 2007, Australia
| | - Long D Nghiem
- School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, NWS 2007, Australia
| | - Ky-Phuong-Ha Huynh
- Faculty of Chemical Engineering, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City 700000, Viet Nam; Vietnam National University Ho Chi Minh (VNU-HCM), Linh Trung ward, Ho Chi Minh City 700000, Viet Nam; Key Laboratory of Advanced Waste Treatment Technology & Faculty of Environment and Natural Resources, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City, Viet Nam
| | - Thi-Kim-Quyen Vo
- Faculty of Biology and Environment - Natural Resources and Climate Change, Ho Chi Minh City University of Food Industry (HUFI), 140 Le Trong Tan street, Tan Phu district, Ho Chi Minh city 700000, Viet Nam; Key Laboratory of Advanced Waste Treatment Technology & Faculty of Environment and Natural Resources, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City, Viet Nam
| | - Thi-Dieu-Hien Vo
- Faculty of Environmental and Food Engineering, Nguyen Tat Thanh University, Ho Chi Minh City, Viet Nam; Key Laboratory of Advanced Waste Treatment Technology & Faculty of Environment and Natural Resources, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, district 10, Ho Chi Minh City, Viet Nam
| | - Chitsan Lin
- Department of Marine Environmental Engineering, National Kaohsiung University of Science and Technology, Kaohsiung City, Taiwan
| | - Shiao-Shing Chen
- Institute of Environmental Engineering and Management, National Taipei University of Technology, Taipei, Taiwan
| |
Collapse
|
10
|
Su K, Li X, Lu T, Mou Y, Liu N, Song M, Yu Z. Screening of the heterotrophic microalgae strain for the reclamation of acid producing wastewater. Chemosphere 2022; 307:136047. [PMID: 35977579 DOI: 10.1016/j.chemosphere.2022.136047] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/15/2022] [Revised: 08/01/2022] [Accepted: 08/08/2022] [Indexed: 06/15/2023]
Abstract
For the sustainable development of the environment, to reduce the high cost and low productivity of microalgae biofuel, nine microalgae strains were screened to study the growh and nutrient removal properties under heterotrophic culture by using the waste carbon source of volatile fatty acids (VFAs). Chlorella sorokiniana (C.sorokiniana) was selected as the best strain with the highest biomass concentration of 0.77 g L-1, specific growth rate of 0.25 d-1, biomass productivity of 91.43 mg L-1 d-1, total nitrogen removal efficiency of 95.96% and total phosphorus removal efficiency of 93.42%. To study the utilization potential of acid-producing wastewater by heterotrophic microalgae, actual acid-producing wastewater was recycled three times for the utilization of C.sorokiniana. After the three utilization cultivation, the removal rates of COD, total nitrogen, ammonia nitrogen, and total phosphorus were 74.44%, 88.05%, 79.08%, and 82.69%, respectively. The total utilization rates of acetic acid, propionic acid, and butyric acid were 58.99%, 70.54%, and 81.52%, respectively. In addition, the highest lipid content of 39.15% and protein content of 42.43% achieved at the third cultivation. After the first cultivation, the composition and diversity of the microbial community structure changed dramatically, with Protebacteria, Bacteroidota, Hydrogenophaga, and Algoriphagus becoming enriched. These results showed a promising way of coupling wastewater treatment with biomass production for long-term sustainability of microalgae lipid production.
Collapse
Affiliation(s)
- Kunyang Su
- School of Environmental Science & Engineering, Qilu University of Technology (Shandong Academy of Sciences), Jinan, Shandong, 250353, PR China
| | - Xue Li
- School of Environmental Science & Engineering, Qilu University of Technology (Shandong Academy of Sciences), Jinan, Shandong, 250353, PR China
| | - Tianxiang Lu
- School of Environmental Science & Engineering, Qilu University of Technology (Shandong Academy of Sciences), Jinan, Shandong, 250353, PR China
| | - Yiwen Mou
- School of Environmental Science & Engineering, Qilu University of Technology (Shandong Academy of Sciences), Jinan, Shandong, 250353, PR China
| | - Na Liu
- School of Environmental Science & Engineering, Qilu University of Technology (Shandong Academy of Sciences), Jinan, Shandong, 250353, PR China
| | - Mingming Song
- School of Environmental Science & Engineering, Qilu University of Technology (Shandong Academy of Sciences), Jinan, Shandong, 250353, PR China.
| | - Ze Yu
- School of Environmental Science and Engineering, Shandong University, Qingdao, 266237, China.
| |
Collapse
|
11
|
Wang HC, Liu Y, Yang YM, Fang YK, Luo S, Cheng HY, Wang AJ. Element sulfur-based autotrophic denitrification constructed wetland as an efficient approach for nitrogen removal from low C/N wastewater. Water Res 2022; 226:119258. [PMID: 36272196 DOI: 10.1016/j.watres.2022.119258] [Citation(s) in RCA: 46] [Impact Index Per Article: 23.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/08/2022] [Revised: 10/10/2022] [Accepted: 10/14/2022] [Indexed: 06/16/2023]
Abstract
Constructed wetlands (CWs) integrated with sulfur autotrophic denitrification to stimulate high-rate nitrogen removal from carbon-limited wastewater holds particular application prospect due to no excessive carbon source addition, high efficiency, and good stability. In this study, we conducted elemental sulfur-based constructed wetland (SCW) and traditional constructed wetland (CW) under different C/N (2, 1, and 0.5) to explore the feasibility and mechanisms for nitrogen removal from low C/N wastewater. Compared with CW, SCW was demonstrated more robust in nitrogen removal in the case of low C/N influent. When the influent C/N control was at 0.5, SCW observed total nitrogen (TN) and nitrate removal efficiency of 69.36 ± 3.96% and 81.71 ± 3.96%, with the corresponding removal rate of 1.18 ± 0.66 and 1.70 ± 0.92 g-N·m-2·d-1, which were 2.11 and 10.03 times of CW, respectively. The nitrate removal rate constant k in the SCW was 1.05, 3.83, and 10.33 times higher than the CW with C/N of 2, 1 and 0.5. Furthermore, 14.40, 54.51, and 79.82% of nitrogen were removed by the sulfur autotrophic denitrification (SAD) in SCW, which also contributed 43.89, 73.68, and 71.70% of sulfate production. Moreover, the combined system of CW-SCW is proved be an efficient operation mode for simultaneously removing total ammonia nitrogen (TAN) and nitrate. In the SCW, the richness of the microbial community was improved and sulfur-oxidizing genera (e.g. Thiobacillus, Sulfurimonas) was selectively enriched, which affect the performance the elemental sulfur-based denitrification process. The nitrate reduction pathway was overwhelmed by denitrification and the dissimilatory nitrate reduction process. These findings offer elemental sulfur-based autotrophic denitrification constructed wetland has excellent potential to enhance nitrogen removal from carbon-limited wastewater.
Collapse
Affiliation(s)
- Hong-Cheng Wang
- State Key Laboratory of Urban Water Resource and Environment, Shenzhen Key Laboratory of Organic Pollution Prevention and Control, School of Civil and Environmental Engineering, Harbin Institute of Technology Shenzhen, Shenzhen 518055, China; State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, China
| | - Ying Liu
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, China
| | - Yu-Meng Yang
- College of the Environment, Liaoning University, Shenyang 110036, China
| | - Ying-Ke Fang
- Key Lab of Environmental Biotechnology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Shuang Luo
- State Key Laboratory of Urban Water Resource and Environment, Shenzhen Key Laboratory of Organic Pollution Prevention and Control, School of Civil and Environmental Engineering, Harbin Institute of Technology Shenzhen, Shenzhen 518055, China
| | - Hao-Yi Cheng
- State Key Laboratory of Urban Water Resource and Environment, Shenzhen Key Laboratory of Organic Pollution Prevention and Control, School of Civil and Environmental Engineering, Harbin Institute of Technology Shenzhen, Shenzhen 518055, China; State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, China
| | - Ai-Jie Wang
- State Key Laboratory of Urban Water Resource and Environment, Shenzhen Key Laboratory of Organic Pollution Prevention and Control, School of Civil and Environmental Engineering, Harbin Institute of Technology Shenzhen, Shenzhen 518055, China; State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, China.
| |
Collapse
|
12
|
Javed MA, Aly Hassan A. Photo fermentative biohydrogen production potential using microalgae-activated sludge co-digestion in a sequential flow batch reactor (SFBR). RSC Adv 2022; 12:29785-29792. [PMID: 36321096 PMCID: PMC9577477 DOI: 10.1039/d2ra06014k] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/23/2022] [Accepted: 10/01/2022] [Indexed: 11/17/2022] Open
Abstract
Biohydrogen (bioH2) is a sustainable energy source that can produce carbon-free energy upon combustion. BioH2 can be generated from microalgae by photolytic and anaerobic digestion (AD) pathways. The AD pathway faces many challenges when scaling up using different bioreactors, particularly the continuous stirred tank reactor (CSTR) and sequential flow batch reactor (SFBR). Therefore, the performance characteristics of SFBR were analysed in this study using Chlorella vulgaris and domestic wastewater activated sludge (WWAS) co-culture. An organic loading rate (OLR) of 4.7 g COD L-1 day-1 was fed to the SFBR with a hydraulic retention time (HRT) of five days in the presence of light under anaerobic conditions. The pH of the medium was maintained at 6 using a pH controller for the incubation period of 15 days. The maximum bioH2 concentrations of 421.1 μmol L-1 and 56.6 μmol L-1 were observed in the exponential and steady-state phases, respectively. The effluent had an unusually high amount of acetate of 16.6 g L-1, which remained high with an average of 11.9 g L-1 during the steady state phase. The amount of bioH2 produced was found to be inadequate but consistent when operating the SFBR with a constant OLR. Because of the limitations in CSTR handling, operating a SFBR by optimizing OLR and HRT might be more feasible in operation for bioH2 yield in upscaling. A logistic function model was also found to be the best fit for the experimental data for the prediction of bioH2 generation using co-culture in the SFBR.
Collapse
Affiliation(s)
- Muhammad Asad Javed
- Department of Civil and Environmental Engineering, United Arab Emirates UniversityAl Ain 15551United Arab Emirates,National Water and Energy Center, United Arab Emirates UniversityAl Ain 15551United Arab Emirates
| | - Ashraf Aly Hassan
- Department of Civil and Environmental Engineering, United Arab Emirates UniversityAl Ain 15551United Arab Emirates,National Water and Energy Center, United Arab Emirates UniversityAl Ain 15551United Arab Emirates
| |
Collapse
|
13
|
Chen Z, Chen X, Li Q, Zhou P, Zhao Z, Li B. Transcriptome Analysis Reveals Potential Mechanisms of L-Serine Production by Escherichia coli Fermentation in Different Carbon–Nitrogen Ratio Medium. Foods 2022; 11:foods11142092. [PMID: 35885334 PMCID: PMC9318367 DOI: 10.3390/foods11142092] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/04/2022] [Revised: 07/09/2022] [Accepted: 07/09/2022] [Indexed: 12/10/2022] Open
Abstract
L-serine is an industrially valuable amino acid that is widely used in the food, cosmetics and pharmaceutical industries. In this study, transcriptome sequencing technology was applied to analyze the changes in gene expression levels during the synthesis of L-serine in Escherichia coli fermentation. The optimal carbon–nitrogen ratio for L-serine synthesis in E. coli was determined by setting five carbon–nitrogen ratios for shake flask fermentation. Transcriptome sequencing was performed on E. coli fermented in five carbon–nitrogen ratio medium in which a total of 791 differentially expressed genes (DEGs) were identified in the CZ4_vs_CZ1 group, including 212 upregulated genes and 579 downregulated genes. Gene Ontology (GO) and Kyoto Encyclopedia of Genes and Genomes (KEGG) enrichment analysis of these DEGs showed that the effect of an altered carbon–nitrogen ratio on the fermentability of E. coli was mainly focused on metabolic pathways such as GABAergic synapse and the two-component system (TCS) in which the genes playing key roles were mainly gadB, gadA, glsA, glnA, narH and narJ. In summary, these potential key metabolic pathways and key genes were proposed to provide valuable information for improving glucose conversion during E. coli fermentation.
Collapse
Affiliation(s)
- Zheng Chen
- School of Health Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China; (Z.C.); (P.Z.)
- Lab of Biorefinery, Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai 201210, China; (X.C.); (Q.L.)
| | - Xiaojia Chen
- Lab of Biorefinery, Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai 201210, China; (X.C.); (Q.L.)
| | - Qinyu Li
- Lab of Biorefinery, Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai 201210, China; (X.C.); (Q.L.)
| | - Peng Zhou
- School of Health Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China; (Z.C.); (P.Z.)
- Lab of Biorefinery, Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai 201210, China; (X.C.); (Q.L.)
| | - Zhijun Zhao
- Lab of Biorefinery, Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai 201210, China; (X.C.); (Q.L.)
- Correspondence: (Z.Z.); (B.L.)
| | - Baoguo Li
- School of Health Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China; (Z.C.); (P.Z.)
- Correspondence: (Z.Z.); (B.L.)
| |
Collapse
|