A full scale worm reactor for efficient sludge reduction by predation in a wastewater treatment plant

Effects of sludge retention time on sludge reduction by ultrasound treatment: Sludge characteristics, microbial community, and metabolism

Both ultrasound and sludge retention time (SRT) enable the in-situ sludge reduction during wastewater treatment, but the influence of SRT on ultrasonic lysis - cryptic growth is unclear. This paper researched the influence of different SRTs on sludge lysis - cryptic growth using a sequential bio-reactor (SBR), then explained in details the changes of microorganisms in the SBR. The best SRT for sludge reduction was 30 d, and 47.29% reduction in sludge was achieved. The different SRTs changed the organic matter removal in the wastewater, and the removal rate decreased when SRT exceeded 60 d. The size of the sludge particles varied depending on the SRT, with the smallest size at SRT of 10d being 45.6 μm and the largest size at SRT of 90d being 110.0 μm. SEM showed that the sludge surface changed rough at longer SRT. FTIR and XPS showed notable effect in sludge functional group strength at SRT of 30 d. Extracellular polymeric substance (EPS) reduced the most at SRT of 30 d. The microbial communities of sludge varied with the SRT, and the unique main genus at SRT of 5, 15, 30 and 90 d were C10-SB1A, Lactococcus, Propioniciclava, Lactococcus, respectively. Furthermore, the SRT changed relative abundance of enzymes concerned with metabolism of carbon, nitrogen, and phosphorus. Similarly, SRT changed the metabolic rate, and the metabolic rate of carbon, nitrogen and phosphorus was best at SRT of 30 d.

Effects of benthic bioturbation on anammox in nitrogen removal at the sediment-water interface in eutrophic surface waters

Anaerobic ammonium oxidation (anammox) significantly contributes to nitrogen loss in freshwater ecosystems. The sediment-water interface (SWI), known as a "hot spot" for anammox, also harbors numerous macroinvertebrates. However, the impact of their bioturbation on anammox has generally been overlooked. This study compared the effects of three representative macroinvertebrates (i.e., Propsilocerus akamusi, Branchiura sowerbyi and Radix swinhoei) with different bioturbation modes on anammox and the N-removal processes at the SWI by using a microcosmic system. The results demonstrated that all three benthic macroinvertebrates promoted anammox in addition to denitrification processes. The highest N-removal was achieved in the presence of P. akamusi considered as a gallery-diffuser, where the relative abundance of Planctomycetes (to which the anammox bacteria belong) increased by 70%. P. akamusi increased the abundance of anammox hzsB gene by 2.58-fold and promoted potential anammox rate by 12.79 nmol N g-1 h-1, which in turn facilitated total N-removal mass increased by 2.42-fold. In the presence of B. sowerbyi and R. swinhoei, the potential anammox rates increased by 4.81 and 5.57 nmol N g-1 h-1, respectively. These results underscore the substantial impact of macroinvertebrates on anammox and N-removal processes, highlighting their crucial role in N pollution control, and sustaining the overall health and stability of eutrophic water bodies.

Interaction between Cr(VI) and Tubificidae in sludge reduction system: effect, reduction, and redistribution of Cr(VI)

The treatment of heavy metals in sewage treatment systems has gained more attention with the increase in heavy metal hazards. Tubificidae in sludge reduction have been widely studied; however, little is known about the effect of Tubificidae in the treatment of Cr-containing wastewater. In this study, the mechanism of Tubificidae in the sludge reduction system with Cr stress was studied. Predation experiments by Tubificidae in a Cr-containing sludge reduction system were conducted to investigate the changes in enzyme activities in the Tubificidae under different concentrations of Cr, and the distribution of Cr in the sludge reduction reactor was analyzed. The kinetic model of uptake and elimination of Cr in Tubificidae was established. The results showed that the maximum activation multiplier factor of superoxide dismutase (SOD) activity was 1.95 under the low concentration of Cr(VI), which indicated that Tubificidae had a certain detoxification. After the effect of Tubificidae on Cr(VI) experiments, the Cr concentrations in Tubificidae, sludge, and feces increased first and then decreased with exposure time, and the proportion of total Cr and Cr(VI) in the sludge decreased from 71.98% and 42.7% to 29.18% and 6.82%, respectively. The detoxification mechanism of the Tubificidae could be activated with Cr stress, and 63.22% of the Cr(VI) was converted to Cr(III). The bioconcentration factor (BCF) for theoretical equilibrium was 446, the maximum bioaccumulation factor (BAF) reached 0.97 on the 15th day. It can be seen that Tubificidae could be considered a good scavenger of environmental Cr(VI). The hyperbolic model fits the process of Cr uptake and elimination well and can be used as a predictive tool for Tubificidae accumulation.

New insights into mycelial pellets for aerobic sludge granulation in membrane bioreactor: Bio-functional interactions among metazoans, microbial communities and protein expression

Direct cultivation of aerobic granular sludge (AGS) in membrane bioreactor (MBR) has gained increasing attention. Mycelial pellets (MPs) has been shown capable of promoting rapid granulation of aerobic sludge in MBR, yet mechanisms remain unclear and in-depth insight into cross-scale interactions between MPs and indigenous microbiota as well as the corresponding protein expression functions is necessary. Herein, we found that the addition of MPs in MBR resulted in massive growth of metazoans with 40-400 /mL for rotifers, 20-140 /mL for nematodes and 2-420 /mL for oligochaetes in the initial phase of granulation. This facilitated the MPs to rapidly aggregate with bacteria to form defensive granules for physical protection from predation by metazoans, which inhibited the overgrowth of filamentous bacteria Thiothrix and promoted the reproduction of functional bacteria related to nitrogen removal (Nitrospira, Trichococcus and Acinetobacter). Proteomic analysis demonstrated that the upregulation of functional proteins was mainly ascribed to the decrease of Thiothrix and the increase of Nitrospira, resulting in the enhancement of metabolic pathways involved in glycolysis/gluconeogenesis, citrate (TCA) cycle, oxidative phosphorylation, pyruvate metabolism, nitrogen metabolism and biosynthesis of amino acids, which was responsible for MPs-induced AGS with denser structure, more abundant proteins and β-polysaccharides, higher species diversity, significant nitrogen removal (33.12-42.33%) and lower membrane fouling potential. This study provided a novel and comprehensive insight into the enhanced granulation of aerobic sludge by MPs and the functional superiority of MPs-induced AGS in MBR system.

Wastewater treatment plant contaminant profiles affect macroinvertebrate sludge degradation

Disposal of the overwhelming amounts of excess wastewater treatment plant (WWTP) sludge is an increasing financial and environmental problem, and new methods to reduce the amount of excess sludge are therefore required. In the natural environment, interactions between multiple macroinvertebrate detritivores mediate the degradation of organic matter. Macroinvertebrates may thus also be able to degrade WWTP sludge, but may meanwhile be impacted by the associated contaminants. Therefore, the aim of the present study was to examine if WWTPs contaminant concentrations and profiles affect the biotic interactions and macroinvertebrate mediated degradation of sludge. Assessing degradation of sludge from three WWTPs differing in contaminant profile by (combinations of) three macroinvertebrate detritovore taxa, revealed that macroinvertebrate enhanced sludge degradation was WWTP and taxa combination specific. Yet, taxa combinations only had an additional positive effect on sludge degradation when compared to single taxa in sludge with a higher contaminant load. This was confirmed by the results of a Cu-spiked sludge degradation experiment, indicating a possible effect of biotic interactions. It was concluded that macroinvertebrates are a potential tool for the reduction of excess WWTP sludge, and that using multispecies assemblages of detritivorous macroinvertebrates may increase the resilience of this additional treatment step.

Feasibility of isolated novel facultative quorum quenching consortiums for fouling control in an AnMBR

Anaerobic membrane bioreactor (AnMBR) technology is being recognized as an appealing strategy for wastewater treatment, however, severity of membrane fouling inhibits its widespread implementations. This study engineered novel facultative quorum quenching consortiums (FQQs) coping with membrane fouling in AnMBRs with preliminary analysis for their quorum quenching (QQ) performances. Herein, Acyl-homoserine lactones (AHLs)-based quorum sensing (QS) in a lab-scale AnMBR initially revealed that N-Hexanoyl-dl-homoserine lactone (C6-HSL), N-Octanoyl-dl-homoserine lactone (C8-HSL) and N-Decanoyl-dl-homoserine lactone (C10-HSL) were the dominant AHLs in AnMBRs in this study. Three FQQs, namely, FQQ-C6, FQQ-C8 and FQQ-C10, were harvested after anaerobic screening of aerobic QQ consortiums (AeQQs) which were isolated by enrichment culture, aiming to degrade C6-HSL, C8-HSL and C10-HSL, respectively. Growth of FQQ-C6 and FQQ-C10 using AHLs as carbon source under anaerobic condition was significantly faster than those using acetate, congruously suggesting that their QQ performance will not be compromised in AnMBRs. All FQQs degraded a wide range of AHLs pinpointing their extensive QQ ability. FQQ-C6, FQQ-C8 and FQQ-C10 remarkably alleviated extracellular polymeric substances (EPS) production in a lab-scale AnMBR by 72.46%, 35.89% and 65.88%, respectively, and FQQ-C6 retarded membrane fouling of the AnMBR by 2 times. Bioinformatics analysis indicated that there was a major shift in dominant species from AeQQs to FQQs where Comamonas sp., Klebsiella sp., Stenotrophomonas sp. and Ochrobactrum sp. survived after anaerobic screening and were the majority in FQQs. High growth rate utilizing AHLs under anaerobic condition and enormous EPS retardation efficiency in FQQ-C6 and FQQ-C10 could be attributed to Comamonas sp.. These findings demonstrated that FQQs could be leveraged for QQ under anaerobic systems. We believe that this was the first work proposing a bacterial pool of facultative QQ candidates holding biotechnological promises for membrane fouling control in AnMBRs.

Sludge reduction based on microbial metabolism for sustainable wastewater treatment

Sludge reduction via microbial metabolism does not require extra energy and resource inputs and thus merits attention as an alternative approach for sustainable wastewater treatment. This review presents a summary and analysis of the existing literatures on sludge reduction based on microbial metabolism, as well as interprets these sludge reduction mechanisms using bacterial thermodynamics and stoichiometry. Future efforts should be directed toward using advanced analytical techniques to further reveal sludge reduction mechanisms. The feasibility of coupling sludge reduction and nutrient removal by microorganism metabolism needs to be further evaluated to minimize the effect of sludge reduction on nutrient removal. A comprehensive life cycle assessment of sludge reduction strategies is recommended to effectively confirm their sustainability. Full-scale research is needed to verify the results obtained from bench- and pilot-scale experiments. This review presents the future opportunities and challenges for sludge reduction based on microbial metabolism in the excess sludge disposal.

Enhanced denitrifying phosphorus removal and mass balance in a worm reactor

Phosphorus release is one of the disadvantages during worm predation, which has an adverse effect on wastewater treatment. In order to investigate and reveal the effects and mechanisms of worm predation on phosphorus transformation, batch experiments were conducted on a long-running worm reactor (WR). Denitrifying phosphorus removal (DPR) was observed in WR for the first time owing to the special reactor configuration and operating conditions. After DPR in WR, the concentration of supernatant phosphorus increased to 42.2 ± 1.1 mg L^-1 owing to bacterial phosphorus release and worm predation, which further promoted DPR in the subsequent cycle. DPR rate in the WR was 12.3 times higher than that in the blank reactor (BR). In addition, the synergistic effects of worm predation and bacterial metabolism on sludge reduction and nutrients transformation were analyzed. The sludge reduction of WR was 84.5% higher than that of BR. Bacterial metabolism played an important role in the removal of supernatant nutrients, which consumed 60.2% of total nitrogen and 55.5% of chemical oxygen demand derived from the reduced sludge. The study suggested that under certain conditions, WR could be functionalized as a bacteria selection tank to further improve the wastewater treatment efficiency. Bacterial metabolism was essential for supernatant nutrients removal during worm predation.

Effect of earthworms and plants on the efficiency of vertical flow systems treating university wastewater

One of the possible ways to improve the operation efficiency of constructed wetlands and to prevent their clogging is the application of earthworms. They have already been successfully applied for vermicomposting and for sludge dewatering and treatment. A few studies have already examined the effect of earthworms on the treatment of wastewater by vertical flow constructed wetlands (VFCWs), but none of them have provided a yearlong research result from an open-air system or compared the effect that different seasons in a temperate climate area can have on these invertebrates. The goal of this research was to estimate the effect that earthworms and plants have on VFCW's operation. Four mesocosms (a filter, a filter with earthworms, a VFCW and a VFCW with earthworms) were built and their influent and effluent water quality was monitored for a period of 1 year. They were fed with wastewater coming from a building of the University of Bologna (Italy). The results have shown that the presence of earthworms in this specific system did not reduce the organic matter content of the substrate, but it has positively influenced plants' growth. However, since neither earthworms nor plants had a statistically significant effect on the effluent quality, it can be concluded that the integration of these invertebrates cannot improve wastewater treatment of vertical flow filters or constructed wetlands.

Elucidating the microbial community associated with the protein preference of sludge-degrading worms

Sludge predation by aquatic worms results in an increased sludge reduction rate, which is mainly due to the specific removal of a protein fraction from the sludge. As microorganisms play an essential role in sludge hydrolysis a better understanding of the microbial community involved in the worm predation process will provide more insight into the relations between the aquatic worms, their associated microbiome and the efficient sludge reduction. In this study, the microbial community associated with predation by the Tubifex tubifex was investigated. The microbial diversity in the samples of the worm faeces (WF), predated activated sludge and protein-rich substrates were compared. The results indicated that predation on sludge resulted in a microbial change from Actinobacteria (44%) in the sludge, to Proteobacteria (64%) and Bacteriodites (36%) in the WF. Interestingly, the faecal microbial community was more related to the community in (predated) protein-rich substrates than to the community in predated or endogenously respirated activated sludge samples. This similar microbial community could be due to microbial utilisation of protein hydrolysis products. Alternatively, conditions in the worm gut could facilitate a protein hydrolysing community which assists in protein hydrolysis. The genera Burkholderiales, Chryseobacterium and Flavobacterium were found to be associated with predation by T. tubifex.

A new approach for excess sludge reduction by manganese dioxide oxidation: performance, kinetics, and mechanism studies

A considerable amount of excess sludge, a kind of hazardous waste, is produced from the conventional wastewater treatment systems such as activated sludge process, and efficient sludge reduction processes are needed. A new chemical method for sludge reduction was proposed by using manganese dioxide as oxidant in this study. A favorable condition for sludge reduction is determined as manganese dioxide dosage of 0.165 g g^-1 wet sludge, sulfuric acid concentration of 3 mol L^-1, and reduction temperature of 90 °C for 90 min, where the sludge reduction efficiency can reach 73.30%. Reaction kinetic study revealed that the sludge reduction rate was controlled by the surface chemical reaction and the reaction followed a shrinking core kinetic model with apparent activation energy of 37.76 kJ mol^-1. Furthermore, reaction process analysis indicated that the sludge hydrolysis included two steps, i.e., floc destruction and microbial cell disruption. Considering the high efficiency and short treatment time, manganese dioxide oxidation is suggested to be a feasible method for disintegration of excess activated sludge.

Unravelling the protein preference of aquatic worms during waste activated sludge degradation

Worm predation (WP) by Tubifex tubifex was investigated using waste activated sludge (WAS) as the substrate. In order to better understand the sludge degradation mechanisms during WP, the activity of five common hydrolytic enzymes was determined and compared among the initial feed activated sludge, endogenous respirated sludge and worm predated sludge. The results showed that the enzymatic activity decreased upon aerobic (worm) treatment of WAS and that this activity was predominantly associated with the removed solids fraction of the sludge. Interestingly, the protease activity showed a smaller decrease in activity when the worms were present. Flow cell cytometry revealed the release of intestinal bacteria from the worms, which are presumed to be largely responsible for the observed protease activity. Additionally, experiments in which T. tubifex were treated with antibiotics showed that the worms are responsible for a maximum of 73% of the observed proteolytic activity. The remaining 27% is attributed to the intestinal bacteria that exhibit a synergistic relationship with T. tubifex towards protein hydrolysis.

Technologies for reducing sludge production in wastewater treatment plants: State of the art

This review presents the state-of-the-art sludge reduction technologies applied in both wastewater and sludge treatment lines. They include chemical, mechanical, thermal, electrical treatment, addition of chemical un-coupler, and predation of protozoa/metazoa in wastewater treatment line, and physical, chemical and biological pretreatment in sludge treatment line. Emphasis was put on their effect on sludge reduction performance, with 10% sludge reduction to zero sludge production in wastewater treatment line and enhanced TS (total solids) or volatile solids removal of 5-40% in sludge treatment line. Free nitrous acid (FNA) technology seems good in wastewater treatment line but it is only under the lab-scale trial. In sludge treatment line, thermal, ultrasonic (<4400kJ/kg TS), FNA pretreatment and temperature-phased anaerobic digestion (TPAD) are promising if pathogen inactivation is not a concern. However, thermal pretreatment and TPAD are superior to other pretreatment technologies when pathogen inactivation is required. The new wastewater treatment processes including SANI®, high-rate activated sludge coupled autotrophic nitrogen removal and anaerobic membrane bioreactor coupled autotrophic nitrogen removal also have a great potential to reduce sludge production. In the future, an effort should be put on the effect of sludge reduction technologies on the removal of organic micropollutants and heavy metals.

Physical and biochemical changes in sludge upon Tubifex tubifex predation

Worm predation (WP) on activated sludge leads to increased sludge degradation rates, irrespective of the type of worm used or reactor conditions employed. However, the cause of the increased sludge degradation rates remains unknown. This paper presents a comparative analysis of the physical and biochemical aspects of predated sludge, providing insight into the hydrolytic mechanisms underlying WP. To this end, the sessile worm Tubifex tubifex was used as a model oligochaete and was batch cultivated in an 18-L airlift reactor. Predation on activated sludge showed an average reduction rate of 12 ± 3.8%/d versus 2 ± 1.3%/d for endogenous respirated sludge. Sludge predation resulted in an increased release of inorganic nitrogen, phosphate and soluble chemical oxygen demand (sCOD). The sCOD consisted mainly of polysaccharides; however, fluorescence excitation emission matrix spectroscopy analysis also revealed the presence of Tryptophan-protein-like substances. Results suggest that the released polysaccharides contain a protein-like element. Additionally, soluble iron increased slightly in concentration after WP. The extent of hydrolysis seemed to reach an average plateau of about 40% volatile solids (VS) reduction after 4 days, which is substantially higher than the 29% VS reduction for endogenous decay of activated sludge after 30 days. Furthermore, T. tubifex predominantly consumed the protein fraction of the extracellular polymeric substances. Results suggest that that the worms specifically target a fraction of the sludge that is predominantly biodegradable under aerobic conditions, albeit at significantly higher degradation rates when compared to the endogenous decay of waste activated sludge.

Sludge reduction using aquatic worms under different aeration regimes

Adding aquatic worms to a wastewater treatment system can reduce sludge production through predation. The aeration level is crucial for success. To evaluate aeration impacts on sludge reduction and determine an optimal aeration regime, this study investigated the processes of in-situ sludge reduction, using aquatic worms exposed to different aeration levels. The experiment also compared treatment results between a conventional reactor and an aquatic worm reactor (WR). Results indicated that the recommended concentration of dissolved oxygen (DO) was 2.5 mg L^-1. The removal rate of chemical oxygen demand remained steady at 80% when the DO concentration was higher than 2.5 mg L^-1, while the removal rate of ammonia nitrogen continued to moderately increase. Increasing the DO concentration to 5 mg L^-1 did not improve sludge reduction, and consumed more power. With a DO concentration of 2.5 mg L^-1 and a power of 0.19 kWh t^-1 water, the absolute sludge reduction and relative sludge reduction rates in the WR were 60.0% and 45.7%, respectively, and the daily aquatic worm growth rate was 0.150 d^-1 during the 17-d test. Therefore, at the recommended aeration regime, aquatic worms reduced the sludge without increasing the power consumption or deteriorating the effluent.

Analysis and modelling of predation on biofilm activated sludge process: Influence on microbial distribution, sludge production and nutrient dosage

The influence of predation on the biofilm activated sludge (BAS) process is studied using a unified model that incorporates hydrolysis and predation phenomena into the two stages of the BAS system: moving bed biofilm reactor pre-treatment (bacterial-predator stage) and activated sludge (predator stage). The unified model adequately describes the experimental results obtained in a cellulose and viscose full-scale wastewater plant and has been used to evaluate the role and contribution of predator microorganisms towards removal of COD, nutrient requirements, sludge production and microbial distribution. The results indicate that predation is the main factor responsible for the reduction of both nutrient requirements and sludge production. Furthermore, increasing the sludge retention time (SRT) does not influence the total biomass content in the AS reactor of a BAS process in two different industrial wastewater treatments.

Improvement of an integrated system of membrane bioreactor and worm reactor by phosphorus removal using additional post-chemical treatment

A membrane bioreactor (MBR) coupled with a worm reactor (SSBWR) was designed as SSBWR-MBR for sewage treatment and excess sludge reduction. However, total phosphorus (TP) release caused by worm predation in the SSBWR could increase the effluent TP concentration in the SSBWR-MBR. To decrease the amount of TP excreted, chemical treatment reactor was connected after the SSBWR-MBR to remove the excess phosphorus (P). The effects of chemical treatment at different time intervals on the performance of the SSBWR-MBR were assessed. The results showed that a maximum TP removal efficiency of 21.5 ± 1.0% was achieved in the SSBWR-MBR after chemical treatment. More importantly, a higher sulfate concentration induced by chemical treatment could promote TP release in the SSBWR, which provided further TP removal from the SSBWR-MBR. Additionally, chemical oxygen demand (COD) removal efficiency of the SSBWR-MBR was increased by 1.3% after effective chemical treatment. In the SSBWR-MBR, the chemical treatment had little effects on NH₃-N removal and sludge production. Eventually, chemical treatment also alleviated the membrane fouling in the SSBWR-MBR. In this work, the improvement on TP, COD removal and membrane fouling alleviation was achieved in the SSBWR-MBR using additional chemical treatment.

An integrated mathematical model for chemical oxygen demand (COD) removal in moving bed biofilm reactors (MBBR) including predation and hydrolysis

An integrated mathematical model is proposed for modelling a moving bed biofilm reactor (MBBR) for removal of chemical oxygen demand (COD) under aerobic conditions. The composite model combines the following: (i) a one-dimensional biofilm model, (ii) a bulk liquid model, and (iii) biological processes in the bulk liquid and biofilm considering the interactions among autotrophic, heterotrophic and predator microorganisms. Depending on the values for the soluble biodegradable COD loading rate (SCLR), the model takes into account a) the hydrolysis of slowly biodegradable compounds in the bulk liquid, and b) the growth of predator microorganisms in the bulk liquid and in the biofilm. The integration of the model and the SCLR allows a general description of the behaviour of COD removal by the MBBR under various conditions. The model is applied for two in-series MBBR wastewater plant from an integrated cellulose and viscose production and accurately describes the experimental concentrations of COD, total suspended solids (TSS), nitrogen and phosphorous obtained during 14 months working at different SCLRs and nutrient dosages. The representation of the microorganism group distribution in the biofilm and in the bulk liquid allow for verification of the presence of predator microorganisms in the second reactor under some operational conditions.

Can aquatic worms enhance methane production from waste activated sludge?

Although literature suggests that aquatic worms can help to enhance the methane production from excess activated sludge, clear evidence for this is missing. Therefore, anaerobic digestion tests were performed at 20 and at 30°C with sludge from a high-loaded membrane bioreactor, the aquatic worm Lumbriculus variegatus, feces from these worms and with mixtures of these substrates. A significant synergistic effect of the worms or their feces on methane production from the high-loaded sludge or on its digestion rate was not observed. However, a positive effect on low-loaded activated sludge, which generally has a lower anaerobic biodegradability, cannot be excluded. The results furthermore showed that the high-loaded sludge provides an excellent feed for L. variegatus, which is promising for concepts where worm biomass is considered a resource for technical grade products such as coatings and glues.

Investigation of relationships between removals of tetracycline and degradation products and physicochemical parameters in municipal wastewater treatment plant

Determination of the effect of physicochemical parameters on the removal of tetracycline (TC) and degradation products is important because of the importance of the removal of antibiotics in Wastewater Treatment Plant (WWTP). Therefore, the purpose of this study was to investigate the relationships between removals of TC and degradation products and physicochemical parameters in Municipal Wastewater Treatment Plant (MWWTP). For this aim, (i) the removals of physicochemical parameters in a MWWTP located in Elazığ city (Turkey) were determined (ii) the removals of TC and degradation products in MWWTP were determined (iii) the relationships between removals of TC and degradation products and physicochemical parameters were investigated. TC, 4-epitetracycline (ETC), 4-epianhydrotetracycline (EATC), anhydrotetracycline (ATC), and physicochemical parameters (pH, temperature, electrical conductivity (EC), suspended solids (SS), BOD5, COD, total organic carbon (TOC), NH4(+)-N, NO2(-)-N, NO3(-)-N and O-PO4(-3)) were determined. The calculation of the correlation coefficients of relationships between the physicochemical parameters and TC, EATC, ATC showed that, among the investigated parameters, EATC and SS most correlated. The removals of other physicochemical parameters were not correlated with TC, EATC and ATC.

Biological control of biofilms on membranes by metazoans

Traditionally, chemical and physical methods have been used to control biofouling on membranes by inactivating and removing the biofouling layer. Alternatively, the permeability can be increased using biological methods while accepting the presence of the biofouling layer. We have investigated two different types of metazoans for this purpose, the oligochaete Aelosoma hemprichi and the nematode Plectus aquatilis. The addition of these grazing metazoans in biofilm-controlled membrane systems resulted in a flux increase of 50% in presence of the oligochaetes (Aelosoma hemprichi), and a flux increase of 119-164% in presence of the nematodes (Plectus aquatilis) in comparison to the control system operated without metazoans. The change in flux resulted from (1) a change in the biofilm structure, from a homogeneous, cake-like biofilm to a more heterogeneous, porous structure and (2) a significant reduction in the thickness of the basal layer. Pyrosequencing data showed that due to the addition of the predators, also the community composition of the biofilm in terms of protists and bacteria was strongly affected. The results have implications for a range of membrane processes, including ultrafiltration for potable water production, membrane bioreactors and reverse osmosis.

Chronic effects of temperature and nitrate pollution on Daphnia magna: Is this cladoceran suitable for widespread use as a tertiary treatment?

Effluent clarification and disinfection are major challenges in wastewater management. The cladoceran Daphnia magna has been proposed as a cost-effective and ecosystem-friendly option to clarify and disinfect secondary effluents, but its efficacy has not been fully tested under different sewage conditions. The present study explores the effects of temperature and nitrate on the efficacy of D. magna as a tertiary treatment at two different scales (individual assays and microcosms). Individual assays were employed to determine direct effects of temperature and/or nitrate on D. magna cultured in a suspension of organic matter. Using microcosms under the same environmental conditions, we explored the clearing efficacy of D. magna interacting with a natural microbial community. Individual assays revealed that D. magna mortality increased by 17% at 26 °C, 21% at >250 mg NO3(-)/l and by 60% at 26 °C and at >250 mg NO3(-)/l, and individuals displayed reduced body size, filtering rates and fecundity when compared to those at 21 °C and <40 mg NO3(-)/l. Improved performance under these conditions was also mirrored in the microcosms, with a higher density of D. magna (>100 ind/l) at 21 °C and <40 mg NO3(-)/l compared to the number (0-21 ind/l) at 26 °C and/or >250 mg NO3(-)/l. In the microcosms at 21 °C and <40 mg NO3(-)/l, turbidity and the density of bacteria, protists and micro-metazoa decreased in relation to those at 26 °C and/or >250 mg NO3(-)/l. Each treatment developed a unique and characteristic microbial assemblage, and D. magna was identified as the major driver of the community structure of protists and micro-metazoa. This enabled us to determine taxa vulnerability to D. magna grazing, and to re-define their tolerance thresholds for nitrate. In conclusion, this study increases our knowledge of how microbes respond to temperature and nitrate pollution, and highlights that D. magna efficacy as a tertiary treatment can be seriously compromised by variable environmental conditions.

Prediction of the effect of fine grit on the MLVSS/MLSS ratio of activated sludge

This paper investigated the suspension properties of fine grit with different particle sizes in a bioreactor and developed a model to predict its effect on the ratio of mixed liquor volatile suspended solids to the mixed liquor suspended solids (MLVSS/MLSS) of activated sludge. The experimental results revealed that a smaller particle size corresponds to a larger suspension ratio, defined as the proportion of fine grit brought in by influent that is suspended in the activated sludge, and a smaller MLVSS/MLSS ratio. The model demonstrated that the effect of fine grit on the MLVSS/MLSS ratio is related to the fine grit concentration and chemical oxygen demand in influent and the observed sludge yield. However, fine grit has no influence on the activity of microorganisms. Wastewater treatment plants (WWTPs) can adjust MLSS based on the MLVSS/MLSS ratio to ensure the stability of MLVSS, which can achieve the stable operation of WWTPs.

The effects of operational conditions on the respiration rate of Tubificidae

Tubificidae is often used in the wastewater treatment systems to minimize the sludge production because it can be fed on the activated sludge. The process conditions have effect on the growth, reproduction, and sludge reduction efficiency of Tubificidae. The effects of the water quality, density of worms, pH, temperature and dissolved oxygen (DO) concentration on the respiration rate of Tubificidae were investigated to determine the optimal conditions for the growth and metabolism of the worms and reveal the mechanisms involving the efficient sludge reduction in terms of these conditions. It was observed that the respiration rate was highest in the water discharged from an ecosystem that included symbiotic Tubificidae and microbes and was lowest in distilled water. Considering density of the worms, the highest rate was 81.72±5.12 mg O2/g(dry weight)·h·L with 0.25 g (wet weight) of worms in 1 L test flask. The maximum Tubificidae respiration rate was observed at a pH of 8.0±0.05, a rate that was more than twice as high as those observed at other pH values. The respiration rate increased in the temperature range of ∼8°C-22°C, whereas the rate declined in the temperature range of ∼22°C-30°C. The respiration rate of Tubificidae was very high for DO range of ∼3.5-4.5 mg/L, and the rates were relatively low for out of this DO range. The results of this study revealed the process conditions which influenced the growth, and reproduction of Tubificidae and sludge reduction at a microscopic level, which could be a theoretical basis for the cultivation and application of Tubificidae in wastewater treatment plants.

Evaluation of sludge reduction and carbon source recovery from excess sludge by the advanced Sludge reduction, Inorganic solids separation, Phosphorus recovery, and Enhanced nutrient Removal (SIPER) wastewater treatment process

An advanced wastewater treatment process involving Sludge reduction, Inorganic solids separation, Phosphorus recovery, and Enhanced nutrient Removal (SIPER) was developed to reduce sludge production, prevent the accumulation of inorganic solids, recover phosphorus, and enhance nutrient removal. The feasibility of recovering carbon (C)-source from excess sludge to enhance nutrient removal and the sludge reduction potential of the process was evaluated. The results showed that sludge hydrolysis and acidification yields were 20±3% and 34±2%, respectively. The COD/TN and VFA/TP ratios for the supernatant of alkaline-treated sludge were 2.8 and 2.5 times those in the influent, respectively. Nutrients were removed effectively in the system, especially TN, for which the removal efficiency reached 80±2%. The C-source recovered from the excess sludge was successfully employed as an internal C-source for enhanced nutrient removal. The observed sludge yield of the system was 0.096 g VSS g COD(-1), demonstrating the excellent sludge reduction potential of this process.

Effect of earthworms on the biochemical characterization of biofilms in vermifiltration treatment of excess sludge

In this study, the biofilms formed in a vermifilter (VF) with earthworms and a conventional biofilter (BF) without earthworms were compared to investigate the effects of earthworms on the characteristics of biofilms during an excess sludge treatment period of 4months. Typical macrographs and micrographs of the biofilms showed that the feeding and casting actions of earthworms remarkably modified the VF morphology. Elemental analysis and fluorescence spectra indicated that earthworms enhanced the stabilization of organic matter by accelerating the mineralization and humification of organic materials during vermiconversion. In addition, bacterial communities inhabiting the VF biofilm showed that earthworms increased both bacterial diversity and metabolic activities in the film, as revealed by automatic testing bacteriology (ATB) expression and sequencing data. These results demonstrate that earthworms influence the structure and biochemical characteristics of biofilms and enhance their bacterial diversity and functions for improved sludge stabilization.

Pilot-scale test of an advanced, integrated wastewater treatment process with sludge reduction, inorganic solids separation, phosphorus recovery, and enhanced nutrient removal (SIPER)

Sludge reduction technologies are increasingly important in wastewater treatment, but have some defects. In order to remedy them, a novel, integrated process including sludge reduction, inorganic solids separation, phosphorus recovery, and enhanced nutrient removal was developed. The pilot-scale system was operated steadily at a treatment scale of 10 m(3)/d for 90 days. The results showed excellent nutrient removal, with average removal efficiencies for NH4(+)-N, TN, TP, and COD reaching 98.2 ± 1.34%, 75.5 ± 3.46%, 95.3 ± 1.65%, and 92.7 ± 2.49%, respectively. The ratio of mixed liquor volatile suspended solids (MLVSS) to mixed liquor suspended solids (MLSS) in the system gradually increased, from 0.33 to 0.52. The process effectively prevented the accumulation of inert or inorganic solids in activated sludge. Phosphorus was recovered as a crystalline product with aluminum ion from wastewater. The observed sludge yield Yobs of the system was 0.103 gVSS/g COD, demonstrating that the system's sludge reduction potential is excellent.

A free nitrous acid (FNA)-based technology for reducing sludge production

Sludge treatment and disposal is one of the major challenges for biological wastewater treatment plants and can represent up to 60% of their total operating costs. This study presents a novel strategy based on free nitrous acid (FNA or HNO2) treatment to achieve sludge reduction. Two sequencing batch reactors treating synthetic domestic wastewater were used, with one serving as an experimental reactor and the other as a control. In the experimental system, 50% of the excess sludge was exposed to FNA at 2.0 mg N/L for 24-42 h in an FNA treatment unit and then returned to the parent reactor. The sludge wastage flow from the experimental reactor was adjusted to obtain a similar mixed liquor suspended solids concentration to that in the control reactor, which was operated at a sludge retention time of 15 days. It was found that sludge production in the experimental system was 28% lower in comparison to the control. The addition of the FNA-treated sludge did not negatively affect the treatment performance and sludge properties of the experimental reactor, namely the organic carbon and nitrogen removal, nitrous oxide (N2O) emission and sludge settleability. Endogenous denitrification batch tests indicate that FNA-treated sludge is available as a carbon source for denitrification.

Activity of metazoa governs biofilm structure formation and enhances permeate flux during Gravity-Driven Membrane (GDM) filtration

The impact of different feed waters in terms of eukaryotic populations and organic carbon content on the biofilm structure formation and permeate flux during Gravity-Driven Membrane (GDM) filtration was investigated in this study. GDM filtration was performed at ultra-low pressure (65 mbar) in dead-end mode without control of the biofilm formation. Different feed waters were tested (River water, pre-treated river water, lake water, and tap water) and varied with regard to their organic substrate content and their predator community. River water was manipulated either by chemically inhibiting all eukaryotes or by filtering out macrozoobenthos (metazoan organisms). The structure of the biofilm was characterized at the meso- and micro-scale using Optical Coherence Tomography (OCT) and Confocal Laser Scanning Microscopy (CLSM), respectively. Based on Total Organic Carbon (TOC) measurements, the river waters provided the highest potential for bacterial growth whereas tap water had the lowest. An increasing content in soluble and particulate organic substrate resulted in increasing biofilm accumulation on membrane surface. However, enhanced biofilm accumulation did not result in lower flux values and permeate flux was mainly influenced by the structure of the biofilm. Metazoan organisms (in particular nematodes and oligochaetes) built-up protective habitats, which resulted in the formation of open and spatially heterogeneous biofilms composed of biomass patches. In the absence of predation by metazoan organisms, a flat and compact biofilm developed. It is concluded that the activity of metazoan organisms in natural river water and its impact on biofilm structure balances the detrimental effect of a high biofilm accumulation, thus allowing for a broader application of GDM filtration. Finally, our results suggest that for surface waters with high particulate organic carbon (POC) content, the use of worms is suitable to enhance POC removal before ultrafiltration units.

A full-scale house fly (Diptera: Muscidae) larvae bioconversion system for value-added swine manure reduction

Manure produced from confined animal farms can threaten public and environmental health if not managed properly. Herein, a full-scale commercial bioconversion operation in DeQing County, China for value-added swine manure reduction using house fly, Musca domestica L., larvae is reported. The greenhouse-assisted larvae bioreactor had a maximum daily treatment capacity of 35 m(3) fresh raw manure per day. The bioconversion process produced a fresh larvae yield of 95-120 kg m(3) fresh raw manure. This process provided an alternative animal foodstuff (having 56.9 and 23.8% protein and total fat as dry matter, respectively), as well as captured nutrients for agricultural re-utilization. Bioconversion reduced odour emission (characterized by 3-methylindole) and the Escherichia coli (E. coli) index by 94.5 and 92.0%, respectively, and reductions in total weight, moisture and total Kjeldahl nitrogen in solids were over 67.2, 80.0 and 76.0%, respectively. Yearly profit under this trial period ranged from US$33.4-46.1 per m(3). It is concluded that swine manure larvae bioconversion technology with subsequent production of value-added bio-products can be a promising avenue when considering a programme to reduce waste products in an intensive animal production system.

Heavy metal distribution and speciation during sludge reduction using aquatic worms

Changes in heavy metal distribution and speciation during the reduction of sewage sludge with the worm, Limnodrilus hoffmeisteri were assessed. In sludge containing 108.3 ± 2.2, 455.5 ± 10.3, and 39.4 ± 1.8 mg/kg of Cu, Zn, and Pb, respectively, more than 81% of these metals remained in the sludge after predation by the worms, while 4.1-9.7% of these metals were released into the liquid. The maximum uptake values of Cu, Zn, and Pb by the worms reached 180.5, 587.4, and 55.8 mg/kg, respectively. The predation did not increase metal bioavailability in the final sludge as reflected by a 9.5-12.5% decrease in labile Cu and unchanged levels in labile Zn and Pb. The sewage sludge reduction efficiency of L. hoffmeisteri was 27.6-29.2%. These results indicated the relatively moderate changes in speciation and distribution of Cu, Zn, and Pb and the stable performance of worms in reducing sewage sludge.

Performance analysis of a combined system of membrane bioreactor and worm reactor: wastewater treatment, sludge reduction and membrane fouling

A new process that combined a membrane bioreactor (S-MBR) and a novel worm reactor was proposed in this study. The combined system indicated excellent sludge reduction efficiency, wastewater treatment performance and membrane permeability. The sludge reduction percentage of the combined system was about 1.9 times higher than that of the conventional MBR. The chemical oxygen demand (COD) discharge rate in the combined system was only one fourth of that in the conventional MBR, indicating that the COD was removed more thoroughly. Low extracellular polymeric substances level (60-75 μg/mg), low filamentous bacteria level, narrow floc size distribution (distribution spread index of 0.91) and high roundness (0.80 ± 0.10) were observed in the S-MBR sludge. Deposited by this modified sludge, a fouling layer with smaller thickness, larger porosity and less proteins and polysaccharides accumulation was formed in the S-MBR, demonstrating that the combined system was able to alleviate membrane fouling.

Swine manure vermicomposting via housefly larvae (Musca domestica): the dynamics of biochemical and microbial features

Improper handling of animal manure generated from concentrated swine operations greatly deteriorates water ecosystems. In this study, a full-scale vermireactor using housefly larvae (Musca domestica) was designed to investigate the effectiveness and efficiency of swine manure reduction, and to explore the associated biochemical-biological mechanisms. The one-week larvae vermireactor resulted in a total weight reduction rate of 106±17 kg/(m(3) d) and moisture reduction of 80.2%. Microbial activities in manure decreased by 45% after vermicomposting, while the activities of cellulose, proteases, and phosphatases in the vermicompost were significantly 69 times, 48%, and 82% lower than those in raw manure, respectively. The vermicompost was exclusively dominated by Entomoplasma somnilux, Proteobacterium, and Clostridiaceae bacterium where the microbial diversity was decreased from 2.57 in raw manure to 1.77. Correlation coefficients statistic showed that organic C might be a key indicator of the biochemical features and microbial functions of the larvae vermireactor.