Carbon nanotubes accelerate methane production in pure cultures of methanogens and in a syntrophic coculture

Effects of carbon-based conductive materials on semi-continuous anaerobic co-digestion of organic fraction of municipal solid waste and waste activated sludge

Organic fraction of municipal solid waste (OFMSW) and waste activated sludge (WAS) are the most produced organic waste streams in urban centres. Their anaerobic co-digestion (AcoD) allows to generate methane (CH4) and digestate employable as renewable energy source and soil amendment, respectively, fully in accordance with circular bioeconomy principles. However, the widespread adoption of such technology is limited by relatively low CH4 yields that fail to bridge the gap between benefits and costs. Among strategies to boost AcoD of OFMSW and WAS, use of conductive materials (CMs) to promote interspecies electron transfer has gained increasing attention. This paper presents one of the few experimental attempts of investigating the effects of four different carbon(C)-based CMs (i.e., granular activated carbon - GAC, graphite - GR, graphene oxide - GO, and carbon nanotubes - CNTs) separately added in semi-continuous AcoD of OFMSW and thickened WAS. The presence of C-based CMs has been observed to improve CH4 yield of the control process. Specifically, after 63 days of operation (concentrations of GAC and GR of 10.0 g/L and of GO and CNTs of 0.2 g/L), 0.186 NL/gVS, 0.191 NL/gVS, 0.203 NL/gVS, and 0.195 NL/gVS of CH4 were produced in reactors supplemented with GAC, GR, GO, and CNTs, respectively, compared to 0.177 NL/gVS produced in the control process. Likewise, at the end of the test (i.e., after 105 days at concentrations of C-based CMs half of the initial ones), CH4 yields were 0.193 NL/gVS, 0.201 NL/gVS, 0.211 NL/gVS, and 0.206 NL/gVS in reactors supplemented with GAC, GR, GO, and CNTs, respectively, compared to 0.186 NL/gVS of the control process. Especially with regard to GR, GO, and CNTs, results obtained in the present study represent a significant advance of the knowledge on the effects of such C-based CMs to realistic and scalable AD process conditions respect to previous literature.

Research on the Resource Recovery of Medium-Chain Fatty Acids from Municipal Sludge: Current State and Future Prospects

The production of municipal sludge is steadily increasing in line with the production of sewage. A wealth of organic contaminants, including nutrients and energy, are present in municipal sludge. Anaerobic fermentation can be used to extract useful resources from sludge, producing hydrogen, methane, short-chain fatty acids, and, via further chain elongation, medium-chain fatty acids. By comparing the economic and use values of these retrieved resources, it is concluded that a high-value resource transformation of municipal sludge can be achieved via the production of medium-chain fatty acids using anaerobic fermentation, which is a hotspot for future research. In this study, the selection of the pretreatment method, the method of producing medium-chain fatty acids, the influence of the electron donor, and the technique used to enhance product synthesis in the anaerobic fermentation process are introduced in detail. The study outlines potential future research directions for medium-chain fatty acid production using municipal sludge. These acids could serve as a starting point for investigating other uses for municipal sludge.

Utilization of carbon-based nanomaterials for wastewater treatment and biogas enhancement: A state-of-the-art review

The management of environmental pollution and carbon dioxide (CO2) emissions is a challenge that has spurred increased research interest in determining sustainable alternatives to decrease biowaste. This state-of-the-art review aimed to describe the preparation and utilization of carbon-based nanomaterials (CNM) for biogas enhancement and wastewater contaminant (dyes, color, and dust particles) removal. The novelty of this review is that we elucidated that the performance of CNMs in the anaerobic digestion (AD) varies from one system to another. In addition, this review revealed that increasing the pyrolysis temperature can facilitate the transition from one CNM type to another and outlined the methods that can be used to develop CNMs, including arc discharge, chemical exfoliation, and laser ablation. In addition, this study showed that methane (CH4) yield can be slightly increased (e.g. from 33.6% to 60.89%) depending on certain CNM factors, including its type, concentration, and feedstock. Temperature is a fundamental factor involved in the method and carbon sources used for CNM synthesis. This review determined that graphene oxide is not a good additive for biogas and CH4 yield improvement compared with other types of CNM, such as graphene and carbon nanotubes. The efficacy of CNMs in wastewater treatment depends on the temperature and pH of the solution. Therefore, CNMs are good adsorbents for wastewater contaminant removal and are a promising alternative for CO2 emissions reduction. Further research is necessary to determine the relationship between CNM synthesis and preparation costs while accounting for other factors such as gas flow, feedstock, consumption time, and energy consumption.

Riboflavin-loaded carbon cloth aids the anaerobic digestion of cow dung by promoting direct interspecies electron transfer

Cow dung generates globally due to increased beef and milk consumption, but its treatment efficiency remains low. Previous studies have shown that riboflavin-loaded conductive materials can improve anaerobic digestion through enhance direct interspecies electron transfer (DIET). However, its effect on the practical anaerobic digestion of cow dung remained unclear. In this study, carbon cloth loaded with riboflavin (carbon cloth-riboflavin) was added into an anaerobic digester treating cow dung. The carbon cloth-riboflavin reactor showed a better performance than other two reactors. The metagenomic analysis revealed that Methanothrix on the surface of the carbon cloth predominantly utilized the CO2 reduction for methane production, further enhanced after riboflavin addition, while Methanothrix in bulk sludge were using the acetate decarboxylation pathway. Furthermore, the carbon cloth-riboflavin enriched various major methanogenic pathways and activated a large number of enzymes associated with DIET. Riboflavin's presence altered the microbial communities and the abundance of functional genes relate to DIET, ultimately leading to a better performance of anaerobic digestion for cow dung.

Biological treatment processes for saline organic wastewater and related inhibition mechanisms and facilitation techniques: A comprehensive review

Owing to its profound pollution-inducing properties and resistance to biodegradation, saline organic wastewater (SOW) has unavoidably emerged as a predominant focal point within the wastewater treatment domain. Substantial quantities of SOW are discharged by diverse industries encompassing food processing, pharmaceuticals, leather manufacturing, petrochemicals, and textiles. Within this review, the inhibitory repercussions of elevated salinity upon biological water treatment systems are subject to methodical scrutiny spanning from sludge characteristics, microbial consortia to the physiological functionality of microorganisms have been investigated. This exposition elucidates the application of both anaerobic and aerobic biological technologies for SOW treatment, which noting that conventional bioreactors can effectually treat SOW through microbial adaptation, and elaborating that cultivation of salt-tolerant bacteria and the design of advanced bioreactors represents a promising avenue for SOW treatment. Furthermore, the mechanisms underpinning microbial acclimatization to hypersaline milieus and the methodologies aimed at amplifying the efficacy of biological SOW treatment are delved into, which point out that microorganism exhibit salt tolerance via extracellular polymeric substance accumulation or by facilitating the influx of osmolarity-regulating agents into the bacterial matrix. Finally, the projections for future inquiry are proffered, encompassing the proliferation and deployment of high salt-tolerant strains, as well as the development of techniques enhancing the salt tolerance of microflora engaged in wastewater treatment.

Study on the effect of different additives on the anaerobic digestion of hybrid Pennisetum: Comparison of nano-ZnO, nano-Fe2O3 and nano-Al2O3

The effects of three nanomaterials (ZnO, Al₂O₃, and Fe₂O₃) on the wet and dry anaerobic digestion (AD) processes of hybrid Pennisetum were assessed over 33 days, and the microbial communities of dry AD systems were studied. The results demonstrated that biogas production improved by 72.2% and 33.6% when nanoporous Al₂O₃ (nano-Al₂O₃) and nano-Fe₂O₃ were added during dry AD, respectively. However, biogas production decreased by 39.4% with nano-ZnO. Kinetic analysis showed that the three nanomaterials could shorten the lag phase of the AD sludge, while the 16S rRNA gene amplicon sequencing results demonstrated that microbes such as Longilinea and Methanosarcina were enriched in the nano-Al₂O₃ reactors and methanogenic communities community such as Methanobacterium sp., Methanobrevibacter sp., and Methanothrix sp., which were enriched in the nano-Al₂O₃ and nano-Fe₂O₃ reactors. However, the microbial community and some methanogenic communities diversity and richness were inhibited by the addition of nano-ZnO.

Magnetite Nanoparticles and Carbon Nanotubes for Improving the Operation of Mesophilic Anaerobic Digesters

Anaerobic waste processing contributes to the development of the bioenergy sector and solves environmental problems. To date, many technologies have been developed for increasing the rate of the anaerobic digestion process and yield of methane. However, new technological advancements are required to eliminate biogas production inefficiencies. The performance of anaerobic digesters can be improved by adding conductive materials. In this study, the effects of the separate and shared use of magnetite nanoparticles and carbon nanotubes in anaerobic digesters converting high-nitrogen-containing waste, chicken manure, were investigated. The tested nanomaterials accelerated the methane production and increased the decomposition of products from the acidogenesis and acetogenesis stages. The combined use of magnetite nanoparticles and carbon nanotubes gavae better results compared to using them alone or without them. Members of the bacterial classes Bacteroidia, Clostridia, and Actinobacteria were detected at higher levels in the anaerobic digesters, but in different proportions depending on the experiment. Representatives of the genera Methanosarcina, Methanobacterium, and Methanothrix were mainly detected within the methanogenic communities in the anaerobic digesters. The present study provides new data for supporting the anaerobic treatment of substrates with a high content of inhibitory compounds, such as chicken wastes.

Magnetite-based nanoparticles and nanocomposites for recovery of overloaded anaerobic digesters

The effect of magnetite nanoparticles and nanocomposites (magnetite nanoparticles impregnated into graphene oxide) supplement on the recovery of overloaded laboratory batch anaerobic reactors was assessed using two types of starting inoculum: anaerobic granular sludge (GS) and flocculent sludge (FS). Both nanomaterials recovered methane production at a dose of 0.27 g/L within 40 days in GS. Four doses of magnetite nanoparticles from 0.075 to 1 g/L recovered the process in FS systems between 30 and 50 days relaying on the dose. The presence of nanomaterials helped to reverse the effect of volatile fatty acids inhibition and enabled microbial communities to recover but also favoured the development of certain microorganisms over others. In GS reactors, the methanogenic population changed from being mostly acetoclastic (Methanothrix soehngenii) to being dominated by hydrogenotrophic species (Methanobacterium beijingense). Nanomaterial amendment may serve as a preventative measure or provide an effective remedial solution for system recovery following overloading.

Suppressing Methane Production to Boost High-Purity Hydrogen Production in Microbial Electrolysis Cells

Hydrogen gas (H₂) is an attractive fuel carrier due to its high specific enthalpy; moreover, it is a clean source of energy because in the combustion reaction with oxygen (O₂) it produces water as the only byproduct. The microbial electrolysis cell (MEC) is a promising technology for producing H₂ from simple or complex organics present in wastewater and solid wastes. Methanogens and non-archaeal methane (CH₄)-producing microorganisms (NAMPMs) often grow in the MECs and lead to rapid conversion of produced H₂ to CH₄. Moreover, non-archaeal methane production (NAMP) catalyzed by nitrogenase of photosynthetic bacteria was always overlooked. Thus, suppression of CH₄ production is required to enhance H₂ yield and production rate. This review comprehensively addresses the principles and current state-of-the-art technologies for suppressing methanogenesis and NAMP in MECs. Noteworthy, specific strategies aimed at the inhibition of methanogenic enzymes and nitrogenase could be a more direct approach than physical and chemical strategies for repressing the growth of methanogenic archaea. In-depth studies on the multiomics of CH₄ metabolism can possibly provide insights into sustainable and efficient approaches for suppressing metabolic pathways of methanogenesis and NAMP. The main objective of this review is to highlight key concepts, directions, and challenges related to boosting H₂ generation by suppressing CH₄ production in MECs. Finally, perspectives are briefly outlined to guide and advance the future direction of MECs for production of high-purity H₂ based on genetic and metabolic engineering and on the interspecific interactions.

Stimulating Effect of Trichococcus flocculiformis on a Coculture of Syntrophomonas wolfei and Methanospirillum hungatei

Syntrophic anaerobic consortia comprised of fatty acid-degrading bacteria and hydrogen/formate-scavenging methanogenic archaea are of central importance for balanced and resilient natural and manufactured ecosystems: anoxic sediments, soils, and wastewater treatment bioreactors. Previously published studies investigated interaction between the syntrophic bi-cultures, but little information is available on the influence of fermentative bacteria on syntrophic fatty acid oxidation, even though fermentative organisms are always present together with syntrophic partners in the above-mentioned ecosystems. Here, we present experimental observations of stimulated butyrate oxidation and methane generation by a coculture of Syntrophomonas wolfei with any of the following methanogens: Methanospirillum hungatei, Methanobrevibacter arboriphilus, or Methanobacterium formicicum due to the addition of a fermentative Trichococcus flocculiformis strain ES5. The addition of T. flocculiformis ES5 to the syntrophic cocultures led to an increase in the rates of butyrate consumption (120%) and volumetric methane production (150%). Scanning electron microscopy of the most positively affected coculture (S. wolfei, M. hungatei, and T. flocculiformis ES5) revealed a tendency of T. flocculiformis ES5 to aggregate with the syntrophic partners. Analysis of coculture’s proteome with or without addition of the fermentative bacterium points to a potential link with signal transducing systems of M. hungatei, as well as activation of additional butyryl coenzyme A dehydrogenase and an electron transfer flavoprotein in S. wolfei.

IMPORTANCE Results from the present study open doors to fascinating research on complex microbial cultures in anaerobic environments (of biotechnological and ecological relevance). Such studies of defined mixed populations are critical to understanding the highly intertwined natural and engineered microbial systems and to developing more reliable and trustable metabolic models. By investigating the existing cultured microbial consortia, like the ones described here, we can acquire knowledge on microbial interactions that go beyond “who feeds whom” relations but yet benefit the parties involved. Transfer of signaling compounds and stimulation of gene expression are examples of indirect influence that members of mixed communities can exert on each other. Understanding such microbial relationships will enable development of new sustainable biotechnologies with mixed microbial cocultures and contribute to the general understanding of the complex natural microbial interactions.

Improvement of Direct Interspecies Electron Transfer via Adding Conductive Materials in Anaerobic Digestion: Mechanisms, Performances, and Challenges

Anaerobic digestion is an effective and sustainable technology for resource utilization of organic wastes. Recently, adding conductive materials in anaerobic digestion to promote direct interspecies electron transfer (DIET) has become a hot topic, which enhances the syntrophic conversion of various organics to methane. This review comprehensively summarizes the recent findings of DIET mechanisms with different mediating ways. Meanwhile, the influence of DIET on anaerobic digestion performance and the underlying mechanisms of how DIET mediated by conductive materials influences the lag phase, methane production, and system stability are systematically explored. Furthermore, current challenges such as the unclear biological mechanisms, influences of non-DIET mechanisms, limitations of organic matters syntrophically oxidized by way of DIET, and problems in practical application of DIET mediated by conductive materials are discussed in detail. Finally, the future research directions for practical application of DIET are outlined.

Carbon-based conductive materials enhance biomethane recovery from organic wastes: A review of the impacts on anaerobic treatment

Amongst the most important sustainable waste management strategies, anaerobic biotechnology has had a central role over the past century in the management of high-pollution load sources, such as food, agricultural and municipal wastes. During anaerobic digestion (AD), valuable by-products such as digestate and biogas are produced. Biogas (mainly composed of methane) is generated through a series of reactions between bacteria and archaea. Enhancement of AD process with higher methane yield, accelerated methane production rate, and shorter start-up time is possible via tapping into a novel methanogenic pathway discovered a decade ago. This fundamentally new concept that is a substitute to interspecies hydrogen transfer is called direct interspecies electron transfer (DIET). DIET, a thermodynamically more feasible way of electron transfer, has been proven to occur between bacteria and methanogens. It is well-documented that amendment of carbon-based conductive materials (CCMs) can stimulate DIET via serving as an electrical conduit between microorganisms. Therefore, different types of CCMs such as biochar and activated carbon have been amended to a variety of AD reactors and enhancement of process performance was reported. In this review, a comparative analysis is presented for enhancement of AD performance in relation to major CCM related factors; electrical conductivity, redox properties, particle size and dosage. Additionally, the impacts of AD operational conditions such as organic loading rate and temperature on CCM amended reactors were discussed. Further, the changes in microbial communities of CCM amended reactors were reviewed and future perspectives along with challenges for CCM application in AD have been provided.

Mechanism study of improving anaerobic co-digestion performance of waste activated sludge and food waste by Fe3O4

A large amount of waste activated sludge (WAS) and food waste (FW) are produced every year in China. Anaerobic co-digestion is considered to be an effective way to solve this problem. This study applied FW/WAS mixture as co-substrate to create different digestive environment, aiming to understand the mechanism of Fe₃O₄ particles in promoting AD performance. The results showed that the addition of Fe₃O₄ presented various performances when facing different digestive acidification stress brought by different mixing ratios of WAS and FW. Methanogenic pathways and microbial communities varied with substrates' properties. For group A (WAS mono-digestion), the acetoclastic methanogens dominated, 20 mg/g VS (according to the iron element) Fe₃O₄ could promote methane production, while 200 mg/g VS Fe₃O₄ would inhibit microbial activity. The promoted methane production by Fe₃O₄ was attributable to the promotion of sludge hydrolysis. For group B (WAS: FW = 1:0.5, based on VS addition, similarly hereinafter), Fe₃O₄ triggered direct interspecific electron transfer (DIET) between bacteria and methanogens. For group C (WAS: FW = 1:1), the hydrogenotrophic methanogens dominated, bacteria excreted more non-conductive polysaccharides in EPS to resist unfavorable environment, thereby it prevented their contact with Fe₃O₄ particles. So, it was difficult for Fe₃O₄ to trigger DIET and promote the digestive performance of batch experiments in such condition.

Anaerobic bacterial responses to carbonaceous materials and implications for contaminant transformation: Cellular, metabolic, and community level findings

Carbonaceous materials (CM) enhance the abundance and activity of bacteria capable of persistent organic (micro)pollutant (POP) degradation. This review synthesizes anaerobic bacterial responses to minimally modified CM in non-fuel cell bioremediation applications at three stages: attachment, metabolism, and biofilm genetic composition. Established relationships between biological behavior and CM surface properties are identified, but temporal relationships are not well understood, making it difficult to connect substratum properties and "pioneer" bacteria with mature microorganism-CM systems. Stark differences in laboratory methodology at each temporal stage results in observational, but not causative, linkages as system complexity increases. This review is the first to critically examine relationships between material and cellular properties with respect to time. The work highlights critical knowledge gaps that must be addressed to accurately predict microorganism-CM behavior and to tailor CM properties for optimized microbial activity, critical frontiers in establishing this approach as an effective bioremediation strategy.

Modified biochar promotes the direct interspecies electron transfer between iron-reducing bacteria and methanogens in high organic loading co-digestion

High organic loading (HOL) could reduce substrate degradation and methane production. The objective of this study was to investigate the promotion mechanism of iron-modified biochar in HOL co-digestion. The results showed that the specific surface area of iron-modified biochar prepared at 500 ⁰C (500Fe@BC) was 131.7 m²/g. In 12% (w/w) of HOL co-digestion, 500Fe@BC addition enhanced methanogenesis by both aceticlastic and hydrogenotrophic pathways and showed the best methane yield performance. Compared with the non-biochar addition group, an increase of 56.6% and 11% in average methane content and cumulative methane yield was observed in the presence of 500Fe@BC during 25 days of hydraulic retention time. Furthermore, the buffer capacity of HOL co-digestion has been intensified, which attributed to the 500Fe@BC accelerated the hydrolysis of substrates and promoted the consumption of the volatile fatty acids. Moreover, 500Fe@BC promoted the enrichment of iron-reducing bacteria (Clostridium_sensu_stricto_1, Romboutsia) and methanogens (Methanosarcina, Methanobacterium).

Modification of hydrochar increased the capacity to promote anaerobic digestion

Hydrochar has been demonstrated to increase methane production rate during anaerobic digestion (AD) of organic wastes/wastewater by facilitating direct interspecies electron transfer (DIET). The present study compared the hydrochars prepared at different conditions (260 °C-1 h, 260 °C-8 h, 320 °C-1 h and 320 °C-8 h) on AD of glucose. Hydrochar prepared at lower temperature and residence time (260 °C-1 h) resulted in the highest methane production rate, which was 237% higher of control experiment without hydrochar. Modification of hydrochar (260 °C-1 h) by ball-milling further increased the capacity to increase methane production rate. Hydrothermal liquefaction (HTL) conditions affected the surface oxygen-containing functional groups that related with DIET, and hydrochar (260 °C-1 h) had higher peaks relating with C-O and O-H functional groups. Ball-milling enhanced the formation of such groups. Microbial analysis showed hydrochar (260 °C-1 h) by ball-milling resulted in the formation of different microbial communities as compared with control experiments, and Azospira and Methanosarcina were enriched, which might be involved in DIET.

Promotion of direct interspecies electron transfer and potential impact of conductive materials in anaerobic digestion and its downstream processing - a critical review

Addition of conductive materials (CMs) has been reported to facilitate direct interspecies electron transfer (DIET) and improved anaerobic digestion (AD) performance. This review summarises the benefits and outlines remaining research challenges of the addition of CMs with a focus on the downstream processing of AD. CM addition may alter biogas quality, digestate dewaterability, biosolids volume, and centrate quality. Better biogas quality has been observed due to the adsorption of H₂S to metallic CMs. The addition of CMs results in an increase in solid content of the digestate and thus an additional requirement for sludge dewatering and handling and the final biosolids volume for disposal. This review highlights the need for more research at pilot scale to validate the benefits of CM addition and to evaluate CM selection, doses, material costs, and the impact on downstream processes. The lack of research on the impact of CMs on the downstream process of AD is highlighted.

Progress and prospects of applying carbon-based materials (and nanomaterials) to accelerate anaerobic bioprocesses for the removal of micropollutants

Carbon‐based materials (CBM), including activated carbon (AC), activated fibres (ACF), biochar (BC), nanotubes (CNT), carbon xenogels (CX) and graphene nanosheets (GNS), possess unique properties such as high surface area, sorption and catalytic characteristics, making them very versatile for many applications in environmental remediation. They are powerful redox mediators (RM) in anaerobic processes, accelerating the rates and extending the level of the reduction of pollutants and, consequently, affecting positively the global efficiency of their partial or total removal. The extraordinary conductive properties of CBM, and the possibility of tailoring their surface to address specific pollutants, make them promising as catalysts in the treatment of effluents containing diverse pollutants. CBM can be combined with magnetic nanoparticles (MNM) assembling catalytic and magnetic properties in a single composite (C@MNM), allowing their recovery and reuse after the treatment process. Furthermore, these composites have demonstrated extraordinary catalytic properties. Evaluation of the toxicological and environmental impact of direct and indirect exposure to nanomaterials is an important issue that must be considered when nanomaterials are applied. Though the chemical composition, size and physical characteristics may contribute to toxicological effects, the potential toxic impact of using CBM is not completely clear and is not always assessed. This review gives an overview of the current research on the application of CBM and C@MNM in bioremediation and on the possible environmental impact and toxicity.

Monitoring of seven industrial anaerobic digesters supplied with biochar

BACKGROUND

Recent research articles indicate that direct interspecies electron transfer (DIET) is an alternative metabolic route for methanogenic archaea that improves microbial methane productivity. It has been shown that multiple conductive materials such as biochar can be supplemented to anaerobic digesters to increase the rate of DIET. However, the industrial applicability, as well as the impact of such supplements on taxonomic profiles, has not been sufficiently assessed to date.

RESULTS

Seven industrial biogas plants were upgraded with a shock charge of 1.8 kg biochar per ton of reactor content and then 1.8 kg per ton were added to the substrate for one year. A joint analysis for all seven systems showed a decreasing trend for the concentration of acetic acid (p < 0.0001), propionic acid (p < 0.0001) and butyric acid (p = 0.0022), which was significant in all cases. Quantification of the cofactor F420 using fluorescence microscopy showed a reduction in methanogenic archaea by up to a power of ten. Methanogenic archaea could grow within the biochar, even if the number of cells was 4 times less than in the surrounding sludge. 16S-rRNA gene amplicon sequencing showed a higher microbial diversity in the biochar particles than in the sludge, as well as an accumulation of secondary fermenters and halotolerant bacteria. Taxonomic profiles indicate microbial electroactivity, and show the frequent occurrence of Methanoculleus, which has not been described in this context before.

CONCLUSIONS

Our results shed light on the interplay between biochar particles and microbial communities in anaerobic digesters. Both the microbial diversity and the absolute frequency of the microorganisms involved were significantly changed between sludge samples and biochar particles. This is particularly important against the background of microbial process monitoring. In addition, it could be shown that biochar is suitable for reducing the content of inhibitory, volatile acids on an industrial scale.

Corksorb Enhances Alkane Degradation by Hydrocarbonoclastic Bacteria

Biosorbent materials are effective in the removal of spilled oil from water, but their effect on hydrocarbonoclastic bacteria is not known. Here, we show that corksorb, a cork-based biosorbent, enhances growth and alkane degradation by Rhodococcus opacus B4 (Ro) and Alcanivorax borkumensis SK2 (Ab). Ro and Ab degraded 96 ± 1% and 72 ± 2%, respectively, of a mixture of n-alkanes (2 g L^–1) in the presence of corksorb. These values represent an increase of 6 and 24%, respectively, relative to the assays without corksorb. The biosorbent also increased the growth of Ab by 51%. However, no significant changes were detected in the expression of genes involved in alkane uptake and degradation in the presence of corksorb relative to the control without the biosorbent. Nevertheless, transcriptomics analysis revealed an increased expression of rRNA and tRNA coding genes, which confirms the higher metabolic activity of Ab in the presence of corksorb. The effect of corksorb is not related to the release of soluble stimulating compounds, but rather to the presence of the biosorbent, which was shown to be essential. Indeed, scanning electron microscopy images and downregulation of pili formation coding genes, which are involved in cell mobility, suggest that cell attachment on corksorb is a determinant for the improved activity. Furthermore, the existence of native alkane-degrading bacteria in corksorb was revealed, which may assist in situ bioremediation. Hence, the use of corksorb in marine oil spills may induce a combined effect of sorption and stimulated biodegradation, with high potential for enhancing in situ bioremediation processes.

Enhancing anaerobic digestion process with addition of conductive materials

Anaerobic digestion is widely used for the treatment of wastewater for its low costs and bioenergy production, but the performances of anaerobic digestion often need improving in practical applications. The addition of conductive materials could lead to direct interspecies electron transfer (DIET) among the anaerobic microorganisms, and consequently enhance the efficiencies of anaerobic digestion. In this paper, the effects of DIET via conductive materials on chemical organic demand (COD) removal, volatile fatty acid (VFA) consumption and methane production were reviewed. The reports on the increase of conductive microorganisms due to the addition of conductive materials were discussed. Results regarding activities of microorganisms and morphology and properties of sludge were described and commented, and future research needs were also proposed which included better understanding of the roles of DIET in each step of anaerobic digestion, mechanisms of metabolism of pollutants in DIET-established systems and inhibition of excessive dosage of conductive materials.

Synergetic effects of biochars and denitrifier on nitrate removal

Nitrate is one of the most common water contaminants and has caused severe environmental problems. This work aimed to investigate the effects of integration of denitrifier with biochars on nitrate removal and understand the underlying mechanisms. The results showed that physiochemical properties of biochars varied according to different feedstocks, which influenced bacteria attachment and nitrate removal through adsorption. However, bacteria could colonize on biochars no matter biochars surface were favorable for bacteria attachment or not. Immobilization of denitrifier on biochars significantly improved nitrate removal efficiencies and reduced lag time. Underlying mechanisms investigation showed that the integration of denitrifier with biochars had synergetic effects on promoting nitrate removal, which improved not only the expression and activity of nitrate reductase, but also the electron transport system activity.

Zeolitic imidazolate framework-derived porous carbon enhances methanogenesis by facilitating interspecies electron transfer: Understanding fluorimetric and electrochemical responses of multi-layered extracellular polymeric substances

Modulating microbial electron transfer during anaerobic digestion can significantly improve syntrophic interactions for enhanced biogas production. As a carbonaceous conductive material, zeolite imidazolate framework-67 (ZIF-67)-derived porous carbon (PC) was hypothesized to act as a microbial electron transfer highway and assessed with respect to understanding the fluorimetric and electrochemical responses of multilayered extracellular polymeric substances (EPS). The highest biomethane yield (614.0 mL/g) from ethanol was achieved in the presence of 100 mg/L PC prepared at a carbonization temperature of 800 °C (PC-800), which was 28.2% higher than that without PC addition. Electrochemical analysis revealed that both the redox peak currents and conductivity of the methanogenic sludge increased, while the free charge transfer resistance decreased with PC-800 addition. The conductive PC-800 potentially functioned as an abiotic electron conduit to promote direct interspecies electron transfer, thereby resulting in decreased expression of functional genes associated with electrically conductive pili (e-pili) and hemeproteins. Additionally, PC-800 stimulated the secretion of redox-active humic substances (HSs), and excitation emission matrix spectra analysis indicated that the largest increase in percent fluorescence response of HSs occurred in the tightly bound EPS (TB-EPS) with addition of PC-800. This was attributed to the strong complexation ability of PC-800 particles to hydroxyl/carboxylic/phenolic moieties of HSs contained in the TB-EPS. Microbial analysis revealed that syntrophic/exoelectrogenic bacteria such as Pelotomaculum and Syntrophomonas, as well as hydrogenotrophic/electrotrophic methanogens such as Methanoculleus and Methanobacterium, were enriched in methanogenic sludge with adding PC-800. This study provided comprehensive insights for understanding the interactions among ZIF-derived PC, methanogenic microorganisms and their multilayered EPS.

Direct interspecies electron transfer mechanism in enhanced methanogenesis: A mini-review

The role of direct interspecies electron transfer (DIET) on enhancement of methanogenesis has been studied. This mini-review updated the current researches on the potential role of DIET on enhanced performance for anaerobic digestion of organic substrates with effective strategies implemented. Since most experimental observations correlated with the DIET mechanism are yet to be consolidated, this article categorized and discussed the current experimental observations supporting DIET mechanism for methanogenesis, mainly based on those with supplement of carbon materials, from which the prospects and challenges for further studies to confirm the role of DIET in anaerobic digestion processes were highlighted.

Detoxification of Ciprofloxacin in an Anaerobic Bioprocess Supplemented with Magnetic Carbon Nanotubes: Contribution of Adsorption and Biodegradation Mechanisms

In anaerobic bioreactors, the electrons produced during the oxidation of organic matter can potentially be used for the biological reduction of pharmaceuticals in wastewaters. Common electron transfer limitations benefit from the acceleration of reactions through utilization of redox mediators (RM). This work explores the potential of carbon nanomaterials (CNM) as RM on the anaerobic removal of ciprofloxacin (CIP). Pristine and tailored carbon nanotubes (CNT) were first tested for chemical reduction of CIP, and pristine CNT was found as the best material, so it was further utilized in biological anaerobic assays with anaerobic granular sludge (GS). In addition, magnetic CNT were prepared and also tested in biological assays, as they are easier to be recovered and reused. In biological tests with CNM, approximately 99% CIP removal was achieved, and the reaction rates increased ≈1.5-fold relatively to the control without CNM. In these experiments, CIP adsorption onto GS and CNM was above 90%. Despite, after applying three successive cycles of CIP addition, the catalytic properties of magnetic CNT were maintained while adsorption decreased to 29 ± 3.2%, as the result of CNM overload by CIP. The results suggest the combined occurrence of different mechanisms for CIP removal: adsorption on GS and/or CNM, and biological reduction or oxidation, which can be accelerated by the presence of CNM. After biological treatment with CNM, toxicity towards Vibrio fischeri was evaluated, resulting in ≈ 46% detoxification of CIP solution, showing the advantages of combining biological treatment with CNM for CIP removal.

Stimulation of Biomethane Productivity in Anaerobic Digestion Using Electro-Conductive Carbon-Nanotube Hollow-Fiber Media

The production of biogas was promoted via direct interspecies electron transfer (DIET) by employing electro-conductive carbon-nanotube hollow-fiber media (CHM) in anaerobic digestion. Experimental results showed a positive effect of CHM presence on CH4 productivity with 34% higher CH4 production rate than that of in the presence of non-electroconductive polymeric hollow fiber media. An increased CH4 production rate was due to the shift in the microbiome with more abundant Pelobacter (10.0%), Geobacter (6.9%), and Methanosaeta (15.7%), which play key roles in promoting CH4 production via syntrophic metabolism associated with DIET. Microscopic morphology analysis, using confocal laser scanning microscopy and scanning electron microscopy, exhibited that several living cells were attached with electro-conductive pili on the CHM surface, thereby facilitated electron transport between microbial cells.

Microbes trading electricity in consortia of environmental and biotechnological significance

Favorable interspecies associations prevail in natural microbial assemblages. Some of these favorable associations are co-metabolic dependent partnerships in which extracellular electrons are exchanged between species. For such electron exchange to occur, the cells must exhibit electroactive interfaces and get involved in direct cell-to-cell contact (Direct Interspecies Electron Transfer/DIET) or use available conductive mineral grains from their environment (Conductive-particle-mediated Interspecies Electron Transfer/CIET). This review will highlight recent discoveries and knowledge gaps regarding DIET and CIET interspecies associations in artificial co-cultures and consortia from natural and man-made environments and emphasize approaches to validate DIET and CIET. Additionally, we acknowledge the initiation of a movement towards applying electric syntrophies in biotechnology, bioremediation and geoengineering for natural attenuation of toxic compounds. Next, we have highlighted the urgent research needs that must be met to develop such technologies.

Long-Chain Fatty Acids Degradation by Desulfomonile Species and Proposal of "Candidatus Desulfomonile Palmitatoxidans"

Microbial communities with the ability to convert long-chain fatty acids (LCFA) coupled to sulfate reduction can be important in the removal of these compounds from wastewater. In this work, an enrichment culture, able to oxidize the long-chain fatty acid palmitate (C_{16 : 0}) coupled to sulfate reduction, was obtained from anaerobic granular sludge. Microscopic analysis of this culture, designated HP culture, revealed that it was mainly composed of one morphotype with a typical collar-like cell wall invagination, a distinct morphological feature of the Desulfomonile genus. 16S rRNA gene amplicon and metagenome-assembled genome (MAG) indeed confirmed that the abundant phylotype in HP culture belong to Desulfomonile genus [ca. 92% 16S rRNA gene sequences closely related to Desulfomonile spp.; and ca. 82% whole genome shotgun (WGS)]. Based on similar cell morphology and average nucleotide identity (ANI) (77%) between the Desulfomonile sp. in HP culture and the type strain Desulfomonile tiedjei strain DCB-1^T, we propose a novel species designated as "Candidatus Desulfomonile palmitatoxidans." This bacterium shares 94.3 and 93.6% 16S rRNA gene identity with Desulfomonile limimaris strain DCB-M^T and D. tiedjei strain DCB-1^T, respectively. Based on sequence abundance of Desulfomonile-morphotype in HP culture, its predominance in the microscopic observations, and presence of several genes coding for enzymes involved in LCFA degradation, the proposed species "Ca. Desulfomonile palmitatoxidans" most probably plays an important role in palmitate degradation in HP culture. Analysis of the growth of HP culture and D. tiedjei strain DCB-1^T with short- (butyrate), medium- (caprylate) and long-chain fatty acids (palmitate, stearate, and oleate) showed that both cultures degraded all fatty acids coupled to sulfate reduction, except oleate that was only utilized by HP culture. In the absence of sulfate, neither HP culture, nor D. tiedjei strain DCB-1^T degraded palmitate when incubated with Methanobacterium formicicum as a possible methanogenic syntrophic partner. Unlike D. tiedjei strain DCB-1^T, "Ca. Desulfomonile palmitatoxidans" lacks reductive dehalogenase genes in its genome, and HP culture was not able to grow by organohalide respiration. An emended description of the genus Desulfomonile is proposed. Our study reveals an unrecognized LCFA degradation feature of the Desulfomonile genus.

Insight into sludge anaerobic digestion with granular activated carbon addition: Methanogenic acceleration and methane reduction relief

In this study, the multiple effects of granular activated carbon (GAC) on sludge anaerobic digestion at ambient (16-24 °C), mesophilic (35 °C) and thermophilic (55 °C) temperature were investigated. After GAC addition, although the methane yields of raw sludge were reduced by 6.5%-36.9%, the lag phases of methanogenesis were shortened by 19.3%-30.6% and the reductions of methane yields were declined to only 5.9%-8.1% simultaneously for pretreated sludge. The inhibitory substances like phenols that generated by thermal pretreatment were reduced after GAC addition, which were demonstrated to be responsible for the methanogenic acceleration. Meanwhile, the methane reduction due to the non-selective adsorption by GAC could be mitigated by pretreatment and elevated temperature. Thus, a strategy coupling thermal pretreatment with detoxification by GAC was proposed to improve the methane production rate and avoid the negative effects during sludge anaerobic digestion with GAC addition.

An underappreciated DIET for anaerobic petroleum hydrocarbon-degrading microbial communities

Direct interspecies electron transfer (DIET) via electrically conductive minerals can play a role in the anaerobic oxidation of petroleum hydrocarbons in contaminated sites and can be exploited for the development of new, more effective bioremediation approaches.

Inhibition mitigation of methanogenesis processes by conductive materials: A critical review

Methanogenesis can be promoted by the addition of conductive materials. Although stimulating effects of conductive materials on methane (CH₄) production has been extensively reported, the crucial roles on recovering methanogenic activities under inhibitory conditions have not been systematically discussed. This critical review presents the current findings on the effects of conductive materials in methanogenic systems under volatile fatty acids (VFAs), ammonia, sulfate, and nano-cytotoxicity stressed conditions. Conductive materials induce fast VFAs degradation, avoiding VFAs accumulation during anaerobic digestion. Under high ammonia concentrations, conductive materials may ensure sufficient energy conservation for methanogens to maintain intracellular pH and proton balance. When encountering the competition of sulfate-reducing bacteria, conductive materials can benefit electron competitive capability of methanogens, recovering CH₄ production activity. Conductive nanomaterials stimulate the excretion of extracellular polymeric substances, which can prevent cells from nano-cytotoxicity. Future perspectives about unraveling mitigation mechanisms induced by conductive materials in methanogenesis processes are further discussed.

Multi-Walled Carbon Nanotubes Enhance Methanogenesis from Diverse Organic Compounds in Anaerobic Sludge and River Sediments

Conductive nanomaterials affect anaerobic digestion (AD) processes usually by improving methane production. Nevertheless, their effect on anaerobic communities, and particularly on specific trophic groups such as syntrophic bacteria or methanogens, is not extensively reported. In this work, we evaluate the effect of multi-walled carbon nanotubes (MWCNT) on the activity of two different anaerobic microbial communities: an anaerobic sludge and a river sediment. Methane production by anaerobic sludge was assessed in the presence of different MWCNT concentrations, with direct methanogenic substrates (acetate, hydrogen) and with typical syntrophic substrates (ethanol, butyrate). MWCNT accelerated the initial specific methane production rate (SMPR) from all compounds, with a more pronounced effect on the assays with acetate and butyrate, i.e., 2.1 and 2.6 times, respectively. In the incubations with hydrogen and ethanol, SMPR increased 1.1 and 1.2 times. Experiments with the river sediment were performed in the presence of MWCNT and MWCNT impregnated with 2% iron (MWCNT-Fe). Cumulative methane production was 10.2 and 4.5 times higher in the assays with MWCNT-Fe and MWCNT, respectively, than in the assays without MWCNT. This shows the high potential of MWCNT toward bioenergy production, in waste/wastewater treatment or ex situ bioremediation in anaerobic digesters.

Influence of Granular Activated Carbon on Anaerobic Co-Digestion of Sugar Beet Pulp and Distillers Grains with Solubles

Anaerobic digestion is an important technology to receive energy from various types of biomass. In this work, the impact of granular activated carbon (GAC) on the mesophilic anaerobic co-digestion of sugar beet pulp and distillers grains was investigated. After a short period, anaerobic reactors began to produce biomethane and were ready for completion within 19–24 days. The addition of GAC to reactors (5–10 g L−1) significantly enhanced the methane production rate and consumption of produced volatile fatty acids. Thus, the maximum methane production rate increased by 13.7% in the presence of GAC (5 g L−1). Bacterial and archaeal community structure and dynamics were investigated, based on 16S rRNA genes analysis. The abundant classes of bacteria in GAC-free and GAC-containing reactors were Clostridia, Bacteroidia, Actinobacteria, and Synergistia. Methanogenic communities were mainly represented by the genera Methanosarcina, Methanoculleus, Methanothrix, and Methanomassiliicoccus in GAC-free and GAC-containing reactors. Our results indicate that the addition of granular activated carbon at appropriate dosages has a positive effect on anaerobic co-digestion of by-products of the processing of sugar beet and ethanol distillation process.

Methanogenesis inhibitors used in bio-electrochemical systems: A review revealing reality to decide future direction and applications

Microbial fuel cell (MFC) is a robust technology capable of treating real wastewaters by utilizing mixed anaerobic microbiota as inoculum for producing electricity from oxidation of the biodegradable matters. However, these mixed microbiota comprises of both electroactive microorganisms (EAM) and substrate/electron scavenging microorganisms such as methanogens. Hence, in order to maximize bioelectricity from MFC, different physio-chemical techniques have been applied in past investigations to suppress activity of methanogens. Interestingly, recent investigations exhibit that methanogens can produce electricity in MFC and possess the cellular machinery like cytochrome c and Type IV pili to perform extracellular electron transfer (EET) in the presence of suitable electron acceptors. Hence, in this review, in-depth analysis of versatile behaviour of methanogens in both MFC and natural anaerobic conditions with different inhibition techniques is explored. This review also discusses the future research directions based on the latest scientific evidence on role of methanogens for EET in MFC.

Key syntrophic partnerships identified in a granular activated carbon amended UASB treating municipal sewage under low temperature conditions

Two laboratory-scale up-flow anaerobic sludge blankets (UASB) reactors, one with and one without granular activated carbon (GAC), were operated for municipal sewage treatment at low temperatures (16.5 ± 2.0 °C). During the 120-day operation, the GAC-amended reactor significantly enhanced COD removal (from 62% to 75%, P < 0.05) and methane production (from 87 to 218 mg CH₄-COD/reactor/d) than the non-GAC reactor. Bacterial communities were significantly different between the two reactors (P < 0.05). Geobacter, a key indicator for direct interspecies electron transfer (DIET), had the highest differential score (LEfSe analysis), showing significantly higher abundances in the GAC-amended reactor (3.7-8.8%) than the non-GAC reactor (0.9-4.0%). GAC also enriched syntrophic bacteria, Syntrophomonas, Syntrophus and sulfate reducing bacteria. Methanobacterium dominated the archaeal community in the GAC-amended reactor sludge (35.7%) and GAC-biofilm (75.3%), and was less abundant in the non-GAC reactor (9.9%). It indicates that GAC enriched microbial syntrophic partners with potential electro-activities in the anaerobic digestion process.

Stimulation of methane production from benzoate with addition of carbon materials

Huge amounts of wastewater that contain aromatic compounds such as benzene and phenols are discharged worldwide. Benzoate is a typical intermediate in the anaerobic transformation of those aromatic compounds. In this study, electrically conductive carbon-based materials of granulated activated carbon (GAC), multiwalled carbon nanotubes (MwCNTs), and graphite were evaluated for the ability to promote the benzoate degradation. The results showed that 82-93% of the electrons were recovered in CH₄ production from benzoate. The carbon materials stimulated benzoate degradation in the sequence of GAC (5 g/L) > MwCNTs (1 g/L) ~ Graphite (0.1 g/L) > Control. Acetate was the only detected intermediate in the process of benzoate degradation. Taxonomic analyses revealed that benzoate was degraded by Syntrophus to acetate and H₂, which were subsequently converted to methane by Methanosarcina (both acetoclastic methanogens and hydrogenotrophic methanogens) and Methanoculleus (hydrogenotrophic methanogens), and direct interspecies electron transfer (DIET) of Desulfovibrio and Methanosarcina. Thus, these results suggest a method to effectively enhance the removal of aromatic compounds and methane recovery.

TiO2 nanoparticles accelerate methanogenesis in mangrove wetlands sediment

In this study, the response of methane (CH₄) production to the addition of titanium dioxide nanoparticles (TiO₂ NPs) with three types of short-chain fatty acids (sodium acetate, sodium propionate and sodium butyrate) as carbon sources in mangrove sediment was investigated. The results showed that the maximum CH₄ formation rate increased by 45.2%, 32.7% and 48.6% and the maximum cumulative CH₄ production increased by 25.2%, 7.7% and 6.3% with the addition of TiO₂ NPs in the sodium acetate, sodium propionate and sodium butyrate systems, respectively. The microbial community analysis revealed that the electrogenic bacteria Proteiniclasticum and Pseudomonas, butyrate oxidizing bacteria Syntrophomonas and methanogens Methanobacterium and Methanosarcina were significantly enriched in the presence of TiO₂ NPs, indicating that TiO₂ NPs can enhance CH₄ production by stimulating the growth of different species of methanogens and butyrate oxidizing bacteria. The enlarged distance between microbes, the enhanced conductivity of the sediment and the typical microorganisms for direct interspecies electron transfer (DIET) with the addition of TiO₂ NPs suggest that the promoted DIET between distinct microorganisms could be another possible explanation for the improvement in CH₄ production. It can be speculated that a weaker effect on methanogenesis increases under the natural concentration of TiO₂ NPs compared with the experimental conditions; however, the amounts of TiO₂ NPs are increasing enriched in wetland environments. Therefore, the findings of this study increase current knowledge about the effect of nanomaterials on global CH₄ emissions and suggest that the discharge of wastewater containing TiO₂ NPs from the synthesis and incorporation of TiO₂ NPs in customer products needs to be monitored.

Enhanced Anaerobic Digestion by Stimulating DIET Reaction

Since the observation of direct interspecies electron transfer (DIET) in anaerobic mixed cultures in 2010s, the topic “DIET-stimulation” has been the main route to enhance the performance of anaerobic digestion (AD) under harsh conditions, such as high organic loading rate (OLR) and the toxicants’ presence. In this review article, we tried to answer three main questions: (i) What are the merits and strategies for DIET stimulation? (ii) What are the consequences of stimulation? (iii) What is the mechanism of action behind the impact of this stimulation? Therefore, we introduced DIET history and recent relevant findings with a focus on the theoretical advantages. Then, we reviewed the most recent articles by categorizing how DIET reaction was stimulated by adding conductive material (CM) and/or applying external voltage (EV). The emphasis was made on the enhanced performance (yield and/or production rate), CM type, applied EV, and mechanism of action for each stimulation strategy. In addition, we explained DIET-caused changes in microbial community structure. Finally, future perspectives and practical limitations/chances were explored in detail. We expect this review article will provide a better understanding for DIET pathway in AD and encourage further research development in a right direction.

Effects of graphene oxide and reduced graphene oxide on acetoclastic, hydrogenotrophic and methylotrophic methanogenesis

This study describes the effects of graphene oxide (GO) and reduced graphene oxide (rGO) on the acetoclastic, hydrogenotrophic and methylotrophic pathways of methanogenesis by an anaerobic consortium. The results showed that GO negatively affected the hydrogenotrophic and acetoclastic pathways at a concentration of 300 mg/L, causing a decrease of ~ 38% on the maximum specific methanogenic activity (MMA) with respect to the controls lacking GO. However, the presence of rGO (300 mg/L) promoted an improvement of the MMA (> 45%) achieved with all substrates, except for the hydrogenotrophic pathway, which was relatively insensitive to rGO. The presence of either rGO or GO enhanced the methylotrophic pathway and resulted in an increase of the MMA of up to 55%. X-ray photoelectron spectroscopy (XPS) analysis revealed that GO underwent microbial reduction during the incubation period. Electrons derived from substrates oxidation were deviated from methanogenesis towards the reduction of GO, which may explain the MMA decreased observed in the presence of GO. Furthermore, XPS evidence indicated that the extent of GO reduction depended on the metabolic pathway triggered by a given substrate.

Enhanced Anaerobic Digestion of Long Chain Fatty Acid by Adding Magnetite and Carbon Nanotubes

This study investigated the impact of stimulating direct interspecies electron transfer (DIET), by supplementing nano-sized magnetite (nFe3O4, 0.5 g Fe/g VSS) and carbon nanotubes (CNT, 1 g/L), in anaerobic digestion of oleic acid (OA) at various concentrations (0.10 - 4.00 g chemical oxygen demand(COD)/L). Both supplementations could enhance CH4 production, and its beneficial impact increased with increased OA concentration. The biggest improvements of 114% and 165% compared to the control were achieved by nFe3O4 and CNT, respectively, at OA of 4 g COD/L. The enhancement can be attributed to the increased sludge conductivity: 7.1 ± 0.5 (control), 12.5 ± 0.8 (nFe3O4-added), and 15.7 ± 1.1 µS/cm (CNT-supplemented). Dissolved iron concentration, released from nFe3O4, seemed to have a negligible role in improving CH4 production. The excretion of electron shuttles, i.e., humic-like substances and protein-like substances, were found to be stimulated by supplementing nFe3O4 and CNT. Microbial diversity was found to be simplified under DIET-stimulating conditions, whereby five genera accounted for 88% of the total sequences in the control, while more than 82% were represented by only two genera (Methanotrix concilli and Methanosarcina flavescens) by supplementing nFe3O4 and CNT. In addition, the abudance of electro-active bacteria such as Syntrophomonas zehnderi was significantly increased from 17% to around 45%.

Applying potentials to conductive materials impairs High-loading anaerobic digestion performance by affecting direct interspecies electron transfer

In order to illustrate the impact that application of positive or negative potential to conductive materials can have on direct interspecies electron transfer (DIET) and reactor performance under high organic loading rates, three continuous laboratory-scale reactors with carbon-cloth electrodes poised at +0.7 V, -0.7 V (vs. Ag/AgCl) and no-potential were fed high concentrations of ethanol wastewater. While exoelectrogens and methanogens that are capable of DIET were significantly enriched in poised reactors, they performed worse than the non-current control. Volatile fatty acids (VFAs) accumulated more rapidly in the positively then negatively poised reactor, but neither could withstand high-loading rates. These results demonstrate that applying potential to conductive materials had a negative effect on anaerobic digestion under high-loading conditions.

Individual and combined effects of magnetite addition and external voltage application on anaerobic digestion of dairy wastewater

Direct interspecies electron transfer (DIET) between exoelectrogenic fatty acid oxidizers and electrotrophic methanogens plays an important role in keeping the overall anaerobic digestion (AD) process well-balanced. This study examined the individual and combined effects of two different DIET-promoting strategies, i.e., magnetite addition (20 mM Fe) and external voltage application (0.6 V), in continuous digesters treating dairy wastewater. Although the strategies were both effective in enhancing the process performance and stability, adding magnetite had a much greater stimulatory effect. External voltage contributed little to the methane yield, and the digester with magnetite addition alone achieved stable performance, comparable to that of the digester where both strategies were combined, at short hydraulic retention times (down to 7.5 days). Diverse (putative) electroactive microorganisms were significantly enriched under DIET-promoting conditions, particularly with magnetite addition. The overall results suggest that magnetite addition could effectively enhance AD performance and stability by promoting DIET-based electro-syntrophic microbial interactions.

Conductive materials in anaerobic digestion: From mechanism to application

Anaerobic digestion (AD) is an effective strategy combined advantages of maintaining the global carbon flux and efficient energy conversion. Various conductive materials (CMs) have been applied in anaerobic digesters to improve the performance of anaerobic fermentation and methanogenesis, including carbon-based CMs and metal-based CMs. Generally, CMs facilitated the AD thermodynamically and kinetically because they triggered more efficient syntrophic metabolism to increase electron capture capability and accelerate reaction rate as well as enhance the performance of AD stages (hydrolysis-acidification, methanogenesis). Besides, adding CMs into anaerobic digester is benefit to dealing with the deteriorating AD, which induced from temperature variation, acidified working condition, higher H₂ partial pressure, etc. However, few CMs exhibited inhibition on AD, including ferrihydrite, magnesium oxide, silver nanoparticles and carbon black. Inhibition comes from a series of complex factors, such as substrate competition, direct inhibition from Fe(III), Fe(III) reduction of methanogens, toxic effects to microorganisms and mass transfer limitation.

Carbon cloth enhances treatment of high-strength brewery wastewater in anaerobic dynamic membrane bioreactors

Anaerobic dynamic membrane bioreactors (AnDMBRs) can improve the efficiency of organic matter removal during wastewater treatment at a low cost. However, application of AnDMBRs for treatment of high-strength wastewater is usually unsuccessful. This study investigated whether use of conductive carbon cloth as the supporting material in an AnDMBR permits higher organic loading rates for treatment of brewery wastewater than non-conductive polyester cloth. The AnDMBR with carbon cloth operated stably with a COD removal efficiency of 98% even when high concentrations of influent COD (10,000 mg/L) were provided, while the polyester cloth reactor deteriorated when reactors were fed only 5000 mg/L influent COD. Microorganisms capable of direct interspecies electron transfer (DIET), including Geobacter and Methanothrix species, dominated the surface of the carbon cloth. These results demonstrate that carbon cloth provides an excellent supporting material for AnDMBRs by stimulating growth of microorganisms that can directly transport electrons to and from conductive materials.

Effects of carbon nanotube on denitrification performance of Alcaligenes sp. TB: Promotion of electron generation, transportation and consumption

Multi-walled carbon nanotubes (MWCNTs) promote biodegradation in water treatment, but the effect of MWCNT on denitrification under aerobic conditions is still unclear. This investigation focused on the denitrification performance of MWCNT and its toxic effects on Alcaligenes sp. TB which showed that 30 mg/L MWCNTs increased NO₃^- removal efficiency from 84% to 100% and decreased the NO₂^-and N₂O accumulation rates by 36% and 17.5%, respectively. Nitrite reductase and nitrous oxide reductase activities were further increased by 19.5% and 7.5%, respectively. The mechanism demonstrated that electron generation (NADH yield) and electron transportation system activity increased by 14.5% and 104%, respectively. Cell membrane analysis found that MWCNT caused an increase in polyunsaturated fatty acids, which had positive effects on electron transportation and membrane fluidity at a low concentration of 96 mg/kg but caused membrane lipid peroxidation and impaired membrane integrity at a high concentration of 115 mg/L. These findings confirmed that MWCNT affects the activity of Alcaligenes sp. TB and consequently enhances denitrification performance.

Metatranscriptomic Evidence for Magnetite Nanoparticle-Stimulated Acetoclastic Methanogenesis under Continuous Agitation

Conductive nanomaterials have been reported to accelerate methanogenesis by promoting direct interspecies electron transfer (DIET), while their effects seem to vary depending on operational conditions. The present study examined the effects of magnetite nanoparticles (MNPs) on methanogenesis from acetate by soil-derived anaerobic cultures under continuous agitation. We found that MNPs accelerated methanogenesis in agitated cultures, as has been observed previously for static cultures. Metabarcoding of 16S rRNA gene amplicons showed that Methanosarcina substantially increased in the presence of MNPs, while DIET-related Geobacter did not occur. Metagenomic and metatranscriptomic analyses confirmed the predominance of Methanosarcina in MNP-supplemented agitated cultures. In addition, genes coding for acetoclastic methanogenesis, but not those for hydrogenotrophic methanogenesis, were abundantly expressed in the dominant Methanosarcina in the presence of MNPs. These results suggest that MNPs stimulate acetoclastic methanogenesis under continuous agitation.IMPORTANCE Previous studies have shown that conductive nanoparticles, such as MNPs, accelerate methanogenesis and suggested that MNPs facilitate DIET between exoelectrogenic bacteria and methanogenic archaea. In these methanogens, electrons thus obtained are considered to be used for hydrogenotrophic methanogenesis. However, the present work provides evidence that shows that MNPs accelerate DIET-independent acetoclastic methanogenesis under continuous agitation. Since most of previous studies have examined effects of MNPs in static or weakly agitated methanogenic cultures, results obtained in the present work suggest that hydraulic conditions definitively determine how MNPs accelerate methanogenesis. In addition, the knowledge obtained in this study is useful for engineers operating stirred-tank anaerobic digesters, since we show that MNPs accelerate methanogenesis under continuous agitation.