Effects of different hypochlorite types on the waste activated sludge fermentation from the perspectives of volatile fatty acids production, microbial community and activity, and characteristics of fermented sludge

Upcycling harmful algal blooms into short-chain organic matters assisted with cellulose-based flocculant

Upcycling harmful algal blooms (HABs) into short-chain organic matters (SCOMs) presents a significantly underexplored opportunity for addressing environmental concerns and achieving circular economy. But there are challenges of low HABs harvesting and SCOMs conversion efficiencies. To address these issues, a novel cellulose-based flocculant derived from abundant agricultural waste (wheat straw) was developed. This flocculant possesses high surface positive charge to aggregate negatively charged microalgae cells via charge neutralization mechanism, resulting in HABs harvesting efficiency of 97 %. Moreover, the flocculant can serve as a carbon to nitrogen (C/N) regulator to optimize the harvested slurry properties for downstream fermentation. Following hydrothermal pretreatment for one hour, the HABs-flocculant slurry was effectively converted into SCOMs with a total energy output of 64.3 kJ/L and energy conversion efficiency of 67 %, in which SCOMs was major contributor (92 %). This work may inspire eco-friendly and cost-effective approach for HABs disposal with extra benefits of SCOMs production.

Novel calcium hypochlorite/ferrous iron as an ultrafiltration membrane pretreatment process for purifying algae-laden water

Algal fouling has become one of the most critical factors hindering the large-scale development of membrane processes in algae-laden water treatment. Herein, novel calcium hypochlorite (Ca(ClO)2)/ferrous iron (Fe(II)) process was proposed as an ultrafiltration (UF) membrane pretreatment technology, and its effects on membrane fouling and water properties were systematically studied. Results showed that the terminal specific fluxes were significantly elevated to 0.925 and 0.933, with the maximum removal ratios of reversible resistance reaching 99.65% and 96.99% for algae-laden water and extracellular organic matter (EOM), respectively. The formation of cake filtration was dramatically delayed, accompanied by a significant reduction of the adhesion free energy, and the contaminants attached to the membrane surface were effectively decomposed. With respect to water quality, the removal ratios of OD685 and turbidity achieved 81.25-95.31% and 90.16-97.72%, individually. The maximum removal rates of DOC, UV254 and fluorescent organics in influent water reached 46.14%, 55.17% and 75.77%, respectively. Furthermore, the generated reactive species (e.g., •OH, Cl•, Cl2•- and ClO•) could efficiently degrade EOM, which appreciably reduced the electrostatic repulsion between the algal foulants while ensuring the integrity of algal cells. At the Ca(ClO)2/Fe(II) dosage of 0.04/0.24 mM, the zeta potential changed from -32.9 mV to -10.8 mV, and a large range of aggregates was formed. The macromolecules in the algal solution were significantly removed, and the proportion of micromolecular organics was increased to some extent. Coagulation of in-situ formed Fe(III) dominated the membrane fouling mitigation, and the reactive species also contributed to the improvement of filtration performance. Overall, Ca(ClO)2/Fe(II) pretreatment has an exceptional prospect for efficient degradation of algal pollutants and enhancement of UF capability.

Surfactant and antibiotic co-occurrence reshaped the acidogenic process for volatile fatty acids production during sludge anaerobic fermentation

The overuse of surfactants and antibiotics has led to their high concentration in waste activated sludge (WAS), and these exogenous pollutants have been shown to pose various influences on the subsequent anaerobic treatment process. Previous works have primarily concerned the impacts of individual pollutants on WAS anaerobic fermentation process. This work revealed the synergetic effects of sodium dodecyl benzene sulfonate (SDBS) and sulfadiazine (SDZ) co-occurrence in WAS on the biosynthesis of volatile fatty acids (VFAs). The addition of SDBS in the SDZ reactor significantly increased VFAs generation, and this increase was correlated with the concentration of SDZ. The VFAs production exhibited a 200.0-211.9 % and 5.9-20.4 % increase in comparison with the sole SDZ and SDBS reactor, respectively. The SDBS and SDZ co-occurrence facilitated the solubilization, hydrolysis, and acidification stages of WAS fermentation synchronously. SDBS was effectively to disintegrate the cemented structure of extracellular polymeric substances and meanwhile improve the SDZ solubilization, which increase the SDZ bioavailability as well as biotoxicity to the anaerobic species. Herein, the anaerobic consortia structure was evidently reshaped, and the keystone microbes Acetoanaerobium and Fususibacter, as well-tolerated hydrolytic-acidogenic bacteria, were greatly enriched. Furthermore, the functional microbial metabolic traits responsible for the substrate extracellular hydrolysis (e.g., glsA and MAN2C1), intracellular metabolism (e.g., ALDO and asdA), and fatty acid generation (e.g., aarC) were all upregulated in the SDBS/SDZ co-occurrence reactor.

Effect of different types of volatile fatty acids on the performance and bacterial population in a batch reactor performing biological nutrient removal

Different ratios of four volatile fatty acids (VFAs) were used as the primary feed to a laboratory scale biological nutrient reactor during four operational stages. The reactor performed efficiently over 500 days of operation with over 90% dissolved phosphorus and over 98% ammonium-nitrogen (NH4+-N) removal. Through in the first experimental phase, acetate and propionate were present in a significant proportion as carbon sources, the relative abundance of Candidatus Accumulibacter, a potential polyphosphate accumulating organism, increased from 10% to 57% and the Defluviicoccus genus, a known glycogen accumulating organism (GAO), decreased from 41% to 5%. Further tests indicated the presence of denitrifying phosphorus accumulating organisms (DPAO) belonging to Clade IIC, that could use nitrite as the electron acceptor during P-uptake. In general, VFAs favored the increase of the genus Defluviicoccus and Candidatus Accumulibacter. High relative abundance of Defluviicoccus did not affect the stability and the performance of the BNR process.

Wastewater reuse in agriculture: Prospects and challenges

Sustainable water recycling and wastewater reuse are urgent nowadays considering water scarcity and increased water consumption through human activities. In 2015, United Nations Sustainable Development Goal 6 (UN SDG6) highlighted the necessity of recycling wastewater to guarantee water availability for individuals. Currently, wastewater irrigation (WWI) of crops and agricultural land appears essential. The present work overviews the quality of treated wastewater in terms of soil microbial activities, and discusses challenges and benefits of WWI in line with wastewater reuse in agriculture and aquaculture irrigation. Combined conventional-advanced wastewater treatment processes are specifically deliberated, considering the harmful impacts on human health arising from WWI originating from reuse of contaminated water (salts, organic pollutants, toxic metals, and microbial pathogens i.e., viruses and bacteria). The comprehensive literature survey revealed that, in addition to the increased levels of pathogen and microbial threats to human wellbeing, poorly-treated wastewater results in plant and soil contamination with toxic organic/inorganic chemicals, and microbial pathogens. The impact of long-term emerging pollutants like plastic nanoparticles should also be established in further studies, with the development of standardized analytical techniques for such hazardous chemicals. Likewise, the reliable, long-term and extensive judgment on heavy metals threat to human beings's health should be explored in future investigations.

Anaerobic fermentation of organic solid waste: Recent updates in substrates, products, and the process with multiple products co-production

The effective conversion and recycling of organic solid waste contribute to the resolution of widespread issues such as global environmental pollution, energy scarcity and resource depletion. The anaerobic fermentation technology provides for the effective treatment of organic solid waste and the generation of various products. The analysis, which is based on bibliometrics, concentrates on the valorisation of affordable and easily accessible raw materials with high organic matter content as well as the production of clean energy substances and high value-added platform products. The processing and application status of fermentation raw materials such as waste activated sludge, food waste, microalgae and crude glycerol are investigated. To analyse the status of the preparation and engineering applications of the products, the fermentation products biohydrogen, VFAs, biogas, ethanol, succinic acid, lactic acid, and butanol are employed as representatives. Simultaneously, the anaerobic biorefinery process with multiple product co-production is sorted out. Product co-production can reduce waste discharge, enhance resource recovery efficiency, and serve as a model for improving anaerobic fermentation economics.

Ultrasonic-assisted hypochlorite activation accelerated volatile fatty acids production during sewage sludge fermentation: Critical insights on solubilization/hydrolysis stages and microbial traits

The effective disruption of extracellular polymeric substances using appropriate pretreatment is critical to achieving resource recovery from sewage sludge (SS) by anaerobic fermentation. This work proposed an ultrasonic-assisted hypochlorite activation strategy for enhanced production of volatile fatty acids (VFAs) during SS fermentation. The results demonstrated that after individual ultrasonic and hypochlorite pretreatment, the maximum VFAs yield improved by 8 and 107% with that in control, respectively, while a combination of both techniques led to an improvement of 119%, indicating their synergistic effects on SS fermentation. This method enhanced the solubilization and hydrolysis efficiencies and contributed to the increased biodegradable substrates, which would be beneficial in enhancing microbial activity for VFAs production. The functional anaerobes, metabolic pathways, and gene expressions involved in VFAs biosynthesis were effectively improved. This work would bring a novel insight into the disposal of municipal solid waste for resource recovery.

Anaerobic fermentation of aerobic granular sludge: Insight into the effect of granule size and sludge structure on hydrolysis and acidification

Aerobic granular sludge (AGS) has different physicochemical properties and microbial communities compared to conventional activated sludge (CAS), which may result in different behaviors during anaerobic fermentation and require further investigation. This study investigated the effect of granule size and sludge structure on the hydrolysis and acidification of AGS. Experimental results show that AGS exhibited significantly higher soluble chemical oxygen demand (SCOD) dissolution and total volatile fatty acids (TVFA) production (330.6-430.3 mg/gVSS and 231.0-312.5 mgCOD/gVSS) compared to conventional activated sludge (CAS) (167.0 mg/gVSS and 133.3 mgCOD/gVSS). This is because AGS (90.6-96.9 mg/gVSS) had higher extracellular polymeric substances (EPS) content than CAS (81.2 mg/gVSS). EPS can not only serve as substrates but also release the trapped hydrolases. Moreover, the relative abundances of hydrolytic/acidogenic bacteria and genes were higher in AGS (0.46%-3.60% and 3.01 × 10^-3%-4.04 × 10^-3%) than in CAS (0.30% and 1.23 × 10^-3%). The optimal granule size for AGS fermentation was found to be 500-1600 μm. The crushing of granule structure promoted the dissolution of small amounts of EPS and the release of some trapped hydrolases, thereby potentially enhancing the enzyme-substrate contacts and bacteria-substrate interactions. Therefore, the highest SCOD dissolution (510.6 mg/gVSS) and TVFA production (352.1 mgCOD/gVSS) from crushed 500-1600 μm AGS were observed. Overall, the findings of this study provide valuable insights into the recovery of organic carbon from AGS via anaerobic fermentation.

Performance and mechanism of microbial fuel cell coupled with anaerobic membrane bioreactor system for fouling control

To remove membrane fouling, a bio-electrochemical system that can generate a micro-electric field and micro-current was constructed. After 11 days of operation, the trans-membrane pressure difference of membrane modules in the open- and closed-circuit groups increased by 35.8 kPa and 6.2 kPa, respectively. The concentrations of total polysaccharide and protein in the open-circuit group were 1.8 and 1.1 times higher than those in the closed-circuit group, respectively. In addition, X-ray photoelectron spectroscopy and thermogravimetric analysis showed that inorganic crystals such as calcium carbonate were present on the membrane surface, and the concentration of calcium ion in the control group was 14.7 times that of the experimental group. High-throughput sequencing demonstrated that the enrichment of some electroactive bacteria and other microorganisms has a positive effect on the control of membrane fouling. Therefore, this system can effectively alleviate membrane fouling of a bioreactor, by targeting the membrane foulants.

In-situ sulfite treatment enhanced the production of short-chain fatty acids from waste activated sludge in the side-stream anaerobic fermentation

Sulfite-based technology could enhance methane production from anaerobic sludge digestion. However, its potential for in-situ direct sludge treatment without anaerobic sludge addition in the side-stream remains unclear. This study investigated the feasibility of using in-situ sulfite treating sludge for short-chain fatty acids (SCFAs) production via anaerobic fermentation of waste activated sludge (WAS) as a side-stream treatment. In-situ sulfite direct sludge treatment enhanced SCFAs and acetic acid production by 2.03 and 4.89 times at 500 mg S/L compared to the control. With in-situ sulfite treatment, WAS hydrolysis and acidification were enhanced while methanogenesis was spontaneously hindered. The in-situ sulfite treatment inactivated pathogens and improved the sludge dewatering properties. The relative abundances of SCFAs-production microbial were stimulated, facilitating the sludge bioconversion. The produced SCFAs from in-situ sulfite side-stream treatment could be applied as an "internal carbon source" to enhance biological nutrient removal to improve economic and environmental value from sludge treatment.

Enhancing anaerobic fermentation of waste activated sludge by investigating multiple electrochemical pretreatment conditions: Performance, modeling and microbial dynamics

Electrochemical pretreatment (EPT) is an efficient technology to improve volatile fatty acids (VFAs) production during anaerobic fermentation of waste activated sludge (WAS). This study investigated the co-effects of different current intensities, electrolyte NaCl dosage and pretreatment time for promoting VFAs production. The results showed that it was considerably enhanced by 51.6 % when EPT was performed at 1.0 A, 1.0 g/L and 60 min, and response surface methodology strategy adjusted the optimal EPT conditions to 1.0 A, 1.2 g/L and 66 min. The potential mechanisms were proposed that EPT at optimal conditions greatly enhanced solubilization and hydrolysis of WAS and selectively inactivated methanogens, causing the enrichment of acidogenic bacteria (i.e., Lactobacillus, Saccharimonadales, Tetrasphaera and Prevotella) due to generated reactive chlorine species. Finally, the economic analysis indicated the promising application potential with the profit of EPT at optimal conditions increasing by 36.0 %.

A novel conversion of marine macroalgal biomass to biofuel (biohydrogen) via calcium hypochlorite induced dispersion

Environmental pollution due to the consumption of non-renewable energy lead the search for alternative eco-friendly renewable fuel. The study details the biohydrogen production efficiency by potential macroalgal (Ulva reticulata) biomass improved by a disperser combined with calcium hypochlorite pretreatment technology. Calcium hypochlorite was added to decrease the surface energy of the medium induced by sole disperser pretreatment. Optimum condition for algal disperser treatment was 10,000 rpm with 30 min as dispersion time. The specific energy spent for the disintegration of the macroalgal biomass was 1231.58 kJ/kg TS. COD solubilization rate of 11.79% was attained with mechanical pretreatment whereas increased to 20.23% with combined pretreatment. Combination of disperser with calcium hypochlorite significantly reduced the specific energy input spent to 500 kJ/kg TS. The amount of organic materials such as carbohydrates, proteins and lipids released were 680 mg/L, 283 mg/L and 136 mg/L respectively. Thus, the combinative pretreatment with disperser rotor speed (10,000 rpm) for pretreatment time (12 min) and calcium hypochlorite dosage (0.1 g/g) derived as optimum condition for effective solubilization of macroalgal biomass. Biohydrogen production potential was maximum in the macroalgae pretreated with both disperser and calcium hypochlorite recorded highest yield (54.6 mL H₂/g COD) compared to the macroalgae pretreated with disperser alone (31.7 mL H₂/g COD) and untreated macroalgae (11.5 mL H₂/g COD).

Effects of enzymes on organic matter conversion in anaerobic fermentation of sludge to produce volatile fatty acids

Sludge hydrolysis is a vital step in anaerobic digestion of sludge. This study compared the efficacy of free versus immobilized enzymes at different concentrations in promoting sludge disintegration. Pretreatment with 1,000 mg/L immobilized enzymes was more efficient in promoting sludge disintegration than free enzymes at the same concentration. Under the optimized conditions, volatile fatty acids (VFAs) were produced at 10.6 g/L, accounting for 85 % of total soluble chemical oxygen demand. Improved VFA production was attributed to the release of large amounts of polysaccharides and proteins from the enzymatically pretreated sludge. Released organic matter are the substrates for VFAs generated by the determined microbial community of Firmicutes, Proteobacteria, Bacteroidetes, Actinobacteria, and Chloroflexi. In this study, anaerobic fermentation was used to successfully convert organic matter in sludge into high-value-added VFAs. Therefore, this process can be selected as a strategy to reduce carbon emissions from wastewater treatment plants (WWTPs).

Anaerobic digestion of thickened waste activated sludge under calcium hypochlorite stress: Performance stability and microbial communities

Hypochlorite pretreatment has been proven effective in enhancing waste activated sludge (WAS) anaerobic digestion performances recently. In this study, two semi-continuous anaerobic sequencing batch reactors (ASBRs), one fed with Ca(ClO)₂ pretreated thickened WAS (TWAS) and one with raw TWAS, were operated at mesophilic conditions (35 °C) for 145 days. Three loading shocks were introduced to each reactor to compare the performance stability and resilience between the digestion of Ca(ClO)₂ pretreated TWAS and untreated TWAS. Microbial community shifts were quantified to reveal the microbiome responses to disturbances. The results suggested that 1% Ca(ClO)₂ enhanced the digestion of TWAS by inactivating and transforming the biomass to more easily digested substrates. Co-occurrence network analysis revealed that the strongest interactions in the microbial community occurred in the steady state of TWAS anaerobic digestion.

Enhanced methane yield through sludge two-phase anaerobic digestion process with the addition of calcium hypochlorite

This study investigated the effects of calcium hypochlorite (Ca(ClO)₂) on biomethane generation from sludge two-phase anaerobic digestion system. In first (acidogenic) phase, volatile fatty acids (VFAs) were largely generated when pretreated by Ca(ClO)₂, while the methane yield was severely inhibited. In second (methanogenic) phase, the methane yield was observably enhanced by Ca(ClO)₂. Further calculation showed that the total methane yield from the two phases was firstly promoted from 156.0 ± 4.5 to 269.9 ± 5.2 mL when Ca(ClO)₂ dosage enhanced from 0 to 1.6 g/L, which then reduced to 235.4 ± 5.5 mL when Ca(ClO)₂ content reached 2.0 g/L. Mechanism analysis showed that the suppression of Ca(ClO)₂ on coenzyme F₄₂₀ activity was relieved in methanogenic phase, and the abundances of functional microbes in methanogenic phase were enriched when added with Ca(ClO)₂. The Ca(ClO)₂-based method well realized the balance between efficacy and economy, possessing outstanding potential for large-scale applications.

Calcium hypochlorite pretreatment improves thermophilic digestion of waste activated sludge in an upflow anaerobic sludge blanket reactor

Anaerobic wasted activated sludge (WAS) digestion has been widely applied to reduce sludge volume and generate bioenergy in the form of methane. However, anaerobic WAS digestion performance is often challenged with poor hydrolysis of biomass cellular structures. In the present study, the feasibility of using calcium hypochlorite (Ca(ClO)₂) to improve the thermophilic digestion of WAS was studied. Two thermophilic upflow anaerobic sludge bed (UASB) reactors (one with and one without Ca(ClO)₂ pretreatment) were operated for 120 days under low and high organic loading rate (OLR) conditions, corresponding hydraulic retention time (HRT) of 10 days and 6 days, respectively. Both reactors achieved satisfied performance during the studied period. Under the low OLR condition, Ca(ClO)₂ pretreatment significantly improved WAS total volatile solids (VS) removal efficiency (from 48.06 ± 2.63% to 57.34 ± 3.54%) and methane yield (from 289.2 ± 27.6 to 362.2 ± 36.7 N mL/g VS). However, no significant improvement was observed under the high OLR condition. g_S1 and g_Fervidobacterium were predominant bacteria in the thermophilic UASB reactor fed with Ca(ClO)₂ pretreated WAS. Methanosarcina was dominant archaea in both reactors. The treatment mechanism and application potential of using Ca(ClO)₂ to enhance the WAS digestibility were further discussed.

Enhancing microbial fuel cell performance using anode modified with Fe3O4 nanoparticles

Low electricity generation efficiency is one of the key issues that must be addressed for the practical application of microbial fuel cells (MFCs). Modification of microbial electrode materials is an effective method to enhance electron transfer. In this study, magnetite (Fe₃O₄) nanoparticles synthesized by co-precipitation were added to anode chambers in different doses to explore its effect on the performance of MFCs. The maximum power density of the MFCs doped with 4.5 g/L Fe₃O₄ (391.11 ± 9.4 mW/m²) was significantly increased compared to that of the undoped MFCs (255.15 ± 24.8 mW/m²). The COD removal efficiency of the MFCs increased from 85.8 ± 2.8% to 95.0 ± 2.1%. Electrochemical impedance spectroscopy and cyclic voltammetry tests revealed that the addition of Fe₃O₄ nanoparticles enhanced the biocatalytic activity of the anode. High-throughput sequencing results indicated that 4.5 g/L Fe₃O₄ modified anodes enriched the exoelectrogen Geobacter (31.5%), while control MFCs had less Geobacter (17.4%). Magnetite is widely distributed worldwide, which provides an inexpensive means to improve the electrochemical performance of MFCs.

Revealing the intrinsic drawbacks of waste activated sludge for efficient anaerobic digestion and the potential mitigation strategies

Anaerobic digestion (AD) is an effective approach for waste activated sludge (WAS) disposal with substantial recovery of valuable substrates. Previous studies have extensively explored the correlations of common operational parameters with AD efficiency, but the impacts of intrinsic characteristics of WAS on the AD processes are generally underestimated. This study focused on disclosing the association of intrinsic drawbacks in WAS with AD performance, and found that the cemented WAS structure, low fraction of biomass and various high levels of inhibitory pollutants (e.g., organic pollutants and heavy metals), as the integral parts of WAS all greatly restricted the AD performance. The main potential strategies and underlying mechanisms to mitigate the restrictions for efficient WAS digestion, including the practical pretreatment methods, bioaugmentation and aided substances addition, were critically analyzed. Also, future directions for the improvement of WAS digestion were proposed from the perspectives of technical, management and economic aspects.

Current status of hypochlorite technology on the wastewater treatment and sludge disposal: Performance, principals and prospects

As cost-effective and high-efficient oxidants, the hypochlorite chemicals have been widely utilized for bleaching and disinfection. However, its potential applications in wastewater treatment and sludge disposal were less concerned. This paper mainly summarized the state-of-the-art applications of hypochlorite technology in wastewater and sludge treatment based on the main influencing factors and potential mechanisms of hypochlorite treatment. The results indicated that the hypochlorite approaches were not only effective in pollutants removal and membrane fouling mitigation for wastewater treatment, but also contributed to sludge dewatering and resource recovery for sludge disposal. The ClO^- and large generated free active radicals (i.e., reactive chlorine species and reactive oxygen species), which possessed strong oxidative ability, were the primary contributors to the pollutants decomposition, and colloids/microbes flocs disintegration during the hypochlorite treatment process. The performance of hypochlorite treatment was highly associated with various factors (i.e., pH, temperature, hypochlorite types and dosage). In combination with the reasonable activators (i.e., Fe²⁺ and ultraviolet), auxiliary agents, and innovative processes (i.e., hydrothermal and electro-oxidation), the operational performance of hypochlorite technology could be further enhanced. Finally, the feasibility and benefits of hypochlorite application for wastewater and sludge treatment were analyzed, and the existing challenges and future research efforts that need to be made have also prospected. The review can hopefully provide a theoretical basis and technical guidance to extend the application of hypochlorite technology for wastewater treatment and sludge disposal on large scale.

Effect of polystyrene microplastics on the volatile fatty acids production from waste activated sludge fermentation

Anaerobic fermentation is crucial to resource utilization of waste activated sludge (WAS). However, accumulated microplastics (MPs) in sludge could not be ignored. Here, a typical MP, polystyrene (PS), was selected to study the effects of different concentrations of PS on anaerobic fermentation under the optimal volatile fatty acids (VFAs) production. Compared to the control, low PS concentrations (30 particles/g _{total solid}) significantly (p = 0.002) increased the production of VFAs to 112.8 ± 2.4% due to solubilization enhancement and enzymatic activity. High concentrations of PS (90 particles/g _{total solid}) significantly (p = 0.000) decreased VFAs production to 83.01 ± 0.76% because of the inactive related microbial activities, although organic matter release was enhanced in the initial stage. Mechanism studies showed that the toxicity of high PS concentration could be attributed to reactive oxygen species (ROS) production, excess sodium dodecyl sulfate (SDS), and synergistic toxicity of aged MPs with external pollutants.

Waste-to-energy: Cellulase induced waste activated sludge and paper waste co-fermentation for efficient volatile fatty acids production and underlying mechanisms

This study mainly investigated the feasibility of utilizing cellulase to enhance waste activated sludge (WAS) and paper waste (PW) co-fermentation for the generation of volatile fatty acids (VFAs). The introduction of cellulase effectively enhanced the co-fermentation efficiency, and the maximum VFAs generation reached 3014 mg COD/L with 60 mg cellulase/g TSS while it was 1512 mg COD/L in the control reactor. The presence of cellulase evidently improved the concentration of soluble bioavailable substrates (e.g., carbohydrates and proteins) via inducing the EPS disintegration and PW disruption. More importantly, the functional anaerobes (i.e., Macellibacteroides and Bacteroides) and the microbial activities (i.e., ATP, key acid-forming enzymes, and genetic expressions) that related with the VFAs biosynthesis were enriched and enhanced due to the stimulation of cellulase, contributing to the ultimate VFAs promotion. This study provided a novel strategy to recover valuable products from waste biomass with constructive mechanistic exploration.

Effects of chlorine disinfectants on the microbial community structure and the performance of anaerobic digestion of swine manure

The residual chlorine disinfectants (CDs) in swine slurry could negatively impact the anaerobic digestion (AD). The objective of this study was to investigate the effects of CDs on mesophilic and thermophilic AD. The results indicated that CDs exerted inhibition effects on methanogenesis at the initial stage of mesophilic AD, leading to the extension of lag time from 0.62 days for control to 0.85, 1.9, 3.8, and 5.5 days with the increasing CDs concentrations of 50, 100, 200, and 400 mg/L, respectively. Under thermophilic condition, the inhibition effects reduced significantly at the initial stage but a decrease of CMP_u at later stage was observed. The microbial analysis revealed that CDs resulted in the enrichment of chlorine-resistant bacteria (Clostridum_sensu_stricto_1) and archaea (Methanosarcina). Addition of activated carbon (AC), zero-valent iron (ZVI) and biochar (BC) was evaluated for alleviating the inhibitions of CDs and proved to be feasible strategies to alleviate the inhibited AD.

Calcium hypochlorite enhances the digestibility of and the phosphorus recovery from waste activated sludge

Waste activated sludge (WAS) can be treated using anaerobic digestion (AD) for biogas recovery and volume reduction. However, the poor digestibility and hydrolysis of WAS limit AD applications. The current study investigated the feasibility of applying calcium hypochlorite as a WAS pretreatment strategy to improve AD treatment efficiency using laboratory reactors. The results showed that pretreatment with 5 - 20% Ca(ClO)₂ (total suspended solids basis) significantly enhanced WAS anaerobic digestibility, and led to significantly enhanced methane production rate and biomethane yield comparing to the AD of raw WAS (P < 0.05). Low Ca(ClO)₂ pretreatment (5 - 10%) significantly enhanced digestion efficiency, which can be attributed to the development of fermentative and syntrophic bacteria. However, high Ca(ClO)₂ doses (>20%) reduced microbial activities, leading to slow release of dissolved organic compounds and prolonged methane production lag phase. In addition, high Ca(ClO)₂ removed 82.7% of the initial phosphate by calcium-phosphate binding, reducing the phosphorus in liquid digestate.

Insights into the accelerated venlafaxine degradation by cysteine-assisted Fe2+/persulfate: Key influencing factors, mechanisms and transformation pathways with DFT study

The effective removal of refractory antidepressant in wastewater is challenging. In this study, a novel strategy of cysteine-assisted Fe²⁺/persulfate system (Fe²⁺/Cys/PS) was applied for the venlafaxine (Ven, as a typical antidepressant) degradation. The obtained results revealed that the Ven removal was evidently accelerated and enhanced in Fe²⁺/Cys/PS process, and achieved complete degradation in 5 min with optimal dosage. Further analysis indicated that the Ven degradation efficiency was associated with the chemical concentrations (i.e. Fe²⁺, Cys and PS) and operational conditions (i.e. pH and temperature). Moreover, the reactions were not impacted by the co-occurring organic matters (i.e. fulvic acid) and inorganic ions (i.e. Cl^-) potentially existing in real wastewater matrices. Mechanistic explorations demonstrated that the presence of Cys promoted the Fe³⁺/Fe²⁺ redox cycle, and thus enhanced the reactive oxygen species yields (ROS). The OH was considered as the primary ROS in Fe²⁺/Cys/PS process for Ven degradation via the radical scavenger verification. Also, the main intermediates of Ven degradation were identified, and the possible transformation pathway was proposed, in which the hydroxylation attacked by the OH was the main reaction. Moreover, the active reaction sites in Ven were calculated with the density function theory (DFT), which was consistent with the observed metabolic routes.

Mini art review for zero valent iron application in anaerobic digestion and technical bottlenecks

Zero valent iron (ZVI) has been used extensively to control environmental pollution owing to its strong reducibility and low cost. Herein, we evaluate the impact of ZVI (iron scrap and ZVI powder with different scales) on anaerobic digestion (AD) reactor performance improvement and syntrophic relationship stimulation among various microbial groups in the methanogenesis process. In recent studies, ZVI addition significantly enhanced methane and volatile fatty acid (VFA) yields and alleviated excessive acidification, ammonia accumulation, and odorous gas production. Further, we reviewed the changes in enzyme activity and microbial metabolism after the addition of ZVI throughout the reaction process. Certain innovative technologies, such as bioelectrochemical system assistance and combined usage of conductive materials, may improve AD performance compared to the use of ZVI alone, the mechanism of which has been discussed from various viewpoints. Furthermore, the primary technical bottlenecks, such as poor mass transfer efficiency in dry AD and high ZVI dosage, have been illustrated, and syntrophic methanogenesis regulated by ZVI addition can be further studied by conducting theoretical research.

Enhanced methane production from anaerobic digestion of waste activated sludge through preliminary pretreatment using calcium hypochlorite

Methane recovery from waste activated sludge (WAS) through anaerobic digestion is generally restricted by the poor degradability of WAS. Herein, a novel sludge pretreatment technology by using the calcium hypochlorite (Ca(ClO)₂) in enhancing the methane production from WAS anaerobic digestion was reported. The solubilization of WAS was significantly increased after 10-240 mg Ca(ClO)₂/g VS (VS: volatile solids) pretreatment for 48 h, under which the solubilization was 1.7-3.4 folds (i.e., 0.17-0.34 mg SCOD/mg VS; SCOD: soluble chemical oxygen demand) higher than that without Ca(ClO)₂ pretreatment (i.e., 0.1 mg SCOD/mg VS). Correspondingly, the methane production was increased from 250.0 ± 5.3 mL/g VS to 385.1 ± 3.3 mL/g VS with the doses of Ca(ClO)₂ increasing from 10 mg/g VS to 240 mg/g VS, resulted in an increasing methane production of 3.6%-59.7% than that without Ca(ClO)₂ pretreatment. The microbial community composition results exhibited that the populations of key acidogens (e.g., Longilinea sp.) and methanogens (e.g., Methanosaeta sp.) were both reduced significantly. Moreover, Ca(ClO)₂ decreased the cells viability, leading to a 76.2% reduction of living cells fraction. Accordingly, it was further confirmed that high dosage of Ca(ClO)₂ could inhibit three microbial-related processes relevant to methane production, i.e., acidification, hydrolysis and methanogenesis.

A preliminary metatranscriptomic insight of eggshells conditioning on substrates metabolism during food wastes anaerobic fermentation

The anaerobic treatment of food wastes (FW) for resource recovery has been extensively studied. However, the information on the traits of functional genes and enzymes for substrates metabolisms and their associations with microbial community are little. In this study, the influences of eggshells conditioning on the substrates metabolism for volatile fatty acids production (VFAs) in the process of FW fermentation were investigated at genetic levels by using the metatranscriptomic approach. The obtained results suggested that the critical genes involved in the carbohydrate and protein metabolisms (i.e. pgmB, GPI, glsA, pyrB and etc.) were up-regulated in the eggshell-conditioned reactor, which were beneficial to the bioconversion of macromolecule organics during FW fermentation. Moreover, the functional genes related with the intermediate products metabolism (i.e. pyruvate acid, butanoate) also exhibited differential genetic expression levels, which resulted in the alteration of microbial metabolic pathways and contributed to the acetic and butyric acids accumulation. In addition, a preliminary association of microbial distribution and genetic expressions was analyzed. The distinct distribution of microbial community in different FW fermentation systems affected the corresponding microbial contribution to those genetic expression levels of metabolic enzymes involved in VFAs production. This study would provide new insights of the underlying mechanism of VFAs promotion in the eggshell-conditioned FW fermentation process from the perspectives of substrates metabolisms at genetic and functional traits.

Distinct effects of hypochlorite types on the reduction of antibiotic resistance genes during waste activated sludge fermentation: Insights of bacterial community, cellular activity, and genetic expression

The effectiveness of hypochlorites (NaClO and Ca(ClO)₂) on the reduction of antibiotic resistance genes (ARGs) during waste activated sludge (WAS) fermentation was determined by the quantitative PCR. NaClO and Ca(ClO)₂ exhibited distinct effects on ARGs fates. Ca(ClO)₂ was effective in removing all investigated ARGs, and the efficiency was highly dose-dependent. Unexpectedly, the NaClO treatment attenuated ARGs with lower efficiency and even caused the propagation of certain ARGs (i.e., aadA1 and tetQ) at higher doses. The extracellular polymeric substances dissolution and membrane integrity suggested that unstable NaClO had acute effects on bacteria initially, while it was ineffective to further attenuate ARGs released from hosts due to the rapid consumption of oxidative ClO^-. Without lasting and strong oxidative stress, the microbial activities of tolerant ARGs hosts will partially recover and then contribute to the ARGs dissemination across genera. In contrast, solid-state Ca(ClO)₂ was slowly released and exhibited prolonged effects on bacteria by disrupting cell membranes and removing the susceptible ARGs released from hosts. Furthermore, bacterial taxa-ARG network analysis indicated that Ca(ClO)₂ reduced the abundance of potential hosts, and the metabolic pathway and gene expression related to ARGs propagation were significantly downregulated by Ca(ClO)₂, which contributed to efficient ARGs attenuation.

Biosynthesized iron sulfide nanoparticles by mixed consortia for enhanced extracellular electron transfer in a microbial fuel cell

The bioanode of mixed consortia was for the first time used to in-situ synthesize iron sulfide nanoparticles in a microbial fuel cell (MFC) over a long-term period (46 days). These poorly crystalline nanoparticles with an average size of 29.97 ± 7.1 nm, comprising of FeS and FeS₂, significantly promoted extracellular electron transfer and thus the electricity generation of the MFC. A maximum power density of 519.00 mW/m² was obtained from the MFC, which was 1.92 times as high as that of the control. The cell viability was promoted by a small amount of iron sulfide nanoparticles but inhibited by the thick nanoparticle "shell" covered on the bacterial cells. Some electroactive and sulfur reducing bacteria (eg. Enterobacteriaceae, Desulfovibrio, and Geobacter) were specifically enriched on the anode. This study provides a novel insight for improving the performance of bioelectrochemical systems through in-situ sustainable nanomaterials biofabrication by mixed consortia.

Continuous waste activated sludge and food waste co-fermentation for synchronously recovering vivianite and volatile fatty acids at different sludge retention times: Performance and microbial response

A practical approach of synchronously recovering vivianite and volatile fatty acids (VFAs) by food waste (FW) and waste activated sludge (WAS) co-fermentation in continuous operation was investigated. Approximately 82.88% P as high-purity vivianite (95.23%) and 7894 mg COD/L VFAs were finally recovered. The simultaneous addition of FW and FeCl₃ contributed to the fermentation conditions by adjusting pH biologically and increasing the concentration of organic substrates, which enhanced the Fe³⁺ reduction efficiency and microbial activities (e.g., hydrolases and acidogenic enzymes). Microbial analysis found the functional bacteria related to Fe³⁺ reduction and VFAs generation were further enhanced and enriched. Besides, results indicated that the efficiencies of Fe²⁺ and P release and VFAs recovery were highly linked to SRT, the satisfactory fermentation performance was obtained at SRT of 6 d. This research would provide a practical waste recycling technology to treat FW and WAS simultaneously for recovering vivianite and VFAs synchronously.