1
|
Zhang X, Chen D, Jiang N, Hou X, Li Y, Wang Y, Shen J. New insights into algal-bacterial sludge granulation based on the tightly-bound extracellular polymeric substances regulation in response to N-Methylpyrrolidone. WATER RESEARCH 2024; 257:121754. [PMID: 38762929 DOI: 10.1016/j.watres.2024.121754] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/09/2024] [Revised: 04/26/2024] [Accepted: 05/07/2024] [Indexed: 05/21/2024]
Abstract
Algal-bacterial granular sludge (ABGS) system is promising in wastewater treatment for its potential in energy-neutrality and carbon-neutrality. However, traditional cultivation of ABGS poses significant challenges attributable to its long start-up period and high energy consumption. Extracellular polymeric substances (EPS), which could be stimulated as a self-defense strategy in cells under toxic contaminants stress, has been considered to contribute to the ABGS granulation process. In this study, photogranulation of ABGS by EPS regulation in response to varying loading rates of N-Methylpyrrolidone (NMP) was investigated for the first time. The results indicated the formation of ABGS with a maximum average diameter of ∼3.3 mm and an exceptionally low SVI5 value of 67 ± 2 mL g-1 under an NMP loading rate of 125 mg L-1 d-1, thereby demonstrating outstanding settleability. Besides, almost complete removal of 300 mg L-1 NMP could be achieved at hydraulic retention time of 48 h, accompanied by chemical oxygen demand (COD) and total nitrogen (TN) removal efficiencies higher than 90 % and 70 %, respectively. Moreover, possible degradation pathway and metabolism mechanism in the ABGS system for enhanced removal of NMP and nitrogen were proposed. In this ABGS system, the mycelium with network structure constituted by filamentous microorganisms was a prerequisite for photogranulation, instead of necessarily leading to granulation. Stress of 100-150 mg L-1 d-1 NMP loading rate stimulated tightly-bound EPS (TB-EPS) variation, resulting in rapid photogranulation. The crucial role of TB-EPS was revealed with the involved mechanisms being clarified. This study provides a novel insight into ABGS development based on the TB-EPS regulation by NMP, which is significant for achieving the manipulation of photogranules.
Collapse
Affiliation(s)
- Xiaoyu Zhang
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Dan Chen
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China; Engineering Research Centre of Chemical Pollution Control, Ministry of Education, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China.
| | - Na Jiang
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Xinying Hou
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Yan Li
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Yixuan Wang
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China; Engineering Research Centre of Chemical Pollution Control, Ministry of Education, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Jinyou Shen
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China; Engineering Research Centre of Chemical Pollution Control, Ministry of Education, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China.
| |
Collapse
|
2
|
Zhong J, Tang L, Gao M, Wang S, Wang X. Beyond feast and famine: Cultivating hydrodynamic oxygenic photogranules with better performances under permanent feast regime. BIORESOURCE TECHNOLOGY 2024; 401:130752. [PMID: 38685514 DOI: 10.1016/j.biortech.2024.130752] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/15/2024] [Revised: 04/26/2024] [Accepted: 04/26/2024] [Indexed: 05/02/2024]
Abstract
Oxygenic photogranules (OPGs) are currently obtained in permanent famine or cyclic feast-famine regimes. Whether photogranulation occurs under a permanent feast regime and how these regimes impact OPGs are unknown. Herein, the three regimes, each applied in two replicate hydrodynamic reactors, were established by different feeding frequencies. Results showed that OPGs were successfully cultivated in all regimes after 24-36 days of photogranulation phases with similar microbial community functions, including filamentous gliding, extracellular polymeric substances production, and carbon/nitrogen metabolism. The OPGs were then operated under the same sequencing batch mode and all achieved efficient removal of chemical oxygen demand (>91 %), ammonium (>96 %), and total nitrogen (>76 %) after different adaptation periods (19-41 days). Notably, the permanent feast regime obtained OPGs with the best physicochemical properties, the shortest adaptation period, and the lowest effluent turbidity, thus representing a novel means of hydrodynamic cultivating OPGs with better performances for sustainable wastewater treatment.
Collapse
Affiliation(s)
- Jiewen Zhong
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Liaofan Tang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Mingming Gao
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Shuguang Wang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China; Weihai Research Institute of Industrial Technology of Shandong University, Weihai 264209, China
| | - Xinhua Wang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China.
| |
Collapse
|
3
|
Li J, Tang L, Zhang Y, Gao M, Wang S, Wang X. Hydrodynamic cultivation of aeration-free oxygenic photogranules is favored by sufficient amounts of organic carbon. BIORESOURCE TECHNOLOGY 2024; 401:130736. [PMID: 38670289 DOI: 10.1016/j.biortech.2024.130736] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/22/2024] [Revised: 04/09/2024] [Accepted: 04/23/2024] [Indexed: 04/28/2024]
Abstract
Oxygenic photogranules (OPGs) have great potential for the aeration-free treatment of various wastewater, however, the effects of wastewater carbon composition on OPGs remain unknown. This study investigated the hydrodynamic photogranulation in three types of wastewater with the same total carbon concentration but different inorganic/organic carbon compositions, each operated at two replicated reactors. Results showed that photogranulation failed in reactors fed with only inorganic carbon. In reactors with equal inorganic and organic carbon, loose-structured OPGs formed but then disintegrated. Comparatively, reactors treating organic carbon-based wastewater obtained regular and dense OPGs with better settleability, lower effluent turbidity, excellent structural stability, and higher carbon assimilation rate. Sufficient amounts of organic carbon were crucial for the formation and stability of OPGs as they promoted the secretion of extracellular polymeric substances (EPS) and the growth of filamentous cyanobacteria. This study provides a basis for the startup of OPGs process and facilitates its large-scale application.
Collapse
Affiliation(s)
- Junrong Li
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Liaofan Tang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Yuqing Zhang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Mingming Gao
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China
| | - Shuguang Wang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China; Weihai Research Institute of Industrial Technology of Shandong University, Weihai 264209, China
| | - Xinhua Wang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao 266237, China.
| |
Collapse
|
4
|
Tang L, Gao M, Liang S, Wang S, Wang X. Enhanced biological phosphorus removal sustained by aeration-free filamentous microalgal-bacterial granular sludge. WATER RESEARCH 2024; 253:121315. [PMID: 38382289 DOI: 10.1016/j.watres.2024.121315] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/02/2023] [Revised: 01/30/2024] [Accepted: 02/13/2024] [Indexed: 02/23/2024]
Abstract
The microalgal-bacterial granular sludge (MBGS) based enhanced biological phosphorus removal (EBPR) (MBGS-EBPR) was recently proposed as a sustainable wastewater treatment process. Previous work showed the possibility of obtaining an MBGS-EBPR process starting from mature MBGS and phosphate-accumulating organisms (PAOs) enriched aerobic granular sludge (AGS) and validated the effectiveness of removing carbon/nitrogen/phosphorus with mechanical aeration. The present work evaluated whether the same could be achieved starting from conventional activated sludge and operating under aeration-free conditions in an alternating dark/light photo-sequencing batch reactor (PSBR). We successfully cultivated filamentous MBGS with a high settling rate (34.5 m/h) and fast solid-liquid separation performance, which could be attributed to the proliferation of filamentous cyanobacteria and stimulation of extracellular polymeric substances (EPS) production. The process achieved near-complete steady-state removal of carbon (97.2 ± 1.9 %), nitrogen (93.9 ± 0.7 %), and phosphorus (97.7 ± 1.7 %). Moreover, improved phosphorus release/uptake driven by photosynthetic oxygenation under dark/light cycles suggests the enrichment of PAOs and the establishment of MBGS-EBPR. Batch tests showed similar phosphorus release rates in the dark but significantly lower phosphorus uptake rates in the presence of light when the filamentous granules were disrupted. This indicates that the filamentous structure of MBGS has minor limitations on substrate mass transfer while exerting protective effects on PAOs, thus playing an important role in sustaining the function of aeration-free EBPR. Microbial assays further indicated that the enrichment of filamentous cyanobacteria (Synechocystis, Leptoolybya, and Nodosilinea), putative PAOs and EPS producers (Hydrogenophaga, Thauera, Flavobacterium, and Bdellovibrio) promoted the development of filamentous MBGS and enabled the high-efficient pollutant removal. This work provides a feasible and cost-effective strategy for the startup and operation of this innovative process.
Collapse
Affiliation(s)
- Liaofan Tang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao, 266237, China
| | - Mingming Gao
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao, 266237, China
| | - Shuang Liang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao, 266237, China
| | - Shuguang Wang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao, 266237, China; Weihai Research Institute of Industrial Technology of Shandong University, Weihai, 264209, China
| | - Xinhua Wang
- Shandong Key Laboratory of Water Pollution Control and Resource Reuse, Shandong Key Laboratory of Environmental Processes and Health, School of Environmental Science and Engineering, Shandong University, Qingdao, 266237, China.
| |
Collapse
|
5
|
Han M, Xie P, Ren N, Ho SH. Cytoprotective alginate microcapsule serves as a shield for microalgal encapsulation defensing sulfamethoxazole threats and safeguarding nutrient recovery. JOURNAL OF HAZARDOUS MATERIALS 2024; 465:133454. [PMID: 38198867 DOI: 10.1016/j.jhazmat.2024.133454] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/11/2023] [Revised: 12/13/2023] [Accepted: 01/03/2024] [Indexed: 01/12/2024]
Abstract
Microalgal encapsulation technology is expected to broaden more possibilities for employing microalgae for upgrading conventional biological wastewater treatment. However, only limited and fragmented information is currently available on microalgal encapsulation and pollutant removal. It is ambiguous whether it hold potential for wastewater treatment. Particularly, it remains to be determined whether this technology can provide more possibilities in harsh sewage environments. Here, potential of encapsulated technology to recover nutrients from wastewater was examined, simultaneously compared with commonly adopted suspended system. Results indicate the encapsulated microalgal system showed outstanding advantages in nutrient recovery and defense against antibiotic threats. Moreover, by examining the cellular oxidative stress response and changes of the photosynthetic system, the encapsulated system exhibited potential cytoprotective advantages to microalgal cells for defensing antibiotic threats. Molecular dynamics simulation revealed that the differences among superficial aggregation between the nutrients' ions and molecular sulfamethoxazole on the cross-linked alginate microcapsule surface dominated the nutrient recovery and cytoprotective functions. Ultimately, the molecular nature of pollutants was found to be the most critical aspect for predicting application of this microalgal microcapsule. Cytoprotective systems created with alginate microcapsules can potentially handle more diverse threats with a single type of surface charge in their outermost layer.
Collapse
Affiliation(s)
- Meina Han
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| | - Peng Xie
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| | - Nanqi Ren
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| | - Shih-Hsin Ho
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China.
| |
Collapse
|
6
|
Zhang JT, Wang JX, Liu Y, Zhang Y, Wang JH, Chi ZY, Kong FT. Microalgal-bacterial biofilms for wastewater treatment: Operations, performances, mechanisms, and uncertainties. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 907:167974. [PMID: 37884155 DOI: 10.1016/j.scitotenv.2023.167974] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/18/2023] [Revised: 09/28/2023] [Accepted: 10/18/2023] [Indexed: 10/28/2023]
Abstract
Microalgal-bacterial biofilms have been increasingly considered of great potential in wastewater treatment due to the advantages of microalgal-bacterial synergistic pollutants removal/recovery, CO2 sequestration, and cost-effective biomass-water separation. However, such advantages may vary widely among different types of microalgal-bacterial biofilms, as the biofilms could be formed on different shapes and structures of attachment substratum, generating "false hope" for certain systems in large-scale wastewater treatment if the operating conditions and pollutants removal properties are evaluated based on the general term "microalgal-bacterial biofilm". This study, therefore, classified microalgal-bacterial biofilms into biofilms formed on 2D substratum, biofilms formed on 3D substratum, and biofilms formed without substratum (i.e. microalgal-bacterial granular sludge, MBGS). Biofilms formed on 2D substratum display higher microalgae fractions and nutrients removal efficiencies, while the adopted long hydraulic retention times were unacceptable for large-scale wastewater treatment. MBGS are featured with much lower microalgae fractions, most efficient pollutants removal, and acceptable retention times for realistic application, yet the feasibility of using natural sunlight should be further explored. 3D substratum systems display wide variations in operating conditions and pollutants removal properties because of diversified substratum shapes and structures. 2D and 3D substratum biofilms share more common in eukaryotic and prokaryotic microbial community structures, while MGBS biofilms are more enriched with microorganisms favoring EPS production, biofilm formation, and denitrification. The specific roles of stratified extracellular polymeric substances (EPS) in nutrients adsorption and condensation still require in-depth exploration. Nutrients removal uncertainties caused by microalgal-bacterial synergy decoupling under insufficient illumination, limited microbial community control, and possible greenhouse gas emission exacerbation arising from microalgal N2O generation were also indicated. This review is helpful for revealing the true potential of applying various microalgal-bacterial biofilms in large-scale wastewater treatment, and will provoke some insights on the challenges to the ideal state of synergistic pollutants reclamation and carbon neutrality via microalgal-bacterial interactions.
Collapse
Affiliation(s)
- Jing-Tian Zhang
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Jian-Xia Wang
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Yang Liu
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Ying Zhang
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Jing-Han Wang
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China; Key Laboratory of Environment Controlled Aquaculture, Dalian Ocean University, Dalian 116023, PR China.
| | - Zhan-You Chi
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Fan-Tao Kong
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| |
Collapse
|
7
|
de Morais EG, Sampaio ICF, Gonzalez-Flo E, Ferrer I, Uggetti E, García J. Microalgae harvesting for wastewater treatment and resources recovery: A review. N Biotechnol 2023; 78:84-94. [PMID: 37820831 DOI: 10.1016/j.nbt.2023.10.002] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/17/2023] [Revised: 09/21/2023] [Accepted: 10/07/2023] [Indexed: 10/13/2023]
Abstract
Microalgae-based wastewater treatment has been conceived to obtain reclaimed water and produce microalgal biomass for bio-based products and biofuels generation. However, microalgal biomass harvesting is challenging and expensive, hence one of the main bottlenecks for full-scale implementation. Finding an integrated approach that covers concepts of engineering, green chemistry and the application of microbial anabolism driven towards the harvesting processes, is mandatory for the widespread establishment of full-scale microalgae wastewater treatment plants. By using nature-based substances and applying concepts of chemical functionalization in already established harvesting methods, the costs of harvesting processes could be reduced while preventing microalgae biomass contamination. Moreover, microalgae produced during wastewater treatment have unique culture characteristics, such as the consortia, which are primarily composed of microalgae and bacteria, that should be accounted for prior to downstream processing. The aim of this review is to examine recent advances in microalgal biomass harvesting and recovery in wastewater treatment systems, considering the impact of consortia variability. The costs of available harvesting technologies, such as coagulation/flocculation, coupled to sedimentation and differential air flotation, are provided. Additionally, promising technologies are discussed, including autoflocculation, bioflocculation, new filtration materials, nanotechnology, microfluidic and magnetic methods.
Collapse
Affiliation(s)
- Etiele Greque de Morais
- GEMMA - Group of Environmental Engineering and Microbiology, Department of Civil and Environmental Engineering, Universitat Politècnica de Catalunya, BarcelonaTech, c/ Jordi Girona 1-3, Building D1, E-08034 Barcelona, Spain
| | - Igor Carvalho Fontes Sampaio
- CPID - Espírito Santo's Center for Research, Innovation and Development, Eliezer Batista hill, Jardim América, 29140-130 Cariacica, Espírito Santo, Brazil
| | - Eva Gonzalez-Flo
- GEMMA - Group of Environmental Engineering and Microbiology, Department of Civil and Environmental Engineering, Universitat Politècnica de Catalunya, BarcelonaTech, c/ Jordi Girona 1-3, Building D1, E-08034 Barcelona, Spain; GEMMA-Group of Environmental Engineering and Microbiology, Department of Civil and Environmental Engineering, Escola d'Enginyeria de Barcelona Est (EEBE), Universitat Politècnica de Catalunya-BarcelonaTech, Av. Eduard Maristany 16, Building C5.1, E-08019 Barcelona, Spain
| | - Ivet Ferrer
- GEMMA - Group of Environmental Engineering and Microbiology, Department of Civil and Environmental Engineering, Universitat Politècnica de Catalunya, BarcelonaTech, c/ Jordi Girona 1-3, Building D1, E-08034 Barcelona, Spain
| | - Enrica Uggetti
- GEMMA - Group of Environmental Engineering and Microbiology, Department of Civil and Environmental Engineering, Universitat Politècnica de Catalunya, BarcelonaTech, c/ Jordi Girona 1-3, Building D1, E-08034 Barcelona, Spain
| | - Joan García
- GEMMA - Group of Environmental Engineering and Microbiology, Department of Civil and Environmental Engineering, Universitat Politècnica de Catalunya, BarcelonaTech, c/ Jordi Girona 1-3, Building D1, E-08034 Barcelona, Spain.
| |
Collapse
|
8
|
Li Z, Wang J, Liu W, Zhao Y, Lei Z, Yuan T, Shimizu K, Zhang Z, Lee DJ. Photosynthetic oxygen-supported algal-bacterial aerobic granular sludge can facilitate carbon, nitrogen and phosphorus removal from wastewater: Focus on light intensity selection. BIORESOURCE TECHNOLOGY 2023; 388:129752. [PMID: 37714495 DOI: 10.1016/j.biortech.2023.129752] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/16/2023] [Revised: 09/02/2023] [Accepted: 09/07/2023] [Indexed: 09/17/2023]
Abstract
Photosynthetic O2 is a promising alternative for mechanical aeration, the major energy-intensive unit in wastewater treatment plants. This study aimed to investigate the effects of light intensity varied from 190 to 1400 µmol·s-1·m-2 on photosynthetic O2-supported algal-bacterial aerobic granular sludge (AGS) system. Results indicate photosynthetic O2 can implement aerobic phosphorus (P) uptake and ammonia oxidation under the test illumination range even at dissolved oxygen concentration < 0.5 mg/L. An obvious O2 accumulation occurred after 60-90% nutrients being removed under 330-1400 µmol·s-1·m-2, and highly efficient ammonia removal, P uptake, and dissolved inorganic carbon removal were achieved under 670-1400 µmol·s-1·m-2. On the other hand, photosynthesis as O2 supplier showed little effect on major ions except for K+. This study provides a better understanding of the roles of light intensity on photosynthetic O2-supported algal-bacterial AGS system, targeting a sustainable wastewater industry.
Collapse
Affiliation(s)
- Zejiao Li
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Jixiang Wang
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China
| | - Wenjun Liu
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Yankai Zhao
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhongfang Lei
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan.
| | - Tian Yuan
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Kazuya Shimizu
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhenya Zhang
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tang, Hong Kong, China; Department of Chemical Engineering and Materials Science, Yuan Ze University, Chung-li, Taiwan 32003
| |
Collapse
|
9
|
Zhi M, Zhao Y, Zeng X, Maddela NR, Xiao Y, Chen Y, Prasad R, Zhou Z. Filamentous cyanobacteria and hydrophobic protein in extracellular polymeric substances facilitate algae-bacteria aggregation during partial nitrification. Int J Biol Macromol 2023; 251:126379. [PMID: 37595699 DOI: 10.1016/j.ijbiomac.2023.126379] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/27/2023] [Revised: 07/08/2023] [Accepted: 08/15/2023] [Indexed: 08/20/2023]
Abstract
In algae-bacteria symbiotic wastewater treatment, the excellent settling performance of algae-bacteria aggregates is critical for biomass separation and recovery. Here, the composition of extracellular polymeric substances (EPS), microbial profiles, and functional genes of algae-bacteria aggregates were investigated at different solid retention times (SRTs) (10, 20, and 40 d) during partial nitrification in photo sequencing bioreactors (PSBRs). Results showed that SRTs greatly influenced the nitrogen transformation and the formation and morphological structure of algae-bacteria aggregates. The highest nitrite accumulation, the largest particle size (~1.54 mm) and the best settling performance were observed for the algae-bacteria aggregates in the PSBR with an SRT of 10 d, where the abundant occurrence of filamentous cyanobacteria with the highest ratio of chlorophyll a/b and the lowest EPS amount with the highest protein-to-polysaccharide ratio were observed. In particular, the EPS at 10 d of SRT contained a higher amount of protein-related hydrophobic groups and a lower ratio of α-helix/(β-sheet + random coil), indicating a looser protein structure, which might facilitate the formation and stabilization of algae-bacteria aggregates. Moreover, algal-bacterial aggregation greatly depended on the composition and evolution of filamentous cyanobacteria (unclassified _o__Oscillatoriales and Phormidium accounted for 56.29 % of the identified algae at SRT 10 d). The metagenomic analysis further revealed that functional genes related to amino acid metabolism (e.g., genes of phenylalanine, tyrosine, and tryptophan biosynthesis) were expressed at high levels within 10 d of SRT. Overall, this study demonstrates the influence of EPS structures and filamentous cyanobacteria on algae-bacteria aggregation and reveals the biological mechanisms driving photogranule structure and function.
Collapse
Affiliation(s)
- Mei Zhi
- College of Resources and Environment, Southwest University, Chongqing 400715, China; Chongqing Engineering Research Center of Rural Cleaner Production, Chongqing 400715, China
| | - Yiying Zhao
- College of Resources and Environment, Southwest University, Chongqing 400715, China
| | - Xinyu Zeng
- College of Resources and Environment, Southwest University, Chongqing 400715, China
| | - Naga Raju Maddela
- Departamento de Ciencias Biológicas, Facultad de Ciencias de la Salud, Universidad Técnica de Manabí, Portoviejo 130105, Ecuador
| | - Yeyuan Xiao
- Department of Civil and Environmental Engineering, Shantou University, Shantou 515063, China
| | - Yucheng Chen
- College of Resources and Environment, Southwest University, Chongqing 400715, China; Chongqing Engineering Research Center of Rural Cleaner Production, Chongqing 400715, China
| | - Ram Prasad
- Department of Botany, Mahatma Gandhi Central University, Motihari, Bihar 845401, India.
| | - Zhongbo Zhou
- College of Resources and Environment, Southwest University, Chongqing 400715, China; Chongqing Engineering Research Center of Rural Cleaner Production, Chongqing 400715, China.
| |
Collapse
|
10
|
Zhang X, Chen D, Hou X, Jiang N, Li Y, Ge S, Mu Y, Shen J. Nitrification-denitrification co-metabolism in an algal-bacterial aggregates system for simultaneous pyridine and nitrogen removal. JOURNAL OF HAZARDOUS MATERIALS 2023; 460:132390. [PMID: 37659235 DOI: 10.1016/j.jhazmat.2023.132390] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/25/2023] [Revised: 08/07/2023] [Accepted: 08/22/2023] [Indexed: 09/04/2023]
Abstract
Photosynthetic oxygenation in algal-bacterial symbiotic (ABS) system was mainly concerned to enhance contaminant biodegradation by developing an aerobic environment, while the role of nitrification-denitrification involved is often neglected. In this study, an algal-bacterial aggregates (ABA) system was developed with algae and activated sludge (PBR-1) to achieve simultaneous pyridine and nitrogen removal. In PBR-1, as high as 150 mg·L-1 pyridine could be completely removed at hydraulic residence time of 48 h. Besides, total nitrogen (TN) removal efficiency could be maintained above 80%. Nitrification-denitrification was verified as the crucial process for nitrogen removal, accounting for 79.3% of TN removal at 180 μmol·m-2·s-1. Moreover, simultaneous pyridine and nitrogen removal was enhanced through nitrification-denitrification co-metabolism in the ABA system. Integrated bioprocesses in PBR-1 including photosynthesis, pyridine biodegradation, carbon and nitrogen assimilation, and nitrification-denitrification, were revealed at metabolic and transcriptional levels. Fluorescence in situ hybridization analysis indicated that algae and aerobic species were located in the surface layer, while denitrifiers were situated in the inner layer. Microelectrode analysis confirmed the microenvironment of ABA with dissolved oxygen and pH gradients, which was beneficial for simultaneous pyridine and nitrogen removal. Mechanism of nitrification-denitrification involved in pyridine and nitrogen removal was finally elucidated under the scale of ABA.
Collapse
Affiliation(s)
- Xiaoyu Zhang
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Dan Chen
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China.
| | - Xinying Hou
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Na Jiang
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Yan Li
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Shijian Ge
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China
| | - Yang Mu
- CAS Key Laboratory of Urban Pollutant Conversion, Department of Environmental Science and Engineering, University of Science and Technology of China, Hefei 230026, China
| | - Jinyou Shen
- Key Laboratory of Environmental Remediation and Ecological Health, Ministry of Industry and Information Technology, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Nanjing 210094, China.
| |
Collapse
|
11
|
Su Y, Gao L, Peng L, Diao X, Lin S, Bao R, Mehmood T. Heterogeneous aggregation between microplastics and microalgae: May provide new insights for microplastics removal. AQUATIC TOXICOLOGY (AMSTERDAM, NETHERLANDS) 2023; 261:106638. [PMID: 37517318 DOI: 10.1016/j.aquatox.2023.106638] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/09/2023] [Revised: 07/20/2023] [Accepted: 07/22/2023] [Indexed: 08/01/2023]
Abstract
Existing studies have shown that microplastics (MPs) as artificial surfaces can be colonized by plankton microorganisms. However, systematic research on exploring the aggregation formation process of MPs and microalgae is still lacking and particularly the influencing factors of aggregation remain to be elucidated. Therefore, this study investigated the heterogeneous aggregation process between various microalgal species (i.e., Chlorella vulgaris, Scenedesmus obliquus, Tetraselmis subcordiformis, Chaetoceros müelleri and Streptococcus westermani) and MPs (i.e., mPS and mPLA) with different sizes (i.e., 74 μm and 613 μm), concentrations (i.e., 0.1 g/L, 1 g/L and 2 g/L) and shapes (i.e., the particle and sheet). The results showed that microalgae can first attach to the holes or protrusions of MPs and highly accumulate in the local region, and then multi-layer aggregation can be formed subsequently. The aggregation degree between MPs and microalgae was closely related to the MPs shape and size, and was less related to the MPs concentration. The aggregation speed of small-sized MPs (e.g., 74 μm) was faster than the large-sized ones (e.g., 613 μm). The MPs in a shape of sheet were more obvious than those in particle on their aggregation with microalgae. The density of aggregates was increased compared with pristine MPs, which is related to the cell density and cell number of attached microalgae. For the same type of MPs, the aggregation degree for the tested microalgae was as follows: Scenedesmus obliquus > C. vulgaris > T. subcordiformis > C. müelleri > S. westermani. Meanwhile, MPs inhibited cell growth of microalgae, particularly under the circumstance of their aggregation, by limiting the gas and mass transfer between microalgal cells and the extracellular environment. The heterogeneous aggregation of MPs and microalgae may provide new ideas for treatment and controlling of MPs in the environment.
Collapse
Affiliation(s)
- Yuanyuan Su
- Key Laboratory of Agro-Forestry Environmental Processes and Ecological Regulation of Hainan Province, Center for Eco-Environment Restoration Engineering of Hainan Province, Hainan University, Haikou 570228, China; College of Ecology and Environment, Hainan University, Haikou 570228, China; State Key Laboratory of Marine Resource Utilization in South China Sea, Hainan University, Haikou 570228, China
| | - Liu Gao
- Key Laboratory of Agro-Forestry Environmental Processes and Ecological Regulation of Hainan Province, Center for Eco-Environment Restoration Engineering of Hainan Province, Hainan University, Haikou 570228, China; College of Ecology and Environment, Hainan University, Haikou 570228, China
| | - Licheng Peng
- Key Laboratory of Agro-Forestry Environmental Processes and Ecological Regulation of Hainan Province, Center for Eco-Environment Restoration Engineering of Hainan Province, Hainan University, Haikou 570228, China; College of Ecology and Environment, Hainan University, Haikou 570228, China.
| | - Xiaoping Diao
- State Key Laboratory of Marine Resource Utilization in South China Sea, Hainan University, Haikou 570228, China.
| | - Shengyou Lin
- Key Laboratory of Agro-Forestry Environmental Processes and Ecological Regulation of Hainan Province, Center for Eco-Environment Restoration Engineering of Hainan Province, Hainan University, Haikou 570228, China; College of Ecology and Environment, Hainan University, Haikou 570228, China
| | - Ruiqi Bao
- Key Laboratory of Agro-Forestry Environmental Processes and Ecological Regulation of Hainan Province, Center for Eco-Environment Restoration Engineering of Hainan Province, Hainan University, Haikou 570228, China; College of Ecology and Environment, Hainan University, Haikou 570228, China
| | - Tariq Mehmood
- Key Laboratory of Agro-Forestry Environmental Processes and Ecological Regulation of Hainan Province, Center for Eco-Environment Restoration Engineering of Hainan Province, Hainan University, Haikou 570228, China; College of Ecology and Environment, Hainan University, Haikou 570228, China
| |
Collapse
|
12
|
Ovis-Sánchez JO, Perera-Pérez VD, Buitrón G, Quintela-Baluja M, Graham DW, Morales-Espinosa R, Carrillo-Reyes J. Exploring resistomes and microbiomes in pilot-scale microalgae-bacteria wastewater treatment systems for use in low-resource settings. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 882:163545. [PMID: 37080313 DOI: 10.1016/j.scitotenv.2023.163545] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/30/2022] [Revised: 02/17/2023] [Accepted: 04/13/2023] [Indexed: 05/03/2023]
Abstract
Antibiotic resistance genes (ARGs) released into the environment are an emerging human and environmental health concern, including ARGs spread in wastewater treatment effluents. In low-to-middle income countries (LMICs), an alternate wastewater treatment option instead of conventional systems are low-energy, high-rate algal ponds (HRAP) that use microalgae-bacteria aggregates (MABA) for waste degradation. Here we studied the robustness of ARG removal in MABA-based pilot-scale outdoor systems for 140 days of continuous operation. The HRAP system successfully removed 73 to 88 % chemical oxygen demand and up to 97.4 % ammonia, with aggregate size increasing over operating time. Fourteen ARG classes were identified in the HRAP influent, MABA, and effluent using metagenomics, with the HRAP process reducing total ARG abundances by up to 5-fold from influent to effluent. Parallel qPCR analyses showed the HRAP system significantly reduced exemplar ARGs (p < 0.05), with 1.2 to 4.9, 2.7 to 6.3, 0 to 1.5, and 1.2 to 4.8 log-removals for sul1, tetQ, blaKPC, and intl1 genes, respectively. Sequencing of influent, effluent and MABAs samples showed associated microbial communities differed significantly, with influent communities by Enterobacteriales (clinically relevant ARGs carrying bacteria), which were less evident in MABA and effluent. In this sense, such bacteria might be excluded from MABA due to their good settling properties and the presence of antimicrobial peptides. Microalgae-bacteria treatment systems steadily reduced ARGs from wastewater during operation time, using sunlight as the energetic driver, making them ideal for use in LMIC wastewater treatment applications.
Collapse
Affiliation(s)
- Julián O Ovis-Sánchez
- Laboratorio de Investigación en Procesos Avanzados de Tratamiento de Aguas, Unidad Académica Juriquilla, Instituto de Ingeniería, Universidad Nacional Autónoma de México, Querétaro 76230, Mexico
| | - Victor D Perera-Pérez
- Laboratorio de Investigación en Procesos Avanzados de Tratamiento de Aguas, Unidad Académica Juriquilla, Instituto de Ingeniería, Universidad Nacional Autónoma de México, Querétaro 76230, Mexico
| | - Germán Buitrón
- Laboratorio de Investigación en Procesos Avanzados de Tratamiento de Aguas, Unidad Académica Juriquilla, Instituto de Ingeniería, Universidad Nacional Autónoma de México, Querétaro 76230, Mexico
| | - Marcos Quintela-Baluja
- School of Engineering, Newcastle University, Cassie Building, Newcastle upon Tyne NE1 7RU, UK
| | - David W Graham
- School of Engineering, Newcastle University, Cassie Building, Newcastle upon Tyne NE1 7RU, UK
| | - Rosario Morales-Espinosa
- Laboratorio de Genómica Bacteriana, Departamento de Microbiología y Parasitología, Facultad de Medicina, Universidad Nacional Autónoma de México, Ciudad de México 04510, Mexico
| | - Julián Carrillo-Reyes
- Laboratorio de Investigación en Procesos Avanzados de Tratamiento de Aguas, Unidad Académica Juriquilla, Instituto de Ingeniería, Universidad Nacional Autónoma de México, Querétaro 76230, Mexico.
| |
Collapse
|
13
|
Kong L, Zheng R, Feng Y, Du W, Xie C, Gu Y, Liu S. Anammox bacteria adapt to long-term light irradiation in photogranules. WATER RESEARCH 2023; 241:120144. [PMID: 37300965 DOI: 10.1016/j.watres.2023.120144] [Citation(s) in RCA: 7] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/09/2023] [Revised: 05/13/2023] [Accepted: 05/28/2023] [Indexed: 06/12/2023]
Abstract
Photogranules composed of algae, nitrifiers, and anammox bacteria are promising for nitrogen removal from wastewater with reduced aeration and carbon emissions. However, it is difficult to be achieved as the potential inhibition of anammox bacteria by light. In this study, a syntrophic algal-partial nitrification/anammox granular sludge process was developed, with a nitrogen removal rate of 294.5 mg N/(L·d). We found the symbiosis in the community promoted the adaptation of anammox bacteria under light, and cross-feeding played an important role. Microalgae in the outer layers of photogranules sheltered most of the light and supplied cofactors and amino acids to promote nitrogen removal. In particular, Myxococcota MYX1 degraded the extracellular proteins produced by microalgae, providing amino acids to the entire bacterial community, which helped anammox bacteria save metabolic energy and adapt to light. Notably, the anammox bacteria Candidatus Brocadia exhibited unique light-sensing potential and adaptations to light irradiation compared with Candidatus Jettenia, including diverse DNA repair, scavenging of reactive oxygen species, cell movement. The phytochrome-like proteins encoded by Candidatus Brocadia further facilitated their spatial positioning and niche partitioning in photogranules. This study provides insights into the response of anammox bacteria in the algae-bacteria symbiosis system and suggests its potential application for carbon-negative nitrogen removal.
Collapse
Affiliation(s)
- Lingrui Kong
- College of Environmental Sciences and Engineering, Peking University, Beijing 100871, China; Key Laboratory of Water and Sediment Sciences, Ministry of Education of China, Beijing 100871, China
| | - Ru Zheng
- College of Environmental Sciences and Engineering, Peking University, Beijing 100871, China; Key Laboratory of Water and Sediment Sciences, Ministry of Education of China, Beijing 100871, China
| | - Yiming Feng
- College of Environmental Sciences and Engineering, Peking University, Beijing 100871, China; Key Laboratory of Water and Sediment Sciences, Ministry of Education of China, Beijing 100871, China
| | - Wenran Du
- School of Environment and Energy, Peking University Shenzhen Graduate School, Shenzhen 518055, China
| | - Chen Xie
- National Engineering Laboratory for Advanced Municipal Wastewater Treatment and Reuse Technology, Engineering Research Center of Beijing, Beijing University of Technology, Beijing 100124, China
| | - Yuanqi Gu
- College of Environmental Sciences and Engineering, Peking University, Beijing 100871, China
| | - Sitong Liu
- College of Environmental Sciences and Engineering, Peking University, Beijing 100871, China; Key Laboratory of Water and Sediment Sciences, Ministry of Education of China, Beijing 100871, China.
| |
Collapse
|
14
|
Trebuch LM, Sohier J, Altenburg S, Oyserman BO, Pronk M, Janssen M, Vet LEM, Wijffels RH, Fernandes TV. Enhancing phosphorus removal of photogranules by incorporating polyphosphate accumulating organisms. WATER RESEARCH 2023; 235:119748. [PMID: 36944303 DOI: 10.1016/j.watres.2023.119748] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/19/2022] [Revised: 01/21/2023] [Accepted: 02/12/2023] [Indexed: 06/18/2023]
Abstract
Photogranules are a novel wastewater treatment technology that can utilize the sun's energy to treat water with lower energy input and have great potential for nutrient recovery applications. They have been proven to efficiently remove nitrogen and carbon but show lower conversion rates for phosphorus compared to established treatment systems, such as aerobic granular sludge. In this study, we successfully introduced polyphosphate accumulating organisms (PAOs) to an established photogranular culture. We operated photobioreactors in sequencing batch mode with six cycles per day and alternating anaerobic (dark) and aerobic (light) phases. We were able to increase phosphorus removal/recovery by 6 times from 5.4 to 30 mg/L/d while maintaining similar nitrogen and carbon removal compared to photogranules without PAOs. To maintain PAOs activity, alternating anaerobic feast and aerobic famine conditions were required. In future applications, where aerobic conditions are dependent on in-situ oxygenation via photosynthesis, the process will rely on sunlight availability. Therefore, we investigated the feasibility of the process under diurnal cycles with a 12-h anaerobic phase during nighttime and six short cycles during the 12 h daytime. The 12-h anaerobic phase had no adverse effect on the PAOs and phototrophs. Due to the extension of one anaerobic phase to 12 h the six aerobic phases were shortened by 47% and consequently decreased the light hours per day. This resulted in a decrease of phototrophs, which reduced nitrogen removal and biomass productivity up to 30%. Finally, we discuss and suggest strategies to apply PAO-enriched photogranules at large-scale.
Collapse
Affiliation(s)
- Lukas M Trebuch
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands; Bioprocess Engineering, AlgaePARC Wageningen University, P.O. Box 16, 6700 AA, Wageningen, The Netherlands.
| | - Jasper Sohier
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands
| | - Sido Altenburg
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands
| | - Ben O Oyserman
- Department of Microbial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands; Bioinformatics Group, Wageningen University, Wageningen, The Netherlands
| | - Mario Pronk
- Department of Biotechnology, Delft University of Technology, Van der Maasweg 9, Delft, 2629 HZ, The Netherlands; Royal HaskoningDHV, Laan1914 35, Amersfoort, 3800 AL, The Netherlands
| | - Marcel Janssen
- Bioprocess Engineering, AlgaePARC Wageningen University, P.O. Box 16, 6700 AA, Wageningen, The Netherlands
| | - Louise E M Vet
- Department of Terrestrial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands
| | - René H Wijffels
- Bioprocess Engineering, AlgaePARC Wageningen University, P.O. Box 16, 6700 AA, Wageningen, The Netherlands; Faculty of Biosciences and Aquaculture, Nord University, N-8049, Bodø, Norway
| | - Tânia V Fernandes
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands
| |
Collapse
|
15
|
Dos Santos Neto AG, Barragán-Trinidad M, Florêncio L, Buitrón G. Strategy for the formation of microalgae-bacteria aggregates in high-rate algal ponds. ENVIRONMENTAL TECHNOLOGY 2023; 44:1863-1876. [PMID: 34898377 DOI: 10.1080/09593330.2021.2014577] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/01/2021] [Accepted: 11/28/2021] [Indexed: 06/14/2023]
Abstract
This work studied the formation of aggregates used for wastewater treatment in high-rate algal ponds (HRAP). For this, the establishment of microalgae-bacteria aggregates in these systems was evaluated, considering strategies for the inoculation and start-up. Two HRAP were operated in parallel, at first in batch mode and then in continuous flow. The wastewater treatment was efficient, with removal rates around 80% for COD and N-ammoniacal. Volatile suspended solids and chlorophyll for the culture grew continuously reached a concentration of 548 ± 11 mg L-1 and 7.8 mg L-1, respectively. Larger photogranules were observed when the system was placed in a continuous regime. The protein fraction of extracellular polymeric substances was identified as a determinant in photogranules formation. During the continuous regime, more than 50% of the biomass was higher than 0.2 mm, flocculation efficiency of 78 ± 6%, and the volumetric sludge index of 32 ± 5 mL g-1. The genetic sequencing showed the growth of cyanobacteria in the aggregate and the presence of microalgae from the chlorophytes and diatoms groups in the final biomass.
Collapse
Affiliation(s)
- Antonio G Dos Santos Neto
- Laboratory for Research on Advanced Processes for Water Treatment, Instituto de Ingeniería, Unidad Académica Juriquilla, Universidad Nacional Autónoma de México, Querétaro, Mexico
- Department of Civil and Environmental Engineering, Laboratory of Environmental Sanitation, Federal University of Pernambuco, Recife, Brazil
| | - Martín Barragán-Trinidad
- Laboratory for Research on Advanced Processes for Water Treatment, Instituto de Ingeniería, Unidad Académica Juriquilla, Universidad Nacional Autónoma de México, Querétaro, Mexico
| | - Lourdinha Florêncio
- Department of Civil and Environmental Engineering, Laboratory of Environmental Sanitation, Federal University of Pernambuco, Recife, Brazil
| | - Germán Buitrón
- Laboratory for Research on Advanced Processes for Water Treatment, Instituto de Ingeniería, Unidad Académica Juriquilla, Universidad Nacional Autónoma de México, Querétaro, Mexico
| |
Collapse
|
16
|
Liu Z, Wang J, Zhang S, Hou Y, Wang J, Gao M, Chen X, Zhang A, Liu Y, Li Z. Formation characteristics of algal-bacteria granular sludge under low-light environment: From sludge characteristics, extracellular polymeric substances to microbial community. BIORESOURCE TECHNOLOGY 2023; 376:128851. [PMID: 36898567 DOI: 10.1016/j.biortech.2023.128851] [Citation(s) in RCA: 4] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/03/2023] [Revised: 03/03/2023] [Accepted: 03/06/2023] [Indexed: 06/18/2023]
Abstract
In this study, the formation characteristics of algal-bacteria granular sludge (ABGS) under low-light environment (80, 110, and 140 μmol/m2/s) were investigated. The findings revealed that the stronger light intensity favored the improvement of sludge characteristics, nutrient removal performances, and extracellular polymeric substance (EPS) secretion at the growing stage, which were more preferential to facilitate the formation of ABGS. However, after the mature stage, the weaker light intensity ensured more stable operation of the system, as shown by contributing to sludge settlement performance, denitrification, and EPS secretion. According to the results of high-throughput sequencing, the dominant bacterial genus of the mature ABGS cultured under low light intensity were all Zoogloe, while the dominant algal genus was different. For the mature ABGS, the 140 and 80 μmol/m2/s light intensity had the most significant activation effect to the functional genes related to carbohydrate metabolism and amino acid metabolism, respectively.
Collapse
Affiliation(s)
- Zhe Liu
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China; Key Lab of Northwest Water Resource, Environment and Ecology, Ministry of Education, Xi'an University of Architecture and Technology, Xi'an 710055, China; Yulin Ecological Environment Monitoring Station, High-tech Zone Xingda Road, Yulin 719000, China.
| | - Jingwen Wang
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China
| | - Shumin Zhang
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China
| | - Yiwen Hou
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China
| | - Jiaxuan Wang
- School of Architecture and Civil Engineering, Xi'an University of Science and Technology, Yan Ta Road, No. 58, Xi'an 710054, China
| | - Min Gao
- School of Environmental and Chemical Engineering, Xi an Polytechnic University, Jin Hua Nan Road, No. 19, Xi'an 710048, China
| | - Xingdu Chen
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China
| | - Aining Zhang
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China
| | - Yongjun Liu
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China; Key Lab of Northwest Water Resource, Environment and Ecology, Ministry of Education, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Zhihua Li
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Yan Ta Road, No. 13, Xi'an 710055, China
| |
Collapse
|
17
|
Cremin K, Duxbury SJN, Rosko J, Soyer OS. Formation and emergent dynamics of spatially organized microbial systems. Interface Focus 2023; 13:20220062. [PMID: 36789239 PMCID: PMC9912014 DOI: 10.1098/rsfs.2022.0062] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/25/2022] [Accepted: 12/19/2022] [Indexed: 02/12/2023] Open
Abstract
Spatial organization is the norm rather than the exception in the microbial world. While the study of microbial physiology has been dominated by studies in well-mixed cultures, there is now increasing interest in understanding the role of spatial organization in microbial physiology, coexistence and evolution. Where studied, spatial organization has been shown to influence all three of these aspects. In this mini review and perspective article, we emphasize that the dynamics within spatially organized microbial systems (SOMS) are governed by feedbacks between local physico-chemical conditions, cell physiology and movement, and evolution. These feedbacks can give rise to emergent dynamics, which need to be studied through a combination of spatio-temporal measurements and mathematical models. We highlight the initial formation of SOMS and their emergent dynamics as two open areas of investigation for future studies. These studies will benefit from the development of model systems that can mimic natural ones in terms of species composition and spatial structure.
Collapse
Affiliation(s)
- Kelsey Cremin
- School of Life Sciences, University of Warwick, Coventry CV4 7AL, UK
| | | | - Jerko Rosko
- School of Life Sciences, University of Warwick, Coventry CV4 7AL, UK
| | - Orkun S. Soyer
- School of Life Sciences, University of Warwick, Coventry CV4 7AL, UK
| |
Collapse
|
18
|
Trebuch LM, Bourceau OM, Vaessen SMF, Neu TR, Janssen M, de Beer D, Vet LEM, Wijffels RH, Fernandes TV. High resolution functional analysis and community structure of photogranules. THE ISME JOURNAL 2023; 17:870-879. [PMID: 36997724 DOI: 10.1038/s41396-023-01394-0] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/30/2022] [Revised: 02/28/2023] [Accepted: 03/03/2023] [Indexed: 03/31/2023]
Abstract
AbstractPhotogranules are spherical aggregates formed of complex phototrophic ecosystems with potential for “aeration-free” wastewater treatment. Photogranules from a sequencing batch reactor were investigated by fluorescence microscopy, 16S/18S rRNA gene amplicon sequencing, microsensors, and stable- and radioisotope incubations to determine the granules’ composition, nutrient distribution, and light, carbon, and nitrogen budgets. The photogranules were biologically and chemically stratified, with filamentous cyanobacteria arranged in discrete layers and forming a scaffold to which other organisms were attached. Oxygen, nitrate, and light gradients were also detectable. Photosynthetic activity and nitrification were both predominantly restricted to the outer 500 µm, but while photosynthesis was relatively insensitive to the oxygen and nutrient (ammonium, phosphate, acetate) concentrations tested, nitrification was highly sensitive. Oxygen was cycled internally, with oxygen produced through photosynthesis rapidly consumed by aerobic respiration and nitrification. Oxygen production and consumption were well balanced. Similarly, nitrogen was cycled through paired nitrification and denitrification, and carbon was exchanged through photosynthesis and respiration. Our findings highlight that photogranules are complete, complex ecosystems with multiple linked nutrient cycles and will aid engineering decisions in photogranular wastewater treatment.
Collapse
|
19
|
Trebuch LM, Schoofs K, Vaessen SMF, Neu TR, Janssen M, Wijffels RH, Vet LEM, Fernandes TV. N 2 -fixation can sustain wastewater treatment performance of photogranules under nitrogen-limiting conditions. Biotechnol Bioeng 2023; 120:1303-1315. [PMID: 36779371 DOI: 10.1002/bit.28349] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/30/2022] [Revised: 12/23/2022] [Accepted: 02/09/2023] [Indexed: 02/14/2023]
Abstract
Wastewater characteristics can vary significantly, and in some municipal wastewaters the N:P ratio is as low as 5 resulting in nitrogen-limiting conditions. In this study, the microbial community, function, and morphology of photogranules under nitrogen-replete (N+) and limiting (N-) conditions was assessed in sequencing batch reactors. Photogranules under N- condition were nitrogen deprived 2/3 of a batch cycle duration. Surprisingly, this nitrogen limitation had no adverse effect on biomass productivity. Moreover, phosphorus and chemical oxygen demand removal were similar to their removal under N+ conditions. Although performance was similar, the difference in granule morphology was obvious. While N+ photogranules were dense and structurally confined, N- photogranules showed loose structures with occasional voids. Microbial community analysis revealed high abundance of cyanobacteria capable of N2 -fixation. These were higher at N- (38%) than N+ (29%) treatments, showing that photogranules could adjust and maintain treatment performance and high biomass productivity by means of N2 -fixation.
Collapse
Affiliation(s)
- Lukas M Trebuch
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Wageningen, The Netherlands.,Bioprocess Engineering, AlgaePARC Wageningen University, Wageningen, The Netherlands
| | - Kobe Schoofs
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Wageningen, The Netherlands.,Bioprocess Engineering, AlgaePARC Wageningen University, Wageningen, The Netherlands
| | - Stijn M F Vaessen
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Wageningen, The Netherlands.,Bioprocess Engineering, AlgaePARC Wageningen University, Wageningen, The Netherlands
| | - Thomas R Neu
- Microbiology of Interfaces, Department River Ecology, Helmholtz Centre for Environmental Research - UFZ, Magdeburg, Germany
| | - Marcel Janssen
- Bioprocess Engineering, AlgaePARC Wageningen University, Wageningen, The Netherlands
| | - René H Wijffels
- Bioprocess Engineering, AlgaePARC Wageningen University, Wageningen, The Netherlands.,Faculty of Biosciences and Aquaculture, Nord University, Bodø, Norway
| | - Louise E M Vet
- Department of Terrestrial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Wageningen, The Netherlands
| | - Tânia V Fernandes
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Wageningen, The Netherlands
| |
Collapse
|
20
|
Xiong W, Wang S, Jin Y, Wu Z, Liu D, Su H. Insights into nitrogen and phosphorus metabolic mechanisms of algal-bacterial aerobic granular sludge via metagenomics: Performance, microbial community and functional genes. BIORESOURCE TECHNOLOGY 2023; 369:128442. [PMID: 36470490 DOI: 10.1016/j.biortech.2022.128442] [Citation(s) in RCA: 13] [Impact Index Per Article: 13.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/01/2022] [Revised: 11/30/2022] [Accepted: 12/01/2022] [Indexed: 06/17/2023]
Abstract
Aiming to propose the potential mechanism for the enhancement of nitrogen (N) and phosphorus (P) removal of algal-bacterial aerobic granular sludge (A-AGS), metagenomic analysis was applied to identify the metabolic pathways. The results showed that chemical oxygen demand, ammonia nitrogen, total N, and total P removal of A-AGS could reach to 94.5%, 97.5%, 78.1%, and 88.5%, respectively. Algae enriched the content of extracellular polymeric substance, which significantly promoted the formation of A-AGS. Further investigations in functional genes suggested that nitrification process (amo, nxr, hao, etc.), denitrification process (nir, nap, nor, etc.), and polyphosphate accumulation (ppk, ppk2, etc.) were enhanced greatly in A-AGS. Notably, genus Thauera was the dominant source of functional genes, which penetrated both in N and P metabolism. The higher N and P removal performance in A-AGS could be attributed to synergistic effect between bacteria and microalgae, which may provide the basic for the application in wastewater treatment.
Collapse
Affiliation(s)
- Wei Xiong
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Shaojie Wang
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Yu Jin
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Zhiqing Wu
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Dan Liu
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Haijia Su
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China.
| |
Collapse
|
21
|
Shi Y, Ji B, Zhang X, Liu Y. Auto-floating oxygenic microalgal-bacterial granular sludge. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 856:159175. [PMID: 36191702 DOI: 10.1016/j.scitotenv.2022.159175] [Citation(s) in RCA: 7] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/25/2022] [Revised: 09/26/2022] [Accepted: 09/28/2022] [Indexed: 06/16/2023]
Abstract
As an emerging green wastewater treatment technology, the microalgal-bacterial granular sludge (MBGS) process has attracted increasing interest under the current situation of global climate change. However, little information is available for its performance in treating municipal wastewater under outdoor conditions. Thus, this study evaluated the behaviors of MBGS for treating simulated and real municipal wastewater under natural diel conditions. The results showed that a significant accumulation of oxygen bubbles during daily operation led to the auto-floating of the conventional settable MBGS. The removal of organics was relatively stable during day-night cycles, while the removals of total nitrogen and total phosphorus were dependent on the saturated oxygen concentration over 10 mg/L in MBGS system. Furthermore, oxygen bubbles generated by photosynthesis of microalgae (Scenedesmaceae and Cyanobacteria) due to microalgae phototaxis were found to be attached onto the surface of granules, causing the auto-flotation of MBGS. The formation process of the auto-floating oxygenic MBGS was clarified and further analysis suggested that the non-aerated settable MBGS would be able to auto-float at an average outdoor light intensity of 140 μ mol/m2/s. Overall, the auto-floating oxygenic MBGS process was demonstrated to be feasible for real municipal wastewater treatment, even under rainy and cloudy days, advancing the knowledge and adding theoretical basis for its further applications.
Collapse
Affiliation(s)
- Yuting Shi
- Department of Water and Wastewater Engineering, School of Urban Construction, Wuhan University of Science and Technology, Wuhan 430065, China
| | - Bin Ji
- Department of Water and Wastewater Engineering, School of Urban Construction, Wuhan University of Science and Technology, Wuhan 430065, China.
| | - Xiaoyuan Zhang
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore
| | - Yu Liu
- Advanced Environmental Biotechnology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, 50 Nanyang Avenue, Singapore 639798, Singapore
| |
Collapse
|
22
|
Li C, Wang JH, Yu C, Zhang JT, Chi ZY, Zhang Q. Growth-promoting effects of phytohormones on capillary-driven attached Chlorella sp. biofilm. BIORESOURCE TECHNOLOGY 2022; 364:128117. [PMID: 36244605 DOI: 10.1016/j.biortech.2022.128117] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/07/2022] [Revised: 10/07/2022] [Accepted: 10/08/2022] [Indexed: 06/16/2023]
Abstract
Using low strength wastewater for microalgae cultivation is challenged by slow growth and biomass harvesting issue in suspended systems, and growth-promoting effects of phytohormones at currently recommended dosages could neither obtain high enough biomass concentrations nor economic feasibility. This study aims to solve the issues of slow growth, biomass harvest, and phytohormone costs altogether by supplementing low dosage phytohormones in an improved capillary-driven attached cultivation device. The device displayed nutrients-condensing properties, and dosages of indole acetic acid (IAA), 6-benzylaminopurine (6-BA), and salicylic acid (SA) for highest microalgal growth were respectively 10-6 M, 10-6 M, and 10-7 M, being at least one order of magnitude lower than in suspended cultures. SA was most effective in growth-promoting (up to 7.0 g/m2 biomass density) and nutrients uptake (up to 98.6 % from the bulk environment), while IAA was most effective in antioxidative defenses. These results provided new insights in cost-effective and harvesting-convenient microalgae production.
Collapse
Affiliation(s)
- Chi Li
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Jing-Han Wang
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China; Key Laboratory of Environment Controlled Aquaculture, Dalian Ocean University, Dalian 116023, PR China.
| | - Chong Yu
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Jing-Tian Zhang
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Zhan-You Chi
- School of Bioengineering, Dalian University of Technology, Dalian 116024, PR China
| | - Qian Zhang
- Key Laboratory of Environment Controlled Aquaculture, Dalian Ocean University, Dalian 116023, PR China
| |
Collapse
|
23
|
Han F, Zhou W. Nitrogen recovery from wastewater by microbial assimilation - A review. BIORESOURCE TECHNOLOGY 2022; 363:127933. [PMID: 36100188 DOI: 10.1016/j.biortech.2022.127933] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/29/2022] [Revised: 09/03/2022] [Accepted: 09/06/2022] [Indexed: 06/15/2023]
Abstract
The increased nitrogen (N) input with low utilization rate in artificial N management has led to massive reactive N (Nr) flows, putting the Earth in a high-risk state. It is essential to recover and recycle Nr during or after Nr removal from wastewater to reduce N input while simultaneously mitigate Nr pollution in addressing the N stress. However, mechanisms for efficient Nr recovery during or after Nr removal remain unclear. Here, the occurrence of N risk and progress in wastewater treatment in recent years as well as challenges of the current technologies for N recovery from wastewater were reviewed. Through analyzing N conversion fluxes in biogeochemical N-cycling networks, microbial N assimilation through photosynthetic and heterotrophic microorganisms was highlighted as promising alternative for synergistic N removal and recovery in wastewater treatment. In addition, the prospects and gaps of Nr recovery from wastewater through microbial assimilation are discussed.
Collapse
Affiliation(s)
- Fei Han
- School of Environmental Science and Engineering, Shandong University, Qingdao, Shandong 266000, China
| | - Weizhi Zhou
- School of Civil Engineering, Shandong University, Jinan, Shandong 250002, China.
| |
Collapse
|
24
|
Abbew AW, Amadu AA, Qiu S, Champagne P, Adebayo I, Anifowose PO, Ge S. Understanding the influence of free nitrous acid on microalgal-bacterial consortium in wastewater treatment: A critical review. BIORESOURCE TECHNOLOGY 2022; 363:127916. [PMID: 36087656 DOI: 10.1016/j.biortech.2022.127916] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/12/2022] [Revised: 08/31/2022] [Accepted: 09/04/2022] [Indexed: 06/15/2023]
Abstract
Microalgal-bacterial consortium (MBC) constitutes a sustainable and efficient alternative to the conventional activated sludge process for wastewater treatment (WWT). Recently, integrating the MBC process with nitritation (i.e., shortcut MBC) has been proposed to achieve added benefits of reduced carbon and aeration requirements. In the shortcut MBC system, nitrite or free nitrous acid (FNA) accumulation exerts antimicrobial influences that disrupt the stable process performance. In this review, the formation and interactions that influence the performance of the MBC were firstly summarized. Then the influence of FNA on microalgal and bacterial monocultures and related mechanisms together with the knowledge gaps of FNA influence on the shortcut MBC were highlighted. Other challenges and future perspectives that impact the scale-up of the shortcut MBC for WWT were illustrated. A potential roadmap is proposed on how to maximize the stable operation of the shortcut MBC system for sustainable WWT and high-value biomass production.
Collapse
Affiliation(s)
- Abdul-Wahab Abbew
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Ayesha Algade Amadu
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Shuang Qiu
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Pascale Champagne
- Department of Chemistry, Queen's University, Kingston, Ontario K7L 3N6, Canada
| | - Ismaeel Adebayo
- School of Chemical Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Peter Oluwaseun Anifowose
- School of Science, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Shijian Ge
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China.
| |
Collapse
|
25
|
Jiang Q, Chen H, Fu Z, Fu X, Wang J, Liang Y, Yin H, Yang J, Jiang J, Yang X, Wang H, Liu Z, Su R. Current Progress, Challenges and Perspectives in the Microalgal-Bacterial Aerobic Granular Sludge Process: A Review. INTERNATIONAL JOURNAL OF ENVIRONMENTAL RESEARCH AND PUBLIC HEALTH 2022; 19:13950. [PMID: 36360829 PMCID: PMC9655209 DOI: 10.3390/ijerph192113950] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 09/27/2022] [Revised: 10/18/2022] [Accepted: 10/25/2022] [Indexed: 06/16/2023]
Abstract
Traditional wastewater treatment technologies have become increasingly inefficient to meet the needs of low-consumption and sustainable wastewater treatment. Researchers are committed to seeking new wastewater treatment technologies, to reduce the pressure on the environment caused by resource shortages. Recently, a microalgal-bacterial granular sludge (MBGS) technology has attracted widespread attention due to its high efficiency wastewater treatment capacity, low energy consumption, low CO2 emissions, potentially high added values, and resource recovery capabilities. This review focused primarily on the following aspects of microalgal-bacterial granular sludge technology: (1) MBGS culture and maintenance operating parameters, (2) MBGS application in different wastewaters, (3) MBGS additional products: biofuels and bioproducts, (4) MBGS energy saving and consumption reduction: greenhouse gas emission reduction, and (5) challenges and prospects. The information in this review will help us better understand the current progress and future direction of the MBGS technology development. It is expected that this review will provide a sound theoretical basis for the practical applications of a MBGS technology in environmentally sustainable wastewater treatment, resource recovery, and system optimization.
Collapse
Affiliation(s)
- Qianrong Jiang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
- South China Institute of Environmental Sciences, Ministry of Ecology and Environment, Guangzhou 510655, China
| | - Honglei Chen
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Zeding Fu
- School of Hydraulic and Environmental Engineering, Changsha University of Science & Technology, Changsha 410114, China
| | - Xiaohua Fu
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Jiacheng Wang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Yingqi Liang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Hailong Yin
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Junbo Yang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Jie Jiang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
- South China Institute of Environmental Sciences, Ministry of Ecology and Environment, Guangzhou 510655, China
| | - Xinxin Yang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - He Wang
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Zhiming Liu
- Department of Biology, Eastern New Mexico University, Portales, NM 88130, USA
| | - Rongkui Su
- Ecological Environment Management and Assessment Center, Central South University of Forestry and Technology, Changsha 410004, China
- School of Environmental Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| |
Collapse
|
26
|
Wang YN, Zhang JT, Wang JH, Chi ZY, Zhang Q. High robustness of attached Chlorella sp. on semi-continuous low strength effluent polishing under axenic and xenic conditions. ALGAL RES 2022. [DOI: 10.1016/j.algal.2022.102836] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/01/2022]
|
27
|
Li J, Ma J, Liao H, Li X, Shen L, Lin H, Sun L, Ou R, He D. Hot-pressed membrane assemblies enhancing the biofilm formation and nitrogen removal in a membrane-aerated biofilm reactor. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 833:155003. [PMID: 35390370 DOI: 10.1016/j.scitotenv.2022.155003] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/07/2022] [Revised: 03/23/2022] [Accepted: 03/30/2022] [Indexed: 06/14/2023]
Abstract
Membrane-aerated biofilm reactor (MABR) is gaining popularity in wastewater treatment as a result of the low-energy delivery of oxygen from the carrier side and reduced sludge waste production, although its wider application suffers from the difficulty in microbial colonization on the smooth, hydrophobic membrane surface. In this study, a newly designed membrane/non-woven fabric assembly, prepared via a facile hot-pressing method, is demonstrated to be efficient in promoting the biofilm formation and nitrogen removal in MABR. The assembly achieved rough surface structure to retain biomass whilst sustained the surface hydrophobicity for a high oxygen transfer ability, which is crucial to support a resilient biofilm. Compared with the slower biomass growth and severe detachment of biofilm in the control, a thicker biofilm was quickly developed on the hot-pressed membrane assembly. High loading rates of organic matter, ammonia nitrogen and total nitrogen (TN) in the MABR using the hot-pressed membrane were 154.9 ± 5.4 g COD/(m2·d), 25.5 ± 0.6 g N/(m2·d) and 22.6 ± 0.7 g N/(m2·d), respectively. Particularly, the removal efficiency of TN was up to 82.8%, which was 2.5 times higher than the control. Furthermore, the biofilm grown on the hot-pressed membrane assembly organized a stable microbial community structure with a steady evolution to achieve a synergistic denitrifying function. Among the bacterial phylotypes, OLB8 might be crucial in denitrification. This study highlighted the significance of this facile membrane modification method to improve the process performance of MABR in wastewater treatment.
Collapse
Affiliation(s)
- Jibin Li
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China
| | - Jinxing Ma
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China; Southern Marine Science and Engineering Guangdong Laboratory (Guangzhou), Guangzhou 511458, PR China
| | - Huaiyu Liao
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China
| | - Xianhui Li
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China; Southern Marine Science and Engineering Guangdong Laboratory (Guangzhou), Guangzhou 511458, PR China
| | - Liguo Shen
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua 321004, PR China
| | - Hongjun Lin
- College of Geography and Environmental Sciences, Zhejiang Normal University, Jinhua 321004, PR China
| | - Li Sun
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China
| | - Rui Ou
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China
| | - Di He
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, PR China; Southern Marine Science and Engineering Guangdong Laboratory (Guangzhou), Guangzhou 511458, PR China.
| |
Collapse
|
28
|
|
29
|
Sirohi R, Joun J, Lee JY, Yu BS, Sim SJ. Waste mitigation and resource recovery from food industry wastewater employing microalgae-bacterial consortium. BIORESOURCE TECHNOLOGY 2022; 352:127129. [PMID: 35398537 DOI: 10.1016/j.biortech.2022.127129] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/27/2022] [Revised: 04/03/2022] [Accepted: 04/05/2022] [Indexed: 06/14/2023]
Abstract
Wastewater generated by the food industry is rich in nitrogen and phosphorus with possible presence of heavy metals. Physical and chemical methods of treatment, although effective, are expensive and may cause secondary environmental pollution damaging aquatic and human life. Traditional biological methods are eco-friendly and cost-effective but involve standalone microorganisms that pose risk of contamination and are not as effective. This review discusses the application of novel microalgal-bacterial consortium as a solution for the resource recovery and treatment of dairy, starch and aquaculture wastewater. Use of biofilm reactors containing anaerobic and aerobic sludge has shown 80-90% and > 90% COD and nutrient removal efficiency in treatment of dairy and starch processing wastewater, respectively. The treatment of aquaculture processing wastewater can be challenging due to high sality and requires salt-tolerant bacteria-microalgae consortium. In this regard, the identification of dominant microalgae and bacteria using 16S rRNA and 18S rRNA genes is recommended.
Collapse
Affiliation(s)
- Ranjna Sirohi
- Department of Chemical and Biological Engineering, Korea University, 145, Anam-ro, Seongbuk-gu, Seoul 02841, Republic of Korea
| | - Jaemin Joun
- Department of Chemical and Biological Engineering, Korea University, 145, Anam-ro, Seongbuk-gu, Seoul 02841, Republic of Korea
| | - Ji Young Lee
- Department of Chemical and Biological Engineering, Korea University, 145, Anam-ro, Seongbuk-gu, Seoul 02841, Republic of Korea
| | - Byung Sun Yu
- Department of Chemical and Biological Engineering, Korea University, 145, Anam-ro, Seongbuk-gu, Seoul 02841, Republic of Korea
| | - Sang Jun Sim
- Department of Chemical and Biological Engineering, Korea University, 145, Anam-ro, Seongbuk-gu, Seoul 02841, Republic of Korea.
| |
Collapse
|
30
|
Blansaer N, Alloul A, Verstraete W, Vlaeminck SE, Smets BF. Aggregation of purple bacteria in an upflow photobioreactor to facilitate solid/liquid separation: Impact of organic loading rate, hydraulic retention time and water composition. BIORESOURCE TECHNOLOGY 2022; 348:126806. [PMID: 35131464 DOI: 10.1016/j.biortech.2022.126806] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/17/2021] [Revised: 01/26/2022] [Accepted: 01/28/2022] [Indexed: 06/14/2023]
Abstract
Purple non-sulfur bacteria (PNSB) form an interesting group of microbes for resource recovery from wastewater. Solid/liquid separation is key for biomass and value-added products recovery, yet insights into PNSB aggregation are thus far limited. This study explored the effects of organic loading rate (OLR), hydraulic retention time (HRT) and water composition on the aggregation of Rhodobacter capsulatus in an anaerobic upflow photobioreactor. Between 2.0 and 14.6 gCOD/(L.d), the optimal OLR for aggregation was 6.1 gCOD/(L.d), resulting in a sedimentation flux of 5.9 kgTSS/(m2.h). With HRT tested between 0.04 and 1.00 d, disaggregation occurred at the relatively long HRT (1 d), possibly due to accumulation of thus far unidentified heat-labile metabolites. Chemical oxygen demand (COD) to nitrogen ratios (6-35 gCOD/gN) and the nitrogen source (ammonium vs. glutamate) also impacted aggregation, highlighting the importance of the type of wastewater and its pre-treatment. These novel insights to improve purple biomass separation pave the way for cost-efficient PNSB applications.
Collapse
Affiliation(s)
- Naïm Blansaer
- Research Group of Sustainable Energy, Air and Water Technology, Department of Bioscience Engineering, University of Antwerp, Groenenborgerlaan 171, 2020 Antwerpen, Belgium
| | - Abbas Alloul
- Research Group of Sustainable Energy, Air and Water Technology, Department of Bioscience Engineering, University of Antwerp, Groenenborgerlaan 171, 2020 Antwerpen, Belgium
| | - Willy Verstraete
- Center for Microbial Ecology and Technology, Faculty of Bioscience Engineering, Ghent University, Coupure Links 653, 9000 Gent, Belgium
| | - Siegfried E Vlaeminck
- Research Group of Sustainable Energy, Air and Water Technology, Department of Bioscience Engineering, University of Antwerp, Groenenborgerlaan 171, 2020 Antwerpen, Belgium
| | - Barth F Smets
- Department of Environmental Engineering, Technical University of Denmark, Kongens Lyngby 28000, Denmark.
| |
Collapse
|
31
|
Wang D, Li A. Effect of zero-valent iron and granular activated carbon on nutrient removal and community assembly of photogranules treating low-strength wastewater. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 806:151311. [PMID: 34743817 DOI: 10.1016/j.scitotenv.2021.151311] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/21/2021] [Revised: 10/18/2021] [Accepted: 10/25/2021] [Indexed: 06/13/2023]
Abstract
Traditional wastewater treatment processes with high energy consumption and greenhouse gas emissions are not suitable for rural areas with low sewage strength and wide distribution. In this study, a microalgae-bacteria synergistic photogranules system was developed under the impetus of green chemical additives to address these challenges. The results showed that zero-valent iron (ZVI) or granular activated carbon (GAC) addition made successful photogranulation treating low-strength wastewater with excellent settleability and stability performance (settling velocity: 14-22 m h-1; integrity coefficient: 0.81-6.62%), while systems without light or additives failed due to the bio-granules disintegration caused by the overgrowth of predators or phototrophic species. A better nutrient removal performance (TN < 15 mg L-1, TP < 0.4 mg L-1) was observed in photogranules systems, and stoichiometric and biological analysis found that the divisions of nitrogen removal by microalgae and bacteria were different for photogranules between GAC and ZVI additions. As a physical enhancer, GAC can be used as the nucleus of photogranules regenerating after granules disintegration rather than affecting the community succession process. However, ZVI addition strengthened the sedimentation ability and stability of photogranules through chemical and biological effects, focusing on enhancing bacterial community diversity, enriching biofilm formation bacteria and inhibiting the overgrowth of filamentous cyanobacteria. Notably, the photogranules process with ZVI addition could be operated under non-aeration conditions without compromising removal efficiency. There existed an ideal distribution of microalgae and bacterial functional species in the photogranules, which seemed to be essential for its self-sustained synergistic symbiosis and stability. Consequently, this work might provide engineering alternatives for realizing carbon neutrality and environmental sustainability of the decentralized wastewater treatment process for low-strength wastewater in rural areas.
Collapse
Affiliation(s)
- Danyang Wang
- Key Laboratory of Water and Sediment Sciences of Ministry of Education, State Key Laboratory of Water Environment Simulation, School of Environment, Beijing Normal University, Beijing 100875, China
| | - Anjie Li
- Key Laboratory of Water and Sediment Sciences of Ministry of Education, State Key Laboratory of Water Environment Simulation, School of Environment, Beijing Normal University, Beijing 100875, China.
| |
Collapse
|
32
|
Ji B, Liu C. CO 2 improves the microalgal-bacterial granular sludge towards carbon-negative wastewater treatment. WATER RESEARCH 2022; 208:117865. [PMID: 34826738 DOI: 10.1016/j.watres.2021.117865] [Citation(s) in RCA: 41] [Impact Index Per Article: 20.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/03/2021] [Revised: 11/08/2021] [Accepted: 11/09/2021] [Indexed: 06/13/2023]
Abstract
As a promising wastewater treatment technology, little is known about whether the greenhouse gas CO2 can be applied for microalgal-bacterial granular sludge (MBGS) process. This article applied CO2 for improving MBGS process. It was found that the physical structure of MBGS with no CO2 addition appeared to have a trend to be loose and disintegrated, with a sludge volume index at 5 min (SVI5) of over 150 mL/g and an average pore size of 35 nm in 60 d operation. However, CO2 could maintain the compact and integrated structure of MBGS with a SVI5 lower than 50 mL/g and an average pore size ranging from 10 to 13 nm. CO2 could enhance the production of extracellular polysaccharides and aromatic protein, thus favoring the granular stability of MBGS. CO2 could change the aqueous environment, e.g. lowering the pH values, which resulted in different microbial communities as well as metabolic potentials of MBGS. As for the reactor performance, CO2 could significantly improve the removals of organics and phosphorus, evidenced by the enhancement of genes encoding acetate-CoA ligase and ATPase, respectively. Although the mass ratio of algae to bacteria was elevated by CO2 addition, the ammonia removal related enzymes of glutamate dehydrogenase and glutamine synthetase could be negatively and positively impacted by CO2, respectively. Mass balance analysis of carbon indicated that CO2 could provide additional carbon source as well as enhance the buffering capacity for the MBGS system. Further estimations suggested that the MBGS process could achieve a carbon-negative objective for municipal wastewater treatment by supplying CO2 as additional carbon source. Hence, CO2 supply for MBGS process in municipal wastewater treatment can be deemed as a two-birds-one-stone strategy, i.e. maintaining the granular stability and eliminating the carbon emission. This article can advance our basic knowledge on MBGS process towards environment-sustainable wastewater treatment.
Collapse
Affiliation(s)
- Bin Ji
- Department of Water and Wastewater Engineering, Wuhan University of Science and Technology, Wuhan, 430065, China.
| | - Cheng Liu
- Department of Water and Wastewater Engineering, Wuhan University of Science and Technology, Wuhan, 430065, China
| |
Collapse
|
33
|
Wang YN, Pang H, Yu C, Li C, Wang JH, Chi ZY, Xu YP, Li SY, Zhang Q, Che J. Growth and nutrients removal characteristics of attached Chlorella sp. using synthetic municipal secondary effluent with varied hydraulic retention times and biomass harvest intervals. ALGAL RES 2022. [DOI: 10.1016/j.algal.2021.102600] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/27/2022]
|
34
|
Zhang C, Li S, Ho SH. Converting nitrogen and phosphorus wastewater into bioenergy using microalgae-bacteria consortia: A critical review. BIORESOURCE TECHNOLOGY 2021; 342:126056. [PMID: 34601027 DOI: 10.1016/j.biortech.2021.126056] [Citation(s) in RCA: 67] [Impact Index Per Article: 22.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/28/2021] [Revised: 09/23/2021] [Accepted: 09/27/2021] [Indexed: 06/13/2023]
Abstract
Conventional wastewater treatment using activated sludge cannot efficiently eliminate nitrogen and phosphorus, thus engendering the risk of water eutrophication and ecosystem disruption. Fortunately, a new wastewater treatment process applying microalgae-bacteria consortia has attracted considerable interests due to its excellent performance of nutrients removal. Moreover, some bacteria facilitate the harvest of microalgal biomass through bio-flocculation. Additionally, while stimulating the functional bacteria, the improved biomass and enriched components also brighten bioenergy production from the perspective of practical applications. Thus, this review first summarizes the current development of nutrients removal and mutualistic interaction using microalgae-bacteria consortia. Then, advancements in bio-flocculation are completely described and the corresponding mechanisms are thoroughly revealed. Eventually, the recent advances of bioenergy production (i.e., biodiesel, biohydrogen, bioethanol, and bioelectricity) using microalgae-bacteria consortia are comprehensively discussed. Together, this review will provide the ongoing challenges and future developmental directions for better converting nitrogen and phosphorus wastewater into bioenergy using microalgae-bacteria consortia.
Collapse
Affiliation(s)
- Chaofan Zhang
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| | - Shengnan Li
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| | - Shih-Hsin Ho
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, PR China.
| |
Collapse
|
35
|
Qi F, Jia Y, Mu R, Ma G, Guo Q, Meng Q, Yu G, Xie J. Convergent community structure of algal-bacterial consortia and its effects on advanced wastewater treatment and biomass production. Sci Rep 2021; 11:21118. [PMID: 34702904 PMCID: PMC8548336 DOI: 10.1038/s41598-021-00517-x] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/07/2021] [Accepted: 10/06/2021] [Indexed: 11/08/2022] Open
Abstract
Microalgal-bacterial consortium is an effective way to meet increasingly stringent standards in wastewater treatment. However, the mechanism of wastewater removal effect has not been properly explained in community structure by phycosphere. And little is known about that the concept of macroecology was introduced into phycosphere to explain the phenomenon. In the study, the algal-bacterial consortia with different ratios of algae and sludge were cultured in same aerobic wastewater within 48 h in photobioreactors (PSBRs). Community structure at start and end was texted by metagenomic analysis. Bray-Curtis similarities analysis based on microbial community showed that there was obvious convergent succession in all consortia, which is well known as "convergence" in macroecology. The result showed that Bray-Curtis similarities at End (overall above 0.88) were higher than these at Start (almost less than 0.66). In terms of community structure, the consortium with 5:1 ratio at Start are the more similar with the consortia at End by which the maximum removal of total dissolved nitrogen (TDN, 73.69%), total dissolved phosphorus (TDP, 94.40%) and NH3-N (93.26%) in wastewater treatment process and biomass production (98.2%) higher than other consortia, according with climax community in macroecology with the highest resource utilization than other communities. Therefore, the macroecology can be introduced into phycosphere to explain the consortium for advanced wastewater treatment and optimization community structure. And the study revealed a novel insight into treatment effect and community structure of algal-bacterial consortia for advanced wastewater treatment, a new idea for to shortening the culture time of consortium and optimize predicting their ecological community structure and predicting ecological community.
Collapse
Affiliation(s)
- Feng Qi
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Yantian Jia
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Ruimin Mu
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China.
| | - Guixia Ma
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Qingyang Guo
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Qianya Meng
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Gejiang Yu
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Jun Xie
- Shandong Provincial Eco-Environment Monitoring Center, Jinan, China
| |
Collapse
|
36
|
Fan S, Zhu L, Ji B. Deciphering the effect of light intensity on microalgal-bacterial granular sludge process for non-aerated municipal wastewater treatment. ALGAL RES 2021. [DOI: 10.1016/j.algal.2021.102437] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
37
|
Park C, Takeuchi N. Unmasking photogranulation in decreasing glacial albedo and net autotrophic wastewater treatment. Environ Microbiol 2021; 23:6391-6404. [PMID: 34545673 PMCID: PMC9292683 DOI: 10.1111/1462-2920.15780] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/02/2021] [Revised: 09/13/2021] [Accepted: 09/16/2021] [Indexed: 11/29/2022]
Abstract
In both natural and built environments, microbes on occasions manifest in spherical aggregates instead of substratum‐affixed biofilms. These microbial aggregates are conventionally referred to as granules. Cryoconites are mineral rich granules that appear on glacier surfaces and are linked with expanding surface darkening, thus decreasing albedo, and enhanced melt. The oxygenic photogranules (OPGs) are organic rich granules that grow in wastewater, which enables wastewater treatment with photosynthetically produced oxygen and which presents potential for net autotrophic wastewater treatment in a compact system. Despite obvious differences inherent in the two, cryoconite and OPG pose striking resemblance. In both, the order Oscillatoriales in Cyanobacteria envelope inner materials and develop dense spheroidal aggregates. We explore the mechanism of photogranulation on account of high similarity between cryoconites and OPGs. We contend that there is no universal external cause for photogranulation. However, cryoconites and OPGs, as well as their intravariations, which are all under different stress fields, are the outcome of universal physiological processes of the Oscillatoriales interfacing with goldilocks interactions of stresses. Finding the rules of photogranulation may enhance engineering of glacier and wastewater systems to manipulate their ecosystem impacts.
Collapse
Affiliation(s)
- Chul Park
- Department of Civil and Environmental Engineering, University of Massachusetts Amherst, Amherst, Massachusetts, 01003, USA
| | - Nozomu Takeuchi
- Department of Earth Sciences, Graduate School of Science, Chiba University, Chiba, 263-8522, Japan
| |
Collapse
|
38
|
Su X, Yuan J, Dong W, Sun F, Wang M, Dong Z, Li W, Du C. Organic and nitrogenous pollutants removal paths in vegetation activated sludge process (V-ASP) for decentralized wastewater treatment by using stable isotope technique. BIORESOURCE TECHNOLOGY 2021; 330:124959. [PMID: 33735729 DOI: 10.1016/j.biortech.2021.124959] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/11/2021] [Revised: 03/04/2021] [Accepted: 03/05/2021] [Indexed: 06/12/2023]
Abstract
The organics (C) and nitrogenous (N) pollutants removal paths by functional units in vegetation-activated sludge process (V-ASP) were investigated by using stable isotope probing and high-throughput sequencing for the first time. V-ASP system displayed superior treatment performance compared to conventional activated sludge system, as manifested by its greater C and N removal efficiencies, higher abundance of denitrifying and heterotrophic functional Genus, and better resistance to low temperature. Isotope δ13C and δ15N were continuously accumulated in plant roots allocated in the V-ASP, where suspended sludge demonstrated obviously higher C and N enrichment rates compared to the rhizosphere sludge. The mass balance estimation showed that bacterial dissimilation was the dominant removal paths for C (54.13%) and N (47.53%). The underlying pollutants removal paths evidenced the advantageous of V-ASP that is a high feasible and promising approach for decentralized wastewater treatment process.
Collapse
Affiliation(s)
- Xiaoli Su
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen 518055, China
| | - Jiajia Yuan
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen 518055, China; School of Civil and Environmental Engineering, Shenzhen Polytechnic, Shenzhen 518055, China
| | - Wenyi Dong
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen 518055, China
| | - Feiyun Sun
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen 518055, China.
| | - Mingming Wang
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen 518055, China
| | - Zijun Dong
- School of Civil and Environmental Engineering, Shenzhen Polytechnic, Shenzhen 518055, China
| | - Wenzheng Li
- School of Life and Environmental Sciences, The University of Sydney, Sydney, Australia
| | - Changhang Du
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen 518055, China
| |
Collapse
|
39
|
Leong WH, Lim JW, Lam MK, Lam SM, Sin JC, Samson A. Novel sequential flow baffled microalgal-bacterial photobioreactor for enhancing nitrogen assimilation into microalgal biomass whilst bioremediating nutrient-rich wastewater simultaneously. JOURNAL OF HAZARDOUS MATERIALS 2021; 409:124455. [PMID: 33168319 DOI: 10.1016/j.jhazmat.2020.124455] [Citation(s) in RCA: 17] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/07/2020] [Revised: 09/11/2020] [Accepted: 10/30/2020] [Indexed: 06/11/2023]
Abstract
A novel sequential flow baffled microalgal-bacterial (SFB-AlgalBac) photobioreactor was designed to cater for the synergistic interactions between microalgal and bacterial consortia to enhance nitrogen assimilation into microalgal biomass from nutrient-rich wastewater medium. The performance of the SFB-AlgalBac photobioreactor was found to be optimum at the influent flow rate of 5.0 L/d, equivalent to 20 days of hydraulic retention time (HRT). The highest microalgal nitrogen assimilation rate (0.0271 /d) and biomass productivity (1350 mg/d) were recorded amidst this flow rate. Further increase to the 10.0 L/d flow rate reduced the photobioreactor performance, as evidenced by a reduction in microalgal biomass productivity (>10%). The microalgal biomass per unit of nitrogen assimilated values were attained at 16.69 mg/mg for the 5.0 L/d flow rate as opposed to 7.73 mg/mg for the 10.0 L/d flow rate, despite both having comparable specific growth rates. Also, the prior influent treatment by activated sludge was found to exude extracellular polymeric substances which significantly improved the microalgal biomass settleability up to 37%. The employment of SFB-AlgalBac photobioreactor is anticipated could exploit the low-cost nitrogen sources from nutrient-rich wastewaters via bioconversion into valuable microalgal biomass while fulfilling the requirements of sustainable wastewater treatment technologies.
Collapse
Affiliation(s)
- Wai Hong Leong
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610 Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Jun Wei Lim
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610 Seri Iskandar, Perak Darul Ridzuan, Malaysia.
| | - Man Kee Lam
- Department of Chemical Engineering, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610 Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Sze Mun Lam
- Department of Environmental Engineering, Faculty of Engineering and Green Technology (FEGT), Universiti Tunku Abdul Rahman, 31900 Kampar, Perak Darul Ridzuan, Malaysia
| | - Jin Chung Sin
- Department of Petrochemical Engineering, Faculty of Engineering and Green Technology (FEGT), Universiti Tunku Abdul Rahman, 31900 Kampar, Perak Darul Ridzuan, Malaysia
| | - Abby Samson
- Department of Mechanical Engineering, The University of Sheffield, Western Bank, Sheffield, S10 2TN, United Kingdom
| |
Collapse
|
40
|
Ji B, Wang S, Silva MRU, Zhang M, Liu Y. Microalgal-bacterial granular sludge for municipal wastewater treatment under simulated natural diel cycles: Performances-metabolic pathways-microbial community nexus. ALGAL RES 2021. [DOI: 10.1016/j.algal.2021.102198] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/27/2022]
|
41
|
Ji B, Zhu L, Wang S, Liu Y. Temperature-effect on the performance of non-aerated microalgal-bacterial granular sludge process in municipal wastewater treatment. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2021; 282:111955. [PMID: 33453624 DOI: 10.1016/j.jenvman.2021.111955] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/18/2020] [Revised: 11/11/2020] [Accepted: 01/03/2021] [Indexed: 06/12/2023]
Abstract
This paper investigated the performance of non-aerated microalgal-bacterial granular sludge (MBGS) process in municipal wastewater treatment at different temperatures. Results showed that the 70.5%, 81.9% and 86.1% of chemical oxygen demand (COD) could be removed at 15, 22 and 30 °C, respectively, indicating that a high temperature favored removal of organics due to promoted biomass growth. It was found that most of ammonia-N was removed via microbial assimilation by microalgae and bacteria in granules, with bacterial assimilation being dominant at the lower temperature. The phosphorus removal efficiency of 90.1% was achieved at 22 °C, with the presence of abundant Leptolyngbyales, a potential phosphorus accumulating alga. Chlorophyta grew much faster than Leptolyngbyales at 30 °C in microalgal-bacterial granules. It can be concluded that the contributions of microalgal and bacterial assimilations toward COD, ammonia and P removal appeared to be temperature-dependent, i.e. temperature could alter the symbiotic relationship between microalgae and bacteria. This study would contribute to the application of non-aerated MBGS process in municipal wastewater treatment with seasonal variation of temperature.
Collapse
Affiliation(s)
- Bin Ji
- Department of Water and Wastewater Engineering, Wuhan University of Science and Technology, Wuhan, 430065, China.
| | - Lin Zhu
- Department of Water and Wastewater Engineering, Wuhan University of Science and Technology, Wuhan, 430065, China
| | - Shulian Wang
- Hubei Key Laboratory of Ecological Remediation for Rivers-Lakes and Algal Utilization, Hubei University of Technology, Wuhan, 430068, China; Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore, 637141, Singapore
| | - Yu Liu
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore, 637141, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, 50 Nanyang Avenue, Singapore, 639798, Singapore
| |
Collapse
|
42
|
Stegman S, Batstone DJ, Rozendal R, Jensen PD, Hülsen T. Purple phototrophic bacteria granules under high and low upflow velocities. WATER RESEARCH 2021; 190:116760. [PMID: 33360616 DOI: 10.1016/j.watres.2020.116760] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/05/2020] [Revised: 12/16/2020] [Accepted: 12/16/2020] [Indexed: 06/12/2023]
Abstract
The application of granular biomass has enabled energy efficient, high-rate wastewater treatment systems. While initially designed for high-strength wastewater treatment, granular systems can also play a major role in resource recovery. This study focused on the formation of purple phototrophic bacteria (PPB) granular biomass during synthetic wastewater treatment. Liquid upflow velocity was applied as the driving force for granulation. Separate reactors were operated at either low (2-5m h-1) or high (6-9m h-1) upflow velocities, with sludge retention times (SRTs) ranging from 5-15d. Reactors produced anaerobic, photo-granules within ~50d. The sludge volume index (SVI30) of the granules was 10mL g-1 and average settling rates were greater than 30m h-1, both metrics being similar to existing granular technologies. Granule sizes of 2-3mm were recorded, however the particle size distribution was bimodal with a large floc fraction (70-80% volume fraction). The extracellular polymeric substance (EPS) and alginate-like extract (ALE) contents were similar to those in aerobic granular biomass. Fluorescence in-situ hybridisation (FISH) imaging identified PPB bacteria dispersed throughout the granules with very few methanogens and an active core. Outer layer morphology was substantially different in the two reactors. The high-upflow reactor had an outer layer of Chromatiales and an inner layer of Rhodobacteriales, while the low-upflow reactor had lower abundances of both, and limited layering. According to 16s gene sequencing, PPB were a similar fraction of the microbial community in both reactors (40-70%), but the high upflow granules were dominated by Chromatiales (supporting FISH results), while the low upflow velocity reactor had a more diverse PPB community. Methanogens were seen only in the low upflow granules and only in small amounts (≤8%). Granule crude protein content was ~0.60gCP gVS-1 (~0.45gCP gTS-1), similar to that from other PPB production technologies. The growth of a rapid settling and discrete PPB granular biomass on synthetic wastewater suggests methods for resource recovery using PPB can be diversified to also include granular biomass.
Collapse
Affiliation(s)
- Samuel Stegman
- Advanced Water Management Centre, Gehrmann Building, The University of Queensland, Brisbane, Queensland 4072, Australia
| | - Damien J Batstone
- Advanced Water Management Centre, Gehrmann Building, The University of Queensland, Brisbane, Queensland 4072, Australia
| | - René Rozendal
- Paques BV, Tjalke de Boerstritte 24, 8561 EL, Balk, Netherlands
| | - Paul D Jensen
- Advanced Water Management Centre, Gehrmann Building, The University of Queensland, Brisbane, Queensland 4072, Australia
| | - Tim Hülsen
- Advanced Water Management Centre, Gehrmann Building, The University of Queensland, Brisbane, Queensland 4072, Australia.
| |
Collapse
|
43
|
Zhang M, Ji B, Liu Y. Microalgal-bacterial granular sludge process: A game changer of future municipal wastewater treatment? THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 752:141957. [PMID: 32890823 DOI: 10.1016/j.scitotenv.2020.141957] [Citation(s) in RCA: 52] [Impact Index Per Article: 17.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/06/2020] [Revised: 08/22/2020] [Accepted: 08/22/2020] [Indexed: 06/11/2023]
Abstract
This article is in the hope to open a fundamental discussion on what should future municipal wastewater treatment process be. A paradigm shift of treatment technology from present single functionality of removing to multiple-functionality of synergetic water-resource-energy recovery and carbon neutral for maximizing both environmental and economic sustainability. However, the current treatment technologies could hardly meet such requirements. It is elucidated in this article that a microalgal-bacterial granular sludge process could offer a promising option for achieving the multiple goals of municipal wastewater reclamation including energy generation, resource recovery and carbon reduction.
Collapse
Affiliation(s)
- Meng Zhang
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore
| | - Bin Ji
- Department of Water and Wastewater Engineering, Wuhan University of Science and Technology, Wuhan 430065, China
| | - Yu Liu
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, 50 Nanyang Avenue, Singapore 639798, Singapore.
| |
Collapse
|
44
|
Wang W, Wang J, Wang H, Ma J, Wu M, Wang Y. Anammox Granule Enlargement by Heterogenous Granule Self-assembly. WATER RESEARCH 2020; 187:116454. [PMID: 33011570 DOI: 10.1016/j.watres.2020.116454] [Citation(s) in RCA: 28] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/28/2020] [Revised: 09/21/2020] [Accepted: 09/23/2020] [Indexed: 06/11/2023]
Abstract
Expansion in the size is an indispensable stage in the granular sludge life cycle, but little attention has been payed to the enlargement mechanism of granular sludge. Here, we propose a novel anammox granule enlargement mechanism by the self-assembly of heterogenous granules. Two different colors of anammox granules, dark-red granules (DR-Granules) and bright-red granules (BR-Granules) were found in an expanded granular sludge bed reactor. These two heterogenous granules were not isolated but were assembled into granules with a larger DR-Granule in the center and many smaller BR-Granules aggregated on the surface, increasing the overall granular size. Their physiochemical characteristics in terms of EPS, adherence, rheological properties, and microbial compositions, were identified and compared to elucidate the interaction between the different colors of granules. The BR-Granules created 92% more extracellular polymeric substances than the DR-Granules. This material blocked the passage of gas and substrate, leading to BR-Granules smaller size and a yield stress approximately 48% lower than that of the DR-Granules. Nevertheless, the BR-Granules had compact extracellular protein secondary structures and a high adherence rate to the surface of the DR-Granules, upon which they formed a compact adhered layer. These unique features enabled them to directionally adhere to DR-Granules in the core, that is, two heterogenous colors of granules self-assembled into large anammox granules. The enlargement mechanism was further supported by the abundance of K-strategy Ca. Kuenenia in the DR-Granules (inner layer) being higher than in the BR-Granules (outer layer; 2.9 ± 0.4% vs. 0.4 ± 0.1%; p = 0.0003) and by visualized confirmation that the larger BR-Granules wrapped around smaller DR-Granules inside. This demonstrates that heterogenous anammox granules actively self-assemble into large granules, which is an important step in the lifecycle of anammox granules.
Collapse
Affiliation(s)
- Weigang Wang
- State Key Laboratory of Pollution Control and Resources Reuse, Shanghai Institute of Pollution Control and Ecological Security, College of Environmental Science and Engineering, Tongji University, Siping Road, Shanghai 200092, P. R. China
| | - Junjie Wang
- State Key Laboratory of Pollution Control and Resources Reuse, Shanghai Institute of Pollution Control and Ecological Security, College of Environmental Science and Engineering, Tongji University, Siping Road, Shanghai 200092, P. R. China
| | - Han Wang
- State Key Laboratory of Pollution Control and Resources Reuse, Shanghai Institute of Pollution Control and Ecological Security, College of Environmental Science and Engineering, Tongji University, Siping Road, Shanghai 200092, P. R. China
| | - Jie Ma
- State Key Laboratory of Pollution Control and Resources Reuse, Shanghai Institute of Pollution Control and Ecological Security, College of Environmental Science and Engineering, Tongji University, Siping Road, Shanghai 200092, P. R. China
| | - Min Wu
- State Key Laboratory of Pollution Control and Resources Reuse, Shanghai Institute of Pollution Control and Ecological Security, College of Environmental Science and Engineering, Tongji University, Siping Road, Shanghai 200092, P. R. China
| | - Yayi Wang
- State Key Laboratory of Pollution Control and Resources Reuse, Shanghai Institute of Pollution Control and Ecological Security, College of Environmental Science and Engineering, Tongji University, Siping Road, Shanghai 200092, P. R. China.
| |
Collapse
|
45
|
Wang J, Lei Z, Wei Y, Wang Q, Tian C, Shimizu K, Zhang Z, Adachi Y, Lee DJ. Behavior of algal-bacterial granular sludge in a novel closed photo-sequencing batch reactor under no external O 2 supply. BIORESOURCE TECHNOLOGY 2020; 318:124190. [PMID: 33038621 DOI: 10.1016/j.biortech.2020.124190] [Citation(s) in RCA: 23] [Impact Index Per Article: 5.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/15/2020] [Revised: 09/22/2020] [Accepted: 09/24/2020] [Indexed: 06/11/2023]
Abstract
Algal-bacterial aerobic granular sludge (AB-AGS) as a symbiosis system possesses high potential for being operated without external O2 supply. In this study, a novel lab-scale closed photo-sequencing batch reactor (PSBR) was developed for AB-AGS operation under successively open (Phase Ⅰ) and closed (Phase Ⅱ) conditions. Results show that AB-AGS maintained almost 100% of organics removal, exhibiting higher removals of phosphate (63 ± 20%), K+ (19 ± 12%) and Mg2+ (26 ± 12%), and higher chlorophylls content during Phase II. Meanwhile, only O2 besides N2 was detectable in the headspace of PSBR. The change of granular structure and faster algae growth during Phase Ⅱ may contribute to the increase of microbial activity and phosphorus bioavailability, in which lower extracellular polymeric substances content may account for low biomass retention. Results from this closed PSBR imply that AB-AGS has the potential to reduce some greenhouse gases like CO2 and CH4 emission.
Collapse
Affiliation(s)
- Jixiang Wang
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhongfang Lei
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan.
| | - Yanjun Wei
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Qian Wang
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Caixing Tian
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Kazuya Shimizu
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhenya Zhang
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Yasuhisa Adachi
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Duu-Jong Lee
- Department of Chemical Engineering, National Taiwan University, Taipei 10617, Taiwan
| |
Collapse
|
46
|
Landazuri CFG, Gomez JS, Raaijmakers JM, Oyserman BO. Restoring degraded microbiome function with self-assembled communities. FEMS Microbiol Ecol 2020; 96:5956484. [PMID: 33150935 DOI: 10.1093/femsec/fiaa225] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/16/2020] [Accepted: 11/03/2020] [Indexed: 01/04/2023] Open
Abstract
The natural microbial functions of many soils are severely degraded. Current state-of-the-art technology to restore these functions is through the isolation, screening, formulation and application of microbial inoculants and synthetic consortia. These approaches have inconsistent success, in part due to the incompatibility between the biofertilizer, crop, climate, existing soil microbiome and physicochemical characteristics of the soils. Here, we review the current state of the art in biofertilization and identify two key deficiencies in current strategies: the difficulty in designing complex multispecies biofertilizers and the bottleneck in scaling the production of complex multispecies biofertilizers. To address the challenge of producing scalable, multispecies biofertilizers, we propose to merge ecological theory with bioprocess engineering to produce 'self-assembled communities' enriched for particular functional guilds and adapted to a target soil and host plant. Using the nitrogen problem as an anchor, we review relevant ecology (microbial, plant and environmental), as well as reactor design strategies and operational parameters for the production of functionally enriched self-assembled communities. The use of self-assembled communities for biofertilization addresses two major hurdles in microbiome engineering: the importance of enriching microbes indigenous to (and targeted for) a specific environment and the recognized potential benefits of microbial consortia over isolates (e.g. functional redundancy). The proposed community enrichment model could also be instrumental for other microbial functions such as phosphorus solubilization, plant growth promotion or disease suppression.
Collapse
Affiliation(s)
- Carlos Fernando Gutierrez Landazuri
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental and Natural Resources, Engineering Faculty, Universidad del Valle, 760032, Cali, Colombia
| | - Janeth Sanabria Gomez
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental and Natural Resources, Engineering Faculty, Universidad del Valle, 760032, Cali, Colombia
| | - Jos M Raaijmakers
- Department of Microbial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands.,Institute of Biology, Leiden University, Sylviusweg 72, 2333 BE, Leiden, The Netherlands
| | - Ben O Oyserman
- Department of Microbial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands.,Bioinformatics Group, Wageningen University, Droevendaalsesteeg 1,6708 PB, Wageningen, The Netherlands
| |
Collapse
|
47
|
Ouazaite H, Milferstedt K, Hamelin J, Desmond-Le Quéméner E. Mapping the biological activities of filamentous oxygenic photogranules. Biotechnol Bioeng 2020; 118:601-611. [PMID: 33006374 DOI: 10.1002/bit.27585] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/20/2020] [Revised: 09/17/2020] [Accepted: 09/28/2020] [Indexed: 11/08/2022]
Abstract
Oxygenic photogranules have been suggested as alternatives to activated sludge in wastewater treatment. Challenging for modeling photogranule-based processes is the heterogeneity of photogranule morphologies, resulting in different activities by photogranule type. The measurement of microscale-activities of filamentous photogranules is particularly difficult because of their labile interfaces. We present here an experimental and modeling approach to quantify phototrophic O2 production, heterotrophic O2 consumption, and O2 diffusion in filamentous photogranules. We used planar optodes for the acquisition of spatio-temporal oxygen distributions combined with two-dimensional mathematical modeling. Light penetration into the photogranule was the factor controlling photogranule activities. The spatial distribution of heterotrophs and phototrophs had less impact. The photosynthetic response of filaments to light was detectable within seconds, emphasizing the need to analyze dynamics of light exposure of individual photogranules in photobioreactors. Studying other recurring photogranule morphologies will eventually enable the description of photogranule-based processes as the interplay of interacting photogranule populations.
Collapse
|
48
|
Ji B, Zhang M, Wang L, Wang S, Liu Y. Removal mechanisms of phosphorus in non-aerated microalgal-bacterial granular sludge process. BIORESOURCE TECHNOLOGY 2020; 312:123531. [PMID: 32446034 DOI: 10.1016/j.biortech.2020.123531] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/21/2020] [Revised: 05/05/2020] [Accepted: 05/06/2020] [Indexed: 06/11/2023]
Abstract
Microalgal-bacterial granular sludge processes are attracting increasing research interest in fields of biological municipal wastewater treatment. However, these processes currently suffer from inefficient phosphorus removal and long hydraulic reaction time. As such, a self-sustaining synergetic microalgal-bacterial granular sludge process was explored for improving phosphorus removal. Results showed that about 86% of influent phosphorus could be removed within 6 h comprising 2-hr dark phase and 4-hr light phase. Slight phosphorus release was observed in dark phase, followed by a significant phosphorus uptake in light phase together with the accumulation of poly-phosphorus in microalgal cells. The analyses by PacBio's sequencing and fluorescence in situ hybridization revealed that microalgal genus of Pantanalinema were the major phosphorus-accumulating organisms. Based on these experimental observations, the removal mechanisms of phosphorus by microalgal-bacterial granular sludge process were identified. It is expected that this study may shed lights on the pathways of biological phosphorus removal in microalgal-bacterial granular sludge process.
Collapse
Affiliation(s)
- Bin Ji
- Department of Water and Wastewater Engineering, Wuhan University of Science and Technology, Wuhan 430065, China; Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore
| | - Meng Zhang
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore
| | - Li Wang
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore
| | - Shulian Wang
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore; Hubei Key Laboratory of Ecological Remediation for Rivers-Lakes and Algal Utilization, School of Civil Engineering, Architecture and Environment, Hubei University of Technology, Wuhan 430068, China
| | - Yu Liu
- Advanced Environmental Biotechnology Centre, Nanyang Environment & Water Research Institute, Nanyang Technological University, 1 Cleantech Loop, Singapore 637141, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, 50 Nanyang Avenue, Singapore 639798, Singapore.
| |
Collapse
|