1
|
Wang H, Gao R, Song X, Yuan X, Chen X, Zhao Y. Study on the production of Sophorolipid by Starmerella bombicola yeast using fried waste oil fermentation. Biosci Rep 2024; 44:BSR20230345. [PMID: 38063133 PMCID: PMC10830443 DOI: 10.1042/bsr20230345] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/18/2023] [Revised: 10/20/2023] [Accepted: 11/20/2023] [Indexed: 02/03/2024] Open
Abstract
Sophorolipids (SLs) are surface active compounds that have excellent surface-lowering properties. SLs were produced by Starmerella bombicola (CGMCC1576) yeast with sunflower seed oil, fried waste oil, cooked tung oil and raw tung oil used as hydrophobic carbon sources. The results showed that the strain could use sunflower seed oil and fried waste oil as hydrophobic carbon sources to produce SLs, and the yields were 44.52 and 39.09 gl-1. It could not be used as cooked tung oil and raw tung oil. The analysis by high-performance liquid chromatography/high resolution mass spectrometry (HPLC-MS/MS) showed that the main composition and structure of SLs produced by fermentation using fried waste oil were similar to that of sunflower seed oil as hydrophobic carbon source. The yield of SLs was the highest when the fried waste oil was used as hydrophobic carbon source, glucose (8%), waste oil (6%) and yeast (0.3%). When fried waste oil was used as a hydrophobic carbon source in a parallel 4-strand fermentation tank (FT), the combination with the largest yield and the most cost saving was that 3% of fried waste oil was added into the initial medium, and another 3% was again added after 72 h of fermentation. The total yield of SLs was 121.28 gl-1, and the yield of lactone SLs was 48.07 gl-1.
Collapse
Affiliation(s)
- Haifeng Wang
- Department of Food and Drug, Baotou Light Industry Vocational Technical College, Baotou, Inner Mongolia, China
| | - Ruifang Gao
- Modern Agriculture and Animal Husbandry Development Center, Bureau of Agriculture and Animal, Husbandry of Bayannur City, Bayannur, Inner Mongolia, China
| | - Xin Song
- Institute of Microbial Technology, Shandong University, Qingdao, Shandong, China
| | - Xiangdong Yuan
- Department of Food and Drug, Baotou Light Industry Vocational Technical College, Baotou, Inner Mongolia, China
| | - Xiuli Chen
- School of Biological Science and Technology, Baotou Teachers’ College, Baotou, Inner Mongolia, China
| | | |
Collapse
|
2
|
Pala M, Castelein MG, Dewaele C, Roelants SLKW, Soetaert WK, Stevens CV. Tuning the antimicrobial activity of microbial glycolipid biosurfactants through chemical modification. Front Bioeng Biotechnol 2024; 12:1347185. [PMID: 38419728 PMCID: PMC10900251 DOI: 10.3389/fbioe.2024.1347185] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/30/2023] [Accepted: 01/30/2024] [Indexed: 03/02/2024] Open
Abstract
Sophorolipids, glycolipid biosurfactants derived from microorganisms such as Starmerella bombicola, possess distinctive surface-active and bioactive properties, holding potential applications in cosmetics, pharmaceuticals and bioremediation. However, the limited structural variability in wild-type sophorolipids restricts their properties and applications. To address this, metabolic engineering efforts have allowed to create a portfolio of molecules. In this study, we went one step further by chemically modifying microbially produced sophorosides, produced by an engineered S. bombicola. Twenty-four new sophoroside derivatives were synthesized, including sophoroside amines with varying alkyl chain lengths (ethyl to octadecyl) on the nitrogen atom and their corresponding quaternary ammonium salts. Additionally, six different microbially produced glycolipid biosurfactants were hydrogenated to achieve fully saturated lipid tails. These derivatives, along with microbially produced glycolipids and three benchmark biosurfactants (di-rhamnolipids, alkyl polyglucosides, cocamidopropyl betaine), were assessed for antimicrobial activity against bacteria (Bacillus subtilis, Staphylococcus aureus, Listeria monocytogenes, Escherichia coli, Pseudomonas aeruginosa) and yeast (Candida albicans). Results indicated that microbially produced glycolipids, such as bola sophorosides, acidic sophorolipids and acidic glucolipids exhibit selective antimicrobial activity against the test organisms. Conversely, lactonic sophorolipids, sophoroside amines and quaternary ammonium salts display a broad antimicrobial activity. N-octyl, N-dodecyl and N-octadecyl derivatives exhibit the lowest minimal inhibitory concentrations, ranging from 0.014 to 20.0 mg mL-1. This study demonstrates the potential synergy of thoughtful biotechnology and targeted chemistry to precisely tailor glycolipid biosurfactants to meet specific requirements across applications.
Collapse
Affiliation(s)
- Melike Pala
- SynBioC, Department of Green Chemistry and Technology, Faculty of Bioscience Engineering, Ghent University, Ghent, Belgium
| | - Martijn G. Castelein
- Department of Biotechnology, Centre for Industrial Biotechnology and Biocatalysis (InBio.be), Faculty of Bioscience Engineering, Ghent University, Ghent, Belgium
| | - Camille Dewaele
- Department of Biotechnology, Centre for Industrial Biotechnology and Biocatalysis (InBio.be), Faculty of Bioscience Engineering, Ghent University, Ghent, Belgium
| | - Sophie L. K. W. Roelants
- Department of Biotechnology, Centre for Industrial Biotechnology and Biocatalysis (InBio.be), Faculty of Bioscience Engineering, Ghent University, Ghent, Belgium
- Bio Base Europe Pilot Plant (BBEPP), Ghent, Belgium
| | - Wim K. Soetaert
- Department of Biotechnology, Centre for Industrial Biotechnology and Biocatalysis (InBio.be), Faculty of Bioscience Engineering, Ghent University, Ghent, Belgium
- Bio Base Europe Pilot Plant (BBEPP), Ghent, Belgium
| | - Christian V. Stevens
- SynBioC, Department of Green Chemistry and Technology, Faculty of Bioscience Engineering, Ghent University, Ghent, Belgium
| |
Collapse
|
3
|
Puyol McKenna P, Naughton PJ, Dooley JSG, Ternan NG, Lemoine P, Banat IM. Microbial Biosurfactants: Antimicrobial Activity and Potential Biomedical and Therapeutic Exploits. Pharmaceuticals (Basel) 2024; 17:138. [PMID: 38276011 PMCID: PMC10818721 DOI: 10.3390/ph17010138] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/30/2023] [Revised: 01/14/2024] [Accepted: 01/18/2024] [Indexed: 01/27/2024] Open
Abstract
The rapid emergence of multidrug-resistant pathogens worldwide has raised concerns regarding the effectiveness of conventional antibiotics. This can be observed in ESKAPE pathogens, among others, whose multiple resistance mechanisms have led to a reduction in effective treatment options. Innovative strategies aimed at mitigating the incidence of antibiotic-resistant pathogens encompass the potential use of biosurfactants. These surface-active agents comprise a group of unique amphiphilic molecules of microbial origin that are capable of interacting with the lipidic components of microorganisms. Biosurfactant interactions with different surfaces can affect their hydrophobic properties and as a result, their ability to alter microorganisms' adhesion abilities and consequent biofilm formation. Unlike synthetic surfactants, biosurfactants present low toxicity and high biodegradability and remain stable under temperature and pH extremes, making them potentially suitable for targeted use in medical and pharmaceutical applications. This review discusses the development of biosurfactants in biomedical and therapeutic uses as antimicrobial and antibiofilm agents, in addition to considering the potential synergistic effect of biosurfactants in combination with antibiotics. Furthermore, the anti-cancer and anti-viral potential of biosurfactants in relation to COVID-19 is also discussed.
Collapse
Affiliation(s)
- Patricia Puyol McKenna
- The Nutrition Innovation Centre for Food and Health (NICHE), School of Biomedical Sciences, Faculty of Life and Health Sciences, Ulster University, Coleraine BT52 1 SA, UK; (P.P.M.); (P.J.N.); (J.S.G.D.); (N.G.T.)
| | - Patrick J. Naughton
- The Nutrition Innovation Centre for Food and Health (NICHE), School of Biomedical Sciences, Faculty of Life and Health Sciences, Ulster University, Coleraine BT52 1 SA, UK; (P.P.M.); (P.J.N.); (J.S.G.D.); (N.G.T.)
| | - James S. G. Dooley
- The Nutrition Innovation Centre for Food and Health (NICHE), School of Biomedical Sciences, Faculty of Life and Health Sciences, Ulster University, Coleraine BT52 1 SA, UK; (P.P.M.); (P.J.N.); (J.S.G.D.); (N.G.T.)
| | - Nigel G. Ternan
- The Nutrition Innovation Centre for Food and Health (NICHE), School of Biomedical Sciences, Faculty of Life and Health Sciences, Ulster University, Coleraine BT52 1 SA, UK; (P.P.M.); (P.J.N.); (J.S.G.D.); (N.G.T.)
| | - Patrick Lemoine
- Nanotechnology and Integrated Bioengineering Centre (NIBEC), School of Engineering, Ulster University, Belfast BT15 1ED, UK;
| | - Ibrahim M. Banat
- Pharmaceutical Science Research Group, Biomedical Sciences Research Institute, Ulster University, Coleraine BT52 1SA, UK
| |
Collapse
|
4
|
Liu F, Greenwood AI, Xiong Y, Miceli RT, Fu R, Anderson KW, McCallum SA, Mihailescu M, Gross R, Cotten ML. Host Defense Peptide Piscidin and Yeast-Derived Glycolipid Exhibit Synergistic Antimicrobial Action through Concerted Interactions with Membranes. JACS AU 2023; 3:3345-3365. [PMID: 38155643 PMCID: PMC10751773 DOI: 10.1021/jacsau.3c00506] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 08/26/2023] [Revised: 09/25/2023] [Accepted: 09/29/2023] [Indexed: 12/30/2023]
Abstract
Developing new antimicrobials as alternatives to conventional antibiotics has become an urgent race to eradicate drug-resistant bacteria and to save human lives. Conventionally, antimicrobial molecules are studied independently even though they can be cosecreted in vivo. In this research, we investigate two classes of naturally derived antimicrobials: sophorolipid (SL) esters as modified yeast-derived glycolipid biosurfactants that feature high biocompatibility and low production cost; piscidins, which are host defense peptides (HDPs) from fish. While HDPs such as piscidins target the membrane of pathogens, and thus result in low incidence of resistance, SLs are not well understood on a mechanistic level. Here, we demonstrate that combining SL-hexyl ester (SL-HE) with subinhibitory concentration of piscidins 1 (P1) and 3 (P3) stimulates strong antimicrobial synergy, potentiating a promising therapeutic window. Permeabilization assays and biophysical studies employing circular dichroism, NMR, mass spectrometry, and X-ray diffraction are performed to investigate the mechanism underlying this powerful synergy. We reveal four key mechanistic features underlying the synergistic action: (1) P1/3 binds to SL-HE aggregates, becoming α-helical; (2) piscidin-glycolipid assemblies synergistically accumulate on membranes; (3) SL-HE used alone or bound to P1/3 associates with phospholipid bilayers where it induces defects; (4) piscidin-glycolipid complexes disrupt the bilayer structure more dramatically and differently than either compound alone, with phase separation occurring when both agents are present. Overall, dramatic enhancement in antimicrobial activity is associated with the use of two membrane-active agents, with the glycolipid playing the roles of prefolding the peptide, coordinating the delivery of both agents to bacterial surfaces, recruiting the peptide to the pathogenic membranes, and supporting membrane disruption by the peptide. Given that SLs are ubiquitously and safely used in consumer products, the SL/peptide formulation engineered and mechanistically characterized in this study could represent fertile ground to develop novel synergistic agents against drug-resistant bacteria.
Collapse
Affiliation(s)
- Fei Liu
- Department
of Chemistry, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Alexander I. Greenwood
- Department
of Applied Science, William & Mary, Williamsburg, Virginia 23185, United States
| | - Yawei Xiong
- Department
of Applied Science, William & Mary, Williamsburg, Virginia 23185, United States
| | - Rebecca T. Miceli
- Department
of Chemistry, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
- Center
for Biotechnology and Interdisciplinary Studies, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Riqiang Fu
- Center
of Interdisciplinary Magnetic Resonance, National High Magnetic Field Laboratory, Tallahassee, Florida 32310, United States
| | - Kyle W. Anderson
- National
Institute of Standards and Technology, Rockville, Maryland 20850, United States
| | - Scott A. McCallum
- Center
for Biotechnology and Interdisciplinary Studies, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Mihaela Mihailescu
- Institute
for Bioscience and Biotechnology Research, University of Maryland, Rockville, Maryland 20850, United States
| | - Richard Gross
- Department
of Chemistry, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
- Center
for Biotechnology and Interdisciplinary Studies, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Myriam L. Cotten
- Department
of Applied Science, William & Mary, Williamsburg, Virginia 23185, United States
| |
Collapse
|
5
|
Ceresa C, Fracchia L, Sansotera AC, De Rienzo MAD, Banat IM. Harnessing the Potential of Biosurfactants for Biomedical and Pharmaceutical Applications. Pharmaceutics 2023; 15:2156. [PMID: 37631370 PMCID: PMC10457971 DOI: 10.3390/pharmaceutics15082156] [Citation(s) in RCA: 5] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/17/2023] [Revised: 08/13/2023] [Accepted: 08/15/2023] [Indexed: 08/27/2023] Open
Abstract
Biosurfactants (BSs) are microbial compounds that have emerged as potential alternatives to chemical surfactants due to their multifunctional properties, sustainability and biodegradability. Owing to their amphipathic nature and distinctive structural arrangement, biosurfactants exhibit a range of physicochemical properties, including excellent surface activity, efficient critical micelle concentration, humectant properties, foaming and cleaning abilities and the capacity to form microemulsions. Furthermore, numerous biosurfactants display additional biological characteristics, such as antibacterial, antifungal and antiviral effects, and antioxidant, anticancer and immunomodulatory activities. Over the past two decades, numerous studies have explored their potential applications, including pharmaceuticals, cosmetics, antimicrobial and antibiofilm agents, wound healing, anticancer treatments, immune system modulators and drug/gene carriers. These applications are particularly important in addressing challenges such as antimicrobial resistance and biofilm formations in clinical, hygiene and therapeutic settings. They can also serve as coating agents for surfaces, enabling antiadhesive, suppression, or eradication strategies. Not least importantly, biosurfactants have shown compatibility with various drug formulations, including nanoparticles, liposomes, micro- and nanoemulsions and hydrogels, improving drug solubility, stability and bioavailability, and enabling a targeted and controlled drug release. These qualities make biosurfactants promising candidates for the development of next-generation antimicrobial, antibiofilm, anticancer, wound-healing, immunomodulating, drug or gene delivery agents, as well as adjuvants to other antibiotics. Analysing the most recent literature, this review aims to update the present understanding, highlight emerging trends, and identify promising directions and advancements in the utilization of biosurfactants within the pharmaceutical and biomedical fields.
Collapse
Affiliation(s)
- Chiara Ceresa
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (L.F.); (A.C.S.)
| | - Letizia Fracchia
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (L.F.); (A.C.S.)
| | - Andrea Chiara Sansotera
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (L.F.); (A.C.S.)
| | | | - Ibrahim M. Banat
- Pharmaceutical Science Research Group, Biomedical Science Research Institute, Ulster University, Coleraine BT52 1SA, UK
| |
Collapse
|
6
|
Xia Y, Shi Y, Chu J, Zhu S, Luo X, Shen W, Chen X. Efficient Biosynthesis of Acidic/Lactonic Sophorolipids and Their Application in the Remediation of Cyanobacterial Harmful Algal Blooms. Int J Mol Sci 2023; 24:12389. [PMID: 37569764 PMCID: PMC10418985 DOI: 10.3390/ijms241512389] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/25/2023] [Revised: 07/21/2023] [Accepted: 07/31/2023] [Indexed: 08/13/2023] Open
Abstract
Cyanobacterial harmful algal blooms (CyanoHABs) pose significant threats to human health and natural ecosystems worldwide, primarily caused by water eutrophication, increased surface water temperature, and co-occurring microorganisms. Urgent action is needed to develop an eco-friendly solution to effectively curb the proliferation of CyanoHABs. Sophorolipids (SLs) are fully biodegradable biosurfactants synthesized by Starmerella bombicola. They can be classified into lactone and acid types. The lactone type displays strong antimicrobial activity, while the acid type exhibits good solubility, which make them ideal agents for mitigating CyanoHABs. Nevertheless, the broad utilization of SLs are hindered by their expensive production costs and the absence of effective genetic editing tools in the native host. In this study, we constructed recombinant strains capable of producing either acidic or lactonic SLs using the CRISPR-Cas9 gene editing system. The yields of acidic and lactonic SLs reached 53.64 g/L and 45.32 g/L in a shaking flask, respectively. In a 5 L fermenter, acidic SLs reached 129.7 g/L using low-cost glucose and rapeseed oil as substrates. The addition of 5 mg/L lactonic SLs effectively degraded cyanobacteria within 30 min, and a ratio of 8.25:1.75 of lactonic to acidic SLs showed the highest degradation efficiency. This study offers a safe and promising solution for CyanoHABs treatment.
Collapse
Affiliation(s)
- Yuanyuan Xia
- Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, China; (Y.X.); (Y.S.); (J.C.); (S.Z.); (W.S.)
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Yibo Shi
- Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, China; (Y.X.); (Y.S.); (J.C.); (S.Z.); (W.S.)
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Jieyu Chu
- Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, China; (Y.X.); (Y.S.); (J.C.); (S.Z.); (W.S.)
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Shiying Zhu
- Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, China; (Y.X.); (Y.S.); (J.C.); (S.Z.); (W.S.)
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Xiaozhou Luo
- Center for Synthetic Biochemistry, Shenzhen Institutes for Advanced Technologies, Chinese Academy of Sciences, Shenzhen 518055, China;
| | - Wei Shen
- Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, China; (Y.X.); (Y.S.); (J.C.); (S.Z.); (W.S.)
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Xianzhong Chen
- Key Laboratory of Industrial Biotechnology, Ministry of Education, School of Biotechnology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, China; (Y.X.); (Y.S.); (J.C.); (S.Z.); (W.S.)
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| |
Collapse
|
7
|
Roberge CL, Miceli RT, Murphy LR, Kingsley DM, Gross RA, Corr DT. Sophorolipid Candidates Demonstrate Cytotoxic Efficacy against 2D and 3D Breast Cancer Models. JOURNAL OF NATURAL PRODUCTS 2023; 86:1159-1170. [PMID: 37104545 PMCID: PMC10760934 DOI: 10.1021/acs.jnatprod.2c00804] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/27/2023]
Abstract
Sophorolipids are biosurfactants derived from the nonpathogenic yeasts such as Starmerella bombicola with potential efficacy in anticancer applications. Simple and cost-effective synthesis of these drugs makes them a promising alternative to traditional chemotherapeutics, pending their success in preliminary drug-screening. Drug-screening typically utilizes 2D cell monolayers due to their simplicity and ease of high-throughput assessment. However, 2D assays fail to capture the complexity and 3D context of the tumor microenvironment and have consequently been implicated in the high percentage of drugs investigated in vitro that later fail in clinical trials. Herein, we screened two sophorolipid candidates and a clinically-used chemotherapeutic, doxorubicin, on in vitro breast cancer models ranging from 2D monolayers to 3D spheroids, employing optical coherence tomography to confirm these morphologies. We calculated corresponding IC50 values for these drugs and found one of the sophorolipids to have comparable toxicities to the chemotherapeutic control. Our findings show increased drug resistance associated with model dimensionality, such that all drugs tested showed that 3D spheroids exhibited higher IC50 values than their 2D counterparts. These findings demonstrate promising preliminary data to support the use of sophorolipids as a more affordable alternative to traditional clinical interventions and demonstrate the importance of 3D tumor models in assessing drug response.
Collapse
Affiliation(s)
- Cassandra L Roberge
- Department of Biomedical Engineering, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Rebecca T Miceli
- Department of Chemistry and Chemical Biology, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
- Center for Biotechnology and Interdisciplinary Sciences, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Lillian R Murphy
- Department of Biomedical Engineering, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - David M Kingsley
- Department of Biomedical Engineering, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - Richard A Gross
- Department of Chemistry and Chemical Biology, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
- Center for Biotechnology and Interdisciplinary Sciences, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| | - David T Corr
- Department of Biomedical Engineering, Rensselaer Polytechnic Institute, Troy, New York 12180, United States
| |
Collapse
|
8
|
Silva JDME, Martins LHDS, Moreira DKT, Silva LDP, Barbosa PDPM, Komesu A, Ferreira NR, de Oliveira JAR. Microbial Lipid Based Biorefinery Concepts: A Review of Status and Prospects. Foods 2023; 12:2074. [PMID: 37238892 PMCID: PMC10217607 DOI: 10.3390/foods12102074] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/28/2023] [Revised: 05/17/2023] [Accepted: 05/17/2023] [Indexed: 05/28/2023] Open
Abstract
The use of lignocellulosic biomass as a raw material for the production of lipids has gained increasing attention, especially in recent years when the use of food in the production of biofuels has become a current technology. Thus, the competition for raw materials for both uses has brought the need to create technological alternatives to reduce this competition that could generate a reduction in the volume of food offered and a consequent commercial increase in the value of food. Furthermore, the use of microbial oils has been studied in many industrial branches, from the generation of renewable energy to the obtainment of several value-added products in the pharmaceutical and food industries. Thus, this review provides an overview of the feasibility and challenges observed in the production of microbial lipids through the use of lignocellulosic biomass in a biorefinery. Topics covered include biorefining technology, the microbial oil market, oily microorganisms, mechanisms involved in lipid-producing microbial metabolism, strain development, processes, lignocellulosic lipids, technical drawbacks, and lipid recovery.
Collapse
Affiliation(s)
- Jonilson de Melo e Silva
- Program of Food Science and Technology, Federal University of Pará (UFPA), Belém 66075-110, PA, Brazil
| | | | | | - Leonardo do Prado Silva
- Department of Food Science and Nutrition, Faculty of Food Engineering (FEA), State University of Campinas (UNICAMP), Campinas 13083-862, SP, Brazil
| | | | - Andrea Komesu
- Department of Marine Sciences (DCMar), Federal University of São Paulo (UNIFESP), Santos 11070-100, SP, Brazil
| | - Nelson Rosa Ferreira
- Faculty of Food Engineering, Technology Institute, Federal University of Pará (UFPA), Belém 66077-000, PA, Brazil;
| | | |
Collapse
|
9
|
Gu X, Xu L, Yuan H, Li C, Zhao J, Li S, Yu D. Sophorolipid-toluidine blue conjugates for improved antibacterial photodynamic therapy through high accumulation. RSC Adv 2023; 13:11782-11793. [PMID: 37077994 PMCID: PMC10106977 DOI: 10.1039/d3ra01618h] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/12/2023] [Accepted: 04/10/2023] [Indexed: 04/21/2023] Open
Abstract
Anti-bacterial photodynamic therapy is the most promising treatment protocol for bacterial infection, but low accumulation of photosensitizers has seriously hindered their development in clinical application. Here, with inherent outstanding affinity to bacterial cell envelope, sophorolipid produced from Candida bombicola has been conjugated to toluidine blue (SL-TB) through amidation reaction. The structure of SL-TB conjugates was identified by 1H-NMR, FT-IR and ESI-HRMS. The interfacial assembly and photophysical properties of SL-TB conjugates have been disclosed through surface tension, micro-polarity, electronic and fluorescence spectra. After light irradiation, the log10 (reduced CFU) of free toluidine blue to P. aeruginosa and S. aureus were 4.5 and 7.9, respectively. In contrast, SL-TB conjugates showed a higher bactericidal activity, with a reduction of 6.3 and 9.7 log10 units of CFU against P. aeruginosa and S. aureus, respectively. The fluorescence quantitative results showed that SL-TB could accumulate 2850 nmol/1011 cells and 4360 nmol/1011 cells by P. aeruginosa and S. aureus, which was much higher than the accumulation of 462 nmol/1011 cells and 827 nmol/1011 cells of free toluidine blue. Through the cooperation of triple factors, including sophorose affinity to bacterial cells, hydrophobic association with plasma membrane, and electrostatic attraction, higher SL-TB accumulation was acquired, which has enhanced antibacterial photodynamic efficiencies.
Collapse
Affiliation(s)
- Xiaoxiao Gu
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University Nanjing 211816 PR China +86-25-58139386
| | - Lixian Xu
- Department of Dermatology, The Second Affiliated Hospital of Nanjing Medical University No.121 Jiangjiayuan Road Nanjing 210000 P. R. China
| | - Haoyang Yuan
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University Nanjing 211816 PR China +86-25-58139386
| | - Cailing Li
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University Nanjing 211816 PR China +86-25-58139386
| | - Juan Zhao
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University Nanjing 211816 PR China +86-25-58139386
| | - Shuang Li
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University Nanjing 211816 PR China +86-25-58139386
| | - Dinghua Yu
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University Nanjing 211816 PR China +86-25-58139386
| |
Collapse
|
10
|
Pal S, Chatterjee N, Das AK, McClements DJ, Dhar P. Sophorolipids: A comprehensive review on properties and applications. Adv Colloid Interface Sci 2023; 313:102856. [PMID: 36827914 DOI: 10.1016/j.cis.2023.102856] [Citation(s) in RCA: 6] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/14/2022] [Revised: 01/27/2023] [Accepted: 02/04/2023] [Indexed: 02/11/2023]
Abstract
Sophorolipids are surface-active glycolipids produced by several non-pathogenic yeast species and are widely used as biosurfactants in several industrial applications. Sophorolipids provide a plethora of benefits over chemically synthesized surfactants for certain applications like bioremediation, oil recovery, and pharmaceuticals. They are, for instance less toxic, more benign and environment friendly in nature, biodegradable, freely adsorb to different surfaces, self-assembly in hydrated solutions, robustness for industrial applications etc. These miraculous properties result in valuable physicochemical attributes such as low critical micelle concentrations (CMCs), reduced interfacial surface tension, and capacity to dissolve non-polar components. Moreover, they exhibit a diverse range of physicochemical, functional, and biological attributes due to their unique molecular composition and structure. In this article, we highlight the physico-chemical properties of sophorolipids, how these properties are exploited by the human community for extensive benefits and the conditions which lead to their unique tailor-made structures and how they entail their interfacial behavior. Besides, we discuss the advantages and disadvantages associated with the use of these sophorolipids. We also review their physiological and functional attributes, along with their potential commercial applications, in real-world scenario. Biosurfactants are compared to their man-made equivalents to show the variations in structure-property correlations and possible benefits. Those attempting to manufacture purported natural or green surfactant with innovative and valuable qualities can benefit from an understanding of biosurfactant features structured along the same principles. The uniqueness of this review article is the detailed physico-chemical study of the sophorolipid biosurfactant and how these properties helps in their usage and detailed explicit study of their applications in the current scenario and also covering their pros and cons.
Collapse
Affiliation(s)
- Srija Pal
- Laboratory of Food Science and Technology, Food and Nutrition Division, University of Calcutta, 20B Judges Court Road, Kolkata 700027, West Bengal, India
| | - Niloy Chatterjee
- Laboratory of Food Science and Technology, Food and Nutrition Division, University of Calcutta, 20B Judges Court Road, Kolkata 700027, West Bengal, India; Centre for Research in Nanoscience & Nanotechnology, University of Calcutta, JD 2, Sector III, Salt Lake City, Kolkata 700 098, West Bengal, India
| | - Arun K Das
- Eastern Regional Station, ICAR-IVRI, 37 Belgachia Road, Kolkata 700037, West Bengal, India
| | - David Julian McClements
- Department of Food Science, University of Massachusetts Amherst, Amherst, MA 01003, USA; Department of Food Science & Bioengineering, Zhejiang Gongshang University, 18 Xuezheng Street, Hangzhou, Zhejiang 310018, China
| | - Pubali Dhar
- Laboratory of Food Science and Technology, Food and Nutrition Division, University of Calcutta, 20B Judges Court Road, Kolkata 700027, West Bengal, India; Centre for Research in Nanoscience & Nanotechnology, University of Calcutta, JD 2, Sector III, Salt Lake City, Kolkata 700 098, West Bengal, India.
| |
Collapse
|
11
|
Draft Genome Sequence of the Sophorolipid-Producing Yeast Pseudohyphozyma bogoriensis ATCC 18809. Microbiol Resour Announc 2023; 12:e0056622. [PMID: 36448832 PMCID: PMC9872583 DOI: 10.1128/mra.00566-22] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/02/2022] Open
Abstract
Pseudohyphozyma bogoriensis is gaining attention as a microbial source of high-value sophorolipids. We report here on its genomic sequence, which will improve our understanding of its metabolic pathways and allow the development of genome manipulation systems. PacBio sequencing was performed, yielding a 26-Mbp genome with 57% GC content and encoding 7,847 predicted proteins.
Collapse
|
12
|
Nooman MU, Al-Kashef AS, Rashad MM, Khattab AENA, Ahmed KA, Abbas SS. Sophorolipids produced by Yarrowia lipolytica grown on Moringa oleifera oil cake protect against acetic acid-induced colitis in rats: impact on TLR-4/p-JNK/NFκB-p65 pathway. J Pharm Pharmacol 2023; 75:544-558. [PMID: 36680771 DOI: 10.1093/jpp/rgac101] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/12/2022] [Accepted: 12/14/2022] [Indexed: 01/22/2023]
Abstract
OBJECTIVES Toll-like receptor-4 (TLR-4) activation plays a major role in triggering oxidative stress (OS) and inflammation implicated in the pathogenesis of ulcerative colitis (UC). Due to sophorolipids (SLs) antioxidant and anti-inflammatory properties, they are interestingly becoming more valued for their potential effectiveness in treating a variety of diseases. This study was designed to explore the effect of SLs produced by microbial conversion of Moringa oleifera oil cake using isolated yeast Yarrowia lipolytica against UC induced by acetic acid (AA) in rats. METHODS The produced SLs were identified by FTIR, 1H NMR and LC-MS/MS spectra, and administered orally for 7 days (200 mg/kg/day) before AA (2 ml, 4% v/v) to induce UC intrarectally on day eight. Biochemically, the levels of TLR-4, c-Jun N-terminal kinase (JNK), nuclear factor kappa B-p65 (NFκB-p65), interleukin-1beta (IL-1β), malondialdehyd, glutathione, Bax/Bcl2 ratio and the immunohistochemical evaluation of inducible nitric oxide synthase and caspase-3 were assayed. KEY FINDINGS SLs significantly reduced OS, inflammatory and apoptotic markers in AA-treated rats, almost like the reference sulfasalazine. CONCLUSIONS This study provided a novel impact for SLs produced by microbial conversion of M. oleifera oil cake against AA-induced UC in rats through hampering the TLR-4/p-JNK/NFκB-p65 signalling pathway.
Collapse
Affiliation(s)
- Mohamed U Nooman
- Biochemistry Department, Biotechnology Research Institute, National Research Centre, Cairo, Egypt
| | - Amr S Al-Kashef
- Biochemistry Department, Biotechnology Research Institute, National Research Centre, Cairo, Egypt
| | - Mona M Rashad
- Biochemistry Department, Biotechnology Research Institute, National Research Centre, Cairo, Egypt
| | - Abd El-Nasser A Khattab
- Genetics and Cytology Department, Biotechnology Research Institute, National Research Centre, Cairo, Egypt
| | - Kawkab A Ahmed
- Pathology Department, Faculty of Veterinary Medicine, Cairo University, Cairo, Egypt
| | - Samah S Abbas
- Pharmacology and Toxicology Department, Faculty of Pharmacy, Misr International University, Cairo, Egypt
| |
Collapse
|
13
|
Sarangi MK, Padhi S, Patel LD, Rath G, Nanda SS, Yi DK. Theranostic efficiency of biosurfactants against COVID-19 and similar viruses - A review. J Drug Deliv Sci Technol 2022; 76:103764. [PMID: 36090183 PMCID: PMC9444339 DOI: 10.1016/j.jddst.2022.103764] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/18/2022] [Revised: 07/28/2022] [Accepted: 08/29/2022] [Indexed: 12/02/2022]
Abstract
The world has witnessed an extreme vulnerability of a pandemic during 2020; originated from China. The coronavirus disease 2019 (COVID-19) is infecting and beginning deaths in thousands to millions, creating of the global economic crisis. Biosurfactants (BSs) can carry the prevention, control and management of pandemic out through diverse approaches, such as pharmaceutical, therapeutic, hygienic and environmental. The microbiotas having virulent intrinsic properties towards starting as easily as spreading of diseases (huge morbidity and mortality) could be inhibited via BSs. Such elements could be recognised for their antimicrobial activity, capability to interact with the immune system via micelles formation and in nanoparticulate synthesis. However, they can be used for developing novel and more effective therapeutics, pharmaceuticals, non-toxic formulations, vaccines, and effective cleaning agents. Such approaches can be utilized for product development and implemented for managing and combating the pandemic conditions. This review emphasized on the potentiality of BSs as key components with several ways for protecting against unknown and known pathogens, including COVID-19.
Collapse
Affiliation(s)
- Manoj Kumar Sarangi
- Department of Pharmaceutics, School of Pharmaceutical Sciences, Sardar Bhagwan Singh University, Balawala, Dehradun, Uttarakhand, Pin-248001, India
| | - Sasmita Padhi
- Department of Pharmaceutics, School of Pharmaceutical Sciences, Sardar Bhagwan Singh University, Balawala, Dehradun, Uttarakhand, Pin-248001, India
| | - L D Patel
- Department of Pharmaceutics, Parul Institute of Pharmacy, Parul University, Vadodara, Gujarat, Pin-391760, India
| | - Goutam Rath
- Department of Pharmaceutics, School of Pharmaceutical Sciences, Siksha 'O' Anusandhan University, Bhubaneswar, 751030, Odisha, India
| | | | - Dong Kee Yi
- Department of Chemistry, Myongji University, Yongin, 03674, South Korea
| |
Collapse
|
14
|
Raza ZA, Shahzad Q, Rehman A, Taqi M, Ayub A. Biosurfactants in the sustainable eradication of SARS COV-2 from the environmental surfaces. 3 Biotech 2022; 12:273. [PMID: 36101547 PMCID: PMC9464425 DOI: 10.1007/s13205-022-03320-1] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/02/2021] [Accepted: 08/19/2022] [Indexed: 11/03/2022] Open
Abstract
The COVID-19 outbreak has brought the world, at least, to one consensus that cleanliness is unavoidable under all circumstances. Hands are the main body part to interact with the environment and thus are prone to receive, initiate and propagate the chain of infection. Hand hygiene has, therefore, been most emphasized by experts to interrupt the spread of infection. Various harsh chemicals like synthetic surfactants and alcoholic preparations have been in practice to eradicate and disinfect the germs. This choice may be unsafe and cause a subsequent chain of adversities. Thereby, biosurfactants have been proposed as sustainable, non-toxic and safe surface cleaners cum disinfectants under a wide range of physiological and environmental conditions. The amphiphilic micellar behavior of biosurfactants makes them promising candidates as hygienic surface cleaners and therapeutic carriers. We overview the possibilities of using biosurfactants in different ways against microbial pathogens, in general, and the SARS COV-2, in specific.
Collapse
|
15
|
Kumar S, Acharya C, Abhinav N, Jaisankar P. Novel Spirooxindole Derivatives as Potential Non‐Detergent Type Spermicides. ChemistrySelect 2022. [DOI: 10.1002/slct.202202210] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
Affiliation(s)
- Shrabanti Kumar
- Laboratory of Catalysis and Chemical Biology Department of Organic and Medicinal Chemistry CSIR-Indian Institute of Chemical Biology 4, Raja S. C. Mullick Road, Jadavpur Kolkata 700032 India
| | - Chiranjit Acharya
- Laboratory of Catalysis and Chemical Biology Department of Organic and Medicinal Chemistry CSIR-Indian Institute of Chemical Biology 4, Raja S. C. Mullick Road, Jadavpur Kolkata 700032 India
| | - Nipun Abhinav
- Laboratory of Catalysis and Chemical Biology Department of Organic and Medicinal Chemistry CSIR-Indian Institute of Chemical Biology 4, Raja S. C. Mullick Road, Jadavpur Kolkata 700032 India
- Department of Natural Products National Institute of Pharmaceutical Education and Research Kolkata 700054 India
| | - Parasuraman Jaisankar
- Laboratory of Catalysis and Chemical Biology Department of Organic and Medicinal Chemistry CSIR-Indian Institute of Chemical Biology 4, Raja S. C. Mullick Road, Jadavpur Kolkata 700032 India
| |
Collapse
|
16
|
Sophorolipids—Bio-Based Antimicrobial Formulating Agents for Applications in Food and Health. Molecules 2022; 27:molecules27175556. [PMID: 36080322 PMCID: PMC9457973 DOI: 10.3390/molecules27175556] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/25/2022] [Revised: 08/25/2022] [Accepted: 08/25/2022] [Indexed: 11/22/2022] Open
Abstract
Sophorolipids are well-known glycolipid biosurfactants, produced mainly by non-pathogenic yeast species such as Candida bombicola with high yield. Its unique environmental compatibility and high biodegradable properties have made them a focus in the present review for their promising applications in diverse areas. This study aims to examine current research trends of sophorolipids and evaluate their applications in food and health. A literature search was conducted using different research databases including PubMed, ScienceDirect, EBSCOhost, and Wiley Online Library to identify studies on the fundamental mechanisms of sophorolipids and their applications in food and health. Studies have shown that various structural forms of sophorolipids exhibit different biological and physicochemical properties. Sophorolipids represent one of the most attractive biosurfactants in the industry due to their antimicrobial action against both Gram-positive and Gram-negative microorganisms for applications in food and health sectors. In this review, we have provided an overview on the fundamental properties of sophorolipids and detailed analysis of their applications in diverse areas such as food, agriculture, pharmaceutical, cosmetic, anticancer, and antimicrobial activities.
Collapse
|
17
|
Surface-Active Compounds Produced by Microorganisms: Promising Molecules for the Development of Antimicrobial, Anti-Inflammatory, and Healing Agents. Antibiotics (Basel) 2022; 11:antibiotics11081106. [PMID: 36009975 PMCID: PMC9404966 DOI: 10.3390/antibiotics11081106] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/03/2022] [Revised: 07/29/2022] [Accepted: 08/02/2022] [Indexed: 11/25/2022] Open
Abstract
Surface-active compounds (SACs), biomolecules produced by bacteria, yeasts, and filamentous fungi, have interesting properties, such as the ability to interact with surfaces as well as hydrophobic or hydrophilic interfaces. Because of their advantages over other compounds, such as biodegradability, low toxicity, antimicrobial, and healing properties, SACs are attractive targets for research in various applications in medicine. As a result, a growing number of properties related to SAC production have been the subject of scientific research during the past decade, searching for potential future applications in biomedical, pharmaceutical, and therapeutic fields. This review aims to provide a comprehensive understanding of the potential of biosurfactants and emulsifiers as antimicrobials, modulators of virulence factors, anticancer agents, and wound healing agents in the field of biotechnology and biomedicine, to meet the increasing demand for safer medical and pharmacological therapies.
Collapse
|
18
|
Callaghan B, Twigg MS, Baccile N, Van Bogaert INA, Marchant R, Mitchell CA, Banat IM. Microbial sophorolipids inhibit colorectal tumour cell growth in vitro and restore haematocrit in Apc min+/- mice. Appl Microbiol Biotechnol 2022; 106:6003-6016. [PMID: 35965289 PMCID: PMC9467956 DOI: 10.1007/s00253-022-12115-6] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/30/2022] [Revised: 07/27/2022] [Accepted: 07/28/2022] [Indexed: 11/28/2022]
Abstract
Abstract
Sophorolipids are glycolipid biosurfactants consisting of a carbohydrate sophorose head with a fatty acid tail and exist in either an acidic or lactonic form. Sophorolipids are gaining interest as potential cancer chemotherapeutics due to their inhibitory effects on a range of tumour cell lines. Currently, most anti-cancer studies reporting the effects of sophorolipids have focused on lactonic preparations with the effects of acidic sophorolipids yet to be elucidated. We produced a 94% pure acidic sophorolipid preparation which proved to be non-toxic to normal human colonic and lung cells. In contrast, we observed a dose-dependent reduction in viability of colorectal cancer lines treated with the same preparation. Acidic sophorolipids induced apoptosis and necrosis, reduced migration, and inhibited colony formation in all cancer cell lines tested. Furthermore, oral administration of 50 mg kg−1 acidic sophorolipids over 70 days to Apcmin+/− mice was well tolerated and resulted in an increased haematocrit, as well as reducing splenic size and red pulp area. Oral feeding did not affect tumour numbers or sizes in this model. This is the first study to show that acidic sophorolipids dose-dependently and specifically reduces colon cancer cell viability in addition to reducing tumour-associated bleeding in the Apcmin+/− mouse model. Key points • Acidic sophorolipids are produced by yeast species such as Starmerella bombicola. • Acidic sophorolipids selectively killed colorectal cells with no effect on healthy gut epithelia. • Acidic sophorolipids reduced tumour-associated gut bleed in a colorectal mouse model. Graphical abstract ![]()
Supplementary Information The online version contains supplementary material available at 10.1007/s00253-022-12115-6.
Collapse
Affiliation(s)
- Breedge Callaghan
- School of Biomedical Sciences, Ulster University, Coleraine, BT52 1SA, UK
| | - Matthew S Twigg
- School of Biomedical Sciences, Ulster University, Coleraine, BT52 1SA, UK
| | - Niki Baccile
- Sorbonne Universités, UPMC Univ Paris 06, CNRS, Collège de France UMR 7574, Chimie de La Matière Condensée de Paris, UMR 7574, 75005, Paris, France
| | - Inge N A Van Bogaert
- Centre for Synthetic Biology, Department of Biotechnology, Ghent University, Coupure Links 653, 9000, Ghent, Belgium
| | - Roger Marchant
- School of Biomedical Sciences, Ulster University, Coleraine, BT52 1SA, UK
| | | | - Ibrahim M Banat
- School of Biomedical Sciences, Ulster University, Coleraine, BT52 1SA, UK.
| |
Collapse
|
19
|
Current advances in the classification, production, properties and applications of microbial biosurfactants – A critical review. Adv Colloid Interface Sci 2022; 306:102718. [DOI: 10.1016/j.cis.2022.102718] [Citation(s) in RCA: 9] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/17/2022] [Revised: 06/07/2022] [Accepted: 06/07/2022] [Indexed: 11/21/2022]
|
20
|
Chen Y, Hao S, Xuan HZ, Li M, Kong J, Zhang Q, Liu J. Interactional, Functional and Biological Properties of Lactone Sophorolipid (LSL) and Collagen Oligopeptides (COP) in Aqueous Solution. LUMINESCENCE 2022; 37:1666-1675. [PMID: 35834479 DOI: 10.1002/bio.4338] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/24/2022] [Revised: 06/14/2022] [Accepted: 07/10/2022] [Indexed: 11/07/2022]
Abstract
For the mixed aqueous solution of LSL and COP, the interaction mode and mechanism have been comprehensively studied using multispectral methods including fluorescence spectrum, ultraviolet-visible adsorption spectrum (UV-Vis), and circular dichroism spectrum (CD). Then its surface activity, particle size, foaming, emulsifying, viscosity, and antibacterial properties are evaluated in detail by surface tension measurement (ST), dynamic light scattering (DLS), oscillametric method, spectrophotometer, ubbelohde viscometer and zone of inhibition separately. Compared with the single LSL or COP aqueous solution, the mixed system shows different performance optimizations in different aspects. The surface activity and foaming properties are mainly attributed to LSL, and the viscosity is attributed to COP. Fluorescence spectroscopy results show that the fluorescence distribution of COP has significant changes by the LSL addition and a static quenching mechanism is proved. The results of UV-Vis and CD spectra also show the changing conformation of COP by the LSL addition. The data of thermodynamic parameters prove that the combination of LSL and COP is a spontaneous exothermic process and is an enthalpy-driven process. The interaction mechanism between LSL and COP is very helpful for the application and development of the mixed mild biosurfactant-protein system used in the cosmetic and food industries.
Collapse
Affiliation(s)
| | - Shengyu Hao
- School of Physical Science and Information Technology
| | - Hong Zhuan Xuan
- School of Life Science, Liaocheng University, Liaocheng, Shandong, P. R. China
| | - Mingyuan Li
- School of Chemistry and Chemical Engineering
| | - Jing Kong
- School of Chemistry and Chemical Engineering
| | - Qian Zhang
- School of Chemistry and Chemical Engineering
| | - Jie Liu
- School of Chemistry and Chemical Engineering
| |
Collapse
|
21
|
Miceli RT, Corr DT, Barroso M, Dogra N, Gross RA. Sophorolipids: Anti-cancer activities and mechanisms. Bioorg Med Chem 2022; 65:116787. [PMID: 35526504 DOI: 10.1016/j.bmc.2022.116787] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/06/2022] [Revised: 04/19/2022] [Accepted: 04/28/2022] [Indexed: 11/18/2022]
Abstract
Sophorolipids (SLs) are biosurfactants synthesized as secondary metabolites by non-pathogenic yeasts and other microorganisms. They are members of glycolipid microbial surfactant family that consists of a sophorose polar head group and, most often, an ω-1 hydroxylated fatty acid glycosidically linked to the sophorose moiety. Since the fermentative production of SLs is high (>200 g/L), SLs have the potential to provide low-cost therapeutics. Natural and modified SLs possess anti-cancer activity against a wide range of cancer cell lines such as those derived from breast, cervical, colon, liver, brain, and the pancreas. Corresponding data on their cytotoxicity against noncancerous cell lines including human embryo kidney, umbilical vein, and mouse fibroblasts is also discussed. These results are compiled to elucidate trends in SL-structures that lead to higher efficacy against cancer cell lines and lower cytotoxicity for normal cell lines. While extrapolation of these results provides some insights into the design of SLs with optimal therapeutic indices, we also provide a critical assessment of gaps and inconsistencies in the literature as well as the lack of data connecting structure-to-anticancer and cytotoxicity on normal cells. Furthermore, SL-mechanism of action against cancer cell lines, that includes proliferation inhibition, induction of apoptosis, membrane disruption and mitochondria mediated pathways are discussed. Perspectives on future research to develop SL anticancer therapeutics is discussed.
Collapse
Affiliation(s)
- Rebecca T Miceli
- Center for Biotechnology and Interdisciplinary Sciences and Rensselaer Polytechnic Institute, 110 Eighth Street, Troy, NY 12180, United States; Department of Chemistry and Chemical Biology and Rensselaer Polytechnic Institute, 110 Eighth Street, Troy, NY 12180, United States; Department of Biomedical Engineering, Rensselaer Polytechnic Institute, 110 Eighth Street, Troy, NY 12180, United States
| | - David T Corr
- Department of Biomedical Engineering, Rensselaer Polytechnic Institute, 110 Eighth Street, Troy, NY 12180, United States
| | - Margardia Barroso
- Department of Molecular and Cellular Physiology, Albany Medical College, Albany, NY 12208, United States
| | - Navneet Dogra
- Department of Genetics and Genomics Sciences, Icahn School of Medicine at Mount Sinai, New York, NY 10029, United States
| | - Richard A Gross
- Center for Biotechnology and Interdisciplinary Sciences and Rensselaer Polytechnic Institute, 110 Eighth Street, Troy, NY 12180, United States; Department of Chemistry and Chemical Biology and Rensselaer Polytechnic Institute, 110 Eighth Street, Troy, NY 12180, United States.
| |
Collapse
|
22
|
A comprehensive review on natural occurrence, synthesis and biological activities of glycolipids. Carbohydr Res 2022; 516:108556. [DOI: 10.1016/j.carres.2022.108556] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/27/2021] [Revised: 03/30/2022] [Accepted: 04/05/2022] [Indexed: 01/10/2023]
|
23
|
Comprehensive Review on Applications of Surfactants in Vaccine Formulation, Therapeutic and Cosmetic Pharmacy and Prevention of Pulmonary Failure due to COVID-19. CHEMISTRY AFRICA 2022. [PMCID: PMC8934726 DOI: 10.1007/s42250-022-00345-0] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
Abstract
Our world is under serious threat of environmental degradation, climate change and in association with this the out breaks of diseases as pandemics. The devastating impact of the very recent COVID-19, The sharp increase in cases of Cancer, Pulmonary failure, Heart health has triggered questions for the sustainable development of pharmaceutical and medical sciences. In the search of inclusive and effective strategies to meet today’s demand, improvised methodologies and alternative green chemical, bio-based precursors are being introduced by scientists around the globe. In this extensive review we have presented the potentiality and Realtime applications of both synthetic and bio-based surfactants in bio-medical and pharmaceutical fields. For their excellent unique amphoteric nature and ability to solubilise in both organic and inorganic drugs, surfactants are one of the most potential candidates for bio-medicinal fields such as dermatology, drug delivery, anticancer treatment, surfactant therapy, vaccine formulation, personal hygiene care and many more. The self-assembly property of surfactants is a very powerful function for drug delivery systems that increases the bio-availability of the poorly aqueous soluble pharmaceutical products by influencing their solubility. Over the decades many researchers have reported the antimicrobial, anti-adhesive, antibiofilm, anti-inflammatory, antioxidant activities of surfactants regarding its utility in medicinal purposes. In some reports surfactants are found to have spermicidal and laxative activity too. This comprehensive report is targeted to enlighten the versatile applications of Surfactants in drug delivery, vaccine formulation, Cancer Treatment, Therapeutic and cosmetic Pharmaceutical Sciences and prevention of pulmonary failure due to COVID-19.
Collapse
|
24
|
Agarwal HK, Chhikara BS, Ye G, Bhavaraju S, Dixit A, Kumar A, Doncel GF, Parang K. Synthesis and Biological Evaluation of 5'- O-Fatty Acyl Ester Derivatives of 3'-Fluoro-2',3'-dideoxythymidine as Potential Anti-HIV Microbicides. Molecules 2022; 27:3352. [PMID: 35630829 PMCID: PMC9143043 DOI: 10.3390/molecules27103352] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/22/2022] [Revised: 05/20/2022] [Accepted: 05/21/2022] [Indexed: 11/23/2022] Open
Abstract
A number of 5′-O-fatty acyl derivatives of 3′-fluoro-2′,3′-dideoxythymidine (FLT, 1) were synthesized. These conjugates were evaluated for their potential as topical microbicides with anti-HIV activity against cell-free (X4 and R5), cell-associated, and multidrug-resistant viruses. Compared to FLT and 3′-azido-2′,3′-dideoxythymidine (AZT), 5′-O-(12-azidododecanoyl) (5), 5′-O-myristoyl (6), and 5′-O-(12-thioethyldodecanoyl) (8) derivatives of FLT were found to be more active against both cell-free viruses (lymphocytotropic and monocytotropic strains) with EC50 values of 0.4 μM, 1.1 μM, and <0.2 μM, respectively, as well as cell-associated virus with EC50 values of 12.6, 6.4, and 2.3 μM, respectively. Conjugates 5, 6, and 8 exhibited >4 and >30 times better antiviral index than FLT and AZT, respectively. Conjugates 5 and 8 were significantly more potent than FLT against many multidrug-resistant strains. A comparison of the anti-HIV activity with the corresponding non-hydrolyzable ether conjugates suggested that ester hydrolysis to FLT and fatty acids is critical to enable anti-HIV activity. Cellular uptake studies were conducted using fluorescent derivatives of FLT attached with 5(6)-carboxyfluorescein through either β-alanine (23) or 12-aminododecanoic acid (24) spacers. The lipophilic fluorescent analog with a long chain (24) showed more than 12 times higher cellular uptake profile than the fluorescent analog with a short chain (23). These studies further confirmed that the attachment of fatty acids improved the cellular uptake of nucleoside conjugates. In addition, 5, 6, and 8 were the least cytotoxic and did not alter vaginal cell and sperm viability compared to the positive control, a commercial topical spermicide (N-9), which significantly decreased sperm and vaginal cell viability inducing the generation of proinflammatory cytokines.
Collapse
Affiliation(s)
- Hitesh K. Agarwal
- Department of Pharmaceutical Sciences, School of Pharmacy, South University, 709 Mall Boulevard, Savannah, GA 31406, USA
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
| | - Bhupender S. Chhikara
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
| | - Guofeng Ye
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
| | - Sitaram Bhavaraju
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
| | - Ajay Dixit
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
- ITC Life Science & Technology Center, #3, 1st Main, Peenya Industrial Area, 1st Phase, Bangalore 560058, India
| | - Anil Kumar
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
| | - Gustavo F. Doncel
- CONRAD, Department of Obstetrics and Gynecology, Eastern Virginia Medical School, Norfolk, VA 23507, USA
| | - Keykavous Parang
- Department of Biomedical and Pharmaceutical Sciences, School of Pharmacy, University of Rhode Island, Kingston, RI 02881, USA; (B.S.C.); (G.Y.); (S.B.); (A.D.); (A.K.)
- Center for Targeted Drug Delivery, Department of Biomedical and Pharmaceutical Sciences, Chapman University School of Pharmacy, Harry and Diane Rinker Health Science Campus, Irvine, CA 92618, USA
| |
Collapse
|
25
|
Park I, Oh S, Goo D, Celi P, Lillehoj HS. Effect of dietary sophorolipids on growth performance and gastrointestinal functionality of broiler chickens infected with Eimeria maxima. Poult Sci 2022; 101:101944. [PMID: 35679665 PMCID: PMC9189210 DOI: 10.1016/j.psj.2022.101944] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/24/2022] [Revised: 04/15/2022] [Accepted: 04/25/2022] [Indexed: 11/08/2022] Open
Abstract
Two experiments were conducted to evaluate the effects of dietary sophorolipids (SLs) supplementation as antibiotic alternatives on growth performance and gut health of chickens infected with Eimeria maxima. In experiment 1, 336 (zero-day-old) male broilers were used. The chickens were weighed and randomly allocated to the following 6 treatments groups with 7 chickens/cage and 8 cages/treatment: control group that received a basal diet (NC), positive control group that received a basal diet and was challenged with E. maxima (PC), PC+C18:1 lactonic diacetyled SL (SL1), PC+C18:1 deacetyled SL (SL2), PC+C18:1 monoacetyled SL (SL3), and PC+C18:1 diacetyled SL (SL4). Each SL (200 mg/kg feed) was added to the corresponding treatment group. In experiment 2, 588 (zero-day-old) male broilers were used. The chickens were randomly allocated to the following experimental groups with 10 or 11 chickens/cage and 8 cages/treatment: NC, PC, PC+ monensin at 90 mg/kg feed (MO), PC+SL1 at 200 mg/kg feed (SL1 200), PC+SL1 at 500 mg/kg feed (SL1 500), PC+SL4 at 200 mg/kg feed (SL4 200), and PC+SL4 at 500 mg/kg of feed (SL4 500). The chickens and feed were weighed at 0, 7, 14, 20, and 22 d to determine growth performance. In both experiments, all chickens except the NC group were orally infected with E. maxima (10,000 oocysts/chicken) at d 14. One chicken per cage was euthanized at d 20 to sample jejunal tissue to measure lesion scores, cytokines, and tight junction (TJ) proteins. Excreta samples were collected daily between d 20 and 22 to measure oocyst numbers. Data were analyzed using Mixed Model (PROC MIXED) in SAS. In experiment 1, SLs did not affect the growth of broiler chickens, but SL4 decreased (P < 0.05) the lesion score and oocyst number compared to PC chickens. In terms of cytokines and TJ protein gene expression, SLs increased (P < 0.05) IL-1β, IL-6, IL-17F, IL-4, IL-13, occludin, and ZO1 levels compared to PC chickens. In experiment 2, monensin increased (P < 0.05) body weight, and decreased (P < 0.05) the lesion score and oocyst number compared to the PC group. SL4 500 increased (P < 0.05) average daily gain and feed conversion ratio but decreased (P < 0.05) lesion score and fecal oocyst number. SL4 decreased (P < 0.05) IL-6, IL-17F, TNFSF-15, IL-2, and IL-10 levels but increased (P < 0.05) occludin and ZO-1 levels. Overall, dietary SL supplementation, especially SL4, improved growth and gastrointestinal functionality of young broiler chickens, demonstrating significant potential as an antibiotic alternative.
Collapse
|
26
|
Ma E, Chen K, Sun L, Fu Z, Guo J, Liu J, Zhao J, Liu Z, Lei Z, Li L, Hu X, Guo X. Rapid Construction of Green Nanopesticide Delivery Systems Using Sophorolipids as Surfactants by Flash Nanoprecipitation. JOURNAL OF AGRICULTURAL AND FOOD CHEMISTRY 2022; 70:4912-4920. [PMID: 35417168 DOI: 10.1021/acs.jafc.2c00743] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/26/2023]
Abstract
Green delivery carriers of nanopesticides, like sophorolipid biosurfactants, are of great significance to reduce environmental pollution and promote sustainable agricultural development. However, the molecular diversity of an unisolated sophorolipid mixture with almost unpredictable self-assembly properties has limited the in-depth study of its structure-activity relationship and hindered the development of green pesticide delivery systems. In this work, the acidic and lactonic sophorolipids were successfully separated from the sophorolipid mixture through silica gel column chromatography. A series of cost-effective green nanopesticides loaded with lambda-cyhalothrin (LC) were rapidly fabricated based on a combination of the acidic and lactonic sophorolipids as surfactants by flash nanoprecipitation. The effects of the acidic-to-lactonic ratio on particle size, drug loading capacity, and biological activity against Hyphantria cunea of LC-loaded nanoparticles were systematically investigated. The resultant nanopesticides exhibited a better insecticidal efficacy than a commercial emulsifiable concentrate formulation. This work opens up a novel strategy to construct scalable, cost-effective, and environmentally friendly nanopesticide systems.
Collapse
Affiliation(s)
- Enguang Ma
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
| | - Kai Chen
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
| | - Liang Sun
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
| | - Zhinan Fu
- School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, P. R. China
| | - Jiangtao Guo
- School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, P. R. China
| | - Jichang Liu
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
- School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, P. R. China
| | - Jigang Zhao
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
- School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, P. R. China
| | - Zhiyong Liu
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
| | - Zhigang Lei
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
| | - Li Li
- School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, P. R. China
| | - Xiao Hu
- School of Materials Science and Engineering, Nanyang Technological University, 639798 Singapore
| | - Xuhong Guo
- School of Chemistry and Chemical Engineering, Shihezi University, Shihezi 832003, P. R. China
- School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, P. R. China
| |
Collapse
|
27
|
Shi Y, Zhang L, Zhang M, Chu J, Xia Y, Yang H, Liu L, Chen X. A CRISPR-Cas9 System-Mediated Genetic Disruption and Multi-fragment Assembly in Starmerella bombicola. ACS Synth Biol 2022; 11:1497-1509. [PMID: 35294186 DOI: 10.1021/acssynbio.1c00582] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Abstract
Gene editing technology plays an extremely significant role in synthetic biology and metabolic engineering. Traditional genetic manipulation methods, such as homologous recombination, however, are inefficient, time-consuming, and barely feasible when disrupting multiple genes simultaneously. Starmerella bombicola, a nonconventional yeast that overproduces sophorolipids, lacks convenient genetic tools for engineering strains. Here, we developed an efficient CRISPR-Cas9 genome editing technology by combining molecular element mining and expression system optimization for S. bombicola. This CRISPR-Cas9 system improved the efficiency of gene-integration/target gene-introducing disruption by homology-directed repair and realized the multi-gene simultaneous disruptions. Based on this CRISPR-Cas9 system, we also further constructed an engineered strain via the in vivo assembly of multiple DNA fragments (10 kb) that can produce acid-type sophorolipids. These results showed that the CRISPR-Cas9 system may be an efficient and convenient strategy to perform genetic manipulation in S. bombicola.
Collapse
Affiliation(s)
- Yibo Shi
- Key Laboratory of Industrial Biotechnology, Ministry of Education, Jiangnan University, Wuxi 214122, China
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Lihua Zhang
- Key Laboratory of Industrial Biotechnology, Ministry of Education, Jiangnan University, Wuxi 214122, China
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Min Zhang
- Key Laboratory of Industrial Biotechnology, Ministry of Education, Jiangnan University, Wuxi 214122, China
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Jieyu Chu
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Yuanyuan Xia
- Key Laboratory of Industrial Biotechnology, Ministry of Education, Jiangnan University, Wuxi 214122, China
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Haiquan Yang
- Key Laboratory of Industrial Biotechnology, Ministry of Education, Jiangnan University, Wuxi 214122, China
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| | - Liming Liu
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
- State Key Laboratory of Food Science and Technology, Jiangnan University, Wuxi 214122, China
| | - Xianzhong Chen
- Key Laboratory of Industrial Biotechnology, Ministry of Education, Jiangnan University, Wuxi 214122, China
- School of Biotechnology, Jiangnan University, Wuxi 214122, China
| |
Collapse
|
28
|
Park I, Oh S, Nam H, Celi P, Lillehoj HS. Antimicrobial activity of sophorolipids against Eimeria maxima and Clostridium perfringens, and their effect on growth performance and gut health in necrotic enteritis. Poult Sci 2022; 101:101731. [PMID: 35176703 PMCID: PMC8851262 DOI: 10.1016/j.psj.2022.101731] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/03/2021] [Revised: 01/10/2022] [Accepted: 01/10/2022] [Indexed: 11/26/2022] Open
Abstract
The in vitro antimicrobial activity of sophorolipids (SLs) against Eimeria maxima and Clostridium perfringens, and the in vivo effects of SLs on growth performance and gut health in necrotic enteritis (NE)-afflicted broiler chickens were studied. To test the direct killing effects of SLs on enteric pathogens, 2.5 × 105 freshly prepared sporozoites of each Eimeria acervulina, E. maxima, and E. tenella were placed in each well of a 96-well plate, and the vegetative stage of Clostridium perfringens was prepared at 1 × 109 cfu/well. Four different SLs (C18:1 lactonic diacetyled SL [SL1], C18:1 deacetyled SL [SL2], C18:1 monoacetyled SL [SL3], and C18:1 diacetyled SL [SL4]), and 2 anticoccidial chemical controls, decoquinate and monensin, were evaluated at 3 dose levels (125 µg/mL, 250 µg/mL, and 500 µg/mL). Samples were incubated at 41°C for 3 h, and microbial survival ratios were measured by using a cell counter to quantify the number of live microbes stained by fluorescent dye. A total of 336 (0-day-old) male commercial broiler chickens were used to assess the effects of SLs in vivo. Chickens were randomly allocated to 6 treatment groups (7 chickens per cage, 8 cages per treatment) as follows: a control group which received a basal diet (CON), a negative control group (NC) which received a basal diet and NE challenge, and 4 SL treatment groups with NE (NC+SL1, NC+SL2, NC+SL3, and NC+SL4). The inclusion rates of SLs in each group were 200 mg/kg of feed. NE-induced chickens were orally infected with E. maxima (10,000 oocysts/chicken) on d 14, followed by C. perfringens (1 × 109 cfu/chicken) on d 19. Disease parameters measured included gut lesion scores, intestinal cytokine production, and level of tight junction protein expression. Data were analyzed using a Mixed Model (PROC MIXED) in SAS. In vitro (Experiment 1), all SLs dose-dependently decreased (P < 0.001) the viability of the three species of Eimeria sporozoites and C. perfringens. In vivo (Experiment 2), dietary SLs increased (P < 0.001) body weight and average daily gain of broiler chickens infected with NE. Dietary SL1 and SL4s increased (P < 0.05) feed conversion ratio compared to NC. Furthermore, SL1 and SL4 decreased (P < 0.05) gut lesion scores in combination with increased expression of IL1β, IL8, TNFSF15, and IL10 genes (P < 0.05) in NE-afflicted chickens. Overall, dietary SLs promoted growth performance, intestinal immune responses, and intestinal barrier integrity of NE-afflicted, young broiler chickens.
Collapse
Affiliation(s)
- Inkyung Park
- Animal Bioscience and Biotechnology Laboratory, Beltsville Agricultural Research Center, Agricultural Research Service, USDA, Beltsville, MD 20705, USA
| | - Sungtaek Oh
- Neuroregeneration and Stem Cell Programs, Institute for Cell Engineering, Johns Hopkins University School of Medicine, Baltimore, MD 21205, USA
| | - Hyoyoun Nam
- Animal Bioscience and Biotechnology Laboratory, Beltsville Agricultural Research Center, Agricultural Research Service, USDA, Beltsville, MD 20705, USA
| | - Pietro Celi
- DSM Nutritional Products, Animal Nutrition and Health, Columbia, MD 21045, USA; Faculty of Veterinary and Agricultural Sciences, The University of Melbourne, Parkville, VIC, 3010, Australia
| | - Hyun S Lillehoj
- Animal Bioscience and Biotechnology Laboratory, Beltsville Agricultural Research Center, Agricultural Research Service, USDA, Beltsville, MD 20705, USA.
| |
Collapse
|
29
|
Qazi MA, Wang Q, Dai Z. Sophorolipids bioproduction in the yeast Starmerella bombicola: Current trends and perspectives. BIORESOURCE TECHNOLOGY 2022; 346:126593. [PMID: 34942344 DOI: 10.1016/j.biortech.2021.126593] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/09/2021] [Revised: 12/15/2021] [Accepted: 12/16/2021] [Indexed: 06/14/2023]
Abstract
Sophorolipids are highly active green surfactants (glycolipid biosurfactants) getting tremendous appreciation worldwide due to their low toxicity, biodegradability, broad spectrum of applications, and significant biotechnological potential. Sophorolipids are mainly produced by an oleaginous budding yeast Starmerella bombicola using low-cost substrates. Therefore, the recent state-of-art literature information about S. bombicola yeast is hereby provided, especially the underlying production pathways, biosynthetic gene cluster, and regulatory enzymes. Moreover, the S. bombicola offers flexibility for regulating the structural diversity of sophorolipids, either genetically or by varying fermentative conditions. The emergence of advanced technologies like 'Omics and CRISPR/Cas have certainly boosted rational engineering research for designing high-performing platform strains. Therefore, currently available genetic engineering tools in S. bombicola were reviewed, thereby opening up exciting new possibilities for improving the overall bioproduction titers, structural variability, and stability of sophorolipids. Finally, some technical perspectives to address the current challenges were discussed.
Collapse
Affiliation(s)
- Muneer Ahmed Qazi
- Key Laboratory of Systems Microbial Biotechnology, Tianjin Institute of Industrial Biotechnology, Chinese Academy of Sciences, Tianjin 300308, PR China; National Center of Technology Innovation for Synthetic Biology, Tianjin 300308, PR China; Institute of Microbiology, Faculty of Natural Science, Shah Abdul Latif University, Khairpur, 66020 Sindh, Pakistan
| | - Qinhong Wang
- Key Laboratory of Systems Microbial Biotechnology, Tianjin Institute of Industrial Biotechnology, Chinese Academy of Sciences, Tianjin 300308, PR China; National Center of Technology Innovation for Synthetic Biology, Tianjin 300308, PR China
| | - Zongjie Dai
- Key Laboratory of Systems Microbial Biotechnology, Tianjin Institute of Industrial Biotechnology, Chinese Academy of Sciences, Tianjin 300308, PR China; National Center of Technology Innovation for Synthetic Biology, Tianjin 300308, PR China.
| |
Collapse
|
30
|
Overview on Glycosylated Lipids Produced by Bacteria and Fungi: Rhamno-, Sophoro-, Mannosylerythritol and Cellobiose Lipids. ADVANCES IN BIOCHEMICAL ENGINEERING/BIOTECHNOLOGY 2022; 181:73-122. [DOI: 10.1007/10_2021_200] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/25/2022]
|
31
|
Xu M, Zhao M, Li RHW, Lin Z, Chung JPW, Li TC, Lee TL, Chan DYL. Effects of nonoxynol-9 (N-9) on sperm functions: systematic review and meta-analysis. REPRODUCTION AND FERTILITY 2022; 3:R19-R33. [PMID: 35350652 PMCID: PMC8956826 DOI: 10.1530/raf-21-0024] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/16/2022] [Accepted: 02/21/2022] [Indexed: 11/09/2022] Open
Abstract
Objective To summarize the currently available phase I and II clinical trials of the effects of nonoxynol-9 (N-9) on human sperm structure and functions. Methods A systematic review and meta-analysis aiming to evaluate the spermicidal activity of N-9 on motility, was conducted in PubMed, EMBASE, and Cochrane databases by 10 March 2021. The counted numbers of progressive motile (PR) sperm in cervical mucus and the vanguard sperm penetration distances were analyzed. Other effects on sperm structures and physiological activities were reviewed as well. Results In the pooled results, percentages or counted numbers of PR sperm decreased after the treatment of N-9. Vanguard sperm penetration distance was shortened in treated groups. N-9 has been confirmed to damage the structures of sperm, as well as other organelles like acrosome and mitochondria. The physiological activities such as generation of reactive oxygen species, superoxide dismutase activity, acrosin activity, and hemizona binding were all inhibited in the reviewed studies. Conclusions N-9 has several impacts on sperm owing to its potency in reducing sperm motility and cervical mucus penetration, as well as other functional competencies. Lay summary Nonoxynol-9 (N-9) has been used worldwide as a spermicide to kill sperm for more than 60 years but can cause side effects including vaginal irritation and can increase the rate of contraceptive failure. A detailed analysis of published literature aiming to evaluate the spermicidal activity of N-9 on sperm was carried out. In the pooled results, N-9 reduced the number of active sperm and the distance they traveled. It also caused damage to the structures of sperm and to the way the sperm acted and interacted with the egg. In conclusion, N-9 impacts on sperm in a number of ways that lead to sperm death and dysfunction.
Collapse
Affiliation(s)
- Murong Xu
- Assisted Reproductive Technology Unit, Department of Obstetrics and Gynaecology, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
- School of Biomedical Sciences, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
| | - Mingpeng Zhao
- Assisted Reproductive Technology Unit, Department of Obstetrics and Gynaecology, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
| | - Raymond Hang Wun Li
- Department of Obstetrics and Gynaecology, The University of Hong Kong, Queen Mary Hospital, Hong Kong, China
| | - Zhixiu Lin
- Hong Kong Institute of Integrative Medicine, Faculty of Medicine, The Chinese University of Hong Kong, Sha Tin, Hong Kong, China
| | - Jacqueline Pui Wah Chung
- Assisted Reproductive Technology Unit, Department of Obstetrics and Gynaecology, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
| | - Tin Chiu Li
- Assisted Reproductive Technology Unit, Department of Obstetrics and Gynaecology, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
| | - Tin-Lap Lee
- School of Biomedical Sciences, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
| | - David Yiu Leung Chan
- Assisted Reproductive Technology Unit, Department of Obstetrics and Gynaecology, Faculty of Medicine, The Chinese University of Hong Kong, Hong Kong, China
| |
Collapse
|
32
|
Daverey A, Dutta K, Joshi S, Daverey A. Sophorolipid: a glycolipid biosurfactant as a potential therapeutic agent against COVID-19. Bioengineered 2021; 12:9550-9560. [PMID: 34709115 PMCID: PMC8810061 DOI: 10.1080/21655979.2021.1997261] [Citation(s) in RCA: 16] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/18/2021] [Revised: 10/16/2021] [Accepted: 10/16/2021] [Indexed: 12/12/2022] Open
Abstract
Biosurfactants are natural surfactants produced by a variety of microorganisms. In recent years, biosurfactants have garnered a lot of interest due to their biomedical and pharmaceutical applications. Sophorolipids are glycolipid types of biosurfactants produced by selected nonpathogenic yeasts. In addition to the detergent activity (reduction in surface and interfacial tension), which is commonly utilized by biomedical applications, sophorolipids have shown some unique properties such as, antiviral activity against enveloped viruses, immunomodulation, and anticancer activity. Considering their antiviral activity, the potential of sophorolipids as an antiviral therapy for the treatment of COVID-19 is discussed in this review. Being a surfactant molecule, sophorolipid could solubilize the lipid envelope of SARS-CoV-2 and inactivate it. As an immunomodulator, sophorolipid could attenuate the cytokine storm caused by the SARS-CoV-2 upon infection, and inhibit the progression of COVID-19 in patients. Sophorolipids could also be used as an effective treatment strategy for COVID-19 patients suffering from cancer. However, there is limited research on the use of sophorolipid as a therapeutic agent for the treatment of cancer and viral diseases, and to modulate the immune response. Nevertheless, the multitasking capabilities of sophorolipids make them potential therapeutic candidates for the bench-to-bedside research for the treatment of COVID-19.
Collapse
Affiliation(s)
- Amita Daverey
- Department of Neurosurgery, University of Nebraska Medical Center, Omaha, NE, USA
| | - Kasturi Dutta
- Department of Biotechnology and Medical Engineering, National Institute of Technology, Rourkela, India
| | - Sanket Joshi
- Oil & Gas Research Center, Central Analytical and Applied Research Unit, Sultan Qaboos University, Muscat, Oman
| | - Achlesh Daverey
- School of Environment and Natural Resources, Doon University, Dehradun, India
- School of Biological Sciences, Doon University, Dehradun, India
| |
Collapse
|
33
|
Xie M, Song Q, Zhao H. Investigation on the surface-active and antimicrobial properties of a natural glycolipid product. Food Funct 2021; 12:11537-11546. [PMID: 34708225 DOI: 10.1039/d1fo02359d] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
Abstract
Glycolipids are a group of sugar-containing lipids with versatile functions. In this study, a natural glycolipid product was obtained from soy lecithin, and its emulsifying, oil-gelling, antibacterial and antiviral properties were investigated. A silica-based extraction method on a preparative scale was used to recover the glycolipid product (GLP) from soy lecithin. The GLP consisted of three different glycolipid classes: acylated sterol glucoside (64.16%), sterol glucoside (25.57%) and cerebroside (6.71%). As an emulsifier, the GLP was able to form a stable water-in-oil emulsion. The GLP exhibited a good oil-gelling property, capable of gelling rapeseed oil at a concentration of 6%. For the investigated microorganisms (Escherichia coli, Pseudomonas aeruginosa and Staphylococcus aureus), the GLP did not show any antibacterial effects. The GLP exerted antiviral activity against lentivirus, but not adenovirus. The results of this study help in enriching the knowledge on the properties of naturally occurring glycolipids, which may find potential applications in the food, pharmaceutical and related industries.
Collapse
Affiliation(s)
- Meizhen Xie
- School of Food Equipment Engineering and Science, Xi'an Jiaotong University, Xi'an 710049, China.
| | - Qing Song
- Frontiers Science Center for Flexible Electronics (FSCFE), Xi'an Institute of Flexible Electronics (IFE), Xi'an Institute of Biomedical Materials & Engineering (IBME), Northwestern Polytechnical University, Xi'an 710072, China.
| | - Hong Zhao
- School of Food Equipment Engineering and Science, Xi'an Jiaotong University, Xi'an 710049, China.
| |
Collapse
|
34
|
Ozdener MH, Spielman AI, Wise PM. Sophorolipid Reduces Bitter Taste in Humans
In Vivo
and
In Vitro. J SURFACTANTS DETERG 2021. [DOI: 10.1002/jsde.12526] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/23/2022]
Affiliation(s)
| | | | - Paul M. Wise
- Monell Chemical Senses Center 3500 Market Street Philadelphia PA 19104 USA
| |
Collapse
|
35
|
Chen Y, Nai X, Li M, Kong J, Hao S, Yan H, Liu M, Zhang Q, Liu J. A comprehensive research on Lactone Sophorolipid (LSL) and Soy Protein Isolate (SPI) interacting mixture. J Mol Liq 2021. [DOI: 10.1016/j.molliq.2021.117239] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
36
|
Simon M, Veit M, Osterrieder K, Gradzielski M. Surfactants - Compounds for inactivation of SARS-CoV-2 and other enveloped viruses. Curr Opin Colloid Interface Sci 2021; 55:101479. [PMID: 34149296 PMCID: PMC8196227 DOI: 10.1016/j.cocis.2021.101479] [Citation(s) in RCA: 27] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/15/2022]
Abstract
We provide here a general view on the interactions of surfactants with viruses, with a particular emphasis on how such interactions can be controlled and employed for inhibiting the infectivity of enveloped viruses, including coronaviruses. The aim is to provide to interested scientists from different fields, including chemistry, physics, biochemistry, and medicine, an overview of the basic properties of surfactants and (corona)viruses, which are relevant to understanding the interactions between the two. Various types of interactions between surfactant and virus are important, and they act on different components of a virus such as the lipid envelope, membrane (envelope) proteins and nucleocapsid proteins. Accordingly, this cannot be a detailed account of all relevant aspects but instead a summary that bridges between the different disciplines. We describe concepts and cover a selection of the relevant literature as an incentive for diving deeper into the relevant material. Our focus is on more recent developments around the COVID-19 pandemic caused by SARS-CoV-2, applications of surfactants against the virus, and on the potential future use of surfactants for pandemic relief. We also cover the most important aspects of the historical development of using surfactants in combatting virus infections. We conclude that surfactants are already playing very important roles in various directions of defence against viruses, either directly, as in disinfection, or as carrier components of drug delivery systems for prophylaxis or treatment. By designing tailor-made surfactants, and consequently, advanced formulations, one can expect more and more effective use of surfactants, either directly as antiviral compounds or as part of more complex formulations.
Collapse
Key Words
- AFM, atomic force microscopy
- BVDV, Bovine Viral Diarrhea Virus
- C12E8, dodecyloctaglycol
- CPyC, cetylpyridinium chloride
- DSPC, 1,2-distearoyl-sn-glycero-3-phosphocholine
- Disinfection
- Enveloped viruses
- Flu, influenza virus
- HIV, human immunodeficiency virus
- HSV, herpes simplex virus
- ITC, isothermal titration calorimetry
- Ld, liquid-disordered
- Lipid bilayers
- Lo, liquid-ordered
- PA, phosphatidic acid (anionic)
- PC, phosphatidylcholine (zwitterionic)
- PE, phosphatidylethanolamine (zwitterionic)
- PI, phosphatidylinositol (anionic)
- POPC, 1-Palmitoyl-2-oleoyl-sn-glycero-3-phosphocholine
- PS, phosphatidylserine (anionic)
- QUAT, quaternary alkyl ammonium
- RNP, ribonucleoprotein particle
- SAXS, small-angle X-ray scattering
- SDS, sodium dodecyl sulphate
- Surfactant
- TBP, tri-n-butyl phosphate
- TEM, transmission electron microscopy
- Virus inactivation
- cac, critical aggregate concentration
- cmc, critical micelle concentration
- p, packing parameter
Collapse
Affiliation(s)
- Miriam Simon
- Dept. of Chemical Engineering and the Russell Berrie Nanotechnolgy Inst. (RBNI), Technion-Israel Institute of Technology, Haifa, IL 3200003, Israel
| | - Michael Veit
- Institut für Virologie, Fachbereich Veterinärmedizin, Freie Universität Berlin, Robert von Ostertag-Straße 7-13, 14163 Berlin, Germany
| | - Klaus Osterrieder
- Institut für Virologie, Fachbereich Veterinärmedizin, Freie Universität Berlin, Robert von Ostertag-Straße 7-13, 14163 Berlin, Germany
- Department of Infectious Diseases and Public Health, Jockey Club College of Veterinary Medicine and Life Sciences, City University of Hong Kong, Kowloon Tong, Hong Kong
| | - Michael Gradzielski
- Stranski-Laboratorium für Physikalische und Theoretische Chemie, Institut für Chemie, Straße des 17. Juni 124, Sekr. TC7, Technische Universität Berlin, D-10623 Berlin, Germany
| |
Collapse
|
37
|
Mishra S, Lin Z, Pang S, Zhang Y, Bhatt P, Chen S. Biosurfactant is a powerful tool for the bioremediation of heavy metals from contaminated soils. JOURNAL OF HAZARDOUS MATERIALS 2021; 418:126253. [PMID: 34119972 DOI: 10.1016/j.jhazmat.2021.126253] [Citation(s) in RCA: 66] [Impact Index Per Article: 22.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/09/2021] [Revised: 05/26/2021] [Accepted: 05/26/2021] [Indexed: 05/05/2023]
Abstract
Heavy metal toxicity has become a pressing ecological problem that affects the ecosystems through bioaccumulation, representing a serious public health hazard. Many conventional strategies have been developed and applied to decontaminate and restore metal-contaminated areas. However, these conventional approaches are not very suitable and environmentally safe for heavy metal remediation because of their high operational costs, high energy requirements, post-waste disposal problems, and secondary pollutant generation. Thus, biosurfactant-based bioremediation of heavy metals is a sustainable and promising approach because of its biodegradation capability, economic effectiveness, and ecofriendly nature. Pseudomonas sp., Bacillus sp., Citrobacter freundii, and Candida tropicalis have been isolated as potential sources of biosurfactants and produce compounds such as surfactin, rhamnolipids, and sophorolipids. Owing to the severity of heavy metal pollution in certain parts of the environment, biosurfactants have garnered great interest and attention as an emerging multi-functional technology of the new century for successful removal of heavy metal pollutants. The present study describes the role of biosurfactants in the bioremediation of heavy metals from contaminated environments. Moreover, the interaction mechanism underlying biosurfactant-metal complexation and metal remediation are discussed. Based on the review of the literature, further research is warranted to elucidate the mechanistic roles and explore the structural characterization and gene regulation of biosurfactants to improve their productivity and expand their applicability in bioremediation.
Collapse
Affiliation(s)
- Sandhya Mishra
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-bioresources, Guangdong Province Key Laboratory of Microbial Signals and Disease Control, Integrative Microbiology Research Centre, South China Agricultural University, Guangzhou 510642, China; Guangdong Laboratory for Lingnan Modern Agriculture, Guangzhou 510642, China
| | - Ziqiu Lin
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-bioresources, Guangdong Province Key Laboratory of Microbial Signals and Disease Control, Integrative Microbiology Research Centre, South China Agricultural University, Guangzhou 510642, China; Guangdong Laboratory for Lingnan Modern Agriculture, Guangzhou 510642, China
| | - Shimei Pang
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-bioresources, Guangdong Province Key Laboratory of Microbial Signals and Disease Control, Integrative Microbiology Research Centre, South China Agricultural University, Guangzhou 510642, China; Guangdong Laboratory for Lingnan Modern Agriculture, Guangzhou 510642, China
| | - Yuming Zhang
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-bioresources, Guangdong Province Key Laboratory of Microbial Signals and Disease Control, Integrative Microbiology Research Centre, South China Agricultural University, Guangzhou 510642, China; Guangdong Laboratory for Lingnan Modern Agriculture, Guangzhou 510642, China
| | - Pankaj Bhatt
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-bioresources, Guangdong Province Key Laboratory of Microbial Signals and Disease Control, Integrative Microbiology Research Centre, South China Agricultural University, Guangzhou 510642, China; Guangdong Laboratory for Lingnan Modern Agriculture, Guangzhou 510642, China
| | - Shaohua Chen
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-bioresources, Guangdong Province Key Laboratory of Microbial Signals and Disease Control, Integrative Microbiology Research Centre, South China Agricultural University, Guangzhou 510642, China; Guangdong Laboratory for Lingnan Modern Agriculture, Guangzhou 510642, China.
| |
Collapse
|
38
|
Franco Marcelino PR, Ortiz J, da Silva SS, Ortiz A. Interaction of an acidic sophorolipid biosurfactant with phosphatidylcholine model membranes. Colloids Surf B Biointerfaces 2021; 207:112029. [PMID: 34399158 DOI: 10.1016/j.colsurfb.2021.112029] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/05/2021] [Revised: 08/04/2021] [Accepted: 08/05/2021] [Indexed: 11/17/2022]
Abstract
Sophorolipids (SLs) constitute a group of unique biosurfactants (BS) in the light of their outstanding properties, among which their antimicrobial activities stand out. SLs can exist mainly in an acidic and a lactonic form, both of which display inhibitory activity. Given the amphipathic nature of SLs it is feasible that these antimicrobial actions are the result of the perturbation of the physicochemical properties of targeted membranes. Thus, in this work we have carried out a biophysical study to unveil the molecular details of the interaction of an acidic SL with a model phospholipid membrane made of 1,2-dipalmitoy-sn-glycero-3-phosphocholine (DPPC). Using differential scanning calorimetry it was found that SL altered the phase behaviour of DPPC at low molar fractions, producing fluid phase immiscibility with the result of formation of biosurfactant-enriched domains within the phospholipid bilayer. Fourier-transform infrared spectroscopy showed that SL interacted with DPPC increasing ordering of the phospholipid acyl chain palisade and hydration of the lipid/water interface. Small angle X-ray scattering showed that SL did not modify bilayer thickness in the biologically relevant Lα fluid phase. SL was found to induce contents leakage in 1-palmitoy-2-oleoy-sn-glycero-3-phosphocholine (POPC) unilamellar liposomes, at sublytic concentrations below the cmc. This SL-induced membrane permeabilization at concentrations below the onset for membrane solubilization can be the result of the formation of laterally segregated domains, which might contribute to provide a molecular basis for the reported antimicrobial actions of SLs.
Collapse
Affiliation(s)
- Paulo Ricardo Franco Marcelino
- Laboratório de Bioprocessos e Produtos Sustentáveis (LBios), Escola de Engenharia de Lorena (EEL), Universidade de São Paulo (USP), Brazil
| | - Julia Ortiz
- Departamento de Bioquímica y Biología Molecular-A, Facultad de Veterinaria, Universidad de Murcia, Spain
| | - Silvio Silvério da Silva
- Laboratório de Bioprocessos e Produtos Sustentáveis (LBios), Escola de Engenharia de Lorena (EEL), Universidade de São Paulo (USP), Brazil
| | - Antonio Ortiz
- Departamento de Bioquímica y Biología Molecular-A, Facultad de Veterinaria, Universidad de Murcia, Spain.
| |
Collapse
|
39
|
From bumblebee to bioeconomy: Recent developments and perspectives for sophorolipid biosynthesis. Biotechnol Adv 2021; 54:107788. [PMID: 34166752 DOI: 10.1016/j.biotechadv.2021.107788] [Citation(s) in RCA: 25] [Impact Index Per Article: 8.3] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/25/2021] [Revised: 06/16/2021] [Accepted: 06/17/2021] [Indexed: 12/16/2022]
Abstract
Sophorolipids are biobased compounds produced by the genera Starmerella and Pseudohyphozyma that gain exponential interest from academic and industrial stakeholders due to their mild and environmental friendly characteristics. Currently, industrially relevant sophorolipid volumetric productivities are reached up to 3.7 g∙L-1∙h-1 and sophorolipids are used in the personal care and cleaning industry at small scale. Moreover, applications in crop protection, food, biohydrometallurgy and medical fields are being extensively researched. The research and development of sophorolipids is at a crucial stage. Therefore, this work presents an overview of the state-of-the-art on sophorolipid research and their applications, while providing a critical assessment of scientific techniques and standardisation in reporting. In this review, the genuine sophorolipid producing organisms and the natural role of sophorolipids are discussed. Subsequently, an evaluation is made of innovations in production processes and the relevance of in-situ product recovery for process performance is discussed. Furthermore, a critical assessment of application research and its future perspectives are portrayed with a focus on the self-assembly of sophorolipid molecules. Following, genetic engineering strategies that affect the sophorolipid physiochemical properties are summarised. Finally, the impact of sophorolipids on the bioeconomy are uncovered, along with relevant future perspectives.
Collapse
|
40
|
da Silva AF, Banat IM, Giachini AJ, Robl D. Fungal biosurfactants, from nature to biotechnological product: bioprospection, production and potential applications. Bioprocess Biosyst Eng 2021; 44:2003-2034. [PMID: 34131819 PMCID: PMC8205652 DOI: 10.1007/s00449-021-02597-5] [Citation(s) in RCA: 32] [Impact Index Per Article: 10.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/15/2021] [Accepted: 06/01/2021] [Indexed: 11/24/2022]
Abstract
Biosurfactants are in demand by the global market as natural commodities that can be added to commercial products or use in environmental applications. These biomolecules reduce the surface/interfacial tension between fluid phases and exhibit superior stability to chemical surfactants under different physico-chemical conditions. Biotechnological production of biosurfactants is still emerging. Fungi are promising producers of these molecules with unique chemical structures, such as sophorolipids, mannosylerythritol lipids, cellobiose lipids, xylolipids, polyol lipids and hydrophobins. In this review, we aimed to contextualize concepts related to fungal biosurfactant production and its application in industry and the environment. Concepts related to the thermodynamic and physico-chemical properties of biosurfactants are presented, which allows detailed analysis of their structural and application. Promising niches for isolating biosurfactant-producing fungi are presented, as well as screening methodologies are discussed. Finally, strategies related to process parameters and variables, simultaneous production, process optimization through statistical and genetic tools, downstream processing and some aspects of commercial products formulations are presented.
Collapse
Affiliation(s)
- André Felipe da Silva
- Department of Microbiology, Immunology and Parasitology, Federal University of Santa Catarina (UFSC), Florianópolis, SC, Brazil.,Bioprocess and Biotechnology Engineering Undergraduate Program, Federal University of Tocantins (UFT), Gurupi, TO, Brazil
| | - Ibrahim M Banat
- School of Biomedical Sciences, Faculty of Life and Health Sciences, Ulster University, Coleraine, UK
| | - Admir José Giachini
- Department of Microbiology, Immunology and Parasitology, Federal University of Santa Catarina (UFSC), Florianópolis, SC, Brazil
| | - Diogo Robl
- Department of Microbiology, Immunology and Parasitology, Federal University of Santa Catarina (UFSC), Florianópolis, SC, Brazil.
| |
Collapse
|
41
|
Totsingan F, Liu F, Gross RA. Structure-Activity Relationship Assessment of Sophorolipid Ester Derivatives against Model Bacteria Strains. Molecules 2021; 26:3021. [PMID: 34069408 PMCID: PMC8158775 DOI: 10.3390/molecules26103021] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/29/2021] [Revised: 05/12/2021] [Accepted: 05/16/2021] [Indexed: 11/27/2022] Open
Abstract
Sophorolipids (SLs) are glycolipids that consist of a hydrophilic sophorose head group covalently linked to a hydrophobic fatty acid tail. They are produced by fermentation of non-pathogenic yeasts such as Candida Bombicola. The fermentation products predominantly consist of the diacetylated lactonic form that coexists with the open-chain acidic form. A systematic series of modified SLs were prepared by ring opening of natural lactonic SL with n-alkanols of varying chain length under alkaline conditions and lipase-selective acetylation of sophorose primary hydroxyl groups. The antimicrobial activity of modified SLs against Gram-positive human pathogens was a function of the n-alkanol length, as well as the degree of sophorose acetylation at the primary hydroxyl sites. Modified SLs were identified with promising antimicrobial activities against Gram-positive human pathogens with moderate selectivity (therapeutic index, TI = EC50/MICB. cereus = 6-33). SL-butyl ester exhibited the best antimicrobial activity (MIC = 12 μM) and selectivity (TI = 33) among all SLs tested. Kinetic studies revealed that SL-ester derivatives kill B. cereus in a time-dependent manner resulting in greater than a 3-log reduction in cell number within 1 h at 2×MIC. In contrast, lactonic SL required 3 h to achieve the same efficiency.
Collapse
Affiliation(s)
- Filbert Totsingan
- Department of Chemistry and Chemical Biology, Rensselaer Polytechnic Institute, Troy, NY 12180, USA
| | - Fei Liu
- Center for Biotechnology and Interdisciplinary Studies (CBIS), Rensselaer Polytechnic Institute, Troy, NY 12180, USA;
| | - Richard A. Gross
- Center for Biotechnology and Interdisciplinary Studies (CBIS), Rensselaer Polytechnic Institute, Troy, NY 12180, USA;
| |
Collapse
|
42
|
Cloutier M, Prévost MJ, Lavoie S, Feroldi T, Piochon M, Groleau MC, Legault J, Villaume S, Crouzet J, Dorey S, Dìaz De Rienzo MA, Déziel E, Gauthier C. Total synthesis, isolation, surfactant properties, and biological evaluation of ananatosides and related macrodilactone-containing rhamnolipids. Chem Sci 2021; 12:7533-7546. [PMID: 34163844 PMCID: PMC8171317 DOI: 10.1039/d1sc01146d] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/25/2021] [Accepted: 04/22/2021] [Indexed: 01/20/2023] Open
Abstract
Rhamnolipids are a specific class of microbial surfactants, which hold great biotechnological and therapeutic potential. However, their exploitation at the industrial level is hampered because they are mainly produced by the opportunistic pathogen Pseudomonas aeruginosa. The non-human pathogenic bacterium Pantoea ananatis is an alternative producer of rhamnolipid-like metabolites containing glucose instead of rhamnose residues. Herein, we present the isolation, structural characterization, and total synthesis of ananatoside A, a 15-membered macrodilactone-containing glucolipid, and ananatoside B, its open-chain congener, from organic extracts of P. ananatis. Ananatoside A was synthesized through three alternative pathways involving either an intramolecular glycosylation, a chemical macrolactonization or a direct enzymatic transformation from ananatoside B. A series of diasteroisomerically pure (1→2), (1→3), and (1→4)-macrolactonized rhamnolipids were also synthesized through intramolecular glycosylation and their anomeric configurations as well as ring conformations were solved using molecular modeling in tandem with NMR studies. We show that ananatoside B is a more potent surfactant than its macrolide counterpart. We present evidence that macrolactonization of rhamnolipids enhances their cytotoxic and hemolytic potential, pointing towards a mechanism involving the formation of pores into the lipidic cell membrane. Lastly, we demonstrate that ananatoside A and ananatoside B as well as synthetic macrolactonized rhamnolipids can be perceived by the plant immune system, and that this sensing is more pronounced for a macrolide featuring a rhamnose moiety in its native 1 C 4 conformation. Altogether our results suggest that macrolactonization of glycolipids can dramatically interfere with their surfactant properties and biological activity.
Collapse
Affiliation(s)
- Maude Cloutier
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
| | - Marie-Joëlle Prévost
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
| | - Serge Lavoie
- Laboratoire d'Analyse et de Séparation des Essences Végétales (LASEVE), Département des Sciences Fondamentales, Université du Québec à Chicoutimi 555, Boulevard de l'Université Chicoutimi (Québec) G7H 2B1 Canada
| | - Thomas Feroldi
- Laboratoire d'Analyse et de Séparation des Essences Végétales (LASEVE), Département des Sciences Fondamentales, Université du Québec à Chicoutimi 555, Boulevard de l'Université Chicoutimi (Québec) G7H 2B1 Canada
| | - Marianne Piochon
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
| | - Marie-Christine Groleau
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
| | - Jean Legault
- Laboratoire d'Analyse et de Séparation des Essences Végétales (LASEVE), Département des Sciences Fondamentales, Université du Québec à Chicoutimi 555, Boulevard de l'Université Chicoutimi (Québec) G7H 2B1 Canada
| | - Sandra Villaume
- Université de Reims Champagne-Ardenne, INRAE, USC RIBP 1488, SFR Condorcet-FR CNRS 3417 51100 Reims France
| | - Jérôme Crouzet
- Université de Reims Champagne-Ardenne, INRAE, USC RIBP 1488, SFR Condorcet-FR CNRS 3417 51100 Reims France
| | - Stéphan Dorey
- Université de Reims Champagne-Ardenne, INRAE, USC RIBP 1488, SFR Condorcet-FR CNRS 3417 51100 Reims France
| | - Mayri Alejandra Dìaz De Rienzo
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
- School of Pharmacy and Biomolecular Sciences, Liverpool John Moores University L3 3AF Liverpool UK
| | - Eric Déziel
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
| | - Charles Gauthier
- Centre Armand-Frappier Santé Biotechnologie, Institut National de la Recherche Scientifique (INRS) 531, Boulevard des Prairies Laval (Québec) H7V 1B7 Canada
| |
Collapse
|
43
|
Liwarska-Bizukojc E, Stevens CV, Delbeke EIP, Van Geem KM. Endocrine disrupting potency and toxicity of novel sophorolipid quaternary ammonium salts. ECOTOXICOLOGY (LONDON, ENGLAND) 2021; 30:658-666. [PMID: 33730294 PMCID: PMC8060166 DOI: 10.1007/s10646-021-02378-6] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Accepted: 02/23/2021] [Indexed: 06/12/2023]
Abstract
A new class of biosurfactants, namely quaternary ammonium sophorolipids (SQAS), suitable for pharmaceutical applications, was tested for the evaluation of their (anti)estrogenic and (anti)androgenic potency with the help of YES/YAS assays. Also their toxicity towards yeasts (Saccharomyces cerevisiae) and bacteria (Escherichia coli) was checked. The results achieved for SQAS, which can be regarded as potential micropollutants, were compared with those obtained for two well-known micropollutants diclofenac and 17α-ethinylestradiol subjected to the same testing procedures. This work demonstrated that acetylation of the hydroxyl group of the carbohydrate head of SQAS decreased the toxicity of this class of biosurfactants towards Saccharomyces cerevisiae. Furthermore, it contributed to the decrease of their endocrine disrupting potency. None of the SQAS studied showed clear agonist activity for female or male hormones. SQAS1 and SQAS2 revealed weak antiestrogenic and antiandrogenic potency. All of these properties were weaker, not only to the potency of the appropriate positive control in the antagonists bioassays, but also compared to the potency of other tested compounds, i.e. DCF and EE2. SQAS3 possessed most probably inhibitory activity towards male hormones. Moreover, cytotoxicity of two out of four studied SQAS at the highest concentrations towards the strains of Saccharomyces cerevisiae interfered with the endocrine disruption activity. It would be also worth studying it with the use of another endocrine activity test.
Collapse
Affiliation(s)
- Ewa Liwarska-Bizukojc
- Institute of Environmental Engineering and Building Installations, Lodz University of Technology, Al. Politechniki 6, 90-924, Lodz, Poland.
| | - Christian V Stevens
- Faculty of Bioscience Engineering, Department of Green Chemistry and Technology, Ghent University, Coupure Links 653, B-9000, Ghent, Belgium
| | - Elisabeth I P Delbeke
- Faculty of Bioscience Engineering, Department of Green Chemistry and Technology, Ghent University, Coupure Links 653, B-9000, Ghent, Belgium
| | - Kevin M Van Geem
- Faculty of Engineering and Architecture, Department of Materials, Textile and Chemical Engineering, Ghent University, Technologiepark 914, B-9052, Ghent-Zwijnaarde, Belgium
| |
Collapse
|
44
|
Leyton A, Araya M, Tala F, Flores L, Lienqueo ME, Shene C. Macrocystis pyrifera Extract Residual as Nutrient Source for the Production of Sophorolipids Compounds by Marine Yeast Rhodotorula rubra. Molecules 2021; 26:2355. [PMID: 33919590 PMCID: PMC8074180 DOI: 10.3390/molecules26082355] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/30/2021] [Revised: 04/13/2021] [Accepted: 04/16/2021] [Indexed: 12/03/2022] Open
Abstract
Seaweed processing generates liquid fraction residual that could be used as a low-cost nutrient source for microbial production of metabolites. The Rhodotorula strain is able to produce antimicrobial compounds known as sophorolipids. Our aim was to evaluate sophorolipid production, with antibacterial activity, by marine Rhodotorula rubra using liquid fraction residual (LFR) from the brown seaweed Macrocystis pyrifera as the nutrient source. LFR having a composition of 32% w/w carbohydrate, 1% w/w lipids, 15% w/w protein and 52% w/w ash. The best culture condition for sophorolipid production was LFR 40% v/v, without yeast extract, artificial seawater 80% v/v at 15 °C by 3 growth days, with the antibacterial activity of 24.4 ± 3.1 % on Escherichia coli and 21.1 ± 3.8 % on Staphylococcus aureus. It was possible to identify mono-acetylated acidic and methyl ester acidic sophorolipid. These compounds possess potential as pathogen controllers for application in the food industry.
Collapse
Affiliation(s)
- Allison Leyton
- Center for Biotechnology and Bioengineering (CeBiB), Center of Food Biotechnology and Bioseparations, BIOREN and Department of Chemical Engineering, Universidad de La Frontera, Francisco Salazar 01145, Temuco 4780000, Chile; (L.F.); (C.S.)
| | - Michael Araya
- Centro de Investigación y Desarrollo Tecnológico de Algas y otros Recursos Biológicos (CIDTA), Facultad de Ciencias Marinas, Universidad Católica del Norte, Coquimbo 17811421, Chile; (M.A.); (F.T.)
| | - Fadia Tala
- Centro de Investigación y Desarrollo Tecnológico de Algas y otros Recursos Biológicos (CIDTA), Facultad de Ciencias Marinas, Universidad Católica del Norte, Coquimbo 17811421, Chile; (M.A.); (F.T.)
- Departamento de Biología Marina, Universidad Católica del Norte, Larrondo 1281, Coquimbo 17811421, Chile
- Coastal Socio-Ecological Millenium Institute (SECOS), Santiago 8370459, Chile
| | - Liset Flores
- Center for Biotechnology and Bioengineering (CeBiB), Center of Food Biotechnology and Bioseparations, BIOREN and Department of Chemical Engineering, Universidad de La Frontera, Francisco Salazar 01145, Temuco 4780000, Chile; (L.F.); (C.S.)
| | - María Elena Lienqueo
- Center for Biotechnology and Bioengineering (CeBiB), Department of Chemical Engineering, Biotechnology and Materials, Universidad de Chile, Beauchef 851, Santiago 8370459, Chile;
| | - Carolina Shene
- Center for Biotechnology and Bioengineering (CeBiB), Center of Food Biotechnology and Bioseparations, BIOREN and Department of Chemical Engineering, Universidad de La Frontera, Francisco Salazar 01145, Temuco 4780000, Chile; (L.F.); (C.S.)
| |
Collapse
|
45
|
Ceresa C, Fracchia L, Fedeli E, Porta C, Banat IM. Recent Advances in Biomedical, Therapeutic and Pharmaceutical Applications of Microbial Surfactants. Pharmaceutics 2021; 13:466. [PMID: 33808361 PMCID: PMC8067001 DOI: 10.3390/pharmaceutics13040466] [Citation(s) in RCA: 19] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/29/2021] [Revised: 03/18/2021] [Accepted: 03/23/2021] [Indexed: 12/19/2022] Open
Abstract
The spread of antimicrobial-resistant pathogens typically existing in biofilm formation and the recent COVID-19 pandemic, although unrelated phenomena, have demonstrated the urgent need for methods to combat such increasing threats. New avenues of research for natural molecules with desirable properties to alleviate this situation have, therefore, been expanding. Biosurfactants comprise a group of unique and varied amphiphilic molecules of microbial origin capable of interacting with lipidic membranes/components of microorganisms and altering their physicochemical properties. These features have encouraged closer investigations of these microbial metabolites as new pharmaceutics with potential applications in clinical, hygiene and therapeutic fields. Mounting evidence has indicated that biosurfactants have antimicrobial, antibiofilm, antiviral, immunomodulatory and antiproliferative activities that are exploitable in new anticancer treatments and wound healing applications. Some biosurfactants have already been approved for use in clinical, food and environmental fields, while others are currently under investigation and development as antimicrobials or adjuvants to antibiotics for microbial suppression and biofilm eradication strategies. Moreover, due to the COVID-19 pandemic, biosurfactants are now being explored as an alternative to current products or procedures for effective cleaning and handwash formulations, antiviral plastic and fabric surface coating agents for shields and masks. In addition, biosurfactants have shown promise as drug delivery systems and in the medicinal relief of symptoms associated with SARS-CoV-2 acute respiratory distress syndrome.
Collapse
Affiliation(s)
- Chiara Ceresa
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (E.F.); (C.P.)
| | - Letizia Fracchia
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (E.F.); (C.P.)
| | - Emanuele Fedeli
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (E.F.); (C.P.)
| | - Chiara Porta
- Department of Pharmaceutical Sciences, Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy; (C.C.); (E.F.); (C.P.)
- Center for Translational Research on Autoimmune & Allergic Diseases (CAAD), Università del Piemonte Orientale “A. Avogadro”, 28100 Novara, Italy
| | - Ibrahim M. Banat
- Pharmaceutical Science Research Group, Biomedical Science Research Institute, Ulster University, Coleraine, Northern Ireland BT52 1SA, UK;
| |
Collapse
|
46
|
|
47
|
Li Y, Chen Y, Tian X, Chu J. Advances in sophorolipid-producing strain performance improvement and fermentation optimization technology. Appl Microbiol Biotechnol 2020; 104:10325-10337. [PMID: 33097965 DOI: 10.1007/s00253-020-10964-7] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/03/2020] [Revised: 10/07/2020] [Accepted: 10/12/2020] [Indexed: 12/31/2022]
Abstract
Sophorolipids (SLs), currently one of the most promising biosurfactants, are secondary metabolites produced by many non-pathogenic yeasts, among which Candida bombicola ATCC 22214 is the main sophorolipid-producing strain. SLs have gained much attention since they exhibit anti-tumor, anti-bacterial, anti-inflammatory, and other beneficial biological activities. In addition, as biosurfactants, SLs have a low toxicity level and are easily degradable without polluting the environment. However, the production cost of SLs remains high, which hinders the industrialization process of SL production. This paper describes SL structure and the metabolic pathway of SL synthesis firstly. Furthermore, we analyze factors that contribute to the higher production cost of SLs and summarize current research status on the advancement of SL production based on two aspects: (1) the improvement of strain performance and (2) the optimization of fermentation process. Further prospects of lowering the cost of SL production are also discussed in order to achieve larger-scale SL production with a high yield at a low cost. KEY POINTS: • Review of advances in strain performance improvement and fermentation optimization. • High-throughput screening and metabolic engineering for high-performance strains. • Low-cost substrates and semi-continuous strategies for efficient SL production.
Collapse
Affiliation(s)
- Ya Li
- State Key Laboratory of Bioreactor Engineering, East China University of Science and Technology, P.O. Box 329, 130 Meilong Road, Shanghai, 200237, People's Republic of China
| | - Yang Chen
- State Key Laboratory of Bioreactor Engineering, East China University of Science and Technology, P.O. Box 329, 130 Meilong Road, Shanghai, 200237, People's Republic of China
| | - Xiwei Tian
- State Key Laboratory of Bioreactor Engineering, East China University of Science and Technology, P.O. Box 329, 130 Meilong Road, Shanghai, 200237, People's Republic of China.
| | - Ju Chu
- State Key Laboratory of Bioreactor Engineering, East China University of Science and Technology, P.O. Box 329, 130 Meilong Road, Shanghai, 200237, People's Republic of China.
| |
Collapse
|
48
|
Subramaniam MD, Venkatesan D, Iyer M, Subbarayan S, Govindasami V, Roy A, Narayanasamy A, Kamalakannan S, Gopalakrishnan AV, Thangarasu R, Kumar NS, Vellingiri B. Biosurfactants and anti-inflammatory activity: A potential new approach towards COVID-19. CURRENT OPINION IN ENVIRONMENTAL SCIENCE & HEALTH 2020; 17:72-81. [PMID: 33015428 PMCID: PMC7525250 DOI: 10.1016/j.coesh.2020.09.002] [Citation(s) in RCA: 30] [Impact Index Per Article: 7.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/05/2023]
Abstract
Coronavirus disease 2019 (COVID-19) has grown to be global public health emergency. The biosurfactants (BSs) are surface-active biomolecules with unique properties and wide applications. Several microbes synthesize secondary metabolites with surface-active properties, which have a wide range of anti-inflammatory and anti-viral roles. The monocytes and neutrophils are activated by bacteria, which subsequently result in high secretion of pro-inflammatory cytokines (TNF-α, IL-6, IL-8, IL-12, Il-18 and IL-1β) and toll-like receptors-2 (TLR-2). Following the inflammatory response, BSs induce the production of cationic proteins, reactive oxygen species (ROS) and lysozyme, and thus can be used for therapeutic purposes. This article provides recent advances in the anti-inflammatory and antiviral activities of BSs and discusses the potential use of these compounds against COVID-19, highlighting the need for in-vitro and in-vivo approaches to confirm this hypothesis. This suggestion is necessary because there are still no studies that have focused on the use of BSs against COVID-19.
Collapse
Affiliation(s)
- Mohana Devi Subramaniam
- SN ONGC Department of Genetics and Molecular Biology, Vision Research Foundation, Chennai, 600006, Tamil Nadu, India
| | - Dhivya Venkatesan
- Human Molecular Cytogenetics and Stem Cell Laboratory, Department of Human Genetics and Molecular Biology, Bharathiar University, Coimbatore, 641046, Tamil Nadu, India
| | - Mahalaxmi Iyer
- Department of Zoology, Avinashilingam Institute for Home Science and Higher Education for Women, Coimbatore, 641 043, Tamil Nadu, India
| | - Sarathbabu Subbarayan
- Department of Biotechnology, Mizoram University (A Central University), Aizawl, 796 004, Mizoram, India
| | | | - Ayan Roy
- Department of Biotechnology, Lovely Professional University, Punjab, 144411, India
| | - Arul Narayanasamy
- Disease Proteomics Laboratory, Department of Zoology, Bharathiar University, Coimbatore, 641 046, Tamil Nadu, India
| | - Siva Kamalakannan
- National Center for Disease Control, Ministry of Health and Family Welfare, Government of India, New Delhi, 110054, India
| | - Abilash Valsala Gopalakrishnan
- Department of Biomedical Sciences, School of Biosciences and Technology, Vellore Institute of Technology, Vellore, 632 014, Tamil Nadu, India
| | - Raviminickam Thangarasu
- School of Life Sciences, Department of Zoology, Tamil Nadu Open University, Chennai, Tamil Nadu, India
| | - Nachimuthu Senthil Kumar
- Department of Biotechnology, Mizoram University (A Central University), Aizawl, 796 004, Mizoram, India
| | - Balachandar Vellingiri
- Human Molecular Cytogenetics and Stem Cell Laboratory, Department of Human Genetics and Molecular Biology, Bharathiar University, Coimbatore, 641046, Tamil Nadu, India
| |
Collapse
|
49
|
Singh PK, Bohr SSR, Hatzakis NS. Direct Observation of Sophorolipid Micelle Docking in Model Membranes and Cells by Single Particle Studies Reveals Optimal Fusion Conditions. Biomolecules 2020; 10:E1291. [PMID: 32906821 PMCID: PMC7564020 DOI: 10.3390/biom10091291] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/25/2020] [Revised: 09/03/2020] [Accepted: 09/05/2020] [Indexed: 11/16/2022] Open
Abstract
Sophorolipids (SLs) are naturally produced glycolipids that acts as drug delivery for a spectrum of biomedical applications, including as an antibacterial antifungal and anticancer agent, where they induce apoptosis selectively in cancerous cells. Despite their utility, the mechanisms underlying their membrane interactions, and consequently cell entry, remains unknown. Here, we combined a single liposome assay to observe directly and quantify the kinetics of interaction of SL micelles with model membrane systems, and single particle studies on live cells to record their interaction with cell membranes and their cytotoxicity. Our single particle readouts revealed several repetitive docking events on individual liposomes and quantified how pH and membrane charges, which are known to vary in cancer cells, affect the docking of SL micelles on model membranes. Docking of sophorolipids micelles was found to be optimal at pH 6.5 and for membranes with -5% negatively charge lipids. Single particle studies on mammalian cells reveled a two-fold increased interaction on Hela cells as compared to HEK-293 cells. This is in line with our cell viability readouts recording an approximate two-fold increased cytotoxicity by SLs interactions for Hela cells as compared to HEK-293 cells. The combined in vitro and cell assays thus support the increased cytotoxicity of SLs on cancer cells to originate from optimal charge and pH interactions between membranes and SL assemblies. We anticipate studies combining quantitative single particle studies on model membranes and live cell may reveal hitherto unknown molecular insights on the interactions of sophorolipid and additional nanocarriers mechanism.
Collapse
Affiliation(s)
- Pradeep Kumar Singh
- Department of Chemistry & Nanoscience Center, University of Copenhagen, Thorvaldsensvej 40, C 1871 Frederiksberg, Denmark
- Department of Chemistry, University of Akron, Akron, OH 44325, USA
| | - Søren S-R Bohr
- Department of Chemistry & Nanoscience Center, University of Copenhagen, Thorvaldsensvej 40, C 1871 Frederiksberg, Denmark
- Novo Nordisk Center for Protein Research (CPR), University of Copenhagen, Blegdamsvej 3B, 2200 Copenhagen, Denmark
| | - Nikos S Hatzakis
- Department of Chemistry & Nanoscience Center, University of Copenhagen, Thorvaldsensvej 40, C 1871 Frederiksberg, Denmark
- Novo Nordisk Center for Protein Research (CPR), University of Copenhagen, Blegdamsvej 3B, 2200 Copenhagen, Denmark
| |
Collapse
|
50
|
Anestopoulos I, Kiousi DE, Klavaris A, Galanis A, Salek K, Euston SR, Pappa A, Panayiotidis MI. Surface Active Agents and Their Health-Promoting Properties: Molecules of Multifunctional Significance. Pharmaceutics 2020; 12:E688. [PMID: 32708243 PMCID: PMC7407150 DOI: 10.3390/pharmaceutics12070688] [Citation(s) in RCA: 30] [Impact Index Per Article: 7.5] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/30/2020] [Revised: 07/15/2020] [Accepted: 07/17/2020] [Indexed: 12/11/2022] Open
Abstract
Surface active agents (SAAs) are molecules with the capacity to adsorb to solid surfaces and/or fluid interfaces, a property that allows them to act as multifunctional ingredients (e.g., wetting and dispersion agents, emulsifiers, foaming and anti-foaming agents, lubricants, etc.) in a widerange of the consumer products of various industrial sectors (e.g., pharmaceuticals, cosmetics, personal care, detergents, food, etc.). Given their widespread utilization, there is a continuously growing interest to explore their role in consumer products (relevant to promoting human health) and how such information can be utilized in order to synthesize better chemical derivatives. In this review article, weaimed to provide updated information on synthetic and biological (biosurfactants) SAAs and their health-promoting properties (e.g., anti-microbial, anti-oxidant, anti-viral, anti-inflammatory, anti-cancer and anti-aging) in an attempt to better define some of the underlying mechanism(s) by which they exert such properties.
Collapse
Affiliation(s)
- Ioannis Anestopoulos
- Department of Molecular Biology & Genetics, Democritus University of Thrace, 68100 Alexandroupolis, Greece; (I.A.); (D.E.K.); (A.G.)
| | - Despoina Eugenia Kiousi
- Department of Molecular Biology & Genetics, Democritus University of Thrace, 68100 Alexandroupolis, Greece; (I.A.); (D.E.K.); (A.G.)
| | - Ariel Klavaris
- Department of Biological Sciences, University of Cyprus, 2109 Nicosia, Cyprus;
| | - Alex Galanis
- Department of Molecular Biology & Genetics, Democritus University of Thrace, 68100 Alexandroupolis, Greece; (I.A.); (D.E.K.); (A.G.)
| | - Karina Salek
- Institute of Mechanical, Process & Energy Engineering, Heriot Watt University, Edinburgh EH14 4AS, UK; (K.S.); (S.R.E.)
| | - Stephen R. Euston
- Institute of Mechanical, Process & Energy Engineering, Heriot Watt University, Edinburgh EH14 4AS, UK; (K.S.); (S.R.E.)
| | - Aglaia Pappa
- Department of Molecular Biology & Genetics, Democritus University of Thrace, 68100 Alexandroupolis, Greece; (I.A.); (D.E.K.); (A.G.)
| | - Mihalis I. Panayiotidis
- Department of Applied Sciences, Northumbria University, Newcastle Upon Tyne NE1 8ST, UK
- Department of Electron Microscopy & Molecular Pathology, The Cyprus Institute of Neurology & Genetics, 2371 Nicosia, Cyprus
- The Cyprus School of Molecular Medicine, P.O. Box 23462, 1683 Nicosia, Cyprus
| |
Collapse
|