Identification of mutation sites on Delta12 desaturase genes from Mortierella alpina 1S-4 mutants

The mutation sites on the Delta12 desaturase gene in Mortierella alpina Delta12 desaturase-defective mutants SR88, TM912, and Mut48 accumulating Mead acid were identified. Each mutation resulted in an amino acid replacement (H116Y and P166L) in the Delta12 desaturase gene from SR88 and Mut48, respectively.

Identification of mutation sites on omega3 desaturase genes from Mortierella alpina 1S-4 mutants

The mutation sites on omega3 desaturase genes in two omega3 desaturase-defective mutants derived from arachidonic acid-producing Mortierella alpina 1S-4 were identified. The mutations each resulted in an amino acid replacement (W232Stop or W386Stop) which caused a lack of omega3 desaturase activity in these mutants.

Various oils and detergents enhance the microbial production of farnesol and related prenyl alcohols

The object of this research was improvement of prenyl alcohol production with squalene synthase-deficient mutant Saccharomyces cerevisiae ATCC 64031. On screening of many kinds of additives, we found that oils and detergents significantly enhanced the extracellular production of prenyl alcohols. Soybean oil showed the most prominent effect among the additives tested. Its effect was accelerated by a high concentration of glucose in the medium. The combination of these cultivation conditions led to the production of more than 28 mg/l of farnesol in the soluble fraction of the broth. The addition of these compounds to the medium was an effective method for large-scale production of prenyl alcohols with microorganisms.

Accumulation of prenyl alcohols by terpenoid biosynthesis inhibitors in various microorganisms

Squalene synthase inhibitors significantly accelerate the production of farnesol by various microorganisms. However, farnesol production by Saccharomyces cerevisiae ATCC 64031, in which the squalene synthase gene is deleted, was not affected by the inhibitors, indicating that farnesol accumulation is enhanced in the absence of squalene synthase activity. The combination of diphenylamine as an inhibitor of carotenoid biosynthesis and a squalene synthase inhibitor increases geranylgeraniol production by a yeast, Rhodotorula rubra NBRC 0870. An ent-kauren synthase inhibitor also enhances the production of farnesol and geranylgeraniol by a filamentous fungus, Gibberella fujikuroi NBRC 30336. These results indicate that the inhibition of downstream enzymes from prenyl diphosphate synthase leads to the production of farnesol and geranylgeraniol.

Cytological and biochemical analysis of COF1, an Arabidopsis mutant of an ABC transporter gene

In transposon-tagged lines of Arabidopsis we found two new mutants, cof1-1 and cof1-2 (cuticular defect and organ fusion), that show the phenotype of wilting when grown in soil, organ fusion of rosette leaves and infertility. Toluidine blue testing and scanning electron microscopy observation revealed that these mutants had cuticular defects in the stems and adult leaves, but not in cotyledones. Transmission electron microscopy observation revealed thinner cuticle layers in the mutants, and cuticular materials interspersed between the two fused epidermal layers were observed in the mutant rosette leaves. These two mutants had a transposon insertion in the coding regions of WBC11, which was classified as a member of ABC transporter genes in Arabidopsis. WBC11 showed high sequence similarity to CER5 (also called WBC12), which was involved in cuticular lipid export. Gas chromatographic analysis revealed that C29 alkane extracted from the stem surface of cof1 mutants was reduced whereas C29 ketone was accumulated, which was different from the case of cer5 mutants. While cer5 mutants had fairly normal morphology, cof1 mutants had pleiotropic phenotypes so that COF1/WBC11 could have important roles different from those of CER5/WBC12. We also found that C29 alkane was accumulated in the intracellular extract of cof1 mutants, suggesting a function for WBC11 in the direct transport of lipid molecules. Pollen observation showed that mutant pollen grains were irregularly shaped. The function of COF1/WBC11 in lipid transport for the construction of cuticle layers and pollen coats for normal organ formation is discussed.

Identification of a sterol Delta7 reductase gene involved in desmosterol biosynthesis in Mortierella alpina 1S-4

Molecular cloning of the gene encoding sterol Delta7 reductase from the filamentous fungus Mortierella alpina 1S-4, which accumulates cholesta-5,24-dienol (desmosterol) as the main sterol, revealed that the open reading frame of this gene, designated MoDelta7SR, consists of 1,404 bp and codes for 468 amino acids with a molecular weight of 53,965. The predicted amino acid sequence of MoDelta7SR showed highest homology of 51% with that of sterol Delta7 reductase (EC 1.3.1.21) from Xenopus laevis (African clawed frog). Heterologous expression of the MoDelta7SR gene in yeast Saccharomyces cerevisiae revealed that MoDelta7SR converts ergosta-5,7-dienol to ergosta-5-enol (campesterol) by the activity of Delta7 reductase. In addition, with gene silencing of MoDelta7SR gene by RNA interference, the transformant accumulated cholesta-5,7,24-trienol up to 10% of the total sterols with a decrease in desmosterol. Cholesta-5,7,24-trienol is not detected in the control strain. This indicates that MoDelta7SR is involved in desmosterol biosynthesis in M. alpina 1S-4. This study is the first report on characterization of sterol Delta7 reductase from a microorganism.

Identification of a novel bifunctional Δ12/Δ15 fatty acid desaturase from a basidiomycete,Coprinus cinereusTD#822-2

A new gene encoding a delta12 fatty acid desaturase-related protein was cloned from a multicellular basidiomycete Coprinus cinereus TD#822-2. The 1326 bp full-length gene, designated as Cop-odeA, codes for a putative protein of 442 amino acids with a MW of 49224. The Cop-odeA yeast transformant accumulated four new fatty acids identified as 9,12-hexadecadienoic acid, 9,12,15-hexadecatrienoic acid, linoleic acid, and alpha-linolenic acid, which comprised 8.8%, 1.0%, 29.0%, and 0.6% of the total fatty acids, respectively. The Cop-odeA protein was confirmed to be a novel bifunctional fatty acid desaturase with both high delta12 desaturase activity and unusual delta15 desaturase activity.

Different specificity of two types of Pseudomonas lipases for C20 fatty acids with a Delta5 unsaturated double bond and their application for selective concentration of fatty acids

Two kinds of lipases, AK-lipase and HU-lipase, produced by two different Pseudomonas fluorescens strains, AK102 and HU380, respectively, were evaluated as to fatty acid hydrolysis specificity using six types of oil containing higher amounts of C20 fatty acids such as arachidonic acid (5,8,11,14-eicosatetraenoic acid, AA, or 20:4omega6), dihomo-gamma-linolenic acid (8,11,14-eicosatrienoic acid, DGLA, or 20:3omega6), 5,8,11,14,17-eicosapentaenoic acid (EPA or 20:5omega3), mead acid (5,8,11-eicosatrienoic acid, MA, or 20:3omega9), 8,11-eicosadienoic acid (20:2omega9) and 8,11,14,17-eicosatetraenoic acid (20:4omega3). Although HU-lipase did not show any specificity for C20 fatty acids with respect to the presence or absence of a Delta5 unsaturated bond, it exhibited comparatively low reactivity for 4,7,10,13,16,19-docosahexaenoic acid (DHA or 22:6omega3). In contrast, AK-lipase was less reactive for C20 fatty acids with a Delta5 unsaturated bond. However, the specificity of hydrolysis of AK-lipase gradually decreased as the reaction proceeded. Utilizing this fatty acid specificity, we concentrated either EPA or DHA from fish oils containing both EPA and DHA by means of lipase-catalyzed hydrolysis and urea adduction. Hydrolysis and urea adduction of refined cod oil including 12.2% EPA and 6.9% DHA with HU-lipase provided free fatty acids with 43.1% EPA and 7% DHA, respectively. The resulting yield of concentrated total fatty acids comprised 2.6% of the fatty acids from the cod oil. Thus, EPA was particularly concentrated in the fatty acids derived from refined cod oil on partial hydrolysis with HU-lipase followed by urea adduction. On the other hand, hydrolysis of cuttlefish oil with AK-lipase followed by urea adduction increase slightly the EPA composition from 14.2% to 16.8%, and markedly enhanced the composition of DHA from 16.3% to 44.6% in the hydrolyzed fatty acids. The yield of purified total fatty acids by urea concentrate was 9.4% of the fatty acids from the cuttlefish oil. Thus, DHA was particularly concentrated in the fatty acids derived from on partial hydrolysis with AK-lipase followed by urea adduction. We concluded that EPA and DHA concentrates can be easily and inexpensively obtained using HU-lipase and AK-lipase, respectively. Furthermore, it might be possible to separate and concentrate C20 polyunsaturated fatty acids (PUFAs) with or without a Delta5 double bond from PUFAs rich oils including both fatty acids.

Acidolysis and glyceride synthesis reactions using fatty acids with two Pseudomonas lipases having different substrate specificities

Enzymatic acidolysis and glyceride synthesis using polyunsaturated fatty acids (PUFAs) with lipases from Pseudomonas fluorescens HU380 (HU-lipase), P. fluorescens AK102 (AK-lipase), and Candida rugosa (CR-lipase) were studied. The acidolysis of triolein with eicosapentaenoic acid (EPA) or docosahexaenoic acid (DHA) in n-hexane was evaluated with lipases immobilized on Celite 545. HU-lipase showed the highest incorporation rate at a low temperature (10 degrees C) with either EPA or DHA as the acyl donor, and the rate decreased with increasing reaction temperature. At 45 degrees C, the rates for EPA and DHA were 7.1 and 0.5 relative to those at 10 degrees C, respectively. The EPA incorporation rate was even higher at a low temperature (10 degrees C), and the DHA incorporation rate increased with decreasing temperature. Although AK-lipase showed the reverse tendency for incorporation rate, the DHA incorporation rate increased with increasing reaction temperature with both PUFAs. HU-lipase reacted well with PUFAs such as DHA, EPA, arachidonic acid (AA), mead acid (MA), and dihomo-gamma-linolenic acid (DGLA) on acidolysis and glyceride synthesis. The reactivities of AK-lipase toward these PUFAs except for DGLA, i.e., MA, AA, EPA, and DHA, were low for both reactions. The unique substrate specificities of the lipases from the Pseudomonas strains will enable us to use these lipases for the modification of fats and oils containing PUFAs such as fish oil.

Identification and production of n−8 odd-numbered polyunsaturated fatty acids by a Δ12 desaturation-defective mutant of Mortierella alpina 1S-4

A mutant of Mortierella alpina, JT-180, which is defective in its delta12 desaturase activity but exhibits enhanced activities of delta5 and delta6 desaturases, produced a high proportion (up to 80%) of odd-chain FA when grown on 3% n-heptadecane. Following growth of the mutant on n-heptadecane, three unusual odd-chain fatty acyl residues were identified as 6,9-heptadecadienoic acid (17:2), 8,11 -nonadecadienoic acid (19:2), and 5,8,11-nonadecatrienoic acid (19:3) by means of GC-MS, MS-MS, and NMR analyses. The mycelial contents of these FA reached 20.3, 3.6, and 5.8 mg/g dry mycelia, respectively, when it was cultivated in medium comprising 4% (vol/vol) n-heptadecane and 1% (wt/vol) yeast extract, pH 6.0, at 28 degrees C for 7 d. The biosynthetic route (n-8 route) to 19:3 was presumed to mimic the n-9 route to Mead acid (20:3n-9) in mammals: 17:0 --> 9-17:1 --> 6,9-17:2 --> 8,11-19:2 --> 5,8,11-19:3.

Functional characterization of Δ9 and ω9 desaturase genes in Mortierella alpina 1S-4 and its derivative mutants

Cloning and characterization of the Delta9 desaturase (Delta9I) gene of a fungus, Mortierella alpina 1S-4, was previously reported. In this study, two genes encoding Delta9 desaturase homologs were isolated from this fungus. One is a Delta9 desaturase (Delta9II) that exhibits 86% amino acid sequence similarity to Delta9I. Functional analysis involving expression of the encoding gene in Aspergillus oryzae revealed that Delta9II exhibits Delta9 desaturase activity, 18:0 being converted to 18:1Delta9. However, unlike Delta9I, the Delta9II transformant accumulated a low amount of 16:1Delta9. The other homolog is a omega9 desaturase (omega9) that exhibits 56 and 58% amino acid sequence similarity to Delta9I and Delta9II, respectively. On functional analysis with the Aspergillus transformant, it was found that omega9 does not convert 18:0 to 18:1Delta9, but converts 24:0 and 26:0 to 24:1omega9 and 26:1omega9, respectively. On the other hand, Delta9 desaturation-defective mutants characterized by accumulation of 18:0 were derived from M. alpina 1S-4 with a chemical mutagen, and the mutated sites of the Delta9 desaturase genes were identified. The mutation on the Delta9I gene was assumed to cause an amino acid replacement (W136Stop, G265D, and W360Stop) in the mutants (HR222, T4, and ST56), respectively. In these mutants, there was no mutated site on the Delta9II and omega9 genes. Real-time quantitative PCR (RTQ-PCR) analysis revealed that (1) the transcriptional level of the Delta9I gene in HR222 and T4 was much higher than that in the wild strain until the fifth day of the cultivation periods, (2) the Delta9II gene of the mutants was transcribed until the fourth day at the same level as the Delta9I gene of the wild strain, whereas the Delta9II gene of the wild strain was transcribed at a lower level, and (3) the transcriptional level of the omega9 gene in both the mutants and the wild strain was low, i.e., as low as that of the Delta9II gene of the wild strain. In these Delta9 desaturation-defective mutants, Delta9II is likely to play an important role in Delta9 desaturation.

Transformation of oil-producing fungus, Mortierella alpina 1S-4, using Zeocin, and application to arachidonic acid production

The arachidonic acid-producing fungus Mortierella alpina 1S-4, an industrial strain, was endowed with Zeocin resistance by integration of the Zeocin-resistance gene at the rDNA locus of genomic DNA. Plasmid DNA was introduced into spores by microprojectile bombardment. Twenty mg/ml Zeocin completely inhibited the germination of M. alpina 1S-4 spores, and decreased the growth rate of fungal filaments to some extent. It was suggested that preincubation period and temperature had a great influence on transformation efficiency. Four out of 26 isolated transformants were selected. Molecular analysis of these stable transformants showed that the plasmid DNA was integrated into the rDNA locus of the genomic DNA. We expect that this system will be applied for useful oil production by gene manipulation of M. alpina 1S-4 and its derivative mutants. On the basis of the fundamental transformation system, we also tried to overexpress a homologous polyunsaturated fatty acid elongase gene, which has been reported to be included in the rate-limiting step for arachidonic acid production, thereby leading to increased arachidonic acid production.

Improvement of the fatty acid composition of an oil-producing filamentous fungus, Mortierella alpina 1S-4, through RNA interference with delta12-desaturase gene expression

An oleaginous fungus, Mortierella alpina 1S-4, is used commercially for arachidonic acid production. Delta12-Desaturase, which desaturates oleic acid (18:1n-9) to linoleic acid (18:2n-6), is a key enzyme in the arachidonic acid biosynthetic pathway. To determine if RNA interference (RNAi) by double-stranded RNA occurs in M. alpina 1S-4, we silenced the Delta12-desaturase gene. The silenced strains accumulate 18:2n-9, 20:2n-9, and Mead acid (20:3n-9), which are not detected in either the control strain or wild type strain 1S-4. The fatty acid composition of stable transformants was similar to that of Delta12-desaturation-defective mutants previously identified. Thus, RNAi occurs in M. alpina and could be used to alter the types and relative amounts of fatty acids produced by commercial strains of this fungus without mutagenesis or other permanent changes in the genetic background of the producing strains.

Improvement of arachidonic acid production by mutants with lower n-3 desaturation activity derived from Mortierella alpina

Five mutants were obtained, Y11, Y135, Y164, Y180 and Y61, capable of accumulating higher amounts of arachidonic acid (AA) than Mortierella alpina 1S-4, an industrial strain for the production of AA-rich triacylglycerol (TG). This is thought to be due to low or no activity of n-3 desaturation with conversion of AA to eicosapentaenoic acid, which functions at a cultural temperature below 20 degrees C. In small-scale cultivation under optimum conditions, Y11 and Y61 respectively accumulated 4.97 mg/ml and 4.11 mg/ml of AA, using a high concentration of glucose at 20 degrees C, compared with 3.74 mg/ml for M. alpina 1S-4. In a 5-1 jar fermentor, the AA content in Y11 and Y61 kept increasing during cultivation, with consumption of the glucose in the medium; and this reached 1.48 mg/ml and 1.77 mg/ml (118 mg/g, 120 mg/g of dry mycelia) at day 10, respectively, compared with 0.95 mg/ml (86 mg/g of dry mycelia) for M. alpina 1S-4. From the results of lipid analysis, the TG contents of Y11 and Y61 in the major lipids were significantly higher than that of M. alpina 1S-4; and the AA percentages in TG of Y11 and Y61 were also higher. Both Y11 and Y61 are potential producers of TG rich in AA.

Identification of mutation sites on Δ5 desaturase genes from Mortierella alpina 1S-4 mutants

The mutation sites on delta5 desaturase genes in delta5 desaturase-defective mutants derived from arachidonic acid-producing Mortierella alpina 1S-4 were identified. The mutations resulted in an amino acid replacement (G189E or W301Stop) and uncorrected transcription caused by recognition of an AG-terminal newly created on C207A gene mutation, resulting in low or no delta5 desaturase activity in these mutants.

Molecular evidence that the rate-limiting step for the biosynthesis of arachidonic acid in Mortierella alpina is at the level of an elongase

The oil-producing fungus Mortierella alpina 1S-4 is an industrial strain for arachidonic acid (AA) production. To determine its physiological properties and to clarify the biosynthetic pathways for PUFA, heterologous and homologous gene expression systems were established in this fungus. The first trial was performed with an enhanced green fluorescent protein gene to assess the transformation efficiency for heterologous gene expression. As a result, strong fluorescence was observed in the spores of the obtained transformant, suggesting that the foreign gene was inherited by the spores. The next trial was performed with a homologous PUFA elongase (GLELOp) gene, this enzyme having been reported to catalyze the elongation of GLA (18:3n-6) to dihomo-gamma-linolenic acid (20:3n-6), and to be the rate-limiting step of AA production. The FA composition of the transformant was different from that of the host strain: The GLA content was decreased whereas that of AA was increased. These data support the hypothesis that the GLELOp enzyme plays an important role in PUFA synthesis, and may indicate how to control PUFA biosynthesis.

A novel fungal omega3-desaturase with wide substrate specificity from arachidonic acid-producing Mortierella alpina 1S-4

A filamentous fungus, Mortierella alpina 1S-4, is capable of producing not only arachidonic acid (AA; 20:4n-6) but also eicosapentaenoic acid (EPA; 20:5n-3) below a cultural temperature of 20 degrees C. Here, we describe the isolation and characterization of a gene (maw3) that encodes a novel omega3-desaturase from M. alpina 1S-4. Based on the conserved sequence information for M. alpina 1S-4 Delta12-desaturase and Saccharomyces kluyveri omega3-desaturase, the omega3-desaturase gene from M. alpina 1S-4 was cloned. Homology analysis of protein databases revealed that the amino acid sequence showed 51% identity, at the highest, with M. alpina 1S-4 Delta12-desaturase, whereas it exhibited 36% identity with Sac. kluyveri omega3-desaturase. The cloned cDNA was confirmed to encode the omega3-desaturase by its expression in the yeast Sac. cerevisiae. Analysis of the fatty acid composition of the yeast transformant demonstrated that 18-carbon and 20-carbon n-3 polyunsaturated fatty acids (PUFAs) were accumulated through conversion of exogenous 18-carbon and 20-carbon n-6 PUFAs. The substrate specificity of the M. alpina 1S-4 omega3-desaturase differs from those of the known fungal omega3-desaturases from Sac. kluyveri and Saprolegnia diclina. Plant, cyanobacterial and Sac. kluyveri omega3-desaturases desaturate 18-carbon n-6 PUFAs, Spr. diclina omega3-desaturase desaturates 20-carbon n-6 PUFAs and Caenorhabditis elegans omega3-desaturase prefers 18-carbon n-6 PUFAs as substrates rather than 20-carbon n-6 PUFAs. The substrate specificity of M. alpina 1S-4 omega3-desaturase is rather similar to that of C. elegans omega3-desaturase, but the M. alpina omega3-desaturase can more effectively convert AA into EPA when expressed in yeast. The M. alpina 1S-4 omega3-desaturase is the first known fungal desaturase that uses both 18-carbon and 20-carbon n-6 PUFAs as substrates.

Cloning and sequencing of the ura3 and ura5 genes, and isolation and characterization of uracil auxotrophs of the fungus Mortierella alpina 1S-4

The oil-producing fungus Mortierella alpina 1S-4 is an industrial strain. In order to prepare host strains for a transformation system for this fungus, six uracil auxotrophs were obtained by means of random mutation with N-methyl-N'-nitro-N-nitrosoguanidine (MNNG). When the activities of orotate phosphoribosyl transferase (OPRTase, EC 2.4.2.10) and orotidine-5'-phosphate decarboxylase (OMPdecase, EC 4.1.1.23) were examined in the mutants and wild strain, OPRTase activity was found to be completely absent in all mutants, on the other hand, OMPdecase activity was intact. The genomic DNA and cDNA of the ura5 gene encoding OPRTase and the ura3 gene encoding OMPdecase were cloned and sequenced. The Ura5p deduced amino acid sequence of this fungus showed highest similarity to that of Vibrio cholerae classed among prokaryote. Furthermore, the mutational points in the ura5 genes of two selected mutants were identified; a base-replacement and a base-insertion.

Establishment of an overall transformation system for an oil-producing filamentous fungus, Mortierella alpina 1S-4

Oil-producing fungus Mortierella alpina 1S-4 is an industrial strain. To determine its physiological properties and to clarify the biosynthetic pathways for polyunsaturated fatty acids, a transformation system for this fungus was established using a derivative of it, i.e., a ura5- mutant lacking orotate phosphoribosyl transferase (OPRTase, EC.2.4.2.10) activity. Transformation with a vector containing the homologous ura5 gene as a marker was successfully performed using microprojectile bombardment, other methods frequently used for transformation, such as the protoplasting, lithium acetate, or electroporation methods, not giving satisfactory results. As a result, two types of transformants were obtained: a few stable transformants overexpressing the ura5 gene, and many unstable transformants showing OPRTase activity comparable to that of the wild-type strain. The results of quantitative PCR indicated that the stable transformants could retain the ura5 genes originating from the transformation vector regardless of the culture conditions. On the other hand, unstable transformants easily lost the marker gene under uracil-containing conditions, as expected. In this paper, we report that an overall transformation system for this fungus was successfully established, and propose how to select useful transformants as experimental and industrial strains.

Isolation and characterization of delta(6)-desaturase, an ELO-like enzyme and delta(5)-desaturase from the liverwort Marchantia polymorpha and production of arachidonic and eicosapentaenoic acids in the methylotrophic yeast Pichia pastoris

The liverwort Marchantia polymorpha contains high proportions of arachidonic and eicosapentaenoic acids. In general, these C20 polyunsaturated fatty acids (PUFA) are synthesized from linoleic and alpha -linolenic acids, respectively, by a series of reactions catalyzed by Delta(6)-desaturase, an ELO-like enzyme involved in Delta(6) elongation and Delta(5)-desaturase. Here we report the isolation and characterization of the cDNAs, MpDES6, MpELO1 and MpDES5, coding for the respective enzymes from M. polymorpha. Co-expression of the MpDES6, MpELO1 and MpDES5 cDNAs resulted in the accumulation of arachidonic and eicosapentaenoic acids in the methylotrophic yeast Pichia pastoris. Interestingly, Delta(6) desaturation by the expression of the MpDES6 cDNA appears to occur both in glycerolipids and the acyl-CoA pool, although other lower-plant Delta(6)-desaturases are known to have a strong preference for glycerolipids.