Direct interspecies electron transfer (DIET) can be suppressed under ammonia-stressed condition - Reevaluate the role of conductive materials

Plasticizers inhibit food waste anaerobic digestion performance by affecting microbial succession and metabolism

The widely existed plastic additives plasticizers in organic wastes possibly pose negative influences on anaerobic digestion (AD) performance, the direct evidence about the effects of plasticizers on AD performance is still lacking. This study evaluated the influencing mechanism of two typical plasticizers bisphenol A (BPA) and dioctyl phthalate on the whole AD process. Results indicated that plasticizers addition inhibited methane production, and the inhibiting effects were reinforced with the increase of concentration. By contrast, 50 mg/L BPA exhibited the strongest inhibition on methane production. Physicochemical analysis showed plasticizers inhibited the metabolism efficiency of soluble polysaccharide and volatile fatty acids. Microbial communities analyses suggested that plasticizers inhibited the direct interspecies electron transfer participators of methanogenic archaea (especially Methanosarcina) and syntrophic bacteria. Furthermore, plasticizers inhibited the methane metabolisms, key coenzymes (CoB, CoM, CoF420 and methanofuran) biosynthesis and the metabolisms of major organic matters. This study shed light on the effects of plasticizers on AD performance and provided new insights for assessing the influences of plasticizers or plastic additives on the disposal of organic wastes.

Powdered activated carbon facilitated degradation of complex organic compounds and tetracycline in stressed anaerobic digestion systems

Tetracycline exerts an inhibitory effect on anaerobic digestion, inducing stressed microbial activities and even system failure. Continuous-flow reactors (CFRs) and sequencing batch reactors (SBRs) were employed along with the dosage of powdered activated carbon (PAC) to enhance tetracycline removal during anaerobic digestion of complex organic compounds. PAC increased the maximum methane production rate by 15.6% (CFRs) and 13.8% (SBRs), and tetracycline biodegradation by 24.4% (CFRs) and 19.2% (SBRs). CFRs showed higher tetracycline removal and methane production rates than SBRs. Geobacter was enriched in CFRs, where Methanothrix was enriched with the addition of PAC. Desulfomicrobium harbored abundant propionate degradation-related genes, significantly correlating with tetracycline removal. The genes encoding carbon dioxide reduction in Methanothrix along with the detection of Geobacter might indicate direct interspecies electron transfer for methanogenesis in CFRs and PAC-added reactors. The study offers new insights into anaerobic digestion under tetracycline-stressed conditions and strategies for optimizing tetracycline removal.

Multi-criteria-based decision-making assessment for anaerobic digestion of ammonia-rich distillery wastewater: Effect of pyrochar and temperature

Energy-efficient wastewater treatment units are imperative to achieve carbon neutrality and a circular economy at the industrial scale. In the present study, pyrochar loading and digestion temperature were tested to assess their impact on the performance of an anaerobic digester running on distillery wastewater. The digestion temperature (37 °C and 55 °C) and pyrochar loading (7.5 - 30 g/L.feed) were selected as two primary design factors. Experiments were designed using Taguchi's design of experiments and specific methane yield, total ammonia nitrogen, pH and buffering capacity were selected as experimental outputs for multi-criteria assessment. The results from the confirmation test indicated that the addition of pyrochar (7.5 g/Lfeed) improved the methane yield (276 ± 15 L/kg VS) significantly compared to the control (167 ± 15 L/kg VS) at 37 °C. The detailed post-digestion analysis showed that the adsorption of ammonia on pyrochar may be the primary reason for enhanced digester performance.

Comparing the mechanisms of syntrophic volatile fatty acids oxidation and methanogenesis recovery from ammonia stress in regular and biochar-assisted anaerobic digestion: Different roads lead to the same goal

Biochar has been recognized as a promising additive to mitigate ammonia inhibition during syntrophic methanogenesis, while the key function of biochar in this process is still in debates. This study clarified the distinct mechanisms of syntrophic volatile fatty acids -oxidizing and methanogenesis recovery from ammonia inhibition in regular and biochar-assisted anaerobic digestion. Under 5 g/L ammonia stress, adding biochar shortened the methanogenic lag time by 10.9% and dramatically accelerated the maximum methane production rate from 60.3 to 94.7 mLCH4/gVSsludge/d. A photometric analysis with a nano-WO3 probe revealed that biochar enhanced the extracellular electron transfer (EET) capacity of suspended microbes (Pearson's r = -0.98), confirming that biochar facilitated methanogenesis by boosting EET between syntrophic butyrate oxidizer and methanogens. Same linear relationship between EET capacity and methanogenic rate was not observed in the control group. Microbial community integrating functional genes prediction analysis uncovered that biochar re-shaped syntrophic partners by enriching Constridium_sensu_stricto/Syntrophomonas and Methanosarcina. The functional genes encoding Co-enzyme F420 hydrogenase and formylmethanofuran dehydrogenase were upregulated by 1.4-2.3 times, consequently enhanced the CO2-reduction methanogenesis pathway. Meanwhile, the abundances of gene encoding methylene-tetrahydrofolate transformation, a series of intermediate processes involved in acetate oxidation, in the biochar-assisted group were 28.2-63.7% higher than these in control group. Comparatively, Methanosaeta played a pivotal role driving aceticlastic methanogenesis in the control group because the abundance of gene encoding acetyl-CoA decarbonylase/synthase complex increased by 1.9 times, suggesting an aceticlastic combining H2-based syntrophic methanogenesis pathway was established in control group to resist ammonia stress. A 2nd period experiment elucidated that although depending on distinct mechanisms, the volatile fatty acid oxidizers and methanogens in both groups developed sustained and stable strategies to resist ammonia stress. These findings provided new insights to understand the distinct methanogenic recovery strategy to resist toxic stress under varied environmental conditions.

Elucidating Multiple Electron-Transfer Pathways for Metavanadate Bioreduction by Actinomycetic Streptomyces microflavus

While microbial reduction has gained widespread recognition for efficiently remediating environments polluted by toxic metavanadate [V(V)], the pool of identified V(V)-reducing strains remains rather limited, with the vast majority belonging to bacteria and fungi. This study is among the first to confirm the V(V) reduction capability of Streptomyces microflavus, a representative member of ubiquitous actinomycetes in environment. A V(V) removal efficiency of 91.0 ± 4.35% was achieved during 12 days of operation, with a maximum specific growth rate of 0.073 d-1. V(V) was bioreduced to insoluble V(IV) precipitates. V(V) reduction took place both intracellularly and extracellularly. Electron transfer was enhanced during V(V) bioreduction with increased electron transporters. The electron-transfer pathways were revealed through transcriptomic, proteomic, and metabolomic analyses. Electrons might flow either through the respiratory chain to reduce intracellular V(V) or to cytochrome c on the outer membrane for extracellular V(V) reduction. Soluble riboflavin and quinone also possibly mediated extracellular V(V) reduction. Glutathione might deliver electrons for intracellular V(V) reduction. Bioaugmentation of the aquifer sediment with S. microflavus accelerated V(V) reduction. The strain could successfully colonize the sediment and foster positive correlations with indigenous microorganisms. This study offers new microbial resources for V(V) bioremediation and improve the understanding of the involved molecular mechanisms.

Effects of zero-valent iron and magnetite on ethanol and lactic acid production in the anaerobic fermentation of food waste

With the increasing global concern about food waste management, finding efficient ways to convert it into valuable products is crucial. The addition of zero-valent iron and magnetite to enhance ethanol and lactic acid fermentation yields from food waste emerges as a potential solution. This study compared the effects of 50-nm and 500-nm particle sizes of zero-valent iron and magnetite on ethanol and lactic acid fermentation and analyzed the mechanism of action from the perspective of organic matter material transformation and microbiology. The experimental results showed that 500-nm particle size magnetite and zero-valent iron could promote the hydrolysis of polysaccharides and proteins. 500-nm particle size magnetite could increase ethanol production (1.4-fold of the control), while 500-nm particle size zero-valent iron could increase lactic acid production (2.8-fold of the control). Metagenomic analysis showed that 500-nm magnetite increased the abundance of genes for amino acid metabolic functions, while 500-nm zero-valent iron increased the abundance of glycoside hydrolase genes (1.3-fold of the control). It's worth noting that while these findings are promising, they are based on controlled experimental conditions, and real-world applications may vary. his research not only offers a novel approach to augmenting anaerobic fermentation yields but also contributes to sustainable food waste management practices, potentially reducing environmental impacts and creating valuable products.

Biochar facilitates methanogens evolution by enhancing extracellular electron transfer to boost anaerobic digestion of swine manure under ammonia stress

This study explored the mechanisms by which biochar mitigates ammonia inhibition in anaerobic digestion (AD) of swine manure. Findings show 2-8 g/L exogenous ammonia dosages gradually inhibited AD, leading to decreases in the efficiencies of hydrolysis, acidogenesis and methanogenesis by 3.4-70.8%, 6.0-82.0%, and 4.9-93.8%, respectively. However, biochar addition mitigated this inhibition and facilitated methane production. Biochar enhanced microbial activities related to electron transport and extracellular electron transfer. Moreover, biochar primarily enriched Methanosarcina, which, consequently, upregulated the genes encoding formylmethanofuran dehydrogenase and methenyltetrahydromethanopterin cyclohydrolase for the CO2-reducing methanogenesis pathway by 26.9-40.8%. It is believed that biochar mediated direct interspecies electron transfer between syntrophic partners, thereby enhancing methane production under ammonia stress. Interestingly, biochar removal did not significantly impact the AD performance of the acclimated microbial community. This indicated the pivotal role of biochar in triggering methanogen evolution to mitigate ammonia stress rather than the indispensable function after the enrichment of ammonia-resistance methanogen.

Stimulating anaerobic digestion to degrade recalcitrant organic pollutants: Potential role of conductive materials-led direct interspecies electron transfer

This review aims to provide a comprehensive understanding of the potential of CMs-dominated DIET in the degradation of recalcitrant organic pollutants in AD. The review covers the mechanisms and efficiencies of recalcitrant organic pollutant degradation by CMs-dominated DIET, the comparison of degradation pathways between DIET and chemical treatment, recent insights on DIET-enhanced degradation, and the evaluation of the potential and future development of CMs-dominated DIET. The review emphasizes the importance of coupled syntrophic microorganisms, electron flux, and physicochemical properties of CMs in enhancing the degradation performance of AD. Additionally, it highlights the advantages of DIET-led syntrophic metabolism over traditional oxidation technologies in terms of environmental friendliness and efficiency. Finally, the review acknowledges the potential risks associated with introducing CMs into AD systems and provides guidance for waste treatment and energy recovery.

Unravelling the resilience of magnetite assisted granules to starvation and oxytetracycline stress

Starvation and antibiotics pollution are two frequent perturbations during breeding wastewater treatment process. Supplying magnetite into anaerobic system has been proved efficient to accelerate microbial aggregates and alleviate the adverse effect caused by process disturbance. Nevertheless, whether these magnetite-based granules are still superior over normal granules after a long-term starvation period remains unknown, the responsiveness of these granules to antibiotics stress is also ambiguous. In current study, we investigated the resilience of magnetite-based anaerobic granular sludge (AnGS) to starvation and oxytetracycline (OTC) stress, by unravelling the variations of reactor performance, sludge properties, ARGs dissemination and microbial community. Compared with the AnGS formed without magnetite, the magnetite assisted AnGS appeared more robust defense to starvation and OTC stress. With magnetite supplement, the average methane yield after starvation recovery, 50 mg/L and 200 mg/L OTC stress was enhanced by 48.95%, 115.87% and 488.41%, respectively, accompanied with less VFAs accumulation, improved tetracycline removal rate (76.3-86.6% vs. 51.0-53.5%) and higher ARGs reduction. Meanwhile, magnetite supplement effectively ameliorated the potential sludge breakage by triggering more large granules formation. Trichococcus was considered an important impetus in maintaining the stability of magnetite-based AnGS process. By inducing more syntrophic methanogenesis partnerships, especially for hydrogenotrophic methanogenesis, magnetite ensured the improved reactor performance and stronger resilience at stress conditions.

Revealing the mechanism of novel nitrogen-doped biochar supported magnetite (NBM) enhancing anaerobic digestion of waste-activated sludge by sludge characteristics

Anaerobic digestion (AD) is a promising technology in waste treatment and energy recovery. However, it suffers from long retention time and low biogas yield. In this study, novel nitrogen-doped biochar supported magnetite (NBM) was synthesized and applied to enhance the AD of waste-activated sludge. Results showed that NBM increased cumulative methane production and SCOD removal efficiency by up to 1.75 times and 15% respectively at 5 g/L compared with the blank. NBM enhanced both hydrolysis and methanogenesis process during AD and the activities of α-glucosidase, protease, coenzyme F₄₂₀ and electron transport system were increased by 19%, 163%, 104% and 160% respectively at 5 g/L NBM compared with the blank. NBM also facilitated the secretion of conductive protein in extracellular polymeric substances as well as the formation of conductive pili, leading to 3.18-7.59 times higher sludge electrical conductivity. Microbial community analysis revealed that bacteria Clostridia and archaea Methanosarcina and Methanosaeta were enriched by the addition of NBM, and direct interspecies electron transfer might be promoted between them. This study provides a practical reference for future material synthesis and its application.

Integrated genome-centric metagenomic and metaproteomic analyses unravel the responses of the microbial community to ammonia stress

Ammonia is a major inhibitor in anaerobic digestion of nitrogen-rich organic wastes. In this study, integrated genome-centric metagenomic and metaproteomic analyses were used to identify the key microorganisms and metabolic links causing instability by characterizing the process performance, microbial community, and metabolic responses of key microorganisms during endogenous ammonia accumulation. The identification of 89 metagenome-assembled genomes and analysis of their abundance profile in different operational phases permitted the identification of key taxa (Firmicutes and Proteobacteria) causing poor performance. Metabolic reconstruction indicated that the key taxa had the genetic potential to participate in the metabolism of C2C5 volatile fatty acids (VFAs). Further investigation suggested that during Phase I, the total ammonia nitrogen (TAN) level was maintained below 2000 mg N/L, and the reactor showed a high methane yield (478.30 ± 33.35 mL/g VS) and low VFAs concentration. When the TAN accumulated to > 2000 mg N/L, acid accumulation, mainly of acetate, began to occur, and the methane yield gradually decreased to 330.44 mL/g VS (Phase II). During this phase, the VFA degradation functions of the community were mainly mediated by Firmicutes. Approximately 61.54% of significant differentially expressed proteins (DEPs) related to acetate metabolism in Firmicutes were down-regulated, which led to an increase in acetate concentration to 4897.91 ± 1558.96 mg/L. However, the reactor performance showed spontaneous recovery without any interference (Phase III), during which Firmicutes gradually adapted to the high ammonia conditions. Approximately 75% of the significant DEPs related to acetate metabolism of Proteobacteria were also up-regulated in Phase III compared with Phase II; thus, VFA-related metabolic functions of the community were enhanced, which resulted in a decrease in the total VFA concentration to 195.39 mg/L. When the TAN increased above 4000 mg N/L, the system gradually showed acid accumulation dominated by propionate, accompanied by a second decrease in methane yield (Phase IV). During this phase, the number of up-regulated and down-regulated proteins related to acetate metabolism of Firmicutes and butyrate/valerate metabolism of Proteobacteria was comparable with that of Phase III, indicating that the metabolic functions related to acetate, butyrate, and valerate of the microbial community were not significantly affected. However, for propionate metabolism, the expression activity of fumarate hydratase from Firmicutes and Proteobacteria was severely inhibited by ammonia, as shown by down-regulation ratios of 63.64% and 85.71%, respectively. No protein with the same function that was not inhibited by ammonia could be detected, and the fumarate degradation function of the microbial community was severely damaged, leading to blocked propionate metabolism and irreversible deterioration of reactor performance. This study has provided a new perspective on the microecological mechanisms of ammonia inhibition.

Conductive materials enhance microbial salt-tolerance in anaerobic digestion of food waste: Microbial response and metagenomics analysis

Previous studies have shown that high salinity environments can inhibit anaerobic digestion (AD) of food waste (FW). Finding ways to alleviate salt inhibition is important for the disposal of the growing amount of FW. We selected three common conductive materials (powdered activated carbon, magnetite, and graphite) to understand their performance and individual mechanisms that relieve salinity inhibition. Digester performances and related enzyme parameters were compared. Our data revealed that under normal and low salinity stress conditions, the anaerobic digester ran steady without significant inhibitions. Further, the presence of conductive materials promoted conversion rate of methanogenesis. This promotion effect was highest from magnetite > powdered activated carbon (PAC) > graphite. At 1.5% salinity, PAC and magnetite are beneficial in maintaining high methane production efficiency while control and the graphite added digester acidified and failed rapidly. Additionally, metagenomics and binning were used to analyze the metabolic capacity of the microorganisms. Some species enriched by PAC and magnetite possessed higher cation transport capacities and were to accumulate compatible solutes. PAC and magnetite promoted direct interspecies electron transference (DIET) and syntrophic oxidation of butyrate and propionate. Also, the microorganisms had more energy available to cope with salt inhibition in the PAC and magnetite added digesters. Our data imply that the promotion of Na+/H+ antiporter, K+ uptake, and osmoprotectant synthesis or transport by conductive materials may be crucial for their proliferation in highly stressful environments. These findings will help to understand the mechanisms of alleviate salt inhibition by conductive materials and help to recover methane from high-salinity FW.

Effectively facilitating the degradation of chloramphenicol by the synergism of Shewanella oneidensis MR-1 and the metal-organic framework

Electroactive bacteria (EAB) and metal oxides are capable of synergistically removing chloramphenicol (CAP). However, the effects of redox-active metal-organic frameworks (MOFs) on CAP degradation with EAB are not yet known. This study investigated the synergism of iron-based MOFs (Fe-MIL-101) and Shewanella oneidensis MR-1 on CAP degradation. 0.5 g/L Fe-MIL-101 with more possible active sites led to a three-fold higher CAP removal rate in the synergistic system with MR-1 (initial bacterial concentration of 0.2 at OD₆₀₀), and showed a superior catalytic effect than exogenously added Fe(III)/Fe(II) or magnetite. Mass spectrometry revealed that CAP was transformed into smaller molecular weight and less toxic metabolites in cultures. Transcriptomic analysis showed that Fe-MIL-101 enhanced the expression of genes related to nitro and chlorinated contaminants degradation. Additionally, genes encoding hydrogenases and c-type cytochromes associated with extracellular electron transfer were significantly upregulated, which may contribute to the simultaneous bioreduction of CAP both intracellularly and extracellularly. These results indicated that Fe-MIL-101 can be used as a catalyst to synergize with EAB to effectively facilitate CAP degradation, which might shed new light on the application in the in situ bioremediation of antibiotic-contaminated environments.

Novel nitrogen-doped biochar supported magnetite promotes anaerobic digestion: Material characterization and metagenomic analysis

Although different conductive materials have been applied to anaerobic digestion, there has not been a material that can really combine their merits and make up their shortcoming from each other. In this study, a novel nitrogen-doped biochar supported magnetite (Fe₃O₄@N-BC) was synthesized. Various material characterizations confirmed that nitrogen atoms were successful doped into the biochar and magnetite precipitated on its surface. 5 g/L Fe₃O₄@N-BC achieved the highest promotion of cumulative CH₄ production by 1.75 times compared with the blank group. Further metagenomic analysis revealed that Fe₃O₄@N-BC could increase the gene abundances of pilA, MmcA, Fpo, Rnf and HdrEd in bacteria Clotridium, Pseudomonas and Syntrophomonas and archaea Methanosarcina. Redundancy analysis showed that it was electrical conductivity and electron exchange capacity that were the key physicochemical characteristics for Fe₃O₄@N-BC to facilitating direct interspecies electron transfer. This study provides a reference for future conductive material synthesis and its application for anaerobic digestion.

Conductive materials as fantastic toolkits to stimulate direct interspecies electron transfer in anaerobic digestion: new insights into methanogenesis contribution, characterization technology, and downstream treatment

Direct interspecies electron transfer (DIET) stimulated by conductive materials (CMs) enables intercellular metabolic coupling that can address the unfavorable thermodynamical dilemma inherent in anaerobic digestion (AD). Although the DIET mechanism and stimulation have been extensively summarized, the methanogenesis contribution, characterization techniques, and downstream processes of CMs-led DIET in AD are surprisingly under-reviewed. Therefore, this review aimed to address these gaps. First, the contribution of CMs-led DIET to methanogenesis was re-evaluated by comparing the effect of various factors, including volatile fatty acids, free ammonia, and functional enzymes. It was revealed that AD systems are usually intricate and cannot allow the methanogenesis stimulation to be singularly attributed to the establishment of DIET. Additionally, considerable attention has been attached to the characterization of DIET occurrence, involving species identification, gene expression, electrical properties, cellular features, and syntrophic metabolism, suggesting the significance of accurate characterization methods for identifying the syntrophic metabolism interactions. Moreover, the type of CMs has a significant impact on AD downstream processes involving biogas purity, sludge dewaterability, and biosolids management. Finally, the central bottleneck consists in building a mathematical model of DIET to explain the mechanism of DIET in a deeper level from kinetics and thermodynamics.

Enhancing anaerobic fermentation of waste activated sludge by investigating multiple electrochemical pretreatment conditions: Performance, modeling and microbial dynamics

Electrochemical pretreatment (EPT) is an efficient technology to improve volatile fatty acids (VFAs) production during anaerobic fermentation of waste activated sludge (WAS). This study investigated the co-effects of different current intensities, electrolyte NaCl dosage and pretreatment time for promoting VFAs production. The results showed that it was considerably enhanced by 51.6 % when EPT was performed at 1.0 A, 1.0 g/L and 60 min, and response surface methodology strategy adjusted the optimal EPT conditions to 1.0 A, 1.2 g/L and 66 min. The potential mechanisms were proposed that EPT at optimal conditions greatly enhanced solubilization and hydrolysis of WAS and selectively inactivated methanogens, causing the enrichment of acidogenic bacteria (i.e., Lactobacillus, Saccharimonadales, Tetrasphaera and Prevotella) due to generated reactive chlorine species. Finally, the economic analysis indicated the promising application potential with the profit of EPT at optimal conditions increasing by 36.0 %.

Metagenomic analysis reveals the size effect of magnetite on anaerobic digestion of waste activated sludge after thermal hydrolysis pretreatment

Although magnetite has been widely investigated in anaerobic digestion (AD), its role in the practical AD of waste-activated sludge (WAS) after thermal hydrolysis pretreatment (THP) and its size effect remain unclear. In this study, magnetite with four different particle sizes was added during the AD of WAS after THP. With the reduction of magnetite particle size, cumulative methane production was increased, while the optimal dosage of magnetite decreased, with 0.1 μm magnetite at an optimal dosage of 2 g/L achieving the highest cumulative methane production increase of 111.97 % compared with the blank group (without magnetite). Smaller magnetite particles increased α-glucosidase and protease activities, coenzyme F₄₂₀ concentration, and electron-transport system activity (20.30 %, 173.02 %, 60.39 % and 158.08 % higher respectively than the blank group). The size of magnetite also influenced the establishment of direct interspecies electron transfer (DIET) during AD. Based on the analysis of the pilA gene abundance, magnetite with a large particle size could promote the formation of e-pili in syntrophic electroactive bacteria (Clostridium, Syntrophomonas, and Pseudomonas) and methanogens (Methanospirillum), thereby completing electron transfer. However, small-sized magnetite particles stimulated DIET by enhancing the secretion of conductive proteins in extracellular polymeric substances and membrane-bound enzymes (Fpo) in Methanosarcina.

Polylactide (PLA) as a Cell Carrier in Mesophilic Anaerobic Digestion-A New Strategy in the Management of PLA

The management of waste polylactide (PLA) in various solutions of thermophilic anaerobic digestion (AD) is problematic and often uneconomical. This paper proposes a different approach to the use of PLA in mesophilic AD, used more commonly on the industrial scale, which consists of assigning the function of a microbial carrier to the biopolymer. The study involved the testing of waste wafers and waste wafers and cheese in a co-substrate system, combined with digested sewage sludge. The experiment was conducted on a laboratory scale, in a batch bioreactor mode. They were used as test samples and as samples with the addition of a carrier: WF-control and WFC-control; WF + PLA and WFC + PLA. The main objective of the study was to verify the impact of PLA in the granular (PLAG) and powder (PLAP) forms on the stability and efficiency of the process. The results of the analysis of physicochemical properties of the carriers, including the critical thermal analysis by differential scanning calorimetry (DSC), as well as the amount of cellular biomass of Bacillus amyloliquefaciens obtained in a culture with the addition of the tested PLAG and PLAP, confirmed that PLA can be an effective cell carrier in mesophilic AD. The addition of PLAG produced better results for bacterial proliferation than the addition of powdered PLA. The highest level of dehydrogenase activity was maintained in the WFC + PLAG system. An increase in the volume of the methane produced for the samples digested with the PLA granules carrier was registered in the study. It went up by c.a. 26% for WF, from 356.11 m³ Mg^-1 VS (WF-control) to 448.84 m³ Mg^-1 VS (WF + PLAG), and for WFC, from 413.46 m³ Mg^-1 VS, (WFC-control) to 519.98 m³ Mg^-1 VS (WFC + PLAG).

Zero-valent iron is not always effective in enhancing anaerobic digestion performance

Liquid nitrogen was employed as a low-temperature medium to activate zero-valent iron (ZVI) powder in an attempt to strengthen its enhancement effect on anaerobic digestion (AD) of swine manure (SM). Surprisingly, it was found that both pristine ZVI and liquid nitrogen-pretreated ZVI (LZVI) did not significantly improve the AD performance or change the archaeal community structure. It was hypothesized that ZVI might not be effective at stress-free environment like in these digesters. To confirm this, an additional set of AD experiments were performed at high ammonia stress (about 4000 mg/L), results showed that ZVI and LZVI greatly alleviated ammonia inhibition and increased the CH₄ yield by 11.6% and 28.2%, respectively. Apparently, ZVI mainly affected AD systems by changing the metabolism pathways and enhancing the microbial activity to overcome process inhibition, and pretreatment of liquid nitrogen could significantly accelerate the dissolution of ZVI and improve its utilization efficiency, contributing to a greater extend of process recovery and improvement.

Enhanced methane production in anaerobic digestion: A critical review on regulation based on electron transfer

Anaerobic digestion (AD) is a potential bioprocess for waste biomass utilization and energy conservation. Various iron/carbon-based CMs (e.g., magnetite, biochar, granular activated carbon (GAC), graphite and zero valent iron (ZVI)) have been supplemented in anaerobic digestors to improve AD performance. Generally, the supplementation of CMs has shown to improve methane production, shorten lag phase and alleviate environmental stress because they could serve as electron conduits and promote direct interspecies electron transfer (DIET). However, the CMs dosage varied greatly in previous studies and CMs wash out remains a challenge for its application in full-scale plants. Future work is recommended to standardize the CMs dosage and recover/reuse the CMs. Moreover, additional evidence is required to verify the electrotrophs involved in DIET.

Effects of various materials used to promote the direct interspecies electron transfer on anaerobic digestion of low-concentration swine manure

The activation of direct interspecies electron transfer (DIET) by the supplementation of conductive materials is one of the effective and available methods to enhance anaerobic digestion (AD). Microorganisms that colonize the surface of these materials form biofilms, the study of which could provide new insights into the character of the DIET process and its effect on AD. The present study focused on AD performance, microbial community, as well as morphological and topological features of biofilms on various materials used to promote DIET during AD of low-concentration swine manure. The best AD characteristics were observed in stainless steel mesh (SM)/digested cow manure (CM) and polyester felt (PF)/digested sewage sludge (SS) combinations used as material/inoculum, respectively. Thus, potential methane yields in CM-SM and SS-PF were up to 26.4% and 26.2% higher compared to the corresponding controls. Microbial analysis of biofilms revealed the dominance of putatively syntrophic bacteria of the MBA03 group of the Limnochordia class in CM inoculated reactors, and syntrophic proteolytic bacteria of the genus Coprothermobacter and acetogenic Clostridium sensu stricto 1, known for their ability to carry out DIET, in SS inoculated reactors. Biofilms on non-conductive materials contained pili-like structures, which were observed only in SS inoculated reactors. Polyester felt tended to biofoul better than carbon felt, resulting in up to 2.8, 3.2 and 1.8 higher nucleic acid, extracellular polymeric substances, and total biomass content, respectively, depending on the inoculum. These results provide new insights into the different types of DIET that can occur in low-loaded AD systems with attached growth.

Role of interspecies electron transfer stimulation in enhancing anaerobic digestion under ammonia stress: Mechanisms, advances, and perspectives

Ammonia stress is a commonly encountered issue in anaerobic digestion (AD) process when treating proteinaceous substrates. The enhanced relationship between syntrophic bacteria and methanogens triggered by interspecies electron transfer (IET) stimulation is one of the potential mechanisms for an improved methane yield from the AD plant under ammonia-stressed condition. There is, however, lack of synthesized information on the mechanistic understanding of IET facilitation in the ammonia-stressed AD processes. This review critically discusses recovery of AD system from ammonia-stressed condition, focusing on H₂ transfer, redox compound-mediated IET, and conductive material-induced direct IET. The effects and the associated mechanisms of IET stimulation on mitigating ammonia stress and promoting methanogenesis were elucidated. Finally, prospects and challenges of IET stimulation were critically discussed. This review highlights, for the first time, the critical role of IET stimulation in enhancing AD process under ammonia-stressed condition.

Potential of biogas residue biochar modified by ferric chloride for the enhancement of anaerobic digestion of food waste

Biogas residue biochar (BRB) and BRB modified by ferric chloride (BRB-FeCl₃) were applied to promote anaerobic digestion (AD) of food waste (FW), related mechanisms were also proposed in this study. Results indicated BRB-FeCl₃ showed higher specific surface area, more abundant functional groups and impregnate iron than BRB, and they respectively increased 22.50% and 12.79% cumulative methane yields compared with control group because of accelerated volatile fatty acids (VFAs) transformation, which were confirmed by enhanced metabolism of glycolysis, fatty acid degradation and pyruvate. BRB, especially BRB-FeCl₃ facilitated the growth of Syntrophomonas, Methanofollis, Methanoculleus and Methanosarcina, which further promoted the methanogenesis by enhancing the metabolic activities of methanol, dimethylamine and methylamine pathways, thereby causing more metabolically diverse methanogenic pathways. Metagenomics analysis revealed BRB, especially BRB-FeCl₃ promoted the relative abundances of functional genes involved in direct interspecies electron transfer (DIET). Present study explored the enhancement mechanisms and feasibility of BRB-FeCl₃ for AD process.

Quantitative and Qualitative Changes in the Genetic Diversity of Bacterial Communities in Anaerobic Bioreactors with the Diatomaceous Earth/Peat Cell Carrier

This paper analyses the impact of the diatomaceous earth/peat (DEP; 3:1) microbial carrier on changes in the bacterial microbiome and the development of biofilm in the anaerobic digestion (AD) of confectionery waste, combined with digested sewage sludge as inoculum. The physicochemical properties of the carrier material are presented, with particular focus on its morphological and dispersion characteristics, as well as adsorption and thermal properties. In this respect, the DEP system was found to be a suitable carrier for both mesophilic and thermophilic AD. The evaluation of quantitative and qualitative changes in the genetic diversity of bacterial communities, carried out using next-generation sequencing (NGS), showed that the material has a modifying effect on the bacterial microbiome. While Actinobacteria was the most abundant cluster in the WF-control sample (WF—waste wafers), Firmicutes was the dominant cluster in the digested samples without the carrier (WF-dig.; dig.—digested) and with the carrier (WF + DEP). The same was true for the count of Proteobacteria, which decreased twofold during biodegradation in favor of Synergistetes. The Syntrophomonas cluster was identified as the most abundant genus in the two samples, particularly in WF + DEP. This information was supplemented by observations of morphological features of microorganisms carried out using fluorescence microscopy. The biodegradation process itself had a significant impact on changes in the microbiome of samples taken from anaerobic bioreactors, reducing its biodiversity. As demonstrated by the results of this innovative method, namely the BioFlux microfluidic flow system, the decrease in the number of taxa in the digested samples and the addition of DEP contributed to the microbial adhesion in the microfluidic system and the formation of a stable biofilm.

Electrical stimulation enhancing anaerobic digestion under ammonia inhibition: A comprehensive investigation including proteomic analysis

Microbial electrolysis cell (MEC) coupled anaerobic digestion (AD), named as MEC-AD system, can effectively promote methane production under ammonia inhibition, but the inherent mechanism is still poorly understood. This study comprehensively explored the MEC-AD performance and mechanism under high-concentration ammonia stress including using proteomic analysis. It was found that the methane generation rates in MEC-AD systems were 2.0-2.7 times that of AD ones under 5.0 g/L ammonia stress. Additionally, the experimental conditions for methane generation in MEC-AD systems were optimized using response surface methodology. Further analysis indicates that the activities of acetate kinase and F₄₂₀ were improved, and particularly the direct interspecies electron transfer (DIET) was promoted in MEC-AD systems, as indicated by increased electroactive extracellular polymeric substance, decreased charge transfer resistance, and enrichment of electroactive microbes such as Geobacter on the bioelectrodes. Moreover, proteomic analysis reveals that the DIET associated proteins such as Cytochrome C was up-regulated, and ammonia transfer-related proteins were down-regulated and ammonium detoxification-related proteins were up-regulated in MEC-AD systems. This work provides us a better understanding on the MEC-AD performance especially for the treatment of wastewater containing high-concentration ammonia.

Consolidation of hydrogenotrophic methanogenesis by sulfidated nanoscale zero-valent iron in the anaerobic digestion of food waste upon ammonia stress

The feasibility of adding sulfidated nanoscale zero-valent iron (S-nZVI) into anaerobic systems to improve anaerobic digestion of food waste (FW) under ammonia stress was evaluated in this study. The addition of S-nZVI improved the methane production compared to nanoscale zero-valent iron (nZVI), indicating that sulfidation significantly reinforced the enhancement effect of nZVI in consolidating the hydrogenotrophic methanogenesis. The promoted methanogenic performance was associated with chemical reaction and variances of microbial community induced by S-nZVI. With the characteristics of generation of Fe²⁺ and slow-release of H₂, S-nZVI made the anaerobic system respond positively in facilitating extracellular polymeric substances secretion and optimizing the microbial community structure. Moreover, microbial community analysis showed that S-nZVI addition enriched the species related to biohydrogen production (e.g., Prevotella) and ammonia-tolerant hydrogenotrophic methanogenesis (e.g., Methanoculleus), possibly enhancing the hydrogenotrophic methanogenesis pathway to accelerate methane production. Therefore, adding S-nZVI into the anaerobic systems might propose a feasible engineering strategy to improve the methanogenic performance of the anaerobic digestion of FW upon ammonia stress.

The role of biochar on alleviating ammonia toxicity in anaerobic digestion of nitrogen-rich wastes: A review

This paper reviewed the mechanisms of biochar in relieving ammonia inhibition. Biochar affects nitrogen-rich waste's anaerobic digestion (AD) performance through four ways: promotion of direct interspecies electron transfer (DIET) and microbial growth, adsorption, pH buffering, and provision of nutrients. Biochar enhances the DIET pathway by acting as an electron carrier. The role of DIET in relieving ammonia nitrogen may be exaggerated because many related studies don't provide definite evidence. Therefore, some bioinformatics technology should be used to assist in investigating DIET. Biochar absorbs ammonia nitrogen by chemical adsorption (electrostatic attraction, ion exchange, and complexation) and physical adsorption. The absorption efficiency, mainly affected by the properties of biochar, pH and temperature of AD, can reach 50 mg g^-1 on average. The biochar addition can buffer pH by reducing the concentrations of VFAs, alleviating ammonia inhibition. In addition, biochar can release trace elements and increase the bioavailability of trace elements.

Response of methanogenic granules enhanced by magnetite to ammonia stress

Excessive ammonia has an inhibitory effect on anaerobic granular sludge (AnGS) when treating industrial wastewater with high concentration of ammonia and organic matters. The addition of conductive materials has been widely reported to improve the AnGS activity, which has the potential to alleviate the ammonia inhibition. In this study, the addition of magnetite was carried out to enhance the activity of AnGS in UASB reactor, then the response of AnGS to different ammonia levels was investigated. Results showed that magnetite facilitated the enrichment of Methanosaeta and Clostridium sensu stricto 1. Under the ammonia stress (up to 5 g TAN/L), it was interesting that Methanosaeta was better retained (abundance of 45.8%), and the abundance of ammonia-resistant Clostridium sensu stricto 1 increased to 34.3% in presence of magnetite. RT-qPCR analysis revealed that Methanosaeta could maintain metabolically active for counteracting the ammonia inhibition along with the higher transcription of genes encoding for CO₂-dependent pathway. The electron transport activity and ATP content of AnGS were 1.25-2.12 and 1.23-2.56 folds higher than those in the control group, respectively. In addition, the AnGS could maintain the stability of structure because Methanosaeta was the skeleton of AnGS. As a result, the analysis of enzyme activity showed that the overall methanogenic metabolism was more active, thus ensured the effective operation of UASB reactor. This study provided the scientific understanding about the role of magnetite to alleviate the ammonia inhibition, and had important implications for stable treatment and recycling of industrial wastewater.

Combined effect of zero valent iron and magnetite on semi-dry anaerobic digestion of swine manure

Combined effect of zero valent iron (ZVI) and magnetite on semi-dry anaerobic digestion of swine manure was studied. Compared with control, the addition of 5 g/L ZVI, magnetite and their mixture (1:1 wt) increased the CH₄ yield by 17.6%, 22.7% and 21.9%, respectively. The three additives improved CH₄ production through altering the metabolism pathways, rather than improving the solid degradation efficiency. ZVI promoted interspecies hydrogen transfer (IHT) by enriching H₂-comsuming Methanolinea and acetate-oxidizing bacteria (Sedimentibacter and Clostridium). Magnetite enriched dissimilatory iron reduction bacteria (Acinetobacter) to accelerate organic hydrolysis and established direct interspecies electron transfer (DIET) by enriching Methanothrix and Methanospirillum. Key microorganisms relative to IHT (Clostridium) and DIET (Methanothrix and Methanospirillum) were simultaneously enriched with ZVI + magnetite, but they only showed an additive effect on methanogenesis, the lack of synergetic effect was attributable to the possible trade-off between IHT and DIET, or the little improvement effect of additives on substrate biodegradability.

Effects of sludge thermal hydrolysis pretreatment on anaerobic digestion and downstream processes: mechanism, challenges and solutions

Thermal hydrolysis pretreatment (THP), as a step prior to sludge anaerobic digestion (AD), is widely applied due to its effectiveness in enhancing organic solids hydrolysis and subsequent biogas productivity. However, THP also induces a series of problems including formation of refractory compounds in THP cylinder, high residual ammonia and organic in the AD centrate, inhibition on downstream nitrogen removal process and reduction in UV-disinfection effectiveness during post-treatment. More attention should be paid on how to mitigate these negative effects. Despite intensive studies were carried out to reduce refractory compounds formation and enhance biological performance, there is limited effort to discuss the solutions to tackle the THP associated problems in a holistic manner. This paper summarizes the solutions developed to date and analyzes their technology readiness to assess application potential in full-scale settings. The content highlights the limitations of THP and proposes potential solutions to address the technological challenges.

Activated carbon modified with nano manganese dioxide triggered electron transport pathway changes for boosted anaerobic treatment of dyeing wastewater

Herein, an expanded granular sludge bed (EGSB) reactor with activated carbon (AC)-nano manganese dioxide (MnO₂) added was employed for azo dye wastewater treatment to investigate its effectiveness at decolorizing of azo dyes and removing COD. The results showed that the treatment of azo dye wastewater with the AC-MnO₂ modified EGSB reactor gave an 83% average decolorization efficiency, which was more efficient than the pure AC modified EGSB reactor. Moreover, the COD removal and changes in the intermediate products were controlled by AC-MnO₂. Additionally, there was a sharp increase in the sludge conductivity, while there was a significant decrease in the coenzyme F₄₂₀ concentration with long-term operation. Moreover, electrochemical analysis showed that the addition of AC-MnO₂ can enhance electron transfer in anaerobic system. The AC-MnO₂ can act as redox mediator; in the presence of the Mn⁴⁺/Mn²⁺ cycle, accelerating the electron transfer between the microbial cells and dyes, thereby promoting the decolorization of azo dyes. This caused a decrease in the methanogenic activity. Furthermore, high-throughput sequencing showed that the relative abundances of Pseudomonas and Desulfovibrio were significantly high among the acidogenic bacteria community, while Methanobacterium and Methanosaeta had very low abundances from among the methanogenic archaea community.

Syntrophic propionate-oxidizing bacteria in methanogenic systems

The mutual nutritional cooperation underpinning syntrophic propionate degradation provides a scant amount of energy for the microorganisms involved, so propionate degradation often acts as a bottleneck in methanogenic systems. Understanding the ecology, physiology and metabolic capacities of syntrophic propionate-oxidizing bacteria (SPOB) is of interest in both engineered and natural ecosystems, as it offers prospects to guide further development of technologies for biogas production and biomass-derived chemicals, and is important in forecasting contributions by biogenic methane emissions to climate change. SPOB are distributed across different phyla. They can exhibit broad metabolic capabilities in addition to syntrophy (e.g. fermentative, sulfidogenic and acetogenic metabolism) and demonstrate variations in interplay with cooperating partners, indicating nuances in their syntrophic lifestyle. In this review, we discuss distinctions in gene repertoire and organization for the methylmalonyl-CoA pathway, hydrogenases and formate dehydrogenases, and emerging facets of (formate/hydrogen/direct) electron transfer mechanisms. We also use information from cultivations, thermodynamic calculations and omic analyses as the basis for identifying environmental conditions governing propionate oxidation in various ecosystems. Overall, this review improves basic and applied understanding of SPOB and highlights knowledge gaps, hopefully encouraging future research and engineering on propionate metabolism in biotechnological processes.

Effect of magnetite on anaerobic digestion treating saline wastewater: Methane production, biomass aggregation and microbial community dynamics

In this study, the effect of magnetite amendment on anaerobic digestion was investigated at three increasing salinity levels (0.5%, 1% and 2% NaCl). The amendment of magnetite enhanced the methane yield by 36.3%, 33.3% and 16.5% at low salinity (0.5% NaCl) and high salinity (1% and 2% NaCl), respectively. Meanwhile, a larger proportion of granules was obtained in the magnetite amended reactor (48.05% vs 33.16% at the end of operation). Microbial analysis suggested magnetite could induce more methanogenesis partnerships between hydrogenotrophic methanogens and syntrophic bacteria. Methanosaeta and Methanocorpusculum were the alternating dominant methanogens at low salinity and high salinity. While Streptococcus and Mesotoga were two prevalent bacteria that showed totally different transition tendency in two reactors. Additionally, the supplement of magnetite could relieve the suppression of methanogenesis-related gene expression caused by salinity, thus facilitated the higher methane production.

Impact of biochar supported nano zero-valent iron on anaerobic co-digestion of sewage sludge and food waste: Methane production, performance stability and microbial community structure

This work evaluates the effects of biochar supported nano zero-valent iron (nZVI-BC) on anaerobic co-digestion (co-AD) of sewage sludge and food waste. Kinetic model analysis suggested that nZVI-BC addition significantly increased the methane production potential (R₀) and daily methane production rate (G_m) by 42.87% and 49.87%, while the raw biochar only increased R₀ and G_m by 5.11% and 6.73%, respectively. Supplementation of higher concentrations of nZVI-BC was not preferable as inhibition of methane productivity was appeared. nZVI-BC addition remarkably improved organics degradation efficiency, as the reduction rate of TCOD, VSS and TSS were increased by 34.93%, 11.44% and 13.96%, respectively. The microbial analysis demonstrated that nZVI-BC facilitated the growth of hydrogentrophic methanogens, while acetotrophic methanogens which can only use acetate as electron donor were restrained. The study demonstrated nZVI-BC can effectively strengthen methanogenesis mainly through the enhancement of DIET between bacteria and methanogens, and the enrichment of hydrogenotrophic methanogens.

Combined microbial transcript and metabolic analysis reveals the different roles of hydrochar and biochar in promoting anaerobic digestion of waste activated sludge

Hydrothermal pretreatment of waste activated sludge (WAS) could eliminate the rate limiting step of anaerobic digestion (AD) -hydrolysis. However, the high organic loading rate may cause acid accumulation, thus leading to an unstable system. This study compared the effect of different hydrochar (HC2-260°C and HC3-320°C) and biochar (BC5-500°C and BC7-700°C) on AD of hydrothermal pretreated WAS (HPS). Results demonstrated that hydrochar was superior to biochar in the methane yield and production rate, especially HC2. HC2 had the highest surface oxygen-containing functional groups that could facilitate direct interspecies electron transfer (DIET). The enhanced methane yield was related with the increased protein utilization, and hydrochar and biochar enriched different microbes related to protein degradation. Metabolomic analysis showed the significantly changed metabolites induced by hydrochar and biochar were involved in fatty acids and amino acids-related metabolism, indicating the rapid conversion of intermediated products, which was consistent with the microbial community structure results. Hydrochar and biochar also induced upregulation of metabolites related to microbial metabolic activity and extracellular electron transfer. Although biochar induced the same metabolic changes, the alterations of these metabolites were weaker than those of hydrochar. The results of this study offered new insights into the molecular mechanisms of enhanced AD of HPS by hydrochar and biochar.

Mini art review for zero valent iron application in anaerobic digestion and technical bottlenecks

Zero valent iron (ZVI) has been used extensively to control environmental pollution owing to its strong reducibility and low cost. Herein, we evaluate the impact of ZVI (iron scrap and ZVI powder with different scales) on anaerobic digestion (AD) reactor performance improvement and syntrophic relationship stimulation among various microbial groups in the methanogenesis process. In recent studies, ZVI addition significantly enhanced methane and volatile fatty acid (VFA) yields and alleviated excessive acidification, ammonia accumulation, and odorous gas production. Further, we reviewed the changes in enzyme activity and microbial metabolism after the addition of ZVI throughout the reaction process. Certain innovative technologies, such as bioelectrochemical system assistance and combined usage of conductive materials, may improve AD performance compared to the use of ZVI alone, the mechanism of which has been discussed from various viewpoints. Furthermore, the primary technical bottlenecks, such as poor mass transfer efficiency in dry AD and high ZVI dosage, have been illustrated, and syntrophic methanogenesis regulated by ZVI addition can be further studied by conducting theoretical research.

Promoting direct interspecies electron transfer and acetoclastic methanogenesis for enhancing anaerobic digestion of butanol octanol wastewater by coupling granular activated carbon and exogenous hydrogen

Butanol octanol wastewater (BOW) generated from syngas conversion of coal contained abundant toxic organic pollutants. Anaerobic digestion is a promising technology for BOW, but abundant toxic substances would inhibit the activity of anaerobic microorganisms. Granular activated carbon (GAC) and exogenous hydrogen (EH₂) were employed to enhance anaerobic digestion of BOW. The results indicated that methane production increased to 289.55 ± 17.43 mL CH₄/g COD in EH₂/GAC group, which was 1.07, 2.04, and 1.98 times of that in GAC, EH₂, and control groups, respectively. In EH₂/GAC group. The relative abundance of Geobacter and Methanosaeta increased rapidly to 25.36% and 52.81%, respectively, and the relative abundance of Clostridium was 9.78%. The underlying mechanism might be that GAC promoted the enrichment of Geobacter, and EH₂ changed metabolic mechanism of Clostridium, stimulating the enrichment of Methanosaeta. Direct interspecies electron transfer was promoted by EH₂/GAC, thus improving the methane production rate of BOW.

Mitigation of acidogenic product inhibition and elevated mass transfer by biochar during anaerobic digestion of food waste

Anaerobic digestion (AD) of food waste is widely accepted as a promising technology for both waste disposal and resource recovery. With the advancing of AD technology, to exploit the capacity of organic waste for maximum energy/resource recovery becomes the new focus and hence, improve the viability of this technology for practical application. Product inhibition and mass transfer are the common limitations encountered during AD of putrescible organic waste. Biochar materials have been widely used to promote AD process in recent years. This review summarizes the mechanism and regulation strategies of biochar and its modified derivatives in promoting AD of solid waste (mainly food waste) from the three aspects of hydrolysis, syntrophic acetogenesis, and methane production. At the same time, the relationship between carbon materials and electron transfer among anaerobic microbes is summarized from the perspective of microbial community. In addition, the market application of this technology was evaluated.

Promoting anaerobic co-digestion of sewage sludge and food waste with different types of conductive materials: Performance, stability, and underlying mechanism

In this research, we investigated and compared the effects of three widely used conductive materials, e.g., zero-valent iron (Fe⁰), magnetite (Fe₃O₄), and biochar on the performance, stability, and in-depth mechanism during the anaerobic co-digestion process of sewage sludge and food waste. Among the three conductive materials, Fe⁰ could achieve the highest cumulative methane production of 394.0 mL/g volatile solids (VS) _added, which was 1.24-fold and 1.17-fold higher than that receiving Fe₃O₄ and biochar. The mechanistic studies indicated that compared to the Fe₃O₄ and biochar groups, Fe⁰ could significantly enhance the release of soluble protein, polysaccharide, and dissolved organic matters, the degradation of volatile fatty acids and VS, and the activities of key enzymes and direct interspecies electron transfer (DIET). Consequently, the methane yield and digestate dewaterability were notably improved. Collectively, these findings will offer suggestions of the preferable conductive materials in the anaerobic co-digestion process for decision makers.

Algae biochar enhanced methanogenesis by enriching specific methanogens at low inoculation ratio during sludge anaerobic digestion

Carbon materials are promising in improving the performance of anaerobic digestion, however, interactive mechanisms between the carbon-based enhancement and operating parameters remained unclear. Using anaerobic digested sludge as inoculum, the effects of Taihu blue algae biochar (ABC) on methanogenesis at different inoculation ratios were investigated during sludge anaerobic digestion. Results showed that ABC enhanced methane productions at the lower inoculation ratios (4% and 1%, v/v), but not at the higher ratio (10%, v/v). Mechanism analysis demonstrated methanogenic improvements at the lower inoculation ratios were not owing to initial organic loading rate increments. Otherwise, ABC addition at the lower inoculation ratios were more favorable for the enrichment of Methanosarcina than the higher ratio, which might be benefit for methanogenesis through directed interspecies electron transfer. Thus, for the improvement of sludge anaerobic digestion, the microbial enrichments at different inoculation ratios would be more important than the merely biochar addition.

Engineering anaerobic digestion via optimizing microbial community: effects of bactericidal agents, quorum sensing inhibitors, and inorganic materials

Anaerobic digestion of sewage sludge (SS) is one of the effective ways to reduce the waste generated from human life activities. To date, there are many reports to improve or repress methane production during the anaerobic digestion of SS. In the anaerobic digestion process, many microorganisms work positively or negatively, and as a result of their microbe-to-microbe interaction and regulation, methane production increases or decreases. In other words, understanding the complex control mechanism among the microorganisms and identifying the strains that are key to increase or decrease methane production are important for promoting the advanced production of bioenergy and beneficial compounds. In this mini-review, the literature on methane production in anaerobic digestion has been summarized based on the results of antibiotic addition, quorum sensing control, and inorganic substance addition. By optimizing the activity of microbial groups in SS, methane or acetate can be highly produced. KEY POINTS: • Bactericidal agents such as an antibiotic alter microbial community for enhanced CH₄ production. • Bacterial interaction via quorum sensing is one of the key points for biofilm and methane production. • Anaerobic digestion can be altered in the presence of several inorganic materials.

Proteomics reveal biomethane production process induced by carbon nanotube

Biomethane produced by methanogenic archaea is a main greenhouse resource of terrestrial and marine ecosystems, which strongly affects the global environment change. Conductive materials, especially nano-scale, show considerable intervention on biomethane production potential, but the mechanism is still unclear. Herein, we precisely quantified the absolute abundance of Methanosarcina spp. proteins affected by carbon nanotubes (CNTs) using tandem mass tag (TMT) proteomics technology. Among the 927 detectable proteins, more than three hundred, 304, showed differential expression. Gene Set Enrichment Analysis on KEGG pathways and GO biological processes revealed a trend of decreased protein synthesis induced by CNTs, suggesting these conductive nanomaterials may replace part of the cell structure and function. Interestingly, increased acetoclastic methanogenesis actually came at the expense of reduced protein synthesis in related pathways. CNTs stimulated biomethane production from acetate by stimulating intracellular redox activity and the -COOH oxidation process. These findings enhanced the understanding of the biomethane production process affected by conductive materials.

Genome-Centric Metatranscriptomics Analysis Reveals the Role of Hydrochar in Anaerobic Digestion of Waste Activated Sludge

Anaerobic digestion (AD) of waste activated sludge (WAS) has been widely used, while it poses problems including low methane yield and production rate. Hydrochar is produced by hydrothermal liquefaction of biomass; however, little is known about the role of hydrochar in promoting AD of WAS. The present study showed that hydrochar increased the methane production rate by 30.8% and yield by 31.4% of hydrothermal pretreated dewatered WAS. Hydrochar increased the methane production rate and yield by enhancing the acidification and methanogenesis processes. Genomic-centric metatranscriptomics were used to identify the metabolic activities and transcriptomic response of individual metagenome-assembled genomes that were enriched by hydrochar. Although Methanosarcina sp. FDU0106 had been shown unable to used H₂, it had the complete pathway for the reduction of CO₂ to methane. Syntrophomonas sp. FDU0164 expressed genes for extracellular electron transfer via electrically pili, suggesting that Syntrophomonas sp. FDU0164 and Methanosarcina sp. FDU0106 were exchanging electrons via direct interspecies electron transfer. The expression of pili was decreased, indicating that hydrochar could replace its roles. Additionally, Firmicutes sp. FDU0048, Proteiniphilum sp. FDU0082, and Aminobacterium mobile FDU0089 were related to the degradation of organics, which could be related to the enhanced methane yield.

Direct interspecies electron transfer mechanism in enhanced methanogenesis: A mini-review

The role of direct interspecies electron transfer (DIET) on enhancement of methanogenesis has been studied. This mini-review updated the current researches on the potential role of DIET on enhanced performance for anaerobic digestion of organic substrates with effective strategies implemented. Since most experimental observations correlated with the DIET mechanism are yet to be consolidated, this article categorized and discussed the current experimental observations supporting DIET mechanism for methanogenesis, mainly based on those with supplement of carbon materials, from which the prospects and challenges for further studies to confirm the role of DIET in anaerobic digestion processes were highlighted.

Insight into the performance and microbial community profiles of magnetite-amended anaerobic digestion: Varying promotion effects at increased loads

In current study, the enhancement effect of magnetite on anaerobic digestion was evaluated at increased organic loading rate (OLR) from 1.6 to 25.6 kg COD·m^-3·d^-1. The supplement of magnetite enhanced the methane yield by 7-483% accompanied with faster VFAs conversion. Microbial analysis suggested the varied enhancing effect achieved at different OLRs was attributed to different syntrophic interactions triggered by magnetite. More specially, an electroactive syntropy was established between Trichococcus with Methanobacterium at OLR lower than 6.4 kg COD·m^-3·d^-1, while with the OLR increase, more acid fermentative bacteria (Propionimicrobium, Syner-01) were enriched and further enhanced methanogenesis in a syntrophic way with Methanosaeta. Overall, the incorporation of magnetite was a promising approach to achieve efficient anaerobic digestion, OLR was also critical factor affecting the methanogenesis and should be carefully regulated in future application.

Sparking Anaerobic Digestion: Promoting Direct Interspecies Electron Transfer to Enhance Methane Production

Anaerobic digestion was one of the first bioenergy strategies developed, yet the interactions of the microbial community that is responsible for the production of methane are still poorly understood. For example, it has only recently been recognized that the bacteria that oxidize organic waste components can forge electrical connections with methane-producing microbes through biologically produced, protein-based, conductive circuits. This direct interspecies electron transfer (DIET) is faster than interspecies electron exchange via diffusive electron carriers, such as H2. DIET is also more resilient to perturbations such as increases in organic load inputs or toxic compounds. However, with current digester practices DIET rarely predominates. Improvements in anaerobic digestion associated with the addition of electrically conductive materials have been attributed to increased DIET, but experimental verification has been lacking. This deficiency may soon be overcome with improved understanding of the diversity of microbes capable of DIET, which is leading to molecular tools for determining the extent of DIET. Here we review the microbiology of DIET, suggest molecular strategies for monitoring DIET in anaerobic digesters, and propose approaches for re-engineering digester design and practices to encourage DIET.