Chemical composition of commercial citrus fruit essential oils and evaluation of their antimicrobial activity acting alone or in combined processes

Antimicrobial activity of orange juice processing waste in powder form and its suitability to produce antimicrobial packaging

Orange peel essential oil is a common value-added product from orange juice processing waste. It is antimicrobial and used to produce antimicrobial films and coatings. This study reports the first development of antimicrobial films using orange peel as powder (OPP) instead of the extracted essential oil. The OPP amount needed for antimicrobial films was determined by studying the OPP effects on conidia germination inhibition (minimum inhibitory concentration (MIC)) and mycelial growth reduction for Botrytis cinerea, Aspergillus niger, and Penicillium sp. This amount was incorporated into linear low-density polyethylene using plastic processing machinery. The resulting LLDPE/OPP composite film was characterized for antimicrobial activity against Botrytis cinerea, antimicrobial compound release, and mechanical, barrier, and optical properties. We found the same OPP MIC (8.4 mg OPP/mL air) for the three fungi although their mycelial growth kinetics and conidia germination inhibition periods varied with OPP amount differently. 21.1 mg OPP/mL air completely inhibited the germination of Penicillium sp., B. cinerea, and A. niger conidia for 3, 2, and 1 days. The antimicrobial film was a LLDPE/OPP composite with 46% plastic replacement that reduced B. cinerea growth by 30% over a 7-day storage period at 23 °C, less than OPP due to limonene/citral reduction during processing. Plastic replacement resulted in films with the barrier and mechanical properties of plastics commonly used in food packaging. This study demonstrates the OPP antimicrobial capacity against food spoilage microorganisms and its suitability to produce antimicrobial packaging for food applications and presents a novel approach to utilizing orange juice processing waste.

Comparing Three Types of Mandarin Powders Prepared via Microfluidic-Jet Spray Drying: Physical Properties, Phenolic Retention and Volatile Profiling

This study aimed to offer an alternative way for delivering the benefits of the mandarin fruit juice to consumers via spray drying microencapsulation. Two mandarin cultivars, Afourer (A) and Richard Special (RS), were studied. Three types of juice sample were prepared, i.e., the whole fruit juice (A3 & RS3), the flavedo-removed fruit juice (A2 & RS2), and the peel-removed fruit juice (A1 & RS1) samples. Gum Acacia and maltodextrin (ratio of 1:1, w/w) were chosen as wall matrices for aiding the drying of the juice samples while using a microfluidic-jet spray dryer. The properties of the fruit powder (colour, water activity, bulk/trapped density, solubility, hygroscopicity, morphology) and the retention of major phytochemicals (i.e., phenolic and volatile compounds) were examined. The results showed that the powders produced from the whole fruit juices (A3 and RS3) gave higher yellow colour with a regular winkled surface than other powders (A1 & RS1, and A2 & RS2). The water activity of mandarin powders was in a range of 0.14 to 0.25, and the solubility was around 74% with no significant difference among all of the powders. The whole fruit powders had a significantly higher concentration of phenolic compounds (A3, 1023 µg/100 mg vs. A2, 809 µg/100 mg vs. A1, 653 µg/100 mg) and aroma compounds (A3, 775,558 µg/L vs. A2, 125,617 µg/L vs. A1, 12,590 µg/L). This study contributed to the delivery of phenolic and flavour compounds of the mandarin fruits, at the same time minimising waste generation during processing. It also gave insight into the production of spray-dried powders from the whole mandarin fruits.

Improved in vitro and in vivo Anti-Candida albicans Activity of Cymbopogon nardus Essential Oil by Its Incorporation into a Microemulsion System

PURPOSE

Vulvovaginal candidiasis (VVC) is an opportunistic fungal infection that adversely affects a woman's health, due to unpleasant symptoms, therapeutic challenges, and the emergence of resistant strains. The association of natural products and nanotechnology is important to improve the antifungal potential of medicinal plants. We aimed to evaluate the in vitro and in vivo anti-Candida albicans activity of unloaded (EO) and loaded (ME+EO) essential oil of Cymbopogon nardus in the microemulsion (ME).

METHODS

The chemical analysis of the EO was performed by gas chromatography-mass spectrometry. The ME and ME+EO were characterized by scattering, zeta potential, polarized light microscopy, rheological assays, mucoadhesiveness and transmission electronic microscopy. The in vitro antifungal activity of the EO and ME+EO were evaluated by microdilution technique. The toxicity of EO and ME+EO was analyzed on human cell line HaCat and using alternative model assay with Artemia salina. The experimental in vivo VVC was performed in female mice (C57BL/6).

RESULTS

The main compounds of the EO were found to be citronellal, geranial, geraniol, citronellol, and neral. The formulations exhibited suitable size, homogeneity, negative charge, isotropic behavior, highly organized structure, and pseudoplastic behavior, for vaginal application. TEM photomicrographs showed possible EO droplets inside the spherical structures. The EO, when loaded into the ME, exhibited an improvement in its antifungal action against C. albicans. The EO was not toxic against brine shrimp nauplii. An in vivo VVC assay showed that the use of the ME significantly improved the action of the EO, since only the ME+EO promoted the eradication of the fungal vaginal infection on the third day of treatment.

CONCLUSION

The EO and ME+EO are promising alternatives for the control of fungal infections caused by C. albicans, once the use of nanotechnology significantly improved the antifungal action of the EO, especially in an in vivo model of VVC.

Substitution of synthetic nitrates and antioxidants by spices, fruits and vegetables in Clean label Spanish chorizo

Natural extracts obtained from fruits and vegetables processing are important sources of phenolic compounds and nitrates, with excellent antioxidant and antimicrobial properties. The aim of this study was to elaborate a Clean label dry-cured meat product (Spanish "chorizo") using Mediterranean Diet ingredients (Citrus, Acerola, Rosemary, Paprika, Garlic, Oregano, Lettuce + Arugula + Watercress, Spinach + Celery, Chard + Beet). For that, a self-life study for 150 days was carried out, when physical-chemical (colour, pH, a_w, thiol loss, volatile compounds profile), microbiological, and organoleptic changes were determined. The combination of citrus extracts and leafy green vegetables halved the hexanal and nonanal content for 150 days. In addition, this change did not affect to the sensory properties of the product, which obtained the highest acceptance avoiding the oxidative damage (colour, volatile compounds release, thiol loss) and the microbiological growth. Nevertheless, rosemary extract incorporation altered sensory quality, unless it also avoided protein and lipid oxidation, as well as microbiological growth. Otherwise, Control sample elaborated with synthetic sources of nitrates and nitrites showed a lower sensory quality due to the increased hardness, protein oxidation, hexanal, and nonanal concentrations, related to lipid oxidation, and hence, to rancid flavour apparition.

Antibacterial Effects and Mechanism of Mandarin (Citrus reticulata L.) Essential Oil against Staphylococcus aureus

Staphylococcus aureus (S. aureus) creates an array of challenges for the food industry and causes foodborne diseases in people, largely due to its strong antibiotic resistance. Mandarin (Citrus reticulata L.) essential oil (MEO) is recognized as a natural and safe preservative; however, the antibacterial effects and mechanism of MEO to combat S. aureus are not yet clearly understood. This study will examine the inhibitory effects of MEO against S. aureus and explore the antibacterial mechanism thereof from the perspective of membrane destruction. The antibacterial activity of MEO on planktonic S. aureus was examined to determine the minimal inhibitory concentration (MIC). Scanning electron microscope (SEM) images revealed the direct impacts of MEO treatment on the cell structure of S. aureus. The cell membrane was observed to be depolarized, the determination of extracellular nucleic acids, proteins and intracellular adenosine triphosphate (ATP) confirmed the increased permeability of the cell membrane, its integrity was destroyed and the cellular constituents had leaked. These results, thus, provided conclusive evidence that MEO constrains the growth of planktonic S. aureus by affecting the permeability and integrity of its cell membrane. Our study provides a basis for the further development and utilization of MEO as a natural antibacterial agent in the food industry.

Nanocomposite starch-based films containing silver nanoparticles synthesized with lemon juice as reducing and stabilizing agent

Silver nanoparticles (AgNP L) synthesis using the active compounds of lemon juice was optimized. The obtained nanoparticles were included in starch-based film formulations, studying the relevant properties that condition their application in the packaging area. The optimized conditions for AgNP L' synthesis were 30 min at 90 °C, which led to the lowest nanoparticle size (5.5 nm) with the highest associated stability (ζ= -29.5 mV) up to 90 days. Nanocomposite films resulted with an orange tone that increased with AgNP L concentration (14.3-143 ppm). Water vapor permeability decreased while tensile mechanical resistance increased up to an aggregate of 71.5 ppm of AgNP L, indicating the nanoparticles' reinforcement of the polymer matrix. Besides, the citric acid content provided by lemon juice also affected the starch-based relevant film properties. Regarding antimicrobial capacity, a synergic effect between active compounds of lemon juice and silver nanoparticles was evidenced, being Salmonella spp. the most sensitive bacteria.

Improvement of the Shelf-Life Status of Modified Atmosphere Packaged Camel Meat Using Nisin and Olea europaea Subsp. laperrinei Leaf Extract

The impact of combined biopreservation treatment with Olea europaea subsp. laperrinei leave extracts (laper.OLE) and nisin on the quality attributes of camel steaks packaged under high O₂ (80%) and CO₂ (20%) atmosphere was investigated during refrigerated (1 ± 1 °C) long-term storage. As measured by reversed phase HPLC/DAD analysis, oleuropein is the phenolic compound most present in the chemical composition of laper.OLE (63.03%). Camel steaks treated with laper.OLE had a lower concentration of thiobarbituric acid-reactive substances (TBA-RSs) in the course of 30 days of storage. Surface metmyoglobin (MetMb) increased at a reduced rate in laper.OLE-treated samples compared to control samples. Neither modified atmosphere packaging (MAP) nor biopreservation treatments significantly altered the tenderness of camel steaks, expressed in terms of Warner-Bratzler shear force (WBSF), as compared to control samples. After 30 days of storage, psychrotrophic bacteria and Pseudomonas spp. counts were significantly lower in camel steaks treated with a combination of laper.OLE and nisin than in untreated steaks. Moreover, samples treated with laper.OLE received higher scores on bitterness acceptability. In sum, the use of combined biopreservation methods could be a sustainable solution for the preservation and promotion of the quality characteristics of camel meat in arid regions.

Incubation with a Complex Orange Essential Oil Leads to Evolved Mutants with Increased Resistance and Tolerance

Emergence of strains with increased resistance/tolerance to natural antimicrobials was evidenced after cyclic exposure to carvacrol, citral, and (+)-limonene oxide. However, no previous studies have reported the development of resistance and tolerance to complex essential oils (EOs). This study seeks to evaluate the occurrence of Staphylococcus aureus strains resistant and tolerant to a complex orange essential oil (OEO) after prolonged cyclic treatments at low concentrations. Phenotypic characterization of evolved strains revealed an increase of minimum inhibitory and bactericidal concentration for OEO, a better growth fitness in presence of OEO, and an enhanced survival to lethal treatments, compared to wild-type strain. However, no significant differences (p > 0.05) in cross-resistance to antibiotics were observed. Mutations in hepT and accA in evolved strains highlight the important role of oxidative stress in the cell response to OEO, as well as the relevance of the cell membrane in the cell response to these natural antimicrobials. This study demonstrates the emergence of S. aureus strains that are resistant and tolerant to EO (Citrus sinensis). This phenomenon should be taken into account to assure the efficacy of natural antimicrobials in the design of food preservation strategies, in cleaning and disinfection protocols, and in clinical applications against resistant bacteria.

Physiological alterations involved in inactivation of autochthonous spoilage bacteria in orange juice caused by Citrus essential oils and mild heat

This study investigated physiological alterations involved in the inactivation of Levilactobacillus (L.) brevis and Leuconostoc (Lc.) mesenteroides in orange juice caused by Citrus lemon essential oil (CLEO) and C. reticulata essential oil (CREO) alone and combined with mild heat treatment (MHT). Damage in DNA, membrane integrity, membrane potential, metabolic and efflux activity of bacterial cells were measured after exposure (6 and 12 min) to CLEO or CREO (0.5 μL/mL) and/or MHT (54 °C) using flow cytometry. Limonene was the major constituent in CLEO (66.4%) and CREO (89.4%). The size of the damaged cell subpopulations increased (p < 0.05) after longer exposure time and varied with the tested essential oil and/or bacterial isolate. After exposure to CLEO and CREO alone, the cell subpopulations with damage in measured physiological functions were in a range of 19.6-66.8% and 23.8-75.9%, respectively. Exposure to CREO resulted in larger Lc. mesenteroides cell subpopulations (35.4-68.7%) with damaged DNA, permeabilized and depolarized membrane and compromised metabolic or efflux activity compared to L. brevis (23.8-58.0%). In contrast, exposure to CLEO led to higher damaged L. brevis cell subpopulations (35.1-77%) compared to Lc. mesenteroides (25.3-36.6%). Exposure to combined treatments (CLEO or CREO and MHT) affected the measured physiological functions in almost the entire L. brevis and Lc. mesenteroides cell population (up to 99%), although the damage extension on each isolate varied with tested essential oil. Results show that inactivation of L. brevis and Lc. mesenteroides cells caused by CLEO and CREO alone and combined with MHT in orange juice involves a multi-target action, which causes DNA damage, altered permeability and depolarization of membrane and compromised metabolic and efflux activities.

Antimicrobial Efficacy of Liposome-Encapsulated Citral and Its Effect on the Shelf Life of Shatangju Mandarin

ABSTRACT

Liposome-encapsulated citral was prepared by means of a hot homogenization method. The microstructure, particle size, and zeta potential of the capsules were analyzed by transmission electron microscope and dynamic light scattering, respectively, in which the results showed a good dispersion stability of the citral-loaded liposome. In vitro tests showed that liposome-encapsulated citral significantly (P < 0.05) reduced the populations of Escherichia coli, Bacillus subtilis, Staphylococcus aureus, and Penicillium italicum more than free citral. In vivo tests conducted on fresh Shatangju mandarin showed that liposome-encapsulated citral-treated fruit exhibited a decay incidence of 56.67%, which is 42.04% lower than free citral-treated fruit (97.78%) after 26 days of storage at 25°C and 60 to 70% relative humidity. Additionally, fruit treated with citral-loaded liposome significantly reduced weight loss and viable yeast and mold during storage. In summary, liposome-encapsulated citral could be an effective antimicrobial agent to extend the shelf life of the Shatangju mandarin.

HIGHLIGHTS

A biorefinery for conversion of citrus peel waste into essential oils, pectin, fertilizer and succinic acid via different fermentation strategies

A process for the valorization of citrus peel waste (CPW) has been developed aiming to produce succinic acid and a series of added-value products through the biorefinery platform. CPW was subject to physicochemical and biological treatment to isolate essential oils (0.43%) and pectin (30.53%) as extractable products, pretreating the material for subsequent production of succinic acid that enabled application of remaining biorefinery residues (BR) as fertilizer substitute. Cellulose, hemicellulose and lignin contents of CPW accounted for 22.45%, 8.05% and 0.66% respectively, while acid hydrolysis reduced hemicellulose by 3.42% in BR. Moreover, essential oils extracted from CPW included 17 compounds, among which D-limonene reached 96.7%. The hydrolyzate generated was fermented for succinic acid production using Actinobacillus succinogenes. Different batch experiments demonstrated that the combined use of corn steep liquor (CSL) and vitamins in a lab-scale bioreactor resulted in product concentration and yield that reached 18.5 g L^-1 and 0.62 g g^-1 respectively. Although simultaneous saccharification and fermentation (SSF) could not enhance succinic acid production, a fed-batch fermentation strategy increased succinic acid concentration and yield generating 22.4 g L^-1 and 0.73 g g^-1 respectively, while the mass of the platform chemical formed was enhanced by 27% as compared to the batch process. BR was explored as fertilizer substitute aiming to close the loop in the management of CPW towards development of a zero-waste process demonstrating that although the material imposed stress on plant growth, the content of potassium, phosphorus and nitrogen in the mixture increased.

Chitosan nanoemulsions of cold-pressed orange essential oil to preserve fruit juices

Sweet orange essential oil is obtained from the peels of Citrus sinensis (CSEO) by cold pressing, and used as a valuable product by the food industry. Nanoencapsulation is known as a valid strategy to improve chemical stability, organoleptic properties, and delivery of EO-based products. In the present study we encapsulated CSEO using chitosan nanoemulsions (cn) as nanocarrier, and evaluated its antimicrobial activity in combination with mild heat, as well as its sensorial acceptability in orange and apple juices. CSEO composition was analyzed by GC-MS, and 19 components were identified, with limonene as the predominant constituent (95.1%). cn-CSEO was prepared under low shear conditions and characterized according to droplet size (<60 nm) and polydispersity index (<0.260 nm). Nanoemulsions were stable for at least 3 months at 4 ± 2 °C. cn-CSEO were compared with suspensions of CSEO (s-CSEO) (0.2 μL of CSEO/mL) in terms of antibacterial activity in combination with mild heat (52 °C) against Escherichia coli O157:H7 Sakai. cn-CSEO displayed a greater bactericidal activity than s-CSEO at pH 7.0 and pH 4.0. The validation in fruit juices showed an improved bactericidal effect of cn-CSEO in comparison with s-CSEO when combined with mild heat in apple juice, but not in orange juice. In both juices, the combination of CSEO and mild heat exerted synergistic lethal effects, reducing the treatment time to cause the inactivation of up to 5 Log₁₀ cycles of E. coli O157:H7 Sakai cells. Finally, the sensory characteristics of both juices were acceptable either when using s-CSEO or CSEO nanoemulsified with chitosan. Therefore, as a promising carrier for lipophilic substances, the encapsulation of EOs with chitosan nanoemulsions might represent an advantageous alternative when combined with mild heat to preserve fruit juices.

Inactivation of foodborne pathogens by the synergistic combinations of food processing technologies and food-grade compounds

There is a need to develop food processing technologies with enhanced antimicrobial capacity against foodborne pathogens. While considering the challenges of adequate inactivation of pathogenic microorganisms in different food matrices, the emerging technologies are also expected to be sustainable and have a minimum impact on food quality and nutrients. Synergistic combinations of food processing technologies and food-grade compounds have a great potential to address these needs. During these combined treatments, food processes directly or indirectly interact with added chemicals, intensifying the overall antimicrobial effect. This review provides an overview of the combinations of different thermal or nonthermal processes with a variety of food-grade compounds that show synergistic antimicrobial effect against pathogenic microorganisms in foods and model systems. Further, we summarize the underlying mechanisms for representative combined treatments that are responsible for the enhanced microbial inactivation. Finally, regulatory issues and challenges for further development and technical transfer of these new approaches at the industrial level are also discussed.

Application of essential oils and polyphenols as natural antimicrobial agents in postharvest treatments: Advances and challenges

The use of natural antimicrobial agents is an attractive ecological alternative to the synthetic fungicides applied to control pathogens during postharvest. In order to improve industrial production systems, postharvest research has evolved toward integration with science and technology aspects. Thus, the present review aims to draw attention to the achieved advances and challenges must be overcome, to promote application of essential oils and polyphenols as antimicrobial agents, against phytopathogens and foodborne microorganisms during postharvest. Besides that, it attempts to highlight the use of coating and encapsulation techniques as emerging methods that improve their effectiveness. The integral knowledge about the vegetable systems, molecular mechanisms of pathogens and mechanisms of these substances would ensure more efficient in vitro and in vivo experiences. Finally, the cost-benefit, toxicity, and ecotoxicity evaluation will be guaranteed the successful implementation and commercialization of these technologies, as a sustainable alternative to minimize production losses of vegetable commodities.

Chemical Composition, Antifungal and Insecticidal Activities of the Essential Oils from Tunisian Clinopodium Nepeta Subsp. nepeta and Clinopodium Nepeta Subsp. Glandulosum

The present investigation was focused on the study of the chemical composition variability and biological activities of the essential oils from Clinopodium nepeta subsp. nepeta and subsp. glandulosum. Essential oils extraction was performed using hydrodistillation and the separation of the constituents was carried out by gas chromatography coupled with mass spectrometry (GC-MS). Antifungal activities were tested against Aspergillus flavus, Aspergillus terreus, Microsporum canis, Microsporum gypseum, Trichophyton mentagrophytes, and Candida albicans. Toxicity and repellency were evaluated against the stored product pests Tribolium confusum and Sitophilus zeamais. Both essential oils were characterized by a high content of oxygenated monoterpenes. Piperitone ranks first in the subspecies nepeta and piperitenone oxide is the dominant constituent in the subspecies glandulosum. All tested samples displayed noteworthy antifungal properties, with the highest activity observed for the essential oil of C. nepeta subsp. glandulosum, collected in Béni-M'tir, against T. mentagrophytes (MIC = 40 µg/mL). The essential oil samples of C. nepeta subsp. glandulosum were strongly repellent to the insect species (PR > 80%, after 2h) and highly toxic to S. zeamais reaching 97.5%-100% mortality after 24 h of exposure. In conclusion, this study showed considerable intra-specific changes in the quality of C. nepeta essential oils, which is reflected in different rates of antifungal and insecticidal activity.

Triploid Citrus Genotypes Have a Better Tolerance to Natural Chilling Conditions of Photosynthetic Capacities and Specific Leaf Volatile Organic Compounds

Low temperatures during winter are one of the main constraints for citrus crop. Polyploid rootstocks can be used for improving tolerance to abiotic stresses, such as cold stress. Because the produced fruit are seedless, using triploid scions is one of the most promising approaches to satisfy consumer expectations. In this study, we evaluated how the triploidy of new citrus varieties influences their sensitivity to natural chilling temperatures. We compared their behavior to that of diploid citrus, their parents (Fortune mandarin and Ellendale tangor), and one diploid clementine tree, as reference, focusing on photosynthesis parameters, oxidative metabolism, and volatile organic compounds (VOC) in leaves. Triploid varieties appeared to be more tolerant than diploid ones to natural low temperatures, as evidenced by better photosynthetic properties (Pnet, gs, Fv/Fm , ETR/P net ratio), without relying on a better antioxidant system. The VOC levels were not influenced by chilling temperatures; however, they were affected by the ploidy level and atypical chemotypes were found in triploid varieties, with the highest proportions of E-β-ocimene and linalool. Such compounds may contribute to better stress adaptation.

Orange peel waste-based liquid medium for biodiesel production by oleaginous yeasts

Orange peel waste (OPW), the primary byproduct of the juice extraction process, is annually generated in massive amounts (21 Mton), and its aqueous extraction in biorefining operations yields a liquid fraction, referred to as orange peel extract (OPE). Although OPE contains significant amounts of easily assimilable carbohydrates, such as fructose, glucose, and sucrose, no investigations have been conducted yet to assess its possible use in biodiesel production by oleaginous yeasts. Consequently, the objective of the present study was to assess whether OPE might act as the basis of a liquid medium for microbial lipid production. A screening conducted with 18 strains of oleaginous yeasts in shaken flask on the OPE-based medium showed that Rhodosporidium toruloides NRRL 1091 and Cryptococcus laurentii UCD 68-201 gave the best results in terms of lipid production (5.8 and 4.5 g L^-1, respectively) and accumulation (77 and 47% on a dry matter basis, respectively). The subsequent scale transfer of the process to a 3-L STR operated in batch mode halved the time required to reach the lipid peak with the ensuing increase in volumetric productivities in R. toruloides NRRL 1091 (3646 mg L^-1 day^-1) and C. laurentii UCD 68-201 (2970.7 mg L^-1 day^-1). The biodiesel yields from the lipids of the former and the latter strain were 36.9 and 31.9%, respectively. Based on multivariate analysis of fatty acid methyl ester compositions, the lipids from the former and the latter strain were highly resembling those of Jatropha and palm oils, two commonly used feedstocks for biodiesel manufacturing.

Evaluation of Nematocidal Action against Caenorhabditis elegans of Essential Oil of Flesh Fingered Citron and Its Mechanism

Essential oils from flesh fingered citrons were obtained by mechanical pressing extraction under optimal conditions. Thirty-three components, representing 78.25% of the total oil, were identified by gas chromatography-mass spectrometry (GC-MS). In this study, we explored the toxicity of the essential oil of flesh fingered citrons and the associated regulatory mechanism using Caenorhabditis elegans as a model organism. The mortality experiment showed that the LD50 value is 1.48 mg/ml. Oxidative stress experiments showed that essential oils of flesh fingered citrons can reduce the antioxidation of nematodes and can shorten their lifespan. In survival rate experiments for verification, d-limonene had a nematocidal effect by destroying the waterproof protective layer on the surface of the worm. β-Pinene can interfere with the normal growth of nematodes according to behavioral experiments, and reproduction experiments showed that α-pinene has very strong nematocidal properties. γ-Terpinene also has good nematocidal activity. The results demonstrated that the essential oil of flesh fingered citron has great potential to act as a new nematicide.

Evaluation of Fungistatic Activity of Eight Selected Essential Oils on Four Heterogeneous Fusarium Isolates Obtained from Cereal Grains in Southern Poland

The aim of the study was to determine the relationship between the chemical composition of eight commercial essential oils (EsO) (garlic, grapefruit, lemon grass, tea tree, thyme, verbena, cajeput, and Litsea cubeba) and their fungistatic activity in relation to four species of Fusarium: F. avenaceum, F. culmorum, F. graminearum, and F. oxysporum. The species identification of Fusarium isolates was confirmed by matrix-assisted laser desorption/ionization time-of-flight (MALDI-TOF) mass spectrometer. The determination of qualitative and quantitative chemical composition of the EsO was carried out using the gas chromatography-mass spectrometry (GC-MS) method. The fungistatic activity of EsO was assessed by using the method of poisoned substrates. The data were compiled in the STATISTICA 13.0 program. The chemical composition of the tested oils varied; the dominant fraction, except for grapefruit and garlic oils, were monoterpenoids. The greatest similarity to the action of the synthetic pesticide Funaben T was found in four oils, i.e., thyme, lemongrass, verbena, and Litsea cubeba. The studies showed that F. oxysporum and F. avenaceum were characterized by a higher resistance to low oil concentrations, and F. culmorum and F. graminearum by sensitivity. The fungicidal activity of two EsO-dominant monoterpenoids-thymol and citral-has been confirmed.

Unraveling the selective antibacterial activity and chemical composition of citrus essential oils

Post-weaning diarrhea (PWD) is an often disease affecting piglets. It is caused mainly by enterotoxigenic Escherichia coli (ETEC) colonization in pig gut. Antibiotics has been used to prevent, combat and control PWD and its negative impact on the productivity of pig breeding sector. Nonetheless, antibiotics due to their wide antibacterial spectrum also can reach beneficial gut bacteria, such as Lactobacillus. Lately, essential oils (EOs) have emerged as a potential alternative to using antibiotics in animal breeding because of their effect on bacterial growth. Commonly, citrus EOs are by-products of food industry and the availability of these EOs in the worldwide market is huge. Thus, six commercials citrus EOs were evaluated on ETEC strains, as model of pathogenic bacteria, and on Lactobacillus species, as models of beneficial bacteria. In overall, citrus EOs exhibited a selective antibacterial activity with higher effect on pathogenic bacteria (ETECs) than beneficial bacteria (Lactobacillus). Brazilian orange terpenes (BOT) oil presented the highest selective performance and caused higher disturbances on the normal growth kinetic of ETEC than on Lactobacillus rhamnosus. The action was dose-dependent on the maximal culture density (A) and the lag phase duration (λ) of the ETEC. The highest sub-inhibitory concentration (0.925 mg/mL) extended the λ duration to ETEC eight times (14.6 h) and reduced A in 55.9%. For L. rhamnosus, the λ duration was only extended 1.6 times. Despite the fact that limonene was detected as the major compound, the selective antibacterial activity of the citrus EOs could not be exclusively attributed to limonene since the presence of minor compounds could be implicated in conferring this feature.

Peel oils from three Citrus species: volatile constituents, antioxidant activities and related contributions of individual components

In the present study, peel oils were extracted through hydrodistillation and cold pressing from three Citrus species (Valencia orange, Ponkan and Eureka lemon) to investigate their volatile constituents and antioxidant activities. A total of 47 volatile components were identified by GC-MS, and then grouped by principal component analysis. The extraction methods were found to have an obvious effect on the proportion of terpenes and oxygenated compounds in the six Citrus oils, especially for Eureka lemon oils. The major fractions in the Citrus oils were found to be monoterpenes (78.65-96.57%), with limonene occupying a dominant percentage (51.22-86.65%). Furthermore, γ-terpinene and terpinolene displayed strong DPPH (1,1-diphenyl-2-picrylhydrazyl) scavenging abilities and efficient inhibition of lipid peroxidation, while oxygenated compounds of α-terpineol and terpinen-4-ol showed poor DPPH radical-scavenging abilities. Therefore, hydrodistillated Eureka lemon oil with high levels of α-terpineol (9.11%) and terpinen-4-ol (4.69%) presented low radical scavenging capability. Citral displayed a high pro-oxidant ability against thiobarbituric acid reactive species formation, which might lead to the decreased ability of the Eureka lemon oils in inhibition of lipid peroxidation, since citral was significantly high in Eureka lemon oils. This study facilitated the understanding of volatile constituents and antioxidant activities in different Citrus peel oils.

Antimicrobial influence of nanoemulsified lemon essential oil and pure lemon essential oil on food-borne pathogens and fish spoilage bacteria

The antimicrobial activities of lemon oil based nanoemulsion and two different concentrations of lemon essential oil (100% and 10%) on food-brne pathogens (Staphylococcus aureus, Klebsiella pneumoniae, Enterococcus faecalis and Salmonella Paratyphi A) and fish spoilage bacteria (Photobacterium damselae, Enterococcus faecalis, Vibrio vulnificus, Proteus mirabilis, Serratia liquefaciens, and Pseudomonas luteola) were compared in terms of disc diffusion, minimum inhibition concentration (MIC) and minimum bactericidal concentration (MBC). The constitutes of extracted lemon essential oil were identified by using GC-MS. Viscosity, the mean droplet size, thermodynamic stability and refractive index of nanoemulsions were determined. The main components detected in the lemon essential oil were d-limonene, p-cymene, β-pinene with percentages of 52.85%, 14.36%, and 13.69%, respectively. It was found that lemon nanoemulsion was more effective on food-borne pathogens except K. pneumoniae than 100% lemon essential oil. 10% lemon essential oil showed the highest inhibition effect on S. Paratyphi A. The conversion of the essential oil into nanoemulsion improved antimicrobial activity. According to value of MIC, both nanoemulsion and 100% essential oil inhibited bacterial growth of all of the pathogen bacteria tested whereas they were less effective on inhibition of fish spoilage bacteria. However, 10% essential oil was more effective on spoilage bacteria than pathogens. MBC showed that nanoemulsion and 100% lemon essential oil presented a noticeable bactericidal activity against S. paratyphi A whereas 10% lemon essential oil was found as ≥25 mg/mL against pathogens and spoilage bacteria. Therefore, the use of nanoemulsion based on lemon essential oil can have potential as a natural antimicrobial agent against food-borne pathogen and spoilage bacteria for fish processing industry.

Control of Autochthonous Spoilage Lactic Acid Bacteria in Apple and Orange Juices by Sensorially Accepted Doses of Citrus Spp. Essential Oils Combined with Mild Heat Treatments

This study assessed the compromised acceptance threshold (CAT) and rejection threshold (RT) of Citrus lemon (CLEO) and Citrus reticulata essential oil (CREO) in apple and orange juices. The efficacy of CLEO and CREO concentrations below the RT were evaluated alone and combined with mild heat treatment (MHT) (54 °C, up to 12 min) to inactivate the autochthonous spoilage bacteria Lactobacillus brevis, Lactobacillus plantarum, and Leuconostoc mesenteroides in apple and orange juices. The CAT of CLEO and CREO varied from 0.15 to 0.17 μL/mL in orange and apple juices. The RT of CLEO was approximately 0.58 μL/mL in apple and orange juices, and the RT of CREO was 0.68 μL/mL in both juices. When CLEO and CREO were assayed alone, the highest concentration (0.50 μL/mL) decreased counts of all strains approximately 2 log₁₀ CFU/mL after 12 min of exposure to 54 °C. All concentrations of CLEO or CREO in combination with MHT acted synergistically against L. brevis, L. plantarum, and L. mesenteroides. Decreases in counts varied with the strain, CLEO and CREO concentrations, juice type, and exposure time to the combined treatment. CREO was more effective than CLEO in combination with MHT against the strains in apple and orange juices. Effective combinations of CLEO or CREO with MHT to control the autochthonous spoilage bacteria did not compromise the quality parameters (°Brix, pH, and titratable acidity) that characterize unsweetened juices. These results indicate CLEO or CREO at concentrations below the sensory RT in combination with MHT as a feasible technology to control autochthonous spoilage bacteria in fresh fruit juices. PRACTICAL APPLICATION: The present study provides novel information concerning the efficacy of sensorially accepted doses of CLEO and CREO combined with MHT against autochthonous spoilers in fruit juice. The valuable synergistic effects that can be observed when combining CLEO and CREO with MHT reveal a feasible preservation technology and alternative to traditional treatments that are successful because they help reduce treatment intensity, thereby avoiding adverse effects on the sensory, physicochemical, and nutritional properties of these products.

Valorisation of citrus processing waste: A review

This study analyses the quantitative and qualitative characteristics of citrus peel waste and discusses the systems for its valorisation. Citrus peel waste (CPW) is the main residue of the citrus processing industries and is characterised by a seasonal production (which often requires biomass storage) as well as high water content and concentration of essential oils. The disposal of CPW has considerable constraints due to both economic and environmental factors. Currently this residue is mainly used as food for animals, thanks to its nutritional capacity. If enough agricultural land is available close to the processing industries, the use of CPW as organic soil conditioner or as substrate for compost production is also possible, thus improving the organic matter content of the soil. Recently, the possibility of its valorisation for biomethane or bioethanol production has been evaluated by several studies, but currently more research is needed to overcome the toxic effects of the essential oils on the microbial community. Considering the high added value of the compounds that can be recovered from CPW, it has promising potential uses: in the food industry (for production of pectin, dietary fibres, etc.), and in the cosmetic and pharmaceutic industries (extraction of flavonoids, flavouring agents and citric acid). However, in many cases, these uses are still not economically sustainable.

Using Citrus aurantifolia essential oil for the potential biocontrol of Colocasia esculenta (taro) leaf blight caused by Phytophthora colocasiae

The aim of this work was to evaluate the antimicrobial activities of leaves and epicarp of Citrus aurantifolia essential oil against Phytophthora colocasiae, the causative agent of taro leaf blight. Oils were extracted by hydrodistillation, and their chemical composition was determined by gas chromatography and gas chromatography coupled with mass spectrometry. Antimicrobial activities of oils were tested in vitro against mycelium growth and sporangium production. In situ tests were done on healthy taro leaves, and the necrosis symptoms were evaluated. Results showed that the essential oil extraction yields from leaves and epicarp were 0.61 and 0.36%, respectively. Limonene (48.96%), bornyl acetate (14.18%), geraniol (10.53%), geranial (3.93%), and myrcene (3.14%) were the main components in leaf oil, while limonene (59.09%), cis-hydrate sabinene (7.53%), geranial (5.61%), myrtenol (5.02%), and terpinen-4-ol (3.48%) were the main components in epicarp oil. Both oils exhibited antimicrobial activities with total inhibition of the mycelium growth at 500 and 900 ppm for leaf and epicarp, respectively. The highest inhibitory concentration of sporangium production was 400 (72.84%) and 800 ppm (80.65%) for leaf and epicarp oil, respectively. For the standard fungicide (metalaxyl), the total inhibition value of mycelial growth and sporangium production was 750 ppm. In situ tests showed that, at 5000 ppm, total inhibition (100%) was obtained for a preventive test, while 50% of the inhibition was observed for a curative test when leaf oil was applied. When epicarp essential oil was applied at 5000 ppm, 47.5 and 16.66% of the reduction of leaf necrosis were observed for the preventive and curative test, respectively. There were positive correlations between both the oil concentration and the reduction of necrosis caused by P. colocasiae. These findings suggest that the C. aurantifolia essential oil could serve as an eco-friendly biocontrol for the management of taro leaf blight.

Navel Orange Peel Essential Oil To Control Food Spoilage Molds in Potato Slices

The aim of this study was to investigate the efficacy of navel orange, Citrus sinensis (L.) Osbeck, peel essential oil (NOPEO) for inhibiting spoilage fungi in potato slices. Sixteen different components accounting for 99.79% of the headspace components of NOPEO were identified by gas chromatography-mass spectrometry. d-Limonene was the major component of NOPEO. Antifungal activity of NOPEO was tested in vitro and in vivo against four foodborne fungi. A MIC of NOPEO against the four fungal species was 9.40 μL/mL_air. NOPEO provided about 74, 74, 73, and 69% protection against Aspergillus niger, Mucor wutungkiao, Penicillium funiculosum, and Rhizopus oryzae at 2.00 μL/mL_air concentration, respectively. NOPEO has been demonstrated to significantly improve the microbiological quality of potato slices.

Antifungal Activity of Essential Oil Compounds (Geraniol and Citral) and Inhibitory Mechanisms on Grain Pathogens (Aspergillus flavus and Aspergillus ochraceus)

The grain contamination by Aspergillus spp. has been a serious issue. This study exhibited the excellent antifungal effects of the essential oil compounds (EOCs) geraniol and citral against common grain pathogens (A. flavus and A. ochraceus) in vitro and in situ. The inhibitory mechanisms were also evaluated from the perspective of cell membrane permeability, reactive oxygen species (ROS) generation, and Aspergillus spp. growth-related gene expression. Meanwhile, the combined effects of EOCs in the vapor phase and modified atmosphere packaging (MAP) were examined to find an alternative preservation method for controlling Aspergillus spp. The results indicated that citral exhibited the antifungal activity mainly by downregulating the sporulation- and growth-related genes for both pathogens. Geraniol displayed inhibitory effectiveness against A. flavus predominantly by inducing the intracellular ROS accumulation and showed toxicity against A. ochraceus principally by changing cell membrane permeability. Furthermore, the synthetic effects of EOCs and MAP (75% CO₂ and 25% N₂) induced better grain quality than the current commercial fumigant AlP. These findings reveal that EOCs have potential to be a novel grain preservative for further application.

Classification of Bitter Orange Essential Oils According to Fruit Ripening Stage by Untargeted Chemical Profiling and Machine Learning

The quality and composition of bitter orange essential oils (EOs) strongly depend on the ripening stage of the citrus fruit. The concentration of volatile compounds and consequently its organoleptic perception varies. While this can be detected by trained humans, we propose an objective approach for assessing the bitter orange from the volatile composition of their EO. The method is based on the combined use of headspace gas chromatography–mass spectrometry (HS-GC-MS) and artificial neural networks (ANN) for predictive modeling. Data obtained from the analysis of HS-GC-MS were preprocessed to select relevant peaks in the total ion chromatogram as input features for ANN. Results showed that key volatile compounds have enough predictive power to accurately classify the EO, according to their ripening stage for different applications. A sensitivity analysis detected the key compounds to identify the ripening stage. This study provides a novel strategy for the quality control of bitter orange EO without subjective methods.

Whole-Genome Sequencing and Genetic Analysis Reveal Novel Stress Responses to Individual Constituents of Essential Oils in Escherichia coli

Food preservation by the use of essential oils (EOs) is being extensively studied because of the antimicrobial properties of their individual constituents (ICs). Three resistant mutants (termed CAR, CIT, and LIM) of Escherichia coli MG1655 were selected by subculturing with the ICs carvacrol, citral, and (+)-limonene oxide, respectively. These derivative strains showed increased MIC values of ICs and concomitantly enhanced resistance to various antibiotics (ampicillin, trimethoprim, chloramphenicol, tetracycline, kanamycin, novobiocin, norfloxacin, cephalexin, and nalidixic acid) compared to those for the parental strain (wild type [WT]). Whole-genome sequencing (WGS) of these hyperresistant strains permitted the identification of single nucleotide polymorphisms (SNPs) and deletions in comparison to the WT. In order to analyze the contribution of these mutations to the increased antimicrobial resistance detected in hyperresistant strains, derivative strains were constructed by allelic reversion. A role of the SoxR D137Y missense mutation in CAR was confirmed by growth in the presence of some ICs and antibiotics and by its tolerance to ICs but not to lethal heat treatments. In CIT, increased resistance relied on contributions by several detected SNPs, resulting in a frameshift in MarR and an in-frame GyrB ΔG157 mutation. Finally, both the insertion resulting in an AcrR frameshift and large chromosomal deletions found in LIM were correlated with the hyperresistant phenotype of this strain. The nature of the obtained mutants suggests intriguing links to cellular defense mechanisms previously implicated in antibiotic resistance.IMPORTANCE The antimicrobial efficacy of ICs has been proven over the years, together with their potential to improve traditional heat treatments by reducing treatment intensity and, consequently, adverse effects on food quality. However, the mechanisms of bacterial inactivation by ICs are still not well understood, in contrast to antibiotics. We performed WGS of three E. coli strains that are hyperresistant to ICs. The information provided detailed insight into the mechanisms of bacterial resistance arising from exposure to carvacrol, citral, and (+)-limonene oxide. Future experiments will undoubtedly yield additional insights into genes and pathways contributing to the acquisition of endogenous resistance to ICs.

Water accelerated transformation of d-limonene induced by ultraviolet irradiation and air exposure

d-Limonene is a fragrant chemical that widely exists in aromatic products. Isotopic labelling of water molecules plus GC-MS and GC-PCI-Q-TOF analyses were used to investigate the influence of water molecules on chemical transformation of d-limonene induced by UV irradiation and air exposure. The results showed that the synergistic effect of UV irradiation, air exposure and water presence could facilitate d-limonene transformation into the limonene oxides: p-mentha-2,8-dienols, hydroperoxides, carveols, l-carvone and carvone oxide. UV irradiation, air exposure, or water alone, however, caused negligible d-limonene transformation. With the aid of isotopic labelling of water and oxygen molecules, it was found that water molecules were split into hydrogen radicals and hydroxyl radicals, and the hydrogen radicals, in particular, promoted the transformation reactions. This study has elucidated the mechanism and factors that influence the transformation of d-limonene, which will benefit industries involved in production and storage of d-limonene-containing products.