Dairy Manure Co-composting with Wood Biochar Plays a Critical Role in Meeting Global Methane Goals

Commercial-scale co-composting of wood-derived biochar with source-selected organic fraction of municipal solid waste

This full-scale trial aims to systematically examine the effect of the addition (10 % DW ratio) of wood-derived biochar produced at 700 °C on the composting of source-selected organic fraction of municipal solid waste (OFMSW) and compare it with an identical treatment without biochar addition. The study mainly focused on (i) composting process performance, including compost quality, and (ii) gaseous emissions (ammonia, methane, nitrous oxide, volatile organic compounds (VOC) and odor emissions) from the two experimental piles, in which representative areas within each pile were identified as independent regions (n = 6) for sampling, obtaining over 1300 independent gas sampling data points. During the first 50 days, biochar contributed to a more sustained thermophilic temperature compared to the control (average 47 and 38 °C, respectively). Over the 80 days of composting, biochar significantly (p < 0.003) decreased methane (from 0.17 to 0.05 kg CH4 Mg-1 OFMSW) and ammonia (from 0.57 to 0.35 kg NH3 Mg-1 OFMSW) emissions. The differences in VOC emission from the two treatments were only significant (p < 0.001) during the maturation phase (from day 50 onwards) with average values of 35 and 175 g C-VOC day-1, for the biochar and control treatments, respectively. Odor emissions were smaller in the presence of biochar (1.1E + 0.6 vs. 1.9E + 0.6 ou Mg-1 OFMSW). The agronomic value of the resultant biochar co-compost was similar to that of the control compost. Biochar can thus contribute to climate change mitigation, not only through CO2 removal, but also through the reduction of non-CO2 greenhouse gases emissions during composting, while also decreasing the odor impact of the plant on nearby residents.

Exploring the Dual Nature of Integrated Crop-Livestock Systems: A Review of Environmental Benefits and Risk Challenges

Integrated crop-livestock systems (ICLS) are acknowledged as both productive and environmentally sustainable, with notable potential to optimize resource use, enhance ecosystem services, and boost crop yields. However, manure application, a critical component of ICLS, may amplify negative environmental impacts, particularly the risks associated with emerging pollutants, which remain underexplored and insufficiently understood. This comprehensive review seeks to thoroughly evaluate the environmental benefits of ICLS. It integrates case studies of successful ICLS models implemented across leading agricultural nations to deepen insights into their practical application. Moreover, this review uniquely underscores the environmental challenges posed by emerging pollutants in ICLS and examines mitigation strategies. Additionally, technological advancements, sustainable practices, assessment models, and policy interventions are essential for ICLS development, highlighting the need for further in-depth research.

Use of biochar derived from Spartina alterniflora to reduce sediment methane (CH4) production potential during non-farming period in earthen aquaculture ponds

Biochar has been proposed as an effective material for mitigating greenhouse gas emissions from farmlands, but comparable information for earthen aquaculture ponds is limited. A field study was conducted to investigate the effects of adding biochar (200-1600 kg ha-1) derived from the invasive plant Spartina alterniflora on sediment physico-chemical properties, CH4 production potential (PCH4), and the relevant functional gene abundances in earthen aquaculture ponds during the non-farming period. The results indicated that biochar treatments increased sediment porosity and salinity, while decreasing dissolved organic carbon and microbial biomass carbon. Biochar-treated sediments also exhibited a significantly lower abundance of mcrA gene especially in the early drainage stage, and a higher abundance of pmoA gene especially in the intermediate and final drainage stages. Consequently, the mean PCH4 in biochar-treated sediments (1.28-21.12 ng g-1 d-1) was 57-73% lower than in the control group (5.41-39.45 ng g-1 d-1). The reduction in PCH4 did not differ between biochar produced at 300 °C vs. 500 °C and was not dependent on the amount of biochar added. The findings suggest that using biochar derived from S. alterniflora can be a cost-effective method to control the spread of this invasive plant and reduce CH4 production in aquaculture pond sediment during the non-farming period.

Implications of Pyrolytic Gas Dynamic Evolution on Dissolved Black Carbon Formed During Production of Biochar from Nitrogen-Rich Feedstock

Gases and dissolved black carbon (DBC) formed during pyrolysis of nitrogen-rich feedstock would affect atmospheric and aquatic environments. Yet, the mechanisms driving biomass gas evolution and DBC formation are poorly understood. Using thermogravimetric-Fourier transform infrared spectrometry and two-dimensional correlation spectroscopy, we correlated the temperature-dependent primary noncondensable gas release sequence (H2O → CO2 → HCN, NH3 → CH4 → CO) with specific defunctionalization stages in the order: dehydration, decarboxylation, denitrogenation, demethylation, and decarbonylation. Our results revealed that proteins in feedstock mainly contributed to gas releases, and low-volatile pyrolytic products contributed to DBC. Combining mass difference analysis with Fourier transform ion cyclotron resonance mass spectrometry, we showed that 44-60% of DBC molecular compositions were correlated with primary gas-releasing reactions. Dehydration (-H2O), with lower reaction energy barrier, contributed to DBC formation most at 350 and 450 °C, whereas decarboxylation (-CO2) and deamidization (-HCNO) prevailed in contributing to DBC formation at 550 °C. The aromaticity changes of DBC products formed via gas emissions were deduced. Compared to their precursors, dehydration increased DBC aromaticity, while deamidization reduced the aromaticity of DBC products. These insights on pyrolytic byproducts help predict and tune DBC properties via changing gas formed during biochar production, minimizing their negative environmental impacts.

Global natural and anthropogenic methane emissions with approaches, potentials, economic costs, and social benefits of reductions: Review and outlook

The increase in atmospheric methane (CH4) level directly contributes to approximately one-fifth of global mean temperature rise since preindustrial era, only next to CO2. Global anthropogenic CH4 emissions has augmented by nearly three-fifths during the past five decades; due to climate change, natural CH4 emissions are plausibly projected to increase in the foreseeable future. Thereby, examining and projecting long-term natural and anthropogenic CH4 emissions and sinks are imperative. According to peer-reviewed literatures as information sources for this compendium, we recapitulate natural and anthropogenic CH4 emissions, summarize available abatement approaches and their mitigation potentials, and investigate and encapsulate economic costs and social benefits of reductions. We list current challenges in realizing CH4 emissions reductions and suggest possible technical pathways for future mitigation.

Dual mechanism of membrane covering on GHG and NH3 mitigation during industrial-scale experiment on dairy manure composting: Inhibiting formation and blocking emissions

An industrial-scale experiment on dairy manure composting with the control group (Ctrl) and the membrane covering group (CM) was conducted to explore the effects of functional membrane covering on gas emissions, the conversion of carbon and nitrogen, and revealing the underlying mechanisms. Results indicated that CM achieved the synergistic effects on gas mitigation and improved compost product quality. CO2, CH4, N2O, and NH3 emissions were reduced by 81.8%, 87.0%, 82.6%, and 82.2%, respectively. The micro-aerobic condition formed in membrane covering compost pile together with the covering inhibiting effect dominated the mitigation effect. CM significantly downregulated the mcrA gene copies and the value of mcrA/pmoA (p < 0.01), which reduced CH4 emission. CM decreased the nirS and nirK gene copies and increased the nosZ gene copies to reduce N2O emission. Functional Annotation of Prokaryotic Taxa showed that membrane covering effectively amended part of carbon and nitrogen cycles, which stimulated the degradation of organic matter, accelerated compost maturity and reduced the gaseous emissions.

Biochar, phosphate, and magnesium oxide in seaweed and cornstarch dregs co-composting: Enhancing organic matter degradation, humification, and nitrogen retention

Seaweed waste, abundant and rich in plant-stimulating properties, has the potential to be transformed into valuable soil amendments through proper composting and utilization management. Given its low carbon-to-nitrogen ratio, co-composting seaweed with carbon-rich cornstarch dregs is an effective strategy. However, the potential application of co-composting largely depends on the efficiency of the composting and the quality of the product. This study explores the effects of adding 10 % corn stalk biochar to a co-composting system of seaweed and cornstarch dregs, alongside varying buffering capacities of phosphates (KH2PO4 and K2HPO4·3H2O-KH2PO4) and MgO, on the degradation efficiency of organic matter, nitrogen transformation, and humification. The results indicate that the addition of biochar and salts enhances the oxygen utilization rate (OUR) and cellulase activity during the thermophilic phase. Additionally, X-ray diffraction (XRD) and parallel factor analysis (PARAFAC) demonstrate more intense solubilization and transformation of proteinaceous substances, along with cellulose degradation. These processes are crucial for enhancing organic matter degradation and humification, significantly boosting degradation (with an increase of 28.6 % to 33.8 %) and humification levels (HA/FA increased by 37.1 % to 49.6 %). Specifically, groups with high buffering capacity significantly promote the formation of NO3--N and NH4+-N, and a higher degree of humification, creating an optimal environment for significantly improving nitrogen retention (increased by 4.80 %). Additionally, this treatment retains and slightly enhances the plant-stimulating properties of seaweed. These findings underscore the potential of integrating biochar with specific ratios of phosphates and MgO to enhance composting efficiency and product quality while preserving the plant-stimulating effects of seaweed.

The molecular binding sequence transformation of soil organic matter and biochar dissolved black carbon antagonizes the transport of 2,4,6-trichlorophenol

Dissolved organic matter (DOM) and dissolved black carbon (DBC) are significant environmental factors that influence the transport of organic pollutants. However, the mechanisms by which their molecular diversity affects pollutant transport remain unclear. This study elucidates the molecular binding sequence and adsorption sites through which DOM/DBC compounds antagonize the transport of 2,4,6-trichlorophenol (TCP) using column experiments and modelling. DBC exhibits a high TCP adsorption rate (kn = 5.32 × 10-22 mol1-n∙Ln-1∙min-1) and conditional stability constant (logK = 5.19-5.74), indicating a strong binding affinity and antagonistic effect on TCP. This is attributed to the high relative content of lipid/protein compounds in DBC (25.65 % and 30.28 %, respectively). Moreover, the small molecule lipid compounds showed stronger TCP adsorption energy (Ead = -0.0071 eV/-0.0093 eV) in DOM/DBC, combined with two-dimensional correlation spectroscopy model found that DOM/DBC antagonized TCP transport in the environment through binding sequences that transformed from lipid/protein small molecule compounds to lignin/tannin compounds. This study used a multifaceted approach to comprehensively assess the impact of DOM/DBC on TCP transport. It reveals that the molecular diversity of DOM/DBC is a critical factor affecting pollutant transport, providing important insights into the environmental trend and ecological effects of pollutants.

Reduced greenhouse gas emission by reactive oxygen species during composting

Reactive oxygen species (ROS) is produced in the composting, which effectively promote organic matter transformation and humification process, but the effect of ROS on greenhouse gas emissions in this process has not been understood. This study proposed and validated that ROS can effectively reduce greenhouse gas emissions intheprocessofcomposting. Compared with ordinary thermophilic composting (oTC), thermophilic composting (imTC) that was supplemented by iron mineral increased ROS production by 1.38 times, and significantly reduced greenhouse gas emissions by 45.12%. Microbial community analysis showed no significant difference in the abundance of microbes involved in greenhouse gas production between oTC and imTC. Further correlation analysis proved that ROS played a crucial role in influencing greenhouse gas emissions throughout the composting process, especially in the initial phase. These findings provide new strategies for managing livestock and poultry manure to mitigate climate change.

Addressing the gaseous and odour emissions gap in decentralised biowaste community composting

Composting has demonstrated to be an effective and sustainable technology to valorise organic waste in the framework of circular economy, especially for biowaste. Composting can be performed in various technological options, from full-scale plants to community or even individual composters. However, there is scarce scientific information about the potential impact of community composting referred to gaseous emissions. This work examines the emissions of methane and nitrous oxide as main GHG, ammonia, VOC and odours from different active community composting sites placed in Spain, treating kitchen, leftovers and household biowaste. Expectedly, the gaseous emissions have an evident relation with the composting progress, represented mainly by its decrease as temperature or biological activity decreases. GHG and odour emission rates ranged from 5.3 to 815.2 mg CO2eq d-1 kg-1VS and from 69.8 to 1088.5 ou d-1 kg-1VS, respectively, generally being lower than those find in open-air full-scale composting. VOC characterization from the community composting gaseous emissions showed a higher VOC families' distribution in the emissions from initial composting phases, even though terpenes such as limonene, α-pinene and β-pinene were the most abundant VOC along the composting process occurring in the different sites studied. The results presented in this study can be the basis to evaluate systematically and scientifically the numerous current projects for a worldwide community composting implementation in decentralised biowaste management schemes.

Biochar-amended compost as a promising soil amendment for enhancing plant productivity: A meta-analysis study

A meta-analysis was conducted to evaluate the effect of biochar-amended compost (BAC) on plant productivity (PP) and soil quality. The analysis was based on observations from 47 peer-reviewed publications. The results showed that BAC application significantly increased PP by 74.9 %, the total nitrogen content of soil by 37.6 %, and the organic matter content of soil by 98.6 %. Additionally, BAC application significantly decreased the bioavailability of cadmium (-58.3 %), lead (-50.1 %), and zinc (-87.3 %). However, the bioavailability of copper increased by 30.1 %. The study explored the key factors regulating the response of PP to BAC through subgroup analysis. It was found that the increase in the organic matter content of the soil was the key mechanism for PP improvement. The recommended rate of BAC application for improving PP was found to be between 10 and 20 t ha-1. Overall, the findings of this study are significant in providing data support and technical guidance for the application of BAC in agricultural production. However, the high heterogeneity of BAC application conditions, soil properties, and plant types suggests that site-specific factors should be considered when applying BAC to soils.