Glycosylation and secretion of human tissue plasminogen activator in recombinant baculovirus-infected insect cells

Increased production of active human beta(2)-adrenergic/G(alphas) fusion receptor in Sf-9 cells using nutrient limiting conditions

Using the baculovirus/insect-cell expression vector system, we succeeded in obtaining a high yield of active human beta(2)-adrenergic receptor/G(alphas) fusion protein. This was achieved following high cell density production under nutrient-limiting conditions using a very low multiplicity of infection (MOI). This approach was found to significantly reduce inactive protein accumulation that occurred when production was done using conventional high MOI procedures. The maximum specific and volumetric yields of active receptor using this strategy increased by factors of two- and sixfold, respectively. Our results suggest that the increase in the ratio of active/total protein produced results from production under nutrient limitation. Since low multiplicity of infection offers many advantages for large-scale applications, we suggest that this simple production method should be considered when optimizing expression of G-protein-coupled receptors and other complex proteins.

Characterization of the secretable ectodomain of thyrotropin receptor produced by the recombinant baculovirus system

Thyrotropin receptor (TSHR) is a member of the glycoprotein hormone receptor family and an autoantigen of Graves' disease. Various attempts have been made to obtain a large amount of soluble ectodomain of TSHR in insect or mammalian cells, but most of them failed to secrete the overexpressed ectodomain. In the present study, we observed that about one-third of the ectodomain protein (sTSHR-gp), in which the signal peptide of TSHR was replaced by the baculovirus-encoded glycoprotein 67-signal peptide, was secreted into the culture medium and the remainder stayed within cells in the recombinant baculovirus system. Microsequencing the N-terminal of the purified protein confirmed that the baculovirus signal peptide was cleaved at the expected site. Carbohydrate studies using several glycosidases and lectins revealed that the secreted form of the ectodomain had biantennary carbohydrate, whereas the non-secreted form had high-mannose. Moreover, the secreted form of sTSHR-gp exhibited high-affinity ligand binding, whereas the non-secreted form did not show any significant ligand binding. Regarding the interactions of TSHR ectodomains with anti-TSHR antibodies, both the secreted and non-secreted forms of sTSHR-gp, almost completely neutralized the stimulatory and inhibitory anti-TSHR antibody activities. In conclusion, we succeeded in secreting the ectodomain of TSHR into culture medium, which was capable of binding to TSH and neutralizing anti-TSHR antibody activities.

Expression of C1 esterase inhibitor by the baculovirus expression vector system: preparation, purification, and characterization

C1 esterase inhibitor (C1INH) is an important regulator of the classical complement pathway. Hereditary deficiency of C1INH causes angioedema of the skin, gut, and respiratory tissues that may be fatal. C1INH replacement therapy may be lifesaving for patients with this disorder. The objective of this study was to evaluate the use of the baculovirus expression vector system for mass producing biologically active human recombinant (rC1INH). A recombinant baculovirus was constructed coding the human native (nC1INH) sequence under control of the polyhedrin promoter. Spodoptera frugiperda Sf-9 insect cells were infected with this recombinant baculovirus in a medium-scale (10-L) bioreactor to produce rC1INH with a specific activity of 45 U/mg. Purification of rC1INH from the culture harvested at 60 h postinfection yielded 5.9 microg rC1INH/mL supernatant of a 75-kDa product with a specific activity of 31,000 U/mg purified rC1INH compared to 71,000 U/mg purified nC1INH from human serum using the same procedure. This rC1INH was about 25 kDa smaller than nC1INH, suggesting that Sf-9 cells express underglycosylated rC1INH. Glycan analysis showed that both N-glycan and O-glycan chains were present in rC1INH. The N-glycan chains, released using PNGaseF and fluorescently labeled, were analyzed using exoglycosidase treatment and capillary electrophoresis. Their high-mannose structure was consistent with the known failure of the insect cell glycosylation pathway to afford the fully elaborated biantennary structures found on human native nC1INH.

Determination of Nucleotides and Sugar Nucleotides Involved in Protein Glycosylation by High-Performance Anion-Exchange Chromatography: Sugar Nucleotide Contents in Cultured Insect Cells and Mammalian Cells

We have developed a simple and highly sensitive HPLC method for determination of cellular levels of sugar nucleotides and related nucleotides in cultured cells. Separation of 9 sugar nucleotides (CMP-Neu5Ac, CMP-Neu5Gc, CMP-KDN, UDP-Gal, UDP-Glc, UDP-GalNAc, UDP-GlcNAc, GDP-Fuc, GDP-Man) and 12 nucleotides (AMP, ADP, ATP, CMP, CDP, CTP, GMP, GDP, GTP, UMP, UDP, and UTP) was examined by reversed-phase HPLC and high-performance anion-exchange chromatography (HPAEC). Although the reversed-phase HPLC, using an ion-pairing reagent, gave a good separation of the 12 nucleotides, it did not separate sufficiently the sugar nucleotides for quantification. On the other hand, the HPAEC method gave an excellent and reproducible separation of all nucleotides and sugar nucleotides with high sensitivity and reproducibility. We applied the HPAEC method to determine the intracellular sugar nucleotide levels of cultured Spodoptera frugiperda (Sf9) and Trichoplusia ni (High Five, BTN-TN-5B1-4) insect cells, and compared them with those in Chinese hamster ovary (CHO-K1) cells. Sf9 and High Five cells showed concentrations of UDP-GlcNAc, UDP-Gal, UDP-Glc, GDP-Fuc, and GDP-Man equal to or higher than those in CHO cells. CMP-Neu5Ac was detected in CHO cells, but it was not detected in Sf9 and High Five cells. In conclusion, the newly developed HPAEC method could provide valuable information necessary for generating sialylated complex-type N-glycans in insect or other cells, either native or genetically manipulated.

Expression of a human, neutralizing monoclonal antibody specific to puumala virus G2-protein in stably-transformed insect cells

We cloned the heavy- and light-chain antibody genes of a human X (humanxmouse) trioma secreting a neutralizing, IgG monoclonal antibody to the G2-protein of Puumala virus. The antibody genes were inserted separately into plasmid transfer vector pIEI-4 such that the genes were under control of the baculovirus immediate early gene promoter, IEI. Trichoplusia ni (TN) cells were co-transfected with these constructs and a selection plasmid containing a neomycin-resistance gene. Cloned transformants expressing the IgG monoclonal antibody were identified by ELISA of transfected TN cell culture supernatants. TN cell lines were established from four selected clones, of which one was chosen for detailed analysis. Specificity of the insect cell-expressed human antibody was determined by ELISA with Puumala virus-infected cell lysates and by immune-precipitation of radiolabeled Puumala virus proteins. The expressed IgG retained the ability to neutralize Puumala virus in plaque-reduction neutralization assays. Using competitive polymerase chain reaction methods, multiple copies of integrated heavy- and light-chain antibody genes were detected in the insect cell genome. The transformed insect cells were stable and continuously expressed biologically active IgG. We conclude that this methodology provides an alternative eukaryotic source for the generation of human antibodies.

Characterization of the oligosaccharide structures associated with the cystic fibrosis transmembrane conductance regulator

The cystic fibrosis transmembrane conductance regulator (CFTR) is a plasma membrane-associated glycoprotein. The protein can exist in three different molecular weight forms of approximately 127, 131, and 160 kDa, representing either nonglycosylated, core glycosylated, or fully mature, complex glycosylated CFTR, respectively. The most common mutation in cystic fibrosis (CF) results in the synthesis of a variant (DeltaF508-CFTR) that is incompletely glycosylated and defective in its trafficking to the cell surface. In this study, we have analyzed the oligosaccharide structures associated with the different forms of recombinant CFTR, by expressing and purifying the channel protein from either mammalian Chinese hamster ovary (CHO) or insect Sf9 cells. Using glycosidases and FACE analysis (fluorophore-assisted carbohydrate electrophoresis) we determined that purified CHO-CFTR contained polylactosaminoglycan (PL) sequences, while Sf9-CFTR had only oligomannosidic saccharides with fucosylation on the innermost GlcNAc. The presence of PL sequences on the recombinant CHO-CFTR is consistent with a normal feature of mammalian processing, since endogenous CFTR isolated from T84 cells displayed a similar pattern of glycosylation. The present study also reports on the use of FACE for the qualitative analysis of small amounts of glycoprotein oligosaccharides released enzymatically.

N-Glycan processing by a lepidopteran insect alpha1,2-mannosidase

Protein glycosylation pathways are relatively poorly characterized in insect cells. As part of an overall effort to address this problem, we previously isolated a cDNA from Sf9 cells that encodes an insect alpha1,2-mannosidase (SfManI) which requires calcium and is inhibited by 1-deoxymannojirimycin. In the present study, we have characterized the substrate specificity of SfManI. A recombinant baculovirus was used to express a GST-tagged secreted form of SfManI which was purified from the medium using an immobilized glutathione column. The purified SfManI was then incubated with oligosaccharide substrates and the resulting products were analyzed by HPLC. These analyses showed that SfManI rapidly converts Man(9)GlcNAc(2)to Man(6)Glc-NAc(2)isomer C, then more slowly converts Man(6)GlcNAc(2)isomer C to Man(5)GlcNAc(2). The slow step in the processing of Man(9)GlcNAc(2)to Man(5)GlcNAc(2)by SfManI is removal of the alpha1,2-linked mannose on the middle arm of Man(9)GlcNAc(2). In this respect, SfManI is similar to mammalian alpha1,2-mannosidases IA and IB. However, additional HPLC and(1)H-NMR analyses demonstrated that SfManI converts Man(9)GlcNAc(2)to Man(5)GlcNAc(2)primarily through Man(7)GlcNAc(2)isomer C, the archetypal Man(9)GlcNAc(2)missing the lower arm alpha1,2-linked mannose residues. In this respect, SfManI differs from mammalian alpha1,2-mannosidases IA and IB, and is the first alpha1,2-mannosidase directly shown to produce Man(7)GlcNAc(2)isomer C as a major processing intermediate.

Expression and characterization of glycolipid-anchored B7-1 (CD80) from baculovirus-infected insect cells: protein transfer onto tumor cells

Tumor cells can be modified to express immunostimulatory molecules such as B7-1 by protein transfer using purified glycosylphosphatidylinositol-anchored B7-1 (GPI-B7-1). In this study recombinant baculovirus encoding GPI-B7-1 (vBacB7-1(GPI)) was established to obtain large quantities of purified GPI-B7-1 to modify tumor cells by protein transfer. vBacB7-1(GPI)-infected insect cells showed high-level cell surface expression of GPI-B7-1 that was susceptible to PIPLC treatment. GPI-B7-1 expressed in insect cells (Bac-GPI-B7-1) mediated T cell proliferation, indicating that the GPI-B7-1 retains costimulatory activity. Moreover, Bac-GPI-B7-1 was completely solubilized in Triton X-100 at 4 degrees C compared to 22% solubilization of GPI-B7-1 expressed in CHOK1 cells, suggesting that GPI-anchored proteins expressed in insect cells may not be clustered into the detergent-insoluble fraction. SDS-PAGE analysis of Bac-GPI-B7-1 showed faster mobility (45 kDa) compared to GPI-B7-1 from CHOK1 (68 kDa) and this difference may be due to a difference in glycosylation. Cell binding assays showed that immunoaffinity-purified Bac-GPI-B7-1 retained its functional ability to bind CD28(+) cells. Moreover, when human tumor cells were incubated with this functionally active purified GPI-B7-1, an efficient transfer of B7-1 onto tumor cells was observed. These results demonstrate that GPI-B7-1 can be expressed in insect cells in a functionally active form and can be used to modify tumor cells for immunotherapeutic applications.

Discrimination of granulocyte colony-stimulating factor isoforms by high-performance capillary electrophoresis

Granulocyte colony-stimulating factor (G-CSF) is a glycoprotein which acts primarily to stimulate the proliferation, differentiation and activation of committed progenitor cells of the neutrophil-granulocyte lineage into functionally mature neutrophils. The traditional biological assays employed to detect G-CSF are a myeloid bone marrow colony assay, a factor-dependent cell line specific for G-CSF and commercially available immunoassays. However, these methods will not distinguish between glycosylated and non-glycosylated forms of the molecule. In this study high-performance capillary electrophoresis (HPCE) was used to analyse glycosylated and non-glycosylated recombinant human granulocyte colony-stimulating factor (r-met-hG-CSF). Glycosylated G-CSF preparations contained human serum albumin (HSA), added as a protein carrier. Glycosylated and non-glycosylated G-CSFs were prepared in 40 mM Na2HPO4 buffer, pH 2.5, containing hydroxypropylmethylcellulose (HPMC) or 50 mM Na2HPO4 buffer, pH 9.0. Glycosylated G-CSF could be separated into two distinct glycoform populations at the lower pH studied. Differences in migration time and peak shape between glycosylated and non-glycosylated G-CSF were demonstrated. HPCE analysis of G-CSF produced using a baculovirus expression vector system revealed a further distinct G-CSF glycoform and demonstrated the resolving power of the technique.

O-glycosylation potential of lepidopteran insect cell lines

The enzyme activities involved in O-glycosylation have been studied in three insect cell lines, Spodoptera frugiperda (Sf-9), Mamestra brassicae (Mb) and Trichoplusia ni (Tn) cultured in two different serum-free media. The structural features of O-glycoproteins in these insect cells were investigated using a panel of lectins and the glycosyltransferase activities involved in O-glycan biosynthesis of insect cells were measured (i.e., UDP-GalNAc:polypeptide N-acetylgalactosaminyltransferase, UDP-Gal:core-1 beta1, 3-galactosyltransferase, CMP-NeuAc:Galbeta1-3GalNAc alpha2, 3-sialyltransferase, and UDP-Gal:Galbeta1-3GalNAc alpha1, 4-galactosyltransferase activities). First, we show that O-glycosylation potential depends on cell type. All three lepidopteran cell lines express GalNAcalpha-O-Ser/Thr antigen, which is recognized by soy bean agglutinin and reflects high UDP-GalNAc:polypeptide N-acetylgalactosaminyltransferase activity. Capillary electrophoresis and mass spectrometry studies revealed the presence of at least two different UDP-GalNAc:polypeptide N-acetylgalactosaminyltransferases in these insect cells. Only some O-linked GalNAc residues are further processed by the addition of beta1,3-linked Gal residues to form T-antigen, as shown by the binding of peanut agglutinin. This reflects relative low levels of UDP-Gal:core-1 beta1,3-galactosyltransferase in insect cells, as compared to those observed in mammalian control cells. In addition, we detected strong binding of Bandeiraea simplicifolia lectin-I isolectin B4 to Mamestra brassicae endogenous glycoproteins, which suggests a high activity of a UDP-Gal:Galbeta1-3GalNAc alpha1, 4-galactosyltransferase. This explains the absence of PNA binding to Mamestra brassicae glycoproteins. Furthermore, our results substantiated that there is no sialyltransferase activity and, therefore, no terminal sialic acid production by these cell lines. Finally, we found that the culture medium influences the O-glycosylation potential of each cell line.

A novel form of human neuropsin, a brain-related serine protease, is generated by alternative splicing and is expressed preferentially in human adult brain

We have cloned cDNAs encoding two isoforms of a human novel serine protease. They encoded sequences of 260 and 305 amino acids, and both showed significant homology to mouse neuropsin. Mouse neuropsin has been reported to be involved in hippocampal plasticity, therefore we designated the proteins as type 1 and type 2 neuropsin, respectively. The amino acid sequences of the two types of human neuropsin were identical, except that type 2 carried an insert of 45 amino acids at the C-terminus of the leader sequence. The essential three amino acids in the active site triad, His, Asp, and Ser, and the single putative N-glycosylation site were conserved in human and mouse neuropsin. Sequence analysis of the 946 bp genomic DNA spanning the region encoding the insertion sequence revealed that two isoforms were generated in human brain by alternative splicing. However, the mouse genomic sequence did not conserve the 3' acceptor consensus sequence at the corresponding position, suggesting that type 2 neuropsin was a species-specific splice variant. When the open reading frames of human neuropsin were expressed in insect cells, both types of neuropsin were detected in the conditioned media by western blot analysis using anti-human neuropsin serum. Northern blot hybridization and reverse transcription-polymerase chain reaction showed predominant expression of type 1 neuropsin in pancreas. Type 2 neuropsin was preferentially expressed in human adult brain and hippocampus, although both types were expressed in fetal brain and placenta in comparable amounts. Dot blot hybridization showed that neuropsin was expressed in various regions of adult brain, including the hippocampus and cerebral cortex, and also in various fetal tissues. These results suggest that human type 2 neuropsin may be important to the adult brain plasticity, although both types may be necessary for the development of the nervous system.

Critical relationship between glycosylation of recombinant lutropin receptor ectodomain and its secretion from baculovirus-infected insect cells

The lutropin receptor ectodomain overexpressed under the control of the powerful polyhedrin promoter in baculovirus-infected Sf9 insect cells, is mainly found in an inactive, intracellularly-aggregated form. It is secreted in an active form under the control of the P10 promoter, a somewhat weaker and earlier promoter, at the price of a lower production. The apparent molecular masses of the two species encoded by the same cDNA are 48 kDa and 60-68 kDa, respectively. The relationship between the extent and type of glycosylation and the extracellular targeting for the recombinant lutropin receptor ectodomains was investigated precisely with endoglycosidases, lectins of various specificities, and a glycosylation inhibitor, and tested with monoclonal and polyclonal antibodies. The results indicate that the strong polyhedrin promoter probably overwhelms the processing capacity of the ER in Sf9 cells, so that only a high-mannose precursor is expressed in large amounts. Only a minute amount of protein is secreted, which has been processed by Sf9 exoglycosidases/glycosyltransferases and bears complex/hybrid oligosaccharides. The weaker P10 promoter allows secretion of a mature and active receptor ectodomain, bearing complex glycosylation. An important O-linked glycosylation is also added post-translationally on this species. In particular, beta-galactose and sialic acid residues were specifically detected in the secreted species, evidence of the induction of the corresponding glycosyltransferases or of their genes. These results suggest that Sf9 cells should eventually be engineered with chaperones and glycosyltransferases in order to improve the production of demanding glycoproteins such as the porcine lutropin ectodomain, so as to open the way to resolution of the three-dimensional structures of these receptors.

A bacterial signal peptidase enhances processing of a recombinant single chain antibody fragment in insect cells

The production of an antibody single chain fragment (scFv) in insect cells was accompanied by the formation of an insoluble intracellular precursor even with the inclusion of the bee melittin signal peptide. The presence of the precursor polypeptide suggests a limitation in the processing of the signal peptide so a baculovirus containing a signal peptidase from Bacillus subtilis (SipS) was constructed for expression studies. When the wild type SipS was coexpressed with scFv, preprocessed scFv fragments were no longer detected in insect cell lysates. Conversely, coexpression of scFv alone or with an inactive mutant SipS resulted in at least 30% of the intracellular polypeptide in an unprocessed form at 3 days post infection. Production of scFv in the medium was also enhanced in the presence of SipS; however, low secretion levels indicate the presence of a post-processing bottleneck.

High-level expression of secreted glycoproteins in transformed lepidopteran insect cells using a novel expression vector

An expression cassette for continuous high-level expression of secreted glycoproteins by transformed lepidopteran insect cells has been developed as an alternative to baculovirus and mammalian cell expression systems. The expression cassette utilizes the promoter of the silkmoth cytoplasmic actin gene to drive expression from foreign gene sequences, and also contains the ie-1 transactivator gene and the HR3 enhancer region of BmNPV to stimulate gene expression. Using an antibiotic-resistance selection scheme, we have cloned a Bm5 (silkmoth) cell line overexpressing the secreted glycoprotein juvenile hormone esterase (JHE-KK) at levels of 190 mg/L in batch suspension cultures. A baculovirus (AcNPV) expressing the same gene under the control of the p10 promoter of AcNPV produced only 4 mg/L active JHE in static cultures of infected Sf21 cells. A cloned Bm5 cell line overexpressing a soluble isoform of the alpha-subunit of the granulocyte-macrophage colony stimulating factor receptor (solGMRalpha) was also generated and produced five times more solGMRalpha in static cultures than a cloned BHK cell line obtained by transformation with a recombinant expression cassette utilizing the human cytomegalovirus (CMV) enhancer-promoter system. Finally, we show that recombinant protein expression levels in transformed Bm5 cells remain high in serum-free media, that expression is stable even in the absence of antibiotic selection, and that lepidopteran cells other than Bm5 may be used equally efficiently with this new expression cassette for producing recombinant proteins.

Characterization of a UDP-Gal:Galbeta1-3GalNAc alpha1, 4-galactosyltransferase activity in a Mamestra brassicae cell line

The binding of Bandeiraea simplicifolia lectin-I isolectin B4 on the endogenous glycoproteins of different insect cell lines led us to characterize for the first time a UDP-Gal:Galbeta1-3GalNAc alpha1, 4-galactosyltransferase in a Mamestra brassicae cell line (Mb). The study of the acceptor specificity indicated that the Mb alpha-galactosyltransferase prefers Galbeta1-3-R as acceptor, and among such glycans, the relative substrate activity Vmax/Km was equal to 20 microliters.mg-1.h-1 for Galbetal-3GlcNAcbeta1-O-octyl and to 330 microliters.mg-1.h-1 for Galbeta1-3GalNAcalpha-1-O-benzyl, showing clearly that Galbeta1-3GalNAc disaccharide was the more suitable acceptor substrate for Mb alpha-galactosyltransferase activity. Nuclear magnetic resonance and mass spectrometry data allowed us to establish that the Mb alpha-galactosyltransferase synthesizes one unique product, Galalpha1-4Galbeta1-3GalNAcalpha1-O-benzyl. The Galbeta1-3GalNAc disaccharide is usually present on O-glycosylation sites of numerous asialoglycoproteins and at the nonreducing end of some glycolipids. We observed that Mb alpha1,4-galactosyltransferase catalyzed the transfer of galactose onto both natural acceptors. Finally, we demonstrated that the trisaccharide Galalpha1-4Galbeta1-3GalNAcalpha1-O-benzyl was able to inhibit anti-PK monoclonal antibody-mediated hemagglutination of human blood group PK1 and PK2 erythrocytes.

Molecular characterization, enzymatic analysis, and purification of murine proprotein convertase-1/3 (PC1/PC3) secreted from recombinant baculovirus-infected insect cells

A cDNA coding for the murine proprotein convertase-1 (mPC1 also known as mPC3 or mSPC3) was inserted into the Autographa californica nuclear polyhedrosis virus. Following infection of Spodoptera frugiperda cells, the recombinant N-glycosylated protein is secreted into the cell culture medium from which it can be purified to homogeneity as a fully enzymatically active enzyme. Two major secreted molecular forms of mPC1 with apparent molecular weights of 85 and 71 kDa, respectively, and a minor one of 75 kDa are immunodetected in the medium. Automated NH2-terminal sequencing reveals that all three forms result from processing at the predicted zymogen activation site whereas both the 75- and the 71-kDa forms are truncated at their COOH-terminus. Labeling by an active-site titrant demonstrates that the 85-kDa form is optimally labeled at near neutral pH whereas the COOH-truncated forms are optimally labeled at acidic pH. Additionally it is shown that the 85-kDa mPC1 is transformed into the COOH-truncated forms following in vitro incubation at acidic pH levels and in presence of calcium. Concomitantly, the transformation from 85 to 71 kDa is accompanied by a 10- to 40-fold increase in enzymatic activity upon assaying at pH 6.0. The 71-kDa form can be recovered after purification at a level of 1 to 1.5 mg per liter of cell culture medium and is enzymatically stable only in the pH range from 5.0 to 6.5. Cells treated with tunicamycin show a drastically reduced secretion of the convertase in the medium but are not affected by swainsonine and deoxymannojirimycin. Finally, the 85-kDa secreted mPC1 is shown to be sulfated.

Recombinant breast carcinoma-associated mucins expressed in a baculovirus system contain a tumor specific epitope

Mucins are highly immunogenic glycoproteins that are abundantly expressed by breast and other adenocarcinomas. In order to progress in the understanding of the structure immunity relationship of the breast tumor associated mucin and normal tissue mucin, two forms of breast carcinoma associated mucin, muc7-BV and pem-BV, were expressed in a baculovirus expression system. The muc7-BV was constructed by inserting the seven tandem repeats of mucin core cDNA fragment into transfer vector pAc360, forming a fusion protein containing 14 amino acids of the baculovirus polyhedrin N-terminus. The pem-BV was constructed by cloning full-length mucin cDNA into the transfer vector pVL1392. The recombinant mucins were purified using immunoaffinity chromatography. The purified muc7-BV and pem-BV had molecular weights of 28 and 59 kd, respectively. No carbohydrate was detected on these recombinant mucins and is speculated to explain why both forms of recombinant mucin showed strong affinity to tumor-specific monoclonal antibody SM3. These recombinant mucins may have the potential value to develop vaccines against breast and other adenocarcinomas and to induce cytotoxic T-lymphocyte lines for immunotherapy of the same.

Expression, characterization, processing and immunogenicity of an insulin-dependent diabetes mellitus autoantigen, IA-2, in Sf-9 cells

Autoantibodies to a 64-kD protein and a 40-kD tryptic fragment from pancreatic islets have been detected at high frequency in the sera of patients with insulin-dependent diabetes mellitus (IDDM). IA-2, a newly isolated transmembrane protein tyrosine phosphatase, is a major islet cell autoantigen in IDDM and the precursor of a 40-kD tryptic fragment. To express large quantities of recombinant IA-2 protein and analyse post-translational modifications we expressed full-length human IA-2 in baculovirus-infected Sf-9 cells. IA-2 expression was analysed by Western blot and by immunoprecipitation of 35S-methionine-radiolabelled proteins with rabbit antisera or IDDM sera. A 120-kD IA-2 protein was detected during the early, but not the late, phase of the infection. Pulse-chase experiments showed that the 120-kD protein was processed into fragments of 64 kD and smaller fragments of approximately 50 kD, 38 kD and 32 kD. The 64-kD fragment appeared as a doublet. Tunicamycin and PNGase F treatment down-shifted the 120-kD protein and the 64-kD doublet into lower molecular weight bands, suggesting that both were glycosylated. Trypsin treatment converted the 120-kD protein and the 64-kD doublet into a 40-kD fragment. Baculovirus-expressed IA-2 was as sensitive or slightly more sensitive than in vitro translated IA-2 in detecting autoantibodies to IA-2: 66% of sera from newly diagnosed IDDM patients reacted with baculovirus-expressed IA-2 compared with 59% of the same sera which reacted with in vitro translated IA-2. It is concluded that baculovirus-expressed IA-2 is a good source of autoantigen and that a number of lower molecular weight fragments with which IDDM autoantibodies react are derived from the 120-kD full-length IA-2 molecule.

Baculovirus-mediated expression of a scorpion depressant toxin improves the insecticidal efficacy achieved with excitatory toxins

The insecticidal efficacy towards Helicoverpa armigera lepidopteran larvae of recombinant Autographa californica M nucleopolyhedroviruses, expressing depressant and excitatory scorpion anti-insect selective toxins, was investigated. The ET50 (effective paralysis time 50%) values obtained with the recombinant viruses expressing the depressant toxin, LqhIT2, and the excitatory toxin, LqhIT1, were 59 h and 66 h, respectively, whereas the ET50 value of the wild-type virus was longer, 87 h post infection. The insecticidal effects obtained when using two distinct temporally regulated viral promoters revealed advantage for the very late p10 promoter over the p35 early promoter. The higher insecticidity of the virus expressing the depressant toxin compared to the excitatory toxin suggests that pharmacokinetic factors and/or promoter efficiency may play a role during infection of insect pest larvae by recombinant baculoviruses.

Expression and characterization of recombinant human type II collagens with low and high contents of hydroxylysine and its glycosylated forms

Insect cells coinfected with two baculoviruses, one coding for the pro alpha chains of human type II procollagen and the other for both the alpha and beta subunits of human prolyl 4-hydroxylase, produced the cartilage-specific type II collagen with a stable triple helix. The highest expression levels, up to 50 mg/l of type II collagen, were obtained in suspension culture using a modified construct in which sequences coding for the signal peptide and N propeptide of type II procollagen had been replaced by those for type III procollagen. The type III N propeptide artificially generated into type II procollagen was found to be cleaved at a much higher rate than the wild-type type II N propeptide, probably because the former interacted poorly with the triple-helical domain of type II procollagen. The amino acid composition of the recombinant type II collagen was very similar to that of the non-recombinant protein, but the hydroxylysine content was only 17% and that of glycosylated hydroxylysines was equally low. The hydroxylysine content was increased to the level found in the non-recombinant collagen by using an additional baculovirus coding for lysyl hydroxylase, and a substantial increase was also found in the glycosylated hydroxylysine content. No difference in thermal stability was found between the low- and high-hydroxylysine collagens.

Expression of wild-type and modified proalpha chains of human type I procollagen in insect cells leads to the formation of stable [alpha1(I)]2alpha2(I) collagen heterotrimers and [alpha1(I)]3 homotrimers but not [alpha2(I)]3 homotrimers

Insect cells coinfected with a baculovirus coding for the proalpha1(I) chain of human type I procollagen and a double promoter virus coding for the alpha and beta subunits of human prolyl 4-hydroxylase produced homotrimeric [proalpha1(I)]3 procollagen molecules. The use of an additional virus coding for the proalpha2(I) chain led to the formation of a heterotrimeric molecule with the correct 2:1 ratio of proalpha1 to proalpha2 chains of type I procollagen (proalpha1(I) and proalpha2(I) chains, respectively), unless the proalpha1(I) chain was expressed in a relatively large excess. Replacement of the sequences coding for the signal peptide and the N propeptide of the proalpha1(I) chain with those of the proalpha1(III) chain increased level of expression of the proalpha1(I) chain, whereas no similar effect was found when the corresponding modification was made to the virus coding for the proalpha2(I) chain. Molecules containing such modified N propeptides were found to be processed at their N terminus more rapidly than those containing the wild-type propeptides. The Tm of the type I collagen homotrimer was similar to that of the heterotrimer, both values being about 42-43 degrees C when determined by circular dichroism. The wild-type proalpha2(I) chain formed no homotrimers. Replacement of the C propeptide of the proalpha2(I) chain with that of the proalpha1(I) chain or proalpha1 chain of type III procollagen (proalpha1(III) chain) led to the formation of homotrimers, but the alpha2(I) chains in such molecules were completely digested by pepsin in 1 h at 22 degrees C. The data thus suggest that, in addition to control at the level of the C propeptide, other restrictions may exist at the level of the collagen domain that prevent the formation of stable homotrimeric [proalpha2(I)]3 molecules in insect cells.

Functional equivalence of native light-sensitive channels in the Drosophila trp301 mutant and TRPL cation channels expressed in a stably transfected Drosophila cell line

Drosophila photoreceptors express two putative cation channels encoded by the transient receptor potential (trp) and trp-like (trpl) genes, which represent prototypical members of a novel family of phosphoinositide-regulated calcium influx channels. Mutations of both trp and trpl selectively abolish components of the light-sensitive current and, when heterologously expressed, both generate cation permeable conductances; however, a detailed comparison of recombinant and native channel properties is lacking. To more rigorously test the hypothesis that TRPL channels mediate one component of the light-sensitive current we have generated cell lines (Drosophila S2 cells) stably transfected with trpl cDNA and compared the recombinant channel properties with those of the light-sensitive conductance in situ in a Drosophila trp mutant under identical conditions. We found close correspondence in respect of a number of quantifiable biophysical parameters including: current voltage relationships, ionic selectivity, voltage independent block by external Mg2+ ions and effective single channel conductance and gating kinetics derived by noise analysis. Our estimate of 60-70 pS for channel conductance was confirmed directly in patch clamp recordings of single TRPL channels in S2 cells. These findings indicate that channels encoded by the trpl gene can completely account for the component of the light-sensitive conductance remaining in the trp mutant.

Baculovirus-mediated expression of chicken growth hormone

A full-length chicken growth hormone (cGH) cDNA was placed downstream from the Autograph californica nuclear polyhedron virus, AcNPV, polyhedron gene promoter and expressed in Sf9 insect cells. Secreted recombinant cGH levels averaged 2-10 micrograms/ml from day 5-10 postinfection. The recombinant cGH analyzed by SDS-PAGE gels and Western blotting consisted of a doublet with M(r) of 26.5 and 23.5 kDa. Analysis by 2-D electrophoresis of partially-purified recombinant cGH and purified native cGH revealed similar immunoreactive charge isoforms and M(r) variants. The recombinant hormone was biologically active in a homologous radioreceptor assay. The results show that cGH expressed in insect cells is biologically and immunologically active, and that a variety of isoforms are secreted which exhibit size and charge properties similar to those of pituitary-derived cGH.

Differential N-glycan patterns of secreted and intracellular IgG produced in Trichoplusia ni cells

Structures of the N-linked oligosaccharide attached to the heavy chain of a heterologous murine IgG2a produced from Trichoplusia ni (TN-5B1-4, High Five) insect cells were characterized. Coexpression of the chaperone immunoglobulin heavy chain-binding protein (BiP) in the baculovirus-infected insect cells increased the soluble intracellular and secreted IgG level. This facilitated the detailed analysis of N-glycans from both intracellular and secreted IgG. Following purification of the immunoglobulins using Protein A-Sepharose, glycopeptides, prepared by trypsin-chymotrypsin digestion, were further digested with glycoamidase from sweet almond emulsin to obtain the oligosaccharide moieties. The resulting oligosaccharides were then reductively aminated with 2-aminopyridine and the structures identified by two-dimensional high performance liquid chromatography mapping (Tomiya, N., Awaya, J., Kurono, M., Endo, S., Arata, Y., and Takahashi, N. (1988) Anal. Biochem. 171, 73-90). The N-glycans obtained from the secreted IgG contain 35% complex type, some with terminal galactose residues at either alpha1, 3-Man or alpha1,6-Man branches of the Man3GlcNAc2 core. The remaining oligosaccharides detected in the secreted IgG were principally hybrid (30%) and paucimannosidic (35%) type N-glycans. Most (84%) of these secreted glycoforms contained fucose alpha1, 6-linked to the innermost GlcNAc residue and the presence of a potentially allergenic fucose alpha1,3-linked to the innermost GlcNAc residue was also detected. In contrast, the intracellular immunoglobulins included 50% high mannose-type N-glycans with lower levels of complex, hybrid, and paucimannosidic-type structures. Reverse phase one-dimensional high performance liquid chromatography analysis of the IgG N-glycans in the absence of heterologous BiP exhibited a similar distribution of intracellular and secreted glycoforms. These studies indicate that Trichoplusia ni TN-5B1-4 cells are capable of terminal galactosylation. However, the processing pathways in these cell lines appear to diverge from mammalian cells in the formation of paucimannosidic structures, in the presence of alpha1,3-fucose linkages, and in the absence of sialylation.

Influence of simulated microgravity on the longevity of insect-cell culture

Simulated microgravity within the NASA High Aspect Rotating-Wall Vessel (HARV) provides a quiescent environment to culture fragile insect cells. In this vessel, the duration of stationary and death phase for cultures of Spodoptera frugiperda cells was greatly extended over that achieved in shaker-flask controls. For both HARV and control cultures, S. frugiperda cells grew to concentrations in excess of 1 x 10(7) viable cells ml-1 with viabilities greater than 90%. In the HARV, stationary phase was maintained 9-15 days in contrast to 4-5 days in the shaker flask. Furthermore, the rate of cell death was reduced in the HARV by a factor of 20-90 relative to the control culture and was characterized with a death rate constant of 0.01-0.02 day-1. Beginning in the stationary phase and continuing in the death phase, there was a significant decrease in population size in the HARV versus an increase in the shaker flask. This phenomenon could represent cell adaptation to simulated microgravity and/or a change in the ratio of apoptotic to necrotic cells. Differences observed in this research between the HARV and its control were attributed to a reduction in hydrodynamic forces in the microgravity vessel.

Purification and analysis of a polydnavirus gene product expressed using a poly-histidine baculovirus vector

The VHv1.1 polydnavirus gene has been implicated in suppressing the encapsulation response in parasitized insects [Li and Webb (1994) J. Virol. 68, 7482-7489]. In order to characterize this gene product and to further our analysis of its immunosuppressive function, we expressed the VHv1.1 using a custom-designed C-terminal poly-histidine baculovirus vector which allows for high expression and single-step purification of the protein. The 34 kDa VHv1.1 protein was expressed in baculovirus-infected cell cultures and in H. virescens larvae. Highly enriched preparations of the secreted VHv1.1 protein were obtained after affinity chromatography using a NTA-(Ni2+) resin. Characterization with purified preparations of the VHv1.1 protein established that the protein is N-glycosylated, containing glycogroups which are PNGase F-sensitive but Endo H-resistant. The recombinant VHv1.1 protein bound to hemocytes in vitro and in vivo and was endocytosed in a manner similar to the native protein produced in CsPDV-infected larvae.

Selective inhibition of cyclooxygenase-1 and -2 using intact insect cell assays

We have utilized the baculovirus expression system to develop an in vitro intact cell assay for screening nonsteroidal anti-inflammatory drug (NSAID) inhibition of the two isozymes of human cyclooxygenase (prostaglandin endoperoxidase synthase, EC 1.14.99.1). Infected Spodoptera frugiperda (sf9) cells expressing either human cyclooxygenase-1 (hCOX-1) or human cyclooxygenase-2 (hCOX-2) were harvested 24 hr postinfection, a time point where all cells are viable and hCOX-1 or hCOX-2 are correctly processed. Cells were distributed to a 96-well plate, preincubated with various NSAIDs, and challenged with 10 microM arachidonic acid; then cyclooxygenase activity was assessed indirectly by prostaglandin E2-specific radioimmunoassay. The rank order of potency of NSAID-mediated inhibitions of hCOX-1 and hCOX-2 paralleled those that have been observed in other cell systems. This sf9 cell-based assay can be utilized for the identification of potent and selective inhibitors of hCOX-1 and/or hCOX-2. Compounds that preferentially inhibit hCOX-2 may provide novel NSAIDs that reduce inflammation while sparing the stomach and kidneys of toxic side-effects seen with current nonselective NSAIDs.

Modifying the insect cell N-glycosylation pathway with immediate early baculovirus expression vectors

The baculovirus-insect cell expression system is well-suited for recombinant glycoprotein production because baculovirus vectors can provide high levels of expression and insect cells can modify newly synthesized proteins in eucaryotic fashion. However, the N-glycosylation pathway of baculovirus-infected insect cells differs from the pathway found in higher eucaryotes, as indicated by the fact that glycoproteins produced in the baculovirus system typically lack complex biantennary N-linked oligosaccharide side chains containing penultimate galactose and terminal sialic acid residues. We recently developed a new type of baculovirus vector that can express foreign genes immediately after infection under the control of the viral ie1 promoter. These immediate early baculovirus expression vectors can be used to modify the insect cell N-glycosylation pathway and produce a foreign glycoprotein with more extensively processed N-linked oligosaccharides. These vectors can also be used to study the influence of the late steps in N-linked oligosaccharide processing on glycoprotein function. Further development could lead to baculovirus-insect cell expression systems that can produce recombinant glycoproteins with complex biantennary N-linked oligosaccharides structurally identical to those produced by higher eucaryotes.

Overexpression of a functional NMDA receptor subunit (NMDAR1) in baculovirus-infected Trichoplusia ni insect cells

For overexpression of the N-methyl-D-aspartate (NMDA) receptor subunit 1b (NMDAR1b), its corresponding cDNA was extended by codons for six histidine residues at the 3'-end, cloned into a baculovirus transfer vector and integrated into the viral genome. Infection of Trichoplusia ni insect cells (High FiveTM cells) with recombinant baculovirus resulted in the production of 126- and 105-kDa NR 1b proteins in the cell membrane fraction. Enzymatic deglycosylation with PNGase F as well as infection of the insect cells in the presence of tunicamycin revealed that the two proteins represented the N-glycosylated and non-glycosylated forms of NMDAR1b, respectively. The recombinant NR1b protein was also identified with immunocytochemical methods employing a monoclonal antibody which recognized the six histidine residues. The affinity of this histidine tag to nickel ions was used for the purification of the NR1b protein. The glycine binding site of the subunit was successfully identified and analyzed with the specific antagonist 5,7-[3-3H]dichlorokynurenate (DCKA). The observed binding characteristics were similar to those obtained for native NMDA receptors. Whereas in electrophysiological measurements a functional NMDA receptor channel could not be found in infected insect cells, its expression was demonstrated in the Xenopus oocyte system after injection of the NMDAR1b cDNA construct.

Characterization of lysosomal acid lipase by site-directed mutagenesis and heterologous expression

Lysosomal acid lipase (LAL) is essential for the hydrolysis of cholesterol esters and triglycerides that are delivered to the lysosomes via the low density lipoprotein receptor system. The deficiency of LAL is associated with cholesteryl ester storage disease (CESD) and Wolman's disease (WD). We cloned the human LAL cDNA and expressed the active enzyme in the baculovirus system. Two molecular forms (M(r) approximately 41,000 and approximately 46,000) with different glycosylation were found intracellularly, and approximately 24% of the M(r) approximately 46,000 form was secreted into the medium. Tunicamycin treatment produced only an inactive M(r) approximately 41,000 form. This result implicates glycosylation occupancy in the proper folding for active-site function. Catalytic activity was greater toward cis- than trans-unsaturated fatty acid esters of 4-methylumbelliferone and toward esters with 7-carbon length acyl chains. LAL cleaved cholesterol esters and mono-, tri-, and diglycerides. Heparin had a biphasic effect on enzymatic activity with initial activation followed by inhibition. Inhibition of LAL activity by tetrahydrolipstatin and diethyl p-nitrophenyl phosphate suggested the presence of active serines in binding/catalytic domain(s) of the protein. Site-directed mutagenesis at two putative active centers, GXSXG, showed that Ser153 was important to catalytic activity, whereas Ser99 was not and neither was the catalytic nucleophile. Three reported mutations (L179P, L336P, and delta AG302 deletion) from CESD patients were created and expressed in the Sf9 cell system. None cleaved cholesterol esters, and L179P and L336P cleaved only triolein at approximately 4% of wild-type levels. These results suggest that mechanisms, in addition to LAL defects, may operate in the selective accumulation of cholesterol esters or triglycerides in CESD and WD patients.

Overexpression of integral membrane proteins for structural studies

Determination of the structure of integral membrane proteins is a challenging task that is essential to understand how fundamental biological processes (such as photosynthesis, respiration and solute translocation) function at the atomic level. Crystallisation of membrane proteins in 3D has led to the determination of four atomic resolution structures [photosynthetic reaction centres (Allenet al. 1987; Changet al. 1991; Deisenhofer & Michel, 1989; Ermleret al. 1994); porins (Cowanet al. 1992; Schirmeret al. 1995; Weisset al. 1991); prostaglandin H2synthase (Picotet al. 1994); light harvesting complex (McDermottet al. 1995)], and crystals of membrane proteins formed in the plane of the lipid bilayer (2D crystals) have produced two more structures [bacteriorhodopsin (Hendersonet al. 1990); light harvesting complex (Kühlbrandtet al. 1994)].

Purification and characterization of recombinant cystic fibrosis transmembrane conductance regulator from Chinese hamster ovary and insect cells

We have developed procedures to purify highly functional recombinant cystic fibrosis transmembrane conductance regulator (CFTR) from Chinese hamster ovary (CHO) cells to high homogeneity. Purification of CHO-CFTR was achieved using a combination of alkali stripping, alpha-lysophosphatidylcholine extraction, DEAE ion-exchange, and immunoaffinity chromatography. Insect CFTR from Sf9 cells was purified using a modification of the method of Bear et al. (Bear, C. E., Li, C., Kartner, N., Bridges, R. J., Jensen, T. J., Ramjeesingh, M. and Riordan, J. R. (1992) Cell 68, 809-818), which included extraction with sodium dodecyl sulfate, hydroxyapatite, and gel filtration chromatography. Characterization of the properties of purified CFTR from both cell sources using a variety of electrophysiological and biochemical assays indicated that they were very similar. Both the purified CHO-CFTR and Sf9-CFTR when reconstituted into planar lipid bilayers exhibited a low pS, chloride-selective ion channel activity that was protein kinase A- and ATP-dependent. Both the purified CHO-CFTR and Sf9-CFTR were able to interact specifically with the nucleotide photoanalogue 8-N3-[alpha-32P]ATP with half-maximal binding at 25 and 50 microM, respectively. These values compare well with those reported for 8-N3-[alpha-32P]ATP binding to CFTR in its native membrane form. Thus CFTR from either insect or CHO cells can be purified to high homogeneity with retention of many of the biochemical and electrophysiological characteristics of the protein associated in its native plasma membrane form. The availability of these reagents will facilitate further investigation and study of the structure and function of CFTR and its interactions with cellular proteins.

Cassette baculovirus vectors for the production of chimeric, humanized, or human antibodies in insect cells

Plasmid cassette-transfer vectors pBHuC chi and pBHuC gamma l have been designed which enable the construction of recombinant baculoviruses directing the co-expression of complete immunoglobulin in insect cells. We describe the application of these vectors for the expression of a human/mouse chimeric monoclonal antibody of potential immunosuppressive clinical value derived from a mouse anti-human CD29 monoclonal antibody (Mu-K20). The chimeric K20 light and heavy chains produced in sf9 insect cells were correctly processed and assembled into a normal immunoglobulin which is secreted into the culture medium of infected cells. The chimeric mAb Ch-K20-sf9 reproduces in vitro the functional properties of the parental mouse K20, including affinity and inhibition of lymphocyte proliferation. These results demonstrate that the baculovirus/insect cell expression system is suitable for the expression of fully active monoclonal antibodies of therapeutic value. Our generic cassette approach makes this system a very flexible and convenient one for the rapid production of either chimeric, humanized or human mAb with heavy and light chains of any isotype.

Insertion into Aspergillus nidulans of functional UDP-GlcNAc: alpha 3-D- mannoside beta-1,2-N-acetylglucosaminyl-transferase I, the enzyme catalysing the first committed step from oligomannose to hybrid and complex N-glycans

Filamentous fungi are capable of secreting relatively large amounts of heterologous recombinant proteins. Recombinant human glycoproteins expressed in this system, however, carry only carbohydrates of the oligomannose type limiting their potential use in humans. One approach to the problem is genetic engineering of the fungal host to permit production of complex and hybrid N-glycans. UDP-GlcNAc:alpha 3-D-mannoside beta- 1,2-N-acetylglucosaminyltransferase I (GnT I) is essential for the conversion of oligomannose to hybrid and complex N-glycans in higher eukaryotic cells. Since GnT I is not produced by fungi, we have introduced into the genome of Aspergillus nidulans the gene encoding full-length rabbit GnT I and demonstrated the expression of GnT I enzyme activity at levels appreciably higher than occurs in most mammalian tissues. All the GnT I activity in the Aspergillus transformants remains intracellular suggesting that the rabbit trans-membrane sequence may be capable of targeting GnT I to the fungal Golgi apparatus.

Generation, purification, and characterization of a recombinant source of human prostate-specific antigen

Human prostate-specific antigen (PSA), a 33- to 34-kDa serine proteinase with extensive homology to glandular kallikrein, is a single-chain glycoprotein that contains 7% carbohydrate. The presence of PSA in the serum of patients with prostatic cancer is widely employed as a marker of disease status. PSA has also been thought of as a possible target for use in active specific immunotherapy protocols. To date, the source of PSA employed has been seminal fluid from different individuals; this has raised concerns about differences among PSA batches for standardization of assays. This report is the first description of the production and the purification of a recombinant source of PSA using a baculovirus expression system. A baculovirus recombinant of the cDNA encoding the full length PSA was expressed in insect cells yielding two major immunoreactive products of 31 and 29 kDa. The latter size conforms to the molecular weight of a core preprotein deduced from the sequence of the cDNA insert. The larger protein represents the N-linked glycosylated form of the preprotein. Western blot analysis showed that both the glycosylated and aglycosylated forms of PSA reacted with a polyclonal and two different monoclonal antibodies specific for PSA. bV-PSA, like commercially available PSA, showed also low-molecular-weight immunoreactive products when culture supernatants were concentrated or taken through steps of purification. bV-PSA was purified to a final product consisting of a major 29-kDa protein and a minor 31-kDa protein.(ABSTRACT TRUNCATED AT 250 WORDS)

Expression and characterization of a soluble rubella virus E1 envelope protein

Individual specific antigenic rubella virus (RV) structural proteins are required for accurate serological diagnosis of acute and congenital rubella infections as well as rubella immune status. The RV envelope glycoprotein E1 is the major target antigen and plays an important role in viral-specific immune responses. The native virion is difficult to produce in large quantities and the protein subunits are also difficult to isolate without loss of antigenicity. The production of a soluble RV E1 (designated E1 delta Tm) using the baculovirus-insect cell expression system is described. In contrast to wild-type RV E1, the genetically engineered E1 delta Tm protein lacks a transmembrane anchor. It behaved as a secretory protein and was secreted abundantly from insect cells. Pulse-chase studies were used to examine the synthesis, glycosylation, and secretion of E1 delta Tm by the insect cells. The secreted E1 delta Tm protein was purified from serum-free medium by one-step immunochromatography. The purified E1 delta Tm protein retained full antigenicity and may be a convenient source of E1 protein for use in diagnostic assay and rubella vaccine development.

Evidence for N-glycosylation and ubiquitination of the prolactin receptor expressed in a baculovirus-insect cell system

The molecular mass of the rabbit prolactin receptor (rbPRLR) deduced from cDNA cloning is 66 kDa. However, the molecular mass of the full-length receptor expressed in the insect Sf9 cells was found to be 94 kDa. In order to explain this discrepancy, we analyzed the possible post-translational modifications of the PRLR. Sf9 cells were infected with recombinant baculoviruses in the presence of tunicamycin, an inhibitor of N-glycosylation. Results showed that an additional approximately 9 kDa of the extracellular domain could be attributed to the N-glycosylation and another additional approximately 20 kDa covalent modification occurred in the cytoplasmic part of the receptor. Western blot analysis, using anti-ubiquitin antibodies, revealed that the rbPRLR was ubiquitinated in its cytoplasmic domain.

High-level expression of the truncated alpha chain of human high-affinity receptor for IgE as a soluble form by baculovirus-infected insect cells. Biochemical characterization of the recombinant product

The binding subunit of human high-affinity receptor for IgE (Fc epsilon RI alpha) was efficiently expressed as a truncated form in insect cells. The soluble (s)Fc epsilon RI alpha purified from culture medium by affinity chromatography with an anti-(alpha chain) mAb was nearly homogeneous and had an IgE-binding activity. The amino acid composition and the revealed N-terminal amino acid sequence of sFc epsilon RI alpha suggested that it was properly processed in insect cells. The apparent molecular mass (35 kDa) of purified sFc epsilon RI alpha was smaller than that of sFc epsilon RI alpha produced by CHO transfectants. The reduction of the apparent molecular mass after N-glycanase treatment showed the recombinant product was N-glycosylated. Peptide mapping of native and deglycosylated sFc epsilon RI alpha indicated that three Asn residues (Asn21, Asn42 and Asn166) should be almost fully glycosylated, and that two Asn residues (Asn74 and Asn135) were partially glycosylated.

Glycosylation of two recombinant human uterine tissue plasminogen activator variants carrying an additional N-glycosylation site in the epidermal-growth-factor-like domain

Recombinant human uterine tissue plasminogen activator (tPA) glycosylation mutants carrying an additional N-glycosylation site in the epidermal-growth-factor-like domain due to the replacement of either Tyr67 by Asn (YN-tPA) or Gly60 by Ser (GS-tPA) were expressed in mouse epithelial cells (C127) in the presence of [6-3H]glucosamine. Glycopeptides comprising individual glycosylation sites were isolated and oligosaccharides attached were liberated by treatment with endo-beta-N-acetylglucosaminidase H or peptide-N4-(N-acetyl-beta-glucosaminyl)asparagine amidase F. Oligosaccharide alditols obtained after reduction were either directly characterized by high-pH anion-exchange chromatography (high-mannose and hybrid-type glycans) or preparatively subfractionated after enzymic desialylation and separation from sulphated asialooligosaccharides (complex-type sugar chains). Individual (sub)fractions of glucans were studied by methylation analysis, liquid secondary-ion mass spectrometry and, in part, by exoglycosidase digestion, whereas corresponding deglycosylated peptides were identified by amino acid analysis and N-terminal amino acid sequencing. The results revealed that Asn117 of YN-tPA carried exclusively high-mannose-type glycans with five to nine mannose residues similar to wild-type tPA expressed in this cell line [Pfeiffer, G., Schmidt, M., Strube, K.-H. & Geyer, R. (1989) Eur. J. Biochem. 186, 273-286]. In contrast, Asn117 of GS-tPA carried only small amounts (about 25%) of high-mannose and hybrid-type species and predominantly complex-type sugar chains (about 75%) which were partially incomplete and mostly devoid of fucose. Newly introduced N-glycosylation sites at Asn67 (YN-tPA) or Asn58 (GS-tPA) as well as those at Asn184 and Asn448 were solely substituted by complex-type glycans. Each carbohydrate attachment site displayed a peculiar oligosaccharide pattern with regard to branching and substitution by Gal alpha 3-residues, sulphate groups, intersecting GlcNAc and lactosamine repeats. Our study clearly demonstrates that creation of a new glycosylation site at Asn58 influenced the oligosaccharide processing and, hence, the glycosylation pattern at Asn117, whereas introduction of a new site at Asn67 did not. The relative amounts of complex-type glycans at Asn117 of GS-tPA correlated with the degree of carbohydrate substitution of Asn58. Therefore, it can be concluded that the presence of a sugar chain at the position and not the Gly to Ser mutation itself is responsible for the observed alteration of GS-tPA glycosylation.