MWCNT-7 administered to the lung by intratracheal instillation induces development of pleural mesothelioma in F344 rats

Evaluation of inflammatory and mesothelioma-related responses in mice following the intraperitoneal administration of cellulose nanofibers

Mesothelioma can develop from long-term exposure to fine fibrous materials including asbestos and carbon nanotubes, and chronic inflammation is critical for its development. Inflammatory responses and key related markers associated with the development of mesothelioma were evaluated over time in relation to cellulose nanofibers (CNFs), which are being developed as new plant-derived materials, for the purpose of risk management Three types of CNFs, mechanically fibrillated CNFs, TEMPO-oxidized CNFs, and phosphorylated CNFs, were administered intraperitoneally to mice at doses of 0.1 and 1.0 mg per animal, and progress was observed for up to 2 years. In the group receiving mechanically fibrillated CNFs, white substances were observed adhering to the liver surface throughout the observation period. This white substance was presumed to be cellulose. Some CNFs have been shown to persist in the body. During this period, inflammation markers and mesothelioma-related markers were evaluated at 1, 2, and 6 months, and 1, and 2 years after administration. No significant symptoms were observed in animals administered one of the three types of CNFs intraperitoneally during the observation period. Inflammatory markers in the peritoneal lavage fluid remained below the detection limit throughout the entire observation period. Additionally, no significant increase in blood levels of mesothelioma or the major related markers mesothelin, osteopontin, or HMGB1 was observed. In this study, although some CNFs remained in the body, no inflammatory response was observed in vivo under the concentration conditions and observation periods used. Furthermore, no evidence of long-term effects, such as cancer, was found.

The empirical metric of mesothelial carcinogenicity for carbon nanotubes and elongate mineral particles

INTRODUCTION

Carcinogenic potential of elongate particles depends on many characteristics, with dimensional parameters playing an important role at all stages of disease origination and progression. It is important to develop quantitative metrics of mesothelial carcinogenicity for particles in order to predict their behavior within biological systems. It would be especially valuable if such metrics could be developed for both carbon nanotubes (CNTs) and elongate mineral particles (EMPs) to demonstrate similarities and differences in the estimations of mesothelioma risk.

METHODS

The database is organized with dimensional characteristics of EMPs, containing 570,950 records for 246 asbestiform, non-asbestiform, and mixed datasets. A database on carbon nanotubes (CNTs) with various toxicological outcomes of animal experiments, including mesothelioma, was also created. Mathematical modeling was used to determine the best metric of mesotheliomagenicity that would work for CNTs and EMPs.

RESULTS

The dimensional coefficient of carcinogenicity (DCC) was introduced with the formula DCC = 1-exp(-AxSA/(BxWidth3+C)), where SA - surface area of the elongate particle, Width - particle width, A, B, C - coefficients. It was demonstrated that DCC can efficiently determine mesotheliomagenic varieties of CNTs and EMPs, with a threshold for carcinogenic potential of 0.05 with A = 0.11, B = 1000, C = 1.

DISCUSSION

The new quantitative metric of carcinogenicity can be used for the purposes of mineralogical evaluation and toxicological analysis. It was confirmed that DCC-based models predict negligible mesothelioma potency for non-asbestiform amphiboles.

Critical values for dimensional parameters of mesotheliomagenic mineral fibers: evidence from the dimensions and rigidity of MWCNT

MWCNT (multi-walled carbon nanotubes) used in 72 animal instillation or inhalation studies were classified by average length, average width, Young's modulus, Rigidity Index (RI), and potency for mesothelioma in animals. The RI is based on the Euler buckling theory. MWCNT that induce mesothelioma have average lengths >2 µm and widths >37 nm, and average RI > 0.05 (µm2 x GPa x 104). Many noncarcinogenic MWCNT materials have RI < 0.05 and lack biological rigidity. In comparison, Elongate Mineral Particle (EMP) populations with one exception have RI > 0.05. Mineral particles likely to have RI < 0.05 include chrysotile fibrils with lengths >5 μm, amosite and crocidolite fibers with widths <60 nm, and sheet silicate fibers with widths <200 nm. The product of percent EMPA, average RI, and biosolubility among silicates correlates with known mesothelioma potency. The derived models reproduce published values of RM with high statistical significance (P < 0.05). Average RI, length, and width are critical parameters for mesotheliomagenicity for both MWCNT and EMPA mineral fiber.

Fibrotic pulmonary dust foci is an advanced pneumoconiosis lesion in rats induced by titanium dioxide nanoparticles in a 2-year inhalation study

BACKGROUND

We have previously reported that inhalation exposure to titanium dioxide nanoparticles (TiO2 NPs) for 13 weeks causes early pneumoconiosis lesions in the alveolar region of F344 rats. We defined these characteristic lesions as pulmonary dust foci (PDF). In this report, we re-evaluate and detail the histopathological data regarding particle-induced pneumoconiosis lesions, including progressive lesions of the early PDF lesions, that developed in F344 rats exposed TiO2 NPs by whole body inhalation over a period of two years.

METHODS

Male and female F344 rats were exposed to 0.5, 2, and 8 mg/m3 anatase type TiO2 NPs for 6 h/day, 5 days/week for 104 weeks using a whole-body inhalation exposure system. After the final exposure, the rats were euthanized. In the present study, the collected lungs were re-evaluated macroscopically and histopathologically.

RESULTS

Rats exposed to TiO₂ NPs developed macroscopic white lesions, primarily in the subpleural and hilar regions of the lung, which increased in size and number with exposure concentration. Histologically, two lesion types were identified: (1) Fibrotic Pulmonary Dust Foci (fPDF), characterized by collagen deposition, inflammatory infiltration, and disrupted alveolar epithelial differentiation, and (2) Dust Macules (DM), characterized by macrophage accumulation without significant fibrosis or inflammation. fPDFs, but not DMs, were observed after 13 weeks exposure to TiO₂ NPs, indicating that the DM-type pneumoconiosis lesions required a longer time to develop compared to fPDF-type pneumoconiosis lesions. Histopathological analysis revealed that the DM-type pneumoconiosis lesions that developed in rats exposed to TiO₂ NPs were similar to DM-type pneumoconiosis lesions that develop in humans.

CONCLUSIONS

Inhalation exposure to TiO₂ NPs caused the development of two types of pneumoconiosis lesions in rats with distinct pathological features, fPDFs and DMs. The histopathological similarity of the DM-type pneumoconiosis lesions that developed in rat lung in the present study with the DM-type pneumoconiosis lesions that develop in the human lung adds strong support to the conclusion that humans exposed to airborne TiO₂ NPs are at risk of developing pneumoconiosis.

Safety of Mechanically Fibrillated Cellulose Nanofibers (CNFs) by Inhalation Exposure Based on TG412

An investigation into the acute toxicity of mechanically fibrillated cellulose nanofibers (fib-CNFs), with a fiber length ranging from 500 to 600 nm, was conducted in accordance with the OECD TG412 guidelines. In this study, rats were exposed to fib-CNFs via nasal inhalation for 6 h daily over a 28-day period. The highest exposure concentration was set at 35 mg/m3, with intermediate and low concentrations at 7.0 mg/m3 and 1.5 mg/m3, respectively. No significant differences were observed in body weight, hematological parameters, or biochemical profiles between the fib-CNF-exposed groups and the control group. However, the histopathological examination of lung tissue revealed elevated macrophage counts in both the alveolar spaces and lymph nodes, accompanied by a significant increase in lung weight. The most severe effects were observed in the high-concentration group, while the low-concentration group exhibited only mild inflammatory changes. Based on these findings, the no observable adverse effect level (NOAEL) for the acute toxicity of fib-CNFs is estimated to be below 1.5 mg/m3.

A Review of the Carcinogenic Potential of Thick Rigid and Thin Flexible Multi-Walled Carbon Nanotubes in the Lung

The carcinogenic potential of MWCNTs is not well defined. Currently, IARC has classified MWCNT-7 as a Group 2 B material, possibly carcinogenic to humans, and all other MWCNTs as Group 3 materials, inadequate evidence in experimental animals for their carcinogenicity and not classifiable as to their carcinogenicity to humans. In this review we discuss studies that investigated the lung toxicity of well characterized MWCNTs in mice and rats. Intraperitoneal and intrascrotal injection studies identified rigid MWCNTs as hazardous materials. The assessment of lung toxicity of MWCNTs in short and medium term instillation and inhalation studies were not conclusive; therefore, these studies do not confirm the hazard of MWCNTs. However, two-year carcinogenicity studies indicate that MWCNT-7 and other MWCNTs, both thick rigid MWCNTs and thin flexible MWCNTs, are carcinogenic in test animals. Therefore, the carcinogenicity of MWCNTs in experimental animals should be reassessed.

Comparison of Single and Multiple Intratracheal Administrations for Pulmonary Toxic Responses of Multi-Walled Carbon Nanotubes in Rats

The purpose of the present study is to contribute to the establishment of a standard method for evaluating the adverse effects of nanomaterials by intratracheal administration. Low and high doses of multi-walled carbon nanotubes (MWCNTs) were administered to rats in a single administration or the same final dose as the single administration but divided over four administrations. Bronchoalveolar lavage examination on day 14 showed an inflammatory reaction and cytotoxicity in the lung, generally greater at the higher dose, and tending to be greater in the rats with four administrations at both the low and high doses. Histopathologic findings showed increased alveolar macrophages and MWCNT deposition (fibers phagocytosed by alveolar macrophages and fibers that were not phagocytosed) in the alveolar space, granulomatous changes, and MWCNT deposition in bronchus-associated lymphoid tissue (BALT) and lung-related lymph nodes on days 14, 28, and 91. In addition, alveolar type II epithelial hyperplasia was observed on day 91, and fibrosis of the alveolar wall was observed on days 28 and 91. Fewer alveolar macrophages with phagocytosed MWCNTs were present at day 91 compared to day 28. MWCNT deposition tended to be higher in the BALT after a single administration, whereas deposition was higher in the lung-related lymph nodes after four administrations. MWCNTs were considered to be transported from the lungs or BALT to the lymph nodes over time. There were no significant differences in MWCNT deposition in the lung after the single administration compared with four administrations at either the low or high doses, and the histopathological findings were similar after single and four administrations, at both the low and high doses. Based on the above findings, a toxicity evaluation of the nanomaterials can be sufficiently performed by intratracheal administration, even with a single intratracheal administration.

Fullerene and fullerene whisker are not carcinogenic to the lungs and pleura in rat long-term study after 2-week intra-tracheal intrapulmonary administration

Fullerene whiskers (FLW)s are thin rod-like structures composed of C60 and C70 fullerene (FL). The shape of FLWs suggests potential toxic effects including carcinogenicity to the lung and pleura, similar to effects elicited by asbestos and multi-walled carbon nanotubes (MWCNT)s. However, no long-term carcinogenic studies of FL or FLW have been conducted. In the present study we investigated the pulmonary and pleural carcinogenicity of FL and FLW. Twelve-week-old male F344 rats were administered 0.25 or 0.5 mg FL, FLW, MWCNT-7, and MWCNT-N by intra-tracheal intra-pulmonary spraying (TIPS). Acute lung lesions and carcinogenicity were analyzed at 1 and 104 weeks after 8 doses/15 days TIPS administration. At week 1, FLW, MWCNT-7, and MWCNT-N significantly increased alveolar macrophage infiltration. Expression of Ccl2 and Ccl3, reactive oxygen species production, and cell proliferation were significantly increased by administration of MWCNT-7 and MWCNT-N but not FL or FLW. At week 104, the incidence of bronchiolo-alveolar adenoma plus adenocarcinoma was significantly increased in the MWCNT-7 and MWCNT-N groups, and the incidence of mesothelioma was significantly increased in the MWCNT-7 group. No significant induction of pulmonary or pleural tumorigenesis was observed in the FL or FLW groups. The number of 8-OHdG-positive cells in the alveolar epithelium was significantly increased in the MWCNT-7 and MWCNT-N groups but not in the FL or FLW groups. FL and FLW did not exert pulmonary or pleural carcinogenicity in our study. In addition, oxidative DNA damage was implicated in MWCNT-induced lung carcinogenesis, suggesting that it may be a useful initial marker of carcinogenicity.

The oxidative stress-dependent pulmonary inflammation of inhalable multi-walled carbon nanotube-containing nano-concrete dust and its comparison with conventional concrete dust and DQ12

Nano-concrete, which is an admixture of nanomaterials in concrete recipes, has been investigated to overcome the limitations of existing concrete, such as its stability and strength. However, there is no information on the human health effects of broken-down dust released during the construction and demolition efforts. In this study, we prepared an inhalable fraction of multi-walled carbon nanotube-containing nano-concrete dust and performed comparative toxicity studies with conventional concrete dust and DQ12 using a rat intratracheal instillation model. Although the recipes for concrete and nano-concrete are entirely different, the pulverized dust samples showed similar physicochemical properties, such as 0.46-0.48 µm diameter and chemical composition. Both concrete and nano-concrete dust exhibited similar patterns and magnitudes, representing acute neutrophilic inflammation and chronic active inflammation with lymphocyte infiltration. The toxicity endpoints of the tested particles at both time points showed an excellent correlation with the reactive oxygen species levels released from the alveolar macrophages, highlighting that alveolar macrophages are the primary target cells and that the oxidative stress paradigm is the main toxicity mechanism of the tested particles. In addition, the toxicity potentials of both concrete and nano-concrete dust were more than 10 times lower than that of DQ12.

Potent lung tumor promotion by inhaled MWCNT

In the lung, carcinogenesis is a multi-stage process that includes initiation by a genotoxic agent, promotion that expands the population of cells with damaged DNA to form a tumor, and progression from benign to malignant neoplasms. We have previously shown that Mitsui-7, a long and rigid multi-walled carbon nanotube (MWCNT), promotes pulmonary carcinogenesis in a mouse model. To investigate the potential exposure threshold and dose-response for tumor promotion by this MWCNT, 3-methylcholanthrene (MC) initiated (10 μg/g, i.p., once) or vehicle (corn oil) treated B6C3F1 mice were exposed by inhalation to filtered air or MWCNT (5 mg/m3) for 5 h/day for 0, 2, 5, or 10 days and were followed for 17 months post-exposure for evidence of lung tumors. Pulmonary neoplasia incidence in MC-initiated mice significantly increased with each MWCNT exposure duration. Exposure to either MC or MWCNT alone did not affect pulmonary neoplasia incidence compared with vehicle controls. Lung tumor multiplicity in MC-initiated mice also significantly increased with each MWCNT exposure duration. Thus, a significantly higher lung tumor multiplicity was observed after a 10-day MWCNT exposure than following a 2-day exposure. Both bronchioloalveolar adenoma and bronchioloalveolar adenocarcinoma multiplicity in MC-initiated mice were significantly increased following 5- and 10-day MWCNT exposure, while a 2-day MWCNT exposure in MC-initiated mice significantly increased the multiplicity of adenomas but not adenocarcinomas. In this study, even the lowest MWCNT exposure promoted lung tumors in MC-initiated mice. Our findings indicate that exposure to this MWCNT strongly promotes pulmonary carcinogenesis.

Malignant peritoneal mesotheliomas of rats induced by multiwalled carbon nanotubes and amosite asbestos: transcriptome and epigenetic profiles

BACKGROUND

Malignant mesothelioma is an aggressive cancer that often originates in the pleural and peritoneal mesothelium. Exposure to asbestos is a frequent cause. However, studies in rodents have shown that certain multiwalled carbon nanotubes (MWCNTs) can also induce malignant mesothelioma. The exact mechanisms are still unclear. To gain further insights into molecular pathways leading to carcinogenesis, we analyzed tumors in Wistar rats induced by intraperitoneal application of MWCNTs and amosite asbestos. Using transcriptomic and epigenetic approaches, we compared the tumors by inducer (MWCNTs or amosite asbestos) or by tumor type (sarcomatoid, epithelioid, or biphasic).

RESULTS

Genome-wide transcriptome datasets, whether grouped by inducer or tumor type, showed a high number of significant differentially expressed genes (DEGs) relative to control peritoneal tissues. Bioinformatic evaluations using Ingenuity Pathway Analysis (IPA) revealed that while the transcriptome datasets shared commonalities, they also showed differences in DEGs, regulated canonical pathways, and affected molecular functions. In all datasets, among highly- scoring predicted canonical pathways were Phagosome Formation, IL8 Signaling, Integrin Signaling, RAC Signaling, and TREM1 Signaling. Top-scoring activated molecular functions included cell movement, invasion of cells, migration of cells, cell transformation, and metastasis. Notably, we found many genes associated with malignant mesothelioma in humans, which showed similar expression changes in the rat tumor transcriptome datasets. Furthermore, RT-qPCR revealed downregulation of Hrasls, Nr4a1, Fgfr4, and Ret or upregulation of Rnd3 and Gadd45b in all or most of the 36 tumors analyzed. Bisulfite sequencing of Hrasls, Nr4a1, Fgfr4, and Ret revealed heterogeneity in DNA methylation of promoter regions. However, higher methylation percentages were observed in some tumors compared to control tissues. Lastly, global 5mC DNA, m6A RNA and 5mC RNA methylation levels were also higher in tumors than in control tissues.

CONCLUSIONS

Our findings may help better understand how exposure to MWCNTs can lead to carcinogenesis. This information is valuable for risk assessment and in the development of safe-by-design strategies.

Difference in carcinogenicities of two different vapor grown carbon fibers with different physicochemical characteristics induced by intratracheal instillation in rats

BACKGROUND

Carbon fibers are high aspect ratio structures with diameters on the submicron scale. Vapor grown carbon fibers are contained within multi-walled carbon tubes, with VGCF™-H commonly applied as a conductive additive in lithium-ion batteries. However, several multi-walled carbon fibers, including MWNT-7, have been reported to induce lung carcinogenicity in rats. This study investigated the carcinogenic potential of VGCF™-H fibers in F344 rats of both sexes with the vapor grown carbon fibers VGCF™-H and MWNT-7 over 2 years. The carbon fibers were administered to rats by intratracheal instillation at doses of 0, 0.016, 0.08, and 0.4 mg/kg (total doses of 0, 0.128, 0.64, and 3.2 mg/kg) once per week for eight weeks and the rats were observed for up to 2 years after the first instillation.

RESULTS

Histopathological examination showed the induction of malignant mesothelioma on the pleural cavity with dose-dependent increases observed at 0, 0.128, 0.64, and 3.2 mg/kg in rats of both sexes that were exposed to MWNT-7. On the other hand, only two cases of pleural malignant mesothelioma were observed in the VGCF™-H groups; both rats that received 3.2 mg/kg in male. The animals in the MWNT-7 groups either died or became moribund earlier than those in the VGCF™-H groups, which is thought related to the development of malignant mesothelioma. The survival rates were higher in the VGCF™-H group, and more carbon fibers were observed in the pleural lavage fluid (PLF) of the MWNT-7 groups. These results suggest that malignant mesothelioma is related to the transfer of carbon fibers into the pleural cavity.

CONCLUSIONS

The intratracheal instillation of MWNT-7 clearly led to carcinogenicity in both male and female rats at all doses. The equivocal evidence for carcinogenic potential that was observed in male rats exposed to VGCF™-H was not seen in the females. The differences in the carcinogenicities of the two types of carbon fibers are thought due to differences in the number of carbon fibers reaching the pleural cavity. The results indicate that the carcinogenic activity of VGCF™-H is lower than that of MWNT-7.

Exposure of Rats to Multi-Walled Carbon Nanotubes: Correlation of Inhalation Exposure to Lung Burden, Bronchoalveolar Lavage Fluid Findings, and Lung Morphology

To evaluate lung toxicity due to inhalation of multi-walled carbon nanotubes (MWCNTs) in rats, we developed a unique MWCNT aerosol generator based on dry aerosolization using the aerodynamic cyclone principle. Rats were exposed to MWNT-7 (also known as Mutsui-7 and MWCNT-7) aerosolized using this device. We report here an analysis of previously published data and additional unpublished data obtained in 1-day, 2-week, 13-week, and 2-year inhalation exposure studies. In one-day studies, it was found that approximately 50% of the deposited MWNT-7 fibers were cleared the day after the end of exposure, but that clearance of the remaining fibers was markedly reduced. This is in agreement with the premise that the rapidly cleared fibers were deposited in the ciliated airways while the slowly cleared fibers were deposited beyond the ciliated airways in the respiratory zone. Macrophage clearance of MWNT-7 fibers from the alveoli was limited. Instead of macrophage clearance from the alveoli, containment of MWNT-7 fibers within induced granulomatous lesions was observed. The earliest changes indicative of pulmonary toxicity were seen in the bronchoalveolar lavage fluid. Macrophage-associated inflammation persisted from the one-day exposure to MWNT-7 to the end of the two-year exposure period. Correlation of lung tumor development with MWNT-7 lung burden required incorporating the concept of area under the curve for the duration of the study; the development of lung tumors induced by MWNT-7 correlated with lung burden and the duration of MWNT-7 residence in the lung.

Carbon nanotube pathogenicity conforms to a unified theory for mesothelioma causation by elongate materials and fibers

The purpose of this review is to elucidate how dimensional and durability characteristics of high aspect ratio nanomaterials (HARN), including carbon nanotubes (CNT) and metal nanowires (MeNW), contribute to understanding the fiber pathogenicity paradigm (FPP), including by explaining the structure-activity relationships (SAR) of a diverse range of natural and synthetic elongate materials that may or may not contribute to mesothelioma development in the lung. While the FPP was originally developed to explain the critical importance of asbestos and synthetic vitreous fiber length, width, aspect ratio and biopersistence in mesothelioma development, there are a vast number of additional inhalable materials that need to be considered in terms of pathogenic features that may contribute to mesothelioma or lack thereof. Not only does the ability to exert more exact control over the length and biopersistence of HARNs confirm the tenets of the FPP, but could be studied by implementating more appropriate toxicological tools for SAR analysis. This includes experimentation with carefully assembled libraries of CNTs and MeNWs, helping to establish more precise dimensional features for interfering in lymphatic drainage from the parietal pleura, triggering of lysosomal damage, frustrated phagocytosis and generation of chronic inflammation. The evidence includes data that long and rigid, but not short and flexible multi-wall CNTs are capable of generating mesotheliomas in rodents based on an adverse outcome pathway requiring access to pleural cavity, obstruction of pleural stomata, chronic inflammation and transformation of mesothelial cells. In addition to durability and dimensional characteristics, bending stiffness of CNTs is a critical factor in determining the shape and rigidity of pathogenic MWCNTs. While no evidence has been obtained in humans that CNT exposure leads to a mesothelioma outcome, it is important to monitor exposure levels and health effect impacts in workers to prevent adverse health outcomes in humans.

Time-Course of Transcriptomic Change in the Lungs of F344 Rats Repeatedly Exposed to a Multiwalled Carbon Nanotube in a 2-Year Test

Despite intensive toxicological studies of carbon nanotubes (CNTs) over the last two decades, only a few studies have demonstrated their pulmonary carcinogenicities in chronic animal experiments, and the underlying molecular mechanisms are still unclear. To obtain molecular insights into CNT-induced lung carcinogenicity, we performed a transcriptomic analysis using a set of lung tissues collected from rats in a 2-year study, in which lung tumors were induced by repeated intratracheal instillations of a multiwalled carbon nanotube, MWNT-7. The RNA-seq-based transcriptome identified a large number of significantly differentially expressed genes at Year 0.5, Year 1, and Year 2. Ingenuity Pathway Analysis revealed that macrophage-elicited signaling pathways such as phagocytosis, acute phase response, and Toll-like receptor signaling were activated throughout the experimental period. At Year 2, cancer-related pathways including ERBB signaling and some axonal guidance signaling pathways such as EphB4 signaling were perturbed. qRT-PCR and immunohistochemistry indicated that several key molecules such as Osteopontin/Spp1, Hmox1, Mmp12, and ERBB2 were markedly altered and/or localized in the preneoplastic lesions, suggesting their participation in the induction of lung cancer. Our findings support a scenario of inflammation-induced carcinogenesis and contribute to a better understanding of the molecular mechanism of MWCNT carcinogenicity.

Needlelike, short and thin multi-walled carbon nanotubes: comparison of effects on wild type and p53+/- rat lungs

Carbon nanotubes (CNTs) are nanomaterials presenting an occupational inhalation risk during production or handling. The International Agency for Research on Cancer classified one CNT, Mitsui-7 (MWNT-7), as 'possibly carcinogenic to humans'. In recognition of their similarities, a proposal has been submitted to the risk assessment committee of ECHA to classify all fibers with 'Fibre Paradigm' (FP)-compatible dimensions as carcinogenic. However, there is a lack of clarity surrounding the toxicity of fibers that do not fit the FP criteria. In this study, we compared the effects of the FP-compatible Mitsui-7, to those of NM-403, a CNT that is too short and thin to fit the paradigm. Female Sprague Dawley rats deficient for p53 (GMO) and wild type (WT) rats were exposed to the two CNTs (0.25 mg/rat/week) by intratracheal instillation. Animals (GMO and WT) were exposed weekly for four consecutive weeks and were sacrificed 3 days or 8 months after the last instillation. Exposure to both CNTs induced acute lung inflammation. However, persistent inflammation at 8 months was only observed in the lungs of rats exposed to NM-403. In addition to the persistent inflammation, NM-403 stimulated hyperplasic changes in rat lungs, and no adenomas or carcinomas were detected. The degree and extent of hyperplasia was significantly more pronounced in GMO rats. These results suggest that CNT not meeting the FP criteria can cause persistent inflammation and hyperplasia. Consequently, their health effects should be carefully assessed.

Single-Walled vs. Multi-Walled Carbon Nanotubes: Influence of Physico-Chemical Properties on Toxicogenomics Responses in Mouse Lungs

Single-walled carbon nanotubes (SWCNTs) and multi-walled carbon nanotubes (MWCNTs) are nanomaterials with one or multiple layers of carbon sheets. While it is suggested that various properties influence their toxicity, the specific mechanisms are not completely known. This study was aimed to determine if single or multi-walled structures and surface functionalization influence pulmonary toxicity and to identify the underlying mechanisms of toxicity. Female C57BL/6J BomTac mice were exposed to a single dose of 6, 18, or 54 μg/mouse of twelve SWCNTs or MWCNTs of different properties. Neutrophil influx and DNA damage were assessed on days 1 and 28 post-exposure. Genome microarrays and various bioinformatics and statistical methods were used to identify the biological processes, pathways and functions altered post-exposure to CNTs. All CNTs were ranked for their potency to induce transcriptional perturbation using benchmark dose modelling. All CNTs induced tissue inflammation. MWCNTs were more genotoxic than SWCNTs. Transcriptomics analysis showed similar responses across CNTs at the pathway level at the high dose, which included the perturbation of inflammatory, cellular stress, metabolism, and DNA damage responses. Of all CNTs, one pristine SWCNT was found to be the most potent and potentially fibrogenic, so it should be prioritized for further toxicity testing.

Functional Micro-/Nanostructures in Agrofood Science: Precise Inspection, Hazard Elimination, and Potential Health Risks

Nanotechnology, biotechniques, and chemical engineering have arisen as new trends with significant impacts on agrofood science development. Advanced analytical techniques with high sensitivity, specificity, and automation based on micro-/nanomaterials for food hazard elimination have become leading research hotspots in agrofood science. Research progress in micro-/nanomaterials has provided a solid theoretical basis and technical support to solve problems in the industry. However, the rapid development of micro-/nanostructures has also raised concerns regarding potential risks to human health. This review presents the latest advances in the precise inspection and elimination of food hazards from micro-/nanomaterials and discusses the potential threats to human health posed by nanomaterials. The theoretical reference was provided for the application trend of micro-/nanomaterials in the field of agrofood science in the future.

Mechanisms of the carcinogenicity of nanomaterials

Nanomaterials become more widespread in the different areas of human life, forming the new technosphere philosophy, in particular, new approaches for development and usage of these materials in everyday life, manufacture, medicine etc.The physicochemical characteristics of nanomaterials differ significantly from the corresponding indicators of aggregate materials and at least some of them are highly reactive and / or highly catalytic. This suggests their aggressiveness towards biological systems, including involvement in carcinogenesis. The review considers the areas of use of modern nanomaterials, with special attention paid to the description of medicine production using nanotechnologies, an analysis of the mechanisms of action of a number of nanomaterials already recognized as carcinogenic, and also presents the available experimental and mechanistic data obtained from the study of the carcinogenic / procarcinogenic effects of various groups of nanomaterials currently not classified as carcinogenic to humans.Preparing the review, information bases of biomedical literature were analysed: Scopus (307), PubMed (461), Web of Science (268), eLibrary.ru (190) were used. To obtain full-text documents, the electronic resources of PubMed Central (PMC), Science Direct, Research Gate, Sci-Hub and eLibrary.ru databases were used.

Grouping MWCNTs based on their similar potential to cause pulmonary hazard after inhalation: a case-study

BACKGROUND

The EU-project GRACIOUS developed an Integrated Approach to Testing and Assessment (IATA) to support grouping high aspect ratio nanomaterials (HARNs) presenting a similar inhalation hazard. Application of grouping reduces the need to assess toxicity on a case-by-case basis and supports read-across of hazard data from substances that have the data required for risk assessment (source) to those that lack such data (target). The HARN IATA, based on the fibre paradigm for pathogenic fibres, facilitates structured data gathering to propose groups of similar HARN and to support read-across by prompting users to address relevant questions regarding HARN morphology, biopersistence and inflammatory potential. The IATA is structured in tiers, allowing grouping decisions to be made using simple in vitro or in silico methods in Tier1 progressing to in vivo approaches at the highest Tier3. Here we present a case-study testing the applicability of GRACIOUS IATA to form an evidence-based group of multiwalled carbon nanotubes (MWCNT) posing a similar predicted fibre-hazard, to support read-across and reduce the burden of toxicity testing.

RESULTS

The case-study uses data on 15 different MWCNT, obtained from the published literature. By following the IATA, a group of 2 MWCNT was identified (NRCWE006 and NM-401) based on a high degree of similarity. A pairwise similarity assessment was subsequently conducted between the grouped MWCNT to evaluate the potential to conduct read-across and fill data gaps required for regulatory hazard assessment. The similarity assessment, based on expert judgement of Tier 1 assay results, predicts both MWCNT are likely to cause a similar acute in vivo hazard. This result supports the possibility for read-across of sub-chronic and chronic hazard endpoint data for lung fibrosis and carcinogenicity between the 2 grouped MWCNT. The implications of accepting the similarity assessment based on expert judgement of the MWCNT group are considered to stimulate future discussion on the level of similarity between group members considered sufficient to allow regulatory acceptance of a read-across argument.

CONCLUSION

This proof-of-concept case-study demonstrates how a grouping hypothesis and IATA may be used to support a nuanced and evidence-based grouping of 'similar' MWCNT and the subsequent interpolation of data between group members to streamline the hazard assessment process.

Two-year intermittent exposure of a multiwalled carbon nanotube by intratracheal instillation induces lung tumors and pleural mesotheliomas in F344 rats

BACKGROUND

A mounting number of studies have been documenting the carcinogenic potential of multiwalled carbon nanotubes (MWCNTs); however, only a few studies have evaluated the pulmonary carcinogenicity of MWCNTs in vivo. A 2-year inhalation study demonstrated that MWNT-7, a widely used MWCNT, was a pulmonary carcinogen in rats. In another 2-year study, rats administered MWNT-7 by intratracheal instillation at the beginning of the experimental period developed pleural mesotheliomas but not lung tumors. To obtain data more comparable with rats exposed to MWNT-7 by inhalation, we administered MWNT-7 to F344 rats by intratracheal instillation once every 4-weeks over the course of 2 years at 0, 0.125, and 0.5 mg/kg body weight, allowing lung burdens of MWNT-7 to increase over the entire experimental period, similar to the inhalation study.

RESULTS

Absolute and relative lung weights were significantly elevated in both MWNT-7-treated groups. Dose- and time-dependent toxic effects in the lung and pleura, such as inflammatory, fibrotic, and hyperplastic lesions, were found in both treated groups. The incidences of lung carcinomas, lung adenomas, and pleural mesotheliomas were significantly increased in the high-dose group compared with the control group. The pleural mesotheliomas developed mainly at the mediastinum. No MWNT-7-related neoplastic lesions were noted in the other organs. Cytological and biochemical parameters of the bronchoalveolar lavage fluid (BALF) were elevated in both treated groups. The lung burden of MWNT-7 was dose- and time-dependent, and at the terminal necropsy, the average value was 0.9 and 3.6 mg/lung in the low-dose and high-dose groups, respectively. The number of fibers in the pleural cavity was also dose- and time-dependent.

CONCLUSIONS

Repeated administration of MWNT-7 by intratracheal instillation over the 2 years indicates that MWNT-7 is carcinogenic to both the lung and pleura of rats, which differs from the results of the 2 carcinogenicity tests by inhalation or intratracheal instillation.

Assessment of the toxicity and carcinogenicity of double-walled carbon nanotubes in the rat lung after intratracheal instillation: a two-year study

BACKGROUND

Considering the expanding industrial applications of carbon nanotubes (CNTs), safety assessment of these materials is far less than needed. Very few long-term in vivo studies have been carried out. This is the first 2-year in vivo study to assess the effects of double walled carbon nanotubes (DWCNTs) in the lung and pleura of rats after pulmonary exposure.

METHODS

Rats were divided into six groups: untreated, Vehicle, 3 DWCNT groups (0.12 mg/rat, 0.25 mg/rat and 0.5 mg/rat), and MWCNT-7 (0.5 mg/rat). The test materials were administrated by intratracheal-intrapulmonary spraying (TIPS) every other day for 15 days. Rats were observed without further treatment until sacrifice.

RESULTS

DWCNT were biopersistent in the rat lung and induced marked pulmonary inflammation with a significant increase in macrophage count and levels of the chemotactic cytokines CCL2 and CCL3. In addition, the 0.5 mg DWCNT treated rats had significantly higher pulmonary collagen deposition compared to the vehicle controls. The development of carcinomas in the lungs of rats treated with 0.5 mg DWCNT (4/24) was not quite statistically higher (p = 0.0502) than the vehicle control group (0/25), however, the overall incidence of lung tumor development, bronchiolo-alveolar adenoma and bronchiolo-alveolar carcinoma combined, in the lungs of rats treated with 0.5 mg DWCNT (7/24) was statistically higher (p < 0.05) than the vehicle control group (1/25). Notably, two of the rats treated with DWCNT, one in the 0.25 mg group and one in the 0.5 mg group, developed pleural mesotheliomas. However, both of these lesions developed in the visceral pleura, and unlike the rats administered MWCNT-7, rats administered DWCNT did not have elevated levels of HMGB1 in their pleural lavage fluids. This indicates that the mechanism by which the mesotheliomas that developed in the DWCNT treated rats is not relevant to humans.

CONCLUSIONS

Our results demonstrate that the DWCNT fibers we tested are biopersistent in the rat lung and induce chronic inflammation. Rats treated with 0.5 mg DWCNT developed pleural fibrosis and lung tumors. These findings demonstrate that the possibility that at least some types of DWCNTs are fibrogenic and tumorigenic cannot be ignored.

Pulmonary toxicity and gene expression changes in response to whole-body inhalation exposure to multi-walled carbon nanotubes in rats

Purpose: To investigate the molecular mechanisms underlying the pulmonary toxicity induced by exposure to one form of multi-walled carbon nanotubes (MWCNT-7).Materials and methods: Rats were exposed, by whole-body inhalation, to air or an aerosol containing MWCNT-7 particles at target cumulative doses (concentration x time) ranging from 22.5 to 180 (mg/m³)h over a three-day (6 hours/day) period and toxicity and global gene expression profiles were determined in the lungs.Results: MWCNT-7 particles, associated with alveolar macrophages (AMs), were detected in rat lungs following the exposure. Mild to moderate lung pathological changes consisting of increased cellularity, thickening of the alveolar wall, alveolitis, fibrosis, and granuloma formation were detected. Bronchoalveolar lavage (BAL) toxicity parameters such as lactate dehydrogenase activity, number of AMs and polymorphonuclear leukocytes (PMNs), intracellular oxidant generation by phagocytes, and levels of cytokines were significantly (p < 0.05) increased in response to exposure to MWCNT-7. Global gene expression profiling identified several significantly differentially expressed genes (fold change >1.5 and FDR p value <0.05) in all the MWCNT-7 exposed rats. Bioinformatic analysis of the gene expression data identified significant enrichment of several diseases/biological function categories (for example, cancer, leukocyte migration, inflammatory response, mitosis, and movement of phagocytes) and canonical pathways (for example, kinetochore metaphase signaling pathway, granulocyte and agranulocyte adhesion and diapedesis, acute phase response, and LXR/RXR activation). The alterations in the lung toxicity parameters and gene expression changes exhibited a dose-response to the MWCNT exposure.Conclusions: Taken together, the data provided insights into the molecular mechanisms underlying the pulmonary toxicity induced by inhalation exposure of rats to MWCNT-7.

Spontaneous Primary Pleural Mesothelioma in Fischer 344 (F344) and Other Rat Strains: A Retrospective Review

Spontaneous primary pleural mesotheliomas in Fischer 344 (F344) or other rat strains have rarely been reported. The objectives of this retrospective study were to develop historical incidence data and better characterize the light-microscopic morphology of these naturally occurring neoplasms in a large cohort of rats of several strains. A retrospective review was performed of National Toxicology Program (NTP) studies in rats conducted between 1980 and 2019 and comprising a total of 104,029 rats (51,326 males, 52,703 females), predominantly (90%) of the F344 strain. Of the 94,062 F344 rats surveyed, there were 30 cases of primary pleural mesotheliomas (22 males, 8 females). Of the 2998 Wistar Han rats surveyed, primary pleural mesotheliomas were present in 2 male rats. No primary pleural mesotheliomas were noted in male and female rats of other strains (6669 Sprague Dawley; 300 Osborne-Mendel). All primary pleural mesotheliomas in control and treated F344 and Wistar Han rats were considered spontaneous and unrelated to treatment. Based on light-microscopic evaluation of paraffin-embedded hematoxylin and eosin stained sections, only epithelioid and biphasic histologic subtypes were observed: 18 and 12 in F344 rats, respectively, and one each in Wistar Han rats. No sarcomatoid subtype cases were noted in any strain of rat.

miR221 regulates cell migration by targeting annexin a1 expression in human mesothelial MeT-5A cells neoplastic-like transformed by multi-walled carbon nanotube

Background

Multi-walled carbon nanotube (MWCNT) is one of the most widely used manufactured nanomaterials, however, its potential harmful effect on human health is of great concern. Previously we have shown the acute and chronic exposure to MWCNT induced different responses in human mesothelial MeT-5A cells. In the current study, MeT-5A cells were continuously subjected to MWCNT exposure at 10 μg/cm² for 48 h per passage, up to a whole year, to further clarify the carcinogesis and its potential mechanisms of MWCNT.

Results

After one-year MWCNT treatment, MeT-5A cells exhibited neoplastic-like properties, including morphological changes, anchorage-independent growth, increased cell proliferation and cell migration. Further examination revealed the expression of microRNA 221 (miR221) was gradually decreased, while the annexin a1 expression was increased at both the mRNA and protein level during the exposure. Bioinformatic analysis indicated that annexin a1 is a target for miR221 regulation, and it was confirmed by transfecting cells with miR221 mimics, which resulted in the downregulation of annexin a1. Detailed analyses demonstrated miR221 was involved in the regulation of cell migration, e.g., downregulation of miR221 or overexpression of ANNEXIN A1, contributed to the increased cell migration. In contrast, overexpression of miR221 or downregulation of ANNEXIN A1 slowed cell migration.

Conclusions

Taken together, these results point to a neoplastic-transforming property of MWCNT, and the miR221-annexin a1 axis is involved in the regulation of cell migration in the transformed cells.

Supplementary Information

The online version contains supplementary material available at 10.1186/s41021-021-00209-y.

Carbon Nanotubes: A Summary of Beneficial and Dangerous Aspects of an Increasingly Popular Group of Nanomaterials

Carbon nanotubes (CNTs) are nanomaterials with broad applications that are produced on a large scale. Animal experiments have shown that exposure to CNTs, especially one type of multi-walled carbon nanotube, MWCNT-7, can lead to malignant transformation. CNTs have characteristics similar to asbestos (size, shape, and biopersistence) and use the same molecular mechanisms and signaling pathways as those involved in asbestos tumorigenesis. Here, a comprehensive review of the characteristics of carbon nanotubes is provided, as well as insights that may assist in the design and production of safer nanomaterials to limit the hazards of currently used CNTs.

Genotoxicity of multi-walled carbon nanotube reference materials in mammalian cells and animals

Carbon nanotubes (CNTs) were the first nanomaterials to be evaluated by the International Agency for Research on Cancer (IARC). The categorization as possibly carcinogenic agent to humans was only applicable to multi-walled carbon nanotubes called MWCNT-7. Other types of CNTs were not classifiable because of missing data and it was not possible to pinpoint unique CNT characteristics that cause cancer. Importantly, the European Commission's Joint Research Centre (JRC) has established a repository of industrially manufactured nanomaterials that encompasses at least four well-characterized MWCNTs called NM-400 to NM-403 (original JRC code). This review summarizes the genotoxic effects of these JRC materials and MWCNT-7. The review consists of 36 publications with results on cell culture experiments (22 publications), animal models (9 publications) or both (5 publications). As compared to the publications in the IARC monograph on CNTs, the current database represents a significant increase as there is only an overlap of 8 publications. However, the results come mainly from cell cultures and/or measurements of DNA strand breaks by the comet assay and the micronucleus assay (82 out of 97 outcomes). A meta-analysis of cell culture studies on DNA strand breaks showed a genotoxic response by MWCNT-7, less consistent effect by NM-400 and NM-402, and least consistent effect by NM-401 and NM-403. Results from other in vitro tests indicate strongest evidence of genotoxicity for MWCNT-7. There are too few observations from animal models and humans to make general conclusions about genotoxicity.

Histological sequence of the development of rat mesothelioma by MWCNT, with the involvement of apolipoproteins

A rat model of mesothelioma development by peritoneal injection of multiwalled carbon nanotube (MWCNT) has been established and found to be useful to understand the mechanisms underlying fibrous particles‐associated carcinogenesis. Its detailed histological sequence, however, remains largely obscure. We therefore aimed to assess the time‐course of mesothelioma development by MWCNT and evaluate a set of lipoprotein‐related molecules as potential mechanism‐based biomarkers for the phenomenon. Male Fischer 344 rats were injected intraperitoneally (ip) with MWCNT (MWNT‐7) at 1 mg/kg body weight, and necropsied at 8, 16, 24, 32, or 42 wk after injection. For biochemical analyses of the lipoprotein‐related molecules, more samples, including severe mesothelioma cases, were obtained from 2 other carcinogenicity tests. Histologically, in association with chronic inflammation, mesothelial proliferative lesions appeared at c. Wk‐24. Before and at the beginning of the tumor development, a prominent infiltration of CD163‐positive cells was seen near mesothelial cells. The histological pattern of early mesothelioma was not a papillary structure, but was a characteristic structure with a spherical appearance, composed of the mesothelioma cells in the surface area that were underlain by connective tissue‐like cells. Along with the progression, mesotheliomas started to show versatile histological subtypes. Serum levels of apolipoprotein A‐I and A‐IV, and a ratio of HDL cholesterol to total cholesterol were inversely correlated with mesothelioma severity. Overall, the detailed histological sequence of mesotheliomagenesis by MWCNT is demonstrated, and indicated that the altered profile of apolipoproteins may be involved in its underlying mechanisms.

An integrated approach to testing and assessment of high aspect ratio nanomaterials and its application for grouping based on a common mesothelioma hazard

Here we describe the development of an Integrated Approach to Testing and Assessment (IATA) to support the grouping of different types (nanoforms; NFs) of High Aspect Ratio Nanomaterials (HARNs), based on their potential to cause mesothelioma. Hazards posed by the inhalation of HARNs are of particular concern as they exhibit physical characteristics similar to pathogenic asbestos fibres. The approach for grouping HARNs presented here is part of a framework to provide guidance and tools to group similar NFs and aims to reduce the need to assess toxicity on a case-by-case basis. The approach to grouping is hypothesis-driven, in which the hypothesis is based on scientific evidence linking critical physicochemical descriptors for NFs to defined fate/toxicokinetic and hazard outcomes. The HARN IATA prompts users to address relevant questions (at decision nodes; DNs) regarding the morphology, biopersistence and inflammatory potential of the HARNs under investigation to provide the necessary evidence to accept or reject the grouping hypothesis. Each DN in the IATA is addressed in a tiered manner, using data from simple in vitro or in silico methods in the lowest tier or from in vivo approaches in the highest tier. For these proposed methods we provide justification for the critical descriptors and thresholds that allow grouping decisions to be made. Application of the IATA allows the user to selectively identify HARNs which may pose a mesothelioma hazard, as demonstrated through a literature-based case study. By promoting the use of alternative, non-rodent approaches such as in silico modelling, in vitro and cell-free tests in the initial tiers, the IATA testing strategy streamlines information gathering at all stages of innovation through to regulatory risk assessment while reducing the ethical, time and economic burden of testing.

Occupational Exposure to Carbon Nanotubes and Carbon Nanofibres: More Than a Cobweb

Carbon nanotubes (CNTs) and carbon nanofibers (CNFs) are erroneously considered as singular material entities. Instead, they should be regarded as a heterogeneous class of materials bearing different properties eliciting particular biological outcomes both in vitro and in vivo. Given the pace at which the industrial production of CNTs/CNFs is increasing, it is becoming of utmost importance to acquire comprehensive knowledge regarding their biological activity and their hazardous effects in humans. Animal studies carried out by inhalation showed that some CNTs/CNFs species can cause deleterious effects such as inflammation and lung tissue remodeling. Their physico-chemical properties, biological behavior and biopersistence make them similar to asbestos fibers. Human studies suggest some mild effects in workers handling CNTs/CNFs. However, owing to their cross-sectional design, researchers have been as yet unable to firmly demonstrate a causal relationship between such an exposure and the observed effects. Estimation of acceptable exposure levels should warrant a proper risk management. The aim of this review is to challenge the conception of CNTs/CNFs as a single, unified material entity and prompt the establishment of standardized hazard and exposure assessment methodologies able to properly feed risk assessment and management frameworks.

Cellular senescence as a response to multiwalled carbon nanotube (MWCNT) exposure in human mesothelial cells

Cellular senescence is a stable cell cycle arrest induced by diverse triggers, including replicative exhaustion, DNA damaging agents, oncogene activation, oxidative stress, and chromatin disruption. With important roles in aging and tumor suppression, cellular senescence has been implicated also in tumor promotion. Here we show that certain multiwalled carbon nanotubes (MWCNTs), as fiber-like nanomaterials, can trigger cellular senescence in primary human mesothelial cells. Using in vitro approaches, we found manifestation of several markers of cellular senescence, especially after exposure to a long and straight MWCNT. These included inhibition of cell division, senescence-associated heterochromatin foci, senescence-associated distension of satellites, LMNB1 depletion, γH2A.X nuclear panstaining, and enlarged cells exhibiting senescence-associated β-galactosidase activity. Furthermore, genome-wide transcriptome analysis revealed many differentially expressed genes, among which were genes encoding for a senescence-associated secretory phenotype. Our results clearly demonstrate the potential of long and straight MWCNTs to induce premature cellular senescence. This finding may find relevance in risk assessment of workplace safety, and in evaluating MWCNT's use in medicine such as drug carrier, due to exposure effects that might prompt onset of age-related diseases, or even carcinogenesis.

Lung toxicity of a vapor-grown carbon fiber in comparison with a multi-walled carbon nanotube in F344 rats

Carbon fibers have excellent physicochemical and electrical properties. Vapor-grown carbon fibers are a type of carbon fibers that have a multi-walled carbon tube structure with a high aspect ratio. The representative vapor-grown carbon fiber, VGCF^TM-H, is extremely strong and stable and has superior thermal and electrical conductivity. Because some high-aspect-ratio multi-walled carbon nanotubes (MWCNTs) have been reported to have toxic and carcinogenic effects in the lungs of rodents, we performed a 13-week lung toxicity study using VGCF^TM-H in comparison with one of MWCNTs, MWNT-7, in rats. Male and female F344 rats were intratracheally administered VGCF^TM-H at doses of 0.2, 0.4, and 0.8 mg/kg bw or MWNT-7 at doses of 0.4 and 0.8 mg/kg bw once a week for 8 weeks and then up to week 13 without treatment. The lung burden was equivalent in the VGCF^TM-H and MWNT-7 groups; however, the lung weight had increased and the inflammatory and biochemical parameters in the broncho-alveolar lavage fluid and histopathological parameters, including inflammatory cell infiltration, alveolar type II cells proliferation, alveolar fibrosis, pleural fibrosis, lung mesothelium proliferation, and diaphragm fibrosis, were milder in the VGCF^TM-H group than in the MWNT-7 group. In addition, the proliferating cell nuclear antigen (PCNA)-positive index in the visceral and pleural mesothelium was significantly higher in the MWNT-7 group than in the controls, but not in the VGCF^TM-H group. Thus, the results of this study indicate that the lung and pleural toxicities of VGCF^TM-H were less than those of MWNT-7.

Predictive Biomarkers for the Ranking of Pulmonary Toxicity of Nanomaterials

We analyzed the mRNA expression of chemokines in rat lungs following intratracheal instillation of nanomaterials in order to find useful predictive markers of the pulmonary toxicity of nanomaterials. Nickel oxide (NiO) and cerium dioxide (CeO₂) as nanomaterials with high pulmonary toxicity, and titanium dioxide (TiO₂) and zinc oxide (ZnO) as nanomaterials with low pulmonary toxicity, were administered into rat lungs (0.8 or 4 mg/kg BW). C-X-C motif chemokine 5 (CXCL5), C-C motif chemokine 2 (CCL2), C-C motif chemokine 7 (CCL7), C-X-C motif chemokine 10 (CXCL10), and C-X-C motif chemokine 11 (CXCL11) were selected using cDNA microarray analysis at one month after instillation of NiO in the high dose group. The mRNA expression of these five genes were evaluated while using real-time quantitative polymerase chain reaction (RT-qPCR) from three days to six months after intratracheal instillation. The receiver operating characteristic (ROC) results showed a considerable relationship between the pulmonary toxicity ranking of nanomaterials and the expression of CXCL5, CCL2, and CCL7 at one week and one month. The expression levels of these three genes also moderately or strongly correlated with inflammation in the lung tissues. Three chemokine genes can be useful as predictive biomarkers for the ranking of the pulmonary toxicity of nanomaterials.

Comparative carcinogenicity study of a thick, straight-type and a thin, tangled-type multi-walled carbon nanotube administered by intra-tracheal instillation in the rat

Background

Multi-walled carbon nanotubes can be divided into two general subtypes: tangled and straight. MWCNT-N (60 nm in diameter) and MWCNT-7 (80–90 nm in diameter) are straight-type MWCNTs, and similarly to asbestos, both are carcinogenic to the lung and pleura when administered to rats via the airway. Injection of straight-type MWCNTs into the peritoneal cavity also induces the development of mesothelioma, however, injection of tangled-type MWCNTs into the peritoneal cavity does not induce carcinogenesis. To investigate these effects in the lung we conducted a 2-year comparative study of the potential carcinogenicities of a straight-type MWCNT, MWCNT-A (approximately 150 nm in diameter), and a tangled-type MWCNT, MWCNT-B (7.4 nm in diameter) after administration into the rat lung. Crocidolite asbestos was used as the reference material, and rats administered vehicle were used as the controls. Test materials were administered by intra-Tracheal Intra-Pulmonary Spraying (TIPS) once a week over a 7 week period (8 administrations from day 1 to day 50), followed by a 2-year observation period without further treatment. Rats were administered total doses of 0.5 or 1.0 mg MWCNT-A and MWCNT-B or 1.0 mg asbestos.

Results

There was no difference in survival between any of the groups. The rats administered MWCNT-A or asbestos did not have a significant increase in bronchiolo-alveolar hyperplasia or tumors in the lung. However, the rats administered MWCNT-B did have significantly elevated incidences of bronchiolo-alveolar hyperplasia and tumors in the lung: the incidence of bronchiolo-alveolar hyperplasia was 0/20, 6/20, and 9/20 in the vehicle, 0.5 mg MWCNT-B, and 1.0 mg MWCNT-B groups, respectively, and the incidence of adenoma and adenocarcinoma combined was 1/19, 5/20, and 7/20 in the vehicle, 0.5 mg MWCNT-B, and 1.0 mg MWCNT-B groups, respectively. Malignant pleural mesothelioma was not induced in any of the groups.

Conclusions

The results of this initial study indicate that tangled-type MWCNT-B is carcinogenic to the rat lung when administered via the airway, and that straight-type MWCNT-A did not have higher carcinogenic potential in the rat lung than tangled-type MWCNT-B.

Multi-walled carbon nanotubes induce IL-1β secretion by activating hemichannels-mediated ATP release in THP-1 macrophages

Multi-walled carbon nanotubes (MWCNTs) are known to induce pulmonary inflammatory effects through stimulating pro-inflammatory cytokine secretion from alveolar macrophages. Despite extensive studies on MWCNTs' pro-inflammatory reactivity, the understanding of molecular mechanisms involved is still incomplete. In this study, we investigated hemichannel's involvement in MWCNTs-induced macrophage IL-1β release. Our results showed that the unmodified and COOH MWCNTs could induce ATP release and ATP-P2X₇R axis-dependent IL-1β secretion from THP-1 macrophages. By using various inhibitors, we confirmed that the MWCNTs-induced ATP release was primarily through hemichannels. EtBr dye uptake assay detected significant hemichannels opening in MWCNTs exposed THP-1 macrophages. Inhibition of hemichannels by CBX, ⁴³Gap27, or ¹⁰Panx1 pretreatment results in decreased ATP and IL-1β release. The addition of ATP restored the reduced IL-1β secretion level from hemichannel inhibition. We also confirmed with five other types of MWCNTs that the induction of hemichannels by MWCNTs strongly correlates with their capacity to induce IL-1β secretion. Taken together, we conclude that hemichannels-mediated ATP release and subsequent NLRP3 inflammasome activation through P2X₇R may be one mechanism by which MWCNTs induce macrophage IL-1β secretion. Our findings may provide a novel molecular mechanism for MWCNTs induced IL-1β secretion.

Extracellular vesicles as biomarkers in malignant pleural mesothelioma: A review

Extracellular vesicles (EV) are secreted by all cells, including cancer cells, as a mode of intercellular transport and communication. The main types of EV known to date include exosomes, microvesicles and apoptotic bodies, as well as oncosomes and large oncosomes, which are specific to cancer cells. These different EV populations carry specific cargo from one cell to another to stimulate a specific response. They can be found in all body fluids and can be detected in liquid biopsies. EV released from mesothelioma cells can reveal important information about the molecules and signalling pathways involved in the development and progression of the tumour. The presence of tumour-derived EV in circulating body fluids makes them potential novel biomarkers for early diagnosis, prognostication and surveillance of cancer. In this review, we explore the characteristics and functional roles of EV reported in the literature, with a focus on their role in malignant pleural mesothelioma.

Frequent homozygous deletion of Cdkn2a/2b in tremolite-induced malignant mesothelioma in rats

The onset of malignant mesothelioma (MM) is linked to exposure to asbestos fibers. Asbestos fibers are classified as serpentine (chrysotile) or amphibole, which includes the crocidolite, amosite, anthophyllite, tremolite, and actinolite types. Although few studies have been undertaken, anthophyllite has been shown to be associated with mesothelioma, and tremolite, a contaminant in talc and chrysotile, is a risk factor for carcinogenicity. Here, after characterizing the length and width of these fibers by scanning electron microscopy, we explored the cytotoxicity induced by tremolite and anthophyllite in cells from an immortalized human mesothelial cell line (MeT5A), murine macrophages (RAW264.7), and in a rat model. Tremolite and short anthophyllite fibers were phagocytosed and localized to vacuoles, whereas the long anthophyllite fibers were caught on the pseudopod of the MeT5A and Raw 264.7 cells, according to transmission electron microscopy. The results from a 2-day time-lapse study revealed that tremolite was engulfed and damaged the MeT5A and RAW264.7 cells, but anthophyllite was not cytotoxic to these cells. Intraperitoneal injection of tremolite in rats induced diffuse serosal thickening, whereas anthophyllite formed focal fibrosis and granulomas on peritoneal serosal surfaces. Furthermore, the loss of Cdkn2a/2b, which are the most frequently lost foci in human MM, were observed in 8 cases of rat MM (homozygous deletion [5/8] and loss of heterozygosity [3/8]) by array-based comparative genomic hybridization techniques. These results indicate that tremolite initiates mesothelial injury and persistently frustrates phagocytes, causing subsequent peritoneal fibrosis and MM. The possible mechanisms of carcinogenicity based on fiber diameter/length are discussed.

MWCNT-7 administered to the lung by intratracheal instillation induces development of pleural mesothelioma in F344 rats

Multi‐walled carbon nanotube‐7 (MWCNT‐7) fibers are biopersistent and have a structure similar to asbestos. MWCNT‐7 has been shown to induce malignant mesothelioma when administered by intrascrotal or intraperitoneal injection in rats and mice, and an inhalation study demonstrated that rats exposed to respirable MWCNT‐7 developed lung tumors. MWCNT‐N, which is similar to MWCNT‐7, was shown to induce both lung tumors and malignant mesothelioma in rats when administered by trans‐tracheal intrapulmonary spraying (TIPS). The present study was performed to investigate the carcinogenicity of MWCNT‐7 when administered by the TIPS method. Ten‐week‐old male F344/Crj rats were divided into 3 groups and administered 0.5 mL vehicle, 0.250 μg/mL MWCNT‐7 or 0.250 μg/mL crocidolite once a week for 12 weeks (total doses of 1.5 mg/rat) and then observed for up to 104 weeks. Rats in the MWCNT‐7 group began to die from pathologies associated with the development of malignant mesothelioma 35 weeks after the final TIPS administration. Overall, the incidence of malignant mesothelioma in the MWCNT‐7 group was significantly higher than in the vehicle or crocidolite groups.