Determination of Fusarium mycotoxins beauvericin and enniatins (A, A1, B, B1) in eggs of laying hens using liquid chromatography–tandem mass spectrometry (LC–MS/MS)

Emerging mycotoxin occurrence in chicken feed and eggs from Algeria

Poultry farming has developed into one of Algeria's most productive industrial farming because of the growing demand for sources of protein among Algerian society. Laying hen feed consists mainly of cereals, which can be contaminated with molds and subsequently with their secondary metabolites known as mycotoxins. These later can pose a serious danger to the production and quality of eggs in the commercial layer industry. This work focuses on the detection of emerging mycotoxins, mainly enniatins (ENNs) and beauvericin (BEA), in poultry feed and eggs from different locations in Algeria. Two different QuEChERS-based extractions were established to extract ENNs and BEA from chicken feed and eggs. The determination of mycotoxin occurrence was achieved by a UHPLC-MS/MS method using 0.1% (v/v) formic acid in water and MeOH as mobile phase, an ESI interface operating in positive mode, and a triple quadrupole mass spectrometer operating in MRM for the detection. Matrix-matched calibration curves were carried out for both matrices, obtaining good linearity (R2 > 0.99). The method performance was assessed in terms of extraction recovery (from 87 to 107%), matrix effect (from - 47 to - 86%), precision (RSD < 15%), and limits of quantitation (≤ 1.1 µg/kg for feed and ≤ 0.8 µg/kg for eggs). The analysis of 10 chicken feed samples and 35 egg samples composed of a 10-egg pool each showed that ENN B1 was the most common mycotoxin (i.e., found in 9 feed samples) with contamination levels ranging from 3.6 to 41.5 µg/kg, while BEA was detected only in one feed sample (12 µg/kg). However, eggs were not found to be contaminated with any mycotoxin at the detection limit levels. Our findings indicate that the searched mycotoxins are present in traces in feed and absent in eggs. This can be explained by the application of a mycotoxin binder. However, this does not put a stop on the conduction of additional research and ultimately setting regulations to prevent the occurrence of emerging mycotoxins.

Simultaneous determination of 17 regulated and non-regulated Fusarium mycotoxins co-occurring in foodstuffs by UPLC-MS/MS with solid-phase extraction

Fusarium species produce numerous mycotoxins known to co-occur in food. While some of these mycotoxins (e.g., deoxynivalenol, fumonisins) are regulated in several countries, others are non-regulated (e.g., nivalenol, beauvericin). In this study, UPLC-MS/MS with solid-phase extraction cleanup was used to determine 17 Fusarium mycotoxins (FTs) simultaneously. The method showed excellent performance in terms of linearity (R2 > 0.99), LOD (<1.2 μg/kg), LOQ (<3.6 μg/kg), accuracy (70.0-116.3 %), repeatability (<15.7 %), reproducibility (<25.3 %), and expanded uncertainty (<41.7 %). The validated method was successfully applied to 198 marketed food samples collected in South Korea. Of the tested samples, 79 % were contaminated with at least one FT. Job's tears showed the highest prevalence of 14 FTs, and sorghum had the highest total FTs level (3.03 mg/kg). The results suggest that this method can be used for the simultaneous analysis of 17 FTs in food samples, which would serve as crucial information for risk management.

Enniatin B1: Emerging Mycotoxin and Emerging Issues

Although over the last 10 years several studies have focused on the emerging mycotoxins known as enniatins (ENNs), there is still a lack of knowledge regarding their toxicological effects and the development of a correct risk assessment. This is especially true for enniatin B1 (ENN B1), considered the younger sister of the widely studied enniatin B (ENN B). ENN B1 has been found in several food commodities and, as with other mycotoxins, presents antibacterial and antifungal properties. On the other hand, ENN B1 has shown cytotoxic activity, impairment of the cell cycle, the induction of oxidative stress, and changes in mitochondrial membrane permeabilization, as well as negative genotoxic and estrogenic effects. Overall, considering the paucity of information available regarding ENN B1, further studies are necessary to perform a risk assessment. This review summarizes information on the biological characteristics and toxicological effects of ENN B1 as well as the future challenges that this mycotoxin could present.

Survey of the enniatins and beauvericin in raw and UHT cow's milk in Poland

Introduction

The enniatins A, A1, B and B1 (ENNs) and beauvericin (BEA) are structurally related compounds produced by Fusarium species. They occur as contaminants in cereals, such as wheat, barley and maize. They are called "emerging mycotoxins", because they have been reported in feed and food and their toxic effects are not fully known. Data on their levels in food (especially in milk) are limited. The study aimed to evaluate the occurrence of ENNs and BEA in milk.

Material and Methods

A total of 103 bovine milk samples (76 of raw milk and 27 of UHT milk) were collected from different parts of Poland and analysed using liquid chromatography-tandem mass spectrometry.

Results

Among the 76 raw milk samples, 31 (41%) and 15 (20%) samples were contaminated with ENN B and with BEA, respectively. No contamination with other enniatins was found. The highest concentration of BEA was found in raw milk and was 6.17 μg kg-1. Out of the 27 samples of UHT milk, 16 (59%) were contaminated with ENN B at concentrations ranging from 0.157 μg kg-1 to 0.587 μg kg-1 (limit of quantification (LOQ) 0.098 μg kg-1). Beauvericin was detected in 9 UHT milk samples (33%) at concentrations ranging from 0.101 μg kg-1 to 1.934 μg kg-1 (LOQ 0.095 μg kg-1).

Conclusion

This study demonstrated constant but low milk contamination in Poland with ENN B and BEA. The analysis of milk samples revealed that the emerging mycotoxins ENN B and BEA were measured in trace amounts. It does not suggest any immediate risk to milk consumers; however, it is unknown whether long-term exposure to low levels of toxins may be harmful.

Cytochrome P450 isoforms contribution, plasma protein binding, toxicokinetics of enniatin A in rats and in vivo clearance prediction in humans

Emerging mycotoxins, such as enniatin A (ENNA), are becoming a worldwide concern owing to their presence in different types of food and feed. However, comprehensive toxicokinetic data that links intake, exposure and toxicological effects of ENNA has not been elucidated yet. Therefore, the present study investigated the in vitro (rat and human) and in vivo (rat) toxicokinetic properties of ENNA. Towards this, an easily applicable and sensitive bioanalytical method was developed and validated for the estimation of ENNA in rat plasma. ENNA exhibited high plasma protein binding (99%), high hepatic clearance and mainly underwent metabolism via CYP3A4 (74%). The in-house predicted hepatic clearance (54 mL/min/kg) and observed in vivo rat clearance (55 mL/min/kg) were comparable. The predicted in vivo human hepatic clearance was 18 mL/min/kg. ENNA underwent slow absorption (T_max = 4 h) and rapid elimination following oral administration to rats. The absolute oral bioavailability was 47%. The toxicokinetic findings for ENNA from this study will help in designing and interpreting toxicological studies in rats. Besides, these findings could be used in physiologically based toxicokinetic (PBTK) model development for exposure predictions and risk assessment for ENNA in humans.

[Simultaneous determination of beauvericin and four enniatins in eggs by ultra-performance liquid chromatography-tandem mass spectrometry coupled with cold-induced liquid-liquid extraction and dispersive solid phase extraction]

新型生物毒素白僵菌素(BEA)和恩镰孢菌素(ENNs)是由镰刀菌种产生的有毒代谢产物,主要污染谷物及其制品,会威胁人类健康,因此受到人们越来越多的关注。该工作建立了冷诱导液液萃取-分散固相萃取净化-超高效液相色谱-串联质谱法(CI-LLE-DSPE-UPLC-MS/MS)同时测定鸡蛋中白僵菌素和4种恩镰孢菌素残留的分析方法。以乙腈-水-乙酸(79:20:1, v/v/v)为提取溶剂,采用冷诱导液液萃取与分散固相萃取净化相结合的方法进行样品处理,同时,对影响待测物提取与净化效率的提取溶剂、冷冻萃取温度与时间、净化剂用量等因素和色谱条件进行了优化。样品经20 mL提取液涡旋提取20 min,放入-40 ℃冰箱静置30 min后,取2 mL上层溶液经70 mg C18粉末净化,离心,上清液于40 ℃浓缩至近干,残留物用1 mL 80%(v/v)乙腈水溶液溶解,进样分析。以乙腈与5 mmol/L甲酸铵溶液作为流动相进行梯度洗脱,经ACQUITY UPLC BEH C18色谱柱(100 mm×2.1 mm, 1.7 μm)分离,采用ESI⁺电离,在多反应监测模式下采集,白僵菌素采用稳定同位素内标法定量,4种恩镰孢菌素采用基质匹配曲线外标法定量。结果表明,5种待测物在0.1~50.0 μg/L范围内线性关系良好,相关系数(r²)为0.9983~0.9997,该方法的检出限(LOD)为0.05~0.15 μg/kg,定量限(LOQ)为0.20~0.50 μg/kg。以阴性鸡蛋样品为基质,在低、中、高3个浓度水平(0.5、5.0、25.0 μg/kg)下进行加标试验考察方法的准确度与精密度,各待测物的平均回收率为81.1%~106%,相对标准偏差(RSD)为0.27%~9.79%。采用所建立的方法对农村散养鸡蛋与市售鸡蛋进行检测,结果表明,BEA在散养鸡蛋的检出率为30.4%, 4种ENNs均未被检出。该方法灵敏度高,稳定性好,回收率高,定量准确,简单易操作,适用于禽蛋食品中白僵菌素与恩镰孢菌素的同时快速测定。

A global systematic review and meta-analysis of concentration and prevalence of mycotoxins in birds' egg

In the current study, the concentration and prevalence of birds' egg's mycotoxins among 11 articles (66 studies) based on countries, part of eggs, and type of mycotoxins subgroups were meta-analyses using a random-effect model. The order of mycotoxin according to concentration of mycotoxin was Deoxynivalenol (20.083 μg/kg) > Zearalenone (2.065 μg/kg) > Enniatin (1.120 μg/kg) > Total aflatoxin (0.371 μg/kg) > Beauvericin (0.223 μg/kg) > Ochratoxins (0.087 μg/kg) > Citrinin (0.010 μg/kg). Further, the mycotoxins' concentration in the yolk part (2.070 μg/kg) was higher than the mixed eggs (0.283 μg/kg). The rank order of mycotoxin based on country was China (14.990 μg/kg) > Cameroon (7.594 μg/kg) > Thailand (1.870 μg/kg) > Finland (0.920 μg/kg) > Iran (0.312 μg/kg) > Jordan (0.202 μg/kg) > Belgium (0.183 μg/kg) > Spain ( South Korea ( DON (85.00%) > AFT (20.15%) > OT (16.00%). The overall prevalence of mycotoxin was equal to 29.65%. Also, the concentration of mycotoxins in China and Cameroon was higher than in other countries. Therefore, the monitoring programs to reduce mycotoxins in bird eggs consumed in some countries such as China and Cameroon should be considered.

Pilot Study: Does Contamination with Enniatin B and Beauvericin Affect the Antioxidant Capacity of Cereals Commonly Used in Animal Feeding?

Increasing consumption of cereals has been associated with reduced risk of several chronic diseases, as they contain phytochemicals that combat oxidative stress. Cereal contamination by the "emerging mycotoxins" beauvericin (BEA) and enniatins (ENs) is a worldwide health problem that has not yet received adequate scientific attention. Their presence in feeds represents a risk for animals and a potential risk for humans because of their carry-over to animal-derived products. This preliminary study aimed to investigate if the total antioxidant capacity (TAC) of corn, barley, and wheat flours could be influenced by contamination with increasing levels of BEA and ENN B. The highest TAC value was observed in barley compared with wheat and corn (p < 0.001) before and after contamination. No effect of mycotoxin or mycotoxin level was found, whereas cereal x mycotoxin exhibited a significant effect (p < 0.001), showing a lower TAC value in wheat contaminated by ENN B and in barley contaminated by BEA. In conclusion, barley is confirmed as a source of natural antioxidants with antiradical potentials. Additional studies with a larger sample size are necessary to confirm the obtained results, and investigations of the toxic effects of these emergent mycotoxins on animals and humans should be deepened.

Feedborne Mycotoxins Beauvericin and Enniatins and Livestock Animals

Mycotoxins are secondary metabolites produced by several species of fungi, including the Fusarium, Aspergillus, and Penicillium species. Currently, more than 300 structurally diverse mycotoxins are known, including a group called minor mycotoxins, namely enniatins, beauvericin, and fusaproliferin. Beauvericin and enniatins possess a variety of biological activities. Their antimicrobial, antibiotic, or ionoforic activities have been proven and according to various bioassays, they are believed to be toxic. They are mainly found in cereal grains and their products, but they have also been detected in forage feedstuff. Mycotoxins in feedstuffs of livestock animals are of dual concern. First one relates to the safety of animal-derived food. Based on the available data, the carry-over of minor mycotoxins from feed to edible animal tissues is possible. The second concern relates to detrimental effects of mycotoxins on animal health and performance. This review aims to summarize current knowledge on the relation of minor mycotoxins to livestock animals.

Beauvericin and Enniatins: In Vitro Intestinal Effects

Food and feed contamination by emerging mycotoxins beauvericin and enniatins is a worldwide health problem and a matter of great concern nowadays, and data on their toxicological behavior are still scarce. As ingestion is the major route of exposure to mycotoxins in food and feed, the gastrointestinal tract represents the first barrier encountered by these natural contaminants and the first structure that could be affected by their potential detrimental effects. In order to perform a complete and reliable toxicological evaluation, this fundamental site cannot be disregarded. Several in vitro intestinal models able to recreate the different traits of the intestinal environment have been applied to investigate the various aspects related to the intestinal toxicity of emerging mycotoxins. This review aims to depict an overall and comprehensive representation of the in vitro intestinal effects of beauvericin and enniatins in humans from a species-specific perspective. Moreover, information on the occurrence in food and feed and notions on the regulatory aspects will be provided.

Carry-over of some Fusarium mycotoxins in tissues and eggs of chickens fed experimentally mycotoxin-contaminated diets

Fusarium mycotoxins are fungal contaminants found in different crops intended for human and animal consumption. Due to the co-occurrence of several of mycotoxins, the present study aimed at examining the transfer of these toxins into tissues of broiler chickens and eggs of laying hens fed contaminated diets. After an adaptation period, the chickens were fed contaminated diets containing mg/kg levels of deoxynivalenol (DON), enniatins (ENN A, A₁, B, B₁) and beauvericin (BEA) and high μg/kg levels of HT-2 toxin (HT-2), T-2 toxin (T-2) and zearalenone (ZEN) during a repletion period of two weeks, followed by a depletion period of two weeks. DON, ZEN, T-2 and HT-2 were not carried out into the skin and the liver of broiler chickens. ENN B (20.5 ± 6.6 μg/kg) and BEA (162 ± 55 μg/kg) were found in the liver, while in the skin their respective concentrations were 50 ± 17 μg/kg and 120 ± 16 μg/kg during the first week of the repletion period. Carry-over rates into liver and skin were higher for BEA (1.6% and 1.2%, respectively) than for ENNs (0.1 and 0.4%, respectively). During the depletion period, ENNs and BEA were eliminated from the skin and the liver. ENN B, ENN B₁ and BEA were carried over into eggs at 0.1%, 0.05% and 0.44% upon 2-3 days of feeding the contaminated diet, respectively. These transfers were fully eliminated 9-10 days after feeding the control diet again. These results indicate the transfer of ENN B, ENN B₁ and BEA from feed to chicken offal, meat products and eggs at a very low degree, thus marginally contribute to the total dietary intake of these fusariotoxins for consumers. Nevertheless, taking precautionary measures in the field, harvest, transport and storage of the raw materials is required to keep the mycotoxin concentration in feed below the safe levels.

Biomonitoring of Enniatin B1 and Its Phase I Metabolites in Human Urine: First Large-Scale Study

Enniatins (Enns) are mycotoxins produced by Fusarium spp. which are a fungus widely spread throughout cereals and cereal-based products. Among all the identified enniatins, Enn B1 stands as one of the most prevalent analogues in cereals in Europe. Hence, the aim of this study was to evaluate for the first time the presence of Enn B1 and its phase I metabolites in 300 human urine samples using an ultrahigh-performance liquid chromatography high resolution mass spectrometry (UHPLC-Q-Orbitrap HRMS) methodology. Enn B1 was detected in 94.3% of samples ranging from 0.007 to 0.429 ng/mL (mean value: 0.065 ng/mL). In accordance with previous in vitro and in vivo analysis, hydroxylated metabolites (78.0% samples) and carbonylated metabolites (66.0% samples) were tentatively identified as the major products. Results from this biomonitoring study point to a frequent intake of Enn B1 in the studied population, suggesting that in-depth toxicological studies are needed in order to understand the potential effects in humans.

Removal of Small Kernels Reduces the Content of Fusarium Mycotoxins in Oat Grain

Cereal grain contaminated by Fusarium mycotoxins is undesirable in food and feed because of the harmful health effects of the mycotoxins in humans and animals. Reduction of mycotoxin content in grain by cleaning and size sorting has mainly been studied in wheat. We investigated whether the removal of small kernels by size sorting could be a method to reduce the content of mycotoxins in oat grain. Samples from 24 Norwegian mycotoxin-contaminated grain lots (14 from 2015 and 10 from 2018) were sorted by a laboratory sieve (sieve size 2.2 mm) into large and small kernel fractions and, in addition to unsorted grain samples, analyzed with LC-MS-MS for quantification of 10 mycotoxins. By removing the small kernel fraction (on average 15% and 21% of the weight of the samples from the two years, respectively), the mean concentrations of HT-2+T-2 toxins were reduced by 56% (from 745 to 328 µg/kg) in the 2015 samples and by 32% (from 178 to 121 µg/kg) in the 2018 samples. Deoxynivalenol (DON) was reduced by 24% (from 191 to 145 µg/kg) in the 2018 samples, and enniatin B (EnnB) by 44% (from 1059 to 594 µg/kg) in the 2015 samples. Despite low levels, our analyses showed a trend towards reduced content of DON, ADON, NIV, EnnA, EnnA1, EnnB1 and BEA after removing the small kernel fraction in samples from 2015. For several of the mycotoxins, the concentrations were considerably higher in the small kernel fraction compared to unsorted grain. Our results demonstrate that the level of mycotoxins in unprocessed oat grain can be reduced by removing small kernels. We assume that our study is the first report on the effect of size sorting on the content of enniatins (Enns), NIV and BEA in oat grains.

Risk assessment for mycotoxin contamination in fish feeds in Europe

Mycotoxins are difficult to monitor continuously, and a tool to assess the risk would help to judge if there is a particular risk due to the inclusion of certain feed ingredients. For this, the toxin contents of 97 commercial fish feeds have been estimated, and the most prominent toxins in fish feed are calculated to be deoxynivalenol, zearalenone, fumonisins and enniatins. These pose a risk to fish well-being, as can be calculated by the Bayesian models for determining the critical concentrations 5% (CC5) for the different toxins. Besides fishmeal, wheat, soybean products and corn are regularly used as fish feed ingredients. The calculated scenarios show that fish are at high risk of toxin contamination if feed ingredients of low quality are chosen for feed production. Due to this, specific maximum allowable levels for several mycotoxins in fish feeds should be established.

Multimycotoxin Determination in Tunisian Farm Animal Feed

Mycotoxins presence was evaluated in animal feed marketed in Tunisia for the first time ever. A QuEChERS method was performed to analyze the natural copresence of 22 mycotoxins (enniatins, beauvericin, ochratoxin A, aflatoxins, alternariol monomethyl ether, alternariol, tentoxin, zearalenone, deoxynivalenol, 3-acetyldeoxynivalenol, 15-acetyldeoxynivalenol, nivalenol, neosolaniol, diacetoxyscirpenol, T-2 toxin, and HT-2 toxin) in 122 Tunisian marketed feed samples, intended for poultry (n = 43), cattle (n = 35), rabbit (n = 12), sheep (n = 16), and horse (n = 16). Analytes detection and quantification were done using both liquid chromatography and gas chromatography coupled to tandem mass spectrometry. The analytical method showed good linearity (R > 0.996) and sensitivity, the limits of quantification ranged from 0.1 ng/g (enniatin A1) to 225 ng/g (3-acetyldeoxynivalenol). Eighty-five percent of the analyzed samples were positive. Poultry (n = 43) and rabbit (n = 12) feed samples were the most contaminated. Enniatin B was the most prevalent mycotoxin with values ranged between 0.5 ng/g for horse feed and 40 ng/g for poultry feed, followed by deoxynivalenol detected from 16 ng/g in cattle feed to 250 ng/g in poultry feed. None exceeded the limits set by EU recommendations for animal feed. Mycotoxins co-occurrence was observed at most by five different mycotoxins (26%) and up to eight mycotoxins was recorded in 5% of samples. Furthermore, a relatively high copresence rate of different fusariotoxins was registered. Even if no toxicological concern was clearly revealed, the contamination is a real fact and will probably present influence on meat production and on food safety.

Development and Validation of a Liquid Chromatography High-Resolution Mass Spectrometry Method for the Simultaneous Determination of Mycotoxins and Phytoestrogens in Plant-Based Fish Feed and Exposed Fish

New protein sources in fish feed require the assessment of the carry-over potential of contaminants and anti-nutrients from feed ingredients into the fish, and the assessment of possible health risks for consumers. Presently, plant materials including wheat and legumes make up the largest part of aquafeeds, so evaluation of the transfer capabilities of typical toxic metabolites from plant-infesting fungi and of vegetable phytoestrogens into fish products is of great importance. With the aim of facilitating surveillance of relevant mycotoxins and isoflavones, we have developed and validated a multi-analyte LC-HRMS/MS method that can be used to ensure compliance to set maximum levels in feed and fish. The method performance characteristics were determined, showing high specificity for all 25 targeted analytes, which included 19 mycotoxins and three isoflavones and their corresponding aglycons with sufficient to excellent sensitivities and uniform analytical linearity in different matrices. Depending on the availability of matching stable isotope-labelled derivates or similar-structure homologues, calibration curves were generated either by using internal standards or by matrix-matched external standards. Precision and recovery data were in the accepted range, although they varied between the different analytes. This new method was considered as fit-for-purpose and applied for the analysis of customised fish feed containing wheat gluten, soy, or pea protein concentrate as well as salmon and zebrafish fed on diets with these ingredients for a period of up to eight weeks. Only mycotoxin enniatin B, at a level near the limit of detection, and low levels of isoflavones were detected in the feed, demonstrating the effectiveness of maximum level recommendations and modern feed processing technologies in the Norwegian aquaculture industry. Consequently, carry-over into fish muscle was not observed, confirming that fillets from plant-fed salmon were safe for human consumption.

Development of Sensitive and Reliable UPLC-MS/MS Methods for Food Analysis of Emerging Mycotoxins in China Total Diet Study

With the climatic changes that have taken place during the last decade, the spectrum of fungal pathogens as well as mycotoxins has considerably changed. As a result, some emerging mycotoxins have been shown to occur frequently in agricultural products. In this study, a sensitive and reliable method for the determination of 10 emerging mycotoxins (beauvericin, enniatin A, enniatin A1, enniatin B, enniatin B1, alternariol, alternariol monomethyl ether, altenuene, tentoxin, and tenuazonic acid) in 12 different food matrices (cereals, legumes, potatoes, meats, eggs, aquatic foods, dairy products, vegetables, fruits, sugars, beverages, and alcohol beverages) was developed and validated. After a simple extraction, a one-step sample clean-up by a HLB solid phase extraction (SPE) column was sufficient for all 12 food matrices prior to analysis with ultra-high performance liquid chromatography coupled to tandem mass spectrometry (UPLC-MS/MS). Isotope internal standards 13C-TeA, TEN-d₃, and 13C-AFB2 were used for accurate quantification. Validation in terms of linearity, selectivity, sensitivity, accuracy, and precision (intra and inter-day variability) were evaluated for the 10 mycotoxins in all selected matrices. The sensitivity varied from 0.0004 to 0.3 ng mL-1 (limits of detection) and from 0.002 to 0.9 ng mL-1 (limits of quantitation). The recoveries of 10 mycotoxins in fortified samples were from 60.6% to 164% including very low spiking levels in all 12 food matrices, with relative standard deviations (RSDs) less than 12%. The proposed methodology was applied to the analysis of 60 samples collected from five provinces within the 6th China Total Diet Study with the results discussed in detail. The advantages of sensitivity, accuracy, and robustness made it a powerful tool for emerging mycotoxin monitoring and dietary exposure assessment.

Chronic Dietary Intake of Enniatin B in Broiler Chickens Has Low Impact on Intestinal Morphometry and Hepatic Histology, and Shows Limited Transfer to Liver Tissue

The Fusarium mycotoxin enniatin B (ENN B) is a so-called emerging mycotoxin frequently contaminating poultry feed. To investigate the impact of chronic ENN B exposure on animal health, broiler chickens were fed either a diet naturally contaminated with ENN B (2352 µg/kg) or a control diet (135 µg/kg) for 2, 7, 14, or 21 days. ENN B concentrations were determined in plasma and liver using a validated ultra-high performance liquid chromatography—tandem mass spectrometry UHPLC-MS/MS method. Liver was evaluated histologically, and the villus length and crypt depth of the duodenum, jejunum, and ileum were measured. Histopathology of the livers did not reveal major abnormalities. Feeding an ENN B-contaminated diet could possibly inhibit the proliferation of enterocytes in the duodenal crypts, but did not affect villus length, crypt depth, or villus length-crypt depth ratio of the jejunum and ileum. ENN B levels in plasma and liver were significantly higher in the ENN B-fed group and ranged between <25–264 pg/mL and <0.05–0.85 ng/g, respectively. ENN B carry-over rates from feed to liver tissue were 0.005–0.014% and 0.034–0.109% in the ENN B and control group, respectively. Carry-over rates were low and indicated a limited contribution of poultry tissue-derived products to the total dietary ENN B intake for humans. The above results support the opinion of the European Food Safety Authority stating that adverse health effects from ENN B in broiler chickens are unlikely.

In vitro mechanisms of Beauvericin toxicity: A review

Beauvericin (BEA) is a mycotoxin produced by many species of fungus Fusarium and by Beauveria bassiana; BEA is a natural contaminant of cereals and cereals based products and possesses a wide variety of biological properties. The mechanism of action seems to be related to its ionophoric activity, that increases ion permeability in biological membranes. As a consequence, BEA causes cytotoxicity in several cell lines and is capable to produce oxidative stress at molecular level. Moreover, BEA is genotoxic (produces DNA fragmentation, chromosomal aberrations and micronucleus) and causes apoptosis with the involvement of mitochondrial pathway. However, several antioxidant mechanisms protect cells against oxidative stress produced by BEA. Despite its strong cytotoxicity, no risk assessment have been still carried out by authorities due to a lack of toxicity data, so research on BEA toxicological impact is still going on. This review reports information available regarding BEA mechanistic toxicology with the aim of updating information regarding last researches on this mycotoxin.

Emerging Mycotoxins: Beyond Traditionally Determined Food Contaminants

Modern analytical techniques can determine a multitude of fungal metabolites contaminating food and feed. In addition to known mycotoxins, for which maximum levels in food are enforced, also currently unregulated, so-called "emerging mycotoxins" were shown to occur frequently in agricultural products. The aim of this review is to critically discuss the relevance of selected emerging mycotoxins to food and feed safety. Acute and chronic toxicity as well as occurrence data are presented for enniatins, beauvericin, moniliformin, fusaproliferin, fusaric acid, culmorin, butenolide, sterigmatocystin, emodin, mycophenolic acid, alternariol, alternariol monomethyl ether, and tenuazonic acid. By far not all of the detected compounds are toxicologically relevant at their naturally occurring levels and are therefore of little or no health concern to consumers. Still, gaps in knowledge have been identified for several compounds. These gaps should be closed by the scientific community in the coming years to allow a proper risk assessment.

Emerging Fusarium and Alternaria Mycotoxins: Occurrence, Toxicity and Toxicokinetics

Emerging Fusarium and Alternaria mycotoxins gain more and more interest due to their frequent contamination of food and feed, although in vivo toxicity and toxicokinetic data are limited. Whereas the Fusarium mycotoxins beauvericin, moniliformin and enniatins particularly contaminate grain and grain-based products, Alternaria mycotoxins are also detected in fruits, vegetables and wines. Although contamination levels are usually low (µg/kg range), higher contamination levels of enniatins and tenuazonic acid may occasionally occur. In vitro studies suggest genotoxic effects of enniatins A, A1 and B1, beauvericin, moniliformin, alternariol, alternariol monomethyl ether, altertoxins and stemphyltoxin-III. Furthermore, in vitro studies suggest immunomodulating effects of most emerging toxins and a reproductive health hazard of alternariol, beauvericin and enniatin B. More in vivo toxicity data on the individual and combined effects of these contaminants on reproductive and immune system in both humans and animals is needed to update the risk evaluation by the European Food Safety Authority. Taking into account new occurrence data for tenuazonic acid, the complete oral bioavailability, the low total body clearance in pigs and broiler chickens and the limited toxicity data, a health risk cannot be completely excluded. Besides, some less known Alternaria toxins, especially the genotoxic altertoxins and stemphyltoxin III, should be incorporated in risk evaluation as well.

Mitigation of enniatins in edible fish tissues by thermal processes and identification of degradation products

Emerging mycotoxins, such as enniatins and beauvericin, are common contaminants in vegetal matrices, but recently, the occurrence of mycotoxins in foodstuffs from animal origin has been also reported as they can be present in edible tissues of animals fed with contaminated feedstuffs. Sea bass, sea bream, Atlantic salmon and rainbow trout from aquaculture analyzed in the present survey showed contamination by emerging Fusarium mycotoxins enniatins (ENs). ENs were extracted from raw and cooked fish with acetonitrile and analyzed by Liquid Chromatography coupled to Mass Spectrometry. In this study, the stability of ENs was evaluated during food processing by the application of different cooking methods (broiling, boiling, microwaving and baking treatments). All treated samples showed a reduction in mycotoxin levels with different percentages depending on the type of EN and the fish species. Thus, the reduction obtained ranged from 30 to 100%. The thermal treatments have shown to be a good strategy to mitigate ENs content in edible fish tissues. On the other hand, some ENs degradation products originated during the application of thermal treatments were identified.

Development and validation of ultra-high-performance liquid chromatography-tandem mass spectrometry methods for the simultaneous determination of beauvericin, enniatins (A, A1, B, B1) and cereulide in maize, wheat, pasta and rice

Rapid and accurate UPLC-MS/MS methods for the simultaneous determination of beauvericin and the related enniatins (A, A1, B, B1), together with cereulide were successfully developed and validated in cereal and cereal-based food matrices such as wheat, maize, rice and pasta. Although these emerging foodborne toxins are of different microbial origin, the similar structural, toxicological and food safety features provided rationale for their concurrent detection in relevant food matrices. A Waters Acquity UPLC system coupled to a Waters Quattro Premier XE™ Mass Spectrometer operating in ESI+ mode was employed. Sample pretreatment involved a fast and simple liquid extraction of the target toxins without any further clean-up step. For all toxins the sample preparation resulted in acceptable extraction recoveries with values of 85-105% for wheat, 87-106% for maize, 84-106% for rice and 85-105% for pasta. The efficient extraction protocol, together with a fast chromatographic separation of 7min allowed substantial saving costs and time showing its robustness and performance. The validation of the developed method was performed based on Commission Decision 2002/657/EC. The obtained limits of detection ranged from 0.1 to 1.0μgkg^-1 and the limits of quantification from 0.3 to 2.9μgkg^-1 for the targeted toxins in the selected matrices. The obtained sensitivities allow detection of relevant toxicological concentrations. All relative standard deviations for repeatability (intra-day) and intermediate precision (inter-day) were lower than 20%. Trueness, expressed as the apparent recovery varied from 80 to 107%. The highly sensitive and repeatable validated method was applied to 57 naturally contaminated samples allowing detection of sub-clinical doses of the toxins.

Comparative Oral Bioavailability, Toxicokinetics, and Biotransformation of Enniatin B1 and Enniatin B in Broiler Chickens

A toxicokinetic study of the Fusarium mycotoxins enniatin B1 (ENN B1) and enniatin B (ENN B) was performed in broiler chickens. Each animal received ENN B1 or B orally via an intracrop bolus and intravenously at a dose of 0.2 mg/kg body weight. Both enniatins were poorly absorbed after oral administration, with absolute oral bioavailabilities of 0.05 and 0.11 for ENNs B1 and B, respectively. Both enniatins were readily distributed to the tissues, with mean volumes of distribution of 25.09 and 33.91 L/kg for ENNs B1 and B, respectively. The mean total body clearance was rather high, namely, 6.63 and 7.10 L/h/kg for ENNs B1 and B, respectively. Finally, an UHPLC-HRMS targeted approach was used to investigate the phase I and II biotransformations of both mycotoxins. Oxygenation was the major phase I biotransformation pathway for both ENNs B1 and B. Neither glucuronide nor sulfate phase II metabolites were detected.

Fusarium mycotoxin enniatin B: Cytotoxic effects and changes in gene expression profile

The mycotoxin enniatin B, a cyclic hexadepsipeptide produced by the plant pathogen Fusarium, is prevalent in grains and grain-based products in different geographical areas. Although enniatins have not been associated with toxic outbreaks, they have caused toxicity in vitro in several cell lines. In this study, the cytotoxic effects of enniatin B were assessed in relation to cellular energy metabolism, cell proliferation, and the induction of apoptosis in Balb 3T3 and HepG2 cells. The mechanism of toxicity was examined by means of whole genome expression profiling of exposed rat primary hepatocytes. Enniatin B altered cellular energy metabolism and reduced cell proliferation in Balb 3T3 and HepG2 cell lines. Furthermore, the proportion of apoptotic cell populations of Balb 3T3 cells slightly increased. On the other hand, enniatin B caused necrotic cell death in primary hepatocytes. Gene expression studies revealed the alteration of energy metabolism due to effects on mitochondrial organization and function and the assembly of complex I of the electron transport chain.

Human skin permeation of emerging mycotoxins (beauvericin and enniatins)

Currently, dermal exposure data of cyclic depsipeptide mycotoxins are completely absent. There is a lack of understanding about the local skin and systemic kinetics and effects, despite their widespread skin contact and intrinsic hazard. Therefore, we provide a quantitative characterisation of their dermal kinetics. The emerging mycotoxins enniatins (ENNs) and beauvericin (BEA) were used as model compounds and their transdermal kinetics were quantitatively evaluated, using intact and damaged human skin in an in vitro Franz diffusion cell set-up and ultra high-performance liquid chromatography (UHPLC)-MS analytics. We demonstrated that all investigated mycotoxins are able to penetrate through the skin. ENN B showed the highest permeation (kp,v=9.44 × 10(-6) cm/h), whereas BEA showed the lowest (kp,v=2.35 × 10(-6) cm/h) and the other ENNs ranging in between. Combining these values with experimentally determined solubility data, Jmax values ranging from 0.02 to 0.35 μg/(cm(2) h) for intact skin and from 0.07 to 1.11 μg/(cm(2) h) for damaged skin were obtained. These were used to determine the daily dermal exposure (DDE) in a worst-case scenario. On the other hand, DDE's for a typical occupational scenario were calculated based on real-life mycotoxin concentrations for the industrial exposure of food-related workers. In the latter case, for contact with intact human skin, DDE's up to 0.0870 ng/(kg BW × day) for ENN A were calculated, whereas for impaired skin barrier this can even rise up to 0.3209 ng/(kg BW × day) for ENN B1. This knowledge is needed for the risk assessment after skin exposure of contaminated food, feed, indoor surfaces and airborne particles with mycotoxins.

Risks of Mycotoxins from Mycoinsecticides to Humans

There are more than thirty mycotoxins produced by fungal entomopathogens. Totally, they belong to two classes, NRP and PK mycotoxins. Most of mycotoxins have not been paid sufficient attention yet. Generally, mycotoxins do not exist in mycoinsecticide and might not be released to environments unless entomogenous fungus proliferates and produces mycotoxins in host insects or probably in plants. Some mycotoxins, destruxins as an example, are decomposed in host insects before they, with the insect's cadavers together, are released to environments. Many species of fungal entomopathogens have the endophytic characteristics. But we do not know if fungal entomopathogens produce mycotoxins in plants and release them to environments. On the contrary, the same mycotoxins produced by phytopathogens such as Fusarium spp. and Aspergillus spp. have been paid enough concerns. In conclusion, mycotoxins from mycoinsecticides have limited ways to enter environments. The risks of mycotoxins from mycoinsecticides contaminating foods are controllable.

Sequence divergence of the enniatin synthase gene in relation to production of beauvericin and enniatins in Fusarium species

Beauvericin (BEA) and enniatins (ENNs) are cyclic peptide mycotoxins produced by a wide range of fungal species, including pathogenic Fusaria. Amounts of BEA and ENNs were quantified in individual rice cultures of 58 Fusarium strains belonging to 20 species, originating from different host plant species and different geographical localities. The species identification of all strains was done on the basis of the tef-1α gene sequence. The main aim of this study was to analyze the variability of the esyn1 gene encoding the enniatin synthase, the essential enzyme of this metabolic pathway, among the BEA- and ENNs-producing genotypes. The phylogenetic analysis based on the partial sequence of the esyn1 gene clearly discriminates species producing exclusively BEA from those synthesizing mainly enniatin analogues.

Biosynthesis of 15N3-labeled enniatins and beauvericin and their application to stable isotope dilution assays

The first stable isotope dilution assay for the determination of enniatins A, A1, B, and B1 and beauvericin was developed. The (15)N(3)-labeled enniatins and beauvericin were biosynthesized by feeding two Fusarium strains Na(15)NO(3) and subsequently isolated from the fungal culture. The chemical structures of the biosynthesized products were characterized by LC-MS/MS and (1)H NMR. Standard solutions of (15)N(3)-labeled beauvericin, enniatin A, and enniatin A1 were accurately quantitated by quantitative NMR. On the basis of the use of the labeled products as internal standards, stable isotope dilution assays were developed and applied to various food samples using LC-MS/MS. The sample extracts were directly injected without any tedious cleanup procedures. The limits of detection were 3.9, 2.6, 3.7, 1.9, and 4.4 μg/kg for enniatins A, A1, B, and B1 and beauvericin, respectively. Limits of quantitation were 11.5 (enniatin A), 7.6 (enniatin A1), 10.9 (enniatin B), 5.8 (enniatin B1), and 13.1 μg/kg (beauvericin). Recoveries were within the range between 90 and 120%, and good intraday and interday precisions with coefficients of variation between 1.35 and 8.61% were obtained. Thus, the stable isotope dilution assay presented here is similarly sensitive and precise but more accurate than assays reported before. Analyses of cereals and cereal products revealed frequent contaminations of barley, wheat, rye, and oats with enniatins B and B1, whereas beauvericin was not quantifiable.

Analysis of mycotoxins in barley using ultra high liquid chromatography high resolution mass spectrometry: comparison of efficiency and efficacy of different extraction procedures

The effectiveness of four extraction methods (modified QuEChERS, matrix solid-phase dispersion (MSPD), solid-liquid extraction (SLE) and solid-phase extraction (SPE) clean-up) were evaluated for simultaneous determination of 32 mycotoxins produced by the genus Fusarium, Claviceps, Aspergillus, Penicillium and Alternaria in barley by ultra high pressure liquid chromatography coupled to ultra-high resolution mass spectrometry (UHPLC-Orbitrap(®) MS). The efficiency and efficacy of extraction methods were evaluated and compared in number of extracted mycotoxins and obtained recoveries. From the one point of view, QuEChERS procedure was fast and easy, as well as it was able to successfully extract all selected mycotoxins. On the other hand, SLE method, MSPD and SPE clean-up method did not extract adequately all selected mycotoxins and recoveries were not suitable enough. Thereby, method employing QuEChERS extraction connected with UHPLC-Orbitrap(®) MS was developed to quantify 32 mycotoxins in barley within this study. Analytical method was validated and recoveries ranged from 72% to 101% for selected mycotoxins with only one exception nivalenol (NIV) and deoxynivalenol-3-glucoside (D3G), which were lower than 67%. Relative standard deviations (RSD) were lower than 17.4% for all target mycotoxins. The lowest calibration levels (LCLs) ranged from 1 to 100 μg/kg. Validated method was finally used for monitoring mycotoxins in a total of 15 Czech barley samples, when only Fusarium toxins representatives were detected in 53% of samples and the mycotoxins with the highest incidence were enniatins.

Multiclass mycotoxin analysis in food, environmental and biological matrices with chromatography/mass spectrometry

Mold metabolites that can elicit deleterious effects on other organisms are classified as mycotoxins. Human exposure to mycotoxins occurs mostly through the intake of contaminated agricultural products or residues due to carry over or metabolite products in foods of animal origin such as milk and eggs, but can also occur by dermal contact and inhalation. Mycotoxins contained in moldy foods, but also in damp interiors, can cause diseases in humans and animals. Nephropathy, various types of cancer, alimentary toxic aleukia, hepatic diseases, various hemorrhagic syndromes, and immune and neurological disorders are the most common diseases that can be related to mycotoxicosis. The absence or presence of mold infestation and its propagation are seldom correlated with mycotoxin presence. Mycotoxins must be determined directly, and suitable analytical methods are necessary. Hundreds of mycotoxins have been recognized, but only for a few of them, and in a restricted number of utilities, a maximum acceptable level has been regulated by law. However, mycotoxins seldom develop alone; more often various types and/or classes form in the same substrate. The co-occurrence might render the individual mycotoxin tolerance dose irrelevant, and therefore the mere presence of multiple mycotoxins should be considered a risk factor. The advantage of chromatography/mass spectrometry (MS) is that many compounds can be determined and confirmed in one analysis. This review illustrates the state-of-the-art of mycotoxin MS-based analytical methods for multiclass, multianalyte determination in all the matrices in which they appear. A chapter is devoted to the history of the long-standing coexistence and interaction among humans, domestic animals and mycotoxicosis, and the history of the discovery of mycotoxins. Quality assurance, although this topic relates to analytical chemistry in general, has been also examined for mycotoxin analysis as a preliminary to the systematic literature excursus. Sample handling is a crucial step to devise a multiclass analytical method; so when possible, it has been treated separately for a better comparison before tackling the instrumental part of the whole analytical method. This structure has resulted sometimes in unavoidable redundancies, because it was also important to underline the interconnection. Most reviews do not deal with all the possible mycotoxin sources, including the environmental ones. The focus of this review is the analytical methods based on MS for multimycotoxin class determination. Because the final purpose to devise multimycotoxin analysis should be the assessment of the danger to health of exposition to multitoxicants of natural origin (and possibly also the interaction with anthropogenic contaminants), therefore also the analytical methods for environmental relevant mycotoxins have been thoroughly reviewed. Finally, because the best way to shed light on actual risk assessment could be the individuation of exposure biomarkers, the review covers also the scarce literature on biological fluids.

Fusaproliferin, beauvericin and enniatins: occurrence in food – a review

The present review summarises data on the prevalence and concentration of fusaproliferin, beauvericin and enniatins in small grains, maize and processed grain-based foods. These fungal secondary metabolites possess interesting biological activities and are presently often referred to as 'emerging mycotoxins'. They have been considered as less important since they are likely not of acute toxicity. However, their high prevalence in foodstuffs, occasionally in higher mg/kg concentrations, warrants an assessment of their true importance for food (and feed) safety. Thorough surveys that determine the contamination of raw and processed foods with fusaproliferin, beauvericin and enniatins are still scarce and are generally limited to Northern Europe and the Mediterranean. The reported data suggest a connection between the observed concentrations and climate. The data further suggest that humans might be exposed continuously to low levels of enniatins as these compounds were of particularly high prevalence in the surveys. The highest concentrations of enniatins were reported from Spain and Northern Africa (maximum concentration of enniatin A1 814 mg/kg in rice from the Spanish market), while concentrations were significantly lower in Northern Europe (maximum concentration of enniatin B 18.3 mg/kg in wheat from Finland). Beauvericin appears to be of low significance in grains from cooler climates while it has been reported to occur at concentrations of tens of mg/ kg in Southern Europe and Morocco (maximum concentration 59 mg/kg in maize from Morocco). Fusaproliferin has been least investigated. Several reports from the Mediterranean show its occasional occurrence up to 19.6 mg/ kg in rice from Morocco, while its natural occurrence in cooler climates seems to be more rare.

Beauvericin production by the Lepidoptera pathogenic fungus Isaria tenuipes: Analysis of natural specimens, synnemata from cultivation, and mycelia from liquid-media fermentation

Beauvericin was analyzed in three forms of the Lepidoptra pathogenic fungus Isaria tenuipes (4 isolates): (a) natural specimen, (b) cultivated synnemata on rice media, and (c) mycelia from fermentation in liquid media. Beauvericin was detected in very low amounts in all tested natural specimens. Synnemata on rice contained much higher concentrations of beauvericin than the corresponding natural materials, although the concentrations were lower than mycelia from liquid fermentation. The results casted a caution that beauvericin concentration should be carefully checked, as a possible toxic constituent, upon mass production of a selected strain of Isaria tenuipes for health food purposes.