Effect of production system on physical-chemical, antioxidant and fatty acids composition of Longissimus dorsi and Serratus ventralis muscles from Iberian pig

Feeding pigs with hazelnut skin and addition of a concentrated phenolic extract from olive-milling wastewaters during pork processing: Effects on salami quality traits and acceptance by the consumers

Two groups of ten barrows received a conventional- (CTRL) or an experimental- (HZL) finishing diet containing 11% of hazelnut skin. From each barrow, two types of salami (namely, NITR, and PHEN) were obtained. NITR salami was added with E250 and E252. The latter were replaced by a phenolic concentrated extract from olive-milling wastewaters in PHEN salami. Salami fatty acids (FA), antioxidant capacity, lipid and color stability during refrigerated storage were assessed. A consumer test was also performed. Feeding strategy minimally affected the investigated parameters. PHEN salami had lower TBARS than NITR salami (P-value <0.001) during refrigerated storage despite comparable antioxidant capacity and similar PUFA content. Moreover, within CTRL group, lipid oxidation was lower in PHEN than NITR salami (P-value = 0.040). At the blind taste, dietary treatment did not affect salami sensorial properties nor consumer acceptance, whereas NITR salami showed better color (P-value = 0.036). Interestingly, HZL and PHEN salami showed improved sensorial properties and consumer acceptance after that consumers received information on salami origin.

Does hunted wild boar meat meet modern consumer nutritional expectations?

The present study aimed to evaluate the nutritional characteristics of hunted wild boar (WB) meat and compare them with those of meat from analogous domestic animals (pigs) reared in two different rearing systems: indoor-intensive (PI) and outdoor-extensive (PO). WB meat showed a lower amount of lipid content compared to pork and a higher antioxidant activity compared to PI and PO. The comparison of the fatty acid composition of WB and domestic pig reveals significant differences in saturated fatty acids (SFA) and polyunsaturated fatty acids (PUFA), with WB having the highest PUFA level and the lowest SFA level. The omega 6/omega 3 (n-6/n-3) PUFA ratio, PUFA/SFA, atherogenic and thrombogenic indices (AI and TI), as well as the hypocholesterolemic/ hypercholesterolemic index (h/H), were calculated. The n-6/n-3 PUFA ratio was higher in pork independently of the rearing system. The PUFA/SFA ratio of WB meat was above the minimum ratio of 0.40 recommended to contribute to a reduction in the risk of coronary diseases in pork from both rearing systems. AI and TI were lower in WB meat compared to commercially reared pigs, while h/H was higher in WB in comparison with pork meat. WB meat shows good nutritional quality; therefore, the use of game meat as a food source could be appropriate and could benefit contemporary consumers looking for "green" and high-nutritional products.

The Antioxidant Effect of Burdock Extract on the Oxidative Stability of Lard and Goose Fat during Heat Treatment

Concerns regarding product quality and nutrition are raised due to the effects of high temperatures on frying fats. The aim of this research was to examine the effects of temperature and burdock extract addition in relation to quality parameters for dietary lard and goose fat exposed to heating. In order to monitor quality changes, animal fats and 0.01% additivated fats were heated at different temperatures (110, 130, 150, 170, 190, and 210 °C for 30 min). Thiobarbituric acid-reactive substances test (TBARS), peroxide value (PV), iodine value (IV), acid value (AV), saponification value (SV), total polar compounds (TPoC), total phenolic content (TPC), fatty acid (FA) content, and microscopic examination were established in order to quantify the level of oxidative rancidity. Heating temperature and additivation had a significant (p < 0.001) effect on peroxide value. In all fats, values of thiobarbituric acid-reactive substances significantly (p < 0.001) increased with heating temperature, but values decreased when burdock extract was added in a proportion of 0.01%. Positive correlations were found between AV and PV for lard (r = 0.98; p < 0.001) and goose fat (r = 0.96; p < 0.001). The heating temperature had a significant effect on total MUFAs in both lard and goose fat (mostly in non-additivated fat). Statistical analysis of the data showed that the addition of burdock extract at a concentration of 0.01% significantly (p < 0.01) reduced the installation of oxidation process in alimentary fats heated at different temperatures. Animal fats were well protected from oxidation by burdock extract, which demonstrated its efficacy as an antioxidant; it may be used to monitor the fats oxidation and to estimate their shelf-life stability.

Effects of Animal Diet and Processing Methods on the Quality Traits of Dry-Cured Ham Produced from Turopolje Pigs

The Turopolje pig (TP) is a local Croatian pig breed that almost became extinct in the second half of the 20th century. Today, the TP is still endangered, and a new conservation strategy based on products with higher added value is needed to preserve the breed. There is little information on the quality of TP meat products such as smoked and dry-cured ham, including the impact of natural feeds or processing innovations such as smoke reduction. This study, therefore, investigated the effects of the animal's diet (either conventionally fed or acorn-supplemented) and the processing method (standard or lightly smoked) on the quality traits of dry-cured TP ham. Twenty hams, evenly distributed among the treatments, were processed for 15 months and then analysed for physicochemical and textural traits, volatiles and sensory profile. The hams from acorn-supplemented pigs lost less weight during processing (p ≤ 0.05). Otherwise, the diet had no significant effect on most examined ham traits. The exceptions were protein content and the texture parameter hardness, which decreased (p ≤ 0.05), and the degree of proteolysis and colour parameters, which increased (p ≤ 0.05) as a result of acorn supplementation. However, these effects were generally small and varied between the inner (m. biceps femoris) and outer (m. semimembranosus) muscles. Furthermore, acorn supplementation was associated with less typical ham odour and lower sensory scores for sweetness and colour uniformity (p ≤ 0.05). The smoke reduction had no effect on the physicochemical and colour properties but resulted in a significant reduction (p ≤ 0.05) in the volatile phenolic compounds and an improved texture to the hams. This was reflected both in reduced (p ≤ 0.05) hardness, identified in the instrumental analysis, and in an increased (p ≤ 0.05) softness, solubility and moistness, identified in the sensory evaluation. To summarize, the quality of the TP ham under the conditions studied was only slightly affected by acorn supplementation, whereas reduced smoking had a more significant effect, which was mainly reflected in an improved texture.

Differences in Muscle Lipogenic Gene Expression, Carcass Traits and Fat Deposition among Three Iberian Pig Strains Finished in Two Different Feeding Systems

The Iberian pig breed includes several well-differentiated strains. The present study evaluated carcass traits, fat deposition and muscle expression of important lipogenic genes (SCD, ME1, ACACA, FASN, EGR1, ACOX and ACLY) using 65 male pigs of 3 Iberian strains (20 Lampiño, 23 Torbiscal, and 22 Retinto) finished either in a conventional, concentrate-based system (CF) or in montanera (MF), a traditional free-range system with acorn feeding. Torbiscal had the highest ham, Longissimus thoracis and prime cuts yields, and the thinnest subcutaneous adipose tissue (SAT). Retinto had the highest monounsaturated fatty acids (MUFA) and percentage of intramuscular fat (IMF), while Lampiño had the greatest content of saturated fatty acids (SFA), polyunsaturated fatty acids (PUFA), atherogenic (AI) and thrombogenic (TI) indexes in SAT. Conventionally finished pigs had the highest ham, L. thoracis and prime cuts yields, and SFA. Montanera-finished animals had the highest PUFA and MUFA contents, and the lowest AI, TI and n6/n3 ratio in SAT. In relation to gene expression, Retinto had the greatest SCD, FASN and ACLY levels. Most studied genes were overexpressed in CF pigs. In conclusion, MF pigs had healthier fat than CF pigs, and Retinto had the healthiest fat and the greatest lipogenic trend in muscle, supported by IMF and lipogenic gene expression.

Fattening Iberian Pigs Indoors vs. Outdoors: Production Performance and Market Value

The current Quality Standard regulating the Iberian pig provides for various differentiated farming systems subject to the type of management implemented and the breed of the pigs. This study attempts to analyse the differences between two of these production systems, i.e., the outdoor and the indoor rearing systems by comparing the main technical and economic factors of six farms, three operating under each system, in order to ascertain the most profitable production system. This analysis is based on the information provided by the farm owners. It also evaluates the impact that the COVID-19 pandemic outbreak had on profitability. The results show that both systems spend the same resources on animal feed, which represents nearly 60% of the expense, with the price of purchase of piglets representing 30-32% of the total; however, there are differences in the cost of labour, which is higher in the outdoor variant. In economic terms, outdoor farms obtained a higher gross margin than indoor farms did. Although their production costs are higher, these are offset with larger incomes due to the higher market price of the pigs at the time of slaughter. Lastly, all the farms under study reveal large financial losses on account of COVID-19, given that there was a general decrease in the revenues due to the decrease in the selling price of the pigs, which seems to be the most determinant factor for the economic profits made by these kinds of farms.

Antioxidant Properties and Proximate Composition of Different Tissues of European Beaver

The chemical composition, content of cholesterol, retinol and α-tocopherol, and the total antioxidant capacity of different tissues from wild beavers were investigated. The total phenolic contents and free radical scavenging activity (DPPH and ABTS assays) were analysed spectrophotometrically, and fat-soluble vitamins were quantified using high-performance liquid chromatography. The type of tissue (skeletal muscle from loin and hind leg vs. adipose tissue from subcutaneous fat and tail) significantly affected content of all chemical components. The concentration of cholesterol was not related to total fat content. The retinol and α-tocopherol contents (µg/100 g) were significantly higher in the tail (13.0 and 391.2) and subcutaneous fat (12.2 and 371.3) compared to skeletal muscles (as an average 9.1 and 361.4). Among all tissues the tail showed significantly the highest values of DPPH (3.07 mM TE/100 g), ABTS (3.33 mM TE/100 g), and total phenolics (TPC, 543.7 mg GAE/100 g). The concentration of retinol was positively correlated with α-tocopherol (0.748, p < 0.001), and both vitamins were very strongly correlated with DPPH (0.858 and 0.886, p < 0.001), ABTS (0.894 and 0.851, p < 0.001), and TPC (0.666 and 0.913, p < 0.001). The principal component analysis proved that moisture, ash, and protein contents were representative for skeletal muscles, whereas, retinol, α-tocopherol, ABTS and DPPH accurately described the antioxidant capacity of tissue from the tail.

Effect of High-Hydrostatic-Pressure Processing and Storage Temperature on Sliced Iberian Dry-Cured Sausage (“Salchichón”) from Pigs Reared in Montanera System

The top-quality “salchichón” (a fermented dry-cured sausage) is manufactured from Iberian pigs reared outdoors. This work aims to evaluate the effect of hydrostatic high pressure (HHP) and storage temperature on sliced vacuum-packaged top-quality Iberian “salchichón”. Two types of “salchichón” (S1 and S2, manufactured at different companies) were processed at 600 MPa for 8 min and stored at 4 and 20 °C for 180 days. Microbiological, physicochemical, and sensory changes were evaluated. Microbiological counts were reduced by HHP treatment and also generally decreased during storage at both temperatures. Lightness and redness of slices decreased during storage at 20 °C, while yellowness values increased. Changes in color were also observed in sensory analysis of the dry-cured sausages. HHP increased lipid and protein oxidation values in S1, whereas protein oxidation increased at 20 °C in S2. S1 was more affected by HHP while S2 was more affected by the temperature of storage. Therefore, despite both products belonging to the same commercial category, slight differences in the composition of both products and/or differences in packaging determined a different behavior after HHP treatment and during storage at different temperatures.

Qualitative Attributes of Commercial Pig Meat from an Italian Native Breed: The Nero d’Abruzzo

The main objective of this study was to characterize the main qualitative properties of commercial meat obtained from the Nero d’Abruzzo pig, a native breed of Central Italy. In order to valorize this animal production, a direct comparison was made with commercial meat products obtained from hybrid pigs. Over a period of 30 days, 76 steaks for each breed were purchased from the market, and samples were analyzed for total lipid content, fatty acids profile, Coenzyme Q10 content, resistance of meat to oxidative processes, volatile profile of cooked meat and electrophoretic profile of myofibrillar and sarcoplasmic proteins. Results showed the Nero d’Abruzzo to be richer in fat, which, however, is characterized by a higher concentration of α-linolenic acid, to which are attributed important health benefits. The native breed was also richer in Coenzyme Q10, a compound credited with antioxidant potential, whose presence could explain the better oxidative stability of meat samples that were cooked and stored for up to 7 days at +4 °C. In support of this last data, our finding of the characterization of the volatile profile of cooked meat, at the end of the storage period, showed in Nero d’Abruzzo a reduction in the accumulation of hexanal, notoriously associated with oxidative events and the development of unpleasant aromatic notes. In conclusion, aspects that can justify the nutritional superiority of this niche production compared to meat coming from cosmopolitan breeds have been identified.

Olive Leaf Extract (OLE) Addition as Tool to Reduce Nitrate and Nitrite in Ripened Sausages

Olive leaf extract (OLE) is known to be a source of phenolic compounds with antioxidant and antimicrobial activities. This study investigated the effects of the OLE addition to reduce nitrate/nitrite (NO) content on the physico-chemical features of ripened pork sausages. Seven formulations of pork sausages were set up: CTRL (0 mg/kg OLE; 300 mg/kg NO), Tr1 (200 mg/kg OLE; 150 mg/kg NO), Tr2 (400 mg/kg OLE; 150 mg/kg NO), Tr3 (800 mg/kg OLE; 150 mg/kg NO), Tr4 (200 mg/kg OLE; 0 mg/kg NO), Tr5 (400 mg/kg OLE; 0 mg/kg NO), and Tr6 (800 mg/kg OLE; 0 mg/kg NO). At the end of the ripening period, all the samples were within hygienic limits and the substitution of the additives with OLE allowed the reduction of NO residual contents. Both OLE and NO influenced the colour parameters. At the highest dose of OLE, both alone and in combination with reduced dose of NO, no significant differences in terms of moisture, pH, and aw were found compared to CTRL. In absence of NO, a significant reduction of weight loss was observed. Moreover, in the samples without NO a reduction of the hardness was detected. Finally, the oxidative stability test showed that the increase of the OLE amount prolonged the induction time.

Impact of Heat Stress on Meat Quality and Antioxidant Markers in Iberian Pigs

Heat stress is associated with impaired meat quality and disruption of redox balance. This study investigated the effect of chronic exposure to high temperature on meat quality and antioxidant markers of muscles (longissimus lumborum and gluteus medius) of growing Iberian pigs. Twenty-four pure Iberian pigs were allocated during 28 days to one of three treatments (n = 8/treatment): thermoneutral conditions (20 °C) and ad libitum feeding (TN), heat stress conditions (30 °C) and ad libitum feeding (HS) and thermoneutral and pair-fed with HS (TN-pf). Muscles of the HS group had greater intramuscular fat content than the TN-pf group and higher Zn levels than TN and TN-pf, whereas differences on fatty acid composition were negligible. Heat exposure did not affect pH, color coordinates of redness (a*) and yellowness (b*) and MDA values but had a positive influence on lightness and drip losses. Moreover, chronic heat stress stimulated the activity of antioxidant defenses SOD, CAT and GPx. The statistical factor analysis adequately classified the muscles studied, but was unable to differentiate samples according with treatments. Findings of the present study support an adaptive response of the Iberian pig to high temperatures and show the high Iberian meat quality even under adverse climate situations.

Review: Pork quality attributes from farm to fork. Part I. Carcass and fresh meat

This work considers all factors along the production chain from farm to fork influencing the quality of fresh pork and processed products. Pork quality is multidimensional and comprises various attributes: commercial value of carcasses, meat organoleptic, nutritional, technological (i.e. suitability for processing and storage) properties, convenience, and societal image. The latter denotes cultural, ethical (including animal welfare) and environmental dimensions related to pork production, including geographical origin, all of which influence societal perceptions for pork. This review covers the impact of production factors, slaughter methods, carcass processing, and post mortem ageing on fresh meat quality. The impact on pork quality from some of these factors are now well documented and clearly established (e.g. genetics and pork technological attributes; diet and lipid profile; preslaughter and slaughter conditions and pork technological or organoleptic attributes…). Gaps in scientific knowledge are also identified, including the need for a better understanding of regulatory pathways for oxidative stress in vivo and post mortem that can contribute to optimise pork organoleptic and nutritional attributes and its suitability for processing and storage. This review highlights the strong interactions between primary production factors on pork quality attributes. Interactions are particularly marked in alternative production systems, in which synergies between factors can lead to specific quality characteristics that can be used to market pork at a premium as branded products. There are also antagonisms between quality attributes, namely between carcass commercial value and pork technological and organoleptic properties, between nutritional attributes and processing and storage suitability of fat tissues, between societal image and pork technological attributes in outdoor production systems, and between societal image (better welfare) and organoleptic attributes (risk for boar taint) in entire male production. Further research is needed to better understand the effects of some specific production factors and their interactions on quality attributes. A holistic approach with the use of multicriteria analyses can help to work out the trade-offs between pork quality attributes and between stakeholders (farmer, slaughterhouse or processing plant, consumers, citizens …) whose priorities may differ.

Finishing season and feeding resources influence the quality of products from extensive-system Gascon pigs. Part 2: muscle traits and sensory quality of dry-cured ham

The quality of pork products from local breeds in extensive systems depends, among other things, on pig production. In particular, the variability in climatic conditions and feeding resources may influence the properties of tissues at slaughter and the quality of pork and processed products. The present study (part 2) was part of a larger project that assessed the influence of the finishing season and feeding resources on carcass and tissue traits and the quality of meat and dry-cured ham from Gascon pigs in an extensive system. Following the specifications of the Protected Designation of Origin "Noir de Bigorre", castrated Gascon males were reared on rangelands (grassland and forest areas) and received a supplementary diet from 5 to 6 months of age until slaughter at a minimum of 12 months and ca. 170 kg BW. Three finishing seasons were considered: Winter (n = 18), Spring (n = 22) and Autumn (n = 23). To estimate the specific effects of season on quality traits and avoid bias due to effects of genes known to influence these traits, polymorphisms in the RYR1, PRKAG3, MC4R and LEPR genes were included in the analysis models. Compared to Winter pigs, Spring and Autumn pigs had higher ultimate pH in the semimembranosus and gluteus medius (GM) muscles, lower meat lightness (P < 0.05) and tended to have higher GM intramuscular fat (IMF) content (P < 0.10). They also had higher GM contents of saturated, monounsaturated and polyunsaturated fatty acids (FAs) than Winter pigs (P < 0.05). Spring pigs had the lowest n-6:n-3 polyunsaturated FA ratio and the highest GM α-tocopherol content (P < 0.001), indicating pig grazing. The finishing season did not influence the processing yield of dry-cured hams (24-month process). Within each seasonal group, ten hams selected for genetic variability and IMF content were analyzed by a trained sensory panel. The season did not modify the appearance or odor, but influenced texture and taste. Hams from Winter and Spring pigs had higher tenderness and melting fat scores than hams from Autumn pigs (P < 0.01). Hams from Spring pigs had higher taste intensity and salty taste (P < 0.01) but lower positive tastes (e.g. fruits, forest) than hams from the other groups. Overall, finishing season had moderate effects on ham sensory traits. Furthermore, our results reveal high redness, tenderness, taste and odor intensity, and low rancid flavor of hams from Gascon pigs produced in an extensive system.

Quality Traits of Montanera Iberian Dry-Cured lomito as Affected by Pre-Cure Freezing Practice

The seasonality to which dry-cured products from Iberian breed pigs finished in Montanera (free-range rearing system with feed based exclusively on ad libitum consumption of natural resources; acorns and grass) are subjected could be overcome by pre-cure freezing. Three sets of Montanera Iberian presas (Serratus ventralis muscle)(n = 15) were established to assess the impact of frozen storage -0, or non-frozen, 3 and 6 months-previous to the technological process of curing-on the quality traits of the dry-cured product Montanera Iberian dry-cured lomito. Similar seasoning and curing processing conditions were applied to all sets. Lower productive performance due to higher weight loss during curing, and lower colour intensity were observed in pre-frozen dry-cured lomitos. The fatty acid profile was more saturated, and the oxidative status increased as a result of pre-cure freezing. On the matter of texture, all parameters were modified, highlighting the higher values of hardness and shear force of pre-frozen dry-cured lomitos. The time that raw material was frozen exerted a slight, thus helping manufacturers to better address the gap between industry and consumer demand with minimal effect on quality traits.

Measurement of Antioxidant Capacity of Meat and Meat Products: Methods and Applications

At present, a wide variety of analytical methods is available to measure antioxidant capacity. However, this great diversity is not reflected in the analysis of meat and meat products, as there are a limited number of studies on determining this parameter in this complex food matrix. Despite this, and due to the interest in antioxidants that prevent oxidation reactions, the identification of antioxidants in meat and meat products is of special importance to the meat industry. For this reason, this review compiled the main antioxidant capacity assays employed in meat and meat products, to date, describing their foundations, and showing both their advantages and limitations. This review also looked at the different applications of antioxidant properties in meat and meat products. In this sense, the suitability of using these methodologies has been demonstrated in different investigations related to these foods.

Do animal slaughter age and pre-cure freezing have a significant impact on the quality of Iberian dry-cured pork loin?

The influence of various animal slaughter age and of pre-cure freezing times on the quality traits of dry-cured loins from Iberian × Duroc (IBxD) crossbreed animals was assessed. Three animal batches (n = 15) were selected (IBxD8, IBxD10 and IBxD12) to be slaughtered at the age of 8, 10 and 12 months, respectively. Following slaughter, longissimus thoracis et lumborum muscles were extracted and submitted to curing (T0) or freezing storage during three (T3) or six (T6) months prior to curing. The dry-cured loins from IBxD12 yielded lower intramuscular fat and lightness, a less saturated fatty acid profile and the highest hardness and shear force (P ≤ 0.05). The pre-cure freezing process increased weight loss, saturated fatty acids, lipid oxidation, and most of the textural parameters (P ≤ 0.05). So, both slaughter age and pre-cure freezing should be taken into account in order to obtain quality and productive performance.

Effect of high-pressure treatment and storage temperature on top-quality (Montanera) Iberian dry-cured pork sausages (chorizo)

The stability after hydrostatic high pressure (HHP) (600 MPa/8 min/10 °C) and 180 days of storage at 4 and 20 °C was evaluated on Iberian dry-cured pork sausages (chorizo) packaged sliced or as half-pieces from pigs raised outdoors. Microbiological, physical-chemical, oxidative, and sensory changes were analyzed. The evolution of mesophilic aerobic and molds and yeasts counts was different in the half and sliced packaged pork sausages after processing and during storage. Sliced and half-packaged pork sausages had instrumental color stability after HHP and during storage. TBA-RS values were quite stable in both products. Protein oxidation values of pork sausage in half-products were increased by at 20 °C. In sliced pork sausage, both HPP and 20 °C storage favored the development of protein oxidation at the end of storage. In the sensory analysis, the sliced product developed more rancidity than the half-pieces during the storage. Therefore, the storage temperature has great importance for the preservation of dry-cured pork sausages, the increases of protein oxidation, and rancidity could reduce the shelf-life at these conditions. The presentation of the product is also relevant when HHP is applied, and this would also compromise the stability of the product when it is stored at room temperature. PRACTICAL APPLICATION: Chorizo is a traditional dry-fermented pork sausage that is generally considered to be microbiologically safe. However, the initial contamination of the raw materials, and some processes, such as the slicing or packaging, can compromise the safety of these products. Additionally, packaged dry-cured sausages require long shelf-life, and although they are normally stored at refrigeration temperature; sometimes, they are preserved at room temperature. The application of hydrostatic high pressure could increase the safety of dry-cured meat products even when they are stored at room temperature. Initial characteristics of each type of pork sausage could determine their technological behavior during processing or during storage under different conditions.

Near infrared spectroscopy (NIRS) as tool for classification into official commercial categories and shelf-life storage times of pre-sliced modified atmosphere packaged Iberian dry-cured loin

The potential of Near Infrared Spectroscopy combining different spectral treatments and classification models was assessed for the classification of individual pre-sliced Iberian dry-cured loin packaged under modified atmosphere packaging (MAP) into three official commercial categories (which involve the breed purity and production system) according to the current Iberian Quality Standard (Black, Red and White) and for the assignment to the shelf-life time (0, 4, 8 and 12 months). External validation results provided acceptable results, with up to 100% of samples correctly assigned to Black and White official commercial category and into all storage times. Actually the 100% assignments were obtained using more than one approach (SIMCA and LDA for commercial categories and PLS-DA, SIMCA and LDA for storage times). These results might contribute to support the on-line control of authenticity of official commercial category and to facilitate the monitoring of the quality of pre-package dry-cured products throughout the shelf-life prediction.

Effect of Breed Purity and Rearing Systems on the Stability of Sliced Iberian Dry-Cured Ham Stored in Modified Atmosphere and Vacuum Packaging

The long-term storage stability of three quality categories of sliced Iberian dry-cured ham defined by the Spanish Iberian Quality Standard (Black, purebred Iberian reared outdoors in Montanera system; Red, Iberian × Duroc crossed (50%) pigs reared outdoors in Montanera system;, and White, Iberian × Duroc crossed (50%) pigs commercially fed) and packaged under vacuum and modified atmosphere packaging (MAP) was studied. Commercial category affected the shelf life, being Black and Red presented the highest lipid oxidation during storage, whereas the effect of packaging was not as clear as the effect of commercial category. MAP preserved more the colour and the antioxidants content than vacuum packaging, while this latter reduced lipid oxidation development and maintained better the brightness and flavour of slices than MAP.

The Quality and Health-Promoting Value of Meat from Pigs of the Native Breed as the Effect of Extensive Feeding with Acorns

Simple Summary

Modern society is paying more attention to the quality of meat and its production system. Therefore, in this study, we analyzed the possibility of using a native pig breed—Złotnicka Spotted. This breed’s popularity has increased in Poland as it may be a good source of valuable meat. Compared to the meat frompigs of the same breed following intensive fattening, the meat from free-range pigs extensively fed on silage and small amounts of acorns is characterized by a higher content of fat, which acts as a carrier for flavor and, indirectly, juiciness. Moreover, rearing systems with traditional feeding, e.g., with the use of acorns, may have a positive effect on meat quality, dietetic value, and, therefore, consumer acceptance of the product.

Abstract

The popularity of meat from animals of native breeds is growing all over the world, due to consumer belief regarding its higher quality compared to meat from industrial farm animals. In addition, the living conditions (welfare) are of great importance for consumers. We observed the effect of different ways of keeping and feeding pigs of the same conservative breed on the quality of meat and its health benefits. The aim of the study was to compare the meat quality from pigs of the native Złotnicka Spotted breed, fattened intensively or extensively (with conventional farm-produced compound feed and acorns). The meat from free-range pigs extensively fed on silage and small amounts of acorns was characterized by a higher content of fat, which acts as a carrier for flavor and juiciness, as well as higher monounsaturated fatty acid (MUFA) content (p ≤ 0.05) and lower atherogenic, thrombogenic, and peroxidability indices (p ≤ 0.05). It may be stated that the meat quality of the native pig breed is significantly dependent on the housing and feeding method. A more beneficial effect on the quality of meat and its dietetic value, as well as its susceptibility to rancidity, can be obtained throughextensive pig feeding with roughage and the addition of acorns.

Physico-chemical and sensory characterization of sliced Iberian chorizo from raw material of three commercial categories and stability during refrigerated storage packaged under vacuum and modified atmospheres

Physico-chemical and sensory analysis of Iberian chorizo manufactured from three commercial categories raw material compiled in the current Spanish Iberian Quality standard (Black, Red; 100% Iberian and 50% Iberian × Duroc pigs, respectively, under Montanera, and White; 50% Iberian × Duroc pigs commercially fed) and packed under vacuum and modified atmosphere (MAP) were carried out, in order to address the influence of the genotype and animal production system and packaging on quality parameters, as well as the stability of these throughout long-term storage. Montanera categories showed higher values of γ-tocopherol, mono- and poly-unsaturated fatty acids, greater scores of flavour and taste and higher lipid oxidation during the whole storage. MAP preserved better colour, especially redness and lipid oxidative status. Iberian chorizo could attain a differentiated quality because of physico-chemical and sensorial characteristics derived from the Montanera that would be adequate preserved in both vacuum and MAP throughout long-term storage.

Total Phenol Content and Antioxidant Activity of Different Celta Pig Carcass Locations as Affected by the Finishing Diet (Chestnuts or Commercial Feed)

The objective of this research was to evaluate the total phenol content, total flavonoids, and antioxidant activity of chestnuts (Castanea sativa Mill.) and commercial feed employed in the finishing diet of the Celta pig breed and analyze the effect of the feeding (chestnuts vs. commercial feed) in the finishing diet on total phenol content and antioxidant activity of Longissimus thoracis et lumborum, Psoas major, and Biceps femoris muscles and liver of the Celta pig breed. The antioxidant activity of the feed and animal tissue was investigated using three antioxidant methods (2,2-Diphenyl-1-picrylhydrazyl (DPPH) radical scavenging activity, 2-2'-Azino-di-[3-ethylbenzthiazoline sulfonate] (ABTS) radical scavenging activity, and ferric reducing antioxidant power (FRAP) assay). The determination of the total phenol content and total flavonoids showed that chestnut had a significantly lower concentration than commercial feed in these compounds (130.00 vs. 312.89 mg gallic acid equivalents/100 g fresh weight and 8.58 vs. 32.18 mg catechin equivalents/100 g fresh weight, respectively). However, the results displayed that chestnuts had a higher antioxidant activity when compared with the commercial feed through the DPPH and ABTS methods (1152.42 vs. 957.33 µg Trolox equivalents/g fresh weight, and 9379.74 vs. 7613.44 µg Trolox equivalents/g fresh weight, for DPPH and ABTS assay, respectively), while the antioxidant activity measured by the FRAP assay turned out to show higher values for commercial feed (1777.49 and 1946.09 µmol Fe2+/100 fresh weight for chestnut and commercial feed, respectively), although significant differences were only found in the ABTS assay. On the other hand, the present study found that chestnut significantly reduces the total phenol content and declines the antioxidant activity of Longissimus thoracis et lumborum, Psoas major, and Biceps femoris muscles and liver of the Celta pig breed. Finally, it has been found that liver is the location that has the best antioxidant characteristics compared to any muscle, regardless of diet utilized.

Variability in subcutaneous fat composition of Iberian pigs reared in free-range conditions in the southwest of the Iberian Peninsula

A total of 80 free-range Iberian pigs reared with acorns and grass in eight different free-range systems (n = 10) in the southwest of the Iberian Peninsula were used to determine the relationship between fatty acid, tocopherol, and neophytadiene subcutaneous fat composition. The pigs were fed extensively for 79.1 ± 9.5 d from 110.9 ± 11.9 kg live weight at the beginning of the final fattening phase to 175.0 ± 15.9 kg slaughtered weight. Quercus suber and Quercus rotundifolia acorns were characterised by a high content of C18:1n-9 (58.3 and 63.1%, respectively) and γ-tocopherol [43.7 and 43.0 mg kg−1 dry matter (DM), respectively], while grass exhibited a high content of C18:3n-3 (42.5%), α-tocopherol (366.5 mg kg−1 DM) and neophytadiene (136.2 relative area units). The C18:1n-9 (54.4%–57.7%) and γ-tocopherol (2.7–4.1 mg kg−1 DM) contents in subcutaneous fat from Iberian pigs differed (p < 0.001) between the free-range systems studied. Pasture intake had a significant effect (p < 0.01) on subcutaneous fat content of C18:3n-3 (0.5%–0.8%), α-tocopherol (7.8–13.1 mg kg−1 DM) and neophytadiene (2.6–6.3 relative area units). However, the results demonstrated no correlations between accumulated levels of these compounds throughout the free-range period. In conclusion, the absence of correlations corroborated the heterogeneity of extensive rearing systems, with variations between years and geographical areas where the Iberian pigs were reared.

Consumption of fresh Iberian pork: Two-stage cluster for the identification of segments of consumers according to their habits and lifestyles

This study investigates the behaviour of consumers regarding four cuts of Iberian meat with greater presence in the market: tenderloin, secreto, presa and pluma. A sample of 1501 consumers responded to an online survey about their consumption habits for these four cuts, sociodemographic characteristics and lifestyle. From this information, three homogeneous segments of consumers were identified: "unmotivated and indifferent to Iberian meat", "innovators and stakeholders" and "traditional with frequent consumption". The Iberian tenderloin and the secreto were the most consumed cuts in all consumption segments, while the main reason for the lower consumption of presa and pluma was "I don't like it", especially among "unmotivated" consumers.

Effect of Two Organic Production Strategies and Ageing Time on Textural Characteristics of Beef from the Retinta Breed

The primary aim of this paper is to determine the influence of two organic production systems, organic grass-fed (OG) and organic concentrate-fed (OC), vs. a conventional concentrate-fed (CC) system; the second aim is to determine the influence of the ageing period on the physical parameters and texture properties of beef from the Retinta breed. Muscle samples from Longissimus thoracis were stored at 2-4 ± 1 °C for 0, 7, 14, and 21 days for the purposes of ageing. Analyses of pH, water losses (drip loss and cooking loss), Warner-Bratzler shear force, texture profile analysis (TPA), and histological analysis of muscle fibre were carried out. The results revealed that organic meat experienced lower drip loss and higher cooking loss than conventional meat. Although the meat of organic grass-fed animals was tougher initially, it showed a higher tenderisation speed in the first ageing days than OC and CC meats. The sarcomere length increased during the ageing period, which showed a negative correlation to shear force. According to its texture characteristics, the Retinta meat produced in organic systems could be recommended by its quality.

Views of Farmers and Industrial Entrepreneurs on The Iberian Pig Quality Standard: An In-Depth Interview Research Study

Simple Summary

This paper aims to assess the main opinions of farmers and industrial entrepreneurs on the implementation of the current Spanish Iberian Pig Quality Standards regulation as well as on the processing technologies of Iberian cured products. The study is based on a qualitative research process through in-depth interviews, and has allowed the identification of aspects that can be improved both at the level of the Iberian meat industry and in the administrative processes in the view of the main actors of the Iberian pork sector in Spain. The aspects of the Quality Standard related to the protection of the base of the Iberian breed, the conditions of production in the traditional system (the montanera), as well as the ripening time of the products were mostly supported by the farmers and industrial entrepreneurs. However, they showed certain inconformity with the requirements established by the Quality Standard for other production systems such as the non-free-range fodder-fed and free-range fodder-fed, therefore they demanded changes in these aspects.

Abstract

Since 2014, the Quality Standard for Iberian meat, leg ham, shoulder ham and dry-cured loin has regulated production factors and processes involved in the raw material and manufactured products from Iberian pigs, the most important pig breed in both population size and economic importance of the southwest Iberian Peninsula. Regarding the changes to the Quality Standard that industrial entrepreneurs and farmers are currently demanding, a qualitative research study has been developed through 14 in-depth interviews with the purpose of understanding the perception of Iberian pig farmers and industrial entrepreneurs of the requirements of the currently-effective Quality Standard, as well as the conditions under which this is being applied. The results showed a consensus amongst the majority of the participants in aspects such as the maintenance of the breed base as 100% Iberian for reproductive females, weight and age requirements at the time of slaughter for the montanera category and the manufacturing lengths for dry-cured products. On the other hand, there were discrepancies between the requirements defined by the Quality Standard and those requested by the respondents for the non-free-range fodder-fed and free-range fodder-fed categories, with the industrial entrepreneurs and farmers being inclined towards the reduction in the age of slaughter of the former and the distinction in the production conditions of the latter.

Effect of Fattening Period Length on Intramuscular and Subcutaneous Fatty Acid Profiles in Iberian Pigs Finished in the Montanera Sustainable System

Twenty-four extensively reared Iberian pigs were used to study the influence of fattening period length (30, 60 or 90 days) on the fatty acid profiles of intramuscular and subcutaneous fat and the relationships between both profiles. Regarding fatty acid (FA) percentage, PUFA was greater in backfat and MUFA was greater in intramuscular fat (IMF), regardless of fattening period length. The longer fattening period increased MUFA content in backfat (which had a more marked change in oleic acid) and decreased PUFA content in backfat and IMF, but it did not affect SFA content. Within the three-layer subcutaneous backfat, SFA content was greater in the inner layer, MUFA was greater in the outer layer and PUFA was greater in both of these layers. The few differences in FA composition between both adipose tissues suggest that the changes due to the feeding regime are slow and, therefore, although the length of the fattening phase was increased, the fatty acid profile did not change substantially. The strong relationship between the FA profiles of IMF and backfat might be used to predict one profile from the other one when the latter is more readily available for sampling or analytical reasons.

Understanding consumers' perceptions towards Iberian pig production and animal welfare

The Spanish market offers a greater variety of Iberian pork products. The aim of this paper is to determine the perception of consumers of several aspects of Iberian pig production and animal welfare depending on the consumers' characteristics. Consumers from two Spanish regions (n = 403) answered a questionnaire about their beliefs and the importance of pig production, their purchase intentions and their willingness to pay. Consumers were segmented according to their level of knowledge about Iberian pig production. The results of this work indicate that consumers have poor knowledge about Iberian pig production. Even so, consumers show a remarkable preference for Iberian products, especially when the animals are reared freely and in natural conditions, giving great importance to animal welfare. Consumer preferences indicate the importance of emphasizing Iberian traditional pig product characteristics on the label to promote their purchase choices.

Potential Use of Near-Infrared Spectroscopy to Predict Fatty Acid Profile of Meat from Different European Autochthonous Pig Breeds

Autochthonous pig breeds provide products of differentiated quality, among which quality control is difficult to perform and insufficient for current market requirements. The present research evaluates the predictive ability of near-infrared (NIR) spectroscopy, combined with chemometric methods as a rapid and affordable tool to assure traceability and quality control. Thus, NIR technology was assessed for intact and minced muscle Longissimus thoracis et lumborum samples collected from 12 European autochthonous pig breeds for the quantification of lipid content and fatty acid composition. Different tests were performed using different numbers of samples for calibration and validation. The best predictive ability was found using minced presentation and set with 80% of the samples for the calibration and the remaining 20% for the external validation test for the following traits: lipid content and saturated and polyunsaturated fatty acids, which attained both the highest determination coefficients (0.89, 0.61, and 0.65, respectively) and the lowest root mean square errors in external validation (0.62, 1.82, and 1.36, respectively). Lower predictive ability was observed for intact muscles. These results could contribute to improve the management of autochthonous breeds and to ensure quality of their products by traditional meat industry chains.

Quality traits of fresh and dry-cured loin from Iberian x Duroc crossbred pig in the Montanera system according to slaughtering age

Iberian x Duroc cross grower pigs of similar weight, but 12, 10 and 8 months of age, were finished using the Montanera system to study effects on fresh and dry cured loin quality. Pigs were slaughtered simultaneously at 16, 14 and 12 months of age (IBxD16, IBxD14 and IBxD12) and longissimus thoracis et lumborum were removed and processed into dry-cured loin. Fresh and dry cured loins from the oldest animals (IBxD16) had higher tocopherols, C18:2 n-6 and PUFA as well as higher insoluble collagen, which led to greater hardness. Fresh loin from the youngest animals (IBxD12) had the lowest myoglobin content, redness (a*), chroma and hue angle. No differences in proximate composition or instrumental colour were found in dry-cured loins.

Effect of Free-Range and Low-Protein Concentrated Diets on Growth Performance, Carcass Traits, and Meat Composition of Iberian Pig

Simple Summary

It is generally assumed in the Iberian pig sector that substitution of traditional free-range rearing, with acorns and grass, by mixed diets affects intramuscular fat content and fatty-acid composition, among others, causing a decrease in meat quality. As mixed diets are usually formulated with higher protein contents than those supplied by natural resources consumed by Iberian pig fed extensively, we hypothesized that the use of a low-protein diet in the final fattening period of pig could be a suitable strategy to improve meat and dry-cured product quality. However, it is also necessary to evaluate the effect of this strategy on performance and carcass traits of pigs. In this study, we found that Iberian pigs fed on low-protein diets had higher intramuscular fat content and different meat composition compared to pigs fed on concentrates with standard protein levels, which could be a suitable way of improving the Iberian pig meat and dry-cured product quality.

Abstract

The feeding system is one of the main factors influencing the Iberian pig meat quality. This experiment was undertaken to evaluate the influence of feeding diets containing different levels of protein on performance, carcass, and meat quality of Iberian pigs. To that aim, 24 castrated male Retinto Iberian pigs with an average weight of 116 kg were fed under free-range conditions with acorns and grass (FR), and on concentrated diets in confinement with standard (SP) and low protein content (LP). The crude protein content in acorns was lower than that in the grass and SP diet, but similar to that in the LP diet. FR pigs needed more time to achieve slaughter weight than LP and SP pigs. Iberian pigs fed on low-protein diet (FR and LP) had a higher intramuscular fat content in the musculus serratus ventralis than SP pigs. The influence of diet on the fatty-acid composition was reflected more markedly in subcutaneous fat than in muscles. FR pigs showed a higher level of C18:1 n-9 and total polyunsaturated fatty acids and lower total saturated fatty acids in subcutaneous fat than LP and SP. It is concluded that diets with low protein levels do not affect Iberian pig productive traits but change the meat composition, rendering them an interesting strategy to improve the quality of Iberian pig meat and dry-cured products.

Is production system a relevant attribute in consumers' food preferences? The case of Iberian dry-cured ham in Spain

Spanish consumers have a strong preference for Iberian meat products, as they perceive them to be of extra sensorial and nutritional quality. The production of these meat products depends on multiple variables, such as genetics, livestock production systems and, above all, the feed provided. The aim of this paper is to study the preferences of Spanish consumers for the various types of Iberian dry-cured ham, analysing whether they are willing to pay the premium required by the highest-quality products. The methodological approach combined a sensory analysis and a choice-based conjoint experiment with obtained through tasting sessions in Extremadura (SW of Spain). Findings of the sensory test have shown that there are significant differences in odour, texture and taste, explained mainly by the type of feed pigs were fed. The main results of the choice experiment have also shown that the type of feed is the most preferred attribute by consumers, in line with the sensory analysis.

Comparison of antioxidant compounds in pig meat from Italian autochthonous pig Suino Nero Lucano and a modern crossbred pig before and after cooking

This study aimed to evaluate and compare the antioxidant compounds of raw and cooked Longissimus lumborum muscles from Suino Nero Lucano (SNL) and a modern crossbred (CG) pig. Vitamin E, phenols, histidine-containing peptides, and superoxide dismutase (SOD) activity have been detected in the raw and cooked meat of both genetic types. Cooking process decreased the content of all considered antioxidant compounds (P < 0.05). The antioxidant compounds of meat were significantly influenced by genetic type (P < 0.001). Autochthonous SNL raw and cooked meat showed a higher endogenous antioxidants content (P < 0.001) and SOD activity (P < 0.02) compared to CG meat. The results of this research highlighted that the pig meat, in particular autochthonous pig meat, showed good concentrations of endogenous antioxidant compounds that could confer functional properties to the product.

Differences on meat colour and composition between ‘Landrace × Large White’ and ‘Iberian’ pigs under identical nutritional and management conditions

In pig production, factors such as nutritional system and genotype affect quality characteristics of meat. This study was aimed to evaluate differences in nutritional composition and colour of meat between Iberian (IB) and Landrace × Large White (LLW) pigs reared under identical nutrition and management conditions. Nutrient composition, mineral content, fatty acid profile and instrumental colour of two muscles (longissimus thoracis and biceps femoris) were examined at two growing stages (50- and 115-kg weight). Significant differences were found in relation to genotype. IB muscles contained higher amounts of intramuscular fat, dry matter, monounsaturated fatty acids, iron and zinc, and were redder (higher a* value) and with less colour saturation (lower hue angle), than those from LLW pigs. Significant relationships between colour coordinates with the mineral content and the lipid profile of muscles were found: redness was mainly linked to iron, zinc and monounsaturated fatty acids levels, whereas yellowness was positively related with copper, polyunsaturated fatty acids and linoleic acid level. The results of the present study support that muscles from the IB pig genotype have special characteristics, which may enhance the overall quality of meat compared with conventional or high-lean porcine breeds, even under identical management system, due to its particular fat composition and colour attributes.

Fatty acids composition, cholesterol and vitamin E contents of Longissimus dorsi and Semitendinosus muscles of Suino Nero Lucano pigs slaughtered at two different weights

The nutritional quality of the lipid fraction of two muscles (Longissimus dorsi and Semitendinous) from Italian autochthonous genotype Suino Nero Lucano pigs slaughtered at two different weights was evaluated. Meat of Suino Nero Lucano pig showed a relatively low content of cholesterol and a higher proportion of unsaturated (UFA) than saturated fatty acids (SFA). Total cholesterol content was influenced by muscle, being higher in Longissimus dorsi (LD) than in Semitendinous (ST) muscle. No significant effects related to slaughter weight or muscle were found regarding vitamin E content. Slaughter weight strongly influenced n-3 and n-6 polyunsaturated fatty acids (PUFA) contents that decreased with increasing weight, and consequently, PUFA/SFA ratio. Muscle markedly influenced the contents of SFA, monounsaturated fatty acids (MUFA), and PUFA, and the dietetic properties of the meat. ST muscle, compared with the LD muscle, showed higher PUFA/SFA and PUFA n-6/PUFA n-3 ratios, and lower atherogenic and thrombogenic indices.

Effect of muscle type and frozen storage on the quality parameters of Iberian restructured meat preparations

The main objective of this study was to evaluate the effect of muscle type and frozen storage on the quality of restructured meat preparations from undervalued Iberian muscle to make use of meat from a high-quality and natural pig production system. The effect of two muscle types (i.e. white-glycolytic (W) and red-oxidative (R)) and frozen storage (lasting 0, 30, 60 and 90 days) on quality characteristics were assessed. Significant differences were found between the W and R Iberian restructured preparations in most physicochemical and some colour, texture and sensory traits, and in the fatty acid profile and oxidative measurements, suggesting that the R muscles are more suitable; however, the microbial contamination should be reduced. Frozen storage reduced but did not eliminate the initial microbial contamination, and it enhanced some quality traits in the Iberian restructured preparations, i.e. increased a* values, cohesiveness and juiciness and decreased adhesiveness and pastiness, without negatively affecting any parameter. Thus, frozen Iberian restructured preparations are recommended to be commercialized. In addition, the implementation or revision of Hazard Analysis and Critical Control Point is recommended to reduce microbial contamination.