The pathobiology and pathology of aseptic implant failure

Spinal implant wear particles: Generation, characterization, biological impacts, and future considerations

The generation of wear debris from orthopedic implants is a known cause of implant failure, particularly in joint replacements. While much research has focused on wear particles from knee and hip implants, spinal implants, such as total disc replacements (TDRs), have received less attention despite their increasing clinical use. Spinal implants face unique biomechanical challenges, including a wider range of motion and higher loads, leading to complex tissue interactions. Studies reveal that TDR wear particles, though similar in size to those from knee implants, cause a stronger immune response, with more macrophages and giant cells found in the surrounding tissue. This may explain the high revision rates seen in spinal surgeries, with some interventions failing in over 30% of cases within 10 years. The younger population undergoing spinal surgery, combined with the productivity losses associated with implant failure, underscores the need for greater understanding. This review discusses recent research on the generation, characterization, and biological impacts of spinal implant wear debris. It draws on retrieval analysis, wear simulation, in vivo models, and a survey conducted with the AO Spine Knowledge Forum Degenerative to assess current clinical practices and highlight gaps in knowledge. Additionally, this critical review explores future strategies to reduce the biological impact of wear particles and improve the safety and longevity of spinal implants through better therapeutics and design innovations. By combining literature and clinical insights, this paper aims to guide future research in addressing the complexities of spinal implant wear and its biological consequences.

Early aseptic loosening and inferior patient-reported outcomes of a cementless tibial baseplate in a modern total knee arthroplasty design

Aims

This study reports the outcome of a modern total knee arthroplasty design using a cementless tibial baseplate compared to the full-cemented version.

Methods

Consecutive cohorts with 12-month follow-up were evaluated. Patients receiving a cementless tibial baseplate were compared to those who received a cemented tibial component. Endpoints included revision rates and reason for revision, patient-reported outcome measures (PROMs) using the Oxford Knee Score (OKS), and progressive radiolucency. Retrieval analysis was performed for the revised cases. Pearson correlation analysis and multiple regression analysis were used.

Results

A total of nine knees (7%) from the cementless cohort were revised, all due to aseptic loosened baseplate at a mean follow-up of 10.4 months (3 to 19), whereas the incidence of aseptic loosening of the cemented tibial baseplate was significantly lower at 0.5% (3/534; p < 0.001). The cemented cohort PROMs outperformed the cementless baseplate group at both 12 months' follow-up and the improvement from baseline (mean OKS 40.4 (SD 6.8) vs 38.5 (SD 8.1); p = 0.006; mean ΔOKS 18.8 (SD 9.0) vs 15.5 (SD 12.8); p < 0.001). There were no significant differences between the groups in the occurrence of new radiolucency at 12 months (p = 0.325). An elevated BMI was the only factor to correlate (r = -0.195) with worse values of ΔOKS (p = 0.048) in the cementless cohort. The multiple regression analysis determined that an increased BMI was the single independent predictor for aseptic loosening (p = 0.024) for the knees with a cementless tibial baseplate. Retrieval analysis suggested failed osseointegration.

Conclusion

In our cohort, there was a significantly higher incidence of aseptic loosening and worse PROMs at one year for the cementless tibial baseplate. An increased BMI may be an independent risk factor for aseptic loosening and inferior PROMs.

A comparison of postoperative microbiological and histological test results with the indication for revision as listed at the time of surgery in the National Joint Registry: a single-centre cohort study of metal-on-metal total hip replacement and hip resurfacing revision procedures

INTRODUCTION

Surgeons allocate an indication(s) for revision surgery on NJR Minimum Data Set forms in the immediate perioperative period, when results from intraoperative histology and microbiology samples are not available. We evaluated to what extent the postoperative diagnostics obtained for patients undergoing metal-on-metal hip arthroplasty (MoMHA) revision surgery align with the indication for revision listed in the NJR.

METHODS

NJR data for MoMHA revision patients (2004-2015) at a single centre were linked to hospital records of microbiology and histology testing for prosthetic joint infection (PJI) and adverse reaction to metal debris (ARMD). The Musculoskeletal Infection Society and Mirra classifications were used as "gold standards' to classify PJI and ARMD respectively and to assess the diagnostic accuracy of the clinician selected revision indication recorded on MDS forms.

RESULTS

Of 301 cases, 5.6% (n = 17) and 3.7% (n = 11) were revised for PJI and ARMD respectively. In a further 6.6% (n = 20, PJI) and 15.6% (n = 47, ARMD) the indication for revision selected at the time of surgery did not corroborate with the test results from intraoperative samples. Diagnostic accuracy analysis revealed sensitivity and specificity of indication for surgery at the time of revision for PJI of 35.5% (95% CI, 19.2-54.6) and 97.8% (CI, 54.6-95.2) respectively, and for ARMD of 7.41% (CI, 2.06-17.9) and 97.2% (CI, 94.3-98.9) respectively.

CONCLUSIONS

We observed that the results of histology and microbiology analyses of intraoperative samples may provide evidence to support alternative diagnoses in 20% of cases. This indicates a need for a change in the work-up of these cases to allow a more accurate prediction of the indication for revision. Alternatively, if there was evidence of a difference in outcome for patients where the indication may be changed when such data becomes available, the feasibility of a facility to add additional information from samples taken intraoperatively when it becomes available should be explored.

A comparison of cemented femoral fixation via anterior versus posterior approach total hip arthroplasty: an analysis of 60,739 total hip arthroplasties

BACKGROUND

Anterior approach total hip arthroplasty (THA) decreases the rate of dislocation but increases femoral-sided complications in the way of periprosthetic fractures and component loosening. A cemented prosthesis may reduce femoral-sided complications and improve the risk:benefit profile of anterior approach THA.

METHODS

Data from the Australian National Joint Replacement Registry were analysed for patients undergoing primary THA via the anterior or posterior approach using a cemented polished femoral stem from January 2015 to December 2021. The primary outcome measure was the cumulative percent revision (CPR) for all causes and CPR for femoral component loosening and fracture. The CPR for the primary outcome measures were compared between the anterior and posterior approach and adjusted for age, sex, ASA score, BMI and femoral head size.

RESULTS

The study included 60,739 THAs with cemented stems (10,742 anterior, 49,997 posterior). The rate of revision of the anterior versus the posterior approach did not significantly differ (HR 0.87 (95% CI, 0.74-1.03), p = 0.100). Anterior approach THA had a significantly higher rate of revision for femoral component loosening (HR 5.06 [95% CI, 3.08-8.30], p < 0.001); and a decreased rate of revision for infection (HR 0.59 [95% CI, 0.43-0.81], p = 0.001) and dislocation/instability (HR 0-3 months 0.48 [95% CI, 0.27-0.83], p = 0.008; HR >3 months 0.30 [95% CI, 0.15-0.61], p < 0.001). There was no difference in the rate of revision surgery for fracture between the 2 approaches (HR 1.01 [95% CI, 0.71-1.43]), p = 0.975).

CONCLUSIONS

There is no significant difference in overall revision rates with cemented femoral fixation performed with an anterior or posterior approach. Cemented fixation performed with the anterior approach partly mitigates femoral complications with no difference in the revision rate for fracture but an increased rate of femoral component loosening.

Mild aseptic lymphocyte-dominated vasculitis-associated lesion (ALVAL)-type reactions also present in patients with failed knee prostheses

Aims

Metal particles detached from metal-on-metal hip prostheses (MoM-THA) have been shown to cause inflammation and destruction of tissues. To further explore this, we investigated the histopathology (aseptic lymphocyte-dominated vasculitis-associated lesions (ALVAL) score) and metal concentrations of the periprosthetic tissues obtained from patients who underwent revision knee arthroplasty. We also aimed to investigate whether accumulated metal debris was associated with ALVAL-type reactions in the synovium.

Methods

Periprosthetic metal concentrations in the synovia and histopathological samples were analyzed from 230 patients from our institution from October 2016 to December 2019. An ordinal regression model was calculated to investigate the effect of the accumulated metals on the histopathological reaction of the synovia.

Results

Median metal concentrations were as follows: cobalt: 0.69 μg/g (interquartile range (IQR) 0.10 to 6.10); chromium: 1.1 μg/g (IQR 0.27 to 4.10); and titanium: 1.6 μg/g (IQR 0.90 to 4.07). Moderate ALVAL scores were found in 30% (n = 39) of the revised knees. There were ten patients with an ALVAL score of 6 or more who were revised for suspected periprosthetic joint infection (PJI), aseptic loosening, or osteolysis. R2 varied between 0.269 and 0.369 for the ordinal regression models. The most important variables were model type, indication for revision, and cobalt and chromium in the ordinal regression models.

Conclusion

We found that metal particles released from the knee prosthesis can accumulate in the periprosthetic tissues. Several patients revised for suspected culture-negative PJI had features of an ALVAL reaction, which is a novel finding. Therefore, ALVAL-type reactions can also be found around knee prostheses, but they are mostly mild and less common than those found around metal-on-metal prostheses.

The activity of monocyte-derived macrophages after stimulation with platelet-rich and platelet-poor concentrates. Study on an ovine model of insertion of a tibial implant coated with silicon-doped diamond-like carbon

Introduction

Macrophages are crucial immune cells that play a role in tissue repair and can exhibit pro- or anti-inflammatory behaviour based on environmental stimulation. Their functional phenotype can be affected by platelet-derived products as determined by those products' composition. When the inflammatory response caused by implantation is excessive, it can lead to rejection of the implant. Therefore, a thorough evaluation of implant haemocompatibility is necessary to minimise undesirable consequences.

Material and Methods

In an in vitro study, monocyte-derived macrophages (MDMs) were obtained from the whole blood of sheep after a silicon-doped diamond-like carbon-coated implant insertion. These MDMs were then exposed to autologous platelet-derived products for functional marker analysis.

Results

Platelet-poor plasma (PPP) and pure platelet-rich plasma (P-PRP) stimulation increased arginase-1 activity, while leukocyte-rich PRP stimulation produced a mixed response involving higher O2- (6.49 ± 2.43 nM vs non-stimulated 3.51 ± 1.23 nM, P-value < 0.05) and NO (3.28 ± 1.38 μM vs non-stimulated 2.55 ± 0.32μM, P-value < 0.05) generation.

Conclusion

Using PPP and P-PRP stimulation in post-implantation procedures may contribute to the polarisation of macrophages towards the M2-like pro-resolving phenotype, thereby accelerating wound healing. This would also prevent implant degradation due to an excessive inflammatory process.

A Mapping Review of the Pathogenesis of Peri-Implantitis: The Biofilm-Mediated Inflammation and Bone Dysregulation (BIND) Hypothesis

This mapping review highlights the need for a new paradigm in the understanding of peri-implantitis pathogenesis. The biofilm-mediated inflammation and bone dysregulation (BIND) hypothesis is proposed, focusing on the relationship between biofilm, inflammation, and bone biology. The close interactions between immune and bone cells are discussed, with multiple stable states likely existing between clinically observable definitions of peri-implant health and peri-implantitis. The framework presented aims to explain the transition from health to disease as a staged and incremental process, where multiple factors contribute to distinct steps towards a tipping point where disease is manifested clinically. These steps might be reached in different ways in different patients and may constitute highly individualised paths. Notably, factors affecting the underlying biology are identified in the pathogenesis of peri-implantitis, highlighting that disruptions to the host-microbe homeostasis at the implant-mucosa interface may not be the sole factor. An improved understanding of disease pathogenesis will allow for intervention on multiple levels and a personalised treatment approach. Further research areas are identified, such as the use of novel biomarkers to detect changes in macrophage polarisation and activation status, and bone turnover.

Emerging factors affecting peri-implant bone metabolism

Implant dentistry has evolved to the point that standard implant osseointegration is predictable. This is attributed in part to the advancements in material sciences that have led toward improvements in implant surface technology and characteristics. Nonetheless, there remain several cases where implant therapy fails (specifically at early time points), most commonly attributed to factors affecting bone metabolism. Among these patients, smokers are known to have impaired bone metabolism and thus be subject to higher risks of early implant failure and/or late complications related to the stability of the peri-implant bone and mucosal tissues. Notably, however, emerging data have unveiled other critical factors affecting osseointegration, namely, those related to the metabolism of bone tissues. The aim of this review is to shed light on the effects of implant-related factors, like implant surface or titanium particle release; surgical-related factors, like osseodensification or implanted biomaterials; various drugs, like selective serotonin reuptake inhibitors, proton pump inhibitors, anti-hypertensives, nonsteroidal anti-inflammatory medication, and statins, and host-related factors, like smoking, diet, and metabolic syndrome on bone metabolism, and aseptic peri-implant bone loss. Despite the infectious nature of peri-implant biological complications, these factors must be surveyed for the effective prevention and management of peri-implantitis.

How Can Imbalance in Oral Microbiota and Immune Response Lead to Dental Implant Problems?

Dental implantology is one of the most dynamically developing fields of dentistry, which, despite developing clinical knowledge and new technologies, is still associated with many complications that may lead to the loss of the implant or the development of the disease, including peri-implantitis. One of the reasons for this condition may be the fact that dental implants cannot yield a proper osseointegration process due to the development of oral microbiota dysbiosis and the accompanying inflammation caused by immunological imbalance. This study aims to present current knowledge as to the impact of oral microflora dysbiosis and deregulation of the immune system on the course of failures observed in dental implantology. Evidence points to a strong correlation between these biological disturbances and implant complications, often stemming from improper osseointegration, pathogenic biofilms on implants, as well as an exacerbated inflammatory response. Technological enhancements in implant design may mitigate pathogen colonization and inflammation, underscoring implant success rates.

Bisphosphonates' use and risk of aseptic loosening following total hip arthroplasty: a systematic review

Purpose

The main indication of bisphosphonates (BPs) is osteoporosis treatment. However, there is growing interest in the peri- and postoperative use of BPs to mitigate total hip arthroplasty (THA) aseptic loosening (AL) risk. This systematic review aimed to evaluate the implant survival and the AL rate in patients with elective THA receiving BPs compared to those that do not receive BPs. Secondary outcomes included the comparison of revision rate, postoperative complications, and patients' functional scores.

Methods

This systematic review was conducted under the PRISMA 2020 guidelines with a pre-registered PROSPERO protocol. Three engines and grey literature were searched up until May 2022. Randomized and nonrandomized controlled trials and comparative cohort studies assessing BP and control therapy impact on THA survival were included.

Results

Twelve studies embraced the inclusion criteria. A total of 99 678 patients and 99 696 THAs were included; 10 025 patients received BPs (BP group), and 89 129 made up the control group. The overall revision and AL rates were lower in the BP group (2.17% and 1.85%) than in the control group (4.06% and 3.2%). Periprosthetic fracture (PPF) cases were higher in the BP group (0.24%) than in the control group (0.04%); however, the majority of PPF cases were derived from a single study. Further complication risk was similar between groups. Most studies reported comparable functional scores between groups.

Conclusion

BP treatment after elective THA seems to reduce the overall revision and AL risk. Other complications' risk and functional scores were similar between groups. Further high-quality studies are needed to validate the results due to the multifactorial AL pathogenesis.

Inflammatory, Oxidative Stress and Small Cellular Particle Response in HUVEC Induced by Debris from Endoprosthesis Processing

We studied inflammatory and oxidative stress-related parameters and cytotoxic response of human umbilical vein endothelial cells (HUVEC) to a 24 h treatment with milled particles simulating debris involved in sandblasting of orthopedic implants (OI). We used different abrasives (corundum-(Al₂O₃), used corundum retrieved from removed OI (u. Al₂O₃), and zirconia/silica composite (ZrO₂/SiO₂)). Morphological changes were observed by scanning electron microscopy (SEM). Concentration of Interleukins IL-6 and IL-1β and Tumor Necrosis Factor α (TNF)-α was assessed by enzyme-linked immunosorbent assay (ELISA). Activity of Cholinesterase (ChE) and Glutathione S-transferase (GST) was measured by spectrophotometry. Reactive oxygen species (ROS), lipid droplets (LD) and apoptosis were measured by flow cytometry (FCM). Detachment of the cells from glass and budding of the cell membrane did not differ in the treated and untreated control cells. Increased concentration of IL-1β and of IL-6 was found after treatment with all tested particle types, indicating inflammatory response of the treated cells. Increased ChE activity was found after treatment with u. Al₂O₃ and ZrO₂/SiO₂. Increased GST activity was found after treatment with ZrO₂/SiO₂. Increased LD quantity but not ROS quantity was found after treatment with u. Al₂O₃. No cytotoxicity was detected after treatment with u. Al₂O₃. The tested materials in concentrations added to in vitro cell lines were found non-toxic but bioactive and therefore prone to induce a response of the human body to OI.

Barium sulphate microparticles are taken up by three different cell types: HeLa, THP-1, and hMSC

Cytotoxicity and cellular uptake of spherical barium sulphate microparticles (diameter 1 µm) were studied with three different cell lines, i.e. THP-1 cells (monocytes; model for a phagocytosing cell line), HeLa cells (epithelial cells; model for a non-phagocytosing cell line), and human mesenchymal stem cells (hMSCs; model for non-phagocytosing primary cells). Barium sulphate is a chemically and biologically inert solid which allows to distinguish two different processes, e.g. the particle uptake and potential adverse biological reactions. Barium sulphate microparticles were surface-coated by carboxymethylcellulose (CMC) which gave the particles a negative charge. Fluorescence was added by conjugating 6-aminofluorescein to CMC. The cytotoxicity of these microparticles was studied by the MTT test and a live/dead assay. The uptake was visualized by confocal laser scanning microscopy (CLSM) and scanning electron microscopy (SEM). The particle uptake mechanism was quantified by flow cytometry with different endocytosis inhibitors in THP-1 and HeLa cells. The microparticles were easily taken up by all cell types, mostly by phagocytosis and micropinocytosis, within a few hours. STATEMENT OF SIGNIFICANCE: The interaction of particles and cells is of primary importance in nanomedicine, drug delivery, and nanotoxicology. It is commonly assumed that cells take up only nanoparticles unless they are able to phagocytosis. Here, we demonstrate with chemically and biologically inert microparticles of barium sulphate that even non-phagocytosing cells like HeLa and hMSCs take up microparticles to a considerable degree. This has considerable implication in biomaterials science, e.g. in case of abrasive debris and particulate degradation products from implants like endoprostheses.

Exuberant Rice Body Formation Associated with Adverse Local Tissue Reaction After Hip Resurfacing Arthroplasty: A Case Report and Review of the Literature

CASE

A 65-year-old man with osteoarthritis of the hip developed a soft-tissue mass of the inferior gluteal region 3 years after metal-on-metal resurfacing hip arthroplasty. Clinical and imaging findings suggested an adverse local tissue reaction. Intraoperatively, nearly 1 liter of intra-articular fibrinous loose bodies (rice bodies) was removed, and histology showed features of an adaptive immune response. The patient had no evidence of an autoimmune disease or mycobacterial infection.

CONCLUSION

To our knowledge, this is the first reported case of florid rice bodies associated with a metal-on-metal hip arthroplasty and adverse local tissue reaction.

Bone and Soft Tissue Reaction to Co(II)/Cr(III) Ions Stimulation in a Murine Calvaria Model: A Pioneering in vivo Study

Metal ions released during wear and corrosion of the artificial knee/hip joints are considered to contribute to aseptic implant failure. However, there are few convincing in vivo studies that demonstrate the effects of metal ions on bone and soft tissue. This study examined the in vivo effects of Co(II)/Cr(III) ions on mouse calvaria and the supra-calvaria soft tissue in an original mouse model. With the implantation of a helmet-like structure, we set up a subcutaneous cavity on the calvaria in which Co(II) Chloride or Cr(III) Chloride solutions were administered respectively. A layer of interface membrane formed on the calvaria along with the implantation of the helmet. The administered Cr(III) ions accumulated in the interface membranes while Co(II) disseminated into the circulation. Accumulated Cr(III) and related products induced local massive macrophage infiltration and skewed the bone metabolic balance. At last, we revealed that lymphocyte aggregates, which are the pathologic hallmark of human periprosthetic tissue, could be caused by either Co(II) or Cr(III) stimulation. These in vivo results may shed light on the effects and pathogenic mechanism of the Co(II)/Cr(III) ions released from the joint prosthesis. STATEMENT OF SIGNIFICANCE: Macrophage infiltration and lymphocyte aggregates are hallmarks of human joint periprosthetic tissue. We chronically administered Co(II)/Cr(III) ions on mouse calvaria and reproduced these two histopathologic hallmarks on mouse tissue based on an implanted helmet-like structure. Our results reveal that Cr(III) ions are locally accumulated and are effective in inducing macrophage infiltration and they can be phagocytosed and stored. However, the lymphocytes aggregates could be induced by both Co(II), Cr(III) and other unspecific inflammatory stimuli.

CoNiCrMo Particles, but Not TiAlV Particles, Activate the NLRP3 Inflammasome in Periprosthetic Cells

Aseptic loosening is the main reason for arthroplasty failure. The wear particles generated at the tribological bearings are thought to induce an inflammatory tissue response, leading to bone loss and the subsequent loosening of the implant. Different wear particles have been shown to activate the inflammasome, thereby contributing to an inflammatory milieu in the direct vicinity of the implant. The aim of this study was to investigate whether the NLRP3 inflammasome is activated by different metal particles in vitro and in vivo. Three different cell lines representing periprosthetic cell subsets (MM6, MG63 and Jurkat) were incubated with different amounts of TiAlV or CoNiCrMo particles. The activation of the NLRP3 inflammasome was determined through the detection of the caspase 1 cleavage product p20 in a Western blot. The formation of the inflammasome was also investigated in vivo using immunohistological staining for ASC in primary synovial tissues as well as tissues containing TiAlV and CoCrMo particles and in vitro after the stimulation of the cells. The results show that the CoCrMo particles induced ASC more markedly, as a readout for inflammasome formation in vivo, compared to TiAlV particular wear. The CoNiCrMo particles also induced ASC-speck formation in all the tested cell lines, which was not induced by the TiAlV particles. The Western blot shows that NRLP3 inflammasome activation, measured through caspase 1 cleavage, was increased only by the CoNiCrMo particles in the MG63 cells. We conclude from our data that the activation of the inflammasome is mainly driven by CoNiCrMo particles and less by TiAlV particles, indicating that different inflammatory pathways are activated by the different alloys.

Profiling the Immune Response to Periprosthetic Joint Infection and Non-Infectious Arthroplasty Failure

Arthroplasty failure is a major complication of joint replacement surgery. It can be caused by periprosthetic joint infection (PJI) or non-infectious etiologies, and often requires surgical intervention and (in select scenarios) resection and reimplantation of implanted devices. Fast and accurate diagnosis of PJI and non-infectious arthroplasty failure (NIAF) is critical to direct medical and surgical treatment; differentiation of PJI from NIAF may, however, be unclear in some cases. Traditional culture, nucleic acid amplification tests, metagenomic, and metatranscriptomic techniques for microbial detection have had success in differentiating the two entities, although microbiologically negative apparent PJI remains a challenge. Single host biomarkers or, alternatively, more advanced immune response profiling-based approaches may be applied to differentiate PJI from NIAF, overcoming limitations of microbial-based detection methods and possibly, especially with newer approaches, augmenting them. In this review, current approaches to arthroplasty failure diagnosis are briefly overviewed, followed by a review of host-based approaches for differentiation of PJI from NIAF, including exciting futuristic combinational multi-omics methodologies that may both detect pathogens and assess biological responses, illuminating causes of arthroplasty failure.

Sonicate Fluid Cellularity Predicted by Transcriptomic Deconvolution Differentiates Infectious from Non-Infectious Arthroplasty Failure

BACKGROUND

Although cellularity is traditionally assessed morphologically, deep sequencing approaches being used for microorganism detection may be able to provide information about cellularity. We hypothesized that cellularity predicted using CIBERSORTx (Stanford University), a transcriptomic-based cellular deconvolution tool, would differentiate between infectious and non-infectious arthroplasty failure.

METHODS

CIBERSORTx-derived cellularity profiles of 93 sonicate fluid samples, including 53 from subjects who underwent failed arthroplasties due to periprosthetic joint infection (PJI) (abbreviated for the purpose of this study as PJIF) and 40 from subjects who had undergone non-infectious arthroplasty failure (abbreviated NIAF) that had been subjected to bulk RNA sequencing were evaluated.

RESULTS

Samples from PJIF and NIAF subjects were differentially clustered by principal component analysis based on the cellularity profile. Twelve of the 22 individual predicted cellular fractions were differentially expressed in the PJIF cases compared with the NIAF cases, including increased predicted neutrophils (mean and standard error, 9.73% ± 1.06% and 0.81% ± 0.60%), activated mast cells (17.12% ± 1.51% and 4.11% ± 0.44%), and eosinophils (1.96% ± 0.37% and 0.42% ± 0.21%), and decreased predicted M0 macrophages (21.33% ± 1.51% and 39.75% ± 2.45%), M2 macrophages (3.56% ± 0.52% and 8.70% ± 1.08%), and regulatory T cells (1.57% ± 0.23% and 3.20% ± 0.34%). The predicted total granulocyte fraction was elevated in the PJIF cases (32.97% ± 2.13% and 11.76% ± 1.61%), and the samples from the NIAF cases had elevated predicted total macrophage and monocyte (34.71% ± 1.71% and 55.34% ± 2.37%) and total B cell fractions (5.89% ± 0.30% and 8.62% ± 0.86%). Receiver operating characteristic curve analysis identified predicted total granulocytes, neutrophils, and activated mast cells as highly able to differentiate between the PJIF cases and the NIAF cases. Within the PJIF cases, the total granulocyte, total macrophage and monocyte, M0 macrophage, and M2 macrophage fractions were differentially expressed in Staphylococcus aureus compared with Staphylococcus epidermidis -associated samples. Within the NIAF cases, the predicted total B cell, naïve B cell, plasma cell, and M2 macrophage fractions were differentially expressed among different causes of failure.

CONCLUSIONS

CIBERSORTx can predict the cellularity of sonicate fluid using transcriptomic data, allowing for the evaluation of the underlying immune response during the PJIF and NIAF cases, without a need to phenotypically assess cell composition.

On Peri-Implant Bone Loss Theories: Trying To Piece Together the Jigsaw

This review aims to explore the plausibility of new theories on the etiopathogenesis of marginal bone loss (MBL) and peri-implantitis (PI) and to discuss possible underlying pathogenic mechanisms. The former concept of osteointegration of dental implants can now be conceptualized as a foreign body response histologically characterized by a bony demarcation in combination with chronic inflammation. Different risk factors can provoke additional inflammation and, therefore, pro-inflammatory cytokine release in soft tissues and bone, leading to an overpass of the threshold of peri-implant bone defensive and regenerative capacity. Progressive bone loss observed in MBL and PI is ultimately due to a localized imbalance in the receptor activator of nuclear factor kappaB ligand (RANKL)/Receptor activator of nuclear factor κ B (RANK)/osteoprotegerin (OPG) pathway in favor of increased catabolic activity. The genetic background and the severity and duration of the risk factors could explain differences between individuals in the threshold needed to reach an imbalanced scenario. MBL and PI pathogenesis could be better explained by the "inflammation-immunological balance" theory rather than a solely "infectious disease" conception. The link between the effect of biofilm and other risk factors leading to an imbalanced foreign body response lies in osteoclast differentiation and activation pathways (over)stimulation.

Periarticular metal hypersensitivity complications of hip bearings containing cobalt-chromium

Hip joints with bearings composed of cobalt-chromium alloy (metal-on-metal bearings) have been one of the most widely used implants in joint replacement arthroplasty. Unfortunately, these implants can contribute to a complication called aseptic lymphocyte-dominated vasculitis-associated lesion (ALVAL), a type IV metal hypersensitivity response around the joint. Consistent with such bearings, increased metal debris can be found in the surrounding fluids and in remote tissues and organs, due to wear and corrosion. It is hypothesized that metal ions released from the prosthesis (including Co2+) can potentially form haptens with proteins such as serum albumin in synovial fluid that in turn elicit ALVAL. Generally, elevated cobalt and chromium levels in synovial fluids may indicate implant failure. However, such measurements cannot be used as a reliable tool to predict the onset of ALVAL. To detect ALVAL, some diagnostic tests, questionnaires and imaging techniques have been used clinically with some success, but a standardized approach is lacking. At present, guidelines for implant usage and patient management are ambiguous and inconsistent across health care authorities. To reduce and better manage the development of ALVAL, further research into the precise molecular mechanism(s) by which ALVAL develops is urgently needed. Identification of diagnostic and prognostic biomarkers for ALVAL is required, as are more standardized guidelines for surgery and patient management.

Innate Immune Response in Orthopedic Implant Failure

The total joint replacement is recognized as one of the most effective medical arbitrations leading to increased mobility, pain relief, and an overall restored function of the joint. Unfortunately, prosthetic debris accumulates after long-term wear of the implant leading to activation of the innate immune response and periprosthetic osteolysis. Understanding the intricate biological mechanisms underlying the innate immune response to implant debris would support the development of novel pharmacological treatments to prolong the life span of the implant. This article provides a detailed description on the role of the innate immune system in response to implant debris, emphasizing the most recent research and outstanding questions. Furthermore, a critical discussion is presented on the novel pharmacological treatments currently under investigation to prevent implant failure.

A 92 protein inflammation panel performed on sonicate fluid differentiates periprosthetic joint infection from non-infectious causes of arthroplasty failure

Periprosthetic joint infection (PJI) is a major complication of total joint arthroplasty, typically necessitating surgical intervention and prolonged antimicrobial therapy. Currently, there is no perfect assay for PJI diagnosis. Proteomic profiling of sonicate fluid has the potential to differentiate PJI from non-infectious arthroplasty failure (NIAF) and possibly clinical subsets of PJI and/or NIAF. In this study, 200 sonicate fluid samples, including 90 from subjects with NIAF (23 aseptic loosening, 35 instability, 10 stiffness, five osteolysis, and 17 other) and 110 from subjects with PJI (40 Staphylococcus aureus, 40 Staphylococcus epidermidis, 10 Staphylococcus lugdunensis, 10 Streptococcus agalactiae, and 10 Enterococcus faecalis) were analyzed by proximity extension assay using the 92 protein Inflammation Panel from Olink Proteomics. Thirty-seven of the 92 proteins examined, including CCL20, OSM, EN-RAGE, IL8, and IL6, were differentially expressed in PJI versus NIAF sonicate fluid samples, with none of the 92 proteins differentially expressed between staphylococcal versus non-staphylococcal PJI, nor between the different types of NIAF studied. IL-17A and CCL11 were differentially expressed between PJI caused by different bacterial species, with IL-17A detected at higher levels in S. aureus compared to S. epidermidis and S. lugdunensis PJI, and CCL11 detected at higher levels in S. epidermidis compared to S. aureus and S. agalactiae PJI. Receiver operative characteristic curve analysis identified individual proteins and combinations of proteins that could differentiate PJI from NIAF. Overall, proteomic profiling using this small protein panel was able to differentiate between PJI and NIAF sonicate samples and provide a better understanding of the immune response during arthroplasty failure.

Biodegradable interbody cages for lumbar spine fusion: Current concepts and future directions

Lumbar fusion often remains the last treatment option for various acute and chronic spinal conditions, including infectious and degenerative diseases. Placement of a cage in the intervertebral space has become a routine clinical treatment for spinal fusion surgery to provide sufficient biomechanical stability, which is required to achieve bony ingrowth of the implant. Routinely used cages for clinical application are made of titanium (Ti) or polyetheretherketone (PEEK). Ti has been used since the 1980s; however, its shortcomings, such as impaired radiographical opacity and higher elastic modulus compared to bone, have led to the development of PEEK cages, which are associated with reduced stress shielding as well as no radiographical artefacts. Since PEEK is bioinert, its osteointegration capacity is limited, which in turn enhances fibrotic tissue formation and peri-implant infections. To address shortcomings of both of these biomaterials, interdisciplinary teams have developed biodegradable cages. Rooted in promising preclinical large animal studies, a hollow cylindrical cage (Hydrosorb™) made of 70:30 poly-l-lactide-co-d, l-lactide acid (PLDLLA) was clinically studied. However, reduced bony integration and unfavourable long-term clinical outcomes prohibited its routine clinical application. More recently, scaffold-guided bone regeneration (SGBR) with application of highly porous biodegradable constructs is emerging. Advancements in additive manufacturing technology now allow the cage designs that match requirements, such as stiffness of surrounding tissues, while providing long-term biomechanical stability. A favourable clinical outcome has been observed in the treatment of various bone defects, particularly for 3D-printed composite scaffolds made of medical-grade polycaprolactone (mPCL) in combination with a ceramic filler material. Therefore, advanced cage design made of mPCL and ceramic may also carry initial high spinal forces up to the time of bony fusion and subsequently resorb without clinical side effects. Furthermore, surface modification of implants is an effective approach to simultaneously reduce microbial infection and improve tissue integration. We present a design concept for a scaffold surface which result in osteoconductive and antimicrobial properties that have the potential to achieve higher rates of fusion and less clinical complications. In this review, we explore the preclinical and clinical studies which used bioresorbable cages. Furthermore, we critically discuss the need for a cutting-edge research program that includes comprehensive preclinical in vitro and in vivo studies to enable successful translation from bench to bedside. We develop such a conceptual framework by examining the state-of-the-art literature and posing the questions that will guide this field in the coming years.

Mesoporous Silk-Bioactive Glass Nanocomposites as Drug Eluting Multifunctional Conformal Coatings for Improving Osseointegration and Bactericidal Properties of Metal Implants

Endowing metal implants with multifunctional traits to prevent implant-associated infections and improve osseointegration has become a pivotal facet in orthopedics and dental fixation. Herein, we report the synthesis of mesoporous 70S bioactive glass-silk fibroin nanocomposites inspired by the biomimetic organo-apatites of mineralized collagen. The mesoporous, biomimetic nanocomposites enabled loading of antibiotics (gentamicin and doxycycline) and favored their release in a rapid manner while preserving their bioactivity. Ease in modification of the mesoporous nanocomposites enabled tailoring of 3-(aminopropyl)-triethoxysilane to the silanol network of bioactive glass, which improved the loading capacity of the hydrophobic drug (dexamethasone). The modification favored the slow and sustained release of dexamethasone from the modified mesoporous nanocomposites, which is desired for mediating osteogenesis and immunomodulation. Conformal coatings of these drug-loaded nanocomposites were materialized on stainless-steel implants through a facile electrophoretic deposition (EPD) technique, wherein the deposition yield can be controlled by applied parameters. Antibiotic coatings exhibited antibacterial efficacy with bioactivity retained up to 28 days, while dexamethasone-loaded coatings favored mesenchymal stem cell adhesion and osteoinduction. The immunomodulatory roles were also ascertained, wherein M2 macrophage biasness was favored in dexamethasone-loaded coatings. The versatility of these mesoporous biomimetic nanocomposites guarantee the loading of scenario-specific drugs to aid their local delivery through the conformal EPD coatings developed over metal implants toward improving implant patency.

Backside polyethylene wear in reverse shoulder arthroplasty

BACKGROUND

Aseptic loosening from implant-associated osteolysis in reverse shoulder arthroplasty (RSA) may contribute to premature implant failure. Although articular side polyethylene (PE) damage has been well documented in the literature, no studies to date have investigated backside wear in RSA. The aims of this investigation were to (1) document and compare the damage between the backside and articular surface in explanted RSA components, (2) assess whether certain quadrants have a greater propensity for damage, and (3) report the most common mode(s) of backside PE damage.

METHODS

Twenty-one RSA humeral liners retrieved during revision procedures between 2005 and 2014 were included for analysis. The mean time between implantation and extraction was 16 months (10 days-88 months). Diagnoses at the time of revision included dislocation (10), infection (4), mechanical failure (3), loosening (2), and unknown (2). Liners were examined under light microscopy (×10-30 magnification) and damage on the articular and backside of the liner surface was graded using the modified Hood score. The location and damage modality were compared between the articular side and backside of the implant.

RESULTS

Damage was noted on the articular surfaces of all 21 liners and on the backside surface of 20 liners. The total damage in all the quadrants was higher on the articular surface than on the backside of the component, with a mean difference in total quadrant damage scores of 11.74 ± 3.53 (P < .001). There was no difference in damage among the quadrants on the backside (P = .44) or the articular surface (P = .08). The articular side exhibited greater scratching, abrasion, and surface deformation than the backside (P < .001).

CONCLUSIONS

This short-term retrieval study demonstrated that backside PE damage occurs on the humeral component of RSA implants. There was greater damage to the articular side of the liner but wear to the backside was present in almost all liners. The clinical importance of backside wear in RSA and its overall contribution to PE particulate disease and osteolysis needs further investigation.

Inflammatory tissue reactions around aseptically loose cemented hip prostheses: A retrieval study of the Spectron EF stem with Reflection All-Poly acetabular cup

The cemented Spectron EF stem in combination with the cemented non‐crosslinked Reflection All‐Poly cup showed a high rate of mid‐term aseptic loosening. However, the failure mechanisms are not fully known. We assessed the inflammatory tissue reactions and wear particles in periprosthetic tissues, implant wear and blood metal ion levels in 28 patients with failed implants. Histological analysis showed a macrophage pre‐dominant pattern with randomly distributed lymphocytes, with various amounts of neutrophils and giant cells. The number of different cell types in the tissue samples from patients in the cup group and in the stem group was similar. Wear particles, mainly ZrO₂, CoCrMo, and polyethylene particles of different sizes and shapes, were associated with macrophages/giant cells, and total particle load/mm² was higher in cases of stem loosening. The Spectron EF stems were heavily worn, abraded, and polished. Stem abrasion correlated with metal ion concentrations in blood. The median polyethylene wear rate of the Reflection cups was 0.23 mm/year. The high proximal roughness of the Spectron EF stem resulted in excessive cement wear during loosening. The resulting inflammatory tissue responses to the degradation products both from the cup and the stem led to massive osteolysis and subsequent implant loosening.

Additive Effect of Parathyroid Hormone and Zoledronate Acid on Prevention Particle Wears-Induced Implant Loosening by Promoting Periprosthetic Bone Architecture and Strength in an Ovariectomized Rat Model

Implant-generated particle wears are considered as the major cause for the induction of implant loosening, which is more susceptible to patients with osteoporosis. Monotherapy with parathyroid hormone (PTH) or zoledronate acid (ZOL) has been proven efficient for preventing early-stage periprosthetic osteolysis, while the combination therapy with PTH and ZOL has exerted beneficial effects on the treatment of posterior lumbar vertebral fusion and disuse osteopenia. However, PTH and ZOL still have not been licensed for the treatment of implant loosening to date clinically. In this study, we have explored the effect of single or combined administration with PTH and ZOL on implant loosening in a rat model of osteoporosis. After 12 weeks of ovariectomized surgery, a femoral particle-induced periprosthetic osteolysis model was established. Vehicle, PTH (5 days per week), ZOL (100 mg/kg per week), or combination therapy was utilized for another 6 weeks before sacrifice, followed by micro-CT, histology, mechanical testing, and bone turnover examination. PTH monotherapy or combined PTH with ZOL exerted a protective effect on maintaining implant stability by elevating periprosthetic bone mass and inhibiting pseudomembrane formation. Moreover, an additive effect was observed when combining PTH with ZOL, resulting in better fixation strength, higher periprosthetic bone mass, and less pseudomembrane than PTH monotherapy. Taken together, our results suggested that a combination therapy of PTH and ZOL might be a promising approach for the intervention of early-stage implant loosening in patients with osteoporosis.

Long-term Interactions of Circulating Neutrophils with Titanium Implants, the Role of Platelets in Regulation of Leukocyte Function

Despite the fact that different biomaterials are widely used in many biomedical applications, they can still cause side effects. Therefore, our aim was to assess neutrophil activity during the inflammatory phase of the repair process and long-term interactions between circulating neutrophils and Titanium (Ti) implants. Additionally, neutrophil in vitro response after stimulation by the extract of antimicrobial peptides (AMP extract), pentoxifylline (PTX) and some platelet-rich (L-PRP and PURE PRP) and platelet-poor (PPP) concentrates were tested. The study was conducted on eight sheep after Ti implant insertion into the tibia and revealed that the Ti implant did not cause any side effects during the course of experiment. After addition of L-PRP into neutrophils, culture activity of these cells significantly increased (p < 0.01), whereas treatment with AMP extract, PURE PRP, PPP or PTX caused decrease in neutrophil enzymatic response (on the basis of elastase, myeloperoxidase and alkaline phosphatase release) and free radical generation. These effects were observed in neutrophils isolated during the inflammatory phase as well as 4 and 10 months after implantation. Obtained results will be useful in regulation of inflammatory response during implantation of biomaterial and create possibility to modulate the cells response towards pro- or anti-inflammatory to reduce host tissue damage.

The Expression Levels of Toll-like Receptors after Metallic Particle and Ion Exposition in the Synovium of a Murine Model

To date, the exact role of specific Toll-like receptors (TLRs) in regulating immune reactivity to metallic byproducts of orthopedic implants has not been fully clarified. In light of the situation, our objective in this investigation was to assess the expression levels of surface TLRs after metallic particle and ion exposure in an established animal model. Ten female BALB/c mice in each group received intra-articular injections of phosphate buffer (PBS) (control), metallic particles (MP), and metallic ions (MI), respectively. Seven days later, immunohistochemical staining was undertaken in the synovial layer of the murine knee joints using anti-TLR 1, 2, 4, 5, and 6 polyclonal antibodies. In addition to increased cellular infiltrates and a hyperplastic synovial membrane, the MP group showed significantly elevated TLR expression compared to the control group and had higher TLR 1-, 4-, and 6-positive cells than the MI group (p < 0.0167). TLR 4- and TLR 6-positive cells were significantly augmented for the MI group compared to the control group (p < 0.0167). Additionally, greenish corrosion particles found in the necrotic tissue suggested that metallic particles might release a certain level of locally toxic metallic ions in vivo.

Regulation of neuropeptide Y in body microenvironments and its potential application in therapies: a review

Neuropeptide Y (NPY), one of the most abundant neuropeptides in the body, is widely expressed in the central and peripheral nervous systems and acts on the cardiovascular, digestive, endocrine, and nervous systems. NPY affects the nutritional and inflammatory microenvironments through its interaction with immune cells, brain-derived trophic factor (BDNF), and angiogenesis promotion to maintain body homeostasis. Additionally, NPY has great potential for therapeutic applications against various diseases, especially as an adjuvant therapy for stem cells. In this review, we discuss the research progress regarding NPY, as well as the current evidence for the regulation of NPY in each microenvironment, and provide prospects for further research on related diseases.

Wear and damage in retrieved humeral inlays of reverse total shoulder arthroplasty-where, how much, and why?

BACKGROUND

Polyethylene (PE) wear and material degradation have been reported as complications in reverse total shoulder replacements (rTSAs). In this regard, scapular notching is associated with more clinical complications. Therefore, the purposes of the study were to quantify the linear and volumetric wear, as a measure for the amount of removed material, and to qualitatively assess the PE damage modes to describe the material degradation in retrieved rTSA humeral PE inlays that contribute to failure of shoulder replacements. Furthermore, this study aimed to evaluate the effect of scapular notching on PE wear and rim damage of the humeral components.

METHODS

The total study population of 39 humeral inlays contains 2 cohorts that were used for the damage mode analysis and for the wear analysis, respectively. The extent and presence of wear damage modes in 5 defined zones were assessed by a grading system for all PE joint replacements. For quantitative wear analysis the most frequent design (n = 17) was chosen. Using a coordinate-measuring machine and postprocessing software, volumetric wear measurements for the retrieved humeral PE inlays were undertaken. Furthermore, prerevision radiographs were analyzed for scapular notching. Finally, retrieval findings were correlated with clinical and radiographic data to consider the effect of notching and to identify risk of failures for these prostheses.

RESULTS

Damage on the rim of the humeral PE inlays was more frequent and severe than on the intended articulation surface. Irrespective of the damage mode, the inferior rim zone sustained the greatest amount of wear damage followed by the posterior zone. Burnishing, scratching, pitting, and embedded particles are most likely to occur in the articular surface area, whereas surface deformation, abrasion, delamination and gross material degradation are predominantly present in the inferior and posterior rim zones. The retrieved inlays exhibited a mean volumetric wear rate of 296.9 mm³/yr ± 87.0 mm³/yr. However, if the notched and non-notched components were compared, a significant higher volumetric wear rate (296.5 ± 106.1 mm³/yr) was found for the notched components compared to the non-notched group (65.7 ± 7.4 mm³/yr). Generally, there was a significantly greater incidence of damage and greater amount of wear if scapular notching occurred.

CONCLUSION

The notched components showed a 5-fold increase in PE wear rate. Therefore, scapular notching has a strong effect on PE damage and wear. If scapular notching can be clinically avoided, the PE wear performance is in a similar magnitude as found for hip and knee replacements.

Curculigoside Protects against Titanium Particle-Induced Osteolysis through the Enhancement of Osteoblast Differentiation and Reduction of Osteoclast Formation

Wear particle-induced periprosthetic osteolysis is mainly responsible for joint replacement failure and revision surgery. Curculigoside is reported to have bone-protective potential, but whether curculigoside attenuates wear particle-induced osteolysis remains unclear. In this study, titanium particles (Ti) were used to stimulate osteoblastic MC3T3-E1 cells in the presence or absence of curculigoside, to determine their effect on osteoblast differentiation. Rat osteoclastic bone marrow stromal cells (BMSCs) were cocultured with Ti in the presence or absence of curculigoside, to evaluate its effect on osteoclast formation in vitro. Ti was also used to stimulate mouse calvaria to induce an osteolysis model, and curculigoside was administrated to evaluate its effect in the osteolysis model by micro-CT imaging and histopathological analyses. As the results indicated, in MC3T3-E1 cells, curculigoside treatment attenuated the Ti-induced inhibition on cell differentiation and apoptosis, increased alkaline phosphatase activity (ALP) and cell mineralization, and inhibited TNF-α, IL-1β, and IL-6 production and ROS generation. In BMSCs, curculigoside treatment suppressed the Ti-induced cell formation and suppressed the TNF-α, IL-1β, and IL-6 production and F-actin ring formation. In vivo, curculigoside attenuated Ti-induced bone loss and histological damage in murine calvaria. Curculigoside treatment also reversed the RANK/RANKL/OPG and NF-κB signaling pathways, by suppressing the RANKL and NF-κB expression, while activating the OPG expression. Our study demonstrated that curculigoside treatment was able to attenuate wear particle-induced periprosthetic osteolysis in in vivo and in vitro experiments, promoted osteoblastic MC3T3-E1 cell differentiation, and inhibited osteoclast BMSC formation. It suggests that curculigoside may be a potential pharmaceutical agent for wear particle-stimulated osteolysis therapy.

The rationale behind implant coatings to promote osteointegration, bone healing or regeneration

Implant loosening, bone healing failure, implant-associated infections, and large bony defects remain challenges in orthopedic surgery. Implant surface modifications and coatings are being developed to promote osteointegration, prevent colonization by bacteria, and release bioactive factors. The following mini-review briefly discusses the clinical problem, explains the four "osteos", presents examples of coatings used for different orthopedic indications, and finally raises awareness of the coating and translational requirements.

Large Soft-tissue Mass Formation After Revision Total Knee Arthroplasty: An Unusual Case of Adverse Reaction to Metal Debris and Review of the Literature

We report about the rare case of a patient who developed large soft-tissue mass formations related with revision total knee arthroplasty which was implanted 4 years prior. Owing to suspected periprosthetic joint infection, the prosthesis was removed and the lesions were resected, resulting in severe soft-tissue loss and temporary arthrodesis using a poly(methyl methacrylate) spacer. Histological analysis revealed a type VI periprosthetic membrane. The situation was further complicated by wound infection requiring multiple revision surgeries. After discussion and evaluation of the available treatment options, the decision for an above-the-knee amputation was made. The tissue reaction resulting in these soft-tissue lesions is referred to as an "adverse local tissue reaction." Wear-induced lesions after total knee arthroplasty, especially of this magnitude, are very rare and difficult to treat.

Immunological Aspects of Dental Implant Rejection

Nowadays, dental implants are a prominent therapeutic approach among dentists for replacing missing teeth. Failure in dental implants is a severe challenge recently. The factors which lead to dental implant failure are known. These factors can be categorized into different groups. In this article, we discussed the immunological aspects of implant failure as one of these groups. Cytokines and immune cells have extensive and various functions in peri-implantitis. The equilibrium between pro and anti-inflammatory cytokines and cells, which involve in this orchestra, has a crucial role in implant prognosis. In conclusion, immune cells, especially macrophages and dendritic cells, almost increased in the patients with implant failure. Also, proinflammatory cytokines were proposed as diagnostic factors according to their higher levels in dental implant rejection.

Role of the Hippo-YAP/NF-κB signaling pathway crosstalk in regulating biological behaviors of macrophages under titanium ion exposure

The presence of metal ions, such as titanium (Ti) ions, is toxic to adjacent tissues of implants. Indeed, Ti ions may induce an inflammatory response through the NF-κB pathway, thus causing damage to soft and hard tissues. The involvement of Yes-associated protein (YAP), a key factor of the Hippo pathway, in an immuno-inflammatory response has been confirmed, whereas its role in Ti ion-mediated inflammation has not been elucidated. Therefore, this study aimed to investigate the role of signal crosstalk between the Hippo/YAP and NF-κB signaling pathways in the pro-inflammatory effect of Ti ions on macrophages. In our work, RAW264.7 cells were cocultured with Ti ions. The migration capacity of macrophages under Ti ion exposure was measured by transwell assay. Western blot analysis was used to detect the expressions of related proteins. Polymerase chain reaction was used to evaluate the expression of pro-inflammatory cytokines. The nucleus translocation of YAP and P65 was visualized and analyzed via immunofluorescence staining. The results showed that the migration of macrophages was promoted under Ti ion exposure. Ten parts per million Ti ions induced nuclear expression of YAP and activated the NF-κB pathway, which finally upregulated the expression of pro-inflammatory cytokines in macrophages. Moreover, the inhibition of the NF-κB pathway rescued the reduction of YAP expression under Ti ion exposure. Most importantly, the overexpression of YAP exacerbated the inflammatory response mediated by Ti ions through the NF-κB pathway. In summary, this study explored the mechanism of Hippo-YAP/NF-κB pathway crosstalk involved in the regulation of macrophage behaviors under Ti ion exposure.

Retention of metals in periprosthetic tissues of patients with metal-on-metal total hip arthroplasty is reflected in the synovial fluid to blood cobalt transfer ratio in the presence of a pseudotumour

Background

Modern metal-on-metal (MOM) arthroplasties were performed for over a decade before alarming reports of adverse metal reactions dramatically reduced their use. Failures are seen more often with high-wearing implants, but also well-positioned components with more favourable wear patterns can cause problems. There are no specific clinical indicators that could help us to predict the prognosis of these implants. For this reason, we still need more information on the effect of underlying factors that contribute to this process.

Methods

In this prospective cohort study, we investigated how cup orientation and type of pseudotumour determined by the Hart classification effect the distribution of metals in blood, synovial fluid and tissues surrounding the metal-on-metal hip prosthesis in revision surgery patients. One thousand two hundred twenty-nine metal-on-metal hip patients were screened and of those, 60 patients that had a revision surgery due to adverse metal reaction were included. Whole blood, synovial fluid and synovial/pseudotumour tissue samples were analysed for metal ion concentrations (Co, Cr, Mo and Ti).

Results

The lowest metal concentrations were found when both cup anteversion and inclination were optimal, and the highest when both were suboptimal. Suboptimal anteversion alone raised Cr-ion concentrations more than suboptimal inclination. The concentrations of metals in blood, synovial fluid or synovial soft tissue were the same in patients with and without a pseudotumour, but the relative transfer percentage of cobalt from synovial fluid to blood was higher in patients with a pseudotumour.

Conclusions

The implant orientation alone does not explain the metal concentrations found in tissues or distribution of metals between different tissues. The accumulation of metals in periprosthetic soft tissues increase the total metal load, and in the presence of a pseudotumour this is reflected in the transfer ratio of Co from synovial fluid to the blood. The total metal load of the pseudotumour tissue should be defined in future studies to determine if this will provide new insights for clinical practice.

Activation of synovial fibroblasts from patients at revision of their metal-on-metal total hip arthroplasty

Background

The toxicity of released metallic particles generated in metal-on-metal (MoM) total hip arthroplasty (THA) using cobalt chromium (CoCr) has raised concerns regarding their safety amongst both surgeons and the public. Soft tissue changes such as pseudotumours and metallosis have been widely observed following the use of these implants, which release metallic by-products due to both wear and corrosion. Although activated fibroblasts, the dominant cell type in soft tissues, have been linked to many diseases, the role of synovial fibroblasts in the adverse reactions caused by CoCr implants remains unknown. To investigate the influence of implants manufactured from CoCr, the periprosthetic synovial tissues and synovial fibroblasts from patients with failed MoM THA, undergoing a revision operation, were analysed and compared with samples from patients undergoing a primary hip replacement, in order to elucidate histological and cellular changes.

Results

Periprosthetic tissue from patients with MoM implants was characterized by marked fibrotic changes, notably an increase in collagen content from less than 20% to 45–55%, an increase in α-smooth muscle actin positive cells from 4 to 9% as well as immune cells infiltration. Primary cell culture results demonstrated that MoM synovial fibroblasts have a decreased apoptosis rate from 14 to 6% compared to control synovial fibroblasts. In addition, synovial fibroblasts from MoM patients retained higher contractility and increased responsiveness to chemotaxis in matrix contraction. Their mechanical properties at a single cell level increased as observed by a 60% increase in contraction force and higher cell stiffness (3.3 kPa in MoM vs 2.18 kPa in control), as measured by traction force microscopy and atomic force microscopy. Further, fibroblasts from MoM patients promoted immune cell invasion by secreting monocyte chemoattractant protein 1 (MCP-1, CCL2) and induced monocyte differentiation, which could also be associated with excess accumulation of synovial macrophages.

Conclusion

Synovial fibroblasts exposed in vivo to MoM THA implants that release CoCr wear debris displayed dramatic phenotypic alteration and functional changes. These findings unravelled an unexpected effect of the CoCr alloy and demonstrated an important role of synovial fibroblasts in the undesired tissue reactions caused by MoM THAs.

Multivariate use of MRI biomarkers to classify histologically confirmed necrosis in symptomatic total hip arthroplasty

The failure of total hip arthroplasty (THA) is commonly associated with the necrosis of the periprosthetic tissue. To date, there is no established method to noninvasively quantify the progression of such necrosis. Magnetic resonance imaging (MRI) of soft tissues near implants has undergone a recent renaissance due to the development of multispectral metal-artifact reduction techniques. Advanced analysis of multispectral MRI has been shown capable of detecting small magnetism effects of metallic debris in periprosthetic tissue. The purpose of this study is to demonstrate the diagnostic utility of these MRI-based tissue-magnetism signatures. Together with morphological MRI metrics, such as synovial volume and thickness, these measurements are utilized as biomarkers to noninvasively detect soft-tissue necrosis in symptomatic THA patients ( N = 78 ). All subjects underwent an advanced MRI scan before revision surgery and tissue biopsies utilized for necrosis grading. Statistical analyses demonstrated a weak, but significant positive correlation (P = .04) between MRI magnetism signatures and necrosis scores, while indicating no meaningful association between the latter and serum cobalt and chromium ion levels. Receiver-operating characteristic (ROC) analyses were then performed based on uni- and multivariate logistic regression models utilizing the measured MRI biomarkers as predictors of severe necrosis. The area under the curve of the ROC plots for MRI biomarkers as combined predictors were found to be 0.70 and 0.84 for cross-validation and precision-recall tests, respectively.

ZBTB20-mediated titanium particle-induced peri-implant osteolysis by promoting macrophage inflammatory responses

Aseptic loosening (AL) caused by wear particles released from implant surfaces is one of the main causes for the failure of artificial joints, which is initiated by macrophage inflammatory responses. Emerging evidence suggests that the member of a broad-complex, tramtrack, bric-a-brac/poxvirus and zinc finger (BTB/POZ) family as well as zinc finger and BTB domain-containing protein 20 (ZBTB20) can inhibit IκBα gene transcription, promote NF-κB activation, and initiate innate immune responses. The molecular mechanism(s) by which ZBTB20 contributes to titanium particle (TiP)-induced macrophage inflammatory responses and osteolysis has not been fully elucidated. Here, we showed that ZBTB20 increased either in the AL group's synovial membranes or in TiP-stimulated bone-marrow-derived macrophages (BMDMs) as compared to that in the control groups. Moreover, the knockdown of ZBTB20 led to the inhibition of proinflammatory factors induced by TiPs in BMDMs, such as tumor necrosis factor-α (TNF-α), interleukin-6 (IL-6), and interferon-β (IFN-β). Here, we also reported that the knockdown of ZBTB20 suppressed TiP-induced NF-κB activation and M1 polarization as well as stabilized the trans Golgi network (TGN) in BMDMs. The dual-luciferase reporter assay identified the binding between the IκBα promoter and ZBTB20, and IκBα knockdown could rescue the antiinflammatory effects induced by the ZBTB20 knockdown in BMDMs. Finally, we found that sh-ZBTB20 lentivirus injection could reduce TiP-induced osteolysis in mouse calvaria, inhibiting TiP-induced proinflammatory factors and loss of bone volume/total volume (BV/TV) as well as bone mineral density (BMD). These results suggest that ZBTB20 positively regulated NF-κB activation and M1 polarization as well as the production of TGN-derived tubular carriers in BMDMs, playing a positive role in macrophage activation and mouse cranial osteolysis induced by TiPs. It may be a potential therapeutic target for the prevention of aseptic loosening of prostheses.

Magnoflorine Suppresses MAPK and NF-κB Signaling to Prevent Inflammatory Osteolysis Induced by Titanium Particles In Vivo and Osteoclastogenesis via RANKL In Vitro

Wear particles that detach from the surface of prostheses induce excessive activation of osteoclast and immoderate release of inflammatory cytokines that lead to peri-implant osteolysis and aseptic loosening. In this work, we investigated whether magnoflorine, a quaternary aporphine alkaloid extracted from the Chinese herb Magnolia or Aristolochia, could effectively inhibit inflammatory calvarial osteolysis caused by titanium particles in mouse models, inflammatory response as well as osteoclastogenesis in vitro mediated via receptor activator of NF-κB ligand (RANKL). Micro-computed tomography and histological examination of mice treated with magnoflorine revealed fewer resorption pits, less osteoclasts formation and inflammatory cytokine expression. Moreover, in vitro differentiation of osteoclasts and bone resorption as well as titanium particle-induced inflammatory response were dose-dependently inhibited by magnoflorine. These were accompanied by reduced transcription of osteoclast-specific genes encoding tartrate-resistant acid phosphatase (TRAP), V-ATPase d2, c-Fos, cathepsin K, nuclear factor of activated T cells (NFAT) c1, and calcitonin receptor (CTR). Further research on mechanism showed that the inhibition of phosphorylation of TAK1 and subsequent activation of MAPK and NF-κB signaling pathways were found to mediate the suppressive effects of magnoflorine. Collectively, these results suggested that magnoflorine treatment could effectively prevent peri-implant osteolysis due to wear debris as well as other diseases caused by chronic inflammation and excessive osteoclast activation.

Is early migration enough to explain late clinical loosening of hip prostheses?

Prosthetic loosening has been debated for decades, both in terms of the timing and nature of the triggering events. Multiple radiostereometric studies of hip prostheses have now shown that early migration poses a risk of future clinical failure, but is this enough to explain late clinical loosening?To answer this question, the progression of loosening from initiation to radiographic detection is described; and the need for explanations other than early prosthetic loosening is analysed, such as stress-shielding, particle disease, and metal sensitivity.Much evidence indicates that prosthetic loosening has already been initiated during or shortly after the surgery, and that the subsequent progression of loosening is affected by biomechanical factors, fluid pressure fluctuations and inflammatory responses to necrotic cells and cell fragments, i.e. the concept of late loosening appears to be a misinterpretation of late-detected loosening.Clinical implications: atraumatic surgery and initial prosthetic stability are crucial in ensuring low risk of prosthetic loosening. Cite this article: EFORT Open Rev 2020;5:113-117. DOI: 10.1302/2058-5241.5.190014.

Evidence for Gender-Specific Bone Loss Mechanisms in Periprosthetic Osteolysis

Osteolysis adjacent to total hip replacement (THR) prostheses is a major cause of their eventual failure. Periprosthetic osteolysis is associated with the production of bioactive particles, produced by the wear of articulating prosthesis surfaces. Wear particles invade the periprosthetic tissue, inducing inflammation and bone resorption. Previous studies have shown that osteocytes, the most numerous cell type in mineralised bone, can respond to wear particles of multiple orthopaedic material types. Osteocytes play important roles in bone resorption, regulating bone resorption by osteoclasts and directly through osteocytic osteolysis, also known as perilacunar remodelling. In this study, we perform a histological analysis of bone biopsies obtained from cohorts of male and female patients undergoing either primary THR surgery or revision THR surgery for aseptic loosening. The osteocyte lacunae area (Ot.Lac.Ar) and percentage lacunar area/bone area (%Ot.Lac.Ar/B.Ar) were significantly larger overall in revision THR bone than bone from similar sites in primary THR. Analysis by patient gender showed that increased Ot.Lac.Ar, indicative of increased perilacunar remodelling, was restricted to female revision samples. No significant differences in osteoclast parameters were detectable between the cohorts. These findings suggest previously unrecognised gender-specific mechanisms of bone loss in orthopaedic wear particle-induced osteolysis in humans.

Solochrome cyanine: A histological stain for cobalt-chromium wear particles in metal-on-metal periprosthetic tissues

Metal-on-metal (MoM) hip arthroplasties produce abundant implant-derived wear debris composed mainly of cobalt (Co) and chromium (Cr). Cobalt-chromium (Co-Cr) wear particles are difficult to identify histologically and need to be distinguished from other wear particle types and endogenous components (e.g., haemosiderin, fibrin) which may be present in MoM periprosthetic tissues. In this study we sought to determine whether histological stains that have an affinity for metals are useful in identifying Co-Cr wear debris in MoM periprosthetic tissues. Histological sections of periprosthetic tissue from 30 failed MoM hip arthroplasties were stained with haematoxylin-eosin (HE), Solochrome Cyanine (SC), Solochrome Azurine (SA) and Perls' Prussian Blue (PB). Sections of periprosthetic tissue from 10 cases of non-MoM arthroplasties using other implant biomaterials, including titanium, ceramic, polymethylmethacrylate (PMMA) and ultra-high molecular weight polyethylene (UHMWP) were similarly analysed. Sections of 10 cases of haemosiderin-containing knee tenosynovial giant cell tumour (TSGCT) were also stained with HE, SC, SA and PB. In MoM periprosthetic tissues, SC stained metal debris in phagocytic macrophages and in the superficial necrotic zone which exhibited little or no trichrome staining for fibrin. In non-MoM periprosthetic tissues, UHMWP, PMMA, ceramic and titanium particles were not stained by SC. Prussian Blue, but not SC or SA, stained haemosiderin deposits in MoM periprosthetic tissues and TSGT. Our findings show that SC staining (most likely Cr-associated) is useful in distinguishing Co-Cr wear particles from other metal/non-metal wear particles types in histological preparations of periprosthetic tissue and that SC reliably distinguishes haemosiderin from Co-Cr wear debris.

Inflammation time-axis in aseptic loosening of total knee arthroplasty: A preliminary study

OBJECTIVE

Aseptic loosening (AL) is the most frequent long-term reason for revision of total knee arthroplasty (TKA) affecting about 15-20% patients within 20 years after the surgery. Although there is a solid body of evidence about the crucial role of inflammation in the AL pathogenesis, scared information on inflammation signature and its time-axis in tissues around TKA exists.

DESIGN

The inflammation protein signatures in pseudosynovial tissues collected at revision surgery from patients with AL (AL, n = 12) and those with no clinical/radiographic signs of AL (non-AL, n = 9) were investigated by Proximity Extension Assay (PEA)-Immunoassay and immunohistochemistry.

RESULTS

AL tissues had elevated levels of TNF-family members sTNFR2, TNFSF14, sFasL, sBAFF, cytokines/chemokines IL8, CCL2, IL1RA/IL36, sIL6R, and growth factors sAREG, CSF1, comparing to non-AL. High interindividual variability in protein levels was evident particularly in non-AL. Levels of sTNFR2, sBAFF, IL8, sIL6R, and MPO discriminated between AL and non-AL and were associated with the time from index surgery, suggesting the cumulative character of inflammatory osteolytic response to prosthetic byproducts. The source of elevated inflammatory molecules was macrophages and multinucleated osteoclast-like cells in AL and histiocytes and osteoclast-like cells in non-AL tissues, respectively. All proteins were present in higher levels in osteoclast-like cells than in macrophages.

CONCLUSIONS

Our study revealed a differential inflammation signature between AL and non-AL stages of TKA. It also highlighted the unique patient's response to TKA in non-AL stages. Further confirmation of our preliminary results on a larger cohort is needed. Analysis of the time-axis of processes ongoing around TKA implantation may help to understand the mechanisms driving periprosthetic bone resorption needed for diagnostic/preventative strategies.

Mechanisms of Adverse Local Tissue Reactions to Hip Implants

Adverse Local Tissue Reactions (ALTRs) are one of the main causes of hip implant failures. Although the metal release from the implants is considered as a main etiology, the mechanisms, and the roles of the released products are topics of ongoing research. The alloys used in the hip implants are considered biocompatible and show negligible corrosion in the body environment under static conditions. However, modularity and its associated mechanically assisted corrosion have been shown to release metal species into the body fluids. ALTRs associated with metal release have been observed in hip implants with metal-on-metal articulation initially, and later with metal-on-polyethylene articulation, the most commonly used design in current hip replacement. The etiological factors in ALTRs have been the topics of many studies. One commonly accepted theory is that the interactions between the metal species and body proteins and cells generate a delayed type IV hypersensitivity reaction leading to ALTRs. However, lymphocyte reactions are not always observed in ALTRS, and the molecular mechanisms have not been clearly demonstrated. A more accepted mechanism is that cell damage generated by metal ions may trigger the secretion of cytokines leading to the inflammatory reactions observed in ALTRs. In this inflammatory environment, some patients would develop hypersensitivity that is associated with poor outcomes. Concerns over ALTRS have brought significant impact to both the clinical selection and development of hip implants. This review is focused on the mechanisms of ALTRs, specifically, the metal release process and the roles of the metal species released in the etiology and pathogenesis of the disease. Hopefully, our presentation and discussion of this biological process from a material perspective could improve our current understanding on the ALTRs and provide useful guidance in developing preventive solutions.

Non-union: Indications for external fixation

External fixation is currently used as the definitive mode of fracture stabilisation in the management of ˜50% of long-bone non-unions. Distinction between non-union and delayed union is a diagnostic dilemma especially in fractures healing by primary bone repair. This distinction is important, as non-unions are not necessarily part of the same spectrum as delayed unions. The aetiology of a fracture non-union is usually multifactorial and the factors can be broadly categorized into mechanical factors, biological (local and systemic) factors, and infection. Infection is present in ˜40% of fracture non-unions, often after open fractures or impaired wound healing, but in 5% of all non-unions infection is present without any clinical or serological suspicion. General indications for external fixation include clinical scenarios where; 1) percutaneous correction of alignment, or mechanical stimulation of the non-union site is required; 2) fixation of juxta-articular or 'emmental' bone fragments is necessary; and 3) staged bone or soft tissue reconstruction is anticipated. Specific anatomical indications include infected non-unions of the tibia, humerus, and juxta-articular bone. External fixation is an essential tool in the management of fracture non-unions. However, with greater understanding of the outcomes associated with both external and internal fixation the relative indications are now being refined.

Host-specific factors affect the pathogenesis of adverse reaction to metal debris

Background

Adverse Reaction to Metal Debris (ARMD) is a major reason for revision surgeries in patients with metal-on-metal (MoM) hip replacements. Most failures are related to excessively wearing implant producing harmful metal debris (extrinsic factor). As ARMD may also occur in patients with low-wearing implants, it has been suggested that there are differences in host-specific intrinsic factors contributing to the development of ARMD. However, there are no studies that have directly assessed whether the development of ARMD is actually affected by these intrinsic factors.

Methods

We included all 29 patients (out of 33 patients) with sufficient data who had undergone bilateral revision of ASR MoM hips (58 hips) at our institution. Samples of the inflamed synovia and/or pseudotumour were obtained perioperatively and sent to histopathological analysis. Total wear volumes of the implants were assessed. Patients underwent MARS-MRI imaging of the hips preoperatively. Histological findings, imaging findings and total wear volumes between the hips of each patient were compared.

Results

The difference in wear volume between the hips was clinically and statistically significant (median difference 15.35 mm³, range 1 to 39 mm³, IQR 6 to 23 mm³) (p < 0.001). The median ratio of total wear volume between the hips was 2.0 (range 1.09 to 10.0, IQR 1.67 to 3.72). In majority of the histological features and in presence of pseudotumour, there were no differences between the left and right hip of each patient (p > 0.05 for all comparisons). These features included macrophage sheet thickness, perivascular lymphocyte cuff thickness, presence of plasma cells, presence of diffuse lymphocytic infiltration and presence of germinal centers.

Conclusions

Despite the significantly differing amounts of wear (extrinsic factor) seen between the sides, majority of the histological findings were similar in both hips and the presence of pseudotumour was symmetrical in most hips. As a direct consequence, it follows that there must be intrinsic factors which contribute to the symmetry of the findings, ie. the pathogenesis of ARMD, on individual level. This has been hypothesized in the literature but no studies have been conducted to confirm the hypothesis. Further, as the threshold of metal debris needed to develop ARMD appears to be largely variable based on the previous literature, it is likely that there are between-patient differences in these intrinsic factors, ie. the host response to metal debris is individual.

Electronic supplementary material

The online version of this article (10.1186/s12891-019-2578-0) contains supplementary material, which is available to authorized users.