Extraction of total phenolic content from Azadirachta indica or (neem) leaves: Kinetics study

Proximate composition, some phytochemical constituents, potential uses, and safety of neem leaf flour: A review

Globally, there is a growing concern about avoiding using artificial compounds in food ingredients, food preservation, and packaging. Among the parts of the neem tree, leaf flour is one of the most commonly used parts in some countries for food and medicinal purposes and is known for containing several nutrients and phytochemicals. In this review, the proximate composition, phytochemical constituents, potential uses, and safety issues of neem leaf flour are discussed. Neem leaf flour contains high levels of crude protein, total carbohydrate, crude fat, and fiber and moderate amounts of crude fat and ash. In addition, it contains numerous health-promoting phytochemical constituents. Some phytochemicals, such as ascorbic acid, saponin, total alkaloids, carotenoids, total phenols, total flavonoids, and the total antioxidant capacity of neem leaf flour, have been critically discussed. Neem leaf flour has various potential applications in food science, such as preserving foods and preparing food packaging materials. However, researchers' perspectives on its safety are not yet in agreement. In general, the proximate compositions, phytochemical constituents, potential uses, and safety issues of neem leaf flour were compiled and critically reviewed. In addition, research is needed to identify all the toxic substances found in neem leaves and develop methods to eliminate them that hinder their use for various purposes in food. Further research is needed to develop food products from neem leaf flour and evaluate its nutritional value and phytochemical constituents.

Green and efficient extraction of phenolic compounds from Neem leaves using deep eutectic solvents based ultrasonic-assisted extraction

Deep eutectic solvent (DES) combined with ultrasonic-assisted extraction was employed as an environmentally friendly technique for extracting antioxidant phenolic compounds from Neem leaves in place of organic solvents. Choline chloride-Ethylene glycol (1:2) with 40% V/V water content (DES-1) was investigated as a potential total phenolic content extractant (38.2 ± 1.2 mg GAE/g DW, where GAE: gallic acid equivalent, DW: dry weight). The optimal operational parameters assessed using single-factor experiments to maximize the total phenolic compounds content were as follows: extraction time of 30 min, 40% V/V water content, liquid-solid ratio of 15:1, and room temperature. Additionally, the in-vitro antioxidant experiments (2,2-diphenyl-1- picrylhydrazyl radical scavenging assay and ferric reducing antioxidant power assay) demonstrated the DES-1-based extract of Neem leaves as a potent antioxidant agent, compared to traditional solvents. Moreover, microscopic morphological analysis supported the effectiveness of DES-1 for the noticeable alteration in the fiber surface structure of Neem leaves after extraction which benefited in the release of polyphenols from these leaves. Eventually, the mass analysis of the extract disclosed the presence of eleven polyphenols in the extract. The Green Analytical Procedure Index revealed the greenness of the extraction method.

Optimization studies on batch extraction of phenolic compounds from Azadirachta indica using genetic algorithm and machine learning techniques

Phenolic compounds play a crucial role as secondary metabolites due to their substantial biological activity and medicinal value. These compounds are present in various parts of plant species. This study focused on solid-liquid batch extraction to recover total phenolic compounds from Azadirachta indica leaves. The experimental design was based on the Taguchi L16 array, considering four independent factors: extraction time, temperature, particle size, and solid-to-solvent ratio. Among these factors, the particle size exerted the maximum influence. Particle size inversely affects the yield of total phenolic content (TPC), while temperature, time, and solid-to-liquid ratio have a direct impact. The process factors concerned were investigated both experimentally and through machine learning techniques. Support vector regression (SVR) and random forest method (RFM) algorithms were utilized for predicting TPC, while a genetic algorithm (GA) was employed to derive optimal process parameters. The GA predicts the optimal extraction factors, yielding the maximum TPC. During this study, these factors were the following: particle size of 0.15 mm, extraction time of 40 min, solid-to-liquid ratio of 1:25 g/mL, and a temperature of 55 °C, with a predicted value of 23.039 mg GAE/g of plant material. Notably, in this study, the SVR values of TPC yield closely matched the experimental values for the training and test data set when compared with the random forest method values.

The hypocholesterolemic effect of methanolic extract of Bassia muricata l. on hypercholesterolemic rats

Hypercholesterolemia is correlated with cardiovascular diseases. The search for effective alternatives for lipid-lowering drugs is continuous. We investigated the hypocholesterolemic activity of Bassia muricata methanolic extract (BMME) in a model of hyperlipidemia. B. muricata was extracted with methanol. Male rats were randomly divided into six groups: normal control group (G1) was fed normal diet, negative control group (G2) was fed high cholesterol and fat diet (HCFD), positive control group (G3) was fed HCFD and treated with atorvastatin (20 mg/kg), a fourth, fifth and sixth groups (G4, G5, and G6) were fed HCFD and treated with 10, 30 and 100 mg/Kg of BMME, respectively. All rat groups received, for 4 weeks, the appropriate daily dose after initial two weeks of feeding normal diet or HCFD. Body weight, lipid profile, serum glucose, liver enzymes were measured weekly. HCFD caused an increased total cholesterol (TC), low-density lipoprotein cholesterol (LDL-C), and glucose, decreased triglycerides (TG) and high-density lipoprotein cholesterol (HDL-C), and blunted the normal gain of body weight. BMME doses restored the normal gain of body weight, caused significant decrease in serum TC, LDL-C, and increased HDL-C when compared to G2. 10 mg/kg and 30 mg/kg of BMME failed to induce any change in alkaline phosphatase whereas 100 mg/Kg of BMME caused a significant increase in alanine transaminase. 10 mg/kg and 30 mg/kg of BMME significantly decreased serum glucose whereas 100 mg/kg BMME significantly increased it. BMME had significant hypocholesterolemic effect and 100 mg/kg BMME increased alanine transaminase, TG and glucose in rats.

Graphical abstract

Biosynthesized selenium nanoparticles to rescue coccidiosis-mediated oxidative stress, apoptosis and inflammation in the jejunum of mice

One of the most crucial approaches for treating human diseases, particularly parasite infections, is nanomedicine. One of the most significant protozoan diseases that impact farm and domestic animals is coccidiosis. While, amprolium is one of the traditional anticoccidial medication, the advent of drug-resistant strains of Eimeria necessitates the development of novel treatments. The goal of the current investigation was to determine whether biosynthesized selenium nanoparticles (Bio-SeNPs) using Azadirachta indica leaves extract might treat mice with Eimeria papillata infection in the jejunal tissue. Five groups of seven mice each were used, as follows: Group 1: Non-infected-non-treated (negative control). Group 2: Non-infected treated group with Bio-SeNPs (0.5 mg/kg of body weight). Groups 3-5 were orally inoculated with 1×10³ sporulated oocysts of E. papillata. Group 3: Infected-non-treated (positive control). Group 4: Infected and treated group with Bio-SeNPs (0.5 mg/kg). Group 5: Infected and treated group with the Amprolium. Groups 4 and 5 daily received oral administration (for 5 days) of Bio-SeNPs and anticoccidial medication, respectively, after infection. Bio-SeNPs caused a considerable reduction in oocyst output in mice feces (97.21%). This was also accompanied by a significant reduction in the number of developmental parasitic stages in the jejunal tissues. Glutathione reduced (GSH), glutathione peroxidase (GPx), and superoxide dismutase (SOD) levels were dramatically reduced by the Eimeria parasite, whereas, nitric oxide (NO) and malonaldehyde (MDA) levels were markedly elevated. The amount of goblet cells and MUC2 gene expression were used as apoptotic indicators, and both were considerably downregulated by infection. However, infection markedly increased the expression of inflammatory cytokines (IL-6 and TNF-α) and the apoptotic genes (Caspase-3 and BCL2). Bio-SeNPs were administrated to mice to drastically lower body weight, oxidative stress, and inflammatory and apoptotic indicators in the jejunal tissue. Our research thus showed the involvement of Bio-SeNPs in protecting mice with E. papillata infections against jejunal damage.

Ethanol Extracts of Eriobotrya japonica (Loquat) Seeds, Leaves, and Fruits Have Anti-obesity and Hypolipidemic Effects in Rats

Background:

Obesity is a serious public health problem contributing to development of several diseases, including hyperlipidemia, hyperglycemia, and hypertension. The plant Eriobotrya japonica (loquat) has been used in traditional Chinese medicine to treat many ailments and traditional healers used it to reduce weight.

Objective:

To examine the potential anti-obesity and hypolipidemic effects of ethanol extract of loquat in rats.

Materials and Methods:

Loquat leaves, fruits, or seeds were extracted with ethanol. About 96 Wistar male rats were fed either a normal rat diet (normal control group; group 1) or a high-fat diet (HFD) for 12 weeks (obese; groups 2−12). Obese rats were divided into11 groups as follows: (obese control: group 2) (obese positive control which received the hypolipidemic reference drug atorvastatin: group 3). Groups (4−6), (7−9), and (10−12) were given seed, leaf, or fruit extract, respectively, at 40,100, and 400 mg/kg. Body weight, serum glucose, lipid profile, creatinine, liver enzymes, albumin, and total protein were measured weekly.

Results:

HFD consumption significantly increased body weight and serum total cholesterol (TC), triglycerides (TGs), low-density lipoprotein (LDL), very-low density lipoprotein (VLDL), and glucose and decreased HDL compared to rats fed the normal diet. HFD also increased serum glutamic-oxaloacetic transaminase (GOT), gamma-glutamyl transferase (GGT), alkaline phosphatase (ALP) and creatinine but decreased serum albumin and total protein. Administration of E. japonica seed, leaf, or fruit extract significantly decreased body weight, TC, TGs, LDL, VLDL, glucose, liver, and renal enzymes but increased HDL, albumin, and total protein levels.

Conclusion:

E. japonica seed, leaf, and fruit ethanol extract regulates body weight gain, has hypolipidemic properties, and positively affects liver and kidney enzymes.

Antibacterial and Antiproliferative Activities of Azadirachta indica Leaf Extract and Its Effect on Oil-in-Water Food Emulsion Stability

The present study aims to identify and quantify the phenolic compounds of Azadirachta indica leaf extract using HPLC-MS and to evaluate the antioxidant, antibacterial (against different Gram-positive and negative bacteria) and in vitro anti-proliferative activities of this extract (against breast, human liver and cervix adenocarcinoma-derived cells). The application of this extract as a natural antioxidant for food preservation was also tested on oil-in-water food emulsions for the first time in the present work in order to determine the use of Azadirachta indica leaves as a natural additive to preserve the food against lipid oxidation and rancidity. The results obtained revealed that 50%-aqueous ethanol leaf extract showed the best extraction yield (25.14%), which was characterized by a high content in phenolic compounds and strong antioxidant activity. Moreover, this leaf extract inhibited the growth of the bacterial strains tested (Staphylococcus aureus, Escherichia coli, Salmonella paratyphi and Micrococcus luteus) and showed better anti-proliferative activity against breast and cervix adenocarcinoma-derived cells than human liver cancer cells after 48 h of treatment. Additionally, Azadirachta indica leaf extract showed almost similar effects as gallic acid solutions (0.25% and 0.5%) in preserving the oxidation of oil-in-water food emulsions and prevented the formation of secondary oxidation products (malondialdehyde) as well. The results obtained suggested that extracts of Azadirachta indica leaves are a potential source of antioxidant and antibacterial compounds and pointed to the potential of these natural extracts as therapeutic agents.

Inclusion of Natural Antioxidants of Mango Leaves in Porous Ceramic Matrices by Supercritical CO2 Impregnation

Mango is one of the most important, medicinal tropical plants in the world from an economic point of view due to the presence of effective bioactive substances as co-products in its leaves. The aim of this work was to enhance the impregnation of natural antioxidants from mango leaves into a porous ceramic matrix. The effects of pressure, temperature, impregnation time, concentration of the extract and different porous silica on impregnation of phenolic compounds and antioxidant activity were analyzed. The volume of the pressurized fluid extract and amount of porous ceramic matrix remained constant. The best impregnation conditions were obtained at 6 h, 300 bar, 60 mg/mL, 35 °C and with MSU-H porous silica. The results indicated that increasing the pressure, concentration of the extract and temperature during impregnation with phenolic compounds such as gallic acid and iriflophenone 3-C (2-O-p-hydroxybenzolyl)-β-D-glucoside increased the antioxidant activity and the amount of total phenols.

Effects of a Dried Neem Leaf Extract on the Growth Performance, Meat Yield and Meat Quality in Skeletal Muscle of Broiler Chickens Under High-Temperature Conditions

We aimed to examine the effects of cyclical high ambient temperature (HT) and dried Neem (Azadirachta indica) leaf extract (DNE) supplementation on the growth performance, muscle lipid peroxidation level, and muscle drip loss of broiler chickens. Twenty-four 15-day old broiler chickens (Chunky strain ROSS 308) were divided into four treatment groups that were fed diets with or without 2.0% DNE under thermoneutral (25 ± 1°C) or cyclical HT (35 ± 1°C for 8 h/day) conditions. Supplementation of DNE did not affect the growth performance of the chicks, but HT reduced their feed intake, the weights of breast muscle and heart. In addition, supplementation with DNE ameliorated the negative effects of cyclical HT on feed intake and breast muscle mass. Furthermore, cyclical HT increased the malondialdehyde (MDA) concentration and drip loss over 48 h of storage of the breast muscle, and these effects were ameliorated by DNE. Collectively, we conclude that dietary supplementation with DNE reduces the muscle MDA concentration and drip loss of broiler chickens kept under HT conditions.

Effects of Supplementation with Dried Neem Leaf Extract on Lipid Peroxidation and Antioxidant Enzyme mRNA Expression in the Pectoralis Major Muscle of Broiler Chickens

This study was conducted to evaluate the effects of dietary supplementation of dried neem (Azadirachta indica) leaf extract (DNE) on lipid peroxidation and the expression of genes encoding mRNAs in antioxidant enzymes in the pectoralis major muscle of chickens. A total of 24 male broiler chickens (ROSS308) were divided into three groups (n=8) at 21 days of age. The control group of chickens was fed a basal diet, and the remaining two groups of chickens were fed a basal diet supplemented with DNE at a concentration of 0.5% or 2.0% until 35 days of age. Growth performance (body weight, weight gain, feed intake, and feed conversion ratio) and tissue weights did not differ among the three groups. The 2.0% DNE-supplemented diet decreased the muscle malondialdehyde content, a marker of lipid peroxidation, and drip loss compared to the control chickens. In addition, the expression of genes encoding mRNAs of antioxidant enzymes (i.e., Cu/Zn-superoxide dismutase, Mn-superoxide dismutase, glutathione peroxidase 7, and catalase) were higher in the pectoralis major muscle of chickens fed the 2.0% DNE-supplemented diet than in the control chickens. Therefore, DNE supplementation increased the expression of genes encoding mRNAs in antioxidant enzymes and reduced lipid peroxidation and drip loss in the pectoralis major muscle of broiler chickens.

The inhibitory effect of a novel neem paste against cariogenic bacteria

Background

Dental caries is a major oral health problem, which associates with cariogenic bacteria. Streptococcus mutans and Lactobacillus acidophilus are facultative anaerobic bacteria that are found in tooth decay. Accordingly, neem leaf extract was developed due to its great anti-microbial property against many bacteria. The aim of this study was to determine anti-cariogenic properties of neem leaf extract in a novel paste preparation.

Material and Methods

The neem extract was derived from maceration of dry neem leaves in ethanol for 48 h. The ethanolic extract was subjected to chemical identification using GC-MS. Neem pastes were prepared from ethanolic extract mixed with polyethylene glycol paste with or without zinc oxide. S. mutans and L. acidophilus test were initiated at bacterial concentration of 108 CFU/ml. The antibacterial activity was then performed by disc diffusion method following by minimum bactericidal concentration (MBC) technique.

Results

GC-MS result displayed 35 compounds. Compounds found in the extract were n-Hexadecanoic acid (31.18%), Hentriacontane (18%), Phytol (16.79%). Disc diffusion showed that ethanolic extract and neem pastes inhibited growth of both bacteria. For MBC, neem paste with zinc oxide at concentration of neem 0.4 mg/ml was the most effective concentration on inhibiting S. mutans growth. Neem pastes and ethanolic extract at concentration of neem 6.25 mg/ml inhibited L. acidophilus growth.

Conclusions

The ethanolic neem leaf extract and novel neem pastes had antimicrobial effect on both S. mutans and L. acidophilus. By this property, neem paste could be developed for the application in dental field, i.e. pulp capping.

Key words:Neem, Azadirachta indica, antimicrobial, cariogenic bacteria.

Kinetic modelling of the solid-liquid extraction process of polyphenolic compounds from apple pomace: influence of solvent composition and temperature

This study aims to assess kinetic modelling of the solid-liquid extraction process of total polyphenolic compounds (TPC) from apple pomace (AP). In this regard, we investigated the effects of temperature and solvent (i.e. water, ethanol, and acetone) on TPC extraction over various periods. The highest TPC yield of 11.1 ± 0.49 mg gallic acid equivalent (GAE)/g db (dry basis) was achieved with a mixture of 65% acetone-35% water (v/v) at 60 °C. The kinetics of the solvent-based TPC extraction processes were assessed via first-order and second-order kinetic models, with an associated investigation of the kinetic parameters and rate constants, saturation concentrations, and activation energies. The second-order kinetic model was sufficient to describe the extraction mechanism of TPC from AP. This study provides an understanding of the mass transfer mechanism involved in the polyphenolic compound extraction process, thus facilitating future large-scale design, optimization, and process control to valorize pomace waste.

Extraction of total antioxidants from Azadirachta indica (neem) using three phase partitioning and its process intensification using ultrasound

The majority of the naturally occurring antioxidants are obtained from plant sources. The antioxidant activity is mostly exhibited by polyphenols present in the plant cells. Azadirachta Indica (Neem) leaves are renowned for their medicinal applications due to their anti-inflammatory, antimalarial, antifungal, antibacterial, antiviral, antioxidant, and anticarcinogenic properties. This work aims to optimize the extraction of Azadirachta Indica (Neem) leaf antioxidants using three-phase partitioning (TPP). The optimized conditions are operating time 15 minutes, slurry ratio 1:30 (g/mL), salt concentration 30% (w/v), aqueous to solvent ratio 1:1.5 (v/v), and stirring speed 400 rpm that infer 74.66% extraction yield. Additionally, ultrasonic pretreatment was also employed to increase the extraction yield up to 86.61%. Sonication pretreatment for 4 min operated at 30 W power, and 75% duty cycle was observed to offer maximum antioxidant extraction about 3.3 mg/g.

Development of a Green Methodology for Simultaneous Extraction of Polyphenols and Pigments from Red Winemaking Solid Wastes (Pomace) Using a Novel Glycerol-Sodium Benzoate Deep Eutectic Solvent and Ultrasonication Pretreatment

In this examination, two glycerol-based deep eutectic solvents (DESs) were tested for their efficiency in the recovery of antioxidant polyphenols and anthocyanin pigments from red grape pomace (RGP). The two DESs synthesized had sodium acetate and sodium benzoate as hydrogen bond acceptors, to test the role of the hydrogen bond acceptor polarity on the extraction performance. Furthermore, the process was enhanced by an ultrasonication pretreatment stage. After initial testing with respect to water content, ultrasonication power and liquid-to-solid ratio, the DES composed of glycerol and sodium benzoate (GL-SBz) was shown to be significantly more efficient than the one made of glycerol and sodium acetate (GL-SAc). Further optimization of the extraction with regard to time and temperature demonstrated GL-SBz to be a highly effective solvent for the production of RGP extracts rich in polyphenols including gallic acid, catechin and quercetin, and pigments including malvidin 3-O-glucoside p-coumarate and malvidin 3-O-glucoside. The extracts produced also had significantly higher antiradical activity and reducing power compared to those generated with aqueous ethanol or water. From this study, evidence emerged regarding the role of the hydrogen bond acceptor nature in the extraction efficiency of polyphenols. The process developed is proposed as a green, high-performing methodology for the production of RGP extracts with enhanced polyphenolic content and antioxidant activity.

Techniques and modeling of polyphenol extraction from food: a review

There is a growing demand for vegetal food having health benefits such as improving the immune system. This is due in particular to the presence of polyphenols present in small amounts in many fruits, vegetables and functional foods. Extracting polyphenols is challenging because extraction techniques should not alter food quality. Here, we review technologies for extracting polyphenolic compounds from foods. Conventional techniques include percolation, decoction, heat reflux extraction, Soxhlet extraction and maceration, whereas advanced techniques are ultrasound-assisted extraction, microwave-assisted extraction, supercritical fluid extraction, high-voltage electric discharge, pulse electric field extraction and enzyme-assisted extraction. Advanced techniques are 32-36% more efficient with approximately 15 times less energy consumption and producing higher-quality extracts. Membrane separation and encapsulation appear promising to improve the sustainability of separating polyphenolic compounds. We present kinetic models and their influence on process parameters such as solvent type, solid and solvent ratio, temperature and particle size.

Antidiabetic potential evaluation of aqueous extract of waste Syzygium cumini seed kernel's by in vitro α-amylase and α-glucosidase inhibition

Syzygium cumini, owing to higher bioactive constituents, its parts principally kernels are used for the antidiabetic purpose since the olden days. The current manuscript illustrated batch extraction of phenolic compounds from S. cumini using a stirred extractor. The yields 0.61 mg/g, 35.9 mg/g, 79.89 mg GAE/g, and 7.29 mg CE/g of catechin, gallic acid, TPC and TFC, respectively, were obtained in 105 min. at 1:20 SCKP to water, 50 ± 2 °C temperature, 4 pH, at 250 rpm and 106 µm particle size of SCKP. In vitro evaluation of the antioxidant and antidiabetic potential of the obtained aqueous extract was carried out by DPPH, α-amylase, and α-glucosidase inhibitory assays. The IC₅₀ values of SCKP aqueous extract obtained were 12.97, 9.03, and 7.13 µg/mL for DPPH scavenging, inhibition of α-amylase, and α-glucosidase, respectively. The cost required to extract 1 kg of catechin, gallic acid, TPC, and TFC was Rs 6691.6, 113.7, 51.1, and 559.93/-, respectively. Stirred batch extraction technique manifests traditional but simple, ecofriendly, and efficient compared to other traditional techniques. The output of this research bestows support to utilize the SCKP stirred batch extract as a promising source of antioxidant and antidiabetic compounds in ayurvedic formulations.

Ultrasound processing of coffee silver skin, brewer's spent grain and potato peel wastes for phenolic compounds and amino acids: a comparative study

Awareness towards utilizing food-processing by-products are increasing in health as well as environmental purview. Coffee silver skin (CSS), potato peel (PP) and brewer's spent grain (BSG) are voluminous by-products in their respective processing industries. The present study compared these three by-products for their prospective utilization in producing polyphenols-rich aqueous extracts by using ultrasound-assisted extractions (UAE). A probe-type sonicator was used for ultrasound treatments. The total phenolic contents in the extracts were assessed by Folin-Ciocalteu assay, while the phenolic profiles of the extract was characterized by LC-Q-TOF mass spectrometry. The microstructure of the samples after UAE was evaluated by scanning electron microscopy (SEM). Ultrasound treatment enhanced the rate of extraction and recovered 2.79, 2.12 and 0.66 mg gallic acid equivalents/g of TPC from CSS, PP and BSG, respectively in 30 min, which correspond to recoveries of 97.6%, 84.5% and 84.6%, respectively, compared to conventional solid-liquid extractions carried out for 24 h. The extraction yield was dependent on the particle size of the raw materials and the highest yield was obtained from the materials with 100-250 µm particle size. The SEM imaging revealed that ultrasound treatment caused prominent tissue damage. Extracts contained mainly hydroxycinnamic acid derivatives of phenolic acids. PP and CSS had the highest amounts of umami free amino acids (0.13 mg/g in each), while BSG contained the highest amount of essential amino acids (92 mg/g). The present work shows that CSS, PP and BSG are good sources of polyphenols and UAE can be employed to enhance the extraction efficiency as means of a green approach.

Hydroxypropyl-β-Cyclodextrin as a Green Co-Solvent in the Aqueous Extraction of Polyphenols from Waste Orange Peels

There is, to-date, an expanding interest concerning the use of cyclodextrins as green food-grade co-solvents in the aqueous extraction of polyphenols, however, data regarding polyphenol extraction from waste orange peels (WOP) are lacking. On this ground, hydroxypropyl β-cyclodextrin (HP-β-CD), a highly water-soluble cyclodextrin, was used to develop a simple and straightforward methodology for the effective recovery of WOP polyphenols. Process optimization by response surface showed that maximum total polyphenol recovery (26.30 ± 1.49 mg gallic acid equivalents g−1 dry mass) could be accomplished with 15 mM HP-β-CD at 40 °C. On the other hand, integration of ultrasonication pretreatment was found unsuitable, as it resulted in reduced polyphenol yield. Examination of solvent acidity indicated that polyphenol extraction may be enhanced at pH 4, but the difference was non-significant (p > 0.05) compared to yields attained at pH 2, 3, and 5. Extraction of WOP polyphenols with HP-β-CD was shown to provide significantly higher hesperidin yield compared to 60% (v/v) aqueous ethanol, which suggested selectivity of HP-β-CD toward this polyphenolic metabolite.

Batch Stirred-Tank Green Extraction of Salvia fruticosa Mill. Polyphenols Using Newly Designed Citrate-Based Deep Eutectic Solvents and Ultrasonication Pretreatment

A series of citrate salts were tested as hydrogen bond acceptors to synthesize deep eutectic solvents (DES) based on lactic acid and glycerol, used as hydrogen bond donors. The DES produced were then screened to identify the highest performing system for the effective extraction of polyphenolic phytochemicals from the medicinal plant Salvia fruticosa Mill. (Greek sage). The most efficacious DES was the one composed of lactic acid and sodium citrate dibasic, at a molar ratio of 15:1 (LA-SCDB15). Furthermore, for the first time there has been evidence concerning DES pH and extraction efficiency. Using this solvent, a batch, stirred-tank extraction process was developed, by employing ultrasonication pretreatment and response surface methodology. The optimal settings determined were stirring speed 900 rpm, proportion of DES/water 77% (w/v), and ultrasonication pretreatment time 15 min. By adjusting these optimal settings, the predicted maximum total polyphenol yield was calculated to be 79.93 ± 1.92 mg gallic acid equivalents g−1 dry mass. The examination of temperature effects demonstrated that the batch, stirred-tank extraction stage was very energy-efficient, with a barrier of 7.64 kJ mol−1. Comparison of the extraction of Salvia fruticosa polyphenols with other green processes previously developed, illustrated the high extraction capacity of LA-SCDB15. The major polyphenols identified in the extracts produced under optimized settings were chlorogenic acid, luteolin 7-O-glucuronide and rosmarinic acid.

Development of a Low-Temperature and High-Performance Green Extraction Process for the Recovery of Polyphenolic Phytochemicals from Waste Potato Peels Using Hydroxypropyl β-Cyclodextrin

Potato peels (PP) are a major agri-food side-stream originating from potato processing, but to date, their green valorization as a bioresource of antioxidant polyphenols is limited to extraction processes involving mainly water/ethanol-based solvents, whereas other eco-friendly methodologies are scarce. This study aimed at developing a simple, straight-forward and green extraction methodology to effectively recover PP polyphenols, using hydroxypropyl β-cyclodextrin (HP-β-CD). After an initial assay to identify the optimal HP-β-CD concentration that would provide increased extraction yield, optimization based on response surface methodology enabled maximization of the extraction performance, providing a total polyphenol yield of 17.27 ± 0.93 mg chlorogenic acid equivalent g−1 dry mass, at 30 °C. Testing of temperatures higher than 30 °C and up to 80 °C did not favor higher yields. The extracts obtained with HP-β-CD were slightly richer in polyphenols than extracts prepared with conventional solvents, such as aqueous ethanol and methanol, displaying similar antioxidant characteristics. The major polyphenols that could be identified in the extracts were neochlorogenic, chlorogenic, caffeic and ferulic acids. The outcome of this study demonstrated that HP-β-CD may be used as a highly effective green means of recovering PP polyphenols, at near-ambient temperature.

Green Valorization of Olive Leaves to Produce Polyphenol-Enriched Extracts Using an Environmentally Benign Deep Eutectic Solvent

Olive leaves (OLL) are considered to be a highly appreciated bioresource of bioactive polyphenolic phytochemicals, embracing several different structures. However, extraction processes based on deep eutectic solvents (DES) are very limited despite the wide range of techniques developed for the efficient recovery of polyphenols. This study had as objective the development of a simple, green, high-performance extraction methodology for OLL polyphenols, using a recently reported effective DES, composed of L-lactic acid and glycine. Initially, a screening was performed to select the most appropriate L-lactic/glycine molar ratio and process optimization was then carried out with response surface methodology. The optimized process variable values were DES/water (78% w/v), liquid-to-solid ratio of 36 mL g−1, and stirring speed of 500 rounds per minute, and the total polyphenol yield amounted to 97.53 ± 3.54 mg gallic acid equivalents per g dry matter. Extraction with DES at 80 °C did not significantly increase the total polyphenol yield, but it did enhance the total flavonoid yield and antioxidant activity. High-performance liquid chromatography analyses revealed that extraction with the DES resulted in extended oleuropein hydrolysis, to the favor of hydroxytyrosol formation. This finding might have a prospect in using properly tuned DES for polyphenol modification with improved bioactivities.

A Green Extraction Process for Polyphenols from Elderberry (Sambucus nigra) Flowers Using Deep Eutectic Solvent and Ultrasound-Assisted Pretreatment

Sambucus nigra flowers, known as elderberry flowers (EBF), are a plant tissue rich in polyphenolic phytochemicals with important bioactivities. However, there are few studies dealing with the production of polyphenol-containing EBF extracts. The objective of the investigation presented herein was the development of a high-performance green extraction methodology, to generate EBF extracts enriched in polyphenolic substances, using an efficient deep eutectic solvent, combined with ultrasonication pretreatment. The DES was composed of L-lactic acid (hydrogen bond donor—HBD) and glycine (hydrogen bond acceptor—HBA) and, after an initial screening to properly regulate HBD/HBA ratio, the extraction was optimized by deploying response surface methodology. Under the optimized conditions, which were DES/water (85% w/v), liquid-to-solid ratio 60 mL g⁻¹, and stirring speed 200 rounds per minute, the extraction yield in total polyphenols amounted to 121.24 ± 8.77 mg gallic acid equivalents per g dry matter. The integration of ultrasonication prior to the batch stirred-tank extraction boosted polyphenol recovery of up to 174.73 ± 2.62 mg gallic acid equivalents per g dry matter. Liquid chromatography–mass spectrometry analysis showed that the richest EBF extract obtained was dominated by rutin, a di-p-coumaroylquic acid and chlorogenic acid.

The Effect of Ultrasonication Pretreatment on the Production of Polyphenol-Enriched Extracts from Moringa oleifera L. (Drumstick Tree) Using a Novel Bio-Based Deep Eutectic Solvent

Moringa oleifera L. leaves are a plant tissue particularly rich in polyphenolic phytochemicals with significant bioactivities, and there has been significant recent interest for the production of extracts enriched in these substances. The current investigation is aimed at establishing a green extraction process, using a novel eco-friendly natural deep eutectic solvent, composed of glycerol and nicotinamide. Furthermore, sample ultrasonication prior to batch stirred-tank extraction was studied to examine its usefulness as a pretreatment step. Optimization of the extraction process through response surface methodology showed that the maximum total polyphenol yield (82.87 ± 4.28 mg gallic acid equivalents g−1 dry mass) could be achieved after a 30 min ultrasonication pretreatment, but the difference with the yield obtained from the non-pretreated sample was statistically non-significant (p < 0.05). Extraction kinetics revealed that the activation energy for the ultrasonication-pretreated samples was more energy-demanding, a fact attributed to phenomena pertaining to washing of the readily extracted polyphenols during pretreatment. Liquid-chromatography-diode array-mass spectrometry showed that ultrasonication pretreatment may have a limited positive effect on polyphenol extractability, but the overall polyphenolic profile was identical for the ultrasonication-pretreated and non-pretreated samples.

Saffron Processing Wastes as a Bioresource of High-Value Added Compounds: Development of a Green Extraction Process for Polyphenol Recovery Using a Natural Deep Eutectic Solvent

The current investigation was undertaken to examine saffron processing waste (SPW) as a bioresource, which could be valorized to produce extracts rich in antioxidant polyphenols, using a green, natural deep eutectic solvent (DES). Initially, there was an appraisal of the molar ratio of hydrogen bond donor/hydrogen bond acceptor in order to come up with the most efficient DES composed of L-lactic acid/glycine (5:1). The following step was the optimization of the extraction process using response surface methodology. The optimal conditions thus determined were a DES concentration of 55% (w/v), a liquid-to-solid ratio of 60 mL g⁻¹, and a stirring speed of 800 rounds per minute. Under these conditions, the extraction yield in total polyphenols achieved was 132.43 ± 10.63 mg gallic acid equivalents per g of dry mass. The temperature assay performed within a range of 23 to 80 °C, suggested that extracts displayed maximum yield and antioxidant activity at 50–60 °C. Liquid chromatography-mass spectrometry analysis of the SPW extract obtained under optimal conditions showed that the predominant flavonol was kaempferol 3-O-sophoroside and the major anthocyanin delphinidin 3,5-di-O-glucoside. The results indicated that SPW extraction with the DES used is a green and efficient methodology and may afford extracts rich flavonols and anthocyanins, which are considered to be powerful antioxidants.

Comparative assessment of solvents and lignocellulolytic enzymes affiliated extraction of polyphenols from the various lignocellulosic agro-residues: identification and their antioxidant properties

The present investigation was aimed to utilize lignocellulosic agro-residues and compare the extraction of polyphenols utilizing lignocellulolytic enzymes secreted by Sphingobacterium sp. ksn and with that of the solvents (ethanol, methanol) affiliated methods. The maximum amount of polyphenols, flavonoids and tannins were 94.29, 11.36, and 79.21 g 100 g^-1 respectively, found in the extracts obtained by enzymes affiliated extraction of coffee cherry husk (CCH). The phenolics namely, gallic acid, caffeic acid, coumaric acid, 1-hydroxybenzoic acid, 2,5-dihydroxybenzoic acid, p-hydroxybenzaldehyde were commonly found whereas syringic acid, quercetin, kaempferol, and epicatechin were hardly found in the extracts of agro-residues. The extracts of CCH shown maximum antioxidant properties for DPPH, ABTS, and FRAP. The present study reports that the affiliation of enzymes for the extraction of polyphenols from agro-residues is more efficient than that of the solvents affiliation and CCH as the good source of polyphenols.

Polyphenol Extraction from Humulus lupulus (Hop) Using a Neoteric Glycerol/L-Alanine Deep Eutectic Solvent: Optimisation, Kinetics and the Effect of Ultrasound-Assisted Pretreatment

The investigation presented herein had as its scope the development of an integrated process for the efficient extraction of polyphenols from hop. For this purpose, a novel, natural deep eutectic solvent (DES) was synthesised, composed of glycerol and L-alanine, and the process was optimised by deploying a response surface methodology based on a Box–Behnken design. The variables considered were the DES/water proportion, the liquid-to-solid ratio and the stirring speed. Under the optimised conditions, the yield in total polyphenols achieved was 118.97 ± 8.27 mg gallic acid equivalents per g of dry mass. Ultrasonication, incorporated into the process as a pretreatment step, was shown to significantly change the kinetic pattern of polyphenol extraction and contributed to attaining higher yields only at 80 °C, whereas at lower temperatures a supressing effect was observed. Furthermore, increasing temperature was negatively correlated with the second-order extraction rates, evidencing a slow-down of the extraction rate at elevated temperatures.