1
|
Palomar J, Lemus J, Navarro P, Moya C, Santiago R, Hospital-Benito D, Hernández E. Process Simulation and Optimization on Ionic Liquids. Chem Rev 2024; 124:1649-1737. [PMID: 38320111 PMCID: PMC10906004 DOI: 10.1021/acs.chemrev.3c00512] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/17/2023] [Revised: 11/16/2023] [Accepted: 01/10/2024] [Indexed: 02/08/2024]
Abstract
Ionic liquids (ILs) are promising alternative compounds that enable the development of technologies based on their unique properties as solvents or catalysts. These technologies require integrated product and process designs to select ILs with optimal process performances at an industrial scale to promote cost-effective and sustainable technologies. The digital era and multiscale research methodologies have changed the paradigm from experiment-oriented to hybrid experimental-computational developments guided by process engineering. This Review summarizes the relevant contributions (>300 research papers) of process simulations to advance IL-based technology developments by guiding experimental research efforts and enhancing industrial transferability. Robust simulation methodologies, mostly based on predictive COSMO-SAC/RS and UNIFAC models in Aspen Plus software, were applied to analyze key IL applications: physical and chemical CO2 capture, CO2 conversion, gas separation, liquid-liquid extraction, extractive distillation, refrigeration cycles, and biorefinery. The contributions concern the IL selection criteria, operational unit design, equipment sizing, technoeconomic and environmental analyses, and process optimization to promote the competitiveness of the proposed IL-based technologies. Process simulation revealed that multiscale research strategies enable advancement in the technological development of IL applications by focusing research efforts to overcome the limitations and exploit the excellent properties of ILs.
Collapse
Affiliation(s)
- Jose Palomar
- Chemical
Engineering Department, Autonomous University
of Madrid, Calle Tomás y Valiente 7, 28049 Madrid, Spain
| | - Jesús Lemus
- Chemical
Engineering Department, Autonomous University
of Madrid, Calle Tomás y Valiente 7, 28049 Madrid, Spain
| | - Pablo Navarro
- Chemical
Engineering Department, Autonomous University
of Madrid, Calle Tomás y Valiente 7, 28049 Madrid, Spain
| | - Cristian Moya
- Departamento
de Tecnología Química, Energética y Mecánica, Universidad Rey Juan Carlos, 28933 Madrid, Spain
| | - Rubén Santiago
- Departamento
de Ingeniería Eléctrica, Electrónica, Control,
Telemática y Química aplicada a la Ingeniería,
ETS de Ingenieros Industriales, Universidad
Nacional de Educación a Distancia (UNED), 28040 Madrid, Spain
| | - Daniel Hospital-Benito
- Chemical
Engineering Department, Autonomous University
of Madrid, Calle Tomás y Valiente 7, 28049 Madrid, Spain
| | - Elisa Hernández
- Chemical
Engineering Department, Autonomous University
of Madrid, Calle Tomás y Valiente 7, 28049 Madrid, Spain
| |
Collapse
|
2
|
Kammoun M, Margellou A, Toteva VB, Aladjadjiyan A, Sousa AF, Luis SV, Garcia-Verdugo E, Triantafyllidis KS, Richel A. The key role of pretreatment for the one-step and multi-step conversions of European lignocellulosic materials into furan compounds. RSC Adv 2023; 13:21395-21420. [PMID: 37469965 PMCID: PMC10352963 DOI: 10.1039/d3ra01533e] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/08/2023] [Accepted: 07/04/2023] [Indexed: 07/21/2023] Open
Abstract
Nowadays, an increased interest from the chemical industry towards the furanic compounds production, renewable molecules alternatives to fossil molecules, which can be transformed into a wide range of chemicals and biopolymers. These molecules are produced following hexose and pentose dehydration. In this context, lignocellulosic biomass, owing to its richness in carbohydrates, notably cellulose and hemicellulose, can be the starting material for monosaccharide supply to be converted into bio-based products. Nevertheless, processing biomass is essential to overcome the recalcitrance of biomass, cellulose crystallinity, and lignin crosslinked structure. The previous reports describe only the furanic compound production from monosaccharides, without considering the starting raw material from which they would be extracted, and without paying attention to raw material pretreatment for the furan production pathway, nor the mass balance of the whole process. Taking account of these shortcomings, this review focuses, firstly, on the conversion potential of different European abundant lignocellulosic matrices into 5-hydroxymethyl furfural and 2-furfural based on their chemical composition. The second line of discussion is focused on the many technological approaches reported so far for the conversion of feedstocks into furan intermediates for polymer technology but highlighting those adopting the minimum possible steps and with the lowest possible environmental impact. The focus of this review is to providing an updated discussion of the important issues relevant to bringing chemically furan derivatives into a market context within a green European context.
Collapse
Affiliation(s)
- Maroua Kammoun
- Laboratory of Biomass and Green Technologies, University of Liege Belgium
| | - Antigoni Margellou
- Department of Chemistry, Aristotle University of Thessaloniki 54124 Thessaloniki Greece
| | - Vesislava B Toteva
- Department of Textile, Leather and Fuels, University of Chemical Technology and Metallurgy Sofia Bulgaria
| | | | - Andreai F Sousa
- CICECO-Aveiro Institute of Materials, Department of Chemistry, University of Aveiro 3810-193 Aveiro Portugal
- Centre for Mechanical Engineering, Materials and Processes, Department of Chemical Engineering, University of Coimbra Rua Sílvio Lima-Polo II 3030-790 Coimbra Portugal
| | - Santiago V Luis
- Dpt. of Inorganic and Organic Chemistry, Supramolecular and Sustainable Chemistry Group, University Jaume I Avda Sos Baynat s/n E-12071-Castellon Spain
| | - Eduardo Garcia-Verdugo
- Dpt. of Inorganic and Organic Chemistry, Supramolecular and Sustainable Chemistry Group, University Jaume I Avda Sos Baynat s/n E-12071-Castellon Spain
| | | | - Aurore Richel
- Laboratory of Biomass and Green Technologies, University of Liege Belgium
| |
Collapse
|
3
|
Cao C, Xu X, Wang G, Yang Z, Cheng Z, Zhang S, Li T, Pu Y, Lv G, Xu C, Cai J, Zhou W, Li F, Pu Z, Li X. Characterization of ionic liquids removing heavy metals from electroplating sludge: Influencing factors, optimisation strategies and reaction mechanisms. CHEMOSPHERE 2023; 324:138309. [PMID: 36889480 DOI: 10.1016/j.chemosphere.2023.138309] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/18/2022] [Revised: 02/21/2023] [Accepted: 03/03/2023] [Indexed: 06/18/2023]
Abstract
The disposal of electroplating sludge (ES) is a common concern of researchers. Currently, it is difficult to achieve effective fixation of heavy metals (HMs) using traditional ES treatment. As green and effective HMs removal agents, ionic liquids can be used for the disposal of ES. In this study, 1-butyl-3-methyl-imidazole hydrogen sulphate ([Bmim]HSO4) and 1-propyl sulphonic acid-3-methyl imidazole hydrogen sulphate ([PrSO3Hmim]HSO4) were used as washing solvents for the removal of Cr, Ni, and Cu from ES. In reaction with increased agent concentration, solid-liquid ratio, and duration, the amount of HMs eliminated from ES rises, whereas opposite patterns were shown in response to rising pH. The quadratic orthogonal regression optimisation analysis also revealed that the ideal washing specifications for [Bmim]HSO4 were 60 g L-1, 1:40, and 60 min, respectively, for agent concentration, solid-liquid ratio, and washing time, while those for [PrSO3Hmim]HSO4 were 60 g L-1, 1:35, and 60 min, respectively. Under the optimal experimental conditions, the Cr, Ni, and Cu removal efficiencies for [Bmim]HSO4 were 84.3, 78.6, and 89.7%, respectively, and those values for [PrSO3Hmim]HSO4 were 99.8, 90.1, and 91.3%, respectively. This was mainly attributed to that ionic liquids enhance metal desorption through acid solubilisation, chelation, and electrostatic attraction. Overall, ionic liquids are reliable washing reagents for ES contaminated by HMs.
Collapse
Affiliation(s)
- Chenchen Cao
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China
| | - Xiaoxun Xu
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China; Key Laboratory of Soil Environment Protection of Sichuan Province, Chengdu, 611130, China.
| | - Guiyin Wang
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China; Key Laboratory of Soil Environment Protection of Sichuan Province, Chengdu, 611130, China
| | - Zhanbiao Yang
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China; Key Laboratory of Soil Environment Protection of Sichuan Province, Chengdu, 611130, China
| | - Zhang Cheng
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China
| | - Shirong Zhang
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China; Key Laboratory of Soil Environment Protection of Sichuan Province, Chengdu, 611130, China
| | - Ting Li
- College of Resources, Sichuan Agricultural University, Chengdu, 611130, China
| | - Yulin Pu
- College of Resources, Sichuan Agricultural University, Chengdu, 611130, China
| | - Guochun Lv
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China
| | - Changlian Xu
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China
| | - Junzhuo Cai
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China
| | - Wei Zhou
- College of Resources, Sichuan Agricultural University, Chengdu, 611130, China
| | - Feng Li
- College of Environmental Sciences, Sichuan Agricultural University, Chengdu, 611130, China
| | - Zhien Pu
- College of Agronomy, Sichuan Agricultural University, Chengdu, 611130, China
| | - Xiaofan Li
- Environmental Research Institute, Shandong University, Qingdao, 266237, China
| |
Collapse
|
4
|
Lorente A, Huertas-Alonso AJ, Salgado-Ramos M, González-Serrano DJ, Sánchez-Verdú MP, Cabañas B, Hadidi M, Moreno A. Microwave radiation-assisted synthesis of levulinic acid from microcrystalline cellulose: Application to a melon rind residue. Int J Biol Macromol 2023; 237:124149. [PMID: 36965554 DOI: 10.1016/j.ijbiomac.2023.124149] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/10/2022] [Revised: 03/16/2023] [Accepted: 03/20/2023] [Indexed: 03/27/2023]
Abstract
The circular economy considers waste to be a new raw material for the development of value-added products. In this context, agroindustrial lignocellulosic waste represents an outstanding source of new materials and platform chemicals, such as levulinic acid (LA). Herein we study the microwave (MW)-assisted acidic conversion of microcrystalline cellulose (MCC) into LA. The influence of acidic catalysts, inorganic salt addition and ball-milling pre-treatment of MCC on LA yield was assessed. Depolymerization and disruption of cellulose was monitored by FTIR, TGA and SEM, whereas the products formed were analyzed by HPLC and NMR spectroscopy. The parameters that afforded the highest LA yield (48 %, 100 % selectivity) were: ball-milling pre-treatment of MCC for 16 min at 600 rpm, followed by MW-assisted thermochemical treatment for 20 min at 190 °C, aqueous p-toluenesulfonic acid (p-TSA) 0.25 M as catalyst and saturation with KBr. These optimal conditions were further applied to a lignocellulosic feedstock, namely melon rind, to afford a 51 % yield of LA. These results corroborate the suitability of this method to obtain LA from agroindustrial wastes, in line with a circular economy-based approach.
Collapse
Affiliation(s)
- Almudena Lorente
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain
| | - Alberto J Huertas-Alonso
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain; Universidad de Castilla La Mancha, Departamento de Química Física, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela s/n, Ciudad Real 13071, Spain.
| | - Manuel Salgado-Ramos
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain
| | - Diego J González-Serrano
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain
| | - M Prado Sánchez-Verdú
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain
| | - Beatriz Cabañas
- Universidad de Castilla La Mancha, Departamento de Química Física, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela s/n, Ciudad Real 13071, Spain
| | - Milad Hadidi
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain
| | - Andrés Moreno
- Universidad de Castilla-la Mancha, Departamento de Química Inorgánica, Orgánica y Bioquímica, Facultad de Ciencias y Tecnologías Químicas, Avenida Camilo José Cela n°10, 13005 Ciudad Real, Spain.
| |
Collapse
|
5
|
Papaiconomou N, Magnin JP, Billard I. Treatment of Pulp Black Liquor with an Ionic Liquid: Modeling and Optimization by Using Response Surface Methodology and Central Composite Design. Chempluschem 2023; 88:e202200348. [PMID: 36701112 DOI: 10.1002/cplu.202200348] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/07/2022] [Revised: 01/25/2023] [Accepted: 01/26/2023] [Indexed: 01/27/2023]
Abstract
In this study, selective extraction towards ionic liquid trihexyltetradecylphosphonium chloride ([P66614 ]Cl) of lignin residues, polysaccharides and organic acids present in black liquor (BL), the main principal wastewater of pulping industry was studied. With the objective of finding optimized conditions allowing to extract lignin residues while polysaccharides and organic acids remain in aqueous solution, a design of experiments approach based on a response surface methodology was used. Three continuous factors, namely initial pH varying from 9 to 13.5, dilution of BL varying from 5 to 20 and volumetric ratio of black liquor vs. ionic liquid RV ., varying from 1 to 19, were investigated. Concentration of lignin residues, polysaccharides and organic acids were measured using Folin-Ciocalteu method, the anthrone method and HPLC, respectively. Results showed that a multi-response optimization led to the extraction of 84.8 % of lignin residues, 66.0 % of polysaccharides, and no extraction of OA under optimised conditions.
Collapse
Affiliation(s)
- Nicolas Papaiconomou
- Université Côte d'Azur, CNRS, Institut de Chimie de Nice UMR 7272, 06108, Nice, France
| | - Jean-Pierre Magnin
- Univ. Grenoble Alpes.,Univ. Savoie Mont Blanc, CNRS, Grenoble INP, LEPMI, 38000, Grenoble, France
| | - Isabelle Billard
- Univ. Grenoble Alpes.,Univ. Savoie Mont Blanc, CNRS, Grenoble INP, LEPMI, 38000, Grenoble, France
| |
Collapse
|
6
|
Omidi M, Mobinikhaledi A, Ahadi N. A Facile and Efficient Synthesis of Indole Derivatives in Aqueous Media Catalyzed by [DMAP-SO 3H]Cl and [DMAP-H]HSO 4. ORG PREP PROCED INT 2023. [DOI: 10.1080/00304948.2022.2162319] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/16/2023]
Affiliation(s)
- Mahdi Omidi
- Department of Chemistry, Faculty of Science, Arak University, Arak, Iran
| | - Akbar Mobinikhaledi
- Department of Chemistry, Faculty of Science, Arak University, Arak, Iran
- Institute of Nanosciences and Nanotechnology, Arak University, Arak, Iran
| | - Najmieh Ahadi
- Department of Chemistry, Faculty of Science, Arak University, Arak, Iran
| |
Collapse
|
7
|
Bioethanol Production from Lignocellulosic Biomass-Challenges and Solutions. Molecules 2022; 27:molecules27248717. [PMID: 36557852 PMCID: PMC9785513 DOI: 10.3390/molecules27248717] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/03/2022] [Revised: 12/02/2022] [Accepted: 12/07/2022] [Indexed: 12/14/2022] Open
Abstract
Regarding the limited resources for fossil fuels and increasing global energy demands, greenhouse gas emissions, and climate change, there is a need to find alternative energy sources that are sustainable, environmentally friendly, renewable, and economically viable. In the last several decades, interest in second-generation bioethanol production from non-food lignocellulosic biomass in the form of organic residues rapidly increased because of its abundance, renewability, and low cost. Bioethanol production fits into the strategy of a circular economy and zero waste plans, and using ethanol as an alternative fuel gives the world economy a chance to become independent of the petrochemical industry, providing energy security and environmental safety. However, the conversion of biomass into ethanol is a challenging and multi-stage process because of the variation in the biochemical composition of biomass and the recalcitrance of lignin, the aromatic component of lignocellulose. Therefore, the commercial production of cellulosic ethanol has not yet become well-received commercially, being hampered by high research and production costs, and substantial effort is needed to make it more widespread and profitable. This review summarises the state of the art in bioethanol production from lignocellulosic biomass, highlights the most challenging steps of the process, including pretreatment stages required to fragment biomass components and further enzymatic hydrolysis and fermentation, presents the most recent technological advances to overcome the challenges and high costs, and discusses future perspectives of second-generation biorefineries.
Collapse
|
8
|
Patil P, Kadam S, Patil D, More P. A green approach for the multicomponent synthesis of polyhydroquinolines and 6-unsubstituted dihydropyrimidinones using novel highly proficient acidic ionic liquid [CEMIM][MSA] as a reusable catalyst. CATAL COMMUN 2022. [DOI: 10.1016/j.catcom.2022.106500] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/02/2022] Open
|
9
|
Ionic Liquids Mediated One‐Pot Synthesis of Second Generation 5‐Ethoxymethylfurfural (5‐EMF); A Potent Biofuel Candidate. ChemistrySelect 2022. [DOI: 10.1002/slct.202201161] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
|
10
|
Reyes G, Pacheco CM, Isaza-Ferro E, González A, Pasquier E, Alejandro-Martín S, Arteaga-Peréz LE, Carrillo RR, Carrillo-Varela I, Mendonça RT, Flanigan C, Rojas OJ. Upcycling agro-industrial blueberry waste into platform chemicals and structured materials for application in marine environments. GREEN CHEMISTRY : AN INTERNATIONAL JOURNAL AND GREEN CHEMISTRY RESOURCE : GC 2022; 24:3794-3804. [PMID: 35694220 PMCID: PMC9086861 DOI: 10.1039/d2gc00573e] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 02/11/2022] [Accepted: 03/25/2022] [Indexed: 06/15/2023]
Abstract
Blueberry pruning waste (BPw), sourced as residues from agroforestry operations in Chile, was used to produce added-value products, including platform chemicals and materials. BPw fractionation was implemented using biobased solvents (γ-valerolactone, GVL) and pyrolysis (500 °C), yielding solid fractions that are rich in phenols and antioxidants. The liquid fraction was found to be enriched in sugars, acids, and amides. Alongside, filaments and 3D-printed meshes were produced via wet spinning and Direct-Ink-Writing (DIW), respectively. For the latter purpose, BPw was dissolved in an ionic liquid, 1-ethyl-3-methylimidazolium acetate ([emim][OAc]), and regenerated into lignocellulose filaments with highly aligned nanofibrils (wide-angle X-ray scattering) that simultaneously showed extensibility (wet strain as high as 39%). BPw-derived lignocellulose filaments showed a tenacity (up to 2.3 cN dtex-1) that is comparable to that of rayon fibers and showed low light reflectance (R ES factor <3%). Meanwhile, DIW of the respective gels led to meshes with up to 60% wet stretchability. The LCF and meshes were demonstrated to have reliable performance in marine environments. As a demonstration, we show the prospects of replacing plastic cords and other materials used to restore coral reefs on the coast of Mexico.
Collapse
Affiliation(s)
- Guillermo Reyes
- Biobased Colloids and Materials, Department of Bioproducts and Biosystems, School of Chemical Engineering, Aalto University FI-00076 Espoo Finland
| | - Claudia M Pacheco
- Facultad de Ingenierías, Universidad Cooperativa de Colombia Cra 22 No. 7-06 sur Villavicencio Colombia
| | - Estefania Isaza-Ferro
- Department of Bioproducts and Biosystems, School of Chemical Engineering, Aalto University FI-00076 Espoo Finland
| | - Amaidy González
- Laboratory of Thermal and Catalytic Processes, Facultad de Ingeniería, Universidad del Bío-Bío Av. Collao 1202 Concepción Chile
| | - Eva Pasquier
- Biobased Colloids and Materials, Department of Bioproducts and Biosystems, School of Chemical Engineering, Aalto University FI-00076 Espoo Finland
- Université Grenoble Alpes, CNRS, Grenoble INP (Institute of Engineering) LGP2 F-38000 Grenoble France
| | - Serguei Alejandro-Martín
- Laboratorio de Cromatografía Gaseosa y Pirólisis Analítica, Departamento de Ingeniería en Maderas, Universidad del Bío-Bío Av.Collao 1202, Casilla 5-C Concepción Chile
| | - Luis E Arteaga-Peréz
- Laboratory of Thermal and Catalytic Processes, Facultad de Ingeniería, Universidad del Bío-Bío Av. Collao 1202 Concepción Chile
| | - Romina R Carrillo
- Facultad de Ciencias Químicas, Depto. Química Analítica e Inorgánica, Universidad de Concepción Concepción Chile
| | - Isabel Carrillo-Varela
- Laboratorio de Recursos Renovables, Centro de Biotecnología, Universidad de Concepción, Concepción Casilla 160-C Concepción Chile
| | - Regis Teixeira Mendonça
- Centro de Investigación de Polímeros Avanzados, CIPA, Avenida Collao 1202, Edificio de Laboratorios Concepción 4030000 Chile
- Facultad de Ciencias Forestales, Universidad de Concepción Casilla 160-C Concepción Chile
| | - Colleen Flanigan
- Zoe - A Living Sea Sculpture in Cozumel, Av. Rafael E. Melgar 77688 San Miguel de Cozumel Q.R. Mexico
| | - Orlando J Rojas
- Biobased Colloids and Materials, Department of Bioproducts and Biosystems, School of Chemical Engineering, Aalto University FI-00076 Espoo Finland
- Bioproducts Institute, Department of Chemical & Biological Engineering, Department of Chemistry and Department of Wood Science, 2360 East Mall, The University of British Columbia Vancouver BC V6T 1Z3 Canada
| |
Collapse
|
11
|
Mero A, Guglielmero L, D'Andrea F, Pomelli CS, Guazzelli L, Koutsoumpos S, Tsonos G, Stavrakas I, Moutzouris K, Mezzetta A. Influence of the cation partner on levulinate ionic liquids properties. J Mol Liq 2022. [DOI: 10.1016/j.molliq.2022.118850] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/30/2022]
|
12
|
Marullo S, D’Anna F. The Role Played by Ionic Liquids in Carbohydrates Conversion into 5-Hydroxymethylfurfural: A Recent Overview. Molecules 2022; 27:2210. [PMID: 35408609 PMCID: PMC9000634 DOI: 10.3390/molecules27072210] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/21/2022] [Revised: 03/22/2022] [Accepted: 03/28/2022] [Indexed: 02/04/2023] Open
Abstract
Obtaining industrially relevant products from abundant, cheap, renewable, and low-impacting sources such as lignocellulosic biomass, is a key step in reducing consumption of raw fossil materials and, consequently, the environmental footprint of such processes. In this regard, a molecule that is similar to 5-hydroxymethylfurfural (5-HMF) plays a pivotal role, since it can be produced from lignocellulosic biomass and gives synthetic access to a broad range of industrially important products and polymers. Recently, ionic liquids (ILs) have emerged as suitable solvents for the conversion of biomass and carbohydrates into 5-HMF. Herein, we provide a bird's-eye view on recent achievements about the use of ILs for the obtainment of 5-HMF, covering works that were published over the last five years. In particular, we first examine reactions involving homogeneous catalysis as well as task-specific ionic liquids. Then, an overview of the literature addressing the use of heterogeneous catalysts, including enzymes, is presented. Whenever possible, the role of ILs and catalysts driving the formation of 5-HMF is discussed, also comparing with the same reactions that are performed in conventional solvents.
Collapse
Affiliation(s)
| | - Francesca D’Anna
- Dipartimento STEBICEF, Università degli Studi di Palermo, Viale delle Scienze Ed. 17, 90128 Palermo, Italy;
| |
Collapse
|
13
|
Naz S, Uroos M. Ionic Liquids: Designer Solvents for Cleaner Technologies. LETT ORG CHEM 2022. [DOI: 10.2174/1570178619666220110142647] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
Affiliation(s)
- Sadia Naz
- Centre for Research in Ionic Liquids, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Maliha Uroos
- Centre for Research in Ionic Liquids, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| |
Collapse
|
14
|
Culaba AB, Mayol AP, San Juan JLG, Vinoya CL, Concepcion RS, Bandala AA, Vicerra RRP, Ubando AT, Chen WH, Chang JS. Smart sustainable biorefineries for lignocellulosic biomass. BIORESOURCE TECHNOLOGY 2022; 344:126215. [PMID: 34728355 DOI: 10.1016/j.biortech.2021.126215] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/31/2021] [Revised: 10/18/2021] [Accepted: 10/21/2021] [Indexed: 06/13/2023]
Abstract
Lignocellulosic biomass (LCB) is considered as a sustainable feedstock for a biorefinery to generate biofuels and other bio-chemicals. However, commercialization is one of the challenges that limits cost-effective operation of conventional LCB biorefinery. This article highlights some studies on the sustainability of LCB in terms of cost-competitiveness and environmental impact reduction. In addition, the development of computational intelligence methods such as Artificial Intelligence (AI) as a tool to aid the improvement of LCB biorefinery in terms of optimization, prediction, classification, and decision support systems. Lastly, this review examines the possible research gaps on the production and valorization in a smart sustainable biorefinery towards circular economy.
Collapse
Affiliation(s)
- Alvin B Culaba
- Department of Mechanical Engineering, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines.
| | - Andres Philip Mayol
- Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Department of Manufacturing Engineering and Management, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines
| | - Jayne Lois G San Juan
- Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Department of Industrial and Systems Engineering, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines
| | - Carlo L Vinoya
- Department of Mechanical Engineering, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; School of Sciences and Engineering, University of Asia and the Pacific, Pearl Dr, Ortigas Center, Pasig, 1605 Metro Manila, Philippines
| | - Ronnie S Concepcion
- Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Department of Manufacturing Engineering and Management, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines
| | - Argel A Bandala
- Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Department of Electronics and Computer Engineering, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines
| | - Ryan Rhay P Vicerra
- Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Department of Manufacturing Engineering and Management, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines
| | - Aristotle T Ubando
- Department of Mechanical Engineering, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Center for Engineering Sustainable Development Research, De La Salle University, 2401 Taft Avenue, 0922 Manila, Philippines; Thermomechanical Analysis Laboratory, De La Salle University, Laguna Campus, LTI Spine Road, Laguna Blvd, Biñan, Laguna 4024, Philippines
| | - Wei-Hsin Chen
- Department of Aeronautics and Astronautics, National Cheng Kung University, Tainan 701, Taiwan; Research Center for Smart Sustainable Circular Economy, Tunghai University, Taichung 407, Taiwan; Department of Mechanical Engineering, National Chin-Yi University of Technology, Taichung 411, Taiwan
| | - Jo-Shu Chang
- Department of Chemical and Materials Engineering, Tunghai University, Taichung 407, Taiwan; Research Center for Smart Sustainable Circular Economy, Tunghai University, Taichung 407, Taiwan; Department of Chemical Engineering, National Cheng Kung University, Tainan 701, Taiwan
| |
Collapse
|
15
|
Uroos M, Javaid A, Bashir A, Tariq J, Khan IH, Naz S, Fatima S, Sultan M. Green synthesis of coumarin derivatives using Brønsted acidic pyridinium based ionic liquid [MBSPy][HSO 4] to control an opportunistic human and a devastating plant pathogenic fungus Macrophomina phaseolina. RSC Adv 2022; 12:23963-23972. [PMID: 36093243 PMCID: PMC9400593 DOI: 10.1039/d2ra03774b] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/19/2022] [Accepted: 08/05/2022] [Indexed: 11/21/2022] Open
Abstract
An eco-friendly simple protocol has been devised for the preparation of coumarin derivatives using doubly Brønsted acidic task specific ionic liquid (TSIL) as a catalyst. Solvent-free conditions were employed for the reaction of different substituted phenols with β-ketoester in TSIL to produce corresponding substituted coumarin derivatives in good to excellent yields at ambient conditions; at room temperature and with reduced reaction times. The ionic liquid catalyst can be recycled and reused up to five times. All the synthesized coumarins were evaluated for their antifungal activities against Macrophomina phaseolina, a plant as well as an opportunistic human pathogenic fungus affecting more than 500 plant species worldwide and with no registered commercial fungicide available against it, to date. Amongst all the coumarins tested, compounds 3f and 3i showed excellent antifungal activity comparable to reference fungicide mancozeb. The current methodology provides an easy and expedient way to access the coumarin core in search of potential fungicides for sustainable agriculture. An eco-friendly simple protocol has been devised for the preparation of coumarin derivatives using doubly Brønsted acidic task specific ionic liquid (TSIL) as a catalyst.![]()
Collapse
Affiliation(s)
- Maliha Uroos
- Centre for Research in Ionic Liquids & Centre for Organic Chemistry, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Arshad Javaid
- Department of Plant Pathology, Faculty of Agricultural Sciences, University of the Punjab, Quaid-i-Azam Campus, Lahore 54590, Pakistan
| | - Amina Bashir
- Centre for Research in Ionic Liquids & Centre for Organic Chemistry, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Javaria Tariq
- Centre for Research in Ionic Liquids & Centre for Organic Chemistry, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Iqra Haider Khan
- Department of Plant Pathology, Faculty of Agricultural Sciences, University of the Punjab, Quaid-i-Azam Campus, Lahore 54590, Pakistan
| | - Sadia Naz
- Centre for Research in Ionic Liquids & Centre for Organic Chemistry, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Sameeta Fatima
- Centre for Research in Ionic Liquids & Centre for Organic Chemistry, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Misbah Sultan
- Centre for Applied Chemistry, School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| |
Collapse
|
16
|
Naz S, Uroos M, Ayoub M. Cost-Effective Processing of Carbon-Rich Materials in Ionic Liquids: An Expeditious Approach to Biofuels. ACS OMEGA 2021; 6:29233-29242. [PMID: 34746611 PMCID: PMC8567403 DOI: 10.1021/acsomega.1c04881] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 09/04/2021] [Accepted: 10/14/2021] [Indexed: 06/13/2023]
Abstract
This work presents a cost-effective approach for processing of renewable carbon-rich biomass using pyridinium-based Lewis acidic ionic liquids (LAILs). Rice husk as carbon-rich lignocellulosic waste was pretreated with a series of neutral and Lewis acidic ionic liquids to yield valuable intermediate platform monosaccharides. Novelty in the work lies in direct conversion of lignocellulosic carbohydrates into reducing sugars without their further conversion into 5-hydroxymethylfurfural or any other platform chemicals that are fermentation inhibitors for bioethanol production. The unconverted cellulose-rich material (CRM) is regenerated as a delignified material by the simultaneous addition of antisolvents. CRM and recovered lignin obtained after pretreatment were analyzed via scanning electron microscopy (SEM), thermogravimetric analysis (TGA), and Fourier transform infrared (FTIR) spectroscopy. The process was optimized with respect to a high yield of platform sugars and the quantity as well as quality of recovered CRM and lignin contents. Various reaction parameters involving the molecular structure of ionic liquids (ILs), Lewis acidic strength of ILs, biomass loading into IL, time, temperature, and biomass particle size were screened thoroughly. From all of the tested ILs, unsymmetrical 3-methylpyridinium IL having N-octyl substitution and chloroaluminate anion showed a greater conversion efficiency at 100 °C for 1.5 h. FTIR and SEM analyses of recovered CRM justify >90% lignin removal from rice husk. From all of the removed lignin, 60 wt % of original lignin content was recovered. The Lewis acidic system possessed recycling ability up to 3 times for subsequent treatment of rice husk without a significant loss of efficiency.
Collapse
Affiliation(s)
- Sadia Naz
- Centre
for Research in Ionic Liquids & Centre for Organic Chemistry,
School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Maliha Uroos
- Centre
for Research in Ionic Liquids & Centre for Organic Chemistry,
School of Chemistry, University of the Punjab, 54590 Lahore, Pakistan
| | - Muhammad Ayoub
- Department
of Chemical Engineering, Universiti Teknologi
PETRONAS, 32610 Perak, Malaysia
| |
Collapse
|
17
|
Nasrollahzadeh M, Ghasemzadeh M, Gharoubi H, Nezafat Z. Progresses in polysaccharide and lignin-based ionic liquids: Catalytic applications and environmental remediation. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.117559] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/13/2022]
|
18
|
Application of protic ammonium-based ionic liquids with carboxylate anions for phenol extraction from aqueous solution and their cytotoxicity on human cells. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.117447] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/08/2023]
|
19
|
Li X, Guo Z, Li J, Yang M, Yao S. Swelling and microwave-assisted hydrolysis of animal keratin in ionic liquids. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.117306] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
20
|
Shi S, Wu Y, Zhang M, Zhang Z, Oderinde O, Gao L, Xiao G. Direct conversion of cellulose to levulinic acid using SO3H-functionalized ionic liquids containing halogen-anions. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.117278] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
21
|
Heo JB, Lee YS, Chung CH. Conversion of inulin-rich raw plant biomass to 2,5-furandicarboxylic acid (FDCA): Progress and challenge towards biorenewable plastics. Biotechnol Adv 2021; 53:107838. [PMID: 34571195 DOI: 10.1016/j.biotechadv.2021.107838] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/16/2021] [Revised: 09/15/2021] [Accepted: 09/19/2021] [Indexed: 12/27/2022]
Abstract
The current commercial plastic manufactures have been produced using petroleum-based resource. However, due to concerns over the resource depletion and the environmental sustainability, bioresource-based manufacturing processes have been developed to cope against these concerns. Bioresource-derived 2,5-furandicarboxylic acid (FDCA) can be utilized as a building block material for plastic manufactures. To date, numerous technologies have been developed for the production of FDCA using various types of bio-based feedstocks such as hydroxymethylfurfural (HMF), 6-C sugars, and polysaccharides. The commercial companies produce FDCA using HMF-based production processes due to their high production efficiency, but the high price of HMF is a problem bottleneck. Our review affords important information on breakthrough approaches for the cost-efficient and sustainable production of FDCA using raw plant feedstocks rich in inulin. These approaches include bioprocessing technology based on the direct use of raw plant feedstocks and biomodification of the target plant sources. For the former, an ionic liquid-based processing system is proposed for efficient pretreatment of raw plant feedstocks. For the latter, the genes encoding the key enzymes; sucrose:sucrose 1-fructoyltransferase (1-SST), fructan:fructan 1-fryuctosyltransferase (1-FFT), fructan 1-exohydrolase (1-FEH), and microbe-derived endoinulinase, are introduced for biomodification conducive to facilitating bioprocess and improving inulin content. These approaches would contribute to cost-efficiently and sustainably producing bio-based FDCA.
Collapse
Affiliation(s)
- Jae Bok Heo
- Department of Molecular Genetic Biotechnology, Dong-A University, Busan, South Korea
| | - Yong-Suk Lee
- Division of Applied Life Science (BK21), Gyeongsang National University, Jinju, South Korea
| | - Chung-Han Chung
- Department of Biotechnology, Dong-A University, Busan, South Korea.
| |
Collapse
|
22
|
Ionic liquid pretreatment of stinging nettle stems and giant miscanthus for bioethanol production. Sci Rep 2021; 11:18465. [PMID: 34531459 PMCID: PMC8445950 DOI: 10.1038/s41598-021-97993-y] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/07/2021] [Accepted: 08/27/2021] [Indexed: 02/08/2023] Open
Abstract
Production of ethanol from lignocellulosic biomass is considered the most promising proposition for developing a sustainable and carbon-neutral energy system. The use of renewable raw materials and variability of lignocellulosic feedstock generating hexose and pentose sugars also brings advantages of the most abundant, sustainable and non-food competitive biomass. Great attention is now paid to agricultural wastes and overgrowing plants as an alternative to fast-growing energetic crops. The presented study explores the use of stinging nettle stems, which have not been treated as a source of bioethanol. Apart from being considered a weed, stinging nettle is used in pharmacy or cosmetics, yet its stems are always a non-edible waste. Therefore, the aim was to evaluate the effectiveness of pretreatment using imidazolium- and ammonium-based ionic liquids, enzymatic hydrolysis, fermentation of stinging nettle stems, and comparison of such a process with giant miscanthus. Raw and ionic liquid-pretreated feedstocks of stinging nettle and miscanthus were subjected to compositional analysis and scanning electron microscopy to determine the pretreatment effect. Next, the same conditions of enzymatic hydrolysis and fermentation were applied to both crops to explore the stinging nettle stems potential in the area of bioethanol production. The study showed that the pretreatment of both stinging nettle and miscanthus with imidazolium acetates allowed for increased availability of the critical lignocellulosic fraction. The use of 1-butyl-3-methylimidazolium acetate in the pretreatment of stinging nettle allowed to obtain very high ethanol concentrations of 7.3 g L-1, with 7.0 g L-1 achieved for miscanthus. Results similar for both plants were obtained for 1-ethyl-3-buthylimidazolium acetate. Moreover, in the case of ammonium ionic liquids, even though they have comparable potential to dissolve cellulose, it was impossible to depolymerize lignocellulose and extract lignin. Furthermore, they did not improve the efficiency of the hydrolysis process, which in turn led to low alcohol concentration. Overall, from the presented results, it can be assumed that the stinging nettle stems are a very promising bioenergy crop.
Collapse
|
23
|
Maia Cardoso CK, Mattedi S, Lobato AKDCL, Andrade Moreira ÍT. Remediation of petroleum contaminated saline water using value-added adsorbents derived from waste coconut fibres. CHEMOSPHERE 2021; 279:130562. [PMID: 34134407 DOI: 10.1016/j.chemosphere.2021.130562] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/30/2020] [Revised: 03/18/2021] [Accepted: 04/07/2021] [Indexed: 06/12/2023]
Abstract
Oil spill from petrochemical industries into marine areas has resulted in severe environmental pollution. The use of natural sorbents to clean marine areas affected by petroleum contaminants is a promising approach to alleviate this problem. Therefore, this study aims at developing an technique that uses waste coconut fibres (Cocos nucifera L.) pre-treated with a "green" solvent, viz. protic ionic liquid (PIL) [2-HEA][Ac], for the remediation of oil in saline water. Conventional chemical pre-treatments (mercerisation/acetylation) and the innovative treatment (using PIL), chemical characterisation, Scanning Electron Microscope, Fourier-transform infrared spectroscopy, and oil sorption tests in hydrodynamic simulation on a laboratory scale were conducted. The fibres treated with PIL[2-HEA][Ac] possessed more pores and hydrophobic content than the mercerised/acetylated coconut fibres, indicating the efficiency of sorption. The average sorption of the PIL[2-HEA][Ac] fibre was 1.40 ± 0.06 g/g and that of the mercerised/acetylated fibre was 1.32 ± 0.12 g/g. Although the difference in sorption results is not significant, according to the Tukey test, fibre pre-treatment with PIL[2-HEA][Ac] is more advantageous than conventional treatments because it exhibits better average sorption results; furthermore, the synthesis procedure for PIL[2-HEA][Ac] is simple, reusable and non-toxic. Therefore, the use of these petroleum biosorbents is a technology with environmental benefits, such as the availability of the biosorbent in the form of biodegradable waste and treated with a "green" solvent, both of which can be reused. Thus, it adds value for its use in industries with a circular economy product; that are environment-friendly and economical.
Collapse
Affiliation(s)
- Célia Karina Maia Cardoso
- Federal University of Bahia, Graduate Program in Chemical Engineering, R. Prof. Aristídes Novis, 2- Federação, Salvador - BA, 2nd floor, 40210-630, Salvador, BA, Brazil
| | - Silvana Mattedi
- Federal University of Bahia, Graduate Program in Chemical Engineering, R. Prof. Aristídes Novis, 2- Federação, Salvador - BA, 2nd floor, 40210-630, Salvador, BA, Brazil
| | - Ana Katerine de Carvalho Lima Lobato
- Federal University of Bahia, Graduate Program in Chemical Engineering, R. Prof. Aristídes Novis, 2- Federação, Salvador - BA, 2nd floor, 40210-630, Salvador, BA, Brazil; Salvador University, R. Dr. José Peroba, 251 - Stiep, Salvador - BA, 41770-235, Salvador, Bahia, Brazil
| | - Ícaro Thiago Andrade Moreira
- Federal University of Bahia, Graduate Program in Chemical Engineering, R. Prof. Aristídes Novis, 2- Federação, Salvador - BA, 2nd floor, 40210-630, Salvador, BA, Brazil; Federal University of Bahia, Department of Environmental Engineering, Prof. Aristídes Novis, 2- Federação, Salvador - BA, 4th floor, 40210-630, Salvador, BA, Brazil.
| |
Collapse
|
24
|
Review of advances in the development of laccases for the valorization of lignin to enable the production of lignocellulosic biofuels and bioproducts. Biotechnol Adv 2021; 54:107809. [PMID: 34333091 DOI: 10.1016/j.biotechadv.2021.107809] [Citation(s) in RCA: 27] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/25/2021] [Revised: 07/23/2021] [Accepted: 07/24/2021] [Indexed: 12/30/2022]
Abstract
Development and deployment of commercial biorefineries based on conversion of lignocellulosic biomass into biofuels and bioproducts faces many challenges that must be addressed before they are commercially viable. One of the biggest challenges faced is the efficient and scalable valorization of lignin, one of the three major components of the plant cell wall. Lignin is the most abundant aromatic biopolymer on earth, and its presence hinders the extraction of cellulose and hemicellulose that is essential to biochemical conversion of lignocellulose to fuels and chemicals. There has been a significant amount of work over the past 20 years that has sought to develop innovative processes designed to extract and recycle lignin into valuable compounds and help reduce the overall costs of the biorefinery process. Due to the complex matrix of lignin, which is essential for plant survival, the development of a reliable and efficient lignin conversion technology has been difficult to achieve. One approach that has received significant interest relies on the use of enzymes, notably laccases, a class of multi‑copper green oxidative enzymes that catalyze bond breaking in lignin to produce smaller oligomers. In this review, we first assess the different innovations of lignin valorization using laccases within the context of a biorefinery process, and then assess the latest economical advances that these innovations offered. Finally, we review laccase characterization and optimization, as well as the prospects and bottlenecks of this class of enzymes within the industrial and biorefining sectors.
Collapse
|
25
|
Evaporation thermodynamics of the tetraoctylphosphonium bis(trifluoromethansulfonyl)imide([P8888]NTf2) and tetraoctylphosphonium nonafluorobutane-1-sulfonate ([P8888]NFBS) ionic liquids. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.115892] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
|
26
|
Effect of molecular structure of cation and anions of ionic liquids and co-solvents on selectivity of 5-hydroxymethylfurfural from sugars, cellulose and real biomass. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.116523] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
27
|
Synthesis, thermal behavior and kinetic study of N-morpholinium dicationic ionic liquids by thermogravimetry. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.115662] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
|
28
|
Liang X, Wang J, Liu H. Quantitative recovery and regeneration of acidic ionic liquid 1-butyl-3-methylimidazolium hydrogen sulphate via industrial strategy for sustainable biomass processing. BIORESOURCE TECHNOLOGY 2021; 325:124726. [PMID: 33486410 DOI: 10.1016/j.biortech.2021.124726] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/07/2020] [Revised: 01/11/2021] [Accepted: 01/12/2021] [Indexed: 06/12/2023]
Abstract
Quantitative recovery is necessary for scale-up application of acidic ionic liquids (AILs). Ultrafiltration and bipolar membrane electrodialysis (BMED) was employed for the recovery and regeneration of acidic ionic liquid 1-butyl-3-methylimidazolium hydrogen sulphate (Bmim[HSO4]) after biomass pretreatment. Ultrafiltration was designed for the purification of BMED feed solution. During BMED treatment, Bmim+ retention with OH- generation occurred in mixing section and SO42- immigration with H+ generation occurred in aciding section. Resulting aqueous Bmim[OH] in mixing section and H2SO4 in aciding section could be utilized for quantitative synthesis of Bmim[HSO4]. Influence of BMED operating mode and major parameters including BMED feed concentration and current density of BMED module were studied in detail. The highest recovery ratio for Bmim+ and SO42- reached 96.2% and 96.0%. And the lowest energy consumption of specific Bmim[HSO4] recovery approached 9.0 kw∙h/kg. Insight gained from this study suggested a sustainable biomass processing methodology using AILs.
Collapse
Affiliation(s)
- Xiaocong Liang
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China.
| | - Junyu Wang
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China
| | - Hantao Liu
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China
| |
Collapse
|
29
|
COSMO-RS based screening of ionic liquids for extraction of phenolic compounds from aqueous media. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.115387] [Citation(s) in RCA: 14] [Impact Index Per Article: 4.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022]
|
30
|
Khan AS, Ibrahim TH, Jabbar NA, Khamis MI, Nancarrow P, Mjalli FS. Ionic liquids and deep eutectic solvents for the recovery of phenolic compounds: effect of ionic liquids structure and process parameters. RSC Adv 2021; 11:12398-12422. [PMID: 35423754 PMCID: PMC8697206 DOI: 10.1039/d0ra10560k] [Citation(s) in RCA: 21] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2020] [Accepted: 03/15/2021] [Indexed: 11/21/2022] Open
Abstract
Water pollution is a severe and challenging issue threatening the sustainable development of human civilization. Besides other pollutants, waste fluid streams contain phenolic compounds. These have an adverse effect on the human health and marine ecosystem due to their toxic, mutagenic, and carcinogenic nature. Therefore, it is necessary to remove such phenolic pollutants from waste stream fluids prior to discharging to the environment. Different methods have been proposed to remove phenolic compounds from wastewater, including extraction using ionic liquids (ILs) and deep eutectic solvent (DES), a class of organic salts having melting point below 100 °C and tunable physicochemical properties. The purpose of this review is to present the progress in utilizing ILs and DES for phenolic compound extraction from waste fluid streams. The effects of IL structural characteristics, such as anion type, cation type, alkyl chain length, and functional groups will be discussed. In addition, the impact of key process parameters such as pH, phenol concentration, phase ratio, and temperature will be also described. More importantly, several ideas for addressing the limitations of the treatment process and improving its efficiency and industrial viability will be presented. These ideas may form the basis for future studies on developing more effective IL-based processes for treating wastewaters contaminated with phenolic pollutants, to address a growing worldwide environmental problem.
Collapse
Affiliation(s)
- Amir Sada Khan
- Department of Chemical Engineering, College of Engineering, American University of Sharjah P.O. Box 26666 Sharjah United Arab Emirates .,Department of Chemistry, University of Science & Technolgy Banuu-28100 Khyber Pakhthunkhwa Pakistan
| | - Taleb H Ibrahim
- Department of Chemical Engineering, College of Engineering, American University of Sharjah P.O. Box 26666 Sharjah United Arab Emirates
| | - Nabil Abdel Jabbar
- Department of Chemical Engineering, College of Engineering, American University of Sharjah P.O. Box 26666 Sharjah United Arab Emirates
| | - Mustafa I Khamis
- Department of Biology, Chemistry and Environmental Sciences, American University of Sharjah P.O. Box 26666 Sharjah United Arab Emirates
| | - Paul Nancarrow
- Department of Chemical Engineering, College of Engineering, American University of Sharjah P.O. Box 26666 Sharjah United Arab Emirates
| | - Farouq Sabri Mjalli
- Petroleum & Chemical Engineering Department, Sultan Qaboos University Muscat 123 Oman
| |
Collapse
|
31
|
Asim AM, Uroos M, Naz S, Muhammad N. Pyridinium protic ionic liquids: Effective solvents for delignification of wheat straw. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2020.115013] [Citation(s) in RCA: 19] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/25/2022]
|
32
|
Abstract
The booming demand for energy across the world, especially for petroleum-based fuels, has led to the search for a long-term solution as a perfect source of sustainable energy. Lignocellulosic biomass resolves this obstacle as it is a readily available, inexpensive, and renewable fuel source that fulfills the criteria of sustainability. Valorization of lignocellulosic biomass and its components into value-added products maximizes the energy output and promotes the approach of lignocellulosic biorefinery. However, disruption of the recalcitrant structure of lignocellulosic biomass (LCB) via pretreatment technologies is costly and power-/heat-consuming. Therefore, devising an effective pretreatment method is a challenge. Likewise, the thermochemical and biological lignocellulosic conversion poses problems of efficiency, operational costs, and energy consumption. The advent of integrated technologies would probably resolve this problem. However, it is yet to be explored how to make it applicable at a commercial scale. This article will concisely review basic concepts of lignocellulosic composition and the routes opted by them to produce bioenergy. Moreover, it will also discuss the pros and cons of the pretreatment and conversion methods of lignocellulosic biomass. This critical analysis will bring to light the solutions for efficient and cost-effective conversion of lignocellulosic biomass that would pave the way for the development of sustainable energy systems.
Collapse
|
33
|
Synthesis of a novel acidic ionic liquid catalyst and its application for preparation of pyridines via a cooperative vinylogous anomeric-based oxidation. RESEARCH ON CHEMICAL INTERMEDIATES 2021. [DOI: 10.1007/s11164-020-04361-y] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/22/2023]
|
34
|
Muazzam R, Asim AM, Uroos M, Muhammad N, Hallett JP. Evaluating the potential of a novel hardwood biomass using a superbase ionic liquid. RSC Adv 2021; 11:19095-19105. [PMID: 35478656 PMCID: PMC9033503 DOI: 10.1039/d1ra01328a] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/18/2021] [Accepted: 05/10/2021] [Indexed: 11/21/2022] Open
Abstract
Lignocellulosic biomass, being ubiquitous and easily accessible, bears a huge potential for sustainable energy and other products.
Collapse
Affiliation(s)
- Rabia Muazzam
- Centre for Research in Ionic Liquids
- School of Chemistry
- University of the Punjab
- Lahore
- Pakistan
| | - Azmat Mehmood Asim
- Centre for Research in Ionic Liquids
- School of Chemistry
- University of the Punjab
- Lahore
- Pakistan
| | - Maliha Uroos
- Centre for Research in Ionic Liquids
- School of Chemistry
- University of the Punjab
- Lahore
- Pakistan
| | - Nawshad Muhammad
- Institute of Basic Medical Sciences
- Khyber Medical University
- Pakistan
| | - Jason P. Hallett
- Department of Chemical Engineering
- Imperial College London
- London
- UK
| |
Collapse
|
35
|
Asim AM, Uroos M, Muhammad N. Extraction of lignin and quantitative sugar release from biomass using efficient and cost-effective pyridinium protic ionic liquids. RSC Adv 2020; 10:44003-44014. [PMID: 35517143 PMCID: PMC9058325 DOI: 10.1039/d0ra09098k] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/26/2020] [Accepted: 11/16/2020] [Indexed: 11/29/2022] Open
Abstract
Lignocellulosic biomass is enormously abundant around the globe. It bears huge potential for renewable products as its components can be converted to many useful products via cheaper processes. Recently, the component of biomass that has attracted enormous attention is lignin owing to its several aromatic or phenolic constituents. The utilization of lignin, however, is hindered by its troublesome separation mainly due to the difficult nature of the lignocellulosic biomass. Protic ionic liquids have great potential for extraction of lignin from the lignocellulosic biomass to make it viable for various transformations. In this study, protic ionic liquids comprising a pyridinium cation and a dihydrogen phosphate anion (H2PO4−) were prepared and used for lignin extraction and subsequent saccharification of the cellulose pulp. The ILs exhibited appreciably high lignin yields (optimum 73%) under mild conditions (100 °C) and shorter time (2 h). Fairly good sugar (glucose) yields (77%) verify effective delignification. The analysis of ILs and biomass was accomplished by H-NMR, FT-IR, SEM, HSQC and GPC. Lignocellulosic biomass is enormously abundant around the globe. It bears huge potential for renewable products as its components can be converted to many useful products via cheaper processes.![]()
Collapse
Affiliation(s)
| | - Maliha Uroos
- Institute of Chemistry, University of the Punjab 54000 Lahore Pakistan
| | - Nawshad Muhammad
- Interdisciplinary Research Centre in Biomedical Materials (IRCBM), COMSATS University Islamabad, Lahore Campus 54600 Lahore Pakistan .,Department of Dental Materials, Institute of Medical Sciences Khyber Medical University Peshawar Pakistan
| |
Collapse
|
36
|
Liang X, Wang J, Bao H, Liu H. Accurately-controlled recovery and regeneration of protic ionic liquid after Ionosolv pretreatment via bipolar membrane electrodialysis with ultrafiltration. BIORESOURCE TECHNOLOGY 2020; 318:124255. [PMID: 33096443 DOI: 10.1016/j.biortech.2020.124255] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/11/2020] [Revised: 10/08/2020] [Accepted: 10/09/2020] [Indexed: 06/11/2023]
Abstract
Efficient recovery and regeneration of ionic liquid is significant for industrial Ionosolv pretreatment. Complicated electrolyte composition restricts the scale-up recovery and application of protic ionic liquid such as triethylammonium hydrogen sulfate [TEA][HSO4] in biomass-related research. Recovery of [TEA][HSO4] after Ionosolv pretreatment for miscanthus powder was studied using bipolar membrane electrodialysis (BMED) assisted with ultrafiltration (UF) by the divisional recovery of TEA+ as TEA and recovery of SO42- as H2SO4 in different BMED compartments. Hence accurately-controlled regeneration of [TEA][HSO4] could be realized. Influence of current density and feed concentration of BMED module was studied in detail. In this study, the highest recovery ratio for TEA+ and SO42- reached 93.7% and 96.4%. The lowest energy consumption of specific [TEA][HSO4] recovery was about 6.2 kwh/kg. Insight gained from this study suggests a potentially industrial methodology for complicated protic ionic liquid recovery after biomass processing.
Collapse
Affiliation(s)
- Xiaocong Liang
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China.
| | - Junyu Wang
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China
| | - Haizhen Bao
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China
| | - Hantao Liu
- Research Center of Shanxi Province for Solar Energy Engineering and Technology, School of Energy and Power Engineering, North University of China, Taiyuan 030051, China
| |
Collapse
|
37
|
Zhang T, Wei H, Xiao H, Li W, Jin Y, Wei W, Wu S. Advance in constructing acid catalyst-solvent combinations for efficient transformation of glucose into 5-Hydroxymethylfurfural. MOLECULAR CATALYSIS 2020. [DOI: 10.1016/j.mcat.2020.111254] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
38
|
Tampucci S, Guazzelli L, Burgalassi S, Carpi S, Chetoni P, Mezzetta A, Nieri P, Polini B, Pomelli CS, Terreni E, Monti D. pH-Responsive Nanostructures Based on Surface Active Fatty Acid-Protic Ionic Liquids for Imiquimod Delivery in Skin Cancer Topical Therapy. Pharmaceutics 2020; 12:pharmaceutics12111078. [PMID: 33187215 PMCID: PMC7697672 DOI: 10.3390/pharmaceutics12111078] [Citation(s) in RCA: 36] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/30/2020] [Revised: 11/06/2020] [Accepted: 11/07/2020] [Indexed: 12/12/2022] Open
Abstract
For topical treatment of skin cancer, the design of pH-responsive nanocarriers able to selectively release the drug in the tumor acidic microenvironment represents a reliable option for targeted delivery. In this context, a series of newly synthesized surface-active fatty acid-protic ionic liquids (FA-PILs), based on tetramethylguanidinium cation and different natural hydrophobic fatty acid carboxylates, have been investigated with the aim of developing a pH-sensitive nanostructured drug delivery system for cutaneous administration in the skin cancer therapy. The capability of FA-PILs to arrange in micelles when combined with each other and with the non-ionic surfactant d-α-Tocopherol polyethylene glycol succinate (vitamin E TPGS) as well as their ability to solubilize imiquimod, an immuno-stimulant drug used for the treatment of skin cancerous lesions, have been demonstrated. The FA-PILs-TPGS mixed micelles showed pH-sensitivity, suggesting that the acidic environment of cancer cells can trigger nanostructures’ swelling and collapse with consequent rapid release of imiquimod and drug cytotoxic potential enhancement. The in vitro permeation/penetration study showed that the micellar formulation produced effective imiquimod concentrations into the skin exposed to acid environment, representing a potential efficacious and selective drug delivery system able to trigger the drug release in the tumor tissues, at lower and less irritating drug concentrations.
Collapse
Affiliation(s)
- Silvia Tampucci
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
- Correspondence: (S.T.); (L.G.)
| | - Lorenzo Guazzelli
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
- Correspondence: (S.T.); (L.G.)
| | - Susi Burgalassi
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Sara Carpi
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
- NEST, Istituto Nanoscienze-CNR and Scuola Normale Superiore, Piazza San Silvestro 12, 56127 Pisa, Italy
| | - Patrizia Chetoni
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Andrea Mezzetta
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Paola Nieri
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Beatrice Polini
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Christian Silvio Pomelli
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Eleonora Terreni
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| | - Daniela Monti
- Department of Pharmacy, University of Pisa, Via Bonanno 6, 56127 Pisa, Italy; (S.B.); (S.C.); (P.C.); (A.M.); (P.N.); (B.P.); (C.S.P.); (E.T.); (D.M.)
| |
Collapse
|
39
|
Zhao ZM, Liu ZH, Pu Y, Meng X, Xu J, Yuan JS, Ragauskas AJ. Emerging Strategies for Modifying Lignin Chemistry to Enhance Biological Lignin Valorization. CHEMSUSCHEM 2020; 13:5423-5432. [PMID: 32750220 DOI: 10.1002/cssc.202001401] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/05/2020] [Revised: 07/19/2020] [Indexed: 06/11/2023]
Abstract
Biological lignin valorization represents a promising approach contributing to sustainable and economic biorefineries. The low level of valuable lignin-derived products remains a major challenge hindering the implementation of microbial lignin conversion. Lignin's properties play a significant role in determining the efficiency of lignin bioconversion. To date, despite significant progress in the development of biomass pretreatment, lignin fractionation, and fermentation over the last few decades, little efforts have gone into identifying the ideal lignin substrates for an efficient microbial metabolism. In this Minireview, emerging and state-of-the-art strategies for biomass pretreatment and lignin fractionation are summarized to elaborate their roles in modifying lignin structure for bioconversion. Fermentation strategies aimed at enhancing lignin depolymerization for microbial utilization are systematically reviewed as well. With an improved understanding of the ideal lignin structure elucidated by comprehensive metabolic pathways and/or big data analysis, modifying lignin chemistry could be more directional and effective. Ultimately, together with the progress of fermentation process optimization, biological lignin valorization will become more competitive in biorefineries.
Collapse
Affiliation(s)
- Zhi-Min Zhao
- School of Ecology and Environment, Inner Mongolia Key Laboratory of Environmental Pollution Controlling and Wastes Recycling, Inner Mongolia University, Hohhot, 010021, P. R. China
- Department of Chemical & Biomolecular Engineering, University of Tennessee Knoxville, Knoxville, TN 37996, USA
| | - Zhi-Hua Liu
- Synthetic and Systems Biology Innovation Hub (SSBiH), Texas A&M University, College Station, TX 77843, USA
- Department of Plant Pathology and Microbiology, Texas A&M University, College Station, TX 77843, USA
| | - Yunqiao Pu
- Center for Bioenergy Innovation, Joint Institute of Biological Science, Biosciences Division, Oak Ridge National Laboratory (ORNL), Oak Ridge, TN 37831, USA
| | - Xianzhi Meng
- Department of Chemical & Biomolecular Engineering, University of Tennessee Knoxville, Knoxville, TN 37996, USA
| | - Jifei Xu
- School of Ecology and Environment, Inner Mongolia Key Laboratory of Environmental Pollution Controlling and Wastes Recycling, Inner Mongolia University, Hohhot, 010021, P. R. China
| | - Joshua S Yuan
- Synthetic and Systems Biology Innovation Hub (SSBiH), Texas A&M University, College Station, TX 77843, USA
- Department of Plant Pathology and Microbiology, Texas A&M University, College Station, TX 77843, USA
| | - Arthur J Ragauskas
- Department of Chemical & Biomolecular Engineering, University of Tennessee Knoxville, Knoxville, TN 37996, USA
- Center for Bioenergy Innovation, Joint Institute of Biological Science, Biosciences Division, Oak Ridge National Laboratory (ORNL), Oak Ridge, TN 37831, USA
- Department of Forestry, Wildlife, and Fisheries, Center for Renewable Carbon, University of Tennessee Institute of Agriculture, Knoxville, TN 37996, USA
| |
Collapse
|
40
|
Saldarriaga-Hernández S, Velasco-Ayala C, Leal-Isla Flores P, de Jesús Rostro-Alanis M, Parra-Saldivar R, Iqbal HMN, Carrillo-Nieves D. Biotransformation of lignocellulosic biomass into industrially relevant products with the aid of fungi-derived lignocellulolytic enzymes. Int J Biol Macromol 2020; 161:1099-1116. [PMID: 32526298 DOI: 10.1016/j.ijbiomac.2020.06.047] [Citation(s) in RCA: 58] [Impact Index Per Article: 14.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/20/2020] [Revised: 06/03/2020] [Accepted: 06/05/2020] [Indexed: 02/08/2023]
Abstract
Lignocellulosic material has drawn significant attention among the scientific community due to its year-round availability as a renewable resource for industrial consumption. Being an economic substrate alternative, various industries are reevaluating processes to incorporate derived compounds from these materials. Varieties of fungi and bacteria have the ability to depolymerize lignocellulosic biomass by synthesizing degrading enzymes. Owing to catalytic activity stability and high yields of conversion, lignocellulolytic enzymes derived from fungi currently have a high spectrum of industrial applications. Moreover, these materials are cost effective, eco-friendly and nontoxic while having a low energy input. Techno-economic analysis for current enzyme production technologies indicates that synthetic production is not commercially viable. Instead, the economic projection of the use of naturally-produced ligninolytic enzymes is promising. This approach may improve the economic feasibility of the process by lowering substrate expenses and increasing lignocellulosic by-product's added value. The present review will discuss the classification and enzymatic degradation pathways of lignocellulolytic biomass as well as the potential and current industrial applications of the involved fungal enzymes.
Collapse
Affiliation(s)
- Sara Saldarriaga-Hernández
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Campus Monterrey, Ave. Eugenio Garza Sada 2501, Monterrey, Nuevo Leon 64849, Mexico
| | - Carolina Velasco-Ayala
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Campus Monterrey, Ave. Eugenio Garza Sada 2501, Monterrey, Nuevo Leon 64849, Mexico
| | - Paulina Leal-Isla Flores
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Campus Monterrey, Ave. Eugenio Garza Sada 2501, Monterrey, Nuevo Leon 64849, Mexico
| | - Magdalena de Jesús Rostro-Alanis
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Campus Monterrey, Ave. Eugenio Garza Sada 2501, Monterrey, Nuevo Leon 64849, Mexico
| | - Roberto Parra-Saldivar
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Campus Monterrey, Ave. Eugenio Garza Sada 2501, Monterrey, Nuevo Leon 64849, Mexico
| | - Hafiz M N Iqbal
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Campus Monterrey, Ave. Eugenio Garza Sada 2501, Monterrey, Nuevo Leon 64849, Mexico
| | - Danay Carrillo-Nieves
- Tecnologico de Monterrey, Escuela de Ingenieria y Ciencias, Av. General Ramón Corona 2514, Nuevo México, Zapopan C.P. 45138, Jalisco, Mexico.
| |
Collapse
|
41
|
Ghasemzadeh MA, Bakhshali‐Dehkordi R. Novel and Green Preparation of Fe
3
O
4
@TiO
2
‐Immobilized‐ILs Based on DABCO for Highly Efficient Synthesis of Primido[4,5‐d]pyrimidines. ChemistrySelect 2020. [DOI: 10.1002/slct.202002085] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
Affiliation(s)
- Mohammad Ali Ghasemzadeh
- Department of Chemistry, Qom BranchIslamic Azad University Qom, Iran Post Box: 37491–13191 I. R. Iran
| | | |
Collapse
|
42
|
Bakhshali‐Dehkordi R, Ghasemzadeh MA, Safaei‐Ghomi J. Preparation and characterization of a novel DABCO‐based ionic liquid supported on Fe
3
O
4
@TiO
2
nanoparticles and investigation of its catalytic activity in the synthesis of quinazolinones. Appl Organomet Chem 2020. [DOI: 10.1002/aoc.5721] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
Affiliation(s)
| | | | - Javad Safaei‐Ghomi
- Department of Organic Chemistry, Faculty of ChemistryUniversity of Kashan Kashan Iran
| |
Collapse
|
43
|
The molecular design and experimental study on the catalytic cleavage of linkages in lignin with binuclear ionic liquid. J Mol Liq 2020. [DOI: 10.1016/j.molliq.2020.113128] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/12/2023]
|
44
|
Bakhshali-Dehkordi R, Ghasemzadeh MA, Safaei-Ghomi J. Multicomponent Preparation of Quinazolinone Derivatives in the Presence of TiO2 Nanoparticles Supported Ionic Liquids. Polycycl Aromat Compd 2020. [DOI: 10.1080/10406638.2020.1759661] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/01/2023]
Affiliation(s)
| | | | - Javad Safaei-Ghomi
- Department of Organic Chemistry, Faculty of Chemistry, University of Kashan, Kashan, Iran
| |
Collapse
|
45
|
Naz S, Uroos M, Asim AM, Muhammad N, Shah FU. One-Pot Deconstruction and Conversion of Lignocellulose Into Reducing Sugars by Pyridinium-Based Ionic Liquid-Metal Salt System. Front Chem 2020; 8:236. [PMID: 32351933 PMCID: PMC7174784 DOI: 10.3389/fchem.2020.00236] [Citation(s) in RCA: 17] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/23/2019] [Accepted: 03/11/2020] [Indexed: 11/13/2022] Open
Abstract
Constantly decreasing fossil resources and exceeding energy demands are the most alarming concerns nowadays. The only way out is to develop efficient, safe, and economical biomass processing protocols that can lead toward biofuels and fine chemicals. This research is one of such consequences involving the deconstruction and conversion of wheat straw carbohydrate constituents into reducing sugars via one-pot reaction promoted by Lewis acidic pyridinium-based ionic liquids (PyILs) mixed with different metal salts (MCl). Various parameters such as the type of metal salt, loading amount of metal salt, time, temperature, particle size of biomass, and water content which affect the deconstruction of wheat straw have been evaluated and optimized. Among the studied ionic liquid (IL) and metal salt systems, the best results were obtained with [BMPy]+CoCl 3 - . The dinitrosalicylic acid (DNS) assay was used to determine the percentage of total reducing sugars (TRS) generated during treatment of wheat straw. The deconstructed wheat straw was characterized with various analytical tools, that is, Fourier transform infrared (FTIR) spectroscopy, scanning electron microscopy (SEM), and X-ray powder diffraction (XRD) analyses. The IL-metal salt system was recycled for subsequent treatment of wheat straw. Statistical parameters were calculated from analysis of variance (ANOVA) at the 0.05 level of confidence.
Collapse
Affiliation(s)
- Sadia Naz
- Institute of Chemistry, University of the Punjab, Lahore, Pakistan
| | - Maliha Uroos
- Institute of Chemistry, University of the Punjab, Lahore, Pakistan
| | | | - Nawshad Muhammad
- Interdisciplinary Research Centre in Biomedical Materials (IRCBM), COMSATS University Islamabad, Lahore, Pakistan
| | - Faiz Ullah Shah
- Chemistry of Interfaces, Luleå University of Technology, Luleå, Sweden
| |
Collapse
|
46
|
Green synthesis and immobilization of TiO2 NPs using ILs-based on imidazole and investigation of its catalytic activity for the efficient synthesis of pyrimido[4,5-d]pyrimidines. J Mol Struct 2020. [DOI: 10.1016/j.molstruc.2020.127698] [Citation(s) in RCA: 13] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/13/2023]
|
47
|
Vieira S, Barros MV, Sydney ACN, Piekarski CM, de Francisco AC, Vandenberghe LPDS, Sydney EB. Sustainability of sugarcane lignocellulosic biomass pretreatment for the production of bioethanol. BIORESOURCE TECHNOLOGY 2020; 299:122635. [PMID: 31882200 DOI: 10.1016/j.biortech.2019.122635] [Citation(s) in RCA: 31] [Impact Index Per Article: 7.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/29/2019] [Revised: 12/12/2019] [Accepted: 12/15/2019] [Indexed: 05/12/2023]
Abstract
The sustainability of a biofuel is severely affected by the technological route of its production. Chemical pretreatment can be considered the traditional method of decomposition of the lignocellulose into its mono and oligomeric units, which can be further bioconverted to ethanol. The evaluation of the recent advances in chemical pretreatments of sugarcane bagasse, especially diluted acids, alkaline, organosolv and ionic liquids, identified the critical points for sustainability. In this context, chemicals recovery and reutilization or their substitution by green solvents, heat and electricity generation through bioenergy, reutilization of water from evaporators, vinasse concentration and the upgrading of lignin were discussed as strategic routes for developing sustainable chemical-based lignocellulose pretreatment. The advances in the technologies that allow greater fractionation of lignocellulosic biomass should be focused on the minimization of the use of natural resources, effluent generation and energy expenditure.
Collapse
Affiliation(s)
- Sabrina Vieira
- Universidade Tecnológica Federal do Paraná UTFPR - Campus Ponta Grossa, Department of Bioprocess Engineering and Biotechnology, 84016-210 Ponta Grossa, Paraná, Brazil
| | - Murillo Vetroni Barros
- Universidade Tecnológica Federal do Paraná UTFPR - Campus Ponta Grossa, Sustainable Production Systems Laboratory (LESP), 84016-210 Ponta Grossa, Paraná, Brazil
| | - Alessandra Cristine Novak Sydney
- Universidade Tecnológica Federal do Paraná UTFPR - Campus Ponta Grossa, Department of Bioprocess Engineering and Biotechnology, 84016-210 Ponta Grossa, Paraná, Brazil
| | - Cassiano Moro Piekarski
- Universidade Tecnológica Federal do Paraná UTFPR - Campus Ponta Grossa, Sustainable Production Systems Laboratory (LESP), 84016-210 Ponta Grossa, Paraná, Brazil
| | - Antônio Carlos de Francisco
- Universidade Tecnológica Federal do Paraná UTFPR - Campus Ponta Grossa, Sustainable Production Systems Laboratory (LESP), 84016-210 Ponta Grossa, Paraná, Brazil
| | - Luciana Porto de Souza Vandenberghe
- Federal University of Paraná, Department of Bioprocess Engineering and Biotechnology, Centro Politécnico, 81531-990 Curitiba, Paraná, Brazil
| | - Eduardo Bittencourt Sydney
- Universidade Tecnológica Federal do Paraná UTFPR - Campus Ponta Grossa, Department of Bioprocess Engineering and Biotechnology, 84016-210 Ponta Grossa, Paraná, Brazil.
| |
Collapse
|
48
|
Treichel H, Fongaro G, Scapini T, Frumi Camargo A, Spitza Stefanski F, Venturin B. Waste Biomass Pretreatment Methods. UTILISING BIOMASS IN BIOTECHNOLOGY 2020. [DOI: 10.1007/978-3-030-22853-8_3] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/21/2022]
|
49
|
Galbe M, Wallberg O. Pretreatment for biorefineries: a review of common methods for efficient utilisation of lignocellulosic materials. BIOTECHNOLOGY FOR BIOFUELS 2019; 12:294. [PMID: 31890022 PMCID: PMC6927169 DOI: 10.1186/s13068-019-1634-1] [Citation(s) in RCA: 121] [Impact Index Per Article: 24.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/22/2019] [Accepted: 12/11/2019] [Indexed: 05/02/2023]
Abstract
The implementation of biorefineries based on lignocellulosic materials as an alternative to fossil-based refineries calls for efficient methods for fractionation and recovery of the products. The focus for the biorefinery concept for utilisation of biomass has shifted, from design of more or less energy-driven biorefineries, to much more versatile facilities where chemicals and energy carriers can be produced. The sugar-based biorefinery platform requires pretreatment of lignocellulosic materials, which can be very recalcitrant, to improve further processing through enzymatic hydrolysis, and for other downstream unit operations. This review summarises the development in the field of pretreatment (and to some extent, of fractionation) of various lignocellulosic materials. The number of publications indicates that biomass pretreatment plays a very important role for the biorefinery concept to be realised in full scale. The traditional pretreatment methods, for example, steam pretreatment (explosion), organosolv and hydrothermal treatment are covered in the review. In addition, the rapidly increasing interest for chemical treatment employing ionic liquids and deep-eutectic solvents are discussed and reviewed. It can be concluded that the huge variation of lignocellulosic materials makes it difficult to find a general process design for a biorefinery. Therefore, it is difficult to define "the best pretreatment" method. In the end, this depends on the proposed application, and any recommendation of a suitable pretreatment method must be based on a thorough techno-economic evaluation.
Collapse
Affiliation(s)
- Mats Galbe
- Department of Chemical Engineering, Lund University, P.O. Box 124, 221 00 Lund, Sweden
| | - Ola Wallberg
- Department of Chemical Engineering, Lund University, P.O. Box 124, 221 00 Lund, Sweden
| |
Collapse
|