Enhanced short-chain fatty acids production from waste activated sludge with alkaline followed by potassium ferrate treatment

Biochar derived from alkali-treated sludge residue regulates anaerobic digestion: Enhancement performance and potential mechanisms

Biochar produced from bio-wastes has been widely used to promote the performance of anaerobic digestion. Waste activated sludge (WAS) is considered as a kind of popular precursor for biochar preparation, but the abundant resources in WAS were neglected previously. In this study, the roles of biochar prepared from raw, pretreated, and fermented sludge on anaerobic digestion were investigated. That is, parts of carbon sources and nutrients like polysaccharides, proteins, and phosphorus were firstly recovered after sludge pretreatment or fermentation, and then the sludge residuals were used as raw material to prepare biochar. The methane yield improved by 22.1% with adding the biochar (AK-BC) prepared by sludge residual obtained from alkaline pretreatment. Mechanism study suggested that the characteristics of AK-BC like specific surface area and defect levels were updated. Then, the conversion performance of intermediate metabolites and electro-activities of extracellular polymeric substances were up-regulated. As a result, the activity of electron transfer was increased with the presence of AK-BC, with increase ratio of 21.4%. In addition, the electroactive microorganisms like Anaerolineaceae and Methanosaeta were enriched with the presence of AK-BC, and the potential direct interspecies electron transfer was possibly established. Moreover, both aceticlastic and CO2-reducing methanogenesis pathways were improved by up-regulating related enzymes. Therefore, the proposed strategy can not only obtain preferred biochar but also recover abundant resources like carbon source, nutrients, and bioenergy.

Improved biohydrogen production by co-fermentation of corn straw and excess sludge: Insights into biochemical process, microbial community and metabolic genes

The global climate change mainly caused by fossil fuels combustion promotes that zero-carbon hydrogen production through eco-friendly methods has attracted attention in recent years. This investigation explored the biohydrogen production by co-fermentation of corn straw (CS) and excess sludge (ES), as well as comprehensively analyzed the internal mechanism. The results showed that the optimal ratio of CS to ES was 9:1 (TS) with the biohydrogen yield of 101.8 mL/g VS, which was higher than that from the mono-fermentation of CS by 1.0-fold. The pattern of volatile fatty acids (VFAs) indicated that the acetate was the most preponderant by-product in all fermentation systems during the biohydrogen production process, and its yield was improved by adding appropriate dosage of ES. In addition, the content of soluble COD (SCOD) was reduced as increasing ES, while concentration of NH4+-N showed an opposite tendency. Microbial community analysis revealed that the microbial composition in different samples showed a significant divergence. Trichococcus was the most dominant bacterial genus in the optimal ratio of 9:1 (CS/ES) fermentation system and its abundance was as high as 41.8%. The functional genes prediction found that the dominant metabolic genes and hydrogen-producing related genes had not been significantly increased in co-fermentation system (CS/ES=9:1) compared to that in the mono-fermentation of CS, implying that enhancement of biohydrogen production by adding ES mainly relied on balancing nutrients and adjusting microbial community in this study. Further redundancy analysis (RDA) confirmed that biohydrogen yield was closely correlated with the enrichment of Trichococcus.

Synergic effects of free ammonia and sodium percarbonate for enhancing short-chain fatty acid production during sludge fermentation: Effectiveness assessment and mechanism elucidation

The production of short-chain fatty acids (SCFAs) from waste activated sludge (WAS) via anaerobic fermentation is typically restricted by poor sludge decomposition capacity and low substrate-availability. Therefore, the free ammonia (FA)‑sodium percarbonate (SPC) technology was presented to successfully overcome the limitation while addressing unsatisfactory acidogenic fermentation pretreated with sole FA or SPC. It revealed that FA + SPC co-pretreatment could boost the SCFA concentration to 347.1 mg COD/g VSS at 180 mg/L FA and 0.15 g/g TSS SPC. In-depth studies demonstrated that FA + SPC pretreatment greatly improved sludge disintegration, biodegradability of substrates and acidification of hydrolysis products. Furthermore, FA + SPC co-pretreatment stimulated the activity of hydrolytic and acidogenic enzymes but inhibited methanogenic enzymes while changing the microbial structure and promoting the enrichment of fermentation microorganisms. The synergistic effect of FA and SPC in this work improves the yield of SCFAs from WAS and facilitates the study of WAS carbon resource recovery.

Percarbonate-strengthened ferrate pretreatment for enhancing short-chain fatty acids production from sewage sludge

Sewage sludge management poses a pressing environmental challenge, demanding the implementation of sustainable solutions to facilitate resource recovery. Short-chain fatty acids (SCFAs) serve as valuable chemicals and renewable energy sources, underscoring the importance of maximizing their production to achieve sustainable waste management. Therefore, this study proposes a novel and green strategy, i.e., percarbonate-strengthened ferrate pretreatment to enhance SCFAs synthesis from sewage sludge, because percarbonate could activate ferrate oxidation through providing (bi) carbonate and hydrogen peroxide. Results show that percarbonate largely reduces the required ferrate dosage for fermentation improvement, and their combination exhibits obvious synergistic effects on SCFAs accumulation and sludge reduction. Under the optimal pretreatment conditions, SCFAs production is promoted to 3670.2 mg COD/L, representing a remarkable increase of 5512.4 %, 156.0 % or 395.1 % compared to the control, percarbonate alone or ferrate alone, respectively. Mechanism explorations demonstrate that percarbonate-strengthened ferrate pretreatment significantly enhances sludge solubilization, elevates substrate biodegradability, and alters the physiochemical properties of sludge to favor organics fermentation. The synergistic effects on solid organics release and sludge properties can be attributed to the combined mechanisms of enhanced oxidation and alkaline hydrolysis. Further investigations on metabolic pathways reveal that the combination substantially improves key enzyme activities associated with hydrolysis and SCFAs formation, while severely inhibits that of SCFAs consumption. These findings are further supported by the functional genes coding relevant enzymes. Moreover, the combination alters microbial structures and compositions, leading to the screening and enrichment of key microbes that facilitate SCFAs accumulation. This innovative strategy holds significant promise in advancing sewage sludge management towards a more circular and resource-efficient paradigm.

Endogenous biopolymer hydrolysis for enhancing short-chain fatty acids recovery from excess sludge: Combination of lysozyme-catalyzing and cation exchange resin-mediated metal regulation

In decades, anaerobic fermentation with short-chain fatty acids (SCFAs) recovery from excess sludge have attained rising attention. However, rigid particulate organic matter (POMs) structure with slow hydrolysis limited anaerobic fermentation performance of excess sludge. Remarkable sludge hydrolysis performance was supposed to be achievable by the synchronous EPS repture and microbial cell lysis. This study clarified the improvement of overall anaerobic fermentation performance by combination treatment of lysozyme (Lyso) catalysis and metal regulation (MR). The Lyso + MR treatment triggered EPS rupture by protein structure deflocculation while catalyzing microbial cell lysis, which promoted massive extracellular and intracellular POMs hydrolysis. As a result, a significant amount of SCOD (5646.67 mg/L) was produced. Such endogenous organic matters hydrolysis led to considerable SCFAs accumulation (3651.14 mg COD/L) through 48-h anaerobic fermentation at 1.75 g/g SS cation-exchange resin and Lyso dosage of 10% (w/w), which was 5.945 times higher than that in the control. Additionally, it suggested that most of the recovered SCFAs remained in fermentative liquid after chemical conditioning and mechanical dewatering towards solid-liquid separation, which provided considerable economic benefit of 363.6-1059.1 CNY/ton SS.

Natural zeolite enhances anaerobic digestion of waste activated sludge: Insights into the performance and the role of biofilm

Anaerobic digestion is widely employed for the treatment of waste activated sludge (WAS) due to its advantages like simultaneous energy recovery and sludge stabilization, promoting carbon-neutral operation of wastewater treatment plants. Natural zeolite, a low-cost and eco-friendly additive, has the potential to improve methane production from anaerobic digestion. This study investigated the effects of natural zeolite on anaerobic digestion when the substrate was WAS. It was found that methane production potential in response to natural zeolite was dosage-dependent. The optimal dosage was 0.1 g zeolite/g volatile suspended solids (VSS), with a methane yield of 181.89 ± 6.75 mL/g VSS, which increased by 20.1% compared to that of the control. Although the methane yields with other dosages of natural zeolite were higher than that of control, they were lesser than that with 0.1 g zeolite/g VSS. Natural zeolite affected transfer and conversion of proteins much more than polysaccharides in liquid phase and extracellular polymeric substances. In anaerobic digestion, natural zeolite had with little effects on WAS solubilization, while it improved hydrolysis, acidification, and methanogenesis. The dosages of natural zeolite did have significant effects on bacterial communities in biofilm rather than suspension, while the archaeal communities in biofilm and suspension were all greatly related to natural zeolite dosages. The developed biofilms promoted richness and functionality of microbial communities. The syntrophic metabolism relationships between methanogens and bacteria were improved, which was proved by selective enrichment of Methanosarcina, Syntrophomonas, and Petrimonas. The findings of this work provided some new solutions for promoting methane production from WAS, and the roles of natural zeolite in anaerobic digestion.

Response characteristics of indigenous microbial community in polycyclic aromatic hydrocarbons (PAHs) contaminated aquifers under polyethylene microplastics stress: A microcosmic experimental study

To understand the response characteristics of indigenous microbial community in PAH-contaminated aquifers to the coexistence of microplastics. In this paper, we constructed a groundwater microecosystem using lithologic media collected from the field and subjected it to the stress of a polyethylene microplastics (PE-MPs) concentration gradient. By conducting adsorption experiments and 16S rRNA sequencing, we revealed the growth, structure, metabolism, and resistance mechanisms of the indigenous microbial community in the aquifer lithologic media exposed to varying levels of co-stress from PE-MPs and phenanthrene. Our findings suggest that the adsorption capacity of aquifer lithologic media for phenanthrene is significantly weaker than that of PE-MPs. Additionally, our observations indicated that small particle lithologic media had a greater adsorption capacity for phenanthrene than large particle lithologic media. The presence of PE-MPs was found to increase both the abundance and diversity of microbial communities, although the relationship was not linear with the content of PE-MPs. When exposed to the combined stress of PE-MPs and phenanthrene, the relative abundance of Proteobacteria decreased while that of Bacteroidetes increased. Several genera belonging to Proteobacteria (Aeromonas, Desulfovibrio, Klebsiella, Pantoea, and Microvirgula) and Bacteroidetes (Macellibacteroides and Bacteroides) occupied a central position in the microbial community interaction network and showed significant correlations with other genera. Furthermore, an increase in the proportion of genera capable of degrading various refractory organics was observed. The presence of PE-MPs increased the phenanthrene content in the aquifer lithologic media, thereby intensifying the inhibitory effect on indigenous microbial community in this environment. Despite an increase in the phenanthrene content of aquifer lithologic media due to the presence of PE-MPs, indigenous microbial community in this environment exhibited resistance to the combined inhibition of PE-MPs and phenanthrene through a series of resistance mechanisms. These mechanisms included strengthening the N-cycle process, enhancing metabolic capacity for phenanthrene, improving perception, response, and adaptation to changes in the external environment or intracellular state, modifying the transmembrane transport of the cell membrane to the substrate, and regulating life processes.

Regulation of the autochthonous microbial community in excess sludge for the bioconversion of carbon dioxide to acetate without exogenic hydrogen

The autochthonous microbial community from excess sludge was regulated for enhanced conversion of CO₂ to acetate without exogenic H₂. It was interesting that the acetate-fed system exhibited a surprising performance to regulate the microbial community for a high acetate yield and selectivity. As a result, some hydrogen-producing bacteria (e.g., Proteiniborus) and acetogenic bacteria with the ability of CO₂ reduction were enriched by acetate feeding, 2-bromoethanesulfonate (BES) addition and CO₂ stress. When the selected microbial community was applied to convert CO₂, the accumulation of acetate was positively correlated to the concentration of yeast extract. Finally, the acetate yield reached up to 67.24 mM with a high product selectivity of 84 % in the presence of yeast extract (2 g/L) and sufficient CO₂ in semi-continuous culture for 10 days. This work should help get new insights into the regulation of microbial community for the efficient acetate production from CO₂.

Role of potassium ferrate in anaerobic digestion of waste activated sludge: Phenotypes and genotypes

The specific effects of potassium ferrate (PF) on acid and methane production in anaerobic digestion need further exploration. This study comprehensively investigated the role of PF in organic matter conversion in waste activated sludge (WAS) digestion. Due to the high pH produced by PF self-decomposition, the hydrolysis of organic matter was promoted, whereas the methanogenesis was inhibited. PF could further directly oxidize protein and polysaccharides released by hydrolysis to produce volatile fatty acids (VFAs) and involve in the transformation of ammonia nitrogen. PF could induce the enrichment of functional genes related to fermentation pathways and lessen those related to methanogenesis, and the phylum resistant to PF oxidation and the strains capable of producing VFAs were enriched, resulting in VFAs accumulation. This study analyzed the participation way of PF in anaerobic digestion and provided a theoretical basis for the application of PF in promoting VFAs recovery from sludge digestion.

Steel slag assists potassium ferrate to improve SCFAs production from anaerobic sludge fermentation

Potassium ferrate (PF) pretreatment in anaerobic sludge and its potential influence mechanisms have received widely attention. This study investigated the coupling effect of PF loading on steel slag (SS) on excess sludge anaerobic fermentation. Results showed that SS loading increase the treatment performance of PF on short chain volatile fatty acids (SCFAs) production from anaerobic fermented sludge. It was showed that the modified PF loaded SS (MPF-SS) promoted the dissolution and release of organic substrates from intracellular to extracellular. Further exploration showed the promotion of PF and MPF-SS exposure to acid production microorganisms was much more than that to acid consumption microorganisms. MPF-SS addition can also effectively reinforce the carbohydrate transport, amino acid metabolism and the key enhanced genes associated with fatty acid biosynthesis pathways. This study fills the knowledge gap about modified PF on sludge treatment and also expands a new perspective for its application for sludge resource recovery.

Performance and mechanisms of citric acid improving biotransformation of waste activated sludge into short-chain fatty acids

Numerous effective chemical strategies have been explored for short-chain fatty acids (SCFAs) production from waste activated sludge (WAS), but many technologies have been questioned due to the chemical residues. This study proposed a citric acid (CA) treatment strategy for improving SCFAs production from WAS. The optimum SCFAs yield reached 384.4 mg COD/g VSS with 0.08 g CA/g TSS addition. Meanwhile, CA biodegradation occurred and its contribution to the yield of total SCFAs, especially acetic acid, cannot be ignored. Intensive exploration indicated the sludge decomposition, the biodegradability of fermentation substrates, as well as the abundance of fermenting microorganisms were definitely enhanced in the existence of CA. The optimization of SCFAs production techniques based on this study deserved further study. This study comprehensively revealed the performance and mechanisms of CA enhancing biotransformation of WAS into SCFAs and the findings promotes the research of carbon resource recovery from sludge.

Enhancing methane production from waste activated sludge with heat-assisted potassium ferrate (PF) pretreatment: Reaction kinetics and mechanisms

This work proposed a novel strategy via heat-assisted potassium ferrate (PF) pretreatment to enhance methane production from waste activated sludge (WAS) during anaerobic digestion. In this research, five dosages of PF (i.e., 0, 0.05, 0.1, 0.3 and 0.5 g/g VSS) at two temperatures (i.e., 25 °C and 55 °C) were explored. Biochemical methane potential experiments illustrated that heat-assisted PF pretreatment improved cumulative methane production with the maximum yield up to 163.93 mL CH₄/g VSS, 149.0 %, 119.6 % and 121.0 % of that in the control, individual 0.5 g PF/g VSS and individual heat (i.e., 55 °C) pretreatment digesters, respectively. The maximum methane potential (B₀) was promoted by 63.2 % with heat-assisted PF pretreatment compared to the control, while the hydrolysis rate (k) changed slightly. Mechanism analysis revealed that heat-assisted PF pretreatment accelerated WAS solubilization and enhanced the biodegradability of released substances, providing more available matrix for bacteria during the following anaerobic digestion processes. Microbial community analysis exhibited that several microbes such as Proteiniclasticum sp., Sedimentibacter sp. and Methanosaeta sp. associated with hydrolysis, acidification and methanogenesis respectively were improved after heat-assisted PF pretreatment. In addition, the relative bioactivities of protease, butyrate kinase and acetate kinase were also increased. Furthermore, variation of dominant genes associated with methane production indicated that acetate-dependent methanogenesis was the main pathway while CO₂-dependent methanogenesis pathway was inhibited by heat-assisted PF pretreatment.

Spatial distribution of fecal pollution indicators in sewage sludge flocs and their removal and inactivation as revealed by qPCR/viability-qPCR during potassium ferrate treatment

Sludge reuse and utilization is one of important routines of disseminating fecal pollution to surface water and groundwater. However, it remains unclear the spatial distribution of fecal pollution indicators in sludge flocs and their reductions during sludge treatment processes. In this study, the abundances of fecal pollution indicators including cross-assembly phage (crAssphage), JC and BK polyomavirus (JCPyV, BKPyV), human adenovirus (HAdV), the human-specific HF183 Bacteroides (HF183) and Escherichia coli (EC) in soluble extracellular polymeric substances (S-EPS), loosely-bound EPS (LB-EPS), tightly-bound EPS (TB-EPS), and pellets of sludge flocs were determined, and the effect of potassium ferrate (PF) treatment on their removal and inactivation was investigated by using both qPCR and viability-qPCR. Results showed that all investigated indicators were detected in each fraction of sludge flocs. The PF treatment led to a great migration of indicators from sludge pellets to sludge EPS and some extent of their inactivation in each fraction of sludge flocs. The overall reductions of human fecal indicators in sludge determined by qPCR were 0-1.30 logs, which were 0-2 orders of magnitude lower than those of 0.69-2.39 logs detected by viability-qPCR, implying their inactivation by PF treatment to potentially alleviate the associated human health risks.

A novel strategy and mechanism for high-quality volatile fatty acids production from primary sludge: Peroxymonosulfate pretreatment combined with alkaline fermentation

To obtain high-quality VFAs production from primary sludge, a novel strategy that combined peroxymonosulfate (PMS) pretreatment and alkaline fermentation (i.e., PMS & pH9) was proposed in the study. The results showed that PMS & pH9 was efficient in sludge solubilization and hydrolysis, resulting in a maximal VFAs yield of 401.2 mg COD/g VSS, which was 7.3-, 2.1-, and 8.8-fold higher than the sole PMS, sole pH9, and control, respectively. Acetate comprised 87.6% of VFAs in this integration system. Mechanism investigations revealed that sulfate and free radicals produced by PMS play roles in improving VFAs yield under alkaline conditions. Besides, sulfate also aided in C3∼C5 VFAs converting to acetate under alkaline conditions depending on the increase of incomplete-oxidative sulfate-reducing bacteria (iso-SRB) (i.e., Desulfobulbus and Desulfobotulus). Moreover, the relative abundances of acid-forming characteristic genera (i.e., Proteiniborus, Proteinilcasticum, and Acetoanaerobium) were higher in PMS & pH9.

Impact of N-butyryl-l-homoserine lactone-mediated quorum sensing on acidogenic fermentation under saline conditions: Insights into volatile fatty acids production and microbial community

Anaerobic fermentation is often inhibited under high salinity conditions. This study discovered a strong, positive association between N-butyryl-l-homoserine lactone (C4-HSL)-mediated quorum sensing (QS) and the production of volatile fatty acids (VFAs) under saline conditions. N-acyl-homoserine lactones were identified during acidogenic fermentation for VFA production. Only C4-HSL was detected at all salt concentrations, and a maximum C4-HSL concentration of 0.49 μg/L was observed at a salt concentration of 15 g/L. C4-HSL secretion was closely related to salinity, and a strong correlation was observed between C4-HSL and VFAs (p < 0.01), especially butyrate. Further experiments with C4-HSL addition indicated that exogenous C4-HSL promoted substrate hydrolysis and increased butyrate production by 1.5 times at 15 g/L NaCl. Microbial community analysis indicated that unclassified_f__Enterobacteriaceae and Clostridium_sensu_stricto_1, associated with QS genes and butyrate production, were positively associated with C4-HSL. This study demonstrates the positive effect of C4-HSL-mediated QS on acidogenic fermentation.

Moderate potassium ferrate dosage enhances methane production from the anaerobic digestion of waste activated sludge

The annual increase of waste activated sludge (WAS) has become an urgent problem to be solved in sewage plants worldwide. Anaerobic digestion (AD) of WAS is an attractive choice to maximize the resource utilization rate. Nevertheless, the disintegration of sludge complex polymers is difficult, resulting in a low bioconversion rate. Potassium ferrate (PF), as a green oxidant with strong oxidizing property, has attracted great attention in WAS pretreatment recently. The effects of PF pretreatment on WAS hydrolysis and its dosage-response on methane production were investigated in the present study. Results show that as PF dosage raise from 0 to 50 g-K2FeO4/ kg-TS (total solids), the methane yield enhanced significantly by 40.3% from 0.083 to 0.12 L/g-VSadded (volatile solids). Nevertheless, the further increase in PF dosage resulted in decreased methane production. Especially with the PF dosage of 500 g-K2FeO4/ kg-TS, methane production is even slightly lower than the control reactor without PF oxidation. The mechanism analysis showed that although the dissolution of polysaccharides and proteins was enhanced with the high dosage of PF, the accompanying released humic-like substances and high concentration of ferric ions should be the main reasons inhibiting methane production.

Effect of activated carbon/graphite on enhancing anaerobic digestion of waste activated sludge

The conductive media was capable to enhance anaerobic digestion and promote direct interspecific electron transfer (DIET). In this study, the effects of activated carbon- and graphite-conductive media on promoting anaerobic digestion efficiency of waste activated sludge were experimentally studied. The results show that the 100 mesh-activated carbon group reactor produced a largest biogas yield of 468.2 mL/g VSS, which was 13.8% higher than the blank test. The graphite group reactor with 400-grain size produced a largest biogas yield of 462.9 mL/g VSS, which was 12.5% higher than the blank test. Moreover, the optimal particle size of such two carbon- conductive mediators were optimized for enhancing degradation efficiency of VSS, TCOD, total protein and total polysaccharide of waste sludge. Activated carbon was capable to promote the hydrolytic acidification stage in anaerobic digestion of waste sludge. When the particle size reduced to the optimal particle size, the promoting effect could be strengthened for producing more hydrolytic acidification products for methanogenesis. However, in the graphite group, the methane production is increased by promoting the consumption of hydrolysis and acidification products and is enhanced with the particle size reduction, thus promoting the methanogenesis process, and improving the anaerobic digestion efficiency. Microbial community analysis showed that both activated carbon and graphite cultivated the genera of Methanosaeta, Methanobacterium, Nitrososphaeraceae, which promoted the improvement of methane production through the acetate debris methanogenesis pathway.

Chronic effects of benzalkonium chlorides on short chain fatty acids and methane production in semi-continuous anaerobic digestion of waste activated sludge

As an emerging pollutant, benzalkonium chlorides (BACs) potentially enriched in waste activated sludge (WAS). However, the microbial response mechanism under chronic effects of BACs on acidogenesis and methanogenesis in anaerobic digestion (AD) has not been clearly disclosed. This study investigated the AD (by-)products and microbial evolution under low to high BACs concentrations from bioreactor startup to steady running. It was found that BACs can lead to an increase of WAS hydrolysis and fermentation, but a disturbance to acidogenic bacteria also occurred at low BACs concentration. A noticeable inhibition to methanogenesis occurred when BAC concentration was up to 15 mg/g TSS. Metagenomic analysis revealed the key genes involved in acetic acid (HAc) biosynthesis (i.e. phosphate acetyltransferase, PTA), β-oxidation pathway (acetyl-CoA C-acetyltransferase) and propionic acid (HPr) conversion was slightly promoted compared with control. Furthermore, BACs inhibited the acetotrophic methanogenesis (i.e. acetyl-CoA synthetase), especially BAC concentration was up to 15 mg/g TSS, thereby enhanced short chain fatty acids (SCFAs) accumulation. Overall, chronic stimulation of functional microorganisms with increasing concentrations of BACs impact WAS fermentation.

Bioconversion of waste activated sludge hydrolysate into polyhydroxyalkanoates using Paracoccus sp. TOH: Volatile fatty acids generation and fermentation strategy

The expensive carbon matrix is a bottleneck restricting the industrialization of polyhydroxyalkanoates (PHAs). Volatile fatty acids (VFAs) derived from waste activated sludge via anaerobic fermentation might be alternative carbon matters for PHAs synthesis. In this study, the effect of enzymes on VFAs yields and the feasibility of the produced VFAs for PHAs fermentation by Paracoccus sp. TOH were investigated. The optimum cumulative VFAs concentration reached 4076.6 mg-COD·L^-1 in the lysozyme treatment system. Correspondingly, the highest poly(3-hydroxybuturate-co-3-hydroxyvalerate) (PHBV) concentration (119.1 mg·L^-1) containing 20.3 mol% 3-hydroxyvalerate was obtained. It proved that Paracoccus sp. TOH possesses the capability for PHBV accumulation. The functional hydrolytic-acidogenic microorganisms, such as Clostridium sensu stricto and Bacteroides sp. were accumulated. The functional genes encoding hydrolysis, carbohydrates metabolism, VFAs generation were enriched. This study offered a possible strategy for VFAs production and verified the feasibility of sludge hydrolysate as a high-quality carbon substrate for PHAs fermentation.

A review of enhanced municipal wastewater treatment through energy savings and carbon recovery to reduce discharge and CO2 footprint

Municipal wastewater treatment that mainly performed by conventional activated sludge (CAS) process faces the challenge of intensive aeration-associated energy consumption for oxidation of organics and ammonium, contributing to significant directly/indirectly greenhouse gas (GHG) emissions from energy use, which hinders the achievement of carbon neutral, the top priority mission in the coming decades to cope with the global climate change. Therefore, this article aimed to offer a comprehensive analysis of recently developed biological treatment processes with the focus on reducing discharge and CO2 footprint. The biotechnologies including "Zero Carbon", "Low Carbon", "Carbon Capture and Utilization" are discussed, it suggested that, by integrating these processes with energy-saving and carbon recovery, the challenges faced in current wastewater treatment plants can be overcome, and a carbon-neutral even be possible. Future research should investigate the integration of these methods and improve anammox contribution as well as minimize organics lost under different scales.

Synergic role of ferrate and nitrite for triggering waste activated sludge solubilisation and acidogenic fermentation: Effectiveness evaluation and mechanism elucidation

Enhancing anaerobic treatment efficiency of waste activated sludge (WAS) toward preferable resource recovery would be an important requirement for achieving carbon-emission reduction, biosolids minimization, stabilization and security concurrently. This study demonstrated the synergic effect of potassium ferrate (PF) and nitrite on prompting WAS solubilisation and acidogenic fermentation toward harvesting volatile fatty acids (VFAs). The results indicated the PF+NaNO₂ co-pretreatment boosted 7.44 times and 1.32 times higher WAS solubilisation [peak soluble chemical oxygen demand (SCOD) of 2680 ± 52 mg/L] than that by the single nitrite- and PF-pretreatment, respectively, while about 2.77 times and 2.11 times higher VFAs production were achieved (maximum VFAs accumulation of 3536.25 ± 115.24 mg COD/L) as compared with the single pretreatment (nitrite and PF)-fermentations. Afterwards the WAS dewaterability was improved simultaneously after acidogenic fermentation. Moreover, a schematic diagram was established for illustrating mechanisms of the co-pretreatment of PF and nitrite for enhancing the VFAs generation via increasing key hydrolytic enzymes, metabolic functional genes expression, shifting microbial biotransformation pathways and elevating abundances of key microbes in acidogenic fermentation. Furthermore, the mechanistic investigations suggested that the PF addition was conducive to form a relatively conductive fermentation environment for enhancing electron transfer (ET) efficiency, which contributed to the VFAs biotransformation positively. This study provided an effective strategy for enhancing the biodegradation/bioconversion efficiency of WAS organic matters with potential profitable economic returns.

Potassium ferrate pretreatment promotes short chain fatty acids yield and antibiotics reduction in acidogenic fermentation of sewage sludge

During the acidogenic fermentation converting waste activated sludge (WAS) into short-chain fatty acids (SCFA), hydrolysis of complex organic polymers is a limiting step and the transformation of harmful substances (such as antibiotics) during acidogenic fermentation is unknown. In this study, potassium ferrate (K₂FeO₄) oxidation was used as a pretreatment strategy for WAS acidogenic fermentation to increase the hydrolysis of sludge and destruct the harmful antibiotics. Pretreatment with K₂FeO₄ can effectively increase the SCFA production during acidogenic fermentation and change the distribution of SCFA components. With the dosage of 0.2 g/g TS, the maximum SCFA yield was 4823 mg COD/L, which is 28.3 times that of the control group; acetic acid accounts for more than 90% of the total SCFA. The higher dosage (0.5 g/g TS) can further increase the proportion of acetic acid, but inhibit the overall performance of SCFA production. Apart from the promotion of hydrolysis and acidogenesis, K₂FeO₄ pretreatment can also simultaneously oxidizes and degrades part of the antibiotics in the sludge. When the dosage is 0.5 g/g TS, the degradation efficacy of antibiotics is the most significant, and the contents of ofloxacin, azithromycin, and tetracycline in the sludge are reduced by 69%, 42%, and 50%, respectively. In addition, K₂FeO₄ pretreatment can also promote the release of antibiotics from sludge flocs, which is conducive to the simultaneous degradation of antibiotics in the subsequent biological treatment process.

pH regulated potassium ferrate oxidation promotes acetic acid yield and phosphorous recovery rate from waste activated sludge

To improve the dose efficiency of K₂FeO₄ in waste activated sludge (WAS) treatment, pH regulation on K₂FeO₄ pretreatment and acidogenic fermentation was investigated. Four pretreatments were compared, i.e. pH3 + 50 g/kg-TS, pH10 + 50 g/kg-TS, neutral pH + 50 g/kg-TS and neutral pH + 100 g/kg-TS (without pH adjustment). The higher short chain fatty acids (SCFAs) yield and phosphorous dissolution rate was found under the condition of pH 10.0. In pH10 + 50 g/kg-TS, the maximum concentration of SCFAs was 5591 mg-COD/L, which yield was 22.6 times higher than that of the neutral pH + 50 g/kg-TS (237 mg COD/L). The acidogenic fermentation period could be shortened to 5 days and acetic acid accounted for 70 % of SCFAs. Furthermore, PO₄^3--P in the hydrolysate (346.5 mg/L) accounted for 47.59 % of TP, which is easier to be recovered by chemical precipitation. Therefore, a more economical and feasible utilization mode of potassium ferrate was proposed.

How does the polyhexamethylene guanidine interact with waste activated sludge and affect the metabolic functions in anaerobic fermentation for volatile fatty acids production

Antibacterial agents are frequently used to ensure public hygiene. Most of the massively consumed chemicals are discarded and accumulated in waste activated sludge (WAS), which might influence the subsequent anaerobic fermentation process for WAS treatment. This study mainly investigated the impacts of polyhexamethylene guanidine (PHMG, considered as a safe and efficient broad-spectrum antibacterial agent) on the volatile fatty acids (VFAs) production derived from WAS anaerobic fermentation and disclosed the key mechanisms. Results demonstrated that low level of PHMG evidently increased the VFAs accumulation as well as the acetic acid proportion, while the excessive dose posed evident negative effects. Further analysis found that appropriate PHMG synchronously stimulated the solubilization/hydrolysis and acidification processes but inhibited methanogenesis. Mechanistic exploration revealed that PHMG firstly absorbed on WAS due to electric attraction but then interacted with WAS to promote extracellular polymeric substance (EPS) disintegration and organics release (especially proteinaceous matter). Moreover, PHMG affected the microbial community structure and metabolic functions. The low level of PHMG evidently enriched functional VFAs producers (i.e., Desulfobulbus, Macellibacteroides and Sporanaerobacter) and upregulated the critical genes expression responsible for substrates metabolism (particularly the proteins) and VFAs biosynthesis (i.e., aldehyde dehydrogenase (NAD+) (K00128) and molybdopterin oxidoreductase (K00184)). This study provides an in-depth understanding of emerging pollutant impacts on WAS fermentation and provides insightful guidance on WAS disposal.

Determination of methanogenesis by nutrient availability via regulating the relative fitness of methanogens in anaerobic digestion

Response of microbial community to nutrient availability in anaerobic digestion (AD) remains elusive. Prokaryotic communities in AD batch cultures with 0, 1, 3, 5, 7, 11, 15, 20, and 25 g/L peptone were monitored using massive parallel sequencing and quantitative PCR over a 34-day experimental period. Methane production displayed a hump-shaped response to the nutrient gradient (peaking at 15 g/L peptone). Moreover, total and acetoclastic methanogens showed hump-shaped responses (both peaking at 11 g/L peptone). However, prokaryotic population increased with nutrient concentration (linear regression, R² = 0.86) while diversity decreased (R² = 0.94), and ordination analysis showed a gradual succession of community structure along the first axis. Network analysis revealed that extent of interspecific interactions (e.g., edge number and clustering coefficient) exhibited a hump-shaped response. The combined results indicate that abundant species became more dominated with increasing nutrient, which can result in a gain or loss of interspecific interaction within the community. Network module analysis showed that one module dominated the network at each nutrient level (comprising 41%-65% of the nodes), indicating that AD community formed a core microbial guild. The most abundant phylotypes, Macellibacteroides and Butyricicoccaceae, were consistently negative with acetoclastic methanogens in the dominant modules. Their predominance at ≥15 g/L peptone can explain the hump-shaped responses of methanogenesis and methanogens. Collectively, methanogenesis and microbial network exhibited hump-shaped responses, although microbial community exhibited monotonic responses. Therefore, nutrient availability can determine the methanogenesis through regulating the relative fitness of methanogens within the community.

Electrochemical valorization of waste activated sludge for short-chain fatty acids production

A tremendous amount of waste activated sludge (WAS) ends up in landfilling even after a substantial retention time during anaerobic digestion. This leftover activated sludge is an organic-rich material with the high potential to produce value-added chemicals such as short chain fatty acids (SCFAs). In the present study, a novel electrochemical conversion of activated sludge (E-WAS) was carried out on the surface of non-precious electrodes (nickel, stainless-steel and copper) in alkaline media at low applied potential and temperature. Cyclic voltammetry showed that Cu (II)/Cu (III) and Ni (II)/Ni(III) redox couple catalyzed the WAS oxidation reaction to produce SCFAs and hydrogen. The results revealed that Cu(II)/Cu(III) has higher catalytic oxidation capability towards SCFAs. Yields of 48.7, 21.4, and 14.6 mg SCFAs per g of volatile solids were achieved by using copper, nickel and stainless-steel as working electrodes, respectively. Post analysis characterization techniques indicate that copper oxide films lead to WAS oxidation. Total volatile solid removal of 30% was obtained at 35°C and 1.65 V in 0.2 M NaOH after 2 h of operation in an electrochemical digestor with copper electrodes which is more efficient than a conventional alkaline treatment (24 h, 55%, 1M NaOH). Ammonia was produced as the by-product of E-WAS oxidation. The highest amount of ammonia (250 mg L−1) was obtained by using nickel as the working electrode after 2 h operation at 35°C and 1.35 V applied potential. The change in WAS morphology revealed that the copper oxide film is an effective electrocatalyst for WAS disinfection.

Biohydrogen production from waste activated sludge through thermochemical mechanical pretreatment

Generation of excess sludge in large quantities from wastewater treatment plant face huge problem in terms of handling and management, whereas it possess higher organic and inorganic constituents and thus it can be used as a feedstock for the generation of biofuel with proper disintegration techniques.In this regard, an effort has been made in this study to combine thermo-chemo-disperser pretreatment for the disintegration of paper mill waste activated sludge for the production of biohydrogen in an energy efficient way. These combinations of thermo-chemo-disperser (TCD) tend to be effective in disintegration and possess 24.3% COD solubilization and higher suspended solid reduction of 18.8% at the specific energy usage of 2081.82 kJ/kg TS. The pretreatment with TCD technique shows the biohydrogen production of 120.2 mLH₂/gCOD as compared to thermochemically pretreated alone (73.6 mLH₂/gCOD) sample. Thus, the combined process was considered to be potentially effective in sludge disintegration.

Potassium ferrate followed by alkali-stripping treatment to achieve short-chain fatty acids and nitrogen recovery from waste activated sludge

Waste activated sludge (WAS) is a potential resource to achieve carbon-neutral goal of wastewater treatment plant. However, the solubilization is always the rate-limiting step for resource recovery from anaerobic digestion of WAS. This study reported a novel strategy, i.e., potassium ferrate (PF) followed by alkali-stripping treatment, to achieve short-chain fatty acids (SCFAs) and nitrogen recovery from WAS. Results showed that whether the stripping process was conducted under alkaline condition or not, the SCFAs production potential was increased rather than reduced. The promoted SCFAs production was due to the accelerated solubilization and hydrolysis stages but the inhibited methanogenesis stage. The SCFAs yield reached 258 mg chemical oxygen demand (COD)/g volatile suspended solids (VSS), and the carbon source, including SCFAs, soluble polysaccharides and proteins, reached 384 mg COD/g VSS. The potentially recovered nitrogen was about 8.71 mg NH₄⁺-N/g VSS. This work may provide some new solutions for enhancing resource recovery from WAS.

An enhanced excess sludge fermentation process by anthraquinone-2-sulfonate as electron shuttles for the biorefinery of zero-carbon hydrogen

Excess sludge (ES) largely produced in municipal wastewater treatment plants is known as a waste biomass and the traditional treatment processes such as landfill and incineration are considered as unsustainable due to the negative environmental impact. Fermentation process of ES for the biorefinery of zero-carbon hydrogen has attracted an increasing interesting and was extensively researched in the last decades. However, the technology is far from commercial application due to the insufficient effectivity. In the present study, anthraquinone-2-sulfonate (AQS) as electron shuttles was introduced into the fermentation process of ES for mediating the composition and activity of bacterial community to get an enhanced biohydrogen production. Inoculated with the same anaerobic activated sludge of 1.12 gVSS/L, a series of batch anaerobic fermentation systems with various dosage of AQS were conducted at the same ES load of 2.75 gVSS/L, initial pH 6.5 and 35 °C. The results showed that the fermentation process was remarkably enhanced by the introduction of 100 mg/L AQS, accompanying the lag phase was shortened to 1.35 h from 7.62. The obtained biohydrogen yield and the specific biohydrogen production rate were also remarkably enhanced to 24.9 mL/gVSS and 0.3 mL/(gVSS·h), respectively. Illumina Miseq sequencing showed that Longilinea and Guggenheimella as the dominant genera had been enriched from 9.2% to 0-12.0% and 4.7%, respectively, in the presence of 100 mg/L AQS. Function predicted analysis suggested that the presence of AQS had increased the abundance of genes involved in the transport and metabolism of carbohydrate, amino acid and energy production. Further redundancy analysis (RDA) revealed that the enhanced hydrogen production was highly positively correlated with the enrichment of genera such as Longilinea and Guggenheimella. The research work presents a novel potential biorefinery of ES for the effective production of zero-carbon hydrogen.

Up-flow anaerobic column reactor for sulfate-rich cadmium-bearing wastewater purification: system performance, removal mechanism and microbial community structure

This study constructed an up-flow anaerobic column reactor fed with synthetic sulfate-rich cadmium (Cd(II))-bearing wastewater, for investigating its Cd(II) removal performance and mechanism. Long-term experiment results manifest that introducing Cd(II) into influent led to an enhanced sulfate removal but did not increase the effluent sulfide concentration, implying the CdS formation. When influent Cd(II) concentration was shifted from 50 to 100 mg/L, the median Cd(II) removal rate was increased from 13.6 to 32.2 mg/(L·d). Batch tests indicate that the uptake and sequestration function of anaerobes merely led to a small portion of Cd(II) removal. A majority of aqueous Cd(II) (86.3%) was eliminated by precipitation reactions. The generated precipitates were found to be dominantly presented in carbonate, Fe-Mn oxide, sulfide bound and residue forms, which account for 92.6-93.9% of total Cd content of sludge obtained at diverse operation phases. The crystallographic CdS (i.e., residue fraction) particles have nano-scale sizes, and the relatively high atomic ratio of S to Cd was likely due to the adsorption/deposition of other sulfides. The dominant sulfate-reducing bacteria (SRB) were recognized as Desulfurella, Desulforhabdus and Desulfovibrio, and the primary competitor with them for substrate utilization were identified to be methanogens.

Monitor process state of batch anaerobic digestion in reliance on volatile and semi-volatile metabolome

It has been a challenge to recognize appropriate compounds as indicators for monitoring and early-warning of the anaerobic digestion process. A strategy was initiated to explore the evolution of the panorama profile of volatile and semi-volatile metabolites. Non-target analysis using high-resolution gas chromatography coupled with Orbitrap mass spectrometry was applied to construct a time-series molecular fingerprint of 218 metabolites classified in 14 categories. Alkanes accounted for the main part in early and late stages of methanization and aromatic compounds were the major in middle stage. Spearman correlation analysis and partial least squares analysis unwind that Trichococcus (1.49%-83.96%) was positively related to most of metabolites at early and middle stages, while Brevundimonas (0%-24.04%) was positively related to acylamide at late stage. This indicated that microbial volatile organic compounds were possible to serve as biochemical indicators for anaerobic digestion performance and to build nexus of "what" (metabolites), "who" (microorganism), and "how" (kinetics).

Stepwise freezing-thawing treatment promotes short-chain fatty acids production from waste activated sludge

Waste activated sludge (WAS), as the byproducts of wastewater treatment plants, has been greatly produced. With high cost and environmental risk of WAS disposal, to explore a low-cost and environment-friendly technology has been a great challenge. Considering that WAS is a collection of organic matters, anaerobic fermentation has been selected as a sustainable way to simultaneously recover resources and reduce environmental pollution. To recover short-chain fatty acids (SCFAs) has gained great concern because of the high value-added application and high-efficiency production process. Considering the temperature in some areas of the world can reach to below 0 °C, this study proposed an efficient strategy, i.e., stepwise freezing and thawing treatment, to promote SCFAs production. The maximal production of SCFAs, i.e., 246 mg COD/g volatile suspended solid, was obtained with the shortened retention time of five days. Mechanistic studies showed that the solubilization of both extracellular polymeric substances (EPSs) and microbial cells could be accelerated, with the EPSs removal of 58.3% for proteins and 59.0% for polysaccharides. Also, the hydrolysis process was promoted to provide more substrates for subsequent acidogenisis, and the functional microorganisms, such as Romboutsia, Paraclostridium, Macellibacteroides and Conexibacter, were greatly enriched, with a total abundance of 26.2%. Moreover, compared to control, methanogenesis was inhibited at a shortened sludge retention time (e.g., five days), which benefited to the accumulation of SCFAs, but the methane production was increased by 25.2% at a longer sludge retention time (e.g., ten days). Thus, these findings of this work may provide some new solutions for the enhanced resource recovery from WAS, and further for carbon-neutral operation of wastewater treatment plants.

Role and significance of water and acid washing on biochar for regulating methane production from waste activated sludge

Methane recovered from anaerobic digestion of waste activated sludge (WAS) can be used as the energy supplement of the wastewater treatment plant, benefiting to its carbon-neutral operation. In order to enhance methane production, biochar (BC) has been widely selected as conductive material to build direct interspecies electron transfer (DIET) in anaerobic digestion of WAS. However, the role and significance of washing strategies, including water and acid washing, on BCs for regulating methane production have not been reported. This study selected the frequently used woody- (W) and straw (S)-BCs as mode. Compared to raw W-BC, water and acid washing W-BC increased the methane yields by 19.1% and 15.7%, respectively. Differently, the methane yields among raw, water and acid washing S-BCs were similar. Mechanism study showed that both the two washing strategies optimized the properties of raw W-BC for promoting methane production. Water and acid washing W-BCs increased the electron transfer functional groups, such as ketones and quinones, which were not observed in S-BCs. Moreover, the electron-active microorganisms were enriched with the presence of water and acid washing W-BCs, and the predominant pathway for methane production shifted from hydrogentrophic to acetotrophic and DIET methanogenesis, while the microbial communities, including bacteria and archaea, were similar with the presence of raw, water and acid washing S-BCs. These findings of this work provide some new insights for production improvement regulation of methane from anaerobic digestion of wastes induced by BCs.

Effect of potassium persulphate addition on sludge disintegration of a mesophilic anaerobic fermentation system

Persulphates, an advanced oxidation process, has been recently used as an alternative pretreatment method to enhance short-chain fatty acids (SCFAs) yield from waste-activated sludge (WAS) anaerobic fermentation (AF). But so far, the effects of peroxydisulphate (PDS) dosages on mesophilic anaerobic fermentation are still not studied fully. Herein, we explored the influences of potassium PDS addition on mesophilic AF of WAS. Notably, the addition of PDS could drastically accelerate WAS solubilization and hydrolysis, which was proportional to the amount of PDS. The maximal total SCFAs yield of 249.14 mg chemical oxygen demand/L was obtained with 120 mg PDS/g suspended solids addition at 6 days of AF, which was 2.2-fold that of the control one. Tightly bound extracellular polymeric substances (EPSs) were transformed into loosely bound EPS and dissolved organic matters, and aromatic proteins and humic-like substances of EPSs were disintegrated, which were caused by the devastating effects of PDS treatments on EPSs disruption. The intracellular constituents of microbial cells in the sludge were released accordingly. As a result, there was release of soluble substrates derived from the disintegration of both EPSs and cells, the amounts of which were proportional to the dose of PDS. Moreover, microbial diversity and richness were both decreased in the presence of PDS, and the relative abundance of phyla Actinobacteria increased with the increase of the PDS dosage. In addition, the stability of sludge flocs was destroyed in the presence of PDS, the distribution of particle size tended to be small and dispersive, and dewaterability of the sludge was deteriorated.

Performance and Mechanism of Fe3O4 Improving Biotransformation of Waste Activated Sludge into Liquid High-Value Products

This study demonstrated that Fe₃O₄ simultaneously improves the total production and formation rate of medium-chain fatty acids (MCFAs) and long-chain alcohols (LCAs) from waste activated sludge (WAS) in anaerobic fermentation. Results revealed that when Fe₃O₄ increased from 0 to 5 g/L, the maximal MCFA and LCA production increased significantly, and the optimal fermentation time was also remarkably shortened from 24 to 9 days. Moreover, Fe₃O₄ also enhanced WAS degradation, and the corresponding degradation rate in the fermentation system increased from 43.86 to 72.38% with an increase in Fe₃O₄ from 0 to 5 g/L. Further analysis showed that Fe₃O₄ promoted the microbe activities of all the bioprocesses (including hydrolysis, acidogenesis, and chain elongation processes) involved in the MCFA and LCA production from WAS. Microbial community analysis indicated that Fe₃O₄ increased the abundances of key microbes involved in abovementioned bioprocesses correspondingly. Mechanistic investigations showed that Fe₃O₄ increased the conductivity of the fermented sludge, providing a better conductive environment for the anaerobic microbes. The redox cycle of Fe(II) and Fe(III) existed in the fermentation system with Fe₃O₄, which was likely to act as electron shuttles to conduct electron transfer (ET) from the electron donor to the acceptor, thus increasing ET efficiency. This study provides an effective method for enhancing the biotransformation of WAS into high-value products, potentially bringing economic benefits to WAS treatment.

Freezing-low temperature treatment facilitates short-chain fatty acids production from waste activated sludge with short-term fermentation

This study proposed a novel and high-efficiency strategy, i.e., freezing followed by low-temperature thermal treatment, to significantly promote short-chain fatty acids (SCFAs) production from waste activated sludge compared to traditional freezing/thawing treatment. The maximal production of SCFAs was 212 mg COD/g VSS with a shortened retention time of five days, and the potentially recovered carbon source, including SCFAs, soluble polysaccharides and proteins, reached 321 mg COD/g VSS, increased by 92.1 and 28.3% compared to sole freezing and thermal treatment. Both the solubilization and hydrolysis steps of WAS were accelerated, and the acid-producing microorganisms, such as Macellibacteroides, Romboutsia and Paraclostridium, were greatly enriched, with a total abundance of 13.9%, which was only 0.54% in control. Interestingly, the methane production was inhibited at a shortened retention time, resulting in SCFAs accumulation, whereas it was increased by 32.0% at a longer sludge retention time, providing a potential solution for energy recovery from WAS.

Enhanced waste activated sludge dewaterability by the ozone-peroxymonosulfate oxidation process: Performance, sludge characteristics, and implication

Dewatering treatment is an essential step to diminish sludge volume, cut down transportation costs, and improve subsequent disposal efficiency. In this study, ozone-peroxymonosulfate (O₃/PMS) oxidation process was employed to ameliorate sludge dewaterability. Sludge capillary suction time (CST) and water content (Wc) of dewatered sludge cake could reduce from 70.5 s and 81.93% to 26.7 s and 65.65%, respectively, under the optimal dosage of 30 mg/g TS O₃ and 0.4 mmol/g TS PMS. The increased sludge zeta potential, particle size, and fluidity promoted sludge dewatering performance apparently. The decreased hydrophilic, fluorescent EPS components and proteins/peptides-like + Lipids percentage in EPS as well as the ratio of α-helix/(β-sheet + random coil) of treated EPS protein secondary structure was greatly responsible for the enhanced sludge dewaterability. SO₄^- and OH were detected in ozone-peroxymonosulfate process to crack sludge flocs, eliminate hydrophilic substances and liberate bound water. Moreover, the concentrations of both heavy metals and polycyclic aromatic hydrocarbons (PAHs) of sludge after O₃/PMS conditioning were decreased, and the stability and toxicity of heavy metals were also reduced, except Zn. In conclusion, this work offered a comprehensive insight based on ozone-peroxymonosulfate (O₃/PMS) advanced oxidation for improving the sludge dewaterability and environmental implication.

Effect of temperature on fermentative VFAs production from waste sludge stimulated by riboflavin and the shifts of microbial community

Fermentative volatile fatty acids (VFAs) production from waste activated sludge (WAS) under moderate temperature is a promising way for resource and energy regeneration in municipal wastewater treatment plants (MWTPs). In this study, the effect of temperature on VFAs production and the associated microbial community from riboflavin-assisted WAS fermentation were investigated. Three fermentative reactors under 25, 35 and 55 °C were operated for 30 days, respectively. The results indicated that riboflavin enhanced VFAs production from WAS fermentation under moderate temperatures (25 °C, 35 °C), increasing conversion of organic matters to bioavailable substrates for the subsequent acidification process. Although a small dosage of riboflavin (1.0 ± 0.05 mM) hardly inhibited the methanogenic process, it could mediate the electron sink for VFAs under lower temperatures. This in turn increased the accumulation of acetic and propionic acids (up to 234 mg/g of volatile suspended solids) and their proportions relative to the total VFAs, being efficient electron donors and carbon sources for nutrient removal in MWTPs. Furthermore, microbial communities were shifted in response to temperature, and riboflavin stimulated the special fermentative bacteria under room temperature and mesophilic conditions. The study suggested a feasible and eco-friendly method to improve VFAs production from crude WAS at a relatively lower temperature.

Polysorbate-80 pretreatment contributing to volatile fatty acids production associated microbial interactions via acidogenic fermentation of waste activated sludge

Polyoxyethylene dehydration sorbitol monooleate (polysorbate-80) pretreatment enhanced volatile fatty acids (VFAs) production of waste activated sludge (WAS) in acidogenic fermentation. The results showed that polysorbate-80 ameliorated WAS solubilization obviously with a soluble chemical oxygen demand (SCOD) increasing to 1536 mg/L within 4 h. Within 2 days of acidogenic fermentation, the maximal VFAs arrived to 2958.35 mg COD/L via polysorbate-80-pretreatment. The polysorbate-80 pretreatment boosted microbial diversity and richness in fermentation process. The Clostridium, Macellibacteroides and Acidocella strengthened microbial cooperation for the metabolic functions enhancement (e.g. amino acid metabolism and carbohydrate metabolism) for VFAs generation from WAS organics. Overall, the polysorbate-80 could play positive roles on the transformation of organic matter from sludge solid matters to VFAs, which was turned out to become an effective enhancing strategy for future WAS treatment / bioresource recovery with relatively low cost.

New insight into enhanced short-chain fatty acids production from waste activated sludge through pretreatment of cation exchange resin coupled NaCl addition

In this study, a novel pretreatment of cation exchange resin (CER) coupled NaCl addition was proposed to enhance waste activated sludge (WAS) hydrolysis and promote short-chain fatty acids (SCFAs) production in the anaerobic fermentation process. At the optimal pretreatment condition of 3 g/g SS CER and 15 g/L NaCl, considerable SCOD (i.e. 5107 mg/L, 35.4% of TCOD) was released after 2-day coupled treatment, which provided sufficient organic substance for the subsequent SCFAs production. The sludge hydrolysis mechanism was illustrated, i.e. CER triggered extracellular polymeric substances (EPS) disruption and NaCl induced microbial cells lysis. The synergistic interaction between CER and NaCl pretreatment was investigated and application potential of fermentative liquid was evaluated after the coupled pretreatment-enhanced anaerobic fermentation. In the presence of abundant biodegradable substrates in the fermentative liquid, 4742 mg COD/L (i.e. 388 mg COD/g VSS) of SCFAs production was achieved within 6-day anaerobic fermentation, mainly composed of acetic and propionic acids (70.4% of total SCFAs).

Effect of polystyrene microplastics on the volatile fatty acids production from waste activated sludge fermentation

Anaerobic fermentation is crucial to resource utilization of waste activated sludge (WAS). However, accumulated microplastics (MPs) in sludge could not be ignored. Here, a typical MP, polystyrene (PS), was selected to study the effects of different concentrations of PS on anaerobic fermentation under the optimal volatile fatty acids (VFAs) production. Compared to the control, low PS concentrations (30 particles/g _{total solid}) significantly (p = 0.002) increased the production of VFAs to 112.8 ± 2.4% due to solubilization enhancement and enzymatic activity. High concentrations of PS (90 particles/g _{total solid}) significantly (p = 0.000) decreased VFAs production to 83.01 ± 0.76% because of the inactive related microbial activities, although organic matter release was enhanced in the initial stage. Mechanism studies showed that the toxicity of high PS concentration could be attributed to reactive oxygen species (ROS) production, excess sodium dodecyl sulfate (SDS), and synergistic toxicity of aged MPs with external pollutants.

Stepwise alkaline treatment coupled with ammonia stripping to enhance short-chain fatty acids production from waste activated sludge

To recover resource from waste activated sludge (WAS) is of great significance. This study proposed a promising way, i.e., stepwise alkaline treatment coupled with ammonia stripping, to remarkably enhance short-chain fatty acids (SCFAs) production from WAS anaerobic digestion. The maximal production of SCFAs, with the value of 323 mg COD/g volatile suspended solid, was obtained with first initial pH = 10 adjustment followed by second initial pH = 10 adjustment on third day coupled with ammonia stripping. Mechanistic studies showed that solubilization of both extracellular polymeric substances and cells could be accelerated by stepwise initial pH = 10 adjustment. However, without ammonia stripping, the activities of either acidogens or methanogens could be inhibited by free ammonia formed under alkaline conditions; positively, anaerobes related to SCFAs production were enriched with ammonia stripping. Moreover, the proposed strategy can simultaneously achieve nitrogen and carbon recovery, providing some solutions for the carbon-neutral operation of wastewater treatment plants.

Responses of anaerobic digestion of waste activated sludge to long-term stress of benzalkonium chlorides: Insights to extracellular polymeric substances and microbial communities

Quaternary ammonium compounds have gained widespread attention due to their extensive enrichment in waste activated sludge (WAS) and potentially adverse effect to anaerobes. This study selected benzalkonium chlorides (BACs) as model to reveal the responses of anaerobic digestion of WAS to long-term stress of BACs. Results showed that the solubilization enhancement of WAS contributed by BACs was the acceleration of cell lysis, rather than the disruption of extracellular polymeric substances, and the accumulation improvement of short chain fatty acids (SCFAs) attributed to hydrolysis improvement and methanogenesis inhibition at either medium -or high level of BACs. In addition, a low level had no significant effect on the production of methane compared to control, with averages of 0.059 and 0.055 m³/(m³·d), respectively, whereas a medium level reduced methane production to 20% of control, and a high level almost completely inhibited methanogenesis. Correspondingly, BACs could shift microbial communities related to SCFAs and methane productions. For the bacterial community, a high level of BACs led to abundance reductions of Firmicutes, Bacteroidetes, Acidobacteria and Chloroflexi, but Synergistetes was increased to 10.5%, which was almost not detected either in control or at a low level of BACs. And for dominant archaeal community, they tended to be shifted from acetotrophic to hydrogenotrophic methanogens with BACs increasing from low to high level. These findings provided some new insights for the role of BACs in anaerobic digestion, as well as resource recovery from WAS.

Effect of temperature on the persistence of fecal bacteria in ambient anaerobic digestion systems treating swine manure

This study aimed to explore the effect of temperature on the persistence of fecal bacteria by multiple approaches in ambient anaerobic digestion systems treating swine manure. Both lab-scale (15 °C, 20 °C, and 25 °C) and field (26 °C on average) studies were conducted by high-throughput sequencing and culture-based methods. A community-wide Bayesian SourceTracker method was used to identify and estimate the fecal bacterial proportion in anaerobic effluent. High proportional contributions of fecal bacteria were observed in effluent at 15 °C (73%) and 20 °C (75%), while less was found at 25 °C (19%). This was further verified by a field study (23%) and an anaerobic reactor study at 37 °C (0.01%). To explore the potential reasons for differences in fecal bacterial proportions, bacterial taxa were divided into "lost" and "survivor" taxa in manure waste by LEfSe. The "survivor" taxa abundance was positively correlated with SourceTracker proportion (r = 0.913, P = 0.001), but negatively correlated with temperature (r = -0.826, P = 0.006). In addition, biomarkers in effluent were divided into "enriched" and "de novo" taxa. "Enriched" taxa, including acidogenic and acetogenic bacteria, were found at all temperatures, whereas taxa related to organic degradation were multiplied "de novo" at 25 °C. Variation partition analysis showed that temperature could explain 30% of variations in effluent bacterial community. Moreover, coliforms isolated from the manure and effluents at 15 °C and 20 °C were also phylogenetically related. This study provided comprehensive insight into the impact of temperature on the persistence of fecal bacteria in anaerobic effluent, with temperatures over 25 °C recommended to reduce fecal pollution.

Performances and mechanisms of simultaneous nitrate and phosphate removal in sponge iron biofilter

Sponge iron is a potential material for nitrogen and phosphate removal. To explore the performances and mechanisms of nitrogen and phosphate removal by sponge iron, a sponge iron biofilter was established. The results showed that nitrate was completely removed at HRT of 48 h without external carbon source and at HRT of 3 h with C/N ratio of 5. Furthermore, it was easy to achieve partial denitrification at HRT of 1 h with C/N ratio of 3. The mechanisms of nitrate removal were chemical reduction and nitrate dependent ferrous oxidation without external carbon source and heterotrophic denitrification with external carbon source. XPS result indicated that phosphate was removed by the formation of ferric phosphate precipitation. High throughput sequencing showed that iron-oxidizing bacteria Gallionellaceae was highly enriched in biofilter, accounting for 17.83%, which indicated that it was feasible to achieve autotrophic nitrate removal by sponge iron biofilter.

Exploration of microbial communities contributing to effective methane production from scum under anaerobic digestion

Scum is formed by the adsorption of long-chain fatty acids (LCFAs) onto biomass surface in anaerobic digestion of oily substrates. Since scum is a recalcitrant substrate to be digested, it is disposed via landfilling or incineration, which results in biomass washout and a decrease in methane yield. The microbes contributing to scum degradation are unclear. This study aimed to investigate the cardinal microorganisms in anaerobic scum digestion. We pre-incubated a sludge with scum to enrich scum-degrading microbes. Using this sludge, a 1.3-times higher methane conversion rate (73%) and a faster LCFA degradation compared with control sludge were attained. Then, we analyzed the cardinal scum-degrading microbes in this pre-incubated sludge by changing the initial scum-loading rates. Increased 16S rRNA copy numbers for the syntrophic fatty-acid degrader Syntrophomonas and hydrogenotrophic methanogens were observed in scum high-loaded samples. 16S rRNA amplicon sequencing indicated that Syntrophomonas was the most abundant genus in all the samples. The amino-acid degrader Aminobacterium and hydrolytic genera such as Defluviitoga and Sporanaerobacter became more dominant as the scum-loading rate increased. Moreover, phylogenic analysis on Syntrophomonas revealed that Syntrophomonas palmitatica, which is capable of degrading LCFAs, related species became more dominant as the scum-loading rate increased. These results indicate that a variety of microorganisms that degrade LCFAs, proteins, and sugars are involved in effective scum degradation.

Synergistic pretreatment of CaO and freezing/thawing to enhance volatile fatty acids recycling and dewaterability of waste activated sludge via anaerobic fermentation

To avoid the generally deteriorated dewaterability of sludge in waste activated sludge (WAS) anaerobic acidogenesis, the combination of varied calcium oxide (CaO) dosage (i.e., 0.01-0.07 g/g TS) and freezing/thawing pretreatment (5 F/T cycles) was investigated for concurrently improving the production of volatile fatty acids (VFAs) and dewatering performance of sludge. The highest release of soluble chemical oxygen demand (SCOD) (1836 ± 96 mg/L) and accumulation of VFAs (448.0 mg COD/g VS) were reached through the co-pretreatment of CaO (0.07 g/g TS) and F/T (50 h at -24 °C) (i.e., 0.07 CaO-F/T). Meanwhile, optimal dewaterability of sludge was also achieved in 0.07 CaO-F/T co-pretreated WAS fermentation, which was reflected by large particle size (98.32 μm), low capillary suction time (41.6 s), decreased specific resistance to filtration (SRF, reduced 47.5% against blank) and high zeta potential (-9.59 mV). Co-pretreatment of CaO and F/T reduced the species number of total microbial population, but improved the abundance of acid-producing bacteria. Increased abundance of Bacteroides, Macellibacteroides, Petrimonas, Prevotella, Clostridium, and Megasphaera was positively relevant to the high yields of VFAs. The economic analysis indicated that CaO-F/T was economically acceptable with considerable estimated net profits, which provided a feasible and efficient alternative for further WAS treatment at large scale.

Keystone Species and Niche Differentiation Promote Microbial N, P, and COD Removal in Pilot Scale Constructed Wetlands Treating Domestic Sewage

The microbial characteristics related to nitrogen (N), phosphorus (P), and chemical oxygen demand (COD) removal were investigated in three pilot scale constructed wetlands (CWs). Compared to horizontal subsurface flow (HSSF) and surface flow (SF) CWs, the aerobic vertical flow (VF) CW enriched more functional bacteria carrying genes for nitrification (nxrA, amoA), denitrification (nosZ), dephosphorization (phoD), and methane oxidation (mmoX), while the removal of COD, total P, and total N increased by 33.28%, 255.28%, and 299.06%, respectively. The co-occurrence network of functional bacteria in the HSSF CW was complex, with equivalent bacterial cooperation and competition. Both the VF and SF CWs exhibited a simple functional topological structure. The VF CW reduced functional redundancy by forming niche differentiation, which filtered out keystone species that were closely related to each other, thus achieving effective sewage purification. Alternatively, bacterial niche overlap protected a single function in the SF CW. Compared with the construction type, temperature, and plants had less effect on nutrient removal in the CWs from this subtropical region. Partial least-squares path modeling (PLS-PM) suggests that high dissolved oxygen and oxidation-reduction potential promoted a diverse bacterial community and that the nonkeystone bacteria reduced external stress for functional bacteria, thereby indirectly promoting nutrient removal.

Evaluating the effect of fluoxetine on mesophilic anaerobic dark biohydrogen fermentation of excess sludge

Recently, the influence behavior of new pollutants in the environment has been widely concerned. However, the effect of antidepressants widely detected in excess sludge (ES) on biohydrogen production from anaerobic dark fermentation has never been explored. To fill this gap, fluoxetine (FLX), a typical antidepressant, was selected to evaluate its effect on ES mesophilic anaerobic dark biohydrogen fermentation. The results showed that FLX reduced biohydrogen production even at low content (0.1 mg/Kg). The biohydrogen yield was only 12.8 mL/g in the 1.8 mg/Kg (based on total suspended solids) FLX group, decreased by about 34.7%, compared with the control group (without FLX). Further mechanism investigation implied that high levels (more than 0.6 mg/Kg) of FLX reduced every step associated with the biohydrogen production. FLX reduced the concentration of ammonia nitrogen and phosphate in fermentation broth. FLX also had a significant negative effect on enzyme activity in ES dark fermentation.

Insights into heterotrophic denitrification diversity in wastewater treatment systems: Progress and future prospects based on different carbon sources

Nitrate, as the most stable form of nitrogen pollution, widely exists in aquatic environment, which has great potential threat to ecological environment and human health. Heterotrophic denitrification, as the most economical and effective method to treat nitrate wastewater, has been widely and deeply studied. From the perspective of heterotrophic denitrification, this review discusses nitrate removal in the aquatic environment, and the behaviors of different carbon source types were classified and summarized to explain the cyclical evolution of carbon and nitrogen in global biochemical processes. In addition, the denitrification process, electron transfer as well as denitrifying and hydrolyzing microorganisms among different carbon sources were analyzed and compared, and the commonness and characteristics of the denitrification process with various carbon sources were revealed. This study provides theoretical support and technical guidance for further improvement of denitrification technologies.