Energy efficiency and net energy prediction of feed in laying hens

Optimizing broiler growth performance through balanced net energy, standard ileal digestible lysine, and amylose/amylopectin ratios: a Box-Behnken response surface approach

This study investigated the effects of net energy (NE), standard ileal digestible lysine (SID Lys), and amylose/amylopectin (AM/AP) ratios on broiler growth performance using a Box-Behnken design. A total of 936 male Arbor Acres Plus broilers (15-35 days post-hatch) were allocated to thirteen treatments with three factors at three levels including NE (2,000, 2,250, 2,500 kcal/kg), SID Lys (1.00 %, 1.20 %, 1.40 %), and AM/AP ratios (0.17, 0.22, 0.27, composed of different ratios of pea starch and waxy corn starch). Growth performance was measured weekly. At the growth stage of 15-20 d, quadratic relationships between dietary NE (P = 0.038), SID Lys (P = 0.010), AM/AP ratios (P = 0.021), and broiler 20 d body weight (BW), with optimization occurring at 2,303 kcal/kg NE, 1.24 % SID Lys, and an AM/AP ratio of 0.22. The 15-25 d feed-to-gain ratio (F/G) decreased linearly with increasing dietary NE (P = 0.038) and SID Lys (P = 0.010). At the growth stage of 21-27 d, linear increases in broiler 27 d BW (P = 0.007) and 21-27 d body weight gain (BWG) (P = 0.013) were observed with higher dietary SID Lys levels, reaching a peak at 2,500 kcal/kg NE, 1.40 % SID Lys, and an AM/AP ratio of 0.17. The 21-27 d F/G decreased linearly with increasing dietary NE (P < 0.001) and SID Lys (P < 0.001) levels. At the 28-35 d growth stage, a significant interaction between NE and SID Lys levels was observed for 35 d BW (P = 0.016) and 28-35 d BWG (P = 0.007). At 2,500 kcal/kg NE, both 35 d BW and 28-35 d BWG increased with higher SID Lys, whereas at 2,000 kcal/kg NE, they initially increased and then decreased as SID Lys levels rose. There was a significant interaction effect of NE and AM/AP ratio on broiler 28-35 d BWG (P = 0.017). Further quadratic curve fitting of 28-35 d BWG and 15-35 d BWG against dietary SID Lys/NE ratio revealed that 28-35 d BWG and 15-35 d BWG were optimized at dietary SID Lys/NE of 5.68 and 5.80 mg/kcal, respectively. These data indicate balancing dietary NE and SID Lys can optimize broiler growth, while lowering the dietary AM/AP ratio further enhances growth performance, likely due to improved starch digestibility and energy release dynamics. This study provides actionable insights for precision nutrition strategies in broiler production.

Guanidinoacetic acid in laying hen diets with varying dietary energy: Productivity, antioxidant status, yolk fatty acid profile, hepatic lipid metabolism, and gut health

This study aimed to investigate the effects of GAA supplementation in diets differing in ME levels on productive performance, egg quality, blood parameters, yolk fatty acid profiles, hepatic expression of genes related to lipid metabolism, gut morphology, and nutrient digestibility in laying hens during their post-peak production phase. Over a 12-week period (52-64 weeks of age), 288 laying hens were randomly assigned to 6 treatments. Each treatment consisted of 8 replicates, with 6 hens per replicate. The experimental treatments were assigned in a 2 × 3 factorial arrangement, comprising 2 levels of dietary ME (a recommended level and a low level, the latter characterized by a 100 kcal/kg reduction in ME) and 3 levels of GAA supplementation (0, 0.6, and 1.2 g/kg). The results showed significant interaction effects (P < 0.05) between GAA supplementation and dietary ME levels on laying rate, egg mass, feed conversion ratio, crude protein digestibility, and AMEn. In hens fed the low-ME diet, GAA supplementation, particularly at 1.2 g/kg, significantly improved laying performance. Moreover, at both 0.6 and 1.2 g/kg under low-ME conditions, GAA significantly enhanced crude protein digestibility and AMEn. The low-ME diet was associated with decreased expression of key lipogenic genes, including sterol regulatory element-binding transcription factor 1 (SREBF1), acetyl-coenzyme A carboxylase (ACC), and fatty acid synthase (FAS), alongside increased expression of genes involved in fatty acid oxidation, such as peroxisome proliferator-activated receptor alpha (PPARα) and carnitine palmitoyltransferase 1 (CPT1). Regardless of ME content, GAA supplementation linearly improved eggshell strength, enhanced the polyunsaturated-to-saturated fatty acid ratio in the yolk, elevated serum levels of creatine and total antioxidant capacity, improved intestinal morphology, and increased radical scavenging activity in the yolk (P < 0.05). Furthermore, GAA supplementation linearly increased the relative mRNA expression of several metabolic genes, including SREBF1, ACC, PPARα, and ApoB (P < 0.05). In conclusion, GAA supplementation enhanced productive performance in low-ME diets and exerted positive effects on egg characteristics and lipid metabolism, regardless of dietary ME content.

Multiprotease supplementation in laying hen diets: Impact on performance, egg quality, digestibility, gut histomorphology, and sustainability

Laying hen responses to supplemental multiprotease on performance, egg quality, digestibility, gut histomorphology, nitrogen excretion, and economic performance of laying hens until 37 weeks of age were investigated. A total of 189 25-week-old Hy-Line Brown hens were housed in enriched cages (7 birds/cage) and randomly allocated to 1 of 3 diets with 9 replicates per treatment. Dietary treatments included: an adequate positive control- PC [met the breed and age standards for crude protein (CP) and amino acids (AA)]; negative control- NC (90 % CP and AA requirement); and NC supplemented with multiprotease - NCMP. Multiprotease was supplemented at 300 g/t of feed equating to 2400 U/kg. Egg production rate and feed intake were not altered (P > 0.10) by the dietary treatments. Between 25 and 37 weeks of age (woa), the NCMP diet reduced the feed conversion ratios by 3 % (1.91 vs 1.97; P < 0.05) in comparison to the NC diet while improving (P < 0.05) the egg weights by 3 % (58.56 vs 56.68); Haugh units by 2 % (91.78 vs 90.20); and breaking strength by 1 % (4.65 vs 4.61). Marginally intensified yolk color and albumen height (P < 0.10) were also observed with the NCMP diet. Furthermore, the NCMP diet marginally improved the villus height, width, and absorptive surface area (P < 0.10) relative to NC. Multiprotease-supplemented NCMP diet improved (P < 0.05) the digestibility of crude protein; and amino acids including lysine, methionine, phenylalanine, isoleucine, leucine, glutamine, tyrosine, relative to the NC diet. Lowered AA/CP diets (NC and NCMP) reduced the N excreted and feed costs (P < 0.05) relative to the PC diet. Multiprotease increased the returns on investment (P < 0.10), and nitrogen retained in egg (P < 0.05) from 25- 37woa. Conclusively, feeding reduced CP/AA diets maintained the egg production rate while reducing the N excreted and feed costs. Multiprotease modulation of ileal absorptive capacity and nutrient digestibility is linked to improved feed efficiency, egg quality, and revenue estimates of supplemented hens.

Metabolizable and net energy evaluation of corn, soybean meal, and wheat bran in growing male pheasants

The apparent metabolizable energy(AME), AME corrected to zero-nitrogen retention(AMEn) and net energy (NE) values of corn, soybean meal and wheat bran were determined in growing male pheasants with reference diet substitution method. Reference diet was formulated according to standard Pheasants requirement, and test diets contained 40 % of corn, 20 % of soybean meal and 30 % of the wheat bran samples of thereference diet. Ninety male pheasants at the age of 12 wk with similar body weights were randomly divided into four groups. The heat production and energy metabolism of birds were measured in open-circuit respiratory chambers with 6 replicates (4 birds per replicate) per diet in a randomized design. Birds were fed experimental diets for 6 D in the chamber as adaptation. During the following 3 D, feed intake, metabolizable energy value, nitrogen balance, energy balance, O2 consumption, CO2 production, and energy efficiency were determined. Pheasants were allowed free access to feed under controlled environmental conditions. Feces were collected using respiratory calorimetry. The AME values of corn, soybean meal and wheat bran were 14.62 MJ/kg, 10.62 MJ/kg and 7.57 MJ/kg DM, respectively. The corresponding AMEn values were 14.71 MJ/kg, 10.64 MJ/kg and 7.25 MJ/kg DM, respectively. The NE values were 11.20 MJ/kg, 7.02 MJ/kg, and 6.19 MJ/kg DM, respectively. The NE:AME ratios of corn, soybean meal and wheat bran were 77.61 %, 65.68 % and 85.17 %, respectively. The NE:AMEn ratios of corn, soybean meal and wheat bran were77.22 % and 66.89 % and 84.76 %, respectively. The AME, AMEn and NE values of corn were higher than the other two samples.

Interaction between energy level and starch:fat ratio on intestinal energy metabolism of layer pullets

During the growing period, the gastrointestinal tract of layer pullets is not yet well developed and may be susceptible to dietary energy level. The energy level and composition might impact the intestinal energy metabolism of layer pullets. To test this hypothesis, a total of 480 "Jing Tint 6" layer pullets were used in an 8-week study and allocated to 4 groups, each consisting of 8 replicates, with 15 birds per replicate. Pullets were treated with low or high starch:fat ratios (LS, 10:1; HS, 20:1) in a 2 × 2 factorial arrangement with regular energy (RE, 11.85 and 11.68 MJ/kg for birds from 6 to 10 weeks of age and 11-14 weeks of age, respectively) or low energy (LE, 0.55 MJ/kg lower than RE) levels. A significant interaction (P < 0.05) showed that HS increased glandular stomach weight and the jejunal villus length to crypt depth ratio (VCR) in LE diets, but decreased these parameters in RE diets. Dietary energy reduction impaired energy metabolism in the ileum (P < 0.05) mainly via decreasing the gene expression of enzymes involved in the tricarboxylic acid (TCA) cycle (α-ketoglutarate dehydrogenase complex [α-KGDH]; isocitrate dehydrogenase (NAD (+) [IDH] catalytic; citrate synthase [CS]) and adenosine triphosphate (ATP) synthesis, reducing contents of phosphoenolpyruvate (PEP) and adenylate energy charges (AEC) and down-regulating the adenosine monophosphate-activated protein kinase (AMPK) pathway. HS stimulated AMPKα phosphorylation, increased protein abundance of peroxisome proliferator activated-receptor gamma coactivator 1α (PGC1α) and improved contents of amino acids (aspartate, glutamate, glutamine, alanine and threonine) and malate in the ileum regardless of energy levels (P < 0.05). By an interaction (P < 0.05), the transition from LS to HS diets up-regulated ileal gene expression of AMPKα1 and decreased content of adenosine monophosphate (AMP), accompanied by higher AEC but only in birds fed with LE diets. Collectively, these results suggest that low energy feeding may not be enough for maintaining intestinal energy homeostasis in layer pullets and emphasizes the importance of a relatively high starch:fat ratio in restoring energy metabolism in the ileum.

OA-ICOS-Based Oxygen and Carbon Dioxide Sensors for Field Applications in Gas Reflux Chicken Coops

To facilitate the effective assessment of respiratory entropy during poultry breeding, a novel oxygen (O2) and carbon dioxide (CO2) sensor was developed based on the off-axis integrated cavity output spectroscopy technique, featuring effective absorption optical paths of 15.5 m and 8.5 m, respectively. The sensor employs integrated environmental control technology, substantially enhancing detection precision. To improve the instrument's response speed, the miniaturization of the cavity and structural optimization were implemented, achieving a rapid response time of merely 6.22 s, addressing the stringent requirements for quick responsiveness in poultry respiration thermometry research. A signal processing model tailored for on-site applications was designed, boosting the system's signal-to-noise ratio by 4.7 times under complex environmental noise conditions. Utilizing Allan variance analysis, the sensor's detection limits for O2 and CO2 were ascertained to be 2.9 ppm and 7.4 ppb, respectively. A 24-h field application test conducted in Gongzhuling demonstrated that the sensor's results align with the respiratory characteristics of poultry under normal physiological conditions, validating its extensive potential for application in respiratory analysis, environmental monitoring, and industrial sectors.

Poultry Nutrition: Achievement, Challenge, and Strategy

Poultry, a vital economic animal, provide a high-quality protein source for human nutrition. Over the past decade, the poultry industry has witnessed substantial achievements in breeding, precision feeding, and welfare farming. However, there are still many challenges restricting the sustainable development of the poultry industry. First, overly focused breeding strategies on production performance have been shown to induce metabolic diseases in poultry. Second, a lack of robust methods for assessing the nutritional requirements poses a challenge to the practical implementation of precision feeding. Third, antibiotic alternatives and feed safety management remain pressing concerns within the poultry industry. Lastly, environmental pollution and inadequate welfare management in farming have a negative effect on poultry health. Despite numerous proposed strategies and innovative approaches, each faces its own set of strengths and limitations. In this review, we aim to provide a comprehensive understanding of the poultry industry over the past decade, by examining its achievements, challenges, and strategies, to guide its future direction.

Broiler Age Differently Affects Apparent Metabolizable Energy and Net Energy of Expanded Soybean Meal

Accurately determining the energy values of ingredients is crucial for meeting energy requirements and achieving maximum production performance of animals. This study was conducted to measure the available energy values of three expanded soybean meals (ESBMs) for Arbor Acres male broilers from 14 to 16 day and 28 to 30 day using the difference method. A corn-soybean basal diet was formulated, and test diets were developed with 25% ESBMs as substitutes for energy-yielding ingredients. A completely randomized design was used for determining heat production and energy balance of broilers in 12 open-circuit respiration chambers, with six replicates per group. Prior to measurement, four (14 to 16 day) or two (28 to 30 day) birds per chamber were given a 4-day adaption to diets and chambers. The period lasted for 3 days to determine the apparent metabolizable energy (AME), nitrogen balance, gas exchanges, and heat production. Broilers fed test diets with 25% ESBM exhibited higher nitrogen intake (p < 0.05), nitrogen excreta (p < 0.05), and increased energy deposition as protein irrespective of age (p < 0.05). Furthermore, results showed that AME, nitrogen corrected AME (AMEn), and net energy (NE) values of 3 ESBMs averaged 10.48, 8.93, and 6.88 MJ/kg for broilers from 14 to 16 day, while averaged 11.91, 10.42, and 6.43 MJ/kg for broilers from 28 to 30 day. Broilers from 28 to 30 day showed significantly higher AMEn values but lower NE/AME values of ESBMs compared with those from 14 to 16 day (p < 0.05). Therefore, age-dependent energy values of a single ingredient should be considered in feed formulations to optimize economic returns.

Integrated omics analysis reveals a correlation between gut microbiota and egg production in captive African penguins (Spheniscus demersus)

The egg production of captive African penguins differs considerably between individuals. An understanding of the physiological differences in African penguins with relatively greater and lesser egg production is meaningful for the captive breeding program of this endangered species. The objective of this study was to investigate differential microbial composition and metabolites in captive African penguins with different egg production. Fecal samples were collected from captive female African penguins during the breeding season. The results of 16 S rRNA gene sequencing showed that African penguins with different egg production had similar microbial diversities, whereas a significant difference was observed between their microbial community structure. African penguins with relatively greater egg production exhibited a higher relative abundance of Alphaproteobacteria, Rhizobiales, Bradyrhizobiaceae, Bradyrhizobium and Bosea. Meanwhile, penguins with relatively lesser egg production had an increased proportion of Klebsiella and Plesiomonas. We further identified a total of 1858 metabolites in female African penguins by liquid chromatography-mass spectrometry analysis. Among these metabolites, 13 kinds of metabolites were found to be significantly differential between African penguins with different egg production. In addition, the correlation analysis revealed that the egg production had significant correlations with most of the differential microbial bacteria and metabolites. Our findings might aid in understanding the potential mechanism underlying the phenomenon of abnormal egg production in captive African penguins, and provide novel insights into the relationship between gut microbiota and reproduction in penguins.

Prediction of net energy of feeds for broiler chickens

Net energy (NE) enables the prediction of more accurate feed energy values by taking into account the heat increment which is approximately 25% of apparent metabolizable energy (AME) in poultry. Nevertheless, application of NE in poultry industry has not been practiced widely. To predict the NE values of broiler diets, 23 diets were prepared by using 13 major ingredients (wheat, corn, paddy rice, broken rice, cassava pellets, full-fat soybean, soybean meal, canola meal, animal protein, rice bran, wheat bran, palm kernel meal and palm kernel oil). The diets were formulated in order to meet the birds' requirements and get a wide range of chemical compositions (on DM basis; 33.6% to 55.3% for starch; 20.8% to 28.4% for CP, 2.7% to 10.6% for ether extract [EE] and 7.0% to 17.2% for NDF), with low correlations between these nutrients and low correlations between the inclusion levels of ingredients allowing for the calculation of robust prediction equations of energy values of diets or ingredients. These diets were fed to Ross 308 broilers raised in 12 open-circuit respiratory chambers from 18 to 23 d of age (4 birds per cage) and growth performance, diet AME content and heat production were measured, and dietary NE values were calculated. The trial was conducted on a weekly basis with 12 diets measured each week (1 per chamber), 1 of the 23 diets (reference diet) being measured each week. Each diet was tested at least 8 times. In total, 235 energy balance data values were available for the final calculations. Growth performance, AME (15.3 MJ/kg DM on average) and AME/GE (79.4% on average) values were as expected. The NE/AME value averaged 76.6% and was negatively influenced by CP and NDF and positively by EE in connection with efficiencies of AME provided by CP, EE and starch for NE of 73%, 87% and 81%, respectively. The best prediction equation was: NE = (0.815 × AME) - (0.026 × CP) + (0.020 × EE) - (0.024 × NDF) with NE and AME as MJ/kg DM, and CP, EE and NDF as % of DM. The NE prediction equations from this study agree with other recently reported equations in poultry and are suitable for both ingredients and complete feeds.

Re-evaluation of recent research on metabolic utilization of energy in poultry: Recommendations for a net energy system for broilers

Different energy systems have been proposed for energy evaluation of feeds for domestic animals. The oldest and most commonly used systems take into account the fecal energy loss to obtain digestible energy (DE), and fecal, urinary and fermentation gases energy losses to calculate metabolizable energy (ME). In the case of ruminants and pigs, the net energy (NE) system, which takes into account the heat increment associated with the metabolic utilization of ME, has progressively replaced the DE and ME systems over the last 50 years. For poultry, apparent ME (AME) is used exclusively and NE is not yet used widely. The present paper considers some important methodological points for measuring NE in poultry feeds and summarizes the available knowledge on NE systems for poultry. NE prediction equations based on a common analysis of three recent studies representing a total of 50 complete and balanced diets fed to broilers are proposed; these equations including the AME content and easily available chemical indicators have been validated on another set of 30 diets. The equations are applicable to both ingredients and complete diets. They rely primarily on an accurate and reliable AME value which then represents the first limiting predictor of NE value. Our analysis indicates that NE would be a better predictor of broiler performance than AME and that the hierarchy between feeds is dependent on the energy system with a higher energy value for fat and a lower energy value for protein in an NE system. Practical considerations for implementing such an NE system from the commonly used AME or AMEn (AME adjusted for zero nitrogen balance) systems are presented. In conclusion, there is sufficient information to allow the implementation of the NE concept in order to improve the accuracy of feed formulation in poultry.

Prediction equations of the metabolizable energy in corn developed by chemical composition and enzymatic hydrolysate gross energy for roosters

Two experiments were conducted to establish the prediction equations for AME and TME of corn based on chemical composition and enzymatic hydrolysate gross energy (EHGE) in roosters. In experiment 1, eighty 32-wk-old Hy-line Brown roosters with an average body weight of 2.55 ± 0.21 kg were randomly assigned to 10 diet treatments in a completely randomized design to determine AME and TME by the force-feeding method. Each treatment had 8 replicates with 1 bird per replicate. The 10 test diets used in the experiment were formulated with corn (including 96.10%) as the sole source of energy. In experiment 2, the EHGE of 14 corn samples was measured by the computer-controlled simulated digestion system (CCSDS) with 5 replicates of each sample. The average AME and TME values of corn were 14.58 and 16.46 MJ/kg DM, respectively. The EHGE of 14 corn samples ranged from 14.66 to 15.89 (the mean was 15.24) MJ/kg DM. The best-fit equations for corn based on chemical composition were AME (MJ/kg DM) = 14.5504 + 0.1166 × ether extract (EE) + 0.5058 × Ash - 0.0957 × neutral detergent fiber (NDF) (R2 = 0.8194, residual standard deviation (RSD) = 0.0860, P < 0.01) and TME (MJ/kg DM) = 16.0625 + 0.1314 × EE + 0.4725 × Ash - 0.0872 × NDF (R2 = 0.7867, RSD = 0.0860, P < 0.01). The best-fit equations for corn based on EHGE were AME (MJ/kg DM) = 7.8883 + 0.4568 × EHGE (R2 = 0.8587, RSD = 0.0693, P < 0.01) and TME (MJ/kg DM) = 10.0099 + 0.4228 × EHGE (R2 = 0.8720, RSD = 0.0608, P < 0.01). The differences between determined and predicted values from equations established based on EHGE were lower than those observed from chemical composition equations. These results indicated that EHGE measured with CCSDS could predict the AME and TME of corn for roosters with high accuracy.

The future of feed formulation for poultry: Toward more sustainable production of meat and eggs

Current methods for feed formulation are based on minimizing costs, not maximizing profits. Complex models of bird growth and reproduction as functions of genetic, feed and other environmental variables are being developed, but their adaptation has been slow. The development of profit maximizing models will evolve to center on the production functions of broilers and layers. The production functions are the relationship between the value of products (mainly meat and eggs) and the cost of feed. The production function is the tool used to maximize profits subject to all the various inputs, not just feed or nutrition. The production function is subject to the law of diminishing returns. The most profitable output levels are those where the marginal value (price) of the meat or eggs is just equal to the marginal cost of the inputs including feed, housing, processing and all other costs. Anything that affects the production function, bird genetics, feed quality, housing and environment, will be considered to maximize profits for the poultry firm. The profit maximizing models of poultry firms will improve as various technical improvements are made: metabolizable energy to describe ingredients will evolve to net energy systems that consider that the heat production (and therefore energetic efficiency) of broilers is different depending on the ingredients used to formulate the feed and the environmental temperatures under which they are reared. Amino acid needs will include a method to find the birds' needs for the non-essential amino acids. "Digestible" amino acid assays will differentiate between digestion and absorption to best balance various sources. The carbohydrate fractions of feed ingredients will be determined to optimize the use of exogenous enzymes. The value of meat and egg co-products will reduce overall costs (e.g., organic fertilizer for crop enhancement). Future profit maximizing production models will be ever evolving processes where field conditions and results are continually being utilized to re-calibrate the technical models so that the management team can use them with cost and return projections to decide on the best choices of inputs and outputs.

Energy utilization and requirement of broiler breeders during the production phase

This study aimed to evaluate energy utilization and propose models for metabolizable and net energy requirements in broiler breeders during the egg production phase. Sixty Cobb500 broiler breeders aged between 29 and 65 wk were randomly assigned to 3 feeding levels. At each age, 6 birds were adapted for 8 d to 3 levels of metabolizable energy intake (MEi), established based on the amount of feed allocated: 1) the amount of feed recommended in the guideline, 2) 25% above, and 3) 25% below. The birds were housed in respirometry chambers for 6 d (1 adaptation, 4 feeding state, 1 fasting) to measure oxygen consumption and carbon dioxide production to calculate heat production (HP) and fasting HP (FHP). Daily measurements of feed intake, egg weight, egg production, and total excreta were recorded. Variables of MEi, HP, and retained energy (RE) in the egg were calculated, while RE in the body and its partitioning into fat and protein in the egg and body were calculated from MEi, total HP (THP), and RE in the egg. Statistical analysis involved linear regression of multiple factors with MEi and age (categorical) as the independent variables. Pearson correlation analysis was conducted to investigate the relationship between visceral mass and the evaluated variables. The study proposed mixed models for developing models of energy requirements for both metabolizable (ME) and net systems (NE). The study found that FHP (average 259 ± 20.08 kJ/kg0.75*d) remained constant throughout the production cycle regardless of the MEi level (P > 0.05). The efficiency of energy utilization for depositing protein and fat in the body changed with the bird's age. The lower error model was considered to select ME requirements for maintenance, egg, and gain efficiencies, disregarding the effect of age. The efficiencies were 0.89, 0.78, and 0.80 for maintenance, gain, and egg production, respectively. The NE was unaffected by age and showed a lower error than the ME model. The NE system was found to be more accurate in expressing the energy requirements of broiler breeders.

Effects of dietary protein levels on performance, nitrogen excretion, and odor emission of growing pullets and laying hens

The objective of this study was to determine the effects of dietary crude protein (CP) levels on production performance, nitrogen balance, and odor emission of excreta in growing pullets and laying hens from 13 to 32 wk of age. Two hundred and forty pullets (Hy-Line Brown) were randomly assigned to 1 of 4 dietary groups with 10 replicates per group, and 6 birds per replicate. Experimental diets were formulated to contain 4 graded CP levels in the diets of pullets ranging from 180, 160, 140, and 120 g/kg of diet during 13 to 18 wk (phase 1) and in the diets of laying hens from 190, 170, 150, and 130 g/kg of diet during 19 to 32 wk (phase 2). The limiting amino acids including lysine, methionine, and threonine were supplemented to maintain constant equal amino acid concentrations in all experiment diets. In phase 1, decreasing dietary CP levels did not affect growth performance but increased (linear and quadratic effect, P < 0.05) the relative abdominal fat contents and triglyceride concentration in serum samples. High-density lipoprotein cholesterol in serum samples decreased as the CP levels decreased in the diets of pullets. Dietary CP levels quadratically increased (P < 0.05) the villus height and the villus height to crypt depth ratio but did not affect tibia traits and relative organ weights in pullets at 18 wk. Apparent digestibility of dry matter and ether extract increased with decreasing dietary CP levels in pullets. Graded CP levels linearly increased the digestibility of dry matter, CP, and ether extracts but lowered that of crude ash in laying hens. Nitrogen excretion was linearly decreased (P < 0.05) as the dietary CP levels decreased in both pullets and laying hens. Dietary CP levels only affected carbon dioxide emission in pullets. In phase 2, dietary CP levels did not affect growth performance and the ages at first egg laying and to reach 50% egg production in laying hens. However, egg weights were decreased (linear and quadratic effect, P < 0.05) as the dietary CP level decreased in laying hens. Increasing dietary CP levels increased Haugh unit at 26 wk but lowered corticosterone concentrations in yolk samples at 22 wk. Collectively, this study shows that dietary CP levels could be decreased to reduce nitrogen excretion without adverse effects on performance and egg quality of growing pullets and laying hens.

Implementation of life cycle analysis on green tea process

This study examines the life cycle analysis of the manufacturing of 1 kg of green tea using various disposal techniques, including landfill procedure, incineration, and modification of green tea waste as an adsorbent for heavy metal removal. OpenLCA is used to produce the evaluation. To identify the objectives and scope, inventory analysis, effect, and interpretation, the assessment process corresponds to ISO 14044 of 2006. AGRIBALYSE version 3 is the database used to evaluate the environmental effects. A reference unit called a DALY is used to study the environmental impact. For the LCA of green tea, there were four main effect categories that were taken into consideration: human carcinogenic toxicity, human non-carcinogenic toxicity, global warming (human health), and fine particle creation. The outcome demonstrates that processing 1 kg of green tea waste has an environmental effect that is around 63% greater than incinerating it and roughly 58% higher than dumping it in a landfill. However the ecology is more affected by the adsorption process than by landfill and incineration of green tea waste. Even yet, if the preparation is done in bulk, the process can be improved by altering the adsorption of green tea waste.

Determination of metabolisable and net energy contents of corn fed to Arbor Acres broilers and Beijing You chickens

This study was done to compare the energy and nutrient utilisation of corn in Arbor Acres (AA) broilers and Beijing You (BJY) chickens. BJY chickens with the same age as AA broilers were named BJY1 chickens, and with the same body weight as AA broilers were named BJY2 chickens. Three groups of broilers (36 male AA broilers, 72 male BJY1 chickens, and 36 male BJY2 chickens), 2 treatments per group, 6 replicates per treatment, 3 chickens or 6 chickens per replicate. During each period, birds were fed in chambers for 11 days, including 5 days for adaptation to the feed, 3 days for excreta and gas data collection and another 3 days for fasting were recorded. Results showed that the fasting heat production (FHP) of AA, BJY1 and BJY2 chickens gradually stabilised after fasting for 72 h, the FHP of AA, BJY1 and BJY2 chickens were 486.54, 536.22 and 548.90 KJ/kg BW^0.70 /day respectively. AA broilers had significantly lower (p < 0.01) apparent total tract digestibility (ATTD) of starch in corn than that of BJY1 and BJY2 chickens, whereas there were no significant differences (p > 0.05) observed in ATTD of dry matter, crude protein, ether extract and crude fibre. The apparent metabolisable energy (AME) values of corn in AA, BJY1 and BJY2 chickens were 16.18, 16.81, and 16.39 MJ/kg dry matter (DM) and the corresponding nitrogen-corrected AME (AMEn) values were 15.71, 16.38 and 15.99 MJ/kg DM respectively. The net energy (NE) values of corn in AA, BJY1 and BJY2 chickens were 12.03, 12.28 and 11.97 MJ/kg DM respectively. In conclusion, BJY chickens had a higher maintenance energy requirement than that of AA broilers, and AA broilers of the same age and weight as BJY chickens showed no significant differences in AME, AMEn and NE values of corn.

Effect on growth performance, carcass traits, and myostatin gene expression in Aseel chicken fed varied levels of dietary protein in isocaloric energy diets

A study was conducted to assess the effect of feeding different crude protein (CP) levels with isocaloric metabolizable energy (ME) diets on growth performance, carcass traits, and myostatin (MSTN) gene expression of Aseel chicken during 0 to 16 weeks of age. A total of two hundred and ten day-old Aseel chickens were randomly allotted to seven dietary treatment groups. Each group had thirty chicks distributed into three replicates of ten chicks in each. Experimental diets were formulated to have varying levels of CP, viz. 18.5, 19.0, 19.5, 20.0, 20.5, 21.0, and 21.5%, with isocaloric energy of 2800 kcal ME/kg diets of mash feed fed to birds in a completely randomized design. Different CP levels had a significant effect (P < 0.05) on the body weight gain (BWG) of Aseel chicken. At the end of 16 weeks of age, the group fed 21% CP gained 223.53 g more than the lowest CP (18.5%)-fed group. The different CP levels did not significantly (P > 0.05) influenced the feed intake of all treatment groups, but numerically highest feed intake was observed in the lowest CP (18.5%)-fed group. However, significant differences in feed efficiency (FE) appeared from the 13th week only with the 21.0% CP-fed group showing the best FE until the 16th week (3.86 to 4.06). The maximum dressing % (70.61) was observed by the 21% CP-fed group. The CP 21% diet down-regulated the MSTN gene expression in breast muscle tissue to 0.07 folds when compared to the diet of CP 20%. The best economical coordinates for maximum performance for Aseel chicken appeared to be CP of 21% and ME of 2800 kcal/kg to achieve the best FE of 3.86 at the earliest age of 13 weeks. In conclusion, 21% CP in an isocaloric diet of 2800 kcal ME/kg, in Aseel chickens, would be optimum to improve the growth performance at maximum in terms of BWG and FE up to 16 weeks of age.

Comparative study of apparent metabolizable energy and net energy values of dephenolized cottonseed proteins for laying hens

Optimizing the energy utilization of nutrients and ensuring maximum benefits are continuous goals for livestock producers. The net energy (NE) value of feed reflects its nutritional value in the precision feeding system. An experiment was conducted to determine the apparent metabolizable energy (AME) and NE values of 3 types of dephenolized cottonseed protein (DCP) for Hy Line Brown hens aged 42 to 45 weeks using the reference diet substitution method. A reference diet based on corn soybean meal was used to meet the nutritional needs of Hy Line Brown laying hens. To render the crude protein and energy values of the 3 test diets similar, 10.5%, 12%, and 16% of the gross energy yielding ingredients from the reference diet were replaced with DCP 1, DCP 2, and DCP 3, respectively. The birds were fed 4 diets during a 7-d adaptation period. After the dietary adaptation period, 2 birds per replicate from each treatment group were placed in an individual open circuit respiratory calorimetry chamber for a 3-d experimental period. Daily O₂ consumption and CO₂ production were recorded, and excreta samples were collected. The AME values of DCP 1, DCP 2, and DCP 3 were 3,049.05, 2,820.13, and 2,982.31 kcal/kg of dry matter (DM), respectively. The NE values of DCP 1, DCP 2, DCP 3 were 1,475.77, 1,910.31, and 1,905.37 kcal/kg of DM, respectively, and the NE:AME ratios were 48.40%, 67.74%, and 63.89%, respectively. Our data show that the AME value of DCP does not reflect the nutritional value of the feed. The NE value of DCP with a high ME value was not necessarily high.

Analysis of energy consumption in poultry management for table egg production in Nigeria

Energy audit and mass flow studies of commercial agricultural systems are increasingly becoming of utmost importance, due to high operation costs and dependence on energy. This research was designed to study energy input, output and efficiency for daily table egg production from commercially managed poultry birds. Three commercially operated poultry farms in Ibadan, Nigeria were visited for assessment of management procedures, data collection, equipment observation and personnel interview. The energy required for each management procedure was calculated from standard methods. Each farm housed average of 25,000 actively laying birds and had average daily egg production of 21,250 egg pieces. This amounted to 1169 kg egg and 3000 kg faecal materials production per day from the average energy input of 122,461.12 MJ/day. The highest energy consumption was biological energy which resulted from daily feed consumption of 3000 kg at the rate of 120 g per bird per day. This made up 83.81% of the total energy consumed. These resulted in an energy consumption ratio of 1.05, energy productivity of 0.034 kg/MJ, specific energy of 29.29 MJ/kg and net energy of 6,569.09 MJ/day, respectively. Faecal materials constituted the bulk of the output from the system. Making use of the faecal material in its treated form for the production of feed components would reduce energy costs, increase farmers’ net income and also encourage environmentally efficient processes.

Internal causality in agri-food Life Cycle Assessments: Solving allocation problems based on feed energy utilization in egg production

Physical allocation in Life Cycle Assessment (LCA) should, ideally, be based on underlying causal relationships. While both cause-oriented and effect-oriented causality referred to in LCA literature are forms of external causality, internal causality addresses the actual flow of materials and inputs in a system - in other words, the real behaviour of the system under study. While a number or examples of allocation based on physical causality have been used in poultry LCAs, none of these represent the internal causality (the actual biological processes) in egg production. The current study remedies that gap by proposing such a method. Agri-food LCAs, in particular LCAs of livestock production, were used to identify existing physical allocation approaches consistent with internal causality. The most commonly used approach was found to be based on the allocation of feed energy to support the various physiological functions of the livestock species. A feed energy - Metabolizable Energy (ME) - utilization model for allocation in egg production LCAs is hence similarly proposed. Using the inventory of a previous LCA study of egg production in Canada, allocation ratios for eggs and spent hens were developed. Feed utilization models specific to each unit process were identified. The overall differences between ME utilization (∼95% eggs, 5% spent hens) and gross chemical energy content (92% eggs, 8% spent hens) for allocation were relatively small. Scenario analysis, however, showed that the allocation ratios can be considerably different if the causal relationship is interpreted differently. Differences over ∼20% was seen in a scenario which did not allocate between the co-products of each unit process in the system, but rather to the products at the end of a biological causal chain straddling multiple unit processes. The proposed approach is consistent with the interpretation of LCA as a natural sciences framework, and with the ISO 14044 multi-functionality hierarchy, because it reflects actual biological causality in egg production systems. The study results also underscore that practitioners should not only clearly justify their choice of allocation strategy, but also describe its application in detail, since small differences in methods can result in divergent outcomes.

Methodologies for energy evaluation of pig and poultry feeds: A review

The cost of feed represents an important part of the total cost in swine and poultry production (>60%) with energy accounting for at least 70% of feed cost. The energy value of ingredients or compound feeds can be estimated as digestible (DE), metabolisable (ME) and net energy (NE) in pigs and ME and NE in poultry. The current paper reviews the different methods for evaluating DE, ME and NE of feeds for monogastric animals and their difficulties and limits, with a focus on NE. In pigs and poultry, energy digestibility depends on the chemical characteristics of the feed, but also on technology (pelleting, for instance) and animal factors such as their health and body weight. The ME value includes the energy losses in urine that are directly dependent on the proportion of dietary N excreted in urine resulting in the concept of ME adjusted for a zero N balance (MEn) in poultry. For poultry, the concept of true ME (TME, TMEn), which excludes the endogenous fecal and urinary energy losses from the excreta energy, was also developed. The measurement of dietary NE is more complex, and NE values of a given feed depend on the animal and environmental factors and also measurement and calculation methods. The combination of NE values of diets obtained under standardised conditions allows calculating NE prediction equations that are applicable to both ingredients and compound feeds. The abundance of energy concepts, especially for poultry, and the numerous feed and animal factors of variation related to energy digestibility or ME utilisation for NE suggest that attention must be paid to the experimental conditions for evaluating DE, ME or NE content. This also suggests the necessity of standardisations, one of them being, as implemented in pigs, an adjustment of ME values in poultry for an N retention representative of modern production conditions (MEs). In conclusion, this review illustrates that, in addition to numerous technical difficulties for evaluating energy in pigs and poultry, the absolute energy values depend on feed and animal factors, the environment, and the methods and concepts. Finally, as implemented in pigs, the use of NE values should be the objective of a more reliable energy system for poultry feeds.

Evaluation of energy and amino acids of brown rice and its effects on laying performance and egg quality of layers

Two experiments were conducted to determine apparent metabolizable energy (AME), nitrogen-corrected AME (AMEn), and ileal digestible amino acid (AA) content of brown rice (BR) and to investigate the effect of dietary supplementation of BR on laying performance and egg quality of laying hens. In Exp. 1, 72 Hy-line Brown layers (49-week-old) were allocated to two treatments using a completely randomized block design, and each treatment included six cages per treatment and six hens per cage. A semi-purified diet was formulated to include BR as the sole source of AA and energy and an N-free diet was used to determine basal endogenous loss of AA. The hens were fed a commercial layer diet for adaptation to the experimental environment and diet for 7 days from d 0, and then fed experimental diets for 5 days from d 7. Excreta were collected from d 10 to 11 and ileal digesta were collected on d 12. On a dry matter (DM) basis, the AME and AMEn of BR was determined at 3,773 and 3,729 kcal/kg, respectively. The apparent ileal digestibility (AID) of BR ranged from 32.7% for Thr to 73.7% for Arg. The range of the standardized ileal digestibility (SID) value was between 79.4% for Met and 96.6% for Lys. In Exp. 2, 252 Hy-line Brown layers (44-week-old) were divided into four groups, comprising seven replicates of nine birds each and assigned to four experimental diets containing 0 (Control), 5%, 10%, or 15% BR for 5 weeks. The BR-containing diets were formulated to be equal in the content of AMEn and digestible AA to those of the diet without BR. No significant differences were observed in laying performances. Egg quality and blood profiles were not linearly or quadratically affected by dietary treatments. These results suggest that up to 15% BR can be included into layer feed without any adverse effects on laying performance and egg quality, if its energy and digestible AA values are well evaluated.

Metabolizable and net energy values of corn stored for 3 years for laying hens

The apparent metabolizable energy (AME), AME corrected to zero-nitrogen retention (AMEn), and net energy (NE) values of 2 corn samples both stored for 3 yr were determined in laying hens with reference diet substitution method. Reference diet was formulated according to standard layer requirement, and test diets contained 50% of corn samples and 50% of the reference diet. Fifty-four Hy-Line Brown hens at the age of 36 wk were used. The heat production and energy metabolism of birds were measured in open-circuit respiratory chambers with 6 replicates (3 birds per replicate) per diet in a randomized design. Birds were fed experimental diets for 7 D in the chamber as adaptation. During the following 3 D, feed intake, metabolizable energy value, nitrogen balance, energy balance, egg production, O₂ consumption, CO₂ production, and energy efficiency were determined. The AME values of corn 1 and corn 2 were 3,485 and 3,675 kcal/kg DM, respectively. The corresponding AMEn values were 3,452 and 3,596 kcal/kg DM, and the NE values were 2,575 and 2,693 kcal/kg DM, respectively. The NE:AME ratios of corn 1 and corn 2 were 74.4 and 73.3%, respectively. The NE:AMEn ratios of corn 1 and corn 2 were 75.0 and 74.9%, respectively. The AME, AMEn, and NE values of the 2 corn samples both stored for 3 yr were lower than the literature values for fresh corn.

Implementation of net energy evaluating system in laying hens: Validation by performance and egg quality

Three experiments were conducted to determine the effect of different dietary net energy (NE) and AMEn ratios (NE:AMEn) on performance, egg quality, and heat production (HP) in laying hens. In experiment 1, 62 Hy-Line Brown hens were fed 2 treatments with 31 replicates from 44 to 54 wk of age. In experiment 2, 600 hens of the same strain were fed 3 treatments from 22 to 42 wk of age with 10 replicates. Both used a completely randomized design. Diets were based on corn, wheat, wheat bran, barley, soybean meal, canola meal, meat and bone meal, and canola oil. In both experiments, the NE:AMEn ratio of diets was increased with higher oil inclusion compared with T1 controls. The AMEn (kcal/kg), NE (kcal/kg), ether extract (g/kg), and CP (g/kg), respectively, on a DM basis in experiment 1 was T1: 3,011, 2,288, 42, 202 and T2: 3,023, 2,374, 81, 203; and in experiment 2, T1: 3,026, 2,324, 25, 187; T2: 2,949, 2,315, 61, 185; and T3: 3,026, 2,397, 73, 181. Increasing the ratio of NE:AMEn decreased feed intake (P < 0.001) and increased egg mass (P < 0.05) in experiment 2 and increased egg weight (P < 0.01), decreased feed conversion ratio (P < 0.01), increased egg albumen % (P < 0.001), and decreased yolk % (P < 0.05) and shell % (P < 0.05) compared with T1 controls in both experiments. Haugh units and yolk color scores were increased with high NE:AMEn in both experiments (P < 0.001; P < 0.01). Experiment 3 was conducted in calorimetry chambers to measure HP in birds fed experiment 2 diets. Increasing the NE:AMEn increased total retained energy (RE), RE as fat, and RE in the body (kcal/kg BW^0.75/D) and NE:AME. The results indicate that using oil to increase the NE:AMEn results in improved performance and egg quality and more efficient energy utilization.

Historical flaws in bioassays used to generate metabolizable energy values for poultry feed formulation: a critical review

Dietary energy available to animals is key for formulating feed as it is required for all aspects of the animal's life. In poultry, apparent (AME) and true (TME) metabolizable energy (ME) values have been used for feed formulation with (AMEn or TMEn) or without correction for nitrogen balance. For the past 50 yr, the accuracy of ME has been an ongoing debate, and the comparability of data produced using different bioassay systems is often questionable. Overall, the ingredient matric ME values used in feed formulation are not consistent, and to some extent, confusing. This review was to examine ME data published in the past century to elucidate the accuracy of different bioassay systems and examine the values for accuracy and useability. A variety of flaws are identified in the literature, suggesting a thorough re-thinking of feedstuff ME values currently used in feed formulation and in developing prediction equations. Two protocols, namely multiple linear regression and basal diet substitution methods, are proposed as more accurate bioassays for feedstuff ME values. AME aligns more closely with the actual energy levels of feed ingredients likely available to growing birds, which should be used for poultry feed formulations instead of AMEn. It is suggested that nutritionists need to carefully apply any reported AME values and only use those in formulation practice after careful scrutinizing. Any in vitro, NIR or table values must be calibrated or computed based on the values produced from flawless bioassays so as to apply the derived values accurately. Flaws identified in this literature review can be avoided with care to achieve more accurate AME. However, the assumption that the energy of individual ingredients is additive in a complete diet is still untrue at least under some circumstances. This may require efforts from industry and researchers to investigate relations among the main ingredients in a complete diet so that more accurate formulation can be performed based on the outcomes that may fine-tune the additivity assumption.

Factors affecting energy metabolism and evaluating net energy of poultry feed

Different energy evaluating systems have been used to formulate poultry diets including digestible energy, total digestible nutrients, true metabolizable energy, apparent metabolizable energy (AME), and effective energy. The AME values of raw materials are most commonly used to formulate poultry diets. The net energy (NE) system is currently used for pig and cattle diet formulation and there is interest for its application in poultry formulation. Each energy evaluating system has some limitations. The AME system, for example, is dependent on age, species, and feed intake level. The NE system takes AME a step further and incorporates the energy lost as heat when calculating the available energy for the production of meat and eggs. The NE system is, therefore, the most accurate representation of energy available for productive purposes. The NE prediction requires the accurate measurement of the AME value of feed and also an accurate measurement of total and fasting heat production using nutritionally balanced diets. At present, there is limited information on NE values of various ingredients for poultry feed formulation. The aim of this review is to examine poultry feed energy systems with the focus on the NE system and its development for chickens.