Health effects of soy-biodiesel emissions: bioassay-directed fractionation for mutagenicity

Toxicity of different biodiesel exhausts in primary human airway epithelial cells grown at air-liquid interface

Biodiesel is created through the transesterification of fats/oils and its usage is increasing worldwide as global warming concerns increase. Biodiesel fuel properties change depending on the feedstock used to create it. The aim of this study was to assess the different toxicological properties of biodiesel exhausts created from different feedstocks using a complex 3D air-liquid interface (ALI) model that mimics the human airway. Primary human airway epithelial cells were grown at ALI until full differentiation was achieved. Cells were then exposed to 1/20 diluted exhaust from an engine running on Diesel (ULSD), pure or 20% blended Canola biodiesel and pure or 20% blended Tallow biodiesel, or Air for control. Exhaust was analysed for various physio-chemical properties and 24-h after exposure, ALI cultures were assessed for permeability, protein release and mediator response. All measured exhaust components were within industry safety standards. ULSD contained the highest concentrations of various combustion gases. We found no differences in terms of particle characteristics for any of the tested exhausts, likely due to the high dilution used. Exposure to Tallow B100 and B20 induced increased permeability in the ALI culture and the greatest increase in mediator response in both the apical and basal compartments. In contrast, Canola B100 and B20 did not impact permeability and induced the smallest mediator response. All exhausts but Canola B20 induced increased protein release, indicating epithelial damage. Despite the concentrations of all exhausts used in this study meeting industry safety regulations, we found significant toxic effects. Tallow biodiesel was found to be the most toxic of the tested fuels and Canola the least, both for blended and pure biodiesel fuels. This suggests that the feedstock biodiesel is made from is crucial for the resulting health effects of exhaust exposure, even when not comprising the majority of fuel composition.

Mutagenicity and carcinogenicity of combustion emissions are impacted more by combustor technology than by fuel composition: A brief review

Studies during the past 50 years have characterized the carcinogenicity and mutagenicity of extractable organic material (EOM) of particulate matter (PM) in ambient air and from combustion emissions. We have summarized conclusions from these studies and present data supporting those conclusions for 50 combustion emissions, including carcinogenic potencies on mouse skin (papillomas/mouse/mg EOM), mutagenic potencies (revertants/μg EOM) in the Salmonella (Ames) mutagenicity assay, and mutagenicity emission factors (revertants/kg fuel or revertants/MJ_thermal ) in Salmonella. Mutagenic potencies of EOM from PM in ambient air and combustion emissions span 1-2 orders of magnitude, respectively. In contrast, the revertants/m³ span >5 orders of magnitude due to variable PM concentrations in ambient air. Carcinogenic potencies of EOM from combustion emissions on mouse skin and EOM-associated human lung cancer risk from those emissions both span ~3 orders of magnitude and are highly associated. The ubiquitous presence of polycyclic aromatic hydrocarbons (PAHs), nitroarenes, and aromatic amines results in mutagenic and carcinogenic potencies of PM that span only 1-3 orders of magnitude; most PM induces primarily G to T mutations. Mutagenicity emission factors of combustion emissions span 3-5 orders of magnitude and correlate with PAH emission factors (r > 0.9). Mutagenicity emission factors were largely a function of how material was burned (highly efficient modern combustors versus open burning) rather than what materials were burned. Combustion systems that minimize kinetic and mass-transfer limitations and promote complete oxidation also minimize the mutagenicity of their emissions. This fundamental engineering principle can inform environmental and public health assessments of combustion emissions.

Chemistry, lung toxicity and mutagenicity of burn pit smoke-related particulate matter

BACKGROUND

Open burning of anthropogenic sources can release hazardous emissions and has been associated with increased prevalence of cardiopulmonary health outcomes. Exposure to smoke emitted from burn pits in military bases has been linked with respiratory illness among military and civilian personnel returning from war zones. Although the composition of the materials being burned is well studied, the resulting chemistry and potential toxicity of the emissions are not.

METHODS

Smoke emission condensates from either flaming or smoldering combustion of five different types of burn pit-related waste: cardboard; plywood; plastic; mixture; and mixture/diesel, were obtained from a laboratory-scale furnace coupled to a multistage cryotrap system. The primary emissions and smoke condensates were analyzed for a standardized suite of chemical species, and the condensates were studied for pulmonary toxicity in female CD-1 mice and mutagenic activity in Salmonella (Ames) mutagenicity assay using the frameshift strain TA98 and the base-substitution strain TA100 with and without metabolic activation (S9 from rat liver).

RESULTS

Most of the particles in the smoke emitted from flaming and smoldering combustion were less than 2.5 µm in diameter. Burning of plastic containing wastes (plastic, mixture, or mixture/diesel) emitted larger amounts of particulate matter (PM) compared to other types of waste. On an equal mass basis, the smoke PM from flaming combustion of plastic containing wastes caused more inflammation and lung injury and was more mutagenic than other samples, and the biological responses were associated with elevated polycyclic aromatic hydrocarbon levels.

CONCLUSIONS

This study suggests that adverse health effects of burn pit smoke exposure vary depending on waste type and combustion temperature; however, burning plastic at high temperature was the most significant contributor to the toxicity outcomes. These findings will provide a better understanding of the complex chemical and combustion temperature factors that determine toxicity of burn pit smoke and its potential health risks at military bases.

Fuel feedstock determines biodiesel exhaust toxicity in a human airway epithelial cell exposure model

BACKGROUND

Biodiesel is promoted as a sustainable replacement for commercial diesel. Biodiesel fuel and exhaust properties change depending on the base feedstock oil/fat used during creation. The aims of this study were, for the first time, to compare the exhaust exposure health impacts of a wide range of biodiesels made from different feedstocks and relate these effects with the corresponding exhaust characteristics.

METHOD

Primary airway epithelial cells were exposed to diluted exhaust from an engine running on conventional diesel and biodiesel made from Soy, Canola, Waste Cooking Oil, Tallow, Palm and Cottonseed. Exhaust properties and cellular viability and mediator release were analysed post exposure.

RESULTS

The exhaust physico-chemistry of Tallow biodiesel was the most different to diesel as well as the most toxic, with exposure resulting in significantly decreased cellular viability (95.8 ± 6.5%) and increased release of several immune mediators including IL-6 (+223.11 ± 368.83 pg/mL) and IL-8 (+1516.17 ± 2908.79 pg/mL) above Air controls. In contrast Canola biodiesel was the least toxic with exposure only increasing TNF-α (4.91 ± 8.61).

CONCLUSION

This study, which investigated the toxic effects for the largest range of biodiesels, shows that exposure to different exhausts results in a spectrum of toxic effects in vitro when combusted under identical conditions.

Elevated urinary mutagenicity among those exposed to bituminous coal combustion emissions or diesel engine exhaust

Urinary mutagenicity reflects systemic exposure to complex mixtures of genotoxic/carcinogenic agents and is linked to tumor development. Coal combustion emissions (CCE) and diesel engine exhaust (DEE) are associated with cancers of the lung and other sites, but their influence on urinary mutagenicity is unclear. We investigated associations between exposure to CCE or DEE and urinary mutagenicity. In two separate cross-sectional studies of nonsmokers, organic extracts of urine were evaluated for mutagenicity levels using strain YG1041 in the Salmonella (Ames) mutagenicity assay. First, we compared levels among 10 female bituminous (smoky) coal users from Laibin, Xuanwei, China, and 10 female anthracite (smokeless) coal users. We estimated exposure-response relationships using indoor air concentrations of two carcinogens in CCE relevant to lung cancer, 5-methylchrysene (5MC), and benzo[a]pyrene (B[a]P). Second, we compared levels among 20 highly exposed male diesel factory workers and 15 unexposed male controls; we evaluated exposure-response relationships using elemental carbon (EC) as a DEE-surrogate. Age-adjusted linear regression was used to estimate associations. Laibin smoky coal users had significantly higher average urinary mutagenicity levels compared to smokeless coal users (28.4 ± 14.0 SD vs. 0.9 ± 2.8 SD rev/ml-eq, p = 2 × 10-5 ) and a significant exposure-response relationship with 5MC (p = 7 × 10-4 ). DEE-exposed workers had significantly higher urinary mutagenicity levels compared to unexposed controls (13.0 ± 10.1 SD vs. 5.6 ± 4.4 SD rev/ml-eq, p = .02) and a significant exposure-response relationship with EC (p-trend = 2 × 10-3 ). Exposure to CCE and DEE is associated with urinary mutagenicity, suggesting systemic exposure to mutagens, potentially contributing to cancer risk and development at various sites.

Zebrafish irritant responses to wildland fire-related biomass smoke are influenced by fuel type, combustion phase, and byproduct chemistry

Human exposure to wildfire-derived particulate matter (PM) is linked to adverse health outcomes; however, little is known regarding the influence of biomass fuel type and burn conditions on toxicity. The aim of this study was to assess the irritant potential of extractable organic material (EOM) of biomass smoke condensates from five fuels (eucalyptus, pine, pine needle, peat, or red oak), representing various fire-prone regions of the USA, burned at two temperatures each [flaming (approximately 640°C) or (smoldering approximately 500°C)] using a locomotor assay in zebrafish (Danio rerio) larvae. It was postulated that locomotor responses, as measures of irritant effects, might be dependent upon fuel type and burn conditions and that these differences relate to combustion byproduct chemistry. To test this, locomotor activity was tracked for 60 min in 6-day-old zebrafish larvae (25-32/group) immediately after exposure to 0.4% dimethyl sulfoxide (DMSO) vehicle or EOM from the biomass smoke condensates (0.3-30 µg EOM/ml; half-log intervals). All EOM samples produced concentration-dependent irritant responses. Linear regression analysis to derive rank-order potency indicated that on a µg PM basis, flaming pine and eucalyptus were the most irritating. In contrast, on an emission-factor basis, which normalizes responses to the amount of PM produced/kg of fuel burned, smoldering smoke condensates induced greater irritant responses (>100-fold) than flaming smoke condensates, with smoldering pine being the most potent. Importantly, irritant responses significantly correlated with polycyclic aromatic hydrocarbon (PAH) content, but not with organic carbon or methoxyphenols. Data indicate that fuel type and burn condition influence the quantity and chemical composition of PM as well as toxicity.

In vitro evaluation of the cytotoxicity, mutagenicity and DNA damage induced by particle matter and gaseous emissions from a medium-duty diesel vehicle under real driving conditions using palm oil biodiesel blends

The influence of palm oil biodiesel content on the cytotoxicity, mutagenicity and genotoxicity of particle- and gas-phase diesel vehicle emissions was investigated. The emissions were collected on-board of a EURO IV diesel truck, fuelled with mixtures of 10% (B10), 20% (B20) and 100% (B100) of palm oil biodiesel, under real driving conditions. Organic extracts of the particulate matter (PM) and gases were characterised for 17 PAH (including EPA priority) and used for the biological assay. Increasing biodiesel content in the fuel mixture results in a decrease in the PM and PAH emission factors, both in the particulate and gas-phase. The majority of the PAH are present in the gas-phase. The mutagenic potencies, in TA98 bacteria, are higher for B20 in both phases, whereas the mutagenicity emission factor, that takes into account the lower emission of PM and PAH, is not significantly different between the fuels. Higher direct mutagenicity (TA98 + S9) is observed in all the tested fuels, indicating the action of carcinogenic compounds other than non-substituted PAH. The gas-phase extracts present higher cytotoxicity and genotoxicity in lung epithelial cell A549, which may be related to the higher PAH content in the gas-phase. The increase in biodiesel content have a different impact on cytotoxicity, being larger in the gas-phase and lower in the particle-phase. This indicates that pulmonary toxicity may be higher for the gaseous emissions, due to the role of different toxic compounds compared to the PM. The adverse biological effects when biodiesel content increases are not consequent with the reduction of the PAH characterised, indicating that other toxic compounds are more relevant. Further investigations to identify these compounds are required in order to update and focus the efforts regarding emission targets and controls.

Inflammation, oxidative stress and genotoxicity responses to biodiesel emissions in cultured mammalian cells and animals

Biodiesel fuels are alternatives to petrodiesel, especially in the transport sector where they have lower carbon footprint. Notwithstanding the environmental benefit, biodiesel fuels may have other toxicological properties than petrodiesel. Particulate matter (PM) from petrodiesel causes cancer in the lung as a consequence of delivery of genotoxic polycyclic aromatic hydrocarbons, oxidative stress and inflammation. We have reviewed articles from 2002 to 2019 (50% of the articles since 2015) that have described toxicological effects in terms of genotoxicity, oxidative stress and inflammation of biodiesel exhaust exposure in humans, animals and cell cultures. The studies have assessed first generation biodiesel from different feedstock (e.g. rapeseed and soy), certain second generation fuels (e.g. waste oil), and hydrogenated vegetable oil. It is not possible to rank the potency of toxicological effects of specific biodiesel fuels. However, exposure to biodiesel exhaust causes oxidative stress, inflammation and genotoxicity in cell cultures. Three studies in animals have not indicated genotoxicity in lung tissue. The database on oxidative stress and inflammation in animal studies is larger (13 studies); ten studies have reported increased levels of oxidative stress biomarkers or inflammation, although the effects have been modest in most studies. The cell culture and animal studies have not consistently shown a different potency in effect between biodiesel and petrodiesel exhausts. Both increased and decreased potency have been reported, which might be due to differences in feedstock or combustion conditions. In conclusion, combustion products from biodiesel and petrodiesel fuel may evoke similar toxicological effects on genotoxicity, oxidative stress and inflammation.

Soy Biodiesel Exhaust is More Toxic than Mineral Diesel Exhaust in Primary Human Airway Epithelial Cells

As global biodiesel production increases, there are concerns over the potential health impact of exposure to the exhaust, particularly in regard to young children who are at high risk because of their continuing lung development. Using human airway epithelial cells obtained from young children, we compared the effects of exposure to exhaust generated by a diesel engine with Euro V/VI emission controls running on conventional diesel (ultra-low-sulfur mineral diesel, ULSD), soy biodiesel (B100), or a 20% blend of soy biodiesel with diesel (B20). The exhaust output of biodiesel was found to contain significantly more respiratory irritants, including NO_x, CO, and CO₂, and a larger overall particle mass. Exposure to biodiesel exhaust resulted in significantly greater cell death and a greater release of immune mediators compared to both air controls and ULSD exhaust. These results have concerning implications for potential global health impacts, particularly for the pediatric population.

Comparative mutagenic activity of atmospheric particulate matter from limeira, stockholm, and kyoto

Atmospheric particulate matter (PM) organic fractions from urban centers are frequently mutagenic for the Salmonella/microsome assay. This mutagenicity is related to both primary and secondary pollutants, and meteorological conditions have great influence on the secondary pollutant's formation. Our objective was to compare the mutagenicity of atmospheric total suspended particulates (TSP) from three cities with marked different meteorological conditions and TSP concentrations: Limeira (Brazil) with 99.0 μg/m³ , Stockholm (Sweden) with 6.2 μg/m³ , and Kyoto (Japan) with 28.0 μg/m³ . For comparison, we used the same batch of filters, sample extraction method, and Salmonella/microsome testing protocol with 11 strains of Salmonella with and without metabolic activation. Samples were collected during winter and pooled into one single extract representing each city. All samples were mutagenic for all tested strains, except for TA102. Based on the strain's selectivity, nitroarenes, polycyclic aromatic hydrocarbons, and aromatic amines play a predominant role in the mutagenicity of these samples. The mutagenic potencies expressed by mass of extracted organic material (EOM; revertants/μg EOM) were similar (~twofold difference) among the cities, despite differences in meteorological conditions and pollution sources. In contrast, the mutagenic potencies expressed by air volume (rev/m³ ) varied ~20-fold, with Limeira > Kyoto ≈ Stockholm. These results are the first systematic assessment of air mutagenicity from cities on three continents using the same protocols. The results confirm that the mutagenic potency expressed by EOM mass is similar regardless of continent of origin, whereas the mutagenic potency expressed by air volume can vary by orders of magnitude. Environ. Mol. Mutagen. 2019. © 2019 Wiley Periodicals, Inc.

Mutagenicity emission factors of canola oil and waste vegetable oil biodiesel: Comparison to soy biodiesel

Canola (or rapeseed) oil and waste vegetable oil (WVO) are used commonly to make biodiesel fuels composed completely from these oils (B100) or as blends with petroleum diesel (B0). However, no studies have reported the mutagenic potencies of the particulate matter with diameter ≤2.5 μm (PM_2.5) or the mutagenicity emission factors, such as revertants/MJ_thermal (rev/MJ_th) for these biodiesel emissions. Using strains TA98 and TA100 with the Salmonella (Ames) mutagenicity assay, we determined these metrics for organic extracts of PM_2.5 of emissions from biodiesel containing 5% soy oil (soy B5); 5, 20, 50, and 100% canola (canola B5, B20, B50, B100), and 100% waste vegetable oil (WVO B100). The mutagenic potencies (rev/mg PM_2.5) of the canola B100 and WVO B100 emissions were generally greater than those of B0, whereas the mutagenicity emission factors (rev/MJ_th, rev/kg fuel, and rev/m³) were less, reflecting the lower PM emissions of the biodiesels relative to B0. Nearly all the rev/mg PM_2.5 and rev/MJ_th values were greater in TA98 with S9 than without S9, indicating a relatively greater role for polycyclic aromatic hydrocarbons, which require S9, than nitroarenes, which do not. In TA100 -S9, the rev/mg PM_2.5 and rev/MJ_th for the biodiesels were generally ≥ to those of B0, indicating that most of these biodiesels produced more direct-acting, base-substitution mutagenic activity than did B0. For B100 biodiesels and petroleum diesel, the rev/MJ_th in TA98 + S9 ranked: petroleum diesel > canola > WVO > soy. The diesel emissions generally had rev/MJ_th values orders of magnitude higher than those of large utility-scale combustors (natural gas, coal, oil, or wood) but orders of magnitude lower than those of inefficient open burning (e.g., residential wood fireplaces). These comparative data of the potential health effects of a variety of biodiesel fuels will help inform the life-cycle assessment and use of biodiesel fuels.

Mutagenicity and Cytotoxicity of Particulate Matter Emitted from Biodiesel-Fueled Engines

Biodiesel engines produce several intermediate species, which can potentially harm the human health. The concentration of these species and their health risk potential varies depending on engine technology, fuel, and engine operating condition. In this study, experiments were performed on a large number of engines having different configurations (emissions norms/fuel used), which were operated at part load/full load using B20 (20% v/v biodiesel blended with mineral diesel) and mineral diesel. Experiments included measurement of gaseous emissions, and physical, chemical, and biological characterization of exhaust particulate matter (PM). Chemical characterization of PM was carried out for detecting polycyclic aromatic hydrocarbons (PAH's) and PM bound trace metals. The biological toxicity associated with PM was assessed using human embryonic kidney 293T cells (HEK 293T). The mutagenic potential of the PM was tested at three different concentrations (500, 100, and 50 μg/mL) using two different  Salmonella strains, TA98 and TA100, with and without liver S9 metabolic enzyme fraction. PM samples exhibited cytotoxic effect on HEK 293T cells (IC₅₀ < 100 μg/mL) and there was significant potential for reactive oxygen species (ROS) generation. Comparison of different engines showed that modern engines (Euro-III and Euro-IV compliant) produced relatively cleaner exhaust compared to older engines (Euro-II compliant). Biodiesel-fueled engines emitted lower number of particles compared to diesel-fueled engines. However, chemical characterization revealed that biodiesel-fueled engines exhaust PM contained several harmful PAHs and trace metals, which affected the biological activity of these PM, as reflected in the biological investigations. Mutagenicity and cytotoxicity of PM from biodiesel-fueled engines were relatively higher compared to their diesel counterparts, indicating the need for exhaust gas after-treatment.

Mutagenicity and Lung Toxicity of Smoldering vs. Flaming Emissions from Various Biomass Fuels: Implications for Health Effects from Wildland Fires

BACKGROUND

The increasing size and frequency of wildland fires are leading to greater potential for cardiopulmonary disease and cancer in exposed populations; however, little is known about how the types of fuel and combustion phases affect these adverse outcomes.

OBJECTIVES

We evaluated the mutagenicity and lung toxicity of particulate matter (PM) from flaming vs. smoldering phases of five biomass fuels, and compared results by equal mass or emission factors (EFs) derived from amount of fuel consumed.

METHODS

A quartz-tube furnace coupled to a multistage cryotrap was employed to collect smoke condensate from flaming and smoldering combustion of red oak, peat, pine needles, pine, and eucalyptus. Samples were analyzed chemically and assessed for acute lung toxicity in mice and mutagenicity in Salmonella.

RESULTS

The average combustion efficiency was 73 and 98% for the smoldering and flaming phases, respectively. On an equal mass basis, PM from eucalyptus and peat burned under flaming conditions induced significant lung toxicity potencies (neutrophil/mass of PM) compared to smoldering PM, whereas high levels of mutagenicity potencies were observed for flaming pine and peat PM compared to smoldering PM. When effects were adjusted for EF, the smoldering eucalyptus PM had the highest lung toxicity EF (neutrophil/mass of fuel burned), whereas smoldering pine and pine needles had the highest mutagenicity EF. These latter values were approximately 5, 10, and 30 times greater than those reported for open burning of agricultural plastic, woodburning cookstoves, and some municipal waste combustors, respectively.

CONCLUSIONS

PM from different fuels and combustion phases have appreciable differences in lung toxic and mutagenic potency, and on a mass basis, flaming samples are more active, whereas smoldering samples have greater effect when EFs are taken into account. Knowledge of the differential toxicity of biomass emissions will contribute to more accurate hazard assessment of biomass smoke exposures. https://doi.org/10.1289/EHP2200.

A paler shade of green? The toxicology of biodiesel emissions: Recent findings from studies with this alternative fuel

BACKGROUND

Biodiesel produced primarily from plants and algal feedstocks is believed to have advantages for production and use compared to petroleum and to some other fuel sources. There is some speculation that exposure to biodiesel combustion emissions may not induce biological responses or health effects or at a minimum reduce the effects relative to other fuels. In evaluating the overall environmental and health effects of biodiesel production to end use scenario, empirical data or modeling data based on such data are needed.

SCOPE OF REVIEW

This manuscript examines the available toxicology reports examining combustion derived biodiesel emissions since approximately 2007, when our last review of the topic occurred. Toxicity derived from other end uses of biodiesel - e.g., spills, dermal absorption, etc. - are not examined. Findings from biodiesel emissions are roughly divided into three areas: whole non-human animal model exposures; in vitro exposures of mammalian and bacterial cells (used for mutation studies primarily); and human exposures in controlled or other exposure fashions.

MAJOR CONCLUSIONS

Overall, these more current studies clearly demonstrate that biodiesel combustion emission exposure- to either 100% biodiesel or a blend in petroleum diesel- can induce biological effects. There are reports that show biodiesel exposure generally induces more effects or a greater magnitude of effect than petroleum diesel, however there are also a similar number of reports showing the opposite trend. It is unclear whether effects induced by exposure to a blend are greater than exposure to 100% biodiesel. Taken together, the evidence suggest biodiesel emissions can have some similar effects as diesel emissions on inflammatory, vascular, mutagenic, and other responses.

GENERAL SIGNIFICANCE

While acute biodiesel exposures can show toxicity with a variety of endpoints, the potential effects on human health need further validation. Additionally there are few or no findings to date on whether biodiesel emissions can induce effects or even a weaker response that petroleum diesel with repeated exposure scenarios such as in an occupational setting. This article is part of a Special Issue entitled Air Pollution, edited by Wenjun Ding, Andrew J. Ghio and Weidong Wu.

Comparative toxicity and mutagenicity of soy-biodiesel and petroleum-diesel emissions: overview of studies from the U.S. EPA, Research Triangle Park, NC

Biodiesel use as a fuel is increasing globally as an alternate to petroleum sources. To comprehensively assess the effects of the use of biodiesel as an energy source, end stage uses of biodiesel such as the effects of inhalation of combusted products on human health must be incorporated. To date, few reports concerning the toxicological effects of the emissions of combusted biodiesel or blends of biodiesel on surrogates of health effects have been published. The relative toxicity of the combusted biodiesel emissions compared to petroleum diesel emissions with short term exposures is also not well known. To address the paucity of findings on the toxicity of combusted biodiesel emissions, studies were undertaken at the U.S. Environmental Protection Agency laboratories in Research Triangle Park, North Carolina. The studies used a variety of approaches with nonhuman animal models to examine biological responses of the lung and cardiovascular systems induced by acute and repeated exposures to pure biodiesel and biodiesel blended with petroleum diesel. Effects of the emissions on induction of mutations in bacterial test strains and mammalian DNA adducts were also characterized and normalized to engine work load. The emissions were characterized as to the physicochemical composition in order to determine the magnitude of the differences among the emissions utilized in the studies. This article summarizes the major finding of these studies which are contained within this special issue of Inhalation Toxicology. The findings provided in these articles provide information about the toxicity of biodiesel emissions relative to petroleum diesel emissions and which can be utilized in a life cycle analyses of the effects of increased biodiesel usage.

Health effects of soy-biodiesel emissions: mutagenicity-emission factors

CONTEXT

Soy biodiesel is the predominant biodiesel fuel used in the USA, but only a few, frequently conflicting studies have examined the potential health effects of its emissions.

OBJECTIVE

We combusted petroleum diesel (B0) and fuels with increasing percentages of soy methyl esters (B20, B50 and B100) and determined the mutagenicity-emission factors expressed as revertants/megajoule of thermal energy consumed (rev/MJ(th)).

MATERIALS AND METHODS

We combusted each fuel in replicate in a small (4.3-kW) diesel engine without emission controls at a constant load, extracted organics from the particles with dichloromethane, determined the percentage of extractable organic material (EOM), and evaluated these extracts for mutagenicity in 16 strains/S9 combinations of Salmonella.

RESULTS

Mutagenic potencies of the EOM did not differ significantly between replicate experiments for B0 and B100 but did for B20 and B50. B0 had the highest rev/MJ(th), and those of B20 and B100 were 50% and ∼85% lower, respectively, in strains that detect mutagenicity due to polycyclic aromatic hydrocarbons (PAHs), nitroarenes, aromatic amines or oxidative mutagens. For all strains, the rev/MJ(th) decreased with increasing biodiesel in the fuel. The emission factor for the 16 EPA Priority PAHs correlated strongly (r(2 )= 0.69) with the mutagenicity-emission factor in strain TA100 + S9, which detects PAHs.

CONCLUSIONS

Under a constant load, soy-biodiesel emissions were 50-85% less mutagenic than those of petroleum diesel. Without additional emission controls, petroleum and biodiesel fuels had mutagenicity-emission factors between those of large utility-scale combustors (e.g. natural gas, coal, or oil) and inefficient open-burning (e.g. residential wood fireplaces).