Mycotoxins in poultry feed and feed ingredients in Nigeria

Seasonal variation of mycotoxin levels in poultry feeds and feed ingredients in Oyo State, Nigeria

Mycotoxins pose a major problem to poultry production as a result of feed contamination which has deleterious consequences such as production losses and human health risks. A total of 158 chicken feed samples were randomly collected from 46 consenting poultry farms in Oyo State throughout the wet season (April-October; 91 samples) and the dry season (November-March; 67 samples), including compounded feed (n = 129) and feed ingredients (n = 29). Samples were promptly transported to the laboratory in sterile plastic vials for lateral flow assay for mycotoxins using six different commercial mycotoxin test kits each for aflatoxin B1, zearalenone, deoxynivalenol, ochratoxin A, fumonisin, and T-2 toxin/HT-2 toxin. Summary values of mycotoxin levels (µg/kg) in the feedstuffs were represented as frequency or median (and range). Fisher exact or Mann-Whitney U tests were carried out where appropriate at α = 0.05. Every sample contained at least four mycotoxins. Aflatoxins and fumonisin co-occurred in 80% of the samples. Aflatoxin and fumonisin concentrations were above the permissible limits in 32.9% and 18.4% respectively in feedstuff sampled in the dry season while the values were 17.1% and 6.3% respectively during the wet season. Among feed ingredients, peanut cake and maize had the highest median concentration of aflatoxin and fumonisin, respectively. Median aflatoxin concentration in the feedstuff was significantly higher than the permissible limit irrespective of season. There is a need to frequently monitor mycotoxin levels of feed and feed ingredients and improve storage system for feed ingredients in order to reduce the risk associated with high mycotoxin intake in poultry.

Mycotoxins evaluation of total mixed ration (TMR) in bovine dairy farms: An update

The total mixed ration (TMR) is currently a widespread method to feed dairy cows. It is a mixture of raw fodder and concentrate feed that can be contaminated by several mycotoxins. The main aim of this paper was to provide a critical review on TMR mycotoxin occurrence and its usefulness to monitor and control them on-farm. Aflatoxins, zearalenone, deoxynivalenol, T-2 toxin and fumonisins (regulated mycotoxins) are the most prevalent mycotoxins evaluated in TMR. Nonetheless, several emerging mycotoxins represent a health risk at the animal level regarding their prevalence and level in TMR. Even when measured at low levels, the co-occurrence of mycotoxins is frequent and synergistic effects on animal health are still underevaluated. Similar to the animal feed industry, on-farm plans monitoring mycotoxin feed contamination can be developed as a herd health management program. The estimated daily intake of mycotoxins should be implemented, but thresholds for each mycotoxin are not currently defined in dairy farms.

Deep Learning-Based Quantitative Assessment of Melamine and Cyanuric Acid in Pet Food Using Fourier Transform Infrared Spectroscopy

Melamine and its derivative, cyanuric acid, are occasionally added to pet meals because of their nitrogen-rich qualities, leading to the development of several health-related issues. A nondestructive sensing technique that offers effective detection must be developed to address this problem. In conjunction with machine learning and deep learning technique, Fourier transform infrared (FT-IR) spectroscopy was employed in this investigation for the nondestructive quantitative measurement of eight different concentrations of melamine and cyanuric acid added to pet food. The effectiveness of the one-dimensional convolutional neural network (1D CNN) technique was compared with that of partial least squares regression (PLSR), principal component regression (PCR), and a net analyte signal (NAS)-based methodology, called hybrid linear analysis (HLA/GO). The 1D CNN model developed for the FT-IR spectra attained correlation coefficients of 0.995 and 0.994 and root mean square error of prediction values of 0.090% and 0.110% for the prediction datasets on the melamine- and cyanuric acid-contaminated pet food samples, respectively, which were superior to those of the PLSR and PCR models. Therefore, when FT-IR spectroscopy is employed in conjunction with a 1D CNN model, it serves as a potentially rapid and nondestructive method for identifying toxic chemicals added to pet food.

The natural occurrence, toxicity mechanisms and management strategies of Fumonisin B1：A review

Fumonisin B1 (FB1) contaminates various crops, causing huge losses to agriculture and livestock worldwide. This review summarizes the occurrence regularity, toxicity, toxic mechanisms and management strategies of FB1. Specifically, FB1 contamination is particularly serious in developing countries, humid and hot regions. FB1 exposure can produce different toxic effects on the nervous system, respiratory system, digestive system and reproductive system. Furthermore, FB1 can also cause systemic immunotoxicity. The mechanism of toxic effects of FB1 is to interfere with the normal pathway of sphingolipid de novo biosynthesis by acting as a competitive inhibitor of ceramide synthase. Meanwhile, the toxic products of sphingolipid metabolic disorders can cause oxidative stress and apoptosis. FB1 also often causes feed contamination by mixing with other mycotoxins, and then exerts combined toxicity. For detection, lateral flow dipstick technology and enzyme linked immunosorbent assay are widely used in the detection of FB1 in commercial feeds, while mainstream detection methods such as high performance liquid chromatography and liquid chromatography-mass spectrometry are widely used in the laboratory theoretical study of FB1. For purification means of FB1, some natural plant extracts (such as Zingiber officinale and Litsea Cubeba essential oil) and their active compounds have been proved to inhibit the toxic effects of FB1 and protect livestock due to their antifungal and antioxidant effects. Natural plant extract has the advantages of high efficiency, low cost and no contamination residue. This review can provide information for comprehensive understanding of FB1, and provide reference for formulating reasonable treatment and management strategies in livestock production.

Curcumin Alleviates Aflatoxin B1-Induced Liver Pyroptosis and Fibrosis by Regulating the JAK2/NLRP3 Signaling Pathway in Ducks

Aflatoxin B₁ (AFB₁) is a serious pollutant in feed and food which causes liver inflammation, fibrosis, and even cirrhosis. The Janus kinase 2 (JAK2)/signal transducers and activators of the transcription 3 (STAT3) signaling pathway is widely involved in inflammatory response and promotes the activation of nod-like receptor protein 3 (NLRP3) inflammasome, thus leading to pyroptosis and fibrosis. Curcumin is a natural compound with anti-inflammatory and anti-cancer properties. However, whether AFB₁ exposure leads to the activation of the JAK2/NLRP3 signaling pathway in the liver and whether curcumin can regulate this pathway to influence pyroptosis and fibrosis in the liver remains unclear. In order to clarify these problems, we first treated ducklings with 0, 30, or 60 µg/kg AFB₁ for 21 days. We found that AFB₁ exposure caused growth inhibition, liver structural and functional damage, and activated JAK2/NLRP3-mediated liver pyroptosis and fibrosis in ducks. Secondly, ducklings were divided into a control group, 60 µg/kg AFB₁ group, and 60 µg/kg AFB₁ + 500 mg/kg curcumin group. We found that curcumin significantly inhibited the activation of the JAK2/STAT3 pathway and NLRP3 inflammasome, as well as the occurrence of pyroptosis and fibrosis in AFB₁-exposed duck livers. These results suggested that curcumin alleviated AFB₁-induced liver pyroptosis and fibrosis by regulating the JAK2/NLRP3 signaling pathway in ducks. Curcumin is a potential agent for preventing and treating liver toxicity of AFB₁.

Safety and Quality of Milk and Milk Products in Senegal—A Review

Historically, local milk production in Senegal has struggled to keep up with the demands of consumers, so there has been a heavy reliance on imported milk and milk products. More recently, efforts have been made to improve local dairy production by establishing large, organized dairies that collect milk from rural production areas and developing small-scale processing units, such as mini dairies. The local dairy value chain in Senegal consists of (1) informal collection systems where farmers commonly deliver milk directly to dairies; (2) traditional and artisanal processing using simple equipment and techniques; and (3) short local marketing and sale circuits. Most West African dairy sectors are dominated by raw, unpasteurized milk or traditional, spontaneously fermented milk products, such as lait caillé in Senegal, sold through small-scale channels without a cold chain, so the risk of food safety hazards may be increased. Microbiological, chemical, and physical hazards have been found in milk and milk products across West Africa. There is a need to educate milk producers, small-scale processors, and vendors on the importance of refrigerating milk immediately after milking as well as maintaining the cold chain until the milk is heat treated and, subsequently, until the milk is marketed to the consumer. However, without assistance, obtaining the equipment necessary for cold storage and processing of milk can be challenging.

Ochratoxin A and Citrinin Differentially Modulate Bovine Mammary Epithelial Cell Permeability and Innate Immune Function

Frequent detection of mycotoxins ochratoxin A (OTA) and citrinin (CIT) in ruminant feed and feedstuff can be a potential threat to feed safety, animal performance and health. Ineffective biodegradation of these mycotoxins by rumen microflora following ingestion of contaminated feeds can lead to their circulatory transport to tissues such as mammary gland as the result of their biodistribution throughout the body. The bovine mammary epithelium plays a pivotal role in maintaining milk yield and composition and contributes to innate immune defense of the udder. The present study is the first to investigate individual effects of OTA and CIT on barrier and innate immune functions of the bovine mammary epithelium using a bovine mammary epithelial cell line (MAC-T). Results indicated that OTA and CIT exposure for 48 h significantly decreased cell viability in a concentration-dependent manner (p < 0.05). A decrease in transepithelial electrical resistance and increase in paracellular flux of FITC-40 kDa dextran was significantly induced by OTA treatment (p < 0.05), but not by CIT after 48 h exposure. qPCR was performed for assessment of expression of tight-junction proteins, Toll-like receptor 4 (TLR4) and cytokines after 4, 24 and 48 h of exposure. Both OTA and CIT markedly downregulated expression of claudin 3 and occludin (p < 0.05), whereas CIT did not affect zonula occludens-1 expression. Expression of TLR4 was significantly upregulated by OTA (p < 0.001) but downregulated by CIT (p < 0.05) at 48 h. Expression of IL-6, TNF-a and TGF-β was significantly upregulated by OTA (p < 0.05), whereas IL-6 and TGF-β expression was downregulated by CIT (p < 0.01). These results suggest that OTA and CIT could potentially differentially modulate barrier and innate immune functions of mammary epithelium. The present study not only throws light on the individual toxicity of each mycotoxin on bovine mammary epithelium but also lays the foundation for future studies on the combined effects of the two mycotoxins.

Development of a reliable UHPLC-MS/MS method for simultaneous determination of zearalenone and zearalenone-14-glucoside in various feed products

A reliable ultra-high-performance liquid chromatography–tandem mass spectrometry method (UHPLC-MS/MS) was developed for the simultaneous determination of two mycotoxins, that is, zearalenone (ZEN) and zearalenone-14-glucoside (ZEN-14G) in formula feed, concentrated feed, and premixed feed products. An improved sample pretreatment was achieved with the hydrophilic–lipophilic balance (HLB) cartridges efficiently removing the impurities and enriching the target analytes in different feeds. The critical parameters affecting the performance of the solid-phase extraction (SPE) procedure were carefully optimized, and 20% acetonitrile in water as the loading solution, 50% methanol in water as the washing solvent, and 5 ml of methanol as the elution solvent yielded the optimal purification efficiencies. The established method was thoroughly validated in terms of linearity (R² ≥ 0.999), sensitivity (limit of quantification in the range of 0.50–5.00 μg kg⁻¹), recovery (89.35 ± 2.67% to 110.93 ± 1.56%), and precision (RSD, 3.00–14.20%), and it was then successfully applied to investigate a total of 60 feed samples. Among them, 50 samples were found to be contaminated with ZEN (an incidence of 83.3%) at levels ranging from 0.63 to 615.24 μg kg⁻¹, whereas 22 samples were contaminated with ZEN-14G (an incidence of 36.7%) in the range of 0.89–15.31 μg kg⁻¹. The developed method proved to be a specific and reliable tool for intensive monitoring of ZEN and ZEN-14G in complex feed matrices.

A review of toxigenic fungi and mycotoxins in feeds and food commodities in West Africa

Fungal contamination is a threat to food safety in West Africa with implications for food and feed due to their climate, which is characterised by high temperatures and high relative humidity, which are environmental favourable for fast fungal growth and mycotoxin production. This report gives perspective on studies on toxigenic fungi (Aspergillus, Fusarium and Penicillium) and their toxins, mainly aflatoxins, fumonisins and ochratoxins commonly found in some West African countries, including Benin, Burkina Faso, Gambia, Ghana, Ivory Coast, Mali, Nigeria, Senegal, Sierra Leone, and Togo. Only four of these countries have mycotoxins regulations in place for feeds and food products (Ghana, Ivory Coast, Nigeria, and Senegal). Food commodities that are widely consumed and were thoroughly investigated in this region include cereals, peanuts, cassava chips (flakes), cassava flour, chilies, peanuts, locust beans, melon, and yam products. In conclusion, authorities and scientists needed to consider research and approaches to monitor mycotoxins in foods and feeds produced and consumed in West Africa.

Occurrence of Total Aflatoxins, Aflatoxin B1, and Ochratoxin A in Chicken and Eggs in Some Cameroon Urban Areas and Population Dietary Exposure

Consumption of chicken and eggs contaminated by mycotoxins could lead to a public health concern. This study was conducted to evaluate the dietary exposure of populations to aflatoxins (AFs) and ochratoxin A (OTA) through these poultry products in the three most urbanized regions of Cameroon (Centre, Littoral, and West). A survey was firstly carried out to know about the consumption frequency by the different population age groups as well as their awareness about mycotoxins. Chicken feed, broiler, and eggs were collected from modern poultry farms. AFs and OTA were analysed using the enzyme-linked immunosorbent assay (ELISA), and dietary exposure was evaluated using a deterministic approach. From the 900 households questioned, a daily consumption frequency of chicken and eggs was the most reported (41% and 69%, respectively), with populations having a very weak knowledge of mycotoxins and their associated health risk (18%). Mean concentrations of AFs, AFB₁, and OTA in poultry tissues were below the established regulated limits (20 μg/kg for AFs, 10 μg/kg for AFB₁, and 5 μg/kg for OTA) in feeds. These toxins were detected at average concentrations of 1800 and 966.7 ƞg/kg for AFs in chicken muscle and egg, respectively, and 1400 and 1933.3 ƞg/kg for OTA in muscle and egg, respectively. Based on the survey, their estimated daily intakes through these poultry products tended to be lower than the limits 1 and 100 ƞg/kg bw/day for AFB₁ and OTA, respectively). The margins of exposure (MOE) of the different population age groups to AFB₁ and OTA obtained suggest that the public health concern associated with the presence of mycotoxins in poultry products shall not be underestimated.

LC-MS/MS based appraisal of multi-mycotoxin co-occurrence in poultry feeds from different regions of Punjab, Pakistan

Mycotoxins, being a threat to animal and human health, contribute significantly towards economic losses in the poultry sector. A liquid chromatography-mass spectrometry-based study was conducted on poultry feed samples collected from Punjab, Pakistan to evaluate the prevalence, contamination levels, and co-occurrence of multi-mycotoxins across different processed forms of the feed, types of utilities and sampling regions. All samples were found to be contaminated with aflatoxin B1 (AFB1) and fumonisin B1 (FB1). The European Commission (EC) maximum level for AFB1 in complete feedingstuffs in poultry and guidance values for FB1 and zearalenone (ZEN) were exceeded in 73%, 2%, and 14% of the contaminated samples, respectively. The corresponding median values were 39.9 µg/kg, 205 µg/kg, and 34.5 µg/kg. In addition to exceeding contamination levels, a varying co-occurrence of three to fourteen mycotoxins was observed in each of the feed samples that calls for mitigation measures to safeguard the feed and its ingredients.

Ultra-fast RP-HPLC-FD-DAD for quantification of total aflatoxins in maize, rice, wheat, peanut and poultry feed without sample clean up, and population exposure risk assessment in Katsina, Nigeria: an optimization study

This study reports the development and validation of a simple, yet efficient method called the ultra-fast reverse phase high-performance liquid chromatography with fluorescence and photodiode array detector (UF-RP-HPLC-FD-DAD) to extract and quantify the total aflatoxin from grains and poultry feed. The proposed method is used to determine the total aflatoxin content in 150 samples of maize, rice, wheat, peanut and poultry feed obtained from open markets in a state in Nigeria. The extent of consumer exposure to aflatoxins and the risk of developing hepatocellular carcinoma (HCC) are evaluated. The UF-RP-HPLC-FD-DAD method was found to be satisfactorily accurate, sensitive and reliable as ascertained by its excellent validation outcomes (R² > 0.999, LoD < 0.08 ng g^-1, LoQ < 0.2 ng g^-1, recovery = 90-102%). The aflatoxin levels in food grains and poultry feed samples obtained in this study implied a moderate dietary exposure of between 10.67 and 20.77 ng/kg BW/day, in which the risk of developing HCC was estimated to be between 6.27 and 21.40% per 100,000 adults/year. Hence, greater monitoring of marketed food and feed is required, besides the deployment of strict controls and preventive techniques to minimize the population's exposure to a high dietary level of aflatoxins.

PINK1/Parkin-mediated mitophagy as a protective mechanism against AFB1-induced liver injury in mice

Aflatoxin B₁ (AFB₁) can cause oxidative stress leading to mitochondrial damage and subsequent liver injury. Although it is well-known that damaged mitochondria are eliminated by PINK1/Parkin-mediated mitophagy, this mechanism has not yet been characterized in the context of AFB₁-induced liver injury. In this study, male wild-type C57BL/6N mice were divided into groups 1-4, which were then orally administered 0, 0.5, 0.75, and 1 mg/kg body weight AFB₁ for 28 d, respectively. Our results demonstrated that oxidative stress, NLRP3-inflammasome activation, and mitochondrial damage were dose-dependently augmented in AFB₁-induced liver injury. Additionally, PINK1/Parkin-mediated mitophagy peaked in the groups that had received a mid-dose of AFB₁ (0.75 mg/kg), which was attenuated slightly in high-dose groups. Afterward, we further characterized AFB₁-induced liver injury by comparing wild-type C57BL/6N mice with Parkin knockout (Parkin^-/-) mice. We found that the restricted mitophagy in Parkin^-/- mice was associated with increased oxidative stress, NLRP3-inflammasome activation, mitochondrial damage, and liver injury. Taken together, these results indicate that PINK1/Parkin-mediated mitophagy plays an important role in attenuating AFB₁-induced liver injury in mice.

Assessment of multi-mycotoxin contamination throughout the supply chain of maize-based poultry feed from selected regions of Malaysia by LC-MS/MS

The objective of this study was to examine the occurrence of multi-mycotoxin contamination throughout the supply chain of maize-based poultry feed. Different sampling points throughout the feed supply chain were selected from two companies that manufactured the poultry feed. A total of 51 samples, consisting of grain maize and maize-based poultry feeds, were collected. The samples were analysed by liquid chromatography-tandem mass spectrometry (LC-MS/MS) to determine the occurrence of multi-mycotoxin. The results revealed that 100% of samples throughout the maize-based poultry feed supply chain were spoiled with more than one mycotoxin. Fumonisin B1 (8.02-1,220 µg/kg) and fumonisin B2 (11.1-1,109 µg/kg) were the main mycotoxins detected at all sampling points throughout the feed supply chain. Zearalenone (ZEA) (6.63-7.50 µg/kg) was also detected in 11.7% (n = 6) (out of a total of 51) samples. As the supply chain progresses, a reduction in mycotoxin contamination was observed. Aflatoxins, ochratoxin A (OTA), deoxynivalenol (DON), HT-2, and T-2 toxin were not detected. The levels of mycotoxins detected throughout the supply chain were below the international regulatory limits, thus indicating the low risk of exposure to mycotoxins in maize-based poultry feed in Malaysia. Nevertheless, due to the presence of multiple ingredients in most food and feed, efforts to understand and address challenges associated with mycotoxins throughout the entire supply chain need to be more holistic to protect public health.

OUP accepted manuscript

Background

Regulations limiting aflatoxin levels in animal feed and guidance values for maximum levels for fumonisins (FB₁ and FB₂), deoxynivalenol (DON), ochratoxin A (OTA), zearalenone (ZON), HT-2, and T-2 toxins are in place both to protect animal health and to minimize potential transfer to animal products for human consumption. A multi-mycotoxin method which can handle complex feed matrices such as distillers dried grains with solubles (DDGS) is essential for analysis and accurate quantification without the need to revert to separately analyze individual mycotoxins.

Objective

The objective of this study is to generate single laboratory validation data for a method employing a multi-antibody immunoaffinity column (IAC) capable of providing cleanup for eleven mycotoxins, followed by LC–MS/MS quantification without the need for isotopic labelled and matrix-matched standards. The applicability of method is to be demonstrated for corn feed, pig feed, and DDGS by fortification and naturally occurring mycotoxins covering the range of regulated limits.

Methods

Feed sample (1 kg) ground by milling to approximately 1–2 mm particle size and sub-sample (5 g) extracted with acetonitrile–water–formic acid, passing through a multi-mycotoxin IAC, washing, and eluting prior to LC–MS/MS analysis monitoring selected ion transitions.

Results

Recoveries were in the range 74 to 117% (excluding five outliers) for aflatoxins, FB₁, FB₂, DON, OTA, ZON, HT-2, and T2- toxins spiked into three commercial animal feed matrixes (n = 84) and within-day RSDs averaged 1.7 to 10.3% (n = 99).

Conclusion

Single laboratory validation of a multi-antibody IAC method coupled with LC–MS/MS has shown the method to be suitable for accurate quantification of eleven regulated mycotoxins in DDGS, pig feed, and poultry feed.

Highlights

IAC method capable of accurately quantifying eleven regulated mycotoxins in complex feed matrices.

Toxic Effects of Mycotoxin Fumonisin B1 at Six Different Doses on Female BALB/c Mice

Background: Fumonisin B1 (FB1) is one of the most common mycotoxins contaminating feed and food. Although regulatory limits about fumonisins have been established in some countries, it is still very important to conduct research on lower doses of FB1 to determine the tolerance limits. The aim of this study was to investigate the effects of different concentrations of FB1, provide further evidence about the toxic doses- and exposure time-associated influence of FB1 on mice, especially low levels of FB1 for long-term exposure. Methods: Female BALB/c mice were treated intragastrically (i.g.) with fumonisin B1 (FB1) solutions (0 mg/kg body weight (BW), 0.018 mg/kg BW, 0.054 mg/kg BW, 0.162 mg/kg BW, 0.486 mg/kg BW, 1.458 mg/kg BW and 4.374 mg/kg BW) once a day for 8 weeks to obtain dose- and time-dependent effects on body and organ weights, hematology, blood chemical parameters and liver and kidney histopathology. Results: After the long-term administration of FB1, the body weights of the mice tended to decrease. Over time, FB1 first increased the relative spleen weight, then increased the relative kidney weight, and finally increased the relative liver weight. The mean corpuscular volume (MCV), mean corpuscular hemoglobin (MCH), hemoglobin (HGB), white blood cells (WBC), platelets (PLT), and mean platelet volume (MPV) were significantly elevated after treatment with FB1 for 8 weeks. Moreover, exposure time-dependent responses were found for aspartate aminotransferase (AST), alanine aminotransferase (ALT) and alkaline phosphatase (ALP) level, which were coupled with hepatic histopathological findings, necroinflammation and vacuolar degeneration and detrital necrosis. Linear dose response was also found for liver histopathology, in which, even the minimum dose of FB1 exposure also caused changes. Renal alterations were moderate compared to hepatic alterations. Conclusion: In conclusion, we demonstrated the systemic toxic effects of different doses of FB1 in female BALB/c mice at different times. Our data indicated that the effects observed in this study at the lowest dose tested are discussed in relation to the currently established provisional maximum tolerable daily intake (PMTDI) for fumonisins. This study suggested that recommendations for the concentration of FB1 in animals and humans are not sufficiently protective and that regulatory doses should be modified to better protect animal and human health. The toxicity of FB1 needs more attention.

Updates on food and feed mycotoxin contamination and safety in Africa with special reference to Nigeria

Mycotoxin contamination of food and feed is a major concern in sub-Sahara African countries, particularly Nigeria. It represents a significant limit to health of human, livestock as well as the international trade. Aflatoxins, fumonisins, ochratoxin, zearalenone, deoxynivalenol and beauvericin are the major mycotoxins recognised in the aetiology of food safety challenges that precipitated countless number of diseases. In Nigeria, aflatoxins and fumonisin found in nearly all crops are the most common mycotoxins of economic and health importance such as sorghum, maize and groundnuts. Thus, consumption of food contaminated with mycotoxins are inevitable, hence the need for adequate regulation is necessary in these frontier economies as done in many developed economies to ensure food safety for human and animals. In low and middle-income countries, especially Nigeria, there is lack of awareness and sufficient information on the risk associated with consequent of mycotoxin contamination on wellbeing of human, animals health and the economy. It is based on the foregoing that this paper summarized the status of mycotoxin present in Nigerian food and feeds relative to the global regulatory standards. This aimed at preventing consuming mycotoxin contaminated food stuff while confronting its associated challenges. Suggestions on some possible control strategies to mitigate vending mycotoxin food and feeds were made.

Development and validation of quantitative thin layer chromatographic technique for determination of total aflatoxins in poultry feed and food grains without sample clean-up

OBJECTIVE

The purpose of this work is to develop and validate an appropriate solvent solution and quantitative thin layer chromatography (TLC) method for determining the aflatoxins content of chicken feeds and dietary grains.

MATERIALS AND METHODS

To obtain the optimal mobile phase, samples were extracted with methanol/water (3:1) + 5% sodium chloride and partitioned using several solvent systems using preparative TLC. Camag TLC scanner 3 was used to scan the TLC plates at 366 nm and quantify them using JustTLC software. The method was tested for linearity, specificity, accuracy, precision, sensitivity, and robustness in accordance with ICH recommendations, and then utilized to screen 132 Nigerian poultry/food samples for total aflatoxins (TAFs).

RESULTS

The best separation of aflatoxins was achieved using acetonitrile and dichloromethane (3:17) mobile phase over an average run time of 45 min, resulting in linear calibration curves (R2 > 0.99) in the concentration range limit of quantitation (LoQ) to 50 ng/spot with a limit of detection of <2.0 ng/g and a LoQ of <4.0 ng/gm for all aflatoxins in all spiked samples. When the proposed TLC method was compared to an optimized high-performance liquid chromatography method, an excellent linear regression was obtained (R2 > 95%). Seventy seven (58.33%) of the 132 samples examined were positive for aflatoxins, with mean values ranging from 3.57 ± 2.55 to 37.31 ± 34.06 ng/gm for aflatoxin B1 and 6.67 ± 0.00 to 38.02 ± 31.52 ng/gm for TAFs, respectively.

CONCLUSIONS

The results demonstrate the feasibility of using the suggested TLC method in conjunction with a novel solvent solution (free of carcinogenic chloroform) for the rapid and accurate measurement of TAFs in foods/feeds.

Mycotoxins in Poultry Feed and Feed Ingredients from Sub-Saharan Africa and Their Impact on the Production of Broiler and Layer Chickens: A Review

The poultry industry in sub-Saharan Africa (SSA) is faced with feed insecurity, associated with high cost of feeds, and feed safety, associated with locally produced feeds often contaminated with mycotoxins. Mycotoxins, including aflatoxins (AFs), fumonisins (FBs), trichothecenes, and zearalenone (ZEN), are common contaminants of poultry feeds and feed ingredients from SSA. These mycotoxins cause deleterious effects on the health and productivity of chickens and can also be present in poultry food products, thereby posing a health hazard to human consumers of these products. This review summarizes studies of major mycotoxins in poultry feeds, feed ingredients, and poultry food products from SSA as well as aflatoxicosis outbreaks. Additionally reviewed are the worldwide regulation of mycotoxins in poultry feeds, the impact of major mycotoxins in the production of chickens, and the postharvest use of mycotoxin detoxifiers. In most studies, AFs are most commonly quantified, and levels above the European Union regulatory limits of 20 μg/kg are reported. Trichothecenes, FBs, ZEN, and OTA are also reported but are less frequently analyzed. Co-occurrences of mycotoxins, especially AFs and FBs, are reported in some studies. The effects of AFs on chickens’ health and productivity, carryover to their products, as well as use of mycotoxin binders are reported in few studies conducted in SSA. More research should therefore be conducted in SSA to evaluate occurrences, toxicological effects, and mitigation strategies to prevent the toxic effects of mycotoxins.

Response of Fecal Bacterial Flora to the Exposure of Fumonisin B1 in BALB/c Mice

Fumonisins are a kind of mycotoxin that has harmful influence on the health of humans and animals. Although some research studies associated with fumonisins have been reported, the regulatory limits of fumonisins are imperfect, and the effects of fumonisins on fecal bacterial flora of mice have not been suggested. In this study, in order to investigate the effects of fumonisin B1 (FB1) on fecal bacterial flora, BALB/c mice were randomly divided into seven groups, which were fed intragastrically with 0 mg/kg, 0.018 mg/kg, 0.054 mg/kg, 0.162 mg/kg, 0.486 mg/kg, 1.458 mg/kg and 4.374 mg/kg of FB1 solutions, once a day for 8 weeks. Subsequently, feces were collected for analysis of microflora. The V3-V4 16S rRNA of fecal bacterial flora was sequenced using the Illumina MiSeq platform. The results revealed that fecal bacterial flora of mice treated with FB1 presented high diversity. Additionally, the composition of fecal bacterial flora of FB1 exposure groups showed marked differences from that of the control group, especially for the genus types including Alloprevotella, Prevotellaceae_NK3B31_group, Rikenellaceae_RC9_gut_group, Parabacteroides and phylum types including Cyanobacteria. In conclusion, our data indicate that FB1 alters the diversity and composition of fecal microbiota in mice. Moreover, the minimum dose of FB1 exposure also causes changes in fecal microbiota to some extent. This study is the first to focus on the dose-related effect of FB1 exposure on fecal microbiota in rodent animals and gives references to the regulatory doses of fumonisins for better protection of human and animal health.

Exploration of plant products and phytochemicals against aflatoxin toxicity in broiler chicken production: Present status

Aflatoxins (AFs) are a class of mycotoxins produced by the toxigenic Aspergillus fungi and are common contaminants of foods and feeds. Aflatoxin B1 (AFB1), the most potent aflatoxin, is well characterized to reduce productive performance and mortality in broilers. This exclusive review summarizes the efficacy of various plant products and phytochemicals to counteract AFB1 toxicity in broilers. The biochemical and molecular mode of action of AFB1 to induce liver damage, genotoxicity, immunosuppression and the protective effect of plant products against such mechanisms and their toxic effects are discussed. The link between antioxidant, immunomodulatory and hepatoprotective functions of plant products; oxidative stress and AFB1 macromolecular adducts mediated AFB1 toxicity are covered. Efficacy of Satureja khuzistanica, Zataria multiflora Boiss, Thymus vulgaris, Sauropsus androgynus, Hemidesmus indicus, Leucas aspera, Moringa oleifera, Eclipta alba, Curcuma longa, Silybum marianum, Urtica dioica, and citrus fruit are summarized. The anti-aflatoxic effect of water-soluble substances of wheat, grape seed proanthocyanidin extract and phytochemicals like thymol, carvarol, piperine, transcinnamaldehyde, resveratrol, curcumin, and silymarin are also discussed. Specific plant products and phytochemicals are shown to be effective against AF toxicity in broilers and could represent an important tool to reduce health and economic losses associated with AFB1 exposure.

Microbial contamination of the air in livestock buildings as a threat to human and animal health – a review

Livestock buildings are often contaminated with bacterial and fungal microflora. Animals living in the buildings, especially their excreta and secretions and their feed, can be a source of microorganisms, including pathogens. Significant microbial contamination occurs in pig houses, poultry houses and cowsheds. The microbes most frequently isolated from the air of these buildings are bacteria of the genera Streptococcus, Staphylococcus, Bacillus, and Clostridium and of the family Enterobacteriaceae. Among fungi, the most common are Aspergillus, Trichoderma, Penicillium, Cladosporium and Alternaria. Microbes present in livestock buildings often pose a hazard to workers, in whom they can cause infectious and allergic diseases, especially respiratory disease. Bacterial endotoxins may also pose a threat to humans and animals. For this reason it is important to carry out microbiological monitoring and preventive measures on livestock farms and to maintain appropriate environmental conditions. This will reduce microbiological contamination of livestock buildings and improve both workers’ health and animal welfare.

Co-occurrence and toxicological relevance of secondary metabolites in dairy cow feed from Thailand

The occurrence of secondary metabolites and co-contaminants in dairy cow feed samples (n = 115), concentrate, roughage, and mixed feed, collected from Ratchaburi and Kanjanaburi provinces, Thailand, between August 2018 and March 2019 were investigated using LC-MS/MS based multi-toxin method. A total of 113 metabolites were found in the samples. Fungal metabolites were the predominant compounds, followed by plant metabolites. Among major mycotoxins, zearalenone and fumonisins were most frequently detected in concentrate and mixed feed samples, while deoxynivalenol and aflatoxin B₁ were found at the frequency lower than 50%. Other metabolites, produced by Aspergillus, Fusarium, Penicillium, and Alternaria species, occurred in the samples. Flavoglaucin, 3-nitropropionic acid, averufin, and sterigmatocystin were the most prevalent Aspergillus metabolites. Common Fusarium metabolites occurring in the samples included moniliformin, beauvericin, and enniatins. For Penicillium metabolites, mycophenolic acid, questiomycin A, quinolactacin A, oxaline, citrinin, and dihydrocitrinone were frequently detected. The toxic Alternaria metabolites, alternariol, and alternariol monomethyl ether showed the high incidence in the samples. Plant metabolites were commonly found, mainly cyanogenic compounds and isoflavones, from cassava and soybean meal used as feed ingredients. Overall, 96.6% of feed samples contained at least two metabolites, in a range from 2 to 69. According to co-contamination of mycotoxins found in feed samples, zearalenone were mostly found in combination with fumonisin B₁, deoxynivalenol, and aflatoxin B₁. Fumonisin B₁ co-occurred with aflatoxin B₁ and deoxynivalenol. The mixtures of deoxynivalenol and aflatoxin B₁, and of zearalenone, fumonisin B₁ and deoxynivalenol were also found. Due to known individual toxicity of fungal and plant metabolites and possible additive or synergistic toxic effects of multi-mycotoxins, the occurrence of these metabolites and co-contaminants should be monitored continuously to ensure food safety through the dairy supply chain.

Prevalence of mycotoxigenic fungi and assessment of aflatoxin contamination: a multiple case study along the integrated corn-based poultry feed supply chain in Malaysia

BACKGROUND

Corn, a main feed ingredient in the livestock industry, is one of the most susceptible crops to fungal infection and aflatoxin contamination. Livestock feeding on aflatoxin (AF)-contaminated feed have been shown to experience feed refusal, and decreased growth rate, milk production, and feed efficiency. In poultry, AF poisoning causes weight loss, poor feed efficiency, and reduced egg production and egg weight. The present work therefore aimed to determine the prevalence of mycotoxigenic fungi and the occurrence of AF contamination along the integrated corn-based poultry feed supply chain in Malaysia. A total of 51 samples were collected from different points along the feed supply chain from integrated poultry feed companies. The samples were subjected to mycological analyses (fungal isolation, enumeration, identification), and AFs were quantified by high-performance liquid chromatography equipped with a fluorescence detector (HPLC-FLD).

RESULTS

Samples collected from sampling point 1 (company A) and sampling point 9 (company B) yielded the highest total fungal load (>log 4 CFU g^-1 ). The prevalent fungal genera isolated were Aspergillus, Fusarium, and Penicillium spp. Aflatoxin B₁ was detected in 8.3% of corn samples, and 7.4% of corn-based poultry feed samples along the feed supply chain, whereas AFs B₂ , G₁ , and G₂ were not detected.

CONCLUSION

The incidence of mycotoxigenic fungi along the integrated poultry feed supply chain warrant continuous monitoring of mycotoxin contamination to reduce the exposure risk of mycotoxin intake in poultry. © 2020 Society of Chemical Industry.

Investigation of feedstuff contaminated with aflatoxigenic fungi species in the semi-arid region in northeast of Iran

There is a close relationship between human health and the quality of the ration used by domestic animals. Also, molds, like genus of Aspergillus, infect animal and human food products with dangerous toxic substances, i.e., aflatoxins that are causing primary and secondary mycotoxicosis in animals and human. The aim of this study was to compare fungal species that contaminated and produced aflatoxin in livestock and poultry feed in Gonabad that is a semi-arid city in northeast of Iran. Sampling was randomly performed three times from two livestock feed mills and two poultry feed mills during summer and autumn. Samples were cultured in two forms of solid and suspension in Sabouraud dextrose agar with chloramphenicol medium (SC) for 5 days in 28 °C. Microscopic diagnostic test and also molecular diagnostic test were used to determine fungal species in culture based on β-tubulin gene sequencing. A total of 27.25% and 31.7% of two livestock feed and two poultry feed samples were contaminated with Aspergillus, respectively. Aspergillus flavus (n = 4), Aspergillus Fumigatus (n = 2), Aspergillus versicolor (n = 2), Aspergillus niger (n = 2), Aspergillus parasiticus (n = 1), Aspergillus ochraceus (n = 1), and Aspergillus terreus (n = 1) were detected by molecular PCR test. The rate of contamination to genus of Aspergillus in autumn was higher than summer (P value = 0.008). Poultry feed sample showed more contamination to Aspergillus species compared with livestock feed.

Mycotoxin profiles of animal feeds in the central part of Thailand: 2015-2020

Background and Aim:

Mycotoxin contamination in animal feeds is of considerable concern because it can affect animal health systems. As a result of contamination in the food chain, humans can indirectly come into contact with mycotoxins. The present study aimed to present mycotoxin contamination patterns in animal feeds from 2015 to 2020 and elucidate associations between the type of feed and the type of ingredient.

Materials and Methods:

Data were summarized from the records of the Kamphaeng Saen Veterinary Diagnosis Center from 2015 to 2020, which comprised the analyses of aflatoxin (AFL), zearalenone (ZEA), T-2 toxin (T-2), fumonisin (FUM), and deoxynivalenol (DON) contamination in feed ingredients, complete feeds, and unclassified feeds. Descriptive statistics, Chi-squared tests, and Fisher’s exact tests were used for data analysis.

Results:

ZEA was prevalent in animal feeds. The prevalence of each mycotoxin was constant from 2015 to 2020. Approximately 20-30% of samples were positive for AFL and FUM. The highest contamination was ZEA, which was found in 50% of the samples, and the occurrence of T-2 and DON was <10%. AFL significantly contaminated complete feeds more than feed ingredients. Feed ingredients were related to mycotoxin contaminations. The highest levels of AFL, FUM, and DON contamination occurred in 2017. The data in this year consisted mostly of soybean, corn, and rice bran.

Conclusion:

The number of positive samples of all five mycotoxins was constant from 2015 to 2020, but the occurrence of ZEA was the highest. Mycotoxins in feedstuffs are significantly related to the type of feed and the type of ingredient.

Synthesis and characterization of tannic acid pillared bentonite composite for the efficient adsorption of aflatoxins

Tannic acid (TA) is a hydrolysable polyphenol with established antioxidant and antibacterial activity along with its tendency to bind both organic and inorganic ions/molecules. In the present study, the sequestration performance of TA pillared bentonite for various aflatoxins (AFs) including AFB1, AFB2, AFG1 and AFG2 from aqueous solutions and simulated poultry gastrointestinal model solution was studied via adsorption. The adsorbents were characterized by scanning electron microscopy (SEM), energy dispersive X-ray (EDX) analysis, Fourier transform infrared (FTIR) spectroscopy, X-ray diffraction (XRD), N₂ adsorption-desorption study and X-ray photoelectron spectroscopy (XPS). The reaction conditions including pH, agitation time, initial toxin concentration and temperature were systematically optimized. The Langmuir adsorption capacity of the adsorbent reached to 86, 71, 74 and 149 mg/g for AFB1, AFB2, AFG1 and AFG2 respectively. Adsorption kinetics and thermodynamic studies showed rapid AFs uptake and the exothermicity of the adsorption reaction respectively. Simultaneous removal of AFs by BTA3 revealed their independent and uninterrupted adsorption and the adsorption mechanism of AFs over BTA3 was elaborated with the help of XPS results. The outstanding AFs sequestering capability of BTA3 in aqueous solution and simulated poultry gastrointestinal model can be envisioned of great promise for the remediation of AFs and other hazardous pollutants from food and poultry industrial products.

Improved Sample Selection and Preparation Methods for Sampling Plans Used to Facilitate Rapid and Reliable Estimation of Aflatoxin in Chicken Feed

Aflatoxin B1 (AFB1), a toxic fungal metabolite associated with human and animal diseases, is a natural contaminant encountered in agricultural commodities, food and feed. Heterogeneity of AFB1 makes risk estimation a challenge. To overcome this, novel sample selection, preparation and extraction steps were designed for representative sampling of chicken feed. Accuracy, precision, limits of detection and quantification, linearity, robustness and ruggedness were used as performance criteria to validate this modification and Horwitz function for evaluating precision. A modified sampling protocol that ensured representativeness is documented, including sample selection, sampling tools, random procedures, minimum size of field-collected aggregate samples (primary sampling), procedures for mass reduction to 2 kg laboratory (secondary sampling), 25 g test portion (tertiary sampling) and 1.3 g analytical samples (quaternary sampling). The improved coning and quartering procedure described herein (for secondary and tertiary sampling) has acceptable precision, with a Horwitz ratio (HorRat = 0.3) suitable for splitting of 25 g feed aliquots from laboratory samples (tertiary sampling). The water slurring innovation (quaternary sampling) increased aflatoxin extraction efficiency to 95.1% through reduction of both bias (-4.95) and variability of recovery (1.2-1.4) and improved both intra-laboratory precision (HorRat = 1.2-1.5) and within-laboratory reproducibility (HorRat = 0.9-1.3). Optimal extraction conditions are documented. The improved procedure showed satisfactory performance, good field applicability and reduced sample analysis turnaround time.

A review of microbes and chemical contaminants in dairy products in sub-Saharan Africa

Animal milk types in sub-Saharan Africa (SSA) are processed into varieties of products using different traditional methods and are widely consumed by households to support nutritional intake and diet. Dairy products contain several microorganisms, their metabolites, and other chemical compounds, some with health benefits and many others considered as potential health hazards. Consumption of contaminated milk products could have serious health implications for consumers. To access the safety of milk products across SSA, studies in the region investigating the occurrences of pathogens as well as chemical compounds such as heat stable toxins and veterinary drug residues in animal milk and its products were reviewed. This is done with a holistic view in light of the emerging exposome paradigm for improving food safety and consumer health in the region. Herein, we showed that several published studies in SSA applied conventional and/or less sensitive methods in detecting microbial species and chemical contaminants. This has serious implications in food safety because the correct identity of a microbial species and accurate screening for chemical contaminants is crucial for predicting the potential human health effects that undermine the benefits from consumption of these foods. Furthermore, we highlighted gaps in determining the extent of viral and parasitic contamination of milk products across SSA as well as investigating multiple classes of chemical contaminants. Consequently, robust studies should be conducted in this regard. Also, efforts such as development cooperation projects should be initiated by all stakeholders including scientists, regulatory agencies, and policy makers to improve the dairy product chain in SSA in view of safeguarding consumer health.

Ochratoxin A: Carryover from animal feed into livestock and the mitigation strategies

This review aims to highlight the effects of ochratoxin A (OTA) in the feed of meat-producing animals. The accumulation of OTA in feed and its distribution in various farm animals were compared and evaluated. Primarily, the oral administration of OTA-contaminated feed and the predisposition in an animal's vital organ were critically examined in this work. The collated reports show that OTA directly associated with endemic nephropathy and its high concentration leads to degeneration of liver cells, and necrosis of intestinal and lymphoid tissues. At present, limited reports are available in the recent literature on the problems and consequences of OTA in feed. Therefore, this review focused on the OTA carryover from feed to farm animals and the interaction of its secondary metabolites on their biochemical parameters. Hence, this report provides greater insights into animal health related to OTA residues in meat and meat products. This article also explores mitigation strategies that can be used to prevent the carryover effects of OTA in livestock feeds and the effects in the food chain.

Dietary ochratoxin A (OTA) decreases growth performance and impairs muscle antioxidant system and meat fatty acid profiles in juvenile tambaqui (Colossoma macropomum)

Plant-based ingredients are successfully replacing fishmeal in fish feeds. However, this practice increases the risk of feed contamination by mycotoxins that reduce production and heath associated with oxidative damage. The aim of this study was to determine whether feed contaminated with environmentally relevant concentrations of ochratoxin A (OTA) causes muscle oxidative damage in tambaqui (Colossoma macropomum), and to determine whether this feed impairs fatty acid profiles in fish meat. Final mean weight, weight gain, daily weight gain, feed efficiency, and specific growth rate were significantly lower in fish fed 1.6 and 2.4 mg OTA/kg compared to those fed basal diet, while feed conversion was significantly higher in these same groups compared to the basal group. Levels of reactive oxygen species and lipid peroxidation in muscle were significantly higher in fish fed 1.6 and 2.4 mg OTA/kg compared to those in the basal group. Likewise, muscle superoxide dismutase and glutathione peroxidase activities were significantly higher in fish fed 1.6 and 2.4 mg OTA/kg then in those fed basal feed. The total content of saturated fatty acids was significantly higher, and total content of polyunsaturated fatty acids was significantly lower in fish fed 2.4 mg OTA/kg compared to those fed basal feed. Taken together, the data suggest that OTA-contaminated feed induces oxidative damage and disturbs enzymatic and non-enzymatic antioxidant responses in tambaqui meat. The perturbations of fatty acid profiles in fish meat appears to mediated by oxidative damage, representing negative impact on fish health and presenting concerns for consumers of fish.

Effects of mycotoxin-contaminated feed on farm animals

Mycotoxins are secondary products produced by fungi in cereals and are frequently found in the livestock industry as contaminants of farm animal feed. Studies analyzing feed mycotoxins have been conducted worldwide and have confirmed the presence of mycotoxins with biological activity, including aflatoxin, ochratoxin A, fumonisin, zearalenone, and deoxynivalenol, in a large proportion of feed samples. Exposure to mycotoxins can cause immunotoxicity and impair reproductive function in farm animals. In addition, exposure of tissues, such as the kidneys, liver, and intestines, to mycotoxins can exert histopathological changes that can interfere with animal growth and survival. This review describes previous studies regarding the presence of major mycotoxins in the feed of farm animals, especially pigs and poultry. Moreover, it describes the adverse effects of mycotoxins in farm animals following exposure, as well as the biological activity of mycotoxins in animal-derived cells. Mycotoxins have been shown to regulate signaling pathways, oxidative stress, endoplasmic reticulum stress, apoptosis, and proliferation in porcine and bovine cells. A clear understanding of the effects of mycotoxins on farm animals will help reduce farm household economic loss and address the health concerns of people who consume these meat and dairy products.

The Biodegradation Role of Saccharomyces cerevisiae against Harmful Effects of Mycotoxin Contaminated Diets on Broiler Performance, Immunity Status, and Carcass characteristics

Simple Summary

Over the past two decades, the use of agents for the biodegradation of mycotoxins has led to a reduction in their accumulation and toxicity in the digestive tract of animals. Thus, mycotoxin decontaminating agents are very useful in the prevention of aflatoxicosis. The present feeding trial aimed to evaluate the biodegradation role of Saccharomyces cerevisiae in the prevention of the harmful effects of a mycotoxin contaminated diet on broiler performance, immunity, and carcass traits. The obtained results revealed significant improvements in broiler growth performance parameters, carcass traits, and antibody titer against infected diseases as an effect of the dietary inclusion of Saccharomyces cerevisiae up to 3.75 g kg⁻¹. Consequentially, it could be used in broiler contaminated diets without negatively affecting bird health.

Abstract

A feeding trial (35 days) was carried out to investigate the effect of Saccharomyces cerevisiae cell wall as a mycotoxin biodegradation agent on the performance, feed efficiency, carcass traits, and immunity response against diseases in broilers fed aflatoxin B1 contaminated diets. For this purpose, 200 one day old broilers were randomly allotted into four groups, each with five replicates (10 birds per replicate). Four starter and finisher experimental rations were formulated by using (A) 0, (B) 1.25, (C) 2.5, and (D) 3.75 g kg⁻¹ of Saccharomyces cerevisiae. Experimental diets were contaminated with aflatoxin B1 (100 ppb kg⁻¹ diet). The experimental chicks were kept under standard managerial conditions, and the vaccination program was followed against infectious bursal disease (IBD), infectious bronchitis (IB), and Newcastle disease (ND) diseases. At the end of the feeding trial, carcass, organ weight, and blood samples were collected randomly to determine the carcass traits and antibody titer against ND and IBD viruses. Throughout the experiment, the addition of 3.75 g kg⁻¹ of the Saccharomyces cerevisiae cell wall (Group-D) in feed resulted in the highest weight gain, final weight, feed intake, and the lowest FCR values followed by C group compared with the other groups. All carcass traits were significantly (p > 0.05) improved by increasing the inclusion levels of Saccharomyces cerevisiae in broiler diets. It could be concluded that the broiler diet supplemented with 2.5 or 3.75 g kg⁻¹ of Saccharomyces cerevisiae as a biodegrading agent resulted in improved growth performance, immunity activity and carcass traits, and supplementation with Saccharomyces cerevisiae at these levels can be used effectively in broiler diets without negatively affecting bird health status.