Purification and characterization of phytase from cotyledons of germinating soybean seeds

Improvement of the recombinant phytase expression by intermittent feeding of glucose during the induction phase of methylotrophic yeast Pichia pastoris

PURPOSE

For growth of methylotrophic yeast, glycerol is usually used as a carbon source. Glucose is used in some cases, but not widely consumed due to strong repressive effect on AOX1 promoter. However, glucose is still considered as a carbon source of choice since it has low production cost and guarantees growth rate comparable to glycerol.

RESULTS

In flask cultivation of the recombinant yeast, Pichia pastoris GS115(pPIC9K-appA38M), while methanol induction point(OD600) and methanol concentration significantly affected the phytase expression, glucose addition in induction phase could enhance phytase expression. The optimal flask cultivation conditions illustrated by Response Surface Methodology were 10.37 OD600 induction point, 2.02 h before methanol feeding, 1.16% methanol concentration and 40.36μL glucose feeding amount(for 20 mL culture volume) in which the expressed phytase activity was 613.4 ± 10.2U/mL, the highest activity in flask cultivation. In bioreactor fermentation, the intermittent glucose feeding showed several advantageous results such as 68 h longer activity increment, 149.2% higher cell density and 200.1% higher activity compared to the sole methanol feeding method. These results implied that remaining glucose at induction point might exhibit a positive effect on the phytase expression.

CONCLUSION

Glucose intermittent feeding could be exploited for economic phytase production and the other recombinant protein expression by P. pastoris GS115.

Zinc biofortification through seed nutri-priming using alternative zinc sources and concentration levels in pea and sunflower microgreens

Micronutrient deficiencies caused by malnutrition and hidden hunger are a growing concern worldwide, exacerbated by climate change, COVID-19, and conflicts. A potentially sustainable way to mitigate such challenges is the production of nutrient-dense crops through agronomic biofortification techniques. Among several potential target crops, microgreens are considered suitable for mineral biofortification because of their short growth cycle, high content of nutrients, and low level of anti-nutritional factors. A study was conducted to evaluate the potential of zinc (Zn) biofortification of pea and sunflower microgreens via seed nutri-priming, examining the effect of different Zn sources (Zn sulfate, Zn-EDTA, and Zn oxide nanoparticles) and concentrations (0, 25, 50, 100, and 200 ppm) on microgreen yield components; mineral content; phytochemical constituents such as total chlorophyll, carotenoids, flavonoids, anthocyanin, and total phenolic compounds; antioxidant activity; and antinutrient factors like phytic acid. Treatments were arranged in a completely randomized factorial block design with three replications. Seed soaked in a 200 ppm ZnSO₄ solution resulted in higher Zn accumulation in both peas (126.1%) and sunflower microgreens (229.8%). However, an antagonistic effect on the accumulation of other micronutrients (Fe, Mn, and Cu) was seen only in pea microgreens. Even at high concentrations, seed soaking in Zn-EDTA did not effectively accumulate Zn in both microgreens' species. ZnO increased the chlorophyll, total phenols, and antioxidant activities compared to Zn-EDTA. Seed soaking in ZnSO₄ and ZnO solutions at higher concentrations resulted in a lower phytic acid/Zn molar ratio, suggesting the higher bioaccessibility of the biofortified Zn in both pea and sunflower microgreens. These results suggest that seed nutrient priming is feasible for enriching pea and sunflower microgreens with Zn. The most effective Zn source was ZnSO₄, followed by ZnO. The optimal concentration of Zn fertilizer solution should be selected based on fertilizer source, target species, and desired Zn-enrichment level.

Characterization of browning during CO2 deastringency treatment in astringent persimmon fruit

Deastringency treatment with CO2 is an effective and convenient method for improving the marketability of persimmon fruit. However, the main persimmon cultivars in China turn brown very quickly following exposure to a high-CO2 atmosphere, causing significant economic loss. However, the mechanisms of persimmon browning under CO2 treatment remain largely unknown. In this study, we evaluated components and enzymes related to persimmon fruit browning. The results revealed that astringency was alleviated by simultaneous reduction of soluble tannin content and accumulation of insoluble tannin. During persimmon browning, fruit firmness, total phenolic content, and phenylalanine ammonia lyase (PAL) activity decreased significantly, whereas malondialdehyde (MDA), superoxide dismutase (SOD), peroxidase (POD), catalase (CAT), and polyphenol oxidase (PPO) activity increased significantly, suggesting that reactive oxygen species (ROS)-scavenging enzymes and non-enzymatic antioxidants cannot effectively maintain redox reaction balance to protect cell membranes from oxidative damage during CO2 treatment. An untargeted metabolomics analysis identified 19 polyhydroxyphenols that were downregulated in CO2-treated fruit, suggesting that phenolics may act as a substrate for persimmon browning. We also identified 11 metabolites associated with abiotic stress. Together, these results study provide valuable information on the mechanism of persimmon fruit browning induced by CO2 treatment and will contribute to the ongoing development of the persimmon fruit industry.

Purple acid phosphatases: roles in phosphate utilization and new emerging functions

Plants strive for phosphorus (P), which is an essential mineral for their life. Since P availability is limiting in most of the world's soils, plants have evolved with a complex network of genes and their regulatory mechanisms to cope with soil P deficiency. Among them, purple acid phosphatases (PAPs) are predominantly associated with P remobilization within the plant and acquisition from the soil by hydrolyzing organic P compounds. P in such compounds remains otherwise unavailable to plants for assimilation. PAPs are ubiquitous in plants, and similar enzymes exist in bacteria, fungi, mammals, and unicellular eukaryotes, but having some differences in their catalytic center. In the recent past, PAPs' roles have been extended to multiple plant processes like flowering, seed development, senescence, carbon metabolism, response to biotic and abiotic stresses, signaling, and root development. While new functions have been assigned to PAPs, the underlying mechanisms remained understood poorly. Here, we review the known functions of PAPs, the regulatory mechanisms, and their relevance in crop improvement for P-use-efficiency. We then discuss the mechanisms behind their functions and propose areas worthy of future research. Finally, we argue that PAPs could be a potential target for improving P utilization in crops. In turn, this is essential for sustainable agriculture.

Plant cell wall chemistry: implications for ruminant utilisation

Ruminants have adapted to cope with bulky, fibrous forage diets by accommodating a large, diverse microbial population in the reticulo-rumen. Ruminants are dependent on forages as their main sources of energy and other nutrients. Forages are comprised of a complex matrix of cellulose, hemicellulose, protein, minerals and phenolic compounds (including lignin and tannins) with various linkages; many of which are poorly defined. The composition and characteristics of polysaccharides vary greatly among forages and plant cell walls. Plant cell walls are linked and packed together in tight configurations to resist degradation, and hence their nutritional value to animals varies considerably, depending on composition, structure and degradability. An understanding of the inter-relationship between the chemical composition and the degradation of plant cell walls by rumen microorganisms is of major economic importance to ruminant production. Increasing the efficiency of fibre degradation in the rumen has been the subject of extensive research for many decades. This review summarises current knowledge of forage chemistry in order to develop strategies to increase efficiency of forage utilisation by ruminants.

Genetically modified phytase crops role in sustainable plant and animal nutrition and ecological development: a review

Globally, plant-derivatives especially cereals and legumes are the major staple food sources for animals. The seeds of these crops comprise of phytic acid, the major repository form of the phosphorus, which is not digestible by simple-stomached animals. However, it is the most important factor responsible for impeding the absorption of minerals by plants that eventually results in less use of fertilizers that ultimately cause eutrophication in water bodies. Although abundant phosphorus (P) exists in the soils, plants cannot absorb most of the P due to its conversion to unavailable forms. Hence, additional P supplementation is indispensable to the soil to promote crop yields which not only leads to soil infertility but also rapid depletion of non-renewable P reservoirs. Phytase/phosphatase enzyme is essential to liberate P from soils by plants and from seeds by monogastric animals. Phytases are kind of phosphatases which can hydrolyse the indigestible phytate into inorganic Phosphate (Pi) and lower myo-inositol. There are several approaches to mitigate the problems associated with phytate indigestibility. One of the best possible solutions is engineering crops to produce heterologous phytase to improve P utilization by monogastric animals, plant nutrition and sustainable ecological developments. Previously published reviews were focused on either soil phytate or seed-phytate, related issues, but this review will address both the problems as well as phytate related ecological problems. This review summarizes the overall view of engineered phytase crops and their role in sustainable agriculture, animal nutrition and ecological development.

Aspergillus ficuum phytase activity is inhibited by cereal grain components

In the current study, we report for the first time that grain components of barley, rice, wheat and maize can inhibit the activity of Aspergillus ficuum phytase. The phytase inhibition is dose dependent and varies significantly between cereal species, between cultivars of barley and cultivars of wheat and between Fusarium graminearum infected and non-infected wheat grains. The highest endpoint level of phytase activity inhibition was 90%, observed with grain protein extracts (GPE) from F. graminearum infected wheat. Wheat GPE from grains infected with F. graminearum inhibits phytase activity significantly more than GPE from non-infected grains. For four barley cultivars studied, the IC₅₀ value ranged from 0.978 ± 0.271 to 3.616 ± 0.087 mg×ml^-1. For two non-infected wheat cultivars investigated, the IC₅₀ values were varying from 2.478 ± 0.114 to 3.038 ± 0.097 mg×ml^-1. The maize and rice cultivars tested gaveIC₅₀ values on 0.983 ± 0.205 and 1.972 ± 0.019 mg×ml^-1, respectively. After purifying the inhibitor from barley grains via Superdex G200, an approximately 30–35 kDa protein was identified. No clear trend for the mechanism of inhibition could be identified via Michaelis-Menten kinetics and Lineweaver-Burk plots. However, testing of the purified phytase inhibitor together with the A. ficuum phytase and the specific protease inhibitors pepstatin A, E64, EDTA and PMSF revealed that pepstatin A repealed the phytase inhibition. This indicates that the observed inhibition of A. ficuum phytase by cereal grain extracts is caused by protease activity of the aspartic proteinase type.

Phytase activity in lichens

Phytase activity was investigated in 13 lichen species using a novel assay method. The work tested the hypothesis that phytase is a component of the suite of surface-bound lichen enzymes that hydrolyse simple organic forms of phosphorus (P) and nitrogen (N) deposited onto the thallus surface. Hydrolysis of inositol hexaphosphate (InsP6 , the substrate for phytase) and appearance of lower-order inositol phosphates (InsP5 -InsP1 ), the hydrolysis products, were measured by ion chromatography. Phytase activity in Evernia prunastri was compared among locations with contrasting rates of N deposition. Phytase activity was readily measurable in epiphytic lichens (e.g. 11.3 μmol InsP6 hydrolysed g(-1)  h(-1) in Bryoria fuscescens) but low in two terricolous species tested (Cladonia portentosa and Peltigera membranacea). Phytase and phosphomonoesterase activities were positively correlated amongst species. In E. prunastri both enzyme activities were promoted by N enrichment and phytase activity was readily released into thallus washings. InsP6 was not detected in tree canopy throughfall but was present in pollen leachate. Capacity to hydrolyse InsP6 appears widespread amongst lichens potentially promoting P capture from atmospheric deposits and plant leachates, and P cycling in forest canopies. The enzyme assay used here might find wider application in studies on plant root-fungal-soil systems.

Phytate in pig and poultry nutrition

Phosphorus (P) is primarily stored in the form of phytates in plant seeds, thus being poorly available for monogastric livestock, such as pigs and poultry. As phytate is a polyanionic molecule, it has the capacity to chelate positively charged cations, especially calcium, iron and zinc. Furthermore, it probably compromises the utilization of other dietary nutrients, including protein, starch and lipids. Reduced efficiency of utilization implies both higher levels of supplementation and increased discharge of the undigested nutrients to the environment. The enzyme phytase catalyses the stepwise hydrolysis of phytate. In respect to livestock nutrition, there are four possible sources of this enzyme available for the animals: endogenous mucosal phytase, gut microfloral phytase, plant phytase and exogenous microbial phytase. As the endogenous mucosal phytase in monogastric organisms appears incapable of hydrolysing sufficient amounts of phytate-bound P, supplementation of exogenous microbial phytase in diets is a common method to increase mineral and nutrient absorption. Plant phytase activity varies greatly among species of plants, resulting in differing gastrointestinal phytate hydrolysis in monogastric animals. Besides the supplementation of microbial phytase, processing techniques are alternative approaches to reduce phytate contents. Thus, techniques such as germination, soaking and fermentation enable activation of naturally occurring plant phytase among others. However, further research is needed to tap the potential of these technologies. The main focus herein is to review the available literature on the role of phytate in pig and poultry nutrition, its degradation throughout the gut and opportunities to enhance the utilization of P as well as other minerals and nutrients which might be complexed by phytates.

Localization of phytase transcripts in germinating seeds of the common bean (Phaseolus vulgaris L.)

The work provides the first-time evidence of tissue-specific expression of a phytase gene in the germinating seeds of Phaseolus vulgaris. Phytase enzyme plays a major role in germinating seeds. It is also active during N2 fixation within nodules of legumes. The effect of phosphorus (P) deficiency on phytase gene expression and localization in N2-fixing root nodules has been recently studied in hydroaeroponic culture of Phaseolus vulgaris. In this study, phytase gene transcripts within the germinating seed tissues of the P-inefficient P. vulgaris recombinant inbred line RIL147 were in situ localized with a similar RT-PCR recipe as that used for nodules. Our results show that the phytase gene expression was mainly localized in the outer layers, vascular cells and parenchyma of germinating seeds whereas it was localized in the inner and middle cortex of nodules. Image analysis quantified higher fluorescence intensity of the phytase transcript signal in the seed embryo than in radicles, cotyledons or the nodule cortex. Furthermore, the phytase activity was 22-fold higher in cotyledons (43 nmol min(-1) g(-1) dry weight) than in nodules (2 nmol min(-1) g(-1) dry weight). The K m and V m values of phytase activity in cotyledons were also significantly higher than in nodules. Interestingly, the amplified sequence of cDNA phytase exhibited highest homology with the Glycine max purple acid phosphatase (NM_001289274) 90 % for germinating seed as compared to nodule phytase cDNA displaying 94 % homology with the Glycine max phytase (GQ422774.1). It is concluded that phytase enzymes are likely to vary from seeds to nodules and that phytase enzymes play key roles in the use of organic P or N2 fixation, as it is well known for germination.

Overexpression and functional characterization of an Aspergillus niger phytase in the fat body of transgenic silkworm, Bombyx mori

In a previous study, we isolated 1,119 bp of upstream promoter sequence from Bmlp3, a gene encoding a member of the silkworm 30 K storage protein family, and demonstrated that it was sufficient to direct fat body-specific expression of a reporter gene in a transgenic silkworm, thus highlighting the potential use of this promoter for both functional genomics research and biotechnology applications. To test whether the Bmlp3 promoter can be used to produce recombinant proteins in the fat body of silkworm pupae, we generated a transgenic line of Bombyx mori which harbors a codon-optimized Aspergillus niger phytase gene (phyA) under the control of the Bmlp3 promoter. Here we show that the Bmlp3 promoter drives high levels of phyA expression in the fat body, and that the recombinant phyA protein is highly active (99.05 and 54.80 U/g in fat body extracts and fresh pupa, respectively). We also show that the recombinant phyA has two optimum pH ranges (1.5-2.0 and 5.5-6.0), and two optimum temperatures (55 and 37 °C). The activity of recombinant phyA was lost after high-temperature drying, but treating with boiling water was less harmful, its residual activity was approximately 84% of the level observed in untreated samples. These results offer an opportunity not only for better utilization of large amounts of silkworm pupae generated during silk production, but also provide a novel method for mass production of low-cost recombinant phytase using transgenic silkworms.

Dephytinisation with intrinsic wheat phytase and iron fortification significantly increase iron absorption from fonio (Digitaria exilis) meals in West African women

Low iron and high phytic acid content make fonio based meals a poor source of bioavailable iron. Phytic acid degradation in fonio porridge using whole grain cereals as phytase source and effect on iron bioavailability when added to iron fortified fonio meals were investigated. Grains, nuts and seeds collected in Mali markets were screened for phytic acid and phytase activity. We performed an iron absorption study in Beninese women (n = 16), using non-dephytinised fonio porridge (FFP) and dephytinised fonio porridge (FWFP; 75% fonio-25% wheat), each fortified with ⁵⁷Fe or ⁵⁸Fe labeled FeSO₄. Iron absorption was quantified by measuring the erythrocyte incorporation of stable iron isotopes. Phytic acid varied from 0.39 (bambara nut) to 4.26 g/100 g DM (pumpkin seed), with oilseeds values higher than grains and nuts. Phytase activity ranged from 0.17±1.61 (fonio) to 2.9±1.3 phytase unit (PU) per g (whole wheat). Phytic acid was almost completely degraded in FWFP after 60 min of incubation (pH≈5.0, 50°C). Phytate∶iron molar ratios decreased from 23.7∶1 in FFP to 2.7∶1 in FWFP. Iron fortification further reduced phytate∶iron molar ratio to 1.9∶1 in FFP and 0.3∶1 in FWFP, respectively. Geometric mean (95% CI) iron absorption significantly increased from 2.6% (0.8–7.8) in FFP to 8.3% (3.8–17.9) in FWFP (P<0.0001). Dephytinisation of fonio porridge with intrinsic wheat phytase increased fractional iron absorption 3.2 times, suggesting it could be a possible strategy to decrease PA in cereal-based porridges.

Phytase, a New Life for an “Old” Enzyme

Phytases are phosphohydrolytic enzymes that initiate stepwise removal of phosphate from phytate. Simple-stomached species such as swine, poultry, and fish require extrinsic phytase to digest phytate, the major form of phosphorus in plant-based feeds. Consequently, this enzyme is supplemented in these species’ diets to decrease their phosphorus excretion, and it has emerged as one of the most effective and lucrative feed additives. This chapter provides a comprehensive review of the evolving course of phytase science and technology. It gives realistic estimates of the versatile roles of phytase in animal feeding, environmental protection, rock phosphorus preservation, human nutrition and health, and industrial applications. It elaborates on new biotechnology and existing issues related to developing novel microbial phytases as well as phytase-transgenic plants and animals. And it targets critical and integrated analyses on the global impact, novel application, and future demand of phytase in promoting animal agriculture, human health, and societal sustainability.

In silico characterization of histidine Acid phytase sequences

Histidine acid phytases (HAPhy) are widely distributed enzymes among bacteria, fungi, plants, and some animal tissues. They have a significant role as an animal feed enzyme and in the solubilization of insoluble phosphates and minerals present in the form of phytic acid complex. A set of 50 reference protein sequences representing HAPhy were retrieved from NCBI protein database and characterized for various biochemical properties, multiple sequence alignment (MSA), homology search, phylogenetic analysis, motifs, and superfamily search. MSA using MEGA5 revealed the presence of conserved sequences at N-terminal "RHGXRXP" and C-terminal "HD." Phylogenetic tree analysis indicates the presence of three clusters representing different HAPhy, that is, PhyA, PhyB, and AppA. Analysis of 10 commonly distributed motifs in the sequences indicates the presence of signature sequence for each class. Motif 1 "SPFCDLFTHEEWIQYDYLQSLGKYYGYGAGNPLGPAQGIGF" was present in 38 protein sequences representing clusters 1 (PhyA) and 2 (PhyB). Cluster 3 (AppA) contains motif 9 "KKGCPQSGQVAIIADVDERTRKTGEAFAAGLAPDCAITVHTQADTSSPDP" as a signature sequence. All sequences belong to histidine acid phosphatase family as resulted from superfamily search. No conserved sequence representing 3- or 6-phytase could be identified using multiple sequence alignment. This in silico analysis might contribute in the classification and future genetic engineering of this most diverse class of phytase.

Characterization of phytase from three ferns with differing arsenic tolerance

Phytase is involved in many physiological activities in plants including phosphorus metabolism and stress response. The effects of arsenic on phytase activities in arsenic-hyperaccumulator Pteris vittata were determined. Two arsenic-sensitive ferns (Pteris ensiformis and Nephrolepis exaltata) were included for comparison purpose. Fern phytase was extracted with Tris-HCl buffer (pH 7.6) followed by ammonium sulfate partial purification to characterize its properties and arsenic stress responses. The phytase showed an optimum pH of 5.0 and temperature of 40 °C except for P. vittata with 40-70 °C. Phytase from P. vittata was the first plant-phytase showing high heat resistance with no loss of activity by heating it at 70 °C, which may have application in feed industry. Phytase activity was inhibited by arsenate but not by arsenite. The fact that P. vittata phytase was the most heat-tolerant (40-70 °C) and had the highest resistance to arsenate among the three ferns suggest that phytase may play a role in arsenic detoxification and arsenic hyperaccumulation in P. vittata.

Selection and use of phytate-degrading LAB to improve cereal-based products by mineral solubilization during dough fermentation

New producers of phytate-degrading enzymes, especially lactic acid bacteria (LAB), were used to improve mineral solubilization during dough fermentation. In all, among strains from different sources by microorganisms (150 lactic acid bacteria, 36 yeasts), 38 (24%) exhibited a clear zone around the colonies by hydrolyzing hexacalcium phytate contained in solid medium. When phytase-positive strains from plate assay were tested for phytase activity in liquid medium, 6 of the strains (37%) exhibited phytate-degrading activity in at least one of the 3 different media used. Of the LAB, the highest phytase values were found for Enterococcus faecium A86 (0.74 U/mL) and Lactobacillus plantarum H5 (0.71 U/mL). Two different starter cultures obtained by combinations of phytase-positive (phy+: L. plantarum H5 and L3, Leuconostoc gelidum A16, and E. faecium A86) or phytase-negative (phy-: L. gelidum LM249, L. plantarum H19, and L. plantarum L8) selected LAB strains, were used to measure mineral concentrations of iron, zinc, and manganese during dough fermentation. Although the 2 kinds of starter showed similar acidic values, the presence of phytate-degrading LAB strains increased mineral solubilization in comparison to the starter phy-.

Degradation of phytates in distillers' grains and corn gluten feed by Aspergillus niger phytase

Distillers' dried grains with solubles (DDGS) and corn gluten feed (CGF) are major coproducts of ethanol production from corn dry grind and wet milling facilities, respectively. These coproducts contain important nutrients and high levels of phytates. The phytates in these products cannot be digested by nonruminant animals; consequently, large quantities of phytate phosphorus (P) are deposited into the soil with the animal wastes which potentially could cause P pollution in soil and underground water resources. To reduce phytates in DDGS and CGF, a phytase from Aspergillus niger, PhyA, was investigated regarding its capability to catalyze the hydrolysis of phytates in light steep water (LSW) and whole stillage (WS). LSW and WS streams are the intermediate streams in the production of CGF and DDGS, respectively, and contribute to most of the P in these streams. Enzyme loadings with activity of 0.1, 1, 2, and 4 FTU/g substrate and temperatures of 35 and 45 degrees C were investigated regarding their influences on the degree of hydrolysis. The analysis of the hydrolyzate suggested to a sequentially degradation of phytates to lower order myo-inositol phosphate isomers. Approximately 90% phytate P of LSW and 66% phytate P of WS were released, suggesting myo-inositol monophosphate as the end product. The maximum amount of released P was 4.52 +/- 0.03 mg/g LSW and 0.86 +/- 0.01 mg/g WS.

Phytate: impact on environment and human nutrition. A challenge for molecular breeding

Phytic acid (PA) is the primary storage compound of phosphorus in seeds accounting for up to 80% of the total seed phosphorus and contributing as much as 1.5% to the seed dry weight. The negatively charged phosphate in PA strongly binds to metallic cations of Ca, Fe, K, Mg, Mn and Zn making them insoluble and thus unavailable as nutritional factors. Phytate mainly accumulates in protein storage vacuoles as globoids, predominantly located in the aleurone layer (wheat, barley and rice) or in the embryo (maize). During germination, phytate is hydrolysed by endogenous phytase(s) and other phosphatases to release phosphate, inositol and micronutrients to support the emerging seedling. PA and its derivatives are also implicated in RNA export, DNA repair, signalling, endocytosis and cell vesicular trafficking. Our recent studies on purification of phytate globoids, their mineral composition and dephytinization by wheat phytase will be discussed. Biochemical data for purified and characterized phytases isolated from more than 23 plant species are presented, the dephosphorylation pathways of phytic acid by different classes of phytases are compared, and the application of phytase in food and feed is discussed.

Transgenic maize plants expressing a fungal phytase gene

Maize seeds are the major ingredient of commercial pig and poultry feed. Phosphorus in maize seeds exists predominantly in the form of phytate. Phytate phosphorus is not available to monogastric animals and phosphate supplementation is required for optimal animal growth. Undigested phytate in animal manure is considered a major source of phosphorus pollution to the environment from agricultural production. Microbial phytase produced by fermentation as a feed additive is widely used to manage the nutritional and environmental problems caused by phytate, but the approach is associated with production costs for the enzyme and requirement of special cares in feed processing and diet formulation. An alternative approach would be to produce plant seeds that contain high phytase activities. We have over-expressed Aspergillus niger phyA2 gene in maize seeds using a construct driven by the maize embryo-specific globulin-1 promoter. Low-copy-number transgenic lines with simple integration patterns were identified. Western-blot analysis showed that the maize-expressed phytase protein was smaller than that expressed in yeast, apparently due to different glycosylation. Phytase activity in transgenic maize seeds reached approximately 2,200 units per kg seed, about a 50-fold increase compared to non-transgenic maize seeds. The phytase expression was stable across four generations. The transgenic seeds germinated normally. Our results show that the phytase expression lines can be used for development of new maize hybrids to improve phosphorus availability and reduce the impact of animal production on the environment.

High level expression of a recombinant acid phytase gene in Pichia pastoris

AIMS

To achieve high phytase yield with improved enzymatic activity in Pichia pastoris.

METHODS AND RESULTS

The 1347-bp phytase gene of Aspergillus niger SK-57 was synthesized using a successive polymerase chain reaction and was altered by deleting intronic sequences, optimizing codon usage and replacing its original signal sequence with a synthetic signal peptide (designated MF4I) that is a codon-modified Saccharomyces cerevisiae mating factor alpha-prepro-leader sequence. The gene constructs containing wild type or modified phytase gene coding sequences under the control of the highly-inducible alcohol oxidase gene promoter with the MF4I- or wild type alpha-signal sequence were used to transform Pichia pastoris. The P. pastoris strain that expressed the modified phytase gene (phyA-sh) with MF4I sequence produced 6.1 g purified phytase per litre of culture fluid, with the phytase activity of 865 U ml(-1). The expressed phytase varied in size (64, 67, 87, 110 and 120 kDa), but could be deglycosylated to produce a homogeneous 64 kDa protein. The recombinant phytase had two pH optima (pH 2.5 and pH 5.5) and an optimum temperature of 60 degrees C.

CONCLUSIONS

The P. pastoris strain with the genetically engineered phytase gene produced 6.1 g l(-1) of phytase or 865 U ml(-1) phytase activity, a 14.5-fold increase compared with the P. pastoris strain with the wild type phytase gene.

SIGNIFICANCE AND IMPACT OF THE STUDY

The P. pastoris strain expressing the modified phytase gene with the MF4I signal peptide showed great potential as a commercial phytase production system.

Ectopic expression of a soybean phytase in developing seeds of Glycine max to improve phosphorus availability

A transgenic approach was used to alter soybean seed phytate content by expressing a soybean phytase gene (GmPhy) during seed development to degrade accumulating phytic acid (IP6). An expression vector containing the soybean phytase cDNA controlled by the seed-specific beta-conglycinin promoter (alpha'-subunit) was used to transform embryogenic soybean cultures. Plants from four independent transgenic lines were analyzed for transgene integration and seed IP6 levels. The reduction in IP6 levels in transgenic seeds compared to control 'Jack' soybeans ranged from 12.6 to 24.8 as determined by HPLC. A low copy transformant was propagated to the T4 generation and examined in more detail for phytase expression and enzyme activity during seed development. Expression of phytase mRNA and phytase activity increased during seed development, consistent with the use of an embryo-specific promoter. Ectopic phytase expression during seed development offers potential as an effective strategy for reducing phytate content in soybean seed.

Isolation, Characterization, and Molecular Cloning of the cDNA Encoding a Novel Phytase from Aspergillus niger 113 and High Expression in Pichia pastoris

Phytases catalyze the release of phosphate from phytic acid. Phytase-producing microorganisms were selected by culturing the soil extracts on agar plates containing phytic acid. Two hundred colonies that exhibited potential phytase activity were selected for further study. The colony showing the highest phytase activity was identified as Aspergillus niger and designated strain 113. The phytase gene from A. niger 113 (phyI1) was isolated, cloned, and characterized. The nucleotide and deduced amino acid sequence identity between phyI1 and phyA from NRRL3135 were 90% and 98%, respectively. The identity between phyI1 and phyA from SK-57 was 89% and 96%. A synthetic phytase gene, phyI1s, was synthesized by successive PCR and transformed into the yeast expression vector carrying a signal peptide that was designed and synthesized using P. pastoris biased codon. For the phytase expression and secretion, the construct was integrated into the genome of P. pastoris by homologous recombination. Over-expressing strains were selected and fermented. It was discovered that ~4.2 g phytase could be purified from one liter of culture fluid. The activity of the resulting phytase was 9.5 U/mg. Due to the heavy glycosylation, the expressed phytase varied in size (120, 95, 85, and 64 kDa), but could be deglycosylated to a homogeneous 64 kDa species. An enzymatic kinetics analysis showed that the phytase had two pH optima (pH 2.0 and pH 5.0) and an optimum temperature of 60 degrees C.

Acid phosphatase activities during the germination of Glycine max seeds

In this paper, we describe a study concerning the determination of some characteristics of soybean seedlings and the detection of acid phosphatase activities towards different substrates during the germination. Enzyme activities with p-nitrophenylphosphate (pNPP) and inorganic pyrophosphate (PPi) as substrates were detected from the 5th and 7th days after germination, respectively. Acid phosphatase activities with tyrosine phosphate (TyrP), glucose-6-phosphate (G6P) and phosphoenol pyruvate (PEP) were also observed but to a lesser extent. Under the same conditions, no enzyme activity was detected with phytic acid (PhyAc) as substrate. The appearance of phosphatase activity was coincident with the decrease of inorganic phosphate content during germination; over the same period, the protein content increased up to the 5th day, decreased until the 8th day, and remained constant after this period. Relative to phosphatase activity in the cotyledons, the activities detected in the hypocotyl and roots were 82% and 38%, respectively. During storage the enzyme maintained about 63% of its activity for 3 months at 5 degrees C. The specificity constant (Vmax/Km) values for pNPP and PPi were 212 and 64 mu kat mM-1 mg-1, respectively. Amongst the substrates tested, PPi could be a potential physiological substrate for acid phosphatase during the germination of soybean seeds.

Purification and properties of a low-molecular-weight phytase from Cladosporium sp. FP-1

A fungus producing high levels of phytase was isolated from air and identified as Cladosporium sp. The phytase production was stimulated by phytate in the medium used. The maximum production of phytase (108 U/ml) occurred in a medium containing 1.0 g of phytate per 100 ml. The phytase was purified to electrophoretic homogeneity by ion-exchange chromatography and gel filtration. Based on SDS-PAGE analysis, the molecular weight of the purified phytase was calculated to be approximately 32.6 kDa, and the narrow protein band indicated that this phytase is not glycosylated. The phytase has an optimum pH of 3.5, and an optimum temperature of 40 degrees C. The phytase activity was stimulated by 2-mercaptoethanol and dithiothreitol, and inhibited by Ba2+, Pb2+, iodoacetate, p-chloromercuribenzoate and phenylmethylsulfonyl fluoride. The phytase displayed high affinity for phytate and the Km was 15.2+/-3.1 microM. NMR analyses (1D and 2D) indicated that the end hydrolysis product of phytate was myo-inositol 1,2,5-triphosphate.

Isolation and characterisation of phytase from dormant Corylus avellana seeds

Phytase (myo-inositol-1,2,3,4,5,6-hexakisphosphate phosphohydrolase, EC 3.1.3.26), which catalyses the step-wise hydrolysis of phytic acid, was purified from cotyledons of dormant Corylus avellana L. seeds. The enzyme was separated from the major soluble acid phosphatase by successive (NH4)(2)SO(4) precipitation, gel filtration and cation exchange chromatography resulting in a 300-fold purification and yield of 7.5%. The native enzyme positively interacted with Concanavalin A suggesting that it is putatively glycosylated. After size exclusion chromatography and SDS-PAGE it was found to be a monomeric protein with molecular mass 72+/-2.5 kDa. The hazel enzyme exhibited optimum activity for phytic acid hydrolysis at pH 5 and, like other phytases, had broad substrate specificity. It exhibited the lowest Km (162 microM) and highest specificity constant (V(max)/Km) for phytic acid, indicating that this is the preferred in vivo substrate. It required no metal ion as a co-factor, while inorganic phosphate and fluoride competitively inhibited enzymic activity (Ki=407 microM and Ki=205 microM, respectively).

Purification and characterization of three phytases from germinated lupine seeds (Lupinus albus var. amiga)

Three phytases were purified about 14200-fold (LP11), 16000-fold (LP12), and 13100-fold (LP2) from germinated 4-day-old lupine seedlings to apparent homogeneity with recoveries of 13% (LP11), 8% (LP12), and 9% (LP2) referred to the phytase activity in the crude extract. They behave as monomeric proteins of a molecular mass of about 57 kDa (LP11 and LP12) and 64 kDa (LP2), respectively. The purified proteins belong to the acid phytases. They exhibit a single pH optimum at 5.0. Optimal temperature for the degradation of sodium phytate is 50 degrees C. Kinetic parameters for the hydrolysis of sodium phytate are K(M) = 80 microM (LP11), 300 microM (LP12), and 130 microM (LP2) and k(cat) = 523 s(-1) (LP11), 589 s(-1) (LP12), and 533 s(-1) (LP2) at pH 5.0 and 35 degrees C. The phytases from lupine seeds exhibit a broad affinity for various phosphorylated compounds and hydrolyze phytate in a stepwise manner.

Engineering crop plants: getting a handle on phosphate

In plant seeds, most of the phosphate is in the form of phytic acid. Phytic acid is largely indigestible by monogastric animals and is the single most important factor hindering the uptake of a range of minerals. Engineering crop plants to produce a heterologous phytase improves phosphate bioavailability and reduces phytic acid excretion. This reduces the phosphate load on agricultural ecosystems and thereby alleviates eutrophication of the aquatic environment. Improved phosphate availability also reduces the need to add inorganic phosphate, a non-renewable resource. Iron and zinc uptake might be improved, which is significant for human nutrition in developing countries.

A novel phytase with sequence similarity to purple acid phosphatases is expressed in cotyledons of germinating soybean seedlings

Phytic acid (myo-inositol hexakisphosphate) is the major storage form of phosphorus in plant seeds. During germination, stored reserves are used as a source of nutrients by the plant seedling. Phytic acid is degraded by the activity of phytases to yield inositol and free phosphate. Due to the lack of phytases in the non-ruminant digestive tract, monogastric animals cannot utilize dietary phytic acid and it is excreted into manure. High phytic acid content in manure results in elevated phosphorus levels in soil and water and accompanying environmental concerns. The use of phytases to degrade seed phytic acid has potential for reducing the negative environmental impact of livestock production. A phytase was purified to electrophoretic homogeneity from cotyledons of germinated soybeans (Glycine max L. Merr.). Peptide sequence data generated from the purified enzyme facilitated the cloning of the phytase sequence (GmPhy) employing a polymerase chain reaction strategy. The introduction of GmPhy into soybean tissue culture resulted in increased phytase activity in transformed cells, which confirmed the identity of the phytase gene. It is surprising that the soybean phytase was unrelated to previously characterized microbial or maize (Zea mays) phytases, which were classified as histidine acid phosphatases. The soybean phytase sequence exhibited a high degree of similarity to purple acid phosphatases, a class of metallophosphoesterases.

Purification and characterization of a phytate-degrading enzyme from germinated faba beans (Vicia faba Var. Alameda)

A phytate-degrading enzyme was purified approximately 2190-fold from germinated 4-day-old faba bean seedlings to apparent homogeneity with a recovery of 6% referred to the phytase activity in the crude extract. It behaves as a monomeric protein of a molecular mass of approximately 65 kDa. The phytate-degrading enzyme belongs to the acidic phytases. It exhibits a single pH optimum at 5.0. Optimal temperature for the degradation of sodium phytate is 50 degrees C. Kinetic parameters for the hydrolysis of sodium phytate are K(M) = 148 micromol L(-1) and k(cat) = 704 s(-1) at 35 degrees C and pH 5.0. The faba bean phytase exhibits a broad affinity for various phosphorylated compounds and hydrolyzes phytate in a stepwise manner. The first hydrolysis product was identified as D/L-myo-inositol(1,2,3,4,5)pentakisphosphate.

Purification and properties of extracellular phytase from Bacillus sp. KHU-10

Bacillus species producing a thermostable phytase was isolated from soil, boiled rice, and mezu (Korean traditinal koji). The activity of phytase increased markedly at the late stationary phase. An extracellular phytase from Bacillus sp. KHU-10 was purified to homogeneity by acetone precipitation and DEAE-Sepharose and phenyl-Sepharose column chromatographies. Its molecular weight was estimated to be 46 kDa on gel filtration and 44 kDa on SDS-polyacrylamide gel elctrophoresis. Its optimum pH and temperature for phytase activity were pH 6.5-8.5 and 40 degrees C without 10 mM CaCl2 and pH 6.0-9.5 and 60 degrees C with 10 mM CaCl2. About 50% of its original activity remained after incubation at 80 degrees C or 10 min in the presence of 10 mM CaCl2. The enzyme activity was fairly stable from pH 6.5 to 10.0. The enzyme had an isoelectric point of 6.8. As for substrate specificity, it was very specific for sodium phytate and showed no activity on other phosphate esters. The Km value for sodium phytate was 50 microM. Its activity was inhibited by EDTA and metal ions such as Ba2+, Cd2+, Co2+, Cr3+, Cu2+, Hg2+, and Mn2+ ions.

Rapid analysis of inositol phosphates

Fast and simple analytical methods for the determination of inositol bis- to hexakisphosphates or only inositol hexakisphosphate in foods and feces are presented. The methods are both faster and simpler with regard to analytical detection and sample pretreatment as compared to previously reported methods. The samples are pretreated using extraction and centrifugal ultrafiltration and analyzed using high-performance ion chromatography (HPIC) with gradient or isocratic elution. The analytes are detected using ultraviolet detection after postcolumn reaction. The methods are efficient, highly selective, and appropriate for analyzing inositol phosphates in food and feces samples. The between- and within-day variances were generally below 8 and 5% (relative standard deviation), respectively, for the presented HPIC method with gradient elution.