Intervention Technologies for Ensuring Microbiological Safety of Meat: Current and Future Trends

Cholesterol oxides and quality attributes of NaCl-substituted low-fat chicken sausages prepared with different antioxidants

This trial investigated how different salts and antioxidants influence cholesterol oxides, microbial profiles, physicochemical properties and organoleptic characteristics of low-fat chicken sausages (CS). CS were formulated with either 2 % NaCl, CS-1; 2 % NaCl +0.02 % butylated hydroxyanisole (BHA), CS-2; 1 % NaCl + 1 % KCl + 0.25 % onionskin extract (OSE), CS-3; 1 % NaCl + 1 % KCl + 0.5 % OSE, CS-4; 1 % NaCl + 1 % K3C6H5O7 + 0.25 % OSE, CS-5 or 1 % NaCl + 1 % K3C6H5O7 + 0.5 % OSE, CS-6, cooked, and refrigerated for 45 d. The Na content in CS-1 and CS-2 (1185 ± 21 mg/100 g) was greater than that in the other CS (640 ± 18 mg/100 g). The 19-hydroxy cholesterol, 7α-hydroxycholesterol, 25-hydroxycholesterol, 5,6β-epoxycholesterol, 7β-hydroxycholesterol and carbonyl content were greater in CS-1 than in the other sausages. The OSE-treated CS group had lower levels of 7β-hydroxycholesterol and 7α-hydroxycholesterol than did the CS-2 group. CS-1 and CS-2 were lighter than the other CS. Malondialdehyde, pH, chemical composition, textural profile, microbial counts, cook loss and sensorial quality were unaffected by additives. The partial replacement of NaCl with KCl and K3C6H5O7, along with the addition of BHA and OSE, decreased the Na and cholesterol oxide contents without affecting the organoleptic qualities of low-fat CS.

Salmonella Inactivation Model by UV-C Light Treatment in Chicken Breast

This study aims to evaluate the effectiveness of inactivating Salmonella enteritidis in fresh chicken breast by irradiation using a combination of short-wave UV (0, 3, 6, 9, 12, and 15 J/cm2) and a natural antimicrobial such as caffeine (0, 5, 10, 15, and 20 nM/g) at 14 °C as alternative proposals to conventional techniques to reduce pathogens in food. The effect of temperature was studied in an initial phase (2 to 22 °C). The most suitable models were double Weibull in 60% of cases, with an adjustment of R2 0.9903-0.9553, and Weibull + tail in 46.67%, with an adjustment of R2 of 0.9998-0.9981. The most effective combination for the reduction in Salmonella was 12 J/cm2 of UV light and 15 nM/g of caffeine, with a reduction of 6 CFU/g and an inactivation rate of 0.72. The synergistic effect was observed by increasing caffeine and UV light. Furthermore, the physico-chemical characteristics of the food matrix were not affected by the combination of both technologies. Therefore, these results suggest that this combination can be used in the food industry to effectively inactivate Salmonella enteritidis without deteriorating product quality.

A review of emerging applications of ultrasonication in Comparison with non-ionizing technologies for meat decontamination

Meat is highly susceptible to contamination with harmful microorganisms throughout the production, processing, and storage chain, posing a significant public health risk. Traditional decontamination methods like chemical sanitizers and heat treatments often compromise meat quality, generate harmful residues, and require high energy inputs. This necessitates the exploration of alternative non-ionizing technologies for ensuring meat safety and quality. This review provides a comprehensive analysis of the latest advancements, limitations, and future prospects of non-ionizing technologies for meat decontamination, with a specific focus on ultrasonication. It further investigates the comparative advantages and disadvantages of ultrasonication against other prominent non-ionizing technologies such as microwaves, ultraviolet (UV) light, and pulsed light. Additionally, it explores the potential of integrating these technologies within a multi-hurdle strategy to achieve enhanced decontamination across the meat surface and within the matrix. While non-ionizing technologies have demonstrated promising results in reducing microbial populations while preserving meat quality attributes, challenges remain. These include optimizing processing parameters, addressing regulatory considerations, and ensuring cost-effectiveness for large-scale adoption. Combining these technologies with other methods like antimicrobial agents, packaging, and hurdle technology holds promise for further enhancing pathogen elimination while safeguarding meat quality.

Research Progress on Bacteria-Reducing Pretreatment Technology of Meat

Reducing the initial bacteria number from meat and extending its shelf life are crucial factors for ensuring product safety and enhancing economic benefits for enterprises. Currently, controlling enzyme activity and the microbial survival environment is a common approach to reducing the rate of deterioration in raw meat materials, thereby achieving the goal of bacteria reduction during storage and preservation. This review summarizes the commonly used technologies for reducing bacteria in meat, including slightly acidic electrolyzed water (SAEW), organic acids, ozone (O3), ultrasound, irradiation, ultraviolet (UV), cold plasma, high-pressure processing (HPP), and biological bacterial reduction agents. This review outlines the mechanisms and main features of these technologies for reducing bacteria in meat processing. Additionally, it discusses the status of these technologies in meat storage and preservation applications while analyzing associated problems and proposing solutions. The aim is to provide valuable references for research on meat preservation technology.

Isolation, characterization, and application of bacteriophage on Vibrio parahaemolyticus biofilm to control seafood contamination

OBJECTIVE

This study intended to isolate a Vibrio-particular phage from the natural environment, analyse its characteristics and genome sequence, and investigate its reduction effect on V. parahaemolyticus biofilm as a biocontrol agent in squid and mackerel.

METHODS

Among 21 phages, phage CAU_VPP01, isolated from beach mud, was chosen for further experiments based on host range and EOP tests. When examining the reduction effect of phage CAU_VPP01 against Vibrio parahaemolyticus biofilms on surfaces (stainless steel [SS] and polyethylene terephthalate [PET]) and food surfaces (squid and mackerel).

RESULTS

The phage showed the most excellent reduction effect at a multiplicity-of-infection (MOI) 10. Three-dimensional images acquired with confocal laser scanning microscopy (CLSM) analysis were quantified using COMSTAT, which showed that biomass, average thickness, and roughness coefficient decreased when treated with the phage. Colour and texture analysis confirmed that the quality of squid and mackerel was maintained after the phage treatment. Finally, a comparison of gene expression levels determined by qRT-PCR analysis showed that the phage treatment induced a decrease in the gene expression of flaA, vp0962, andluxS, as examples.

CONCLUSION

This study indicated that Vibrio-specific phage CAU_VPP01 effectively controlled V. parahaemolyticus biofilms under various conditions and confirmed that the isolated phage could possibly be used as an effective biocontrol weapon in the seafood manufacturing industry.

Photodynamic Inactivation of Foodborne Bacteria: Screening of 32 Potential Photosensitizers

The development of novel antimicrobial technologies for the food industry represents an important strategy to improve food safety. Antimicrobial photodynamic disinfection (aPDD) is a method that can inactivate microbes without the use of harsh chemicals. aPDD involves the administration of a non-toxic, light-sensitive substance, known as a photosensitizer, followed by exposure to visible light at a specific wavelength. The objective of this study was to screen the antimicrobial photodynamic efficacy of 32 food-safe pigments tested as candidate photosensitizers (PSs) against pathogenic and food-spoilage bacterial suspensions as well as biofilms grown on relevant food contact surfaces. This screening evaluated the minimum bactericidal concentration (MBC), minimum biofilm eradication concentration (MBEC), and colony forming unit (CFU) reduction against Salmonella enterica, methicillin-resistant Staphylococcus aureus (MRSA), Pseudomonas fragi, and Brochothrix thermosphacta. Based on multiple characteristics, including solubility and the ability to reduce the biofilms by at least 3 log10 CFU/sample, 4 out of the 32 PSs were selected for further optimization against S. enterica and MRSA, including sunset yellow, curcumin, riboflavin-5'-phosphate (R-5-P), and erythrosin B. Optimized factors included the PS concentration, irradiance, and time of light exposure. Finally, 0.1% w/v R-5-P, irradiated with a 445 nm LED at 55.5 J/cm2, yielded a "max kill" (upwards of 3 to 7 log10 CFU/sample) against S. enterica and MRSA biofilms grown on metallic food contact surfaces, proving its potential for industrial applications. Overall, the aPDD method shows substantial promise as an alternative to existing disinfection technologies used in the food processing industry.

Trans-cinnamaldehyde nanoemulsion wash inactivates Salmonella Enteritidis on shelled eggs without affecting egg color

Salmonella Enteritidis is a major foodborne pathogen that causes enteric illnesses in humans, primarily through the consumption of contaminated poultry meat and eggs. Despite implementation of traditional disinfection approaches to reduce S. Enteritidis contamination, egg-borne outbreaks continue to occur, raising public health concerns and adversely affecting the popularity and profitability for the poultry industry. Generally Recognized as Safe (GRAS) status phytochemicals such as Trans-cinnamaldehyde (TC) have previously shown to exhibit anti-Salmonella efficacy, however, the low solubility of TC is a major hurdle in its adoption as an egg wash treatment. Therefore, the present study investigated the efficacy of Trans-cinnamaldehyde nanoemulsions (TCNE) prepared with emulsifiers Tween 80 (Tw.80) or Gum Arabic and lecithin (GAL) as dip treatments, at 34°C, for reducing S. Enteritidis on shelled eggs in presence or absence of 5% chicken litter. In addition, the efficacy of TCNE dip treatments in reducing trans-shell migration of S. Enteritidis across shell barrier was investigated. The effect of wash treatments on shell color were evaluated on d 0, 1, 7, and 14 of refrigerated storage. TCNE-Tw.80 or GAL treatments (0.06, 0.12, 0.24, 0.48%) were effective in inactivating S. Enteritidis by at least 2 to 2.5 log cfu/egg as early as 1 min of washing time (P < 0.05). In presence of organic matter, nanoemulsions (0.48%) reduced S. Enteritidis counts by ∼ 2 to 2.5 log cfu/egg as early as 1 min, (P < 0.05). Nanoemulsion wash also inhibited trans-shell migration of S. Enteritidis, as compared to control (P < 0.05). The nanoemulsion wash treatments did not affect shell color (P > 0.05). Results suggest that TCNE could potentially be used as an antimicrobial wash to reduce S. Enteritidis on shelled eggs, although further studies investigating the effect of TCNE wash treatments on organoleptic properties of eggs are necessary.

Application of the lytic bacteriophage Rostam to control Salmonella enteritidis in eggs

Foodborne Salmonella enteritidis infections place human health at risk, driven by regular outbreaks and individual cases by different contaminated food materials. This study was conducted to characterize and employ a single bacteriophage as a potential biocontrol agent. Phage Rostam was isolated, characterized and then applied as biocontrol agent against S. enteritidis in liquid whole eggs and eggshell. Rostam is a novel myovirus belonging to the Rosemountvirus genus and active against Escherichia coli and Salmonella spp. Rostam is stable in a pH range from 4 to 10, a salt concentration of 1-9 %, whereas UV radiation gradually reduces phage stability, and its 53 kb genome sequence indicates this phage does not contain known toxins or lysogeny-associated genes. Its latent period is short with a burst size of 151 PFU/cell, under standard growth conditions. Killing curves indicate that at higher multiplicities of infection (MOI), the reduction in S. enteritidis count is more pronounced. Phage Rostam (MOI 10,000) reduces S. enteritidis growth to below the detection limit at 4 °C in both liquid whole eggs and on the eggshell within 24 h. Due to its high lytic activity and stability in relevant conditions, Rostam has the potential to be an efficient biopreservative for egg and egg products.

A potential spoilage bacteria inactivation approach on frozen fish

•

US&HVEF technology revealed an inactivation effect on S. putrefaciens.

•

US&HVEF technology minimized the thawing damage to frozen fish.

•

US&HVEF thawing achieved better quality maintenance of frozen aquatic products.

Frozen products are more susceptible to microbial spoilage during thawing. Therefore, the development of a thawing technology with effective bacteriostasis is still urgent in food science. In this study, red sea bream was used as the research object, S. putrefaciens was incubated on the surface of fish fillets, and ultrasound plus high voltage electric field (US&HVEF) was performed to investigate the antibacterial activity. On this basis, the effect of US&HVEF thawing on the quality characteristics of fillets was further studied. The results indicated that US&HVEF showed a better antibacterial performance toward S. putrefaciens, with the lethality of 96.73%. Furthermore, US&HVEF could minimize thawing loss, preserve fillets texture, stabilize the secondary and tertiary conformation of myofibrillar protein (MFP), and inhibit the MFP aggregation and oxidation. Accordingly, this study shows that food safety also involves spoilage bacteria prevention except for quality and proves that US&HVEF technology has great potential in food thawing.

A survey of food-borne and antimicrobial resistance-harbouring bacteria in meat by-products from knackeries and associated equipment and kennels

Background

In Ireland, meat by-products (MBP) harvested at knackeries from farmed animals that have not died of an infectious or systemic disease are legally permitted to be fed to dogs in kennels and packs of hounds. There is limited information available on the risks of spreading foodborne bacteria or antimicrobial resistant (AMR) determinants to dogs, their handlers or the associated environment. The aim of this study was to investigate the distribution of Salmonella serovars, Listeria monocytogenes, Campylobacter species, enterococci, their associated AMR determinants and the level of Escherichia coli in samples of MBP from knackeries and associated equipment and kennels. For this purpose, 313 fresh and 208 frozen MBP samples from 22 knackeries, 16 swabs of mincing equipment from two of the knackeries and 138 swabs from kennels adjacent to seven of the knackeries were collected and processed over a 12-month period.

Results

From the 521 MBP samples analysed, a total of 77 Salmonella (14.8%), 101 L. monocytogenes (19.4%), 12 Campylobacter (2.3%), 271 Enterococcus faecalis (52.0%) and 127 Enterococcus faecium (24.4%) strains were recovered. The 154 analysed environmental samples from kennels and mincing equipment yielded 194 isolates (3 Salmonella, 85 E. coli, 76 E. faecalis and 30 E. faecium.). E. coli was quantifiable in 423 of the 521 MBP samples with log counts per gram ranging between 1 and 6. AMR characterisation of 168 E. coli, enterococci and Salmonella isolates from MBP and environmental samples showed high levels of AMR including multi-drug resistance (MDR) with 63.6%, 9.1%, 29% and 45.8% of E. coli, Salmonella, E. faecalis and E. faecium isolates, respectively showing resistance to three or more antimicrobials (MDR)

Conclusions

The findings of this survey confirm that MBP from fallen animals contain high levels of zoonotic and AMR-harbouring bacteria that pose a risk of transmission to dogs, their handlers, and the environment.

Novel Techniques for Microbiological Safety in Meat and Fish Industries

The consumer tendency towards convenient, minimally processed meat items has placed extreme pressure on processors to certify the safety of meat or meat products without compromising the quality of product and to meet consumer’s demand. This has prompted difficulties in creating and carrying out novel processing advancements, as the utilization of more up-to-date innovations may influence customer decisions and assessments of meat and meat products. Novel advances received by the fish and meat industries for controlling food-borne microbes of huge potential general wellbeing concern, gaps in the advancements, and the requirement for improving technologies that have been demonstrated to be effective in research settings or at the pilot scale shall be discussed. Novel preparing advancements in the meat industries warrant microbiological approval before being named as industrially suitable alternatives and authorizing infra-structural changes. This miniature review presents the novel techniques for the microbiological safety of meat products, including both thermal and non-thermal methods. These technologies are being successfully implemented and rationalized in subsisting processing surroundings.

Physical, Mechanical, and Water Vapor Barrier Properties of Starch/Cellulose Nanofiber/Thymol Bionanocomposite Films

The application of starch films, such as food packaging materials, has been restricted due to poor mechanical and barrier properties. However, the addition of a reinforcing agent, cellulose nanofibers (CNF) and also thymol, into the films, may improve the properties of films. This work investigates the effects of incorporating different concentrations of thymol (3, 5, 7, and 10 wt.%) on physical, mechanical, water vapor barrier, and antibacterial properties of corn starch films, containing 1.5 wt.% CNF produced using the solvent casting method. The addition of thymol does not significantly affect the color and opacity of the films. It is found that the tensile strength and Young’s modulus of the films decreases from 10.6 to 6.3 MPa and from 436.9 to 209.8 MPa, respectively, and the elongation at break increased from 110.6% to 123.5% with the incorporation of 10 wt.% thymol into the films. Furthermore, the addition of thymol at higher concentrations (7 and 10 wt.%) improved the water vapor barrier of the films by approximately 60.0%, from 4.98 × 10^—9 to 2.01 × 10^—9 g/d.m.Pa. Starch/CNF/thymol bionanocomposite films are also found to exhibit antibacterial activity against Escherichia coli. In conclusion, the produced starch/CNF/thymol bionanocomposite films have the potential to be used as antibacterial food packaging materials.

The Use of Organic Acids (Lactic and Acetic) as a Microbial Decontaminant during the Slaughter of Meat Animal Species: A Review

Wild ungulate species provide a much-needed protein source to many communities in developed and developing countries. Frequently, these game meat animals are slaughtered, and the meat is unknowingly contaminated by microorganisms and released to the unsuspecting public. This review investigates the global usage of organic acids (lactic and acetic acids) as microbial decontamination strategies during slaughter. The results show that there is a more open-minded approach to adopting possible decontamination plans as a tool to improve meat safety during slaughter. Developed countries continue to adopt these strategies, while developing countries are lagging behind. While decontamination of carcasses can lead to a reduction of microbial load on these carcasses, this strategy must not be seen as a replacement of hygiene management during the animals’ slaughter.

Effects of Green Tea Powder, Pomegranate Peel Powder, Epicatechin and Punicalagin Additives on Antimicrobial, Antioxidant Potential and Quality Properties of Raw Meatballs

Alternative technologies, which have been developed in order to meet the consumers’ demand for nourishing and healthy meat and meat products, are followed by the food industry. In the present study, it was determined, using the HPLC method, that green tea contains a high level of epicatechin (EP) under optimal conditions and that pomegranate peel contains a high level of punicalagin (PN). Green tea, pomegranate peel, EP and PN were added to meatballs at different concentrations in eight groups. The antioxidant capacities of extracts were measured. The antimicrobial activity was examined for 72 h using three different food pathogens. The highest level of antimicrobial activity was achieved in the 1% punicalagin group, whereas the minimum inhibition concentration (L. monocytogenes, S. typhimurium) was found to be 1.87 mg/mL. A statistically significant decrease was found in FFA, POV and TBARS levels of meatballs on different days of storage (p < 0.05). When compared to the control group, the bioactive compounds preserved the microbiological and chemical properties of meatballs during storage at +4 °C (14 days). It was concluded that the extracts with high EP and PN concentrations can be used as bio-preservative agents for meat and meat products.

Isolation and Characterization of a Novel Salmonella Phage vB_SalP_TR2

Salmonella is a widely distributed foodborne pathogen. The use of Salmonella phages as biocontrol agents has recently gained significant interest. Because the Salmonella genus has high diversity, efforts are necessary to identify lytic Salmonella phages focusing on different serovars. Here, five Salmonella phages were isolated from soil samples, and vB_SalP_TR2 was selected as a novel phage with high lytic potential against the host Salmonella serovar Albany, as well as other tested serovars, including Corvallis, Newport, Kottbus, and Istanbul. Morphological analyses demonstrated that phage vB_SalP_TR2 belongs to the Podoviridae family, with an icosahedral head (62 ± 0.5 nm in diameter and 60 ± 1 nm in length) and a short tail (35 ± 1 nm in length). The latent period and burst size of phage vB_SalP_TR2 was 15 min and 211 PFU/cell, respectively. It contained a linear dsDNA of 71,453 bp, and G + C content was 40.64%. Among 96 putative open reading frames detected, only 35 gene products were found in database searches, with no virulence or antibiotic resistance genes being identified. As a biological control agent, phage vB_SalP_TR2 exhibited a high temperature and pH tolerance. In vitro, it lysed most S. Albany after 24 h at 37°C with multiplicities of infection of 0.0001, 0.001, 0.01, 0.1, 1, 10, and 100. In food matrices (milk and chicken meat), treatment with phage vB_SalP_TR2 also reduced the number of S. Albany compared with that in controls. These findings highlighted phage vB_SalP_TR2 as a potential antibacterial agent for the control of Salmonella in food samples.

Microbial biopreservatives for controlling the spoilage of beef and lamb meat: their application and effects on meat quality

Biopreservation is a recognized natural method for controlling the growth of undesirable bacteria on fresh meat. It offers the potential to inhibit spoilage bacteria and extend meat shelf-life, but this aspect has been much less studied compared to using the approach to target pathogenic bacteria. This review provides comprehensive information on the application of biopreservatives of microbial origin, mainly bacteriocins and protective cultures, in relation to bacterial spoilage of beef and lamb meat. The sensory effect of these biopreservatives, an aspect that often receives less attention in microbiological studies, is also reviewed. Microbial biopreservatives were found to be able to retard the growth of the major meat spoilage bacteria, Brochothrix thermosphacta, Pseudomonas spp., and Enterobacteriaceae. Their addition did not have any discernible negative impact on the sensory properties of meat, whether assessed by human sensory panels or instrumental and chemical analyses. Although results are promising, the concept of biopreservation for controlling spoilage bacteria on fresh meat is still in its infancy. Studies in this area are still lacking, especially for lamb. Biopreservatives need more testing under conditions representative of commercial meat production, along with studies of any possible sensory effects, in order to validate their potential for large-scale industrial applications.

Impact of a Combination of UV-C Irradiation and Peracetic Acid Spray Treatment on Brochothrix thermosphacta and Yersinia enterocolitica Contaminated Pork

Efficient ways of decontamination are needed to minimize the risk of infections with Yersinia (Y.) enterocolitica, which causes gastrointestinal diseases in humans, and to reduce the numbers of Brochothrix (B.) thermosphacta to extend the shelf-life of meat. While many studies have focused on a single treatment of peracetic acid (PAA) or UV-C-irradiation, there are no studies about a combined treatment on meat. Therefore, in the present study, pork was inoculated with either Y. enterocolitica or B. thermosphacta, and was treated with a combination of 2040 mJ/cm² UV-C irradiation followed by a 2000 ppm PAA spray treatment (30 s). Samples were packed under modified atmosphere and stored for 1, 7, or 14 days. The samples were examined for Y. enterocolitica and B. thermosphacta content, chemical and sensory effects, and meat quality parameters. For Y. enterocolitica, a significant reduction of up to 2.16 log₁₀ cfu/cm² meat and for B. thermosphacta, up to 2.37 log₁₀ cfu/cm² meat was seen on day 14 after UV-C/PAA treatment compared to the untreated controls.

Efficacy of antimicrobial interventions in reducing Salmonella enterica, Shiga toxin-producing Escherichia coli, Campylobacter, and Escherichia coli biotype I surrogates on non-chilled and chilled, skin-on and skinless pork

Effect of various antimicrobial interventions on pork carcass cuts - skin-on and skinless, non-chilled and chilled - was studied. Carcass pieces were inoculated with Salmonella enterica, Shiga toxin-producing Escherichia coli (STEC), Escherichia coli pathogen surrogates or Campylobacter spp. Inoculated pieces were assigned to one of the following antimicrobial treatments: 2.5% and 5.0% room temperature lactic acid, 2.5% and 5.0% warm (55 °C) lactic acid, 400 ppm (0.4 mg/mL) room temperature peroxyacetic acid (PAA) or warm (55 °C) water. Treated pieces were sampled before antimicrobial treatment of non-chilled pork tissue, then at 30 m and 24 h post-treatment. For chilled pork, samples were collected after 24 h chilling and 30 m post-treatment. Lactic acid and PAA treatments reduced (P < 0.05) pathogenic and surrogate bacteria; warm water did not produce similar results. Objective and sensory color evaluations on treated pork indicated minimal negative impacts on pork color. Various antimicrobial interventions were effective in reducing surrogates on pork without diminishing quality.

Antimicrobial resistance associated with the use of antimicrobial processing aids during poultry processing operations: cause for concern?

Antimicrobial resistance has become a global issue and a threat to human and animal health. Contamination of poultry carcasses with meat-borne pathogens represents both an economic and a public health concern. The use of antimicrobial processing aids (APA) during poultry processing has contributed to an improvement in the microbiological quality of poultry carcasses. However, the extensive use of these decontaminants has raised concerns about their possible role in the co-selection of antibiotic-resistant bacteria. This topic is presented in the current review to provide an update on the information related to bacterial adaptation to APA used in poultry processing establishments, and to discuss the relationship between APA bacterial adaptation and the acquisition of a new resistance phenotype to therapeutic antimicrobials by bacteria. Common mechanisms such as active efflux and changes in membrane fluidity are the most documented mechanisms responsible for bacterial cross-resistance to APA and antimicrobials. Although most studies reported a bacterial resistance to antibiotics not reaching a clinical level, the under-exposure of bacteria to APA remains a concern in the poultry industry. Further research is needed to determine if APA used during poultry processing and therapeutic antimicrobials share common sites of action in bacteria and encounter similar mechanisms of resistance.

Natural Phenolic Compounds for the Control of Oxidation, Bacterial Spoilage, and Foodborne Pathogens in Meat

Alternative technologies for long-term preservation, quality assurance, and safety of meat are continuously pursued by the food industry to satisfy the demands of modern consumers for nutritious and healthy meat-based products. Naturally occurring phenolic compounds are considered promising substances by the meat industry for their antioxidant and antimicrobial properties, while consumers seem to embrace them for their claimed health benefits. Despite the numerous in vitro and in situ studies demonstrating their beneficial effects against meat oxidation, spoilage, and foodborne pathogens, wide application and commercialization has not been yet achieved. Major obstacles are still the scarcity of legislative framework, the large variety of meat-based products and targeted pathogens, the limited number of case-specific application protocols and the questionable universal efficiency of the applied ones. The objectives of the present review are i) to summarize the current knowledge about the applications of naturally occurring phenols in meat and meat-based products, emphasizing the mechanisms, determinants, and spectrum of their antioxidant and antimicrobial activity; ii) to present state-of-the-art technologies utilized for the application of phenolic compounds in meat systems; and iii) to discuss relevant regulation, limitations, perspectives, and future challenges for their mass industrial use.

Towards understanding the antagonistic activity of phytic acid against common foodborne bacterial pathogens using a general linear model

The increasing challenge of antibiotic resistance requires not only the discovery of new antibiotics, but also the development of new alternative approaches. Therefore, in the present study, we investigated for the first time the antibacterial potential of phytic acid (myo-inositol hexakisphosphate, IP6), a natural molecule that is 'generally recognized as safe' (FDA classification), against the proliferation of common foodborne bacterial pathogens such as Listeria monocytogenes, Staphylococcus aureus and Salmonella Typhimurium. Interestingly, compared to citric acid, IP6 was found to exhibit significantly greater inhibitory activity (P<0.05) against these pathogenic bacteria. The minimum inhibitory concentration of IP6 varied from 0.488 to 0.97 mg/ml for the Gram-positive bacteria that were tested, and was 0.244 mg/ml for the Gram-negative bacteria. Linear and general models were used to further explore the antibacterial effects of IP6. The developed models were validated using experimental growth data for L. monocytogenes, S. aureus and S. Typhimurium. Overall, the models were able to accurately predict the growth of L. monocytogenes, S. aureus, and S. Typhimuriumin Polymyxin acriflavine lithium chloride ceftazidime aesculin mannitol (PALCAM), Chapman broth, and xylose lysine xeoxycholate (XLD) broth, respectively. Remarkably, the early logarithmic growth phase of S. Typhimurium showed a rapid and severe decrease in a period of less than one hour, illustrating the bactericidal effect of IP6. These results suggest that IP6 is an efficient antibacterial agent and can be used to control the proliferation of foodborne pathogens. It has promising potential for environmentally friendly applications in the food industry, such as for food preservation, food safety, and for prolonging shelf life.

Microbiological properties of poultry breast meat treated with high-intensity ultrasound

Lactic acid, psychrophilic, and mesophilic bacteria, Escherichia coli, Salmonella spp. and Staphylococcus aureus were enumerated on chicken breasts after treatment with different high intensity ultrasound (frequency 40 kHz, intensity 9.6 W/cm^-2) application times (0, 30, and 50 min) and packaging atmospheres (aerobic and vacuum) after a 7-day storage. The experiment was performed in commercial 7-week-old chicken breasts. Counts were performed prior to and immediately after ultrasonication, and on the 7th day of chill-storage. After sonication and storage, mesophiles, psychrophiles, LAB and S. aureus increased statistically. Psychrophiles decreased significantly under anaerobic packaging. There were no differences among ultrasonication times in terms of mesophiles, psychrophiles, LAB, E. coli and Salmonella spp. S. aureus numbers had a significant reduction after 50 min sonication. Under these experimental conditions, high-intensity ultrasound for 50 min is a control method of S. aureus and the anaerobic packaging reduces numbers of psychrophiles in chicken breast. The effect of ultrasound is only significant after the storage time.

Characterization of Salmonella spp.-specific bacteriophages and their biocontrol application in chicken breast meat

Chicken breast meat is considered as the main source of Salmonella infection in humans. The aim of this study was to isolate lytic bacteriophages specific for Salmonella enterica serovars Enteritidis and examine their efficacy in a cocktail for the biocontrol of Salmonella spp. in raw chicken breast meat. Four lytic phages belonging to the Myoviridae and Siphoviridae families were isolated from a river proximate to a duck farm. They exhibited broad lytic activities against 11 strains of S. Enteritidis, 11 strains of S. Typhimurium, and one each of S. Paratyphi A, S. San Diego, and S. Typhi. The phages were determined to be stable, exhibited similar degrees of resistance to heat and pH, and had latent periods ranging from 5 to 30 min. In addition, the phage particles were 100% adsorbed within 18 to 40 min. Viable cell counts of bacteria were significantly reduced in raw chicken breast samples (P < 0.05) when treated with a cocktail of all four bacteriophages at 4 °C for 7 days (multiplicities of infection were from 10⁴ to 10⁶ ). These results indicate the potential efficacy of the bacteriophage cocktail as a biological agent against S. Enteritidis in raw chicken breast meat. PRACTICAL APPLICATION: Our findings demonstrate that the phages could be effective in reducing the viability of Salmonella spp. bacteria in chicken breast meat. Therefore, the phage cocktail is a potential bactericidal agent for the biocontrol of Salmonella spp. in raw chicken breast meat and could be used use in various poultry industries in the future.

Isolation, characterization and application of a polyvalent phage capable of controlling Salmonella and Escherichia coli O157:H7 in different food matrices

Salmonella Enteritidis, Salmonella Typhimurium, and Escherichia coli O157:H7 are the most important foodborne pathogens, causing serious food poisoning outbreaks worldwide. Bacteriophages are increasingly considered as novel antibacterial agents to control foodborne pathogens. In this study, 8 Salmonella phages and 10 E. coli O157:H7 phages were isolated from chicken products. A polyvalent phage PS5 capable of infecting S. Enteritidis, S. Typhimurium, and E. coli O157:H7 was further characterized and its efficacy in reducing these foodborne pathogens was evaluated in in vitro and in foods. Morphology, one-step growth, and stability assay showed that phage PS5 was a myovirus, with relatively short latent periods, large burst sizes, and high stability. Genome sequencing analysis revealed that the genome of PS5 does not contain any genes associated to antibiotic resistance, toxins, lysogeny, and virulence factors. In broth, phage PS5 significantly decreased the viable counts of all the three bacterial hosts by more than 1.3 log CFU/mL compared to controls after 2 h of incubation at 4 °C and 24 °C. In foods, treatment with PS5 also resulted in significant reductions of viable counts of all the three bacterial hosts compared to controls at temperatures tested. This is the first report on single phage capable of simultaneously controlling S. Enteritidis, S. Typhimurium and E. coli O157:H7 in both in vitro and in foods.

Characterization of Lytic Bacteriophages Infecting Multidrug-Resistant Shiga Toxigenic Atypical Escherichia coli O177 Strains Isolated From Cattle Feces

The increasing incidence of antibiotic resistance and emergence of virulent bacterial pathogens, coupled with a lack of new effective antibiotics, has reignited interest in the use of lytic bacteriophage therapy. The aim of this study was to characterize lytic Escherichia coli O177-specific bacteriophages isolated from cattle feces to determine their potential application as biocontrol agents. A total of 31 lytic E. coli O177-specific bacteriophages were isolated. A large proportion (71%) of these phage isolates produced large plaques while 29% produced small plaques on 0.3% soft agar. Based on different plaque morphologies and clarity and size of plaques, eight phages were selected for further analyses. Spot test and efficiency of plating (EOP) analyses were performed to determine the host range for selected phages. Phage morphotype and growth were analyzed using transmission electron microscopy and the one-step growth curve method. Phages were also assessed for thermal and pH stability. The spot test revealed that all selected phages were capable of infecting different environmental E. coli strains. However, none of the phages infected American Type Culture Collection (ATCC) and environmental Salmonella strains. Furthermore, EOP analysis (range: 0.1-1.0) showed that phages were capable of infecting a wide range of E. coli isolates. Selected phage isolates had a similar morphotype (an icosahedral head and a contractile tail) and were classified under the order Caudovirales, Myoviridae family. The icosahedral heads ranged from 81.2 to 110.77 nm, while the contractile tails ranged from 115.55 to 132.57 nm in size. The phages were found to be still active after 60 min of incubation at 37 and 40°C. Incremental levels of pH induced a quadratic response on stability of all phages. The pH optima for all eight phages ranged between 7.6 and 8.0, while at pH 3.0 all phages were inactive. Phage latent period ranged between 15 and 25 min while burst size ranged from 91 to 522 virion particles [plaque-forming unit (PFU)] per infected cell. These results demonstrate that lytic E. coli O177-specific bacteriophages isolated from cattle feces are highly stable and have the capacity to infect different E. coli strains, traits that make them potential biocontrol agents.

Application of chlorine dioxide and peroxyacetic acid during spray chilling as a potential antimicrobial intervention for beef carcasses

Enteric pathogens such as Shiga-toxin producing Escherichia coli (STEC) and Salmonella spp. continue to be a major food safety concern for the beef industry. Currently, no single method is completely effective in controlling these pathogens during carcass processing. Previous research, however, suggested that STEC might become more susceptible to oxidative damage when exposed to carcass chilling (King et al., 2016). We aimed to test that hypothesis by evaluating the antimicrobial effects of an oxidant (chlorine dioxide, ClO₂ or peroxyacetic acid, PAA) on beef meat during a simulated spray chilling process (sprayed for 4 s every 15 min for 36 cycles) and/or when applied (sprayed for 144 s) prior to spray chilling with water. In all experiments, the inactivating effects of oxidants were greatest on fat surfaces and much less effective on lean surfaces. ClO₂ at 15 ppm, a non-lethal level for E. coli under optimal growth conditions, caused higher log reductions in E. coli numbers (approximately 3-log reduction) when applied during spray chilling than when applied immediately prior to 'normal' spray chilling (approximately 1-log reduction). This confirms the hypothesis that E. coli are more susceptible to oxidative stress during spray chilling. In subsequent studies, both ClO₂ and PAA at lethal levels (at ≥20 and ≥ 200 ppm, respectively) applied during spray chilling resulted in pronounced inactivation of both E. coli and Salmonella enterica strains, achieving a ≥4-log reduction at the end of chilling. These results indicate that an oxidant-based application during spray chilling as an antimicrobial intervention could be effective to minimise the problems associated with enteric pathogen contamination on beef meat.

Development and Application of an Active Plastic Multilayer Film by Coating a Plantaricin BM-1 for Chilled Meat Preservation

Abstract

In this study, an active antibacterial packaging film was developed by coating a polyethylene terephthalate/polyvinylidene chloride/retort casting polypropylene (PPR) plastic multilayer film with plantaricin BM‐1 and chitosan. The characteristics of the active packaging film and its antibacterial effect for chilled meat preservation were evaluated. Our results indicated that the barrier properties against oxygen were improved significantly and the tensile strength and the elongation at break were changed slightly. The active plantaricin film significantly (P < 0.05) decreased the viable counts of Listeria monocytogenes by 3.6 log₁₀CFU/mL in liquid medium and approximately 1.4 log₁₀CFU/g in meat stored at 4 °C for 8 days compared with the control. Moreover, the viable counts of aerobes and anaerobes in the meat packaged with the active plantaricin film were significantly (P < 0.05) decreased by approximately 0.6 log₁₀CFU/g and 1.1 log₁₀CFU/g when compared with that packaged with PPR film stored at 4 °C for 12 days. The total volatile base (TVB‐N) in the meat packaged with the active plantaricin film was significantly (P < 0.05) lower than that in the control during the entire storage period. Our results indicated that the active film could extend the meat shelf life by inhibiting the L. monocytogenes and the background spoilage bacteria in chilled meat stored at 4 °C. This outcome suggests that plastic multilayer film incorporating plantaricin BM‐1 can be potentially used for fresh meat packaging.

Practical Application

Fresh meat is highly perishable product. This study developed a plantaricin BM‐1 active plastic multilayer film that can inhibit the growth of microorganisms in chilled meat during storage at 4 °C.

THE PROBLEMS OF MEAT PRODUCTS THERMAL TREATMENT

The main problems of meat products thermal treatment have been considered and analysed in the paper. Analysis of the existing research papers suggests that the main attention is devoted to the influence of temperature value and time of processing on the physical, chemical, microbiological and organoleptic indicators of the product. The influence on the protein and fat components of raw meat has been described as well as the changes in the meat product structure under the influence of temperature have been pointed out. The important impact of thermal treatment on the changes in proteins at heating, including solubility and hydration of the proteins, has been examined. The paper analyses the microbiota screening before and after thermal treatment. Special attention was paid to the impact of temperature on microbiota as it is an important indicator of a meat product safety. Methods and purpose of thermal treatments as well as the advantages and drawbacks of each method were considered. Formation of tastiness properties of the product depending on the methods and thermal cycling was emphasized. Submitted is the analysis of the factors that influence the product mass losses under the impact of high temperature. The dependence conditions of a meat product quality on the thermal cycle were also analysed. Attention is paid to alternative methods of thermal heating as well as their influence on ready product quality and safety. Substantial contribution of Odesa National Academy of Food Technologies to solving problems of the conventional thermal treatment of meat products was shown, same as a possibility of bringing a product to cooking readiness without application of high temperature. The main content of the paper includes analysis of the methods and thermal treatment cycles existing in the world and proves importance of the temperature control and cooking time which influence safety, quality and yield of the product.

Reviewing Interventions against Enterobacteriaceae in Broiler Processing: Using Old Techniques for Meeting the New Challenges of ESBL E. coli?

Extended-spectrum beta-lactamase- (ESBL-) producing Enterobacteriaceae are frequently detected in poultry and fresh chicken meat. Due to the high prevalence, an impact on human colonization and the spread of antibiotic resistance into the environment is assumed. ESBL-producing Enterobacteriaceae can be transmitted along the broiler production chain but also their persistence is reported because of insufficient cleaning and disinfection. Processing of broiler chickens leads to a reduction of microbiological counts on the carcasses. However, processing steps like scalding, defeathering, and evisceration are critical concerning fecal contamination and, therefore, cross-contamination with bacterial strains. Respective intervention measures along the slaughter processing line aim at reducing the microbiological load on broiler carcasses as well as preventing cross-contamination. Published data on the impact of possible intervention measures against ESBL-producing Enterobacteriaceae are missing and, therefore, we focused on processing measures concerning Enterobacteriaceae, in particular E. coli or coliform counts, during processing of broiler chickens to identify possible hints for effective strategies to reduce these resistant bacteria. In total, 73 publications were analyzed and data on the quantitative reductions were extracted. Most investigations concentrated on scalding, postdefeathering washes, and improvements in the chilling process and were already published in and before 2008 (n=42, 58%). Therefore, certain measures may be already installed in slaughterhouse facilities today. The effect on eliminating ESBL-producing Enterobacteriaceae is questionable as there are still positive chicken meat samples found. A huge number of studies dealt with different applications of chlorine substances which are not approved in the European Union and the reduction level did not exceed 3 log10 values. None of the measures was able to totally eradicate Enterobacteriaceae from the broiler carcasses indicating the need to develop intervention measures to prevent contamination with ESBL-producing Enterobacteriaceae and, therefore, the exposure of humans and the further release of antibiotic resistances into the environment.

Chitosan Coating Inhibits the Growth of Listeria monocytogenes and Extends the Shelf Life of Vacuum-Packed Pork Loins at 4 °C

Chitosan coating is a promising method for food preservation. This study aims to fill the data gap regarding the application of chitosan (1% and 2%) on vacuum-packed fresh pork stored at 4 °C for 28 days, with particular attention on the effect on Listeria monocytogenes, inoculated as a cocktail of three strains. Chitosan at both concentrations was able to significantly reduce L. monocytogenes counts by more than 1.5 Log CFU/g with respect to control; moreover, it inhibited the growth of mesophilic bacteria and was particularly effective on lactic acid bacteria and yeasts. The beneficial effects on shelf life were demonstrated by both panel test and pH evolution. In fact, panellists did not detect any sensory difference between samples treated with 1% chitosan and control up to 14 days of storage, while after 28 days, a pungent flesh odour was perceived in control samples only. Interestingly, at aw values of fresh meat (0.984), the chitosan coating exhibited a liquid behaviour, with a dynamic viscosity of 229.4 ± 4.2 mPa/s. Chitosan coating applied on vacuum-packed pork loins contained L. monocytogenes growth and improved the microbiological characteristics of the product, with a beneficial effect on product shelf life.

Comparative evaluation of spoilage-related bacterial diversity and metabolite profiles in chilled beef stored under air and vacuum packaging

Microbial spoilage is a complex event to which different bacterial populations and metabolites can contribute depending on the storage conditions. This study explored the evolution of spoilage and related volatile organic compounds (VOCs) in chilled beef under air and vacuum packaging (VP). The results suggested that different storage conditions affected changes in bacterial communities and metabolites in beef and consequently affected the odor properties of the stored beef, thereby leading to spoilage. Bacterial species belonging to Pseudomonadaceae (Pseudomonas spp.) and lactic acid bacteria (Lactobacillus sp.) dominated the bacterial communities in beef stored under air and VP, respectively, with several VOCs associated with off-odors of the stored beef and most likely produced by both bacteria. Our results suggested several microbial VOCs that could be used as potential spoilage indicators, including acetic acid, butanoic acid, and 2-butanone in VP-stored beef and 3-methylbutan-1-ol, ethyl acetate, acetoin, 2-butanone, and diacetyl in air-stored beef. These findings might provide valuable information regarding the quality monitoring of beef during storage.

Effect of Pressure, Reconstituted RTE Meat Microbiota, and Antimicrobials on Survival and Post-pressure Growth of Listeria monocytogenes on Ham

Pressure treatment of ready-to-eat (RTE) meats extends the shelf life and reduces risks associated with Listeria monocytogenes. However, pressure reduces numbers of Listeria on ham by less than 5 log (CFU/g) and pressure effects on other meat microbiota are poorly documented. This study investigated the impact of pressure and RTE meat microbiota, with or without nisin and rosemary oil, on survival of Listeria after refrigerated storage. Ham was inoculated with a 5-strain cocktail of L. monocytogenes alone or with a cocktail of RTE meat microbiota consisting of Brochothrix thermosphacta, Carnobacterium maltaromaticum, Leuconostoc gelidum, and Lactobacillussakei. Products were treated at 500 MPa at 5°C for 1 or 3 min, with or without rosemary extract or nisin. Surviving cells were differentially enumerated after pressure treatment and after 4 weeks of refrigerated storage. After 4 weeks of storage, products were also analyzed by high throughput sequencing of 16S rRNA amplicons. Pressure treatment reduced counts of Listeria by 1 to 2 log (CFU/g); inactivation of RTE meat microbiota was comparable. Counts of Listeria increased by 1–3 log (CFU/g) during refrigerated storage. RTE meat microbiota did not influence pressure inactivation of Listeria but prevented growth of Listeria during refrigerated storage. Rosemary extract did not influence bacterial inactivation or growth. The combination of nisin with pressure treatment for 3 min reduced counts of Listeria and meat microbiota by >5 log (CFU/g); after 4 weeks of storage, counts were below the detection limit. In conclusion, pressure alone does not eliminate Listeria or other microbiota on RTE ham; however, the presence of non-pathogenic microbiota prevents growth of Listeria on pressure treated ham and has a decisive influence on post-pressure survival and growth.

Spray coating application for the development of nanocoated antimicrobial low-density polyethylene films to increase the shelf life of chicken breast fillets

Antimicrobial coated films were produced by an innovative method that allowed surface modification of commercial low-density polyethylene films so that well-defined antimicrobial surfaces could be prepared. A Pluronic™ surfactant and a polystyrene-polyethylene oxide block copolymer were employed to develop modified materials. The Pluronic™ surfactant provided a more readily functionalised film surface, while block copolymer provided a reactive interface which was important in providing a route to silver nanoparticles that were well adhered to the surface. Antimicrobial films containing silver were manufactured using a spray coater and the amount of silver used for coating purposes varied by the concentration of the silver precursor (silver nitrate) or the number of silver coatings applied. Potential antimicrobial activity of manufactured silver-coated low-density polyethylene films was tested against Pseudomonas fluorescens, Staphylococcus aureus and microflora isolated from raw chicken. The microbiological and physicochemical quality of chicken breast fillets wrapped with silver-coated low-density polyethylene films followed by vacuum skin packaging was also assessed during storage. Antimicrobial activity of developed silver-coated low-density polyethylene films was dependent ( p < 0.05) upon the concentrations of silver precursor and the number of silver coatings used. Better antimicrobial activity against P. fluorescens, S. aureus and chicken microflora was observed when the concentration of silver precursor was 3% and the spray coating deposition of silver was repeated four times. Use of silver-coated low-density polyethylene films extended ( p < 0.05) shelf life of chicken breast fillets and enhanced ( p < 0.05) oxidative stability compared to control films. Results indicated that silver-coated low-density polyethylene films could potentially be used as antimicrobial packaging for food applications.

Bacteriocinogenic LAB Strains for Fermented Meat Preservation: Perspectives, Challenges, and Limitations

Over the last decades, much research has focused on lactic acid bacteria (LAB) bacteriocins because of their potential as biopreservatives and their action against the growth of spoilage microbes. Meat and fermented meat products are prone to microbial contamination, causing health risks, as well as economic losses in the meat industry. The use of bacteriocin-producing LAB starter or protective cultures is suitable for fermented meats. However, although bacteriocins can be produced during meat processing, their levels are usually much lower than those achieved during in vitro fermentations under optimal environmental conditions. Thus, the direct addition of a bacteriocin food additive would be desirable. Moreover, safety and technological characteristics of the bacteriocinogenic LAB must be considered before their widespread applications. This review describes the perspectives and challenges toward the complete disclosure of new bacteriocins as effective preservatives in the production of safe and "healthy" fermented meat products.