Short- and long-term efficacy of single-dose subunit vaccines against Yersinia pestis in mice

Combinatorial Viral Vector-Based and Live Attenuated Vaccines without an Adjuvant to Generate Broader Immune Responses to Effectively Combat Pneumonic Plague

Mice immunized with a combination of an adenovirus vector (Ad5-YFV) and live-attenuated (LMA)-based vaccines were evaluated for protective efficacy against pneumonic plague. While the Ad5-YFV vaccine harbors a fusion cassette of three genes encoding YscF, F1, and LcrV, LMA represents a mutant of parental Yersinia pestis CO92 deleted for genes encoding Lpp, MsbB, and Ail. Ad5-YFV and LMA were either administered simultaneously (1-dose regimen) or 21 days apart in various orders and route of administration combinations (2-dose regimen). The 2-dose regimen induced robust immune responses to provide full protection to animals against parental CO92 and its isogenic F1 deletion mutant (CAF⁻) challenges during both short- and long-term studies. Mice intranasally (i.n.) immunized with Ad5-YFV first followed by LMA (i.n. or intramuscularly [i.m.]) had higher T- and B-cell proliferative responses and LcrV antibody titers than those in mice vaccinated with LMA (i.n. or i.m.) first ahead of Ad5-YFV (i.n.) during the long-term study. Specifically, the needle- and adjuvant-free vaccine combination (i.n.) is ideal for use in plague regions of endemicity. Conversely, with a 1-dose regimen, mice vaccinated with Ad5-YFV i.n. and LMA by the i.m. route provided complete protection to animals against CO92 and its CAF⁻ mutant challenges and elicited Th1/Th2, as well as Th17 responses, making it suitable for emergency vaccination during a plague outbreak or bioterrorist attack. This is a first study in which a viral vector-based and live-attenuated vaccines were effectively used in combination, representing adjuvant- and/or needle-free immunization, with each vaccine triggering a distinct cellular immune response.

Impact of Toll-Like Receptor-Specific Agonists on the Host Immune Response to the Yersinia pestis Plague rF1V Vaccine

Relatively recent advances in plague vaccinology have produced the recombinant fusion protein F1-V plague vaccine. This vaccine has been shown to readily protect mice from both bubonic and pneumonic plague. The protection afforded by this vaccine is solely based upon the immune response elicited by the F1 or V epitopes expressed on the F1-V fusion protein. Accordingly, questions remain surrounding its efficacy against infection with non-encapsulated (F1-negative) strains. In an attempt to further optimize the F1-V elicited immune response and address efficacy concerns, we examined the inclusion of multiple toll-like receptor agonists into vaccine regimens. We examined the resulting immune responses and also any protection afforded to mice that were exposed to aerosolized Yersinia pestis. Our data demonstrate that it is possible to further augment the F1-V vaccine strategy in order to optimize and augment vaccine efficacy.

Single-dose intranasal subunit vaccine rapidly clears secondary sepsis in a high-dose pneumonic plague infection

Yersinia pestis, the causative agent of plague, has killed millions throughout human history. Though public health initiatives have reduced the number of plague cases, it remains endemic in many areas of the world. It also remains a significant threat for use as a biological weapon. Naturally occurring multi-drug antibiotic resistance has been observed in Y. pestis, and resistant strains have been engineered for use as a biological weapon. Vaccines represent our best means of protection against the threat of antibiotic resistant plague. We have developed a vaccine consisting of two Y. pestis virulence factors, LcrV (V) and F1, conjugated to Tobacco Mosaic Virus (TMV), a safe, non-replicating plant virus that can be administered mucosally, providing complete protection against pneumonic plague, the deadliest form of the disease and the one most likely to be seen in a biological attack. A single intranasal (i.n.) dose of TMV-F1 + TMV-V (TMV-F1/V) protected 88% of mice against lethal challenge with 100 LD₅₀ of Y. pestis CO92pgm-, while immunization with rF1 + rV without TMV was not protective. Serum and tissues were collected at various timepoints after challenge to assess bacterial clearance, histopathology, cytokine production, and antibody production. Overall, TMV-F1/V immunized mice showed a significant reduction in histopathology, bacterial burden, and inflammatory cytokine production following challenge compared to rF1 + rV vaccinated and unvaccinated mice. Pneumonic challenge resulted in systemic dissemination of the bacteria in all groups, but only TMV-F1/V immunized mice rapidly cleared bacteria from the spleen and liver. There was a direct correlation between pre-challenge serum F1 titers and recovery in all immunized mice, strongly suggesting a role for antibody in the neutralization and/or opsonization of Y. pestis in this model. Mucosal administration of a single dose of a Y. pestis TMV-based subunit vaccine, without any additional adjuvant, can effectively protect mice from lethal infection.

A new generation needle- and adjuvant-free trivalent plague vaccine utilizing adenovirus-5 nanoparticle platform

A plague vaccine with a fusion cassette of YscF, F1, and LcrV encoding genes in an adenovirus-5 vector (rAd5-YFV) is evaluated for efficacy and immune responses in mice. Two doses of the vaccine provides 100% protection when administered intranasally against challenge with Yersinia pestis CO92 or its isogenic F1 mutant in short- or long- term immunization in pneumonic/bubonic plague models. The corresponding protection rates drop in rAd5-LcrV monovalent vaccinated mice in plague models. The rAd5-YFV vaccine induces superior humoral, mucosal and cell-mediated immunity, with clearance of the pathogen. Immunization of mice with rAd5-YFV followed by CO92 infection dampens proinflammatory cytokines and neutrophil chemoattractant production, while increasing Th1- and Th2-cytokine responses as well as macrophage/monocyte chemo-attractants when compared to the challenge control animals. This is a first study showing complete protection of mice from pneumonic/bubonic plague with a viral vector-based vaccine without the use of needles and the adjuvant.

Protection and Safety Evaluation of Live Constructions Derived from the Pgm- and pPCP1- Yersinia pestis Strain

Based on a live attenuated Yersinia pestis KIM10(pCD1Ap) strain (Pgm-, pPCP1-), we attempted to engineer its lipid A species to achieve improvement of immunogenicity and safety. A mutant strain designated as YPS19(pCD1Ap), mainly synthesizing the hexa-acylated lipid A, and another mutant strain designated as YPS20(pCD1Ap), synthesizing 1-dephosphalated hexa-acylated lipid A (detoxified lipid A), presented relatively low virulence in comparison to KIM10(pCD1Ap) by intramuscular (i.m.) or subcutaneous (s.c.) administration. The i.m. administration with either the KIM10(pCD1Ap) or YPS19(pCD1Ap) strain afforded significant protection against bubonic and pneumonic plague compared to the s.c. administration, while administration with completely attenuated YPS20(pCD1Ap) strain failed to afford significant protection. Antibody analysis showed that i.m. administration induced balanced Th1 and Th2 responses but s.c. administration stimulated Th2-biased responses. Safety evaluation showed that YPS19(pCD1Ap) was relatively safer than its parent KIM10(pCD1Ap) in Hfe-/- mice manifesting iron overload in tissues, which also did not impair its protection. Therefore, the immune activity of hexa-acylated lipid A can be harnessed for rationally designing bacteria-derived vaccines.

Single-dose combination nanovaccine induces both rapid and long-lived protection against pneumonic plague

Yersinia pestis, the causative agent of pneumonic plague, induces a highly lethal infection if left untreated. Currently, there is no FDA-approved vaccine against this pathogen; however, USAMRIID has developed a recombinant fusion protein, F1-V, that has been shown to induce protection against pneumonic plague. Many F1-V-based vaccine formulations require prime-boost immunization to achieve protective immunity, and there are limited reports of rapid induction of protective immunity (≤ 14 days post-immunization (DPI)). The STimulator of INterferon Genes agonists cyclic dinucleotides (CDNs) have been shown to be promising vaccine adjuvants. Polyanhydride nanoparticle-based vaccines (i.e., nanovaccines) have also shown to enhance immune responses due to their dual functionality as adjuvants and delivery vehicles. In this work, a combination nanovaccine was designed that comprised F1-V-loaded nanoparticles combined with the CDN, dithio-RP,RP-cyclic di-guanosine monophosphate, to induce rapid and long-lived protective immunity against pneumonic plague. All mice immunized with a single dose combination nanovaccine were protected from Y. pestis lethal challenge within 14 DPI and demonstrated enhanced protection over F1-V adjuvanted with CDNs alone at challenge doses ≥7000 CFU Y. pestis CO92. In addition, 75% of mice receiving the single dose of the combination nanovaccine were protected from challenge at 182 DPI, while maintaining high levels of antigen-specific serum IgG. ELISPOT analysis of vaccinated animals at 218 DPI revealed F1-V-specific long-lived plasma cells in bone marrow in mice vaccinated with CDN adjuvanted F1-V or the combination nanovaccine. Microarray analysis of serum from these vaccinated mice revealed the presence of serum antibody that bound to a broad range of F1 and V linear epitopes. These results demonstrate that combining the adjuvanticity of CDNs with a nanovaccine delivery system enables induction of both rapid and long-lived protective immunity against Y. pestis. STATEMENT OF SIGNIFICANCE: • Yersinia pestis, the causative agent of pneumonic plague, induces a highly lethal infection if left untreated. Currently, there is no FDA-approved vaccine against this biodefense pathogen. • We designed a combination nanovaccine comprising of F1-V antigen-loaded polyanhydride nanoparticles and a cyclic dinucleotide adjuvant to induce both rapid and long-lived protective immunity against pneumonic plague. • Animals immunized with the combination nanovaccine maintained high levels of antigen-specific serum IgG and long-lived plasma cells in bone marrow and the serum antibody showed a high affinity for a broad range of F1 and V linear epitopes. • The combination nanovaccine is a promising next-generation vaccine platform against weaponized Y. pestis based on its ability to induce both rapid and long-lived protective immunity.

Plague vaccine: recent progress and prospects

Three great plague pandemics, resulting in nearly 200 million deaths in human history and usage as a biowarfare agent, have made Yersinia pestis as one of the most virulent human pathogens. In late 2017, a large plague outbreak raged in Madagascar attracted extensive attention and caused regional panics. The evolution of local outbreaks into a pandemic is a concern of the Centers for Disease Control and Prevention (CDC) in plague endemic regions. Until now, no licensed plague vaccine is available. Prophylactic vaccination counteracting this disease is certainly a primary choice for its long-term prevention. In this review, we summarize the latest advances in research and development of plague vaccines.

A Bivalent Anthrax-Plague Vaccine That Can Protect against Two Tier-1 Bioterror Pathogens, Bacillus anthracis and Yersinia pestis

Bioterrorism remains as one of the biggest challenges to global security and public health. Since the deadly anthrax attacks of 2001 in the United States, Bacillus anthracis and Yersinia pestis, the causative agents of anthrax and plague, respectively, gained notoriety and were listed by the CDC as Tier-1 biothreat agents. Currently, there is no Food and Drug Administration-approved vaccine against either of these threats for mass vaccination to protect general public, let alone a bivalent vaccine. Here, we report the development of a single recombinant vaccine, a triple antigen consisting of all three target antigens, F1 and V from Y. pestis and PA from B. anthracis, in a structurally stable context. Properly folded and soluble, the triple antigen retained the functional and immunogenicity properties of all three antigens. Remarkably, two doses of this immunogen adjuvanted with Alhydrogel^® elicited robust antibody responses in mice, rats, and rabbits and conferred complete protection against inhalational anthrax and pneumonic plague. No significant antigenic interference was observed. Furthermore, we report, for the first time, complete protection of animals against simultaneous challenge with Y. pestis and the lethal toxin of B. anthracis, demonstrating that a single biodefense vaccine can protect against a bioterror attack with weaponized B. anthracis and/or Y. pestis. This bivalent anthrax–plague vaccine is, therefore, a strong candidate for stockpiling, after demonstration of its safety and immunogenicity in human clinical trials, as part of national preparedness against two of the deadliest bioterror threats.

Plague Vaccine Development: Current Research and Future Trends

Plague is one of the world’s most lethal human diseases caused by Yersinia pestis, a Gram-negative bacterium. Despite overwhelming studies for many years worldwide, there is no safe and effective vaccine against this fatal disease. Inhalation of Y. pestis bacilli causes pneumonic plague, a fast growing and deadly dangerous disease. F1/LcrV-based vaccines failed to provide adequate protection in African green monkey model in spite of providing protection in mice and cynomolgus macaques. There is still no explanation for this inconsistent efficacy, and scientists leg behind to search reliable correlate assays for immune protection. These paucities are the main barriers to improve the effectiveness of plague vaccine. In the present scenario, one has to pay special attention to elicit strong cellular immune response in developing a next-generation vaccine against plague. Here, we review the scientific contributions and existing progress in developing subunit vaccines, the role of molecular adjuvants; DNA vaccines; live delivery platforms; and attenuated vaccines developed to counteract virulent strains of Y. pestis.

A Recombinant Trivalent Fusion Protein F1-LcrV-HSP70(II) Augments Humoral and Cellular Immune Responses and Imparts Full Protection against Yersinia pestis

Plague is one of the most dangerous infections in humans caused by Yersinia pestis, a Gram-negative bacterium. Despite of an overwhelming research success, no ideal vaccine against plague is available yet. It is well established that F1/LcrV based vaccine requires a strong cellular immune response for complete protection against plague. In our earlier study, we demonstrated that HSP70(II) of Mycobacterium tuberculosis modulates the humoral and cellular immunity of F1/LcrV vaccine candidates individually as well as in combinations in a mouse model. Here, we made two recombinant constructs caf1–lcrV and caf1–lcrV–hsp70(II). The caf1 and lcrV genes of Y. pestis and hsp70 domain II of M. tuberculosis were amplified by polymerase chain reaction. Both the recombinant constructs caf1–lcrV and caf1–lcrV–hsp70(II) were cloned in pET28a vector and expressed in Escherichia coli. The recombinant fusion proteins F1–LcrV and F1–LcrV–HSP70(II) were purified using Ni-NTA columns and formulated with alum to evaluate the humoral and cell mediated immune responses in mice. The protective efficacies of F1–LcrV and F1–LcrV–HSP70(II) were determined following challenge of immunized mice with 100 LD₅₀ of Y. pestis through intraperitoneal route. Significant differences were noticed in the titers of IgG and it’s isotypes, i.e., IgG1, IgG2b, and IgG3 in anti- F1–LcrV–HSP70(II) sera in comparison to anti-F1–LcrV sera. Similarly, significant differences were also noticed in the expression levels of IL-2, IFN-γ and TNF-α in splenocytes of F1–LcrV–HSP(II) immunized mice in comparison to F1–LcrV. Both F1–LcrV and F1–LcrV–HSP70(II) provided 100% protection. Our research findings suggest that F1–LcrV fused with HSP70 domain II of M. tuberculosis significantly enhanced the humoral and cellular immune responses in mouse model.

Immunogenicity and safety of subunit plague vaccine: A randomized phase 2a clinical trial

BACKGROUND

Although the killed whole-cell and live attenuated plague vaccine have been licensed, they are rarely used today because of toxicities, limited evidence of efficacy against plague, poor immune persistence required booster immunization every year, and limited commercial availability. This study was a randomized phase 2a clinical trial aimed to evaluating the immunogenicity and safety of a novel subunit plague vaccine.

METHODS

240 healthy adults aged 18-55 y were enrolled and randomly assigned at a ratio of 1:1 to receive 2 doses of 15 or 30 mcg vaccine at a 28-day interval between doses. Blood samples were collected at day 0, 28 and 56. Adverse events were collected during the first 28 d after each vaccination. Serious Adverse Event was observed throughout the study period.

RESULTS

239 participants received the first dose at day 0 and 238 received the second dose at day 28. Antibodies to envelope antigen faction 1 (F1) and recombinant virulence antigen (rV) were increased at day 28, and boosted significantly at day 56. For anti-F1 antibodies, geometric mean titer (GMT) and geometric mean fold increase (GMFI) were significantly higher in 30 mcg group than in the 15 mcg group(each P1< 0.05 at day 28 and each P1< 0.001 at day 56), with similar seroconversion rate of antibodies between 15 and 30 mcg group at both of the 2 time points. For anti-rV antibodies, seroconversion rate at day 28 in 30 mcg group was higher than that in 15 mcg group. However, GMT and GMFI of anti-rV antibodies were increased to approximately the same levels in the 2 groups. Similar booster immune response was also noticed in both groups at day 56. The injections were well tolerated, with mainly mild or moderate local and systemic adverse reactions (lower than grad 3). The proportion of pain at injection site was higher in 30 mcg group. None of SAEs were reported during 56 d.

CONCLUSION

The plague vaccine comprised of F1 and rV antigens showed good safety and immunogenicity in adults aged 18-55 y old. The data show that the 30 mcg formulation is generally more immunogenic than the 15 mcg formulation, and represents the preferred formulation for further clinical development. It will be important to evaluate the long-term efficacy for appropriate formulations of the plague subunit vaccine.

Highly Effective Soluble and Bacteriophage T4 Nanoparticle Plague Vaccines Against Yersinia pestis

Plague caused by Yersinia pestis is an ancient disease, responsible for millions of deaths in human history. Unfortunately, there is no FDA-approved vaccine available. Recombinant subunit vaccines based on two major antigens, Caf 1 (F1) and LcrV (V), have been under investigation and showed promise. However, there are two main problems associated with these vaccines. First, the Yersinia capsular protein F1 has high propensity to aggregate, particularly when expressed in heterologous systems such as Escherichia coli, thus affecting vaccine quality and efficacy. Second, the subunit vaccines do not induce adequate cell-mediated immune responses that also appear to be essential for optimal protection against plague. We have developed two basic approaches, structure-based immunogen design and phage T4 nanoparticle delivery, to construct new plague vaccines that may overcome these problems. First, by engineering F1 protein, we generated a monomeric and soluble F1V mutant (F1mutV) which has similar immunogenicity as wild-type F1V. The NH2-terminal β-strand of F1 was transplanted to the COOH-terminus and the sequence flanking the β-strand was duplicated to retain a key CD4(+) T cell epitope. Second, we generated a nanoparticle plague vaccine that can induce balanced antibody- and cell-mediated immune responses. This was done by arraying the F1mutV on phage T4 via the small outer capsid (Soc) protein which binds to T4 capsid at nanomolar affinity. Preparation of these vaccines is described in detail and we hope that these would be considered as candidates for licensing a next-generation plague vaccine.

Bacteriophages of Yersinia pestis

Bacteriophage play many varied roles in microbial ecology and evolution. This chapter collates a vast body of knowledge and expertise on Yersinia pestis phages, including the history of their isolation and classical methods for their isolation and identification. The genomic diversity of Y. pestis phage and bacteriophage islands in the Y. pestis genome are also discussed because all phage research represents a branch of genetics. In addition, our knowledge of the receptors that are recognized by Y. pestis phage, advances in phage therapy for Y. pestis infections, the application of phage in the detection of Y. pestis, and clustered regularly interspaced short palindromic repeats (CRISPRs) sequences of Y. pestis from prophage DNA are all reviewed here.

Characterization of a Cynomolgus Macaque Model of Pneumonic Plague for Evaluation of Vaccine Efficacy

The efficacy of a recombinant plague vaccine (rF1V) was evaluated in cynomolgus macaques (CMs) to establish the relationship among vaccine doses, antibody titers, and survival following an aerosol challenge with a lethal dose of Yersinia pestis strain Colorado 92. CMs were vaccinated with a range of rF1V doses on a three-dose schedule (days 0, 56, and 121) to provide a range of survival outcomes. The humoral immune response following vaccination was evaluated with anti-rF1, anti-rV, and anti-rF1V bridge enzyme-linked immunosorbent assays (ELISAs). Animals were challenged via aerosol exposure on day 149. Vaccine doses and antibody responses were each significantly associated with the probability of CM survival (P < 0.0001). Vaccination also decreased signs of pneumonic plague in a dose-dependent manner. There were statistically significant correlations between the vaccine dose and the time to onset of fever (P < 0.0001), the time from onset of fever to death (P < 0.0001), the time to onset of elevated respiratory rate (P = 0.0003), and the time to onset of decreased activity (P = 0.0251) postinfection in animals exhibiting these clinical signs. Delays in the onset of these clinical signs of disease were associated with larger doses of rF1V. Immunization with ≥ 12 μg of rF1V resulted in 100% CM survival. Since both the vaccine dose and anti-rF1V antibody titers correlate with survival, rF1V bridge ELISA titers can be used as a correlate of protection.

HSP70 domain II of Mycobacterium tuberculosis modulates immune response and protective potential of F1 and LcrV antigens of Yersinia pestis in a mouse model

No ideal vaccine exists to control plague, a deadly dangerous disease caused by Yersinia pestis. In this context, we cloned, expressed and purified recombinant F1, LcrV antigens of Y. pestis and heat shock protein70 (HSP70) domain II of M. tuberculosis in E. coli. To evaluate the protective potential of each purified protein alone or in combination, Balb/C mice were immunized. Humoral and cell mediated immune responses were evaluated. Immunized animals were challenged with 100 LD50 of Y. pestis via intra-peritoneal route. Vaccine candidates i.e., F1 and LcrV generated highly significant titres of anti-F1 and anti-LcrV IgG antibodies. A significant difference was noticed in the expression level of IL-2, IFN-γ and TNF-α in splenocytes of immunized animals. Significantly increased percentages of CD4+ and CD8+ T cells producing IFN-γ in spleen of vaccinated animals were observed in comparison to control group by flow cytometric analysis. We investigated whether the F1, LcrV and HSP70(II) antigens alone or in combination can effectively protect immunized animals from any histopathological changes. Signs of histopathological lesions noticed in lung, liver, kidney and spleen of immunized animals on 3rd day post challenge whereas no lesions in animals that survived to day 20 post-infection were observed. Immunohistochemistry showed bacteria in lung, liver, spleen and kidney on 3rd day post-infection whereas no bacteria was observed on day 20 post-infection in surviving animals in LcrV, LcrV+HSP70(II), F1+LcrV, and F1+LcrV+HSP70(II) vaccinated groups. A significant difference was observed in the expression of IL-2, IFN-γ, TNF-α, and CD4+/CD8+ T cells secreting IFN-γ in the F1+LcrV+HSP70(II) vaccinated group in comparison to the F1+LcrV vaccinated group. Three combinations that included LcrV+HSP70(II), F1+LcrV or F1+LcrV+HSP70(II) provided 100% protection, whereas LcrV alone provided only 75% protection. These findings suggest that HSP70(II) of M. tuberculosis can be a potent immunomodulator for F1 and LcrV containing vaccine candidates against plague.

LcrV delivered via type III secretion system of live attenuated Yersinia pseudotuberculosis enhances immunogenicity against pneumonic plague

Here, we constructed a Yersinia pseudotuberculosis mutant strain with arabinose-dependent regulated and delayed shutoff of crp expression (araC P(BAD) crp) and replacement of the msbB gene with the Escherichia coli msbB gene to attenuate it. Then, we inserted the asd mutation into this construction to form χ10057 [Δasd-206 ΔmsbB868::P(msbB) msbB(EC) ΔP(crp21)::TT araC P(BAD) crp] for use with a balanced-lethal Asd-positive (Asd(+)) plasmid to facilitate antigen synthesis. A hybrid protein composed of YopE (amino acids [aa]1 to 138) fused with full-length LcrV (YopE(Nt138)-LcrV) was synthesized in χ10057 harboring an Asd(+) plasmid (pYA5199, yopE(Nt138)-lcrV) and could be secreted through a type III secretion system (T3SS) in vitro and in vivo. Animal studies indicated that mice orally immunized with χ10057(pYA5199) developed titers of IgG response to whole-cell lysates of Y. pestis (YpL) and subunit LcrV similar to those seen with χ10057(pYA3332) (χ10057 plus an empty plasmid). However, only immunization of mice with χ10057(pYA5199) resulted in a significant secretory IgA response to LcrV. χ10057(pYA5199) induced a higher level of protection (80% survival) against intranasal (i.n.) challenge with ~240 median lethal doses (LD50) (2.4 × 10(4) CFU) of Y. pestis KIM6+(pCD1Ap) than χ10057(pYA3332) (40% survival). Splenocytes from mice vaccinated with χ10057(pYA5199) produced significant levels of gamma interferon (IFN-γ), tumor necrosis factor alpha (TNF-α), and interleukin-17 (IL-17) after restimulation with LcrV and YpL antigens. Our results suggest that it is possible to use an attenuated Y. pseudotuberculosis strain delivering the LcrV antigen via the T3SS as a potential vaccine candidate against pneumonic plague.

Improving the Th1 cellular efficacy of the lead Yersinia pestis rF1-V subunit vaccine using SA-4-1BBL as a novel adjuvant

The lead candidate plague subunit vaccine is the recombinant fusion protein rF1-V adjuvanted with alum. While alum generates Th2 regulated robust humoral responses, immune protection against Yersinia pestis has been shown to also involve Th1 driven cellular responses. Therefore, the rF1-V-based subunit vaccine may benefit from an adjuvant system that generates a mixed Th1 and humoral immune response. We herein assessed the efficacy of a novel SA-4-1BBL costimulatory molecule as a Th1 adjuvant to improve cellular responses generated by the rF1-V vaccine. SA-4-1BBL as a single adjuvant had better efficacy than alum in generating CD4(+) and CD8(+) T cells producing TNFα and IFNγ, signature cytokines for Th1 responses. The combination of SA-4-1BBL with alum further increased this Th1 response as compared with the individual adjuvants. Analysis of the humoral response revealed that SA-4-1BBL as a single adjuvant did not generate a significant Ab response against rF1-V, and SA-4-1BBL in combination with alum did not improve Ab titers. However, the combined adjuvants significantly increased the ratio of Th1 regulated IgG2c in C57BL/6 mice to the Th2 regulated IgG1. Finally, a single vaccination with rF1-V adjuvanted with SA-4-1BBL+alum had better protective efficacy than vaccines containing individual adjuvants. Taken together, these results demonstrate that SA-4-1BBL improves the protective efficacy of the alum adjuvanted lead rF1-V subunit vaccine by generating a more balanced Th1 cellular and humoral immune response. As such, this adjuvant platform may prove efficacious not only for the rF1-V vaccine but also against other infections that require both cellular and humoral immune responses for protection.

A systems approach to designing next generation vaccines: combining α-galactose modified antigens with nanoparticle platforms

Innovative vaccine platforms are needed to develop effective countermeasures against emerging and re-emerging diseases. These platforms should direct antigen internalization by antigen presenting cells and promote immunogenic responses. This work describes an innovative systems approach combining two novel platforms, αGalactose (αGal)-modification of antigens and amphiphilic polyanhydride nanoparticles as vaccine delivery vehicles, to rationally design vaccine formulations. Regimens comprising soluble αGal-modified antigen and nanoparticle-encapsulated unmodified antigen induced a high titer, high avidity antibody response with broader epitope recognition of antigenic peptides than other regimen. Proliferation of antigen-specific CD4⁺ T cells was also enhanced compared to a traditional adjuvant. Combining the technology platforms and augmenting immune response studies with peptide arrays and informatics analysis provides a new paradigm for rational, systems-based design of next generation vaccine platforms against emerging and re-emerging pathogens.

Preclinical Safety Assessment of a Recombinant Plague Vaccine (rF1V)

A recombinant vaccine (rF1V) is being developed to protect adults 18 to 55 years of age from fatal pneumonic plague caused by aerosolized Yersinia pestis. A comprehensive series of studies was conducted to evaluate the general toxicity and local reactogenicity of the rF1V vaccine prior to first use in humans. Toxicity was evaluated in CD-1 mice vaccinated with control material and three dosage concentrations of rF1V with or without Alhydrogel® by intramuscular (IM) injection on Study Days 1, 29, 57 and 71 in a volume of 0.1 mL. Total immunizing protein given in each dose was 0, 20 or 60 μg/animal. Local reactogenicity was evaluated in mice at the dosages given and in New Zealand white (NZW) rabbits using the same injection volume and formulations (40, 80, 160 and 320 μg/mL total antigen and 0.3% (w/v) Alhydrogel®) intended for human use (0.5 mL). The rF1V vaccine produced no apparent systemic toxicity and only transient edema and erythema at the injection site. Together these results indicated a favorable safety profile for rF1V and supported its use in a Phase 1 clinical trial.

Mutated and bacteriophage T4 nanoparticle arrayed F1-V immunogens from Yersinia pestis as next generation plague vaccines

Pneumonic plague is a highly virulent infectious disease with 100% mortality rate, and its causative organism Yersinia pestis poses a serious threat for deliberate use as a bioterror agent. Currently, there is no FDA approved vaccine against plague. The polymeric bacterial capsular protein F1, a key component of the currently tested bivalent subunit vaccine consisting, in addition, of low calcium response V antigen, has high propensity to aggregate, thus affecting its purification and vaccine efficacy. We used two basic approaches, structure-based immunogen design and phage T4 nanoparticle delivery, to construct new plague vaccines that provided complete protection against pneumonic plague. The NH₂-terminal β-strand of F1 was transplanted to the COOH-terminus and the sequence flanking the β-strand was duplicated to eliminate polymerization but to retain the T cell epitopes. The mutated F1 was fused to the V antigen, a key virulence factor that forms the tip of the type three secretion system (T3SS). The F1mut-V protein showed a dramatic switch in solubility, producing a completely soluble monomer. The F1mut-V was then arrayed on phage T4 nanoparticle via the small outer capsid protein, Soc. The F1mut-V monomer was robustly immunogenic and the T4-decorated F1mut-V without any adjuvant induced balanced T_H1 and T_H2 responses in mice. Inclusion of an oligomerization-deficient YscF, another component of the T3SS, showed a slight enhancement in the potency of F1-V vaccine, while deletion of the putative immunomodulatory sequence of the V antigen did not improve the vaccine efficacy. Both the soluble (purified F1mut-V mixed with alhydrogel) and T4 decorated F1mut-V (no adjuvant) provided 100% protection to mice and rats against pneumonic plague evoked by high doses of Y. pestis CO92. These novel platforms might lead to efficacious and easily manufacturable next generation plague vaccines.

Plague caused by Yersinia pestis is a deadly disease that wiped out one-third of Europe's population in the 14th century. The organism is listed by the CDC as Tier-1 biothreat agent, and currently, there is no FDA-approved vaccine against this pathogen. Stockpiling of an efficacious plague vaccine that could protect people against a potential bioterror attack has been a national priority. The current vaccines based on the capsular antigen (F1) and the low calcium response V antigen, are promising against both bubonic and pneumonic plague. However, the polymeric nature of F1 with its propensity to aggregate affects vaccine efficacy and generates varied immune responses in humans. We have addressed a series of concerns and generated mutants of F1 and V, which are completely soluble and produced in high yields. We then engineered the vaccine into a novel delivery platform using the bacteriophage T4 nanoparticle. The nanoparticle vaccines induced robust immunogenicity and provided 100% protection to mice and rats against pneumonic plague. These highly efficacious new generation plague vaccines are easily manufactured, and the potent T4 platform which can simultaneously incorporate antigens from other biothreat or emerging infectious agents provides a convenient way for mass vaccination of humans against multiple pathogens.

Multiple antigen peptide containing B and T cell epitopes of F1 antigen of Yersinia pestis showed enhanced Th1 immune response in murine model

Yersinia pestis is a facultative bacterium that can survive and proliferate inside host macrophages and cause bubonic, pneumonic and systemic infection. Apart from humoral response, cell-mediated protection plays a major role in combating the disease. Fraction 1 capsular antigen (F1-Ag) of Y. pestis has long been exploited as a vaccine candidate. In this study, F1-multiple antigenic peptide (F1-MAP or MAP)-specific cell-mediated and cytokine responses were studied in murine model. MAP consisting of three B and one T cell epitopes of F1-antigen with one palmitoyl residue was synthesized using Fmoc chemistry. Mice were immunized with different formulations of MAP in poly DL-lactide-co-glycolide (PLGA) microspheres. F1-MAP with CpG oligodeoxynucleotide (CpG-ODN) as an adjuvant showed enhanced in vitro T cell proliferation and Th1 (IL-2, IFN-γ and TNF-α) and Th17 (IL-17A) cytokine secretion. Similar formulation also showed significantly higher numbers of cytokine (IL-2, IFN-γ)-secreting cells. Moreover, F1-MAP with CpG formulation showed significantly high (P < 0.001) percentage of CD4(+) IFN-γ(+) cells as compared to CD8(+) IFN-γ(+) cells, and also more (CD4- IFN-γ)(+) cells secrete perforin and granzyme as compared to (CD8- IFN-γ)(+) showing Th1 response. Thus, the study highlights the importance of Th1 cytokine and existence of CD4(+) and CD8(+) immune response. This study proposes a new perspective for the development of vaccination strategies for Y. pestis that trigger T cell immune response.

Evaluation of protective potential of Yersinia pestis outer membrane protein antigens as possible candidates for a new-generation recombinant plague vaccine

Plague caused by Yersinia pestis manifests itself in bubonic, septicemic, and pneumonic forms. Although the U.S. Food and Drug Administration recently approved levofloxacin, there is no approved human vaccine against plague. The capsular antigen F1 and the low-calcium-response V antigen (LcrV) of Y. pestis represent excellent vaccine candidates; however, the inability of the immune responses to F1 and LcrV to provide protection against Y. pestis F1(-) strains or those which harbor variants of LcrV is a significant concern. Here, we show that the passive transfer of hyperimmune sera from rats infected with the plague bacterium and rescued by levofloxacin protected naive animals against pneumonic plague. Furthermore, 10 to 12 protein bands from wild-type (WT) Y. pestis CO92 reacted with the aforementioned hyperimmune sera upon Western blot analysis. Based on mass spectrometric analysis, four of these proteins were identified as attachment invasion locus (Ail/OmpX), plasminogen-activating protease (Pla), outer membrane protein A (OmpA), and F1. The genes encoding these proteins were cloned, and the recombinant proteins purified from Escherichia coli for immunization purposes before challenging mice and rats with either the F1(-) mutant or WT CO92 in bubonic and pneumonic plague models. Although antibodies to Ail and OmpA protected mice against bubonic plague when challenged with the F1(-) CO92 strain, Pla antibodies were protective against pneumonic plague. In the rat model, antibodies to Ail provided protection only against pneumonic plague after WT CO92 challenge. Together, the addition of Y. pestis outer membrane proteins to a new-generation recombinant vaccine could provide protection against a wide variety of Y. pestis strains.

Multiple antigen peptide consisting of B- and T-cell epitopes of F1 antigen of Y. pestis showed enhanced humoral and mucosal immune response in different strains of mice

Yersinia pestis is a causative agent of plague. F1 and V antigen based vaccines have shown remarkable protection in experimental animals. In order to develop epitope based immunogen, three B and one T-cell epitopes of F1 antigen with palmitate residue at amino terminal were assembled on a lysine backbone as multiple antigen peptide (MAP or F1-MAP). MAP was characterized by SDS-PAGE, immunoblot and immunoreactivity with anti F1 sera. MAP was entrapped in PLGA (polylactide-co-glycolide) microparticles and humoral, mucosal immune responses were studied after intranasal immunization with/without CpG ODN 1826 (CpG)/murabutide in different strains of mice. Serum and mucosal washes were measured for MAP specific IgG, IgA, sIgA and IgG subclasses in three strains of mice. F1-MAP showed high serum antibody and mucosal IgG and IgA peak antibody titers. MAP with CpG showed significantly high (p<0.001) peak antibody titer ranging from 102,400 to 204,800 for IgG and 6400 to 12,800 for IgA. High mucosal sIgA and its secretary component detection confirmed generation of mucosal response in intestinal and lung washes. MAP antisera also showed significant immunoreactivity with individual peptides. Moreover, antibody specific activity (IgG, IgA and sIgA) positively correlates with peak antibody titers. Predominantly IgG2a/IgG2b subclass was observed with CpG formulation but in other formulation a mixed IgG1 and IgG2a response was observed. The present study highlights the importance of multiple antigen peptide approach of F1-antigen with CpG as an alternative approach for subunit vaccine.

Establishment of a Swiss Webster mouse model of pneumonic plague to meet essential data elements under the animal rule

A recombinant vaccine (rF1V) is being developed for protection against pneumonic plague. This study was performed to address essential data elements to establish a well-characterized Swiss Webster mouse model for licensing the rF1V vaccine using the FDA's Animal Rule. These elements include the documentation of challenge material characteristics, aerosol exposure parameters, details of the onset and severity of clinical signs, pathophysiological response to disease, and relevance to human disease. Prior to animal exposures, an evaluation of the aerosol system was performed to determine and understand the variability of the aerosol exposure system. Standardized procedures for the preparation of Yersinia pestis challenge material also were developed. The 50% lethal dose (LD(50)) was estimated to be 1,966 CFU using Probit analysis. Following the LD(50) determination, pathology was evaluated by exposing mice to a target LD(99) (42,890 CFU). Mice were euthanized at 12, 24, 36, 48, 60, and 72 h postexposure. At each time point, samples were collected for clinical pathology, detection of bacteria in blood and tissues, and pathology evaluations. A general increase in incidence and severity of microscopic findings was observed in the lung, lymph nodes, spleen, and liver from 36 to 72 h postchallenge. Similarly, the incidence and severity of pneumonia increased throughout the study; however, some mice died in the absence of pneumonia, suggesting that disease progression does not require the development of pneumonia. Disease pathology in the Swiss Webster mouse is similar to that observed in humans, demonstrating the utility of this pneumonic plague model that can be used by researchers investigating plague countermeasures.

Advanced Development of the rF1V and rBV A/B Vaccines: Progress and Challenges

The development of vaccines for microorganisms and bacterial toxins with the potential to be used as biowarfare and bioterrorism agents is an important component of the US biodefense program. DVC is developing two vaccines, one against inhalational exposure to botulinum neurotoxins A1 and B1 and a second for Yersinia pestis, with the ultimate goal of licensure by the FDA under the Animal Rule. Progress has been made in all technical areas, including manufacturing, nonclinical, and clinical development and testing of the vaccines, and in assay development. The current status of development of these vaccines, and remaining challenges are described in this chapter.

Design of a protective single-dose intranasal nanoparticle-based vaccine platform for respiratory infectious diseases

Despite the successes provided by vaccination, many challenges still exist with respect to controlling new and re-emerging infectious diseases. Innovative vaccine platforms composed of adaptable adjuvants able to appropriately modulate immune responses, induce long-lived immunity in a single dose, and deliver immunogens in a safe and stable manner via multiple routes of administration are needed. This work describes the development of a novel biodegradable polyanhydride nanoparticle-based vaccine platform administered as a single intranasal dose that induced long-lived protective immunity against respiratory disease caused by Yesinia pestis, the causative agent of pneumonic plague. Relative to the responses induced by the recombinant protein F1-V alone and MPLA-adjuvanted F1-V, the nanoparticle-based vaccination regimen induced an immune response that was characterized by high titer and high avidity IgG1 anti-F1-V antibody that persisted for at least 23 weeks post-vaccination. After challenge, no Y. pestis were recovered from the lungs, livers, or spleens of mice vaccinated with the nanoparticle-based formulation and histopathological appearance of lung, liver, and splenic tissues from these mice post-vaccination was remarkably similar to uninfected control mice.

Purification and characterization of a recombinant Yersinia pestis V-F1 "Reversed" fusion protein for use as a new subunit vaccine against plague

We previously developed a unique recombinant protein vaccine against plague composed of a fusion between the Fraction 1 capsular antigen (F1) and the V antigen. To determine if overall expression, solubility, and recovery of the F1-V fusion protein could be enhanced, we modified the original fusion. Standard recombinant DNA techniques were used to reverse the gene order such that the V antigen coding sequence was fused at its C-terminus to the N-terminus of F1. The F1 secretion signal sequence (F1S) was subsequently fused to the N-terminus of V. This new fusion protein, designated F1S-V-F1, was then co-expressed with the Y. pestis Caf1M periplasmic chaperone protein in BL21-Star Escherichia coli. Recombinant strains expressing F1-V, F1S-F1-V, or F1S-V-F1 were compared by cell fractionation, SDS-PAGE, Western blotting, and suspension immunolabelling. F1S-V-F1 exhibited enhanced solubility and secretion when co-expressed with Caf1M resulting in a recombinant protein that is processed in a similar manner to the native F1 protein. Purification of F1S-V-F1 was accomplished by anion-exchange and hydrophobic interaction chromatography. The purification method produced greater than 1mg of purified soluble protein per liter of induced culture. F1S-V-F1 polymerization characteristics were comparable to the native F1. The purified F1S-V-F1 protein appeared equivalent to F1-V in its ability to be recognized by neutralizing antibodies.

Cynomolgus macaque model for pneumonic plague

A recombinant vaccine (rF1V) is currently being developed for protection against pneumonic plague. An essential component in evaluating efficacy of the rF1V vaccine is the development of a well-understood animal model that shows similarity to human disease. The objective of this study was to determine the inhaled median lethal dose (LD₅₀), evaluate the pathophysiology of disease and identify appropriate study endpoints in a cynomolgus macaque (CM) model of pneumonic plague. Eighteen CMs were challenged by head-only aerosol exposure with seven dosages of Yersinia pestis CO92. An LD₅₀ of 24 colony forming units was estimated using Probit analysis. Disease pathology was evaluated by blood culture, clinical pathology, histopathology and telemetry. CMs that died became febrile following challenge and died 34-92 h after onset of fever. Bacteremia, increased respiration and heart rate, decreased blood pressure and loss of diurnal rhythm were also observed in conjunction with onset of fever. Histopathological examinations revealed significant findings in the lungs (intra-alveolar neutrophils and fibrinous pleuritis) consistent with pneumonic plague. These data indicate that the disease pathology observed in CMs following aerosol exposure to Y. pestis CO92 is similar to that of pneumonic plague in humans. Thus, the CM is an appropriate model to evaluate efficacy of a recombinant F1V vaccine candidate.

Protective immunity against a lethal respiratory Yersinia pestis challenge induced by V antigen or the F1 capsular antigen incorporated into adenovirus capsid

The aerosol form of the bacterium Yersinia pestis causes pneumonic plague, a rapidly fatal disease that is a biothreat if deliberately released. At present, no plague vaccines are available for use in the United States, but subunit vaccines based on the Y. pestis V antigen and F1 capsular protein show promise when administered with adjuvants. In the context that adenovirus (Ad) gene transfer vectors have a strong adjuvant potential related to the ability to directly infect dendritic cells, we hypothesized that modification of the Ad5 capsid to display either the Y. pestis V antigen or the F1 capsular antigen on the virion surface would elicit high V antigen- or F1-specific antibody titers, permit boosting with the same Ad serotype, and provide better protection against a lethal Y. pestis challenge than immunization with equivalent amounts of V or F1 recombinant protein plus conventional adjuvant. We constructed AdYFP-pIX/V and AdLacZ-pIX/F1, E1(-), E3(-) serotype 5 Ad gene transfer vectors containing a fusion of the sequence for either the Y. pestis V antigen or the F1 capsular antigen to the carboxy-terminal sequence of pIX, a capsid protein that can accommodate the entire V antigen (37 kDa) or F1 protein (15 kDa) without disturbing Ad function. Immunization with AdYFP-pIX/V followed by a single repeat administration of the same vector at the same dose resulted in significantly better protection of immunized animals compared with immunization with a molar equivalent amount of purified recombinant V antigen plus Alhydrogel adjuvant. Similarly, immunization with AdLacZ-pIX/F1 in a prime-boost regimen resulted in significantly enhanced protection of immunized animals compared with immunization with a molar-equivalent amount of purified recombinant F1 protein plus adjuvant. These observations demonstrate that Ad vaccine vectors containing pathogen-specific antigens fused to the pIX capsid protein have strong adjuvant properties and stimulate more robust protective immune responses than equivalent recombinant protein-based subunit vaccines administered with conventional adjuvant, suggesting that F1-and/or V-modified capsid Ad-based recombinant vaccines should be considered for development as anti-plague vaccines.

Human anti-plague monoclonal antibodies protect mice from Yersinia pestis in a bubonic plague model

Yersinia pestis is the etiologic agent of plague that has killed more than 200 million people throughout the recorded history of mankind. Antibiotics may provide little immediate relief to patients who have a high bacteremia or to patients infected with an antibiotic resistant strain of plague. Two virulent factors of Y. pestis are the capsid F1 protein and the low-calcium response (Lcr) V-protein or V-antigen that have been proven to be the targets for both active and passive immunization. There are mouse monoclonal antibodies (mAbs) against the F1- and V-antigens that can passively protect mice in a murine model of plague; however, there are no anti-Yersinia pestis monoclonal antibodies available for prophylactic or therapeutic treatment in humans. We identified one anti-F1-specific human mAb (m252) and two anti-V-specific human mAb (m253, m254) by panning a naïve phage-displayed Fab library against the F1- and V-antigens. The Fabs were converted to IgG1s and their binding and protective activities were evaluated. M252 bound weakly to peptides located at the F1 N-terminus where a protective mouse anti-F1 mAb also binds. M253 bound strongly to a V-antigen peptide indicating a linear epitope; m254 did not bind to any peptide from a panel of 53 peptides suggesting that its epitope may be conformational. M252 showed better protection than m253 and m254 against a Y, pestis challenge in a plague mouse model. A synergistic effect was observed when the three antibodies were combined. Incomplete to complete protection was achieved when m252 was given at different times post-challenge. These antibodies can be further studied to determine their potential as therapeutics or prophylactics in Y. pestis infection in humans.

Encapsulation into amphiphilic polyanhydride microparticles stabilizes Yersinia pestis antigens

The design of biodegradable polymeric delivery systems based on polyanhydrides that would provide for improved structural integrity of Yersinia pestis antigens was the main goal of this study. Accordingly, the full-length Y. pestis fusion protein (F1-V) or a recombinant Y. pestis fusion protein (F1(B2T1)-V10) was encapsulated and released from microparticles based on 1,6-bis(p-carboxyphenoxy)hexane (CPH) and sebacic acid (SA) copolymers and 1,8-bis(p-carboxyphenoxy)-3,6-dioxaoctane (CPTEG) and CPH copolymers fabricated by cryogenic atomization. An enzyme-linked immunosorbent assay was used to measure changes in the antigenicity of the released proteins. The recombinant F1(B2T1)-V10 was unstable upon release from the hydrophobic CPH:SA microparticles, but maintained its structure and antigenicity in the amphiphilic CPTEG:CPH system. The full-length F1-V was stably released by both CPH:SA and CPTEG:CPH microparticles. In order to determine the effect of the anhydride monomers on the protein structure, changes in the primary, secondary, and tertiary structure, as well as the antigenicity of both Y. pestis antigens, were measured after incubation in the presence of saturated solutions of SA, CPH, and CPTEG anhydride monomers. The results indicated that the amphiphilic environment provided by the CPTEG monomer was important to preserve the structure and antigenicity of both proteins. These studies offer an approach by which a thorough understanding of the mechanisms governing antigenic instability can be elucidated in order to optimize the in vivo performance of biodegradable delivery devices as protein carriers and/or vaccine adjuvants.

Prevention of bubonic and pneumonic plague using plant-derived vaccines

Yersinia pestis, the causative agent of bubonic and pneumonic plague, is an extremely virulent bacterium but there are currently no approved vaccines for protection against this organism. Plants represent an economical and safer alternative to fermentation-based expression systems for the production of therapeutic proteins. The recombinant plague vaccine candidates produced in plants are based on the two most immunogenic antigens of Y. pestis: the fraction-1 capsular antigen (F1) and the low calcium response virulent antigen (V) either in combination or as a fusion protein (F1-V). These antigens have been expressed in plants using all three known possible strategies: nuclear transformation, chloroplast transformation and plant-virus-based expression vectors. These plant-derived plague vaccine candidates were successfully tested in animal models using parenteral, oral, or prime/boost immunization regimens. This review focuses on the recent research accomplishments towards the development of safe and effective pneumonic and bubonic plague vaccines using plants as bioreactors.

Identification of in vivo-induced conserved sequences from Yersinia pestis during experimental plague infection in the rabbit

In an effort to identify the novel virulence determinants of Yersinia pestis, we applied the gene "discovery" methodology, in vivo-induced (IVI) antigen technology, to detect genes upregulated during infection in a laboratory rabbit model for bubonic plague. After screening over 70,000 Escherichia coli clones of Y. pestis DNA expression libraries, products from 25 loci were identified as being seroreactive to reductively adsorbed, pooled immune serum. Upon sequence analysis of the predicted IVI gene products, more frequently encountered conserved protein functional categories have emerged, to include type-V autotransporters and components of more complex secretion systems including types III and VI. The recombinant products from eight selected clones were subsequently immunoblotted against pooled immune serum from two naturally infected host species: the prairie dog, and a species refractory to lethal disease, the coyote. Immune prairie dog serum recognized 2-3 of the rabbit-reactive antigens, suggesting at least some overlap in the pathogen's in vivo survival mechanisms between these two hosts. Although the coyote serum failed to recognize most of the IVI antigens, LepA was universally reactive with all three host sera. Collectively, the profiles/patterns of IVI conserved sequences (IVICS) may represent immune "signatures" among different host species, possessing the potential for use as a diagnostic tool for plague. Further, the antigenic nature of IVICS makes them ideal for further evaluation as novel subunit vaccine candidates. The gathering of additional data and analysis of the intact IVI genes and the expressed IVICS products should provide insight into the unique biologic processes of Y. pestis during infection and reveal the genetic patterns of the pathogen's survival strategy in different hosts.

Long-term observation of subunit vaccine F1-rV270 against Yersinia pestis in mice

Long-term protection and antibody response for the subunit vaccine F1-rV270 were determined by using the mouse model. Antibodies to F1 and rV270 were still detectable over a period of 518 days. The complete protection against lethal challenge of Yersinia pestis could be achieved up to day 518 after primary immunization.

Adenovirus-mediated delivery of an anti-V antigen monoclonal antibody protects mice against a lethal Yersinia pestis challenge

Pneumonic plague, caused by inhalation of Yersinia pestis, represents a major bioterrorism threat for which no vaccine is available. Based on the knowledge that genetic delivery of monoclonal antibodies (MAbs) with adenovirus (Ad) gene transfer vectors results in rapid, high-level antibody expression, we evaluated the hypothesis that Ad-mediated delivery of a neutralizing antibody directed against the Y. pestis V antigen would protect mice against a Y. pestis challenge. MAbs specific for the Y. pestis V antigen were generated, and the most effective in protecting mice against a lethal intranasal Y. pestis challenge was chosen for further study. The coding sequences for the heavy and light chains were isolated from the corresponding hybridoma and inserted into a replication-defective serotype 5 human Ad gene transfer vector (AdalphaV). Western analysis of AdalphaV-infected cell supernatants demonstrated completely assembled antibodies reactive with V antigen. Following AdalphaV administration to mice, high levels of anti-V antigen antibody titers were detectable as early as 1 day postadministration, peaked by day 3, and remained detectable through a 12-week time course. When animals that received AdalphaV were challenged with Y. pestis at day 4 post-AdalphaV administration, 80% of the animals were protected, while 0% of control animals survived (P < 0.01). Ad-mediated delivery of a V antigen-neutralizing antibody is an effective therapy against plague in experimental animals and could be developed as a rapidly acting antiplague therapeutic.

Defense Against Biological Weapons (Biodefense)

Biological warfare (germ warfare) is defined as the use of any disease-causing organism or toxin(s) found in nature as weapons of war with the intent to destroy an adversary. Though rare, the use of biological weapons has occurred throughout the centuries.

Immune defense against pneumonic plague

SUMMARY

Yersinia pestis is one of the world's most virulent human pathogens. Inhalation of this Gram-negative bacterium causes pneumonic plague, a rapidly progressing and usually fatal disease. Extensively antibiotic-resistant strains of Y. pestis exist and have significant potential for exploitation as agents of terrorism and biowarfare. Subunit vaccines comprised of the Y. pestis F1 and LcrV proteins are well-tolerated and immunogenic in humans but cannot be tested for efficacy, because pneumonic plague outbreaks are uncommon and intentional infection of humans is unethical. In animal models, F1/LcrV-based vaccines protect mice and cynomolgus macaques but have failed, thus far, to adequately protect African green monkeys. We lack an explanation for this inconsistent efficacy. We also lack reliable correlate assays for protective immunity. These deficiencies are hampering efforts to improve vaccine efficacy. Here, I review the immunology of pneumonic plague, focusing on evidence that humoral and cellular defense mechanisms collaborate to defend against pulmonary Y. pestis infection.

Lipid A mimetics are potent adjuvants for an intranasal pneumonic plague vaccine

An effective intranasal (i.n.) vaccine against pneumonic plague was developed. The formulation employed two synthetic lipid A mimetics as adjuvant combined with Yersinia pestis-derived V- and F1-protective antigens. The two nontoxic lipid A mimetics, classed as amino-alkyl glucosaminide 4-phosphates (AGPs) are potent ligands for the Toll-like receptor (TLR) 4. Using a murine (BALB/c) pneumonic plague model, we showed a single i.n. application of the vaccine provided 63% protection within 21 days against a Y. pestis CO92 100 LD50 challenge. Protection reached 100% by 150 days. Using a homologous i.n. 1 degrees /2 degrees dose regimen, with the boost administered at varying times, 63% protection was achieved within 7 days and 100% protection was achieved by 21 days after the first immunization. Little or no protection was observed in animals that received antigens alone, and no protection was observed when the vaccine was administered to BALB/c TLR4 mutant mice. Vaccine-induced serum IgG titers to F1 and V-antigen were reflected in high titers for IgG1 and IgG2a, the latter reflecting a bias for a cell-mediated (TH1) immune response. This intranasal vaccine showed 90% protection in Sprague-Dawley rats challenged with 1000 LD50. We conclude that lipid A mimetics are highly effective adjuvants for an i.n. plague vaccine.

Effective plague vaccination via oral delivery of plant cells expressing F1-V antigens in chloroplasts

The chloroplast bioreactor is an alternative to fermentation-based systems for production of vaccine antigens and biopharmaceuticals. We report here expression of the plague F1-V fusion antigen in chloroplasts. Site-specific transgene integration and homoplasmy were confirmed by PCR and Southern blotting. Mature leaves showed the highest level of transgene expression on the third day of continuous illumination, with a maximum level of 14.8% of the total soluble protein. Swiss Webster mice were primed with adjuvant-containing subcutaneous (s.c.) doses of F1-V and then boosted with either adjuvanted s.c. doses (s.c. F1-V mice) or unadjuvanted oral doses (oral F1-V mice). Oral F1-V mice had higher prechallenge serum immunoglobulin G1 (IgG1) titers than s.c. F1-V mice. The corresponding serum levels of antigen-specific IgG2a and IgA were 2 and 3 orders of magnitude lower, respectively. After vaccination, mice were exposed to an inhaled dose of 1.02 x 10(6) CFU of aerosolized Yersinia pestis CO92 (50% lethal dose, 6.8 x 10(4) CFU). All control animals died within 3 days. F1-V given s.c. (with adjuvant) protected 33% of the immunized mice, while 88% of the oral F1-V mice survived aerosolized Y. pestis challenge. A comparison of splenic Y. pestis CFU counts showed that there was a 7- to 10-log reduction in the mean bacterial burden in survivors. Taken together, these data indicate that oral booster doses effectively elicit protective immune responses in vivo. In addition, this is the first report of a plant-derived oral vaccine that protected animals from live Y. pestis challenge, bringing the likelihood of lower-cost vaccines closer to reality.

Oral vaccination against bubonic plague using a live avirulent Yersinia pseudotuberculosis strain

We evaluated the possibility of using Yersinia pseudotuberculosis as a live vaccine against plague because it shares high genetic identity with Y. pestis while being much less virulent, genetically much more stable, and deliverable orally. A total of 41 Y. pseudotuberculosis strains were screened by PCR for the absence of the high pathogenicity island, the superantigens YPM, and the type IV pilus and the presence of the pYV virulence plasmid. One strain (IP32680) fulfilled these criteria. This strain was avirulent in mice upon intragastric or subcutaneous inoculation and persisted for 2 months in the mouse intestine without clinical signs of disease. IP32680 reached the mesenteric lymph nodes, spleen, and liver without causing major histological lesions and was cleared after 13 days. The antibodies produced in vaccinated animals recognized both Y. pseudotuberculosis and Y. pestis antigens efficiently. After a subcutaneous challenge with Y. pestis CO92, bacteria were found in low amounts in the organs and rarely in the blood of vaccinated animals. One oral IP32680 inoculation protected 75% of the mice, and two inoculations induced much higher antibody titers and protected 88% of the mice. Our results thus validate the concept that an attenuated Y. pseudotuberculosis strain can be an efficient, inexpensive, safe, and easy-to-produce live vaccine for oral immunization against bubonic plague.

Current challenges in the development of vaccines for pneumonic plague

Inhalation of Yersinia pestis bacilli causes pneumonic plague, a rapidly progressing and exceptionally virulent disease. Extensively antibiotic-resistant Y. pestis strains exist and we currently lack a safe and effective pneumonic plague vaccine. These facts raise concern that Y. pestis may be exploited as a bioweapon. Here, I review the history and status of plague vaccine research and advocate that pneumonic plague vaccines should strive to prime both humoral and cellular immunity.