1
|
Stini E, Tsimogiannis D, Oreopoulou V. The Valorisation of Melissa officinalis Distillation By-Products for the Production of Polyphenol-Rich Formulations. Molecules 2024; 29:377. [PMID: 38257290 PMCID: PMC10819686 DOI: 10.3390/molecules29020377] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/01/2023] [Revised: 01/07/2024] [Accepted: 01/09/2024] [Indexed: 01/24/2024] Open
Abstract
Lemon balm (Melissa officinalis) is an aromatic and medicinal plant, rich in bioactive ingredients and with superior antioxidant activity. The essential oil of this plant is an expensive product, so the use of the by-products of the essential oil industry is particularly useful. The aim of this research was to process Melissa officinalis distillation by-products to develop a series of polyphenol-rich formulations. In the present research, lemon balm was distilled in a laboratory-scale distiller, and the recovered by-product was used for further successive extractions with acetone and water, using a fixed-bed semi-batch extractor. Acetone extract exhibited relatively poor results as far as yield, phenolic composition and antiradical activity are concerned. However, the aqueous extract presented high yield in both total phenolic content (i.e., 111 mg gallic acid equivalents (GAE)/g, on a dry herb basis (dw)), and anti-radical capacity (205 mg trolox equivalents (TE)/g dw). On a dried extract basis, the results were also impressive, with total phenols reaching 322 mg GAE/g dry extract and antiradical capacity at 593 mg TE/g dry extract. The phenolic components of the extract were identified and quantified by HPLC-DAD. Rosmarinic acid was the major component and amounted to 73.5 mg/g dry extract, while the total identified compounds were quantified at 165.9 mg/g dry extract. Finally, formulations with two different wall materials (gum arabic-maltodextrin and maltodextrin) and two different drying methods (spray-drying and freeze-drying) were applied and evaluated to assess their performance, yield, efficiency and shelf-life of total phenolic content and rosmarinic acid concentration. From the present investigation, it is concluded that after one year of storage, rosmarinic acid does not decrease significantly, while total phenolic content shows a similar decrease for all powders. According to the yield and efficiency of microencapsulation, maltodextrin alone was chosen as the wall material and freeze-drying as the preferred drying method.
Collapse
Affiliation(s)
- Eirini Stini
- Laboratory of Food Chemistry and Technology, Department of Chemical Engineering, National Technical University of Athens, 5 Iroon Polytechniou, Zografou, 15780 Athens, Greece; (E.S.); (D.T.)
| | - Dimitrios Tsimogiannis
- Laboratory of Food Chemistry and Technology, Department of Chemical Engineering, National Technical University of Athens, 5 Iroon Polytechniou, Zografou, 15780 Athens, Greece; (E.S.); (D.T.)
- NFA (Natural Food Additives), Laboratory of Natural Extracts Development, 6 Dios St., Tavros, 17778 Athens, Greece
| | - Vassiliki Oreopoulou
- Laboratory of Food Chemistry and Technology, Department of Chemical Engineering, National Technical University of Athens, 5 Iroon Polytechniou, Zografou, 15780 Athens, Greece; (E.S.); (D.T.)
| |
Collapse
|
2
|
Indiarto R, Reni R, Utama GL, Subroto E, Pangawikan AD, Djali M. The physicochemical, antioxidant, and sensory properties of chocolate biscuits incorporated with encapsulated mangosteen ( Garcinia mangostana L.) peel extract. International Journal of Food Properties 2023. [DOI: 10.1080/10942912.2022.2159429] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
Affiliation(s)
- Rossi Indiarto
- Department of Food Industrial Technology, Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Jatinangor, Indonesia
| | - Reni Reni
- Department of Food Industrial Technology, Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Jatinangor, Indonesia
| | - Gemilang Lara Utama
- Department of Food Industrial Technology, Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Jatinangor, Indonesia
| | - Edy Subroto
- Department of Food Industrial Technology, Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Jatinangor, Indonesia
| | - Aldila Din Pangawikan
- Department of Food Industrial Technology, Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Jatinangor, Indonesia
| | - Mohamad Djali
- Department of Food Industrial Technology, Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Jatinangor, Indonesia
| |
Collapse
|
3
|
Laureanti EJG, Paiva TS, de Matos Jorge LM, Jorge RMM. Microencapsulation of bioactive compound extracts using maltodextrin and gum arabic by spray and freeze-drying techniques. Int J Biol Macromol 2023; 253:126969. [PMID: 37730006 DOI: 10.1016/j.ijbiomac.2023.126969] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/06/2023] [Revised: 09/03/2023] [Accepted: 09/15/2023] [Indexed: 09/22/2023]
Abstract
Microencapsulation techniques establish a protective barrier around a sensitive compound, reducing vulnerability to external influences and offering controlled release. This work evaluates microencapsulation of Brazilian seed known as pink pepper (Schinus terebinthifolius) extract incorporated with green propolis extract, (main propolis font from the South America native plant Baccharis dracunculifolia DC) to enhancement antioxidant activity through synergic interaction, comparing to the extracts individually. Four treatments were produced using maltodextrin and combined with gum arabic as encapsulating agent, employing two different microencapsulation technique applied (spray drying and freeze drying) to assess their impact on physicochemical properties. The incorporation of gum arabic into matrix yielded higher encapsulation efficiency values, exhibiting significant differences for both encapsulation techniques. Combining the two encapsulation agents afforded greater protection of the bioactive compounds, resulting in an increase of approximately 31 % in the inhibition of the DPPH● radical. In controlled release analysis, maltodextrin exhibits the best protective effect on total phenolic compounds during intestinal release, whereas combining maltodextrin and gum arabic enhanced protection during gastric phase. Microcapsules may contribute to the protection of important bioactive compound, possessing a wide range of applications such as flavors encapsulation in food industry, lipids, antioxidants and pharmaceutical industry for controlled drug release.
Collapse
Affiliation(s)
- Emanuele Joana Gbur Laureanti
- Graduate Program in Chemical Engineering, Department of Chemical Engineering, Federal University of Paraná, Coronel Francisco Heráclito dos Santos Avenue, Curitiba 81531-980, Brazil
| | - Thainnane Silva Paiva
- Graduate Program in Food Engineering, Department of Chemical Engineering, Federal University of Paraná, Coronel Francisco Heráclito dos Santos Avenue, Curitiba 81531-980, Brazil
| | - Luiz Mário de Matos Jorge
- Graduate Program in Chemical Engineering, Department of Chemical Engineering, Federal University of Paraná, Coronel Francisco Heráclito dos Santos Avenue, Curitiba 81531-980, Brazil; Graduate Program in Food Engineering, Department of Chemical Engineering, Federal University of Paraná, Coronel Francisco Heráclito dos Santos Avenue, Curitiba 81531-980, Brazil; Chemical Engineering Department, State University of Maringá (UEM), Colombo Avenue, 5790, CEP, 87020-900, Maringá, PR, Brazil
| | - Regina Maria Matos Jorge
- Graduate Program in Chemical Engineering, Department of Chemical Engineering, Federal University of Paraná, Coronel Francisco Heráclito dos Santos Avenue, Curitiba 81531-980, Brazil; Graduate Program in Food Engineering, Department of Chemical Engineering, Federal University of Paraná, Coronel Francisco Heráclito dos Santos Avenue, Curitiba 81531-980, Brazil.
| |
Collapse
|
4
|
Santos de Carvalho A, de Oliveira A, Fernandes Moya Moreira T, Gustavo Médice Arabel Costa L, Donato Marcatto G, da Silva Castilhos de Melo A, Hess Gonçalves O, Inês Dias M, Calhelha RC, Barros L, Valderrama P, Cardozo Filho L, Vitória Leimann F. In situ extraction/encapsulation of olive leaves antioxidants in zein for improved oxidative stability of edible oils. Food Res Int 2023; 173:113363. [PMID: 37803661 DOI: 10.1016/j.foodres.2023.113363] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/05/2023] [Revised: 08/02/2023] [Accepted: 08/05/2023] [Indexed: 10/08/2023]
Abstract
This study presents a sustainable and cost-effective method for preserving the bioactivity of phenolic compounds in olive leaves (OLE) during their application. The extraction and nanoencapsulation of OLE were performed in a single-step process using a rotor-stator system with zein as the encapsulating agent. The nanoprecipitation step was carried out using an aqueous sodium caseinate solution, resulting in spherical particles with an average diameter of about 640 nm, as confirmed by Transmission Electron Microscopy. Thermal characterization showed that the produced nanoparticles were more thermally stable than free OLE until 250 °C, and FTIR spectra indicated effective interaction between the phenolic compounds and zein. Antioxidant activity was evaluated using TBARS, DPPH, ABTS, and FRAP assays, with results showing that encapsulated OLE had lower antioxidant activity than free OLE. The best antioxidant capacity results were determined by TBARS assay, with IC50 results equal to 43 and 103 µgOLE/mL for free and encapsulated OLE, respectively. No anti-inflammatory potential was detected for both samples using the RAW 264.7 model, and only free OLE showed cytotoxic activity against lung cancer and gastric carcinoma. Encapsulated and free OLE were used as antioxidants in soy, palm, and palm kernel oils and compared to BHT using Rancimat. The Schaal Oven Test was also performed, and the PARAFAC chemometric method analyzed the UV-Vis spectra, which revealed high stability of the oil when 300 mg or the nanoparticles were added per kg oil. Results suggested that zein-encapsulated olive leaf antioxidants can improve the oxidative stability of edible oils.
Collapse
Affiliation(s)
- Amarilis Santos de Carvalho
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Anielle de Oliveira
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Thaysa Fernandes Moya Moreira
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Luis Gustavo Médice Arabel Costa
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Gabrielle Donato Marcatto
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Andre da Silva Castilhos de Melo
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Odinei Hess Gonçalves
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil; Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal
| | - Maria Inês Dias
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal; Laboratório Associado para a Sustentabilidade e Tecnologia em Regiões de Montanha (SusTEC), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal
| | - Ricardo C Calhelha
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal; Laboratório Associado para a Sustentabilidade e Tecnologia em Regiões de Montanha (SusTEC), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal
| | - Lillian Barros
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal; Laboratório Associado para a Sustentabilidade e Tecnologia em Regiões de Montanha (SusTEC), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal
| | - Patricia Valderrama
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil
| | - Lucio Cardozo Filho
- Department of Chemical Engineering, State University of Maringá - UEM, Maringá, PR, Brazil
| | - Fernanda Vitória Leimann
- Post-Graduation Program of Food Technology (PPGTA), Federal University of Technology - Paraná - UTFPR, Campo Mourão, via Rosalina Maria dos Santos, 1233, CEP 87301-899, Campo Mourão, PR, Brazil; Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal.
| |
Collapse
|
5
|
Iesa NB, Chaipoot S, Phongphisutthinant R, Wiriyacharee P, Lim BG, Sringarm K, Burgett M, Chuttong B. Effects of Maltodextrin and Gum Arabic Composition on the Physical and Antioxidant Activities of Dewaxed Stingless Bee Cerumen. Foods 2023; 12:3740. [PMID: 37893633 PMCID: PMC10606187 DOI: 10.3390/foods12203740] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/29/2023] [Revised: 09/16/2023] [Accepted: 10/09/2023] [Indexed: 10/29/2023] Open
Abstract
BACKGROUND Cerumen is a mixture of beeswax and plant resin made by stingless bees. It has antimicrobial and antioxidant properties and is often used in biological and therapeutic treatments. However, its adhesive characteristic makes cerumen challenging to process into powder. METHODS This study investigated the physical characteristics and antioxidant activity of the encapsulated freeze-dried dewaxed cerumen of Tetragonula laevicpes. The combination of coating materials at concentrations of 20%, 30% and 40% and carrier ratios of maltodextrin to gum arabic of 9:1, 5:5 and 3:7 were used to encapsulate dewaxed cerumen when freeze-dried; the control was maltodextrin at a concentration of 31.25%. RESULTS All carrier matrices showed high yields of >80% and similar powder characteristics of low moisture content, low water activity, high glass transition temperature and water dispersibility. Overall, antioxidant activities ranged from 69-80%, while the encapsulation efficiency of total phenolic content ranged from 46-68%. All carrier matrices show higher antioxidant activities than 31.25% maltodextrin, with the lowest antioxidant at 57%. CONCLUSIONS The carrier ratio of 5:5 resulted in better physical properties and retained 68% of polyphenolic activity in powders.
Collapse
Affiliation(s)
- Nuha Binte Iesa
- Chemical Engineering and Food Technology Cluster, Singapore Institute of Technology, 10 Dover Drive, Singapore 138683, Singapore; (N.B.I.); (B.G.L.)
- Meliponini and Apini Research Laboratory, Department of Entomology and Plant Pathology, Faculty of Agriculture, Chiang Mai University, Chiang Mai 50200, Thailand;
| | - Supakit Chaipoot
- Multidisciplinary Research Institute, Chiang Mai University, Chiang Mai 50200, Thailand; (S.C.); (R.P.)
| | - Rewat Phongphisutthinant
- Multidisciplinary Research Institute, Chiang Mai University, Chiang Mai 50200, Thailand; (S.C.); (R.P.)
| | - Pairote Wiriyacharee
- Division of Product Development Technology, Faculty of Agro-Industry, Chiang Mai University, Chiang Mai 50100, Thailand;
| | - Bee Gim Lim
- Chemical Engineering and Food Technology Cluster, Singapore Institute of Technology, 10 Dover Drive, Singapore 138683, Singapore; (N.B.I.); (B.G.L.)
| | - Korawan Sringarm
- Department of Animal and Aquatic Sciences, Faculty of Agriculture, Chiang Mai University, Chiang Mai 50200, Thailand;
| | - Michael Burgett
- Meliponini and Apini Research Laboratory, Department of Entomology and Plant Pathology, Faculty of Agriculture, Chiang Mai University, Chiang Mai 50200, Thailand;
- Department of Horticulture, Oregon State University, Corvallis, OR 97331, USA
| | - Bajaree Chuttong
- Meliponini and Apini Research Laboratory, Department of Entomology and Plant Pathology, Faculty of Agriculture, Chiang Mai University, Chiang Mai 50200, Thailand;
| |
Collapse
|
6
|
Ciont C, Difonzo G, Pasqualone A, Chis MS, Ranga F, Szabo K, Simon E, Naghiu A, Barbu-Tudoran L, Caponio F, Lelia Pop O, Cristian Vodnar D. Phenolic profile of micro- and nano-encapsulated olive leaf extract in biscuits during in vitro gastrointestinal digestion. Food Chem 2023; 428:136778. [PMID: 37421669 DOI: 10.1016/j.foodchem.2023.136778] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/04/2023] [Revised: 06/16/2023] [Accepted: 06/29/2023] [Indexed: 07/10/2023]
Abstract
Olive leaf was characterized by a high content of phenols and flavonoids (oleuropein, luteolin, and their derivatives), presenting functional and health-related properties. The chemical instability of phenolics through technological processes and their degradation in the digestive system may negatively impact them, leading to lower absorption. This study evaluates the phenolic profile of micro- and nano-encapsulated olive leaf extract in biscuits during the INFOGEST static in vitro digestion, aiming to enhance stability and sensorial properties. Ultrasound-assisted extraction and chromatography characterized the extract, while spray drying (maltodextrin-glucose) and nano-encapsulation (maltodextrin, whey protein isolate, and arabic gum) techniques were used with specific solutions. Encapsulated formulations underwent microscopy (TEM, SEM) and encapsulation efficiency analysis. Micro- and nano-encapsulation improved biscuit functionality by enhancing phenolic stability during digestion. However, the highest concentration adversely affected sensory and textural parameters. These findings contribute to developing functional food products enriched with bioactive compounds, providing improved health benefits while maintaining sensory attributes.
Collapse
Affiliation(s)
- Călina Ciont
- Department of Food Science, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania; Molecular Nutrition and Proteomics Laboratory, Institute of Life Sciences, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania
| | - Graziana Difonzo
- Department of Soil, Plant and Food Science (DISSPA), University of Bari Aldo Moro, I-70126 Bari, Italy.
| | - Antonella Pasqualone
- Department of Soil, Plant and Food Science (DISSPA), University of Bari Aldo Moro, I-70126 Bari, Italy
| | - Maria Simona Chis
- Department Food Technology, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania
| | - Florica Ranga
- Department of Food Science, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania
| | - Katalin Szabo
- Molecular Nutrition and Proteomics Laboratory, Institute of Life Sciences, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania
| | - Elemer Simon
- Molecular Nutrition and Proteomics Laboratory, Institute of Life Sciences, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania
| | - Anca Naghiu
- Research Institute for Analytical Instrumentation, National Institute of Research and Development for Optoelectronics INOE 2000, 67 Donath Street, 400293 Cluj-Napoca, Romania
| | - Lucian Barbu-Tudoran
- Electron Microscopy Center, Faculty of Biology and Geology, Babes-Bolyai University, Clinicilor 5-7, 400006 Cluj-Napoca, Romania
| | - Francesco Caponio
- Department of Soil, Plant and Food Science (DISSPA), University of Bari Aldo Moro, I-70126 Bari, Italy
| | - Oana Lelia Pop
- Department of Food Science, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania; Molecular Nutrition and Proteomics Laboratory, Institute of Life Sciences, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania.
| | - Dan Cristian Vodnar
- Department of Food Science, University of Agricultural Sciences and Veterinary Medicine, 400372, Cluj-Napoca, Romania
| |
Collapse
|
7
|
Medfai W, Oueslati I, Dumas E, Harzalli Z, Viton C, Mhamdi R, Gharsallaoui A. Physicochemical and Biological Characterization of Encapsulated Olive Leaf Extracts for Food Preservation. Antibiotics (Basel) 2023; 12:987. [PMID: 37370306 DOI: 10.3390/antibiotics12060987] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/30/2023] [Revised: 05/24/2023] [Accepted: 05/29/2023] [Indexed: 06/29/2023] Open
Abstract
Phenolic compounds in olive leaves have an excellent antioxidant activity and good antimicrobial properties. These bioactive molecules have beneficial properties for health, arousing great scientific and commercial interest. This study reports lyophilized olive leaf extracts (OLE) encapsulated by spray-drying using maltodextrins, maltodextrins-pectin and maltodextrins-gum Arabic as encapsulating agents. Lyophilized OLE were collected from two varieties cultivated in a harsh pedo-climatic conditions of the arid region of Tunisia. The effects of the genetic factor and the different encapsulating agents on the physicochemical properties of microcapsules and their behavior during storage, as well as their antimicrobial activities, were studied. Microcapsules successfully passed heat treatment and storage conditions and their antimicrobial activities were preserved. The encapsulating agent combination improved the encapsulation efficiency and the product yield in Zarrazi variety compared to Dhokar one. In addition, Dhokar variety microparticles showed the best heat stability at 4 and 25 °C after 90 days of storage and the higher inhibition percent against bacteria. The results of the present study evidenced that the best conditions for OLE encapsulation were obtained when the maltodextrins-pectin and maltodextrins-gum Arabic were combined to form a hybrid coating material.
Collapse
Affiliation(s)
- Wafa Medfai
- Centre of Biotechnology of Borj-Cedria, LR15CBBC05, Laboratory of Olive Biotechnology, Hammam-Lif 2050, Tunisia
- Faculty of Sciences of Tunis, University of Tunis El Manar, El Manar, Tunis 2092, Tunisia
- Univ. Lyon, University Claude Bernard Lyon 1, CNRS, LAGEPP UMR 5007, 43 Bd 11 Novembre 1918, 69622 Villeurbanne, France
| | - Imen Oueslati
- Centre of Biotechnology of Borj-Cedria, LR15CBBC05, Laboratory of Olive Biotechnology, Hammam-Lif 2050, Tunisia
| | - Emilie Dumas
- Univ. Lyon, University Claude Bernard Lyon 1, CNRS, LAGEPP UMR 5007, 43 Bd 11 Novembre 1918, 69622 Villeurbanne, France
| | - Zina Harzalli
- Centre of Biotechnology of Borj-Cedria, LR15CBBC05, Laboratory of Olive Biotechnology, Hammam-Lif 2050, Tunisia
- Faculty of Sciences of Tunis, University of Tunis El Manar, El Manar, Tunis 2092, Tunisia
| | - Christophe Viton
- Univ. Lyon, University Claude Bernard Lyon 1, CNRS, IMP UMR 5223, 15 Bd André Latarjet, 69100 Villeurbanne, France
| | - Ridha Mhamdi
- Centre of Biotechnology of Borj-Cedria, LR15CBBC05, Laboratory of Olive Biotechnology, Hammam-Lif 2050, Tunisia
| | - Adem Gharsallaoui
- Univ. Lyon, University Claude Bernard Lyon 1, CNRS, LAGEPP UMR 5007, 43 Bd 11 Novembre 1918, 69622 Villeurbanne, France
| |
Collapse
|
8
|
Loushigam G, Shanmugam A. Modifications to functional and biological properties of proteins of cowpea pulse crop by ultrasound-assisted extraction. Ultrason Sonochem 2023; 97:106448. [PMID: 37269691 DOI: 10.1016/j.ultsonch.2023.106448] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/23/2023] [Revised: 05/15/2023] [Accepted: 05/17/2023] [Indexed: 06/05/2023]
Abstract
Natural resource depletion, negative environmental effects and the challenge to secure global food security led to the establishment of the Sustainable Development Goals (SDGs). In need to explore underutilized sustainable protein sources, this study aims at isolating protein from cowpea by ultrasound-assisted extraction (UAE), where the techno-functional characteristics of the protein isolates were studied at different sonication conditions i.e., 100 W and 200 W at processing times ranging from 5 to 20 min. The US at 200 W-10 min produced the optimal results for all properties. In this process combination, there was an increase in protein yield, solubility, water-holding capacity, foaming capacity and stability, emulsion activity and stability, zeta-potential, and in-vitro protein digestibility from 31.78% to 58.96%, 57.26% to 68.85%, 3.06 g/g to 3.68 g/g 70.64% to 83.74%, 30.76% to 60.01%, 47.48% to 64.26%, 56.59% to 87.71%, -32.9 mV to -44.2 mV and 88.27% to 89.99%, respectively and particle size dropped from 763 nm to 559 nm in comparison to control. The microstructure and secondary-structure alterations of proteins caused by sonication were validated by SEM images, SDS-PAGE, and FTIR analyses. Sonication leads to acoustic cavitation and penetrate the cell walls, improving extraction from the solid to liquid phase. After sonication, the hydrophobic protein groups were exposed and proteins were partially denatured which increased its functionality. The findings demonstrated that UAE of cowpea protein improved yield, modify characteristics to fit the needs of the food industry, and contribute to achieving SDGs 2, 3, 7, 12, and 13.
Collapse
Affiliation(s)
- Geetarani Loushigam
- Food Processing Business Incubation Centre, National Institute of Food Technology, Entrepreneurship and Management, Thanjavur, India; College of Indigenous Food Technology, Council for Food Research and Development, Konni, Pathanamthitta, Kerala, India
| | - Akalya Shanmugam
- Food Processing Business Incubation Centre, National Institute of Food Technology, Entrepreneurship and Management, Thanjavur, India; Centre of Excellence in Non-Thermal Processing, National Institute of Food Technology, Entrepreneurship and Management, Thanjavur, India.
| |
Collapse
|
9
|
Tatasciore S, Santarelli V, Neri L, González Ortega R, Faieta M, Di Mattia CD, Di Michele A, Pittia P. Freeze-Drying Microencapsulation of Hop Extract: Effect of Carrier Composition on Physical, Techno-Functional, and Stability Properties. Antioxidants (Basel) 2023; 12:antiox12020442. [PMID: 36830001 PMCID: PMC9951912 DOI: 10.3390/antiox12020442] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/09/2022] [Revised: 01/26/2023] [Accepted: 01/30/2023] [Indexed: 02/12/2023] Open
Abstract
In this study, freeze-drying microencapsulation was proposed as a technology for the production of powdered hop extracts with high stability intended as additives/ingredients in innovative formulated food products. The effects of different carriers (maltodextrin, Arabic gum, and their mixture in 1:1 w/w ratio) on the physical and techno-functional properties, bitter acids content, yield and polyphenols encapsulation efficiency of the powders were assessed. Additionally, the powders' stability was evaluated for 35 days at different temperatures and compared with that of non-encapsulated extract. Coating materials influenced the moisture content, water activity, colour, flowability, microstructure, and water sorption behaviour of the microencapsulates, but not their solubility. Among the different carriers, maltodextrin showed the lowest polyphenol load yield and bitter acid content after processing but the highest encapsulation efficiency and protection of hop extracts' antioxidant compounds during storage. Irrespective of the encapsulating agent, microencapsulation did not hinder the loss of bitter acids during storage. The results of this study demonstrate the feasibility of freeze-drying encapsulation in the development of functional ingredients, offering new perspectives for hop applications in the food and non-food sectors.
Collapse
Affiliation(s)
- Simona Tatasciore
- Department of Bioscience and Technologies for Food Agriculture and Environment, University of Teramo, Via Renato Balzarini 1, 64100 Teramo, Italy
| | - Veronica Santarelli
- Department of Bioscience and Technologies for Food Agriculture and Environment, University of Teramo, Via Renato Balzarini 1, 64100 Teramo, Italy
| | - Lilia Neri
- Department of Bioscience and Technologies for Food Agriculture and Environment, University of Teramo, Via Renato Balzarini 1, 64100 Teramo, Italy
- Correspondence:
| | - Rodrigo González Ortega
- Faculty of Science and Technology, University of Bolzano, Piazza Università, 39100 Bolzano, Italy
| | - Marco Faieta
- Department of Bioscience and Technologies for Food Agriculture and Environment, University of Teramo, Via Renato Balzarini 1, 64100 Teramo, Italy
| | - Carla Daniela Di Mattia
- Department of Bioscience and Technologies for Food Agriculture and Environment, University of Teramo, Via Renato Balzarini 1, 64100 Teramo, Italy
| | - Alessandro Di Michele
- Department of Physics and Geology, University of Perugia, Via Pascoli, 06123 Perugia, Italy
| | - Paola Pittia
- Department of Bioscience and Technologies for Food Agriculture and Environment, University of Teramo, Via Renato Balzarini 1, 64100 Teramo, Italy
| |
Collapse
|
10
|
Paciulli M, Grimaldi M, Rinaldi M, Cavazza A, Flamminii F, Mattia CD, Gennari M, Chiavaro E. Microencapsulated olive leaf extract enhances physicochemical stability of biscuits. Future Foods 2022. [DOI: 10.1016/j.fufo.2022.100209] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022] Open
|
11
|
Tosya F, Bölek S. Encapsulation of Bioactive compounds in shalgam and investigation of the possibilities of their use in probiotic food production. FOOD BIOSCI 2022. [DOI: 10.1016/j.fbio.2022.102166] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022]
|
12
|
Ubeyitogullari A, Ahmadzadeh S, Kandhola G, Kim JW. Polysaccharide-based porous biopolymers for enhanced bioaccessibility and bioavailability of bioactive food compounds: Challenges, advances, and opportunities. Compr Rev Food Sci Food Saf 2022; 21:4610-4639. [PMID: 36199178 DOI: 10.1111/1541-4337.13049] [Citation(s) in RCA: 11] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/17/2021] [Revised: 07/28/2022] [Accepted: 08/31/2022] [Indexed: 01/28/2023]
Abstract
Bioactive food compounds, such as lycopene, curcumin, phytosterols, and resveratrol, have received great attention due to their potential health benefits. However, these bioactive compounds (BCs) have poor chemical stability during processing and low bioavailability after consumption. Several delivery systems have been proposed for enhancing their stability and bioavailability. Among these methods, porous biopolymers have emerged as alternative encapsulation materials, as they have superior properties like high surface area, porosity, and tunable surface chemistry to entrap BCs. This reduces the crystallinity (especially for the lipophilic ones) and particle size, and in turn, increases solubilization and bioavailability. Also, loading BCs into the porous matrix can protect them against environmental stresses such as light, heat, oxygen, and pH. This review introduces polysaccharide-based porous biopolymers for improving the bioaccessibility/bioavailability of bioactive food compounds and discusses their recent applications in the food industry. First, bioaccessibility and bioavailability are described with a special emphasis on the factors affecting them. Then, porous biopolymer fabrication methods, including supercritical carbon dioxide (SC-CO2 ) drying, freeze-drying, and electrospinning and electrospraying, are thoroughly discussed. Finally, common polysaccharide-based biopolymers (i.e., starch, nanocellulose, alginate, and pectin) used for generating porous materials are reviewed, and their current and potential future food applications are critically discussed.
Collapse
Affiliation(s)
- Ali Ubeyitogullari
- Department of Food Science, University of Arkansas, Fayetteville, Arkansas, USA.,Department of Biological and Agricultural Engineering, University of Arkansas, Fayetteville, Arkansas, USA
| | - Safoura Ahmadzadeh
- Department of Food Science, University of Arkansas, Fayetteville, Arkansas, USA
| | - Gurshagan Kandhola
- Department of Biological and Agricultural Engineering, University of Arkansas, Fayetteville, Arkansas, USA.,Institute for Nanoscience and Engineering, University of Arkansas, Fayetteville, Arkansas, USA
| | - Jin-Woo Kim
- Department of Biological and Agricultural Engineering, University of Arkansas, Fayetteville, Arkansas, USA.,Institute for Nanoscience and Engineering, University of Arkansas, Fayetteville, Arkansas, USA.,Cell and Molecular Biology Program, University of Arkansas, Fayetteville, Arkansas, USA.,Materials Science and Engineering Program, University of Arkansas, Fayetteville, Arkansas, USA
| |
Collapse
|
13
|
Perez-Palacios T, Ruiz-Carrascal J, Solomando JC, de-la-Haba F, Pajuelo A, Antequera T. Recent Developments in the Microencapsulation of Fish Oil and Natural Extracts: Procedure, Quality Evaluation and Food Enrichment. Foods 2022; 11:3291. [PMID: 37431039 PMCID: PMC9601459 DOI: 10.3390/foods11203291] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/30/2022] [Revised: 10/15/2022] [Accepted: 10/18/2022] [Indexed: 09/28/2023] Open
Abstract
Due to the beneficial health effects of omega-3 fatty acids and antioxidants and their limited stability in response to environmental and processing factors, there is an increasing interest in microencapsulating them to improve their stability. However, despite recent developments in the field, no specific review focusing on these topics has been published in the last few years. This work aimed to review the most recent developments in the microencapsulation of fish oil and natural antioxidant compounds. The impact of the wall material and the procedures on the quality of the microencapsulates were preferably evaluated, while their addition to foods has only been studied in a few works. The homogenization technique, the wall-material ratio and the microencapsulation technique were also extensively studied. Microcapsules were mainly analyzed for size, microencapsulation efficiency, morphology and moisture, while in vitro digestion, flowing properties, yield percentage and Fourier transform infrared spectroscopy (FTIR) were used more sparingly. Findings highlighted the importance of optimizing the most influential variables of the microencapsulation procedure. Further studies should focus on extending the range of analytical techniques upon which the optimization of microcapsules is based and on addressing the consequences of the addition of microcapsules to food products.
Collapse
Affiliation(s)
- Trinidad Perez-Palacios
- Meat and Meat Product University Institute (IProCar), University of Extremadura, Avda. de las Ciencias s/n, 10003 Cáceres, Spain
| | | | | | | | | | | |
Collapse
|
14
|
Estupiñan‐Amaya M, Fuenmayor CA, López‐Córdoba A. Evaluation of mixtures of maltodextrin and gum Arabic for the encapsulation of Andean blueberry (
Vaccinium meridionale
) juice by freeze–drying. Int J Food Sci Technol 2022. [DOI: 10.1111/ijfs.16093] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Affiliation(s)
- Mauren Estupiñan‐Amaya
- Facultad Seccional Duitama, Escuela de Administración de Empresas Agropecuarias Universidad Pedagógica y Tecnológica de Colombia Carrera 18 con Calle 22 Duitama, Boyacá 150461 Colombia
- Instituto de Ciencia y Tecnología de Alimentos (ICTA) Universidad Nacional de Colombia Av. Carrera 30 # 45‐03 Bogotá 111321 Colombia
| | - Carlos Alberto Fuenmayor
- Instituto de Ciencia y Tecnología de Alimentos (ICTA) Universidad Nacional de Colombia Av. Carrera 30 # 45‐03 Bogotá 111321 Colombia
| | - Alex López‐Córdoba
- Facultad Seccional Duitama, Escuela de Administración de Empresas Agropecuarias Universidad Pedagógica y Tecnológica de Colombia Carrera 18 con Calle 22 Duitama, Boyacá 150461 Colombia
| |
Collapse
|
15
|
Valková V, Ďúranová H, Falcimaigne-Cordin A, Rossi C, Nadaud F, Nesterenko A, Moncada M, Orel M, Ivanišová E, Chlebová Z, Gabríny L, Kačániová M. Impact of Freeze- and Spray-Drying Microencapsulation Techniques on β-Glucan Powder Biological Activity: A Comparative Study. Foods 2022; 11:foods11152267. [PMID: 35954036 PMCID: PMC9368466 DOI: 10.3390/foods11152267] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/29/2022] [Revised: 07/15/2022] [Accepted: 07/25/2022] [Indexed: 12/03/2022] Open
Abstract
The study compares the impact of freeze- and spray-drying (FD, SD) microencapsulation methods on the content of β-glucan, total polyphenols (TP), total flavonoids (TF), phenolic acids (PA), and antioxidant activity (AA) in commercially β-glucan powder (Pleurotus ostreatus) using maltodextrin as a carrier. Morphology (scanning electron microscopy- SEM), yield, moisture content (MC), and water activity (aw) were also evaluated in the samples. Our examinations revealed significant structural differences between powders microencapsulated by the drying methods. As compared to non-encapsulated powder, the SD powder with yield of 44.38 ± 0.55% exhibited more reduced (p < 0.05) values for aw (0.456 ± 0.001) and MC (8.90 ± 0.44%) than the FD one (yield: 27.97 ± 0.33%; aw: 0.506 ± 0.002; MC: 11.30 ± 0.28%). In addition, the highest values for β-glucan content (72.39 ± 0.38%), TPC (3.40 ± 0.17 mg GAE/g), and TFC (3.07 ± 0.29 mg QE/g) have been detected in the SD powder. Our results allow for the conclusion that the SD microencapsulation method using maltodextrin seems to be more powerful in terms of the β-glucan powder yield and its contents of β-glucan, TP, and TF as compared to the FD technique.
Collapse
Affiliation(s)
- Veronika Valková
- AgroBioTech Research Centre, Slovak University of Agriculture, Tr. A. Hlinku 2, 94976 Nitra, Slovakia; (V.V.); (H.Ď.); (M.O.); (Z.C.); (L.G.)
| | - Hana Ďúranová
- AgroBioTech Research Centre, Slovak University of Agriculture, Tr. A. Hlinku 2, 94976 Nitra, Slovakia; (V.V.); (H.Ď.); (M.O.); (Z.C.); (L.G.)
| | - Aude Falcimaigne-Cordin
- Enzyme and Cell Engineering, UPJV, CNRS, Université de Technologie de Compiègne, Centre de Recherche Royallieu-CS 60319-60 203 CEDEX, 60200 Compiègne, France; (A.F.-C.); (C.R.)
| | - Claire Rossi
- Enzyme and Cell Engineering, UPJV, CNRS, Université de Technologie de Compiègne, Centre de Recherche Royallieu-CS 60319-60 203 CEDEX, 60200 Compiègne, France; (A.F.-C.); (C.R.)
| | - Frédéric Nadaud
- Service d’Analyse Physico-Chimique, Université de Technologie de Compiègne, Centre de recherche Royallieu-CS 60319-60 203 CEDEX, 60200 Compiègne, France;
| | - Alla Nesterenko
- Integrated Transformations of Renewable Matter, ESCOM, Université de Technologie de Compiègne, Centre de Recherche Royallieu-CS 60319-60 203 CEDEX, 60200 Compiègne, France;
| | - Marvin Moncada
- Department of Food, Bioprocessing, and Nutrition Science, Nord Carolina State University, Raleigh, NC 27606, USA;
| | - Mykola Orel
- AgroBioTech Research Centre, Slovak University of Agriculture, Tr. A. Hlinku 2, 94976 Nitra, Slovakia; (V.V.); (H.Ď.); (M.O.); (Z.C.); (L.G.)
| | - Eva Ivanišová
- Institute of Food Sciences, Slovak University of Agriculture, Trieda Andreja Hlinku 2, 94976 Nitra, Slovakia;
| | - Zuzana Chlebová
- AgroBioTech Research Centre, Slovak University of Agriculture, Tr. A. Hlinku 2, 94976 Nitra, Slovakia; (V.V.); (H.Ď.); (M.O.); (Z.C.); (L.G.)
| | - Lucia Gabríny
- AgroBioTech Research Centre, Slovak University of Agriculture, Tr. A. Hlinku 2, 94976 Nitra, Slovakia; (V.V.); (H.Ď.); (M.O.); (Z.C.); (L.G.)
| | - Miroslava Kačániová
- Institute of Horticulture, Faculty of Horticulture and Landscape Engineering, Slovak University of Agriculture, Tr. A. Hlinku 2, 94976 Nitra, Slovakia
- Department of Bioenergy, Food Technology and Microbiology, Institute of Food Technology and Nutrition, University of Rzeszow, 4 Zelwerowicza Str., 35-601 Rzeszow, Poland
- Correspondence:
| |
Collapse
|
16
|
Tang Y, Li AP, Xiao J, Li D, Wang L. Construction of catechin and bamboo shoot dietary fiber compounds: Their protection and release of catechin during digestion. J FOOD PROCESS PRES 2022. [DOI: 10.1111/jfpp.16703] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
Affiliation(s)
- Yumei Tang
- College of Food Science and Engineering Central South University of Forestry and Technology Changsha China
| | - An Ping Li
- College of Food Science and Engineering Central South University of Forestry and Technology Changsha China
| | - Jianping Xiao
- College of Food Science and Engineering Central South University of Forestry and Technology Changsha China
| | - Dongyang Li
- College of Food Science and Engineering Central South University of Forestry and Technology Changsha China
| | - Le Wang
- College of Food Science and Engineering Central South University of Forestry and Technology Changsha China
| |
Collapse
|
17
|
Malekjani N, Jafari SM. Valorization of olive processing by-products via drying technologies: a case study on the recovery of bioactive phenolic compounds from olive leaves, pomace, and wastewater. Crit Rev Food Sci Nutr 2022; 63:9797-9815. [PMID: 35475951 DOI: 10.1080/10408398.2022.2068123] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022]
Abstract
Olive by-products are rich sources of phenolic compounds and their valorization is a favorable approach in line with sustainable development goals of the United Nations (UN) organization to promote well-being and production of healthier products; also, to deal with the environmental and economic subjects resulting in more profitability in the olive oil industry. The production of value-added ingredients from these by-products is not extensively exploited on the industrial scale. Drying is a critical pretreatment before extraction that can have a direct impact on the recovery and yield of the available bioactive compounds in olive by-products. In order to produce more stable and high quality phenolic products, encapsulation using spray and freeze drying is used. In this study, the effect of the drying process before and after extraction of bioactive compounds from olive by-products as a valuable source of phenolic compounds is reviewed. In addition, fortification using these ingredients and their incorporation in food formulations is also investigated.
Collapse
Affiliation(s)
- Narjes Malekjani
- Department of Food Science and Technology, Faculty of Agricultural Sciences, University of Guilan, Rasht, Iran
| | - Seid Mahdi Jafari
- Faculty of Food Science and Technology, Gorgan University of Agricultural Science and Natural Resources, Gorgan, Iran
- Nutrition and Bromatology Group, Department of Analytical Chemistry and Food Science, Faculty of Science, Universidade de Vigo, Ourense, Spain
| |
Collapse
|
18
|
De Luca I, Di Cristo F, Valentino A, Peluso G, Di Salle A, Calarco A. Food-Derived Bioactive Molecules from Mediterranean Diet: Nanotechnological Approaches and Waste Valorization as Strategies to Improve Human Wellness. Polymers (Basel) 2022; 14:1726. [PMID: 35566894 PMCID: PMC9103748 DOI: 10.3390/polym14091726] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/21/2022] [Revised: 04/15/2022] [Accepted: 04/21/2022] [Indexed: 02/04/2023] Open
Abstract
The beneficial effects of the Mediterranean diet (MedDiet), the most widely followed healthy diet in the world, are principally due to the presence in the foods of secondary metabolites, mainly polyphenols, whose healthy characteristics are widely recognized. However, one of the biggest problems associated with the consumption of polyphenols as nutraceutical adjuvant concerns their bioavailability. During the last decades, different nanotechnological approaches have been developed to enhance polyphenol bioavailability, avoiding the metabolic modifications that lead to low absorption, and improving their retention time inside the organisms. This review focuses on the most recent findings regarding the encapsulation and delivery of the bioactive molecules present in the foods daily consumed in the MedDiet such as olive oil, wine, nuts, spice, and herbs. In addition, the possibility of recovering the polyphenols from food waste was also explored, taking into account the increased market demand of functional foods and the necessity to obtain valuable biomolecules at low cost and in high quantity. This circular economy strategy, therefore, represents an excellent approach to respond to both the growing demand of consumers for the maintenance of human wellness and the economic and ecological exigencies of our society.
Collapse
|
19
|
Rezvankhah A, Emam‐Djomeh Z, Safari M, Salami M, Askari G. Investigating the effects of maltodextrin, gum arabic, and whey protein concentrate on the microencapsulation efficiency and oxidation stability of hemp seed oil. J FOOD PROCESS PRES 2022. [DOI: 10.1111/jfpp.16554] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/28/2022]
Affiliation(s)
- Amir Rezvankhah
- Transfer Phenomena Laboratory (TPL), Controlled Release Center, Department of Food Science, Technology and Engineering University College of Agriculture & Natural Resources, University of Tehran, Karaj Campus Karaj Iran
| | - Zahra Emam‐Djomeh
- Transfer Phenomena Laboratory (TPL), Controlled Release Center, Department of Food Science, Technology and Engineering University College of Agriculture & Natural Resources, University of Tehran, Karaj Campus Karaj Iran
- Functional Food Research Core (FFRC) University of Tehran Tehran Iran
- Center of Excellence in Biothermodynamics University of Tehran Tehran Iran
| | - Mohammad Safari
- Transfer Phenomena Laboratory (TPL), Controlled Release Center, Department of Food Science, Technology and Engineering University College of Agriculture & Natural Resources, University of Tehran, Karaj Campus Karaj Iran
| | - Maryam Salami
- Transfer Phenomena Laboratory (TPL), Controlled Release Center, Department of Food Science, Technology and Engineering University College of Agriculture & Natural Resources, University of Tehran, Karaj Campus Karaj Iran
- Functional Food Research Core (FFRC) University of Tehran Tehran Iran
| | - Gholamreza Askari
- Transfer Phenomena Laboratory (TPL), Controlled Release Center, Department of Food Science, Technology and Engineering University College of Agriculture & Natural Resources, University of Tehran, Karaj Campus Karaj Iran
- Functional Food Research Core (FFRC) University of Tehran Tehran Iran
| |
Collapse
|
20
|
Barradas‐Pretelín R, García‐Barradas O, Beristain‐Guevara CI, Mendoza‐López MR, Pascual‐Pineda LA, Flores‐Andrade E, Jiménez‐Fernández M. Effect of ginger extract on stability, physicochemical and antioxidant properties of avocado powder using maltodextrin as carrier. J FOOD PROCESS PRES 2022. [DOI: 10.1111/jfpp.16541] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Affiliation(s)
- Raúl Barradas‐Pretelín
- Centro de Investigación y Desarrollo en Alimentos, Universidad Veracruzana, Xalapa Veracruz México
| | | | | | | | - Luz A. Pascual‐Pineda
- Centro de Investigación y Desarrollo en Alimentos, Universidad Veracruzana, Xalapa Veracruz México
| | | | | |
Collapse
|
21
|
Rafiq S, Sofi SA, Kumar H, Kaul RK, Mehra R, Awuchi CG, Okpala COR, Korzeniowska M. Physicochemical, antioxidant, and polyphenolic attributes of microencapsulated freeze‐dried kinnow peel extract powder using maltodextrin as wall material. J FOOD PROCESS PRES 2021. [DOI: 10.1111/jfpp.16177] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/27/2022]
Affiliation(s)
- Shafiya Rafiq
- Division of Food Science & Technology Sher‐e‐Kashmir University of Agricultural Science & Technology Chatha India
| | - Sajad Ahmad Sofi
- Department of Food Technology Islamic University of Science & Technology Awantipora India
| | - Harish Kumar
- Amity Institute of Biotechnology Amity University Rajasthan Jaipur India
| | - Raj Kumari Kaul
- Division of Food Science & Technology Sher‐e‐Kashmir University of Agricultural Science & Technology Chatha India
| | - Rahul Mehra
- Amity Institute of Biotechnology Amity University Rajasthan Jaipur India
| | - Chinaza G. Awuchi
- Department of Biochemistry Kampala International University Bushenyi Uganda
| | - Charles Odilichukwu R. Okpala
- Department of Functional Foods Product Development Wrocław University of Environmental and Life Sciences Wrocław Poland
| | - Małgorzata Korzeniowska
- Department of Functional Foods Product Development Wrocław University of Environmental and Life Sciences Wrocław Poland
| |
Collapse
|
22
|
Flamminii F, Paciulli M, Di Michele A, Littardi P, Carini E, Chiavaro E, Pittia P, Di Mattia CD. Alginate-based microparticles structured with different biopolymers and enriched with a phenolic-rich olive leaves extract: A physico-chemical characterization. Curr Res Food Sci 2021; 4:698-706. [PMID: 34661168 PMCID: PMC8503818 DOI: 10.1016/j.crfs.2021.10.001] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/21/2021] [Revised: 10/02/2021] [Accepted: 10/04/2021] [Indexed: 11/26/2022] Open
Abstract
Encapsulation of olive leaves extracts (OLE), rich of healthy components like Oleuropein, Hydroxytyrosol and Verbascoside, represents a new challenge to improve stability and nutritional value of food as well as a way to recover value added compounds from by-products, contributing to a more sustainable food system. In this context, OLE-loaded microbeads of Na alginate alone or in combination with Pectin, Na Caseinate or Whey protein isolates, were produced by emulsification internal ionotropic gelation. Encapsulation efficiency of the main phenolic compounds (Oleuropein, Hydroxytyrosol, Verbascoside) was carried out along with microparticles morphological characterization by scanning electron microscopy (SEM), thermal properties by differential scanning calorimetry (DSC) and color. Encapsulation efficiency resulted higher for Alginate/Pectin, whilst Alginate/Caseinate was the less performing system, probably due to the lower interaction with polyphenols. SEM revealed collapsed structures and continuous smooth surfaces for Alginate and Alginate/Pectin microbeads while more regular structures and porous surfaces were observed for Alginate/Caseinate and Alginate/Whey proteins. Higher hue angle and lower chroma values were observed for all the beads with respect to the pure extract, indicating a reduction of the yellow/brown color. DSC highlighted higher thermal stability for the microbeads in comparison to the original ingredients, showing also new thermal transitions related to bonds formation between polymers and OLE. Verbascoside showed higher encapsulation efficiency compared to Oleuropein. Alginate/Pectin was the most efficient system for encapsulation purposes. Microstructural traits were linked to the encapsulation efficiency. Thermal analysis revealed increased thermal stability of encapsulated polyphenols. Encapsulation allowed a mitigation of the color properties of the olive leaf extract.
Collapse
Affiliation(s)
- Federica Flamminii
- Faculty of Bioscience and Technology for Agriculture, Food and Environment, University of Teramo, Via Balzarini 1, 64100, Teramo, Italy
| | - Maria Paciulli
- Department of Food and Drug, University of Parma, Parco Area Delle Scienze 27/A, 43124, Parma, Italy
| | - Alessandro Di Michele
- Department of Physics and Geology, University of Perugia, Via Pascoli, 06123, Perugia, Italy
| | - Paola Littardi
- Department of Food and Drug, University of Parma, Parco Area Delle Scienze 27/A, 43124, Parma, Italy
| | - Eleonora Carini
- Department of Food and Drug, University of Parma, Parco Area Delle Scienze 27/A, 43124, Parma, Italy
| | - Emma Chiavaro
- Department of Food and Drug, University of Parma, Parco Area Delle Scienze 27/A, 43124, Parma, Italy
| | - Paola Pittia
- Faculty of Bioscience and Technology for Agriculture, Food and Environment, University of Teramo, Via Balzarini 1, 64100, Teramo, Italy
| | - Carla Daniela Di Mattia
- Faculty of Bioscience and Technology for Agriculture, Food and Environment, University of Teramo, Via Balzarini 1, 64100, Teramo, Italy
| |
Collapse
|
23
|
Zhao L, Duan X, Cao W, Ren X, Ren G, Liu P, Chen J. Effects of Different Drying Methods on the Characterization, Dissolution Rate and Antioxidant Activity of Ursolic Acid-Loaded Chitosan Nanoparticles. Foods 2021; 10:foods10102470. [PMID: 34681519 PMCID: PMC8535679 DOI: 10.3390/foods10102470] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/31/2021] [Revised: 10/05/2021] [Accepted: 10/11/2021] [Indexed: 01/08/2023] Open
Abstract
To improve the water solubility of ursolic acid (UA), UA-loaded chitosan nanoparticles were firstly prepared by the ionotropic gelation method and dried by freeze drying (FD), microwave freeze drying (MFD) and spray drying (SD). The characterization of UA-loaded chitosan nanoparticles was performed with particle size, drug loading (DL), scanning electron microscope (SEM), fourier transform infrared spectroscopy (FT-IR), differential scanning calorimetry (DSC), dissolution studies and antioxidant activity. The results demonstrated that UA was successfully encapsulated into chitosan nanoparticles using sodium tripolyphosphate (TPP) as a cross-linker, with a 79% encapsulation efficiency. The spray-dried, UA-loaded chitosan nanoparticles had the lowest drug loading (11.8%) and the highest particle size (496.9 ± 11.20 nm). The particle size of UA-loaded chitosan nanoparticles dried by MFD and FD was lower, at 240.8 ± 12.10 nm and 184.4 ± 10.62 nm, respectively, and their antioxidant activity was higher than those nanoparticles dried by SD. Moreover, the drying time and energy consumption of UA-loaded chitosan nanoparticles dried by MFD and SD were lower than that of FD. The dissolution rates of UA-loaded chitosan nanoparticles prepared by FD and MFD were 60.6% and 57.1%, respectively, in a simulated gastric fluid, which was a greater value than SD (55.9%). Therefore, the UA-loaded chitosan nanoparticles encapsulation method, combined with MFD technology, showed a promising potential to improve the water solubility of UA.
Collapse
Affiliation(s)
| | - Xu Duan
- Correspondence: ; Tel.: +86-13653872870
| | | | | | | | | | | |
Collapse
|
24
|
Alnusaire TS. Olive Leaves (Olea europaea L) Extract Loaded Lipid Nanoparticles: Optimization of Processing Parameters by Box-Behnken Statistical Design, in-vitro Characterization, and Evaluation of Anti-oxidant and Anti-microbial Activity. J Oleo Sci 2021; 70:1403-1416. [PMID: 34615828 DOI: 10.5650/jos.ess21149] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/13/2022] Open
Abstract
The present study was aimed to prepare and evaluated solid lipid nanoparticles (SLNs) of olive leaves extract powder (OLP) which contained many anti-oxidant and antimicrobial agents like oleuropein, a natural polyphenol. The major issue concern OLP was the instability due to environmental conditions and hence compromised bioactivity. To overcome this problem, SLNs were designed by hot homogenous followed by sonication technique to protect the drug and improve its antioxidant and antimicrobial activity. Lipids like compritol 888ATO and surfactant like tween 80 were used for the development and stabilization of SLNS and optimization was done by Box-Behnken statistical design (3x3). The optimized batch (F9) showed particle size, entrapment efficiency, PDI, and zeta potential 277.46 nm, 80.48%, 0.275, and -23.18 mV respectively. Optimized formulation (F9) exhibited a sustained release pattern up to 24 h with first-order release kinetic (R2 = 0.9984) and the mechanism of drug release was found to be Fickian diffusion type (n = 0.441). Upon the stability study, it could be found that SLNs formulation was stable. Anti-oxidation and anti-microbial studies were conducted on optimized formulation and findings suggested that SLNs showed an improved radical scavenging activity and anti-microbial activity against Gram-positive (Staphylococcus aureus) and Gram-negative (Pseudomonas aeruginosa) bacteria. Finally, it was concluded that developed SLNs were able to protect and suitable for the delivery of OLP.
Collapse
Affiliation(s)
- Taghreed S Alnusaire
- Biology Department, College of Science, Jouf University.,Olive Research Center, Jouf University
| |
Collapse
|
25
|
Marcillo-parra V, Tupuna-yerovi DS, González Z, Ruales J. Encapsulation of bioactive compounds from fruit and vegetable by-products for food application – A review. Trends Food Sci Technol 2021; 116:11-23. [DOI: 10.1016/j.tifs.2021.07.009] [Citation(s) in RCA: 26] [Impact Index Per Article: 8.7] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
26
|
Huang K, Yuan Y, Baojun X. A Critical Review on the Microencapsulation of Bioactive Compounds and Their Application. Food Reviews International 2021. [DOI: 10.1080/87559129.2021.1963978] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
Affiliation(s)
- Kehao Huang
- Food Science and Technology Program, BNU-HKBU United International College, Zhuhai, China
- Department Of Food Science And Agricultural Chemistry, McGill University, Quebec, Canada
| | - Yingzhi Yuan
- Food Science and Technology Program, BNU-HKBU United International College, Zhuhai, China
- Department Of Biochemistry, University College London, London, UK
| | - Xu Baojun
- Food Science and Technology Program, BNU-HKBU United International College, Zhuhai, China
| |
Collapse
|
27
|
Al-Maqtari QA, Mohammed JK, Mahdi AA, Al-Ansi W, Zhang M, Al-Adeeb A, Wei M, Phyo HM, Yao W. Physicochemical properties, microstructure, and storage stability of Pulicaria jaubertii extract microencapsulated with different protein biopolymers and gum arabic as wall materials. Int J Biol Macromol 2021; 187:939-954. [PMID: 34343588 DOI: 10.1016/j.ijbiomac.2021.07.180] [Citation(s) in RCA: 21] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/05/2021] [Revised: 07/22/2021] [Accepted: 07/27/2021] [Indexed: 01/16/2023]
Abstract
This study aimed to evaluate the possibility of using gum arabic (GA) with different protein materials namely whey protein isolate (WP), sodium caseinate (SC), and soybean protein (SP) as wall materials to encapsulate Pulicaria jaubertii extract (PJ) using freeze-drying. Four formulations of microencapsulation of Pulicaria jaubertii extract (MPJE) were produced, including WPGA-MPJE, SCGA-MPJE, SPGA-MPJE, and GA-MPJE. The formulations were stored at 4 °C and 25 °C for 28 days to assess the storage stability. The results indicated that mixtures of proteins with GA improved the physicochemical properties and bioactive content of the MPJE compared to GA-MPJE. The SCGA-MPJE formula showed optimal values of particle size (450.13 nm), polydispersity index (0.33), zeta potential (74.63 mV), encapsulation efficiency (91.07%), total phenolic content (25.51 g GAE g-1 capsules), and antioxidants compounds, as well as presented a lower release of bioactive composites with high oxidative stability during storage at 4 °C and 25 °C. The microstructure of MPJE formulations showed a flat surface without any visible cracking on surfaces. The microcapsules prepared from protein mixtures with GA, especially the SCGA-MPJE formula, are the most efficient in encapsulating the plant extract derived from the PJ, which could be useful for application in various industrial fields.
Collapse
Affiliation(s)
- Qais Ali Al-Maqtari
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China; International Joint Laboratory on Food Safety, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China; Department of Biology, Faculty of Science, Sana'a University, Sana'a, Yemen; Department of Food Science and Technology, Faculty of Agriculture, Sana'a University, Sana'a, Yemen
| | - Jalaleldeen Khaleel Mohammed
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China
| | - Amer Ali Mahdi
- Department of Food Science and Technology, Faculty of Agriculture, Sana'a University, Sana'a, Yemen; School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Waleed Al-Ansi
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China; Department of Food Science and Technology, Faculty of Agriculture, Sana'a University, Sana'a, Yemen
| | - Mi Zhang
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China
| | - Abdulqader Al-Adeeb
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China
| | - Minping Wei
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China; International Joint Laboratory on Food Safety, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China
| | - Hsu Mon Phyo
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China; International Joint Laboratory on Food Safety, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China
| | - Weirong Yao
- State Key Laboratory of Food Science and Technology, School of Food Science and Technology, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China; International Joint Laboratory on Food Safety, Jiangnan University, 1800 Lihu Avenue, Wuxi 214122, Jiangsu Province, China.
| |
Collapse
|
28
|
Karagozlu M, Ocak B, Özdestan-ocak Ö. Effect of Tannic Acid Concentration on the Physicochemical, Thermal, and Antioxidant Properties of Gelatin/Gum Arabic–Walled Microcapsules Containing Origanum onites L. Essential Oil. FOOD BIOPROCESS TECH 2021; 14:1231-43. [DOI: 10.1007/s11947-021-02633-y] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
|
29
|
|
30
|
Abstract
Drying is among the most important processes and the most energy-consuming techniques in the food industry. Dried food has many applications and extended shelf life. Unlike the majority of conventional drying methods, lyophilization, also known as freeze-drying (FD), involves freezing the food, usually under low pressure, and removing water by ice sublimation. Freeze-dried materials are especially recommended for the production of spices, coffee, dried snacks from fruits and vegetables and food for military or space shuttles, as well as for the preparation of food powders and microencapsulation of food ingredients. Although the FD process allows obtaining dried products of the highest quality, it is very energy- and time consuming. Thus, different methods of pretreatment are used for not only accelerating the drying process but also retaining the physical properties and bioactive compounds in the lyophilized food. This article reviews the influence of various pretreatment methods such as size reduction, blanching, osmotic dehydration and application of pulsed electric field, high hydrostatic pressure or ultrasound on the physicochemical properties of freeze-dried food and drying rate.
Collapse
|
31
|
Estupiñan-Amaya M, Fuenmayor CA, López-Córdoba A. New Freeze-Dried Andean Blueberry Juice Powders for Potential Application as Functional Food Ingredients: Effect of Maltodextrin on Bioactive and Morphological Features. Molecules 2020; 25:molecules25235635. [PMID: 33265991 PMCID: PMC7730302 DOI: 10.3390/molecules25235635] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/29/2020] [Revised: 11/18/2020] [Accepted: 11/23/2020] [Indexed: 12/31/2022] Open
Abstract
Andean blueberry (Vaccinium meridionale Swartz) fruits are an underutilized source of anthocyanins and other valuable bioactive phytochemicals. The purpose of this work was to obtain Andean blueberry juice powders via freeze-drying processing and evaluate the effect of maltodextrin as a drying aid on their physicochemical, technological, microstructural, and bioactive characteristics. Andean blueberry juices were mixed with variable proportions of maltodextrin (20–50%); freeze-dried; and characterized in terms of their tristimulus color, Fourier transform infrared spectra (FTIR), moisture content, water activity, morphology, water solubility, flow properties, total polyphenols and anthocyanins content, and DPPH•-scavenging capacity. The powders obtained presented suitable characteristics in terms of their water activity (<0.5), solubility (>90%), and bioactive compound recovery (>70% for total phenolics, and >60% for total monomeric anthocyanins), with antioxidant activities up to 4 mg equivalent of gallic acid/g of dry matter. Although an increased content of maltodextrin resulted in lower concentrations of phytochemicals, as expected, it also favored an increased % recovery (over 90% of total phenolics at the highest maltodextrin proportion) and improved their flow properties. Freeze-dried juice powders are a potential alternative for the stabilization and value addition of this fruit as a new source of functionality for processed foods.
Collapse
Affiliation(s)
- Mauren Estupiñan-Amaya
- Facultad Seccional Duitama, Escuela de Administración de Empresas Agropecuarias, Universidad Pedagógica y Tecnológica de Colombia, Carrera 18 con Calle 22 Duitama, Boyaca 150461, Colombia;
| | - Carlos Alberto Fuenmayor
- Instituto de Ciencia y Tecnología de Alimentos (ICTA), Universidad Nacional de Colombia, Av. Carrera 30 # 45-03, Bogota 111321, Colombia;
| | - Alex López-Córdoba
- Facultad Seccional Duitama, Escuela de Administración de Empresas Agropecuarias, Universidad Pedagógica y Tecnológica de Colombia, Carrera 18 con Calle 22 Duitama, Boyaca 150461, Colombia;
- Correspondence: ; Tel.: +57-8-7604100
| |
Collapse
|
32
|
Flamminii F, Di Mattia CD, Sacchetti G, Neri L, Mastrocola D, Pittia P. Physical and Sensory Properties of Mayonnaise Enriched with Encapsulated Olive Leaf Phenolic Extracts. Foods 2020; 9:E997. [PMID: 32722352 DOI: 10.3390/foods9080997] [Citation(s) in RCA: 26] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/01/2020] [Revised: 07/21/2020] [Accepted: 07/22/2020] [Indexed: 11/16/2022] Open
Abstract
This work aimed to study the physical, structural, and sensory properties of a traditional full-fat mayonnaise (≈ 80% oil) enriched with an olive leaf phenolic extract, added as either free extract or encapsulated in alginate/pectin microparticles. Physical characterization of the mayonnaise samples was investigated by particle size, viscosity, lubricant properties, and color; a sensory profile was also developed by a quantitative descriptive analysis. The addition of the extract improved the dispersion degree of samples, especially when the olive leaf extract-loaded alginate/pectin microparticles were used. The encapsulated extract affected, in turn, the viscosity and lubricant properties. In particular, both of the enriched samples showed a lower spreadability and a higher salty and bitter perception, leading to a reduced overall acceptability. The results of this study could contribute to understanding the effects of the enrichment of emulsified food systems with olive by-product phenolic extracts, both as free and encapsulated forms, in order to enhance real applications of research outcomes for the design and development of healthy and functional formulated foods.
Collapse
|