Microstructures and Electrochemical Dissolution Characteristics of Additive-Manufactured Stainless Steel 304 on Different Sections at Low Current Density

Additive manufacturing (AM) is a burgeoning technology for fabricating complex components with high efficiency and low material waste. However, the surface of AM parts is rough owing to partially melted powders and severe surface fluctuation. Electrochemical machining (ECM) is a suitable postprocessing method to finish the surface of the AM parts, and the low current density is usually employed. Our study illustrates the electrochemical dissolution characteristics of the horizontal and vertical sections of the AM SUS 304 component under a low current density and the electrochemical finishing process to obtain smooth surfaces. Linear and fan-shaped melt pools are observed on the horizontal and vertical sections, respectively. Moreover, the melt pool boundaries are vulnerable to dissolution and separate the hollows, basins, and swellings formed after electrochemical dissolution. The two sections display similar current efficiency and polarization because of the single austenitic phase and the identical and uniform elemental content distribution. The top and side surfaces of the AM sample could be efficiently smoothened via ECM by eliminating the partially melted powders and significantly reducing the surface roughness. The numerous band humps make the top surface of the AM sample difficult to smoothen compared with the side surface under the point effect of the electric field.

A gross anatomical study of the styloid process of the temporal bone in Japanese cadavers

BACKGROUND

The incidence of an elongated styloid process (SP) and average length and diameter of SP have not been reported using Japanese cadavers. Data on the female-to-male ratio of an elongated SP vary. We calculated the average length and diameter of SP in Japanese cadavers and compared SP lengths between sexes.

MATERIALS AND METHODS

Twenty-seven sides (right and left of bodies) in males and 51 sides in females were analyzed. Measurements were obtained from the inferior external acoustic meatus to the distal tip of the SP. SP diameters at the proximal base, midpoint, and distal tip were measured. SP >30 mm was considered elongated. We used Welch's t-test for the statistical analysis. Fisher's exact two-tailed test was also performed to analyze the female-to-male elongation ratio. A p-value <0.05 was considered statistically significant.

RESULTS

SP elongation prevalence was 29.5% in our sample. The average full length was 27.04±7.88 mm overall; the average diameters were 5.41±1.77 mm at the proximal base and 2.21±1.22 mm at the distal tip. The average SP measurement was 26.81±5.92 mm in males and 27.16±8.79 mm in females (p=0.74). The female-to-male ratio of SP elongation was 1:2 (p=0.041). Females had longer full lengths of non-elongated SPs than males (p=0.004). Males had wider diameters at the proximal base of elongated SPs than females (p=0.017).

CONCLUSIONS

The average length of SP was 27.04 mm in the Japanese population and about 30% of the Japanese presented SP≥30 mm. Male had significantly higher rate than female among the SP≥30 mm, and female had significantly longer SPs than male among the SP<30 mm. Anatomically, the SP gets narrow as distally goes. Our anatomical findings would be beneficial to creating treatment plans, diagnosis, and surgery.

Variations in the gonadal artery with a single common trunk: embryological hypotheses by observation

BACKGROUND

A gonadal artery originates as a branch of the abdominal aorta and renal artery inferior to the level of origin of the renal arteries. Variations in multiple right testicular arteries (RTAs) arising from the abdominal aorta are common. We aimed to re-evaluate the unusual courses of gonadal arteries with a single common trunk in relation to the inferior vena cava and left renal vein and explain the developmental anatomy.

MATERIALS AND METHODS

The observational cross-sectional study was performed on 54 Japanese adult cadavers (29 men and 25 women). We examined the literature and developed embryological hypotheses on the single common trunk of the gonadal artery.

RESULTS

The gonadal artery, testicular artery, and ovarian artery arose from the abdominal aorta in 93.1%, 96.3%, and 89.6% of cases, respectively, and from the renal artery in 4.9%, 3.7%, and 6.3% of cases, respectively. We found two rare variations in the RTAs observed during the routine dissection of two male cadavers; in these two cases, a single common trunk of the RTAs originated from the abdominal aorta. A single common trunk was found in 3.7% of cadavers, 2.0% of sides, and 2.0% of arteries in the gonadal artery and in 6.9% of cadavers, 3.8% of sides, and 3.7% of arteries in the testicular artery. All cases of the single common trunk, including those in past reports, were observed only in men.

CONCLUSIONS

Knowledge of the variations in RTAs has important clinical consequences for invasive and non-invasive arterial procedures. In addition, this variation provides a new interpretation of the embryology of the gonadal artery. Variations similar to our findings have not been previously reported. Therefore, different variations concerning the RTA should be considered during surgical and non-surgical evaluations.

Calculation of Likelihood Ratio for Identifying Half Sibling Relationship When Both Biological Mothers Participate

Objective To derive the formulae for likelihood ratio （LR） calculation of half sibling relationships when both mothers participate. Methods Based on the fact that both biological mothers participate in the identification of half sibling relationship between the two individuals, test hypothesis for the identification of half sibling relationship was established. Conditional probability ratios of genetic evidence under null hypothesis and alternative hypothesis conditions were simplified, and then applied to a real case of half sibling relationship identification. At the same time, the LR of half sibling relationships under the assumption that only a single biological mother or none of the biological mothers participate were respectively calculated. Results In the cases of identification of half sibling relationship from same fathers, with no biological father involved, after the same genetic indicator test analysis, when both biological mothers participate in the identification, the accumulated LR value was higher than that of accumulated LR with only a single biological mother or no parents participating. Conclusion When the autosome STR test is used for the identification and analysis of half sibling relationship between two individuals, the calculation of LR is more simple, intuitive and operable with both mothers participating. The biological mothers should participate in the test as much as possible, otherwise the number of STR loci would need to be increased for a more specific conclusion.

Investigation of material removal in inner-jet electrochemical grinding of GH4169 alloy

Electrochemical grinding (ECG) is a low-cost and highly efficient process for application to difficult-to-machine materials. In this process, the electrolyte supply mode directly affects machining stability and efficiency. This paper proposes a flow channel structure for an abrasive tool to be used for inner-jet ECG of GH4169 alloy. The tool is based on a dead-end tube with electrolyte outlet holes located in the sidewall. The diameter and number of outlet holes are determined through numerical simulation with the aim of achieving uniform electrolyte flow in the inter-electrode gap. Experiments show that the maximum feed rate and material removal rate are both improved by increasing the diamond grain size, applied voltage, electrolyte temperature and pressure. For a machining depth of 3 mm in a single pass, a feed rate of 2.4 mm min⁻¹ is achieved experimentally. At this feed rate and machining depth, a sample is produced along a feed path under computer numerical control, with the feed direction changing four times. Inner-jet ECG with the proposed abrasive tool shows good efficiency and flexibility for processing hard-to-cut metals with a large removal depth.

[Risk for metastasis of lymph node between sternocleidomastoid and sternohyoid muscle in papillary thyroid cancer]

Objective: To analyze the risk factors for metastasis of lymph nodes between sternocleidomastoid and sternohyoid muscle (LNSS) in papillary thyroid cancer (PTC). Methods: Papillary thyroid cancer patients with clinically positive lateral lymph node metastasis (cN1) who underwent surgery including LNSS dissection between May 1, 2013 and May 31, 2016 at the Department of Head and Neck Surgery, Fudan University Shanghai Cancer Center were retrospectively studied. Logistic regression analysis was performed to evaluate possible clinicopathological factors related to LNSS metastasis. Results: In 85 patients, 54 patients (63.5%) showed LNSS in their surgical specimen, and 20 patients (23.5%) had pathologically positive LNSS metastasis. Patients with LNSS showed preoperatively higher levels of serum thyroid stimulating hormone (TSH) and thyroid peroxidase antibody (TPO-Ab) compared to patients only with fibrofatty tissues between sternocleidomastoid and sternohyoid muscle (P<0.05), and they also displayed a higher proportion of multifocality in ipsilateral thyroid lobe (P<0.05). Multi-factor analysis indicated that LNSS metastasis was correlated with original tumor size (OR=1.819, 95%CI 1.050-3.850, P=0.002) and Level Ⅳ lymph node metastasis (OR=2.190, 95%CI 1.132-2.334, P=0.005). Furthermore, the number of positive LNSS was tightly correlated to that of level Ⅳ lymph node metastasis(P<0.05). Conclusion: LNSS metastasis is occult but not quite rare in PTC. Patients with extensive lymph node metastasis in Level Ⅳhave a higher risk for metastasis of LNSS.

Evaluation of immunogenicity and protective efficacy of recombinant ptfA of avian Pasteurella multocida

Avian Pasteurella multocida is the causative agent of fowl cholera, a disease much affecting the poultry industry. In order to study the efficacy of the recombinant subunit vaccine constructed with ptfA gene of avian P. multocida, the ptfA gene fragment amplified by PCR from avian P. multocida was cloned into the prokaryotic expression vector pET32a and the recombinant plasmid pET32a-ptfA was obtained. The pET32a-ptfA was expressed in Escherichiacoli BL21(DE3) and the target protein rPtfA was purified. The purified protein was then mixed with Freund's adjuvant and the recombinant subunit vaccine was obtained. Three groups of chickens labeled as rPtfA, attenuated live vaccine and PBS were vaccinated with the recombinant subunit vaccine, attenuated live vaccine and PBS, respectively. Serum antibodies, peripheral blood lymphocyte proliferation (PBLP) and interferon-γ (IFN-γ) level secreted by peripheral blood lymphocyte were tested. The immunized chickens were finally challenged with virulent avian P. multocida and the protection rate was counted. Indirect ELISA showed the levels of antibodies in rPtfA and attenuated vaccine groups were most significantly higher than the other groups (P<0.01), and the former was slightly lower than the latter. Peripheral blood lymphocyte proliferation experiments and IFN-γ experiments indicated that SI value and the levels of IFN-γ induced by ConA in the two vaccine groups were significantly higher than those of the PBS groups (P<0.01), and that the attenuated vaccine group was higher than the rPtfA group. The protection rates of rPtfA and attenuated live vaccines were 45% and 75%, respectively. The results indicated that the PtfA recombinant subunit vaccine was capable of improving the immunity level and inducing a protective effect for the vaccinated chickens, but it was barely satisfactory.

Note: Electrochemical etching of cylindrical nanoprobes using a vibrating electrolyte

An electrochemical etching process using a vibrating electrolyte of potassium hydroxide to prepare tungsten cylindrical nanotips is developed. The vibrating electrolyte eases the effects of a diffusion layer and extends the etching area, which aid in the production of cylindrical nanotips. Larger amplitudes and a vibration frequency of 35 Hz are recommended for producing cylindrical nanotips. Nanotips with a tip radius of approximately 43 nm and a conical angle of arctan 0.0216 are obtained.

Note: Buoyant-force assisted liquid membrane electrochemical etching for nano-tip preparation

A liquid membrane electrochemical etching process for preparing nano-tips is proposed by the introduction of buoyant force to the lower tip, in which the lower portion of the anodic wire is immersed into a floating layer. A mathematical model of this method is derived. Both calculation and experimental results demonstrate that the introduction of buoyant force can significantly decrease the tip radius. The lubricating oil and deionized water floating layers were tested for the processing of nano-tips. Further, high-aspect-ratio nano-electrodes were prepared by applying a relative vertical movement to the anodic wire.

Detection of fetal sex chromosome aneuploidy by massively parallel sequencing of maternal plasma DNA: initial experience in a Chinese hospital

OBJECTIVES

To evaluate the performance of a massively parallel sequencing (MPS)-based test in detecting fetal sex chromosome aneuploidy (SCA) and to present a comprehensive clinical counseling protocol for SCA-positive patients.

METHODS

This was a retrospective study in a large patient cohort of 5950 singleton pregnancies which underwent MPS-based testing as a prenatal screening test for trisomies 21, 18 and 13, with X and Y chromosomes as secondary findings, in Southwest Hospital in China. MPS-based SCA-positive women were offered the choice of knowing whether their SCA results were positive and those who did commenced a two-stage post-test clinical counseling protocol. In Stage 1, general information about SCA was given, and women were given the option of invasive testing for confirmation of findings; in Stage 2, those who had chosen to undergo invasive testing were informed about the specific SCA affecting their fetus and their management options.

RESULTS

Thirty-three cases were classified as SCA-positive by MPS-based testing. After Stage 1 of the two-stage post-test clinical counseling session, 33 (100%) of these pregnant women chose to know the screening test results, and 25 (75.76%) underwent an invasive diagnostic procedure and karyotype analysis, in one of whom karyotyping failed. In thirteen cases, karyotyping confirmed the MPS-based test results (two X0 cases, seven XXX cases, three XXY cases and one XYY case), giving a positive predictive value of 54.17% (13/24 cases confirmed by karyotyping). After post-test clinical counseling session Stage 2, seven women chose to terminate the pregnancy: one X0 case, two XXX cases, the three XXY cases and the single XYY case. Six women decided to continue with pregnancy: one X0 case and five XXX cases.

CONCLUSION

Our study showed the feasibility of clinical application of the MPS-based test in the non-invasive detection of fetal SCA. Together with a two-stage post-test clinical counseling protocol, it leads to a well-informed decision-making procedure.

Fabrication of a high-aspect-ratio sub-micron tool using a cathode coated with stretched-out insulating layers

This paper describes a method for preparing a high-aspect-ratio sub-micron tool using a cathode coated with stretched-out insulating layers and a straight reciprocating motion applied at the anode via the liquid membrane electrochemical machining (ECM). Simulation results indicate that the application of a cathode coated with stretched-out insulating layers is beneficial for the localization of ECM. Moreover, a mathematical model was derived to estimate the final average diameter of the fabricated tools. Experiments were conducted to verify the versatility and feasibility of the proposed method and its mathematical model. It was observed that the calculated and the experimental results are in good agreement with each other. A sub-micron tool with an average diameter 140.8 nm and an aspect ratio up to 50 was fabricated using the proposed method.

Chronological changes of delayed-type hypersensitivity in mice immunised with testicular germ cells alone

Experimental autoimmune orchitis (EAO), comprising a breakdown of the testicular immune privilege, is one of the models of immunological male infertility. EAO is characterised by CD4 + T-cell-dependent lymphocytic inflammation and augmented delayed-type hypersensitivity (DTH) against testicular antigens. We previously established an EAO model in mice by immunisation with viable syngeneic testicular germ cells (TGC) alone. However, the sequential change of DTH during development of this EAO has not been analysed yet. In this study, the DTH response during TGC-induced EAO was investigated by the injection of syngeneic TGC protein into the ears of mice. The results showed that a significant DTH response was observed on injection of 20 μg TGC protein, but not on that of 0.2 or 2 μg TGC protein. Also, the level of the DTH response to 20 μg TGC protein was highly relevant to the pathology of EAO development. These results indicate that the DTH response on injection of 20 μg TGC protein into the ears of mice is effective for predicting the pathology of EAO development.

Structure of thymic cysts in congenital lymph nodes-lacking mice

The ALY (aly/aly) mouse, a mutant of the C57BL/6j strain, has a severe immunodeficiency because of immature development of the immune organs. Both lymph nodes and Peyer's patches are lacking and both the thymus and spleen are small. Previous microscopical observation of their thymus glands revealed the presence of an indistinct border between the cortex and medulla, the absence of Hassal's corpuscles and the reduction of the medullary epithelial cell population. However, other microscopical findings for these glands have not yet been reported. In the present study, we performed light and electron microscopical observation of the thymus and found the consistent presence of extremely irregular shaped cystic cavities lined by microvilli-bearing epithelium in the medulla. The cysts comprised ceca and did not open into adjacent capillaries, although they contained some lymphocytes and macrophages in their lumens. In the thymus glands of normal C57BL/6j mice, only some small cysts oval in shape could be inconspicuously found in the medulla. Therefore, the thymic cysts may normally regress during thymic development, however, in ALY mice, the cysts may remain because of the organ immaturity.

Simultaneous determination of two active components in compound aspirin tablets using principal component artificial neural networks (PC-ANNs) on NIR spectroscopy

A method for simultaneous, non-destructive analysis of aspirin and phenacetin in compound aspirin tablets with different concentrations has been developed by principal component artificial neural networks (PC-ANNs) on near-infrared (NIR) spectroscopy. In PC-ANNs models, the spectra data were first analyzed by principal component analysis (PCA). Then the scores of the principal compounds (PCs) were chosen as input nodes for input layer instead of the spectra data. The artificial neural networks (ANNs) models using the spectra data as input nodes were also established, which were compared with the PC-ANNs models. Four different preprocessing methods (first-derivation, second-derivation, standard normal variate (SNV) and multiplicative scatter correction (MSC)) were applied to NIR conventional spectra. The result shows the first-derivative model of PC-ANNs multivariate calibration has the lowest training errors and predicting errors. The concept of the degree of approximation was introduced and performed as the selective criterion of the optimum network parameters.

[Studies on the determination of serum thymic factor by capillary zone electrophoresis]

The determination of serum thymic factor (FTS) by capillary zone electrophoresis was described. The optimum ionic concentration and the pH value of buffer system was examined through orthogonal analysis. The optimum conditions found to be 0.05 mol/L sodium tetraborate, 0.01 mol/L phosphate buffer at pH 8.70, working voltage at 12 kV and wavelength at 200 nm. The recoveries for FTS standards added to the bovine serum albumin and serum samples were measured. The values of the relative standard deviation(RSD), recovery and detection limit were 7.62%, 80.28% and 40 ng/ml respectively. The development of this method provide another way for studying the relations of zinc and thymic factor and investigating the effect of zinc on immune function.

[Effect of methionine supplementation on the selenium bioavailability in rats fed on grains from Keshan disease endemic area]

In order to study the effect of dietary methionine on tissue selenium and glutathione peroxidase activity(GPX) in rats fed on grains from Keshan Disease endemic area, a nonpurified selenium (Se) deficient diet (containing Se 0.007 mg/kg diet) taken from Keshan Disease endemic area was supplemented with selenomethionine (SeMet) to provide selenium content in diet for 0.007, 0.06 and 0.50 mg/kg and added or not added with DL-methionine (Met) 4 g/kg to make 6 kinds of diet. Fifty four male weanling Wistar rats were randomly divided into 6 groups, consuming each one of the 6 diets for 8 weeks. The Se content and GPX activity in tissues of animals with Met supplementation were compared with those without Met supplementation. The results showed that adding Met did not result in significant changes of tissue Se content and GPX activity in animals having dietary Se of 0.007 mg/kg, except for lower muscle Se content. However, in animals having dietary Se of 0.06 mg/kg and supplementing Met resulted in selenium redistribution in tissues-decrease of Se content in muscle, increase of Se content in liver and blood and significant elevation of GPX activity in all tissues. In animals having methionine-added and dietary Se of 0.50 mg/kg, tissue Se content declined to various extent, while GPX activity remained unchanged. The results suggest that SeMet (main chemical form of Se in cereals) is preferentially incorporated into body protein when dietary methionine is limited. Once Met is supplemented, dietary SeMet would provide more Se for the syntheses of GPX and other selenoproteins. The results further suggest that marginal deficiency in sulfur-containing amino acids in the diet from Keshan Disease endemic area might be an additional factor for the development of Keshan Disease under selenium deficiency.

An ethanol inducible gene switch for plants used to manipulate carbon metabolism

Many transgenic plant studies use constitutive promoters to express transgenes. For certain genes, deleterious effects arise from constant expression in all tissues throughout development. We describe a chemically inducible plant gene expression system, with negligible background activity, that obviates this problem. We demonstrate its potential by showing inducible manipulation of carbon metabolism in transgenic plants. Upon rapid induction of yeast cytosolic invertase, a marked phenotype appears in developing leaves that is absent from leaves that developed before induction or after it has ceased.

Mutations in the Fas antigen in patients with multiple myeloma

Programmed cell death, or apoptosis, is well documented as a physiological means of eliminating activated lymphocytes and maintaining immune homeostasis. Apoptosis has also been implicated in the targeting of tumor cells by cytotoxic T lymphocytes and natural killer cells. One of the two primary mechanisms used in cell-mediated cytotoxicity is the Fas/FasLigand system. Activated or transformed cells expressing the Fas antigen on their surface are susceptible to killing by immune effector cells that express the Fas ligand. Many neoplastic cells, including those derived from patients with multiple myeloma, express Fas antigen on their surface, but do not undergo apoptosis in response to antigen crosslinking. One possibility for the lack of Fas-mediated apoptosis includes mutations in the Fas antigen. Loss of function mutations in the Fas antigen have been associated with congenital autoimmune disease in humans, and have been defined as the genetic defect the in lpr mice. Mutations in the Fas antigen have not been previously described in cancer patients. In this study, we show that mutations occur in the Fas antigen which may cause loss of function and contribute to the pathogenesis of the neoplastic disease, multiple myeloma. Using reverse transcriptase-polymerase chain reaction (RT-PCR), single-stranded conformation polymorphism (SSCP) analysis, and DNA sequencing, we examined the cDNA structure of the Fas antigen in 54 bone marrow (BM) specimens obtained from myeloma patients. Six patient specimens (11%) did not express detectable levels of Fas antigen mRNA. Of the 48 BM specimens which did express Fas antigen, 5 (10%) displayed point mutations. All of the mutations identified were located in the cytoplasmic region of the Fas antigen known to be involved in transduction of an apoptotic signal. Two separate individuals demonstrated an identical mutation at a site previously shown to be mutated in the congenital autoimmune syndrome, ALPS. One patient exhibited a point mutation at a site only two amino acids removed from the documented lesion of the lprcg mouse. Although the functional status of these point mutations remains to be determined, we propose that Fas antigen mutations may contribute to the pathogenesis and progression of myeloma in some patients.

Genetic transformation of the C3-C4 intermediate plant, Flaveria pubescens (Asteraceae)

The dicot genus Flaveria (Asteraceae), besides species with C₃ or C₄ photosynthesis, contains taxa with a broad range of different states of transition between the two major photosynthetic types. We have developed a reproducible and efficient Agrobacterium-mediated method for the stable genetic transformation of the C₃-C₄ intermediate species F. pubescens. Fusion constructs of the reporter gene β-glucuronidase (uidA, GUS) to several plant promoters, mainly derived from genes encoding subunits of the glycine cleavage system (gdcs), have been used to confirm the reproducibility and efficiency of the method. The stable integration of the foreign DNA has been examined by Southern analysis, kanamycin resistance, GUS enzyme activities and histochemical staining. Transformed shoots can be routinely obtained within 8-10 weeks after co-cultivation with A. tumefaciens.

[The Chinese total diet study in 1992--macro elements and trace elements]

Ten macro elements and trace elements were directly determined in the 1992 total diet study conducted in four districts of China from north to south. The intake of these elements was evaluated. The levels of intake for seasonal variation and for different age groups were reported. The results showed that the intakes of Ca, P, K, Mg, Zn, Se and Cu were low in children. The intake of Ca, P and Zn was insufficient for adults. The intakes of other seven elements reached or approached their RDA levels, but there were big differences among the 4 districts. The relationships between intakes of Ca/P and Na/K as well as Fe and Cu and iron difficiency anemia were discussed.

[Effect of bushen shengxue recipe on EPO gene expression of chronic renal insufficiency anemia in rats]

The rats were fed with adenine to establish the chronic renal insufficiency anemia model, and the relationship between renal functional impairment and reticulocytes, hemoglobin and erythropoietin (EPO) synthesis was observed to explore the mechanism of Bushen Shengxue drugs in improving the hemopoietic function. The results showed that the Bushen Shengxue drugs could significantly lower the serum creatinine and blood urea nitrogen of renal insufficiency rats, and through the promotion of EPO gene expression, the animals' anemic status was improved.

Isolation of differentially expressed sequence tags from steroid-responsive cells using mRNA differential display

Transcriptional control of steroid-regulated gene networks by nuclear receptor proteins results in the coordinate expression of a limited number of target genes. Although much is known about the structure and function of steroid receptors, relatively few cell-specific steroid-regulated genes have been isolated and characterized. In this paper we describe results using mRNA differential display reverse transcriptase PCR (DDPCR) to identify and isolate short cDNA sequence tags from thymocyte and prostate cells under various hormone conditions. Using this technique we have isolated several differentially expressed sequence tags (DESTs) from the mouse thymocyte cell line WEHI 7.2. Two of these DESTs, GIG10 and GIG18, are rapidly induced by dexamethasone within 2 h of treatment. GIG10 is a novel sequence and GIG18 is the mouse homologue of a human expressed sequence tag isolated from activated B lymphocytes. We also used DDPCR to isolate DESTs from androgen-modulated rat ventral prostate tissue, one of which we characterized and found to correspond to the 3' end of prostatic spermine binding protein mRNA, a known androgen-regulated gene. Modifications of the original DDPCR protocol, which we found can potentially decrease the frequency of isolating false-positive DESTs, are described and the merits of DDPCR, relative to other differential cDNA cloning strategies, are discussed.